Loading...
Toshiba Personal Computer
Satellite P500/Pro500
Maintenance Manual
TOSHIBA CORPORATION
File Number 960-Q08
Satellite P500 and Satellite Pro500 Maintenance Manual (960-Q08)
Copyright
© 2003 by Toshiba Corporation. All rights reserved. Under the copyright laws, this manual cannot be reproduced in any form without the prior written permission of Toshiba. No patent liability is assumed with respect to the use of the information contained herein.
Toshiba Personal Computer Silvis-10M10MG-10AR+10ARG Maintenance Manual
First edition Mar. 2009
Disclaimer
The information presented in this manual has been reviewed and validated for accuracy. The included set of instructions and descriptions are accurate for the Silvis-10M10MG-10AR+10ARG Series at the time of this manual's production. However, succeeding computers and manuals are subject to change without notice. Therefore, Toshiba assumes no liability for damages incurred directly or indirectly from errors, omissions, or discrepancies between any succeeding product and this manual.
Trademarks
Intel, Intel SpeedStep, Pentium and Celeron are trademarks or registered trademarks of Intel Corporation or its subsidiaries in the United States and other countries/regions.
Windows and Microsoft are registered trademarks of Microsoft Corporation. Photo CD is a trademark of Eastman Kodak.
i Link is a trademark of Sony Corporation.
TruSurround XT, Trubass, Dialog Clarity, SRS and (•)symbol are trademarks of SRS Labs, Inc.
TruSurround XT technology is in corporated under license from SRS Labs, Inc.
Other trademarks and registered trademarks not listed above may be used in this manual.
Satellite P500 and Satellite Pro500 Maintenance Manual (960-Q08)
Preface
This maintenance manual describes how to perform hardware service maintenance for the Toshiba Personal Computer Silvis-10M10MG-10AR+10ARG Series.
The procedures described in this manual are intended to help service technicians isolate faulty Field Replaceable Units (FRUs) and replace them in the field.
SAFETY PRECAUTIONS
Four types of messages are used in this manual to bring important information to your attention. Each of these messages will be italicized and identified as shown below.
DANGER: “Danger” indicates the existence of a hazard that could result in death or serious bodily injury, if the safety instruction is not observed.
WARNING: “Warning” indicates the existence of a hazard that could result in bodily injury, if the safety instruction is not observed.
CAUTION: “Caution” indicates the existence of a hazard that could result in property damage, if the safety instruction is not observed.
NOTE: “Note” contains general information that relates to your safe maintenance service.
Improper repair of the computer may result in safety hazards. Toshiba requires service technicians and authorized dealers or service providers to ensure the following safety precautions are adhered to strictly.
Be sure to fasten screws securely with the right screwdriver. If a screw is not fully fastened, it could come loose, creating a danger of a short circuit, which could cause overheating, smoke or fire.
If you replace the battery pack or RTC battery, be sure to use only the same model battery or an equivalent battery recommended by Toshiba. Installation of the wrong battery can cause the battery to explode.
Satellite P500 and Satellite Pro500 Maintenance Manual (960-Q08)
The manual is divided into the following parts:
Chapter 1 Hardware Overview describes the Satellite P500 system unit and each FRU.
Chapter 2 Troubleshooting Procedures explains how to diagnose and resolve FRU problems.
Chapter 3 Test and Diagnostics describes how to perform test and diagnostic operations for maintenance service.
Chapter 4 Replacement Procedures describes the removal and replacement of the FRUs.
Appendices The appendices describe the following:
Handling the LCD Module
Board layout
Pin assignments
Keyboard scan/character codes
Key layout
Wiring diagrams
BIOS Rewrite Procedures
EC/KBC Rewrite Procedures
Reliability
Satellite P500 and Satellite Pro500 Maintenance Manual (960-Q08)
Conventions
This manual uses the following formats to describe, identify, and highlight terms and operating procedures.
Acronyms
On the first appearance and whenever necessary for clarification acronyms are enclosed in parentheses following their definition. For example:
Read Only Memory (ROM)
Keys
Keys are used in the text to describe many operations. The key top symbol as it appears on the keyboard is printed in boldface type.
Key operation
Some operations require you to simultaneously use two or more keys. We identify such operations by the key top symbols separated by a plus (+) sign. For example, Ctrl + Pause (Break) means you must hold down Ctrl and at the same time press Pause (Break). If three keys are used, hold down the first two and at the same time press the third.
