Aprilia SCARABEO 125 User Manual 2001
© 2001 aprilia s.p.a. - Noale (VE)
★
3!&%497!2.).'3
4%#(.)#!,
First edition: september 2001
Reprint:
Produced and printed by:
editing division
Soave (VERONA) - Italy
Tel. +39 - 045 76 11 911
Fax +39 - 045 76 12 241
E-mail: customer@stp.it
www.stp.it
On behalf of:
aprilia s.p.a.
via G. Galilei, 1 - 30033 Noale (VE) - Italy
Tel. +39 - 041 58 29 111
Fax +39 - 041 44 10 54
www.aprilia.com
The following precautionary warnings are
used throughout this manual in order to
convey the following messages:
Safety warning. When you find this
a
symbol on the vehicle or in the
manual, be careful to the potential risk
of personal injury. Non-compliance with
the indications given in the messages
preceded by this symbol may result in
grave risks for your and other people’s
safety and for the vehicle!
aWARNING
Indicates a potential hazard which may
result in serious injury or even death.
aCAUTION
Indicates a potential hazard which may
result in minor personal injury or damage to the vehicle.
NOTE The word “NOTE” in this manual
precedes important information or instructions.
The operations preceded by this
symbol must be repeated also on
the opposite side of the vehicle.
If not expressly indicated otherwise, for the
reassembly of the units repeat the disassembly operations in reverse order.
The terms “right” and “left” are referred to
the rider seated on the vehicle in the normal riding position.
7!2.).'3 02%#!54)/.3
'%.%2!,!$6)#%
Before starting the engine, carefully read
this manual and in particular the section
“SAFE DRIVE”.
Your and other people’s safety depends
not only on your quickness of reflexes and
on your agility, but also on what you know
about the vehicle, on its efficiency and on
your knowledge of the basic information for
“SAFE DRIVE”. Therefore, get a thorough
knowledge of the vehicle, in such a way as
to be able to drive in the traffic safely.
use and maintenance Scarabeo 125 - Scarabeo 150 - Scarabeo 200
2
NOTE This manual must be considered
as an integral part of the vehicle and must
always accompany it, even in case of resale.
aprilia has carried out this manual with the
maximum attention, in order to supply the
user with correct and updated information.
However, since aprilia constantly improves the design of its products, there may
be slight discrepancies between the characteristics of your vehicle and those described in this manual.
For any clarification concerning the information contained in this manual, do not hesitate to contact your aprilia Official Dea-
ler.
For control and repair operations not expressly described in this publication, for the
purchase of aprilia genuine spare parts,
accessories and other products, as well as
for specific advice, contact exclusively
aprilia Official Dealers and Service Centers, which guarantee prompt and accurate
assistance.
Thank you for choosing aprilia. We wish
you a nice ride.
All rights as to electronic storage, reproduction and total or partial adaptation, with
any means, are reserved for all Countries.
NOTE In some countries the antipollu-
tion and noise regulations in force require
periodical inspections.
The user of the vehicle in these countries
must:
– contact an aprilia Official Dealer to have
the non-homologated components repla-
ced with others homologated for use in
the country in question;
– carry out the required periodical inspec-
tions.
NOTE Soon after purchasing the vehi-
cle, write down the identification data indicated on the SPARE PARTS IDENTIFICATION LABEL in the table here below. The
label is stuck to the right upper tube of the
frame; to read it, it is necessary to remove
the central fairing, see see p. 47 (REMOVING THE CENTRAL FAIRING)
These data indicate:
– YEAR = year of manufacture (Y, 1, 2, ...);
– I.M. = modification code (A, B, C, ...);
– COUNTRY CODES = homologation
country (I, UK, A, ...).
and are to be supplied to the aprilia Official Dealer as reference data for the purchase of spare parts or specific accessories of the model you have acquired.
