Delfield DCCS, DCFSRIG, DCFSRKD, DCFSRIKS, DCFSROG Operation Manual

...

0 (0)

Concepts Serving Systems

Use & Care Manual

Please read this manual completely before attempting to install or operate this equipment!

Notify carrier of damage! Inspect all components immediately. See page 2.

Effective June 2010

IMPORTANT INFORMATION

READ BEFORE USE

PLEASE SAVE THESE INSTRUCTIONS!

CAUTION

Concepts Use & Care Manual

For customer service, call (800) 733-8829, (800) 773-8821, Fax (989) 773-3210, www.delﬁeld.com

WARNING Read This Manual Thoroughly Before Operating, Installing, Or Performing

Maintenance On The Equipment.

WARNING Failure To Follow Instructions In This Manual Can Cause Property Damage,

Injury Or Death.

WARNING Do Not Store Or Use Gasoline Or Other Flammable Vapors Or Liquids In The

Vicinity Of This Or Any Other Appliance.

WARNING Unless All Cover And Access Panels Are In Place And Properly Secured, Do

Not Operate This Equipment.

WARNING Do Not Clean With Water Jet.

CAUTION Observe the following:

Minimum clearances must be maintained from all walls and combustible

materials.

Keep the equipment area free and clear of combustible material.

Adequate clearance for air openings.

Operate equipment only on the type of electricity indicated on the

specification plate.

Retain this manual for future reference.

•

Important Warning And Safety Information

Concepts Use & Care Manual

For customer service, call (800) 733-8829, (800) 773-8821, Fax (989) 773-3210, www.delﬁeld.com

If your unit is heated, the serial tag is located above the louvered

panel near the on/off switch.

Refrigerated units have the serial tag located in the compressor

area near the on/off switch.

Understorage units often have the serial tag located on the left

inside the storage area.

All purpose counters, utility equipment or delivery carts do

not require serial numbers but a model tag is placed at the top

of the pylon on the back of the unit.

Always have the serial number of your unit available when

calling for parts or service.

This manual covers standard units only. If you have a custom

unit, consult the customer service department at the number

listed below.

ten permission is prohibited.

“Delfield” is a registered trademarks of The Delfield Company.

Contents Serial Number Information

Receiving & Inspecting The Equipment ....................................4

Specifications ..........................................................................5-7

Installation

Heated Units ...........................................................................8

Refrigerated Units ...................................................................8

Operation

Heated Units ............................................................................9

Mechanically Cooled Serving Counters ..................................9

LiquiTec Units .......................................................................10

Frost Top Serving Counters ..................................................10

Maintenance .............................................................................11

Wiring Diagrams

Heated Serving Counter ........................................................12

Mechanically Cooled Serving Counter ..................................13

LiquiTec Units .......................................................................13

Frost Top Serving Counters ..................................................13

Standard Labor Guidelines ......................................................14

Replacement Parts List ............................................................15

Standard Warranty ..............................................................16-17

Notes ...................................................................................18-19

Concepts Use & Care Manual

For customer service, call (800) 733-8829, (800) 773-8821, Fax (989) 773-3210, www.delﬁeld.com

Receiving And Inspecting The Equipment

Even though most equipment is shipped crated, care should

be taken during unloading so the equipment is not damaged

while being moved into the building.

Visually inspect the exterior of the package and skid or

container. Any damage should be noted and reported to

the delivering carrier immediately.

If damaged, open and inspect the contents with the

carrier.

In the event that the exterior is not damaged, yet upon

opening, there is concealed damage to the equipment

notify the carrier. Notification should be made verbally

as well as in written form.

Request an inspection by the shipping company of the

damaged equipment. This should be done within 10

days from receipt of the equipment.

Check the lower portion of the unit to be sure legs or

casters are not bent.

Also open the compressor compartment housing and

visually inspect the refrigeration package. Be sure lines

are secure and base is still intact.

Freight carriers can supply the necessary damage forms

upon request.

Retain all crating material until an inspection has been

made or waived.

The units with LiquiTec technology cold pans contain

a non-toxic eutectic fluid within a sealed inner liner.

This fluid may leak if the tank is punctured so care

must be taken when uncrating and setting in place.

