Toshiba Personal Computer
TECRA A8 series / Satellite Pro A120 series
Maintenance Manual
TOSHIBA CORPORATION
File Number 960-573
[CONFIDENTIAL]
Copyright
© 2006 by Toshiba Corporation. All rights reserved. Under the copyright laws, this manual cannot be reproduced in any form without the prior written permission of Toshiba. No patent liability is assumed with respect to the use of the information contained herein.
Toshiba Personal Computer TECRA A8 series / Satellite Pro A120 series Maintenance Manual
First edition June 2006
Disclaimer
The information presented in this manual has been reviewed and validated for accuracy. The included set of instructions and descriptions are accurate for the TECRA A8 series / Satellite Pro A120 series at the time of this manual’s production. However, succeeding computers and manuals are subject to change without notice. Therefore, Toshiba assumes no liability for damages incurred directly or indirectly from errors, omissions, or discrepancies between any succeeding product and this manual.
Trademarks
IBM is a registered trademark and IBM PC is a trademark of International Business Machines Corporation.
Intel, Intel SpeedStep, Intel Core, Celeron and Centrino are trademarks or registered trademarks of Intel Corporation or its subsidiaries in the United States and other countries/regions.
Windows and Microsoft are registered trademarks of Microsoft Corporation. Photo CD is a trademark of Eastman Kodak.
Bluetooth is a trademark owned by its proprietor and used by TOSHIBA under license. i.LINK is a trademark of Sony Corporation.
ii |
[CONFIDENTIAL] |
TECRA A8 /Satellite Pro A120 Maintenance Manual (960-573) |
Preface
This maintenance manual describes how to perform hardware service maintenance for the Toshiba Personal Computer TECRA A8 series / Satellite Pro A120 series.
The procedures described in this manual are intended to help service technicians isolate faulty Field Replaceable Units (FRUs) and replace them in the field.
Four types of messages are used in this manual to bring important information to your attention. Each of these messages will be italicized and identified as shown below.
DANGER: “Danger” indicates the existence of a hazard that could result in death or serious bodily injury, if the safety instruction is not observed.
WARNING: “Warning” indicates the existence of a hazard that could result in bodily injury, if the safety instruction is not observed.
CAUTION: “Caution” indicates the existence of a hazard that could result in property damage, if the safety instruction is not observed.
NOTE: “Note” contains general information that relates to your safe maintenance service.
Improper repair of the computer may result in safety hazards. Toshiba requires service technicians and authorized dealers or service providers to ensure the following safety precautions are adhered to strictly.
Be sure to fasten screws securely with the right screwdriver. If a screw is not fully fastened, it could come loose, creating a danger of a short circuit, which could cause overheating, smoke or fire.
If you replace the battery pack or RTC battery, be sure to use only the same model battery or an equivalent battery recommended by Toshiba. Installation of the wrong battery can cause the battery to explode.
TECRA A8 /Satellite Pro A120 Maintenance Manual (960-573) |
[CONFIDENTIAL] |
iii |
The manual is divided into the following parts:
Chapter 1 Hardware Overview describes the TECRA A8 series / Satellite Pro A120 series system unit and each FRU.
Chapter 2 Troubleshooting Procedures explains how to diagnose and resolve FRU problems.
Chapter 3 Test and Diagnostics describes how to perform test and diagnostic operations for maintenance service.
Chapter 4 Replacement Procedures describes the removal and replacement of the FRUs.
Appendices The appendices describe the following:
Handling the LCD module
Board layout
Pin assignments
Keyboard scan/character codes
Key layout
Wiring diagrams
BIOS rewrite procedures
EC/KBC rewrite procedures
Reliability
iv |
[CONFIDENTIAL] |
TECRA A8 /Satellite Pro A120 Maintenance Manual (960-573) |
Conventions
This manual uses the following formats to describe, identify, and highlight terms and operating procedures.
Acronyms
On the first appearance and whenever necessary for clarification acronyms are enclosed in parentheses following their definition. For example:
Read Only Memory (ROM)
Keys
Keys are used in the text to describe many operations. The key top symbol as it appears on the keyboard is printed in boldface type.
Key operation
Some operations require you to simultaneously use two or more keys. We identify such operations by the key top symbols separated by a plus (+) sign. For example, Ctrl + Pause (Break) means you must hold down Ctrl and at the same time press Pause (Break). If three keys are used, hold down the first two and at the same time press the third.