use and maintenance Scarabeo 125 - Scarabeo 150 - Scarabeo 200
In this manual the various versions are indicated by the following symbols:
125 cm3 model
z
150 cm3 model
{
200 cm3 model
Ù
automatic light switching version
e
(Automatic Switch-on Device)
optional
m
VERSION:
Italy
I
United Kingdom
U
Austria
a
Portugal
p
Finland
F
Belgium
B
Germany
d
France
f
Spain
E
Greece
G
Holland
O
Switzerland
Y
Denmark
D
Japan
J
Singapore
S
Slovenia
s
Israel
i
South Korea
¬
Malaysia
M
Chile
c
Croatia
H
Australia
A
United States
u
of America
Brazil
Ä
South Africa
R
New Zealand
n
Canada
C
3
4!",%/&#/.4%.43
SAFE DRIVE ......................................................... 5
BASIC SAFETY RULES ..................................... 6
CLOTHING ......................................................... 9
ACCESSORIES ................................................ 10
LOAD ................................................................ 10
ARRANGEMENT OF THE MAIN ELEMENTS ... 12
ARRANGEMENT
OF THE INSTRUMENTS/CONTROLS ............... 14
INSTRUMENTS AND INDICATORS .................. 14
INSTRUMENTS AND INDICATORS TABLE.... 15
MAIN INDEPENDENT CONTROLS ................... 16
CONTROLS ON THE LEFT SIDE
OF THE HANDLEBAR...................................... 16
CONTROLS ON THE RIGHT SIDE
OF THE HANDLEBAR...................................... 17
IGNITION SWITCH........................................... 18
STEERING LOCK............................................. 18
AUXILIARY EQUIPMENT ................................... 19
DIGITAL CLOCK............................................... 19
BAG HOOK ....................................................... 19
ANTI-THEFT HOOK ......................................... 20
UNLOCKING / LOCKING THE SADDLE.......... 20
CRASH HELMET CASE ................................... 20
GLOVE COMPARTMENT ................................ 21
ADJUSTABLE PASSENGER SEAT................. 21
TOOL KIT ......................................................... 21
MAIN COMPONENTS......................................... 22
FUEL................................................................. 22
LUBRICANTS ................................................... 23
BRAKE FLUID-recommendations..................... 24
DISC BRAKES .................................................. 24
COOLANT......................................................... 26
TYRES .............................................................. 28
AUTOMATIC
LIGHT SWITCHING VERSION
EXHAUST SILENCER ...................................... 29
INSTRUCTIONS FOR USE................................. 30
PRELIMINARY CHECKING OPERATIONS .....30
STARTING ........................................................ 31
DEPARTURE AND DRIVE ............................... 33
_ .................. 29
RUNNING-IN .....................................................35
STOPPING ........................................................35
PARKING ..........................................................35
POSITIONING THE VEHICLE
ON THE STAND................................................36
SUGGESTIONS TO PREVENT THEFT ...........37
MAINTENANCE...................................................37
REGULAR SERVICE INTERVALS CHART......38
IDENTIFICATION DATA ...................................40
CHECKING THE ENGINE OIL LEVEL
AND TOPPING UP............................................41
AIR CLEANER ..................................................42
CHECKING THE BRAKE PAD WEAR..............43
CHECKING THE STAND ..................................44
INSPECTING THE FRONT
AND REAR SUSPENSIONS .............................44
ADJUSTING THE REAR SUSPENSION ..........45
CHECKING THE STEERING ............................46
CHECKING THE ENGINE FULCRUM AXIS .....46
REMOVING THE CENTRAL
INSPECTION COVER.......................................47
REMOVING THE CENTRAL FAIRING .............47
REMOVING THE REAR-VIEW MIRRORS .......48
REMOVING THE FRONT COVER ...................48
REMOVING
THE FRONT INSPECTION COVER .................49
REMOVING THE CRASH HELMET CASE.......49
REMOVING THE
FRONT PART OF THE FAIRING......................49
IDLING ADJUSTMENT .....................................50
ADJUSTING
THE ACCELERATOR CONTROL.....................50
SPARK PLUG ...................................................51
BATTERY ..........................................................52
LONG INACTIVITY OF THE BATTERY............52
EXTRACTING THE BATTERY CASE...............53
CHECKING AND CLEANING
THE TERMINALS..............................................53
REMOVING THE BATTERY .............................53
CHECKING
THE ELECTROLYTE LEVEL ............................54
