Renault Dxi 13 Repair Manual
Andrew Burrows Key / Diagram 14/02/16
Group 0 - Electronics
Polarity N° Designation
0010 Communication bus J1587-1 (+ signal)
0011 Communication bus J1587-1 (- signal)
0012 Communication bus J1939-1 (+ signal)
0013 Communication bus J1939-1 (- signal)
0014 Not assigned
0015 Radio remote control
0016 Radio remote control
0017 Radio remote control
0018 Radio remote control
0019 Radio remote control
0020 Radio remote control
0021 “ZF” communication bus (+ signal)
0022 “ZF” communication bus (- signal)
0023 Power supply relay control by vehicle management ECU
0024 Injection pump and camshaft speed sensor information (electronic injection / - signal)
0025 Injection pump and camshaft speed sensor information (electronic injection / + signal)
0026 Gear lever communication bus (+ signal)
0027 Hydraulic retarder proportional solenoid valve control
0029 Hydraulic retarder oil boosting solenoid valve control
0031 Hydraulic retarder coolant temperature information
0032 Hydraulic retarder coolant temperature information
0038 Retarder manual control (analogue signal)
0039 Alarm siren activation and/or disabling encoded line
0045 Communication bus for EBS trailer socket (+ signal)
0046 Communication bus for EBS trailer socket (- signal)
0056 Vehicle speed sensor encrypted data line
0057 Information display pull-down menu sequence change signal
0058 Information display pull-down menu sequence change signal
0061 Gearbox input shaft speed information (+ signal)
0062 Gearbox input shaft speed information (- signal)
0063 Automatic gearbox casing oil level sensor power supply
0064 Automatic gearbox identification line
1 / 7
Andrew Burrows Key / Diagram 14/02/16
0065 Automatic gearbox casing oil temperature sensor information
0066 Automatic gearbox casing oil level sensor information
0067 Communication bus J1587 for gearbox diagnostic socket (+ signal)
0068 Communication bus J1587 for gearbox diagnostic socket (- signal)
0069 Gearbox speed selector data bit 1
007 Accelerator pedal potentiometer power supply
0070 Gearbox speed selector data bit 2
0071 Gearbox speed selector data bit 4
0072 Gearbox speed selector data bit 8
0073 Gearbox speed selector data parity bit
0074 Link between gearbox ECU and gear lever display
0075 Automatic gearbox gear lever information in input mode on gearbox ECU
0076 Automatic gearbox hydraulic pressure sensor information
0084 Automatic gearbox output speed sensor information (- signal)
0086 Automatic gearbox temperature sensor information
0087 Automatic gearbox turbine speed sensor information
0088 Automatic gearbox output speed sensor information (+ signal)
0089 Retarder coolant temperature sensor information
0100 Onboard management data transmission bus (+ signal)
0101 Onboard management data transmission bus (- signal)
0102 Onboard management data reception bus (+ signal)
0103 Onboard management data reception bus (- signal)
0104 Communication bus J1587-2 (+ signal)
0105 Communication bus J1587-2 (- signal)
0107 RH front brake pads wear analogue sensor earth
0108 RH front brake pads wear analogue sensor information
0109 RH front brake pads wear analogue sensor power supply (+5V)
011 Humidity sensor information
0114 Temperature sensor analogue signal for adjusting exhaust gases (EGR)
0116 Coolant temperature sensor analogue signal
0117 Pusher or follower rear axle angle sensor minimum voltage
0118 Pusher or follower rear axle angle sensor maximum voltage
0119 Front axle angle sensor minimum voltage
0120 Front axle angle sensor minimum voltage
0123 Red LED indicating that vehicle alarm is set (+) power supply
2 / 7
Andrew Burrows Key / Diagram 14/02/16
0127 Alarm ultrasonic reception (RX+ signal)
0128 Alarm ultrasonic reception (RX- signal)
0129 Alarm ultrasonic transmission (RX+ signal)
0130 Alarm ultrasonic transmission (RX- signal)
0143 Engine crankcase pressure sensor information
0144 Fuel pressure sensor information
0145 Available power supply (earth delivered by ECU for on-chassis engine stop control)
0146 Available power supply (Information requested by for on-chassis engine stop control)
0147 Communication bus between EBS ECU and front module (- signal)
0148 Communication bus between EBS ECU and front module (+ signal)
0149 Communication bus between EBS ECU and first additional module (- signal)
0150 Communication bus between EBS ECU and first additional module (- signal)
0151 Engine coolant level sensor information
0160 LH front brake pads wear analogue sensor earth
0161 LH front brake pads wear analogue sensor information
0162 LH front brake pads wear analogue sensor power supply (+5V)
0163 First axle RH rear brake pads wear analogue sensor earth
0164 First axle RH rear brake pads wear analogue sensor information
0165 First axle RH rear brake pads wear analogue sensor power supply (+5V)
