Volvo XC60 2014 User Manual
VOLVO XC60
WIRING DIAGRAM 2014
TP 39263202 Structure week 13w20
Vehicles with SRS (Airbag)/SIPS bag/IC (Inflatable Curtain)
Warning!
Extra caution must be exercised when working on vehicles equipped with SRS/SIPS bag/IC
in order to avoid:
1. Personal injuries when performing repair work.
2. Damage or malfunction of the SRS/SIPS bag/IC system.
Work involving the SRS/SIPS bag/IC systems or other components in the vehicle that may
affect the SRS/SIPS bag/IC systems must always be performed by an authorized Volvo
workshop.
In case of doubt, consult the SRS and SIPS bag/IC service manual.
Is the vehicle equipped with SRS/SIPS bag/IC?
Vehicles with SRS are most easily recognized by the letters SRS in the center of the steering
wheel. If the vehicle also has a passenger side airbag, the letters SRS are stamped on the
dashboard above the glove compartment. SRS vehicles from 1993 and onward also have
explosive seat belt tensioners. SIPS bags are only installed on SRS vehicles from 1995 and
onward. SIPS bag decals are located on the windshield and seat compartment. Vehicles with
IC can be recognized by the letters IC on the C/D panel (4 door) or the B panel (5 door).
General recommendations
• Be especially careful when working on or around SRS, SIPS, and IC components.
• Make sure that no wires are pinched, frayed, or pierced.
• Never install accessories by the sensors.
• Where applicable, work on the steering wheel, steering shaft, or steering gear must be done
in accordance with the methods in the SRS section of VIDA.
• Certain components of the aforementioned systems must be grounded while working. Read
the appropriate sections in VIDA.
• Install no accessories in the areas between the A and B-posts, the B and C-posts, and the C
and D-posts.
Test terminal
Data link connector in the passenger compartment.
Changes introduced up to and including structure week 13w20
Any changes made to the vehicles after this date are not included in the manual. If necessary
refer to service bulletins.
Volvo models are sold in versions adapted for different markets. These adaptations depend
on factors such as legal requirements, taxation, and market demands.
This manual may therefore include illustrations and text that do not apply to the vehicles in
your country.
Ordering:
Electronic Wiring Diagrams (EWD) can be ordered from the Technical Information Shop (TIS)
We reserve the right to make modifications.
© Volvo Car Corporation
Table of Contents 1:3
Explanations & Abbreviations ........................................ 6
How to use the wiring diagrams 1:2............................... 7
Electrical distribution
Overview without Start/Stop function............................. 9
Overview with Start/Stop function................................ 10
Overview, Distribution box in engine compartment ..... 11
Overview, Distribution box in passenger compartment 12
Overview, Distribution box in cargo compartment ....... 13
Fuses
Distribution box in engine compartment F1 - F7........... 14
Distribution box in engine compartment F8 - F23......... 15
Distribution box in engine compartment F27 - F37....... 16
Distribution box in engine compartment F38 ................ 17
Distribution box in engine compartment F39 - F44....... 18
Central electronic module (CEM) F1 - F6 ..................... 19
Central electronic module (CEM) F7 - F16 ................... 20
Central electronic module (CEM) F18 - F24 ................. 21
Distribution box in passenger compartment F1 - F20... 22
Distribution box in passenger compartment F21 - F30. 23
Distribution box in cold zone F1 - MF2 ......................... 24
Distribution box in cargo compartment FA1 - FA11...... 25
Battery PF1 - PF2 ......................................................... 26
Relays
Relays in the engine compartment .............................. 27
Relays in the engine compartment .............................. 28
Relays in passenger and cargo compartments ........... 29
Ground connections
Overview...................................................................... 30
31/1 - 31/6.................................................................... 31
31/7 - 31/10.................................................................. 32
31/15 ........................................................................ 33
31/47 - 31/67................................................................ 34
31/68 - 31/88................................................................ 35
31/89 - 31/96................................................................ 36
31/115 - 31/TRM.......................................................... 37
Control modules
Overview locations....................................................... 38
Overview designations................................................. 39
Central electronic module (CEM) 1:3........................... 40
Data communication high speed CAN 1:2 ................... 43
Data communication intermediate speed CAN, LHD... 45
Data communication intermediate speed CAN, RHD .. 46
Data communication Local CAN .................................. 47
Data communication Extended CAN ........................... 48
Data communication MOST......................................... 49
Data communication, LIN 1:2....................................... 50
Steering Wheel Module (SWM) ................................... 52
Group 26 Cooling system
Cooling fan 4-Cyl. Turbo .............................................. 53
Cooling fan 5-Cyl. Diesel ............................................. 54
Cooling fan 6-Cyl. ........................................................ 55
Group 27 Engine controls
Cruise control 4-Cyl. Turbo ...........................................56
Cruise control 5-Cyl. Diesel ..........................................57
Cruise control 6-Cyl. .....................................................58
Start-/Stop function 4-Cyl. Turbo ..................................59
Start-/Stop function 5-Cyl. Diesel..................................60
Group 28 Ignition and control system
Engine management system, 5-Cyl. Diesel 1:3 ........... 61
Engine management system, 4-Cyl. Turbo 2.0l 1:2..... 64
Engine management system 6-Cyl. 1:2 ....................... 66
Engine management system 6-Cyl. PZEV 1:2............. 68
Engine management system, 6-Cyl. Turbo 1:2............ 70
Emission control 4-Cyl. Turbo...................................... 72
Emission control 6-Cyl. ................................................ 73
Emission control 6-Cyl. Turbo...................................... 74
Group 32 Alternator and voltage regulator
Power supply 4-Cyl. Turbo........................................... 75
Power supply 5-Cyl. & 6-Cyl. ....................................... 76
Power supply 4- & 5-Cyl. with Start/Stop ..................... 77
Group 33 Starting system
Starting system 4-Cyl. Turbo ....................................... 78
Starting system 5- & 6-Cyl. .......................................... 79
Starting system 5-Cyl. Diesel....................................... 80
TP39263202 XC60 2014 © Volvo Car Corporation 2013 3
Table of Contents 2:3
Group 35 Lighting
High and low beam ...................................................... 81
High and low beam (Dual Xenon)................................ 82
Beam length adjustment, manual ................................ 83
Running/Parking light, Tail lights ................................. 84
Fog lights ..................................................................... 85
Daytime Running Lights .............................................. 86
Brake lights .................................................................. 87
Reversing lights ........................................................... 88
Follow-me-home lighting LHD ..................................... 89
Follow-me-home lighting RHD..................................... 90
Active headlight ........................................................... 91
Interior lighting, LHD 1:2 .............................................. 92
Interior lighting, RHD 1:2 ............................................. 94
Lighting in door sill trims .............................................. 96
Auxiliary lights.............................................................. 97
Group 36 Additional electrical equipment
Rain sensor.................................................................. 98