RECHARGING THE BATTERY ........................ 54
INSTALLING THE BATTERY ........................... 54
CHANGING THE FUSES ................................. 55
CHECKING THE SWITCHES ........................... 56
VERTICAL ADJUSTING OF THE
HEADLIGHT BEAM .......................................... 56
BULBS .............................................................. 57
CHANGING THE
DIRECTION INDICATOR BULBS..................... 57
CHANGING THE HEADLIGHT BULBS ............ 58
CHANGING THE REAR LIGHT BULB ............. 59
NUMBER PLATE BULB.................................... 59
TRANSPORT ...................................................... 60
DRAINING THE FUEL TANK ........................... 60
CLEANING .......................................................... 61
LONG PERIODS OF INACTIVITY.................... 62
TECHNICAL DATA .............................................63
WIRING DIAGRAM Scarabeo 125 -
Scarabeo 150 - Scarabeo 200 ......................... 66
WIRING DIAGRAM KEY Scarabeo 125 -
Scarabeo 150 - Scarabeo 200 ......................... 67
LUBRICANT CHART ........................................ 68
Importers ...................................................... 70-71
use and maintenance Scarabeo 125 - Scarabeo 150 - Scarabeo 200
4
safe drive
"!3)#3!&%4925,%3
To drive the vehicle it is necessary to be in
possession of all the requirements prescribed by law (driving licence, minimum
age, psychophysical ability, insurance,
state taxes, vehicle registration, number
plate, etc.).
Gradually get to know the vehicle by driving it first in areas with low traffic and/or private areas.
use and maintenance Scarabeo 125 - Scarabeo 150 - Scarabeo 200
6
The use of medicins, alcohol and drugs or
psychotropic substances notably increases
the risk of accidents.
Be sure that you are in good psychophysical conditions and fit for driving and pay
particular attention to physical weariness
and drowsiness.
Most road accidents are caused by the
driver’s lack of experience.
NEVER lend the vehicle to beginners and,
in any case, make sure that the driver has
all the requirements for driving.
Rigorously observe all road signs and national and local road regulations.
Avoid abrupt movements that can be dangerous for yourself and other people (for
example: rearing up on the back wheel,
speeding, etc.), and give due consideration
to the road surface, visibility and other driving conditions.
Avoid obstacles that could damage the vehicle or make you lose control.
Avoid riding in the slipstream created by
preceding vehicles in order to increase
your speed.
Always keep both hands on the handlebars
and both feet on the footboard (or on the
footrests), in the correct driving posture.
Avoid standing up or stretching your limbs
while driving.
use and maintenance Scarabeo 125 - Scarabeo 150 - Scarabeo 200
7
OIL
COOLER
The driver should pay attention and avoid
distractions caused by people, things and
movements (never smoke, eat, drink, read,
etc.) while driving.
use and maintenance Scarabeo 125 - Scarabeo 150 - Scarabeo 200
8
Use only the vehicle’s specific fuels and lubricants indicated in the "LUBRICANT
CHART"; check all oil, fuel and coolant levels regularly.
If the vehicle has been involved in an accident, make sure that no damage has occurred to the control levers, pipes, wires,
braking system and vital parts.
If necessary, have the vehicle inspected by
an aprilia Official Dealer, who should carefully check the frame, handlebars, suspensions, safety parts and all the devices that
you cannot check by yourself.
Always remember to report any malfunction to the technicians to help them in their
work.
Never use the vehicle when the amount of
damage it has suffered endangers your
safety.
ONLY ORIGINALS
A12
345
Never change the position, inclination or
colour of: number plate, direction indicators, lights and horns.
Any modification of the vehicle will result in
the invalidity of the guarantee.
Any modification of the vehicle and/or the
removal of original components can compromise vehicle performance levels and
safety or even make it illegal.
We recommend respecting all regulations
and national and local provisions regarding
the equipment of the vehicle.
In particular, avoid all modifications that increase the vehicle’s performance levels or
alter its original characteristics.
Never race with other vehicles.
Avoid off-road driving.
use and maintenance Scarabeo 125 - Scarabeo 150 - Scarabeo 200
#,/4().'
Before starting, always wear a correctly
fastened crash helmet. Make sure that it is
homologated, in good shape, of the right
size and that the visor is clean.
