Toshiba Personal Computer
Satellite L630/L635
(PSK00x/PSK01x)
(PSK04x/PSK05x)
Maintenance Manual
TOSHIBA CORPORATION
S/ No
Satellite/Satellite Pro/L630/L635 Maintenance Manual
Copyright
© 2010 by Toshiba Corporation. All rights reserved. Under the copyright laws, this manual cannot be reproduced in any form without the prior written permission of Toshiba. No patent liability is assumed with respect to the use of the information contained herein.
Toshiba Satellite/Satellite Pro/L630/L635 Maintenance Manual
First edition May of 2010
Disclaimer
The information presented in this manual has been reviewed and validated for accuracy. The included set of instructions and descriptions are accurate for the Satellite/Satellite Pro/L630/L635 at the time of this manual's production. However, succeeding computers and manuals are subject to change without notice. Therefore, Toshiba assumes no liability for damages incurred directly or indirectly from errors, omissions, or discrepancies between any succeeding product and this manual.
Trademarks
Intel and Pentium are registered trademarks of Intel Corporation.
IBM, IBM PC/XT, PC/AT, PS/2 and OS/2 are registered trademarks of IBM Corporation. Windows 7 home edition are registered trademarks of Microsoft Corporation.
Sound Blaster and Pro are trademarks of Creative Technology Ltd. UNIX is a registered trademark of X/Open Company Ltd. NetWare are registered trademarks of Novell, Inc.
All other properties are trademarks or registered trademarks of their respective holders.
ii |
Satellite/Satellite Pro/L630/L635 Maintenance Manual |
Preface
This maintenance manual describes how to perform hardware service maintenance for the Toshiba Personal Computer Satellite/Satellite Pro/L630/L635, referred to as Satellite/Satellite Pro/L630/L635 in this manual.
The procedures described in this manual are intended to help service technicians isolate faulty Field Replaceable Units (FRUs) and replace them in the field.
SAFETY PRECAUTIONS
Four types of messages are used in this manual to bring important information to your attention. Each of these messages will be italicized and identified as shown below.
DANGER: “Danger” indicates the existence of a hazard that could result in death or serious bodily injury, if the safety instruction is not observed.
WARNING: “Warning” indicates the existence of a hazard that could result in bodily injury, if the safety instruction is not observed.
CAUTION: “Caution” indicates the existence of a hazard that could result in property damage, if the safety instruction is not observed.
NOTE: “Note” contains general information that relates to your safe maintenance service.
Improper repair of the computer may result in safety hazards. Toshiba requires service technicians and authorized dealers or service providers to ensure the following safety precautions are adhered to strictly.
Be sure to fasten screws securely with the right screwdriver. If a screw is not fully fastened, it could come loose, creating a danger of a short circuit, which could cause overheating, smoke or fire.
If you replace the battery pack, RTC battery or backup battery, be sure to use only the same model battery or an equivalent battery recommended by Toshiba. Installation of the wrong battery can cause the battery to explode.
Satellite/Satellite Pro/L630/L635 Maintenance Manual |
iii |
The manual is divided into the following parts:
Chapter 1 Hardware Overview describes the Satellite/Satellite Pro/L630/L635 system unit and each FRU.
Chapter 2 Troubleshooting Procedures explains how to diagnose and resolve FRU problems.
Chapter 3 Test and Diagnostics describes how to perform test and diagnostic operations for maintenance service.
Chapter 4 Replacement Procedures describes the removal and replacement of the FRUs.
Appendices The appendices describe the following:
Handling the LCD module
Board layout
Keyboard scan/character codes
Key layout
iv |
Satellite/Satellite Pro/L630/L635 Maintenance Manual |
Conventions
This manual uses the following formats to describe, identify, and highlight terms and operating procedures.
Acronyms
On the first appearance and whenever necessary for clarification acronyms are enclosed in parentheses following their definition. For example:
Read Only Memory (ROM)
Keys
Keys are used in the text to describe many operations. The key top symbol as it appears on the keyboard is printed in boldface type.
Key operation
Some operations require you to simultaneously use two or more keys. We identify such operations by the key top symbols separated by a plus (+) sign. For example, Ctrl + Pause (Break) means you must hold down Ctrl and at the same time press Pause (Break). If three keys are used, hold down the first two and at the same time press the third.
