Bh fitness T5 Manual

Treadmill Owner’s Manual

BH Fitness T5

Computer

Upper Controls

Computer Lower Controls

Safety Button & Clip

Pulse Grips

Running Belt

Moving surface

Side Rails

BH FITNESS

20155 Ellipse, Foothill Ranch, CA 92610

Phone: [phone] (USA only), 866-325-2339 (USA & Canada) Fax: [phone]

Email: [e-mail]

Web: www.bhnorthamerica.com and www.bhfitness.com

Revised: 15 August 2008 (v3)

BH Fitness • 20155 Ellipse • Foothill Ranch • CA • 92610

www.bhfitness.com

T5 Treadmill

TABLE OF CONTENTS

SECTION		PAGE
Safety Instructions . . . . . . . . . . . . . . .	. . . . . . . . . . . . . . . . . . . . . . . . . . . . .	2
Assembly . . . . . . . . . . . . . . . . . . . . . . .	. . . . . . . . . . . . . . . . . . . . . . . . . . . . .	5
Folding and Moving . . . . . . . . . . . . . . .	. . . . . . . . . . . . . . . . . . . . . . . . . . . . .	7
Maintenance. . . . . . . . . . . . . . . . . . . . .	. . . . . . . . . . . . . . . . . . . . . . . . . . . . .	10
Lubricating and adjusting the belt. .	. . . . . . . . . . . . . . . . . . . . . . . . . . . . .	10
Removing and washing the bottle holder . . .. . . . . . . . . . . . . . . . . . . . . . .		12
Fitness and Exercise . . . . . . . . . . . . . .	. . . . . . . . . . . . . . . . . . . . . . . . . . . . .	13
Troubleshooting . . . . . . . . . . . . . . . . . .	. . . . . . . . . . . . . . . . . . . . . . . . . . . . .	15
Computer Console . . . . . . . . . . . . . . . .	. . . . . . . . . . . . . . . . . . . . . . . . . . . . .	16
Warranty . . . . . . . . . . . . . . . . . . . . . . .	. . . . . . . . . . . . . . . . . . . . . . . . . . . . .	23

1

BH Fitness • 20155 Ellipse • Foothill Ranch • CA • 92610 www.bhfitness.com • Phone [phone] • Fax [phone]

T5 Treadmill

IMPORTANT SAFETY INSTRUCTIONS

User Safety

1.Users should pass a full medical examination before they begin an exercise program. Work at the recommended exercise level. Do not over exert yourself. If you feel any pain or discomfort, stop exercising immediately and consult your doctor.

2.Do warm up stretching exercises before using the unit.

3.Verify that all of the parts are attached and that the nuts, bolts, pedals and bar are correctly tightened before use.

4.Do not wear loose clothing or high heels. Tie up shoe laces.

5.The maximum weight of a user is 400 pounds (181 Kg).

6.Keep hands away from moving parts.

7.Supervise children, invalids or disabled persons at all times. Children are curious and vulnerable to accidents. Do not use the unit as a toy. Disabled people should not use the exercise equipment without the assistance of a qualified person or doctor.

8.The owner is responsible for explaining safety instructions to each user.

9.The unit can only be used by one person at a time.

Unit Safety

1.For safety, maintain a minimum clearance around the unit. Maintain 18 inches on the front and on each side of the unit plus 24 inches at the rear of the unit.

2.Install and use the unit on a flat, stable surface, with some type of protection for the floor or carpet. Do not place it alongside walls or furniture. Check the unit before each use.

3.Please read all of the instructions before assembling or using this unit.

4.To reduce the dangers and risk of electric shock always unplug the unit from its electrical power immediately after using, before cleaning, opening, disassembling or doing maintenance.

5.Do not place sharp objects near the exercise equipment.

6.Do not use the exercise equipment if it is not working correctly.

7.Do not lean against the computer console.

8.Do not start the treadmill when someone is standing on the running belt moving surface.

9.Connect this treadmill to a properly grounded 110-120V, 15 or 20 Amp dedicated outlet only.

WARNING: To reduce the risk of fire, electric shock, injury to persons or inflicting the harm of a burn:

10.Turn all the controls to the off position, prior to removing the electrical plug from the outlet.

11.The unit should never be left unattended when plugged in. Unplug the unit from the electrical power before leaving the room, when unused and before adding or removing parts.

12.Do not operate the unit under a blanket or pillow. Excessive heating can occur and cause fire, electric shock, injury to persons or inflict the harm of a burn.

13.Use the unit only as described in this manual. Only use attachments recommended by the manufacturer.

14.Never operate this unit if it has a damaged electrical cord or plug. Do not operate this unit if it is not working properly. Do not operate this unit if it has been dropped or damaged. Do not operate this unit if it has been immersed into water. Return the unit to a service center for examination and repair.

15.Do not pull or carry the unit by the electrical cord. Do not use the cord as a handle.

