Loading...Toshiba Personal Computer
PORTÉGÉ R600
Maintenance Manual
First edition September 2008
TOSHIBA CORPORATION
File Number 960-709
[CONFIDENTIAL]
Copyright
© 2008 by Toshiba Corporation. All rights reserved. Under the copyright laws, this manual cannot be reproduced in any form without the prior written permission of Toshiba. No patent liability is assumed with respect to the use of the information contained herein.
TOSHIBA PORTEGE R600 Maintenance Manual
First edition September 2008
Disclaimer
The information presented in this manual has been reviewed and validated for accuracy. The included set of instructions and descriptions are accurate for the TOSHIBA PORTEGE R600at the time of this manual's production. However, succeeding computers and manuals are subject to change without notice. Therefore, Toshiba assumes no liability for damages incurred directly or indirectly from errors, omissions, or discrepancies between any succeeding product and this manual.
Trademarks
IBM is a registered trademark and IBM PC is a trademark of International Business Machines Corporation.
Intel, Intel SpeedStep, Intel Core and Centrino are trademarks or registered trademarks of Intel Corporation.
Windows, Microsoft and Windows Vista are registered trademarks of Microsoft Corporation. Bluetooth is a trademark owned by its proprietor and used by TOSHIBA under license. Photo CD is a trademark of Eastman Kodak.
ConfigFree is a trademark of Toshiba Corporation. Wi-Fi is a registered trademark of the Wi-Fi Alliance. ExpressCard is a trademark of PCMCIA.
Secure Digital and SD are trademarks of SD Card Association.
Other trademarks and registered trademarks not listed above may be used in this manual.
ii |
[CONFIDENTIAL] PORTEGE R600 Maintenance Manual (960-709) |
Preface
This maintenance manual describes how to perform hardware service maintenance for the Toshiba Personal Computer PORTEGE R600
The procedures described in this manual are intended to help service technicians isolate faulty Field Replaceable Units (FRUs) and replace them in the field.
SAFETY PRECAUTIONS
Four types of messages are used in this manual to bring important information to your attention. Each of these messages will be italicized and identified as shown below.
DANGER: “Danger” indicates the existence of a hazard that could result in death or serious bodily injury, if the safety instruction is not observed.
WARNING: “Warning” indicates the existence of a hazard that could result in bodily injury, if the safety instruction is not observed.
CAUTION: “Caution” indicates the existence of a hazard that could result in property damage, if the safety instruction is not observed.
NOTE: “Note” contains general information that relates to your safe maintenance service.
Improper repair of the computer may result in safety hazards. Toshiba requires service technicians and authorized dealers or service providers to ensure the following safety precautions are adhered to strictly.
Be sure to fasten screws securely with the right screwdriver. If a screw is not fully fastened, it could come loose, creating a danger of a short circuit, which could cause overheating, smoke or fire.
If you replace the battery pack or RTC battery, be sure to use only the same model battery or an equivalent battery recommended by Toshiba. Installation of the wrong battery can cause the battery to explode.
PORTEGE R600 Maintenance Manual (960-709) [CONFIDENTIAL] |
iii |
The manual is divided into the following parts:
Chapter 1 Hardware Overview describes the PORTEGE R600system unit and each FRU.
Chapter 2 Troubleshooting Procedures explains how to diagnose and resolve FRU problems.
Chapter 3 Test and Diagnostics describes how to perform test and diagnostic operations for maintenance service.
Chapter 4 Replacement Procedures describes the removal and replacement of the FRUs.
Appendices The appendices describe the following:
Handling the LCD module
Board layout
Pin assignments
Keyboard scan/character codes
Key layout
Wiring diagrams
BIOS rewrite procedures
EC/KBC rewrite procedures
Reliability
iv |
[CONFIDENTIAL] PORTEGE R600 Maintenance Manual (960-709) |
Conventions
This manual uses the following formats to describe, identify, and highlight terms and operating procedures.
Acronyms
On the first appearance and whenever necessary for clarification acronyms are enclosed in parentheses following their definition. For example:
Read Only Memory (ROM)
Keys
Keys are used in the text to describe many operations. The key top symbol as it appears on the keyboard is printed in boldface type.
Key operation
Some operations require you to simultaneously use two or more keys. We identify such operations by the key top symbols separated by a plus (+) sign. For example, Ctrl + Pause (Break) means you must hold down Ctrl and at the same time press Pause (Break). If three keys are used, hold down the first two and at the same time press the third.