0166 First axle LH rear brake pads wear analogue sensor earth
0167 First axle LH rear brake pads wear analogue sensor information
0168 First axle LH rear brake pads wear analogue sensor power supply (+5V)
0169 Second axle RH rear brake pads wear analogue sensor earth
017 Accelerator pedal position potentiometer information
0170 Second axle RH rear brake pads wear analogue sensor information
0171 Second axle LH rear brake pads wear analogue sensor power supply (+5V)
0172 Second axle LH rear brake pads wear analogue sensor earth
0173 Second axle LH rear brake pads wear analogue sensor information
0174 Second axle LH rear brake pads wear analogue sensor power supply (+5V)
0175 First rear axle RH speed sensor information
0176 First rear axle RH speed sensor information
0177 First rear axle LH speed sensor information
0178 First rear axle LH speed sensor information
0180 RH rear brake pads wear analogue sensor earth on PUSHER additional module
0181 RH rear brake pads wear analogue sensor information on PUSHER additional module
3 / 7
Andrew Burrows Key / Diagram 14/02/16
0182 RH rear brake pads wear analogue sensor power supply (+5V) on PUSHER additional module
0183 LH rear brake pads wear analogue sensor earth on PUSHER additional module
0184 LH rear brake pads wear analogue sensor information on PUSHER additional module
0185 LH rear brake pads wear analogue sensor power supply (+5V) on PUSHER additional module
0186 LH rear brake pads wear analogue sensor earth on PUSHER additional module
0187 RH rear brake pads wear sensor information (follower axle module)
0188 RH rear brake pads wear sensor power supply (+5V) (follower axle module)
0189 LH brake pads wear sensor earth (follower axle module)
0190 LH brake pads wear sensor information (follower axle module)
0191 LH brake pads wear sensor power supply (+5V) (follower axle module)
0192 “Driver’s side hand presence” door sensor information (+ signal)
0193 “Driver’s side hand presence” door sensor power supply
0194 “Driver’s side hand presence” door sensor information (- signal)
0195 “Driver’s side hand presence” door sensor information (+ signal)
0196 “Passenger’s side hand presence” door sensor power supply
0197 “Passenger’s side hand presence” door sensor information (- signal)
0198 Driver’s side door antenna (+ signal)
0199 Driver’s side door antenna (- signal)
0200 Passenger’s side door antenna (+ signal)
0201 Passenger’s side door antenna (- signal)
0202 Cab antenna 1 (+ signal)
0203 Cab antenna 1 (- signal)
0204 Cab antenna 2 (+ signal)
0205 Cab antenna 2 (- signal)
0206 Communication bus J1939-6 (+ signal)
0207 Communication bus J1939-6 (- signal)
0208 Communication bus J1587 (+ signal)
0209 Communication bus J1587 (- signal)
0212 Cruise control analogue sensor power supply
022 Accelerator pedal position potentiometer information
028 Cruise control ON/OFF control
029 Cruise control ON/OFF control
03 Rear stop lights power supply (12N socket)
030 RH rear direction indicator light power supply (12N socket)
0307 Rear fog lights power supply (12N socket)
4 / 7
Andrew Burrows Key / Diagram 14/02/16
0308 LH rear direction indicator light power supply (12N socket)
031 Cruise control signal
032 Engine oil temperature information with electronic fuel-injection system
033 Intake air temperature information with electronic fuel-injection system
034 Intake air temperature information (P2) with electronic fuel-injection system
0374 Encoded link between radio frequency receiver and alarm
0375 Hazard lights control by radio frequency receiver and/or alarm
0376 EBS module pressure sensor power supply for trailer control
0377 EBS module pressure sensor information for trailer control
0380 EBS module pressure sensor earth for trailer control
0381 Communication bus between EBS ECU and second additional module (- signal)
0382 Communication bus between EBS ECU and second additional module (+ signal)
0384 "PTO" control signal input for engine speed control (customer’s pre-arrangement)
039 Brake pedal position sensor information with EBS system
040 Brake pedal position sensor information with EBS system
0403 Encoded tractor/trailer link between alarm and freight protection module
0405 Tachograph serial data bus for fleet management
041 Line K information for diagnostic socket
0411 Communication bus J1939-2 (+ signal)
0412 Communication bus J1939-2 (- signal)
0413 Communication bus for bodybuilding or fleet management (- signal)
0414 Communication bus for bodybuilding or fleet management (+ signal)
0415 Communication bus between EBS ECU and on-chassis acceleration sensor (+ signal)
0416 Communication bus between EBS ECU and on-chassis acceleration sensor (- signal)
0424 Communication bus J1939 for docking radar (+ signal)
