|
|
Toshiba Personal Computer
Satellite L510
(PSLFx)
Maintenance Manual
TOSHIBA CORPORATION
S/ NO
Satellite / Satellite Pro L510 / L515 / L517 Maintenance Manual |
|
Copyright
© 2009 by Toshiba Corporation. All rights reserved. Under the copyright laws, this manual cannot be reproduced in any form without the prior written permission of Toshiba. No patent liability is assumed with respect to the use of the information contained herein.
Toshiba Satellite / Satellite Pro L510 / L515 / L517 Maintenance Manual
First edition May of 2009
Disclaimer
The information presented in this manual has been reviewed and validated for accuracy. The included set of instructions and descriptions are accurate for the Satellite / Satellite Pro L510 / L515 / L517 at the time of this manual's production. However, succeeding computers and manuals are subject to change without notice. Therefore, Toshiba assumes no liability for damages incurred directly or indirectly from errors, omissions, or discrepancies between any succeeding product and this manual.
Trademarks
Intel and Pentium are registered trademarks of Intel Corporation. IBM, IBM PC/XT, PC/AT, PS/2 and OS/2 are registered trademarks of IBM Corporation. Windows Vista home edition are registered trademarks of Microsoft Corporation. Sound Blaster and Pro are trademarks of Creative Technology Ltd. UNIX is a registered trademark of X/Open Company Ltd. NetWare are registered trademarks of Novell, Inc. All other properties are trademarks or registered trademarks of their respective holders.
II |
Satellite / Satellite Pro L510 / L515 / L517 Maintenance Manual |
|
|
Preface
This maintenance manual describes how to perform hardware service maintenance for the
Toshiba Personal Computer Satellite / Satellite Pro L510 / L515 / L517, referred to as
Satellite / Satellite Pro L510 / L515 / L517 in this manual.
The procedures described in this manual are intended to help service technicians isolate faulty Field Replaceable Units (FRUs) and replace them in the field.
SAFETY PRECAUTIONS
Four types of messages are used in this manual to bring important information to your attention. Each of these messages will be italicized and identified as shown below.
DANGER: “Danger” indicates the existence of a hazard that could result in death or serious bodily injury, if the safety instruction is not observed.
WARNING: “Warning” indicates the existence of a hazard that could result in bodily injury, if the safety instruction is not observed.
CAUTION: “Caution” indicates the existence of a hazard that could result in property damage, if the safety instruction is not observed.
NOTE: “Note” contains general information that relates to your safe maintenance service.
Improper repair of the computer may result in safety hazards. Toshiba requires service technicians and authorized dealers or service providers to ensure the following safety precautions are adhered to strictly.
Be sure to fasten screws securely with the right screwdriver. If a screw is not fully fastened, it could come loose, creating a danger of a short circuit, which could cause overheating, smoke or fire.
If you replace the battery pack, RTC battery or backup battery, be sure to use only the same model battery or an equivalent battery recommended by Toshiba. Installation of the wrong battery can cause the battery to explode.
Satellite / Satellite Pro L510 / L515 / L517 Maintenance Manual |
III |
The manual is divided into the following parts:
Chapter 1 Hardware Overview describes the Satellite / Satellite Pro L510 / L515 /
L517 system unit and each FRU.
Chapter 2 Troubleshooting Procedures explains how to diagnose and resolve
FRU problems.
Chapter 3 Test and Diagnostics describes how to perform test and diagnostic
operations for maintenance service.
Chapter 4 Replacement Procedures describes the removal and replacement of the
FRUs.
Appendices The appendices describe the following:
Handling the LCD moduleBoard layout
Pin Assignments
Keyboard scan/character codesKey layout
IV |
Satellite / Satellite Pro L510 / L515 / L517 Maintenance Manual |
|
|
Conventions
This manual uses the following formats to describe, identify, and highlight terms and operating procedures.
Acronyms
On the first appearance and whenever necessary for clarification acronyms are enclosed in parentheses following their definition. For example:
Read Only Memory (ROM)
Keys
Keys are used in the text to describe many operations. The key top symbol as it appears on the keyboard is printed in boldface type.
Key operation
Some operations require you to simultaneously use two or more keys. We identify such operations by the key top symbols separated by a plus (+) sign. For example, Ctrl + Pause (Break) means you must hold down Ctrl and at the same time press Pause (Break). If three keys are used, hold down the first two and at the same time press the third.
