Volvo XC60 2013 User Manual

VOLVO XC60

WIRING DIAGRAM 2013

TP 39253202 Structure week 12w20

Vehicles with SRS (Airbag)/SIPS bag/IC (Inflatable Curtain)

Warning!

Extra caution must be exercised when working on vehicles equipped with SRS/SIPS bag/IC in order to avoid:

1. Personal injuries when performing repair work.

2. Damage or malfunction of the SRS/SIPS bag/IC system. Work involving the SRS/SIPS bag/IC systems or other components in the vehicle that may affect the SRS/SIPS bag/IC systems must always be performed by an authorized Volvo workshop. In case of doubt, consult the SRS and SIPS bag/IC service manual.

Is the vehicle equipped with SRS/SIPS bag/IC?

Vehicles with SRS are most easily recognized by the letters SRS in the center of the steering wheel. If the vehicle also has a passenger side airbag, the letters SRS are stamped on the dashboard above the glove compartment. SRS vehicles from 1993 and onward also have explosive seat belt tensioners. SIPS bags are only installed on SRS vehicles from 1995 and onward. SIPS bag decals are located on the windshield and seat compartment. Vehicles with IC can be recognized by the letters IC on the C/D panel (4 door) or the B panel (5 door).

General recommendations

• Be especially careful when working on or around SRS, SIPS, and IC components.

• Make sure that no wires are pinched, frayed, or pierced.

• Never install accessories by the sensors.

• Where applicable, work on the steering wheel, steering shaft, or steering gear must be done in accordance with the methods in the SRS section of VIDA.

• Certain components of the aforementioned systems must be grounded while working. Read the appropriate sections in VIDA.

• Install no accessories in the areas between the A and B-posts, the B and C-posts, and the C and D-posts.

Test terminal

Data link connector in the passenger compartment.

Changes introduced up to and including structure week 12w20

Any changes made to the vehicles after this date are not included in the manual. If necessary refer to service bulletins.

Volvo models are sold in versions adapted for different markets. These adaptations depend on factors such as legal requirements, taxation, and market demands. This manual may therefore include illustrations and text that do not apply to the vehicles in your country.

Ordering: Electronic Wiring Diagrams (EWD) can be ordered from the Technical Information Shop (TIS) We reserve the right to make modifications.

Table of Contents 1:3

Vehicles with SRS (Airbag)/SIPS bag/IC (Inflatable Cur-

tain) .......................................................................... 2

Explanations.................................................................. 6

Abbreviations ................................................................. 6

How to use the wiring diagrams 1:2............................... 7

Electrical distribution

Overview without Start/stop function ............................. 9

Overview with Start/stop function ................................ 10

Overview, Distribution box in engine compartment ..... 11

Overview, Distribution box in passenger compartment 12

Overview, Distribution box in cargo compartment....... 13

Fuses

Distribution box in engine compartment F1-F7.............14

Distribution box in engine compartment F8 - F23......... 15

Distribution box in engine compartment F27-F37.........16

Distribution box in engine compartment F38 ................17

Distribution box in engine compartment F39 - F44....... 18

Central electronic module (CEM) F1 - F6 ..................... 19

Central electronic module (CEM) F7 - F16................... 20

Central electronic module (CEM) F18 - F24 ................. 21

Distribution box in passenger compartment F1 - F20... 22 Distribution box in passenger compartment F21 - F30. 23

Distribution box in cold zone F1 - MF2 ......................... 24

Distribution box in cargo compartment FA1 - FA11...... 25

Battery PF1 - PF2 ......................................................... 26

Relays

Relays in the engine compartment R1 - R9................. 27

Relays in the engine compartment R10 - R13............. 28

Relays in passenger and cargo compartments ........... 29

Ground connections

Overview...................................................................... 30

31/1 - 31/7 ................................................................... 31

31/10 - 31/15 ............................................................... 32

31/15 - 31/48 ............................................................... 33

31/65 - 31/83 ............................................................... 34

31/84 - 31/90 ............................................................... 35

31/93 - 31/131 ............................................................. 36

31/XX4 - 31/TRM ......................................................... 37

Control modules

Overview locations....................................................... 38

Overview designations................................................. 39

Central electronic module (CEM) 1:3........................... 40

Data communication high speed CAN ......................... 43

Data communication intermediate speed CAN, LHD... 44 Data communication intermediate speed CAN, RHD .. 45