User input
Text that you are instructed to type in is shown in the boldface type below:
DISKCOPY A: B:
The display
Text generated by the computer that appears on its display is presented in the type face below:
Format complete
System transferred
TECRA A8 /Satellite Pro A120 Maintenance Manual (960-573) |
[CONFIDENTIAL] |
v |
Chapter 1 Hardware Overview |
|
|
1.1 |
Features ...................................................................................................................... |
1-1 |
1.2 |
2.5-inch Hard Disk Drive......................................................................................... |
1-14 |
1.3 |
Keyboard.................................................................................................................. |
1-16 |
1.4 |
Optical Drive............................................................................................................ |
1-17 |
1.5 |
TFT Color Display................................................................................................... |
1-21 |
1.6 |
Power Supply ........................................................................................................... |
1-24 |
1.7 |
Batteries ................................................................................................................... |
1-28 |
1.8 |
AC Adaptor.............................................................................................................. |
1-30 |
Chapter 2 Troubleshooting Procedures |
|
|
2.1 |
Troubleshooting ......................................................................................................... |
2-1 |
2.2 |
Troubleshooting Flowchart........................................................................................ |
2-3 |
2.3 |
Power Supply Troubleshooting.................................................................................. |
2-7 |
2.4 |
System Board Troubleshooting................................................................................ |
2-21 |
2.5 |
USB FDD Troubleshooting ..................................................................................... |
2-45 |
2.6 |
HDD Troubleshooting ............................................................................................. |
2-48 |
2.7 |
Keyboard and Touch pad Troubleshooting.............................................................. |
2-53 |
2.8 |
Display Troubleshooting.......................................................................................... |
2-56 |
2.9 |
Optical Drive Troubleshooting ................................................................................ |
2-58 |
2.10 |
Modem Troubleshooting.......................................................................................... |
2-60 |
2.11 |
LAN Troubleshooting.............................................................................................. |
2-62 |
2.12 |
Bluetooth Troubleshooting ...................................................................................... |
2-63 |
2.13 |
Wireless LAN Troubleshooting............................................................................... |
2-65 |
2.14 |
Sound Troubleshooting............................................................................................ |
2-67 |
2.15 |
SD card Slot Troubleshooting.................................................................................. |
2-70 |
2.16 |
Fingerprint sensor Troubleshooting......................................................................... |
2-71 |
vi |
[CONFIDENTIAL] |
TECRA A8 /Satellite Pro A120 Maintenance Manual (960-573) |
Chapter 3 Tests and Diagnostics |
|
|
3.1 |
The Diagnostic Test ................................................................................................... |
3-1 |
3.2 |
Executing the Diagnostic Test ................................................................................... |
3-4 |
3.3 |
Setting of the hardware configuration ....................................................................... |
3-9 |
3.4 |
Heatrun Test............................................................................................................. |
3-11 |
3.5 |
Subtest Names.......................................................................................................... |
3-12 |
3.6 |
System Test.............................................................................................................. |
3-14 |
3.7 |
Memory Test............................................................................................................ |
3-16 |
3.8 |
Keyboard Test.......................................................................................................... |
3-17 |
3.9 |
Display Test ............................................................................................................. |
3-18 |
3.10 |
Floppy Disk Test...................................................................................................... |
3-21 |
3.11 |
Printer Test............................................................................................................... |
3-23 |
3.12 |
Async Test ............................................................................................................... |
3-25 |
3.13 |
Hard Disk Test ......................................................................................................... |
3-26 |
3.14 |
Real Timer Test........................................................................................................ |
3-29 |
3.15 |
NDP Test.................................................................................................................. |
3-31 |
3.16 |
Expansion Test......................................................................................................... |
3-32 |
3.17 |
CD-ROM/DVD-ROM Test ..................................................................................... |
3-34 |
3.18 |
Error Code and Error Status Names......................................................................... |
3-35 |
3.19 |
Hard Disk Test Detail Status ................................................................................... |
3-38 |
3.20 |
ONLY ONE TEST................................................................................................... |
3-40 |
3.21 |
Head Cleaning.......................................................................................................... |
3-47 |
3.22 |
Log Utilities ............................................................................................................. |