User input
Text that you are instructed to type in is shown in the boldface type below:
DISKCOPY A: B:
The display
Text generated by the computer that appears on its display is presented in the typeface below:
Format complete
System transferred
Satellite P500 and Satellite Pro500 Maintenance Manual (960-Q08)
Table of Contents |
|
|
Chapter 1 Hardware Overview |
|
|
1.1 |
Features.......................................................................................................................... |
1 |
1.2 |
System Block Diagram .................................................................................................. |
5 |
1.3 |
2.5-inch Hard Disk Drive............................................................................................... |
9 |
1.4 |
Optical Drive................................................................................................................ |
13 |
1.5 |
Keyboard...................................................................................................................... |
19 |
1.6 |
TFT Color Display....................................................................................................... |
20 |
|
1.6.1 LCD Module With CCFL Backlight............................................................. |
20 |
|
1.6.2 CCFL Inverter Board .................................................................................... |
22 |
1.7 |
Power Supply............................................................................................................... |
23 |
1.8 |
Batteries ....................................................................................................................... |
24 |
|
1.8.1 Main Battery ................................................................................................. |
26 |
|
1.8.2 Battery Charging Control.............................................................................. |
27 |
|
1.8.3 RTC battery................................................................................................... |
28 |
1.9 |
AC Adapter .................................................................................................................. |
29 |
Satellite P500 and Satellite Pro500 Maintenance Manual (960-Q08)
Chapter 2 Troubleshooting Procedures |
|
||
2.1 |
Troubleshooting |
............................................................................................................ |
1 |
2.2 |
Troubleshooting ...........................................................................................Flowchart |
3 |
|
2.3 |
Power Supply Troubleshooting..................................................................................... |
7 |
|
|
Procedure 1 .................................................................. |
Power Status Check |
7 |
|
Procedure 2 ..................................................................... |
Connection Check |
9 |
|
Procedure 3 ........................................................................ |
Charging Check |
9 |
|
Procedure 4 ................................................................ |
Replacement Check |
10 |
2.4 |
System Board Troubleshooting................................................................................... |
11 |
|
|
Procedure 1 ....................................................................... |
Message Check |
12 |
|
Procedure 2 ............................................................ |
Debugging Port Check |
14 |
|
Procedure 3 ............................ |
Diagnostic Test Program Execution Check |
19 |
|
Procedure 4 ................................................................ |
Replacement Check |
19 |
2.5 |
USB FDD Troubleshooting ........................................................................................ |
20 |
|
|
Procedure 1 .................................................... |
FDD Head Cleaning Check |
20 |
|
Procedure 2 ............................ |
Diagnostic Test Program Execution Check |
21 |
|
Procedure 3 ............................. |
Connector Check and Replacement Check |
22 |
2.6 |
2.5” HDD Troubleshooting......................................................................................... |
24 |
|
|
Procedure 1 ........................................................................ |
Partition Check |
24 |
|
Procedure 2 ....................................................................... |
Message Check |
25 |
|
Procedure 3 .......................................................................... |
Format Check |
26 |
|
Procedure 4 ............................ |
Diagnostic Test Program Execution Check |
27 |
|
Procedure 5 ............................. |
Connector Check and Replacement Check |
28 |
2.7 |
Keyboard Troubleshooting ......................................................................................... |
29 |
|
|
Procedure 1 ............................ |
Diagnostic Test Program Execution Check |
29 |
|
Procedure 2 ............................. |
Connector Check and Replacement Check |
30 |
2.8 |
Touch pad Troubleshooting ........................................................................................ |
31 |
|
|
Procedure 1 ............................ |
Diagnostic Test Program Execution Check |
31 |
|
Procedure 2 ............................. |
Connector Check and Replacement Check |
32 |
Satellite P500 and Satellite Pro500 Maintenance Manual (960-Q08)
2.9 |
Display Troubleshooting.............................................................................................. |
33 |
|
|
Procedure 1 |
External Monitor Check........................................................... |
33 |
|
Procedure 2 |
Diagnostic Test Program Execution Check ............................. |
33 |
|
Procedure 3 |
Connector and Cable Check .................................................... |
34 |
|
Procedure 4 |
Replacement Check ................................................................. |
35 |
2.10 |
Optical Disk Drive Troubleshooting............................................................................ |
36 |
|
|
Procedure 1 |
Diagnostic Test Program Execution Check ............................. |
36 |
|
Procedure 2 |
Connector Check and Replacement Check.............................. |
36 |
2.11 |
Modem Troubleshooting.............................................................................................. |
38 |
|
|
Procedure 1 |
Diagnostic Test Program Execution Check ............................. |
38 |
|
Procedure 2 |
Connector Check and Replacement Check.............................. |
38 |
2.12 |
LAN Troubleshooting |
.................................................................................................. |
40 |
|
Procedure 1 |
Diagnostic Test Program Execution Check ............................. |
40 |
|
Procedure 2 |
Connector Check and Replacement Check.............................. |
40 |
2.13 |
Wireless LAN Troubleshooting................................................................................... |
41 |
|
|
Procedure 1 |
Transmitting-Receiving Check ................................................ |
41 |
|
Procedure 2 |
Antennas' Connection Check ................................................... |
42 |
|
Procedure 3 |