User input
Text that you are instructed to type in is shown in the boldface type below:
DISKCOPY A: B:
The display
Text generated by the XXXXX that appears on its display is presented in the type face below:
Format complete
System transferred
Satellite/Satellite Pro/L630/L635 Maintenance Manual |
v |
Table of Contents
Chapter 1 |
Hardware Overview |
|
|
1.1 |
Features................................................................................................................................ |
|
5 |
1.2 |
System Unit Components .................................................................................................. |
12 |
|
1.3 |
2.5-inch HDD..................................................................................................................... |
|
17 |
1.4 |
DVD Super Multi (+-R Double Layer).............................................................................. |
18 |
|
1.5 |
Blu-Ray Writer................................................................................................................... |
19 |
|
1.6 |
Power Supply..................................................................................................................... |
|
20 |
1.7 |
Batteries ............................................................................................................................. |
|
21 |
|
1.7.1 |
Main Battery........................................................................................... |
21 |
|
1.7.2 |
Battery Charging Control ....................................................................... |
21 |
|
1.7.3 |
RTC Battery ........................................................................................... |
22 |
Chapter 2 |
Troubleshooting |
|
||
2.1 |
Outline |
.................................................................................................................... |
|
2-1 |
2.2 |
Basic Flowchart...................................................................................................... |
2-2 |
||
2.3 |
Power Supply ......................................................................................................... |
2-6 |
||
|
Procedure ...........................................................................1 Power Icon Check |
2-6 |
||
|
Procedure ...........................................................................2 Connection Check |
2-7 |
||
|
Procedure ........................................................................3 Replacement Check |
2-7 |
||
2.4 |
System .........................................................................................................Board |
2-8 |
||
|
Procedure ...............................................................................1 Message Check |
2-8 |
||
|
Procedure .......................................................................2 Test Program Check |
2-9 |
||
|
Procedure ........................................................................3 Replacement Check |
2-9 |
||
2.5 |
HDD ..................................................................................................................... |
|
|
2-10 |
|
Procedure .............................................................................1 |
Message Check |
2-10 |
|
|
Procedure .............................................................................2 |
Partition Check |
2-10 |
|
|
Procedure ................................................................................3 |
Format Check |
2-11 |
|
|
Procedure .....................................................................4 |
Test Program Check |
2-11 |
|
|
|
|
|
|
vi |
|
|
Satellite/Satellite Pro/L630/L635 |
Maintenance Manual |
|
Procedure 5 Connector Check and Replacement Check................................... |
2-13 |
2.6 |
Keyboard .............................................................................................................. |
2-14 |
|
Procedure 1 Test Program Check ..................................................................... |
2-14 |
|
Procedure 2 Connector Check and Replacement Check................................... |
2-14 |
2.7 |
Display ................................................................................................................. |
2-15 |
|
Procedure 1 External Monitor Check ............................................................... |
2-15 |
|
Procedure 2 Test Program Check ..................................................................... |
2-15 |
|
Procedure 3 Connector Check and Replacement Check................................... |
2-15 |
2.8 |
ODD (Optical Disk Drive) ................................................................................... |
2-17 |
|
Procedure 1 ODD Cleaning Check ................................................................... |
2-17 |
|
Procedure 2 Test Program Check ..................................................................... |
2-17 |
|
Procedure 3 Connector Check and Replacement Check................................... |
2-17 |
2.9 |
LAN...................................................................................................................... |
2-19 |
|
Procedure 1 Test Program Check ..................................................................... |
2-19 |
|
Procedure 2 Connector Check and Replacement Check................................... |
2-19 |
2.10 |
Audio Test ............................................................................................................ |
2-20 |
|
Procedure 1 Test Program Check ..................................................................... |
2-20 |
|
Procedure 2 Connector Check and Replacement Check................................... |
2-20 |
2.11 |
Cooling Module.................................................................................................... |
2-21 |
|
Procedure 1 Test Program Check ..................................................................... |
2-21 |
|
Procedure 2 Connector Check and Replacement Check................................... |
2-21 |
Chapter 3 |
Diagnostic Programs |
|
|
3.1 |
General |
