Zanussi ZJD12191 User Manual

WASHER-DRYER

ZJD 12191

Quick Installation Guide:

visit our WEB SITE to view an install video www.video.uk.electrolux.com

132985530

INSTRUCTION BOOKLET

GB

Important Safety Information

It is most important that this instruction book should be retained with the appliance for future reference. Should the appliance be sold or transferred to another owner, or should you move house and leave the appliance, always ensure that the book is supplied with the appliance in order that the new owner can get to know the functioning of the appliance and the relevant warnings.

These warnings have been provided in the interest of safety. You MUST read them carefully before installing or using the appliance.

Installation		●	Before washing, ensure that all pockets are empty
	This appliance is heavy. Care should be taken when		and buttons and zips are fastened. Avoid washing
●			frayed or torn articles and treat stains such as paint,
	moving it.		ink, rust, and grass before washing. Underwired bras
●	It is dangerous to alter the specifications or attempt		must NOT be machine washed.
	to modify this product in any way.	●	Any objects such as coins, safety pins, nails, screws,
●	All packing and transit bolts must be removed before		stones or any other hard, sharp material can cause
	use. Serious damage can occur to the product and to		extensive damage and must not be placed into the
	property if this is not adhered to. See relevant section		machine.
	in instructions.	●	Garments which have been in contact with volatile
●	Any plumbing work required to install this appliance		petroleum products should not be machine washed.
	should be carried out by a qualified plumber or		If volatile cleaning fluids are used, care should be
	competent person.		taken to ensure that the fluid is removed from the
●	Any electrical work required to install this appliance		garment before placing in the machine.
	should be carried out by a qualified electrician or	●	Wash small items such as socks, laces, washable
	competent person.		belts etc in a washing bag or pillow case as it is
●	Care must be taken to ensure that the appliance does		possible for such items to slip down between the tub
	not stand on the electrical supply cable.		and the inner drum.
			Only use the advised quantities of fabric softener.
●	If the machine is situated on a carpeted floor, please	●
	adjust the feet in order to allow air to circulate freely.		Damage to the fabric can ensue if you over-fill.
			Refer to the manufacturer’s recommendations of
Child Safety			quantities.
	This appliance is designed to be operated by adults.	●	As some duvets and eiderdowns should be washed
●			in large commercial machines because of their bulk,
	Children should not be allowed to tamper with the		please check with the manufacturer of the item
	controls or play with the product.		before washing in a domestic machine.
●	Pets and children have been known to climb into	●	Never tumble dry items that have had contact with
	washing machines. Please check your drum before		chemicals such as dry cleaning fluid.These are of a
	use.		volatile nature and could cause an explosion.
●	The glass door becomes very hot during the washing		Only tumble dry items which have been washed in
	and drying cycle. Keep children away from the		water or require airing.
			Plastic detergent dispensers should not remain in the
	vicinity of the appliance whilst it is in operation.	●
● Keep all packaging well away from children.			drum during the drying cycle, as the plastic used is
			not designed to withstand the heat. If you wish to
● Keep all detergents in a safe place out of children’s
			wash-through-to-dry you should use the
	reach.
			conventional detergent dispenser drawer.
Use		●	Leave the porthole door slightly ajar between washes
	Always unplug the appliance and turn off the water		to preserve the door seal.
●		●	Under no circumstances should you attempt to repair
	supply after use.
			the machine yourself. Repairs carried out by
	Do not overload the appliance. See relevant section
●			inexperienced persons may cause injury or serious
	in the instruction book.		malfunctioning. Contact your local Zanussi Service
●	Only wash fabrics which are designed to be machine		Force Centre. Always insist on genuine Zanussi
	washed. If in doubt, consult the care label on the	2	spare parts.
	clothes.

Contents

For the User

Important Safety Information	2
Your New Washer Dryer	4
Description of the Appliance	5
Detergent dispenser drawer	5
Child safety feature	5
The Control Panel	6-10
Programme Information	10
Operating sequence	11-13
Washing only	11
Load the laundry	11
Measure out the detergent and the fabric softener	11
Jetsystem wash	11
Switch the machine on	11
Select the required programme	11
Select the SPIN SPEED or RINSE HOLD option	12
Select the required options	12
Select the DELAY START	12
Start the programme	12
At the end of the programme	12-13
Drying only	13
Automatic washing and drying	13
Washing and Drying Hints	14-15
Which detergent?....	15
And in which form?	15
Wash Care Symbols	16
Washing and Special Programmes	17-18
Drying Programmes	19
	24

Maintenance and Cleaning	20-21
Descaling	20
After each wash	20
Maintenance wash	20
External cleaning	20
Cleaning the dispenser drawer	20
Cleaning the drawer recess	20
Cleaning the filter	20
The dangers of freezing	21
Emergency emptying out	21
Something Not Working	22-23
Service and Spare Parts	23-24
Guarantee conditions	24