Replacement Check ................................................................. |
43 |
2.14 |
Sound Troubleshooting................................................................................................ |
44 |
|
|
Procedure 1 |
Connector Check...................................................................... |
44 |
|
Procedure 2 |
Replacement Check ................................................................. |
45 |
2.15 |
Fingerprint Troubleshooting ........................................................................................ |
46 |
|
|
Procedure 1 |
Diagnostic Test Program Execution Check ............................. |
46 |
|
Procedure 2 |
Connector Check and Replacement Check............................. |
46 |
2.16 |
Bluetooth Troubleshooting .......................................................................................... |
47 |
|
|
Procedure 1 |
Connector Check and Replacement Check............................. |
47 |
Satellite P500 and Satellite Pro500 Maintenance Manual (960-Q08)
Chapter 3 Diagnostic Programs |
|
|
3.1 |
Tests and Diagnostics Software Overview ....... |
3-Fehler! Textmarke nicht definiert. |
3.2 |
Executing the Diagnostic Test .......................... |
3-Fehler! Textmarke nicht definiert. |
3.3 |
Subtest names.................................................... |
3-Fehler! Textmarke nicht definiert. |
3.4 |
System Test....................................................... |
3-Fehler! Textmarke nicht definiert. |
3.5 |
Memory Test..................................................... |
3-Fehler! Textmarke nicht definiert. |
3.6 |
Keyboard Test.......................................................................................................... |
3-22 |
3.7 |
Display Test ............................................................................................................. |
3-25 |
3.8 |
Floppy Disk Test...................................................................................................... |
3-40 |
3.9 |
Hard Disk Test ......................................................................................................... |
3-42 |
3.10 |
Real Time Clock Test .............................................................................................. |
3-45 |
3.11 |
Cache Memory Test.......................................... |
3-Fehler! Textmarke nicht definiert. |
3.12 |
High Resolution Display Test........................... |
3-Fehler! Textmarke nicht definiert. |
3.13 |
Multimedia Test....................................................................................................... |
3-55 |
3.14 |
MEMORY2 Test............................................... |
3-Fehler! Textmarke nicht definiert. |
3.15 |
Error Codes and Error Status Names................ |
3-Fehler! Textmarke nicht definiert. |
3.16 |
Running Test............................................................................................................ |
3-60 |
3.17 |
DMI INFOEMATION ...................................... |
3-Fehler! Textmarke nicht definiert. |
3.17.1 |
Check DMI Information ................................... |
3-Fehler! Textmarke nicht definiert. |
3.17.2 |
Write DMI Information..................................... |
3-Fehler! Textmarke nicht definiert. |
3.18 |
Log Utilities ............................................................................................................. |
3-63 |
3.18.1 |
Operations................................................................................................................ |
3-63 |
3.19 |
System Configuration .............................................................................................. |
3-65 |
3.20 |
Running Test Edit Item..................................... |
3-Fehler! Textmarke nicht definiert. |
3.20.1 |
Function Description......................................... |
3-Fehler! Textmarke nicht definiert. |
3.20.2 |
Operation Description....................................... |
3-Fehler! Textmarke nicht definiert. |
3.21 |
Common Tests and Operation .......................... |
3-Fehler! Textmarke nicht definiert. |
3.21.1 |
How to operate a window ................................. |
3-Fehler! Textmarke nicht definiert. |
3.21.2 |
How to Stop the Test Program.......................... |
3-Fehler! Textmarke nicht definiert. |
Satellite P500 and Satellite Pro500 Maintenance Manual (960-Q08)
3.21.3 |
Test Status Screen............................................. |
3-Fehler! Textmarke nicht definiert. |
3.21.4 |
Test Stop Display..................................................................................................... |
3-70 |
3.21.5 |
How to enter data..................................................................................................... |
3-70 |
Satellite P500 and Satellite Pro500 Maintenance Manual (960-Q08)
Chapter 4 Replacement Procedures |
|
|
4.1 |
Overview.................................................................................................................... |
4-1 |
|
Safety Precautions................................................................................................ |
4-2 |
|
Before You Begin ................................................................................................ |
4-3 |
|
Disassembly Procedure........................................................................................ |
4-4 |
|
Assembly Procedure ............................................................................................ |
4-5 |
|
Tools and Equipment ........................................................................................... |
4-5 |
|
Screw Tightening Torque .................................................................................... |
4-6 |
|
Grip Color ............................................................................................................ |
4-6 |
|
Screw Notation..................................................................................................... |
4-7 |
4.2 |
Battery pack ............................................................................................................... |
4-8 |
4.3 |
PC card..................................................................................................................... |
4-10 |
4.4 |
HDD(main HDD)..................................................................................................... |
4-12 |
4.5 |
Optical disk drive..................................................................................................... |
4-16 |
4.6 |
HDD(second HDD) ................................................................................................. |
4-18 |
4.7 |
Memory module....................................................................................................... |
4-22 |
4.8 |
Keyboard.................................................................................................................. |
4-25 |
4.6 |
Wireless LAN card .................................................................................................. |
4-28 |
4.10 |
Display assembly ..................................................................................................... |
4-31 |
4.11 |
Cover assembly........................................................................................................ |