Wear protective clothing, preferably in light
and/or reflecting colours.
In this way you will make yourself more visible to the other drivers, thus notably reducing the risk of being knocked down, and
you will be more protected in case of fall.
This clothing should be very tight-fitting
and fastened at the wrists and ankles.
Strings, belts and ties should not be hanging loose; prevent these and other objects
from interfering with driving by getting entangled with moving parts or driving mechanisms.
9
Do not keep objects that can be dangerous
in case of fall, for example pointed objects
like keys, pens, glass vials etc. in your
pockets (the same recommendations also
apply to passengers).
use and maintenance Scarabeo 125 - Scarabeo 150 - Scarabeo 200
10
!##%33/2)%3
The owner of the vehicle is responsible for
the choice, installation and use of any accessory.
Avoid installing accessories that cover
horns or lights or that could impair their
functions, limit the suspension stroke and
the steering angle, hamper the operation of
the controls and reduce the distance from
the ground and the angle of inclination in
turns.
Avoid using accessories that hamper access to the controls, since this can prolong
reaction times during an emergency.
Big fairings and windshields installed on
the vehicle may produce aerodynamic forces that affect the stability of the vehicle, especially when riding at high speed.
Make sure that the equipment is well fastened to the vehicle and not dangerous
during driving. Do not install electrical devices and do not modify those already existing to avoid electrical overloads, because the vehicle could suddenly stop or
there could be a dangerous current shortage in the horn and in the lights.
aprilia recommends the use of "aprilia
genuine accessories".
,/!$
Be careful and moderate when loading
your luggage. Keep any luggage loaded as
close as possible to the center of gravity of
the vehicle and distribute the load uniformly on both sides, in order to reduce umbalance to the minimum. Furthermore, make
sure that the load is firmly secured to the
vehicle, especially during long trips.
KG!
Avoid hanging bulky, heavy and/or dangerous objects on the handlebars, mudguards
and forks: the vehicle might respond more
slowly in turns and its manoeuvrability
could be unavoidably impaired.
Do not place bags that are too bulky on the
vehicle sides, because they could hit people or obstacles, making you lose control of
the vehicle.
Do not carry any bag if it is not tightly secured to the vehicle.
Do not carry bags which protrude too much
from the luggage-rack or which cover the
lights, horn or indicators.
Do not carry animals or children on the
glove compartment or on the luggagerack.
use and maintenance Scarabeo 125 - Scarabeo 150 - Scarabeo 200
Do not exceed the maximum load allowed
for each side-bag.
When the vehicle is overloaded, its stability
and its manoeuvrability can be compromised.
11
!22!.'%-%.4/& 4(% -!).%,%-%.43
+%9
1) Fuse carrier
2) Battery
3) Left rear-view mirror
4) Rear brake reservoir
5) Bag hook
6) Coolant expansion tank plug
7) Expansion tank
8) Air cleaner
9) Anti-theft hook (for the aprilia “BodyGuard” armored cable
10) Centre stand
11) Side stand
12) Passenger left footrest
13) Spark plug
14) Front inspection cover
&)
& (series Ù)
use and maintenance Scarabeo 125 - Scarabeo 150 - Scarabeo 200
12
+%9
1) Crash helmet case
2) Passenger grab rail
3) Passenger seat
4) Fuel tank
5) Filler cap
6) Front brake reservoir
7) Ignition switch / steering lock / saddle
unlocking device
8) Glove compartment
9) Central inspection cover
10) Right rear-view mirror
11) Horn
12) Central fairing
13) Engine oil filling/level cap
14) Passenger right footrest
use and maintenance Scarabeo 125 - Scarabeo 150 - Scarabeo 200
13
!22!.'%-%.4/&4(%).3425-%.43#/.42/,3
).3425-%.43!.$ ).$)#!4/23
+%9
1) Electrical controls on the left side of the handlebar
2) Rear brake lever
3) Front brake lever
4) Throttle grip
5) Electrical controls on the right side of the handlebar
6) Instruments and indicators
7) Ignition switch / steering lock (
device (OPEN)
use and maintenance Scarabeo 125 - Scarabeo 150 - Scarabeo 200
14
n - m - s) / saddle unlocking
+%9
1) Fuel level indicator ( g )
2) Total kilometres odometer
3) Digital clock
4) Digital clock function and setting push buttons
5) Speedometer
5) Speedometer – km/h scale only
6) Coolant temperature indicator ( h )
7) Green right direction indicator warning light ( l )
8) Green low beam warning light (
9) Blue high beam warning light (
10) Red engine oil pressure warning light (j )
11) Amber low fuel warning light (
12) Green left direction indicator warning light (k )
^
b)
a )
g )
).3425-%.43!.$).$)#!4/234!",%
Description Function
Right direction indicator
warning light
Left direction indicator
warning light
Engine oil pressure
warning light
Total kilometres odometer It indicates the total number of kilometres covered.
