Volvo XC60 2012 User Manual

VOLVO XC60

WIRING DIAGRAM 2012

TP 39215202

Vehicles with SRS (Airbag)/SIPS bag/IC (Inflatable Curtain)

Warning!

Extra caution must be exercised when working on vehicles equipped with SRS/SIPS bag/IC
in order to avoid:

1. Personal injuries when performing repair work.

2. Damage or malfunction of the SRS/SIPS bag/IC system.
Work involving the SRS/SIPS bag/IC systems or other components in the vehicle that may
affect the SRS/SIPS bag/IC systems must always be performed by an authorized Volvo
workshop.
In case of doubt, consult the SRS and SIPS bag/IC service manual.

Is the vehicle equipped with SRS/SIPS bag/IC?

Vehicles with SRS are most easily recognized by the letters SRS in the center of the steering
wheel. If the vehicle also has a passenger side airbag, the letters SRS are stamped on the
dashboard above the glove compartment. SRS vehicles from 1993 and onward also have
explosive seat belt tensioners. SIPS bags are only installed on SRS vehicles from 1995 and
onward. SIPS bag decals are located on the windshield and seat compartment. Vehicles with
IC can be recognized by the letters IC on the C/D panel (4 door) or the B panel (5 door).

General recommendations

• Be especially careful when working on or around SRS, SIPS, and IC components.

• Make sure that no wires are pinched, frayed, or pierced.

• Never install accessories by the sensors.

• Where applicable, work on the steering wheel, steering shaft, or steering gear must be done
in accordance with the methods in the SRS section of VIDA.

• Certain components of the aforementioned systems must be grounded while working. Read
the appropriate sections in VIDA.

• Install no accessories in the areas between the A and B-posts, the B and C-posts, and the C
and D-posts.

Test ter m i n al

Data link connector in the passenger compartment.

Changes introduced up to and including structure week 11w20

Any changes made to the vehicles after this date are not included in the manual. If necessary
refer to service bulletins.

Volvo models are sold in versions adapted for different markets. These adaptations depend
on factors such as legal requirements, taxation, and market demands.
This manual may therefore include illustrations and text that do not apply to the vehicles in
your country.

Ordering:
Electronic Wiring Diagrams (EWDs) can be ordered from the Technical Information Shop
(TIS) at www.volvocarstechinfo.ford.com/vss
We reserve the right to make modifications.

© Volvo Car Corporation

Table of Contents 1:3

Vehicles with SRS (Airbag)/SIPS bag/IC (Inflatable

Curtain).......................................................................... 2

Explanations .................................................................. 6

Abbreviations................................................................. 6

How to use the wiring diagrams 1:2............................... 7

Electrical distribution

Overview without Start/stop function ............................. 9

Overview with Start/stop function ................................ 10

Overview, Distribution box in engine compartment ..... 11

Overview, Distribution box in passenger compartment 12

Overview, Distribution box in cargo compartment ....... 13

Fuses

Distribution box in engine compartment F1-F7............. 14

Distribution box in engine compartment F8 - F23 ......... 15

Distribution box in engine compartment F27 - F37 ....... 16

Distribution box in engine compartment F38 - F39 ....... 17

Distribution box in engine compartment F40 - F44 ....... 18

Central electronic module (CEM) F1 - F13 ................... 19

Central electronic module (CEM) F14 - F24................. 20

Distribution box in passenger compartment F1 - F19 ... 21
Distribution box in passenger compartment

F21 - F30 ...................................................................... 22

Distribution box in cold zone F1 - MF2 ......................... 23

Distribution box in cargo compartment FA1 - FA11...... 24

Battery PF1 - PF2......................................................... 25

Relays

Relays in the engine compartment R1 - R9................. 26

Relays in the engine compartment R10 - R13............. 27

Relays in passenger and cargo compartments ........... 28

Ground connections

Overview...................................................................... 29

31/1 - 31/7 ................................................................... 30

31/10 - 31/15 ............................................................... 31

31/47 - 31/68 ............................................................... 32

31/83 - 31/88 ............................................................... 33

31/89 - 31/96 ............................................................... 34

31/131 - 31/TRM.......................................................... 35

Control modules

Overview locations....................................................... 36

Overview designations................................................. 37

Central electronic module (CEM) 1:3........................... 38

Data communication high speed CAN ......................... 41

Data communication intermediate speed CAN, LHD... 42
Data communication intermediate speed CAN, RHD .. 43

Data communication Local CAN.................................. 44

Data communication MOST......................................... 45

Data communication, LIN 1:2....................................... 46

Steering Wheel Module (SWM) ................................... 48

Group 26 Cooling system

Cooling fan 4-Cyl. Turbo.............................................. 49

Cooling fan, 5-Cyl. Diesel ............................................ 50

Cooling fan 6-Cyl. ........................................................ 51

Group 27 Engine controls

Cruise control 4-Cyl. Turbo...........................................52

Cruise control 5-Cyl. Diesel ..........................................53

Cruise control 6-Cyl. .....................................................54

Start-/Stop function 4-Cyl. 1.6L. Turbo .........................55

Start-/Stop function 4-Cyl. 1.6L. Diesel.........................56

Start-/Stop function 5-Cyl. Diesel..................................57

Group 28 Ignition and control system

Engine management system, 5-Cyl. Diesel 1:3 ........... 58

Engine management system, 4-Cyl. Turbo 2.0l 1:2..... 61

Engine management system 6-Cyl. 1:2 ....................... 63

Engine management system 6-Cyl. B6324S4 1:2 ....... 65

Engine management system, 6-Cyl. Turbo 1:2............ 67

Emission control 4-Cyl. Turbo...................................... 69

Emission control 6-Cyl. ................................................ 70

Group 32 Alternator and voltage regulator

Power supply 4-Cyl. Turbo........................................... 71

Power supply 5-Cyl. & 6-Cyl. ....................................... 72

Group 33 Starting system

Starting system 4-Cyl. Turbo ....................................... 73

Starting system 5- & 6-Cyl. .......................................... 74

TP39215202 XC60 2012 3

Table of Contents 2:3

Group 35 Lighting

High and low beam...................................................... 75

High and low beam (Dual Xenon)................................ 76

Beam length adjustment, manual ................................ 77

Running/Parking light, Tail lights ................................. 78

Running/Parking light, Tail lights (Dual Xenon) ........... 79

Fog lights ..................................................................... 80

