Volvo XC60 2014-2015 Wiring Diagram

VOLVO XC60

WIRING DIAGRAM 2014/2015A

TP 39273202 Structure week 13w46

Vehicles with SRS (Airbag)/SIPS bag/IC (Inflatable Curtain)

Warning!

Extra caution must be exercised when working on vehicles equipped with SRS/SIPS bag/IC in order to avoid:

1. Personal injuries when performing repair work.

2. Damage or malfunction of the SRS/SIPS bag/IC system. Work involving the SRS/SIPS bag/IC systems or other components in the vehicle that may affect the SRS/SIPS bag/IC systems must always be performed by an authorized Volvo workshop. In case of doubt, consult the SRS and SIPS bag/IC service manual.

Is the vehicle equipped with SRS/SIPS bag/IC?

Vehicles with SRS are most easily recognized by the letters SRS in the center of the steering wheel. If the vehicle also has a passenger side airbag, the letters SRS are stamped on the dashboard above the glove compartment. SRS vehicles from 1993 and onward also have explosive seat belt tensioners. SIPS bags are only installed on SRS vehicles from 1995 and onward. SIPS bag decals are located on the windshield and seat compartment. Vehicles with IC can be recognized by the letters IC on the C/D panel (4 door) or the B panel (5 door).

General recommendations

• Be especially careful when working on or around SRS, SIPS, and IC components.

• Make sure that no wires are pinched, frayed, or pierced.

• Never install accessories by the sensors.

• Where applicable, work on the steering wheel, steering shaft, or steering gear must be done in accordance with the methods in the SRS section of VIDA.

• Certain components of the aforementioned systems must be grounded while working. Read the appropriate sections in VIDA.

• Install no accessories in the areas between the A and B-posts, the B and C-posts, and the C and D-posts.

Test terminal

Data link connector in the passenger compartment.

Changes introduced up to and including structure week 13w46

Any changes made to the vehicles after this date are not included in the manual. If necessary refer to service bulletins.

Volvo models are sold in versions adapted for different markets. These adaptations depend on factors such as legal requirements, taxation, and market demands. This manual may therefore include illustrations and text that do not apply to the vehicles in your country.

Ordering: Electronic Wiring Diagrams (EWD) can be ordered from the Technical Information Shop (TIS) We reserve the right to make modifications.

Table of Contents 1:3

Explanations & Abbreviations ........................................ 6

How to use the wiring diagrams 1:2............................... 7

Electrical distribution

Overview without Start/Stop function............................. 9

Overview with Start/Stop function................................ 10

Overview, Distribution box in engine compartment

exc. 4-Cyl..................................................................... 11

Overview, Distribution box in engine compartment

4-Cyl. ........................................................................ 12

Overview, Distribution box in passenger compartment 13

Overview, Distribution box in cargo compartment ....... 14

Fuses

Distribution box in engine compartment F1 - F7........... 15

Distribution box in engine compartment F8 - F23......... 16

Distribution box in engine compartment F27 - F37....... 17

Distribution box in engine compartment F38 ................ 18

Distribution box in engine compartment F39 - F44....... 19

Central electronic module (CEM) F1 - F6 ..................... 20

Central electronic module (CEM) F7 - F16 ................... 21

Central electronic module (CEM) F18 - F24 ................. 22

Distribution box in passenger compartment F1 - F20... 23 Distribution box in passenger compartment F21 - F30. 24

Distribution box in cold zone F1 - MF2 ......................... 25

Distribution box in cargo compartment FA1 - FA11...... 26

Battery PF1 - PF2 ......................................................... 27

Relays

Relays in the engine compartment .............................. 28

Relays in the engine compartment .............................. 29

Relays in passenger and cargo compartments ........... 30

Ground connections

Overview...................................................................... 31

31/2 - 31/6.................................................................... 32

31/7 ........................................................................ 33

31/10 ........................................................................ 34

31/15 ........................................................................ 35

31/47 - 31/48................................................................ 36

31/65 - 31/83................................................................ 37

31/84 - 31/90................................................................ 38

31/93 - 31/115.............................................................. 39

31/131 - 31/TRM.......................................................... 40

Control modules

Overview locations....................................................... 41

Overview designations................................................. 42

Central electronic module (CEM) 1:3........................... 43

Data communication high speed CAN exc. 4-Cyl. 1:2 . 46

Data communication high speed CAN 4-Cyl. 1:2......... 48

Data communication intermediate speed CAN, LHD... 50 Data communication intermediate speed CAN, RHD .. 51