0425 Communication bus J1939 for docking radar (- signal)
045 Cruise control deceleration control
0460 Switch-operated control (bodybuilder’s pre-arrangement)
0461 Switch-operated control (bodybuilder’s pre-arrangement)
0462 Communication bus for vehicle OBD data socket (+ signal)
0463 Communication bus for vehicle OBD data socket (- signal)
0464 Diesel fuel particulate filter temperature sensor power supply
0465 Diesel fuel particulate filter temperature sensor power supply
047 Cruise control acceleration control
052 Flywheel engine speed sensor information (+ signal)
5 / 7
Andrew Burrows Key / Diagram 14/02/16
055 Flywheel engine speed sensor information (- signal)
056 Brake pedal position sensor power supply (+5V)
057 EBS system load sensor information
0608 Reversing lights power supply (12N socket)
0632 Rear marker lights power supply (12N socket)
064 Communication bus between EBS ECU and double rear module (- signal)
066 Communication bus between EBS ECU and double rear module (+ signal)
071 EBS system load sensor earth
072 EBS ECU earth for brake valve
073 EBS system load sensor power supply (+5V)
077 Accelerator pedal position sensor information (rest position)
079 Variable-drive fan power supply
080 Engine oil pressure sensor earth
081 Engine oil pressure sensor power supply
082 Communication bus between gear selector and automatic gearbox ECU (+ signal)
083 Communication bus between gear selector and automatic gearbox ECU (- signal)
084 Shunt between gearbox ECU terminal 66 and 26
0801 Communication bus J1587 for adaptive cruise control system (+ signal)
0802 Communication bus J1587 for adaptive cruise control system (- signal)
0803 Information from cruise control system
0804 Information from cruise control system
0805 Information from cruise control system
0806 Information from cruise control system
0807 Information from cruise control system
0808 Information from cruise control system
0809 Information from cruise control system
0810 Gearbox output speed information (+ signal)
0811 Gearbox output speed information (- signal)
0812 First front axle RH roadwheel speed sensor information (+ signal)
0813 First front axle RH roadwheel speed sensor information (- signal)
0814 Second front axle RH roadwheel speed sensor information (+ signal)
0815 Second front axle RH roadwheel speed sensor information (- signal)
0816 First front axle LH wheel speed sensor information (+ signal)
0817 First front axle LH wheel speed sensor information (- signal)
0818 Second front axle LH wheel speed sensor information (+ signal)
6 / 7
Andrew Burrows Key / Diagram 14/02/16
0819 Second front axle LH wheel speed sensor information (- signal)
0820 First front axle RH wheel speed sensor information (+ signal)
0821 First front axle RH wheel speed sensor information (- signal)
0822 First front axle LH wheel speed sensor information (+ signal)
0823 First front axle LH wheel speed sensor information (- signal)
0833 Inclination sensor power supply (+)
0834 Inclination sensor information
0835 Inclination sensor power supply (-)
0836 Clutch position sensor power supply (+)
0837 Clutch position sensor information
0838 Clutch position sensor power supply (-)
0839 Parking brake control power supply (-)
0840 Parking brake control potentiometers N° 1 & 2 power supply
0841 Parking brake wake-up contact power supply
0842 Parking brake control potentiometer N° 1 information
0843 Parking brake control potentiometer N° 2 information
0844 Parking brake unlocking switch N° 1 information
0845 Parking brake unlocking switch N° 2 information
0846 Parking brake module air pressure sensor power supply (+)
0847 Parking brake module air pressure sensor power supply (-)
0848 Parking brake module air pressure sensor information
085 Rail pressure sensor information
087 Engine oil pressure sensor information
088 Retarder torque sensor information
7 / 7
Andrew Burrows Key / Diagram 14/02/16
Group 1 - Earths and negative power supplies
Polarity N° Designation
1 Vehicle general earth
11 Microphone (- signal)
12 Gearbox neutral position sensor information
13 Engine water circuit by-pass solenoid valve control
14 AdBlue heating resistor control (in circuit from tank to pump module)
15 AdBlue heating resistor control (in circuit from pump module to dosing solenoid valve)
16 AdBlue heating resistor control (in circuit from dosing solenoid valve to pump module)
17 AdBlue heating resistor control (in circuit from pump module to tank)
18 12 Volts socket earth (multi-pass cab option)
19 AdBlue heating resistor control (in filter, on pump)
101 Humidity sensor power supply (-)
104 Two-tone horn power supply (-)
106 Assistance control information
119 "Front door open" position sensor information for lighting
(overhead light, stepwell light, locker lights, ambient lighting...)