4-36 |
4.12 |
Touch pad................................................................................................................. |
4-40 |
4.13 |
USB board ................................................................................................................ |
4-43 |
4.14 |
System board............................................................................................................ |
4-44 |
4.15 |
CPU.......................................................................................................................... |
4-47 |
4.16 |
LCD unit / FL inverter ............................................................................................. |
4-50 |
Satellite P500 and Satellite Pro500 Maintenance Manual (960-Q08)
4.17Application for thermal pad and grease on CPU, North Bridge, and VGA Board………………………………………………………………………….....4-55
Satellite P500 and Satellite Pro500 Maintenance Manual (960-Q08)
Appendices |
|
|
Appendix A |
Handling the LCD Module ........................................................................... |
A-1 |
Appendix B |
Board Layout ................................................................................................ |
B-1 |
Appendix C |
Pin Assignments............................................................................................ |
C-1 |
Appendix D |
Keyboard Scan/Character Codes .................................................................. |
D-1 |
Appendix E |
Key Layout..................................................................................................... |
E-1 |
Appendix F |
Wiring Diagrams............................................................................................ |
F-1 |
Appendix G |
BIOS Rewrite Procedures............................................................................. |
G-1 |
Appendix H |
EC/KBC Rewrite Procedures........................................................................ |
H-1 |
Appendix I |
Reliability........................................................................................................ |
I-1 |
Satellite P500 and Satellite Pro500 Maintenance Manual (960-Q08)
Satellite P500 and Satellite Pro500 Maintenance Manual (960-Q08)
Chapter 1
Hardware Overview
Satellite P500 and Satellite Pro500 Maintenance Manual (960-Q08)
Chapter 1 Hardware Overview
Chapter 1 |
Contents |
|
|
1.1 |
Features.......................................................................................................................... |
|
1 |
1.2 |
System Block Diagram .................................................................................................. |
5 |
|
1.3 |
2.5-inch Hard Disk Drive............................................................................................... |
9 |
|
1.4 |
Optical Drive................................................................................................................ |
13 |
|
1.5 |
Keyboard...................................................................................................................... |
|
19 |
1.6 |
TFT Color Display....................................................................................................... |
20 |
|
|
1.6.1 |
LCD Module With CCFL Backlight...................................................... |
20 |
|
1.6.2 |
CCFL Inverter Board ............................................................................. |
22 |
1.7 |
Power Rails .................................................................................................................. |
|
23 |
1.8 |
Batteries ....................................................................................................................... |
|
24 |
|
1.8.1 |
Main Battery........................................................................................... |
26 |
|
1.8.2 |
Battery Charging Control ....................................................................... |
27 |
|
1.8.3 |
RTC battery ............................................................................................ |
28 |
1.9 |
AC Adapter .................................................................................................................. |
|
29 |
Satellite P500 and Satellite Pro500 Maintenance Manual (960-Q08)
ii
Hardware Overview |
Chapter 1 |
|
Figures |
|
|
Figure 1-1 |
Front of the computer......................................................................................... |
4 |
Figure 1-2 |
System block diagram for Intel platform........................................................... |
5 |
Figure 1-3 |
2.5-inch HDD Disk Drive.................................................................................. |
9 |
Figure 1-4 |
DVD Super Muti drive..................................................................................... |
13 |
Figure 1-5 |
Keyboard for US Style..................................................................................... |
19 |
Figure 1-6 |
Keyboard for UK Style .................................................................................... |
19 |
Figure 1-7.... |
SAMSUNG LCD Module…………………………………………………..20 |
|
Tables |
|
|
Table 1-1 |
2.5-inch HDD dimensions ................................................................................. |
9 |
Table 1-2 |
2.5-inch HDD dimensions ............................................................................... |
10 |
Table 1-3 |
2.5-inch HDD specifications............................................................................ |
11 |
Table 1-4 |
DVD Super Multi drive outline dimensions .................................................... |
14 |
Table 1-5 |
HLDS DVD Super Multi drive specifications................................................. |
15 |
Table 1-6 |
Pioneer DVD Super Multi drivespecifications ................................................ |
16 |
Table 1-7 |
Panasonic DVD Super Multi drive specifications........................................... |
17 |
Table 1-8 |
TSST DVD Super Multi drive specifications .................................................. |
18 |
Table 1-9 |
LCD module specifications.............................................................................. |
21 |
Table 1-10 |
FL inverter board specifications ...................................................................... |
22 |
Table 1-11 |
Montevina Power supply output rating............................................................ |
23 |
Table 1-12 |
Battery specifications....................................................................................... |
24 |
Table 1-13 |
Time required for charges of main battery ...................................................... |
25 |
Table 1-14 |
Data preservation time ..................................................................................... |
25 |
Table 1-15 |
Time required for charges of RTC battery....................................................... |
26 |
Table 1-16 |
AC adapter specifications ................................................................................ |
27 |
Satellite P500 and Satellite Pro500 Maintenance Manual (960-Q08) |
|
iii |
Chapter 1 Hardware Overview
Features
1.1 Features
The Satellite P500 (Intel Platform) features are listed below.
