|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
Revision E: |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
• MUZ-GE25VAD- A1 |
, MUZ-GE35VAD- A1 , MUZ-GE42VAD- A1 , |
||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
MUZ-GE50VAD- A1 |
, MUZ-GE60VAD- A1 , MUZ-GE71VAD- A1 |
||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|||||
SPLIT-TYPE AIR CONDITIONERS |
|
|||||||||||||||||||||||||||||||||
|
|
and MUZ-GE80VAD- |
A1 |
have been added. |
||||||||||||||||||||||||||||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
Please void OBH532 REVISED EDITION-D.
OUTDOOR UNIT
SERVICE MANUAL
HFC |
No. OBH532 |
utilized |
REVISED EDITION-E |
R410A |
|
Models
MUZ-GE25VA - A1 MUZ-GE25VA - A2 MUZ-GE25VAD - A1 MUZ-GE33VA - A1 MUZ-GE35VA - A1 MUZ-GE35VA2 - A1 MUZ-GE35VA2 - A2 MUZ-GE35VAD - A1 MUZ-GE42VA - A1 MUZ-GE42VAD - A1
MUZ-GE50VA - A1
MUZ-GE50VA2 - A1
MUZ-GE50VAD - A1
MUZ-GE60VA - A1
MUZ-GE60VAD - A1
MUZ-GE71VA - A1
MUZ-GE71VAD - A1
MUZ-GE80VA - A1
MUZ-GE80VA2 - A1
MUZ-GE80VAD - A1
Indoor unit service manual MSZ-GE•VA Series (OBH531)
CONTENTS
MUZ-GE25VA MUZ-GE25VAD MUZ-GE33VA MUZ-GE35VA MUZ-GE35VA2 MUZ-GE35VAD MUZ-GE42VA MUZ-GE42VAD
1.TECHNICAL CHANGES ··································· 3
2.PART NAMES AND FUNCTIONS····················· 4
3.SPECIFICATION················································ 6
4.NOISE CRITERIA CURVES ·····························11
5.OUTLINES AND DIMENSIONS ······················ 13
6.WIRING DIAGRAM·········································· 15
7.REFRIGERANT SYSTEM DIAGRAM ············· 27
8.PERFORMANCE CURVES ····························· 31
9.ACTUATOR CONTROL··································· 63
10.SERVICE FUNCTIONS···································· 64
11.TROUBLESHOOTING ····································· 65
12.DISASSEMBLY INSTRUCTIONS···················· 86
PARTS CATALOG (OBB532)
NOTE:
RoHS compliant products have <G> mark on the spec name plate.
Use the specified refrigerant only
Never use any refrigerant other than that specified.
Doing so may cause a burst, an explosion, or fire when the unit is being used, serviced, or disposed of. Correct refrigerant is specified in the manuals and on the spec labels provided with our products.
We will not be held responsible for mechanical failure, system malfunction, unit breakdown or accidents caused by failure to follow the instructions.
Revision A :
• MUZ-GE60VA- A1 , MUZ-GE71VA- A1 and MUZ-GE80VA- A1 have been added.
Revision B:
• MUZ-GE33VA- A1 and MUZ-GE42VA- A1 have been added.
Revision C:
• MUZ-GE35VA2- A1 , MUZ-GE50VA2- A1 and MUZ-GE80VA2- A1 have been added.
Revision D:
• MUZ-GE25VA- A2 and MUZ-GE35VA2- A2 have been added.
Revision E:
•MUZ-GE25VAD- A1 , MUZ-GE35VAD- A1 , MUZ-GE42VAD- A1 , MUZ-GE50VAD- A1 , MUZ-GE60VAD- A1 , MUZ-GE71VAD- A1 and MUZ-GE80VAD- A1 have been added.
OBH532E |
2 |
|
1 TECHNICAL CHANGES
MUZ-GE25VA - A1 MUZ-GE33VA - A1 MUZ-GE35VA - A1 MUZ-GE42VA - A1 MUZ-GE50VA - A1 MUZ-GE60VA - A1 MUZ-GE71VA - A1 MUZ-GE80VA - A1
1. New model
MUZ-GE35VA - A1 MUZ-GE35VA2 - A1 MUZ-GE50VA - A1 MUZ-GE50VA2 - A1 MUZ-GE80VA - A1 MUZ-GE80VA2 - A1
1. Inverter P.C. board has been changed.
MUZ-GE25VA - A1 MUZ-GE25VA - A2
1.Compressor has been changed.
2.Back panel has been changed.
3.Outdoor heat exchanger has been changed.
4.Reactor has been changed.
5.Inverter P.C. board has been changed.
6.Maximum heating capacity has been changed.
MUZ-GE35VA2 - A1 MUZ-GE35VA2 - A2
1.Compressor has been changed.
2.Back panel has been changed.
3.Outdoor heat exchanger has been changed.
4.Inverter P.C. board has been changed.
MUZ-GE25VA - A2 MUZ-GE25VAD - A1 MUZ-GE35VA2 - A2 MUZ-GE35VAD - A1 MUZ-GE42VA - A1 MUZ-GE42VAD - A1 MUZ-GE50VA2 - A1 MUZ-GE50VAD - A1
1. Inverter P.C. board has been changed.
MUZ-GE60VA - A1 MUZ-GE60VAD - A1 MUZ-GE71VA - A1 MUZ-GE71VAD - A1 MUZ-GE80VA2 - A1 MUZ-GE80VAD - A1
1.Outdoor heat exchanger has been changed.
2.R.V coil has been changed.
3.4-Way valve has been changed.
4.Service panel has been changed.
5.Terminal block has been changed.
6.Inverter P.C. board has been changed.
OBH532E |
3 |
|
2 PART NAMES AND FUNCTIONS
MUZ-GE25VA MUZ-GE25VAD MUZ-GE33VA
MUZ-GE35VA MUZ-GE35VA2 MUZ-GE35VAD MUZ-GE42VA MUZ-GE42VAD
Air inlet (back and side)
Piping
Drain hose
Air outlet
Drain outlet
MUZ-GE50VA MUZ-GE50VA2 MUZ-GE50VAD
Air inlet (back and side)
Piping
Drain hose
Air outlet
Drain outlet
OBH532E |
4 |
|
MUZ-GE60VA MUZ-GE60VAD MUZ-GE71VA MUZ-GE71VAD
MUZ-GE80VA MUZ-GE80VA2 MUZ-GE80VAD
Air inlet (back and side)
|
|
Piping |
|
|
|
|
Drain hose |
|
|
|
|
Air outlet |
|
|
|
|
Drain outlet |
|
|
ACCESSORIES |
|
|
|
|
|
MUZ-GE25VA MUZ-GE25VAD |
MUZ-GE50VA |
MUZ-GE60VA MUZ-GE60VAD |
|
|
MUZ-GE33VA |
|||
|
MUZ-GE71VA MUZ-GE71VAD |
|||
Model |
MUZ-GE35VA MUZ-GE35VA2 |
MUZ-GE50VA2 |
||
MUZ-GE80VA MUZ-GE80VA2 |
||||
|
MUZ-GE35VAD |
MUZ-GE50VAD |
||
|
MUZ-GE80VAD |
|||
|
MUZ-GE42VA MUZ-GE42VAD |
|
||
|
|
|
||
Drain socket |
1 |
1 |
1 |
|
Drain cap |
- |
2 |
- |
OBH532E |
5 |
|
3 SPECIFICATION
|
Outdoor model |
|
|
MUZ-GE25VA- A1 |
|
MUZ-GE25VA- A2 |
|
MUZ-GE25VAD |
MUZ-GE33VA |
||||
|
|
|
|
|
|
|
|
|
|
|
|||
|
Power supply |
|
|
|
|