Data communication Local CAN .................................. 46

Data communication MOST ......................................... 47

Data communication, LIN 1:2....................................... 48

Steering Wheel Module (SWM) ................................... 50

Group 26 Cooling system

Cooling fan 4-Cyl. Turbo .............................................. 51

Cooling fan, 5-Cyl. Diesel ............................................ 52

Cooling fan 6-Cyl. ........................................................ 53

Group 27 Engine controls

Cruise control 4-Cyl. Turbo........................................... 54

Cruise control 5-Cyl. Diesel ..........................................55

Cruise control 6-Cyl. .....................................................56

Start-/Stop function 4-Cyl. Turbo ..................................57

Start-/stop function 5-Cyl. Diesel .................................. 58

Group 28 Ignition and control system

Engine management system, 5-Cyl. Diesel 1:3........... 59

Engine management system, 4-Cyl. Turbo 2.0l 1:2..... 62

Engine management system 6-Cyl. 1:2....................... 64

Engine management system, 6-Cyl. Turbo 1:2............ 66

Emission control 4-Cyl. Turbo...................................... 68

Emission control 6-Cyl. ................................................ 69

Group 32 Alternator and voltage regulator

Power supply 4-Cyl. Turbo........................................... 70

Power supply 5-Cyl. & 6-Cyl........................................ 71

Power supply 4- & 5-Cyl. with Start/Stop..................... 72

Group 33 Starting system

Starting system 4-Cyl. Turbo ....................................... 73

Starting system 5- & 6-Cyl. .......................................... 74

TP39253202 XC60 2013 3

Table of Contents 2:3

Group 35 Lighting

High and low beam...................................................... 75

High and low beam (Dual Xenon)................................ 76

Beam length adjustment, manual ................................ 77

Running/Parking light, Tail lights ................................. 78

Fog lights ..................................................................... 79

Daytime Running Lights .............................................. 80

Brake lights .................................................................. 81

Reversing lights ........................................................... 82

Follow-me-home lighting LHD ..................................... 83

Follow-me-home lighting RHD..................................... 84

Active headlight ........................................................... 85

Interior lighting, LHD 1:2 .............................................. 86

Interior lighting, RHD 1:2 ............................................. 88

Lighting in door sill trims .............................................. 90

Auxiliary lights.............................................................. 91

Group 36 Additional electrical equipment

Rain sensor.................................................................. 92

Direction indicator and hazard warning flashers LHD . 93 Direction indicator and hazard warning flashers RHD. 94

Wiper/Washer windshield ............................................ 95

Washer headlights ....................................................... 96

Wiper/Washer rear window.......................................... 97

Keyless vehicle 1:2...................................................... 98

Horn ...................................................................... 100

Anti-theft alarm .......................................................... 101

Parking assistance..................................................... 102

Collision warning with power brake booster .............. 103

Tire pressure monitoring system (TPMS) .................. 104

Alcohol lock................................................................ 105

Group 37 Wiring and fuses

Diagnostics system.................................................... 106

Outlet 12 V................................................................. 107

Cable harness towbar/tow hitch 4-pin ....................... 108

Cable harness towbar/tow hitch 7-pin........................ 109

Cable harness towbar/tow hitch 13-pin...................... 110

USB unit (AUU).......................................................... 111

Group 38 Instruments

Seat belt reminder ..................................................... 112

Driver information module.......................................... 113

Group 39 Other

Rear seat entertainment, RSE................................... 114

Audio High/Premium 1:3............................................ 115

Audio 1:2 ................................................................... 118

Cellular phone 1:2...................................................... 120

DAB Radio................................................................. 122

Multimedia monitor with DVD, Dual Screen RSE ...... 123

TV receiver / TV control module ............................... 124

Bluetooth Handsfree .................................................. 125

Navigation system & Traffic information, portable ..... 126

Satellite radio ............................................................. 127

Parking camera.......................................................... 128

Parking camera rear .................................................. 129

Wide angle camera front............................................ 130

Group 43 Transmission

Automatic transmission AWF21................................. 131

Transmission M66...................................................... 132

Automatic transmission MPS6 ................................... 133

Differential electronic module (DEM) ......................... 134

Group 55 Parking brake

Electric parking brake ................................................ 135

Group 59 Brake system

Brake control system & DSTC ................................... 136

Group 64 Steering

Speed dependent power steering.............................. 137

Group 76 Shock absorbers

Four-C ...................................................................... 138

Group 83 Doors and openings

Central locking front doors LHD................................. 139

Central locking front doors RHD ................................ 140

Central locking rear doors.......................................... 141

Central locking tailgate with POT............................... 142

Central locking tailgate without POT.......................... 143

Signal receiver central locking ................................... 144

Central locking fuel filler flap ...................................... 145

Power windows front doors LHD................................ 146

Power windows front doors RHD ............................... 147

Power windows rear doors......................................... 148

Power sunroof............................................................ 149

Group 84 Exterior decorative elements, etc.