...................................................................................................................... |
1 |
3.2 |
Quick Start................................................................................................................. |
3 |
|
|
3.2.1 ............................................................................................... |
Quick Test |
3 |
|
3.2.2 .................................................................................. |
Customization Test |
3 |
|
3.2.3 .............................................................................. |
Keyboard Layout test |
7 |
|
3.2.4 ....................................................................................... |
Audio Play Test |
8 |
|
3.2.5 .................................................................................. |
Audio Record Test |
8 |
|
3.2.6 ................................................................................................ |
DMI Read |
9 |
Satellite/Satellite Pro/L630/L635 Maintenance Manual |
vii |
|
3.2.7 |
DMI Write ................................................................................................ |
9 |
|
3.2.8 |
System Information ................................................................................ |
10 |
|
3.2.9 |
View Logs .............................................................................................. |
12 |
|
3.2.10 |
Exit to Free DOS ................................................................................... |
12 |
|
3.2.11 |
The Diagnostics Screen Explanation ...................................................... |
12 |
3.3 |
Options |
..................................................................................................................... |
16 |
|
3.3.1 ................................................................................................ |
Overview |
16 |
|
3.3.2 ............................................................ |
Batch Parameters Configuration |
17 |
|
3.3.3 ........................................................... |
Item’s Parameters Configuration |
19 |
|
3.3.4 ........................................................................... |
Load Batch Parameters |
20 |
|
3.3.5 ........................................................................... |
Save Batch Parameters |
21 |
|
3.3.6 ......................................................................... |
LOG Parameters Setting |
21 |
|
3.3.7 .............................................................................. |
Specify LOG Viewer |
22 |
|
3.3.8 ................................................................................... |
Display LOG File |
23 |
|
3.3.9 ........................................................................................... |
LOG Viewer |
23 |
|
3.3.10 ................................................................................... |
LOG File Sample |
25 |
3.4 |
Subtests..................................................................................................................... |
|
26 |
3.5 |
System Test .............................................................................................................. |
29 |
|
3.6 |
Memory ............................................................................................................Test |
34 |
|
3.7 |
Storage...................................................................................................................... |
|
40 |
3.8 |
Video ........................................................................................................................ |
|
44 |
3.9 |
Communication ........................................................................................(COMM) |
52 |
|
3.10 |
Peripheral ................................................................................................................. |
53 |
|
3.11 |
Error Codes .....................................................................................and description |
57 |
|
3.12 |
Quick Test ...................................................................................................Item List |
i |
|
Chapter 4 |
Replacement Procedures |
|
|
4.1 |
General ................................................................................................................... |
|
4-1 |
|
Safety ................................................................................................Precautions |
4-2 |
|
|
Safety ................................................................................................Precautions |
4-2 |
|
|
Before ................................................................................................You Begin |
4-4 |
|
|
Disassembly ......................................................................................Procedures |
4-5 |
|
|
|
|
|
viii |
|
Satellite/Satellite Pro/L630/L635 |
Maintenance Manual |
|
Assembly Procedures........................................................................................... |
4-5 |
|
|
Tools and Equipment ........................................................................................... |
4-6 |
|
|
Screw Tightening Torque .................................................................................... |
4-6 |
|
|
Colors of Screw Shanks ....................................................................................... |
4-7 |
|
|
Symbols of Screws on the Computer Body ......................................................... |
4-7 |
|
|
Symbol examples ................................................................................................. |
4-7 |
|
4.2 |
Battery Pack/PC card/Bridge Media ...................................................................... |
4-8 |
|
|
4.2.1 |
Battery Pack ......................................................................................... |
4-8 |
|
Removing the Battery Pack ................................................................................. |
4-8 |
|
|
Installing the Battery Pack................................................................................... |
4-9 |
|
|
4.2.2 |
Bridge Media...................................................................................... |
