Duke RBC-60 Operator’s Manual

OPERATION AND INSTALLATION MANUAL for

60” REFRIGERATED BACK COUNTER (RBC 60) DIGITAL

Please read this manual completely before attempting

to install, operate or service this equipment

Duke Manufacturing Company. All rights res erved.

trademark of the Duke Manufacturing Company.

Duke Manufacturing Company

2305 N. Broadway

www.dukemfg.com

RBC 60

RBC 48

48” REFRIGERATED BACK COUNTER (RBC 48) DIGITAL

This manual is Copyright ©2012

Reproduction without written permission is prohibited. Duke is a registered

Phone: [phone] Toll Free: 1-800-735-3853

St. Louis, MO 63102

Fax: [phone]

229917 1 10/03/16

IMPORTANT WARNING AND SAFETY INFORMATION

WARNING: READ THIS MANUAL THOROUGHLY BEFORE OPERATING,

INSTALLING OR PERFORMING MAINTENANCE ON THE EQUIPMENT.

FAILURE TO FOLLOW INSTRUCTIONS IN THIS MANUAL CAN CAUSE

PROPERTY DAMAGE, INJURY OR DEATH.

DO NOT STORE OR USE GASOLINE OR OTHER FLAMMABLE VAPORS

OR LIQUIDS IN THE VICINITY OF THIS OR ANY OTHER APPLIANCE.

UNLESS ALL COVER AND ACCESS PANELS ARE IN PLACE AND
PROPERLY SECURED, DO NOT OPERATE THIS EQUIPMENT.

CAUTION: OBSERVE THE FOLLOWING:

•

Minimum clearances must be maintained from all walls and combustible

materials.

• Keep the equipment area free and clear of combustible material.

• Adequate clearance for air openings.

• Unit exhausts air to the bottom and the rear.

• Do not set unit on a curb or seal to the wall.

• Do not block the slots in the front kickplate

• Operate equipment only on the type of electricity indicated on the

specification plate.

• Retain this manual for future reference.

229917 2 10/03/16

Table of Contents:

Introduction……………………………………………………………………………………………….. 4
Serial Number……………………………………………………………………………………………. 4
Receiving & Inspecting the Equipment……………………………………………………… 5
Specifications…………………………………………………………………………………………….. 5

Installation................................................................................................. 5

Location…………………………………………………………………………………………….. 5
Inside Unit…………………………………………………………………………………………. 6
Leveling…………………………………………………………………………………………….. 6
Stabilizing………………………………………………………………………………………….. 6
Electrical Connection…………………………………………………………………………. 6
Operation…………………………………………………………………………………………………… 7
Location of Controls………………………………………………………………………….. 7
Operating Procedure………………………………………………………………………… 7
Energy Mode Switch…………………………………………………………………………. 7

Maintenance.............................................................................................. 7
Stainless Steel care & Cleaning………………………………………………………….. 7
Cleaning the Condensor Coil……………………………………………………………… 8
Door Gasket Care………………………………………………………………………………. 9
Drain Maintenance……………………………………………………………………………. 9
Drain Pan Access……………………………………………………………………………….. 10

229917 3 10/03/16

Figure. 1
RBC 48

Figure. 2
RBC 60

INTRODUCTION

This publication contains information regarding the installation and operation of Duke Refriger-

ated Back Counter units. The information contained within applies to the models RBC 48 and

RBC 60. Please read this manual completely before attempting to install and/or operate this
equipment.

Model number RBC 48 describes the 48” wide version of the Refrigerated Back Counter. (Fig. 1)

Model number RBC 60 describes the 60” wide version of the Refrigerated Back Counter. (Fig. 2)

SERIAL NUMBER

Always have the serial number of your unit available when calling for parts or service.

229917 4 10/03/16