User input
Text that you are instructed to type in is shown in the boldface type below:
DISKCOPY A: B:
The display
Text generated by the XXXXX that appears on its display is presented in the type face below:
Format complete
System transferred
Satellite / Satellite Pro L510 / L515 / L517 Maintenance Manual |
V |
Table of Contents
Chapter 1 |
Hardware Overview |
|
1.1 Features ............................................................................................................................... |
|
1 |
1.2 System Unit Components.................................................................................................... |
9 |
|
1.3 2.5-inch HDD .................................................................................................................... |
|
14 |
1.4 DVD Super Multi (+-R Double Layer) ............................................................................. |
15 |
|
1.5 Power Supply .................................................................................................................... |
|
16 |
1.6 Batteries............................................................................................................................. |
|
17 |
1.1.1 Main Battery .......................................................................................... |
17 |
|
1.1.2 Battery Charging Control....................................................................... |
17 |
|
1.1.3 |
RTC Battery........................................................................................... |
18 |
Chapter 2 Troubleshooting |
|
||
2.1 |
Outline .................................................................................................................... |
|
2-1 |
2.2 |
Basic Flowchart ...................................................................................................... |
|
2-2 |
2.3 |
Power Supply.......................................................................................................... |
|
2-6 |
|
Procedure 1 Power Icon Check ........................................................................... |
2-6 |
|
|
Procedure 2 Connection Check ........................................................................... |
2-8 |
|
|
Procedure 3 Replacement Check......................................................................... |
2-8 |
|
2.4 |
System Board .......................................................................................................... |
|
2-9 |
|
Procedure 3 Replacement Check..................................................................... |
2-10 |
|
2.5 |
HDD...................................................................................................................... |
|
2-11 |
|
Procedure 1 Message Check.............................................................................. |
2-11 |
|
|
Procedure 2 |
Partition Check....................................................................... |
2-11 |
|
Procedure 3 |
Format Check .......................................................................... |
2-12 |
|
Procedure 4 |
Test Program Check ................................................................ |
2-13 |
|
Procedure 5 |
Connector Check and Replacement Check ............................. |
2-14 |
2.6 |
Keyboard............................................................................................................... |
|
2-15 |
|
Procedure 1 Test Program Check ....................................................................... |
2-15 |
|
VI |
Satellite / Satellite Pro L510 / L515 / L517 Maintenance Manual |
|
|
|
|
|
|
Procedure 2 Connector Check and Replacement Check .................................... |
2-15 |
||
2.7 |
Display .................................................................................................................. |
|
|
2-16 |
|
Procedure 1 |
External Monitor Check.......................................................... |
2-16 |
|
|
Procedure 2 |
Test Program Check ................................................................ |
2-16 |
|
|
Procedure 3 |
Connector Check and Replacement Check ............................. |
2-16 |
|
2.8 |
ODD (Optical Disk Drive).................................................................................... |
2-18 |
||
|
Procedure 1 |
ODD Cleaning Check ............................................................. |
2-18 |
|
|
Procedure 2 |
Test Program Check ................................................................ |
2-18 |
|
|
Procedure 3 |
Connector Check and Replacement Check ............................. |
2-18 |
|
2.9 |
LAN ...................................................................................................................... |
|
|
2-20 |
|
Procedure 1 |
Test Program Check ................................................................ |
2-20 |
|
|
Procedure 2 |
Connector Check and Replacement Check ............................. |
2-20 |
|
2.10 |
Audio Test ............................................................................................................ |
|
2-21 |
|
|
Procedure 1 Test Program Check ....................................................................... |
2-21 |
||
|
Procedure 2 Connector Check and Replacement Check .................................... |
2-21 |
||
2.11 |
Cooling Module .................................................................................................... |
|
2-22 |
|
|
Procedure 1 |
Test Program Check ................................................................ |
2-22 |
|
|
Procedure 2 |
Connector Check and Replacement Check ............................. |
2-22 |
|
|
|
|
|
|
Chapter 3 |
Diagnostic Programs |
|
||
3.1 |
General....................................................................................................................... |
|
|
1 |
3.2 |
Quick Start ................................................................................................................. |
|
3 |
|
|
3.2.1 |
Quick Test................................................................................................ |
3 |
|
|
3.2.2 |
Customization Test .................................................................................. |
3 |
|
|
3.2.3 |
Keyboard Layout test ............................................................................... |
7 |
|
|
3.2.4 |
Hotkey Test.............................................................................................. |
8 |
|
|
3.2.5 |
Audio Play Test ....................................................................................... |
8 |
|
|
3.2.6 |
Audio Record Test ................................................................................... |
9 |
|
|
3.2.7 |
DMI Read ................................................................................................ |
9 |
|
|
3.2.8 |
DMI Write ............................................................................................... |
9 |
|
|
3.2.9 |
3D Sensor Test....................................................................................... |
11 |
|
Satellite / Satellite Pro L510 / L515 / L517 Maintenance Manual |
