E51 RM-244
Service Manual Level 1&2
SERVICE MANUAL
Level 1&2
RM-244
Transceiver characteristics:
Band:
EGSM: Quad-band 850/900/1800/1900MHz
WCDMA: 850/2100MHz
Display:
LCD: 5.08cm QVGA (2.0”) (240x320 pixel); 16M colors
Camera:
Camera: 2.0 Megapixel
Operating System:
Series 60
Connections:
Wireless: WLAN, Bluetooth
Connector: Mini USB Connector; AV Connector
Memory:
MicroSD™ (max 4GB)
Transceiver with BP-6MT Li-Ion battery pack
Talk time |
Standby |
Note |
|
|
|
up to 7h |
up to 11days |
Depends on network |
parameters and |
||
|
|
phone settings |
Page 1 (13) |
CONFIDENTIAL |
ISSUE 1 |
|
Copyright © 2007 NOKIA. All rights reserved. |
|
|
|
E51 RM-244 |
|
|
Service Manual Level 1&2 |
TABLE OF CONTENTS |
Page |
|
1. |
CHANGE HISTORY |
3 |
2. |
COPYRIGHT |
3 |
3. |
WARNINGS AND CAUTIONS |
4 |
4. |
ESD PROTECTION |
4 |
5. |
CARE AND MAINTENANCE |
5 |
6. |
BATTERY INFORMATION |
5 |
7. |
EXPLODED VIEW |
6 |
8. |
LEVEL 2 SOLDER COMPONENTS |
7 |
9. |
SERVICE TOOLS |
8 |
10. |
SW-UPDATE |
9 |
11. |
DISASSEMBLY INSTRUCTION |
10 |
12. |
ASSEMBLY HINTS |
13 |
Page 2 (13) |
CONFIDENTIAL |
ISSUE 1 |
|
Copyright © 2007 NOKIA. All rights reserved. |
|
E51 RM-244
Service Manual Level 1&2
Status |
Version No. |
Date |
Comments |
Draft |
0.1 |
11.Sep.2007 |
Initial draft |
|
|
|
|
Approved |
1.0 |
25.Sept.2007 |
Approved |
Approved |
2.0 |
28.Sept.2007 |
Tools chapter corrected |
|
|
|
|
The purpose of this document is to help NOKIA service levels 1 and 2 workshop technicians to carry out service to NOKIA products. This Service Manual is to be used only by authorized NOKIA service suppliers, and the content of it is confidential. Please note that NOKIA provides also other guidance documents (e.g. Service Bulletins) for service suppliers, follow these regularly and comply with the given instructions.
While every endeavor has been made to ensure the accuracy of this document, some errors may exist. If you find any errors or if you have further suggestions, please notify NOKIA using the address below:
CMO Operation & Logistics Training and Vendor Development Multimedia Creation & Support mailto:Service.Manual@nokia.com
Please keep in mind also that this documentation is continuously being updated and modified, so watch always out for the newest version.