Speedometer It indicates the driving speed.
High beam warning light
Low beam warning light
Low fuel warning light
Fuel level indicator
Digital clock
Coolant temperature
indicator
l It blinks when the right direction indicator is on.
k It blinks when the left direction indicator is on.
It comes on every time the ignition switch is brought to position “n” and the engine is not running, thus testing
the correct operation of the bulb. If during this phase the lamp does not turn on, it must be replaced.
The warning light must go off when the engine is running.
j
aCAUTION
ately stop the engine and contact your
It comes on when the headlight is in “high beam” position or when the high beam signaller is operated
a
(PASSING
)
.
k
If the warning light comes on during the normal running of the engine, this
means that the oil pressure in the circuit is insufficient. In this case, immedi-
APRILIA
b It comes on when the headlight is in low beam position.
g It comes on when the quantity of fuel left in the tank is about 2 L.
It indicates the approximate fuel level in the tank.
When the pointer reaches the red area, the quantity of fuel left in the tank is about 2
g
In this case, top up as soon as possible, see p. 22 (FUEL).
Hour, date and seconds can be shown on the display, see p. 19 (DIGITAL CLOCK).
It indicates the approximate temperature of the coolant in the engine.
When the pointer starts moving beyond level "min", the temperature is sufficient for driving the vehicle.
The normal running temperature range is indicated by the central area of the scale.
h
If the pointer reaches the red area, stop the engine and check the coolant level, see p. 26 (COOLANT).
aCAUTION
If the maximum allowed temperature is exceeded (red area "max" of the
scale), the engine may be seriously damaged.
Official Dealer.
L.
use and maintenance Scarabeo 125 - Scarabeo 150 - Scarabeo 200
15
-!).).$%0%.$%.4 #/.42/,3
#/.42/,3/.4(%,%&43)$%/&4(%(!.$,%"!2
NOTE The electrical parts work only when the ignition switch is
in position “
1) HORN PUSH BUTTON (
The horn is activated when the "
2) DIRECTION INDICATOR SWITCH (
To indicate the turn to the left, move the switch to the left; to
indicate the turn to the right, move the switch to the right.
To turn off the direction indicator, press the switch on its centre.
3) DIMMER SWITCH (
PUSH BUTTON (PASSING )
When the light switch is in position “
is in position “a”, the high beam comes on, while if it is in position “
The high beam signaller is operated by pressing the dimmer
switch to position (PASSING ), independently of the position of the light switch (
n”.
f )
f" push button is pressed.
c )
b - a ) / HIGH BEAM SIGNALLER
k
o”: if the dimmer switch
b”, the low beam comes on.
k
o - p - • ).
NOTE When the dimmer switch is released, the high beam
signaller is disconnected.
use and maintenance Scarabeo 125 - Scarabeo 150 - Scarabeo 200
16
#/.42/,3/.4(%2)'(43)$%
/&4(%(!.$,%"!2
NOTE The electrical parts work only when the ignition switch is
in position "
1) LIGHT SWITCH (
n".
o - p -
) (_ not provided)
•
aCAUTION
Before operating the light switch, make sure that the dimmer switch ( b - a ) is in position “b”.
When the light switch is in position “
the switch is in position “
board light are on; when the switch is in position “
parking lights, the dashboard light and the low beam are on.
The high beam can be operated by means of the dimmer
switch (
2) START PUSH BUTTON (
When the start push button “r” is pressed, the starter makes
the engine run. For the starting, see p. 31 (STARTING).
