Bosch PNH6B6B90A Installation and Operation Guide for PNH6B6B90A
3FHJTUFS
OFXEFWJDFPO
.Z#PTDIOPXBOE
HFUGSFFCFOFGJUT
ZPVS
CPTDIIPNFDPN
XFMDPNF
Gas hob
PNH6B6B90A
This cooktop is approved for use with Natural Gas and Universal LPG.
Leave these instructions with the owner.
USER INSTRUCTIONS
INSTALLATION INSTRUCTIONS
MAINTENANCE INSTRUCTIONS
en
Table of contents
[en]I n st r uc t i o n manual Gas hob
8 Intended use. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2
8Intended use
( Important safety information . . . . . . . . . . . . . . . 3
What to do if you smell gas . . . . . . . . . . . . . . . . . . . . . 4
5 Installation and connection. . . . . . . . . . . . . . . . . 5
Statutory requirements . . . . . . . . . . . . . . . . . . . . . . . . . 5
Preparing to install . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5
Clearances . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
Installation of cooktop into the kitchen bench . . . . . . . 6
Electrical connection . . . . . . . . . . . . . . . . . . . . . . . . . . 6
Gas connection . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7
Converting the cooktop from Nat. Gas to
Universal LPG. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8
* Getting to know your appliance . . . . . . . . . . . . . 9
Burner locations . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
Controls and burners . . . . . . . . . . . . . . . . . . . . . . . . . . 9
Accessories . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
Ä Gas burners . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10
Switching on manually . . . . . . . . . . . . . . . . . . . . . . . .10
Automatic ignition. . . . . . . . . . . . . . . . . . . . . . . . . . . . 10
Safety system . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10
Switching off a burner . . . . . . . . . . . . . . . . . . . . . . . . 10
Warnings . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .10
Cooking guidelines . . . . . . . . . . . . . . . . . . . . . . . . . . 10
Å Cooking pans . . . . . . . . . . . . . . . . . . . . . . . . . . . 10
Suitable pans . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .10
Precautions for use . . . . . . . . . . . . . . . . . . . . . . . . . . 10
2 Cleaning and maintenance . . . . . . . . . . . . . . . . 11
Cleaning. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .11
Maintenance. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
Intended use
Read these instructions carefully. You will only
be able to use your appliance safely and
effectively when you have read them. These
operating and installation instructions should
be retained, and passed onto the buyer if the
appliance is sold.
Removal of transit protection
Packaging materials of the product are
manufactured from recyclable materials. Do not
dispose of the packaging materials together
with the domestic or other wastes. Take them
to the packaging material collection points
designated by the local Authorities.
The manufacturer is exempt from all
responsibility if the requirements of this
manual are not complied with.
The images shown in these instructions are for
guidance only.
Do not remove the appliance from its
protective packaging until it is installed in the
unit. Do not switch on the appliance if it is
damaged in any way. Contact our Technical
Assistance Service.
Before installing your new hob, ensure that it is
being installed according to the installation
instructions.
This appliance is not suitable for use in a
marine craft, caravan or mobile home.
This appliance must only be used in well
ventilated places. It must not be connected to
a combustion product removal device.
3 Trouble shooting . . . . . . . . . . . . . . . . . . . . . . . . 12
4 Customer service. . . . . . . . . . . . . . . . . . . . . . . . 13
Warranty conditions . . . . . . . . . . . . . . . . . . . . . . . . . .13
Produktinfo
Additional information on products, accessories,
replacement parts and services can be found at
www.bosch-home.com and in the online shop
www.bosch-eshop.com
2
This appliance is not intended for operation
with an external clock timer or a remote control.
This appliance has been designed for home
use only, not for commercial or professional
use. This appliance is only intended for cooking
purposes, not as a heating system. The
warranty will only be valid if the appliance is
used for the purpose for which it was designed.
This appliance is intended for use up to a
maximum height of 2000 metres above sea
level.
Do not use lids or hob guards for children
which are not recommended by the hob
manufacturer. They may cause accidents such
as those due to the overheating, ignition or
detachment of fragments of materials.
Important safety information en
This appliance is not intended for use by
persons (including children) with reduced
physical, sensory or mental capabilities, or
lack of experience and knowledge, unless
they have been given supervision or
instruction concerning use of the appliance by
a person responsible for their safety. Children
should be supervised to ensure that they do
not play with the appliance.
All operations relating to installation,
connection, regulation and conversion to
other gas types must be performed by an
authorised technician, respecting all
applicable regulations, standards and the
specifications of the local gas and electricity
suppliers. Special attention shall be paid to
ventilation regulations.
This appliance leaves the factory set to the
gas type that is indicated on the specifications
plate. If this needs to be changed, please
consult the assembly instructions. It is
recommended you contact the Technical
Assistance Service to change to another gas
type.
Before installing, you need to check that local
distribution conditions are compatible with the
appliance's adjustment indicated on the
specifications plate (gas type and pressure,
power, voltage).
Before you begin, turn off the appliance's
electricity and gas supply.
The supply cable must be attached to the unit
to prevent it from touching hot parts of the
oven or hob.
Appliances with electrical supply must be
earthed.
Cabinets installed above the gas cooktop
must have a minimum clearance of 650 mm
(24”).
The gas pressure regulator supplied with the
appliance must be installed in line with the gas
pipe. (N.G. only).
For pressure testing in excess of 3.5 kPa
(1/2 psig) the appliance and its individual
shutoff valve must be disconnected from the
gas supply piping system.
