Volvo XC60 2010 User Manual
VOLVO XC60
WIRING DIAGRAM 2010
TP 39133202 USA
Vehicles with SRS (Airbag)/SIPS bag/
IC (Inflatable Curtain)
Warning!
Extra caution must be exercised when working on vehicles equipped with SRS/SIPS bag/IC
in order to avoid:
1. Personal injuries when performing repair work.
2. Damage or malfunction of the SRS/SIPS bag/IC system.
Work involving the SRS/SIPS bag/IC systems or other components in the vehicle that may
affect the SRS/SIPS bag/IC systems must always be performed by an authorized Volvo
workshop.
In case of doubt, consult the SRS and SIPS bag/IC service manual.
Is the vehicle equipped with SRS/SIPS bag/IC?
Vehicles with SRS are most easily recognized by the letters SRS in the center of the steering
wheel. If the vehicle also has a passenger side airbag, the letters SRS are stamped on the
dashboard above the glove compartment. SRS vehicles from 1993 and onward also have
explosive seat belt tensioners. SIPS bags are only installed on SRS vehicles from 1995 and
onward. SIPS bag decals are located on the windshield and seat compartment. Vehicles with
IC can be recognized by the letters IC on the C/D panel (4 door) or the B panel (5 door).
General recommendations
• Be especially careful when working on or around SRS, SIPS, and IC components.
• Make sure that no wires are pinched, frayed, or pierced.
• Never install accessories by the sensors.
• Where applicable, work on the steering wheel, steering shaft, or steering gear must be done
in accordance with the methods in the SRS section of VIDA.
• Certain components of the aforementioned systems must be grounded while working. Read
the appropriate sections in VIDA.
• Install no accessories in the areas between the A and B-posts, the B and C-posts, and the C
and D-posts.
Test terminal
Data link connector in the passenger compartment.
Changes implemented up to and including May 2008
Any changes made to the vehicles after this date are not included in the manual. If necessary
refer to service bulletins.
Volvo models are sold in versions adapted for different markets. These adaptations depend
on factors such as legal requirements, taxation, and market demands.
This manual may therefore include illustrations and text that do not apply to the vehicles in
your country.
Ordering:
Electronic Wiring Diagrams (EWDs) can be ordered from the Technical Information Shop
(TIS) at www.volvocarstechinfo.ford.com/vss
We reserve the right to make modifications.
© Volvo Car Corporation
Table of Contents 1:3
Vehicles with SRS (Airbag)/SIPS bag/
IC (Inflatable Curtain)..................................................... 2
Explanations .................................................................. 6
Abbreviations................................................................. 6
How to use the wiring diagrams 1:2............................... 7
Electrical distribution 1:2 ................................................9
Fuses
Distribution box in engine compartment F1-F7............. 11
Distribution box in engine compartment F9-F24........... 12
Distribution box in engine compartment F25-F30......... 13
Distribution box in engine compartment F31-F37......... 14
Distribution box in engine compartment F38-F44......... 15
Central Electronic Module (CEM) F1 - F13...................16
Central Electronic Module (CEM) F14 - F19.................17
Central Electronic Module (CEM) F20 - F28.................18
Rear electrical center FA1-FA12 .................................. 19
Distribution box in cargo compartment FB1-FB12........ 20
Rear electrical center FD1-FD7....................................21
Battery PF1-PF2........................................................... 22
Relays
Relays in the engine compartment R2......................... 23
Relays in the engine compartment R8-R9................... 24
Relays in the engine compartment R10-R13............... 25
Distribution box in cargo compartment RA1-RD1........ 26
Central Electronic Module (CEM) ................................ 27
Ground connections
Overview...................................................................... 28
31/1 - 31/7 ................................................................... 29
31/10 - 31/15 continues ............................................... 30
31/15 - 31/48 ............................................................... 31
31/65 - 31/83 ............................................................... 32
31/84 - 31/95 ............................................................... 33
31/96 - 31/TRM............................................................ 34
Control modules
Overview locations....................................................... 35
Overview designations................................................. 36
Central Electronic Module (CEM) 1:3 .......................... 37
Data communication high speed CAN......................... 40
Data communication intermediate speed CAN, LHD... 41
Data communication intermediate speed CAN, RHD .. 42
Data communication, LIN 1:2 ...................................... 43
Data communication MOST......................................... 45
Steering Wheel Module (SWM) ................................... 46
Group 23 Fuel system
Engine management system, 6-Cyl. Turbo 1:2............ 47
Engine management system, 5-Cyl. Diesel 1:3........... 49
Emission control 6-Cyl. ................................................ 52
Group 26 Cooling system
Cooling fan 6-Cyl. Turbo.............................................. 53
Group 27 Engine controls
Cruise control................................................................ 54
Group 32 Alternator and voltage regulator
Power supply ............................................................... 55
Group 33 Starting system
Starting system ............................................................ 56
Group 35 Lighting
High and low beam ...................................................... 57
High and low beam (Dual Xenon) ................................ 58
Beam length adjustment, manual ................................ 59
Running/Parking light, Tail lights ................................. 60
Running/Parking light, Tail lights (Dual Xenon) ........... 61
Fog lights ..................................................................... 62
Brake lights .................................................................. 63
Reversing lights ........................................................... 64
Follow-me-home lighting LHD...................................... 65
Follow-me-home lighting RHD..................................... 66
Interior lighting, LHD 1:2 .............................................. 67
Interior lighting, RHD 1:2.............................................. 69
Active headlight ........................................................... 71
Lighting in door sill trims .............................................. 72
Auxiliary lights.............................................................. 73
Group 36 Additional electrical equipment
Rain sensor.................................................................. 74
Direction indicator and hazard warning flashers LHD.. 75
Direction indicator and hazard warning flashers RHD . 76