3-48 |
3.23 |
Running Test............................................................................................................ |
3-50 |
3.24 |
Floppy Disk Drive Utilities...................................................................................... |
3-51 |
3.25 |
System Configuration .............................................................................................. |
3-56 |
3.26 |
Wireless LAN Test Program (Atheros) ................................................................... |
3-58 |
3.27 |
Wireless LAN Test Program (Intel-made b/g, a/b/g)............................................... |
3-65 |
3.28 |
LAN/Modem/Bluetooth/IEEE1394 Test Program .................................................. |
3-69 |
3.29 |
Sound Test program................................................................................................. |
3-84 |
3.30 |
SETUP ..................................................................................................................... |
3-90 |
TECRA A8 /Satellite Pro A120 Maintenance Manual (960-573) |
[CONFIDENTIAL] |
vii |
Chapter 4 Replacement Procedures |
|
|
4.1 |
General....................................................................................................................... |
4-1 |
4.2 |
Battery pack ............................................................................................................... |
4-8 |
4.3 |
PC card..................................................................................................................... |
4-10 |
4.4 |
SD card..................................................................................................................... |
4-11 |
4.5 |
HDD......................................................................................................................... |
4-12 |
4.6 |
MDC/Memory module............................................................................................. |
4-16 |
4.7 |
Keyboard.................................................................................................................. |
4-19 |
4.8 |
Optical drive............................................................................................................. |
4-22 |
4.9 |
Wireless LAN card .................................................................................................. |
4-25 |
4.10 |
Cover assembly........................................................................................................ |
4-27 |
4.11 |
SW membrane.......................................................................................................... |
4-31 |
4.12 |
Fingerprint sensor board .......................................................................................... |
4-33 |
4.13 |
Touch pad................................................................................................................. |
4-35 |
4.14 |
SD card slot.............................................................................................................. |
4-38 |
4.15 |
Bluetooth module..................................................................................................... |
4-39 |
4.16 |
Serial/S-Video board................................................................................................ |
4-41 |
4.17 |
RTC battery ............................................................................................................. |
4-42 |
4.18 |
Modem jack ............................................................................................................. |
4-44 |
4.19 |
Fan............................................................................................................................ |
4-45 |
4.20 |
System board............................................................................................................ |
4-47 |
4.21 |
Battery lock.............................................................................................................. |
4-49 |
4.22 |
HDD cable ............................................................................................................... |
4-51 |
4.23 |
Heat sink/CPU ......................................................................................................... |
4-52 |
4.24 |
PC card slot .............................................................................................................. |
4-56 |
4.25 |
LCD unit/FL inverter ............................................................................................... |
4-57 |
4.26 |
Cover latch............................................................................................................... |
4-62 |
4.27 |
Display rear cover.................................................................................................... |
4-63 |
4.28 |
Wireless LAN antenna/Bluetooth antenna............................................................... |
4-65 |
4.29 |
Hinge........................................................................................................................ |
4-71 |
4.30 |
Speaker..................................................................................................................... |
4-73 |
4.31 |
Fluorescent Lamp..................................................................................................... |
4-77 |
viii |
[CONFIDENTIAL] |
TECRA A8 /Satellite Pro A120 Maintenance Manual (960-573) |
Appendices |
|
|
Appendix A |
Handling the LCD Module ........................................................................... |
A-1 |
Appendix B |
Board Layout ................................................................................................ |
B-1 |
Appendix C |
Pin Assignments............................................................................................ |
C-1 |
Appendix D |
Keyboard Scan/Character Codes .................................................................. |
D-1 |
Appendix E |
Key Layout..................................................................................................... |
E-1 |
Appendix F |
Wiring Diagrams............................................................................................ |
F-1 |
Appendix G |
BIOS rewrite Procedures .............................................................................. |
G-1 |
Appendix H |
EC/KBC rewrite Procedures ......................................................................... |
H-1 |
Appendix I |