The eutectic fluid is non-toxic and may be flushed

down a disposal drain. If the LiquiTec unit cold pans

leak, immediately call the Delfield service department

directly at 1-800-733-8821 not your local service

agent.

Uncrating the Equipment

First cut and remove the banding from around the crate.

Remove the front of the crate material, use of some tools will

be required. If the unit is on legs remove the top of the crate

as well and lift the unit off the skid. If the unit is on casters it

can be "rolled" off the skid.

Concepts Use & Care Manual

For customer service, call (800) 733-8829, (800) 773-8821, Fax (989) 773-3210, www.delﬁeld.com

Specifications

This manual covers standard units only. If you have a custom unit, consult the customer service department at the number listed below.

Cashier Counter

Model Length Width Height Ship Weight

DCCS-SD 45.00” 36.00” 36.00” 270lbs/122kg

DCCS-SDW 45.00” 54.00” 36.00” 320lbs/145kg

DCCS-SDWL 45.00” 54.00” 36.00” 295lbs/134kg

DCCS-SDWR 45.00” 54.00” 36.00” 295lbs/134kg

DCCS-DD 72.00” 36.00” 36.00” 540lbs/245kg

DCCS-DDW 72.00” 54.00” 36.00” 590lbs/268kg

DCCS-DDWL 72.00” 54.00” 36.00” 565lbs/256kg

DCCS-DDWR 72.00” 54.00” 36.00” 565lbs/256kg

Flexi Shield™ Food Shields

Radial Glass Fro nt, Single Tier with Glass Shelf, Single Serv ice, Inside & Outside

Model L W H Ship Weight Model L W H Ship Weight

DCFSRIG-2 38.47” 18.00” 18.00” Contact Factor y DCFSROG-2 43.09” 18.00” 18.00” Contact Factor y

DCFSRIG-3 53.43” 18.00” 18.00” Contact Factor y DCFSROG-3 59.85” 18.00” 18.00” Contact Factor y

DCFSRIG-4 68.17” 18.00” 18.00” Contact Factor y DCFSROG-4 76.35” 18.00” 18.00” Contact Factor y

DCFSRIG-5 82.61” 18.00” 18.00” Contact Factor y DCFSROG-5 92.53” 18.00” 18.00” Contact Factor y

Flexi Shield™ Food Shields

Radial Single Tier, Fixed S neeze Guard Front, Dual Ser vi ce

Model L W H Ship Weight

DCFSRKD-2 40.78” 35.50” 14.75” Contact Factor y

DCFSRKD-3 56.64” 35.50” 14.75” Contact Factor y

DCFSRKD-4 72.26” 35.50” 14.75” Contact Factor y

DCFSRKD-5 87.57” 35.50” 14.75” Contact Factor y

Flexi Shield™ Food Shields

Radial Single Tier, Fixed S neeze Guard Front, Sing le Ser vice, Inside & Outside

Model L W H Ship Weight Model L W H Ship Weight

DCFSRIKS-2 38.47” 18.00” 14.75” Contact Factory DCFSROKS-2 43.09” 18.00” 14.75” Contact Factor y

DCFSRIKS-3 53.43” 18.00” 14.75” Contact Factory DCFSROKS-3 59.85” 18.00” 14.75” Contact Factor y

DCFSRIKS-4 68.17” 18.00” 14.75” Contact Factory DCFSROKS-4 76.35” 18.00” 14.75” Contact Factor y

DCFSRIKS-5 82.61” 18.00” 14.75” Contact Factory DCFSROKS-5 92.53” 18.00” 14.75” Contact Factor y

Specifications

Model Length Depth Height Ship Weight Model Length Depth Height Ship Weight

DCBU-38 38.00” 36.00” 36.00” 171lbs/78kg DCBU-T38 38.00” 36.00” 36.00” 171lbs/78kg

DCBU-52 52.00” 36.00” 36.00” 234lbs/106kg DCBU-T52 52.00” 36.00” 36.00” 234lbs/106kg

DCBU-66 66.00” 36.00” 36.00” 297lbs/135kg DCBU-T66 66.00” 36.00” 36.00” 297lbs/135kg