Power door mirrors LHD ............................................ 150

Power door mirrors RHD............................................ 151

Heated door mirrors LHD........................................... 152

Heated door mirrors RHD.......................................... 153

Blind spot information system LHD............................ 154

Blind spot information system RHD ........................... 155

Heated rear window ................................................... 156

TP39253202 XC60 2013 4

Table of Contents 3:3

Group 85 Interior equipment

Power driver’s seat with memory function, LHD........ 157

Power driver’s seat with memory function, RHD ....... 158

Power passenger seat, LHD...................................... 159

Power passenger seat, RHD ..................................... 160

Heated front seats with fans ...................................... 161

Heated front seats without fans................................. 162

Heated rear seat ........................................................ 163

Adjustable Lumbar support........................................ 164

Group 87 Climate control system

Climate control system PTC-elements ...................... 165

Climate control system, 4-Cyl. 1:2............................. 166

Climate control system 5-Cyl. & 6-Cyl. 1:2................ 168

Parking heater, auxiliary heater................................. 170

Parking heater, remote start ...................................... 171

Group 88 Internal equipment

Supplemental restraint system 1:2 ............................ 172

Remote control opener garage door.......................... 174

Power folding headrest.............................................. 175

Rear-view mirror with automatic dimming.................. 176

Connectors .............................................. 177

Branching points .....................................214

Cable harness routing in vehicle

Harness engine 4-Cyl. Turbo......................................233

Harness engine, 6-Cyl. ............................................... 233

Harness engine, 6-Cyl. Turbo.....................................234

Harness engine, Diesel 2.0l........................................ 234

Harness engine, Diesel 2.4l........................................ 235

Engine compartment harness ..................................... 236

Dashboard harness, LHD ...........................................237

Harness Dashboard, RHD ..........................................238

Floor Harness, LHD .................................................... 239

Floor Harness, RHD....................................................240

Harness infotainment, LHD......................................... 241

Harness infotainment, RHD ........................................ 242

Roof harness ..............................................................243

Center console harness .............................................. 243

Tunnel harness ...........................................................244

Harness front door, left ...............................................245

Harness front door, right .............................................245

Harness rear door, left ................................................246

Harness rear door, right .............................................. 246

Tailgate harness .........................................................247

Harnesses rear axle.................................................... 247

Component illustrations..........................248

Index 1:2....................................................303

List of components 1:7........................... 305

TP39253202 XC60 2013 5

Explanations Abbreviations

Groups

Group 26 = Cooling system Group 27 = Engine controls Group 28 = Ignition and control system Group 32 = Alternator and voltage regulator Group 33 = Starting system Group 35 = Lighting Group 36 = Additional electrical equipment Group 37 = Wiring and fuses Group 38 = Instruments Group 39 = Other Group 43 = Transmission Group 55 = Parking brake Group 59 = Brake system Group 64 = Steering Group 76 = Shock absorbers Group 83 = Doors and openings Group 84 = Exterior decorative elements, etc. Group 85 = Interior equipment Group 87 = Climate control system Group 88 = Internal equipment Group 89 = Body other

Ignition switch symbols

X = Accessories (audio position) S = Powered upon insertion of key 15 = Contact remains connected during

start 15l = Contact is broken while starting 30 = Constant power from the battery 50 = Start

Countries/Markets

A= Austria AUS = Australia B = Belgium CDN = Canada CH = Switzerland D = Germany DK = Denmark E = Spain EU/OS = Markets outside USA and Canada FIN = Finland GB = Great Britain ISR = Israel J= Japan KOR = Korea N= Norway NL = Netherlands S = Sweden USA = United States of America WEU = Western Europe

Other

ACC = Adaptive Cruise Control Ag = Silver plated Au = Gold plated AUTO = Automatic transmission BLIS = Blind spot information system CAN = CAN communication DPY = Display ECC = Electronic climate control system ETA = Throttle unit EXC = Exclusive GDL = Gas discharge lamp HS = High speed data bus KEYLESS = Keyless vehicle IR = Infrared sensor LIN = LIN communication LH = Left-hand side LHD = Left-hand drive MAN = Manual transmission MEMORY = Memory driver’s seat MIRCAM = Parking camera in rear-view mirror MS = Midspeed data bus MMS = Mass Movement Sensor PANROOF = Panoramic roof PETROL = Gasoline RH = Right-hand side RHD = Right-hand drive RTI = Road Traffic Information SCR = Screened SRS = Airbag T = Turbocharged engine W/O = Without 2WD = Two-wheel drive 4CYL, I4 = 4-cylinder engine 5CYL, I5 = 5-cylinder engine 6CYL, I6 = 6-cylinder engine

Colors

BK, SB = Black BN = Brown BU, BL = Blue GN = Green GY, GR = Gray LGN = Light Green NL = Natural OG, OR = Orange PK, P = Pink RD, R = Red VT, VO = Violet WH, W = White YE, Y = Yellow

TP39253202 XC60 2013 6

How to use the wiring diagrams 1:2

The descriptions below apply in general to all wiring diagram manuals, although not all sections are necessarily contained in this manual.

A. Component designation

Every component has a component designation that consists of two parts.

The first part is a type number that describes the type of component in question, for example 3/xx.

The second part of the designation is a serial number, e.g. x/2.

Together, this constitutes a component designation, e.g. 3/2.

At the end of the manual is a list of components, where, with the help of the component designation, you can read off the name of the component, for example, 3/2 = light switch.

List of type numbers

The list shows which type of component that respec tive type numbers refer to, for example, 3/x = switch, 6/x = electric motor, etc.