Reliability........................................................................................................ |
I-1 |
TECRA A8 /Satellite Pro A120 Maintenance Manual (960-573) |
[CONFIDENTIAL] |
ix |
x |
[CONFIDENTIAL] |
TECRA A8 /Satellite Pro A120 Maintenance Manual (960-573) |
Chapter 1
Hardware Overview
[CONFIDENTIAL]
1 Hardware Overview
1-ii |
[CONFIDENTIAL] |
TECRA A8 /Satellite Pro A120 Maintenance Manual (960-573) |
|
|
|
1 Hardware Overview |
|
|
|
|
Chapter 1 |
Contents |
|
|
1.1 |
Features....................................................................................................................... |
|
1-1 |
1.2 |
2.5-inch Hard Disk Drive ......................................................................................... |
1-14 |
|
1.3 |
Keyboard .................................................................................................................. |
|
1-16 |
1.4 |
Optical Drive ............................................................................................................ |
1-17 |
|
|
1.4.1 |
CD-ROM Drive .................................................................................. |
1-17 |
|
1.4.2 |
DVD-ROM Drive ............................................................................... |
1-18 |
|
1.4.3 DVD-ROM & CD-R/RW Drive ......................................................... |
1-19 |
|
|
1.4.4 |
DVD-Super Multi Drive ..................................................................... |
1-20 |
1.5 |
TFT Color Display ................................................................................................... |
1-21 |
|
|
1.5.1 |
LCD Module ....................................................................................... |
1-21 |
|
1.5.2 |
FL Inverter Board ............................................................................... |
1-23 |
1.6 |
Power Supply............................................................................................................ |
1-24 |
|
1.7 |
Batteries.................................................................................................................... |
|
1-28 |
|
1.7.1 |
Main Battery ....................................................................................... |
1-28 |
|
1.7.2 |
RTC battery......................................................................................... |
1-29 |
1.8 |
AC Adaptor .............................................................................................................. |
|
1-30 |
TECRA A8 /Satellite Pro A120 Maintenance Manual (960-573) |
[CONFIDENTIAL] |
1-iii |
1 Hardware Overview
Figures |
|
|
Figure 1-1 |
Front of the computer ..................................................................................... |
1-5 |
Figure 1-2 |
System unit configuration............................................................................... |
1-6 |
Figure 1-3-1 System unit block diagram (Intel chipset model)........................................... |
1-7 |
|
Figure 1-3-2 System unit block diagram (ATI chipset model) ........................................... |
1-7 |
|
Figure 1-4 |
2.5-inch HDD ............................................................................................... |
1-14 |
Figure 1-5 |
Keyboard ...................................................................................................... |
1-16 |
Figure 1-6 |
LCD module ................................................................................................. |
1-21 |
Tables |
|
|
Table 1-1 |
2.5-inch HDD specifications ........................................................................ |
1-14 |
Table 1-2 |
CD-ROM drive specifications...................................................................... |
1-17 |
Table 1-3 |
DVD-ROM drive specifications................................................................... |
1-18 |
Table 1-4 |
DVD-ROM & CD-R/RW drive specifications............................................. |
1-19 |
Table 1-5 |
DVD Super Multi drive specifications......................................................... |
1-20 |
Table 1-6 |
LCD module specifications .......................................................................... |
1-21 |
Table 1-7 |
FL inverter board specifications................................................................... |
1-23 |
Table 1-8-1 |
Power supply output rating (Intel chipset model) ........................................ |
1-25 |
Table 1-8-2 |
Power supply output rating (ATI chipset model) ......................................... |
1-26 |
Table 1-9 |
Battery specifications ................................................................................... |
1-28 |
Table 1-10 |
Time required for charges ............................................................................ |
1-28 |
Table 1-11 |
Data preservation time.................................................................................. |
1-29 |
Table 1-12 |
RTC battery charging/data preservation time............................................... |
1-29 |
Table 1-13 |
AC adapter specifications............................................................................. |
1-30 |
1-iv |
[CONFIDENTIAL] |
TECRA A8 /Satellite Pro A120 Maintenance Manual (960-573) |
1.1 Features |
1 Hardware Overview |
1.1Features
The Toshiba TECRA A8 series / Satellite Pro A120 series Personal Computer uses advanced Large Scale Integration (LSI), and Complementary Metal-Oxide Semiconductor (CMOS) technology extensively to provide compact size, minimum weight, low power usage and high reliability. This computer incorporates the following features.
There some models and options according to BTO system. Refer to the Parts List for the configuration of each model and options.
Microprocessor
The TECRA A8 series / Satellite Pro A120 series computer is equipped with one of the following processors.
Intel® CoreTM Duo
CoreTM Duo 1.66GHz (Processor Number : T2300E)
1.66GHz (Processor Number : T2300)
1.83GHz (Processor Number : T2400)
2.00GHz (Processor Number : T2500)
2.16GHz (Processor Number : T2600)
2.33GHz (Processor Number : T2700)
Intel® CoreTM Solo
CoreTM Solo 1.66GHz (Processor Number : T1300)
1.83GHz (Processor Number : T1400)
Intel® Celeron® M
Celeron® M 1.46GHz (Processor Number : 410)
1.60GHz (Processor Number : 420)
1.73GHz (Processor Number : 430)
Chipset
Equipped with ATI RC420MB or Intel 945GM as North Bridge, ATI SB450 or Intel ICH7-M as South Bridge and Texas Instrument PCI7412 as Card Controller.
VGA Controller
An internal Graphics Controller in North Bridge is used.