Data communication Local CAN .................................. 52

Data communication Extended CAN ........................... 53

Data communication MOST......................................... 54

Data communication, LIN 1:3....................................... 55

Steering Wheel Module (SWM) ................................... 58

Group 26 Cooling system

Cooling fan 4-Cyl. Turbo 2.0l ....................................... 59

Cooling fan 4-Cyl. Diesel 2.0l....................................... 60

Cooling fan 5-Cyl. Diesel ............................................. 61

Cooling fan 6-Cyl. ........................................................ 62

Group 27 Engine controls

Cruise control 4-Cyl. Turbo ...........................................63

Cruise control 4-Cyl. Diesel ..........................................64

Cruise control 5-Cyl. Diesel ..........................................65

Cruise control 6-Cyl. .....................................................66

Start-/Stop function 4-Cyl. Turbo 2.0l............................67

Start-/Stop function 4-Cyl. Diesel 2.0l ...........................68

Start-/Stop function 5-Cyl. Diesel..................................69

Group 28 Ignition and control system

Engine management system, 5-Cyl. Diesel 1:3 ........... 70

Engine management system, 4-Cyl. Diesel 1:3 ........... 73

Engine management system, 4-Cyl. Turbo 2.0l 1:3..... 76

Engine management system 6-Cyl. 3.2l 1:2 ................ 79

Engine management system 6-Cyl. 3.2l PZEV 1:2...... 81

Engine management system, 6-Cyl. Turbo 1:2............ 83

Emission control 4-Cyl. Turbo...................................... 85

Emission control 6-Cyl. 3.2l PZEV ............................... 86

Emission control 6-Cyl. 3.2l ......................................... 87

Emission control 6-Cyl. Turbo...................................... 88

Group 32 Alternator and voltage regulator

Power supply 4-Cyl. with Start/Stop............................. 89

Power supply 5-Cyl. with Start/Stop............................. 90

Power supply 5-Cyl. Diesel without Start/Stop............. 91

Power supply 6-Cyl. ..................................................... 92

Group 33 Starting system

Starting system 4-Cyl. Turbo 1:2 ................................. 93

Starting system 4-Cyl. Diesel 1:2................................. 95

Starting system 6-Cyl................................................... 97

Starting system 5-Cyl. With Start/Stop 1:2................... 98

Starting system 5-Cyl. Without Start/Stop.................. 100

TP39273202 XC60 2014 © Volvo Car Corporation 2013 3

Table of Contents 2:3

Group 35 Lighting

High and low beam, Halogen..................................... 101

High and low beam, Dual Xenon ............................... 102

Beam length adjustment, manual .............................. 103

Running/Parking light, Tail lights ............................... 104

Fog lights ................................................................... 105

Brake lights ................................................................ 106

Reversing lights ......................................................... 107

Follow-me-home lighting LHD ................................... 108

Follow-me-home lighting RHD................................... 109

Active headlight ......................................................... 110

Interior lighting, LHD 1:3 ............................................ 111

Interior lighting, RHD 1:3 ........................................... 114

Lighting in door sill trims ............................................ 117

Auxiliary lights............................................................ 118

Group 36 Additional electrical equipment

Rain sensor................................................................ 119

Direction indicator and hazard warning flashers LHD 120 Direction indicator and hazard warning flashers RHD 121

Wiper/Washer windshield .......................................... 122

Washer headlights ..................................................... 123

Wiper/Washer rear window........................................ 124

Keyless vehicle 1:2 .................................................... 125

Horn ...................................................................... 127

Anti-theft alarm .......................................................... 128

Parking assistance..................................................... 129

Collision warning with power brake booster .............. 130

Tire pressure monitoring system (TPMS) .................. 131

Alcohol lock................................................................ 132

Group 37 Wiring and fuses

Diagnostics system.................................................... 133

Outlet 12 V................................................................. 134

Cable harness towbar/tow hitch 4-pin ....................... 135

Cable harness towbar/tow hitch 7-pin........................ 136

Cable harness towbar/tow hitch 13-pin...................... 137

USB unit (AUU).......................................................... 138

Group 38 Instruments

Seat belt reminder ..................................................... 139

Driver information module.......................................... 140

Group 39 Other

Audio High/Premium IAM 1:3 .................................... 141

Audio High/Premium IHU 1:3..................................... 144

Audio 1:2.................................................................... 147

Cellular phone 1:2...................................................... 149

DAB Radio ................................................................. 151

Multimedia monitor with DVD, Dual Screen RSE ...... 152

TV receiver / TV control module ............................... 153

Bluetooth Handsfree IAM........................................... 154

Bluetooth Handsfree IHU ........................................... 155

Navigation system & Traffic information, portable ..... 156

Satellite radio ............................................................. 157

Parking camera.......................................................... 158

Wide angle camera front............................................ 159

Sensus Connected Touch.......................................... 160

Group 43 Transmission

Automatic transmission AWF21................................. 161

Automatic transmission AWF22................................. 162

Transmission M66...................................................... 163

Differential electronic module (DEM) ......................... 164

Group 55 Parking brake

Electric parking brake ................................................ 165

Group 59 Brake system

Brake control system & DSTC ................................... 166

Group 64 Steering

Speed dependent power steering EHPAS................. 167

Speed dependent power steering EPAS ................... 168

Group 76 Shock absorbers

Four-C ...................................................................... 169

Group 83 Doors and openings

Central locking front doors LHD................................. 170

Central locking front doors RHD ................................ 171

Central locking rear doors.......................................... 172

Central locking tailgate with POT............................... 173

Central locking tailgate without POT.......................... 174

Signal receiver central locking ................................... 175

Central locking fuel filler flap ...................................... 176

Power windows front doors LHD................................ 177

Power windows front doors RHD ............................... 178

Power windows rear doors......................................... 179

Power sunroof............................................................ 180

Group 84 Exterior decorative elements, etc.