Direction indicator and hazard warning flashers LHD . 99
Direction indicator and hazard warning flashers RHD 100
Wiper/Washer windshield .......................................... 101
Washer headlights ..................................................... 102
Wiper/Washer rear window........................................ 103
Keyless vehicle 1:2 .................................................... 104
Horn ...................................................................... 106
Anti-theft alarm .......................................................... 107
Parking assistance..................................................... 108
Collision warning with power brake booster .............. 109
Tire pressure monitoring system (TPMS) .................. 110
Alcohol lock................................................................ 111
Group 37 Wiring and fuses
Diagnostics system.................................................... 112
Outlet 12 V................................................................. 113
Cable harness towbar/tow hitch 4-pin ....................... 114
Cable harness towbar/tow hitch 7-pin........................ 115
Cable harness towbar/tow hitch 13-pin...................... 116
USB unit (AUU).......................................................... 117
Bluetooth Handsfree .................................................. 130
Navigation system & Traffic information, portable ..... 131
Satellite radio ............................................................. 132
Parking camera.......................................................... 133
Parking camera rear .................................................. 134
Wide angle camera front............................................ 135
Sensus Connected Touch.......................................... 136
Group 43 Transmission
Automatic transmission AWF21................................. 137
Transmission M66...................................................... 138
Automatic transmission MPS6 ................................... 139
Differential electronic module (DEM) ......................... 140
Group 55 Parking brake
Electric parking brake ................................................ 141
Group 59 Brake system
Brake control system & DSTC ................................... 142
Group 64 Steering
Speed dependent power steering .............................. 143
Group 76 Shock absorbers
Four-C ...................................................................... 144
Group 83 Doors and openings
Central locking front doors LHD................................. 145
Central locking front doors RHD ................................ 146
Central locking rear doors.......................................... 147
Central locking tailgate with POT............................... 148
Central locking tailgate without POT.......................... 149
Signal receiver central locking ................................... 150
Central locking fuel filler flap ...................................... 151
Power windows front doors LHD................................ 152
Power windows front doors RHD ............................... 153
Power windows rear doors......................................... 154
Power sunroof............................................................ 155
Group 38 Instruments
Seat belt reminder ..................................................... 118
Driver information module.......................................... 119
Group 39 Other
Audio High/Premium 1:3............................................ 120
Audio 1:2.................................................................... 123
Cellular phone 1:2...................................................... 125
DAB Radio ................................................................. 127
Multimedia monitor with DVD, Dual Screen RSE ...... 128
TV receiver / TV control module ............................... 129
Group 84 Exterior decorative elements, etc.
Power door mirrors LHD ............................................ 156
Power door mirrors RHD............................................ 157
Heated door mirrors LHD........................................... 158
Heated door mirrors RHD .......................................... 159
Blind spot information system LHD 1:2...................... 160
Blind spot information system RHD 1:2 ..................... 162
Heated windshield LHD ............................................. 164
Heated windshield RHD............................................. 165
Heated rear window ................................................... 166
TP39263202 XC60 2014 © Volvo Car Corporation 2013 4
Table of Contents 3:3
Group 85 Interior equipment
Power driver’s seat with memory function, LHD ........ 167
Power driver’s seat with memory function, RHD ....... 168
Power passenger seat, LHD...................................... 169
Power passenger seat, RHD ..................................... 170
Heated front seats with fans ...................................... 171
Heated front seats without fans ................................. 172
Heated steering wheel ............................................... 173
Heated rear seat ........................................................ 174
Adjustable Lumbar support........................................ 175
Group 87 Climate control system
Climate control system PTC-elements ...................... 176
Climate control system, 4-Cyl. 1:2 ............................. 177
Climate control system 5-Cyl. & 6-Cyl. 1:2 ................ 179
Parking heater, auxiliary heater ................................. 181
Parking heater, remote start ...................................... 182
Group 88 Internal equipment
Supplemental restraint system 1:2 ............................ 183
Remote control opener garage door.......................... 185
Power folding headrest .............................................. 186
Rear-view mirror with automatic dimming.................. 187
Connectors............................................... 188
Cable harness routing in vehicle
Harness engine 4-Cyl. Turbo ......................................243
Harness engine, 6-Cyl. ...............................................243
Harness engine, 6-Cyl. Turbo .....................................244
Harness engine, Diesel 2.0l ........................................244
Harness engine, Diesel 2.4l ........................................245
Engine compartment harness .....................................246
Dashboard harness, LHD ...........................................247
Harness Dashboard, RHD ..........................................248
Floor Harness, LHD ....................................................249
Floor Harness, RHD....................................................250
Harness infotainment, LHD.........................................251
Harness infotainment, RHD ........................................252
Roof harness...............................................................253
Center console harness ..............................................253
Tunnel harness ...........................................................254
Harness front door, left ...............................................255
Harness front door, right .............................................255
Harness rear door, left ................................................256
Harness rear door, right ..............................................256
Tailgate harness .........................................................257
Harnesses rear axle....................................................257
Component illustrations ......................... 258
Index 1:2 ................................................... 313
Branching points .....................................222
List of components 1:6 .......................... 315
TP39263202 XC60 2014 © Volvo Car Corporation 2013 5
Explanations & Abbreviations
Groups
Group 26 = Cooling system
Group 27 = Engine controls
Group 28 = Ignition and control system
Group 32 = Alternator and voltage regulator
Group 33 = Starting system
Group 35 = Lighting
Group 36 = Additional electrical equipment
Group 37 = Wiring and fuses
Group 38 = Instruments
Group 39 = Other
Group 43 = Transmission
Group 55 = Parking brake
Group 59 = Brake system
Group 64 = Steering
Group 76 = Shock absorbers
Group 83 = Doors and openings
Group 84 = Exterior decorative elements, etc.