Single phase, 230 V, 50 Hz |
|
||||||
Capacity |
|
|
|
|
Cooling |
kW |
|
2.5 (1.1 - 3.5) |
|
|
3.3(1.4 - 3.9) |
||
Rated frequency (Min.-Max.) |
Heating |
3.2 (1.3 - 4.5) |
|
3.2 (1.3 - 4.1) |
|
3.2 (1.3 - 4.5) |
4.0 (1.4 - 4.8) |
||||||
Breaker Capacity |
|
|
|
|
A |
|
10 |
|
|||||
data |
Power input |
1 (Total) |
|
Cooling |
W |
|
560 |
|
|
910 |
|||
|
Heating |
|
730 |
|
|
1,030 |
|||||||
|
|
|
|
|
|
|
|
|
|||||
Running current |
1 |
|
|
Cooling |
A |
|
2.9 |
|
|
4.3 |
|||
Electrical |
|
|
|
|
|
||||||||
Power factor 1 (Total) |
|
Heating |
|
84 |
|
|
93 |
||||||
|
% |
|
|
|
|||||||||
|
(Total) |
|
|
|
|
Heating |
|
|
3.8 |
|
|
4.8 |
|
|
|
|
|
|
|
Cooling |
|
|
84 |
|
|
92 |
|
|
|
|
|
|
|
|
|
|
|
|
|
||
|
Starting current |
1 (Total) |
A |
|
3.8 |
|
|
4.8 |
|||||
Coefficient of performance |
|
|
Cooling |
|
4.46 |
|
|
3.63 |
|||||
(COP) 1 (Total) |
|
|
|
|
Heating |
|
4.38 |
|
|
3.88 |
|||
|
|
Model |
|
|
|
|
KNB073FFDHC |
|
KNB073FKVHC |
KNB092FFAHC |
|||
|
|
Output |
|
|
|
W |
|
550 |
|
|
650 |
||
Compressor |
Current |
1 |
|
Cooling |
A |
|
2.44 |
|
|
3.70 |
|||
|
Heating |
|
3.30 |
|
|
4.30 |
|||||||
|
|
|
|
|
|
||||||||
|
|
Refrigeration oil |
L |
0.32 (NEO22) |
|
0.36 (NEO22) |
0.32 (NEO22) |
||||||
|
|
(Model) |
|
|
|
|
|||||||
|
|
|
|
|
|
|
|
|
|
|
|
||
Fan motor |
Model |
|
|
|
|
|
|
RC0J50-DB |
|
||||
Current |
1 |
|
Cooling |
A |
|
0.24 |
|
|
0.31 |
||||
|
|
|
Heating |
|
0.27 |
|
|||||||
|
|
|
|
|
|
|
|
|
|||||
Dimensions W × H × D |
|
|
|
mm |
|
800 × 550 × 285 |
|
||||||
Weight |
|
|
|
|
|
kg |
|
30 |
|
||||
|
Dehumidification |
|
|
|
Cooling |
L/h |
|
0.2 |
|
|
0.6 |
||
|
|
Cooling |
|
|
High |
|
|
|
|
– |
|
||
|
|
|
|
Med. |
|
|
1,806 |
|
|
1,956 |
|||
|
Air flow 1 |
|
|
|
|
Low |
m3/h |
|
1,170 |
|
|
1,806 |
|
|
Heating |
|
|
High |
|
2,106 |
|
|
2,130 |
||||
|
|
|
|
|
|
|
|
||||||
remarks |
|
|
|
Med. |
|
|
1,806 |
|
|
1,956 |
|||
|
|
|
|
|
Low |
|
|
1,452 |
|
|
1,476 |
||
Sound level |
1 |
|
|
|
Heating |
dB(A) |
|
48 |
47 |
||||
|
|
|
|
|
|
Cooling |
|
|
46 |
|
|
||
Special |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
High |
|
|
|
|
– |
|
||
|
Cooling |
|
|
Med. |
|
|
740 |
|
|
800 |
|||
|
|
|
|
|
|
|
|
||||||
|
Fan speed |
|
|
|
|
Low |
rpm |
|
490 |
|
|
740 |
|
|
Heating |
|
|
High |
|
860 |
|
|
870 |
||||
|
|
|
|
|
|
|
|
||||||
|
|
|
|
Med. |
|
|
740 |
|
|
800 |
|||
|
|
|
|
|
|
Low |
|
|
600 |
|
|
610 |
|
|
Fan speed regulator |
|
|
|
|
|
|
|
3 |
|
|||
|
Refrigerant filling capacity |
kg |
|
0.80 |
|
||||||||
|
(R410A) |
|
|
|
|
|
|
|
|||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
NOTE: Test conditions are based on AS/NZS 3823.1.1. |
|
|
|
|
|
||||||||
|
Cooling: Indoor |
Dry-bulb temperature 27°C |
Wet-bulb temperature |
|
19°C |
|
|||||||
|
|
Outdoor Dry-bulb temperature 35°C |
Wet-bulb temperature |
|
(24°C) |
|
|||||||
|
Heating: Indoor |
Dry-bulb temperature 20°C |
Wet-bulb temperature |
|
15.5°C |
|
|||||||
|
|
Outdoor Dry-bulb temperature 7°C |
Wet-bulb temperature |
|
6°C |
|
|||||||
|
Refrigerant piping length (one way): 5 m |
|
|
|
|
|
|||||||
|
1 Measured under rated operating frequency. |
|
|
|
|
|
OBH532E |
6 |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
Outdoor model |
|
|
MUZ-GE35VA |
MUZ-GE35VA2- A1 |
MUZ-GE35VA2- A2 |
|
MUZ-GE35VAD |
MUZ-GE42VA |
|
MUZ-GE42VAD |
|||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|||
|
Power supply |
|
|
|
|
|
Single phase, 230 V, 50 Hz |
|
|
|
||||||
Capacity |
|
|
|
|
Cooling |
kW |
3.5 (1.4 - 3.9) |
|
3.5 (1.1 - 4.0) |
|
|
4.2(0.9-4.8) |
||||
Rated frequency (Min.-Max.) |
Heating |
4.0 (1.4 - 4.8) |
|
4.0 (1.6 - 5.3) |
|
|
5.4(1.4-6.0) |
|||||||||
Breaker Capacity |
|
|
|
|
A |
|
|
10 |
|
|
|
|||||
data |
Power input |
1 (Total) |
|
Cooling |
W |
1,010 |
|
920 |
|
|
1,260 |
|||||
|
Heating |
1,030 |
|
990 |
|
|
1,540 |
|||||||||
|
|
|
|
|
|
|
|
|
||||||||
Running current |
1 |
|
|
Cooling |
A |
4.7 |
|
4.4 |
|
|
|
5.8 |
||||
Electrical |
|
|
|
|
|
|
||||||||||
Power factor 1 (Total) |
|
Heating |
93 |
|
94 |
|
|
|
96 |
|||||||
|
% |
|
|
|
|
|||||||||||
|
(Total) |
|
|
|
|
Heating |
|
4.8 |
|
4.6 |
|
|
|
7.0 |
||
|
|
|
|
|
|
Cooling |
|
93 |
|
91 |
|
|
|
94 |
||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
||
|
Starting current |
1 (Total) |
A |
4.8 |
|
4.6 |
|
|
|
7.0 |
||||||
Coefficient of performance |
|
|
Cooling |
3.47 |
|
3.80 |
|
|
|
3.33 |
||||||
(COP) 1 (Total) |
|
|
|
|
Heating |
3.88 |
|
4.04 |
|
|
|
3.51 |
||||
|
|
Model |
|
|
|
|
KNB092FFAHC |
|
KNB092FNDHC |
SNB130FGBHT |
||||||
|
|
Output |
|
|
|
W |
|
|
650 |
|
|
|
900 |
|||
Compressor |
Current |
1 |
|
Cooling |
A |
4.10 |
|
3.76 |
|
|
|
5.19 |
||||
|
Heating |
4.30 |
|
4.06 |
|
|
|
6.38 |
||||||||
|
|
|
|
|
|
|
||||||||||
|
|
Refrigeration oil |
L |
|
|
0.32 (NEO22) |
|
|
0.45 (NEO22) |
|||||||
|
|
(Model) |
|
|
|
|
|
|
|
|||||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
||
Fan motor |
Model |
|
|
|
|
|
|
RC0J50-DB |
|
|
RC0J50-EA |
|||||
Current |
1 |
|
Cooling |
A |
0.31 |
|
0.35 |
|
|
|
0.32 |
|||||
|
|
|
Heating |
0.27 |
|
|
|
0.31 |
|
|
|
|||||
|
|
|
|
|
|
|
|
|
|
|
|
|
||||
Dimensions W × H × D |
|
|
|
mm |
|
|
800 × 550 × 285 |