Power door mirrors LHD ............................................ 181

Power door mirrors RHD............................................ 182

Heated door mirrors LHD........................................... 183

Heated door mirrors RHD .......................................... 184

Door mirrors with automatic dimming LHD ................ 185

Door mirrors with automatic dimming RHD................ 186

Blind spot information system LHD 1:2...................... 187

Blind spot information system RHD 1:2 ..................... 189

Heated windshield LHD ............................................. 191

Heated windshield RHD............................................. 192

Heated rear window ................................................... 193

TP39273202 XC60 2014 © Volvo Car Corporation 2013 4

Table of Contents 3:3

Group 85 Interior equipment

Power driver’s seat with memory function, LHD ........ 194

Power driver’s seat with memory function, RHD ....... 195

Power passenger seat, LHD...................................... 196

Power passenger seat, RHD ..................................... 197

Heated front seats with fans ...................................... 198

Heated front seats without fans ................................. 199

Heated steering wheel ............................................... 200

Heated rear seat ........................................................ 201

Adjustable lumbar support, driver LHD...................... 202

Adjustable lumbar support, driver RHD ..................... 203

Adjustable lumbar support, passenger LHD .............. 204

Adjustable lumbar support, passenger RHD ............. 205

Group 87 Climate control system

Climate control system PTC-elements ...................... 206

Climate control system, 4-Cyl. Turbo 1:2................... 207

Climate control system, 4-Cyl. Diesel 1:2 .................. 209

Climate control system 5-Cyl. Diesel 1:2 ................... 211

Climate control system 6-Cyl. 1:2 .............................. 213

Parking heater, auxiliary heater ................................. 215

Parking heater, remote start ...................................... 216

Group 88 Internal equipment

Supplemental restraint system 1:2 ............................ 217

Remote control opener garage door.......................... 219

Power folding headrest .............................................. 220

Rear-view mirror with automatic dimming.................. 221

Connectors............................................... 222

Branching points .....................................261

Cable harness routing in vehicle

Harness engine, 4-Cyl. Turbo .....................................283

Harness engine, 4-Cyl. Diesel ....................................283

Harness engine, 5-Cyl. Diesel ....................................284

Harness engine, 6-Cyl. Turbo .....................................284

Harness engine, 6-Cyl. 3,2L .......................................285

Harness engine, 6-Cyl. 3,2L PZEV .............................285

Engine compartment harness, LHD............................286

Engine compartment harness, RHD ...........................286

Dashboard harness, LHD ...........................................287

Dashboard harness, RHD...........................................288

Floor Harness, LHD ....................................................289

Floor Harness, RHD....................................................290

Harness infotainment, LHD.........................................291

Harness infotainment, RHD ........................................292

Roof harness, LHD .....................................................293

Roof harness, RHD.....................................................294

Tunnel harness ...........................................................295

Harness driver door, LHD ...........................................296

Harness driver door, RHD...........................................296

Harness passenger door, LHD ...................................297

Harness passenger door, RHD...................................297

Harness rear door, RHD .............................................298

Harness rear door, LHD..............................................298

Tailgate harness PAC .................................................299

Tailgate harness without PHC ....................................299

Harnesses bumper, front ............................................300

Harnesses bumper, rear .............................................300

Adapter harness, rear bumper ....................................301

Adapter harness, heated windscreen .........................301

Component illustrations ......................... 302

Index 1:2 ................................................... 355

List of components 1:6 .......................... 357

TP39273202 XC60 2014 © Volvo Car Corporation 2013 5

Explanations & Abbreviations

Groups

Group 26 = Cooling system Group 27 = Engine controls Group 28 = Ignition and control system Group 32 = Alternator and voltage regulator Group 33 = Starting system Group 35 = Lighting Group 36 = Additional electrical equipment Group 37 = Wiring and fuses Group 38 = Instruments Group 39 = Other Group 43 = Transmission Group 55 = Parking brake Group 59 = Brake system Group 64 = Steering Group 76 = Shock absorbers Group 83 = Doors and openings Group 84 = Exterior decorative elements, etc. Group 85 = Interior equipment Group 87 = Climate control system Group 88 = Internal equipment Group 89 = Body other

Ignition switch symbols

X = Accessories (audio position) S = Powered upon insertion of key 15 = Contact remains connected during

start 15l = Contact is broken while starting 30 = Constant power from the battery 50 = Start

Countries/Markets

A = Austria AUS = Australia

B = Belgium CDN = Canada CH = Switzerland D = Germany DK = Denmark E = Spain EU/OS = Markets outside USA and Canada FIN = Finland GB = Great Britain ISR = Israel J = Japan KOR = Korea N = Norway NL = Netherlands S = Sweden USA = United States of America WEU = Western Europe

Other

ACC = Adaptive Cruise Control Ag = Silver plated Au = Gold plated AUTO = Automatic transmission AWF21 = TF-80SC & TF-80SD AWF22 = TG-81SC

BLIS = Blind spot information system CAN = CAN communication DPY = Display ECC = Electronic climate control system ETA = Throttle unit EXC = Excluding GDL = Gas discharge lamp HS = High speed data bus KEYLESS = Keyless vehicle IR = Infrared sensor LIN = LIN communication LH = Left-hand side LHD = Left-hand drive MAN = Manual transmission MEMORY = Memory driver’s seat MIRCAM = Parking camera in rear-view mirror MS = Midspeed data bus MMS = Mass Movement Sensor PANROOF = Panoramic roof PETROL = Gasoline RH = Right-hand side RHD = Right-hand drive RTI = Road Traffic Information SCR = Shielded SRS = Airbag

T = Turbocharged engine

W/O = Without 2WD = Two-wheel drive 4CYL, I4 = 4-cylinder engine 5CYL, I5 = 5-cylinder engine 6CYL, I6 = 6-cylinder engine

Colors

BK, SB = Black BN = Brown BU, BL = Blue GN = Green GY, GR = Gray LGN = Light Green NL = Natural OG, OR = Orange PK, P = Pink RD, R = Red VT, VO = Violet WH, W = White

YE, Y = Yellow

TP39273202 XC60 2014 © Volvo Car Corporation 2013 6

How to use the wiring diagrams 1:2

The descriptions below apply in general to all wiring diagram manuals, although not all sections are necessarily contained in this manual.

A. Component designation

Every component has a component designation that consists of two parts.