Group 85 = Interior equipment
Group 87 = Climate control system
Group 88 = Internal equipment
Group 89 = Body other
Ignition switch symbols
X = Accessories (audio position)
S = Powered upon insertion of key
15 = Contact remains connected during
start
15l = Contact is broken while starting
30 = Constant power from the battery
50 = Start
Countries/Markets
A = Austria
AUS = Australia
B = Belgium
CDN = Canada
CH = Switzerland
D = Germany
DK = Denmark
E = Spain
EU/OS = Markets outside USA and Canada
FIN = Finland
GB = Great Britain
ISR = Israel
J = Japan
KOR = Korea
N = Norway
NL = Netherlands
S = Sweden
USA = United States of America
WEU = Western Europe
Other
ACC = Adaptive Cruise Control
Ag = Silver plated
Au = Gold plated
AUTO = Automatic transmission
BLIS = Blind spot information system
CAN = CAN communication
DPY = Display
ECC = Electronic climate control system
ETA = Throttle unit
EXC = Exclusive
GDL = Gas discharge lamp
HS = High speed data bus
KEYLESS = Keyless vehicle
IR = Infrared sensor
LIN = LIN communication
LH = Left-hand side
LHD = Left-hand drive
MAN = Manual transmission
MEMORY = Memory driver’s seat
MIRCAM = Parking camera in rear-view mirror
MS = Midspeed data bus
MMS = Mass Movement Sensor
PANROOF = Panoramic roof
PETROL = Gasoline
RH = Right-hand side
RHD = Right-hand drive
RTI = Road Traffic Information
SCR = Screened
SRS = Airbag
T = Turbocharged engine
W/O = Without
2WD = Two-wheel drive
4CYL, I4 = 4-cylinder engine
5CYL, I5 = 5-cylinder engine
6CYL, I6 = 6-cylinder engine
Colors
BK, SB = Black
BN = Brown
BU, BL = Blue
GN = Green
GY, GR = Gray
LGN = Light Green
NL = Natural
OG, OR = Orange
PK, P = Pink
RD, R = Red
VT, VO = Violet
WH, W = White
YE, Y = Yellow
TP39263202 XC60 2014 © Volvo Car Corporation 2013 6
How to use the wiring diagrams 1:2
The descriptions below apply in general
to all wiring diagram manuals, although
not all sections are necessarily contained in this manual.
A. Component designation
Every component has a component designation that
consists of two parts.
The first part is a type number that describes the
type of component in question, for example 3/xx.
The second part of the designation is a serial num-
ber, e.g. x/2.
Together, this constitutes a component designation,
e.g. 3/2.
At the end of the manual is a list of components,
where, with the help of the component designation,
you can read off the name of the component, for
example, 3/2 = light switch.
List of type numbers
The list shows which type of component that respec
tive type numbers refer to, for example, 3/x = switch,
6/x = electric motor, etc.
1 Battery
2 Relay
3 Switch
4 Control module
5 Driver information module
6 Electric motor
7 Sensor
8 Actuator
9 Heating element
10 Light
11 Fuse
15 Electrical distribution rail/box
16 Audio
17 Service/diagnostics
18 Contact reel
19 Meter
20 Ignition component/shunt
27 Optics
31 Ground connection
73 Branching point
74 Connector
The systems are shown in non-active
status.i.e. with "key removed" and when
the doors, hatches and hood are closed.
B. Branching points
The wiring diagrams contain numbered branching
points, for example 73/5035.
This manual contains a section with a list of branch-
ing points. This list shows all the components that
are connected to each branching point.
The location of the branching points is shown in the
"Cable harness routing in vehicle" section.
C. Connectors
Connectors provide a bridge between two cable harnesses and are described in the "Connectors"
section.
D. Electrical distribution
Operation of the fuses and relays is shown in the
"Electrical distribution" section.
E. Data communication
Today’s cars contain CAN, LIN and MOST networks
that transfer information. Connections to these
networks are not shown in their entirety in the
respective wiring diagram. Complete information on
CAN, LIN and MOST communication is found in the
section "Control modules".
F. Abbreviations
A number of different abbreviations are used in the
manual. These are explained in the section
"Abbreviations".
G. Component location
There is a section at the end of the manual in which
the appearance and location of components is
described in numerical order.
TP39263202 XC60 2014 © Volvo Car Corporation 2013 7
How to use the wiring diagrams 2:2
List of symbols
= System voltage
= Ground connection via wiring
= Ground connection in
component/chassis
= Screened wire
= Junction point
= Twisted cable
= Electrical connection
= Variant
= CAN communication
= CAN high data signal (CAN H)
= CAN low data signal (CAN L)
= LIN communication
= LIN communication
= DIN cable, coaxial cable, etc.