For the Installer

Installation Instructions	25
Technical Specifications	25
Unpacking	26
Positioning	26
Water inlet	26-27
Water drainage	27-28
Levelling	28
Special conditions	28
In the interest of the environment	28
Electrical connection	29
Building-in	30-31

Guide to use the Instruction Book

The following symbols will be found in the text to guide you throughout the instructions:

Safety instructions

Hints and tips

Environmental information

3

Your New Washer-Dryer

Your new washer-dryer fitted with the Zanussi “JET SYSTEM”, meets all modern requirements for effective treatment of laundry with low water, energy and detergent consumption.

Even small loads are washed “economically” because the amount of water used is regulated automatically according to the load and type of fabric.

●Automatic cooling of the wash water to 60°C before draining, with the 95°C programme. This reduces thermal shock to fabrics, helping to prevent creasing.

●The special WOOL programme with its new delicate wash system treats your woollens with extreme care.

●The anti-unbalance device ensures that the washing machine remains stable when spinning.

●The two drying programmes will give your wash that soft, relaxed feel whatever the weather.

Ecological hints

To save water and energy and help protect the environment, we recommend that you follow these hints:

●Adjust the quantity of detergent according to the hardness of your water supply, the amount of laundry and the degree of soiling.

●Select an “economy” programme for lightly soiled laundry.

●A programme without prewash is sufficient for normally soiled laundry.

●The machine works more economically if it is fully loaded both for washing and drying cycles.

●With adequate pre-treatment, stains and limited soiling can be removed; the laundry can then be washed at a lower temperature.

●Always load well spun laundry. The higher the spin speed, the lower the electricity consumption and the shorter the drying times.

In the interest

of the environment

●Materials marked with the symbol are recyclable.

●Check with your local Council or Environmental Health Office to see if there are facilities in your area for re-cycling this appliance.

●When the appliance is to be scrapped, cut off the power supply cable and make the door lock device unusable to prevent young children from being trapped inside.

●Help to keep your country tidy - use authorised disposal sites for your old appliance.

The symbol on the product or on its packaging indicates that this product may not be treated as household waste. Instead it shall be handed over to the applicable collection point for the recycling of electrical and electronic equipment. By ensuring this product is disposed of correctly, you will help prevent potential negative consequences for the environment and human health, which could otherwise be caused by inappropriate waste handling of this product. For more detailed information about recycling of this product, please contact your local city office, your household waste disposal service or the shop where you purchased the product.

How do we help to protect the environment? We use recycled paper!

Important

Your machine is fitted with a balance control device, which ensures the machine is stable during the spin.

If the wash load appears not to have been spun sufficiently at the end of the wash cycle, because it is not evenly distributed in the drum, the balance control device may have operated. It will therefore be necessary to redistribute the wash load manually and select a spin programme. For more detailed information see the section headed "Something Not Working".

4

Description of the Appliance

1Detergent dispenser drawer

2Programme guide

3Control panel

4Door opening handle

5Filter

6Adjustable feet

X

Z J D . 1 2 1 9 1

Detergent dispenser drawer

Prewash

Main wash Fabric softener

Child safety feature

This machine incorporates a special child safety feature to prevent small children from being trapped inside the machine.

To activate this device, rotate the button (without pressing it) inside the door clockwise until the groove is horizontal. If necessary use a coin.

To disable this device and restore the possibility of closing the door, rotate the button anti-clockwise until the groove is vertical.

Programme chart

P0239S

P1131

5

The Control Panel

	1200
	900
	700
	500
	SPIN	QUICK	SUPER	DRYING	DELAY	START
ON/OFF	PREWASH SPEED DAILY	WASH	RINSE	TIME	START	PAUSE

Z J D . 1 2 1 9 1

1	2 3	4 5 6 7 8 91011	13
		12

SPECIAL	X	95º	COTTON
			60ºE
			60º
			40ºE
			40º
			30º
30º
WOOL
40º			60º
			60ºE
DELICATES	40º	30º	40º
			SYNTHETICS

14

1 Detergent dispenser drawer

2 Mains-on light

This light comes on when the ON/OFF button is pressed, and goes out when it is pressed again.

The light corresponding to the selected option illuminates.

The following speeds are available for the different fabrics:

•COTTON, linen: 500/700/900 max 1200 r.p.m.

•SYNTHETICS and WOOL/(handwash) :

500/700 max 900 r.p.m.

3 ON/OFF button

Press this button to switch the machine on. Press it again to switch the machine off.

Programme Option buttons

Depending on the programme, different functions can be combined. These must be selected after choosing the desired programme and before depressing the START PAUSE button.