4-10 |
|
Removing the Bridge Media.............................................................................. |
4-10 |
|
|
Installing the Bridge Media ............................................................................... |
4-10 |
|
4.3 |
Memory Module................................................................................................... |
4-11 |
|
|
Removing the Memory Module......................................................................... |
4-11 |
|
|
Installing the Memory Module .......................................................................... |
4-12 |
|
4.4 |
HDD ..................................................................................................................... |
|
4-13 |
|
Removing the HDD ........................................................................................... |
4-13 |
|
|
Installing the HDD............................................................................................. |
4-15 |
|
4.5 |
ODD Bay Module ................................................................................................ |
4-16 |
|
|
Removing the ODD Bay Module ...................................................................... |
4-16 |
|
|
Installing the ODD Bay Module........................................................................ |
4-17 |
|
|
Disassembling the ODD Drive .......................................................................... |
4-18 |
|
|
Assembling the ODD Bezel............................................................................... |
4-18 |
|
|
Disassembling the ODD Drive .......................................................................... |
4-19 |
|
|
Assembling the ODD Drive............................................................................... |
4-19 |
|
4.6 |
Keyboard .............................................................................................................. |
|
4-20 |
|
Removing Keyboard .......................................................................................... |
4-20 |
|
|
Installing the Keyboard and RTC battery .......................................................... |
4-21 |
|
4.7 |
Wireless LAN Card.............................................................................................. |
4-22 |
|
|
Removing the Wireless LAN Card .................................................................... |
4-22 |
|
|
Installing the Wireless LAN Card...................................................................... |
4-23 |
|
|
|
||
Satellite/Satellite Pro/L630/L635 Maintenance Manual |
ix |
||
4.8 |
Top Cover............................................................................................................. |
4-24 |
|
Installing the Top Cover .................................................................................... |
4-25 |
4.9 |
Display Assembly ................................................................................................ |
4-26 |
|
Removing the Display Assembly....................................................................... |
4-26 |
|
Installing the Display Assembly ........................................................................ |
4-27 |
4.10 |
System Board ....................................................................................................... |
4-28 |
|
Removing the System Board ............................................................................. |
4-28 |
|
Installing the System Board............................................................................... |
4-29 |
4.11 |
Thermal module ................................................................................................... |
4-30 |
|
Remove the Thermal module (for VGA Model) ............................................... |
4-30 |
|
Installing the thermal module (for VGA Model)............................................... |
4-31 |
|
Removing the thermal Module .......................................................................... |
4-32 |
|
Installing the thermal Module............................................................................ |
4-33 |
4.12 |
CPU ...................................................................................................................... |
4-34 |
|
Removing the CPU ............................................................................................ |
4-34 |
|
Installing the CPU.............................................................................................. |
4-35 |
4.13 |
Display Mask........................................................................................................ |
4-37 |
|
Removing the Display Mask.............................................................................. |
4-37 |
|
Installing the Display Mask ............................................................................... |
4-38 |
4.14 |
LCD Module ........................................................................................................ |
4-39 |
|
Removing the LED module ............................................................................... |
4-39 |
|
Installing the LCD Module ................................................................................ |
4-41 |
4.15 |
CCD Board and MIC............................................................................................ |
4-42 |
|
Removing the CCD Board and MIC.................................................................. |
4-42 |
|
Installing the CCD Board and MIC ................................................................... |
4-42 |
4.16 |
Power Button Board ............................................................................................. |
4-43 |
|
Removing the Power Button Board ................................................................... |
4-43 |
|
Installing the Power Button Board..................................................................... |
4-44 |
4.17 |
Speakers ............................................................................................................... |
4-45 |
|