Important. When using a very large pot, leave
a gap of at least 50 mm (2”) to avoid
damaging any parts in bench top wood,
plastic or other non-heat resistant materials.
Never leave oil or hot fat unattended.
(Important safety
information
Impor t ant safet y informat i on
DO NOT MODIFY THIS APPLIANCE.
DO NOT USE OR STORE FLAMMABLE
MATERIALS IN THE APPLIANCE STORAGE
DRAWER OR NEAR THE APPLIANCE.
DO NOT SPRAY AEROSOLS IN THE
VICINITY OF THIS APPLIANCE WHILE IT IS
IN OPERATION.
DO NOT USE THIS APPLIANCE AS A SPACE
HEATER.
If the information in this manual is not followed
exactly, a fire or explosion may result causing
property damage, personal injury or death.
:Warning – Risk of deflagration!
Accumulation of unburned gas in an enclosed
area carries a risk of deflagration. Do not
subject the appliance to draughts. These
might blow out the burners. Carefully read the
instructions and warnings on the operation of
gas burners.
:Warning – Risk of poisoning!
The kitchen will become hot and humid and
combustion products produced when this gas
appliance is used. Make sure the kitchen is
well ventilated, particularly when the hob is in
operation: either keep the natural ventilation
apertures open, or install a ventilation system
(extractor hood). Intense prolonged use of the
appliance may require additional or more
effective ventilation: open a window or
increase the power of the ventilation system.
:Warning – Risk of burns!
■ The burners and their immediate vicinity get
very hot. Never touch the hot surfaces.
Keep children under 8 years old well away
from this appliance.
Risk of burns!
■ If the liquefied gas bottle is not upright,
liquefied propane/butane can enter the
appliance. Intense darting flames may
therefore escape from the burners.
Components may become damaged and
start to leak over time so that gas escapes
uncontrollably. Both can cause burns.
Always use liquefied gas bottles in an
upright position.
■ Grids become very hot during use, take
care not to make contact with the grids.
DO NOT USE IN FREEZING CONDITIONS.
3
en Important safety information
:Warning – Risk of fire!
■ The cooking process must be supervised. A
short cooking process must be supervised
without interruption.
Risk of fire!
■ The burners get very hot. Do not rest
inflammable objects on the hob. Do not
store objects on the hob.
Risk of fire!
■ Do not store or use corrosive chemicals,
products which produce fumes,
inflammable materials or non-food products
below or near this domestic appliance.
Risk of fire!
■ Fat or oil which is overheated can catch fire
easily. Never leave fat or oil to heat up
unattended. If oil or fats do catch fire, never
use water to put the fire out. Put the fire out
by covering the pan with a lid and switch off
the hotplate.
:Warning – Risk of injury!
■ Cracks or fractures in the glass plate are
dangerous. Shut immediately off all burners
and any electrical heating element. Unplug
the appliance from the mains or switch off
the circuit breaker in the fuse box. Shut off
the gas supply. Do not touch the appliance
surface. Never switch on a faulty appliance.
Contact the after-sales service.
Risk of injuries!
■ Sudden changes in temperature may cause
breakage of the glass. While using your
hob, prevent any draughts and do not spill
any cold liquids on it.
Risk of injuries!
■ Pans which are damaged, are not the right
size, hang over the edge of the hob or are
not positioned correctly can cause serious
injuries. Follow the advice and warnings
provided relating to the cooking pans.
Risk of injury!
■ Incorrect repairs are dangerous. Repairs
may only be carried out, and damaged
power and gas lines replaced, by an aftersales engineer trained by us. If the
appliance is faulty, unplug the mains plug or
switch off the fuse in the fuse box. Shut off
the gas supply. Contact the after-sales
service.
Risk of injury!
■ If a control knob is too stiff to turn or it is
loose, it must not be used. Contact our
after-sales service immediately to have the
control knob repaired or replaced.
What to do if you smell gas
■ Do not try to light the appliance.
■ Do not touch any electrical switch; do not
use any phone in your building.
■ Immediately call your gas supplier from a
neighbour’s phone. Follow the gas
supplier’s instructions.
■ If you cannot reach your gas supplier, call
the fire department.
Installation and service must be performed by
an authorised person.
:Warning – Risk of electric shock!
■ Do not clean the appliance using steam
cleaners.
Risk of electric shock!
■ Cracks or fractures in the glass plate could
cause electric shocks. Switch off the circuit
breaker in the fuse box. Contact the aftersales service.
4
5Installation and connection
Instal lation and connecti on
Statutory requirements
This installation must conform with the following:
■ Manufacturer’s Installation instructions
■ Local Gas Fitting Regulations
■ Municipal Building Codes
■ Refer to AS/NZS 5601.1 for Gas Installations
■ S.A.A. Wiring Code
■ Local Electrical Regulations
■ Any other statutory regulations
Preparing to install
Installation and connection en
Refer to AS/NZS 5601.1 for piping size details. These
built-in cooktops are intended to be inserted in a
benchtop cutout.
Do not stick the cooktop onto the worktop with silicone.
Only an officially authorised technician should connect
the appliance.
Before you begin, turn off the gas and electricity supply.
Before connecting the unit, check whether the local
connection conditions (type of gas) are compatible with
the unit’s setting. Observe any special conditions
imposed by local suppliers (utilities). The specifications
of this cooktop are stated on the data label located on
the bottom of the cooktop base.
A duplicate data label is supplied for adhesion to an
accessible location near the hotplate if the data label on
the base of the hotplate cannot be accessed when the
hotplate is installed.
PLQ
PLQ
PLQ
PLQ
5
Loading...