VII |
|
|
|
|
|
3.2.10 System Information................................................................................ |
11 |
|
|
3.2.11 View Logs.............................................................................................. |
12 |
|
|
3.2.12 Exit to 700 DOS .................................................................................. |
12 |
|
|
3.2.13 The Diagnostics Screen Explanation ..................................................... |
13 |
|
3.3 |
Options..................................................................................................................... |
|
16 |
|
3.3.1 |
Overview................................................................................................ |
16 |
|
3.3.2 |
Batch Parameters Configuration ............................................................ |
17 |
|
3.3.3 |
Item’s Parameters Configuration ........................................................... |
19 |
|
3.3.4 |
Load Batch Parameters .......................................................................... |
20 |
|
3.3.5 |
Save Batch Parameters .......................................................................... |
21 |
|
3.3.6 |
LOG Parameters Setting ........................................................................ |
21 |
|
3.3.7 |
Specify LOG Viewer ............................................................................. |
22 |
|
3.3.8 |
Display LOG File................................................................................... |
23 |
|
3.3.9 |
LOG Viewer .......................................................................................... |
23 |
|
3.3.10 LOG File Sample ................................................................................... |
25 |
|
3.4 |
Subtests .................................................................................................................... |
|
26 |
3.5 |
System Test.............................................................................................................. |
29 |
|
3.6 |
Memory Test............................................................................................................ |
34 |
|
3.7 |
Storage ..................................................................................................................... |
|
40 |
3.8 |
Video ....................................................................................................................... |
|
44 |
3.9 |
Communication (COMM) ....................................................................................... |
52 |
|
3.10 |
Peripheral ................................................................................................................. |
53 |
|
3.11 |
Error Codes and description .................................................................................... |
55 |
|
3.12 |
Quick Test Item List ................................................................................................... |
i |
|
Chapter 4 |
Replacement Procedures |
|
|
4.1 |
General.................................................................................................................... |
|
4-1 |
|
Safety Precautions ................................................................................................ |
4-2 |
|
|
Before You Begin................................................................................................. |
4-4 |
|
|
Disassembly Procedures....................................................................................... |
4-5 |
|
|
Assembly Procedures ........................................................................................... |
4-5 |
|
|
Tools and Equipment ........................................................................................... |
4-6 |
|
VIII |
Satellite / Satellite Pro L510 / L515 / L517 Maintenance Manual |
|
|
Screw Tightening Torque ..................................................................................... |
4-6 |
Colors of Screw Shanks ....................................................................................... |
4-7 |
Symbols of Screws on the Computer Body.......................................................... |
4-7 |
Symbol examples ................................................................................................. |
4-7 |
4.2 Battery Pack/PC Card/ Memory Card ........................................................................ |
4-8 |
4.2.1 Removing the Battery Pack…………………………………………..…...4-8
Installing the Battery Pack............................................................….....….4-9 4.2.2 Removing the PC Card…………………………………………….....…4-10 Installing the PC Card………………………………………..………….4-11
4.2.3 Removing the Memory Card...…………………………….…….………4-12
Installing the Memory Card………………………………..………...….4-13 4.3 Memory module…….………………………………………………………………4-14
Removing the Memory module………………………………………………..4-14
Installing the Memory module…………………………………………...……4-15
4.4 HDD………………………………………………………….…………………..….4-16
Removing the HDD............................................................................................ |
4-16 |
Installing the HDD ............................................................................................. |
4-18 |
4.5 MDC Module…………………………………………………………………..…….4-19
Removing the MDC Module.............................................................................. |
4-19 |
Installing the MDC Module ............................................................................... |
4-20 |
4.6 ODD Bay Module……………………………………………………………..……..4-21
|
Removing the ODD Bay Module ....................................................................... |
4-21 |
|
Installing the ODD Bay Module................................................................... |
4-22 |
|
Disassembling the ODD Bay Module .......................................................... |
4-23 |
|
Assembling the ODD Bay Module............................................................... |
4-23 |
4.7 |
Keyboard............................................................................................................... |
4-24 |
|
Removing the Keyboard............................................................................... |
4-24 |
|
Installing the Keyboard ................................................................................ |
4-26 |
4.8 Wireless LAN Card .............................................................................................. |
4-27 |
|
|
Removing the Wireless LAN Card .............................................................. |
4-27 |
|
Installing the Wireless LAN Card ................................................................ |
4-28 |
4.9 |
Top Cover ............................................................................................................ |
4-29 |
Satellite / Satellite Pro L510 / L515 / L517 Maintenance Manual |
IX |
|
|
|
|
Removing the Top Cover ............................................................................... |
4-29 |
|
Installing the Top Cover................................................................................. |