Removing the Speakers ..................................................................................... |
4-45 |
|
Installing the Speakers ....................................................................................... |
4-46 |
4.18 |
Switch board and Button board............................................................................ |
4-47 |
|
|
|
x |
Satellite/Satellite Pro/L630/L635 Maintenance Manual |
|
|
Removing the Switch board and Button board.................................................. |
4-47 |
|
Installing the Switch board and Button board ................................................... |
4-48 |
4.19 |
DC IN cable, Card reader board and Bluetooth Card .......................................... |
4-49 |
|
Removing the DC IN cable, Card reader board and Bluetooth Card................. |
4-49 |
|
Installing the DC IN cable, Card reader board and Bluetooth Card .................. |
4-50 |
Satellite/Satellite Pro/L630/L635 Maintenance Manual |
xi |
Appendices |
|
|
Appendix A Handling the LCD Module ........................................................................... |
A-1 |
|
Appendix B |
Board Layout ................................................................................................. |
B-1 |
Appendix C |
Keyboard Scan/Character Codes ................................................................... |
C-1 |
Appendix D |
Key Layout.................................................................................................... |
D-1 |
xii |
Satellite/Satellite Pro/L630/L635 Maintenance Manual |
Chapter 1
Hardware Overview
1 Hardware Overview
ii |
Satellite/Satellite Pro/L630/L635 |
Maintenance Manual |
1 Hardware Overview
Chapter 1 |
Contents |
|
|
1.1 |
Features ............................................................................................................................... |
|
5 |
1.2 |
System Unit Components ................................................................................................. |
12 |
|
1.3 |
2.5-inch HDD.................................................................................................................... |
|
17 |
1.4 |
DVD Super Multi (+-R Double Layer)............................................................................. |
18 |
|
1.5 |
Blu-Ray Writer.................................................................................................................. |
|
19 |
1.6 |
Power Supply .................................................................................................................... |
|
20 |
1.7 |
Batteries ............................................................................................................................ |
|
21 |
|
1.7.1 |
Main Battery.......................................................................................... |
22 |
|
1.7.2 |
Battery Charging Control ...................................................................... |
22 |
|
1.7.3 |
RTC Battery .......................................................................................... |
23 |
Satellite/Satellite Pro/L630/L635 |
Maintenance Manual |
iii |
1 Hardware Overview
Figures |
|
|
Figure 1-1 ID Parts Description Placement |
...............................................................................9 |
|
Figure 1-2 Computer Block Diagram...................................................................................... |
10 |
|
Figure 1-3 System Board Configurations................................................................................ |
11 |
|
Figure 1-4 |
System Unit Block Diagram.................................................................................. |
12 |
Figure 1-5 SATA HDD ........................................................................................................... |
17 |
|
Figure 1-6 |
DVD Super Multi Drive ........................................................................................ |
18 |
Figure 1-7 |
Blu-Ray Writer Drive ............................................................................................ |
19 |
Tables |
|
|
Table 1-1 HDD Specifications ................................................................................................ |
17 |
|
Table 1-2 DVD Super Multi Drive Specifications .................................................................. |
18 |
|
Table 1-3 |
Blu-Ray Writer Drive Specifications...................................................................... |
19 |
Table 1-4 |
Battery Specifications ............................................................................................. |
21 |
Table 1-5 |
Quick/Normal Charging Time ................................................................................ |
22 |
iv |
Satellite/Satellite Pro/L630/L635 |
Maintenance Manual |
1.1 Features |
1 Hardware Overview |
1.1 Features
Toshiba Satellite L630/L635/Satellite Pro L630/L635 is a full size notebook PC based on the mobile Intel Arrandale Processor, providing high-speed processing capabilities and advanced features. The computer employs a Lithium Ion battery that allows it to be battery-operated for a longer period of time. The display uses 13.3-inch HD LED panel, at a resolution of 1366x768. The uPGA Socket supports BTO/CTO for the CPU so that the system can be designed to suit your needs.
The computer has the following features:
Processor
CPU is mobile Intel Arrandale Processor:
Intel Core i5 CPU (1066MHz FSB)
Core i5-430M(2.26G, Turbo Boost to 2.53G) Hz
Core i5-450M(2.40G, Turbo Boost to 2.66G) Hz
Core i5-520M(2.40G, Turbo Boost to 2.93G) Hz
Intel Core i3 CPU (1066MHz FSB)
Core i3-330M(2.13G) Hz
Core i3-350M(2.26G) Hz
Intel Pentium CPU (1066MHz FSB)
P6000(1.86G) Hz
Host Bridge System Controller
System Controller: Intel 5 Series Chipset HM55.
Graphics
Intel integrated graphics or M92XTX, Park XT discrete graphics.
Memory
Satellite/Satellite Pro/L630/L635 |
Maintenance Manual |
5 |
1 Hardware Overview |
1.1 Features |
The computer has two SO-DIMM slots, which come standard with DDR3-1066MHz (PC3-8500) memory module. DDR3 is driven at 1.5V. It accepts BTO/CTO for your memory requirements. It can incorporate up to 8.0GB of main memory.