= Data communication
= CAN communication
= MOST communication
= MOST communication
= Connection with distribution box
= Further connection to...
= Connector between cable
harnesses
= Connector connected in
component
TP39263202 XC60 2014 © Volvo Car Corporation 2013 8
Electrical distribution
Overview without Start/Stop function
15/31
RD
RD
12
12
12
12
12
73/3137
73/3136
PF1
2
1
11B/27
RD-VT
RD-VT
1
2/31
R7
RD-VT
3
2
1
11A/1
11A/2
11A/4
11A/5
11A/3
1/1
1
5
2
7/240
BMS
I
U
LIN
12V
11B/17
12
BK
GY-BK
GN-VT
RD-BK
RD-BU
4/56
C1:13
RD-GY
RD-BN
C1:63
C5:1
C5:2
F17
12
F18
12
F19
12
F20
12
15/36
2/193
R4
5
2/88
R1
5
1
11C/21
1
2
11C/24
1
11C/28
1
CEM
CAN
LIN
12
1
1
1
1
1
2
3
1
3
2
2
2
C2:5
C1:9
RD-GN
RD-VT
RD-GN
15/32
21
21
21
21
21
21
11D/A1
11D/A2
11D/A3
11D/A4
11D/A5
11D/A6
F1
2
F2
2
F3
2
F4
2
F5
2
F6
VT-GN
14
74/504
74/504B
RD
VT-GN
BU
RD
RD
RD-GN
2
73/5075
RD-GN
RD-VT
21
21
5
3
1
2
5
3
1
2
11D/A11
11D/A12
2/16
RA2
2/82
RA1
A
RD-GN
31/3
TP39263202 XC60 2014 © Volvo Car Corporation 2013 9
B31W051
Electrical distribution
Overview with Start/Stop function
RD
15/31
11B/34
15/37
1
MF2
2
1
MF1
2
RD-GN
RD-VT
RD-GN
RD-GN
RD-VT
RD-VT
RD-VT
1
15/32
RD-VT
21
21
21
21
21
21
21
21
5
2
5
2
7/240
BMS
I
U
LIN
1/1
12V
3
1
3
1
1
11D/A1
11D/A2
11D/A3
11D/A4
11D/A5
11D/A6
11D/A11
11D/A12
2/16
RA2
2/82
RA1
BK
A
2
2/31
1
3
11B/27
1
1
1
1
1
1
1
2
R7
11A/1
2
2
11A/2
11A/4
2
11A/5
2
11A/3
2
5
2
11B/17
1
2
GY-BK
GN-VT
RD-BK
RD-BU
4/56
C1:63
C1:13
C5:1
C5:2
2
1
12
12
1
F17
F18
F19
2
F20
CEM
CAN
LIN
C2:17
C2:5
C1:9
74/504
VT-GN
14
RD
19
RD
74/504
RD
74/504B
2
RD-GN
73/5075
15/36
12
1
M11
2
2/246
R2
2
5
2
F10
2/166
R1
2
11C/21
1
3
1
1
5
2
11B/12
1
3
1
21
21
21
21
21
21
21
1
2
11A/1
11A/2
11A/3
11A/4
11A/5
11A/6
11A/7
11A/8
2
11A/9
RD-GY
RD-BN
RD-GN
RD
RD
RD
2/193
R4
5
3
2
1
2/88
R1
5
3
1
2
12
11C/24
12
11C/28
RD
RD
RD
RD
2
27
RD
MAN
RD
4
PF4
74/301
RD
73/3162
AUTO
RD
74/316
1/2
1
12V
73/3137
73/3136
BK
PF1
31/131
PF1
2
B31W052
31/3
TP39263202 XC60 2014 © Volvo Car Corporation 2013 10
Electrical distribution 1:3
Overview, Distribution box in engine compartment
15/31
73/3068
4 CYL & I5T STOSTA
73/3160
RD-BU
5 CYL D STOSTA
4 CYL D & I5T STOSTA
4/46B:16
73/3085
5CYL D.
RD-BU
4 CYL. & I5T STOSTA
RD-BU
6 CYL
STOSTA
74/316
2
RD-VT
W/O 4 CYL.
A
AUTO
RD-BK
GY-VT
RD
GY-VT
GY-VT
BU-OG
GY-VT
RD
RD
RD
RD
RD
RD
RD
RD-BU
RD
RD-BU
RD
5CYL D.
