Pioneer SC-65, SC-1527-K, SC-1522-K Service manual

ORDER NO.

PIONEER CORPORATION 1-1, Shin-ogura, Saiwai-ku, Kawasaki-shi, Kanagawa 212-0031, Japan

PIONEER ELECTRONICS (USA) INC. P.O. Box 1760, Long Beach, CA 90801-1760, U.S.A.

PIONEER EUROPE NV Haven 1087, Keetberglaan 1, 9120 Melsele, Belgium

PIONEER ELECTRONICS ASIACENTRE PTE. LTD. 253 Alexandra Road, #04-01, Singapore 159936

PIONEER CORPORATION

2012

2012 Printed in Japan

MASTER

VOLUME

STANDBY/ON

INPUT

SELECTOR

iPod iPhone iPadHDMI

ADVANCED

MCACC

FL OFF

SC-65

RRV4311

AV RECEIVER

SC-65

SC-1527-K

SC-1522-K

THIS MANUAL IS APPLICABLE TO THE FOLLOWING MODEL(S) AND TYPE(S).

Model Type Power Requirement Remarks

SC-65 UXJCB AC 120V

SC-1527-K CUXJ AC 120V

SC-1522-K UXJCB AC 120V

K-FZV JUNE

2

SC-65

1

2 3 4

A

B

C

D

E

F

1

2 3 4

SAFETY INFORMATION

1. SAFETY PRECAUTIONS

The following check should be performed for the

continued protection of the customer and service

technician.

LEAKAGE CURRENT CHECK

Measure leakage current to a known earth ground

(water pipe, conduit, etc.) by connecting a leakage

current tester such as Simpson Model 229-2 or

equivalent between the earth ground and all exposed

metal parts of the appliance (input/output terminals,

screwheads, metal overlays, control shaft, etc.). Plug

the AC line cord of the appliance directly into a 120V

AC 60 Hz outlet and turn the AC power switch on. Any

current measured must not exceed 0.5 mA.

ANY MEASUREMENTS NOT WITHIN THE LIMITS

OUTLINED ABOVE ARE INDICATIVE OF A POTENTIAL

SHOCK HAZARD AND MUST BE CORRECTED BEFORE

RETURNING THE APPLIANCE TO THE CUSTOMER.

2. PRODUCT SAFETY NOTICE

Many electrical and mechanical par ts in the appliance

have special safety related characteristics. These are

often not evident from visual inspection nor the protection

afforded by them necessarily can be obtained by using

replacement components rated for voltage, wattage, etc.

Replacement parts which have these special safety

characteristics are identified in this Service Manual.

Electrical components having such features are

identified by marking with a > on the schematics and on

the parts list in this Ser

vice Manual.

The use of

a substitute replacement component which

does not have the same safety characteristics as the

PIONEER recommended replacement one, shown in the

parts list in this Service Manual, may create shock, fire,

or other hazards.

Product Safety is continuously under review and new

instructions are issued from time to time. For the latest

information, always consult the current PIONEER Service

Manual. A subscription to, or additional copies of,

PIONEER Service Manual may be obtained at a nominal

charge from PIONEER.

Leakage

current

tester

Reading should

not be above

0.5 mA

Device

under

test

Test all

exposed metal

surfaces

Also test with

plug reversed

(Using AC adapter

plug as required)

Earth

ground

AC Leakage T est

(FOR USA MODEL ONLY)

WARNING

This product contains lead in solder and certain electrical parts contain chemicals which are known to the state of California to

cause cancer, birth defects or other reproductive harm.

56 noitisoporP - 6.94252 noitceS edoC ytefaS & htlaeH

NOTICE

(FOR CANADIAN MODEL ONLY)

Fuse symbols (fast operating fuse) and/or (slow operating fuse) on PCB indicate that replacement parts must

be of identical designation.

REMARQUE

(POUR MODÈLE CANADIEN SEULEMENT)

Les symboles de fusible (fusible de type rapide) et/ou (fusible de type lent) sur CCI indiquent que les pièces

de remplacement doivent avoir la même désignation.

This service manual is intended for qualified service technicians ; it is not meant for the casual do-it-

yourselfer. Qualified technicians have the necessary test equipment and tools, and have been trained

to properly and safely repair complex products such as those covered by this manual.

Improperly performed repairs can adversely affect the safety and reliability of the product and may

void the warranty. If you are not qualified to perform the repair of this product properly and safely, you

should not risk trying to do so and refer the repair to a qualified service technician.

3

SC-65

5

6 7 8

5

6 7 8

A

B

C

D

E

F

CONTENTS

SAFETY INFORMATION..........................................................................................................................................................2

1. SERVICE PRECAUTIONS........................................... ...... ...... ..... ...... ..... ...... .......................................................................5

1.1 NOTES ON SOLDERING...............................................................................................................................................5

1.2 NOTES ON REPLACING ...............................................................................................................................................5

1.3 CAUTION........................................................................................................................................................................5

1.4 NOTES ON ASSEMBLING.............................................................................................................................................6

2. SPECIFICATIONS........................................................ ...... ...... ..... ...... ..................................................................................7

2.1 SC-65 SPECIFICATIONS...............................................................................................................................................7

2.2 SC-1527-K/SC-1522-K SPECIFICATIONS.....................................................................................................................9

3. BASIC ITEMS FOR SERVICE ............................................................................................................................................11

3.1 CHECK POINTS AFTER SERVICING .........................................................................................................................11

3.2 PCB LOCATIONS.........................................................................................................................................................12

3.3 JIGS LIST.....................................................................................................................................................................14

4. BLOCK DIAGRAM ...................................... ...... ...... ..... ...... ............................................. ..... ...............................................16

4.1 OVERALL WIRING DIAGRAM.....................................................................................................................................16

4.2 BLOCK DIAGRAM FOR AUDIO BLOCK......................................................................................................................18

4.3 BLOCK DIAGRAM FOR DIGITAL MAIN VIDEO BLOCK .............................................................................................20

4.4 BLOCK DIAGRAM FOR DIGITAL MAIN AUDIO BLOCK.............................................................................................22

4.5 BLOCK DIAGRAM FOR COMPOSITE VIDEO BLOCK...............................................................................................24

4.6 BLOCK DIAGRAM FOR COMPONENT VIDEO BLOCK..............................................................................................25

4.7 BLOCK DIAGRAM FOR POWER BLOCK (1)..............................................................................................................26

4.8 BLOCK DIAGRAM FOR POWER BLOCK (2)..............................................................................................................28

5. DIAGNOSIS ..................................... ...... ..... ...... ............................................. ...... ..... ..........................................................30

5.1 DIAGNOSIS FLOWCHART..........................................................................................................................................30

5.2 CIRCUIT DESCRIPTION..............................................................................................................................................39

6. SERVICE MODE.......................................................... ...... ...... ..... ...... ..... ...........................................................................48

6.1 TEST MODE.................................................................................................................................................................48

7. DISASSEMBLY ................................ ...... ..... ............................................. ...... ...... ..... ...... ....................................................50

8. EACH SETTING AND ADJUSTMENT........................................................... ...... ..... ...... ....................................................68

8.1 ADJUSTMENT REQUIRED WHEN THE UNIT IS REPAIRED OR REPLACED..........................................................68

8.2 HOW TO SAVE AND LOAD THE SETTING USING BACKUP FUNCTION WITH USB MEMORY..............................69

8.3 REGION WRITING.......................................................................................................................................................70

8.4 HOW TO UPDATE FIRMWARE....................................................................................................................................71

9. EXPLODED VIEWS AND PARTS LIST...............................................................................................................................74

9.1 PACKING SECTION.....................................................................................................................................................74

9.2 EXTERIOR SECTION..................................................................................................................................................76

9.3 REAR SECTION...........................................................................................................................................................78

9.4 CHASSIS SECTION.....................................................................................................................................................80

9.5 FRONT SECTION........................................................................................................................................................82

10. SCHEMATIC DIAGRAM....................................................................................................................................................84

10.1 AUDIO ASSY (1/3) (GUIDE PAGE) ............................................................................................................................84

10.2 AUDIO ASSY (2/3)......................................................................................................................................................90

10.3 AUDIO ASSY (3/3)......................................................................................................................................................92

10.4 DAC HIGH ASSY (1/2) ...............................................................................................................................................94

10.5 DAC HIGH ASSY (2/2) ...............................................................................................................................................96

10.6 FRONT HDMI USB ASSY..........................................................................................................................................98

10.7 USB RECT ASSY.....................................................................................................................................................100

10.8 DIGITAL MAIN ASSY (1/11).....................................................................................................................................102

10.9 DIGITAL MAIN ASSY (2/11).....................................................................................................................................104

10.10 DIGITAL MAIN ASSY (3/11)...................................................................................................................................106

10.11 DIGITAL MAIN ASSY (4/11)...................................................................................................................................108

10.12 DIGITAL MAIN ASSY (5/11)..................................................................................................

...........

......................110

10.13 DIGITAL MAIN ASSY (6/11)...................................................................................................................................112

10.14 DIGITAL MAIN ASSY (7/11)...................................................................................................................................114

10.15 DIGITAL MAIN ASSY (8/11)...................................................................................................................................116

10.16 DIGITAL MAIN ASSY (9/11)...................................................................................................................................118

10.17 DIGITAL MAIN ASSY (10/11).................................................................................................................................120

10.18 DIGITAL MAIN ASSY (11/11).................................................................................................................................122

10.19 INTERFACE ASSY.................................................................................................................................................124

10.20 COMPONENT ASSY (1/2).....................................................................................................................................126

10.21 COMPONENT ASSY (2/2).....................................................................................................................................128

10.22 COMPOSITE ASSY................................................................................................................................................130

10.23 MIC HP ASSY.........................................................................................................................................................132

10.24 DISPLAY ASSY (1/2)..............................................................................................................................................134

10.25 DISPLAY ASSY (2/2)..............................................................................................................................................136

4

SC-65

1

2 3 4

A

B

C

D

E

F

1

2 3 4

10.26 VOL ASSY and POWER SW ASSY........................................................................................................................138

10.27 ENCODER ASSY....................................................................................................................................................139

10.28 IR BUFFER ASSY (1/2)..........................................................................................................................................140

10.29 IR BUFFER ASSY (2/2)..........................................................................................................................................142

10.30 BUFFER GND ASSY and IR INTERFACE ASSY...................................................................................................144

10.31 D-AMP_S ASSY (1/10)...........................................................................................................................................146

10.32 D-AMP_S ASSY (2/10)...........................................................................................................................................148

10.33 D-AMP_S ASSY (3/10)...........................................................................................................................................150

10.34 D-AMP_S ASSY (4/10)...........................................................................................................................................152

10.35 D-AMP_S ASSY (5/10)...........................................................................................................................................154

10.36 D-AMP_S ASSY (6/10)...........................................................................................................................................156

10.37 D-AMP_S ASSY (7/10)...........................................................................................................................................158

10.38 D-AMP_S ASSY (8/10)...........................................................................................................................................160

10.39 D-AMP_S ASSY (9/10)...........................................................................................................................................162

10.40 D-AMP_S ASSY (10/10).........................................................................................................................................164

10.41 PRIMARY ASSY .....................................................................................................................................................166

10.42 A-REG ASSY..........................................................................................................................................................168

10.43 IR REG ASSY (1/2).................................................................................................................................................170

10.44 IR REG ASSY (2/2).................................................................................................................................................172

10.45 V-REG ASSY (1/3)..................................................................................................................................................173

10.46 V-REG ASSY (2/3)..................................................................................................................................................174