1 Battery 2 Relay 3Switch 4 Control module 5 Driver information module 6 Electric motor 7Sensor 8 Actuator 9 Heating element 10 Light 11 Fuse 15 Electrical distribution rail/box 16 Audio 17 Service/diagnostics 18 Contact reel 19 Meter 20 Ignition component/shunt 27 Optics 31 Ground connection 73 Branching point 74 Connector

The systems are shown in non-active status.i.e. with "key removed" and when the doors, hatches and hood are closed.

B. Branching points

The wiring diagrams contain numbered branching points, for example 73/5035.

This manual contains a section with a list of branching points. This list shows all the components that are connected to each branching point.

The location of the branching points is shown in the "Cable harness routing in vehicle" section.

C. Connectors

Connectors provide a bridge between two cable harnesses and are described in the "Connectors" section.

D. Electrical distribution

Operation of the fuses and relays is shown in the "Electrical distribution" section.

E. Data communication

Today’s cars contain CAN, LIN and MOST networks that transfer information. Connections to these networks are not shown in their entirety in the respective wiring diagram. Complete information on CAN, LIN and MOST communication is found in the section "Control modules".

F. Abbreviations

A number of different abbreviations are used in the manual. These are explained in the section "Abbreviations".

G. Component location

There is a section at the end of the manual in which the appearance and location of components is described in numerical order.

TP39253202 XC60 2013 7

How to use the wiring diagrams 2:2

List of symbols

= System voltage

= Ground connection via wiring

= Ground connection in component/chassis = Screened wire

= Junction point

= Twisted cable

= Electrical connection

= Variant

= CAN communication

= CAN high data signal (CAN H)

= CAN low data signal (CAN L)

= LIN communication

= DIN cable, coaxial cable, etc.

= Data communication

= CAN communication

= MOST communication

= Connection with distribution box

= Further connection to...

= Connector between cable harnesses = Connector connected in component

TP39253202 XC60 2013 8

15/36

2/88

2/193

11D/A6

11D/A5

11D/A3

11D/A2

11D/A1

11D/A4

11D/A11

11D/A12

2/82

15/32

RA2

RA1

RD-GN

RD-VT

73/5075

2/16

74/504B

2/31

11A/3

11A/2

11A/1

11A/4

11A/5

11B/17

15/31

11B/27

C1:63

C1:13

C5:1

C5:2

C2:5

C2:17

C1:9

N00004

GY-BK

RD-BU

RD-BK

GN-VT

RD-GN

RD-BN

RD-GY

RD-GN

74/504

VT-GN

CAN

CEM

4/56

LIN

F17

F20

12V

31/3

1/1

PF1

RD-VT

7/240

BMS

LIN

73/3137

73/3136

GND

Electrical distribution Overview without Start/stop function

TP39253202 XC60 2013 9

15/36

2/88

2/193

11D/A6

11D/A5

11D/A3

11D/A2

11D/A1

11D/A4

11D/A11

11D/A12

2/82

15/32

RA2

RA1

RD-GN

RD-VT

73/5075

2/16

74/504B

2/31

11A/3

11A/2

11A/1

11A/4

11A/5

11B/17

15/31

11B/27

CAN

CEM

4/56

C1:63

C1:13

C5:1

C5:2

LIN

C2:5

C2:17

C1:9

GY-BK

RD-BU

RD-BK

GN-VT

RD-GN

RD-BN

RD-GY

RD-GN

74/504

VT-GN

11A/8

15/37

2/246

11A/7

11B/12

2/166

11A/6

MF1

F10

11A/2

MF2

M11

11A/1

11A/4 11A/5

11A/3

11A/9

12V

31/131

1/2

74/301

74/504

74/316

12V

31/3

1/1

PF1

PF4

PF1

RD-VT

7/240

BMS

LIN

73/3137

73/3136

MAN

73/3162

AUTO

11B/34

N00009

Electrical distribution Overview with Start/stop function

TP39253202 XC60 2013 10

15/31

11B/36

11B/37

11B/38

11B/41

11B/18

11B/16

11B/17

73/3068

73/3085

11B/19

1B/20

1B/21

1B/22

11B/23

11B/28

11B/29

YE-GN

GY-BK

GN-VT

RD-BK

RD-BU

RD-GN

RD-GY

RD-BN

15/36

15/32

4/56C5:2

4/56C5:1

4/46B:16

6 CYL

GY-VT

RD-BK

11B/27

11A/1 11A/2 11A/3 11A/4 11A/5 11A/6

11A/7

11B/40

11B/39

11A/43

11A/42

11A/44

11B/33

11B/32

11B/31

11B/30

11B/35

11B/34

2/22

R13

R10

2/31

2/32

2/35

R12

11B/13 11B/11

11B/9 11B/12 11B/10

11B/14

11B/8

9/42

4/56C1:13

4/56C1:63

RD-VT

2/14

R11

YE-GN

B00001

2/17

2/182

RD-VT

73/3160

74/316

STOSTA

RD-BU

30+

GY-BU

4 CYL D. STOSTA

73/3152

GY-BU

BU-OG

5CYL D.