Brake lights.................................................................. 81

Reversing lights ........................................................... 82

Follow-me-home lighting LHD ..................................... 83

Follow-me-home lighting RHD..................................... 84

Interior lighting, LHD 1:2 .............................................. 85

Interior lighting, RHD 1:2 ............................................. 87

Active headlight ........................................................... 89

Lighting in door sill trims .............................................. 90

Auxiliary lights.............................................................. 91

Group 36 Additional electrical equipment

Rain sensor.................................................................. 92

Direction indicator and hazard warning flashers

LHD ........................................................................ 93

Direction indicator and hazard warning flashers

RHD ........................................................................ 94

Wiper/Washer windshield ............................................ 95

Washer headlights ....................................................... 96

Wiper/Washer rear window.......................................... 97

Horn ........................................................................ 98

Keyless vehicle 1:2...................................................... 99

Anti-theft alarm .......................................................... 101

Parking assistance..................................................... 102

Collision warning with power brake booster .............. 103

Tire pressure monitoring system (TPMS) .................. 104

Alcohol lock................................................................ 105

Group 37 Wiring and fuses

Diagnostics system.................................................... 106

Outlet 12 V................................................................. 107

Cable harness towbar/tow hitch 4-pin ....................... 108

Cable harness towbar/tow hitch 7-pin........................ 109

Cable harness towbar/tow hitch 13-pin...................... 110

USB unit (AUU).......................................................... 111

Rear seat entertainment, RSE................................... 122

Multimedia monitor with DVD, Dual Screen RSE ...... 123

TV receiver / TV control module ............................... 124

Bluetooth Handsfree .................................................. 125

Navigation system & Traffic information, portable ..... 126

Satellite radio ............................................................. 127

Parking camera.......................................................... 128

Parking camera rear .................................................. 129

Wide angle camera front............................................ 130

Group 43 Transmission

Automatic transmission TF-80SC .............................. 131

Transmission M66 & MMT 6...................................... 132

Automatic transmission MPS6................................... 133

Differential electronic module (DEM) ......................... 134

Group 55 Parking brake

Electric parking brake ................................................ 135

Group 59 Brake system

Brake control system & DSTC ................................... 136

Group 64 Steering

Speed dependent power steering .............................. 137

Group 76 Shock absorbers

Four-C ...................................................................... 138

Group 83 Doors and openings

Central locking front doors LHD................................. 139

Central locking front doors RHD ................................ 140

Central locking rear doors.......................................... 141

Central locking tailgate with POT............................... 142

Central locking tailgate without POT.......................... 143

Signal receiver central locking ................................... 144

Central locking fuel filler flap...................................... 145

Power windows front doors LHD................................ 146

Power windows front doors RHD ............................... 147

Power windows rear doors......................................... 148

Power sunroof............................................................ 149

Group 38 Instruments

Seat belt reminder ..................................................... 112

Driver information module.......................................... 113

Group 39 Other

Audio High/Premium 1:3............................................ 114

Audio 1:2 ................................................................... 117

Cellular phone 1:2...................................................... 119

DAB Radio................................................................. 121

TP39215202 XC60 2012 4

Group 84 Exterior decorative elements, etc.