Microprocessor
Microprocessor that is used will be different by the model. It supports processors as follows
1. Intel® Core™2 Duo Mobile Processor
T9900 3.06GHz
T9800 2.93GHz
T9600 2.8GHz
T9550 2.66GHz
P9600 2.66GHz
P8700 2.53GHz
P8600 2.40GHz
P7450 2.13GHz
T6600 2.20GHz
T6400 2.00GHz
2.Intel® Pentium® Dual-Core mobile processor T4200 2.00GHz
T3400 2.16GHz
3. Intel® Celeron® Processor
T1700 1.83GHz
T1600 1.66GHz
Celeron 585 2.16GHz
Satellite P500 and Satellite Pro500 Maintenance Manual (960-Q08) |
|
1 |
Chapter 1 Hardware Overview
Memory
Two DDRII SO-DIMM (800MHz specification compliant) used and be up to 4GB which can be upgraded through Memory Module Slot. Maximum upgradeable system memory may depend on the model
VRAM
Shared with System RAM for Intel GM45, PM45
HDD
5400RPM: 250GB, 320GB, 400GB,500GB, internal drives. 2.5 inch x 9.5mm height.
USB FDD (Option)
Toshiba external USB FDD for option
Display
LCD
18-inch, 1,440 (H) x 900 (V) WXGA+ 262,144 colors + CCFL, High-brightness, amorphous silicon TFT color display.
CRT
Supported via a RGB connector.
Keyboard
Toshiba keyboard module has (104/105/109 keys) with three LEDs design, Support Windows keys & Application keys. Multi-langue support.
New Dummy card slot
The new card slot (dummy card) accommodates one 5mm Type II card. The slot support 16-bit PC cards.
Optical devices
A DVD Super Multi drive is equipped.
2 Satellite P500 and Satellite Pro500 Maintenance Manual (960-Q08)
Chapter 1 Hardware Overview
Battery
The RTC battery is equipped inside the computer.
It is good with no external power source for 1month on average.
The main battery is a detachable lithium ion battery.
6 cell Li-Ion 10.8v/4000mAh
12 cell Li-Ion 10.8v/8000mAh
USB (Universal Serial Bus)
4 USB ports are provided. The ports comply with the USB2.0 standard, which enable data transfer speeds 40 times faster than USB1.1 standard. USB1.1 is also supported.
ESATA
One ESATA port is equipped.
Sound system
Internal stereo speaker, Internal MIC (Option) external monaural microphone connector, stereo headphone connector.
Wireless LAN
The wireless LAN is equipped on the mini card slot.
LAN/MODEM
Connectors for LAN and Modem are separately mounted.
1394
One 1394 port is equipped.
Multiple Digital Media Card Slot XD/MS/MS pro/SD/MMC are supported
Bluetooth
USB Bluetooth Module standard Ver 2.1 & EDR(Enhanced Data Rate) equipped
Satellite P500 and Satellite Pro500 Maintenance Manual (960-Q08) |
|
3 |
Chapter 1 Hardware Overview
Security Kensington Lock,
Fingerprint –Enhanced Lock is also equipped.