BU-OG

5CYL D.

C3:2

RD-BU

4 CYL D & I5T STOSTA

5 CYL D STOSTA

Electrical distribution 1:3 Overview, Distribution box in engine compartment

TP39253202 XC60 2013 11

Electrical distribution 2:3

2/88

2/193

11C/3

11C/2

11C/1

11C/4

11C/7

11C/6

11C/5

11C/8

11C/10

11C/9

11C/11

11C/14

11C/13

11C/12

11C/15

11C/18

11C/17

11C/19

11C/25

11C/24

11C/23

11C/22

11C/21

11C/16

11C/20

11C/27

11C/26

11C/28

11C/29

11C/30

73/5117

15/36

RD-BN

RD-GY

I012227

15/31

11A/5

11A/4

30+

15/37

11A/3

11A/4

RD-GY

RD-BN

STOSTA

Overview, Distribution box in passenger compartment

TP39253202 XC60 2013 12

11D/A6

11D/A5

11D/A3

11D/A2

11D/A1

11D/A4

11D/A11

11D/A12

2/82

15/32

RA2

RA1

RD-GN

RD-VT

73/5075

2/16

74/504B

RD-GN

N00006

11A/5

RD-GN

15/37

STOSTA

15/31

11A/3

15/31

30+

Electrical distribution 3:3 Overview, Distribution box in cargo compartment

TP39253202 XC60 2013 13

Fuses Distribution box in engine compartment F1-F7

15/31 Distribution box in engine compartment

No. No. Fuse function via A

F1 11A/1 4/56 Central electronic module (CEM)

F7 Fuse in the Central electronic module (CEM) F9-F10 Fuses in the Central electronic module (CEM) F21 Fuse in the Central electronic module (CEM) F23 Fuse in the Central electronic module (CEM)

F2 11A/2 4/56 Central electronic module (CEM)

F1-F6 Fuses in the Central electronic module (CEM) F8 Fuse in the Central electronic module (CEM) F11-F12 Fuse in the Central electronic module (CEM) F13-F16 Fuses in the Central electronic module (CEM) F22 Fuse in the Central electronic module (CEM) F24 Fuses in the Central electronic module (CEM)

F3 11A/3 15/32 Distribution box cargo compartment

11D/A111D/A6 Fuses in distribution box cargo compartment 11D/A1111D/A12 Fuses in distribution box cargo compartment

F4 11A/4 2/193 Relay, comfort functions

11C/111C/15 Fuses in distribution box passenger compartment 11C/2111C/22 Fuses in distribution box passenger compartment

F5 11A/5 2/88 Relay, 15-feed

11C/2311C/25 Fuses in distribution box passenger compartment 11C/2611C/30 Fuses in distribution box passenger compartment

F7 11A/7 9/42 PTC-element - 100

continues

relay in CEM

relay in CEM relay in CEM relay in CEM

2/193

2/88

TP39253202 XC60 2013 14

Fuses Distribution box in engine compartment F8 - F23

15/31 Distribution box in engine compartment

No. No. Fuse function via A

F8 11B/8 2/182 Relay, headlight washer motor

6/104 Washer motor headlights

F9 11B/9 6/1 Wiper motor module (WMM) - 30

F10 11B/10 4/7 Combustion preheater module (CPM)

4/106 Control module, remote parking heater start

F11 11B/11 4/31 Fan control module

6/28 Motor, passenger compartment fan

F13 11B/13 4/16 Brake control module (BCM), pump - 40 F14 11B/14 4/16 Brake control module (BCM), valves - 20 F16 11B/16 10/1 Lamp housing, front left

10/2 Lamp housing, front right

F17 11B/17 4/56 Central electronic module (CEM)

F17-F20 Fuses in the Central electronic module (CEM)

F18 11B/18 4/16 Brake control module (BCM) - 5 F19 11B/19 4/99 Electronic power steering control module

6/164 Electrical power steering module (EHPS)

F20 11B/20 4/9 Supplemental restraint system module (SRS)

4/28 Transmission control module (TCM) 4/46 Engine control module (ECM)

F21 11B/21 9/43 Heated windshield washer nozzle, left

9/44 Heated windshield washer nozzle, right

F22 11B/22 6/164 Electrical power steering module (EHPS) - 5 F23 11B/23 3/111 Light switch module (LSM) - 5

continues

2/182

TP39253202 XC60 2013 15

Fuses Distribution box in engine compartment F27-F37

15/31 Distribution box in engine compartment

No. No. Fuse function via A

F27 11B/27 2/17 Relay, horn

2/31 Relay, 15-feed 2/182 Relay, headlight washer motor

F28 11B/28 2/64 Relay auxiliary lights

10/65 Auxiliary lights, front right 10/69 Auxiliary lights, front left

F29 11B/29 16/10 Horn 1

16/11 Horn 2

F30 11B/30 2/32 Main relay, engine management system

4/46 Engine control module (ECM)

F31 11B/31 4/28 Transmission control module (TCM) - 15 F32 11B/32 6/73 Coolant pump

8/3 Electromagnetic clutch, climate control system

F33 11B/33 2/22 Relay, climate control system - 5 F34 11B/34 6/25 Starter motor 2/35 30 F35 11B/35 4/109 Glow plug control module, 5-Cyl. Diesel

20/3-6 Spark plug with ignition coil, 4-Cyl. Turbo 20/3-8 Spark plug with ignition coil, 6-Cyl.