Power door mirrors LHD ............................................ 150

Power door mirrors RHD............................................ 151

Heated door mirrors LHD........................................... 152

Heated door mirrors RHD .......................................... 153

Blind spot information system LHD............................ 154

Blind spot information system RHD ........................... 155

Heated rear window................................................... 156

Table of Contents 3:3

Group 85 Interior equipment

Power driver’s seat with memory function, LHD........ 157

Power driver’s seat with memory function, RHD ....... 158

Power passenger seat, LHD...................................... 159

Power passenger seat, RHD ..................................... 160

Heated front seats with fans ...................................... 161

Heated front seats without fans ................................. 162

Heated rear seat........................................................ 163

Group 87 Climate control system

Climate control system, 4-Cyl. 1:2............................. 164

Climate control system 5-Cyl. & 6-Cyl. 1:2 ................ 166

Climate control system PTC-elements ...................... 168

Parking heater, auxiliary heater................................. 169

Parking heater, remote start ...................................... 170

Group 88 Internal equipment

Rear-view mirror with automatic dimming.................. 171

Supplemental restraint system 1:2 ............................ 172

Remote control opener garage door.......................... 174

Power folding headrest.............................................. 175

Group 89 Body other

Radiator masking blind .............................................. 176

Connectors .............................................. 177

Branching points .....................................211

Cable harness routing in vehicle

Harness engine 4-Cyl. Turbo ......................................228

Engine harness, 6-Cyl.................................................228

Harness engine, 6-Cyl. Turbo .....................................229

Harness engine, Diesel 2.0l........................................229

Harness engine, Diesel 2.4l........................................230

Engine compartment harness.....................................231

Dashboard harness, LHD ...........................................232

Harness Dashboard, RHD .......................................... 233

Floor Harness, LHD ....................................................234

Floor Harness, RHD....................................................235

Harness infotainment, LHD.........................................236

Harness infotainment, RHD ........................................237

Roof harness ..............................................................238

Center console harness..............................................238

Tunnel harness ...........................................................239

Harness front door, left ...............................................240

Harness front door, right ............................................. 240

Harness rear door, left ................................................241

Harness rear door, right.............................................. 241

Tailgate harness ......................................................... 242

Harnesses rear axle....................................................242

Component illustrations ..........................243

Index 1:2 ....................................................295

List of components 1:6 ........................... 297

TP39215202 XC60 2012 5

Explanations
Abbreviations

Groups

Group 26 = Cooling system
Group 27 = Engine controls
Group 28 = Ignition and control system
Group 32 = Alternator and voltage regulator
Group 33 = Starting system
Group 35 = Lighting
Group 36 = Additional electrical equipment
Group 37 = Wiring and fuses
Group 38 = Instruments
Group 39 = Other
Group 43 = Transmission
Group 55 = Parking brake
Group 59 = Brake system
Group 64 = Steering
Group 76 = Shock absorbers
Group 83 = Doors and openings
Group 84 = Exterior decorative elements, etc.
Group 85 = Interior equipment
Group 87 = Climate control system
Group 88 = Internal equipment
Group 89 = Body other

Ignition switch symbols

X= Accessories (audio position)
S= Powered upon insertion of key
15 = Contact remains connected during

start
15l = Contact is broken while starting
30 = Constant power from the battery
50 = Start

Countries/Markets

A= Austria
AUS = Australia
B= Belgium
CDN = Canada
CH = Switzerland
D= Germany
DK = Denmark
E= Spain
EU/OS = Markets outside USA and Canada
FIN = Finland
GB = Great Britain
ISR = Israel
J= Japan
KOR = Korea
N= Norway
NL = Netherlands
S= Sweden
USA = United States of America
WEU = Western Europe

Other

ACC = Adaptive Cruise Control
Ag = Silver plated
Au = Gold plated
AUTO = Automatic transmission
BLIS = Blind spot information system
CAN = CAN communication
DPY = Display
ECC = Electronic climate control system
ETA = Throttle unit
EXC = Exclusive
GDL = Gas discharge lamp
HS = High speed data bus
KEYLESS = Keyless vehicle
IR = Infrared sensor
LIN = LIN communication
LH = Left-hand side
LHD = Left-hand drive
MAN = Manual transmission
MEMORY = Memory driver’s seat
MIRCAM = Parking camera in rear-view mirror
MS = Midspeed data bus
MMS = Mass Movement Sensor
PANROO F = Pano r amic r o of
PETROL = Gasoline
RH = Right-hand side
RHD = Right-hand drive
RTI = Road Traffic Information
SCR = Screened
SRS = Airbag
T= Turbocharged engine
W/O = Without
2WD = Two-wheel drive
4CYL, I4 = 4-cylinder engine
5CYL, I5 = 5-cylinder engine
6CYL, I6 = 6-cylinder engine

Colors

BK, SB = Black
BN = Brown
BU, BL = Blue
GN = Green
GY, GR = Gray
LGN = Light Green
NL = Natural
OG, OR = Orange
PK, P = Pink
RD, R = Red
VT, VO = Violet
WH, W = White
YE, Y = Yellow

TP39215202 XC60 2012 6

How to use the wiring diagrams 1:2

The descriptions below apply in general
to all wiring diagram manuals, although
not all sections are necessarily con­tained in this manual.

A. Component designation

Every component has a component designation that
consists of two parts.

The first part is a type number that describes the
type of component in question, for example 3/xx.

The second part of the designation is a serial num­ber, e.g. x/2.

Together, this constitutes a component designation,
e.g. 3/2.

At the end of the manual is a list of components,
where, with the help of the component designation,
you can read off the name of the component, for
example, 3/2 = light switch.

List of type numbers

The list shows which type of component that respec­tive type numbers refer to, for example, 3/x = switch,
6/x = electric motor, etc.

1Battery
2Relay
3Switch
4Control module
5Driver information module
6Electric motor
7Sensor
8Actuator
9Heating element
10 Light
11 F use
15 Electrical distribution rail/box
16 Audio
17 Service/diagnostics
18 Contact reel
19 Meter
20 Ignition component/shunt
27 Optics
31 Ground connection
73 Branching point
74 Connector

The systems are shown in non-active
status. i.e. with "key removed" and when
the doors, hatches and hood are closed.

B. Branching points

The wiring diagrams contain numbered branching
points, for example 73/5035.

This manual contains a section with a list of branch­ing points. This list shows all the components that
are connected to each branching point.

The location of the branching points is shown in the
"Cable harness routing in vehicle" section.

C. Connectors

Connectors provide a bridge between two cable har­nesses and are described in the "Connectors" sec­tion.

D. Electrical distribution

Operation of the fuses and relays is shown in the
"Electrical distribution" section.

E. Data communication

Today’s cars contain CAN, LIN and MOST networks
that transfer information. Connections to these net­works are not shown in their entirety in the respec­tive wiring diagram. Complete information on CAN,
LIN and MOST communication is found in the sec­tion "Control modules".

F. A bb re vi a ti on s

A number of different abbreviations are used in the
manual. These are explained in the section "Abbre­viations".

G. C om po ne nt l oc at io n

There is a section at the end of the manual in which
the appearance and location of components is
described in numerical order.