The first part is a type number that describes the

type of component in question, for example 3/xx.

The second part of the designation is a serial num-

ber, e.g. x/2.

Together, this constitutes a component designation,

e.g. 3/2.

At the end of the manual is a list of components,

where, with the help of the component designation, you can read off the name of the component, for example, 3/2 = light switch.

List of type numbers

The list shows which type of component that respec

tive type numbers refer to, for example, 3/x = switch, 6/x = electric motor, etc.

1 Battery 2 Relay 3 Switch 4 Control module 5 Driver information module 6 Electric motor 7 Sensor 8 Actuator 9 Heating element 10 Light 11 Fuse 15 Electrical distribution rail/box 16 Audio 17 Service/diagnostics 18 Contact reel 19 Meter 20 Ignition component/shunt 27 Optics 31 Ground connection 73 Branching point 74 Connector

The systems are shown in non-active status.i.e. with "key removed" and when the doors, hatches and hood are closed.

B. Branching points

The wiring diagrams contain numbered branching

points, for example 73/5035.

This manual contains a section with a list of branch-

ing points. This list shows all the components that are connected to each branching point.

The location of the branching points is shown in the

"Cable harness routing in vehicle" section.

C. Connectors

Connectors provide a bridge between two cable harnesses and are described in the "Connectors" section.

D. Electrical distribution

Operation of the fuses and relays is shown in the "Electrical distribution" section.

E. Data communication

Today’s cars contain CAN, LIN and MOST networks

that transfer information. Connections to these networks are not shown in their entirety in the respective wiring diagram. Complete information on CAN, LIN and MOST communication is found in the section "Control modules".

F. Abbreviations

A number of different abbreviations are used in the

manual. These are explained in the section "Abbreviations".

G. Component location

There is a section at the end of the manual in which

the appearance and location of components is described in numerical order.

TP39273202 XC60 2014 © Volvo Car Corporation 2013 7

How to use the wiring diagrams 2:2

List of symbols

= System voltage

= Ground connection via wiring

= Ground connection in component/chassis = Screened wire

= Junction point

= Twisted cable

= Electrical connection

= Variant

= CAN communication

= CAN high data signal (CAN H)

= CAN low data signal (CAN L)

= LIN communication

= DIN cable, coaxial cable, etc.

= Data communication

= CAN communication

= MOST communication

= Connection with distribution box

= Further connection to...

= Connector between cable harnesses = Connector connected in component

TP39273202 XC60 2014 © Volvo Car Corporation 2013 8

Electrical distribution Overview without Start/Stop function

15/31

73/3137

73/3136

PF1

11B/27

RD-VT

2/31

RD-VT

11A/1 11A/2 11A/4 11A/5 11A/3

1/1

7/240

BMS

LIN

12V

11B/17

GY-BK

GN-VT

RD-BK

RD-BU

4/56

C1:13

RD-GY

RD-BN

C1:63

C5:1

C5:2

F17

F18

F19

F20

15/36

2/193

2/88

11C/21

11C/24

11C/28

CEM

CAN

LIN

C2:5

C1:9

RD-GN

RD-VT

RD-GN

15/32

11D/A1 11D/A2 11D/A3 11D/A4

11D/A5 11D/A6

VT-GN

74/504

74/504B

VT-GN

RD-GN

73/5075

RD-GN

RD-VT

11D/A11

11D/A12

2/16

RA2

2/82

RA1

RD-GN

31/3

TP39273202 XC60 2014 © Volvo Car Corporation 2013 9

B31W051

Electrical distribution Overview with Start/Stop function

15/31

11B/34

15/37

MF2

MF1

RD-GN

RD-VT

RD-GN

RD-VT

15/32

RD-VT

7/240

BMS

LIN

1/1

12V

11D/A1 11D/A2 11D/A3 11D/A4

11D/A5 11D/A6

11D/A11

11D/A12

2/16

RA2

2/82

RA1

C1:13

RD-BU

4/56

C1:63

C5:1

C5:2

F17 F18 F19

F20

CEM

CAN

LIN

C2:17

C2:5

C1:9

74/504

VT-GN

74/504

74/504B

RD-GN

73/5075

2/31

11B/27

11A/1

11A/2 11A/4

11A/5

11A/3

11B/17

GY-BK

GN-VT

RD-BK

15/36

M11

2/246

F10

2/166

11C/21

11A/9

YE-RD

74/411

9/42C2:1

YE-RD

73/4028

YE-RD

RD-GY

RD-BN

YE-RD

4/31C1:4

RD-GN

6/28:2

2/193

2/88

11C/24

11C/28

VT-GN

11B/12

11A/1 11A/2 11A/3 11A/4 11A/5 11A/6

11A/7 11A/8

74/301

MANRD

AUTORD RD

73/3162

74/316

1/2

12V

73/3137

73/3136

PF1

31/131

PF1

B34W034

31/3

TP39273202 XC60 2014 © Volvo Car Corporation 2013 10

Electrical distribution 1:4 Overview, Distribution box in engine compartment exc. 4-Cyl.

15/31

73/3085

73/3068

RD-BU

5 CYL D STOSTA

74/316

4/46B:16

5CYL D.

6 CYL

RD-VT

W/O 4 CYL.

AUTO

RD-BK

GY-VT

BU-OG

GY-VT

RD RD

RD-BU

5CYL D.

