Volvo XC60 2010 Wiring Diagram

VOLVO XC60

WIRING DIAGRAM 2010 SUPPLEMENT

TP 39162202 LATE DESIGN

Vehicles with SRS (Airbag)/SIPS bag/IC

(Inflatable Curtain)

Warning!

Extra caution must be exercised when working on vehicles equipped with SRS/SIPS bag/IC in order to avoid:

1. Personal injuries when performing repair work.

2. Damage or malfunction of the SRS/SIPS bag/IC system. Work involving the SRS/SIPS bag/IC systems or other components in the vehicle that may affect the SRS/SIPS bag/IC systems must always be performed by an authorized Volvo workshop. In case of doubt, consult the SRS and SIPS bag/IC service manual.

Is the vehicle equipped with SRS/SIPS bag/IC?

Vehicles with SRS are most easily recognized by the letters SRS in the center of the steering wheel. If the vehicle also has a passenger side airbag, the letters SRS are stamped on the dashboard above the glove compartment. SRS vehicles from 1993 and onward also have explosive seat belt tensioners. SIPS bags are only installed on SRS vehicles from 1995 and onward. SIPS bag decals are located on the windshield and seat compartment. Vehicles with IC can be recognized by the letters IC on the C/D panel (4 door) or the B panel (5 door).

General recommendations

• Be especially careful when working on or around SRS, SIPS, and IC components.

• Make sure that no wires are pinched, frayed, or pierced.

• Never install accessories by the sensors.

• Where applicable, work on the steering wheel, steering shaft, or steering gear must be done in accordance with the methods in the SRS section of VIDA.

• Certain components of the aforementioned systems must be grounded while working. Read the appropriate sections in VIDA.

• Install no accessories in the areas between the A and B-posts, the B and C-posts, and the C and D-posts.

Test terminal

Data link connector in the passenger compartment.

Changes introduced up to and including June 2009

Any changes made to the vehicles after this date are not included in the manual. If necessary refer to service bulletins.

Volvo models are sold in versions adapted for different markets. These adaptations depend on factors such as legal requirements, taxation, and market demands. This manual may therefore include illustrations and text that do not apply to the vehicles in your country.

Ordering: Electronic Wiring Diagrams (EWDs) can be ordered from the Technical Information Shop (TIS) at www.volvocarstechinfo.ford.com/vss We reserve the right to make modifications.

Table of Contents 1:3

Vehicles with SRS (Airbag)/SIPS bag/IC

(Inflatable Curtain) ......................................................... 2

Explanations .................................................................. 6

Abbreviations................................................................. 6

How to use the wiring diagrams 1:2............................... 7

Electrical distribution 1:3 ................................................9

Fuses

Distribution box in engine compartment F1-F7............. 12

Distribution box in engine compartment F8-F23........... 13

Distribution box in engine compartment F27-F36......... 14

Distribution box in engine compartment F37-F38......... 15

Distribution box in engine compartment F39-F43......... 16

Central Electronic Module (CEM) F1 - F8.....................17

Central Electronic Module (CEM) F9 - F19...................18

Central Electronic Module (CEM) F20 - F24.................19

Distribution box in passenger compartment F1 - F19... 20 Distribution box in passenger compartment F21 - F30... 21

Distribution box in cargo compartment FA1-FA11........ 22

Battery PF1-PF2........................................................... 23

Relays

Relays in the engine compartment R1-R2................... 24

Relays in the engine compartment R8......................... 25

Relays in the engine compartment R10-R13............... 26

Relays in passenger compartment R1 - R4................. 27

Cargo compartment RA1 - RA2................................... 28

Ground connections

Overview...................................................................... 29

31/2 - 31/XX10............................................................. 30

Control modules

Central Electronic Module (CEM) 1:3 .......................... 31

Data communication high speed CAN......................... 34

Data communication intermediate speed CAN, LHD... 35 Data communication intermediate speed CAN, RHD .. 36

Data communication Local CAN.................................. 37

Data communication, LIN 1:2 ...................................... 38

Data communication MOST......................................... 40

Steering Wheel Module (SWM) ................................... 41

Group 23 Fuel system

Engine management system, 4-Cyl. Turbo 1:2............ 42

Engine management system 6-Cyl. 1:2....................... 44

Engine management system 6-Cyl. B6324S2 1:2 ....... 46

Engine management system, 6-Cyl. Turbo 1:2............ 48

Engine management system, 5-Cyl. Diesel 1:3........... 50

Emission control 4-Cyl. Turbo...................................... 53

Group 26 Cooling system

Cooling fan 4-Cyl. Turbo.............................................. 54

Group 27 Engine controls

Cruise control 4-Cyl. Turbo ...........................................55

Cruise control................................................................ 56