TP39215202 XC60 2012 7

How to use the wiring diagrams 2:2

List of symbols

= System voltage

= Ground connection via wiring

= Ground connection in
component/chassis
= Screened wire

= Junction point

= Twisted cable

= Electrical connection

= Variant

= CAN communication

= CAN high data signal (CAN H)

= CAN low data signal (CAN L)

= LIN communication

= LIN communication

= DIN cable, coaxial cable, etc.

= Data communication

= CAN communication

= MOST communication

= MOST communication

= Connection with distribution box

= Further connection to...

= Connector between cable
harnesses
= Connector connected in
component

TP39215202 XC60 2012 8

15/36

R1

2/88

2

1

3

5

R4

2/193

2

1

3

5

11D/A7

21

11D/A6

21

11D/A5

21

11D/A8

21

11D/A3

21

11D/A2

21

11D/A1

21

11D/A4

21

11D/A10

21

11D/A9

21

11D/A11

21

11D/A12

21

2

1

3

5

2/82

15/32

RA2

2

1

3

5

A

RA1

RD-GN

RD-GN

RD-GN

RD-VT

RD-VT

73/5075

2/16

74/504B

2

R7

2/31

2

1

3

5

11A/3

12

11A/2

12

11A/1

12

11A/4

12

11A/5

12

11B/17

RD

1

2

12

15/31

11B/27

C1:63

C1:13

C5:1

C5:2

30+

C2:5

C2:17

C1:9

I013545

12

12

12

12

12

GY-BK

RD-BU

RD-BK

GN-VT

RD-GN

RD-BN

RD-GY

RD-GN

74/504

14

VT-GN

VT-GN

BU

CAN

CEM

4/56

LIN

12

12

12

12

12

12

12

12

12

F17

F20

12

F1

F6

TP39215202 XC60 2012 9

Electrical distribution

Overview without Start/stop function

15/36

R1

2/88

2

1

3

5

R4

2/193

2

1

3

5

11D/A7

21

11D/A6

21

11D/A5

21

11D/A8

21

11D/A3

21

11D/A2

21

11D/A1

21

11D/A4

21

11D/A10

21

11D/A9

21

11D/A11

21

11D/A12

21

2

1

3

5

2/82

15/32

RA2

2

1

3

5

A

RA1

RD-GN

RD-GN

RD-GN

RD-VT

RD-VT

73/5075

2/16

74/504B

2

R7

2/31

11A/3

1

2

11A/2

1

2

11A/1

1

2

11A/4

1

2

11A/5

1

2

11B/17

RD

1

2

1

2

15/31

11B/27

CAN

CEM

4/56

C1:63

C1:13

C5:1

C5:2

LIN

C2:5

C2:17

C1:9

I013546

12

12

12

12

12

GY-BK

RD-BU

RD-BK

GN-VT

RD-GN

RD-BN

RD-GY

RD-GN

74/504

14

VT-GN

VT-GN

BU

21

212121

21

21

11A/8

21

2

1

3

5

15/37

R2

2/246

2

1

2

1

2

1

3

5

2

1

3

5

11A/7

2

1

2

1

11B/12

2

1

2

1

2

1

R1

2/166

11A/6

MF1

F10

11A/2

MF2

M11

11A/1

11A/4

11A/5

11A/3

11A/9

12V

BK

31/131

1/2

RD

74/301

27

74/504

3

74/316

4

RD

RD

RD

RD

12V

BK

31/3

1/1

RD

2

1

PF1

2

1

PF4

Electrical distribution

Overview with Start/stop function

TP39215202 XC60 2012 10

Electrical distribution 1:3

15/31

11B/36

21

11B/37

21

11B/38

21

11B/41

11B/18

12

11B/16

12

11B/17

73/3068

73/3085

12

11B/19

12

1

1B/20

12

1

1B/21

12

1

1B/22

12

11B/23

12

11B/28

12

11B/29

12

YE-GN

RD

RD

RD

RD

GY-BK

RD

RD

GN-VT

RD-BK

RD-GN

RD-GY

RD-BN

15/36

15/36

15/32

4/56C5:2

4/56C5:1

RD

RD

RD

4/46B:16

5&6 CYL.T

RD

RD

RD

RD

RD

RD

RD

RD

GY-VT

GY-VT

GY-VT

GY-VT

RD

RD-BK

RD

11B/27

12

11A/1
11A/2
11A/3
11A/4
11A/5
11A/6

12

11A/7

12

12

12

12

12

12

21

11B/40

21

11B/39

21

11A/43

21

11A/42

21

11A/44

21

11B/33

21

11B/32

21

11B/31

21

11B/30

21

11B/35

21

11B/34

21

2

1

3

5

2/22

R13

R10

2

1

3

5

2/31

R7

2

1

3

5

2/32

2

1

3

5

2/35

R12

11B/13
11B/11

11B/9
11B/12
11B/10

12

11B/14

12

12

12

12

12

11B/8

12

9/42

4/56C1:13

4/56C1:63

RD

RD-VT

RD

2/142

R11

Diesel

2/133

R11

4 Cyl. T

4 Cyl. T &

4 Cyl. T

4 Cyl. T

5 Cyl. D

5 Cyl. D

BU-OG

GN-OG

GN-OG

BU-OG

YE-GN

74/301

16

I012216

2

1

3

5

2/17

R8

2

1

3

5

2/182

R9

RD-VT

RD

RD

RD

A

RD-BU

RD-BU

30+

Overview, Distribution box in engine compartment

TP39215202 XC60 2012 11

Electrical distribution 2:3

2

1

3

5

4

R2

R1

2/88

2

1

3

5

4

R3

2

1

3

5

R4

2/193

2

1

3

5

11C/3

12

11C/2

12

11C/1

12

11C/4

12

11C/7

12

11C/6

12

11C/5

12

11C/8

12

11C/10

12

11C/9

12

11C/11

12

11C/14

12

11C/13

12

11C/12

12

11C/15

12

11C/18

12

11C/17

12

11C/19

12

11C/25

12

11C/24

12

11C/23

12

11C/22

12

11C/21

12

11C/16

12

11C/20

12

11C/27

12

11C/26

12

12

11C/28

12

11C/29

12

11C/30

RD

RD

RD

RD

RD

73/5117

15/36

RD-BN

RD-GY

I012227

15/31

11A/5

1

2

11A/4

1

2

30+

15/37

11A/3

