Echo PB-600, PB-601 User Manual

POWER BLOWER

Operator's Manual

MODELS: PB-600

Serial Number 001001 & Up

PB-601

Serial Number 001001 & Up

WARNING

The engine exhaust from this product contains chemicals known to the State of California to cause cancer, birth defects or other reproductive harm.

WARNING DANGER

Read rules for safe operation and all instructions carefully. ECHO provides this Operator's Manual which must be read and understood for proper and safe operation.

	X7501125401	X750000951
		05/00

2

INTRODUCTION

Welcome to the ECHO family. This ECHO product was designed and manufactured to provide long life and on-the-job- dependability. Read and understand this manual. You will find it easy to use and full of helpful operating tips and SAFETY messages.

WARNING DANGER

Read rules for safe operation and instructions carefully. ECHO provides this Operator's Manual which must be read and understood for proper and safe operation.

THE OPERATOR'S MANUAL --

contains specifications and information for operation, starting, stopping, maintenance, storage and assembly specific to this product.

TABLE OF CONTENTS

Introduction ...............................................................		2
-	The Operator's Manual .......................................	2
Manual Safety Symbols and Important Information ..		3
Safety .........................................................................		3
-	General Description ............................................	3
-	Decals .................................................................	4
-	International Symbols .........................................	4
-	Equipment ...........................................................	5
-	Fuel .....................................................................	5
- Personal Condition and Safety Equipment .........		6
-	Safe Operation ....................................................	7
-	Extended Operation/Extreme Conditions ............	8
Description ................................................................		9
-	Emission Control .................................................	9
-	Contents .............................................................	9
Specifications ...........................................................		12
Assembly .................................................................		13
- Install Blower Pipes / Stick Handle (PB-600) .....		13
- Install Blower Pipes (PB-601) ............................		14
Pre-Operation ...........................................................		15
-	Fuel ...................................................................	15
Operation .................................................................		17
-	Starting Cold Engine .........................................	17
CopyRight© 2000 By Echo, Incorporated
All Rights Reserved.

-	Starting Warm Engine .......................................	18
-	Stopping Engine ...............................................	18
-	Operating Blower ..............................................	18
Maintenance ............................................................		20
-	Skill Levels ........................................................	20
-	Maintenance Intervals ......................................	20
-	Air filter .............................................................	21
-	Fuel Filter ..........................................................	21
-	Spark Plug .........................................................	22
-	Cooling System .................................................	22
-	Exhaust System .................................................	23
-	Carburetor Adjustment .....................................	23
Troubleshooting ......................................................		25
Storage .....................................................................		26
Servicing Information ...............................................		28
-	Parts ..................................................................	28
-	Service ..............................................................	28
- ECHO Consumer Product Support ....................		28
-	Warranty Card ..................................................	28
- Additional or Replacement Manuals ................		28
-	Manual Ordering Instructions ..........................	28

Specifications, descriptions and illustrative material in this literature are as accurate as known at the time of publication, but are subject to change without notice. Illustrations may include optional equipment and accessories, and may not include all standard equipment.

POWER BLOWER	3
OPERATOR'S MANUAL

MANUAL SAFETY SYMBOLS AND IMPORTANT INFORMATION

Throughout this manual and on the product itself, you will find safety alerts and helpful, information messages preceded by symbols or key words. The following is an explanation of those symbols and key words and what they mean to you.

This symbol accompanied by the words WARNING and DANGER calls attention to an act or condition that can lead to serious personal injury to operator and bystanders.

The circle with the slash symbol means whatever is shown within the circle is prohibited.

IMPORTANT	NOTE

IMPORTANT The enclosed message provides information necessary for the protection of the unit.

NOTE This enclosed message provides tips for use, care and maintenance of the unit.

SAFETY

GENERAL DESCRIPTION

IMPORTANT

See Description and Specification sections and Decals in this section for full description and illustration of power head, and blower assembly.

	THROTTLE POSITION	AIR	THROTTLEPOSITION	AIR
	LEVER/STOP SWITCH		LEVER/STOP SWITCH	FILTER
		FILTER

BLOWER		BLOWER
		PIPES
PIPES
		MUFFLER
	RECOILSTARTER	MUFFLER
	HANDLE	RECOILSTARTERHANDLE

PB-600

PB-601

4

DECALS

HOT DECAL (near muffler)

Locate these safety decals on your unit. The complete unit illustration, found in the "DESCRIPTION" section, will help you locate them. Make sure the decals are legible and that you understand and follow the instructions on them. If a decal cannot be read, a new one can be ordered from your ECHO dealer. See PARTS ORDERING instructions for specific information.