Wiper/Washer windshield ............................................ 77
High pressure headlight washer .................................. 78
Wiper/Washer rear window.......................................... 79
Horn ........................................................................ 80
Keyless vehicle 1:2 ...................................................... 81
Anti-theft alarm ............................................................ 83
Parking assistance....................................................... 84
Collision warning with power brake booster................. 85
Tire pressure monitoring system (TPMS) .................... 86
Alcohol lock.................................................................. 87
TP39133202 XC60 2009 3
Table of Contents 2:3
Group 37 Wiring and fuses
Diagnostics system...................................................... 88
Outlet 12V.................................................................... 89
Cable harness towbar/tow hitch 4-pin ......................... 90
Cable harness towbar/tow hitch 7-pin.......................... 91
Cable harness towbar/tow hitch 13-pin........................ 92
USB unit (AUU)............................................................ 93
Group 38 Instruments
Seat belt reminder ....................................................... 94
Driver information module............................................ 95
Group 39 Other
Audio Premium 1:3 ...................................................... 96
Audio 1:2 ..................................................................... 99
Cellular phone 1:2...................................................... 101
DAB Radio................................................................. 103
Telephone system Bluetooth ..................................... 104
Bluetooth Handsfree.................................................. 105
Multimedia & Traffic information ................................ 106
Satellite radio............................................................. 107
Parking camera.......................................................... 108
Group 43 Transmission
Transmission M66 ..................................................... 109
Automatic transmission, TF-80SC AWD.................... 110
Differential electronic module (DEM) ......................... 111
Group 55 Parking brake
Electric parking brake ................................................ 112
Group 59 Brake system
Brake control system & DSTC ................................... 113
Group 64 Steering
Electronic power steering .......................................... 114
Group 76 Shock absorbers
Four-C ...................................................................... 115
Group 83 Doors and openings
Central locking front doors LHD................................. 116
Central locking front doors RHD ................................ 117
Central locking rear doors.......................................... 118
Central locking tailgate............................................... 119
Central locking fuel filler flap...................................... 120
Signal receiver central locking ................................... 121
Power windows front doors LHD................................ 122
Power windows front doors RHD ............................... 123
Power windows rear doors......................................... 124
Power sunroof............................................................ 125
Group 84 Exterior decorative elements, etc.
Power door mirrors LHD ............................................ 126
Power door mirrors RHD............................................ 127
Heated door mirrors LHD........................................... 128
Heated door mirrors RHD .......................................... 129
Blind spot information system LHD............................ 130
Blind spot information system RHD ........................... 131
Heated rear window................................................... 132
Group 85 Interior equipment
Power driver’s seat with memory function, LHD ........ 133
Power driver’s seat with memory function, RHD........ 134
Power passenger seat, LHD ...................................... 135
Power passenger seat, RHD ..................................... 136
Heated front seats with fans ...................................... 137
Heated front seats without fans ................................. 138
Heated rear seat ........................................................ 139
Group 87 Climate control system
Climate control system PTC-element ........................ 140
Climate control system 1:2......................................... 141
Parking heater, auxiliary heater ................................. 143
Parking heater, remote start ...................................... 144
Group 88 Internal equipment
Rear-view mirror with automatic dimming.................. 145
Supplemental Restraint System (SRS) 1:2................ 146
Remote controlled garage opening............................ 148
TP39133202 XC60 2009 4
Table of Contents 3:3
Connectors .............................................. 149
Branching points .....................................183
Cable harness routing in vehicle
Harness engine, 6-Cyl. Turbo.....................................198
Harness engine, Diesel............................................... 198
Engine compartment harness..................................... 199
Harness dashboard, LHD ........................................... 200
Harness Dashboard, RHD..........................................201
Harness Floor, LHD....................................................202
Harness Floor, RHD ...................................................203
Harness infotainment, LHD.........................................204
Harness infotainment, RHD ........................................ 205
Roof harness .............................................................. 206
Center console harness.............................................. 206
Tunnel harness ........................................................... 207
Harness front door, left ............................................... 208
Harness front door, right.............................................208
Harness rear door, left................................................209
Harness rear door, right.............................................. 209
Tailgate harness ......................................................... 210
Harnesses rear axle.................................................... 210
Component illustrations ..........................211
Index 1:2....................................................262
List of components 1:7 ............................264
TP39133202 XC60 2009 5
Explanations
Abbreviations
Groups
Group 23 = Fuel system
Group 26 = Cooling system
Group 27 = Engine controls
Group 32 = Alternator and voltage regulator
Group 33 = Starting system
Group 35 = Lighting
Group 36 = Additional electrical equipment
Group 37 = Wiring and fuses
Group 38 = Instruments
Group 39 = Other
Group 43 = Transmission
Group 55 = Parking brake
Group 59 = Brake system
Group 64 = Steering
Group 76 = Shock absorbers
Group 83 = Doors and openings
Group 84 = Exterior decorative elements, etc.