Using the following sizes of memory modules:
1024 MB (128M 64) / DDR3-1066MHz
2048 MB (256M 64) / DDR3-1066MHz
4096 MB (512M 64) / DDR3-1066MHz
Hard Disk Drive (HDD)
The computer accommodates 2.5-inch 9.5mm height Serial ATA HDD with following storage capacities:
250 GB (9.5mm thick) SATA (5,400rpm)
320 GB (9.5mm thick) SATA (5,400rpm)
500 GB (9.5mm thick) SATA (5,400rpm)
640 GB (9.5mm thick) SATA (5,400rpm)
ODD
The computer accommodates a fixed 12.7mm ODD with one of following types:
Tray Type DVD Super Multi +-R Double Layer drive
Tray Type DVD Super Multi +-R Double Layer with Label Flash drive
Tray Type Blue-Ray Combo BD-ROM with Label Flash drive
Tray Type Blue-Ray Writer BD-RE with Label Flash drive
Display
LCD displays come in the following types at resolution 1366x768:
13.3” WXGA HD 1366x768 CSV LED display
On-Board LAN (BTO)
The internal LAN supports 10/100Mbit or 1Gbit Ethernet, enabling connection to a LAN at up to 1Gbps. It supports Wake-up on LAN from S3/S4/S5 and PXE boot support. This internal LAN has RJ45 jack to directly accommodate a LAN cable.
6 |
Satellite/Satellite Pro/L630/L635 |
Maintenance Manual |
1.1 Features |
1 Hardware Overview |
Wireless LAN (BTO)
The internal Mini Card slot supports IEEE802.11bg (MOW) / IEEE802.11abg (MOW) / IEEE802.11abgn (MOW) / IEEE802.11bgn (MOW) / IEEE802.11bg w/BT / IEEE802.11bgn w/BT cards. The Antenna has two wires antenna support for BTO.
Sound System
CONEXANT CX20671 integrated audio controller supports multimedia. The sound system contains the following:
Stereo speakers
Headphone jack
Internal microphone
External microphone jack
Keyboard (BTO)
33 kinds’ countries keyboard, which is TOSHIBA 2010 New A4 with numeric keypad flat one.
Toshiba Touch Pad
Normal Wide Touch Pad with ON / OFF mechanical button.
Bluetooth (BTO)
Bluetooth wireless technology eliminates the need for cables between electronic device such as desktop computer, printer and mobile phone.
eSATA / USB Combo Port
This product has one eSATA / USB Combo port, which allows device connection through either eSATA or USB signals of eSATA / USB Combo Port.
USB Port
The computer has two USB 2.0 ports. It is supported to daisy-chain a maximum of 127 USB devices. The serial data transfer rate is 480Mbps, 12Mbps and 1.5Mbps. These ports support PnP installation and hot plugging.
Satellite/Satellite Pro/L630/L635 |
Maintenance Manual |
7 |
1 Hardware Overview |
1.1 Features |
RGB External Monitor Port
A 15-pin external monitor port is provided, through which the computer automatically recognizes an external VESA DDC 2B compatible monitor.
HDMI Out Port (BTO)
A HDMI monitor can be connected to HDMI Out Port on the computer.
Bridge Media Slot
This slot is for your memory card requirements like SD, Mini-SD, Micro-SD, SDHC, SDXC, MMC, Memory Stick and Memory Stick Pro Cards to provide memory card read on your computer.
Webcam (BTO)
The computer has an internal camera. It supports VGA (640x480) without Macro module, which also equips with Internal MIC.
Battery (BTO)
The computer has a removable 3/6/12 Cell Lithium Ion battery pack and an internal RTC battery (rechargeable).
8 |
Satellite/Satellite Pro/L630/L635 |
Maintenance Manual |
1.1 Features |
1 Hardware Overview |
Figures 1-1/1-2/1-3 and 1-4 show the computer and its system unit configuration, respectively.
Figure 1-1 ID Parts Description Placement
Satellite/Satellite Pro/L630/L635 |
Maintenance Manual |
9 |
1 Hardware Overview |
1.1 Features |
Figure 1-2 Computer Block Diagram
10 |
Satellite/Satellite Pro/L630/L635 |
Maintenance Manual |
1.1 Features |
1 Hardware Overview |
Figure 1-3 System Board Configurations
Satellite/Satellite Pro/L630/L635 |
Maintenance Manual |
11 |
1 Hardware Overview |
1.2 System Unit Components |
1.2 System Unit Components
Figure 1-4 is Block Diagram of the System Unit.
Figure 1-4 System Unit Block Diagram
12 |
Satellite/Satellite Pro/L630/L635 |
Maintenance Manual |
1.2 System Unit Components |
1 Hardware Overview |
The system unit of the computer consists of the following components:
Processor: Mobile Intel Arrandale Processor.