Group 32 Alternator and voltage regulator

Power supply 4-Cyl...................................................... 57

Group 33 Starting system

Starting system 4-Cyl................................................... 58

Starting system ............................................................ 59

Group 35 Lighting

High and low beam ...................................................... 60

High and low beam (Dual Xenon) ................................ 61

Beam length adjustment, manual ................................ 62

Running/Parking light, Tail lights.................................. 63

Running/Parking light, Tail lights (Dual Xenon) ........... 64

Fog lights ..................................................................... 65

Brake lights .................................................................. 66

Reversing lights ........................................................... 67

Follow-me-home lighting LHD...................................... 68

Follow-me-home lighting RHD..................................... 69

Interior lighting, LHD 1:2 .............................................. 70

Interior lighting, RHD 1:2.............................................. 72

Active headlight ........................................................... 74

Lighting in door sill trims .............................................. 75

Auxiliary lights.............................................................. 76

TP39162202 XC60 2010 Supplement 3

Table of Contents 2:3

Group 36 Additional electrical equipment

Rain sensor.................................................................. 77

Direction indicator and hazard warning flashers

LHD ............................................................................. 78

Direction indicator and hazard warning flashers

RHD............................................................................. 79

Wiper/Washer windshield ............................................ 80

Washer headlights....................................................... 81

Wiper/Washer rear window.......................................... 82

Horn ........................................................................ 83

Keyless vehicle 1:2...................................................... 84

Anti-theft alarm ............................................................ 86

Parking assistance....................................................... 87

Collision warning with power brake booster ................ 88

Tire pressure monitoring system (TPMS) .................... 89

Alcohol lock.................................................................. 90

Group 37 Wiring and fuses

Diagnostics system...................................................... 91

Outlet 12 V................................................................... 92

Cable harness towbar/tow hitch 4-pin ......................... 93

Cable harness towbar/tow hitch 7-pin.......................... 94

Cable harness towbar/tow hitch 13-pin........................ 95

USB unit (AUU)............................................................ 96

Group 38 Instruments

Seat belt reminder ....................................................... 97

Driver information module............................................ 98

Group 39 Other

Audio Premium 1:3 ...................................................... 99

Audio 1:2 ................................................................... 102

Cellular phone 1:2...................................................... 104

DAB Radio................................................................. 106

Telephone system Bluetooth ..................................... 107

Bluetooth Handsfree.................................................. 108

Multimedia & Traffic information ................................ 109

Satellite radio............................................................. 110

Parking camera.......................................................... 111

Traffic information, China........................................... 112

Traffic information, Japan .......................................... 113

Group 55 Parking brake

Electric parking brake ................................................ 118

Group 59 Brake system

Brake control system & DSTC ................................... 119

Group 64 Steering

Speed dependent power steering .............................. 120

Group 76 Shock absorbers

Four-C ...................................................................... 121

Group 83 Doors and openings

Central locking front doors LHD................................. 122

Central locking front doors RHD ................................ 123

Central locking rear doors.......................................... 124

Central locking tailgate............................................... 125

Central locking fuel filler flap...................................... 126

Signal receiver central locking ................................... 127

Power windows front doors LHD................................ 128

Power windows front doors RHD ............................... 129

Power windows rear doors......................................... 130

Power sunroof............................................................ 131

Group 84 Exterior decorative elements, etc.