4-31 |
4.10 Display Assembly................................................................................................ |
4-32 |
|
|
Removing the Display Assembly ................................................................... |
4-32 |
|
Installing the Display Assembly..................................................................... |
4-33 |
4.11 System Board, DC-IN Cable, RJ11 cable, USB cable and Bluetooth card ......... |
4-34 |
|
|
Removing the System Board, DC-IN, RJ11, USB and Bluetooth card……..4-34 |
|
|
Installing the System Board, DC-IN, RJ11, USB and Bluetooth card.. ......... |
4-35 |
4.12 CPU Cooling Module and Fan .......................................................................... |
….4-36 |
|
|
Removing the CPU Cooling module and Fan ................................................ |
4-36 |
|
Installing the CPU Cooling module and Fan.................................................. |
4-39 |
|
Removing the CPU Cooling module and Fan (For VGA Module)................ |
4-40 |
|
Installing the CPU Cooling module and Fan (For VGA Module) ................. |
4-43 |
4.13 CPU ........................................................................................................................ |
4-44 |
|
|
Removing the CPU......................................................................................... |
4-44 |
|
Installing the CPU .......................................................................................... |
4-45 |
4.14 Display Mask .......................................................................................................... |
4-47 |
|
|
Removing the LCD Display Mask ................................................................. |
4-47 |
|
Installing the LCD Display Mask ................................................................... |
4-48 |
4.15 LCD Module ........................................................................................................... |
4-49 |
|
|
Removing the LCD module .......................................................................... |
4-49 |
|
Installing the LCD Module............................................................................. |
4-51 |
4.16 |
CCD board and MIC............................................................................................... |
4-52 |
|
Removing the CCD and MIC ............................................................................... |
4-52 |
|
Installing the CCD and MIC ................................................................................ |
4-53 |
4.17 |
Speakers, Switch Board and button board .............................................................. |
4-54 |
|
Removing the Speakers, Switch Board and button board .................................... |
4-54 |
|
Installing the Speakers, Switch Board and button board...................................... |
4-56 |
|
|
|
|
|
|
X |
Satellite / Satellite Pro L510 / L515 / L517 Maintenance Manual |
|
|
Appendices |
|
|
Appendix A |
Handling the LCD Module............................................................................ |
A-1 |
Appendix B |
Board Layout ................................................................................................. |
B-1 |
Appendix C |
Pin Assignments ............................................................................................ |
C-1 |
Appendix D |
Keyboard Scan/Character Codes ................................................................... |
D-1 |
Appendix E |
Key Layout .................................................................................................... |
E-1 |
|
|
|
|
|
|
|
|
|
Satellite / Satellite Pro L510 / L515 / L517 Maintenance Manual |
XI |
Chapter 1
Hardware Overview
i |
Satellite / Satellite Pro L510 / L515 / L517 Maintenance Manual |
1 Hardware Overview
ii |
Satellite / Satellite Pro L510 / L515 / L517 Maintenance Manual |
|
|
1 Hardware Overview |
|
|
|
|
|
|
|
|
|
Chapter 1 |
Contents |
|
|
|
|
1.1 Features ............................................................................................................................... |
|
1 |
1.2 System Unit Components .................................................................................................... |
9 |
|
1.3 2.5-inch HDD .................................................................................................................... |
|
14 |
1.4 DVD Super Multi (+-R Double Layer) ............................................................................. |
15 |
|
1.5 Power Supply .................................................................................................................... |
|
16 |
1.6 Batteries............................................................................................................................. |
|
17 |
1.1.1 |
Main Battery .......................................................................................... |
17 |
1.1.2 |
Battery Charging Control....................................................................... |
17 |
1.1.3 |
RTC Battery........................................................................................... |
18 |
|
|
|
Satellite / Satellite Pro L510 / L515 / L517 Maintenance Manual |
iii |
1 Hardware Overview
Figures |
|
Figure 1-1 ID Parts Description Placement ............................................................................... |
6 |
Figure 1-2 Computer Block Diagram ........................................................................................ |
7 |
Figure 1-3 System Board Configurations .................................................................................. |
8 |
Figure 1-4 System Unit Block Diagram..................................................................................... |
9 |
Figure 1-5 SATA HDD............................................................................................................ |
14 |
Figure 1-6 DVD Super Multi drive.......................................................................................... |
15 |
|
|
Tables |
|
Table 1-1 HDD Specifications ................................................................................................. |
14 |
Table 1-2 DVD Super Multi Drive Specifications................................................................... |
15 |
Table 1-3 Battery specifications............................................................................................... |
17 |
Table 1-4 Quick/Normal charging time ................................................................................... |
18 |
iv |
Satellite / Satellite Pro L510 / L515 / L517 Maintenance Manual |
1 Hardware Overview |
1.1 Features |
|
|
1.1 Features
The Toshiba Satellite / Satellite Pro L510 / L515 / L517 is a full size notebook PC based on the Intel Penryn processors, providing high-speed processing capabilities and advanced features. The computer employs a Lithium Ion battery that allows it to be battery-operated for a longer period of time. The display uses 14-inch LED HD panel. The Micro-FCPGA socket supports BTO for the CPU so that the system can be designed to suit your needs.