10.47 V-REG ASSY (3/3)..................................................................................................................................................176

10.48 V-REG CHILD ASSY...............................................................................................................................................177

10.49 CONNECT ASSY....................................................................................................................................................178

10.50 A-DA C BRIDGE ASSY............................................... ...... ..... ...... ...... ..... .................................................................179

10.51 D-AUDIO BRIDGE ASSY........................................................................................................................................180

10.52 D-DAC BRIDGE ASSY............................................................................................................................................181

10.53 PRE BRIDGE ASSY...............................................................................................................................................182

10.54 FAN CONNECT_S, MIC HP GUARD, BIND DM CABLE, P WIRE GUARD and FFC GUARD ASSYS..................183

10.55 BIND FAN CABLE, VREG GUARD, TRANS VREG STYL, IR EDGE GUARD and PANEL GUARD ASSYS.........184

11. PCB CONNECTION DIAGRAM ......................................................................................................................................186

11.1 AUDIO ASSY ............................................................................................................................................................186

11.2 DAC HIGH ASSY......................................................................................................................................................190

11.3 FRONT HDMI USB ASSY .........................................................................................................................................194

11.4 USB RECT ASSY .....................................................................................................................................................195

11.5 DIGITAL MAIN ASSY............................. ............................................. ..... ...... ..... ...... ...... ... .......................................196

11.6 INTERFACE ASSY....................................................................................................................................................200

11.7 COMPONENT ASSY................................................................................................................................................204

11.8 COMPOSITE ASSY..................................................................................................................................................208

11.9 MIC HP ASSY...........................................................................................................................................................210

11.10 DISPLAY ASSY.......................................................................................................................................................212

11.11 VOL, POWER SW and ENCODER ASSYS............................................................................................................216

11.12 IR BUFFER ASSY...................................................................................................................................................218

11.13 BUFFER GND ASSY and IR INTERFACE ASSY...................................................................................................222

11.14 D-AMP_S ASSY......................................................................................................................................................224

11.15 PRIMARY ASSY .....................................................................................................................................................228

11.16 A-REG ASSY..........................................................................................................................................................232

11.17 IR REG ASSY.........................................................................................................................................................234

11.18 V-REG ASSY ..........................................................................................................................................................238

11.19 VREG CHILD ASSY and CONNECT ASSY...........................................................................................................242

11.20 A-DAC BRIDGE, D-AUDIO BRIDGE, D-DAC BRIDGE and PRE BRIDGE ASSYS................................................244

11.21 FAN CONNECT_S ASSY and MIC HP GUARD ASSY .......................................................................................

...2

48

11.22 BIND DM CABLE ASSY and P WIRE GUARD ASSY ............................................................................................252

11.23 FFC GUARD, BIND FAN CABLE, VREG GUARD, TRANS VREG STYL and IR EDGE GUARD ASSYS..............254

12. PCB PARTS LIST ............................................................................................................................................................256

5

SC-65

5

6 7 8

5

6 7 8

A

B

C

D

E

F

1. SERVICE PRECAUTIONS

1.1 NOTES ON SOLDERING

1.2 NOTES ON REPLACING

1.3 CAUTION

• For environmental protection, lead-free solder is used on the printed circuit boards mounted in this unit.

Be sure to use lead-free solder and a soldering iron that can meet specifications for use with lead-free solders for repairs

accompanied by reworking of soldering.

• Compared with conventional eutectic solders, lead-free solders have higher melting points, by approximately 40 °C.

Therefore, for lead-free soldering, the tip temperature of a soldering iron must be set to around 373 °C in general, although

the temperature depends on the heat capacity of the PC board on which reworking is required and the weight of the tip of

the soldering iron.

Do NOT use a soldering iron whose tip temperature cannot be controlled.

Compared with eutectic solders, lead-free solders have higher bond strengths but slower wetting times and higher melting

temperatures (hard to melt/easy to harden).

The following lead-free solders are available as service parts:

• Par

ts numbers of lead-free solder:

GYP1006 1.0 in dia.

GYP1007 0.6 in dia.

GYP1008 0.3 in dia.

The part listed below is difficult to replace as a discrete component part.

When the part listed in the table is defective, replace whole Assy.

Parts that is Difficult to Replace

ASSY NAME

PCB ASSY

Part No.

Ref No. FUNCTION Part No. Remarks

IC903 HDMI RECEIVER ------------------- IC with heat-pad

IC1204 DIGITAL VIDEO FORMAT

CONVERTER

-------------------

BGA

IC1212 DDR2-SDRAM ------------------- BGA

IC1602 HDMI TRANSMITTER ------------------- IC with heat-pad

IC1609 HDMI TRANSMITTER ------------------- IC with heat-pad

IC9002 1st DSP ------------------- IC with heat-pad

IC9203 LAN PHY ------------------- IC with heat-pad

IC9204 MEDIA PROCESSOR ------------------- BGA

IC9510 REGULATOR ------------------- IC with heat-pad

IC9520 REGULATOR ------------------- IC with heat-pad

IC9521 REGULATOR ------------------- IC with heat-pad

IC9522 REGULATOR ------------------- IC with heat-pad

IC9524 REGULATOR ------------------- IC with heat-pad

IC9602 HDMI RECEIVER ------------------- IC with heat-pad

DIGITAL MAIN

ASSY

AWX1199

IC9702 2nd DSP ------------------- IC with heat-pad

D-AMP_S

ASSY

AWX1210

Q4101,4102

Q4201,4202

Q4301,4302

Q4401,4402

Q4501,4502

Q4601,4602

Q4701,4702

Q4801,4802

Q4901,4902

FET ------------------- Land is under parts

• Discharging

Before starting the diagnosis, wait for three minutes until the electricity of the unit is discharged.

• Ground Points

Please refer to “Ground Points”.

6

SC-65

1

2 3 4

A

B

C

D

E

F

1

2 3 4

1.4 NOTES ON ASSEMBLING

IR BUFFER ASSY

Accessory of Panel Base

IR Cover

D-AMP_S ASSY

Rear Panel

BUFFER GND ASSY

• Front View

Note : The right and left positions for the attachment positioning of digital amplifier block are gradual, however, adjust the

front and back positions correctly. For the positioning procedure, refer to "7. DISASSEMBLY".

When assembling the digital amplifier block, please note the following points of screws to prevent from short-circuit.

The following 7 points of screws must always be used AMZ30P060FTC

Points to be watched for swarf

If a screw at any of these points needs to be removed for service,

be sure to check that the swarf is not on the screw before refastening.

7

SC-65

5

6 7 8

5

6 7 8

A

B

C

D

E

F

2. SPECIFICATIONS

2.1 SC-65 SPECIFICATIONS

Amplifier section

Continuous average power output*

8Ω ............................................................................................................................... 130 W** per channel

6Ω ............................................................................................................................... 170 W*** per channel

* Measured pursuant to the Federal Trade Commission’s Trade Regulation rule on Power Output Claims for Amplifiers

** 1 kHz with no more than 0.08 %**** total harmonic distortion

*** 1 kHz with no more than 1 %**** total harmonic distortion

**** Measured by Audio Spectrum Analyzer

Multi channel simultaneous power output (1 kHz, 1 %, 8 Ω )

9 ch total ............................................................................................................................................ 720 W

Continuous Power Output (1 kHz, 8 Ω, 0.08 %)

Front ...................................................................................................................................... 130 W + 130 W

Center .................................................................................................................................... 130 W

Surround ............................................................................................................................... 130 W + 130 W

Surround back ...................................................................................................................... 130 W + 130 W

Front height/Front wide.......................................................................................................... 130 W + 130 W

Continuous Power Output (1 kHz, 6 Ω, 1.0 %)

Front...................................................................................................................................... 170 W + 170 W

Center..................................................................................................................................... 170 W

Surround................................................................................................................................ 170 W + 170 W

Surround back........................................................................................................................ 170 W + 170 W

Front height/Front wide........................................................................................................... 170 W + 170 W

Continuous Power Output (1 kHz, 4 Ω, 1.0 %)

Front...................................................................................................................................... 210 W + 210 W

Center.................................................................................................................................... 210 W

Surround............................................................................................................................... 210 W + 210 W

Surround back....................................................................................................................... 210 W + 210 W

Front height/Front wide.......................................................................................................... 210 W + 210 W

Total harmonic distortion............................................................................... 0.04 % (1 kHz, 110 W + 110 W, 8 Ω)

Guaranteed speaker impedance..........................................................................................................4Ω to 16 Ω

Audio Section

Input (Sensitivity/Impedance)

LINE....................................................................................................................................... 380 mV/47 kΩ

Output (Level/Impedance)

REC....................................................................................................................................... 380 mV/2.2 kΩ

Signal-to-Noise Ratio (IHF, short circuited, A network)

LINE.................................................................................................................................................... 101 dB

Tuner Section

Frequency Range (FM)........................................................................................................ 87.5 MHz to 108 MHz

Antenna Input (FM).................................................................................................................... 75Ω unbalanced

Frequency Range (AM)......................................................................................................... 530 kHz to 1700 kHz

Antenna (AM)................................................................................................................. Loop antenna (balanced)

Video Section

Signal level

Composite Video ...................................................................................................................... 1 Vp-p (75 Ω)

Component Video...................................................................... Y: 1.0 Vp-p (75 Ω), PB/PR: 0.7 Vp-p (75 Ω)

Corresponding maximum resolution

Component Video..................................................................................... 1080p (1125p) (Video convert off)

8

SC-65

1

2 3 4

A

B

C

D

E

F

1

2 3 4

Digital In/Out Section

HDMI terminal ...............................................................................................................................19-pin (Not DVI)

HDMI output type................................................................................................................................. 5 V, 55 mA

HDMI input/MHL terminal ......................................................................................................................... 5 V, 1 A

USB terminal............................................................................................USB2.0 High Speed (Type A) 5 V, 2.1 A

iPod terminal............................................................................................................ USB, and Video (Composite)

ADAPTER PORT terminal ................................................................................................................. 5 V, 100 mA

WIRELESS LAN ADAPTER terminal ................................................................................................. 5 V, 600 mA

Integrated Control Section

Control (IR) terminal......................................................................................................... ø 3.5 Mini-jack (MONO)

IR signal................................................................................................................. High Active (High Level: 2.0 V)

12 V Trigger terminal........................................................................................................ ø 3.5 Mini-jack (MONO)

12 V Trigger output type ............................................................................................................12 V, Total 150 mA

RS-232C cable type.............................................................................................9-pin, cross type, female-female

EXTENSION terminal .........................................................................................................................5 V, 150 mA

Network Section

LAN terminal....................................................................................................................10 BASE-T/100 BASE-TX

Miscellaneous

Power requirements...................................................................................................................... AC 120 V, 60 Hz

Power consumption ...................................................................................................................................... 330 W

In standby................................................................................................ 0.1 W (HDMI Setup – Control : OFF)

0.3 W (HDMI Setup – Control : ON)

Dimensions............................................................................................. 435 mm (W) x 185 mm (H) x 441 mm (D)

(17 1/8 in. (W) x 7 1/4 in. (H) x 17 3/8 in. (D))

Weight (without package).............................................................................................................. 15.1 kg (33.3 lb)

Number of Furnished Parts

MCACC Setup microphone............................................................................................................................... 1

Remote control unit .......................................................................................................................................... 1

AAA size IEC R03 dry cell batteries .................................................................................................................. 2

iPod cable ......................................................................................................................................................... 1

MHL cable.......................................................................................................................................................... 1

AM loop antenna ................................................................................................................................................ 1

FM wire antenna ................................................................................................................................................ 1

Power cord

CD-ROM (AVNavigator)

Quick start guide

Safety Brochure

Warranty sheet

Note

 Specifications and the design are subject to possible modifications without notice, due to improvements.