User input
Text that you are instructed to type in is shown in the boldface type below:
DISKCOPY A: B:
The display
Text generated by the computer that appears on its display is presented in the type face below:
Format complete
System transferred
PORTEGE R600 Maintenance Manual (960-709) [CONFIDENTIAL] |
v |
Table of Contents
Chapter 1 Hardware Overview |
|
|
1.1 |
Features ...................................................................................................................... |
1-1 |
1.2 |
System Unit Block Diagram ...................................................................................... |
1-8 |
1.3 |
3.5-inch Floppy Disk Drive (USB External) ........................................................... |
1-14 |
1.4 |
2.5-inch Hard Disk Drive......................................................................................... |
1-15 |
1.5 |
1.8-inch Solid State Drive (SSD)............................................................................. |
1-17 |
1.6 |
DVD-Super Multi Drive Optical Drive (ODD)....................................................... |
1-18 |
1.7 |
Keyboard................................................................................................................. |
1- 19 |
1.8 |
TFT Color Display.................................................................................................. |
1- 20 |
1.9 |
Power Supply .......................................................................................................... |
1- 21 |
1.10 |
Batteries .................................................................................................................. |
1- 23 |
1.11 |
AC Adaptor............................................................................................................. |
1- 26 |
vi |
[CONFIDENTIAL] PORTEGE R600 Maintenance Manual (960-709) |
Chapter 2 Troubleshooting Procedures |
|
|
2.1 |
Troubleshooting ......................................................................................................... |
2-1 |
2.2 |
Troubleshooting Flowchart........................................................................................ |
2-3 |
2.3 |
Power Supply Troubleshooting.................................................................................. |
2-8 |
2.4 |
System Board Troubleshooting................................................................................ |
2-18 |
2.5 |
USB FDD Troubleshooting ..................................................................................... |
2-33 |
2.7 |
Keyboard and Touch pad Troubleshooting.............................................................. |
2-43 |
2.8 |
Display Troubleshooting.......................................................................................... |
2-45 |
2.9 |
Optical Disk Drive Troubleshooting........................................................................ |
2-47 |
2.10 |
Modem Troubleshooting.......................................................................................... |
2-50 |
2.11 |
LAN Troubleshooting.............................................................................................. |
2-52 |
2.12 |
Wireless LAN Troubleshooting............................................................................... |
2-53 |
2.13 |
Bluetooth Troubleshooting ...................................................................................... |
2-56 |
2.14 |
Sound Troubleshooting............................................................................................ |
2-59 |
2.15 |
3G Troubleshooting ................................................................................................. |
2-61 |
2.16 |
SD Card Slot Troubleshooting................................................................................. |
2-64 |
2.17 |
Fingerprint sensor .................................................................................................... |
2-65 |
2.18 |
Web camerta Troubleshooting................................................................................. |
2-69 |
2.19 |
Intel Turbo Memory Troubleshooting ..................................................................... |
2-71 |
PORTEGE R600 Maintenance Manual (960-709) [CONFIDENTIAL] |
vii |
Chapter 3 Tests and Diagnostics |
|
|
3.1 |
The Diagnostic Test ................................................................................................... |
3-1 |
3.2 |
Executing the Diagnostic Test ................................................................................... |
3-4 |
3.3 |
Setting of the hardware configuration ....................................................................... |
3-9 |
3.4 |
Heatrun Test............................................................................................................. |
3-11 |
3.5 |
Subtest Names.......................................................................................................... |
3-12 |
3.6 |
System Test.............................................................................................................. |
3-14 |
3.7 |
Memory Test............................................................................................................ |
3-16 |
3.8 |
Keyboard Test.......................................................................................................... |
3-17 |
3.9 |
Display Test ............................................................................................................. |
3-18 |
3.10 |
Floppy Disk Test...................................................................................................... |
3-21 |
3.11 |
Printer Test............................................................................................................... |
3-23 |
3.12 |
Async Test ............................................................................................................... |
3-25 |
3.13 |
Hard Disk Test ......................................................................................................... |