BU-OG

2/32

11B/34

2/35

R12

11B/35

11B/39 11B/40 11B/41

11B/38 11B/37 11B/36

2/14

11A/44 11A/42 11A/43

11B/30

11B/31

11B/32

11B/33

2/22

R13

R10

R11

2/17

11B/29 11B/28 11B/27

11B/17 11B/16 11B/18 11B/19

1B/21

1B/20

1B/22

11B/23

11B/15

2/31

11A/1 11A/2 11A/3 11A/4 11A/5 11A/6

2/182

11B/14 11B/13 11B/11

11B/9 11B/12 11B/10

11B/8

11A/7

C3:2

GY-BK

GN-VT

RD-BK

RD-BU

RD-GN

RD-GY

RD-BN

YE-GN

RD RD RD

RD-VT

4/56C1:63

4/56C1:13

9/42

4/56C5:1

4/56C5:2

15/32 15/36

15/36

30+

TP39273202 XC60 2014 © Volvo Car Corporation 2013 11

B34W035

Electrical distribution 2:4 Overview, Distribution box in engine compartment 4-Cyl.

15/31

RD-WH

1 2

11B/30

11B/31

11B/32

11B/33

11B/34

11B/35

11B/36 11B/37 11B/38

11B/39 11B/40 11B/41

11B/42 11B/43 11B/44

2/32

R10

1 2

RD AUTO

4 CYL.D

GY-VT

VT-RD

73/3068

73/3085

YE-BU

WH-BN 4 CYL.D

RD-WH 4 CYL.D

2/22

R13

2/35

R12

2/14

R11

WH-BN

4 CYL.D

53/7011

WH-BN 4 CYL.D

TP39273202 XC60 2014 © Volvo Car Corporation 2013 12

B33W090

Electrical distribution 3:4 Overview, Distribution box in passenger compartment

15/36

15/31

15/37

30+

11A/5

11A/4

11A/3

2/88

2/193

11C/1 11C/2 11C/3 11C/4

11C/5 11C/6 11C/7 11C/8

11C/9 11C/10 11C/11

11C/12 11C/13 11C/14 11C/15

RD-GY

RD-BN

RD-GY

RD-BN

STOSTA

4 5

73/5117

11C/17 11C/18 11C/19

11C/16 11C/20

11C/21 11C/22

11C/23 11C/24 11C/25

11C/26 11C/27 11C/28

11C/29 11C/30

B31W054

TP39273202 XC60 2014 © Volvo Car Corporation 2013 13

Electrical distribution 4:4 Overview, Distribution box in cargo compartment

30+

15/31

15/37

11A/3

11A/5

RD-GN

74/504B

15/32

STOSTA

RD-GN

RD-VT

RD-GN

11D/A1 11D/A2 11D/A3 11D/A4

11D/A5 11D/A6

73/5075

RD-GN

11D/A11

11D/A12

2/16

RA2

RD-VT

2/82

RA1

B31W055

TP39273202 XC60 2014 © Volvo Car Corporation 2013 14

Fuses Distribution box in engine compartment F1 - F7

15/31 Distribution box in engine compartment

No. No. Fuse function via A

F1 11A/1 4/56 Central electronic module (CEM)

F7 Fuse in the Central electronic module (CEM) F9-F10 Fuses in the Central electronic module (CEM) F23 Fuse in the Central electronic module (CEM)

F2 11A/2 4/56 Central electronic module (CEM)

F1 Fuse in the Central electronic module (CEM) F3-F6 Fuses in the Central electronic module (CEM) F8 Fuse in the Central electronic module (CEM) F11-F12 Fuses in the Central electronic module (CEM) F13-F16 Fuses in the Central electronic module (CEM) F22 Fuse in the Central electronic module (CEM) F24 Fuses in the Central electronic module (CEM)

F3 11A/3 15/32 Distribution box cargo compartment

11D/A111D/A5 Fuses in distribution box cargo compartment 11D/A1111D/A12 Fuses in distribution box cargo compartment

F4 11A/4 2/193 Relay, comfort functions

11C/111C/15 Fuses in distribution box passenger compartment 11C/2111C/22 Fuses in distribution box passenger compartment

F5 11A/5 2/88 Relay, 15-feed

11C/2311C/25 Fuses in distribution box passenger compartment 11C/2611C/30 Fuses in distribution box passenger compartment

F7 11A/7 9/42 PTC-element - 100

continues

relay in CEM

relay in CEM relay in CEM relay in CEM relay in CEM

2/193

2/88

TP39273202 XC60 2014 © Volvo Car Corporation 2013 15

Fuses Distribution box in engine compartment F8 - F23

15/31 Distribution box in engine compartment

No. No. Fuse function via A

F8 11B/8 9/7 Heated windshield 15/46 40

F9 11B/9 6/1 Wiper motor module (WMM) - 30

F10 11B/10 4/7 Combustion preheater module (CPM)

4/106 Control module, remote parking heater start

F11 11B/11 4/31 Fan control module

6/28 Motor, passenger compartment fan

F12 11B/12 9/7 Heated windshield 15/46 40

F13 11B/13 4/16 Brake control module (BCM), pump - 40

F14 11B/14 4/16 Brake control module (BCM), valves - 20

F15 11B/15 6/104 Washer motor headlights 2/182 20

F16 11B/16 10/1 Lamp housing, front left

10/2 Lamp housing, front right

F17 11B/17 4/56 Central electronic module (CEM)

F17-F20 Fuses in the Central electronic module (CEM)

F18 11B/18 4/16 Brake control module (BCM) - 5

F19 11B/19 4/99 Electronic power steering control module

6/163 Electric power steering module (EPAS) 6/164 Electrohydraulic power steering module (EHAPS)

F20 11B/20 4/9 Supplemental restraint system module (SRS)