|
|
|
||||||
Weight |
|
|
|
|
|
kg |
30 |
|
33 |
|
|
|
36 |
|||
|
Dehumidification |
|
|
|
Cooling |
L/h |
0.8 |
|
0.9 |
|
|
|
1.4 |
|||
|
|
Cooling |
|
|
High |
|
|
|
|
|
– |
|
|
|
||
|
|
|
|
Med. |
|
1,956 |
|
|
|
1,872 |
|
|
|
|||
|
Air flow 1 |
|
|
|
|
Low |
m3/h |
1,806 |
|
1,776 |
|
|
1,086 |
|||
|
Heating |
|
|
High |
2,130 |
|
|
|
2,016 |
|
|
|
||||
|
|
|
|
|
|
|
|
|
|
|
||||||
remarks |
|
|
|
Med. |
|
1,956 |
|
|
|
1,776 |
|
|
|
|||
|
|
|
|
|
Low |
|
1,476 |
|
|
|
1,386 |
|
|
|
||
Sound level |
1 |
|
|
|
Heating |
dB(A) |
|
|
48 |
|
|
|
51 |
|||
|
|
|
|
|
|
Cooling |
|
|
|
47 |
|
|
|
50 |
||
Special |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
High |
|
|
|
|
|
– |
|
|
|
||
|
Cooling |
|
|
Med. |
|
800 |
|
|
|
810 |
|
|
|
|||
|
|
|
|
|
|
|
|
|
|
|
||||||
|
Fan speed |
|
|
|
|
Low |
rpm |
740 |
|
770 |
|
|
|
490 |
||
|
Heating |
|
|
High |
|
|
870 |
|
|
|
||||||
|
|
|
|
|
|
|
|
|
|
|||||||
|
|
|
|
Med. |
|
800 |
|
|
|
770 |
|
|
|
|||
|
|
|
|
|
|
Low |
|
|
|
610 |
|
|
|
|||
|
Fan speed regulator |
|
|
|
|
|
|
|
|
3 |
|
|
|
|||
|
Refrigerant filling capacity |
kg |
0.80 |
|
|
|
1.15 |
|
|
|
||||||
|
(R410A) |
|
|
|
|
|
|
|
|
|
|
|
||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
NOTE: Test conditions are based on AS/NZS 3823.1.1. |
|
|
|
|
|
|
|
|
||||||||
|
Cooling: Indoor |
Dry-bulb temperature 27°C |
Wet-bulb temperature |
|
19°C |
|
|
|
||||||||
|
|
Outdoor Dry-bulb temperature 35°C |
Wet-bulb temperature |
|
(24°C) |
|
|
|
||||||||
|
Heating: Indoor |
Dry-bulb temperature 20°C |
Wet-bulb temperature |
|
15.5°C |
|
|
|
||||||||
|
|
Outdoor Dry-bulb temperature 7°C |
Wet-bulb temperature |
|
6°C |
|
|
|
||||||||
|
Refrigerant piping length (one way): 5 m |
|
|
|
|
|
|
|
|
|||||||
|
1 Measured under rated operating frequency. |
|
|
|
|
|
|
|
|
OBH532E |
7 |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
Outdoor model |
|
|
|
MUZ-GE50VA |
MUZ-GE50VA2 |
|
MUZ-GE50VAD |
||||||
|
|
|
|
|
|
|
|
|
|
|
||||
|
Power supply |
|
|
|
|
|
Single phase, 230 V, 50 Hz |
|||||||
Capacity |
|
|
|
|
Cooling |
kW |
|
5.0 (1.4 - 5.4) |
|
|
4.8 (1.4 - 5.4) |
|||
Rated frequency (Min.-Max.) |
Heating |
|
|
|
5.8 (1.4 - 7.2) |
|
|
|||||||
Breaker Capacity |
|
|
|
|
A |
|
|
|
16 |
|
|
|||
data |
Power input |
1 (Total) |
|
Cooling |
W |
|
1,640 |
|
|
|
1,480 |
|||
|
Heating |
|
|
|
1,650 |
|
|
|||||||
|
|
|
|
|
|
|
|
|
|
|
||||
Running current |
1 |
|
|
Cooling |
A |
|
7.4 |
|
|
|
6.8 |
|||
Electrical |
|
|
|
|
|
|
||||||||
Power factor 1 (Total) |
|
Heating |
|
|
|
96 |
|
|
||||||
|
% |
|
|
|
|
|
||||||||
|
(Total) |
|
|
|
|
Heating |
|
|
|
|
7.4 |
|
|
|
|
|
|
|
|
|
Cooling |
|
|
96 |
|
|
|
94 |
|
|
|
|
|
|
|
|
|
|
|
|
|
|||
|
Starting current |
1 (Total) |
A |
|
|
|
7.4 |
|
|
|||||
Coefficient of performance |
|
|
Cooling |
|
3.05 |
|
|
|
3.24 |
|||||
(COP) 1 (Total) |
|
|
|
|
Heating |
|
|
|
3.52 |
|
|
|||
|
|
Model |
|
|
|
|
|
|
|
SNB130FGBHT |
|
|
||
|
|
Output |
|
|
|
W |
|
|
|
900 |
|
|
||
Compressor |
Current |
1 |
|
Cooling |
A |
|
6.69 |
|
|
|
6.09 |
|||
|
Heating |
|
|
|
6.72 |
|
|
|||||||
|
|
|
|
|
|
|
|
|||||||
|
|
Refrigeration oil |
L |
|
|
|
0.45 (NEO22) |
|
|
|||||
|
|
(Model) |
|
|
|
|
|
|
|
|
||||
|
|
|
|
|
|
|
|
|
|
|
|
|
||
Fan motor |
Model |
|
|
|
|
|
|
|
RC0J60-AA |
|
|
|||
Current |
1 |
|
Cooling |
A |
|
|
|
0.32 |
|
|
||||
|
|
|
Heating |
|
|
|
0.32 |
|
|
|||||
|
|
|
|
|
|
|
|
|
|
|
|
|||
Dimensions W × H × D |
|
|
|
mm |
|
|
|
840 × 850 × 330 |
|
|
||||
Weight |
|
|
|
|
|
kg |
|
|
|
54 |
|
|
||
|
Dehumidification |
|
|
|
Cooling |
L/h |
|
1.8 |
|
|
|
1.6 |
||
|
|
Cooling |
|
|
High |
|
|
|
|
|
– |
|
|
|
|
|
|
|
Med. |
|
|
|
|
2,940 |
|
|
|||
|
Air flow 1 |
|
|
|
|
Low |
m3/h |
|
|
|
1,740 |
|
|
|
|
Heating |
|
|
High |
|
|
|
|
– |
|
|
|||
|
|
|
|
|
|
|
|
|
|
|
||||
remarks |
|
|
|
Med. |
|
|
|
|
2,940 |
|
|
|||
|
|
|
|
|
Low |
|
|
|
|
2,142 |
|
|
||
Sound level |
1 |
|
|
|
Heating |
dB(A) |
|
|
|
56 |
|
|
||
|
|
|
|
|
|
Cooling |
|
|
|
|
54 |
|
|
|
Special |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
High |
|
|
|
|
|
– |
|
|
|
|
Cooling |
|
|
Med. |
|
|
|
|
780 |
|
|
|||
|
|
|
|
|
|
|
|
|
|
|||||
|
Fan speed |
|
|
|
|
Low |
rpm |
|
|
|
480 |
|
|
|
|
Heating |
|
|
High |
|
|
|
|
– |
|
|
|||
|
|
|
|
|
|
|
|
|
|
|
||||
|
|
|
|
Med. |
|
|
|
|
780 |
|
|
|||
|
|
|
|
|
|
Low |
|
|
|
|
580 |
|
|
|
|
Fan speed regulator |
|
|
|
|
|
|
|
|
2 |
|
|
||
|
Refrigerant filling capacity |
kg |
|
|
|
1.55 |
|
|
||||||
|
(R410A) |
|
|
|
|
|
|
|
|
|
|
|||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
NOTE: Test conditions are based on AS/NZS 3823.1.1. |
|
|
|
|
|
|||||||||
|
Cooling: Indoor |
Dry-bulb temperature 27°C |
Wet-bulb temperature |
19°C |
|
|
||||||||
|
|
Outdoor Dry-bulb temperature 35°C |
Wet-bulb temperature |
(24°C) |
|
|
||||||||
|
Heating: Indoor |
Dry-bulb temperature 20°C |
Wet-bulb temperature |
15.5°C |
|
|
||||||||
|
|
Outdoor Dry-bulb temperature |
7°C |
Wet-bulb temperature |
6°C |
|
|
|||||||
|
Refrigerant piping length (one way): 5 m |
|
|
|
|
|
|
|||||||
|
1 Measured under rated operating frequency. |
|
|
|
|
|
OBH532E |
8 |
|
Outdoor model
Power supply