Group 85 = Interior equipment
Group 87 = Climate control system
Group 88 = Internal equipment
Ignition switch symbols
X = Accessories (audio position)
S = Powered upon insertion of key
15 = Contact remains connected during
start
15l = Contact is broken while starting
30 = Constant power from the battery
50 = Start
Countries/Markets
A = Austria
AUS = Australia
B = Belgium
CDN = Canada
CH = Switzerland
D = Germany
DK = Denmark
E= Spain
EU/OS = Markets outside USA and Canada
FIN = Finland
GB = Great Britain
ISR = Israel
J = Japan
KOR = Korea
N= Norway
NL = Netherlands
S = Sweden
USA = United States of America
WEU = Western Europe
Other
ACC = Adaptive Cruise Control
Ag = Silver plated
Au = Gold plated
AUTO = Automatic transmission
BLIS = Blind spot information system
CAN = CAN communication
DPY = Display
ECC = Electronic climate control system
ETA = Engine throttle body
EXC = Exclusive
GDL = Gas discharge lamp
HISPEED = High speed data bus
IR = Infrared sensor
LIN = LIN communication
LH = Left-hand side
LHD = Left-hand drive
MAN = Manual transmission
MEMORY = Memory driver’s seat
MIDSPEED = Midspeed data bus
MMS = Mass Movement Sensor
PETROL = Gasoline
RH = Right-hand side
RHD = Right-hand drive
SCR = Screened
SRS = Airbag
T = Turbocharged engine
W/O = Without
2WD = Two-wheel drive
4CYL, I4 = 4-cylinder engine
5CYL, I5 = 5-cylinder engine
6CYL, I6 = 6-cylinder engine
8CYL, V8 = 8-cylinder engine
Colors
BK, SB = Black
BN = Brown
BU, BL = Blue
GN = Green
GY, GR = Gray
LGN = Light Green
NL = Natural
OG, OR = Orange
PK, P = Pink
RD, R = Red
VT, VO = Violet
WH, W = White
YE, Y = Yellow
TP39133202 XC60 2009 6
How to use the wiring diagrams 1:2
The descriptions below apply in general
to all wiring diagram manuals, although
not all sections are necessarily contained in this manual.
A. Component designation
Every component has a component designation that
consists of two parts.
The first part is a type number that describes the
type of component in question, for example 3/xx.
The second part of the designation is a serial number, e.g. x/2.
Together, this constitutes a component designation,
e.g. 3/2.
At the end of the manual is a list of components,
where, with the help of the component designation,
you can read off the name of the component, for
example, 3/2 = light switch.
List of type numbers
The list shows which type of component that respective type numbers refer to, for example, 3/x = switch,
6/x = electric motor, etc.
1 Battery
2Relay
3 Switch
4 Control module
5 Driver information module
6 Electric motor
7Sensor
8 Actuator
9 Heating element
10 Light
11 Fuse
15 Electrical distribution rail/box
16 Audio
17 Service/diagnostics
18 Contact reel
19 Meter
20 Ignition component/shunt
27 Optics
31 Ground connection
73 Branching point
74 Connector
B. Branching points
The wiring diagrams contain numbered branching
points, for example 73/5035.
This manual contains a section with a list of branching points. This list shows all the components that
are connected to each branching point.
The location of the branching points is shown in the
"Cable harness routing in vehicle" section.
C. Connectors
Connectors provide a bridge between two cable harnesses and are described in the "Connectors" section.
D. Electrical distribution
Operation of the fuses and relays is shown in the
"Electrical distribution" section.
E. Data communication
Today’s cars contain CAN, LIN and MOST networks
that transfer information. Connections to these networks are not shown in their entirety in the respective wiring diagram. Complete information on CAN,
LIN and MOST communication is found in the section "Control modules".
F. Abbreviations
A number of different abbreviations are used in the
manual. These are explained in the section "Abbreviations".
G. Component location
The end of the manual contains a section that
describes component appearance and location in
numerical order.
TP39133202 XC60 2009 7
How to use the wiring diagrams 2:2
A
10/3 10/18 10/17
DEC
30+
15/31
1
11A/1211A/2
2
RD-BK
4/56
C5:1
CEM
CAN
C1:49
C1:50
LIN
C2:52
74/601
1
BN-BU YE-VT
2
1
BK-BU
1
RD-BU
C2:50
1
11B/23
2
C5:2
C2:24
VT-GN
C3:52
C1:10
C1:40
GND
3
RD-BK
12
GN-VT
74/411
10/1
TURN POS HIGH LOW
GN-OG
YE-BK
5/1
3/111
1
LSM
RD-BK
6
LIN
10 10
1
GY-RD
5
REV
POSFOGSTOPTURN
10/51
10/52
DIM
2
6
CAN
5
10/2
M
TURN POS HIGH LOW
5
POS FOG STOP TURN
REV
10/44
10/45
F B
73/4017
RHD
BK
BK
LHD
1
GND
3
BK
BK-OG
BK-VT
M
73/4016
73/3035
BK-VT
73/3033
BK-OG
List of symbols
BK
LIN
= System voltage
= Ground connection via wiring
= Ground connection in component/chassis
= Screened wire
= Junction point
= Twisted cable
= Electrical connection
= Variant
= CAN communication
= CAN high data signal (CAN H)
= CAN low data signal (CAN L)
= LIN communication
= LIN communication
= DIN cable, coaxial cable, etc.