1

2

11A/4

1

2

RD-GY

RD-BN

STOSTA

STOSTA

Overview, Distribution box in passenger compartment

TP39215202 XC60 2012 12

11D/A7

21

11D/A6

21

11D/A5

21

11D/A8

21

11D/A3

21

11D/A2

21

11D/A1

21

11D/A4

21

11D/A10

21

11D/A9

21

11D/A11

21

11D/A12

21

2

1

3

5

2/82

15/32

RA2

2

1

3

5

A

RA1

RD-GN

RD-GN

RD-GN

RD-GN

RD-VT

RD-VT

73/5075

2/16

74/504B

2

I012220

15/31

11A/3

12

3

15/31

2

30+

11A/5

12

RD-GN

2

2

RD-GN

15/37

STOSTA

Electrical distribution 3:3
Overview, Distribution box in cargo compartment

TP39215202 XC60 2012 13

Fuses
Distribution box in engine compartment F1 - F7

15/31 Distribution box in engine compartment

No. No. Fuse function via A

F1 11A/1

F2 11A/2

F3 11A/3

F4 11A/4

F5 11A/5

F7 11A/7

4/56 Central electronic module (CEM)

F7 Fuse in the Central electronic module (CEM)

F9-F10 Fuses in the Central electronic module (CEM)

F21 Fuse in the Central electronic module (CEM)

F23 Fuse in the Central electronic module (CEM)

4/56 Central electronic module (CEM)

F1-F6 Fuses in the Central electronic module (CEM)

F8 Fuse in the Central electronic module (CEM)

F11-F12 Fuse in the Central electronic module (CEM)

F13-F16 Fuses in the Central electronic module (CEM)

F22 Fuse in the Central electronic module (CEM)

F24 Fuses in the Central electronic module (CEM)

11D/A 1­11D/A11 Fuse s in distribution box cargo compa rtment

2/193 Relay, comfort functions

11C/1 ­11C/15 Fuses in distribution box passen ger compartmen t

11C/2 1­11C/22 Fu ses in distribution box p assenger co mpartment

11D/A5 Fuses in distribution box c argo compartment

2/88 Relay, 15-feed

11C/2 3­11C/25 Fuses in distribution box passen ger compartmen t

11C/2 6­11C/30 Fuses in distribution box passen ger compartmen t

9/42 PTC-element

continues

-50

-

relay in

CEM

-

-

-50

relay in

CEM

relay in

CEM

relay in

CEM

-

-

-

-

-60

-

2/193

-

-60

2/88

-

-100

60

TP39215202 XC60 2012 14

Fuses
Distribution box in engine compartment F8 - F23

15/31 Distribution box in engine compartment

No. No. Fuse function via A

F8 11B/8

F9 11B/9

F10 11B/10

F11 11B/11

F13 11B/13

F14 11B/14

F16 11B/16

F17 11B/17

F18 11B/18

F19 11B/19

F20 11B/20

F21 11B/21

F22 11B/22

F23 11B/23

2/182 Relay, headlight washer motor

6/104 Washer motor headlights

6/1 Wiper motor module (WMM)

4/7 Combustion preheater module (CPM)

4/106 Control module, remote parking heater start

4/31 Fan control module

6/28 Motor, passenger compartment fan

4/16 Brake control module (BCM), pump

4/16 Brake control module (BCM), valves

10/1 Lamp housing, front left

10/2 Lamp housing, front right

4/56 Central electronic module (CEM)

F18-F20 Fuses in the Central electronic module (CEM)

4/16 Brake control module (BCM)

4/99 Electronic power steering control module

6/164 Electrical power steering module (EPS)

4/9 Supplemental restraint system module (SRS)

4/28 Transmission control module (TCM)

4/46 Engine control module (ECM)

9/43 Heated windshield washer nozzle, left

9/44 Heated windshield washer nozzle, right

2/133 Relay vacuum pump

3/111 Light switch module (LSM)

continues

-20

2/182

-30

-25

-

-40

-

-40

-20

-10

-

-20

-

-5

-5

-

-10

-

-

-10

-

-5

-5

TP39215202 XC60 2012 15

Fuses
Distribution box in engine compartment F27 - F37

15/31 Distribution box in engine compartment

No. No. Fuse function via A

F27 11B/27

F28 11B/28

F29 11B/29

F30 11B/30

F31 11B/31

F32 11B/32

F33 11B/33

F34 11B/34

F35 11B/35

2/17 Relay, horn
2/31 Relay, 15-feed
2/182 Relay, headlight washer motor

2/64 Relay auxiliary lights

10/65 Auxiliary lights, front right

10/69 Auxiliary lights, front left

16/10 Horn 1

16/11 Horn 2

2/32 Main relay, engine management system

4/46 Engine control module (ECM)

4/28 Transmission control module (TCM)

6/73 Coolant pump
8/3 Electromagnetic clutch, climate control system

2/22 Relay, climate control system

6/25 Starter motor

4/109 Glow plug control module, 5-Cyl. Diesel

20/3-6 Spark plug with ignition coil, 4-Cyl. Turbo

-5

-20

2/64

2/64

2/17 15

-

-10

-

-15

2/22 15

-5

2/35 30

-10

F36 11B/36

F37 11B/37

20/3-8 Spark plug with ignition coil, 6-Cyl.