Intel Core i5 Processor (FSB, 1066MHz)
Core Speed: 2.26/2.40 GHz
System Bus: 1066 MHz
On-Die Level 2 Cache: 3 MB
Intel Core i3 Processor (FSB, 1066MHz)
Core Speed: 2.13/2.26 GHz
System Bus: 1066 MHz
On-Die Level 2 Cache: 3 MB
Intel Pentium Processor (FSB, 1066MHz)
Core Speed: 1.86 GHz
System Bus: 1066 MHz
On-Die Level 2 Cache: 3 MB
Memory: Two expansion memory slots are provided. They can hold 1.0/2.0/4.0GB memory modules available as options to grow up to 8.0GB.
PC3-8500 (1066MHz) DDR3 SDRAM supported
1024/2048/4096MB modules supported
1024 MB (128M x 64)
2048 MB (256M x 64)
4096 MB (512M x 64)
DDR3 1.5 volt operation
No parity bit
64-bit data transfer
BIOS ROM (Flash EEPROM)
32Mb x 1 chip (4096KB flash parts)
NvStorage Size : 64K
NvStorage Free Space : 63K
FV00 Size : 992K
FV00 Free Space : 176K
FV01 Size : 384K
FV01 Free Space : 68K
Satellite/Satellite Pro/L630/L635 |
Maintenance Manual |
13 |
1 Hardware Overview |
1.2 System Unit Components |
System Controller
Mobile Intel 5 Series Chipset HM55 PCH
Direct Media Interface (DMI)
PCI Express Interface
Integrated Serial ATA (SATA) Host Controller
Intel High Definition Audio Controller
Simple Serial Transport (SST) 1.0 Bus
Platform Environmental Control Interface (PECI)
Universal Serial Bus (USB) Controller
Integrated Gigabit LAN Controller
Intel Active Management Technology with System Defense
Intel I/O Virtualization (VT-d) Support
Intel Trusted Execution Technology Support
Power Management Logic
External Glue Integration
Enhanced DMA Controller
System Management Bus
High Precision Event Timers
Timers Based on 82C54
Real-Time Clock
System TCO Reduction Circuits
Serial Peripheral Interface (SPI) Support
Interrupt Controller
Firmware Hub Interface Support
Low Pin Count (LPC) I/F
GPIO
Analog and Digit Display Ports
JTAG Boundary Scan Support
Bridge Media Controller
REA_RTS5159
Memory Card Reader Controller
Audio Controller
CONEXANT CX20671 integrated audio controller supports multimedia. The sound system features contain the following:
4 Stereo DACs support 16-bit to 24-bit PCM format for stereo audio playback
6 stereo ADCs support 16-bit to 24-bit PCM format for stereo independent sound inputs
All ADCs support 44.1K to 192.0K Hz sample rate
14 |
Satellite/Satellite Pro/L630/L635 |
Maintenance Manual |
1.2 System Unit Components |
1 Hardware Overview |
Digital microphone interface with internal MIC boost supporting
Jack sense detects up to 4 jacks using only one sense pin
Digital Mixer
+3.3V analog and I/O operation; uses Vaux for power management modes
Audio Director for Headphone and Internal Speakers Redirection
Smart Audio GUI - advanced audio control
KBC/EC (Keyboard Controller/Embedded Controller)
A KBC WINBOND NPCE781LA0DX chip is used to serve as KBC/EC and Super IO: KBC
Scan controller function
Interface controller function
EC
Power supply sequence control
Overheat shutdown support
LED control
Beep control
Device ON/OFF
Cooling fan speed control
Universal I/O port
Battery capacity check
Flash memory reprogramming function
EC access interface
I2C communication control
Battery EEPROM
24C02 equivalent (128 words x 16 bits, I2C interface) integrated in battery pack
Storing records of battery use
Clock Generator
ICS ICS9LPRS3197
Generating the clock signal required for the system
LAN Controller
Satellite/Satellite Pro/L630/L635 |
Maintenance Manual |
15 |
1 Hardware Overview |
1.2 System Unit Components |
Atheros AR8152 / AR8151 - 10/100Mbit / 1Gbit
IEEE802.3 10BASE-T/100BASE-TX physical layer interface
IEEE 802.3u Auto-Negotiation support
Digital Adaptive Equalization control
10BASE-T auto-polarity correction
LAN Connect interface
Automatic detection of “unplugged mode”
Remote boot (PXE 2.1)
Smart power down when link is not detected
Wireless LAN Controller
Support following 3 kinds of mini PCI wireless LAN cards
IEEE 802.11bg
IEEE 802.11ag
IEEE 802.11agn
Data Rate
IEEE 802.11bg: Standard 54M bps
IEEE 802.11ag: Standard 54M bps
IEEE 802.11agn: Standard 130M bps
Frequency Channel
IEEE802.11bg: 2.4GHz
IEEE802.11ag: 2.4GHz / 5.4GHz
IEEE802.11agn: 2.4GHz / 5.4GHz
16 |
Satellite/Satellite Pro/L630/L635 |
Maintenance Manual |
1.3 2.5-inch HDD |
1 Hardware Overview |
1.3 2.5-inch HDD
The computer contains an extremely low-profile, lightweight and high-performance HDD. The HDD incorporates 9.5 mm height magnetic disk and mini-Winchester type magnetic heads. The HDD interface conforms to Serial ATA. Storage capacities supported are 250, 320, 500 & 640GB.
