Iveco EuroTrakker Cursor 13 Service Manual

Troubleshooting-data
EuroTrakker Cursor 13 (...E38)
Model:
Motor:
B11B11088
A31
A18
B15
B1
A17
A23
B27
B1
Component: From: To: Condition: Value Measured:Pic.
. .. Connector seen from wire side . .. Measurements taken with
connector installed B2 Batt. -Battery (earth) Ignition on B1 Batt. -Battery (earth) Ignition on B11 B12CAN BUS SAE J1939 Ignition off B12 B1 1087CAN BUS SAE J1939 Idle
CAN BUS SAE J1939 Idle
B35 B1Accelerator pedal sensor Ignition on B16 B35Accelerator pedal sensor Ignition on B23 B35Accelerator pedal sensor Ignition on, accelerator
released B23 B35Accelerator pedal sensor Ignition on, accelerator fully
depressed
Boost pressure valve Ignition on
B26 B1Brake pedal switch Ignition on, brake pedal
released B26 B1Brake pedal switch Ignition on, brake pedal
depressed B20 B1Clutch switch Ignition on B20 B1Clutch switch Ignition on, pedal activated
Ignition Ignition on
B15 B1Ignition Ignition off A7 A16 1050Inductive position sensor Idle A2 A14 1007Inductive position sensor 1 Starter rpm A1 A14 1012Inductive position sensor 2 Starter rpm
MAP-sensor Ignition on
A12 A23MAP-sensor Ignition on A23 B1MAP-sensor Ignition on A12 A23MAP-sensor 2000 rpm A12 A23MAP-sensor Ignition on, at 2500 - 3000
mbar
Relay Ignition on
B4 B1Relay Ignition on B3 B1Relay Ignition on B27 B1Relay Ignition off B3 B1Relay Ignition off B4 B1Relay Ignition off B29 B1 1047Speedometer Vehicle in motion A35 A24 1079Unit Injector 1 Idle A34 A24 1079Unit Injector 2 Idle
. .
0 V 0 V 55 - 65 ohm
0 V 4,5 - 5,5 V 0,2 - 0,6 V
3,5 - 4 V
22 - 28 V 22 - 28 V
0 V
22 - 28 V 0 V 22 - 28 V 0 V
4,5 - 5,5 V 0,9 - 1,1 V 0 V 1,3 - 1,7 V 3,4 - 4,7 V
0 - 1 V 22 - 28 V 22 - 28 V 22 - 28 V 0 V 0 V
Troubleshooting-data
EuroTrakker Cursor 13 (...E38)
Model:
Motor:
A33
A24
1079
B10
B1
Component: From: To: Condition: Value Measured:Pic.
Unit Injector 3 Idle
A26 A25 1079Unit Injector 4 Idle A28 A25 1079Unit Injector 5 Idle A27 A25 1079Unit Injector 6 Idle B10 B1Windscreen relay Ignition on, 20° C
Windscreen relay Ignition on, engine cold
22 - 28 V 0 - 1 V
Iveco LV
15
16
17
18
34
Yours sincerely
Model Year Engine Maintenance
Engine compartment OK Remarks
EuroTrakker Cursor 13 (...E38) 2001-2009 F3B E0681G 160,000 km/3,200 hs.
Date: Owner Registration No. Mileage
1. Reg. Date
15-08-2011Make
1 Change engine oil 2 Change engine oil filter 3 Change fan belt 4 Change fuel filter 5 Change fuel prefilter 6 Change the air filter of the VGT turbo 7 Check battery 8 Check charge relay and brushes
9 Check clutch fluid 10 Check indicator for engine ventilation filter 11 Check inlet pipe, tensioning of induction manifold 12 Check lock system on bonnet and the engine noise Control 13 Check/ Adjust valve clearance 14 Clean filter for power steering; Change if necessary
Body/ Cabin OK Remarks
Check all lamps/ lights Check body/ paint and undercoating (Inform costumer of damage/ defects) Check the cab tip system for operation and impermeability Control/ Adjust front lights
Chassis/ Underbody OK Remarks
19 Change air drier filter 20 Change differential oil 21 Change oil and filter on PTO and gearbox with intarder (Min. every year) (Only off-road
)
22 Change oil and filter on ZF-gearbox and any intarder (Min. every 2 years) (Only on-roa
d) 23 Change oil in hubs 24 Change oil in transfer gearbox 25 Change oil on gearbox (Manuel transmission) 26 Check brake pads, -discs, shoes and drums for wear 27 Check tyre and inflation pressure (Remember spare) 28 Check/ Adjust bolts of steering box and steering box console 29 Clean differential ventilation filter 30 Clean the transmission ventilation filter (Manual transmission) 31 Lubricate propeller shaft and chassis
Testdrive OK Remarks
32 Stamping of service manual and cleaning of steering wheel and handles after service 33 Test drive with final Check of all systems
Additional points OK Remarks
Check motor Control EDC system and perform engine test
We have noted the following points, of which you should be aware, while examining your vehicle:
n
n n n
Date Mechanic
Iveco LV EuroTrakker Cursor 13 (...E38)
-Oil filter
-Engine oil
-Drive belt(s)
-Fuel filter
-Air filter for the VGT turbo
-Filter in servo
-Air-drying filter
-Transmission oil (Differential)
-Transmission oil
-Oil filter in gearbox
-Oil for hubs
Parts - 160,000 km/3,200 hs.
Loading...