4/28 Transmission control module (TCM) 4/46 Engine control module (ECM)

F21 11B/21 9/58 Heated windshield washer nozzles - 10

F22 11B/22 - --

F23 11B/23 3/111 Light switch module (LSM) - 5

continues

Fuses Distribution box in engine compartment F27 - F37

15/31 Distribution box in engine compartment

No. No. Fuse function via A

F27 11B/27 2/17 Relay, horn

2/31 Relay, 15-feed 2/182 Relay, headlight washer motor

F28 11B/28 2/64 Relay auxiliary lights

10/65 Auxiliary lights, front right 10/69 Auxiliary lights, front left

F29 11B/29 16/10 Horn 1

16/11 Horn 2

F30 11B/30 2/32 Main relay, engine management system

4/46 Engine control module (ECM)

F31 11B/31 4/28 Transmission control module (TCM) - 15

F32 11B/32 6/73 Coolant pump, 4-Cyl. Diesel

8/3 Electromagnetic clutch, climate control system

F33 11B/33 2/22 Relay, climate control system - 5

F34 11B/34 6/25 Starter motor 2/35 30

F35 11B/35 4/109 Glow plug control module, 5-Cyl. Diesel - 10

4/56 Engine Control Module (ECM), 4-Cyl. 20/3-8 Spark plug with ignition coil, 6-Cyl. 20/16 Capacitor, 6-Cyl.

F36 11B/36 4/46 Engine control module (ECM), 4-Cyl. & 6-Cyl. - 10

4/46 Engine control module (ECM), 5-Cyl. Diesel - 15

F37 11B/37 7/17 Mass air flow sensor MAF, 5-Cyl. Diesel

8/98 Control valve fuel pressure, 5-Cyl. Diesel 8/111 Control valve fuel flow, 5-Cyl. Diesel

4/46 Engine control module (ECM), 6-Cyl. 7/17 Mass air flow sensor MAF, 6-Cyl. 8/6-11 Injection valves, 6-Cyl.

6/197 EGR Cooling pump, 4-Cyl. Diesel 7/17 Mass airflow sensor (MAF), 4-Cyl. 7/200 Sensor, coolant temperature, 4-Cyl. Turbo 8/166 Electric thermostat, engine cooling system, 4-Cyl. Turbo 8/197 Vacuum valve, water cooler bypass, 4-Cyl. Diesel 8/18 EVAP valve, 4-Cyl. Turbo

continues

2/64 2/64

2/17 2/17

2/32

2/22 2/22

Fuses Distribution box in engine compartment F38

15/31 Distribution box in engine compartment

No. No. Fuse function via A

F38 11B/38 8/117 Solenoid, variable valve timing, intake, 4-Cyl. Turbo

8/180 Engine oil pump solenoid, 4-Cyl. 8/159 Bypass valve, 4-Cyl. Turbo 8/118 Solenoid, variable valve timing, exhaust, 4-Cyl. Turbo 7/82 Rear oxygen sensor, 4-Cyl. 8/199 Vacuum regulator, turbo bypass control, 4-Cyl. Diesel 8/113 Bypass valve, EGR cooling, 4-Cyl. Diesel

7/35 Oil level sensor, 5-Cyl. Diesel 8/3 Electromagnetic clutch, climate control system, 6-Cyl. 3.2l & 5-Cyl.

Diesel 8/113 Bypass valve, EGR cooling, 5-Cyl. Diesel 8/164 Electric piston cooling valve, 5-Cyl. Diesel

4/46 Engine control module (ECM), 6-Cyl. 6/139 Upper actuator motor intake manifold, 6-Cyl. W/O Turbo. 6/140 Lower actuator motor intake manifold, 6-Cyl. W/O Turbo. 8/3 Electromagnetic clutch, climate control system, 6-Cyl. 8/28 Turbocharger control valve, 6-Cyl. Turbo 8/68 Relief valve, 6-Cyl. Turbo 8/117 Solenoid, variable valve timing, intake, 6-Cyl. 8/125 Solenoid cam profile front, 6-Cyl. W/O Turbo 8/126 Solenoid cam profile rear, 6-Cyl. W/O Turbo

continues

Fuses Distribution box in engine compartment F39 - F44

15/31 Distribution box in engine compartment

No. No. Fuse function via A

F39 11B/39 7/15 Front heated oxygen sensor, 4-Cyl. Turbo

7/15 Front heated oxygen sensor, 5-Cyl. Diesel

7/15 Front heated oxygen sensor, 4-Cyl. 7/15 Front heated oxygen sensor, bank 1, 6-Cyl. 7/82 Rear heated oxygen sensor, bank 1, 6-Cyl. 7/104 Rear heated oxygen sensor, bank 2 6-Cyl. W/O Turbo & 4-Cyl.

Turbo

8/18 EVAP valve, 6-Cyl.

F40 11B/40 20/3-6 Spark plug with ignition coil, 4-Cyl. Turbo - 15

6/179 Electric transmission oil pump 9/38 Heated fuel filter, 5-Cyl. Diesel

F41 11B/41 6/67 Pump, fuel leakage control, 6-Cyl.