TECRA A8 /Satellite Pro A120 Maintenance Manual (960-573) |
[CONFIDENTIAL] |
1-1 |
1 Hardware Overview |
1.1 Features |
Memory
Two DDR2-533/DDR2-667 SDRAM slots. Memory modules can be installed to provide a maximum of 4GB (Intel Chipset model) or 2GB (ATI Chipset model). Memory modules are available in 256MB, 512MB, 1024MB and 2048MB sizes.
HDD
The computer has a 2.5-inch SATA HDD. The following capacities are available.
•40/60/80/100/120 GB
USB FDD
A 3.5-inch USB FDD accommodates 2HD (1.44MB) or 2DD (720KB) disks.
Optical Drive
CD-ROM drive, DVD-ROM drive, DVD-ROM & CD-R/RW drive or DVD Super Multi drive (double layer) can be installed.
Display
LCD : Built-in 15.4 inch, 16M colors, WXGA(1280×800dots) thin type low temperature poly-silicon TFT color display.
External monitor : Supported via an RGB connector.
TV-out : Supporting VIDEO-out. (Only for models S-VIDEO jack mounted)
Keyboard
An-easy-to-use 84(US)/85(UK)-key keyboard provides a numeric keypad overlay for fast
numeric data entry or for cursor and page control. The keyboard also includes two keys that have special functions in Microsoft® Windows® XP.
Touch pad
A Touch Pad and control buttons in the palm rest enable control of the on-screen pointer and scrolling of windows.
Batteries
The computer has two batteries: a rechargeable Lithium-Ion main battery pack and RTC battery (that backs up the Real Time Clock and CMOS memory).
1-2 |
[CONFIDENTIAL] |
TECRA A8 /Satellite Pro A120 Maintenance Manual (960-573) |
1.1 Features |
1 Hardware Overview |
Universal Serial Bus (USB2.0)
Three USB ports are provided. The ports comply with the USB2.0 standard.
IEEE 1394 port
The computer comes with one IEEE 1394 port. It enables high-speed data transfer directly from external devices such as digital video cameras.
External monitor (RGB) port
The port enables connection of an external monitor, which is recognized automatically by Video Electronics Standards Association (VESA) Display Data Channel (DDC) 2B compatible functions.
PC card slot
A PC card slot is provided. The PC card slot (PCMCIA) accommodates one Type II card.
SD card slot
The SD card slot can accommodate Secure Digital flash memory cards with various capacities.
Fingerprint sensor
The computer is equipped with a fingerprint sensor and fingerprint authentication utility. They enable only person who has registered his/her fingerprint to use the computer.
Sound system
The sound system is equipped with the following features:
•Stereo speakers
•Volume control
•Stereo headphone jack
•External microphone jack
TECRA A8 /Satellite Pro A120 Maintenance Manual (960-573) |
[CONFIDENTIAL] |
1-3 |
1 Hardware Overview |
1.1 Features |
Internal LAN/ Internal modem
The computer has built-in support for Ethernet LAN (10 megabits per second, 10BASE- T), Fast Ethernet LAN (100 megabits per second, 100BASE-TX) and Gigabit Ethernet LAN (1000 megabits per second, 1000BASE-T).
The computer contains a MDC, enabling data and fax communication.
Bluetooth
The computer is equipped with Bluetooth (V2.0+EDR) communications standard enable wireless connection between electronic devices such as computers and printers. It supports wireless communication switch.
Wireless LAN
The computer is equipped with PCI Express Mini Card type wireless LAN card that supports 802.11 b/g or 802.11 a/b/g in the PCI Express Mini Card slot. This function can be switched on and off by a switch on the computer.
Presentation button
This button switches the display between internal display, external display, simultaneous display and multi-monitor display.
TOSHIBA Assist button
When this button is pressed during power-on, the computer is connected to “Toshiba Assist”. When this button is pressed during power-off, the computer is turned on and connected to “Toshiba Assist”.
1-4 |
[CONFIDENTIAL] |
TECRA A8 /Satellite Pro A120 Maintenance Manual (960-573) |
1.1 Features |
1 Hardware Overview |
||
The front of the computer is shown in figure 1-1. |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
Figure 1-1 Front of the computer
TECRA A8 /Satellite Pro A120 Maintenance Manual (960-573) |
[CONFIDENTIAL] |
1-5 |
1 Hardware Overview |
1.1 Features |
||
The system unit configuration is shown in figure 1-2. |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
Figure 1-2 System unit configuration
1-6 |
[CONFIDENTIAL] |
TECRA A8 /Satellite Pro A120 Maintenance Manual (960-573) |
1.1 Features |
1 Hardware Overview |
||
Figure 1-3-1, 1-3-2 is a block diagram of the system unit. |
|
|
|
|
|
|
|
|
|
|
|
Figure 1-3-1 System unit block diagram (Intel chipset model)
Figure 1-3-2 System unit block diagram (ATI chipset model)
TECRA A8 /Satellite Pro A120 Maintenance Manual (960-573) |
[CONFIDENTIAL] |
1-7 |
1 Hardware Overview |
1.1 Features |
The system unit is composed of the following major components:
Processor
Intel® CoreTM Duo Processor (dual core), Intel® CoreTM Solo Processor (single core) or Intel® Celeron® M Processor is mounted.
