Daewoo DG-M22D1S-CA, DG-M12D1P-HA, DG-M22D1S-HA, DG-M22D1D-HA/E, DG-M22D1D-HA/I Service Manual

...

S/M No. : DGM12D1001

Service Manual

MODEL: DG-M12D1P-SA

DG-M22D1P-SA DG-M12D1P-HA DG-M22D1P-HA DG-M22D1S-CA DG-M22D1S-HA DG-M22D1D-HA/E DG-M22D1D-HA/I DG-M22D1D-HA/B DG-M12D1D-HA/E DG-M12D1D-HA/I DG-M12D1D-HA/B

NOV. 2005

SPECIFICATIONS..............................................................................................................................................2

SCHEMATIC DIAGRAM ..................................................................................................................................11

TROUBLE SHOOTING....................................................................................................................................28

OPTION TABLE...............................................................................................................................................36

PCB CIRCUIT BOARD....................................................................................................................................37

DISASSEMBLY................................................................................................................................................44

ELECTRICAL PARTSLIST..............................................................................................................................52

CONTENTS

SPECIFICATIONS

SECTION 1st Model REMARK

MODEL For Europe

DAEWOO Model DG-M21D1D-HB Description DVD Recorder + HDD Target Area For Europe Mass Production 05.11

GENERAL

Power Plug 3-Pin type ( For EUROPE) Set Size (WxHxD)

- wihtout leg 435 x 55 x 343 mm

- with leg 435 x 60 x 343 mm Safety Regulation CE Set Weight (Net/Gross) 4.3Kg / 5.6Kg Power Print on Rear Panel 200~240V, 50/60Hz Operation temperature 35 ¡C Power Consumption

- Maximum 57 W

- Operate 40 W

- Stand-By(power off) 4.5 W Power Failure Compensation 1 Min. Stuffing Quantity

- 20 ft 879 EA

- 40 ft 1839 EA

- 40 ft (HQ) 2069 EA

DVD MODULE Spec.

Manufactruer of FEM (Front End Module) Lite On / Daewoo Interface ATA (IDE bus) Interface Opitical P/U SANYO & SONY FE Chip MT1818, MT1816 BE chip type Numbers DMN-8652

HDD Spec.

Drive interface ATA (IDE bus) Interface Capacity 160 GB (1platter) - 80, 160, 250G RPM 7200 RPM Start time 8 sec ( 15 sec max ) Stop time 12 sec ( 20 sec max )

PLAYABLE DISC TYPE

DVD Type :

DVD-ROM / DVD+R / DVD+RW / DVD-R / DVD-RW / DVD-RAM

Yes to All (Except DVD-RAM) - DVD+R/-R After finalize

- DVD-R/-RW (Video Format) CD Type : CD-ROM / CD-R / CD-RW Yes to All Video Format : DVD / VCD / SVCD / MPEG 4 /

JPEG / Kodak picture CD / DviX Yes to All (Except MPEG4, Kodak Picture CD) - DviX : For Europe Only

Audio Format : DVD-Audio / SACD / HDCD /

CDDA / MP3 / WMA / MP3 Pro CDDA / MP3 - WMA is Hidden Disc size 8cm/12cm Regional Code 2

SPECIFICATIONS

SECTION 1st Model REMARK

MODEL For Europe PLAYBACK FEATURES

Disc access time ( play ready time from drawer close press) Less than 20 sec. Fast Scan Motion (FWD / REV) ; DVD (ROM/-VIDEO/-VR) (O/O) : x2, x4, x8, x16, x32 Fast Scan Motion (FWD / REV) ; HDD (With Time Shifting) (O/O) : x2, x4, x8, x16, x32(except REV x2) Fast Scan Motion (FWD / REV) ; VCD (O/O) : x2, x4, x8, x16, x32 Fast Scan Motion (FWD / REV) ; CDDA,MP3 (O/O) : x2 Fast Scan Motion (FWD / REV) ; DivX (O/O) : x2, x4, x8 Slow Motion (FWD / REV) ; DVD (ROM/-VIDEO/-VR) (O/O) : x1/2, x1/4, x 1/8 Slow Motion (FWD / REV) ; HDD (O/O) : x1/2, x1/4, x 1/8 Slow Motion (FWD / REV) ; VCD (O/X) : x1/2, x1/4, x 1/8 Slow Motion (FWD / REV) ; CDDA,MP3 (X/X) Slow Motion (FWD / REV) ; DivX (X/X) Next, Previous O Resume play O (DVD Only) Frame-by-Frame Playback (FWD / REV) (O/X) : DVD, HDD, VCD DVD-R/RW After finalized,

DVD Video format HDD OK

Search Title / Chapter / Track / Time DVD : Title & Chapter

HDD : Title & Chapter

VCD : Track CDDA/MP3 : X Zoom (In Playback or Pause state) O (x2, x4) Subtitle O (DVD-ROM Only)