7/200 Sensor coolant temperature, 6-Cyl. W/O Turbo

6/179 Electric transmission oil pump, Diesel 9/32 PTC resistor crankcase ventilation, 5-Cyl. Diesel

6/67 Pump, fuel leakage control, 4-Cyl. Turbo 8/3 Electromagnetic clutch, climate control system, 4-Cyl. 8/180 Engine oil pump solenoid, 4-Cyl. Diesel

F42 11A/42 4/109 Glow plug control module - 70

6/113 Coolant water pump, 4-Cyl. Turbo - 50

F43 11A/43 4/71 Control module cooling fan 4-Cyl. Turbo - 60

4/71 Cooling fan control module, 5-Cyl. Diesel & 6-Cyl. - 80

F44 11A/44 6/163 Electric power steering module (EPAS)

6/164 Electrohydraylic power steering module (EHPAS)

2/14

100

Fuses Central electronic module (CEM) F1 - F6

4/56 Central electronic module (CEM)

No. Fuse function via A

F1 6/32 Rear window wiper motor 2/16 15

F3 2/254 Relay, lumbar support front

3/26 Switch unit, power driver’s seat 3/27 Switch unit, power passenger seat 3/176 Power window switches, driver’s door 3/291 Tailgate closing switch 4/52 Power seat module (PSM) 10/25 Ceiling light cargo compartment 10/29 Glove compartment lighting 10/97 Left-hand front courtesy lighting 10/102 Right-hand front courtesy lighting 10/125 Left-hand front courtesy lighting 10/126 Right-hand front courtesy lighting 10/127 Load space illumination lamp, left 10/173 Load space illumination lamp, tailgate 10/261 Ground illumination lighting, driver’s side 10/262 Ground illumination lighting, passenger side 17/45 Alcolock outlet 26/6 Converter/control module, sill moldings, driver’s side 26/7 Converter/control module, sill moldings, passenger side 26/8 Alcolock charging cradle

F4 5/1 Driver Information module (DIM) - 5

F5 4/80 Forward Sensing Module (FSM)

7/203 Forward-aimed radar (FLR)

F6 7/149 Rain sensor module (RSM)

10/22 Ceiling light 10/114 Vanity mirror lighting, left 10/115 Vanity mirror lighting, right 10/150A Rear reading light 10/150B Rear reading light

continues

7.5

Fuses Central electronic module (CEM) F7 - F16

4/56 Central electronic module (CEM)

No. Fuse function via A

F7 3/4 Steering wheel switch left (SWSL)

3/130 Steering wheel module (SWM) 3/131 Steering wheel switch right (SWSR)

F8 6/37 Lock motor, fuel filler flap - 10

F9 4/148 Heated Steering Wheel Module (HSWM) - 15

F10 2/81A Relay, heated windshield passenger side

15/46 Relay box in engine compartment

F11 6/8 Central locking motor, tailgate - 10

F12 8/59 Head restraint solenoid left rear

8/60 Head restraint solenoid right rear 6/141 Motor folding head restraint left 6/142 Motor folding head restraint right

F13 4/83 Control module fuel pump Relay in

F14 3/112 Climate control module (CCM)

4/119 Remote Keyless Entry (RKE) 4/119.2 Remote Receiver Module (RRX) 7/122 Mass movement sensor module (MMS), front

F15 4/102 Steering column lock module (SCL) Relay in

F16 16/35 Siren control module (SCM)

17/13 Data link connector

continues

3/130

CEM

7.5

Fuses Central electronic module (CEM) F18 - F24

4/56 Central electronic module (CEM)

No. Fuse function via A

F18 4/9 Supplemental restraint system module (SRS)

7/93 Occupant weight sensor (OWS)

F19 4/80 Forward Sensing Module (FSM)

4/125 Closing velocity module (CVM) 7/203 Forward-aimed radar (FLR)

F20 3/65 Switch, heated rear seat

7/51 Accelerator pedal sensor 8/48 Auto-dimming rearview mirror 9/42 PTC-element

F21 - --

F22 3/9 Contact brake light - 5

F23 4/33 Sun roof module (SRM) - 20

F24 3/1 Ignition lock

16/65 Immobilizer antenna unit

7.5

Fuses Distribution box in passenger compartment F1 - F20

15/36 Distribution box in passenger compartment

No. No. Fuse function via A

F1 11C/1 11C/16-20 Fuses in distribution box passenger compartment

16/105 Audio module (AUD)

F7 11C/7 17/19 12 V outlet, cargo compartment - 15

F8 11C/8 3/126 Driver door module (DDM) - 20

F9 11C/9 3/127 Passenger door module (PDM) - 20

F10 11C/10 3/129 Right rear door module (RDM) - 20

F11 11C/11 3/128 Left rear door module (LDM) - 20

F12 11C/12 4/93 Keyless vehicle module (KVM) - 20

F13 11C/13 3/26 Switch unit, power driver’s seat

4/52 Power seat module (PSM) 4/131 Control module lumbar support massage, left

F14 11C/14 3/27 Switch unit, power passenger seat

4/133 Control module lumbar support massage, right

F16 11C/16 3/281 Infotainment control module (ICM)

16/202 Center console display

F17 11C/17 16/36 TV Receiver

16/105 Audio module (AUD) 16/145 Remote Digital Audio Receiver (RDAR) 16/162 Digital Audio Broadcast Module (DABM)

F18 11C/18 4/124 Accessory USB unit (AUU)

4/185 Infotainment Head Unit (IHU) 16/1 Integrated Audio Module (IAM) 16/159 Control module, cellular phone handsfree

F19 11C/19 16/60 Phone module (PHM) - 5

F20 11C/20 - --

continues

-40

2/254

Fuses Distribution box in passenger compartment F21 - F30

15/36 Distribution box in passenger compartment

No. No. Fuse function via A

F21 11C/21 4/33 Panoramic roof control module

6/48 Damper motor module (DMM), recirculation 6/95 Damper motor module (DMM), temperature, left-hand side 6/96 Damper motor module (DMM), temperature, right-hand side 6/102 Damper motor module (DMM), defroster 6/103 Damper motor module (DMM), floor/ventilation 7/159 Air quality sensor (AQS) 16/159 Control module, cellular phone handsfree