Capacity |
|
|
|
|
Cooling |
kW |
|||
Rated frequency (Min.-Max.) |
|
||||||||
Heating |
|||||||||
Breaker Capacity |
|
|
|
|
A |
||||
data |
Power input |
|
1 (Total) |
Cooling |
W |
||||
|
Heating |
||||||||
|
|
|
|
|
|
|
|||
Running current |
1 |
|
Cooling |
A |
|||||
Electrical |
|
||||||||
Power factor |
1 (Total) |
Heating |
|||||||
% |
|||||||||
|
(Total) |
|
|
|
|
Heating |
|
||
|
|
|
|
|
|
|
Cooling |
|
|
|
Starting current |
|
|
|
|||||
|
1 (Total) |
A |
|||||||
|
|
|
|
|
|
|
|
|
|
Coefficient of performance |
|
Cooling |
|||||||
(COP) 1 (Total) |
|
|
|
Heating |
|||||
|
|
|
Model |
|
|
|
|||
|
|
|
Output |
|
|
W |
|||
Compressor |
|
Current |
1 |
Cooling |
A |
||||
|
Heating |
||||||||
|
|
|
|||||||
|
|
|
Refrigeration |
oil |
L |
||||
|
|
|
(Model) |
|
|
||||
|
|
|
|
|
|
||||
Fan motor |
|
Model |
|
|
|
||||
|
Current |
1 |
Cooling |
A |
|||||
|
|
|
Heating |
||||||
Dimensions W × |
|
H × D |
|
|
mm |
||||
Weight |
|
|
|
|
|
kg |
|||
|
Dehumidification |
|
|
Cooling |
L/h |
||||
|
|
|
|
Cooling |
|
High |
|
||
|
|
|
|
|
Med. |
|
|||
|
Air flow 1 |
|
|
|
|
|
Low |
m3/h |
|
|
|
|
Heating |
|
High |
||||
|
|
|
|
|
|
||||
remarks |
|
|
|
|
Med. |
|
|||
|
|
|
|
|
|
Low |
|
||
Sound level |
|
1 |
|
|
Heating |
dB(A) |
|||
|
|
|
|
|
|
|
Cooling |
|
|
Special |
|
|
|
|
|
|
High |
|
|
|
|
|
|
|
|
|
|||
|
|
|
Cooling |
|
Med. |
|
|||
|
|
|
|
|
|
||||
|
Fan speed |
|
|
|
|
|
Low |
rpm |
|
|
|
|
Heating |
|
High |
||||
|
|
|
|
|
|
||||
|
|
|
|
|
Med. |
|
|||
|
Fan speed |
|
regulator |
|
Low |
|
|||
|
|
|
|
|
|||||
|
Refrigerant filling capacity |
kg |
|||||||
|
(R410A) |
|
|
|
|
|
|||
|
|
|
|
|
|
|
MUZ-GE60VA MUZ-GE60VAD MUZ-GE71VA MUZ-GE71VAD MUZ-GE80VA MUZ-GE80VA2 MUZ-GE80VAD
Single phase, 230 V, 50 Hz
6.0 (1.5 - 7.5) |
7.1 (2.4- 8.7) |
|
8.0 (2.4 - 9.2) |
|
7.8 (2.4 - 9.2) |
||||||
6.8 (2.0 - 9.3) |
8.1 (2.2 - 9.9) |
|
9.0 (2.2 - 11.1) |
|
|||||||
|
|
|
|
20 |
|
|
|
|
|
|
|
|
1,760 |
|
2,130 |
|
2,560 |
|
2,460 |
|
|||
|
1,770 |
|
2,110 |
|
2,540 |
|
2,550 |
|
|||
|
7.8 |
|
9.4 |
|
11.3 |
|
10.8 |
|
|||
|
7.8 |
|
9.5 |
|
|
|
11.2 |
|
|
||
|
98 |
|
99 |
|
98 |
|
99 |
|
|||
|
98 |
|
97 |
|
|
|
99 |
|
|
||
|
7.8 |
|
9.5 |
|
11.3 |
|
11.2 |
|
|||
3.40 |
|
3.41 |
|
3.33 |
|
3.12 |
|
3.17 |
|
||
|
|
|
|
|
|
|
|
|
|
|
|
|
3.84 |
3.83 |
|
3.84 |
|
3.54 |
|
3.53 |
|
||
SNB130FGBMT |
|
|
|
SNB172FEKMT |
|
|
|
||||
|
900 |
|
|
|
1,200 |
|
|
|
|
||
6.62 |
|
6.44 |
8.02 |
|
8.06 |
|
9.89 |
|
9.39 |
|
9.43 |
6.37 |
|
6.34 |
8.13 |
|
8.17 |
|
9.83 |
|
|
9.87 |
|
0.35 (FV50S) |
|
|
|
|
0.4 (FV50S) |
|
|
|
|||
|
|
|
|
|
RC0J60-BC |
|
|
|
|||
|
|
|
|
|
|
|
|
||||
0.84 |
|
0.93 |
|
0.83 |
|
|
|
0.86 |
|
|
|
|
0.93 |
|
|
|
0.82 |
|
|
|
|
||
|
|
|
|
840 × 880 × 330 |
|
|
|
|
|||
|
50 |
|
|
|
53 |
|
|
|
|
||
|
1.9 |
|
2.2 |
|
2.9 |
|
2.7 |
|
|||
|
3,492 |
|
|
|
3,426 |
|
|
|
|
||
|
3,066 |
|
|
|
3,006 |
|
|
|
|
||
|
1,692 |
|
|
|
1,512 |
|
|
|
|
||
|
2,952 |
|
|
|
2,892 |
|
|
|
|
||
|
2,952 |
|
|
|
2,892 |
|
|
|
|
||
|
2,226 |
|
|
|
2,280 |
|
|
|
|
||
|
|
|
|
55 |
|
|
|
|
|
|
|
|
|
|
|
55 |
|
|
|
|
|
|
|
|
|
|
|
950 |
|
|
|
|
|
|
|
|
|
|
|
840 |
|
|
|
|
|
|
|
|
480 |
|
|
|
450 |
|
|
|
|
||
|
|
|
|
810 |
|
|
|
|
|
|
|
|
|
|
|
810 |
|
|
|
|
|
|
|
|
620 |
|
|
|
650 |
|
|
|
|
||
|
|
|
|
3 |
|
|
|
|
|
|
|
|
1.55 |
|
|
|
1.90 |
|
|
|
|
||
|
|
|
|
|
|
|
|
|
|
|
|
NOTE: Test conditions are based on AS/NZS 3823.1.1. |
|
|
|
Cooling: Indoor |
Dry-bulb temperature 27°C |
Wet-bulb temperature |
19°C |
Outdoor |
Dry-bulb temperature 35°C |
Wet-bulb temperature |
(24°C) |
Heating: Indoor |
Dry-bulb temperature 20°C |
Wet-bulb temperature |
15.5°C |
Outdoor Dry-bulb temperature 7°C |
Wet-bulb temperature |
6°C |
|
Refrigerant piping length (one way): 5 m |
|
|
|
1 Measured under rated operating frequency. |
|
|
OBH532E |
9 |
|
Specifications and rated conditions of main electric parts
Item |
Model |
MUZ- |
MUZ- |
MUZ- |
|
|
MUZ- |
MUZ- |
|
MUZ- |
|
MUZ- |
MUZ- |
|
MUZ- |
|
MUZ- |
MUZ- |
|||||
|
GE25VA |
GE25VAD |
GE33VA |
|
GE35VA |
GE35VA2 |
GE35VAD |
GE42VA |
GE42VAD |
GE50VA |
GE50VA2 |
GE50VAD |
|||||||||||
Smoothing |
(C62, C63) |
|
|
600 μF/620 μF 420 V |
|
|
|
|
|
|
|
|
— |
|
|
|
|
||||||
capacitor |
(C61) |
|
|
|
— |
|
|
|
|
|
600 μF/620 μF 420 V |
|
|||||||||||
Diode module |
(DB61) |
|
|
|
|
|
|
15 A 600 V |
|
|
|
|
|
|
|
|
|
25 A 600 V |
|||||
(DB65) |
|
|
|
|
|
|
|
|
|
25 A 600 V |
|
|
|
|
|
|
|
|
|
|
|||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
||||
|
(F62) |
|
|
|
|
|
|
|
|
|
|
— |
|
|
|
|
|
|
|
|
|
|
|
Fuse |
(F61) |
|
|
|
|
|
|
|
|
|
T20AL250V |
|
|
|
|
|
|
|
|
|
|
||
(F701, F801, F901) |
|
|
|
|
|
|
|
T3.15AL250V |
|
|
|
|
|
|
|
|
|||||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
||||||||
|
(F601,F880, F901) |
|
|
|
|
|
|
|
|
|
|
— |
|
|
|
|
|
|
|
|
|
|
|
Intelligent |
(IC932) |
|
|
|
|
|
|
|
|
|
|
— |
|
|
|
|
|
|
|
|
|
|
|
power module / |
(IPM) |
|
|
|
15 A 600 V |
|
|
|
|
|
20 A 600 V |
|
|||||||||||
Power module |
|
|
|
|
|
|
|
|
|
||||||||||||||
1. |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
Expansion valve |
(LEV) |
|
|
|
|
|
|
|
|
|
|
12 VDC |
|
|
|
|
|
|
|
|
|
|
|
coil |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