The computer has the following features.
Processor
The CPU is the Intel Processor.
Core2 Duo Mobile Processor (1066MHz)
P7350(2.0G) Hz
Core2 Duo Mobile Processor (800MHz)
T6500(2.1G) Hz
Pentium Dual Core Processor (800MHz)
T4200(2.0G)/T4300(2.1G) Hz
Celeron Processor (800MHz)
900(2.2G) Hz
Host Bridge System Controller
System Controller: Intel Cantiga GM45/GL40 + ICH9M
Graphics
Intel GL40 integrated and GM45 with ATI M92XT graphic.
Memory
The computer has two SO-DIMMs slot comes standard with DDRII-800MHz module. It supports PC2-6400 and uses SO-DIMMs (DDRII SDRAM) driven at 1.8 V, accepting BTO/CTO for your memory requirements. It can incorporate up to 8 GB of main memory.
Using the following sizes of memory modules:
1 |
Satellite / Satellite Pro L510 / L515 / L517 Maintenance Manual |
1 Hardware Overview 1.1 Features
1024 MB (128M×64)/800 MHZ
2048 MB (256Mx64)/800 MHZ
4096 MB (512Mx64)/800 MHZ
Hard Disk Drive (HDD)
The computer accommodate 9.5 mm height HDD with following storage capacities:
120 GB (9.5 mm thick) SATA (5,400rpm)
160 GB (9.5 mm thick) SATA (5,400rpm)
250 GB (9.5 mm thick) SATA (5,400rpm)
320 GB (9.5 mm thick) SATA (5,400rpm)
400 GB (9.5 mm thick) SATA (5,400rpm)
500 GB (9.5 mm thick) SATA (5,400rpm)
ODD
The computer accommodates a fixed 12.7 mm SATA ODD with one of following types:
DVD Super Multi +-R Double Layer drive
DVD Super Multi +-R Double Layer with Label Flash
Display
The LCD displays available come with one of following types:
14” Standard LED HD color display, resolution 1366×768
Keyboard
The keyboard has 28 kinds’ countries key.
Battery
The computer has a removable 6/12 Cell Lithium Ion battery pack.
Universal Serial Bus (USB) Ports
2 |
Satellite / Satellite Pro L510 / L515 / L517 Maintenance Manual |
1.1 Features |
1 Hardware Overview |
|
|
|
|
The computer has two USB 2.0 ports and one eSATA/USB combo port. It is supported to daisy-chain a maximum of 127 USB devices. The serial data transfer rate is 480 Mbps or 12 Mbps and 1.5 Mbps. These ports support PnP installation and hot plugging.
External Monitor Port
A 15-pin external monitor port is provided, through which the computer automatically recognizes an external VESA DDC 2B compatible monitor.
Multiple Digital Media Card Slot
This computer is equipped with Multiple Digital Media Card Slot that can accommodate SD/ Mini-SD/ Micro-SD/ SD-IO/ SDHC/ MS/ MS Pro/ MMC/ XD memory cards. This slot is for your memory card requirements to provide memory card read on your computer
Toshiba Pointing Device
Toshiba Pointing Device has one kind of Normal touchpad only.
Sound System
The ALC272 integrated audio controller supports multimedia. The sound system contains the following:
Stereo speakers
Headphone jack
Internal microphone
External microphone jack
LAN
The internal LAN board supports 10/100Mbit , enabling connection to a LAN at up to 100Mbps. It also supports Wake-up on LAN from S3/S4/S5 and PXE boot support. The LAN board has RJ45 jack to directly accommodate a LAN cable.