 This product includes FontAvenue

®

fonts licensed by NEC Corporation. FontAvenue is a registered trademark of

NEC Corporation.

9

SC-65

5

6 7 8

5

6 7 8

A

B

C

D

E

F

2.2 SC-1527-K/SC-1522-K SPECIFICATIONS

Amplifier section

Continuous average power output*

8

Ω ............................................................................................................................... 130 W** per channel

6

Ω ............................................................................................................................... 170 W*** per channel

* Measured pursuant to the Federal Trade Commission’s Trade Regulation rule on Power Output Claims for Amplifiers

** 1 kHz with no more than 0.08 %**** total harmonic distortion

*** 1 kHz with no more than 1 %**** total harmonic distortion

**** Measured by Audio Spectrum Analyzer

Multi channel simultaneous power output (1 kHz, 1 %, 8 Ω)

9 ch total.............................................................................................................................................. 720 W

Continuous Power Output (1 kHz, 8 Ω , 0.08 %)

Front...................................................................................................................................... 130 W + 130 W

Center.................................................................................................................................... 130 W

Surround............................................................................................................................... 130 W + 130 W

Surround back....................................................................................................................... 130 W + 130 W

Front height/Front wide.......................................................................................................... 130 W + 130 W

Continuous Power Output (1 kHz, 6 Ω, 1.0 %)

Front...................................................................................................................................... 170 W + 170 W

Center.................................................................................................................................... 170 W

Surround............................................................................................................................... 170 W + 170 W

Surround back........................................................................................................................170 W + 170 W

Front height/Front wide........................................................................................................... 170 W + 170 W

Continuous Power Output (1 kHz, 4 Ω, 1.0 %)

Front.......................................................................................................................................210 W + 210 W

Center..................................................................................................................................... 210 W

Surround................................................................................................................................ 210 W + 210 W

Surround back........................................................................................................................210 W + 210 W

Front height/Front wide........................................................................................................... 210 W + 210 W

Total harmonic distortion.............................................................................. 0.04 % (1 kHz, 110 W + 110 W, 8 Ω)

Guaranteed speaker impedance.........................................................................................................4Ω to 16 Ω

Audio Section

Input (Sensitivity/Impedance)

LINE ...................................................................................................................................... 380 mV/47 kΩ

Output (Level/Impedance)

REC...................................................................................................................................... 380 mV/2.2 kΩ

Signal-to-Noise Ratio (IHF, short circuited, A network)

LINE ................................................................................................................................................... 101 dB

Tuner Section

Frequency Range (FM)........................................................................................................ 87.5 MHz to 108 MHz

Antenna Input (FM).................................................................................................................... 75Ω unbalanced

Frequency Range (AM)...........................................................................................................530kHz to 1700 kHz

Antenna (AM)................................................................................................................. Loop antenna (balanced)

Video Section

Signal level

Composite Video...................................................................................................................... 1 Vp-p (75 Ω)

Component Video ........................................................................ Y:1.0 Vp-p (75 Ω), PB/PR: 0.7 Vp-p (75 Ω)

Corresponding maximum resolution

Component Video...................................................................................... 1080p(1125p) (Video convert off)

10

SC-65

1

2 3 4

A

B

C

D

E

F

1

2 3 4

Digital In/Out Section

HDMI terminal ...............................................................................................................................19-pin(Not DVI)

HDMI output type................................................................................................................................. 5 V, 55 mA

HDMI input/MHL terminal ........................................................................................................................ 5 V, 1 A

USB terminal............................................................................................USB2.0 High Speed (Type A) 5 V, 2.1 A

iPod terminal............................................................................................................ USB,and Video (Composite)

ADAPTER PORT terminal................................................................................................................... 5V, 100 mA

WIRELESS LAN ADAPTER terminal.................................................................................................... 5 V, 600 mA

Integrated Control Section

Control (IR) terminal......................................................................................................... ø3.5 Mini-jack (MONO)

IR signal................................................................................................................. High Active (High Level: 2.0 V)

12 V Trigger terminal........................................................................................................ ø 3.5 Mini-jack (MONO)

12 V Trigger output type............................................................................................................ 12 V, Total 150 mA

RS-232C cable type............................................................................................. 9-pin, cross type, female-female

EXTENSION terminal......................................................................................................................... 5 V, 150 mA

Network Section

LAN terminal....................................................................................................................10BASE-T/100 BASE-TX

Miscellaneous

Power requirements..................................................................................................................... AC 120 V, 60 Hz

Power consumption..................................................................................................................................... 330 W

In standby............................................................................................... 0.1 W (HDMI Setup – Control : OFF)

0.3 W (HDMI Setup – Control : ON)

Dimensions............................................................................................ 435 mm (W) x 185 mm (H) x 441 mm (D)

(17 1/8 in. (W) x 7 1/4 in. (H) x 17 3/8 in. (D))

Weight (without package).............................................................................................................. 15.1 kg (33.3 lb)

Number of Furnished Parts

MCACC Setup microphone............................................................................................................................... 1

Remote control unit........................................................................................................................................... 1

AAA size IEC R03 dry cell batteries .................................................................................................................. 2

iPod cable ......................................................................................................................................................... 1

MHL cable ........................................................................................................................................................ 1

AM loop antenna ............................................................................................................................................... 1

FM wire antenna ............................................................................................................................................... 1

Power cord

CD-ROM (AVNavigator)

Quick start guide

Safety Brochure

Warranty sheet

Note

 Specifications and the design are subject to possible modifications without notice, due to improvements.

 This product includes FontAvenue

®

fonts licensed by NEC Corporation. FontAvenue is a registered trademark of

NEC Corporation.

Manufactured under license from Dolby Laboratories. “Dolby”, “Pro Logic”, “Surround EX” and the double-D symbol

are trademarks of Dolby Laboratories.

Manufactured under license under U.S. Patent No’s: 5,956,674; 5,974,380; 5,978,762; 6,487,535; 6,226,616;

7,212,872; 7,003,467; 7,272,567; 7,668,723; 7,392,195; 7,930,184; 7,333,929; 7,548,853; 7,283,634 & other U.S. and

worldwide patents issued and pending. DTS-HD, the Symbol, & DTS-HD and the Symbol together are registered

trademarks & DTS-HD Master Audio is a trademark of DTS, Inc. Product includes software. © DTS, Inc. All Rights

Reserved.

THX, the THX logo and Select2 Plus are trademarks of THX Ltd. which are registered in some jurisdictions. All rights

reserved. All other trademarks are the property of their respective owners.

Apple, AirPlay, iPad, iPhone, iPod, iPod nano, iPod touch, iTunes and Mac are trademarks of Apple Inc., registered in

the U.S. and other countries.

The AirPlay logo is a trademark of Apple Inc.

Windows and the Windows logo are trademarks of the Microsoft group of companies.

MHL, the MHL Logo, and Mobile High-Definition Link are trademarks or registered trademarks of MHL LLC in the

United States and other countries.













11

SC-65

5

6 7 8

5

6 7 8

A

B

C

D

E

F

3. BASIC ITEMS FOR SERVICE

3.1 CHECK POINTS AFTER SERVICING

oidua gnidrager dekcehc eb ot metIoediv gnidrager dekcehc eb ot metI

Block noise Distortion

Horizontal noise Noise

Flicker Volume too low

Disturbed image (video jumpiness) Volume too high

Too dark Volume fluctuating

detpurretni dnuoSthgirb ooT

Mottled color

stniop kcehCserudecorP.oN

1

2

3

4

5

6

7

8

Confirm whether the customer complain has been solved.

If the customer complain occurs with the particular source,

such as Dolby Digital, DTS, AAC, DVD-A and HDMI, input it for

the operation check.

The customer complain must not be reappeared.

Video, Audio and operations must be normal.

Check the analog audio playback.

(Make the analog connections with a DVD player.)

Each channel audio and operations must be normal.

Check the digital audio playback.

(Make the digital connections with a DVD player.)

Each channel audio and operations must be norm

al.

Check surround playback.

(Select Surround mode and check the multichannel operations

via the DSP circuit.)

Each channel audio and operations must be normal.

.lamron eb tsum snoitarepo dna oiduA.snoitarepo )MF dna MA( renut eht kcehC

Check the video outputs.

(Connect with a DV

D player.)

Video and operations must be normal.

.esion tuohtiw ,lamron eb tsum dnuoS.tuptuo enohpdaeh morf dnuos eht kcehC

Chec

k the a

ppearance of the product. No scratches or dirt on its appearance after receiving it for

service.

Items to be checked after servicing

To keep the product quality after servicing, confirm recommended check points shown below.

See the table below for the items to be checked regarding video and audio.

Cleaning

Before shipping out the product, be sure to clean the following positions by using the prescribed cleaning tools.

Name skrameR.oN traPdenaelc eb ot noitisoP

Refer to “9.4 CHASSIS SECTION”.Cleaning paper 00-DEGsnaF 8

12

SC-65

1

2 3 4

A

B

C

D

E

F

1

2 3 4

3.2 PCB LOCATIONS

COMPONENT ASSY

AA

PRE BRIDGE ASSY

AD

BIND DM CABLE ASSY

AB

FAN CONNECT_S ASSY

AE

P WIRE GUARD ASSY

AC

MIC HP GUARD ASSY

AI

TRANS VREG STYL ASSY

PRIMARY ASSY

R

A-DAC BRIDGE ASSY

X

D-DAC BRIDGE ASSY

Z

COMPOSITE ASSY

H

INTERFACE ASSY

F

D-AUDIO BRIDGE

ASSY

Y

A-REG ASSY

S

I

VREG CHILD ASSY

V

G

IR INTERFACE ASSY

P

CONNECT ASSY

IR BUFFER ASSY

N

IR REG ASSY

T

V-REG ASSY

U

H

USB RECT ASSY

D

DIGITAL MAIN ASSY

E

DAC HIGH ASSY

B

AUDIO ASSY

A

D-AMP_S ASSY

Q

BUFFER GND ASSY

O

BIND FAN CABLE

ASSY

AG

FFC GUARD ASSY

AF

VREG GUARD ASSY

AH

I

IR EDGE GUARD ASSY

AJ

W

13

SC-65

5

6 7 8

5

6 7 8

A

B

C

D

E

F

VOL ASSY

ENCODER ASSY

M

DISPLAY ASSY

J

POWER SW ASSY

L

FRONT HDMI USB

ASSY

C

MIC HP ASSY

I

K

PANEL GUARD ASSY

AK

NOTES:

-

Parts marked by “NSP” are generally unavailable because they are not in our Master Spare Parts List.

-

The > mark found on some component parts indicates the importance of the safety factor of the part.

Therefore, when replacing, be sure to use parts of identical designation.

Mark No. Description Part No.

LIST OF ASSEMBLIES

NSP 1..D-AMP_S ASSY AWH7047

2..D-AMP_S ASSY AWX1210

NSP 1..IR BUFFER ASSY AWM8306

2..IR BUFFER ASSY AWX1155

2..BUFFER GND ASSY AWX1156

NSP 1..PRIM DISPLAY ASSY (SC-65) AWM8289

2..DISPLAY ASSY AWX1131

2..VOL ASSY AWX1134

2..POWER SW ASSY AWX1135

2..PRIMARY ASSY AWX1136

2..MIC HP ASSY AWX1148

2..ENCODER ASSY AWX1150

2..MIC HP GUARD ASSY AWX1152

NSP 2..VREG GUARD ASSY AWX1153

NSP 2..PANEL GUARD ASSY AWX1154

NSP 1..