Reactor |
(L61) |
18 mH |
|
|
|
|
|
|
|
|
|
23 mH |
|
|
|
|
|
|
|
|
|||
(L) |
|
|
|
|
|
|
|
|
|
|
— |
|
|
|
|
|
|
|
|
|
|
||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|||
Power factor |
(PFC) |
|
|
|
|
|
|
|
|
|
|
— |
|
|
|
|
|
|
|
|
|
|
|
controller |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
Current-limiting |
(PTC64, PTC65) |
|
|
|
|
|
|
|
|
|
|
33 Ω |
|
|
|
|
|
|
|
|
|
|
|
PTC thermistor |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
Terminal block |
(TB1, TB2) |
|
|
|
|
|
|
|
|
|
|
3 P |
|
|
|
|
|
|
|
|
|
|
|
|
(X63) |
|
|
|
|
|
|
|
|
|
3 A 250 V |
|
|
|
|
|
|
|
|
|
|
||
Relay |
(X64) |
|
|
|
|
|
|
|
|
|
20 A 250 V |
|
|
|
|
|
|
|
|
|
|
||
(X601) |
|
|
|
|
|
|
|
|
|
|
— |
|
|
|
|
|
|
|
|
|
|
||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|||
|
(X602) |
|
|
|
|
|
|
|
|
|
|
— |
|
|
|
|
|
|
|
|
|
|
|
R.V.coil |
(21S4) |
|
|
|
|
|
|
|
220 - 240 VAC |
|
|
|
|
|
|
|
|
||||||
IGBT |
(TR821) |
|
|
|
|
|
|
|
|
|
30 A 600 V |
|
|
|
|
|
|
|
|
|
|
||
|
|
|
|
|
|
|
1. |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
||
|
|
|
|
|
|
|
|
Intelligent power module: MUZ-GE25VA - A1 , MUZ-GE35/50VA |
|||||||||||||||
|
|
|
|
|
|
|
|
Power module: Other models |
|
|
|
|
|
|
|
|
|||||||
Specifications and rated conditions of main electric parts |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
||||||
Item |
Model |
MUZ-GE60VA |
MUZ-GE60VAD |
|
MUZ-GE71VA |
|
MUZ-GE71VAD |
|
MUZ-GE80VA |
MUZ-GE80VA2 |
MUZ-GE80VAD |
||||||||||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
Smoothing |
(C61, C62, C63) |
|
|
|
|
|
|
|
|
|
|
— |
|
|
|
|
|
|
|
|
|
|
|
capacitor |
(CB1, CB2, CB3) |
|
|
|
|
|
|
|
560 μF 450 V |
|
|
|
|
|
|
|
|
||||||
Diode module |
(DB61) |
|
|
|
|
|
|
|
|
|
|
— |
|
|
|
|
|
|
|
|
|
|
|
(DB65) |
|
|
|
|
|
|
|
|
|
|
— |
|
|
|
|
|
|
|
|
|
|
||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|||
|
(F62) |
T2.0AL250V |
|
— |
|
T2.0AL250V |
|
|
— |
|
|
T2.0AL250V |
|
|
|
— |
|||||||
Fuse |
(F61) |
|
|
|
|
|
|
|
|
|
|
— |
|
|
|
|
|
|
|
|
|
|
|
(F701, F801, F901) |
|
|
|
|
|
|
|
|
|
|
— |
|
|
|
|
|
|
|
|
|
|
||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|||
|
(F601,F880, F901) |
|
|
|
|
|
|
|
T3.15AL250V |
|
|
|
|
|
|
|
|
||||||
Intelligent power |
(IC932) |
|
|
|
|
|
|
|
|
|
5A 600 V |
|
|
|
|
|
|
|
|
|
|
||
module |
(IPM) |
20 A 600 V |
|
— |
|
20 A 600 V |
|
|
— |
|
|
20 A 600 V |
|
|
|
— |
|||||||
IGBT module |
(IC700) |
— |
|
20 A 600 V |
|
— |
|
20 A 600 V |
|
|
— |
|
|
|
20 A 600 V |
||||||||
Expansion valve |
(LEV) |
|
|
|
|
|
|
|
|
|
|
12 VDC |
|
|
|
|
|
|
|
|
|
|
|
coil |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
Reactor |
(L61) |
|
|
|
|
|
|
|
|
|
|
— |
|
|
|
|
|
|
|
|
|
|
|
(L) |
|
|
|
|
|
|
|
|
|
|
340 μH |
|
|
|
|
|
|
|
|
|
|
||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|||
Power factor |
(PFC) |
20 A 600 V |
|
— |
|
20 A 600 V |
|
|
— |
|
|
20 A 600 V |
|
|
|
— |
|||||||
controller |
(IC820) |
— |
|
20 A 600 V |
|
— |
|
20 A 600 V |
|
|
— |
|
|
|
20 A 600 V |
||||||||
Current-limiting |
(PTC64, PTC65) |
|
|
|
|
|
|
|
|
|
|
33 Ω |
|
|
|
|
|
|
|
|
|
|
|
PTC thermistor |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
Terminal block |
(TB1, TB2) |
|
|
|
|
|
|
|
|
|
|
3 P |
|
|
|
|
|
|
|
|
|
|
|
|
(X63) |
|
|
|
|
|
|
|
|
|
|
— |
|
|
|
|
|
|
|
|
|
|
|
Relay |
(X64) |
|
|
|
|
|
|
|
|
|
20 A 250 V |
|
|
|
|
|
|
|
|
|
|
||
(X601) |
|
|
|
|
|
|
|
|
|
3 A 250V |
|
|
|
|
|
|
|
|
|
|
|||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
||||
|
(X602) |
|
|
|
|
|
|
|
|
|
3 A 250V |
|
|
|
|
|
|
|
|
|
|
||
R.V.coil |
(21S4) |
|
|
|
|
|
|
|
220 - 240 VAC |
|
|
|
|
|
|
|
|
||||||
IGBT |
(TR821) |
|
|
|
|
|
|
|
|
|
|
— |
|
|
|
|
|
|
|
|
|
|
OBH532E |
10 |
|
4 NOISE CRITERIA CURVES
MUZ-GE25VA
MUZ-GE25VAD FUNCTION SPL(dB(A)) LINE
|
|
|
|
COOLING |
46 |
|
|
|
|
|
|
|
HEATING |
48 |
|
|
|
|
90 |
|
|
|
|
|
|
|
Pa |
80 |
|
|
|
|
|
|
|
20μ |
|
|
|
|
|
|
|
|
0 dB = |
70 |
|
|
|
|
|
|
NC-70 |
LEVEL, |
60 |
|
|
|
|
|
|
NC-60 |
PRESSURE |
|
|
|
|
|
|
|
|
50 |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
NC-50 |
|
|
|
|
|
|
|
|
|
|
SOUND |
40 |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
NC-40 |
|
BAND |
30 |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
NC-30 |
|
OCTAVE |
|
|
|
|
|
|
|
|
20 |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
NC-10 |
|
NC-20 |
|
|
|
|
|
|
|
|
||
|
10 |
125 |
250 |
500 |
1000 |
2000 |
4000 |
8000 |
|
63 |
BAND CENTER FREQUENCIES, Hz
MUZ-GE35VA2 |
|
|
MUZ-GE35VAD |
FUNCTION |
SPL(dB(A)) LINE |
|
|
|
|
|
COOLING |
47 |
|
|
|
|
|
|
|
HEATING |
48 |
|
|
|
|
90 |
|
|
|
|
|
|
|
Pa |
80 |
|
|
|
|
|
|
|
20μ |
|
|
|
|
|
|
|
|
0 dB = |
70 |
|
|
|
|
|
|
NC-70 |
LEVEL, |
60 |
|
|
|
|
|
|
NC-60 |
PRESSURE |
|
|
|
|
|
|
|
|
50 |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
NC-50 |
|
|
|
|
|
|
|
|
|
|
SOUND |
40 |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
NC-40 |
|
BAND |
30 |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
NC-30 |
|
OCTAVE |
|
|
|
|
|
|
|
|
20 |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
NC-10 |
|
NC-20 |
|
|
|
|
|
|
|
|
||
|
10 |
125 |
250 |