4
74/601
10/17
BK-OG
BK-OG
BK-OG
73/5105
31/48
BK-BU BK-BU
73/5033
CAN
31/8331/9331/9431/47
= Data communication
= CAN communication
= MOST communication
= MOST communication
= Connection with distribution box
= Further connection to...
G
1
= Connector between cable
harnesses
= Connector connected in
1
component
G029147
TP39133202 XC60 2009 8
Electrical distribution 1:2
Overview, Electrical center and Cold zone in engine compartment
4/56C1:48
73/3085
73/3068
4/46B:16
VT-GN
6 CYL
RD-VT
RD-BK
GY-VT
RD
GY-VT
GY-VT
GY-VT
RD
RD
RD
RD
RD
RD
RD
RD
RD
RD-GY
RD
RD
15/31
21
5
3
1
2
5
2
21
21
21
21
21
21
21
7
5
2
21
21
21
21
21
21
21
5
2
5
2
21
21
21
21
2/32
3
1
3
1
3
1
3
1
11B/34
2/35
R12
11B/35
11B/39
11B/40
11B/41
11B/38
11B/37
11B/36
R11
11A/44
11A/42
11A/43
11B/30
11B/31
11B/32
11B/33
2/22
R13
2/193
R9
11B/15
11B/24
11B/25
11B/26
R10
11B/29
11B/28
11B/27
11B/17
11B/16
11B/18
11B/19
1
1B/21
1
1B/20
1
1B/22
11B/23
2/31
11A/1
11A/2
11A/3
11A/4
11A/5
11A/6
11B/14
11B/13
11B/11
11B/9
11B/12
11B/10
11B/8
12
12
12
12
12
12
12
12
12
12
12
3
R8
1
11A/7
12
12
12
12
12
12
12
12
12
12
12
12
12
12
15/33
RD-VT
RD-VT
5
2
2/17
3
R2
1
73/3041
RD-VT
RD
GY-BK
RD
RD
RD
5
2
GN-VT
RD
RD
RD-BK
RD_BU
RD-GN
RD-GY
RD-BN
RD
RD
RD
RD
4/56C1:65
4/56C1:45
9/42
4/56C5:1
4/56C5:2
15/32
15/32
15/32
1
PF1
2
RD
1/1
12V
1
PF2
2
BK
31/3
73/3076
RD
6/25
30
M
RDRD
B+
ACM
6/26
C1:1
G
LIN
31
31
C1:1
TP39133202 XC60 2009 9
G034939
Electrical distribution 2:2
Overview, rear electrical center
30+
15/31
12
12
12
RD-BN
1
74/505
11A/4
11A/3
11A/5
RD-GN
RD-GY
RD-GN
RD-BN
73/5075
74/504B
1
2
RD-GN
RD-GN
RD-VT
RD-GN
RD-GN
RD-GN
RD-VT
15/32
21
21
21
21
21
21
21
21
21
21
21
21
5
2
5
2
3
1
3
1
BK NL
11D/A1
11D/A2
11D/A3
11D/A4
11D/A5
11D/A6
11D/A7
11D/A8
11D/A9
11D/A10
11D/A11
11D/A12
2/16
RA2
2/82
RA1
A
11D/B1
11D/B2
11D/B3
11D/B4
11D/B5
11D/B6
11D/B7
11D/B8
11D/B9
11D/B10
11D/B11
11D/B12
RB2
2/88
RB1
B
D
11D/D1
11D/D2
11D/D3
11D/D4
12
12
12
1
2
12
12
12
12
12
12
12
12
5
3
2
1
5
3
2
1
12
12
12
12
RD-GY
YE-VT
RD-GY
RD-GY
RD-GY
RD-GY
YE-VT
RD-GY
BU-RD
73/5040
12
11D/D5
12
11D/D6
12
11D/D7
12
11D/D8
12
11D/D9
11D/D10
11D/D11
11D/D12
12
12
12
RD2
3
1
RD1
3
1
5
2
4
5
2
BU-RD
RD-BN
BU
G034937
TP39133202 XC60 2009 10
Fuses
Distribution box in engine compartment F1-F7
1
2
3
4
5
6
7
15/31 Distribution box in engine compartment
No. No. Fuse function via A
F1 11A/1 Main fuse for fuses in CEM - 50
F2 11A/2 Main fuse for fuses in CEM - 50
F3 11A/3 11D/A1-11D/A12 Fuses in cargo compartment fuse box - 60
F4 11A/4 2/88 Relay, 15-feed rear
11D/B1-11D/B8 Fuses in cargo compartment fuse box
11D/B9-11D/B12 Fuses in cargo compartment fuse box
F5 11A/5 11D/D1-11D/D7 Fuses in cargo compartment fuse box - 50
F7 11A/7 9/42 PTC-element - 100
continues
-
2/88
-
G029438
60
TP39133202 XC60 2009 11
Fuses
Distribution box in engine compartment F9-F24
39
36
40
37
34
41 38
35
14 13 12
20
16
15
17
21
24
27
18
22
28
25
23
32
30
33
31
42
4344
29
19
26
1011
89
15/31 Distribution box in engine compartment
No. No. Fuse function via A
F9 11B/9 6/1 Wiper motor module (WMM) - 30
F10 11B/10 4/7 Combustion preheater module (CPM) - 25
F11 11B/11 4/31 Fan control module
6/28 Motor, passenger compartment fan
F13 11B/13 4/16 Brake Control Module (BCM), pump - 40
F14 11B/14 4/16 Brake Control Module (BCM), valves - 20
F16 11B/16 4/118 Headlamp Control Module (HCM)
10/1 Lamp housing, front left
10/2 Lamp housing, front right
F17 11B/17 F2-F4 Fuses in the Central Electronic Module (CEM) - 20
F18 11B/18 4/80 Forward Sensing Module (FSM)