Intel® CoreTM Duo Processor:
Speed 1.66GHz (T2300E) 1.66GHz (T2300) 1.83GHz (T2400) 2.00GHz (T2500) 2.16GHz (T2600) 2.33GHz (T2700)
–Integrated L1 cache memory of 64KB (32KB +32KB)
–Integrated L2 cache memory of 2MB
–Processor bus speed: 667MHz
–Core voltage: 1.300 to 1.1625V
–478-pin Micro FC-PGA package
Intel® CoreTM Solo Processor
Speed |
1.66GHz (T1300) |
|
1.83GHz (T1400) |
–Integrated L1 cache memory of 64KB (32KB +32KB)
–Integrated L2 cache memory of 2MB
–Processor bus speed: 667MHz
–Core voltage: 1.300 to 1.1625V
–478-pin Micro FC-PGA package
Intel® Celeron® M Processor
Speed |
1.46GHz (410) |
|
1.60GHz (420) |
|
1.72GHz (430) |
–Integrated L1 cache memory of 64KB (32KB +32KB)
–Integrated L2 cache memory of 1MB
–Processor bus speed: 533MHz
–Core voltage: Multiple VID
–478-pin Micro FC-PGA package
1-8 |
[CONFIDENTIAL] |
TECRA A8 /Satellite Pro A120 Maintenance Manual (960-573) |
1.1 Features |
1 Hardware Overview |
Memory
Two memory slots capable of accepting DDR2-SDRAM 256MB, 512MB, 1024MB or 2048MB memory modules for a maximum of 4GB (Intel Chipset model) or 2GB (ATI Chipset model).
•200-pin Small Outline DIMM
•1.8V operation
•PC2-4200(DDR2-533)/PC2-5300(DDR2-667) support
BIOS ROM
•8Mbits of flash memory are used.
–320KB for System BIOS
–64KB for VGA BIOS
–64KB for Fingerprint sensor
–64KB for LAN BIOS
–24KB for Boot
–16KB for Parameter Block
–32KB for Option Log
–Others
North Bridge
•Intel 945GM:
–Supports Yonah Processor System Bus
–Supports System Memory : DDR2-400/DDR2-533/DDR2-667, 4GB(max)
–Internal Graphics Controller : Inter Generation 3.5 Integrated GFX Core (250MHz)
–DMI(Direct Media Interface)
–Supports ICH.
–1466-ball 37.5×37.5×2.56mm FC-BGA package
•ATI RC420MD:
–Graphic controller
–System Memory controller : DDR2-400/DDR2-533/DDR2-667, 2GB(max)
TECRA A8 /Satellite Pro A120 Maintenance Manual (960-573) |
[CONFIDENTIAL] |
1-9 |
1 Hardware Overview |
1.1 Features |
–PCI Express interface
–A-Link Express
–Supports ICH
–Power management
South Bridge
•Intel ICH7-M:
–DMI(Direct Media Interface)
–PCI Express I/F (4 ports)
–PCI Bus I/F Rev2.3 (6 PCI REQ/GNT Pairs)
–Integrated Serial ATA Host Controller (2 Prots,150MB/S)
–Integrated IDE Controller (Ultra ATA 100/66/33)
–AC’97 2.3 codecs
–Intel High Definition controller (Azalia)
–USB 1.1/2.0 Controller 8 ports
–Built-in LAN controller (WfM 2.0 & IEEE 802.3 compliance)
–Power Management (ACPI 2.0 compliance)
–SMBus2.0 controller
–Low Pin Count (LPC) interface (EC/KBC, Super I/O)
–IRQ controller
–Serial Interrupt Function
–Suspend/Resume control
–Built –in RTC
–GPIO
–652-ball 31×31×2.51mm BGA Package
•ATI SB450:
−PCI Local Bus Specification, Revision 2.3-compliant with support for 33MHz PCI operations
−PCI Express (4 PCI Express root ports)
−ACPI 2.0 compliant
−Enhanced DMA Controller, Interrupt Controller, and Timer Functions