PRIM DISPLAY ASSY (SC-1527-K/SC-1522-K)

AWM8290

2..DISPLAY ASSY AWX1132

2..VOL ASSY AWX1134

2..POWER SW ASSY AWX1151

2..PRIMARY ASSY AWX1136

2..MIC HP ASSY AWX1148

2..ENCODER ASSY AWX1150

2..MIC HP GUARD ASSY AWX1152

NSP 2..VREG GUARD ASSY AWX1153

NSP 2..PANEL GUARD ASSY AWX1154

NSP 1..AUDIO COMPOSITE ASSY AWR7135

2..AUDIO ASSY AWX1113

2..COMPOSITE ASSY AWX1116

2..D-AUDIO BRIDGE ASSY AWX1127

2..D-DAC BRIDGE ASSY AWX1128

2..A-DAC BRIDGE ASSY AWX1129

2..FAN CONNECT_S ASSY AWX1130

NSP 1..INTERFACE REG ASSY AWR7147

2..INTERFACE ASSY AWX1157

2..CONNECT ASSY AWX1160

2..PRE BRIDGE ASSY AWX1161

2..IR REG ASSY AWX1283

NSP 2..TRANS VREG STYL ASSY AWX1256

NSP 1..PRE POWER ASSY AWR7149

2..A-REG ASSY AWX1162

2..V-REG ASSY AWX1163

2..VREG CHILD ASSY AWX1165

2..USB RECT ASSY AWX1166

2..BIND DM CABLE ASSY AWX1168

2..P WIRE GUARD ASSY AWX1229

NSP 2..FFC GUARD ASSY AWX1167

NSP 2..BIND FAN CABLE ASSY AWX1231

1..DAC HIGH ASSY AWX1103

1..COMPONENT ASSY AWX1105

1..FRONT HDMI USB ASSY AWX1110

1..IR INTERFACE ASSY AWX1112

NSP 2..IR EDGE GUARD ASSY AWX1230

1..DIGITAL MAIN ASSY AWX1199

Mark No. Description Part No.

14

SC-65

1

2 3 4

A

B

C

D

E

F

1

2 3 4

3.3 JIGS LIST

[1] Jigs List

Name

Jig No.

Remarks

Diagnosis for AUDIO ASSY, D-AMP_S ASSY,

DIGITAL MAIN ASSY, DAC HIGH ASSY

Diagnosis for AUDIO ASSY, D-AMP_S ASSY

Diagnosis for AUDIO ASSY, D-AMP_S ASSY,

DIGITAL MAIN ASSY, DAC HIGH ASSY

Diagnosis for AUDIO ASSY, D-AMP_S ASSY

Diagnosis for AUDIO ASSY, D-AMP_S ASSY

Diagnosis for AUDIO ASSY, D-AMP_S ASSY

Diagnosis for DIGITAL MAIN ASSY, DAC HIGH ASSY

Diagnosis for DIGITAL MAIN ASSY, DAC HIGH ASSY

Diagnosis for DIGITAL MAIN ASSY, DAC HIGH ASSY

Diagnosis for DAC HIGH ASSY

39P FFC GGD1681

15P FFC GGD1680

20P + 14P board to board extension jig cable GGD1798

23P + 23P board to board extension jig cable GGD1804

5P PH Housing ASSY GGD1594

4P PH Housing ASSY GGD1809

23P

board to board extension jig cable GGD1805

27P board to board extension jig cable GGD1799

30P + 28P board to board extension jig cable GGD1806

28P + 14P board to board extension jig cable GGD1763

[2] Lubricants and Glues List

Name

Lubricants and Glues No.

Remarks

Silicone Grease

ZLB-PN397B

Refer to “9.5 FRONT SECTION”

15

SC-65

5

6 7 8

5

6 7 8

A

B

C

D

E

F

16

SC-65

1

2 3 4

A

B

C

D

E

F

1

2 3 4

4. BLOCK DIAGRAM

4.1 OVERALL WIRING DIAGRAM

23.NC

22.FHL-

21.FHL+

20.V-12FHR

19.V+12FHR

18.IRMUTEFH

17.FHR-

16.FHR+

15.V-12C

14.V+12C

13.NC

12.C-

11.C+

10.V-12FL

9.V+12FL

8.IRMUTEA

7.FL-

6.FL+

5.V-12FR

4.V+12FR

3.NC

2.FR-

1.FR+

20

27

20

9/65

TUNER

MODULE

3/100

1.V+5_EV_1

2.POWLED

3.POWER KEY

4.GNDD

*2mm

1.VOLA

2.VOLB

3.GNDD

39/120

7

1.FRONTV

2.GNDF

2

1.-B+15V

2.-B

1.V+12_DF

2.GND_DF

3.V-12_DF

4.GND_DF(S)

5.V+12_RY

6.V-12_RY

7.V-12_RY

2

1.ACWP

2.GNDV

3.GNDV

4.V+5_V

5.-VF

6.FL AC2

7.FL AC1

15/305

19.EXSO

18.EXSCK

17.EXOE

16.EXST

15.XOLERR

14.XBERR

13.IRMUTEA

12.IRMUTESB

11.IRMUTEFH

10.RY_FW

9.RY_AF

8.RF_CR

7.RF_FH

6.RF_B

5.AMP_TEMP

4.XTEMPSD5

3.XDCERR

2.GNDD

1.GNDD

1.HP L

2.GNDHP

3.HP R

4.GNDHP

5.AMUTE

6.XHPDET

7.XMICDET

8.V-7_A

9.GNDA

10.GNDA

11.V+7_A

12.GNDA

13.MICOUT

14.GNDF

15.FRONTV

4

4

*1.00mm

5555 5

1.V+8_MD

2.GND_MD

3.V-8_MD

4.GND_MD(S)

4

!

FU12

!

FU11

!

FU15

!

FU14

!

FU13

ADD7765-

ADD7781-

ADD7753-

D20PYY0310E

*1.00mm

CN8301

CN3472

CN3001

JH3004

CN7006

CN4000

CN4001

JP3001

CN2503

CN3601

CN8303

JP8402

CN7281

CN8401

CN6803 CN6802

CN3801CN3802

23 23

2323

*4

CN4002

CN4003

CN4004

2

4

7

*3

55555

CN3870CN3880CN3890 CN3850CN3860

CN4700CN4100CN4200 CN4500CN4600

CN7551

JP3001

CN3004

ADD7763-

7/60

6

CN8002

JA8003CN8001

CN3371

J3004

C

14

CN3001CN2861

23

CN3902

14

CCN3792

14

CCN3791

CN7802

19

CN7801

13

CN7803CN7804

23

23

23

27 19

13

CN7004 CN7003

19.V+5R6_EV

18.V+5R6_EV

17.GNDD

16.GNDD

15.XFANERR

14.FANCTLL

13.FANCTLH

12.EXSO

11.EXSCK

10.EXOE

9.EXST

8.GNDD

7.AMPTEMP

6.IRMUTEA

5.IRMUTESB

4.IRMUTEFH

3.RFPOW

2.RYFW

1.GNDD

1.XFANERR

2.FANCTLL

3.FANCTLH

4.EXSO

5.EXSCK

6.EXOE

7.EXST

8.XOLERR

9.AMP_TEMP

10.IRMUTEA

11.IRMUTESB

12.IRMUTEFH

13.RY_FW

CN3653

*1.00mm

23.GGND

22.V-12SBL

21.V+12SBL

20.NC

19.SBL-

6

CN7553

7

*1.00mm

*1.00mm

*1.00mm

ADX7776-

7/205

ADX7747-

2/120

1.GNDD

2.Y_IN

3.GNDD

4.CB_IN

5.GNDD

6.CR_IN

7.GNDD

8.CVBS_IN

9.GNDD

10.V+5_V

11.V+5_V

12.COMP_DET

13.SDA

14.SCL

15.OSDSO

JP7001

*4 *4

JA8001 JA8002

iPod Direct USB HDMI IN5

JA3471JA3472

VIDEO MIC IN HEADPHONE

JA3476

MCACC setup

!

FU10

*4

IR

JA7005

OUTRF 5V OUT

JA7002

JA7003

12V TRG1

12V TRG2

IR IN2IR IN1

2.S7-2

1.S7-1

15.XHPDET

1.XMICDET

5.S6-2

4.S6-1

3.S5-2

2.S5-C

1.S5-1

(DVR) (DVD)

JA8301JA8304

JA8601

IN1

PR

PB

YY

PB

PR

232C MONITOR IN2

OUT

1.V-5_V

2.GNDV

3.V+5_V

4.GNDV

5.ZONE3_OUT

6.GNDV

7.ZONE2_OUT

8.GNDV

9.DVR_OUT

10.GNDV

11.MONITOR_OUT

12.GNDV

13.DVR_IN

14.GNDV

15.VIDEO_IN

16.GNDV

17.TV/SAT_IN

18.GNDV

19.DVD_IN

20.GNDV

OUTIN

DVRSAT DVR

OUT

JA3602JA3605

IN

JA3601JA3603

ZONE2 DVD

OUTIN

MONITOR

SAT

ININ

DVD DVR

INOUT

JA2504JA2501

IN

JA2505

IN1(CD)

FRONT

CENTER

JA4101

RL

for IC3001 DBUG&D.L.

CN3002

J0003

J0007

J0001

J0006

2.GNDUSB

1.V+UN_USB

JP8001

CN3652

1.TURST

2.TUSDA

3.TUSCL

4.TUIREQ

5.NC

6.GNDT

7.TR

8.V+5T

9.TL

1.V+FAN

2.V-FAN

3.LOCK

1.JOG_A

2.JOG_B

3.GNDD

OUT

ZONE2

JA6701

IN5

4

1.V+5_V

2.GNDV

3.GNDV

4.V-5_V

19

CN7011

CN7661

19

19.V+12TRG

18.V+12TRG

17.GNDV

16.GNDV

15.XHPDET

14.AMUTE

13.GNDHP

12.HP_R

11.GNDHP

10.HP_L

9.GNDA

8.MICOUT

7.GNDA

6.V+7_A

5.GNDA

4.V-7_A

3.XMICDET

2.GNDF

1.FRONTV

4.-B(+65V)

3.GND

2.GND

1.+B(+65V)

*1.00mm

CN7901

CN7401

CN7663

CN7251

CN7271

CN7241

*4

!

FU31

!