Wireless LAN
The internal Mini Card slot supports IEEE802.11bg (MOW) / IEEE802.11abg (MOW)/ IEEE802.11abgn (MOW)/ IEEE802.11bgn (MOW) card. The Antenna has two or three wires dual band antenna support (depends on module).
Internal Modem (BTO)
Satellite / Satellite Pro L510 / L515 / L517 Maintenance Manual |
3 |
1 Hardware Overview |
1.1 Features |
|
|
The computer contains a MDC, enabling data and fax communication. It supports ITU- T V.90 (for rest countries)/V.92 (America, Canada, UK, Germany & France). The transfer rates are 56 Kbps for data reception, 33.6 Kbps for data transmission and 14,400 bps for fax transmission. Note, however, that the actual speed depends on the line quality. The RJ11 modem jack is used to accommodate a telephone line.
PCI Express Slot (BTO)
The ICH9-M provides PCI Express root ports which are compliant to the PCI Express Base Specification, Revision 1.0a. The root port supports 2.5 Gb/s bandwidth in each direction (5 Gb/s concurrent) and two virtual channels for full isochronous data support.
CD Key (BTO)
The CD Key supports to play Audio CD directly.
Internal Camera (BTO with Microphone)
The computer has an internal camera. The camera has VGA (640*480) fixed focus.
HDMI Out Port (BTO)
A HDMI monitor can be connected to the HDMI out port on the computer.
The computer has HDMI out port and support BTO.
Bluetooth (BTO)
Bluetooth wireless technology eliminates the need for cables between electronic device such as computers, printers and mobile phones.
4 |
Satellite / Satellite Pro L510 / L515 / L517 Maintenance Manual |
1.1 Features |
1 Hardware Overview |
|
|
|
|
Figures 1-1/1-2/1-3 and 1-4 show the computer and its system unit configuration, respectively.
Figure 1-1 ID Parts Description Placement
Satellite / Satellite Pro L510 / L515 / L517 Maintenance Manual |
5 |
1 Hardware Overview |
1.1 Features |
|
|
Figure 1-2 Computer Block Diagram
6 |
Satellite / Satellite Pro L510 / L515 / L517 Maintenance Manual |
1.1 Features |
1 Hardware Overview |
|
|
|
|
Figure 1-3 System Board Configurations
Satellite / Satellite Pro L510 / L515 / L517 Maintenance Manual |
7 |
1 Hardware Overview |
1.2 System Unit Components |
|
|
1.2 System Unit Components
Figure 1-4 is Block Diagram of the System Unit.
Figure 1-4 System Unit Block Diagram
8 |
Satellite / Satellite Pro L510 / L515 / L517 Maintenance Manual |
1.2 System Unit Components |
1 Hardware Overview |
|
|
The system unit of the computer consists of the following components:
Processor: Core2 Duo Mobile and Core and Celeron Processor.
Core2 Duo Mobile Processor (1066MHz)
− Core speed: 2.0GHz
− System bus: 1066 MHz
− On-die level 2 cache: 3 MB (P7350)
Core2 Duo Mobile Processor (800MHz)
− Core speed: 2.1GHz − System bus: 800 MHz
− On-die level 2 cache: 2 MB (T6500)
Pentium Dual Core Processor (800MHz)
− Core speed: 2.0/2.1GHz − System bus: 800 MHz
− On-die level 2 cache: 1 MB (T4200/T4300)
Celeron Processor (800MHz)
− Core speed: 2.2GHz − System bus: 800 MHz
− On-die level 2 cache: 1 MB (900)
Memory
Two expansion memory slots are provided. They can hold 1024/2048/4096MB expansion memory modules available as options to grow up to 8 GB.