BU-OG
21
5
3
1
2
5
2
21
21
21
21
21
21
21
21
21
21
21
21
21
21
5
2
2/32
3
1
3
1
11B/34
2/35
R12
11B/35
11B/39
11B/40
11B/41
11B/38
11B/37
11B/36
2/14
11A/44
11A/42
11A/43
11B/30
11B/31
11B/32
11B/33
2/22
R13
R10
R11
2/17
11B/29
11B/28
11B/27
11B/17
11B/16
11B/18
11B/19
1
1B/21
1
1B/20
1
1B/22
11B/23
11B/15
2/31
11A/1
11A/2
11A/3
11A/4
11A/5
11A/6
2/182
11B/14
11B/13
11B/11
11B/9
11B/12
11B/10
11B/8
3
R8
1
12
12
12
12
12
12
12
12
12
12
1
2
2
1
3
R7
1
11A/7
12
12
12
12
12
12
12
3
R9
1
12
12
12
12
12
12
12
5
2
5
2
5
2
C3:2
GY-BK
RD
RD
GN-VT
RD
RD
RD
RD-BK
RD-BU
RD-GN
RD-GY
RD-BN
YE-GN
RD
RD
RD
RD
RD
RD-VT
RD
RD
RD
RD
4/56C1:63
4/56C1:13
9/42
4/56C5:1
4/56C5:2
15/32
15/36
15/36
RD
RD
30+
TP39263202 XC60 2014 © Volvo Car Corporation 2013 11
B31W053
Electrical distribution 2:3
Overview, Distribution box in passenger compartment
15/36
15/31
15/37
30+
1
1
1
1
11A/5
11A/4
11A/4
11A/3
R2
R3
2/88
2/193
11C/1
11C/2
11C/3
11C/4
11C/5
11C/6
11C/7
11C/8
11C/9
11C/10
11C/11
11C/12
11C/13
11C/14
11C/15
R1
R4
12
12
12
12
12
12
12
12
12
12
12
12
12
12
12
2
2
2
2
RD-GY
RD-BN
RD-GY
RD-BN
STOSTA
STOSTA
4
5
3
2
1
4
5
3
2
1
3
5
1
2
5
3
1
2
RD
73/5117
RD
RD
RD
RD
11C/17
11C/18
11C/19
11C/16
11C/20
11C/21
11C/22
11C/23
11C/24
11C/25
11C/26
11C/27
11C/28
11C/29
11C/30
12
12
12
12
12
12
12
12
12
12
12
12
12
12
12
B31W054
TP39263202 XC60 2014 © Volvo Car Corporation 2013 12
Electrical distribution 3:3
Overview, Distribution box in cargo compartment
3
30+
15/31
15/31
12
15/37
12
11A/3
11A/5
2
RD-GN
74/504B
2
15/32
STOSTA
RD-GN
RD-GN
2
RD-GN
RD-VT
RD-GN
21
21
21
21
21
21
11D/A1
11D/A2
11D/A3
11D/A4
11D/A5
11D/A6
73/5075
RD-GN
21
21
4
3
1
2
11D/A11
11D/A12
2/16
RA2
RD-VT
4
5
2
2/82
RA1
3
1
A
B31W055
TP39263202 XC60 2014 © Volvo Car Corporation 2013 13
Fuses
Distribution box in engine compartment F1 - F7
15/31 Distribution box in engine compartment
No. No. Fuse function via A
F1 11A/1 4/56 Central electronic module (CEM)
F7 Fuse in the Central electronic module (CEM)
F9-F10 Fuses in the Central electronic module (CEM)
F21 Fuse in the Central electronic module (CEM)
F23 Fuse in the Central electronic module (CEM)
F2 11A/2 4/56 Central electronic module (CEM)
F1-F6 Fuses in the Central electronic module (CEM)
F8 Fuse in the Central electronic module (CEM)
F11-F12 Fuse in the Central electronic module (CEM)
F13-F16 Fuses in the Central electronic module (CEM)
F22 Fuse in the Central electronic module (CEM)
F24 Fuses in the Central electronic module (CEM)
F3 11A/3 15/32 Distribution box cargo compartment
11D/A111D/A6 Fuses in distribution box cargo compartment
11D/A1111D/A12 Fuses in distribution box cargo compartment
F4 11A/4 2/193 Relay, comfort functions
11C/111C/15 Fuses in distribution box passenger compartment
11C/2111C/22 Fuses in distribution box passenger compartment
F5 11A/5 2/88 Relay, 15-feed
11C/2311C/25 Fuses in distribution box passenger compartment
11C/2611C/30 Fuses in distribution box passenger compartment
F7 11A/7 9/42 PTC-element - 100
continues
-
-
relay in CEM
-
-
relay in CEM
relay in CEM
relay in CEM
-
-
-
-
-
-
-
-
2/193
-
2/88
2/88
50
50
60
60
60
TP39263202 XC60 2014 © Volvo Car Corporation 2013 14
Fuses
Distribution box in engine compartment F8 - F23
15/31 Distribution box in engine compartment
No. No. Fuse function via A
F8 11B/8 9/7 Heated windshield 15/46 40
F9 11B/9 6/1 Wiper motor module (WMM) - 30
F10 11B/10 4/7 Combustion preheater module (CPM)
4/106 Control module, remote parking heater start
F11 11B/11 4/31 Fan control module
6/28 Motor, passenger compartment fan
F12 11B/12 9/7 Heated windshield 15/46 40
F13 11B/13 4/16 Brake control module (BCM), pump - 40
F14 11B/14 4/16 Brake control module (BCM), valves - 20
F15 11B/15 6/104 Washer motor headlights 2/182 20
F16 11B/16 10/1 Lamp housing, front left
10/2 Lamp housing, front right
F17 11B/17 4/56 Central electronic module (CEM)
F17-F20 Fuses in the Central electronic module (CEM)
F18 11B/18 4/16 Brake control module (BCM) - 5
F19 11B/19 4/99 Electronic power steering control module
6/164 Electrical power steering module (EHPS)
F20 11B/20 4/9 Supplemental restraint system module (SRS)
4/28 Transmission control module (TCM)
4/46 Engine control module (ECM)
F21 11B/21 9/43 Heated windshield washer nozzle, left
9/44 Heated windshield washer nozzle, right
F22 11B/22 6/164 Electrical power steering module (EHPS) - 5
F23 11B/23 3/111 Light switch module (LSM) - 5
continues
-
-
-
-
-
-
-
-
-
-
-
-
-
-
-
25
40
10
20
5
10
10
TP39263202 XC60 2014 © Volvo Car Corporation 2013 15
Fuses
Distribution box in engine compartment F27 - F37
15/31 Distribution box in engine compartment
No. No. Fuse function via A
F27 11B/27 2/17 Relay, horn
2/31 Relay, 15-feed
2/182 Relay, headlight washer motor
F28 11B/28 2/64 Relay auxiliary lights
10/65 Auxiliary lights, front right
10/69 Auxiliary lights, front left
F29 11B/29 16/10 Horn 1
16/11 Horn 2
F30 11B/30 2/32 Main relay, engine management system
4/46 Engine control module (ECM)
F31 11B/31 4/28 Transmission control module (TCM) - 15
F32 11B/32 6/73 Coolant pump
8/3 Electromagnetic clutch, climate control system
F33 11B/33 2/22 Relay, climate control system - 5
F34 11B/34 6/25 Starter motor 2/35 30
F35 11B/35 4/109 Glow plug control module, 5-Cyl. Diesel
20/3-6 Spark plug with ignition coil, 4-Cyl. Turbo
20/3-8 Spark plug with ignition coil, 6-Cyl.