−Integrated Serial ATA Host Controller (4 ports)
−Integrated IDE controller supports Ultra ATA 100/66/33 (2 ports)
1-10 |
[CONFIDENTIAL] |
TECRA A8 /Satellite Pro A120 Maintenance Manual (960-573) |
1.1 Features |
1 Hardware Overview |
−USB host interface with support for 8 USB ports; 2 OHCI host controllers; 1 EHCI high-speed USB 2.0 Host Controller
−Integrated LAN Controller
−System Management Bus (SM Bus) Specification, Version 2.0 with additional support for I2C devices
−Intel High Definition Audio Interface
−Supports Audio Codec ’97, Revision 2.3 specification or HD Audio
−Low Pin Count (LPC) interface
−Firmware Hub (FHW) interface support
−Alert On LAN (AOL)
−Package 564 pin BGA (31 x 31mm)
PC Card Controller (TI PCI7412)
−PCI I/F
−CardBus / Ultra media Controller (1 socket)
−SD/MMC, Memory Stick, XD Card Controller
−1394 Controller (2 ports)
– 288-ball, 16×16×1.4mm, BGA Package
TECRA A8 /Satellite Pro A120 Maintenance Manual (960-573) |
[CONFIDENTIAL] |
1-11 |
1 Hardware Overview |
1.1 Features |
VGA
Graphics interface in North Bridge (Intel 945GM/ATI RC420MB) is used.
Sound Controller
•Sound controller built in the South Bridge (Intel ICH7-M/ATI SB450) + ALC262, AN12941A.
−Internal stereo speakers
−Volume control
−Stereo headphone jack
−External microphone jack
Modem Controller
•Askey-made one MDC is used.
•This controller has the following functions:
–One RJ11 port
–V.92 (V.90) 56K Modem/FAX
–Supports Ring Wakeup
1-12 |
[CONFIDENTIAL] |
TECRA A8 /Satellite Pro A120 Maintenance Manual (960-573) |
1.1 Features |
1 Hardware Overview |
Internal LAN
•Ethernet LAN (10 megabits per second, 10BASE-T), Fast Ethernet LAN (100 megabits per second, 100BASE-TX) or Gigabit Ethernet LAN (1000 megabits per second, 1000BASE-T) (only Intel chipset model) is used.
– Controller
Gigabit Ethernet: Gigabit Intel Vidaria
Ethernet/Fast Ethernet: ReaLTek RTL 8100CL
–One RJ45 port
–Supports WOL
–Supports LED
Wireless LAN
•Intel made or Askey made wireless LAN card in the PCI Express Mini card slot
−Supports 802.11b/g or 802.11a/b/g
−Supports Wireless Communication SW
−Supports WEP
−Supports WOL (Intel-maid wireless LAN card only )
Other main system chips
•Clock Generator (ICS-made 954321AGLFT)
•EC/KBC (Renesas-made M306KAFCLRP)
•PSC (Toshiba-made TMP86FS49UG)
•Super I/O (LPC-made 47N217)
•Temperature sensor (ADM-made 1032ARMZ ×2)
•Acceleration sensor (ST Micro-made LIS3L02AQ)
•TPM (Infineon-made SLB9635 TT 1.2)
TECRA A8 /Satellite Pro A120 Maintenance Manual (960-573) |
[CONFIDENTIAL] |
1-13 |
1 Hardware Overview |
1.2 2.5-inch Hard Disk Drive |
1.22.5-inch Hard Disk Drive
The removable HDD is a random access non-volatile storage device. It has a non-removable 2.5-inch magnetic disk and mini-Winchester type magnetic heads.
The computer supports a 40GB, 60GB, 80GB, 100GB or 120GB.
The HDD is shown in figure 1-4. Specifications are listed in Table 1-1.