PC2-6400(800MHZ)DDRII SDRAM supported
1024/2048/4096MB modules supported
− 1024 MB (128M x 64) − 2048 MB (256M x 64) − 4096 MB (512M x 64)
1.8 volt operation
No parity bit
64-bit data transfer
BIOS ROM (Flash EEPROM)
Satellite / Satellite Pro L510 / L515 / L517 Maintenance Manual |
9 |
1 Hardware Overview 1.2 System Unit Components
8Mb x 1 chip (1024KB flash parts)
− NvStorage size : 64K
− NvStorage free space : 63K
− FV00 size : 716K
− FV00 free space : 61K
− FV01 size : 128K
− FV01 free space : 2K
System Controllers
North Bridge: Intel GM45/GL40
− CPU Interface and Control − System Memory Support
− PCI Express* Graphics (PEG) Interface − Integrated Display Interface Support
− Internal Graphics Features
− Direct Media Interface (DMI) − Power Management
− Security and Manageability − Serial ATA Interface
− ICH9 Audio Control
South Bridge: Intel ICH9-M
− Direct Media Interface (DMI)
− PCI Express* Interface
− Serial ATA (SATA) Controller
− Advanced Host Controller Interface (AHCI)
− Intel Matrix Storage Technology
− PCI Bus Interface
− Interrupt controller
− Low Pin Count (LPC) Interface
− Serial Peripheral Interface (SPI)
− Compatibility Modules
− Advanced Programmable Interrupt Controller (APIC)
− Universal Serial Bus (USB) Controller
− LAN Controller
− RTC
− GPIO
− Enhanced Power Management
− Intel I/O Virtualization (VT-d) Support
− System Management Bus (SMBus 2.0)
− Intel High Definition Audio Controller
− Enhanced DMA Controller
10 |
Satellite / Satellite Pro L510 / L515 / L517 Maintenance Manual |
1.2 System Unit Components |
1 Hardware Overview |
|
|
Card Bus Controller
R5C804
− PCI-1394 bridge interface
− SD/Mini SD/SD-IO/MS/MS Pro/MMC/XD Card Controller
− PCI Bus interface
Audio Controller
Realtek ALC272 integrated audio controller supports multimedia. The sound system feature contains the following:
2 Stereo DACs support 16/20/24-bit PCM format for stereo audio playback.
2 stereo ADCs support 16/20-bit PCM format for two stereo independent sound inputs.
16/20/24-bit S/PDIF-OUT supports 44.1K/48K/88.2K/96K/192KHz sample rate.
All ADCs support 44.1K/48K/96KHZ sample rate.
4 GPIOs(GPIO0/GPIO3 are digital GPIO shared with digital MIC interface, GPIO1/GPIO2 are analog) for customized applications.
High quality analog differential CD input.
2 jack detection pins each designed to detect up to 4 jacks.
Supports hardware digital volume control for digital microphone input.
Supports external PCBEEP input and built-in digital BEEP generator.
−
KBC/EC (Keyboard Controller/Embedded Controller)
A single KBC NPCE781LA0DX chip is used to serve as KBC/ EC and Super IO.
KBC
− Scan controller function
− Interface controller function
EC
− Power supply sequence control
− Overheat shutdown support
− LED control
− Beep control
− Device ON/OFF
− Cooling fan speed control
− Universal I/O port
− Battery capacity check
− Flash memory reprogramming function
Satellite / Satellite Pro L510 / L515 / L517 Maintenance Manual |
11 |
1 Hardware Overview |
1.2 System Unit Components |
|
|
− EC access interface
− I2C communication control
Battery EEPROM
24C02 equivalent (128 words x 16 bits, I2C interface) integrated in battery pack.
− Storing records of battery use
Clock Generator
ICS9LPRS365
− Generating the clock signal required for the syste
Modem Controller
Built-in MDC card with Askey / Foxconn. Functions of modem controller:
Digital signal conductor protection
Ring wake-up support
Azalia interface
Communication codes supported:
− For data communication: V.90 (China)/V.92, data rates: 28kbps/56kbps V.34 extended rates: 33.6K/2400/V.32 turbo, V.32 bits and fallbacks
− For fax: V.17, V.27, V.29, V.34 and V.21 Channel 2 V.253 Class 1 fax
LAN Controller
Realtek 8103E 10/100Mbit
− IEEE 802.3 10BASE-T/100BASE-TX compliant physical layer interface
− IEEE 802.3u Auto-Negotiation support − Digital Adaptive Equalization control − 10BASE-T auto-polarity correction
− LAN Connect interface
− Automatic detection of “unplugged mode” − Remote boot (PXE 2.1)
− Smart power down when link is not detected
Wireless LAN Controller
Support following 3 kinds of mini PCI wireless LAN cards
12 |
Satellite / Satellite Pro L510 / L515 / L517 Maintenance Manual |
1.2 System Unit Components |
1 Hardware Overview |
|
|
− IEEE 802.11bg
− IEEE 802.11abg
− IEEE 802.11abgn
Data Rate
− IEEE 802.11bg: Standard 54M bps
− IEEE 802.11abg: Standard 54M bps
− IEEE 802.11abgn: Standard 130M bps
Frequency Channel
− IEEE802.11bg: 2.4GHz
− IEEE802.11abg: 2.4GHz / 5.4GHz
− IEEE802.11abgn: 2.4GHz / 5.4GHz
Satellite / Satellite Pro L510 / L515 / L517 Maintenance Manual |
13 |
1.3 2.5-inch HDD |
1 Hardware Overview |
|
|
|
|
1.3 2.5-inch HDD
The computer contains an extremely low-profile and lightweight, high-performance HDD. The HDD incorporates 9.5mm height magnetic disk and mini-Winchester type magnetic heads. The HDD interface conforms to Serial ATA. Storage capacities supported are 120, 160, 250, 320, 400,500 GB.