Power door mirrors LHD ............................................ 132

Power door mirrors RHD............................................ 133

Heated door mirrors LHD........................................... 134

Heated door mirrors RHD .......................................... 135

Blind spot information system LHD............................ 136

Blind spot information system RHD ........................... 137

Heated rear window................................................... 138

Group 85 Interior equipment

Power driver’s seat with memory function, LHD ........ 139

Power driver’s seat with memory function, RHD........ 140

Power passenger seat, LHD ...................................... 141

Power passenger seat, RHD ..................................... 142

Heated front seats ..................................................... 143

Heated rear seat ........................................................ 144

Group 43 Transmission

Transmission M66 ..................................................... 114

Automatic transmission TF-80SC.............................. 115

Automatic transmission MPS6................................... 116

Differential electronic module (DEM) ......................... 117

TP39162202 XC60 2010 Supplement 4

Table of Contents 3:3

Group 87 Climate control system

Climate control system PTC-elements ...................... 145

Climate control system, 4-Cyl. 1:2............................. 146

Climate control system 5-Cyl. & 6-Cyl. 1:2 ................ 148

Parking heater, auxiliary heater ................................. 150

Parking heater, remote start ...................................... 151

Group 88 Internal equipment

Rear-view mirror with automatic dimming.................. 152

Remote control opener garage door.......................... 155

Connectors .............................................. 156

Branching points .....................................181

Cable harness routing in vehicle

Harness engine 4-Cyl. Turbo......................................185

Cable harnessrouting in the car..................................186

Component illustrations ..........................187

Index 1:2....................................................238

List of components 1:7 ............................240

TP39162202 XC60 2010 Supplement 5

Explanations Abbreviations

Groups

Group 23 = Fuel system Group 26 = Cooling system Group 27 = Engine controls Group 32 = Alternator and voltage regulator Group 33 = Starting system Group 35 = Lighting Group 36 = Additional electrical equipment Group 37 = Wiring and fuses Group 38 = Instruments Group 39 = Other Group 43 = Transmission Group 55 = Parking brake Group 59 = Brake system Group 64 = Steering Group 76 = Shock absorbers Group 83 = Doors and openings Group 84 = Exterior decorative elements, etc. Group 85 = Interior equipment Group 87 = Climate control system Group 88 = Internal equipment

Ignition switch symbols

X = Accessories (audio position) S = Powered upon insertion of key 15 = Contact remains connected during

start 15l = Contact is broken while starting 30 = Constant power from the battery 50 = Start

Countries/Markets

A = Austria AUS = Australia B = Belgium CDN = Canada CH = Switzerland D = Germany DK = Denmark E= Spain EU/OS = Markets outside USA and Canada FIN = Finland GB = Great Britain ISR = Israel J = Japan KOR = Korea N= Norway NL = Netherlands S = Sweden USA = United States of America WEU = Western Europe

Other

ACC = Adaptive Cruise Control Ag = Silver plated Au = Gold plated AUTO = Automatic transmission BLIS = Blind spot information system CAN = CAN communication DPY = Display ECC = Electronic climate control system ETA = Throttle unit EXC = Exclusive GDL = Gas discharge lamp HS = High speed data bus KEYLESS = Keyless vehicle IR = Infrared sensor LIN = LIN communication LH = Left-hand side LHD = Left-hand drive MAN = Manual transmission MEMORY = Memory driver’s seat MIRCAM = Parking camera in rear-view mirror MS = Midspeed data bus MMS = Mass Movement Sensor PANROOF = Panoramic roof PETROL = Gasoline RH = Right-hand side RHD = Right-hand drive RTI = Road Traffic Information SCR = Screened SRS = Airbag T = Turbocharged engine W/O = Without 2WD = Two-wheel drive 4CYL, I4 = 4-cylinder engine 5CYL, I5 = 5-cylinder engine 6CYL, I6 = 6-cylinder engine 8CYL, V8 = 8-cylinder engine

Colors

BK, SB = Black BN = Brown BU, BL = Blue GN = Green GY, GR = Gray LGN = Light Green NL = Natural OG, OR = Orange PK, P = Pink RD, R = Red VT, VO = Violet WH, W = White YE, Y = Yellow

TP39162202 XC60 2010 Supplement 6

How to use the wiring diagrams 1:2

The descriptions below apply in general to all wiring diagram manuals, although not all sections are necessarily contained in this manual.

A. Component designation

Every component has a component designation that consists of two parts.

The first part is a type number that describes the type of component in question, for example 3/xx.

The second part of the designation is a serial number, e.g. x/2.

Together, this constitutes a component designation, e.g. 3/2.

At the end of the manual is a list of components, where, with the help of the component designation, you can read off the name of the component, for example, 3/2 = light switch.

List of type numbers

The list shows which type of component that respective type numbers refer to, for example, 3/x = switch, 6/x = electric motor, etc.

1 Battery 2Relay 3 Switch 4 Control module 5 Driver information module 6 Electric motor 7Sensor 8 Actuator 9 Heating element 10 Light 11 Fuse 15 Electrical distribution rail/box 16 Audio 17 Service/diagnostics 18 Contact reel 19 Meter 20 Ignition component/shunt 27 Optics 31 Ground connection 73 Branching point 74 Connector

The systems are shown in non-active status. i.e. with "key removed" and when the doors, hatches and hood are closed.