3-26 |
3.14 |
Real Timer Test........................................................................................................ |
3-29 |
3.15 |
NDP Test.................................................................................................................. |
3-31 |
3.16 |
Expansion Test......................................................................................................... |
3-32 |
3.17 |
CD-ROM/DVD-ROM Test ..................................................................................... |
3-34 |
3.18 |
Error Code and Error Status Names......................................................................... |
3-35 |
3.19 |
Hard Disk Test Detail Status ................................................................................... |
3-38 |
3.20 |
ONLY ONE TEST................................................................................................... |
3-40 |
3.21 |
Head Cleaning.......................................................................................................... |
3-51 |
3.22 |
Log Utilities ............................................................................................................. |
3-52 |
3.23 |
Running Test............................................................................................................ |
3-54 |
3.24 |
Floppy Disk Drive Utilities...................................................................................... |
3-55 |
3.25 |
System Configuration .............................................................................................. |
3-60 |
3.26 |
Wireless LAN Test Program (Atheros) ................................................................... |
3-62 |
3.27 |
Wireless LAN Test Program (Intel-made a/b/g/n Setting up of REF PC)............... |
3-64 |
3.28 |
Wireless LAN Test Program on DUT PC (Intel-made)........................................... |
3-69 |
3.29 |
LAN/Modem/Bluetooth/IEEE1394 Test Program .................................................. |
3-73 |
3.30 |
Sound Test program................................................................................................. |
3-80 |
3.31 |
3G Test program ..................................................................................................... |
3-80 |
|
|
|
viii |
[CONFIDENTIAL] PORTEGE R600 Maintenance Manual (960-709) |
|
3.32 SETUP ..................................................................................................................... |
3-81 |
Chapter 4 |
Replacement Procedures |
|
|
4.1 |
Overview.................................................................................................................... |
4-1 |
|
Appendices |
|
|
|
Appendix A |
Handling the LCD Module ........................................................................... |
A-1 |
|
Appendix B |
Board Layout ................................................................................................ |
B-1 |
|
Appendix C |
Pin Assignments............................................................................................ |
C-1 |
|
Appendix D |
Keyboard Scan/Character Codes .................................................................. |
D-1 |
|
Appendix E |
Key Layout..................................................................................................... |
E-1 |
|
Appendix F |
Wiring Diagrams............................................................................................ |
F-1 |
|
Appendix G |
BIOS rewrite Procedures .............................................................................. |
G-1 |
|
Appendix H |
EC/KBC rewrite Procedures ......................................................................... |
H-1 |
|
Appendix I |
Reliability........................................................................................................ |
I-1 |
|
PORTEGE R600 Maintenance Manual (960-709) [CONFIDENTIAL] |
ix |
x |
[CONFIDENTIAL] PORTEGE R600 Maintenance Manual (960-709) |
Chapter 1
Hardware Overview
[CONFIDENTIAL]
1 Hardware Overview
1-ii |
[CONFIDENTIAL] PORTEGE R600 Maintenance Manual (960-709) |
|
|
|
1 Hardware Overview |
|
|
|
|
Chapter 1 |
Contents |
|
|
1.1 |
Features....................................................................................................................... |
|
1-1 |
1.2 |
System Unit Block Diagram....................................................................................... |
1-8 |
|
1.3 |
3.5-inch Floppy Disk Drive (USB External)............................................................ |
1-14 |
|
1.4 |
2.5-inch Hard Disk Drive ......................................................................................... |
1-15 |
|
1.5 |
1.8-inch Solid State Drive (SSD) ............................................................................. |
1-17 |
|
1.6 |
DVD-Super Multi Drive Optical Drive (ODD)........................................................ |
1-18 |
|
1.7 |
Keyboard ................................................................................................................. |
|
1- 19 |
1.8 |
TFT Color Display .................................................................................................. |
1- 20 |
|
1.9 |
Power Supply........................................................................................................... |
1- 21 |
|
1.10 |
Batteries................................................................................................................... |
|
1- 23 |
|
1.10.1 |
Main Battery ...................................................................................... |
1- 23 |
|
1.10.2 |
Battery Charging Control................................................................... |
1- 24 |
|
1.10.3 |
RTC battery........................................................................................ |
1- 25 |
1.11 |
AC Adaptor ............................................................................................................. |
|
1- 26 |