20/16 Capacitor, 6-Cyl.

F36 11B/36 4/46 Engine control module (ECM), 4-Cyl. Turbo & 6-Cyl. - 10

4/46 Engine control module (ECM), 5-Cyl. Diesel - 15

F37 11B/37 7/17 Mass air flow sensor MAF, 5-Cyl. Diesel

8/98 Control valve fuel pressure, 5-Cyl. Diesel 8/111 Control valve fuel flow, 5-Cyl. Diesel

4/46 Engine control module (ECM), 6-Cyl. 7/17 Mass air flow sensor MAF, 6-Cyl. 8/6-11 Injection valves, 6-Cyl.

continues

2/64 2/64

2/17 2/17

2/32

2/22 2/22

TP39253202 XC60 2013 16

Fuses Distribution box in engine compartment F38

15/31 Distribution box in engine compartment

No. No. Fuse function via A

F38 11B/38 7/17 Mass air flow sensor MAF, 4-Cyl. Turbo

8/18 EVAP valve, 4-Cyl. Turbo 8/19 Solenoid, variable valve timing, intake, 4-Cyl. Turbo 8/28 Turbocharger control valve, 4-Cyl. Turbo 8/81 Solenoid, variable valve timing, exhaust, 4-Cyl. Turbo

7/35 Oil level sensor, 5-Cyl. Diesel 8/3 Electromagnetic clutch, climate control system, 5-Cyl. Diesel 8/113 Bypass valve, EGR cooling, 5-Cyl. Diesel 8/164 Electric piston cooling valve, 5-Cyl. Diesel

4/46 Engine control module (ECM), 6-Cyl. 6/139 Upper actuator motor intake manifold, 6-Cyl. W/O Turbo. 6/140 Lower actuator motor intake manifold, 6-Cyl. W/O Turbo. 8/3 Electromagnetic clutch, climate control system, 6-Cyl. 8/28 Turbocharger control valve, 6-Cyl. Turbo 8/68 Relief valve, 6-Cyl. Turbo 8/117 Solenoid, variable valve timing, intake, 6-Cyl. 8/125 Solenoid cam profile front, 6-Cyl. W/O Turbo 8/126 Solenoid cam profile rear, 6-Cyl. W/O Turbo

continues

TP39253202 XC60 2013 17

Fuses Distribution box in engine compartment F39 - F44

15/31 Distribution box in engine compartment

No. No. Fuse function via A

F39 11B/39 7/15 Front heated oxygen sensor, 4-Cyl. Turbo

7/82 Rear heated oxygen sensor bank 1, 4-Cyl. Turbo 7/15 Front heated oxygen sensor, 5-Cyl. Diesel

7/15 Front heated oxygen sensor, bank 1, 6-Cyl. 7/82 Rear heated oxygen sensor, bank 1, 6-Cyl. 7/103 Front heated oxygen sensor, bank 2 6-Cyl. W/O Turbo 7/104 Rear heated oxygen sensor, bank 2 6-Cyl. W/O Turbo 8/18 EVAP valve, 6-Cyl.

F40 11B/40 6/179 Electric transmission oil pump

9/38 Heated fuel filter, 5-Cyl. Diesel

F41 11B/41 6/67 Pump, fuel leakage control 6-Cyl.

6/179 Electric transmission oil pump, Diesel 9/32 PTC resistor crankcase ventilation, 5-Cyl. Diesel

F42 11A/42 4/109 Glow plug control module

20/22-26 Glow plug, 5-Cyl. Diesel

F43 11A/43 4/71 Control module cooling fan 4-Cyl. Turbo - 60

4/71 Cooling fan control module, 5-Cyl. Diesel & 6-Cyl. - 80

F44 11A/44 6/164 Electrical power steering module (EPS) - 100

2/14

4/109

TP39253202 XC60 2013 18

Fuses Central electronic module (CEM) F1 - F6

4/56 Central electronic module (CEM)

No. Fuse function via A

F1 2/16 Relay, rear window wiper

6/32 Rear window wiper motor

F3 3/26 Switch unit, power driver’s seat

3/27 Switch unit, power passenger seat 3/176 Power window switches, driver’s door 3/291 Tailgate closing switch 4/52 Power seat module (PSM) 10/25 Ceiling light cargo compartment 10/29 Glove compartment lighting 10/125 Left-hand front courtesy lighting 10/126 Right-hand front courtesy lighting 17/45 Alcolock outlet 26/6 Converter/control module, sill moldings, driver’s side 26/7 Converter/control module, sill moldings, passenger side 26/8 Alcolock charging cradle