DCBU-80 80.00” 36.00” 36.00” 360lbs/163kg DCBU-T80 80.00” 36.00” 36.00” 360lbs/163kg

DCBU-94 94.00” 36.00” 36.00” 423lbs/192kg DCBU-T94 94.00” 36.00” 36.00” 423lbs/192kg

DCBU-120 120.00” 36.00” 36.00” 540lbs/245kg DCBU-T120 120.00” 36.00” 36.00” 540lbs/245kg

Concepts Use & Care Manual

For customer service, call (800) 733-8829, (800) 773-8821, Fax (989) 773-3210, www.delﬁeld.com

Specifications, continued

Self-Contained Frost Top Serving Counter

Model Length Depth Height H.P. V/Hz/Ph Amps Ship Weight

DC-FT2 38.00” 36.00” 36.00” 1/4 115/60/1 7.5 399lbs/181kg

DC-FT3 52.00” 36.00” 36.00” 1/4 115/60/1 7.5 546lbs/248kg

DC-FT4 66.00” 36.00” 36.00” 1/4 115/60/1 7.5 693lbs/314kg

DC-FT5 80.00” 36.00” 36.00” 1/4 115/60/1 7.5 840lbs/381kg

DC-FT6 94.00” 36.00” 36.00” 1/3 115/60/1 8.0 987lbs/448kg

Heated Serving Counter

Model Length Depth Height Watts

# of 12x20

Pans Held

V/Hz/Ph Amps Ship Weight

DC-H2 38.00” 36.00” 36.00” 2000 2 115/60/1 16.6 228lbs/103kg

DC-H3 52.00” 36.00” 36.00” 3000/4000 3 208230/60/1 15.0/16.0 312lbs/142kg

DC-H4 66.00” 36.00” 36.00” 4000/4800 4 208230/60/1 20.0/22.0 396lbs/180kg

DC-H5 80.00” 36.00” 36.00” 5000/6000 5 208230/60/1 24.0/27.0 480lbs/218kg

DC-H6 94.00” 36.00” 36.00” 6000/7200 6 208230/60/1 29.0/32.0 564lbs/256kg

Ice Cooled Serving Counter

Model Length Depth Height

# of 12x20

Pans Held

Ship Weight

DC-IC2 38.00” 36.00” 36.00” 2 209lbs/95kg

DC-IC3 52.00” 36.00” 36.00” 3 286lbs/130kg

DC-IC4 66.00” 36.00” 36.00” 4 363lbs/165kg

DC-IC5 80.00” 36.00” 36.00” 5 440lbs/200kg

DC-IC6 94.00” 36.00” 36.00” 6 517lbs/235kg

Self-Contained LiquiTec® Cold Pan Serving Counter

Model Length Depth Height

# of 12x20

Pans Held

H.P. V/Hz/Ph Amps BTU Ship Weight

DC-L2 38.00” 36.00” 36.00” 2 1/4 115/60/1 7.5 379 342lbs/155kg

DC-L3 52.00” 36.00” 36.00” 3 1/4 115/60/1 7.5 569 468lbs/212kg

DC-L4 66.00” 36.00” 36.00” 4 1/4 115/60/1 7.5 758 594lbs/269kg

DC-L5 80.00” 36.00” 36.00” 5 1/4 115/60/1 7.5 948 720lbs/327kg

DC-L6 94.00” 36.00” 36.00” 6 1/4 115/60/1 7.5 1138 846lbs/384kg

Self-Contained Mechanically Cooled Serving Counter

Model Length Depth Height

# of 12x20

Pans Held

H.P. V/Hz/Ph Amps BTU Load Ship Weight

DC-MC2 38.00” 36.00” 36.00” 2 1/4 115/60/1 7.5 379 323lbs/147kg

DC-MC3 52.00” 36.00” 36.00” 3 1/4 115/60/1 7.5 569 442lbs/200kg

DC-MC4 66.00” 36.00” 36.00” 4 1/4 115/60/1 7.5 758 561lbs/254kg

DC-MC5 80.00” 36.00” 36.00” 5 1/4 115/60/1 7.5 948 680lbs/308kg

DC-MC6 94.00” 36.00” 36.00” 6 1/3 115/60/1 8.0 1138 799lbs/362kg

+ 14 hidden pages