7/203 Forward-aimed radar (FLR)
F19 11B/19 4/99 Electronic power steering control module - 5
F20 11B/20 4/9 Supplemental restraint system module (SRS)
4/28 Transmission control module (TCM)
4/46 Engine control module (ECM)
F21 11B/21 9/43 Heated windshield washer nozzle, left
9/44 Heated windshield washer nozzle, right
F23 11B/23 3/111 Light switch module (LSM) - 5
F24 11B/24 6/104 High pressure headlight washer motor - 15
continues
-
-
-
-
-
-
-
-
-
-
-
-
G029458
40
10
5
10
10
TP39133202 XC60 2009 12
Fuses
Distribution box in engine compartment F25-F30
39
36
40
37
34
41 38
35
14 13 12
20
16
15
17
21
24
27
18
22
28
25
23
32
30
33
31
42
4344
29
19
26
1011
89
15/31 Distribution box in engine compartment
No. No. Fuse function via A
F25 11B/25 9/1 Front 12V outlet
9/25 Outlet 12V rear
F26 11B/26 3/117 Switch unit, ceiling light
4/33 Panoramic roof control module
6/48 Damper Motor Module (DMM), recirculation
6/95 Damper Motor Module (DMM), temperature, left-hand side
6/96 Damper Motor Module (DMM), temperature, right-hand side
6/102 Damper Motor Module (DMM), defroster
6/103 Damper Motor Module (DMM), floor/ventilation
7/159 Air quality sensor (AQS)
F27 11B/27 2/31 Relay, 15-feed
2/193 Relay, comfort functions
F28 11B/28 2/64 Relay auxiliary lights
10/65 Auxiliary light, front right
10/69 Auxiliary light, front left
F29 11B/29 2/17 Relay, horn
16/10 Horn 1
F30 11B/30 2/32 Main relay, engine management system
4/46 Engine Control Module (ECM), 6-Cyl. Turbo
continues
-
-
-
-
-
-
-
-
-
-
-
-
2/64
2/64
2/17
-
-
G029458
15
5
5
20
15
10
TP39133202 XC60 2009 13
Fuses
Distribution box in engine compartment F31-F37
39
36
40
37
34
41 38
35
14 13 12
20
16
15
17
21
24
27
18
22
28
25
23
32
30
33
31
42
4344
29
19
26
1011
89
15/31 Distribution box in engine compartment
No. No. Fuse function via A
F31 11B/31 4/28 Transmission control module (TCM) - 15
F32 11B/32 8/3 Electromagnetic clutch, climate control system 2/22 15
F33 11B/33 2/22 Relay, climate control system - 5
F34 11B/34 6/25 Starter motor 2/35 30
F35 11B/35 4/109 Glow plug control module, 5-Cyl. Diesel - 10
20/3-8 Spark plug with ignition coil, 6-Cyl. Turbo
20/16 Capacitor, 6-Cyl. Turbo
F36 11B/36 4/46 Engine control module (ECM), 5-Cyl. Diesel
6/120 Throttle body motor, 5-Cyl. Diesel
8/98 Control valve fuel pressure, 5-Cyl. Diesel
8/111 Control valve fuel flow, 5-Cyl. Diesel
6/120 Throttle body motor, 6-Cyl. Turbo 4/46 10
F37 11B/37 4/46 Engine control module (ECM), 5-Cyl. Diesel
7/17 Mass air flow sensor MAF, 5-Cyl. Diesel
8/6-11 Injection valves, 5-Cyl. Diesel
7/17 Mass air flow sensor MAF, 6-Cyl. Turbo
8/6-11 Injection valves, 6-Cyl. Turbo
continues
-
-
4/46
4/46
4/46
-
4/46
-
-
G029458
20
15
15
TP39133202 XC60 2009 14
Fuses
Distribution box in engine compartment F38-F44
39
36
40
37
34
41 38
35
14 13 12
20
16
15
17
21
24
27
18
22
28
25
23
32
30
33
31
42
4344
29
19
26
1011
89
15/31 Distribution box in engine compartment
No. No. Fuse function via A
F38 11B/38 6/143 Control motor, turbo, 5-Cyl. Diesel
8/3 Electromagnetic clutch, climate control system, 5-Cyl. Diesel
8/113 Bypass valve, EGR cooling, 5-Cyl. Diesel
8/120 EGR valve, 5-Cyl. Diesel
4/46 Engine Control Module (ECM), 6-Cyl. Turbo
8/3 Electromagnetic clutch climate control system, 6-Cyl. Turbo
8/28 Turbocharger control valve, 6-Cyl. Turbo
8/68 Relief valve, 6-Cyl. Turbo
8/117 Solenoid, variable valve timing, intake, 6-Cyl. Turbo
F39 11B/39 7/15 Front heated oxygen sensor, 5-Cyl. Diesel - 10
7/15 Front heated oxygen sensor bank 1, 6-Cyl. Turbo