20/16 Capacitor, 6-Cyl.

4/46 Engine control module (ECM), 5-Cyl. Diesel

4/46 Engine control module (ECM), 4-Cyl. Turbo & 6-Cyl.

7/17 Mass air flow sensor MAF, 5-Cyl. Diesel

8/98 Control valve fuel pressure, 5-Cyl. Diesel

8/111 Control valve fuel flow, 5-Cyl. Diesel

4/46 Engine control module (ECM), 6-Cyl.

7/17 Mass air flow sensor MAF, 6-Cyl.

8/6-11 Injection valves, 6-Cyl.

continues

TP39215202 XC60 2012 16

-20

-

-15

-10

-15

-

-

-

-

-

Fuses
Distribution box in engine compartment F38 - F39

15/31 Distribution box in engine compartment

No. No. Fuse function via A

F38 11B/38

F39 11B/39

7/17 Mass air flow sensor MAF, 4-Cyl. Turbo

8/18 EVAP valve, 4-Cyl. Turbo

8/19 Solenoid, variable valve timing, intake, 4-Cyl. Turbo

8/28 Turbocharger control valve, 4-Cyl. Turbo

8/81 Solenoid, variable valve timing, exhaust, 4-Cyl. Turbo

7/35 Oil level sensor, 5-Cyl. Diesel

8/3 Electromagnetic clutch, climate control system, 5-Cyl. Diesel

8/28 Turbocharger control valve, 5-Cyl. Diesel

8/113 Bypass valve, EGR cooling, 5-Cyl. Diesel

8/157 Turbocharger control valve, 5-Cyl. Diesel

8/164 Electric piston cooling valve, 5-Cyl. Diesel

4/46 Engine control module (ECM), 6-Cyl.

6/139 Upper actuator motor intake manifold, 6-Cyl. W/O Turbo.

6/140 Lower actuator motor intake manifold, 6-Cyl. W/O Turbo.

8/3 Electromagnetic clutch, climate control system, 6-Cyl.

8/28 Turbocharger control valve, 6-Cyl. Turbo

8/68 Relief valve, 6-Cyl. Turbo

8/117 Solenoid, variable valve timing, intake, 6-Cyl.

8/125 Solenoid cam profile front, 6-Cyl. W/O Turbo

8/126 Solenoid cam profile rear, 6-Cyl. W/O Turbo

7/15 Front heated oxygen sensor, 4-Cyl. Turbo

7/82 Rear heated oxygen sensor bank 1, 4-Cyl. Turbo

7/15 Front heated oxygen sensor, 5-Cyl. Diesel

7/15 Front heated oxygen sensor, bank 1, 6-Cyl.

7/82 Rear heated oxygen sensor, bank 1, 6-Cyl.

7/103 Front heated oxygen sensor, bank 2 6-Cyl. W/O Turbo

7/104 Rear heated oxygen sensor, bank 2 6-Cyl. W/O Turbo

8/18 EVAP valve, 6-Cyl.

continues

-10

-

-

-

-

-

-

-

-

-

-

-

-

-

-

-

-

-

-

-

-10

-

-

-15

-

-

-

-

TP39215202 XC60 2012 17

Fuses
Distribution box in engine compartment F40 - F44

15/31 Distribution box in engine compartment

No. No. Fuse function via A

F40 11B/40

F41 11B/41

F42 11A/42

F43 11A/43

F44 11A/44

2/142 Relay pre-heater fuel filter, 5-Cyl. Diesel

6/114 Vacuum pump, 4-Cyl. Turbo

9/32 PTC resistor crankcase ventilation, 5-Cyl. Diesel

9/38 Heated fuel filter, 5-Cyl. Diesel

6/67 Pump, fuel leakage control 6-Cyl.

6/179 Electric transmission oil pump

9/32 PTC resistor crankcase ventilation, 5-Cyl. Diesel

9/38 Heated fuel filter, Diesel

4/109 Glow plug control module

20/22-26 Glow plug, 5-Cyl. Diesel

4/71 Control module cooling fan 4-Cyl. Turbo

4/71 Cooling fan control module, 5-Cyl. Diesel & 6-Cyl.

6/164 Electrical power steering module (EPS)

-20

2/142

-

2/142

-5

-

-

-

-70

4/109

-60

-80

-100

TP39215202 XC60 2012 18

Fuses
Central electronic module (CEM) F1 - F13

4/56 Central electronic module (CEM)

No. Fuse function via A

F1 2/16 Relay, rear window wiper - 15

6/32 Rear window wiper motor 2/16

F3 3/26 Switch unit, power driver’s seat - 7.5

3/27 Switch unit, power passenger seat -

3/176 Power window switches, driver’s door -

3/291 Tailgate closing switch -

4/52 Power seat module (PSM) -

10/25 Ceiling light cargo compartment -

10/29 Glove compartment lighting -

10/125 Left-hand front courtesy lighting -

10/126 Right-hand front courtesy lighting -

17/45 Alcolock outlet
26/6 Converter/control module, sill moldings, driver’s side
26/7 Converter/control module, sill moldings, passenger side
26/8 Alcolock charging cradle