FU32

CN7010

ADD7764-

15/135

VIDEO

IN

JA2502

VIDEO

IN

1.V+12

2.V+5_V

3.V+5_V

4.GNDV

5.GNDV

6.V-5_V

7.V-12

1.V+12

2.V+5_V

3.V+5_V

4.GNDV

5.GNDV

6.V-5_V

7.V-12

*1.00mm

CN7902

1.GNDD

2.BTPOW

3.BTOL

4.BTRX

5.BTTX

6.BTDET

7.GNDD

8.V+3R3_D

9V+3R3 D

JA5101

F-HEIGHT

LR

L

R

SW

BD ININ1 IN2 IN3 IN6IN4

C

C

IN

14

CN2104

BT ADAPTER

PORT JA

23.Z2HPF

1.FHMUTE

14.BT L

13.GNDBT

12.BT R

11.GNDBT

10.V+6_AD

9.V+6_AD

8.GNDAD

7.GNDAD

6.V+12_A

5.V+12_A

4.GNDA

3.GNDA

2.V-12_A

1.V-12_A

28.GNDADS

27.FR IN

26.GNDADS

25.FL IN

24.GNDDAS

23.FR OUT

22.GNDDAS

21.FL OUT

20.GNDDAS

19.SW OUT

18.GNDDAS

17.C OUT

16.GNDDAS

15.SR OUT

14.GNDDAS

13.SL OUT

12.GNDDAS

11 FHR/FWR OUT

1.S

2.S

3.S

4.S

5.S

6.S

7.S

8.S

1.S

2.S

3.S

28 GNDADS

14.BT L

1.V-12_A

39.XFANERR

38.AMPTEMP

37.WUSBPOW

36.XNETRST

35.IRIN

34.XDCERR

33.XOLERR

32.XBERR

31.232CDET

30.232POW

29.232EV

28.EV232TX5

27.EV232RX5

26.XWUSBERR

25.CECIO

24.HOTPLUG

23.NETWOL

22.TEMPERR

21.NC

20.EVREQI5

19.EVSCK

18.EVSO

17.EVSI5

16.XEMRST5

15.EVREQO

14.NETPOW

13.DVCPOW

12.FHD5VEN

11.MHLPOW

10.XMHLPERR

9.ACRY

8.XSMUTE

7.LOWPOW

6.GNDD

5.GNDD

4.GNDD

3.GNDD

2.V+5R6_EV

1.V+5R6_EV

15

15

15.GNDD

14.RYAF

13.RYCR

12.RYFH

11.RYB

10.XBERR

9.XTEMPSD5

8.XDCERR

7.XOLERR

6.GNDD

5.12VTRG1

4.12VTRG2

3.12VERR

2.GNDD

1.IRIN

1.RY_AF

2.RY_CR

3.RY_FH

4.RY_B

5.XBERR

6.XTEMPSD5

7.XDCERR

8.GNDD

9.GNDD

10.12VTRG1

11.12VTRG2

12.12VERR

13.RF_POW

14.GNDD

15.IR_IN

16.V+5R6_EV

17.V+5R6_EV

18.GNDD

19.GNDD

19

19

J0005

ADD7746-

39/140

*1.00mm

5/380

ADX7787-

2/120

ADX7760-

ADX7779-

4/285

4/180

ADX7780-

2/190

ADX7781-

7/180

ADX7782-

CN7552

7

7/65

ADX7783-

4/100

PF04PG-S10

19/90

ADD7747-

J0008

*1.25mm

*1.25mm

1.XHPDET

2.AMUTE

3.GNDHP

4.HPR

5.GNDHP

6.GNDHP

7.HPL

8.GNDA

9.MICOUT

10.GNDA

11.V+7_A

12.GNDA

13.GNDA

14.V-7_A

15.XMICDET

19/360

ADX7732-

*1.25mm

ADD7766-

3/65

15.HP L

1.FRONTV

1.XFANERR

39.V+5R6_EV

JA3206

OUT

ZONE3

3.XFANERR

2.FANCTLL

1.FANCTLH

*1.25mm

CN7009

*1.25mm

1.XFANERR

2.FANCTLL

3.FANCTLH

7.CEC_IO

6.XVDDERR

5.XMHLPERR

4.MHLPOW

3.FHD5VEN

2.MHLWUP

1.GNDD

7.CEC_IO

6.XVDDERR

5.XMHLPERR

4.MHLPOW

3.FHD5VEN

2.MHLWUP

1.GNDD

21.EVSO

22.EVSI5

23.XWUSBERR

24.WUSBPOW

25.EVREQO

26.NETPOW

27.DVCPOW

28.FHD5VEN

29.MHLPOW

30.XMHLPERR

31.XNETRST

32.XEMRST5

33.XOLERR

34.GNDD

35.GNDD

36.GNDD

37.GNDD

38.V+5_EV

39.V+5_EV

1.XFANERR

2.AMPTEMP

3.XDCERR

4.XBERR

5.IRIN

6.232CDET

7.232POW

8.232EV

9.EV232TX5

10.EVREQI5

11.TEMPERR5

12.EV232RX5

13.HOTPLUG

14.XSMUTE

15.CECIO

16.LOW_P

17.NETWOL

18.XRESET

19.ACRY

20.EVSCK

1 Z2HPF

2 RECMUTE

3 TUIREQ

4 TURST

5 TUSDA

6 TUSCL

7 GNDD

8 Z_SIG_DET

9 GNDD

10 GNDD

11 VLSCK

12 VLSO

13 Z2VLSO

14 Z3MUTE

15 Z2MUTE

16 SBMUTE

17 AMUTE

18 PRESEL

19 LSSN

20 XMICDET

21 RYHP

22 XHPDET

23 FHMUTE

19.V+5_EV

18.V+5F

17.GNDD

16.HPD

15.MHL_CTL

14.SDA_SINK

13.SCL_SINK

12.RFXC-

11.GNDD

10.RFXC+

9.RFX0-

8.GNDD

7.RFX0+

6.RFX1-

5.GNDD

4.RFX1+

3.RFX2-

2.MHL_DET

1.RFX2+

6.GNDD

5.USBPOW

4.XUSBERR

3.D+

2.D-

1.GNDD

6.GNDD

5.USBPOW

4.XUSBERR

3.D+

2.D-

1.GNDD

JA9602 JA9603JA9601 JA9604

CN602

CN601

JA9605

CN603

CN901

JA9606 JA9607

CN9202

CN1502

JA2102

CN3772

CN3771

CN7554

JA7001 JA7004

JA9608

IN7

39.XFANERR

1.V+5_EV

Y0027

Y0020

*1.25mm

J0004

J0002

Y0026

Y0025

Y0024

Y0023

JP8701

16.OSDSCK

17.OSDCS

18.XOSDRST

19.GNDD

20.232POW

21.232CDET

22.EV232TX

23.EV232RX

24.GNDD

25.GNDD

26.V+5R6_EV

27.V+5R6_EV

*1.25mm

*1.25mm

*1.25mm

*1.25mm

*1.25mm

*1.25mm

*1.25mm

*1.25mm

SYXJ8

JXJ

DLPWXJ,FXJ,AXJ5

UXJCB,CUXJ

AXX7282-

*3

AXX7283-

-

MODEL TUNER

EXCEPT

JJP MODEL

W

CONNECT ASSY

(AWX1160)

U

U

1/3 -

( )

V-REG ASSY

(AWX1163)

X

Y

AC

AD

AE

AF

AG

AH

F

N

P

FFC GUARD ASSY

(AWX1167)

BIND FAN CABLE ASSY

(AWX1231)

VREG GUARD ASSY

(AWX1153)

TRANS VREG STYL ASSY

(AWX1256)

IR EDGE GUARD ASSY

(AWX1230)

AI

AJ

INTERFACE ASSY

(AWX1157)

IR BUFFER

ASSY

(AWX1155)

IR INTERFA

(AWX1112)

A-DAC

BRIDGE ASSY

(AWX1129)

D-AUDIO

BRIDGE ASSY

(AWX1127)

MIC HP GUARD ASSY

(AWX1152)

BIND DM CABLE ASSY

(AWX1168)

P WIRE GUARD ASSY

(AWX1229)

E

E

1/1

(

DIGITAL M

(AWX1199

J

DISPLAY ASSY

(SC-65 : AWX1131)

(SC-1527-K/

SC-1522-K : AWX1132)

K

VOL ASSY

(AWX1134)

D

USB RECT

ASSY

(AWX1166)

T

T

1/2 -

T

2/2

( )

IR REG ASSY

(AWX1283)

C

FRONT HDMI USB ASSY

(AWX1110)

I

MIC HP ASSY

(AWX1148)

V

VREG CHILD

ASSY

(AWX1165)

U

3/3

H

COMPONENT ASSY(AWX1105)

COMPOSITE ASSY

(AWX1116)

PANEL GUARD ASSY

(AWX1154)

AK

G

G

1/2 -

( )

G

2/2

J

1/2 -

( )

J

2/2

17

SC-65

5

6 7 8

5

6 7 8

A

B

C

D

E

F

!

23

15.V-12C

14.V+12C

13.NC

12.C-

11.C+

10.V-12FL

9.V+12FL

8.IRMUTEA

7.FL-

6.FL+

5.V-12FR

4.V+12FR

3.NC

2.FR-

1.FR+

23

23

!

AC CORD

SECONDARY

PRIMARY

1.V+5_EV_1

2.POWLED

3.POWER KEY

4.GNDD

4/100

5

FAN

IR_REGIR_REG

A-REG

V-REG

USB RECT

55 555

!

FU12

!

FU11

!

FU15

D20PYY0410E

!

JH3002

CN3051

CN6952

CN6801

CN6951

CN7502

CN6803 CN6802

CN3801CN3802

23 23

2323

*1

AXM7040-

BOARD IN

FFC

2.0mm FLAT CABLE

FFC CONNECTOR

2.0mm CABLE HOLDER

*2mm

BOARD TO BOARD

T1501

CAUTION - FOR CONTINUED PROTECTION AGAINST RISK OF FIRE,

REPLACE WITH SAME TYPE AND RATINGS OF FUSE.

with same parts(safety regulation authorized) of identical

The mark found on some component parts should be replaced

designation.

55555

CN387080 CN3830CN3840CN3850CN3860

CN47000 CN4300CN4400CN4500CN4600

CN7501

S2,S3,S9

S5,S6

S4

S1

S7

23

ANOTHER CONNECTOR

CN3401

J3002

JUMPER CONNECTOR

28

CN2502

14

CN3001

2814

CN3794CN3792

2814

CN3793CN3791

CN3783 CN3781

CN3784CN3782

23.GGND

22.V-12SBL

21.V+12SBL

20.NC

19.SBL-

18.SBL+

17.V-12SBR

16.V+12SBR

15.IRMUTEB

14.SBR-

13.SBR+

12.V-12SL

11.V+12SL

10.NC

9.SL-

8.SL+

7.V-12SR

6.V+12SR

5.NC

4.SR-

3.SR+

2.V-12FHL

1.V+12FHL

23.PRESEL(W/XF)

22.V+7_A

21.V-7_A

20.GNDA

19.GNDA

18.SR OUT

17.GNDA

16.SL OUT

15.GNDA

14.FR OUT

13.GNDA

12.C OUT

11.GNDA

10.FL OUT

9.GNDA

8.FH/FWR OUT

7.GNDA

6.FH/FWL OUT

5.GNDA

4.SBR OUT

3.GNDA

2.SBL OUT

1.GNDA

HDMI CONNECTOR

ADX7791-

7/205

JP51

5.V-12_A

4.GNDA

3.GNDA

2.V+12_A

1.V+6_AD

*4 *4

*4

FU4FU1

!!

*4

JA71_1 WHT

JA71 YEL

PIN JACK

1.S4-1

2.NC

3.S4-C

4.NC

5.S4-2

R

DVR

INOUT

JA2504

PRE OUT

L

IN

JA2505

IN1(CD)

1.V+5R6_EV

2.V+5R6_EV

3.V+5R6_EV

4.GNDD

5.GNDD

6.GNDD

7.RYAC

RL

SURROUND

JA4301

LR

JA4901

S-BACK

CN81

CN82

(UXJCB,CUXJ,JXJ)

(SYXJ8,DLPWXJ,FXJ,AXJ5)

MAIN TRANS

SHIELD CABLE

1.V+FAN

2.V-FAN

3.LOCK DET

D20PYY0310E

3/100

1.JOG_A

2.JOG_B

3.GNDD

JH3003

J3003

CN3501

*2mm

JA4501

LR

55

5

CN3820

CN4900

5

CN3810

CN4800

KN6962

CN7400

JP7291

IN

A2502

CN7201

!