500 |
1000 |
2000 |
4000 |
8000 |
|
63 |
BAND CENTER FREQUENCIES, Hz
MUZ-GE33VA
MUZ-GE35VA |
|
FUNCTION SPL(dB(A)) LINE |
|
|
|
|
COOLING |
47 |
|
|
|
|
|
|
|
HEATING |
48 |
|
|
|
|
90 |
|
|
|
|
|
|
|
Pa |
80 |
|
|
|
|
|
|
|
20μ |
|
|
|
|
|
|
|
|
0 dB = |
70 |
|
|
|
|
|
|
NC-70 |
LEVEL, |
60 |
|
|
|
|
|
|
NC-60 |
PRESSURE |
|
|
|
|
|
|
|
|
50 |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
NC-50 |
|
|
|
|
|
|
|
|
|
|
SOUND |
40 |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
NC-40 |
|
BAND |
30 |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
NC-30 |
|
OCTAVE |
|
|
|
|
|
|
|
|
20 |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
NC-10 |
|
NC-20 |
|
|
|
|
|
|
|
|
||
|
10 |
125 |
250 |
500 |
1000 |
2000 |
4000 |
8000 |
|
63 |
BAND CENTER FREQUENCIES, Hz
MUZ-GE42VA |
FUNCTION |
SPL(dB(A)) LINE |
|
MUZ-GE42VAD |
|||
COOLING |
50 |
||
|
|||
|
HEATING |
51 |
|
90 |
|
|
|
|
|
|
|
Pa |
80 |
|
|
|
|
|
|
|
0dB = 20 μ |
70 |
|
|
|
|
|
|
NC-70 |
LEVEL, |
60 |
|
|
|
|
|
|
NC-60 |
PRESSURE |
|
|
|
|
|
|
|
|
50 |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
NC-50 |
|
|
|
|
|
|
|
|
|
|
SOUND |
40 |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
NC-40 |
|
BAND |
30 |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
NC-30 |
|
OCTAVE |
|
|
|
|
|
|
|
|
20 |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
NC-10 |
|
NC-20 |
|
|
|
|
|
|
|
|
||
|
10 |
125 |
250 |
500 |
1000 |
2000 |
4000 |
8000 |
|
63 |
BAND CENTER FREQUENCIES, Hz
OBH532E |
11 |
|
MUZ-GE50VA
MUZ-GE50VA2 |
|
|
|
|
|
FUNCTION |
SPL(dB(A)) |
LINE |
|
||
MUZ-GE50VAD |
|
|
|
|
|
COOLING |
54 |
|
|
|
|
|
|
||||
|
HEATING |
56 |
|
|
|
|
90 |
|
|
|
|
|
|
|
Pa |
80 |
|
|
|
|
|
|
|
20μ |
|
|
|
|
|
|
|
|
0 dB = |
70 |
|
|
|
|
|
|
NC-70 |
LEVEL, |
60 |
|
|
|
|
|
|
NC-60 |
PRESSURE |
|
|
|
|
|
|
|
|
50 |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
NC-50 |
|
|
|
|
|
|
|
|
|
|
SOUND |
40 |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
NC-40 |
|
BAND |
30 |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
NC-30 |
|
OCTAVE |
|
|
|
|
|
|
|
|
20 |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
NC-10 |
|
NC-20 |
|
|
|
|
|
|
|
|
||
|
10 |
125 |
250 |
500 |
1000 |
2000 |
4000 |
8000 |
|
63 |
BAND CENTER FREQUENCIES, Hz
MUZ-GE71VA
MUZ-GE71VAD FUNCTION |
SPL(dB(A)) LINE |
COOLING |
55 |
HEATING |
55 |
|
90 |
|
|
|
|
|
|
|
Pa |
80 |
|
|
|
|
|
|
|
20μ |
|
|
|
|
|
|
|
|
= |
|
|
|
|
|
|
|
|
0 dB |
70 |
|
|
|
|
|
|
NC-70 |
|
|
|
|
|
|
|
||
LEVEL, |
60 |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
NC-60 |
|
PRESSURE |
|
|
|
|
|
|
|
|
50 |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
NC-50 |
|
|
|
|
|
|
|
|
|
|
SOUND |
40 |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
NC-40 |
|
|
|
|
|
|
|
|
|
|
BAND |
30 |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
NC-30 |
|
OCTAVE |
|
|
|
|
|
|
|
|
20 |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
NC-20 |
|
|
|
|
|
|
NC-10 |
|
||
|
|
|
|
|
|
|
||
|
10 |
125 |
250 |
500 |
1000 |
2000 |
4000 |
8000 |
|
63 |
BAND CENTER FREQUENCIES, Hz
MUZ-GE60VA
MUZ-GE60VAD |
FUNCTION |
SPL(dB(A)) LINE |
|
COOLING |
55 |
|
HEATING |
55 |
|
90 |
|
|
|
|
|
|
|
Pa |
80 |
|
|
|
|
|
|
|
20μ |
|
|
|
|
|
|
|
|
= |
|
|
|
|
|
|
|
|
0 dB |
70 |
|
|
|
|
|
|
NC-70 |
|
|
|
|
|
|
|
||
LEVEL, |
60 |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
NC-60 |
|
PRESSURE |
|
|
|
|
|
|
|
|
50 |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
NC-50 |
|
|
|
|
|
|
|
|
|
|
SOUND |
40 |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
NC-40 |
|
|
|
|
|
|
|
|
|
|
BAND |
30 |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
NC-30 |
|
OCTAVE |
|
|
|
|
|
|
|
|
20 |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
NC-20 |
|
|
|
|
|
|
NC-10 |
|
||
|
|
|
|
|
|
|
||
|
10 |
125 |
250 |
500 |
1000 |
2000 |
4000 |
8000 |
|
63 |
BAND CENTER FREQUENCIES, Hz
MUZ-GE80VA
MUZ-GE80VA2 |
|
|
|
|
|
FUNCTION |
SPL(dB(A)) |
LINE |
|
||
MUZ-GE80VAD |
|
|
|
|
|
COOLING |
55 |
|
|
|
|
|
|
||||
|
HEATING |
55 |
|
|
|
|
|
|
|
|
|
|
90 |
|
|
|
|
|
|
|
|
Pa |
80 |
|
|
|
|
|
|
|
|
20μ |
|
|
|
|
|
|
|
|
|
= |
|
|
|
|
|
|
|
|
|
0 dB |
70 |
|
|
|
|
|
|
|
NC-70 |
|
|
|
|
|
|
|
|
||
LEVEL, |
60 |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
NC-60 |
|
BAND SOUND PRESSURE |
|
|
|
|
OCTAVE BAND SOUND |
|
|
|
|
50 |
|
|
|
40 |
|
|
|
||
|
|
|
|
|
|
|
NC-50 |
||
40 |
|
|
|
30 |
|
|
|
||
|
|
|
|
|
|
|
NC-40 |
||
30 |
|
|
|
20 |
|
|
|
||
|
|
|
|
|
|
|
NC-30 |
||
OCTAVE |
|
|
|
|
|
|
|
|
|
20 |
|
|
|
|
10 |
63 |
125 |
25 |
|
|
|
|
|
|
|
||||
|
|
|
|
|
|
|
|
|
NC-20 |
|
|
|
|
|
|
NC-10 |
|
BAND |
|
|
10 |
125 |
250 |
500 |
|
1000 |
2000 |
4000 |
8000 |
|
63 |
|
BAND CENTER FREQUENCIES, Hz
Test conditions |
|
|
Cooling: Dry-bulb temperature 35°C |
Wet-bulb temperature |
(24°C) |
Heating: Dry-bulb temperature 7°C |
Wet-bulb temperature |
6°C |
OUTDOOR UNIT
1 m MICROPHONE
OBH532E |
12 |
|
5 OUTLINES AND DIMENSIONS
MUZ-GE25VA MUZ-GE25VAD MUZ-GE33VA
MUZ-GE35VA MUZ-GE35VA2 MUZ-GE35VAD MUZ-GE42VA
REQUIRED SPACE
Unit: mm
MUZ-GE42VAD
Basically open 100 mm or more without any obstruction in front and on both sides of the unit.