When these buttons are pressed, the corresponding pilot lights come on. When they are pressed again, the pilot lights go out.

If an incorrect option is selected, the corresponding pilot light flashes for about 2 seconds and the message Err is displayed.

4 PREWASH button

The machine performs a prewash cycle at 30°C max. The prewash cycle ends with a short spin at 650 r.p.m. in programmes for COTTON and SYNTHETICS, and with emptying of the water for DELICATES.

This option is not available with the WOOL programme/(handwash) and Miniprogramme . For use when washing heavily soiled laundry.

•DELICATES and MINIPROGRAMME :

500 max 700 r.p.m.

The light corresponding to the selected option illuminates.

Rinse Hold

When RINSE HOLD option is selected, the last rinse water is not emptied out, to prevent the fabrics from creasing. When the programme has finished, the light of the START PAUSE button and the pilot light (DOOR) go out, the light and the pilot light

(END) are alight to indicate that the water must be emptied out.

To empty out water there are 2 possibilities:

•Select programme (draining):

The water is emptied out without spinning.

•Select programme (spin): reduce eventually the spin speed by means of the relevant button and then depress the START PAUSE button.

The water is emptied out and the laundry is spun at the selected spin speed.

Attention! Before selecting programmes (Drain) or

, the selector dial has to be positioned on X (cancelling).

The RINSE HOLD option CANNOT be selected for the automatic Washing & Drying programme.

5 SPIN SPEED button

Press this button to reduce the maximum speed of the final speed proposed by the machine for the selected programme or to select position (RINSE HOLD) .

6 DAILY button

This option can be used for lightly soiled cotton or synthetic items items in order to obtain a good washing performance in a short time.

6

This option cannot be used with the Economy programmes 60°E and E°40 and Miniprogram and also not in combination with QUICK WASH option .

7 QUICK WASH button

This option can be used for lightly soiled cotton, synthetic or delicate items hat have been used or worn for a short time.

This option is not available with the WOOL/ (handwash) programme, the Energy saving programmes (60°E and 40°E) and Miniprogramme .

It cannot be used also in combination with DAILY option.

8 SUPER RINSE button

This option can be selected with all programmes, except the WOOL/ HANDWASH and Miniprogramme . The machine will add 2 rinses for cotton and 1 rinse for synthetics and delicates.

This option is recommended for people who are allergic to detergents and in areas where the water is very soft.

9 DRYING TIME button

By depressing this button you can select the desired drying time according to the fabrics (cotton or synthetics) you have to dry.

To select the drying time you have to push the button until the drying time you want appears in the display.

For COTTON and SYNTHETICS you can select a time from 10 to 130 minutes.

For automatic Washing & Drying programmes the drying time is displayed for 2 seconds, then the duration of the programme will appear.

10 DELAY START button

The wash programme can be delayed from 30 min - 60 min - 90 min, 2 hours and then by 1 hour up to a maximum of 23 hours by means of this button.

Selecting the delayed start

●Select the programme and the required options.

●Select the delay start.

●Depress START PAUSE button: the machine starts its hourly countdown.

The programme will start after the selected delay has

expired. The DELAY START cannot be used with (DRAIN) or (SPIN) programmes.

Cancelling the delayed start

●Depress START PAUSE button.

●Depress DELAY START button until «0’» is displayed.

●Depress START PAUSE button again, if you wish to restart the machine immediately.

11 START/PAUSE button

This button has two functions: Start - Pause

Start

After having selected the required programme, press this button to start the machine; the corresponding pilot light stops flashing.

If you have selected the delayed start, the machine begins its countdown. The duration of the programme or the delay appears on the display.

Pause

To interrupt a programme which is running, depress the START PAUSE button: the corresponding pilot light starts to flash.

To restart the programme from the point at which it was interrupted, press the START PAUSE button again.

12 DISPLAY

The display shows the following information:

Reset/Cancelling - Duration of the programme - Drying time - Delayed start - Incorrect option selection - Alarm code - End of programme

Reset/cancellation of the programme

If the programme selector dial is turned to X position, three blinking dashes are displayed.

Now you can select a new programme.

(If the programme selector dial has not turned to X position , when you press the ON/OFF button to switch the machine on, the display will show a blinking zero.)

---

7

Duration of the selected programme

After selecting a programme, the duration is displayed in hours and minutes (for example 2.05).

2.05

The duration is calculated automatically on the basis of the maximum recommended load for each type of fabric.

After the programme has started, the time remaining is updated every minute.

Drying time

The selected drying time is displayed in minutes.

105

Incorrect option selection

If an option which is not compatible with the set wash programme is selected, the message Err is displayed for 2 seconds.

Alarm codes

In the event of operating problems, some alarm codes can be displayed, for example E20 (see paragraph “Something not working”).