7/82 Rear heated oxygen sensor bank 1, 6-Cyl. Turbo
8/18 EVAP valve, 6-Cyl. Turbo
F40 11B/40 9/32 PTC resistor crankcase ventilation, 5-Cyl. Diesel
9/38 Heated fuel filter, 5-Cyl. Diesel
9/47 PTC resistor crankcase ventilation in hose, 5-Cyl. Diesel
F41 11B/41 6/67 Pump fuel leakage control 6-Cyl. Turbo - 5
F42 11A/42 20/22-26 Glow plug, 5-Cyl. Diesel 4/109 70
F44 11A/44 4/71 Cooling fan control module - 80
-
-
-
-
-
-
-
-
-
-
-
-
-
-
-
G029458
10
15
20
TP39133202 XC60 2009 15
Fuses
Central Electronic Module (CEM) F1 - F13
1 2 3 4 5 6
7 8
9 10 11
12 13
14
15 16 17 18 19 20
21 22 23 24 25
26 27 28
4/56 Central Electronic Module (CEM)
No. Fuse function via A
F1 7/149 Rain sensor module (RSM) - 5
F2 4/9 Supplemental restraint system module (SRS)
7/93 Occupant weight sensor (OWS)
4/125 Closing velocity module (CVM)
F3 4/16 Brake control module (BCM) - 5
F4 3/65 Switch, heated rear seat
7/51 Accelerator pedal sensor
8/48 Auto-dimming rearview mirror
9/42 PTC-element
F6 3/281 Infotainment control module (ICM)
16/1 Integrated Audio Module (IAM)
4/124 Accessory USB unit (AUU)
F7 3/4 Steering wheel switch left (SWSL)
3/131 Steering wheel switch right (SWSR)
3/135 RTI switch
F9 10/1 Lamp housing, front left
10/2 Lamp housing, front right
F10 4/33 Panoramic roof control module - 20
F11 10/48 Reversing light, right
10/55 Reversing light, left
F13 10/5 Fog light, front left
10/6 Fog light, front right
continues
-
-
-
-
-
-
-
-
-
-
3/130
3/130
3/130,
3/131
K2
K2
K3
K3
K1
K1
G029460
10
7.5
15
7.5
15
7.5
15
TP39133202 XC60 2009 16
Fuses
Central Electronic Module (CEM) F14 - F19
1 2 3 4 5 6
7 8
9 10 11
12 13
14
15 16 17 18 19 20
21 22 23 24 25
26 27 28
4/56 Central Electronic Module (CEM)
No. Fuse function via A
F14 6/127 Washer motor K5A, K5B 15
F15 4/80 Forward Sensing Module (FSM) - 10
F17 3/27 Switch unit, power passenger seat
3/176 Switch, driver’s door power window
3/291 Tailgate closing switch
4/76 Remote control unit for garage door opener
7/238 Alcolock sensor
10/22 Ceiling light
10/25 Ceiling light cargo compartment
10/29 Glove compartment lighting
10/114 Vanity mirror lighting, left
10/115 Vanity mirror lighting, right
10/125 Left-hand front courtesy lighting
10/126 Right-hand front courtesy lighting
10/150A Rear reading light
10/150B Rear reading light
17/45 Alcolock outlet
26/6 Converter/control module, sill moldings, driver’s side
26/7 Converter/control module, sill moldings, passenger side
26/8 Alcolock charging cradle
F18 5/1 Driver Information module (DIM) - 5
F19 4/52 Power seat module (PSM) - 5
continues
-
-
-
-
-
-
-
-
-
-
-
-
-
-
-
-
-
-
G029460
7.5
TP39133202 XC60 2009 17
Fuses
Central Electronic Module (CEM) F20 - F28
1 2 3 4 5 6
7 8
9 10 11
12 13
14
15 16 17 18 19 20
21 22 23 24 25
26 27 28
4/56 Central Electronic Module (CEM)
No. Fuse function via A
F20 6/32 Rear window wiper motor 2/16 15
F21 4/119 Remote Keyless Entry (RKE)
4/119.2 Remote Receiver Module (RRX)
7/122 Mass Movement Sensor Module (MMS), front
7/199 Ultrasonic sensor (IMS)
7/214 Heart beat sensor (HBS)
F22 4/83 Control module fuel pump
6/33 Fuel pump
F23 4/102 Steering column lock module (SCL) K9 20
F25 K12 Relay, soldered
6/37 Lock motor, fuel filler flap
F26 4/6 Climate control module (CCM)
16/35 Siren control module (SCM)
17/13 Data link connector
F27 3/132 Start control module (SCU) - 5
F28 3/9 Contact brake light
4/93 Keyless vehicle module (KVM)
-
-
-
-
-
K8
K8, 4/83
-
K12
-
-
-
-
-
G029460
5
20
10
5
5
TP39133202 XC60 2009 18
Fuses