400 |
Drain hole ø42 |
|
Air in |
||
|
100 |
mm |
|
|
|
or |
|
more |
ormore mm 100
344.5 |
285 |
Air
44 in
Bolt pitch for installation 304~325
ormore mm 200
350 |
mm |
|
|
|
or |
|
more |
|
|
|
40 |
17.5 |
|
|
|
|
Open two sides of left, |
|
2 holes 10 X 21 |
|
|
|
|
right, or rear side. |
|||
|
|
|
|
|
|
||||
|
|
|
|
|
|
|
|||
|
22.3 |
Air out |
|
|
|
23 |
Service panel |
||
|
|
|
|
|
|
|
|||
|
Handle |
|
|
|
|
|
|
Liquid refrigerant pipe joint |
|
|
|
|
|
|
|
|
|
Refrigerant pipe (flared) ø6.35 |
|
550 |
|
|
|
|
|
|
|
35 |
43 |
|
|
|
|
|
|
|
|
||
280 |
10 |
|
|
|
164.5 |
|
|
Gas refrigerant pipe joint |
|
|
|
|
|
|
|
|
|
Refrigerant pipe (flared) ø9.52 |
|
|
|
150 |
|
69 |
|
99.5 |
170.5 |
|
|
|
|
|
|
|
|
|
|||
|
|
|
|
|
|
|
|
|
|
|
|
302.5 |
|
|
|
|
Service port |
|
|
|
|
500 Bolt pitch for installation |
|
|
|
|
|
|
|
|
|
800 |
|
|
|
|
|
|
|
MUZ-GE50VA MUZ-GE50VA2 MUZ-GE50VAD |
|
Open as a rule |
|||||||
|
|
|
|
|
|
|
|
|
500 mm or more if |
|
|
|
|
|
|
|
|
|
the front and both |
|
|
|
|
|
|
REQUIRED SPACE |
sides are open |
||
|
|
515 |
|
|
|
|
|
|
|
|
66 |
299 |
Drain holes ø33 |
|
|
|
|
|
100 mm or more |
|
|
|
|
|
|
|
|||
|
Air in |
|
|
|
|
|
|
200 mm or more if |
|
|
|
40 |
|
|
|
|
|
||
|
51 34 |
|
|
|
|
|
|
there are obstacles |
|
|
|
|
|
|
|
|
|
||
|
|
|
|
|
|
|
|
to both sides |
|
|
|
|
|
|
|
|
|
|
|
330 |
Air in |
|
|
360 |
100 |
mm |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
or |
more |
|
|
|
|
|
|
|
|
|
|
850
430
170 |
Air out 500 |
4 holes 10 × 21 |
|
||
|
840 |
80 |
|
121 |
|
Open as a rule
500 mm or more if the back, both sides and top are open
155 |
90 |
350 |
mm |
|
|
|
or |
|
more |
Service panel
Liquid refrigerant pipe joint Refrigerant pipe (flared) ø6.35
30° 35°
Gas refrigerant pipe joint Refrigerant pipe
198 (flared) ø12.7
OBH532E |
13 |
|
MUZ-GE60VA MUZ-GE60VAD MUZ-GE71VA MUZ-GE71VAD MUZ-GE80VA MUZ-GE80VA2 MUZ-GE80VAD
Unit: mm
REQUIRED SPACE
500 mm or more
417.5
Air in
330 |
50 |
Air out
175 500
Drain hole |
42 |
40 |
|
|
100 |
mm |
|
|
|
|
|
or |
360 |
|
more |
2-holes 1021
500 mm or more
100 mm or more
350 |
mm |
|
|
|
or |
|
more |
880
452
840 |
81 |
109
164.5 |
99.5 |
Service panel
Liquid refrigerant pipe joint Refrigerant pipe
(flared) Ø 6.35 (MUZ-GE60)
Ø 9.52 (MUZ-GE71/80)
35
44
Gas refrigerant
195pipe joint Refrigerant pipe
(flared) Ø 15.88
OBH532E |
14 |
|
6 WIRING DIAGRAM
MUZ-GE25VA - A1 MUZ-GE35VA
OBH532E |
15 |
|
MUZ-GE33VA
OBH532E |
16 |
|
MUZ-GE25VA - A2 MUZ-GE35VA2
OBH532E |
17 |
|
MUZ-GE25VAD MUZ-GE35VAD
OBH532E |
18 |
|
MUZ-GE42VA
OBH532E |
19 |
|
MUZ-GE42VAD
OBH532E |
20 |
|
MUZ-GE50VA
OBH532E |
21 |
|
MUZ-GE50VA2
OBH532E |
22 |
|
MUZ-GE50VAD
OBH532E |
23 |
|
MUZ-GE60VA MUZ-GE71VA MUZ-GE80VA
OBH532E |
24 |
|
MUZ-GE80VA2
OBH532E |
25 |
|
MUZ-GE60VAD MUZ-GE71VAD MUZ-GE80VAD
OBH532E |
26 |
|
7 REFRIGERANT SYSTEM DIAGRAM
MUZ-GE25VA MUZ-GE25VAD MUZ-GE33VA MUZ-GE35VA
Unit: mm
Refrigerant pipe |
ø9.52 |
|
|
4-way valve |
|
|
|
|
|
|
|
|
|
|
|
|
||||
(with heat insulator) |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
||||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
||
|
|
Muffler |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
Outdoor heat |
|||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
Stop valve |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
exchanger |
||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
temperature |
|||
|
|
(with service port) |
|
|
|
|
Muffler |
|
Outdoor |
thermistor |
||||||||||
Flared connection |
|
|
|
|
Discharge |
|
|
|
|
|
|
|
|
heat |
RT68 |
|||||
|
|
|
|
|
|
|
|
|
|
|
|
|||||||||
|
|
|
|
|
|
temperature |
|
|
|
|
|
|
|
exchanger |
|
|||||
|
|
|
|
|
|
thermistor |
|
|
|
|
|
|
|
|
|
|
|
|
||
|
|
|
|
|
|
RT62 |
Compressor |
|
|
|
|
|
Ambient |
|||||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|||||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
temperature |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
thermistor |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
Defrost |
|
|
|
|
|
RT65 |
|||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
||||
|
|
|
|
|
|
|
|
|
|
|
thermistor |
|
||||||||
|
|
|
|
|
|
|
|
|
|
|
RT61 |
|
|
|
|
|
|
|||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
Strainer |
||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|||
Flared connection |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
#100 |
|
|||
Capillary tube |
LEV |
|
|
|
|
|
|
|
|
|
R.V. coil |
|||||||||
|
|
|
|
|
|
|
|
|
|
|
||||||||||
|
|
ø3.0×ø2.0×240 |
|
|
|
|
|
|
|
|
|
|
|
|||||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
heating ON |
||
|
|