E20

After starting the programme, the remaining time is updated every minute.

Delayed start

The selected delay (23 hours max) set by means of the relevant button appears on the display for 3 seconds, then the duration of the previously selected programme is displayed.

The countdown is updated every hour and, when remain the last 2 hours, each 30 min.

End of programme

When the programme has finished a flashing zero is displayed. The door can be opened when (DOOR) pilot light has gone out and if the (RINSE HOLD) option has not been selected.

0

DELAY START

8

13 Programme progress display

By selecting the wash programme, the pilot lights corresponding to the various phases making up the programme come on.

After the machine has started, the (DOOR) pilot light and only the running phase light illuminate and stay on.

When the programme has finished, the (END) pilot light comes on and the the

(DOOR) pilot light goes off.

DOOR

PREWASH

WASH

RINSES

DRAIN

SPIN

DRYING

END

The (DOOR) pilot light indicates if during the washing cycle the door can be opened:

•Light on: the door can be opened

(when the washer-dryer is set to PAUSE, the (DOOR) pilot light will go off).

•Light off: the door cannot be opened

(when the washer-dryer is set to PAUSE, the (DOOR) pilot light will start to flash)

The (END) pilot light flashes in the event of operating problems and the corresponding alarm code appears on the display.

E10 = the machine does not fill

E20 = the machine does not empty

E40 = the door has not been closed

To eliminate the problem, see paragraph “Something not working”.

14 Programme selector dial

The selector is divided into 5 sections:

•COTTON,

•SYNTHETICS

•DELICATES

•WOOL (hand washing)

•Special programmes Reset programme X

SPECIAL	X	95º	COTTON
			60ºE
			60º
			40ºE
			40º
			30º
30º
WOOL
40º			60º
			60ºE
30º	40º	30º	40º
DELICATES			SYNTHETICS

The selector dial can be turned either clockwise or anticlockwise.

Position E corresponds to the ENERGY SAVING programme and position to “cold wash”.

Position corresponds to the drying programme.

At the end of the programme the selector dial must be turned to position X (reset).

Functions

End of programme

When the (END) pilot light on the programme progress display illuminates, if the (DOOR) pilot light has gone out, the the door can be opened (if the (RINSE HOLD) option has not been selected) .

Turn the programme selector dial to X.

Switch the machine off by depressing the ON/OFF button before removing the laundry.

Altering an option or a running programme

It is possible to change any option before the programme carries it out.

Before you make any change, you must pause the washer dryer by pressing the START PAUSE button. Changing a running programme is possible only by resetting it. Turn the programme selector dial to "X" and then to the new programme position. The washing water in the tub will not emptied out .

Start the new programme by depressing the START PAUSE button.

Interrupting a programme

Depress the START PAUSE button to interrupt a programme which is running: the corresponding light starts to flash.

Depress the same button to restart the programme.

9

Opening the door after the programme has started

You can open the door, after having set the washer-dryer to PAUSE, provided the following conditions exist:

•the drum temperature is not over 55°C;

•the level of the water is not high;

•the drum is not turning.

If these requirements are met, the (DOOR) pilot light will be on and, when you pause the washing machine, it will goes out: the door can be opened.

Should it not be possible to open the door, and should it be absolutely necessary to do so, switch the machine off by pressing the ON/OFF button.

After approximately 3 minutes, you can open the door.

Pay attention to the level and temperature of the water in the machine!

When you close the door and press the ON/OFF button again, the machine will resume the programme from the point where it had been interrupted.

Programme information

WOOL (HANDWASH )

Washing programme for machine washable wool as well as for hand washable woollens and delicate fabrics with the “hand washing” care symbol.

= Rinses

With this programme it is possible to rinse and spin cotton garments which have been washed by hand. The machine performs 3 rinses, followed by a final spin at 1200 r.p.m.

The spin speed can be reduced by depressing SPIN SPEED button.

= Drain

For emptying out the water of the last rinse in programmes with the RINSE HOLD option.

Turn first the programme selector dial to X, then select programme and depress the START PAUSE button.

= Spin

Separate long spin at the maximum speed for hand washed cotton garments. You can reduce the speed by means of SPIN SPEED button to adapt it to the fabrics to be spun.

= Easy to iron

With this programme the laundry is gently washed and spun to any creasing In this way ironing is easier. To be used for synthetic items.

Washing temperature 40°C Final spin speed 900 r.p.m.

= Miniprogramme

This is a complete programme that can be combined with the following options: SPIN SPEED, RINSE HOLD and

DELAY START.

To be used for laundry which is lightly soiled or which needs freshening up.

Max load 2 kg.

Washing temperature 30°C Programme duration 30 minutes Final spin speed 700 r.p.m.

X = Cancelling

To reset a programme turn the selector dial to X. Now can a new programme be selected.

10