Whirlpool GBD277PDT, GBD277PDS, GBD277PDB, KEBC277KWH, KEBC277KSS Installation Instructions

INSTALLATION INSTRUCTIONS

27" (68.6 CM) ELECTRIC SINGLE AND DOUBLE

BUILT-IN OVEN

Table of Contents
BUILT-IN OVEN SAFETY.................................	1
INSTALLATION REQUIREMENTS..................	2
Tools and Parts .............................................	2
Location Requirements .................................	2
Electrical Requirements ................................	4
INSTALLATION INSTRUCTIONS....................	4
Prepare Built-In Oven....................................	4
Remove Oven Trim........................................	4
Make Electrical Connection ..........................	5
Install Oven....................................................	7
Complete Installation.....................................	8

BUILT-IN OVEN SAFETY

Your safety and the safety of others are very important.

We have provided many important safety messages in this manual and on your appliance. Always read and obey all safety messages.

This is the safety alert symbol.

This symbol alerts you to potential hazards that can kill or hurt you and others.

All safety messages will follow the safety alert symbol and either the word “DANGER” or “WARNING.” These words mean:

DANGER

WARNING

You can be killed or seriously injured if you don't immediately follow instructions.

You can be killed or seriously injured if you don't follow instructions.

All safety messages will tell you what the potential hazard is, tell you how to reduce the chance of injury, and tell you what can happen if the instructions are not followed.

IMPORTANT:

Save for local electrical inspector's use.

W10045000

INSTALLATION REQUIREMENTS

Tools and Parts

Gather the required tools and parts before starting installation. Read and follow the instructions provided with any tools listed here.

Tools needed

	■	Phillips screwdriver	■ Hand or electric drill
	■	Measuring tape	(for wall cabinet installations)
			■ 1" (25 mm) drill bit
		Level
	■		(for wall cabinet installations)

Parts needed

■UL listed or CSA approved conduit connector

■UL listed wire connectors

Parts supplied

■# 8–14 x 1" screws - single oven (2), double oven (4)

■Bottom vent (supplied on some models)

■Two # 8–18 x ³⁄" screws - bottom vent (supplied on some models)

Check local codes. Check existing electrical supply. See “Electrical Requirements.”

It is recommended that all electrical connections be made by a licensed, qualified electrical installer.

Location Requirements

IMPORTANT: Observe all governing codes and ordinances.

■Cabinet opening dimensions that are shown must be used. Given dimensions provide minimum clearance with oven.

■Recessed installation area must provide complete enclosure around the recessed portion of the oven.

■Grounded electrical supply is required. See “Electrical Requirements” section.

■Electrical supply junction box should be located 3" (7.6 cm) maximum below the support surface when the oven is installed in a wall cabinet. A 1" (2.5 cm) minimum diameter hole should have been drilled in the right rear or left rear corner of the support surface to pass the appliance cable through to the junction box.

NOTE: For undercounter installation, it is recommended that the junction box be located in the adjacent right or left cabinet. If you are installing the junction box on rear wall behind oven, the junction box must be recessed and located in the upper or lower right or left corner of the cabinet; otherwise, the oven will not fit into the cabinet opening.

■Oven support surface must be solid, level and flush with bottom of cabinet cutout. Floor must be able to support a single oven weight of 140 lbs (63.5 kg) or a double oven weight of 245 lbs (111.1 kg).

Undercounter Installation (with cooktop installed above):

Ovens approved for this type of installation have an approval label located on the top of the oven. Refer to undercounter installation instructions for cutout dimensions and approved oven cooktop combinations (separate sheet).

Product Dimensions - Single Oven

A

B

E

D C

A.25³⁄ " (64.5 cm) max. recessed width

B.29" (73.7 cm) max. overall height

C.26³⁄ " (67.9 cm) overall width

D.23" (58.4 cm) max. recessed depth

E.27¹⁄ " (69.9 cm) recessed height

Cabinet Dimensions - Single Oven

Single Oven Undercounter (without cooktop installed above)

A B

E

D

C

A.27" (68.6 cm) min. cabinet width

B.1¹⁄ " (3.8 cm) min. top of cutout to underside of countertop

C.5¹⁄ " (13.3 cm) bottom of cutout to floor

D.25¹⁄ " (64.8 cm) cutout width

E.27³⁄ " (70.5 cm) min. cutout height

2

Single Oven Installed in Cabinet

A

	B
F	D
	E
	C

A.27" (68.6 cm) min. cabinet width

B.1" (2.5 cm) top of cutout to bottom of upper cabinet door

C.32" (81.3 cm) bottom of cutout to floor

D.25¹⁄ " (64.8 cm) cutout width

E.1¹⁄ " (3.8 cm) min. bottom of cutout to top of cabinet door

F. 27³⁄ " (70.5 cm) min. cutout height

Product Dimensions - Double Oven

A

B

E

D	C

A.25³⁄ " (64.5 cm) max. recessed width

B.51" (129.5 cm) max. overall height

C.26³⁄ " (67.9 cm) overall width

D.23" (58.4 cm) max. recessed depth

E.49¹⁄ " (125.7 cm) recessed height

Cabinet Dimensions - Double Oven

Double Oven Installed in Cabinet

	A
	B
F	D
	E
	C

A.27" (68.6 cm) min. cabinet width

B.1" (2.5 cm) top of cutout to bottom of upper cabinet door

C.14³⁄ " (37.5 cm) bottom of cutout to floor

D.25¹⁄ " (64.8 cm) cutout width

E.1¹⁄ " (3.8 cm) min. bottom of cutout to top of cabinet door

F. 49³⁄ " (126.4 cm) min. cutout height

Cabinet Side View - Double or Single Oven

	A
	B
E	C
	D

A.23¹⁄ " (59.1 cm) min. cutout depth

B.23" (58.4 cm) recessed oven depth

C.Oven front

D.Recessed oven

E.Cabinet

3