|
|
|
|
|
|
|
|
|
|
|
|
|
|
Figure 1-4 |
2.5-inch HDD |
|
|
|
|
|
|
|
Table 1-1 2.5-inch HDD specifications (1/2) |
|
|||||
|
|
|
|
|
|
|
|
||
|
|
|
|
|
Specifications |
|
|||
|
Items |
|
|
|
|
|
|
||
|
FUJITSU |
FUJITSU |
|
FUJITSU |
FUJITSU |
||||
|
|
|
|
|
|||||
|
|
|
|
G8BC0002W410 |
G8BC0002W610 |
|
G8BC0002W810 |
G8BC0002WA10 |
|
Outline |
|
Width (mm) |
|
70.0 |
|
|
|||
dimensions |
|
Height (mm) |
|
9.5 |
|
|
|||
|
|
Depth (mm) |
|
100.0 |
|
|
|||
|
|
Weight (g) |
|
101 max. |
|
||||
Storage size (formatted) |
40GB |
60GB |
|
80GB |
100GB |
||||
|
|
|
|
|
|
||||
Speed (RPM) |
|
5,400 |
|
|
|||||
|
|
|
|
|
|
|
|||
Data transfer rate |
|
|
|
|
|
|
|||
To/From media |
|
61.3 max. |
|
||||||
To/From host |
|
1.5 (150MB/s) max. |
|
||||||
|
|
|
|
|
|
||||
Data buffer size (MB) |
|
8 |
|
|
|
||||
|
|
|
|
|
|
|
|||
Average seek time (ms) |
|
12 |
|
|
|
||||
Read |
|
|
|
|
|
|
|
||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
||||||
Motor startup time (s) |
|
4 typ. |
|
||||||
|
|
|
|
|
|
|
|
|
|
1-14 |
[CONFIDENTIAL] |
TECRA A8 /Satellite Pro A120 Maintenance Manual (960-573) |
1.2 2.5-inch Hard Disk Drive |
1 Hardware Overview |
Table 1-1 2.5-inch HDD specifications (2/2)
|
Items |
|
Specifications |
|
|||
|
|
|
|
|
|
||
|
HITACHI GST |
HITACHI GST |
|
HITACHI GST |
HITACHI GST |
||
|
|
|
|
||||
|
|
|
G8BC00029410 |
G8BC00029610 |
|
G8BC00029810 |
G8BC00029A10 |
Outline |
|
Width (mm) |
|
69.85±0.25 |
|
||
dimensions |
|
Height (mm) |
|
9.5±0.2 |
|
||
|
|
Depth (mm) |
|
100.2±0.25 |
|
||
|
|
Weight (g) |
95 max. |
|
|
102 max. |
|
Storage size (formatted) |
40GB |
60GB |
|
80GB |
100GB |
||
|
|
|
|
|
|||
Speed (RPM) |
|
5,400 |
|
||||
|
|
|
|
|
|
||
Data transfer rate |
|
493 Mb/s max. |
|
||||
To/From media |
|
|
|||||
To/From host |
|
1.5Gbps |
|
||||
|
|
|
|
|
|||
Data buffer size (MB) |
|
|
8 |
|
|||
|
|
|
|
|
|
||
Average seek time (ms) |
|
12 typ. |
|
||||
Read |
|
|
|
|
|||
|
|
|
|
|
|
|
|
Motor startup time (s) |
|
3.5 typ. |
|
||||
|
|
|
|
|
|
|
|
|
|
|
|
Specifications |
|
|
Items |
|
|
|
|
|
FUJITSU |
|
HITACHI GST |
||
|
|
|
|
||
|
|
|
G8BC0002WC10 |
|
G8BC0002NA10 |
Outline |
|
Width (mm) |
70 |
|
69.85±0.25 |
dimensions |
|
Height (mm) |
9.5 |
|
9.5±0.2 |
|
|
Depth (mm) |
10 |
|
100.2±0.25 |
|
|
Weight (g) |
101 max. |
|
115 max. |
Storage size (formatted) |
120GB |
|
100GB |
||
|
|
|
|
||
Speed (RPM) |
5,400 |
|
7,200 |
||
|
|
|
|
||
Data transfer rate |
|
|
|
||
To/From media |
61.3 MB/s max |
|
629 Mb/s max. |
||
To/From host (Gbps) |
1.5 |
|
1.5 |
||
Data buffer size (KB) |
8,192 |
|
8,192 |
||
|
|
|
|
||
Average seek time (ms) |
12 typ |
|
10 typ. |
||
Read |
|
|
|
||
|
|
|
|
|
|
|
|
|
|
||
Motor startup time (s) |
|
4 typ. |
|||
|
|
|
|
|
|
TECRA A8 /Satellite Pro A120 Maintenance Manual (960-573) |
[CONFIDENTIAL] |
1-15 |
1 Hardware Overview |
1.3 Keyboard |
1.3Keyboard
The keyboard is mounted 84(US)/85(UK) keys that consist of character key and control key. The keyboard is connected to membrane connector on the system board and controlled by the keyboard controller.
Figure 1-5 is a view of the keyboard.
See Appendix E about a layout of the keyboard.
Figure 1-5 Keyboard
1-16 |
[CONFIDENTIAL] |
TECRA A8 /Satellite Pro A120 Maintenance Manual (960-573) |