FU22

!

FU21

*4

1.V+FAN

2.V-FAN

3.LOCK DET

3

CN3651

CN3652

3

1.V+FAN

2.V-FAN

3.LOCK DET

3028

2830

1.BADA

2.SADA

3.CADA

4.FADA

5.DABCK

6.DALRCK

7.FHADA

8.GNDD

9.DAMCK

10.GNDD

11.ZMCLK

12.GNDD

13.ZBCK

14.ZFADA

15.ZLRCK

16.GNDD

17.DIRMCKO

18.GNDD

19.DIRLRCK

20.DIRDATO

21.DIRINT

22.DAC0DET

23.GNDD

24.DIRMCKI

25.GNDD

26.DIRBCK

27.GNDD

28.MSPDIF

1.GNDD

2.BTPOW

3.BTOL

4.BTRX

5.BTTX

6.BTDET

7.GNDD

8.V+3R3_D

9.V+3R3_D

10.GNDD

11.GNDD

12.V+5_D

13.V+5_D

14.DIRPOW

15.DSPSO

16.DSPSCK

17.RYAC

18.ZDZF

19.XZ2DARST

20.XDARST

21.DACS

22.F96K

23.F192K

24.XADRST

25.XTLO

26.XDIRRST

27.DSPSI

28.DIRCS

29.UNLK

30.DAZDB

F-WIDE/B

JA3201

C&SWF

JA3101 JA3202

SBFWS FH

JA3102

SW2

USB

LAN

IN6 OUT 2 OUT 1N4

CN2103

30

CN2102

IN2

JA2006JA2003

30.GNDD

1.DAZDB

30.BADA

1.MSPDIF

30

JA2002

OPT IN2 OPT OUT1

COAX

OPT IN1

28

IN1

14

CN2101CN2104

BT ADAPTER

PORT

28

28

JA2008

14.BT L

13.GNDBT

12.BT R

11.GNDBT

10.V+6_AD

9.V+6_AD

8.GNDAD

7.GNDAD

6.V+12_A

5.V+12_A

4.GNDA

3.GNDA

2.V-12_A

1.V-12_A

28.GNDADS

27.FR IN

26.GNDADS

25.FL IN

24.GNDDAS

23.FR OUT

22.GNDDAS

21.FL OUT

20.GNDDAS

19.SW OUT

18.GNDDAS

17.C OUT

16.GNDDAS

15.SR OUT

14.GNDDAS

13.SL OUT

12.GNDDAS

11.FHR/FWR OUT

10.GNDDAS

9.FHL/FWL OUT

8.GNDDAS

7.SBR OUT

6.GNDDAS

5.SBL OUT

4.GNDDAS

3.ZR OUT

2.GNDDAS

1.ZL OUT

1.S3-1

2.S3-C

3.S3-2

4.S2-1

5.S2-2

6.S9-1

7.S9-C

8.S9-2

1.S1-1

2.S1-C

3.S1-2

28.GNDADS

1.ZL OUT

14.BT L

1.V-12_A

19.EVSCK

18.EVSO

17.EVSI5

16.XEMRST5

15.EVREQO

14.NETPOW

13.DVCPOW

12.FHD5VEN

11.MHLPOW

10.XMHLPERR

9.ACRY

8.XSMUTE

7.LOWPOW

6.GNDD

5.GNDD

4.GNDD

3.GNDD

2.V+5R6_EV

1.V+5R6_EV

3/215

ADX7778-

PF05PG-S20

5/200

13 Z2VLSO

14 Z3MUTE

15 Z2MUTE

16 SBMUTE

17 AMUTE

18 PRESEL

19 LSSN

20 XMICDET

21 RYHP

22 XHPDET

23 FHMUTE

CN9501

JA9201

JA9202

603 JA9604

CN9002

JA1601

CN9003

JA1602

JA2102

JA9608

IN7

Therefore, when replacing, be sure to use parts of identical designation.

When ordering service parts, be sure to refer to "EXPLODED VIEWS and PARTS LIST" or "PCB PARTS LIST".

The > mark found on some component parts indicates the importance of the safety factor of the part.

*OPTION

MODEL MICROPHONE REMO-COM iPod CABLE

AXJ5

UXJCB

DLPWXJ

SC-LX56

SC-LX56

SC-LX56

SYXJ8

CUXJ

JXJ

SC-LX56

FXJ

MHL CABLE WIFI CABLE

SC-65

SC-1522-K

SC-1527-K

ADE7139-ADE7136-APM7010- AXD7668-

APM7010-

APM7010-

APM7010-

APM7010-

AXD7669-

ADE7139-ADE7136- ADE7137-AXD7668-

ADE7136- ADE7139-

ADE7139-AXD7668-ADE7136-

ADE7139-AXD7668-ADE7136-

*1

!

MODEL AC CORDMAIN TRANS

UXJCB

DLPWXJ

CUXJ

SYXJ8

JXJ

FXJ

AXJ5

SC-LX56

SC-LX56

SC-LX56

SC-LX56

SC-LX56

ATS7455-A

ATS7452-A

ATS7454-A

ATS7452-A

ATS7452-A

ATS7453-A

ADG7123-A

ADG7120-A

ADG7122-A

ADG7121-A

ADG7123-A

ADG7118-A

SC-65

SC-1527-K

SC-1522-K

!

*4

FU11,FU12 FU13,FU14 FU15FU1 FU4 FU31,FU32FU21,FU22FU10

MODEL

AXJ5

UXJCB

DLPWXJ

SYXJ8

CUXJ

JXJ

FXJ

SC-65

SC-1527-K

SC-1522-K

SC-LX56

SC-LX56

SC-LX56

SC-LX56

REK1154-

(10A/125V)

REK1154-

(10A/125V)

AEK1061-

(T5A L/250V)

AEK1061-

(T5A L/250V)

DEK1045-

(T10A L/250V)

REK1139-

(T2A H/250V)

REK1139-

(T2A H/250V)

REK1104-

(T4A H/250V)

REK1104-

(T4A H/250V)

REK1139-

(T2A H/250V)

REK1151-

(6A/125V)

REK1151-

(6A/125V)

AEK1061-

(T5A L/250V)

AEK1061-

(T5A L/250V)

AEK1061-

(T5A L/250V)

REK1143-

(1.25A/125V)

REK1143-

(1.25A/125V)

AEK7073-

(T1A L/250V)

AEK7073-

(T1A L/250V)

AEK7073-

(T1A L/250V)

REK1142-

(1A/125V)

REK1142-

(1A/125V)

AEK7072-

(T800mA L/250V)

AEK7072-

(T800mA L/250V)

AEK7072-

(T800mA L/250V)

REK1143-

(1.25A/125V)

REK1143-

(1.25A/125V)

AEK7073-

(T1A L/250V)

AEK7073-

(T1A L/250V)

AEK7073-

(T1A L/250V)

REK1143-

(1.25A/125V)

REK1143-

(1.25A/125V)

AEK7072-

(T800mA L/250V)

AEK7072-

(T800mA L/250V)

AEK7072-

(T800mA L/250V)

REK1144-

(1.6A/125V)

REK1144-

(1.6A/125V)

AEK7072-

(T800mA L/250V)

AEK7072-

(T800mA L/250V)

AEK7072-

(T800mA L/250V)

A

A

1/3 -

A

3/3

( )

AUDIO ASSY(AWX1113)

Q

Q

1/10 -

Q

10/10

( )

D-AMP_S ASSY

(AWX1210)

B

B

1/2 -

B

2/2

( )

DAC HIGH ASSY

(AWX1103)

Z

AA

AB

O

P

R

S

BUFFER GND ASSY

(AWX1156)

IR INTERFACE ASSY

(AWX1112)

PRIMARY ASSY

(AWX1136)

A-REG ASSY

(AWX1162)

D-DAC BRIDGE ASSY

(AWX1128)

PRE BRIDGE ASSY

(AWX1161)

FAN

CONNECT_S

ASSY

(AWX1130)

E

E

1/11 -

E

11/11

( )

DIGITAL MAIN ASSY

(AWX1199)

L

POWER SW ASSY

(SC-65 : AWX1135)

(SC-1527-K/ SC-1522-K : AWX1151)

M

ENCODER ASSY

(AWX1150)

ASSY

-K/

T

2/2

)

Y

)

J

2/2

18

SC-65

1

2 3 4

A

B

C

D

E

F

1

2 3 4

4.2 BLOCK DIAGRAM FOR AUDIO BLOCK

COAX2(SAT/CBL)

OPT IN1(TV)

OPT IN2(DVR/BDR)

COAX1(DVD)

DAC

AK4480EF

X5

TX1

LPF

JA2009

JA2010

JA2011

FRONT HDMI IN

MIC

DVR OUT

ZONE2 SW OUT

HP

SW DownMix

JA3471

JA8001

IC2701, IC2702

JA6701

JA2504

JA3476

ZONE3 OUT

JA6701

HEADPHONE

AMP

<<POWER AMP

<<AUDIO ZONE OUT>>

MIC Amp

IC3471

NJM4565MD

IC2011(FL,FR)

IC2012(C,SW)

IC2013(SL,SR)

IC2014(SBL,SBR)

IC2017(FHL,FHR)

IC2003(FL,FR)

IC2005(C,SW)

IC2006(SL,SR)

IC2007(SBL,SBR)

IC2018(FHL,FHR)

IC2451

(ZONE2)

LPF

I2S

A/D BUFFER

IC2401,2402

NJM4565MD

USB

JA8101

IC8003

HDMI EQ

CXB1443R

OPT OUT1

IC2801

NJM4565MD

JA2008

TUNER Module

IC2001

DIR&DIT

AK4118AEQ

IC2501

Selector /Volume / PRE Amp

IC2431

ADC

PCM1804DB

I2S(DATA)

I2S(BCK,LRCK)

(SBL,SBR)

(FL,FR,C,SW,SL,SR,FHL,FHR)

IC9204

MNP

DM860

IC9602

HDMI PORT

PROCESSER

SII9575CTUC

HDMI IN4

(VIDEO)

HDMI IN6

IC903

HDMI RX

SII9233ACTU

HDMI OUT1

IC9002

1st DSP

D808K013CPTP400

IC1609

HDMI

TRANSMITTER

SII9573CTUC

JA9603

JA9604

JA1601

HDMI IN7

JA9608

JA1602

HDMI OUT2

NETWORK

JA9202

IC9203

ETHERNET

PHYCEIVER

LAN8700C-AEZG

I2S

I2S

S/PDIF

I2S(FL,FR)

NOTE

SPDIF:SONY/Philips Digital Interface

I2S:The Inter-IC Sound

IC1815

ZONE2

USB,NET/USBDAC

SELECTOR

I2S

DSD

BD

JA9601

I2S(except FL,FR)

BT

S/PDIF

I2S

HDMI IN3

(DVR/BDR)

JA9602

HDMI IN2

(SAT/CBL)

JA9607

JA2102

IC9702

2nd DSP

D808K013CPTP400

ZONE2

ZONE2 OUT

JA6701

ZONE2 SW Amp

IC6701

NJM4565MD

IC6703

ZONE2

SELECTOR

IC6702

HPF

IC2471

ZONE2 DAC

AK4388ET

HDMI IN1

(DVD)

JA9606

I2S

I2S

USB DAC ASSY

(Not used)