B. Branching points

The wiring diagrams contain numbered branching points, for example 73/5035.

This manual contains a section with a list of branching points. This list shows all the components that are connected to each branching point.

The location of the branching points is shown in the "Cable harness routing in vehicle" section.

C. Connectors

Connectors provide a bridge between two cable harnesses and are described in the "Connectors" section.

D. Electrical distribution

Operation of the fuses and relays is shown in the "Electrical distribution" section.

E. Data communication

Today’s cars contain CAN, LIN and MOST networks that transfer information. Connections to these networks are not shown in their entirety in the respective wiring diagram. Complete information on CAN, LIN and MOST communication is found in the section "Control modules".

F. Abbreviations

A number of different abbreviations are used in the manual. These are explained in the section "Abbreviations".

G. Component location

The end of the manual contains a section that describes component appearance and location in numerical order.

TP39162202 XC60 2010 Supplement 7

How to use the wiring diagrams 2:2

List of symbols

= System voltage

= Ground connection via wiring

= Ground connection in component/chassis = Screened wire

= Junction point

= Twisted cable

= Electrical connection

= Variant

= CAN communication

= CAN high data signal (CAN H)

= CAN low data signal (CAN L)

= LIN communication

= DIN cable, coaxial cable, etc.

= Data communication

= CAN communication

= MOST communication

= Connection with distribution box

= Further connection to...

= Connector between cable harnesses = Connector connected in component

TP39162202 XC60 2010 Supplement 8

Electrical distribution 1:3 Overview, Electrical center and Cold zone in engine compartment

73/3085

73/3068

4/46B:16

6 CYL

RD-VT

4 Cyl. T &

5 Cyl. D

GN-OG

RD-BK

GY-VT

BU-OG

GY-VT

5 Cyl. D

BU-OG

15/31

2/32

11B/34

2/35

R12

R10

11B/35

11B/39 11B/40 11B/41

11B/38 11B/37 11B/36

R11

2/142

5 Cyl. Diesel

R11

2/133

4 Cyl. T

11A/44 11A/42 11A/43

11B/30

11B/31

11B/32

11B/33

2/22

R13

11B/29 11B/28 11B/27

11B/17 11B/16 11B/18 11B/19

1B/21

1B/20

1B/22

11B/23

2/31

11A/1 11A/2 11A/3 11A/4 11A/5 11A/6

11A/7

RD-VT

73/3041

RD-VT

73/3138

GY-BK

GN-VT

YE-GN

RD-BK

RD_BU

RD-GN

RD-GY

RD-BN

GN-OG

4 Cyl. T

YE-GN

4/56C1:65

74/301

4/56C1:45

9/42

4/56C5:1

4/56C5:2

15/32 15/36

15/36

2/17

2/182

15/33

4 Cyl. T

PF1

1/1

PF2

12V

11B/14 11B/13 11B/11

11B/9 11B/12 11B/10

11B/8

31/3

RDRD

73/3076

C1:1

RD RD RD

6/26

B+

ACM

6/25

LIN

C1:1

G042211

TP39162202 XC60 2010 Supplement 9

Electrical distribution 2:3 Overview, Distribution box in cargo compartment

30+

15/31

11A/3

RD-GN

73/5075

74/504B

RD-GN

RD-VT

RD-GN

15/32

2/16

11D/A1 11D/A2 11D/A3 11D/A4

11D/A5 11D/A6 11D/A7 11D/A8

11D/A9 11D/A10

11D/A11

11D/A12

RA2

2/82

RA1

RD-VT

TP39162202 XC60 2010 Supplement 10

G042220

Electrical distribution 3:3 Overview, Distribution box in passenger compartment

15/36

30+

15/31

11A/4

11A/5

RD-BN

RD-GY

2/88

2/193

11C/1 11C/2 11C/3 11C/4

11C/5 11C/6 11C/7 11C/8

11C/9 11C/10 11C/11

11C/12 11C/13 11C/14 11C/15

4 5

73/5117

11C/17 11C/18 11C/19

11C/16 11C/20

11C/21 11C/22

11C/23 11C/24 11C/25

11C/26 11C/27 11C/28

11C/29 11C/30

G042227

TP39162202 XC60 2010 Supplement 11

Fuses Distribution box in engine compartment F1-F7

15/31 Distribution box in engine compartment

No. No. Fuse function via A

F1 11A/1 4/56 Central electronic module (CEM)