2. |
COPYRIGHT |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
||
Copyright © 2007 Nokia. All rights reserved. |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|||||
Reproduction, transfer, distribution or storage of |
part or all of the contents |
in |
this |
document |
in |
any form |
||||||||||||||||||
without the prior written permission of Nokia is prohibited. |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|||||||
Nokia, Nokia Connecting People, and Nokia X |
and |
Y |
are |
trademarks |
or registered trademarks of Nokia |
|||||||||||||||||||
Corporation. |
Other product |
and company names |
mentioned |
herein |
may |
be |
trademarks |
or |
tradenames |
of |
||||||||||||||
their respective owners. |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|||
Nokia operates a policy of continuous development. Nokia reserves |
the |
right |
to |
make |
changes |
and |
||||||||||||||||||
improvements to any of the products described in this document without prior notice. |
|
|
|
|
|
|
|
|
|
|
|
|
||||||||||||
Under no circumstances shall Nokia be responsible for any loss of data |
or |
income |
or |
any |
special, |
incidental, |
||||||||||||||||||
consequential or indirect damages howsoever caused. |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
||||||
The |
contents of |
this document are provided “as |
is”. |
Except |
as |
required |
by applicable law, no warranties of |
|||||||||||||||||
any |
kind, |
either |
express |
or |
implied, |
including, but not |
limited |
to, |
the |
implied |
warranties |
of |
merchantability |
|||||||||||
and fitness for a particular purpose, are made |
in relation to the accuracy, |
reliability |
or |
contents |
of |
this |
||||||||||||||||||
document. |
Nokia |
reserves |
the right to |
revise this |
document or |
withdraw |
it |
at |
any |
time |
without prior |
notice. |
||||||||||||
The availability of particular products may vary by region. |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
||||||
IMPORTANT |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
This document is intended for use by qualified service personnel only. |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
Page 3 (13) |
CONFIDENTIAL |
ISSUE 1 |
|
Copyright © 2007 NOKIA. All rights reserved. |
|
E51 RM-244
Service Manual Level 1&2
3. WARNINGS AND CAUTIONS
Please refer to the phone’s user guide for instructions relating to operation, care and maintenance including important safety information. Note also the following:
Warnings:
1.CARE MUST BE TAKEN ON INSTALLATION IN VEHICLES FITTED WITH ELECTRONIC ENGINE MANAGEMENT SYSTEMS AND ANTI–SKID BRAKING SYSTEMS. UNDER CERTAIN FAULT CONDITIONS, EMITTED RF ENERGY CAN AFFECT THEIR OPERATION. IF NECESSARY, CONSULT THE VEHICLE DEALER/MANUFACTURER TO DETERMINE THE IMMUNITY OF VEHICLE ELECTRONIC SYSTEMS TO RF ENERGY.
2.THE HANDPORTABLE TELEPHONE MUST NOT BE OPERATED IN AREAS LIKELY TO CONTAIN POTENTIALLY EXPLOSIVE ATMOSPHERES, EG PETROL STATIONS (SERVICE STATIONS), BLASTING AREAS ETC.
3.OPERATION OF ANY RADIO TRANSMITTING EQUIPMENT, INCLUDING CELLULAR TELEPHONES, MAY INTERFERE WITH THE FUNCTIONALITY OF INADEQUATELY PROTECTED MEDICAL DEVICES. CONSULT A PHYSICIAN OR THE MANUFACTURER OF THE MEDICAL DEVICE IF YOU HAVE ANY QUESTIONS. OTHER ELECTRONIC EQUIPMENT MAY ALSO BE SUBJECT TO INTERFERENCE.
Cautions:
1.Servicing and alignment must be undertaken by qualified personnel only.
2.Ensure all work is carried out at an anti–static workstation and that an anti–static wrist strap is worn.
3.Use only approved components as specified in the parts list.
4.Ensure all components, modules screws and insulators are correctly re–fitted after servicing and alignment.
5.Ensure all cables and wires are repositioned correctly.
Nokia requires that service points have sufficient ESD protection (against static electricity) when servicing the phone.
Any product of which the covers are removed must be handled with ESD protection. The SIM card can be replaced without ESD protection if the product is otherwise ready for use.
To replace the covers ESD protection must be applied.
All electronic parts of the product are susceptible to ESD. Resistors, too, can be damaged by static electricity discharge.
All ESD sensitive parts must be packed in metallized protective bags during shipping and handling outside any ESD Protected Area (EPA).
Every repair action involving opening the product or handling the product components must be done under ESD protection.
ESD protected spare part packages MUST NOT be opened/closed out of an ESD Protected Area.
For more information and local requirements about ESD protection and ESD Protected Area, contact your local Nokia After Market Services representative.
Page 4 (13) |
CONFIDENTIAL |
ISSUE 1 |
|
Copyright © 2007 NOKIA. All rights reserved. |
|