Stop valve |
|
|
|
|
|
|
|
|
|
|
|
|
cooling OFF |
|||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
||||
Refrigerant pipe |
ø6.35 (with strainar) |
|
|
|
|
|
|
|
|
|
Refrigerant flow in cooling |
|||||||||
|
|
|
|
|
|
|
|
|
||||||||||||
(with heat insulator) |
|
|
|
|
|
|
|
|
|
|
|
|
|
Refrigerant flow in heating |
MUZ-GE35VA2 MUZ-GE35VAD MUZ-GE42VA MUZ-GE42VAD
Refrigerant pipe ø9.52 |
4-way valve |
|
|
|
|
(with heat insulator) |
|
|
|
||
|
|
|
|
|
|
|
Muffler |
|
|
|
Outdoor heat |
|
|
|
|
|
|
|
Stop valve |
|
|
|
exchanger |
|
|
|
|
temperature |
|
|
(with service port) |
|
|
|
|
Flared connection |
|
Muffler |
Outdoor |
thermistor |
|
Discharge |
|
heat |
RT68 |
||
|
temperature |
exchanger |
|
||
|
thermistor |
|
|
|
|
|
RT62 |
|
Compressor |
|
Ambient |
|
|
|
|
||
|
|
|
|
|
temperature |
|
|
|
|
|
thermistor |
|
|
|
Defrost |
|
RT65 |
|
|
|
|
|
|
|
|
|
thermistor |
|
|
|
|
|
RT61 |
|
|
|
|
|
Capillary tube |
|
|
|
|
|
ø3.0×ø1.8×600(×2) |
|
|
|
|
|
|
Strainer |
|
Flared connection |
|
LEV |
|
#100 |
|
Capillary tube |
|
|
|
||
|
|
R.V. coil |
|||
|
ø3.0×ø2.0×240 |
|
|
||
|
|
|
|
heating ON |
|
|
Stop valve |
|
|
cooling OFF |
|
|
|
|
|
|
|
Refrigerant pipe ø6.35 |
(with strainar) |
|
|
Refrigerant flow in cooling |
|
(with heat insulator) |
|
|
|
Refrigerant flow in heating |
OBH532E |
27 |
|
MUZ-GE50VA MUZ-GE50VA2 MUZ-GE50VAD |
|
Unit: mm |
||
Refrigerant pipe ø12.7 |
|
Muffler |
|
|
4-way valve |
#100 |
|
|
|
(with heat insulator) |
|
|
||
|
|
|
|
|
|
Stop valve |
|
|
|
Flared connection |
(with service port) |
Discharge |
Outdoor |
|
|
heat |
Ambient |
||
|
|
temperature |
exchanger |
temperature |
|
|
thermistor |
Defrost |
thermistor |
|
|
RT62 |
thermistor |
RT65 |
|
|
|
RT61 |
|
|
Compressor |
Outdoor heat |
|
|
|
||
|
|
exchanger |
|
|
|
temperature |
|
|
|
thermistor |
|
Flared connection |
|
RT68 |
|
LEV Strainer |
|
||
Receiver |
R.V. coil |
||
#100 |
|||
|
|
heating ON |
|
Stop valve |
Capillary tube |
cooling OFF |
|
|
|||
Refrigerant pipe ø6.35 (with strainar) |
ø3.6×ø2.4×50 |
Refrigerant flow in cooling |
|
(with heat insulator) |
|
Refrigerant flow in heating |
MUZ-GE60VA MUZ-GE60VAD
Refrigerant pipe ø15.88 |
|
Muffler |
|
4-way valve |
#100 |
||
(with heat insulator) |
|||
|
|
Stop valve |
|
|
|
|
(with service port) |
|
|
Outdoor |
|
Flared connection |
Discharge |
|
heat |
Ambient |
|
temperature |
Defrost |
exchanger |
temperature |
|
thermistor |
|
thermistor |
|
|
RT62 |
thermistor |
|
RT65 |
|
|
RT61 |
|
|
|
Compressor |
Outdoor heat |
|
|
|
|
|
|
|
|
|
|
exchanger |
|
|
|
|
temperature |
|
|
|
|
thermistor |
|
Flared connection |
|
|
RT68 |
|
LEV |
Strainer |
|
|
|
Strainer |
R.V. coil |
|
||
#100 |
|
#100 |
|
|
|
|
|
heating ON |
|
Stop valve |
Capillary tube |
|
cooling OFF |
|
Refrigerant pipe ø6.35 |
ø4.0×ø2.4×100 |
Refrigerant flow in cooling |
||
|
||||
(with heat insulator) |
|
Refrigerant flow in heating |
OBH532E |
28 |
|
MUZ-GE71VA MUZ-GE71VAD
MUZ-GE80VA MUZ-GE80VA2 MUZ-GE80VAD
Unit: mm
Refrigerant pipe ø15.88 |
|
Muffler |
|
4-way valve |
#100 |
||
(with heat insulator) |
|||
|
|
Stop valve |
|
|
|
|
(with service port) |
|
|
Outdoor |
|
Flared connection |
Discharge |
|
heat |
Ambient |
|
temperature |
Defrost |
exchanger |
temperature |
|
thermistor |
|
thermistor |
|
|
RT62 |
thermistor |
|
RT65 |
|
|
RT61 |
|
|
|
Compressor |
Outdoor heat |
|
|
|
|
|
|
|
|
|
|
exchanger |
|
|
|
|
temperature |
|
|
|
|
thermistor |
|
Flared connection |
|
|
RT68 |
|
LEV |
Strainer |
|
|
|
Strainer |
R.V. coil |
|
||
#100 |
|
#100 |
|
|
|
|
|
heating ON |
|
Stop valve |
Capillary tube |
|
cooling OFF |
|
|
|
|
||
Refrigerant pipe ø9.52 |
ø4.0×ø2.4×100 |
Refrigerant flow in cooling |
||
|
||||
(with heat insulator) |
|
Refrigerant flow in heating |
MAX. REFRIGERANT PIPING LENGTH and MAX. HEIGHT DIFFERENCE
|
|
|
Refrigerant piping: m |
Piping size O.D: mm |
||
|
|
|
|
|
||
|
|
|
Max. Length |
Max. Height difference |
|
|
|
|
|
A |
B |
Gas |
Liquid |
MUZ-GE25VA |
|
|
|
|
|
|
MUZ-GE25VAD |
|
|
|
|
|
|
MUZ-GE33VA |
|
|
|
|
|
|
MUZ-GE35VA |
|
20 |
12 |
9.52 |
|
|
MUZ-GE35VA2 |
|
|
||||
|
|
|
|
|
|
|
MUZ-GE35VAD |
|
|
|
|
|
|
MUZ-GE42VA |
|
|
|
|
|
6.35 |
MUZ-GE42VAD |
|
|
|
|
|
|
MUZ-GE50VA |
|
|
|
|
|
|
MUZ-GE50VA2 |
|
|
|
|
12.7 |
|
MUZ-GE50VAD |
|
|
|
|
|
|
MUZ-GE60VA |
|
|
|
|
|
|
MUZ-GE60VAD |
|
30 |
15 |
|
|
|
MUZ-GE71VA |
|
|
|
|||
|
|
|
|
|
|
|
MUZ-GE71VAD |
|
|
|
|
15.88 |
9.52 |
MUZ-GE80VA |
|
|
|
|
|
|
MUZ-GE80VA2 |
|
|
|
|
|
|
MUZ-GE80VAD |
|
|
|
|
|
|
|
|
Indoor |
|
|
|
|
|
|
unit |
|
|
|
|
|
|
|
|
|
|
|
Max. Height difference B
Max. Length A
Outdoor unit
OBH532E |
29 |
|