F7 Fuse in the Central Electronic Module (CEM) F9-F11 Fuses in the Central Electronic Module (CEM) F21 Fuse in the Central Electronic Module (CEM) F23 Fuse in the Central Electronic Module (CEM)

F2 11A/2 4/56 Central electronic module (CEM)

F3-F6 Fuses in the Central Electronic Module (CEM) F8 Fuse in the Central Electronic Module (CEM) F13-F16 Fuses in the Central Electronic Module (CEM) F22 Fuse in the Central Electronic Module (CEM) F24 Fuses in the Central Electronic Module (CEM)

F3 11A/3 11D/A1-11D/A11 Fuses in distribution box cargo compartment - 60

F4 11A/4 2/193 Relay, comfort functions

11C/1 Fuse in distribution box passenger compartment 11C/7-11C/14 Fuses in distribution box passenger compartment 11C/21-11C/22 Fuses in distribution box passenger compartment 11D/A5 Fuses in distribution box cargo compartment

F5 11A/5 2/88 Relay, 15-feed

11C/23-11C/24 Fuses in distribution box passenger compartment 11C/26-11C/30 Fuses in distribution box passenger compartment

F7 11A/7 9/42 PTC-element - 100

continues

relay in CEM relay in CEM relay in CEM relay in CEM

relay in CEM relay in CEM

2/193

2/88 2/88

TP39162202 XC60 2010 Supplement 12

Fuses Distribution box in engine compartment F8-F23

15/31 Distribution box in engine compartment

No. No. Fuse function via A

F8 11B/8 2/182 Relay, headlight washer motor

6/104 Washer motor headlights

F9 11B/9 6/1 Wiper motor module (WMM) - 30

F10 11B/10 4/7 Combustion preheater module (CPM)

4/106 Control module, remote parking heater start

F11 11B/11 4/31 Fan control module

6/28 Motor, passenger compartment fan

F13 11B/13 4/16 Brake control module (BCM), pump - 40

F14 11B/14 4/16 Brake control module (BCM), valves - 20

F16 11B/16 4/118 Headlamp Control Module (HCM)

10/1 Lamp housing, front left 10/2 Lamp housing, front right

F17 11B/17 4/56 Central electronic module (CEM)

F18-F20 Fuses in the Central Electronic Module (CEM)

F18 11B/18 4/16 Brake control module (BCM) - 5

F19 11B/19 4/99 Electronic power steering control module - 5

F20 11B/20 4/9 Supplemental restraint system module (SRS)

4/28 Transmission control module (TCM) 4/46 Engine control module (ECM)

F21 11B/21 9/43 Heated windshield washer nozzle, left

9/44 Heated windshield washer nozzle, right

F22 11B/22 2/133 Relay vacuum pump - 5

F23 11B/23 3/111 Light switch module (LSM) - 5

continues

2/182

-20

TP39162202 XC60 2010 Supplement 13

Fuses Distribution box in engine compartment F27-F36

15/31 Distribution box in engine compartment

No. No. Fuse function via A

F27 11B/27 2/31 Relay, 15-feed - 5

F28 11B/28 2/64 Relay auxiliary lights

10/65 Auxiliary lights, front right 10/69 Auxiliary lights, front left

F29 11B/29 2/17 Relay, horn

16/10 Horn 1

F30 11B/30 2/32 Main relay, engine management system

4/46 Engine control module (ECM), 6-Cyl.

F31 11B/31 4/28 Transmission control module (TCM) - 15

F32 11B/32 8/3 Electromagnetic clutch, climate control system 2/22 15

F33 11B/33 2/22 Relay, climate control system - 5

F34 11B/34 6/25 Starter motor 2/35 30

F35 11B/35 4/109 Glow plug control module, 5-Cyl. Diesel

20/3-6 Spark plug with ignition coil, 4-Cyl. Turbo

20/3-8 Spark plug with ignition coil, 6-Cyl. 20/16 Capacitor, 6-Cyl.

F36 11B/36 4/46 Engine control module (ECM), 5-Cyl. Diesel - 15

4/46 Engine control module (ECM), 4-Cyl. Turbo & 6-Cyl. - 10

continues

2/64 2/64

2/17

-10

TP39162202 XC60 2010 Supplement 14

Fuses Distribution box in engine compartment F37-F38

15/31 Distribution box in engine compartment

No. No. Fuse function via A

F37 11B/37 7/17 Mass air flow sensor MAF, 5-Cyl. Diesel

8/98 Control valve fuel pressure, 5-Cyl. Diesel 8/111 Control valve fuel flow, 5-Cyl. Diesel

4/46 Engine control module (ECM), 6-Cyl. 7/17 Mass air flow sensor MAF, 6-Cyl. 8/6-11 Injection valves, 6-Cyl.