20/16 Capacitor, 6-Cyl.
F36 11B/36 4/46 Engine control module (ECM), 4-Cyl. Turbo & 6-Cyl. - 10
4/46 Engine control module (ECM), 5-Cyl. Diesel - 15
F37 11B/37 7/17 Mass air flow sensor MAF, 5-Cyl. Diesel
8/98 Control valve fuel pressure, 5-Cyl. Diesel
8/111 Control valve fuel flow, 5-Cyl. Diesel
4/46 Engine control module (ECM), 6-Cyl.
7/17 Mass air flow sensor MAF, 6-Cyl.
8/6-11 Injection valves, 6-Cyl.
7/17 Mass airflow sensor (MAF), 4-Cyl. Turbo 2.0l -
continues
-
-
-
2/64
2/64
2/17
2/17
2/32
2/22
2/22
-
-
-
-
-
-
-
-
-
-
5
20
15
10
15
10
20
15
TP39263202 XC60 2014 © Volvo Car Corporation 2013 16
Fuses
Distribution box in engine compartment F38
15/31 Distribution box in engine compartment
No. No. Fuse function via A
F38 11B/38 7/17 Mass air flow sensor MAF, 4-Cyl. Turbo
8/18 EVAP valve, 4-Cyl. Turbo
8/19 Solenoid, variable valve timing, intake, 4-Cyl. Turbo
8/28 Turbocharger control valve, 4-Cyl. Turbo
8/81 Solenoid, variable valve timing, exhaust, 4-Cyl. Turbo
7/35 Oil level sensor, 5-Cyl. Diesel
8/3 Electromagnetic clutch, climate control system, 5-Cyl. Diesel
8/113 Bypass valve, EGR cooling, 5-Cyl. Diesel
8/164 Electric piston cooling valve, 5-Cyl. Diesel
4/46 Engine control module (ECM), 6-Cyl.
6/139 Upper actuator motor intake manifold, 6-Cyl. W/O Turbo.
6/140 Lower actuator motor intake manifold, 6-Cyl. W/O Turbo.
8/3 Electromagnetic clutch, climate control system, 6-Cyl.
8/28 Turbocharger control valve, 6-Cyl. Turbo
8/68 Relief valve, 6-Cyl. Turbo
8/117 Solenoid, variable valve timing, intake, 6-Cyl.
8/125 Solenoid cam profile front, 6-Cyl. W/O Turbo
8/126 Solenoid cam profile rear, 6-Cyl. W/O Turbo
continues
-
-
-
-
-
-
-
-
-
-
-
-
-
-
-
-
-
-
10
TP39263202 XC60 2014 © Volvo Car Corporation 2013 17
Fuses
Distribution box in engine compartment F39 - F44
15/31 Distribution box in engine compartment
No. No. Fuse function via A
F39 11B/39 7/15 Front heated oxygen sensor, 4-Cyl. Turbo
7/82 Rear heated oxygen sensor bank 1, 4-Cyl. Turbo
7/15 Front heated oxygen sensor, 5-Cyl. Diesel
7/15 Front heated oxygen sensor, bank 1, 6-Cyl.
7/82 Rear heated oxygen sensor, bank 1, 6-Cyl.
7/103 Front heated oxygen sensor, bank 2 6-Cyl. W/O Turbo
7/104 Rear heated oxygen sensor, bank 2 6-Cyl. W/O Turbo
8/18 EVAP valve, 6-Cyl.
F40 11B/40 6/179 Electric transmission oil pump
9/38 Heated fuel filter, 5-Cyl. Diesel
F41 11B/41 6/67 Pump, fuel leakage control 6-Cyl.