F4 5/1 Driver Information module (DIM) - 5 F5 4/80 Forward Sensing Module (FSM)

7/203 Forward-aimed radar (FLR)

F6 7/149 Rain sensor module (RSM)

10/22 Ceiling light 10/114 Vanity mirror lighting, left 10/115 Vanity mirror lighting, right 10/150A Rear reading light 10/150B Rear reading light

continues

2/16

7.5

TP39253202 XC60 2013 19

Fuses Central electronic module (CEM) F7 - F16

4/56 Central electronic module (CEM)

No. Fuse function via A

F7 3/4 Steering wheel switch left (SWSL)

3/130 Steering wheel module (SWM) 3/131 Steering wheel switch right (SWSR)

F8 6/37 Lock motor, fuel filler flap - 10

F9 6/127 Washer motor - 15 F10 6/127 Washer motor - 15 F11 6/8 Central locking motor, tailgate - 10 F12 8/59 Head restraint solenoid left rear

8/60 Head restraint solenoid right rear 6/141 Motor folding head restraint left 6/142 Motor folding head restraint right

F13 4/83 Control module fuel pump

6/33 Fuel pump

F14 4/6 Climate control module (CCM)

4/119 Remote Keyless Entry (TRX) 4/119.2 Remote Receiver Module (RRX) 7/122 Mass movement sensor module (MMS), front

F15 4/102 Steering column lock module (SCL) Relay in

F16 16/35 Siren control module (SCM)

17/13 Data link connector

continues

3/130

4/83

CEM

7.5

TP39253202 XC60 2013 20

Fuses Central electronic module (CEM) F18 - F24

4/56 Central electronic module (CEM)

No. Fuse function via A

F18 4/9 Supplemental restraint system module (SRS)

7/93 Occupant weight sensor (OWS)

F19 4/80 Forward Sensing Module (FSM)

4/125 Closing velocity module (CVM) 7/203 Forward-aimed radar (FLR)

F20 3/65 Switch, heated rear seat

7/51 Accelerator pedal sensor 8/48 Auto-dimming rearview mirror 9/42 PTC-element

F21 - -15 F22 3/9 Contact brake light - 5 F23 4/33 Sun roof module (SRM) - 20 F24 3/1 Ignition lock

16/65 Immobilizer antenna unit

7.5

TP39253202 XC60 2013 21

Fuses Distribution box in passenger compartment F1 - F20

15/36 Distribution box in passenger compartment

No. No. Fuse function via A

F1 11C/1 11C/16-20 Fuses in distribution box passenger compartment

16/105 Audio module (AUD)

F7 11C/7 17/19 12 V outlet, cargo compartment - 15 F8 11C/8 3/126 Driver door module (DDM) - 20

F9 11C/9 3/127 Passenger door module (PDM) - 20 F10 11C/10 3/129 Right rear door module (RDM) - 20 F11 11C/11 3/128 Left rear door module (LDM) - 20 F12 11C/12 4/93 Keyless vehicle module (KVM) - 20 F13 11C/13 3/26 Switch unit, power driver’s seat

4/52 Power seat module (PSM)

F14 11C/14 3/27 Switch unit, power passenger seat - 20 F16 11C/16 3/281 Infotainment control module (ICM) - 5 F17 11C/17 16/36 TV Receiver

16/105 Audio module (AUD) 16/145 Remote Digital Audio Receiver (RDAR) 16/162 Digital Audio Broadcast Module (DABM)

F18 11C/18 4/124 Accessory USB unit (AUU)

16/1 Integrated Audio Module (IAM) F19 11C/19 16/60 Phone module (PHM) - 5 F20 11C/20 16/109 RSE control module - 7.5

continues

-40

-15

TP39253202 XC60 2013 22

Fuses Distribution box in passenger compartment F21 - F30

15/36 Distribution box in passenger compartment

No. No. Fuse function via A

F21 11C/21 4/33 Panoramic roof control module

6/48 Damper motor module (DMM), recirculation

6/95 Damper motor module (DMM), temperature, left-hand side

6/96 Damper motor module (DMM), temperature, right-hand side

6/102 Damper motor module (DMM), defroster

6/103 Damper motor module (DMM), floor/ventilation

7/159 Air quality sensor (AQS)

10/22 Ceiling light

16/159 Control module, cellular phone handsfree F22 11C/22 9/1 Outlet 12V front

9/25 Outlet 12V rear

16/45 Navigation system & Traffic information, portable

16/164 Screen, LH head restraint

16/165 Screen, RH head restraint F23 11C/23 9/15 Control module, rear right seat heater - 15

F24 11C/24 9/14 Control module, rear left seat heater - 15 F25 11C/25 4/131 Control module lumbar support massage, left

4/133 Control module lumbar support massage, right F26 11C/26 9/13 Seat heating module (SHM), passenger side - 15