F38 11B/38 7/17 Mass air flow sensor MAF, 4-Cyl. Turbo

8/18 EVAP valve, 4-Cyl. Turbo 8/19 Solenoid, variable valve timing, intake, 4-Cyl. Turbo 8/81 Solenoid, variable valve timing, exhaust, 4-Cyl. Turbo

6/143 Control motor, turbo, 5-Cyl. Diesel 7/35 Oil level sensor, 5-Cyl. Diesel 8/3 Electromagnetic clutch, climate control system, 5-Cyl. Diesel 8/113 Bypass valve, EGR cooling, 5-Cyl. Diesel

4/46 Engine control module (ECM), 6-Cyl. 6/139 Upper actuator motor intake manifold, 6-Cyl. W/O Turbo. 6/140 Lower actuator motor intake manifold, 6-Cyl. W/O Turbo. 8/3 Electromagnetic clutch, climate control system, 6-Cyl. 8/28 Turbocharger control valve, 6-Cyl. Turbo 8/68 Relief valve, 6-Cyl. Turbo 8/117 Solenoid, variable valve timing, intake, 6-Cyl. 8/125 Solenoid cam profile front, 6-Cyl. W/O Turbo 8/126 Solenoid cam profile rear, 6-Cyl. W/O Turbo

continues

TP39162202 XC60 2010 Supplement 15

Fuses Distribution box in engine compartment F39-F43

15/31 Distribution box in engine compartment

No. No. Fuse function via A

F39 11B/39 7/15 Front heated oxygen sensor, 4-Cyl. Turbo

7/82 Rear heated oxygen sensor bank 1, 4-Cyl. Turbo

7/15 Front heated oxygen sensor, 5-Cyl. Diesel -

7/15 Front heated oxygen sensor, bank 1, 6-Cyl. 7/82 Rear heated oxygen sensor, bank 1, 6-Cyl. 7/103 Front heated oxygen sensor, bank 2, 6-Cyl. 7/104 Rear heated oxygen sensor, bank 2 6-Cyl. W/O Turbo 8/18 EVAP valve, 6-Cyl.

F40 11B/40 2/142 Relay pre-heater fuel filter, 5-Cyl. Diesel

6/114 Vacuum pump, 4-Cyl. Turbo 9/38 Heated fuel filter, 5-Cyl. Diesel

F41 11B/41 6/67 Pump, fuel leakage control 6-Cyl.

7/200 Sensor coolant temperature 9/32 PTC resistor crankcase ventilation, 5-Cyl. Diesel

F42 11A/42 20/22-26 Glow plug, 5-Cyl. Diesel 4/109 70

F43 11A/43 4/71 Control module cooling fan 4-Cyl. Turbo - 60

4/71 Cooling fan control module, 5-Cyl. Diesel & 6-Cyl. - 80

2/142 2/142

TP39162202 XC60 2010 Supplement 16

Fuses Central Electronic Module (CEM) F1 - F8

4/56 Central Electronic Module (CEM)

No. Fuse function via A

F1 2/16 Relay, rear window wiper

6/32 Rear window wiper motor

F3 3/27 Switch unit, power passenger seat

3/176 Power window switches, driver’s door 3/291 Tailgate closing switch 4/52 Power seat module (PSM) 4/76 Remote control opener garage door 10/25 Ceiling light cargo compartment 10/29 Glove compartment lighting 10/114 Vanity mirror lighting, left 10/115 Vanity mirror lighting, right 10/125 Left-hand front courtesy lighting 10/126 Right-hand front courtesy lighting 10/150A Rear reading light 10/150B Rear reading light 17/45 Alcolock outlet 26/6 Converter/control module, sill moldings, driver’s side 26/7 Converter/control module, sill moldings, passenger side 26/8 Alcolock charging cradle

F4 5/1 Driver Information module (DIM) - 5

F5 4/80 Forward Sensing Module (FSM)

7/203 Forward-aimed radar (FLR)

F6 7/149 Rain sensor module (RSM) - 7.5

F7 3/4 Steering wheel switch left (SWSL)

3/131 Steering wheel switch right (SWSR)

F8 6/37 Lock motor, fuel filler flap - 10

continues

2/16

3/130 3/130

7.5

TP39162202 XC60 2010 Supplement 17

Fuses Central Electronic Module (CEM) F9 - F19

4/56 Central Electronic Module (CEM)