6/179 Electric transmission oil pump, Diesel
9/32 PTC resistor crankcase ventilation, 5-Cyl. Diesel
F42 11A/42 4/109 Glow plug control module
20/22-26 Glow plug, 5-Cyl. Diesel
F43 11A/43 4/71 Control module cooling fan 4-Cyl. Turbo - 60
4/71 Cooling fan control module, 5-Cyl. Diesel & 6-Cyl. - 80
F44 11A/44 6/164 Electrical power steering module (EPS) - 100
-
-
-
-
-
-
-
-
-
2/14
-
-
-
-
4/109
10
15
20
5
70
TP39263202 XC60 2014 © Volvo Car Corporation 2013 18
Fuses
Central electronic module (CEM) F1 - F6
4/56 Central electronic module (CEM)
No. Fuse function via A
F1 2/16 Relay, rear window wiper
6/32 Rear window wiper motor
F3 3/26 Switch unit, power driver’s seat
3/27 Switch unit, power passenger seat
3/176 Power window switches, driver’s door
3/291 Tailgate closing switch
4/52 Power seat module (PSM)
10/25 Ceiling light cargo compartment
10/29 Glove compartment lighting
10/97 Left-hand front courtesy lighting
10/102 Right-hand front courtesy lighting
10/125 Left-hand front courtesy lighting
10/126 Right-hand front courtesy lighting
10/173 Load space illumination lamp, tailgate
10/261 Ground illumination lighting, driver’s side
10/262 Ground illumination lighting, passenger side
17/45 Alcolock outlet
26/6 Converter/control module, sill moldings, driver’s side
26/7 Converter/control module, sill moldings, passenger side
26/8 Alcolock charging cradle
F4 5/1 Driver Information module (DIM) - 5
F5 4/80 Forward Sensing Module (FSM)
7/203 Forward-aimed radar (FLR)
F6 7/149 Rain sensor module (RSM)
10/22 Ceiling light
10/114 Vanity mirror lighting, left
10/115 Vanity mirror lighting, right
10/150A Rear reading light
10/150B Rear reading light
continues
-
2/16
-
-
-
-
-
-
-
-
-
-
-
-
-
-
-
-
-
-
-
-
-
-
-
-
-
-
15
7.5
10
7.5
TP39263202 XC60 2014 © Volvo Car Corporation 2013 19
Fuses
Central electronic module (CEM) F7 - F16
4/56 Central electronic module (CEM)
No. Fuse function via A
F7 3/4 Steering wheel switch left (SWSL)
3/130 Steering wheel module (SWM)
3/131 Steering wheel switch right (SWSR)
F8 6/37 Lock motor, fuel filler flap - 10
F9 6/127 Washer motor
4/148 Heated Steering Wheel Module (HSWM)
F10 6/127 Washer motor
15/46 Relay box in engine compartment
F11 6/8 Central locking motor, tailgate - 10
F12 8/59 Head restraint solenoid left rear
8/60 Head restraint solenoid right rear
6/141 Motor folding head restraint left
6/142 Motor folding head restraint right
F13 4/83 Control module fuel pump
6/33 Fuel pump
F14 3/112 Climate control module (CCM)
4/119 Remote Keyless Entry (RKE)
4/119.2 Remote Receiver Module (RRX)
7/122 Mass movement sensor module (MMS), front
F15 4/102 Steering column lock module (SCL) Relay in
F16 16/35 Siren control module (SCM)
17/13 Data link connector
continues
3/130
-
3/130
-
-
-
-
-
-
-
-
-
4/83
-
-
-
-
CEM
-
-
7.5
15
15
10
20
5
15
5
TP39263202 XC60 2014 © Volvo Car Corporation 2013 20
Fuses
Central electronic module (CEM) F18 - F24
4/56 Central electronic module (CEM)
No. Fuse function via A
F18 4/9 Supplemental restraint system module (SRS)
7/93 Occupant weight sensor (OWS)
F19 4/80 Forward Sensing Module (FSM)
4/125 Closing velocity module (CVM)
7/203 Forward-aimed radar (FLR)
F20 3/65 Switch, heated rear seat
7/51 Accelerator pedal sensor
8/48 Auto-dimming rearview mirror
9/42 PTC-element
F21 - -15
F22 3/9 Contact brake light - 5
F23 4/33 Sun roof module (SRM) - 20
F24 3/1 Ignition lock
16/65 Immobilizer antenna unit
-
-
-
-
-
-
-
-
-
-
-
10
5
7.5
5
TP39263202 XC60 2014 © Volvo Car Corporation 2013 21
Fuses
Distribution box in passenger compartment F1 - F20
15/36 Distribution box in passenger compartment
No. No. Fuse function via A
F1 11C/1 11C/16-20 Fuses in distribution box passenger compartment
16/105 Audio module (AUD)
F7 11C/7 17/19 12 V outlet, cargo compartment - 15
F8 11C/8 3/126 Driver door module (DDM) - 20
F9 11C/9 3/127 Passenger door module (PDM) - 20
F10 11C/10 3/129 Right rear door module (RDM) - 20
F11 11C/11 3/128 Left rear door module (LDM) - 20
F12 11C/12 4/93 Keyless vehicle module (KVM) - 20
F13 11C/13 3/26 Switch unit, power driver’s seat
4/52 Power seat module (PSM)
F14 11C/14 3/27 Switch unit, power passenger seat - 20
F16 11C/16 3/281 Infotainment control module (ICM) - 5
F17 11C/17 16/36 TV Receiver
16/105 Audio module (AUD)
16/145 Remote Digital Audio Receiver (RDAR)
16/162 Digital Audio Broadcast Module (DABM)
F18 11C/18 4/124 Accessory USB unit (AUU)
16/1 Integrated Audio Module (IAM)
F19 11C/19 16/60 Phone module (PHM) - 5
F20 11C/20 16/109 RSE control module - 7.5
continues
-40
-
-
-
-
-
-
-15
20
10
TP39263202 XC60 2014 © Volvo Car Corporation 2013 22
Fuses
Distribution box in passenger compartment F21 - F30
15/36 Distribution box in passenger compartment
No. No. Fuse function via A
F21 11C/21 4/33 Panoramic roof control module
6/48 Damper motor module (DMM), recirculation
6/95 Damper motor module (DMM), temperature, left-hand side
6/96 Damper motor module (DMM), temperature, right-hand side
6/102 Damper motor module (DMM), defroster
6/103 Damper motor module (DMM), floor/ventilation
7/159 Air quality sensor (AQS)
10/22 Ceiling light