Multi-angle playback O (DVD-ROM Only) -

Only in case that DVD-Video disk

supports multi-angle scenes Random Playback X Program Playback X Repeat DVD : Chapter-> Title -> Disc->

Shuffle ->Scan ->Off HDD : Chapter -> Title -> Disc -> Off VCD : Track-> Disc -> Off

CDDA/MP3 : Track -> All -> Off Repeat A-B DVD,HDD,VCD Yes DVD X Clear Play X Auto Play X x2 Audio X Combination Playback : JPG + MP3 Only O

SYSTEM

Language 15 languages -

>English, German, French,

E/G/F/S/I/D/Nr/Sw/Pr/H/R/Po/Da/Fi/Cz Spanish, Italian, Dutch,

Norwegian,Swedish, Portuguese, Hungarian, Russian,Polish, Danish, Finnish, Czech

intial Language ENGLISH On-screen display on/off-user selectable X Disk Type displayed OSD / Front Panel Display O/X

SECTION 1st Model REMARK

MODEL For Europe SYSTEM

Company LOGO DAEWOO Screen Saver X PBC for VCD 2.0 or SVCD O Parental lock O Child Lock O (Pushing PWR Key 5sec.) TV Aspect Ratio (16x9, Pan Scan, letterbox) O Upgradeable Flash Memory Capability by CD O Video Output Format PAL Information On HDD Size & Available Space O Erase all program on HDD O Auto Chapter Making (5Min, 10Min, 15Min, Off) O Closed Caption X Menu Language Change O Subtitle Laguage Select O Audio Language Select O Network DVD (Digital 5) X Up Scalar Analog Video Out (720p / 1080i) X HDMI Option AV LINK X CM Skip X Time Shift Mode O (Buffering 60Min.) PIP X DV Camcorder Control X

File Management & Editing

Rename O Erase Disc O - Erase all titles on the disc Overwrite disc O - Record a new title to

beginning of the title list Lock O Protect O Edit

- Append X

- Split O (Title / Chapter)

- Delet O (Title / Chapter)

- Delet All O (Chapter)

Menu Display

Thumbnail (Title) O

Thumbnail Change O Manual Chapter Making / Delete Chapter Mark X/X Chapter Hide / Unhide O Edit Title Name O

SPECIFICATIONS

SECTION 1st Model REMARK

MODEL For Europe RECORDING

Dual Format X Video Recording Format DVD + VR Format (Dual Media) Video Recording Compress Format MPEG II

DVD Type DVD+R / DVD+RW / DVD-R / DVD-RW - DVD-R/-RW Dual Media

Format (+VR Format)

Disk Recording Rate (Mbps) & Recording Hour with 4.7 GB HQ : 9.5 Mbps, 60min

SP : 5.1 Mbps, 120min EP : 2.5 Mbps, 240min SLP : 1.7 Mbps, 360min

HDD Recording Capacity (160GB) HQ : 9.5 Mbps, 32Hr

SP : 5.1 Mbps, 66Hr EP : 2.5 Mbps, 128Hr SLP : 1.7 Mbps, 195Hr

DVD data full

- Record (Include T.REC, & OTR) Stop - Warning message such as DISC FULL

HDD data full

- Record (Include T.REC, & OTR) Stop -

Manual Space Management (Default)

Auto Space Management

(oldest title erase) Initialize DVD+R / DVD+RW / DVD-R / DVD-RW Finalize DVD+R / DVD-R / DVD-RW Time Shifting REC O HDD Recording and DVD Playback O DVD Recording and HDD Playback O REC Bit Rate Selection O - By GUI & RCU key Transrating DVD<->HDD ( REC Speed ) X HDD <->DVD copy Disc Writing speed O - X 2.4 HDD <->DVD copy O ( MP3, JPG, JPEG, DivX)

TIMER

Date Recognized Period 2005~2104 Number of Timer Recording 8 Events / 1 Year Clock display method 24 Hour Manual Clock Setting O Auto Clock Setting O Timer Recording System

- General O

- ShowView (VideoPlus+) O

- VPS / PDC O

- EPG X

One Touch Recording O

- Recording Time Display Method Recording Hours (Unit of 15Min)

HDD ; Max (10 Hours / 15Min in any Mode)

Once Recording O Daily Recording O Weekly Recording O Weekend Recording O

SPECIFICATIONS

SECTION 1st Model REMARK

MODEL For Europe TIMER

Timer Recording Contents Display O Method to Timer Recording O

Auto Start when PowerOffWarning&Selection when Power-ON

Timer Recording Start Timing On Time - Set turns on eariler than

Recording time

Priority on Overlap Timer Recording X - Conflict message will show

up on TV

Broadcasting Tuner

Broadcasting System PAL-B/G, PAL-I/I, SECAM-L, DK Channel Selection Method Programmable F/S Band