USB

JA2102

IC5503

DA IC

CM6631

IC1814

SELECTOR

S/PDIF

I2S

DSD

IC1501

USB,NET/USBDAC

SELECTOR

IC1813

Port Process/RX

SELECTOR

A

B

C

E

I

Q

AUDIO ASSY

DAC HIGH ASSY

FRONT HDMI

USB ASSY

DIGITAL MAIN ASSY

MIC HP ASSY

D AMP S ASSY

I

MIC HP ASSY

19

SC-65

5

6 7 8

5

6 7 8

A

B

C

D

E

F

MIC

TV/SAT

VIDEO

CD

PHONO

PREOUT FL/FR

PREOUT SW1

PREOUT SL/SR

PREOUT SBL/SBR

DVR OUT

SP FL/FR

SP C

SP SL/SR

SP SBL/SBR

HP

SW DownMix

JA3471

IC2701, IC2702

JA2502

JA2504

SW PRE Amp

IC2751

<<POWER AMP>>

JA2504

JA3476

JA4101

JA4101

JA4301

JA4501

JA3101

JA3101

JA3201

JA3201

PREOUT C

JA3101

DVD

DVR

JA2501

JA2501

HEADPHONE

AMP

<<POWER AMP

INPUT BUFFER>>

IC6821,

IC6841

IC6801

IC6861,

IC6881

IC6901,

IC6921

<<PREOUT>>

MIC Amp

IC3471

NJM4565MD

NJM4565MD

IC2801

NJM4565MD

JA2503

JA2503

PREOUT FHL/FHR

JA3201

IC3221

PRE SELECTOR

SP FHL/FHR

JA4901

RY4500,RY5000

TUNER Module

IC3271

IC2501

Selector / Volume / PRE Amp

BD3473KS2

IC7491

LR

SELECTOR

SW PRE Amp

IC2751

NJM4565MD

JA3102

PREOUT SW2

PREOUT FWL/FWR

JA3202

IC3272

IC3273

Selector / Volume / PRE

Amp

BD3473KS2

IC7451,

IC7471

SP FWL/FWR

JA5101

ZONE2

ZONE3

ZONE2

ZONE3

I

N

Q

MIC HP ASSY

IR BUFFER

ASSY

D-AMP_S ASSY

I

MIC HP ASSY

20

SC-65

1

2 3 4

A

B

C

D

E

F

1

2 3 4

4.3 BLOCK DIAGRAM FOR DIGITAL MAIN VIDEO BLOCK

HDMI Rx

Silicon Image

"SiI9233"

PortProcessor

SiliconImage

"SiI9575"

Video Decoder

Analog

Devices

"ADV7181C"

Gate Array

SEIKO EPSON

"PE7008A"

LAN PHY

SMCS

"LAN8700"

Media Processor

BRIDGE CO

"DM860A"

SDRAM-166

256Mb(16Mx16)

FLASH ROM

1Gb

iPod

Authentication IC

"341S2162"

36.864MHz

28.63636MHz

27MHz

HDMI IN6

HDMI IN3

HDMI BDIN

HDMI IN1

HDMI IN2

HDMI

/IN5

/MHL

DDC

Buffer

COMPOSITE

COMPONENT

Pb

Pr

ETHERNET

More than VDEC 480p output

CK:27MHz-74.25MHz

/DT:16bit/DE,VS,HS

Y

24MHz

25MHz

HDMI IN7

CK:27MHz

/DT:BT656

BT

HDMI

SW

27MHz

HDMI IN4

27MHz

IC

IC9602

IC903

IC603

IC9206

IC9204

IC9205

IC9201

IC9203

IC909

IC9603

CEC

C

FRONT HDMI

USB ASSY

E

DIGITAL MAIN ASSY

G

H

COMPONENT ASSY

COMPOSITE ASSY

21

SC-65

5

6 7 8

5

6 7 8

A

B

C

D

E

F

IP.SCALER

Marvell

"88DE2750"

EVENT ucom

SANYO

"LC87F5NC8A"

(PDC203A8)

IC3001

SDRAM

256Mb

Gate Array

SEIKO EPSON

"PE7008A"

2162"

2

2

2

2

COMPONENT-Y

COMPOSITE

COMPONENT-Pb

COMPONENT-Pr

USB(FRONT)

HDMI OUT1

22.5792MHz

TMDS

DIGITAL VIDEO

CEC

ANALOG VIDEO

CLOCK

DIGITAL AUDIO

DDR2

512Mb

I2C

24.576MHz

20MHz

2nd DSP

D808K013CPTP400

SDRAM-166

64Mb(8Mx16)

SeriFlash

16Mb

20MHz

CK:27MHz

/DT:BT656

20MHz

PortProcessor

SiliconImage

"SiI9573"

HDMI Tx

Silicon Image

"SiI9136"

"EMMA2LL"

uCOMGUI

1st DSP

D808K013CPTP400

SDRAM-166

64Mb(8Mx16)

SeriFlash

16Mb

Nor FLASH

64Mb

27MHz

HDMI OUT2

SeriFlash

4Mb

IC101

IC1204

IC1212

IC1602

IC1609

IC1612

IC102IC103

IC9002 IC9702

IC9004

IC9001

IC9701

IC9703

27MHz

CEC

J

DISPLAY ASSY

C

FRONT HDMI USB ASSY

G

H

COMPONENT

ASSY

COMPOSITE

ASSY

POWER SUPPLY BLOCK Diagram

(DCDC,LDO)

22

SC-65

1

2 3 4

A

B

C

D

E

F

1

2 3 4

4.4 BLOCK DIAGRAM FOR DIGITAL MAIN AUDIO BLOCK

SEL

(VHC126)

IC1806

DIR

HDMI

Port

Processor

in

COAX 1

COAX 2

OPT 1

OPT 2

ADC

XTI

MCKO1

BCK2

LRCK2

SDTO2

DAUX

MSPDIF

COAX 3

OPT 3

OPT 4

D

AHCLK

ACLKR

AFSR0

AXR0[

AHCLK

ACLKR

AFSR

D1FDT

D1CDT

D1SDT

D1BW

D1HW

D1DM

I2S DT(multi-ch)

SOURCE-I2S(LR)

24MHz

z

NMP

BCo

BCK

LRCK

FD/DSDFL

CD/DSDLFE

SD/DSDC

BD/DSDSR

DSDSL

DSDFR

HDMI

RX

HDMI

Port

Processor

out

AMCLK

BCK

LRCK/DSDFR

FD/DSDFL

SD/DSDC

CD/DSDLFE

BD/DSDSR

SPDIF/DSDSL

AMCL

BCK

LRCK/DSDFR

FD/DSDFL

SD/DSDC

CD/DSDLFE

SPDIF/DSDS

BD/DSDSR

SPDIF/DSDSL

SEL (LCX157)

IC1813

XHDI2SRX

SEL (LCX157)

IC1506

D

SEL (7SZ125)

IC1507

IC1508

DSDFR

SD/DSDC

CD/DSDLFE

SPDIF/DSDSL

BD/DSDSR

SEL

(VHCT126)

IC1613

HDSPDIFRX

HDSPDIFP

DSPI2S

I2S-DATA

I2S-BCK

I2S-LRCK

XHDI2SRX

AND (SZ08)

IC1804

XXTL0

ZDB

24.576MHz

22.5792MHz

SEL

(VHC126)

IC1509

HDMCK

DIRMCK

NBCK

NLRCK

FD/DSDFL

DSDFR

BCK

LRCK

FD

SEL (LCX157)

IC1814

SEL (LCX157)

IC1501

NETMCK

ZNET

USBDMCK

AC

AF

AX

AH

AC

AF

AX

AX

AH

AC

AF

AX

AX

AX

AX

AX

AX

NBCK

NLRCK

DSDFR

FD/DSDFL

IC1609

IC903

IC9602

AND

(LCX08)

SEL (7SZ126)

IC9204

B

E

DAC HIGH A

DIGITAL MAI

23

SC-65

5

6 7 8

5

6 7 8

A

B

C

D

E

F

SEL

(VHC126)

IC1806

SPDIF

AMCLK

I2S

I2S-SURR

I2S-C/LFE

I2S-SRB/HEIGHT

I2S-FW/--

SYSCLK

ZONE-I2S (LR)

ZONE-AMCLK

20.0MHz

FLG

DAC

FL/FR

DAC

C/LFE

DAC

SL/SR

DAC

SBL/SBR

I2S-LR

I2S-C/LFE

I2S-SURR

I2S-SRB/

HEIGHT

Z2DAC

FL/FR

I2S-BCK

I2S-LRCK

I2S-LR

I2S-BCK

I2S-LRCK

I2S-DABCK

I2S-DALRCK

NETPOW

DIRPOW

DVCPOW

IC9702

2nd DSP

D808K013CPTP400

AHCLKR0

ACLKR0

AFSR0

AXR0[0]

AHCLKR1

ACLKR1

AFSR1

D1FDT AXR1[0]

D1CDT AXR1[1]

D1SDT AXR1[2]

D1BWDT AXR1[3]

D1HWDT AXR1[4]

D1DMDT AXR1[5]

DAC

FHL/FHR

RYAC

20.0MHz

IC9002

1st DSP

D808K013CPTP400

I2S BCK, LRCK

DAMCLK

AND (WZ08)

IC1802

24PQLS

22PQLS

DAZDB

NBCK

NLRCK

FD/DSDFL

DSDFR

BCK

LRCK

FD

AHCLKX0

ACLKX0

AFSX0

AXR0[7]D1FDT

AXR0[8]D1CDT

AXR0[9]D1SDT

AXR0[10]D1BWDT

AXR0[12]D1HWDT

AXR0[13]D1HWDT

AMUTE

AHCLKX0

ACLKX0

AFSX0

AXR0[7]D2FDT

AXR0[8]D2CDT

AXR0[9]D2SDT

AXR0[10]D2BWDT

AXR0[12]D2HWDT

AXR0[13]

AMUTE

ACLKR2

AFSR2

AXR2[0]

AHCLKR0

ACLKR0

AFSR0

AXR0[1]

AXR0[2]

AHCLKR1

ACLKR1

AFSR1

AXR1[0]

AXR1[1]

AXR1[2]

AXR1[3]

AXR1[4]

AXR1[5]

AND

(LCX08)

AND

(LCX08)

AND

(LCX08)

DAC HIGH ASSY

DIGITAL MAIN ASSY

24

SC-65

1

2 3 4

A

B

C

D

E

F

1

2 3 4

4.5 BLOCK DIAGRAM FOR COMPOSITE VIDEO BLOCK

IC8301

IC8401

*Not used

IC8501

EMMA

COMPOSITE

INPUT

COMPOSITE

OUTPUT

VDEC

OSD IC

PDC162A

FRONT VIDEO

DVD

TV/SAT

VIDEO

DVR/BDR

VIDEO AMP

NJM2505AF

iPod

ZONE3 OUT

ZONE2 OUT

MONITOR OUT

DVR/BDR OUT

95

94

93

92

91

89

88

87

83

82

81

79

77

75

75

75

VIDEO SW

NJW1327FU1

96

E

G

DIGITAL MAIN

ASSY

COMPONENT ASSY

25

SC-65

5

6 7 8

5

6 7 8

A

B

C

D

E

F

4.6 BLOCK DIAGRAM FOR COMPONENT VIDEO BLOCK

I2C

IC8301

IC8501

*Not used

*Not used

EMMA

IN 1

(DVD)

IN 3

(VIDEO)

IN 2

(DVR/BDR)