Rear electrical center FA1-FA12
4
8
12
11
2
3
7
10
1
5
6
9
15/32 Rear electrical center
No. No. Fuse function via A
FA1 11D/A1 3/126 Driver door module (DDM) - 25
FA2 11D/A2 3/127 Passenger door module (PDM) - 25
FA3 11D/A3 3/128 Left rear door module (LDM) - 25
FA4 11D/A4 3/129 Right rear door module (RDM) - 25
FA6 11D/A6 17/19 12V outlet, cargo compartment - 15
FA7 11D/A7 2/82 Relay, heated rear window
9/2 Heated rear window
FA9 11D/A9 17/39 13-pin outlet, tow hitch cable harness - 15
FA10 11D/A10 4/52 Power seat module (PSM) 25
FA11 11D/A11 4/110 Trailer module (TRM) - 40
FA12 11D/A12 4/116 Power Operated Tailgate Module (POT) - 30
-
2/82
G036053
30
TP39133202 XC60 2009 19
Fuses
Distribution box in cargo compartment FB1-FB12
4
8
12
11
2
3
7
10
1
5
6
9
15/32 Rear electrical center
No. No. Fuse function via A
FB1 11D/B1 4/86 Parking Assistance Module (PAM)
4/110 Trailer module (TRM)
4/120 Parking Assistance Camera (PAC)
FB2 11D/B2 4/84 Suspension module (SUM) - 15
FB3 11D/B3 9/12 Seat Heating Module (SHM), driver’s side - 15
FB4 11D/B4 9/13 Seat Heating Module (SHM), passenger side - 15
FB5 11D/B5 9/15 Control module, rear right seat heater - 15
FB6 11D/B6 4/82 Differential electronic module (DEM) - 10
FB7 11D/B7 9/14 Control module, rear left seat heater - 15
FB9 11D/B9 3/27 Switch unit, power passenger seat - 25
FB10 11D/B10 4/93 Keyless vehicle module (KVM) - 20
FB11 11D/B11 6/146 Lock motor, rear left brake disc 4/115 30
FB12 11D/B12 6/147 Lock motor, rear right brake disc 4/115 30
-
-
-
G036054
5
TP39133202 XC60 2009 20
Fuses
Rear electrical center FD1-FD7
4
8
12
11
2
3
7
10
1
5
6
9
15/32 Rear electrical center
No. No. Fuse function via A
FD1 11D/D1 16/46 High Level Display Front (HLDF)
16/108 Multimedia module (MMM)
FD3 11D/D3 16/79 Subwoofer module (SUB) - 25
FD4 11D/D4 16/145 Remote Digital Audio Receiver (RDAR)
16/162 Digital Audio Broadcast Module (DABM)
FD5 11D/D5 16/105 Audio module (AUD) - 25
FD6 11D/D6 3/281 Infotainment control module (ICM)
4/124 Accessory USB unit (AUU)
16/1 Integrated Audio Module (IAM)
FD7 11D/D7 16/60 Phone module (PHM)
16/147 Bluetooth phone module (BPM)
-
-
-
-
-
-
-
-
-
G036067
10
5
15
5
TP39133202 XC60 2009 21
Fuses
Battery PF1-PF2
PF2
1/1 Battery
No. Fuse function via A
PF1 11A/1-11A/7 Main fuses in engine compartment fuse box
11A/42-11A/44 Main fuses in engine compartment fuse box
11B/8-11B/14 Fuses in engine compartment fuse box
11B/16-11B/22 Fuses in engine compartment fuse box
11B/23 Fuses in engine compartment fuse box
11B/24-11B/26 Fuses in engine compartment fuse box
11B/27-11B/32 Fuses in engine compartment fuse box
11B/33 Fuses in engine compartment fuse box
11B/34 Fuses in engine compartment fuse box
11B/35-11B/41 Fuses in engine compartment fuse box
PF2 6/25 Starter motor
6/26 Alternator control module (ACM)
-
-
-
2/31
-
2/193
-
2/32
-
2/32
-
-
PF1
G029459
150
150
TP39133202 XC60 2009 22
Relays
Relays in the engine compartment R2
15/33 Engine compartment cold zone
Pos Relay function
R2 2/17 Relay, horn
R2
G029468
TP39133202 XC60 2009 23
Relays
Relays in the engine compartment R8-R9
15/31 Distribution box engine compartment
Pos Relay function
R8 2/31 Relay, 15-feed
R9 2/193 Relay, comfort functions
R8 R9
G029466
TP39133202 XC60 2009 24
Relays
Relays in the engine compartment R10-R13
R12 R10
15/31 Distribution box engine compartment
Pos Relay function
R10 2/32 Main relay, engine management system
R11 -
R12 2/35 Relay, starter motor
R13 2/22 Relay, climate control system
R13
R11