The HDD is shown in Figure 1-5 and some of its specifications are listed in Table 1-1.
Figure 1-5 SATA HDD
Table 1-1 HDD Specifications
Item |
|
Specifications |
|
|
|
|
|
Capacity (GB) |
250 GB |
320 GB |
500 GB |
|
|
|
|
Rotational Speed (RPM) |
5400 rpm |
5400 rpm |
5400 rpm |
|
|
|
|
Height |
9.5 mm |
9.5 mm |
9.5 mm |
|
|
|
|
User Data Sectors |
488,397,168 |
625,142,448 |
976,773,168 |
|
|
|
|
Bytes / Sector |
512 |
512 |
512 |
|
|
|
|
Item |
|
Specifications |
|
|
|
|
|
|
|
Capacity (GB) |
640 GB |
- |
- |
|
|
|
|
|
|
Rotational Speed (RPM) |
5400 rpm |
- |
- |
|
|
|
|
|
|
Height |
9.5 mm |
- |
- |
|
|
|
|
|
|
User Data Sectors |
1,250,263,728 |
- |
- |
|
|
|
|
|
|
Bytes / Sector |
512 |
- |
- |
|
|
|
|
|
|
Satellite/Satellite Pro/L630/L635 |
Maintenance Manual |
17 |
1 Hardware Overview |
1.4 DVD Super Multi (+-R Double Layer) |
1.4 DVD Super Multi (+-R Double Layer)
The DVD Super Multi drive accepts 12-cm (4.72-inch) and 8-cm (3.15-inch) discs. At maximum, the drive can play back DVD-ROM at 8x speed, read CD-ROM at 24x speed, and write CD-R at 24x speed, CD-RW at 4x speed, US CD-RW at 24x speed, High Speed CDRW at 10x speed, DVD-R at 8x speed, DVD-RW at 6x speed, DVD-R DL at 6x speed, DVD+R at 8x speed, DVD+RW at 8x speed, DVD+R DL at 6x speed and DVD-RAM at 5x speed.
DVD Super Multi Drive is shown in Figure 1-6 and its specifications are listed in Table 1-2.
Figure 1-6 DVD Super Multi Drive
Table 1-2 DVD Super Multi Drive Specifications
Item |
DVD-ROM mode |
|
CD-ROM mode |
|
|
|
|
Data Transfer Rate |
33.3 (U-DMA transfer mode 2) |
|
|
(Mbytes/s) |
16.7 (PIO mode 4, Multiword DMA mode 2) |
|
|
|
|
||
Access Time (ms) |
|
|
|
Average Random |
130 ms |
|
130 ms |
Access |
|
||
|
|
|
|
Data Buffer Size |
2MB |
|
|
(Mbytes) |
|
||
|
|
|
|
Formats Supported |
DVD: |
|
|
|
DVD-VIDEO, DVD-ROM, DVD-R, DVD-RW, DVD-RAM, |
||
|
DVD+R, DVD+-R (Double Layer), DVD+RW. |
||
|
CD: |
|
|
|
CD-DA, CD-ROM, CD-R, CD-RW, CD-ROMXA, Photo CD (Multi- |
||
|
Session), Video CD, CD-Extra (CD+), CD-Text. |
||
|
|
|
|
18 |
Satellite/Satellite Pro/L630/L635 |
Maintenance Manual |
Loading...