MONITOR OUT

ZONE 2 OUT

COMPONENT

INPUT

COMPONENT

OUTPUT

VDEC

LPF

LPF

LPF

CDET

VIDEO SW

NJW1327FU1

19

21

22

15

16

18

33

34

35

30

31

32

41

40

39

44

43

42

71

70

69

68

75

75

62

61

60

59

75

75

53

52

51

49

75

75

OSD IC

PDC162A

E

DIGITAL MAIN

ASSY

H

COMPONENT ASSY

26

SC-65

1

2 3 4

A

B

C

D

E

F

1

2 3 4

4.7 BLOCK DIAGRAM FOR POWER BLOCK (1)

IC9521

BD9328

V+3R3_NW

NETPOW5

IC9502

S-1172B12

V+1R2_NW

IC9401 IC9202

S-1170B50 BD2226G JA9201

Q9507

RTQ040P02

V+3R3_EM

IC9515

S-1172B15

V+1R5_EM

JA9605

IC9520

BD9328

DVCPOW

IC9508

S-1170B25

V+2R5_EM

IC9511

S-1170B50

V+5_HD

IC9522

BD9329

V+1R2_HD

IC9523

S-1172B12

V+1R2_HD

V+1R8_SC

Q9503

RZQ045P01

IC9501

S-1172B10

V+1R0_SC

IC9524

BD9328

V+5_HD

V+1R3_PP

V+5_HD

V+1R3_PP

SMPS

Other Circuits

V+5R6_EV

Refer to

MAIN Transformer part

IC9204

Network Media

Processor

DM860A

1.2V

LDO

2.5V

LDO

IC903

HDMI Rx

SiI9233ACTU

IC1602

HDMI Tx

SiI9136CTU

IC603

Gate Array

PE7008A

IC9602

HDMI Port

Processor

SiI9575CTUC

1.8V

DCDC

Converter

3.3V

DCDC

Converter

IC101

Main Processor

EMMA2LL

IC102

SDR SDRAM

IC103

NOR FLASH

5V

LDO

3.3

DCDC

Converter

IC1204

Scaler

88DE2750

IC909

Video Decoder

ADV7181CBSTZ

IC1212

DDR2 SDRAM

1.0V

LDO

FET SW

(1.8V)

5V

LDO

1.5V

LDO

IC1609

HDMI Port Processor

SiI9573CTUC

IC1612 Serial Flash

MX25L4006EM2I-12G

FET SW

(3.3V)

1.2V

LDO

1.3V

DCDC

Converter

V+3R3_HHH

V+5R6_EV(DDD)

V+1R8_HHH

V+3R3_DSP

5V

LOAD SW

+5V for

Wireless LAN

Converter

CN9501

JA8003

A

V+5R6_EV

V+5R6_EV

V+5R6_EV

C

E

R

FRONT HDMI

USB ASSY

DIGITAL MAIN ASSY

PRIMARY ASSY

V+5_EV JA9605

D9504

V+5R6_EV

27

SC-65

5

6 7 8

5

6 7 8

A

B

C

D

E

F

V+5_HD

V+1R3_PP

V+5_HD

V+1R3_PP

AAT4610BIGV-1

+5V

+5V

IC9510

NJM2846DL3-33

DIRPOW

IC9518

S-1172B12

V+1R2_D1

IC9514

S-1172B12

V+1R2_D2

IC9512

NJM2872BF33 X1801,1802

V+3R3_OS

IC9504

S-1170B50

V+5_DSP

V+5_D

V+3R3_D

NJM2872BF33

V+5_D JA2102

BT Connector

JA7002

EVENT CPU

V+5_EV

IC3001

IC9602

HDMI Port

Processor

SiI9575CTUC

IC2001

DIR +

Peripheral

AK4118AEQ

IC2***

DAC

AK4480EF

IC2431

A/D

Converter

3.3V

LDO

XTAL

Logic IC

5V

LDO

3.3V

LDO

IC9702

2ndDSP

D808K013CPTP400

IC9701

SDR SDRAM

1.2V

LDO

5V

LOAD SW

IC1609

HDMI Port Processor

SiI9573CTUC

IC1612 Serial Flash

MX25L4006EM2I-12G

IC9603

HDMI SW

PI3HDMI2310

IC9002

1stDSP

D808K013CPTP400

IC9001

SDR SDRAM

1.2V

LDO

DCDC

Converter

3.3V

LDO

V+3R3_DSP

5V

LOAD SW

JA1601

JA1602

IC1605

IC1610

HDMI OUT1

HDMI OUT2

CN9002

CN601

FFC

CN7901

5V

LDO

C

N

2

1

0

4

CN2101

IC8601

RS232C

IR

CN7802

CN602

CN7804

CN7004

CN8301

CN901

CN3784

CN3783

232POW

232POW

BTPOW

Power Supply for

RF Remote/Extention

V+5R6_EV

V+5R6_EV

CN7902

FFC

CN3001

V+5_EV V+5R6_EV

V+3R3_DA

IC2183

IC2181

V+5_DA

C

N

3

7

9

1

C

V+6_AD

5V

LOAD SW

3.3V

LDO

IC2015

NJM2845DL1-05

NJM2872BF33

F

G

J

U

INTERFACE ASSY

COMPONENT ASSY

DISPLAY ASSY

V-REG ASSY

W

Z

CONNECT ASSY

D-DAC BRIDGE ASSY

B

DAC HIGH ASSY

28

SC-65

1

2 3 4

A

B

C

D

E

F

1

2 3 4

4.8 BLOCK DIAGRAM FOR POWER BLOCK (2)

MAIN

Transformer

5

19

+

-

2

V-7_A

V+7_A

V+12TRG

RECTIFIER

D7241-7244

RECTIFIER

D7271-7274

IC7271

NJM78M08FA

IC7272

NJM79M08FA

RECTIFIER

D7251-7254

IC7251

NJM78M12FA

IC7252

NJM79M12FA

Q7211

Q7212

CN7201

8

RECTIFIER

D7201-7204

+

+

+

+

-

-

-

CN7241CN7271CN7291

FAN

-B+15V

V+8_MD

V-8_MD

V+FAN

V-FAN

V+12DF

V-12DF

RECTIFIER

D7400,7401

3

CN7400

+

-

+B

-B

CN4001CN4002CN4003

V+64V

V-64V

VSS+12V

V+5V

V-5V

V+12V

V-12V

V+12RY

V-12RY

V+12**

V-12**

CN3801,3802

CN6802,6803

CN3810-3890

CN4*00

V+7_A

V-7_A

CN7401

IC4*03

NJM2830U1-12

IC4008

NJM78M05DL1A

IC4009

NJM79M05DL1A

Driver IC VCC

CN5932

CN5931

IC7241

NJM78M15FA

FFC

CN3472

CN7663

CN7661

CN7011

CN7551

5

RECTIFIER

D7560

V+12

V-12

IC8701

NJM78M05FA

IC8702

NJM79M05FA

V-5

V+5

CN7552

IC7501

NJM78M12FA

RECTIFIER

C7557,

D7554,7551

V+12TR

V+7_A

V-7_A

RECTIFIER

D7557, D7558,

D7559

CN7010

FFC

CN4004

CN7251

V+12RY

V-12RY

CN6801

A

B

F

I

NP

Q

T

U

V

INTERFACE ASSY

MIC HP

ASSY

IR BUFFER

ASSY

IR INTERFACE

ASSY

D-AMP_S ASSY

IR REG ASSY

V-REG ASSY

VREG CHILD

ASSY

AB

FAN CONNECT_S ASSY

29

SC-65

5

6 7 8

5

6 7 8

A

B

C

D

E

F

RECTIFIER

D7501-7504

IC7501

NJM78M12FA

IC7502

NJM79M12FA

IC7521

NJM78M06FA

5

+

-

+

-

V+12A

V-12A

V+6_AD

2

for FL

Q3001

Q3002

Q3901

V+12_A

V-12_A

TUNER MODULE

CN3902

FFC

V+5_T

V+7_A

V-7_A

V-12_A

V+12_A

V+5_DA

IC2181

NJM2872BF33

V+3R3_DA

Q8401

Q8402

V+5_V

V-5_V

V+3_V

V-3_V

V+5_V V-5_V

CN8303

CN3601

CN3001

CN3792

CN3791

CN2104

CN8302

CN1722

V+5_V

+

FL_AC1,FL_AC2

-VF

V+5_V

IC2183

NJM2845DL1-05

RECTIFIER

D3651

+

V+5_USB

JA8001

USB +5V

Supply

CN3653

IC8004

BD9329EFJ

(DC-DC Conv.)

IC8001

TPS2557DRB

(Load SW)

V+UN_USB

CN3652

JA8001

IC8002

STMPS2171T

(Load SW)

HDMI V+5MHL

Supply

CN7551

5

RECTIFIER

D7560

V+12

V-12

IC8701

NJM78M05FA

IC8702

NJM79M05FA

V-5

V+5

CN7552

RECTIFIER

D7557, D7558,

D7559

CN7661

RECTIFIER

D7521,7522

CN7501

CN7502

CN3051

CN7502

CN6952

CN6951

V+6_AD

B

C

B

C

D

E

G

H

J

S

DAC HIGH ASSY

FRONT HDMI USB ASSY

USB RECT ASSY

DIGITAL MAIN

ASSY

COMPONENT ASSY

COMPOSITE ASSY

DISPLAY ASSY

A-REG ASSY

AA

PRE BRIDGE

ASSY

X

A-DAC

BRIDGE

ASSY

A

AUDIO ASSY

30

SC-65

1

2 3 4

A

B

C

D

E

F

1

2 3 4

5. DIAGNO SIS

5.1 DIAGNOSIS FLOWCHART

NO POWER

This is just for general reference and does not including every single case.

No Power

Error

Indications ?

Stand by

No

Yes

Yes

No

Refer to SM

"5.2 [4] Error Indications"

Other trouble.

FUSE FU4 OPEN ?

No

Yes

Diagnose or replace

PRIMARY ASSY

Check PRIMARY

ASSY JP51-1,2,3 pin

or DIGITAL MAIN

ASSY CN9501-1,2,3 pin

+5.6V

No

Yes

Check DIGITAL MAIN ASSY

CN9501 -1,2,3 pin +5.6V

No

Check +5.6V line on DIGITAL MAIN ASSY

or Replace DIGITAL MAIN ASSY

Yes

Check DISPLAY ASSY

CN3001-38,39 pin +5.6V

No

Replace FFC

(V-REG ASSY to DISPLAY ASSY)

Yes

Check DISPLAY ASSY

C3021 +3.3V

No

Replace DISPLAY ASSY

or replace D3008 or L3001

Yes

Check V-REG ASSY

CN7901-38,39 pin +5.6V

Replace FFC

(DIGITAL MAIN ASSY to V-REG ASSY)

No

Yes

Check V-REG ASSY

CN7902 -1,2 pin +5.6V

No

Replace V-REG ASSY

Yes

Check DISPLAY ASSY

X3001 oscillating

Check DISPLAY ASSY

L3001 +5V

No

Replace DISPLAY ASSY

or replace IC3003

Yes

No

Replace DISPLAY ASSY

Replace X3001

No

or

X3001 doesn't

oscilate

Replace IC3001

Yes

Check DISPLAY ASSY

IC3001 8 pin +5V

(XRESET)

No

Replace DISPLAY ASSY

or replace IC3002

Yes

Remove AC code and

remove CN9501. Insart

AC code and check

JP51-1,2,3 pin +5.6V?

Diagnose or replace

PRIMARY ASSY

No

Diagnose V+5R6_EV power supply

path after PRIMARY ASSY

Yes

A