GENERAL WARNING DECAL (located on top of blower housing)

INTERNATIONAL SYMBOLS

Symbol form/shape	Symbol	Symbol form/shape			Symbol
	description/application				description/application
	Read and understand				Fuel and oil mixture
	Operator's Manual.
	Wear eyes, ears and				Finger Severing
	head protection
	Hot				Wear hand
					protection. Use
	Surface				two handed.
	Safety/Alert				Wear slip
					resistant foot
					wear.
	DO NOT allow				DO NOT smoke
	flames or sparks
					near fuel.
	near fuel.

Symbol form/shape	Symbol	Symbol form/shape	Symbol
	description/application		description/application

	Engine choke	Ignition
		ON/OFF
	control.
	Emergency stop	Primer bulb
	Carburetor adjustment	Carburetor adjustment
		- High speed mixture
	- Low speed mixture
	Carburetor adjustment
	- Idle speed

POWER BLOWER	5
OPERATOR'S MANUAL

EQUIPMENT

Before operation a complete check of the unit must be performed:

-Check unit for loose/missing nuts, bolts and screws. Tighten and/or replace as needed.

-Inspect fuel lines, tank and area around carburetor for fuel leaks. DO NOT operate unit if leaks are found.

Spark Arrestor Muffler

-The spark arrestor muffler controls the exhaust noise and prevents hot, glowing particles of carbon from leaving the muffler. Make sure the spark arrestor screen is in good repair and properly seated in the muffler. (Refer to Exhaust System Maintenance pg. 23.)

Parts

-Do not use blower if any part is missing or damaged.

-Have repairs done only by an authorized ECHO Service dealer.

-Do not use any attachment, accessory or replacement part unless it is recommended in this Operator's Manual.

ATTACHMENTS

AND

ACCESSORIES

FUEL

WARNING DANGER

Fuel is VERY flammable. Use extreme care when mixing, storing or handling or serious personal injury may result.

-Use an approved fuel container.

-DO NOT smoke near fuel.

-DO NOT allow flames or sparks near fuel.

-Fuel tanks/cans may be under pressure. Always loosen fuel caps slowly allowing pressure to equalize.

-NEVER refuel a unit when the engine is HOT!

-NEVER refuel a unit with the engine running.

-DO NOT fill fuel tanks indoors. ALWAYS fill fuel tanks outdoors over bare ground.

-Securely tighten fuel cap after refueling.

-Inspect for fuel leakage. If fuel leakage is found, do not start or operate unit until leakage is repaired.

After Refueling;

-Wipe any spilled fuel from the unit.

-Move at least 3 M (10 ft.) from refueling location before starting.

After use;

-DO NOT store a unit with fuel in its tank. Leaks can occur. Return unused fuel to an approved fuel storage container.

3 M

10 ft.

6

PERSONAL CONDITION AND SAFETY EQUIPMENT

WARNING DANGER

Power Blower users risk injury to themselves and others if the power blower is used improperly and

or safety precautions are not followed. Proper clothing and safety gear must be worn when operating a blower.

Physical Condition --

Your judgment and physical dexterity may not be good:

-if you are tired or sick,

-if you are taking medication,

-if you have taken alcohol or drugs.

Operate unit only if you are physically and mentally well.

Eye Protection --

Wear eye protection that meets ANSI Z87.1 or CE requirements whenever you operate the blower.

Hand Protection --

Wear no-slip, heavy duty work gloves to improve your grip on the blower handle. Gloves also reduce the transmission of machine vibration to your hands.

Breathing Protection --

Wear a face mask to protect against dust.

Hearing Protection --

ECHO recommends wearing hearing protection whenever unit is used.

Proper Clothing --

Wear snug fitting, durable clothing;

-Pants should have long legs, shirts with long sleeves.

-DO NOT WEAR SHORTS,

-DONOTWEARTIES,SCARVES,JEWELRY.

Wear sturdy work shoes with nonskid soles;

-DO NOT WEAR OPEN TOED SHOES,

-DONOTOPERATEUNITBAREFOOTED.

Keep long hair away from engine and blower intake. Retain hair with cap or net.

POWER BLOWER	7
OPERATOR'S MANUAL

Hot Humid Weather --

Heavy protective clothing can increase operator fatigue which may lead to heat stroke. Schedule heavy work for early morning or late afternoon hours when temperatures are cooler.