No. Fuse function via A

F9 6/127 Washer motor - 15

F10 6/127 Washer motor - 15

F13 4/83 Control module fuel pump

6/33 Fuel pump

F14 4/6 Climate control module (CCM)

7/122 Mass movement sensor module (MMS), front 7/214 Heart beat sensor (HBS)

F15 4/102 Steering column lock module (SCL) - 15

F16 16/35 Siren control module (SCM)

17/13 Data link connector

F18 4/9 Supplemental restraint system module (SRS)

4/125 Closing velocity module (CVM) 7/93 Occupant weight sensor (OWS)

F19 4/80 Forward Sensing Module (FSM)

7/203 Forward-aimed radar (FLR)

continues

4/83

TP39162202 XC60 2010 Supplement 18

Fuses Central Electronic Module (CEM) F20 - F24

4/56 Central Electronic Module (CEM)

No. Fuse function via A

F20 3/65 Switch, heated rear seat

7/51 Accelerator pedal sensor 8/48 Auto-dimming rearview mirror 9/42 PTC-element

F21 3/281 Infotainment control module (ICM)

4/124 Accessory USB unit (AUU) 16/1 Integrated Audio Module (IAM) 16/159 Control module, cellular phone handsfree

F22 3/9 Contact brake light - 5

F23 4/33 Sun roof module (SRM) - 20

F24 3/132 Start control module (SCU) - 5

7.5

TP39162202 XC60 2010 Supplement 19

Fuses Distribution box in passenger compartment F1 - F19

15/36 Distribution box in passenger compartment

No. No. Fuse function via A

F1 11C/1 11C/17-19 Fuses in distribution box passenger compartment

16/79 Subwoofer module (SUB) 16/105 Audio module (AUD)

F7 11C/7 17/19 12 V outlet, cargo compartment - 15

F8 11C/8 3/126 Driver door module (DDM) - 25

F9 11C/9 3/127 Passenger door module (PDM) - 25

F10 11C/10 3/129 Right rear door module (RDM) - 25

F11 11C/11 3/128 Left rear door module (LDM) - 25

F12 11C/12 4/93 Keyless vehicle module (KVM) - 20

F13 11C/13 3/26 Switch unit, power driver’s seat

4/52 Power seat module (PSM)

F14 11C/14 3/27 Switch unit, power passenger seat - 20

F17 11C/17 16/45 Road traffic information module (RTI)

16/46 RTI Display 16/108 Multimedia module (MMM) 16/145 Remote Digital Audio Receiver (RDAR) 16/162 Digital Audio Broadcast Module (DABM)

F18 11C/18 3/281 Infotainment control module (ICM)

4/124 Accessory USB unit (AUU) 16/1 Integrated Audio Module (IAM) 16/159 Control module, cellular phone handsfree

F19 11C/19 16/60 Phone module (PHM)

16/147 Bluetooth phone module (BPM)

continues

-5

TP39162202 XC60 2010 Supplement 20

Fuses Distribution box in passenger compartment F21 - F30

15/36 Distribution box in passenger compartment

No. No. Fuse function via A

F21 11C/21 4/33 Panoramic roof control module

6/48 Damper motor module (DMM), recirculation 6/95 Damper motor module (DMM), temperature, left-hand side 6/96 Damper motor module (DMM), temperature, right-hand side 6/102 Damper motor module (DMM), defroster 6/103 Damper motor module (DMM), floor/ventilation 7/159 Air quality sensor (AQS) 10/22 Ceiling light 16/159 Control module, cellular phone handsfree

F22 11C/22 9/1 Outlet 12V front

9/25 Outlet 12V rear

F23 11C/23 9/13 Seat heating module (SHM), passenger side - 15

F24 11C/24 9/12 Seat heating module (SHM), driver’s side - 15

F26 11C/26 9/15 Control module, rear right seat heater - 15

F27 11C/27 9/14 Control module, rear left seat heater - 15

F28 11C/28 4/86 Parking Assistance Module (PAM)

4/110 Trailer module (TRM) 4/120 Parking Assistance Camera (PAC)