PORTEGE R600 Maintenance Manual (960-709) [CONFIDENTIAL] |
1-iii |
1 Hardware Overview
Figures |
|
|
Figure 1-1 |
Front of the computer .................................................................................... |
1- 7 |
Figure 1-2 |
System unit configuration.............................................................................. |
1- 8 |
Figure 1-3 |
System unit block diagram ............................................................................ |
1- 9 |
Figure 1-4 |
3.5-inch FDD (USB External)..................................................................... |
1- 15 |
Figure 1-5 |
2.5-inch HDD .............................................................................................. |
1- 16 |
Figure 1-6 |
DVD Super Multi drive ............................................................................... |
1- 20 |
Figure 1-7 |
Keyboard ..................................................................................................... |
1- 22 |
Figure 1-8 |
LCD module ................................................................................................ |
1- 23 |
Tables |
|
|
Table 1-1 |
3.5-inch FDD specifications........................................................................ |
1- 15 |
Table 1-2 |
2.5-inch HDD specifications ....................................................................... |
1- 16 |
Table 1-3 |
DVD-ROM drive specifications.................................................................. |
1- 18 |
Table 1-4 |
DVD-ROM & CD-R/RW drive specifications............................................ |
1- 19 |
Table 1-5 |
DVD Super Multi drive specifications........................................................ |
1- 21 |
Table 1-6 |
LCD module specifications ......................................................................... |
1- 23 |
Table 1-7 |
FL inverter board specifications.................................................................. |
1- 25 |
Table 1-8 |
Power supply output rating.......................................................................... |
1- 27 |
Table 1-9 |
Battery specifications .................................................................................. |
1- 28 |
Table 1-10 |
Time required for charges ........................................................................... |
1- 29 |
Table 1-11 |
Data preservation time................................................................................. |
1- 30 |
Table 1-12 |
RTC battery charging/data preservation time.............................................. |
1- 30 |
Table 1-13 |
AC adapter specifications............................................................................ |
1- 31 |
1-iv |
[CONFIDENTIAL] PORTEGE R600 Maintenance Manual (960-709) |
1 Hardware Overview
1.1Features
The Toshiba PORTEGE R600 Personal Computer uses extensive Large Scale Integration (LSI), and Complementary Metal-Oxide Semiconductor (CMOS) technology extensively to provide compact size, minimum weight, low power usage and high reliability. This computer incorporates the following features.
There some models and options. Refer to the Parts List for the configuration of each model and options.
Microprocessor
The Toshiba PORTEGE R600 computer is equipped with an Intel® CoreTM 2 Duo ULV Processor. These processors incorporate a math co-processor, a 3MB L2 cache memory.
The PC comes in with one of the following speeds:
Intel® CoreTM 2 Duo ULV Processor (Penryn ULV)
•SU9400 (1.40GHz)
•SU9300 (1.20GHz)
These processors operate at 800MHz bus clock (FSB).
Memory
One DDR2-667/DDR2-800 SDRAM slots. Memory modules can be installed to provide a maximum of 5GB (on board memory 1GB). Memory modules are available in 512MB, 1024MB, 2048MB and 4096MB sizes.
Chipset
The PORTEGE R600 is Equipped with Intel Cantiga GS as North Bridge, Intel ICH9M SFF as South Bridge and RICHO R5C847 Card Controller.
VGA Controller
An internal Graphics Controller in North Bridge is used.
HDD
The computer has a 2.5-inch SATA HDD. The following capacities are available.
•80/120/160/200/250 GB
PORTEGE R600 Maintenance Manual (960-709) [CONFIDENTIAL] |
1-1 |
1 Hardware Overview
SSD
Some models are equipped with a "Solid State Drive (SSD)" instead of a hard disk drive.
•64GB,128GB
USB FDD
A 3.5-inch USB FDD accommodates 2HD (1.44MB) or 2DD (720KB) disks.
Optical Drive
A DVD Super Multi drive (double layer) can be installed.
Display
LCD : Built-in 12.1inch, 16M colors, WXGA(1280×800dots) thin type low temperature poly-silicon TFT color display.
External monitor : Supported via an RGB connector.
Keyboard
An-easy-to-use 85(US)/87(UK)-key keyboard provides a numeric keypad overlay for fast
numeric data entry or for cursor and page control. The keyboard also includes two keys that have special functions in Microsoft® Windows® Vista. It supports software that uses a 101or 102-key enhanced keyboard.
Touch pad
A Touch Pad and control buttons in the palm rest enable control of the on-screen pointer and scrolling of windows.
1-2 |
[CONFIDENTIAL] PORTEGE R600 Maintenance Manual (960-709) |
1 Hardware Overview
Batteries
The computer has two batteries: a rechargeable Lithium-Ion main battery pack and RTC battery (that backs up the Real Time Clock and CMOS memory.
Universal Serial Bus (USB2.0)
Two USB ports are provided. The ports comply with the USB2.0 standard, which enables data transfer speeds 40 times faster than USB1.1 standard. USB1.1 is also supported.
eSATA/USB combo
One eSATA/USB combo port, which complies to. The USB 2.0 standard is provided. This port has eSATA (External Serial ATA) function.
A power supply is always supplied to one USB ports on the left side of a computer.
External monitor (RGB) port
The port enables connection of an external monitor, which is recognized automatically by Video Electronics Standards Association (VESA) Display Data Channel (DDC) 2B compatible functions.
ExpressCard slot
The internal ExpressCard slot is a Universal slot. This slot supports ExpressCard/54 and ExpressCard/34 modules.