F4 5/1 Driver Information module (DIM) - 5

F5 4/80 Forward Sensing Module (FSM) - 10

7/203 Forward-aimed radar (FLR) -

F6 7/149 Rain sensor module (RSM) - 7.5

10/22 Ceiling light -

10/114 Vanity mirror lighting, left -

10/115 Vanity mirror lighting, right -

10/150A Rear reading light -

10/150B Rear reading light -

F7 3/4 Steering wheel switch left (SWSL) 3/130 7.5

3/131 Steering wheel switch right (SWSR) 3/130

F8 6/37 Lock motor, fuel filler flap - 10

F9 6/127 Washer motor - 15

F10 6/127 Washer motor - 15

F13 4/83 Control module fuel pump - 20

6/33 Fuel pump 4/83

-

-

-

continues

TP39215202 XC60 2012 19

Fuses
Central electronic module (CEM) F14 - F24

4/56 Central electronic module (CEM)

No. Fuse function via A

F14 4/6 Climate control module (CCM) - 5

7/122 Mass movement sensor module (MMS), front -

7/199 Ultrasonic sensor (IMS) -

F15 4/102 Steering column lock module (SCL) - 15

F16 16/35 Siren control module (SCM) - 5

17/13 Data link connector -

F18 4/9 Supplemental restraint system module (SRS) - 10

4/125 Closing velocity module (CVM) -

7/93 Occupant weight sensor (OWS) -

F19 4/80 Forward Sensing Module (FSM) - 5

7/203 Forward-aimed radar (FLR) -

F20 3/65 Switch, heated rear seat - 7.5

7/51 Accelerator pedal sensor -

8/48 Auto-dimming rearview mirror -

9/42 PTC-element -

F21 16/1 Integrated Audio Module (IAM) - 15

16/109 RSE control module -

16/159 Control module, cellular phone handsfree -

F22 3/9 Contact brake light - 5

F23 4/33 Sun roof module (SRM) - 20

F24 3/1 Ignition lock - 5

16/65 Immobilizer antenna unit -

TP39215202 XC60 2012 20

Fuses
Distribution box in passenger compartment F1 - F19

15/36 Distribution box in passenger compartment

No. No. Fuse function via A

F1 11C/1 11C/16-20Fuses in distribution box passenger compartment - 40

16/105 Audio module (AUD) -

F7 11C/7 17/19 12 V outlet, cargo compartment - 15

F8 11C/8 3/126 Driver door module (DDM) - 25

F9 11C/9 3/127 Passenger door module (PDM) - 25

F10 11C/10 3/129 Right rear door module (RDM) - 25

F11 11C/11 3/128 Left rear door module (LDM) - 25

F12 11C/12 4/93 Keyless vehicle module (KVM) - 20

F13 11C/13 3/26 Switch unit, power driver’s seat - 20

F14 11C/14 3/27 Switch unit, power passenger seat - 20

F16 11C/16 3/281 Infotainment control module (ICM) - 5

F17 11C/17 16/36 TV Receiver - 10

16/105 Audio module (AUD) -

16/145 Remote Digital Audio Receiver (RDAR) -

16/162 Digital Audio Broadcast Module (DABM) -

F18 11C/18 4/124 Accessory USB unit (AUU) - 15

16/1 Integrated Audio Module (IAM) -

16/159 Control module, cellular phone handsfree -

F19 11C/19 16/60 Phone module (PHM) - 5

continues

TP39215202 XC60 2012 21

Fuses
Distribution box in passenger compartment F21 - F30

15/36 Distribution box in passenger compartment

No. No. Fuse function via A

F21 11C/21 4/33 Panoramic roof control module - 5

6/48 Damper motor module (DMM), recirculation -

6/95 Damper motor module (DMM), temperature, left-hand side -

6/96 Damper motor module (DMM), temperature, right-hand side -

6/102 Damper motor module (DMM), defroster -

6/103 Damper motor module (DMM), floor/ventilation -

7/159 Air quality sensor (AQS) -

10/22 Ceiling light 4/56

16/159 Control module, cellular phone handsfree -

F22 11C/22 9/1 Outlet 12V front - 15

9/25 Outlet 12V rear -

16/45 Navigation system & Traffic information, portable -

F23 11C/23 9/15 Control module, rear right seat heater - 15

F24 11C/24 9/14 Control module, rear left seat heater - 15

F26 11C/26 9/13 Seat heating module (SHM), passenger side - 15

F27 11C/27 9/12 Seat heating module (SHM), driver’s side - 15

F28 11C/28 4/86 Parking Assistance Module (PAM) - 5

4/110 Trailer module (TRM) -

4/120 Parking Assistance Camera (PAC) -

F29 11C/29 4/82 Differential electronic module (DEM) - 10

F30 11C/30 4/84 Suspension module (SUM) - 10

TP39215202 XC60 2012 22

MF1

F1

D1F9 R1

F10 F11 F12

R2

F2 F3 F4 F5

F6

MF2

2/166

2/246

I01322215/37

Fuses
Distribution box in cold zone F1 - MF2

15/37 Distribution box in cold zone engine compartment, Start/Stop function

No. No. Fuse function via A

F1 11A/1 9/42 PTC-element - 100

F2 11A/2 4/56C5:1 Central electronic module (CEM) - 50

F3 11A/3 2/88 Relay, 15-feed rear

11C/23-11C /30 F u s e s in di stribution box passenger compart ment

F4 11A/4 2/193 Relay, comfort functions

11C/21-11C /22 F u s e s in di stribution box passenger compart ment

F5 11A/5 15/32 Distribution box in cargo compartment - 60

F6 11A/6 4/31 Fan control module

6/28 Motor, passenger compartment fan

F7 11A/7 Spare --

F8 11A/8 Spare --

F9 11A/9 6/25 Starter motor 2/35 30

F10 11A/10 Diode D1 -50

F11 M11 Secondary battery 2/246 70

F12 11B/12 4/56 Central electronic module (CEM) - 5

MF1 MF1 11A/1-11A/8 Main fuses in engine compartment fuse box (15/31) - 175

MF2 MF2 11A/1-11A/8 Fuses in fuse box cold zone engine compartment

(15/37)