2

BH Fitness • 20155 Ellipse • Foothill Ranch • CA • 92610 www.bhfitness.com • Phone [phone] • Fax [phone]

T5 Treadmill

IMPORTANT SAFETY INSTRUCTIONS

16.Keep the electrical cord away from heated surfaces.

17.Never operate the unit when the air openings are blocked. Keep the air openings free of lint, hair and the like.

18.Do not drop or insert any objects into any openings.

19.Do not use outdoors or near water.

20.Do not operate where aerosol (spray) products are being used or where oxygen is being administered.

Power Cord Safety

The power cord has a polarized plug (one blade is wider than the other) and grounding pin. This plug will fit only one way into a polarized outlet. If the plug does not fully fit into the outlet, then reverse the plug. If it still does not fit then contact a qualified Electrician to install the correct outlet. Do not change the plug in any way.

The unit must only be connected to a dedicated electrical circuit with an earth ground connection. If not, the user risks receiving an electric shock. Make sure that the outlet has the same pin layout as the plug on the unit. See Fig. A.

	Fig A.	GROUNDED
		OUTLET

GROUNDING

PIN

Please save these instructions.

3

BH Fitness • 20155 Ellipse • Foothill Ranch • CA • 92610 www.bhfitness.com • Phone [phone] • Fax [phone]

T5 Treadmill

IMPORTANT SAFETY INSTRUCTIONS

SAFETY BREAKER

This model is equipped with an electronic circuit breaker to protect both the electronic and electrical circuits. Figure B.

The circuit breaker will be automatically triggered if the unit is subjected to abnormal force or heat.

Should this occur:

1.Set switch (L), located on the main body, to the “0” (OFF) position.

2.Press the circuit button (C) to reset the unit.

3.Next, set switch (L) to the “I” (ON) position and the unit will be ready for use again.

Should the circuit breaker trip repeatedly then the most probable causes are:

-Abnormal working conditions, -Treadmill belt in need of lubricant,

-Solvent based lubricants used (use BH type),

-Belt is too tight.

Plug the unit into a dedicated 110-120V, 15 or 20 Amp circuit with a ground terminal. Set switch

(L) to the “I” (ON) position.

Figure B

4

BH Fitness • 20155 Ellipse • Foothill Ranch • CA • 92610 www.bhfitness.com • Phone [phone] • Fax [phone]

T5 Treadmill

ASSEMBLY

Take the unit out of the box and place it on the floor as shown in Figure 1. Verify that the parts are undamaged and quantities are correct.

ATTENTION: Two assemblers are required. Follow the assembly instructions step by step:

Figure 1

	ITEM	Qty	DESCRIPTION
	A	1	Assembled frame
	B	1	Bottle
	C	1	Right Decoration Cover
	D	1	Left Decoration Cover
	E	1	Wheel Protecting Cover
			(Right)
	F	1	Wheel Protecting Cover
			(Left)

ITEM	DESCRIPTION	Qty	Figure 2
a	Allen Bolt M8 x P1.25 x 20	4
b	Allen Bolt M10 x P1.5 x 35	2
b 1	Sleeve NT-2158	2
b 2 Flat Washer ψ10xψ20x2.0t		2
c	Plastic Handle	2
d	Hex Wrench + Screwdriver	1
	5mm x 70mm x 70mm
e	Allen Wrench	1
	6mm x 80mm x 80mm
f	Truss Phillips Screw	8
	M5 x P0.8 x 15
g	Power Cord	1
h	Bottled SILICONE	1
	Lubricant

5

BH Fitness • 20155 Ellipse • Foothill Ranch • CA • 92610 www.bhfitness.com • Phone [phone] • Fax [phone]

T5 Treadmill

ASSEMBLY CONTINUED

Figures 3 & 4

1.One Assembler should rotate the Uprights in the direction shown in the right drawing. A second assembler should secure with Allen Bolt (a).

1)Turn up the Computer, tighten with Plastic Handle (c).

2)Turn down the Handrails and then tighten with Sleeve (b1), Washer (b2) and Bolt (b).

3)Install the Right and Left Decoration

Cover (C, D) with Screw (f).

4)Install the Right and Left Wheel Protecting Cover (E, F) with Screw

(f).

Uprights

6

BH Fitness • 20155 Ellipse • Foothill Ranch • CA • 92610 www.bhfitness.com • Phone [phone] • Fax [phone]

T5 Treadmill

FOLDING AND MOVING

FOLDING UP THE UNIT

The Treadmill can be folded for storage.

1.Stop the treadmill.

2.Lower the elevation to the minimum.

3.Unplug the electrical connector.

4.Lift the unit until lever (O) clicks into place. Do not touch lever (O).

Figure 5A

Do not hit the cylinder. The cylinder is under high pressure. If the cylinder is damaged, then the treadmill may not operate correctly.

Do not hit the cylinder

Figure 5B

7

BH Fitness • 20155 Ellipse • Foothill Ranch • CA • 92610 www.bhfitness.com • Phone [phone] • Fax [phone]