The HDD is shown in Figure 1-5 and some of its specifications are listed in Table 1-1.
|
|
|
|
|
|
|
|
|
Figure 1-5 SATA HDD |
||||
|
|
|
||||
|
|
Table 1-1 HDD Specifications |
|
|||
|
|
|
|
|
|
|
Item |
|
|
|
Specifications |
|
|
|
|
|
|
|
||
Capacity (GB) |
120 GB |
160 GB |
250 GB |
|||
|
|
|
|
|
||
Rotational Speed (RPM) |
5400 rpm |
5400 rpm |
5400 rpm |
|||
|
|
|
|
|
||
Height |
9.5 mm |
9.5 mm |
9.5 mm |
|||
|
|
|
|
|
||
User Data Sectors |
234,442,648 |
312,581,808 |
488,397,168 |
|||
|
|
|
|
|
||
Bytes / Sector |
512 |
512 |
512 |
|||
|
|
|
|
|
|
|
Item |
|
|
|
Specifications |
|
|
|
|
|
|
|
||
Capacity (GB) |
320 GB |
400 GB |
500 GB |
|||
|
|
|
|
|
||
Rotational Speed (RPM) |
|
5400 rpm |
5400 rpm |
5400 rpm |
||
|
|
|
|
|
||
Height |
9.5 mm |
9.5 mm |
9.5 mm |
|||
|
|
|
|
|
||
User Data Sectors |
625,142,488 |
781,422,768 |
976,773,168 |
|||
|
|
|
|
|||
Bytes / Sector |
512 |
512 |
512 |
|||
|
|
|
|
|
|
|
14 |
Satellite / Satellite Pro L510 / L515 / L517 Maintenance Manual |
1.4 DVD Super Multi (+-R Double Layer) |
1 Hardware Overview |
|
|
|
|
1.4 DVD Super Multi (+-R Double Layer)
The DVD Super Multi drive accepts 12-cm (4.72-inch) and 8-cm (3.15-inch) discs. At maximum, the drive can play back a DVD at 8x speed, read CD-ROM at 24x speed, and write CD-R at 24x speed, CD-RW at 4x speed, US CD-RW at 24x speed, High Speed CDRW at 10x speed, DVD-R at 8x speed, DVD-RW at 6x speed, DVD+R at 8x speed, DVD+R (Double Layer) at 6x speed, DVD-R (Double Layer) at 6x speed, DVD+RW at 8x speed and DVD-RAM at 5x speed. The DVD interface conforms to Serial ATA.
The DVD Super Multi drive is shown in Figure 1-6 and its specifications are listed in Table 1-2.
Figure 1-6 DVD Super Multi drive
Table 1-2 DVD Super Multi Drive Specifications
Item |
DVD-ROM mode |
|
CD-ROM mode |
|
|
|
|
Data Transfer Rate |
33.3 (Ultra-DMA transfer mode 2) |
|
|
(Mbytes/s) |
16.7 (PIO mode 4, Multiword DMA mode 2) |
|
|
|
|
||
|
|
|
|
Access Time (ms) |
180 ms |
|
150 ms |
|
|
||
|
|
|
|
Random Seek Time |
150 ms |
|
140 ms |
|
|
||
|
|
|
|
Data Buffer Size |
2MB |
|
|
(Mbytes) |
|
||
|
|
|
|
|
|
|
|
Formats Supported |
DVD: |
|
|
|
DVD-VIDEO, DVD-ROM, DVD-R, DVD-RW, DVD-RAM, |
||
|
DVD+R, DVD+-R (Double Layer), DVD+RW. |
||
|
CD: |
|
|
|
CD-DA, CD-ROM, CD-R, CD-RW, Mixed-CD, HS CD-RW, US CD- |
||
|
RW, Photo CD (Multi-Session), Video CD, CD-Extra (CD+), CD-Text.. |
||
|
|
|
|
Satellite / Satellite Pro L510 / L515 / L517 Maintenance Manual |
15 |
Loading...