16/159 Control module, cellular phone handsfree
F22 11C/22 9/1 Outlet 12V front
9/25 Outlet 12V rear
16/45 Navigation system & Traffic information, portable
16/164 Screen, LH head restraint
16/165 Screen, RH head restraint
F23 11C/23 9/15 Control module, rear right seat heater - 15
F24 11C/24 9/14 Control module, rear left seat heater - 15
F25 11C/25 4/131 Control module lumbar support massage, left
4/133 Control module lumbar support massage, right
F26 11C/26 9/13 Seat heating module (SHM), passenger side - 15
F27 11C/27 9/12 Seat heating module (SHM), driver’s side - 15
F28 11C/28 4/86 Parking Assistance Module (PAM)
4/110 Trailer module (TRM)
4/120 Parking Assistance Camera (PAC)
4/126 Side Obstacle Detection Control Module left (SODL)
4/127 Side Obstacle Detection Control Module right (SODR)
F29 11C/29 4/82 Differential electronic module (DEM) - 15
F30 11C/30 4/84 Suspension module (SUM) - 10
-
-
-
-
-
-
-
4/56
-
-
-
-
-
-
-
-
-
-
-
-
-
5
15
10
5
TP39263202 XC60 2014 © Volvo Car Corporation 2013 23
Fuses
Distribution box in cold zone F1 - MF2
F10 F11 F12
R2
2/246
MF1
MF2
F6
I01322215/37
D1F9 R1
2/166
F1
F2 F3 F4 F5
15/37 Distribution box in cold zone engine compartment, Start/Stop function
No. No. Fuse function via A
F1 11A/1 9/42 PTC-element - 100
F2 11A/2 4/56C5:1 Central electronic module (CEM) - 50
F3 11A/3 2/88 Relay, 15-feed rear
11C/23-11C/30 Fuses in distribution box passenger compartment
F4 11A/4 2/193 Relay, comfort functions
11C/1-11C/15 Fuses in distribution box passenger compartment
11C/21-11C/22 Fuses in distribution box passenger compartment
F5 11A/5 15/32 Distribution box in cargo compartment - 60
F6 11A/6 4/31 Fan control module
6/28 Motor, passenger compartment fan
F7 11A/7 Spare --
F8 11A/8 Spare --
F9 11A/9 6/25 Starter motor 2/35 30
F10 11A/10 Diode D1 -50
F11 M11 Secondary battery 2/246 70
F12 11B/12 4/56 Central electronic module (CEM) - 15
MF1 MF1 11A/1-11A/8 Main fuses in engine compartment fuse box (15/31) - 175
MF2 MF2 11A/1-11A/8 Fuses in fuse box cold zone engine compartment (15/37)
6/26 Alternator control module (ACM)
-
2/88
-
-
2/193
-
-
- 175
60
60
40
TP39263202 XC60 2014 © Volvo Car Corporation 2013 24
Fuses
Distribution box in cargo compartment FA1 - FA11
15/32 Distribution box in cargo compartment
No. No. Fuse function via A
FA1 11D/A1 4/115 Park Brake Module (PBM) - 30
FA2 11D/A2 4/115 Park Brake Module (PBM) - 30
FA3 11D/A3 2/82 Relay, heated rear window - 30
9/2 Heated rear window 2/82
FA4 11D/A4 17/39 13-pin outlet, tow hitch cable harness - 15
FA5 11D/A5 4/116 Power Operated Tailgate Module (POT) - 20
FA11 11D/A11 4/110 Trailer module (TRM) - 40
TP39263202 XC60 2014 © Volvo Car Corporation 2013 25
Fuses
Battery PF1 - PF2
PF1
PF2
1/1 Battery
No. Fuse function via A
PF1 11A/1-11A/7 Main fuses in distribution box engine compartment - 150
11A/42-11A/44 Main fuses in distribution box engine compartment -
11B/8-11B/14 Fuses in the engine compartment distribution box -
11B/16-11B/22 Fuses in the engine compartment distribution box 2/31
11B/23 Fuses in the engine compartment distribution box -
11B/27-11B/32 Fuses in the engine compartment distribution box -
11B/33 Fuses in the engine compartment distribution box 2/32
11B/34 Fuses in the engine compartment distribution box -
11B/35-11B/41 Fuses in the engine compartment distribution box 2/32
PF2 6/25 Starter motor - 150
6/26 Alternator control module (ACM) -
TP39263202 XC60 2014 © Volvo Car Corporation 2013 26
Relays
Relays in the engine compartment
R2
2/246
15/37 Distribution box in cold zone engine compartment
Pos Relay function
R1 2/166 Battery relay
R2 2/246 Secondary battery relay
R1
2/166
I01322315/37
15/31 Distribution box in engine compartment
Pos Relay function
R7 2/31 Relay, 15-feed
R8 2/17 Relay, horn
R9 2/182 Relay, headlight washer motor
I01946615/31
TP39263202 XC60 2014 © Volvo Car Corporation 2013 27
Relays
Relays in the engine compartment
15/31 Distribution box in engine compartment
Pos Relay function
R10 2/32 Main relay, engine management system
R11 2/14 Relay, diesel filter heater, 5-Cyl. Diesel
R12 2/35 Relay, starter motor
R13 2/22 Relay, climate control system
1
15/46
15/46 Relay box in engine compartment
Pos Relay function
R1 2/81A Relay, heated windshield, passenger side
R2 2/81B Relay, heated windshield, driver’s side
R1
2
5
4
3
2/81A
R2
5
4
21
1
3
2/81B
H01546A
TP39263202 XC60 2014 © Volvo Car Corporation 2013 28
Relays
Relays in passenger and cargo compartments
15/36 Distribution box in passenger compartment
Pos Relay function
R1 2/88 Relay, 15-feed
R2 2/92 Relay, washer motor windshield
R3 2/93 Relay, washer motor rear window
R4 2/193 Relay, comfort functions
15/32 Distribution box in cargo compartment
Pos Relay function
RA1 2/82 Relay, heated rear window
RA2 2/16 Relay, rear window wiper
TP39263202 XC60 2014 © Volvo Car Corporation 2013 29
Ground connections
Overview
31/95
31/93
31/3
31/2
31/4
31/
XX14
31/
XX10
31/XX4
31/88
31/89
31/90
31/AL
31/96
31/94
31/131
31/83
31/10
31/6
31/65
31/66
31/115
31/7
31/84
31/15
31/
INFOT
31/67
31/68
31/47
31/TRM
TP39263202 XC60 2014 © Volvo Car Corporation 2013 30
31/5
31/48
B32G001
Loading...