123 Clutch pedal position sensor information
124 12 volts power socket earth
130 Overhead lights lighting earth (after master switch)
131 Communication bus between gear selector and ECU (- signal)
132 Communication bus between gear selector and ECU (+ signal)
141 Tachograph speed sensor information
142 Tachograph speed sensor information
144 Voltage converter earth for CB power supply
147 Master switch coil control
148 Master switch control
151 Available power supply (rear compartment open warning light)
152 Overhead lights earth
155 Voltage converter earth for radiotelephone power supply
156 Transfer box "low speed" information
157 Front wheels diff lock information
158 Transfer box PTO engaged information
159 Transfer box diff lock information
1 / 3
Andrew Burrows Key / Diagram 14/02/16
169 Doors central locking electronic box inhibition earth (presence of key in ignition switch)
173 N° 1/2/3 cylinder injectors earth (line 1)
174 N° 4/5/6 cylinder injectors earth (line 1)
183 Hydraulic retarder proportional solenoid valve earth
184 Hydraulic retarder charge accumulator solenoid valve earth
193 Earth between A/C ECU and fan management ECU
197 Master switch relay earth
198 Battery charging receptacle earth
1001 Front spotlight earth
1006 Exhaust brake solenoid valve N° 2 control earth
1007 Exhaust brake solenoid valve N° 2 control earth
1008 Exhaust brake electrovalve power supply (-)
1010 Fan electric clutch pilot-control earth
1012 EBS system solenoid valve earth
1018 Reversing lights relay control earth
1019 12 volts socket voltage converter earth
1020 Rear, doors opening/closing information
1021 Rear overhead lights power supply (-)
1025 Corrected vehicle speed information
1026 Engine speed regulation control (first selection)
1029 Automatic gearbox solenoid valve earth
1030 Automatic gearbox solenoid valve earth
1031 Automatic gearbox solenoid valve earth
1032 Automatic gearbox solenoid valve earth
1033 Automatic gearbox solenoid valve earth
1034 Automatic gearbox solenoid valve earth
1035 Automatic gearbox solenoid valve earth
1036 Automatic gearbox solenoid valve earth
1037 Automatic gearbox solenoid valve earth
1038 Automatic gearbox solenoid valve earth
1039 Automatic gearbox neutral earth
1043 Automatic gearbox solenoid valve earth
1045 Retarder control selector interface earth
1046 Automatic gearbox solenoid valve earth
1051 Air conditioning cut-out upon engine power loss control
2 / 3
Andrew Burrows Key / Diagram 14/02/16
1058 Fuel preheating relay control
1077 Earth delivered by engine management ECU for starting relay control
1081 Piloted axle control sensor earth
1084 Piloted axle control solenoid valve earth
1119 Alarm diode earth
1124 Roadwheels anti-slip sensor earth (ESP)
1140 PTO N° 1 engagement request
1141 Engine speed regulation control (second selection)
1147 Master switch closing control (ADR)
1148 Master switch closing control (ADR)
1149 Master switch warning light earth (ADR)
1150 Alternator earthing relay (-) control (ADR)
1151 N° 1/2/3 cylinder injectors earth (line 2)
1152 Cruise control operating control
1153 N° 4/5/6 cylinder injectors earth (line 2)
1154 Fuel pump control
1155 Air suspension ECU relay control
1156 Water/fuel separator bleeding solenoid valve control
1157 Alarm sound volume reduction control
1159 "Door open" information
1160 Engine retarder VGT2 solenoid valve earth
1161 Information feedback for "difficult terrain" warning light
1162 Turbocharger speed sensor earth
1163 Master switch diode earthing (ADR)
1164 Electrical master switch relay earthing (ADR)
1165 Single "H" solenoid valve N° 1 earthing
1166 Single "H" solenoid valve N° 2 earthing
1167 AdBlue tank level and temperature sensor earth
1168 AdBlue tank level and temperature sensor power supply (+5V)
1180 Driver presence in seat sensor power supply (-)
1200 Gearbox neutral position sensor information (after diode)
3 / 3
Loading...