3) ENGINE STOP SWITCH (
a - b).
p”, the parking lights and the dash-
r )
n - m)
”, the lights are off; when
•
o”, the
aWARNING
Do not operate the engine stop switch “n - m” in running
conditions.
This is a safety or emergency switch. With the switch in po-
n”, it is possible to start the engine; the engine can
sition “
be stopped by moving the switch to position “
m”.
aCAUTION
With stopped engine and ignition switch in position “n”,
the battery may run down.
When the vehicle has come to a halt, stop the engine, and
move the ignition switch to position “
m”.
use and maintenance Scarabeo 125 - Scarabeo 150 - Scarabeo 200
17
◆
Press the key (2) and turn it anticlockwise (to the left), then steer the handlebar slowly, until the key (2) reaches posi-
m”.
tion “
◆
Extract the key.
)'.)4)/.37)4#(
The ignition switch (1) is positioned on the
right side, near the steering column.
NOTE The key (2) operates the ignition
switch / steering lock, the saddle lock and
the glove compartment lock.
Two keys are supplied together with the
vehicle (one spare key).
NOTE Do not keep the spare key on the
vehicle.
34%%2).',/#+
aWARNING
Never turn the key to position "s" in running conditions, in order to avoid losing
control of the vehicle.
OPERATION
To lock the steering:
◆
Turn the handlebar completely leftwards.
◆
Turn the key (2) to position “m”.
aWARNING
The simple turning of the key, without
any pressure, operates the saddle lock
and not the steering lock.
NOTE Turn the key and steer the han-
dlebar at the same time.
Position Function
The steering is
locked.
s
Steering
lock
m
n
It is neither
possible to
start the
engine, nor
to switch on
the lights.
Neither the
engine, nor
the lights
can be
switched on.
The engine
and the
lights can be
switched on.
Key
removal
It is possible
to remove the
key.
It is possible
to remove the
key.
It is not possible to remove
the key.
use and maintenance Scarabeo 125 - Scarabeo 150 - Scarabeo 200
18
!58),)!29%15)0-%.4
$)')4!,#,/#+
Function description:
◆
Normal display: hours and minutes.
◆
Date display: press the push button (1)
once to display month and day.
◆
Second display: press the push button
(1) twice to display the seconds.
NOTE To replace the clock battery, con-
tact an aprilia Official Dealer.
Setting:
◆
Press the push button (2) once: date and
time will be displayed alternately.
◆
Month: press the push button (2) again
and the month will be displayed on the
left (the rest disappears).
Press the push button (1) to set the desired month.
◆
Day: press the push button (2) again and
the day will be displayed on the right.
Press the push button (1) to set the desired day.
◆
Time: press the push button (2) again
and the time will be displayed on the left
with letter "A" or "P" (A = AM, P = PM).
◆
Minutes: press the push button (2) again
and the minutes will be displayed on the
right. Press the push button (1) to set the
desired minutes.
Now the clock is set.
Press the push button (2) and then the
push button (1), again to return to normal
functioning.
use and maintenance Scarabeo 125 - Scarabeo 150 - Scarabeo 200
"!'(//+
aWARNING
Do not hang excessively bulky bags or
parcels to the hook, as this may seriously compromise the manoeuvrability
of the vehicle or the movement of your
feet.
The bag hook (3) is positioned on the front
part of the inner shield
Max. allowed weight: 1,5 kg
19
!.4)4(%&4(//+
The anti-theft hook (1) is positioned on the
left side of the vehicle, near the passenger
footrest.
To prevent the vehicle from being stolen, it
is advisable to secure it with the aprilia
“Body-Guard” armored cable
able at any aprilia Official Dealer.
& (2), avail-
aCAUTION
Do not use the hook to lift the vehicle or
for any purpose other than securing the
vehicle once it has been parked.
use and maintenance Scarabeo 125 - Scarabeo 150 - Scarabeo 200
20
5.,/#+).',/#+).'
4(%3!$$,%
OPERATION
To unlock the saddle, proceed as follows:
◆
Position the vehicle on the centre stand.
◆
Insert the key in the ignition switch /
steering lock.