-

60

2/88

-

60

2/193

-

40

-

-175

TP39215202 XC60 2012 23

Fuses
Distribution box in cargo compartment FA1 - FA11

15/32 Distribution box in cargo compartment

No. No. Fuse function via A

FA1 11D/A1 4/115 Par k Br ake Modu le ( PBM) - 30

FA2 11D/A2 4/115 Par k Br ake Modu le ( PBM) - 30

FA3 11D/A3 2/82 Relay, heated rea r wi ndow - 30

9/2 Heated rear window 2/82

FA4 11D/A4 17/3 9 13- pin outl et, tow hitch cable har ness - 15

FA5 11D/A5 4/116 Pow er O pera ted Tailga te M odul e (P OT) - 30

FA11 11D/A 11 4/110 Trail er m odul e (T RM) - 40

TP39215202 XC60 2012 24

Fuses
Battery PF1 - PF2

1/1 Battery

No. Fuse function via A

PF1 11A/1-11A/7 Main fuses in distribution box engine compartment

11A /42-11A/44 Main fuses in distribution box engine compar tment

11B /8-11B/14 Fu ses i n the engine compartment distribution box

11B /16-11B/22 Fuses in the engine compartment distribution box

11B /23 Fu s es in the engine compartment distribution box

11B /27-11B/32 Fuses in the engine compartment distribution box

11B /33 Fu s es in the engine compartment distribution box

11B /34 Fu s es in the engine compartment distribution box

11B /35-11B/41 Fuses in the engine compartment distribution box

PF2 6/25 Starter motor

6/26 Alternator control module (ACM)

-

-

-

2/31

-

-

2/32

-

2/32

-

-

150

150

TP39215202 XC60 2012 25

R1

R2

2/166

2/246

I01322315/37

I01946615/31

Relays
Relays in the engine compartment R1 - R9

15/37 Distribution box in cold zone engine compartment

Pos Relay function

R1 2/166 Battery relay

R2 2/246 Secondary battery relay

15/31 Distribution box in engine compartment

Pos Relay function

R7 2/31 Relay, 15-feed

R8 2/17 Relay, horn

R9 2/182 Relay, headlight washer motor

TP39215202 XC60 2012 26

1

Relays
Relays in the engine compartment R10 - R13

15/31 Distribution box in engine compartment

Pos Relay function

R10 2/32 Main relay, engine management system

R11 2/133 Relay vacuum pump, 4-Cyl. Turbo

2/142 Relay pre-heater fuel filter

R12 2/35 Relay, starter motor

R13 2/22 Relay, climate control system

TP39215202 XC60 2012 27

Relays
Relays in passenger and cargo compartments

15/36 Distribution box in passenger compartment

Pos Relay function

R1 2/88 Relay, 15-feed

R4 2/193 Relay, comfort functions

15/32 Distribution box in cargo compartment

Pos Relay function

RA1 2/82 Relay, heated rear window

RA2 2/16 Relay, rear window wiper

TP39215202 XC60 2012 28

31/AL

31/1

31/96

31/XX4

31/2

31/4

31/3

31/7

31/6

31/84

31/10

31/15

31/68

31/65

31/47

31/67

31/83

31/93

31/95

31/

INFOT

31/88

31/89

31/90

31/66

31/
XX10

31/94

31/5

31/48

31/TRM

31/
XX15

31/
XX14

I03208

31/131

Ground connections
Overview

TP39215202 XC60 2012 29

Ground connections
31/1 - 31/7

31/1 Ground connection, PTC

9/42 PTC-element

31/2 LH wheel housing

4/71 Cooling fan control module

6/114 Vacuum pump, 4-Cyl. Turbo

8/84 Switch vacuum pump 4-Cyl. Turbo

31/3 Body, battery

1/1 Battery

7/240 Battery monitoring sensor

31/4 Engine

31/XX4 Ground connection

31/5 Rear edge roof

9/2 Heated rear window

31/6 Bottom rail, left

3/27 Switch unit, power passenger seat, RHD

3/126 Driver Door Module (DDM), LHD

3/127 Passenger door module (PDM), RHD

3/128 Left rear door module (LDM)

3/176 Switch, driver’s door power window, LHD

3/273 Lock contact, LH front door

3/275 Lock contact, left rear door

4/52 Power seat module (PSM), LHD

6/36 Lock motor, central locking, LH front door

6/57 Lock motor, central locking, LH rear door

9/12 Seat Heating Module (SHM), driver’s side, LHD

9/13 Seat Heating Module (SHM), passenger side, RHD

31/7 Bottom rail, left

3/271 Contact, immobilizer, clutch pedal, LHD

3/281 Infotainment Control Module (ICM), RHD

3/284 Diagnostic contact, brake light, LHD

4/56 Central electronic module (CEM), RHD

4/120 Parking Assistance Camera (PAC), RHD

7/51 Accelerator pedal sensor, LHD

7/175 Weight sensor passenger seat, seat belt reminder, RHD

8/51 Igniter side airbag front left, LHD

8/52 Igniter side airbag front right, RHD

16/1 Integrated Audio Module (IAM), RHD

16/36 TV receiver, RHD

16/109 RSE Control module, RHD

16/145 Remote Digital Audio Receiver (RDAR), RHD

16/162 Digital Audio Broadcast Module (DABM), RHD

16/159 Control module, cellular phone handsfree, RHD

TP39215202 XC60 2012 30