F29 11C/29 4/82 Differential electronic module (DEM) - 10

F30 11C/30 4/84 Suspension module (SUM) - 10

4/56

-15

-5

TP39162202 XC60 2010 Supplement 21

Fuses Distribution box in cargo compartment FA1-FA11

15/32 Distribution box in cargo compartment

No. No. Fuse function via A

FA1 11D/A1 4/115 Park Brake Module (PBM) - 30

FA2 11D/A2 4/115 Park Brake Module (PBM) - 30

FA3 11D/A3 2/82 Relay, heated rear window

9/2 Heated rear window

FA5 11D/A5 4/116 Power Operated Tailgate Module (POT) - 30

FA9 11D/A9 17/39 13-pin outlet, tow hitch cable harness - 15

FA11 11D/A11 4/110 Trailer module (TRM) - 40

2/82

TP39162202 XC60 2010 Supplement 22

Fuses Battery PF1-PF2

1/1 Battery

No. Fuse function via A

PF1 11A/1-11A/7 Main fuses in distribution box engine compartment

11A/42-11A/44 Main fuses in distribution box engine compartment 11B/8-11B/14 Fuses in the engine compartment distribution box 11B/16-11B/22 Fuses in the engine compartment distribution box 11B/23 a Fuses in the engine compartment distribution box 11B/27-11B/32 Fuses in the engine compartment distribution box 11B/33 Fuses in the engine compartment distribution box 11B/34 Fuses in the engine compartment distribution box 11B/35-11B/41 Fuses in the engine compartment distribution box

PF2 6/25 Starter motor

6/26 Alternator control module (ACM)

2/31

2/32

150

TP39162202 XC60 2010 Supplement 23

Relays Relays in the engine compartment R1-R2

15/33 Engine compartment cold zone

Pos Relay function

R1 2/182 Relay, headlight washer motor

R2 2/17 Relay, horn

TP39162202 XC60 2010 Supplement 24

Relays Relays in the engine compartment R8

15/31 Distribution box engine compartment

Pos Relay function

R8 2/31 Relay, 15-feed

TP39162202 XC60 2010 Supplement 25

Relays Relays in the engine compartment R10-R13

15/31 Distribution box engine compartment

Pos Relay function

R10 2/32 Main relay, engine management system

R11 2/133 Relay vacuum pump, 4-Cyl. Turbo

2/142 Relay pre-heater fuel filter

R12 2/35 Relay, starter motor

R13 2/22 Relay, climate control system

TP39162202 XC60 2010 Supplement 26

Relays Relays in passenger compartment R1 - R4

15/36 Distribution box in passenger compartment

Pos Relay function

R1 2/88 Relay, 15-feed

R4 2/193 Relay, comfort functions

TP39162202 XC60 2010 Supplement 27

Relays Cargo compartment RA1 - RA2

15/32 Distribution box in cargo compartment

Pos Relay function

RA1 2/82 Relay, heated rear window

RA2 2/16 Relay, rear window wiper

TP39162202 XC60 2010 Supplement 28

Ground connections Overview

31/95

31/93

31/3

31/2

31/4

31/ XX14

31/ XX10

31/XX4

31/88

31/89

31/90

31/AL

31/ XX15

31/96

31/94

31/1

31/83

31/10

31/6

31/65

31/66

31/7

31/84

31/15

31/67

31/68

31/47

31/TRM

TP39162202 XC60 2010 Supplement 29

31/5

31/

INFOT

31/48

Ground connections 31/2 - 31/XX10

31/2 LH wheel housing

4/71 Cooling fan control module

6/114 Vacuum pump, 4-Cyl. Turbo

8/84 Switch vacuum pump 4Cyl. Turbo

31/93 LH wheel housing 2

4/99 Electronic power steering control module

6/104 Washer motor headlights

7/5 Washer fluid level sensor

9/43 Heated windshield washer nozzle, left

9/44 Heated windshield washer nozzle, right

10/1 Lamp housing, front left

10/5 Fog lights, front left

31/94 RH wheel housing 2

10/2 Lamp housing, front right

10/6 Fog lights, front right

16/10 Horn

31/XX10 LH wheel housing 1

3/10 Reversing light contact

3/282 Switch indicator 1st gear, I5D

4/28 Transmission control module (TCM)

4/46 Engine control module (ECM)

6/139 Upper actuating motor, intake manifold

6/140 Lower actuating motor, intake manifold

7/200 Sensor coolant temperature

8/3 Electromagnetic clutch, climate control system, 4-Cyl.

8/78 Pressure monitor power steering, 4-Cyl. Turbo

9/32 PTC resistor, crankcase ventilation

20/3-6 Spark plug with ignition coil, 4-Cyl. Turbo

TP39162202 XC60 2010 Supplement 30

+ 216 hidden pages