Druck DPI 610, DPI 615 IS Data sheet

PRODUCT INFORMATION AND DATA SHEET

This product is a manufactured article as described in 29 CFR 1910.1200 and is not subject to OSHA's Hazard Communication Standard requirements for preparation of material safety data sheets (MSDS).

SANYO Batteries	Manufacturer's Name	In case of emergency contact:
SANYO Energy (USA) Corp.	SANYO Electric Co., Ltd.	CHEMTREC at [phone]
2055 Sanyo Ave.	Tokonabe-Cho Kasai-City
San Diego, CA 92154	Hyogo, 675-2332, Japan
Telephone No.: [phone]	Telephone No.: 0790-43-2043
www.sanyobatteries.com

Section I – Product Information

Product: Nickel Cadmium Battery	Designated for Recharge? _X_Yes ____ No
Trade Name: CADNICA	Chemical System: Nickel Cadmium	Nominal Voltage: 1.2V

Section II – Composition / Information on Ingredients

The ingredients are contained in a hermetically sealed case, designed to withstand temperatures and pressures encountered during normal use. As a result, during normal use, hazardous materials are fully contained inside the battery. The battery should not be opened or exposed to heat because exposure to the following ingredients contained within could be harmful under

some circumstances. The following information is provided for the user's information only.

Notes: 1. Concentrations vary depending on the state of charge or discharge.

2. TWA is the time weighted average concentration over an 8-hour period.

Date of Last Revision:	Page 1 of 5
March 2006

Section III – Physical Data
Cadmium	Cadmium Hydroxide
Melting point (°F): 610	Melting Point (°F):
Boiling point (°F): 1,407	Boiling Point (°C):
% Volatile by Volume:	% Volatile by Volume:
Vapor Pressure (mm Hg):	Vapor Pressure (mm Hg):
Evaporation Rate:	Evaporation Rate:
Vapor Density (Air =1):	Vapor Density (Air =1):
Specific Gravity (H2O): 8.65 @77¡F	Specific Gravity(H2O): 4.79
Solubility in Water: Insoluble	Solubility in Water: Practically insoluble
Appearance and Odor: Silver-white, blue-tinged,	Appearance and Odor: Powder
lustrous metal
Electrolyte specific gravity : 1.29 g/cm3
Electrolyte viscosity : 2.4 mPas (* mPas : milli-pascal
second)

Nickel Powder	Nickel Hydroxide
Melting point (°F): 2,831	Melting point (°F): *
Boiling point (°F): 5,134	Boiling Point (°F):
% Volatile by Volume:	% Volatile by Volume:
Vapor Pressure (mm Hg):	Vapor Pressure (mm Hg):
Evaporation Rate:	Evaporation Rate:
Vapor Density (Air =1):	Vapor Density (Air = 1):
Specific Gravity (H2O): 8.90	Specific Gravity (H2O):
Solubility in Water: Insoluble	Solubility in Water: Insoluble
Appearance and Odor: Powder	Appearance and Odor: Apple green powder
	* Note: decomposes above 392¡F into NiO and H2O.

Potassium Hydroxide:

Melting point (°F):* Boiling Point (°F):

% Volatile by Volume: Vapor Pressure (mm Hg): Evaporation Rate:

Vapor Density (Air =1): Specific Gravity (H2O):

Solubility in Water: Soluble in 0.9 part water, 0.6 part in boiling water Appearance and Odor: White or slightly yellow

* Note: Potassium hydroxide is present as a liquid or paste and acts as the electrolyte in the battery cell.

Section IV – Fire and Explosion Hazard Data

Flash Point: NA	Extinguishing Media: Any class of extinguishing
Lower Explosive Limit: NA	medium may be used on the batteries or their
Upper Explosive Limit: NA	packing material.

Special Fire Fighting Procedures: Special Fire Fighting Procedures: Exposure to temperatures of above 212°F can cause evaporation of the liquid content of the potassium hydroxide electrolyte resulting in the rupture of the cell. Potential for exposure to cadmium fumes during fire; use self-contained breathing apparatus.

Date of Last Revision:	Page 2 of 5
March 2006