NOTE Turn the key (3) without pressing it.
◆
Turn the key (3) anticlockwise until you
hear the snap that indicates that the lock
is open.
◆
Turn the key back to position “m”.
◆
Raise the saddle (4).
◆
To lock the saddle, lower and press it
(without exerting too much pressure),
thus making the lock snap shut.
aWARNING
Before leaving, make sure that the saddle is properly locked.
#2!3((%,-%4#!3%
Thanks to the crash helmet case, you
needn’t carry the helmet or other encumbering objects with you every time you park
the vehicle. To reach the crash helmet
case, proceed as follows:
◆
Insert the key (5) in the lock.
◆
Turn the key (5) anticlockwise.
◆
Raise the lock unit (6).
◆
Raise and open the cover (7).
NOTE The case can contain one crash
helmet:
Two keys are supplied together with the
vehicle (one spare key).
NOTE Do not keep the spare key on the
vehicle.
aWARNING
Do not overload the crash helmet case.
Maximum allowed weight: 3 kg
',/6%#/-0!24-%.4
It is placed under the handlebar, on the inner part of the shield.
To reach it:
◆
Introduce the ignition key (1) in the lock.
◆
Turn the key clockwise, pull it and open
the door (2).
aCAUTION
Before locking the door, make sure that
you have not left the key in the glove
compartment.
To lock the door (6), raise and press it. It is
not necessary to use the key.
Maximum allowed weight: 1.5 kg.
!$*534!",%0!33%.'%23%!4
The passenger seat (3) can be adjusted
longitudinally in three different positions:
– completely forward (A);
– standard (B);
– completely backward (C).
For the adjustment, proceed as follows:
◆
Raise the saddle, see p. 20 (UNLOCKING / LOCKING THE SADDLE).
aCAUTION
Do not adjust the special screw (5) for
any reason whatsoever. Tampering with
this screw is extremely dangerous.
◆
Loosen the screws (4).
◆
Move the seat (3) to the desired position.
◆
Tighten the screws (4).
4//,+)4
The tool kit (6) is fixed in the appropriate
compartment under the saddle;
to reach it, proceed as follows:
◆
Raise the saddle, see p. 20 (UNLOCKING / LOCKING THE SADDLE).
The tool kit includes:
– 4 mm hexagon spanner;
– 16 mm spark plug socket spanner;
– socket spanner rod;
– 8/10 mm socket spanner;
– double-ended, cross-/cut-headed
screwdriver;
– square pin spanner;
– tool case.
use and maintenance Scarabeo 125 - Scarabeo 150 - Scarabeo 200
21
-!).#/-0/.%.43
&5%,
aWARNING
The fuel used for internal combustion
engines is extremely inflammable and
in particular conditions it can become
explosive. It is important to carry out
the refuelling and the maintenance operations in a well-ventilated area, with
the engine off. Do not smoke while refuelling or near fuel vapours, in any case
avoid any contact with naked flames,
sparks and any other heat source to
prevent the fuel from catching fire or
from exploding. Further, prevent fuel
from flowing out of the fuel filler, as it
could catch fire when getting in contact
with the red-hot surfaces of the engine.
In case some fuel has accidentally been
spilt, make sure that the area is completely dry before starting the vehicle.
Since petrol expands under the heat of
the sun and due to the effects of sun radiation, never fill the tank to the brim.
Screw the cap carefully after refuelling.
Avoid any contact of the fuel with the
skin and the inhalation of vapours; do
not swallow fuel or pour it from a receptacle into another by means of a tube.
DO NOT DISPOSE OF FUEL IN THE ENVIRONMENT.
KEEP AWAY FROM CHILDREN.
Use only leaded (4 Stars
premium grade petrol, min. O.N. 95
(N.O.R.M.) and 85 (N.O.M.M.).
FUEL TANK CAPACITY
(reserve included): 9
TANK RESERVE: 2 L
U) or unleaded
L
To reach the filler cap, proceed as follows:
◆
Raise the saddle, see p. 20 (UNLOCKING / LOCKING THE SADDLE).
◆
Unscrew the filler cap (1).
use and maintenance Scarabeo 125 - Scarabeo 150 - Scarabeo 200
22
Loading...