- PAL-B/G,I/I V-L, V-H, UHF

- PAL/SECAM-L V-L/L , V-H, UHF

Total Channel Number

- PAL BG 116 CH( CH 02-69, 74-80, CC 01-41)

- PAL I/I 116 CH( CH 01-13, 21-69, CC 01-54)

- PAL D/K 119 CH( CH01-12, 21-69, CC 01-58)

- SECAM L 99 CH( CH 02-10, 21-69, CC 01-41) Position Memory Number 99CH Auto Channel Setting

- Auto Search & Memory O

- Auto Channel Sorting Option License (Royalty)

- Auto Station Name Display O Manual Channel Setting

- CH Direct Input O

- Manual Search & Memory O

- Manual Channel Clear O

- Manual Channel Align O Manual Fine Tuning

- Memory Available O

- E2PROM O RF Modulation Out X

- 21 pin Scart Cable Accessory

VIDEO

Horizontal Resolution ( line input ) HQ/SP : 500 Lines (DVD+R/RW)

EP/SLP : 250 Lines (DVD+R/RW) <PAL/SECAM>

Screen size(MPEG encoder) HQ/SP: 720x576 (DVD+R/RW)

LP/EP : 352x576 (DVD+R/RW) SLP : 352x288 (DVD+R/RW)

Video DAC 8bit

PAL

Progressive Scanning O

- 576p By Setup menu & RCU key

Component / RGB Select O (OSD)

SECTION 1st Model REMARK

MODEL For Europe AUDIO

Audio Recording Format MPEG I Layer II Sampling Rate 48 KHz Audio ADC/DAC 24bit S/N Ratio ( line input ) 65 dB weighted Dynamic range ( line input ) 75 dB Digital output DTS, AC3, MPEG2 Audio Digital-to-analog converter 96kHz/24bit Dolby Digital Down Mix (5.1ch to LtRt out) O Dolby Digital Passthrough O DTS Digital Passthrough O MPEG-2 Audio Passthrough O Dolby Digital 5.1-Ch decoding O DTS Digital 5.1-Ch decoding X Open MP3 Compatible (pre recorded MP3 Discs) O AC-3/PCM data Conversion O - Down Mixing 3D Surround O Dynamic range control O

Front Panel

Front Panel Key

11 KeyOpen/Close, Play, Stop, REC, NEXT, PREV , DVD/HDD,

Menu, Standby/ON, PR+ , PR LED Indicator X Front A/V jacks 2EA FOR AUDIO (R/L) 1EA FOR VIDEO IEEE 1394 DV Input Option S-VIDEO Input O USB Input Option Memory Card Slot X PCMCIA X

Front Panel DISPLAY

Device LED Array Display Size 62(W) x 18(H) mm Display Color RED / YELLOW Language English Clock / Counter Change

- On DVD Out Clock

- On DVD In Clock Clock Display Method 24 Hour Counter Display Method Real Time Dimmer at Power Off O

Rear Panel

Analog Audio In (L/R RCA Jack) X Analog Audio Out (L/R RCA Jack) X S-video Out 1 EA Composite Video In (Yellow RCA Jack) X

SPECIFICATIONS

SECTION 1st Model REMARK

MODEL For Europe Rear Panel

Composite Video Out (Yellow RCA Jack) X Component Out (Y/Pb/Pr RCA Jack) 1 EA Component Pair Analog Audio Out (L/R RCA Jack) 1 EA EURO AV (SCART 1) : Composite / RGB Switchable O EURO AV (SCART 2) : Decoder O DVI X HDMI Option Digital Audio In / Out Output Only

- Coaxial O

- Optical O

Power cord Type Polarized

- Cord Holder O Spec & Serial Number Label O (DECs spec) Antenna Jack Type F type : 1 Pair

- Antenna Jack Layout In : Up , Out : Down

REMOTE CONTROL

Tool VR-FA3 Multi-brand TV Control X Code type DAEWOO - Mitsubishi format IR (Infra-Red) Response O Back-lit remote X Joy Stick X Jog / Shuttle on Remote X

Accessories

RMC O Batteris O Bundle Disc X Power Cord X RF cable O Composite A/V Cable X Component Video Cable X S-video cable (4 pin mini DIN) - 6 X Scart Cable O Coaxial, Optical Cable X IB/Safety Tips O IB, Number of Books / Language TBD IB, Color / Size B,W / B5 Safety Sheet / Product Registration Card TBD POP Material X Advertisement Material O

Sensormatic Tag TBD

DivX Spec.