HDD Password
3D Accelerometer for HDD
4 Satellite P500 and Satellite Pro500 Maintenance Manual (960-Q08)
Chapter 1 Hardware Overview
|
|
|
|
1. Web Camera LED* |
2. Web Camera* |
||
3. |
Built-in microphone* |
4. Wireless LAN Antenna* |
|
5. |
Speaker |
6. Touch Pad |
|
7. |
Fingerprint Sensor* |
8. Touch Pad Control Buttons |
|
9. |
Display Screen |
10. Speaker |
|
11. |
Power Button* |
12. |
Internet Button* |
13. |
CD/ DVD Button* |
14. Previous Button* |
|
15. |
Volume Down Button* |
16. Mute Button* |
|
17. |
Play/Pause Button* |
18. |
Next Button* 19. Volume Up Button* |
Figure 1-1 Front of the computer
Satellite P500 and Satellite Pro500 Maintenance Manual (960-Q08) |
|
5 |
Chapter 1 Hardware Overview
1.2 System Block Diagram
Figure 1-2 shows the system block diagram.
Figure 1-2 System block diagram for Intel Platform
6 Satellite P500 and Satellite Pro500 Maintenance Manual (960-Q08)
Chapter 1 Hardware Overview
The PC contains the following components.
CPU
1.Intel® Core™2 Duo Mobile Processor T9900 3.06GHz
T9800 2.93GHz
T9600 2.8GHz
T9550 2.66GHz
P9600 2.66GHz
P8700 2.53GHz
P8600 2.40GHz
P7450 2.13GHz
T6600 2.20GHz
T6400 2.00GHz
2.Intel® Pentium® Dual-Core mobile processor T4200 2.00GHz
T3400 2.16GHz
3. Intel® Celeron® Processor
T1700 1.83GHz
T1600 1.66GHz
Celeron 585 2.16GHz
Memory
Two memory slots capable of accepting DDRII-SDRAM 512MB,1GB, 2GB or 4GB memory modules for a maximum of 4GB.
•200-pin SO-DIMM
•1.8V operation
Satellite P500 and Satellite Pro500 Maintenance Manual (960-Q08) |
|
7 |
Chapter 1 Hardware Overview
BIOS ROM (Flash memory)
•16Mbit
Chipset (Montevina Platform)
This gate array has the following elements and functions.
•North Bridge (Intel PM45,GM45/GL40)
−Merom-M processor System Bus support
−DRAM Controller : DDRII 667/800 support
−DMI
−1299-ball 35 x 35mm Mirco FC-BGA Package
•South Bridge (Intel 82801HBM ICH9-M)
−Direct Media Interface (DMI)
−PCI Express
−Serial ATA (SATA) Controller
−PCI Interface
−Low Pin count (LPC) interface
−Serial Peripheral Interface (SPI)
−DMA controller
−Advanced Programmable Interrupt Controller (APIC)
−USB Controllers
−Gigabit Ethernet Controller
−RTC
−GPIO
−Enhanced Power Management
−SMBus 2.0
−High Definition Audio Controller
−676-pin 31mmx31mm mBGA Package
Other main system chips
• Clock Generator (Montevina Platform: ICS9LPRS365BGLF)
• EC/KBC –[W/CIR(Winbond WPCE775CA0DG)] –[WO/CIR(Winbond WPCE775LA0DG)]
• HD Audio (CONEXANT CX20583-10Z)
8 Satellite P500 and Satellite Pro500 Maintenance Manual (960-Q08)
Chapter 1 Hardware Overview
• Card Reader controller (O2 OZ888GS0LN)
• 10/100 LAN controller (Atheros AR8132M)
• Giga LAN controller (Atheros AR8131M)
Mini Card
Wireless LAN card (BTO)
5.4GHz DSSS/OFDM LAN card is equipped. Conformity with IEEE 802.11b/g, IEEE 802.11 a/g/n and IEEE 802.11a/b/g..
MODEM (Conexant x 1)
Supported by on board Modem + DAA daughter card. Data and FAX transmission is available.
Supports ITU-TV.90.
The transfer speed of data receiving is 56kbps, of data sending is 33.6kbps and of FAX is 14.4kbps. Actual speed depends on the quality of the line used. Connected to telephone line through RJ11 MOD
Blue tooth
Mini USB Bluetooth Module (BTO) V2.1.
Satellite P500 and Satellite Pro500 Maintenance Manual (960-Q08) |
|
9 |
Chapter 1 Hardware Overview
1.3 2.5-inch Hard Disk Drive
A compact, high-capacity HDD with a height of 9.5mm. Contains a 2.5-inch magnetic disk and magnetic heads.
Figure 1-3 shows a view of the 2.5-inch HDD and Tables 1-1 and 1-2 list the specifications.