G029467
TP39133202 XC60 2009 25
Relays
Distribution box in cargo compartment RA1-RD1
A
RA2
RA1
2/16
2/82
15/32 Rear electrical center
Pos Relay function
RA1 2/82 Relay, heated rear window
RA2 2/16 Relay, rear window wiper
RB1 2/88 Relay, 15-feed rear
RB2 -
RD1 Mounting
B
RB2
2/75
RB1
2/88
D
RD1
A
B
D
G036069
TP39133202 XC60 2009 26
Relays - soldered
Central Electronic Module (CEM)
4/56 Central Electronic Module (CEM)
Pos Relay function
K1 Front fog lights
K2 High beam
K3 Reversing lights
K5-A Washer motor
K5-B Washer motor
K8 Fuel pump
K9 Steering column lock module (SCL)
K10-A Interior lighting
K12 Lock motor, fuel filler flap
TP39133202 XC60 2009 27
Ground connections
Overview
31/95
31/93
31/3
31/2
31/4
31/
XX14
31/
XX10
31/XX4
31/XX5
31/88
31/89
31/90
31/AL
31/
XX15
31/96
31/94
31/1
31/83
31/10
31/6
31/65
31/66
31/7
31/84
31/15
31/67
31/68
31/47
31/TRM
31/5
TP39133202 XC60 2009 28
31/
INFOT
31/48
G034229
Ground connections
31/1 - 31/7
31/1 Ground connection, PTC
9/42 PTC-element
31/2 LH wheel housing
4/71 Cooling fan control module
31/3 Body, battery
1/1 Battery
31/4 Engine
31/XX4 Ground connection
31/5 Rear edge roof
9/2 Heated rear window
31/6 Bottom rail, left
3/27 Switch unit, power passenger seat, RHD
3/126 Driver Door Module (DDM), LHD
3/127 Passenger Door Module (PDM), RHD
3/128 Left rear door module (LDM)
3/176 Switch, driver’s door power window, LHD
3/273 Lock contact, LH front door
3/275 Lock contact, left rear door
4/52 Power Seat Module (PSM), LHD
6/36 Lock motor, central locking, LH front door
6/57 Lock motor, central locking, LH rear door
9/12 Seat Heating Module (SHM), driver’s side, LHD
9/13 Seat Heating Module (SHM), passenger side, RHD
31/7 Bottom rail, left
3/271 Contact, immobilizer, clutch pedal, LHD
3/284 Diagnostic contact, brake light, LHD
4/56 Central Electronic Module (CEM), RHD
7/51 Accelerator pedal sensor, LHD
7/175 Weight sensor passenger seat, seat belt reminder, RHD
8/51 Igniter side airbag front left, LHD
8/52 Igniter side airbag front right, RHD
TP39133202 XC60 2009 29
Ground connections
31/10 - 31/15 continues
31/10 Bottom rail, left
3/6 Switch, hazard warning flashers
3/117 Switch unit, ceiling light
4/31 Fan control module
4/33 Panoramic roof control module
4/76 Remote control unit for garage door opener
4/102 Steering column lock module (SCL)
4/119 Remote Keyless Entry (RKE)
4/119.2 Remote Receiver Module (RRX)
4/125 Closing velocity module (CVM)
6/48 Damper Motor Module (DMM), recirculation
6/95 Damper Motor Module (DMM), temperature, left-hand side
6/96 Damper Motor Module (DMM), temperature, right-hand side
6/102 Damper Motor Module (DMM), defroster
6/103 Damper Motor Module (DMM), floor/ventilation
7/149 Rain sensor module (RSM)
7/159 Air quality sensor (AQS)
7/199 Ultrasonic sensor
7/238 Alcolock sensor
8/48 Auto-dimming rearview mirror
10/22 Ceiling light
10/29 Glove compartment lighting
10/114 Vanity mirror lighting, left
10/115 Vanity mirror lighting, right
10/150A Rear reading light
10/150B Rear reading light
17/13 Data link connector
17/45 Alcolock outlet
26/8 Alcolock charging cradle
31/15 Bottom rail, right
3/27 Switch unit, power passenger seat, LHD
3/65 Switch, heated rear seat
3/126 Driver Door Module (DDM), RHD
3/127 Passenger Door Module (PDM), LHD
3/129 Right rear door module (RDM)
3/156 Gear Selector Module (GSM), RHD
3/176 Switch, driver’s door power window, RHD
3/274 Lock contact, RH front door
3/276 Lock contact, RH rear door
continues
TP39133202 XC60 2009 30
Loading...