Playable format

Market Region Support DRM stream(DRM ID) Playback DRM streams (DRM ID) Bit rate Upto 4Mbps

SPECIFICATIONS

A av XV op

SECTION 1st Model REMARK

MODEL For Europe Playable format

Market Region Support DRM stream(DRM ID) Playback DRM streams (DRM ID) Bit rate Upto 4Mbps Frame / sec 30,24, 12, 8 and 25 frames/s

Playable Codec Format DivX5.1, DivX5.05, DivX5.02, option is not available.

DivX4.1.2,DivX3.11, Dr.Divx1.02,

XVID format encoded with GMC

MPEG4 SP, MPEG4 ASP option is not avaiable.

Playable Audio Format MP3, MPEG2 Audio, PCM, AC-3,

AAC, DTS, Ogg Playable DivX File .avi, .divx File System ISO9660,UDF

Sub title

Language support All Occidental languages : Refer to setup menu

Eng/Fre/Spa/Ger/Ita/Dut File type (SMI, TXT, SUB, SRT, PAB, ASS, SSA) MicroDVD.sub, SubViewer.sub,SAMI.smi File over 128kB is not

available (LSI spec)

Selection of subtitle (Auto/Manual) O/O (on Application level) Auto Subtitle On, if the same

titled subtitle file is in the same folder with DiVX file.

Color of text White only

Video Transparency on sub title area O Max resolution (frame rate) 720X480(NTSC) and 720X576(PAL)

Playback function

Time Search O Display menu during playback,

excpet a file without time

information. Change the text size X Transparency on sub title area X LSI : black back/white font Repeat O A-B Repeat X FF / FR O / O (2, 4, 8, 16) SLOW FW / BW X / X STEP FW / BW X / X

File Browser

Program play X Type of browser Type of browser Folder and file names Display full name of file O (32 characters/ line) If title is too long, title name will

be shrunk to distinguish title

file to asubtitle file. Popup listing on playing X Preview on browser X

SPECIFICATIONS

SECTION 1st Model REMARK

MODEL For EuropeKey Action

KEY ACTION

Numeric key on file browser X LSI : Act just on STOP Numeric key on playing X LSI : use for Time Search Display key on file browser X Display key on Playing O Display information O Current track / total track

O Audio Mode(Left,Right,Stereo) O Internal Audio ( current / total ) O

Internal Subtitle ( current / total )

External Subtitle Name, Time Search(Present time display)

Next Key on playing

Single file Display prohibit mark Last file Display prohibit mark Multi file Go to next file

Prev Key on playing

Single file Display prohibit mark First file Display prohibit mark

Multi file Go to previous file Next /Prev key on file browser Go to Next/Prev page. Subtitle key in Playing Change Subtitle

Only for internal subtitle is available. Subtitle key on File Browser No Prohibition Mark Audio Key in playing Change Audio

Others

Repeat Key Change Repeat Mode Repeat A-B is not available Search Key O Zoom X Bookmark X Out of CoDec support Guide message Over spec. of resolution Guide message

SCHEMATIC DIAGRAM

4 4

3 3

2 2

1 1

LSI 8652

MSP

R/L

AUDIO DAC

AUDIO IN SCART1

VFD DRIVER

IIC

AUDIO FROM FRONT

IIS

IIC

ISP

MM1443

S-Video TO JACK

CCIR656 VCLK

COMPOSITE OUT TO CANAL

MM1443

R/L

VIDEO SWITCH AND BUFFER

RESET

VIDEO IN FROM FRONT S-Video

PSCAN COMPONENT OUT

DVD RECORDER LOADER ATAPI 1

BUFFER

LC74793

DECODER

IIC

RESET

VIDEO IN FROM TUNER

MPEG2

IIS

MUX

IIC

IC CANAL+

RESET

SAA7115

FLASH 32M BYTE

CCIR656 VCLK

IIS

IC CANAL+

DATA

VIDEO IN FROM SCART1

MSP3417

RGB OUT TO SCART

CCIR656[7..0]

COMPOSITE OUT TO CANAL

TSB41AB1

RGB OUT TO SCART

VIDEO IN FROM SCART2

VFD/KEY

PSCAN COMPONENT OUT

VPS PDC

ATAPI

ADR/CTL

M3777

AUDIO ADC

DDRAM(256M BIT)

IIS

IIC MASTER

TUNER

OPTION

VIDEO SWITCH

VIDEO

IIC

LA73053

VIDEO FROM FRONT

ADR/CTL

IIC SLAVE

R/L

AUDIO

RESET

AUDIO OUT TO MM1443

CCIR656[7..0]

DATA

CODEC

IIC

MICOM

ISP

LPF SWITCH

DV 1394 INPUT

S-Video TO JACK

REMOCON RECEIVER

ATAPI

HDD ATAPI2

RESET

HDMI

CS 5340

CS4344

VIDEO BLOCK DIAGRAM

SCHEMATIC DIAGRAM

+ 45 hidden pages