Figure 1-3 2.5-inch HDD
Table 1-1 2.5-inch HDD dimensions
|
|
|
|
Standard value |
|
|
|||
Parameter |
TOSHIBA |
TOSHIBA |
|
|
TOSHIBA |
|
TOSHIBA |
TOSHIBA |
|
|
|
MK1246GS |
MK1646GS |
|
|
MK2046GS |
|
MK2546GS |
MK3252GSX |
|
|
X |
X |
|
|
X |
|
X |
|
|
|
|
|
|
|
||||
Outline |
Width (mm) |
|
|
69.85 +/- 0.25 |
|
|
|||
|
|
|
|
|
|
|
|
|
|
Height (mm) |
|
|
9.5 |
|
|
|
|||
dimens |
|
|
|
|
|
||||
|
|
|
|
|
|
|
|||
Depth (mm) |
|
|
100.2 +/- 0.25 |
|
|
||||
ions |
|
|
|
|
|
|
|
|
|
|
Weight (g) |
97/98 |
97/98 |
|
101//102 |
|
101//102 |
||
|
|
|
|
|
|
|
|
|
|
Parameter |
|
Standard value |
|
|||
|
|
FUJITSU |
FUJITSU |
|
FUJITSU |
FUJITSU |
|
|
MHY2120BH |
MHY2160BH |
|
MHY2200BH |
MHY2250BH |
|
Width |
|
|
100 |
|
|
Outline |
(mm) |
|
|
|
|
|
dimensi |
Height |
|
|
9.5 |
|
|
ons |
(mm) |
|
|
|
|
|
|
Depth |
|
|
70 |
|
|
|
(mm) |
|
|
|
|
|
|
Weight |
|
|
101(Max) |
|
|
|
(g) |
|
|
|
|
|
10 Satellite P500 and Satellite Pro500 Maintenance Manual (960-Q08)
Chapter 1 Hardware Overview
Parameter |
|
Standard value |
|
|
|||
|
|
|
|
|
|
|
|
|
|
HITACHI |
HITACHI |
|
HITACHI |
|
HITACHI |
|
|
HTS542512k9SA0 |
HTS542516k9SA |
|
HTS542520k9SA |
|
HTS542525k9S |
|
|
0 |
00 |
|
00 |
|
A00 |
|
|
|
|
|
|
|
|
|
Width (mm) |
|
69.85 +/- 0.25 |
|
|
||
Outlin |
|
|
|
|
|
|
|
Height (mm) |
|
9.5 |
|
|
|
||
e |
|
|
|
|
|||
|
|
|
|
|
|
|
|
dimen |
|
|
|
|
|
|
|
Depth (mm) |
|
100.2 +/- 0.25 |
|
|
|||
sions |
|
|
|
|
|
|
|
|
Weight (g) |
95 (max.) |
95 (max.) |
|
102 (max.) |
102 (max.) |
|
|
|
|
|
|
|
|
|
Table 1-2 2.5-inch HDD dimension
Parameter |
|
Standard value |
|
|
|
|
FUJITSU |
FUJITSU |
FUJITSU |
|
|
MHX2250BT |
MHX2300BT |
MHZ2400BT |
|
|
|
|
|
|
Width |
|
100 |
|
Outline |
(mm) |
|
|
|
dimensi |
Height |
|
12.5 |
|
ons |
(mm) |
|
|
|
|
Depth |
|
70.0 |
|
|
(mm) |
|
|
|
|
Weight |
|
101(Max) |
|
|
(g) |
|
|
|
Satellite P500 and Satellite Pro500 Maintenance Manual (960-Q08) |
|
11 |
Chapter 1 Hardware Overview
Table 1-3 2.5-inch HDD specifications
|
|
|
|
|
|
|
|
|
Specification |
|
|
|
|
|||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
Parameter |
|
|
TOSHIBA |
|
TOSHIBA |
|
|
TOSHIBA |
|
TOSHIBA |
TOSHIBA |
|
|||
|
|
|
MK1246G |
|
MK1646GS |
|
|
MK2046G |
|
MK2546G |
MK3252G |
|
||||
|
|
|
|
|
SX |
|
X |
|
|
SX |
|
SX |
SX |
|
||
|
Storage size (formatted) |
|
|
120GB |
|
160GB |
|
|
200GB |
|
250 GB |
320GB |
|
|||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
Speed (RPM) |
|
|
|
|
|
|
5,400 |
|
|
|
|
|
|||
|
Data transfer Rate |
|
|
|
|
|
|
|
|
|
|
|
|
794Mbits |
|
|
|
- To/From Media |
|
|
|
|
|
730Mbits Media |
|
|
Media |
|
|||||
|
- T0/From Host |
|
|
|
|
|
300MBytes Host |
|
|
3GBytes |
|
|||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
Host |
|
|
bus transfer rate (MB/s) |
|
|
|
|
|
1.5Gbps(150MB/s) |
|
|
|
|
|||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