F27 11C/27 9/12 Seat heating module (SHM), driver’s side - 15 F28 11C/28 4/86 Parking Assistance Module (PAM)

4/110 Trailer module (TRM)

4/120 Parking Assistance Camera (PAC) F29 11C/29 4/82 Differential electronic module (DEM) - 15

F30 11C/30 4/84 Suspension module (SUM) - 10

4/56

TP39253202 XC60 2013 23

MF1

D1F9 R1

F10 F11 F12

F2 F3 F4 F5

MF2

2/166

2/246

I01322215/37

Fuses Distribution box in cold zone F1 - MF2

15/37 Distribution box in cold zone engine compartment, Start/Stop function

No. No. Fuse function via A

F1 11A/1 9/42 PTC-element - 100 F2 11A/2 4/56C5:1 Central electronic module (CEM) - 50 F3 11A/3 2/88 Relay, 15-feed rear

11C/23-11C/30 Fuses in distribution box passenger compartment

F4 11A/4 2/193 Relay, comfort functions

11C/1-11C/15 Fuses in distribution box passenger compartment

11C/21-11C/22 Fuses in distribution box passenger compartment

F5 11A/5 15/32 Distribution box in cargo compartment - 60 F6 11A/6 4/31 Fan control module

6/28 Motor, passenger compartment fan

F7 11A/7 Spare -F8 11A/8 Spare --

F9 11A/9 6/25 Starter motor 2/35 30 F10 11A/10 Diode D1 -50 F11 M11 Secondary battery 2/246 70 F12 11B/12 4/56 Central electronic module (CEM) - 5

MF1 MF1 11A/1-11A/8 Main fuses in engine compartment fuse box (15/31) - 175 MF2 MF2 11A/1-11A/8 Fuses in fuse box cold zone engine compartment (15/37)

6/26 Alternator control module (ACM)

2/88

2/193

-175

TP39253202 XC60 2013 24

Fuses Distribution box in cargo compartment FA1 - FA11

15/32 Distribution box in cargo compartment

No. No. Fuse function via A

FA1 11D/A1 4/115 Park Brake Module (PBM) - 30

FA2 11D/A2 4/115 Park Brake Module (PBM) - 30 FA3 11D/A3 2/82 Relay, heated rear window - 30

9/2 Heated rear window 2/82 FA4 11D/A4 17/39 13-pin outlet, tow hitch cable harness - 15 FA5 11D/A5 4/116 Power Operated Tailgate Module (POT) - 30

FA11 11D /A11 4/110 Trai ler mo dule (TRM) - 4 0

TP39253202 XC60 2013 25

Fuses Battery PF1 - PF2

1/1 Battery

No. Fuse function via A

PF1 11A/1-11A/7 Main fuses in distribution box engine compartment - 150

11A/42-11A/44 Main fuses in distribution box engine compartment 11B/8-11B/14 Fuses in the engine compartment distribution box 11B/16-11B/22 Fuses in the engine compartment distribution box 2/31 11B/23 Fuses in the engine compartment distribution box 11B/27-11B/32 Fuses in the engine compartment distribution box 11B/33 Fuses in the engine compartment distribution box 2/32 11B/34 Fuses in the engine compartment distribution box 11B/35-11B/41 Fuses in the engine compartment distribution box 2/32

PF2 6/25 Starter motor - 150

6/26 Alternator control module (ACM) -

TP39253202 XC60 2013 26

2/166

2/246

I01322315/37

I01946615/31

Relays Relays in the engine compartment R1 - R9

15/37 Distribution box in cold zone engine compartment

Pos Relay function

R1 2/166 Battery relay R2 2/246 Secondary battery relay

15/31 Distribution box in engine compartment

Pos Relay function

R7 2/31 Relay, 15-feed R8 2/17 Relay, horn R9 2/182 Relay, headlight washer motor

TP39253202 XC60 2013 27

Relays Relays in the engine compartment R10 - R13

15/31 Distribution box in engine compartment

Pos Relay function

R10 2/32 Main relay, engine management system R11 2/14 Relay, glow plug system R12 2/35 Relay, starter motor R13 2/22 Relay, climate control system

TP39253202 XC60 2013 28

Relays Relays in passenger and cargo compartments

15/36 Distribution box in passenger compartment

Pos Relay function

R1 2/88 Relay, 15-feed R4 2/193 Relay, comfort functions

15/32 Distribution box in cargo compartment

Pos Relay function

RA1 2/82 Relay, heated rear window RA2 2/16 Relay, rear window wiper

TP39253202 XC60 2013 29

31/AL

31/1

31/96

31/XX4

31/2

31/4

31/3

31/7

31/6

31/84

31/10

31/15

31/68

31/65

31/47

31/67

31/83

31/93

31/95

31/

INFOT

31/88

31/89

31/90

31/66

31/ XX10

31/94

31/5

31/48

31/TRM

31/ XX15

31/ XX14

I03208

31/131

Ground connections Overview

TP39253202 XC60 2013 30

+ 281 hidden pages