F22 11C/22 9/1 Outlet 12V front

9/25 Outlet 12V rear 16/45 Navigation system & Traffic information, portable 16/49 Traffic message channel module (TMC) 16/164 Screen, left head restraint 16/165 Screen, right head restraint 27/8 Camera, wide angle front

F23 11C/23 9/15 Control module, rear right seat heater - 15

F24 11C/24 9/14 Control module, rear left seat heater - 15

F25 11C/25 - --

F26 11C/26 9/13 Seat heating module (SHM), passenger side - 15

F27 11C/27 9/12 Seat heating module (SHM), driver’s side - 15

F28 11C/28 4/86 Parking Assistance Module (PAM)

4/110 Trailer module (TRM) 4/120 Parking Assistance Camera (PAC) 4/126 Side Obstacle Detection Control Module left (SODL) 4/127 Side Obstacle Detection Control Module right (SODR) 6/62 Left power exterior rearview mirror 27/6 Camera, parking

F29 11C/29 4/82 Differential electronic module (DEM) - 15

F30 11C/30 4/84 Suspension module (SUM) - 10

Fuses Distribution box in cold zone F1 - MF2

F10 F11 F12

2/246

MF1

MF2

I01322215/37

D1F9 R1

2/166

F2 F3 F4 F5

15/37 Distribution box in cold zone engine compartment, Start/Stop function

No. No. Fuse function via A

F1 11A/1 9/42 PTC-element - 100

F2 11A/2 4/56 Central electronic module (CEM) - 50

F3 11A/3 2/88 Relay, 15-feed rear

11C/23-11C/30 Fuses in distribution box passenger compartment

F4 11A/4 2/193 Relay, comfort functions

11C/1-11C/15 Fuses in distribution box passenger compartment 11C/21-11C/22 Fuses in distribution box passenger compartment

F5 11A/5 15/32 Distribution box in cargo compartment - 60

F6 11A/6 4/31 Fan control module

6/28 Motor, passenger compartment fan

F7 11A/7 - --

F8 11A/8 - --

F9 11A/9 6/25 Starter motor 2/35 30

F10 11A/10 Diode D1 -50

F11 M11 Secondary battery 2/246 70

F12 11B/12 4/56 Central electronic module (CEM) - 15

MF1 MF1 11A/1-11A/7 Main fuses in engine compartment fuse box (15/31)

11B/27 Fuse in engine compartment fuse box (15/31)

MF2 MF2 11A/1-11A/8 Fuses in fuse box cold zone engine compartment (15/37)

6/26 Alternator control module (ACM)

2/88

2/193

- 175

Fuses Distribution box in cargo compartment FA1 - FA11

15/32 Distribution box in cargo compartment

No. No. Fuse function via A

FA1 11D/A1 4/115 Park Brake Module (PBM) - 30

FA2 11D/A2 4/115 Park Brake Module (PBM) - 30

FA3 11D/A3 2/82 Relay, heated rear window - 30

9/2 Heated rear window 2/82

FA4 11D/A4 17/39 13-pin outlet, tow hitch cable harness - 15

FA5 11D/A5 4/116 Power Operated Tailgate Module (POT) - 20

FA11 11D/A11 4/110 Trailer module (TRM) - 40

Fuses Battery PF1 - PF2

PF1

PF2

1/1 Battery

No. Fuse function via A

PF1 11A/1-11A/7 Main fuses in distribution box engine compartment - 150

11A/42-11A/44 Main fuses in distribution box engine compartment -

11B/8-11B/14 Fuses in the engine compartment distribution box -

11B/16-11B/22 Fuses in the engine compartment distribution box 2/31

11B/23 Fuses in the engine compartment distribution box -

11B/27-11B/32 Fuses in the engine compartment distribution box -

11B/33 Fuses in the engine compartment distribution box 2/32

11B/34 Fuses in the engine compartment distribution box -

11B/35-11B/41 Fuses in the engine compartment distribution box 2/32

PF2 6/25 Starter motor - 150

6/26 Alternator control module (ACM) -

Relays Relays in the engine compartment

2/246

15/37 Distribution box in cold zone engine compartment

Pos Relay function

R1 2/166 Battery relay

R2 2/246 Secondary battery relay

2/166

I01322315/37

15/31 Distribution box in engine compartment

Pos Relay function

R7 2/31 Relay, 15-feed

R8 2/17 Relay, horn

R9 2/182 Relay, headlight washer motor

I01946615/31

Relays Relays in the engine compartment

15/31 Distribution box in engine compartment

Pos Relay function

R10 2/32 Main relay, engine management system

R11 2/14 Relay, diesel filter heater, Diesel

R12 2/35 Relay, starter motor

R13 2/22 Relay, climate control system

15/46

15/46 Relay box in engine compartment

Pos Relay function

R1 2/81A Relay, heated windshield, passenger side

R2 2/81B Relay, heated windshield, driver’s side

2/81A

2/81B

H01546A

Relays Relays in passenger and cargo compartments

15/36 Distribution box in passenger compartment

Pos Relay function

R1 2/88 Relay, 15-feed

R2 2/92 Relay, washer motor windshield

R3 2/93 Relay, washer motor rear window

R4 2/193 Relay, comfort functions

15/32 Distribution box in cargo compartment

Pos Relay function

RA1 2/82 Relay, heated rear window

RA2 2/16 Relay, rear window wiper

+ 332 hidden pages