Average random seek time |
|
|
|
|
|
12 |
|
|
|
|
|
||||
|
(read) (ms) |
|
|
|
|
|
|
|
|
|
|
|
||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
||
|
Power-on-to-ready (sec) |
|
|
|
|
|
3.5(typ)/9.5(Max) |
|
|
|
|
|||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
||
|
|
|
|
|
|
Specification |
|
|
|
|
|
|
|
|
||
|
|
|
|
|
|
|
|
|
|
|
||||||
Parameter |
|
FUJITSU |
|
|
FUJITSU |
|
|
FUJITSU |
|
FUJITSU |
||||||
|
|
MHY2120BH |
|
MHY2160BH |
|
|
MHY2200BH |
|
MHY2250BH |
|||||||
Storage size |
|
80GB |
|
|
|
120GB |
|
|
200GB |
|
250GB |
|||||
(formatted) |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
||||
Speed (RPM) |
|
|
|
|
|
5,400 |
|
|
|
|
|
|||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
Data transfer Rate |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
- To/From Media |
|
|
|
|
|
|
84.6MB/s Max. |
|
|
|
|
|||||
- T0/From Host |
|
|
|
|
|
|
1.5Gbps (150MB/s) |
|
|
|
|
|||||
|
|
|
|
|
|
|
1.5Gbps(150MB/s) |
|
|
|
|
|||||
bus transfer rate |
|
|
|
|
|
|
|
|
|
|
||||||
(MB/s) |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
12.0ms/14.0ms |
|
|
|
|
|||||
Average random seek |
|
|
|
|
|
|
|
|
|
|
||||||
time (read) (ms) |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
4.0 (typ.) |
|
|
|
|
|||||
Power-on-to-ready |
|
|
|
|
|
|
|
|
|
|
||||||
(sec) |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
12 Satellite P500 and Satellite Pro500 Maintenance Manual (960-Q08)
Chapter 1 Hardware Overview
Specification
Parameter |
HITACHI |
|
HITACHI |
|
HITACHI |
|
HITACHI |
|
HTS542512k9 |
HTS542516k9S |
HTS542520k9SA |
HTS542525k9SA0 |
|||
|
SA00 |
|
A00 |
00 |
0 |
||
|
|
|
|
|
|
|
|
Storage size (formatted) |
120GB |
|
160GB |
|
200GB |
|
250GB |
|
|
|
|
|
|
|
|
Speed (RPM) |
|
|
|
5,400 |
|
|
|
|
|
|
|
|
|
|
|
Data transfer Rate |
|
|
|
|
|
|
|
- To/From Media |
65.5MB/s |
|
65.5MB/s |
|
65.5MB/s |
|
65.5MB/s |
- T0/From Host |
1.5Gbps |
|
1.5Gbps |
|
1.5Gbps |
|
1.5Gbps |
|
|
|
|
|
|
|
|
bus transfer rate (MB/s) |
|
|
150 (MB/s |
|
|
||
|
|
|
|
|
|||
|
|
|
|
11 |
|
|
|
Average random seek time |
|
|
|
|
|
|
|
(read) (ms) |
|
|
|
|
|
|
|
|
|
|
3.5 sec |
|
|
||
Power-on-to-ready (sec) |
|
|
|
|
|||
|
|
|
|
|
|
|
|
Specification
Parameter |
FUJITSU |
FUJITSU |
|
FUJITSU |
|
MHX2250BT |
MHX2300BT |
|
MHZ2400BT |
|
|
|
|
|
Storage size |
250GB |
300GB |
|
400GB |
(formatted) |
|
|
|
|
|
|
|
|
|
Speed (RPM) |
|
|
4,200 |
|
|
|
|
|
|
Data transfer Rate |
|
|
|
|
- To/From Media |
|
6 .8MB/s Max. |
|
|
- T0/From Host |
|
1.5Gbps (150MB/s) |
|
|
|
|
|
||
|
|
1.5Gbps (150MB/s) |
|
|
bus transfer rate |
|
|
||
(MB/s) |
|
|
|
|
|
|
12.0ms/14.0ms |
|
|
Average random seek |
|
|
||
time (read) (ms) |
|
|
|
|
|
|
4.0 (typ) |
|
|
Power-on-to-ready |
|
|
||
(sec) |
|
|
|
|
|
|
|
|
|
|
|
|
Satellite P500 and Satellite Pro500 Maintenance Manual (960-Q08) |
13 |
|
Loading...