SAFE OPERATION

Determine Operation Area --

-Review area to be cleared. Look for potential hazards such as stones or metal objects.

-Spectators and fellow workers must be warned, and children and animals prevented from coming nearer than 15M (50 ft.) while the blower is in use.

-Do not operate this product indoors or in inadequately ventilated areas..

-Take wind conditions into account: avoid open doors and windows.

-Provide all operators of this equipment with the Operator's Manual and instructions for safe operation.

-Do not point blower at people or animals.

Use Proper Clothing & Equipment

-Before starting the unit, equip yourself and any other person working within the 15M (50 ft.) Safety Zone with the required Protective Equipment and clothing.

-Keep long hair away from engine and blower intake. Retain hair with cap or net.

-Start unit on ground with throttle at idle. Check that blower pipe is not blocked by the ground or by any objects.

KeepAFirmGrip

-Hold handle with fingers together encircling the handle.

Keep A Solid Stance

-Maintain footing and balance at all times. Do not stand on slippery, uneven or unstable surfaces. Do not work in odd positions or on ladders.

-Do not perform Maintenance or Assembly procedures with engine running.

Noise Control

-Follow local noise regulations on sound levels and hours of operations. Use only during appropriate hours.

-Never use a higher speed setting then necessary to perform a task. The higher the engine speed the louder the blower noise.

-Be a good neighbor.

Avoid Hot Surfaces

-During operation, the exhaust area may become very hot, too hot to touch. Avoid contact during and immediately after operation.

15M

(50 FT.)

8

EXTENDED OPERATION/EXTREME CONDITIONS

Vibration and Cold --

It is believed that a condition called Raynaud’s Phenomenon, which affects the fingers of certain individuals may be brought about by exposure to vibration and cold. Exposure to vibration and cold may cause tingling and burning sensations followed by loss of color and numbness in the fingers. The following precautions are strongly recommended because the minimum exposure which might trigger the ailment is unknown.

•Keep your body warm, especially the head, neck, feet, ankles, hands and wrists.

•Maintain good blood circulation by performing vigorous arm exercises during frequent work breaks and also by not smoking.

•Limit the hours of operation. Try to fill each day with jobs where operating the blower or other hand-held power equipment is not required.

•If you experience discomfort, redness and swelling of the fingers followed by whitening and loss of feeling, consult your physician before further exposing yourself to cold and vibration.

Repetitive Stress Injuries --

It is believed that overusing the muscles and tendons of the fingers, hands, arms and shoulders may cause soreness, swelling, numbness, weakness and extreme pain in those areas. Certain repetitive hand activities may put you at a high risk for developing a Repetitive Stress Injury (RSI). An extreme RSI condition is Carpal Tunnel Syndrome (CTS), which could occur when your wrist swells and squeezes a vital nerve that runs through the area. Some believe that prolonged exposure to vibration may contribute to CTS. CTS can cause severe pain for months or even years. To reduce the risk of RSI/CTS, do the following:

•Avoid using your wrist in a bent, extended or twisted position. Instead try to maintain a straight wrist position. Also, when grasping, use your whole hand, not just the thumb and index finger.

•Take periodic breaks to minimize repetition and rest your hands.

•Reduce the speed & force in which you do the repetitive movement.

•Do exercises to strengthen the hand and arm muscles.

•Immediately stop using all power equipment and consult a doctor if you feel tingling, numbness or pain in the fingers, hands, wrists or arms. The sooner RSI/CTS is diagnosed, the more likely permanent nerve and muscle damage can be prevented.

POWER BLOWER	9
OPERATOR'S MANUAL

DESCRIPTION

EMISSION CONTROL

The emission control system for this engine is EM (Engine Modification).

An Emission Control Label is located on the unit. (This is an EX-

AMPLE ONLY, information on label varies by engine FAMILY).

IMPORTANT ENGINE INFORMATION

ENGINE FAMILY: TEHO58UB25RA

DISPLACEMENT: 58.2 CC

THIS ENGINE MEETS U.S. EPA PH1 EMISSION REGULATIONS FOR

SMALL NON ROAD ENGINES. REFER TO OWNER'S MANUAL FOR

MAINTENANCE SPECIFICATIONS AND ADJUSTMENTS.

CONTENTS

1-Power Head

1-Blower Pipe Assembly

1-Plastic Bag

1- Operator's Manual

1- Warranty Registration Card

1- ECHO Emissions and Warranty Statement

2- Clamps w/screws

1- Stick Handle Assembly (PB-600 Only)

1-Bottle ECHO 2-Stroke Oil Mix