PC card slot (Japanese model only)
PC card slots are provided. The PC card slot (PCMCIA) accommodates one Type II card.
SD/ SDHC memory card slot
One SD/ SDHC memory card slot. Data can be read and written by inserting each media to the slot.
Fingerprint sensor
The computer is equipped with a fingerprint sensor and fingerprint authentication utility. They enable only person who has registered his/her fingerprint to use the computer.
PORTEGE R600 Maintenance Manual (960-709) [CONFIDENTIAL] |
1-3 |
1 Hardware Overview
Docking interface port
The docking interface port enables connection of an optional Slim Port Replicator II. It provides additional features as follows:
•RJ45 LAN jack
•External monitor port
•DC IN 15V jack
•Security lock slot
•Universal Serial Bus 2.0 port (four)
•DVI port
Sound system
The sound system is equipped with the following features:
•speakers
•Volume control
•Stereo headphone jack
•External microphone jack
•Built-in microphone
Internal modem (Not Used)
The computer contains a MDC, enabling data and fax communication. It supports ITU-T V.90 (V.92). The transfer rates are 56 Kbps for data reception, 33.6 Kbps for data transmission, and 14,400 bps for fax transmission. However, the actual speed depends on the line quality. The RJ11 modem jack is used to accommodate a telephone line. Both of V.90 and V.92 are supported only in USA, Canada and Australia. Only V.90 is available in other regions.
Internal LAN
The computer is equipped with LAN circuits that support Gigabit Ethernet LAN (1000 megabits per second, 1000BASE-T). It also supports Wakeup on LAN (WOL), Magic Packet and LED.
1-4 |
[CONFIDENTIAL] PORTEGE R600 Maintenance Manual (960-709) |
1 Hardware Overview
Wireless LAN
The computer is equipped with PCI-Ex MiniCard type wireless LAN board that supports 802.11 b/g, 802.11 a/b/g or 802.11 a/b/g/n in the PCI-Ex MiniCard slot. This function can be switched on and off by a switch on the computer.
Bluetooth
Depending on the model, the computer is equipped with a dedicated Bluetooth module. This enables a communication to devices that support Bluetooth
This Bluetooth Stack is based on the Bluetooth Version 1.1/1.2/2.0+EDR/2.1+EDR specification.
Web Camera
Web Camera is a device that allows you to record video or take photographs with your computer.
Enables the transmission of video and use of video chat via the internet using specialized applications.
The effective pixel count for this web camera is0.3 million (maximum photograph size: 640x480 pixels).
Intel Turbo Memory (Robson): PCI Express Mini Card slot (Not Used) This computer (Some models) is Intel Turbo Memory loading.
3G: PCI Express Mini Card slot 2.
The computer (Some models) is equipped with PCI Express Mini Card type 3G card
TOSHIBA Assist button
When this button is pressed during power-on, the PC is connected to "Toshiba Assist". When this button is pressed during power-off, the PC is turned on and connected to "Toshiba Assist".
Back light On/Off button
If you turn off the back light outdoors in a good weather, you can use the computer for a longer period.
Felica: (Japanese model only)
This manual does not explain.
PORTEGE R600 Maintenance Manual (960-709) [CONFIDENTIAL] |
1-5 |
1 Hardware Overview
The front of the computer is shown in figure 1-1.
Figure 1-1 Front of the computer
1-6 |
[CONFIDENTIAL] PORTEGE R600 Maintenance Manual (960-709) |
1 Hardware Overview
The system unit configuration is shown in figure 1-2.
Figure 1-2 System unit configuration
PORTEGE R600 Maintenance Manual (960-709) [CONFIDENTIAL] |
1-7 |
1 Hardware Overview
1.2System Unit Block Diagram
Figure 1-3 is a block diagram of the system unit.
Figure 1-3 System unit block diagram
1-8 |
[CONFIDENTIAL] PORTEGE R600 Maintenance Manual (960-709) |
1 Hardware Overview
The system unit is composed of the following major components:
Microprocessor
The Toshiba PORTEGE R600 computer is equipped with an Intel® CoreTM 2 Duo ULV Processor. These processors incorporate a math co-processor, a 3MB L2 cache memory.
The PC comes in with one of the following speeds: Intel® CoreTM 2 Duo ULV Processor (Penryn ULV)
•SU9400 (1.40GHz)
•SU9300 (1.20GHz)
These processors operate at 800MHz bus clock (FSB).
Memory
One DDR2-667/DDR2-800 SDRAM slots. Memory modules can be installed to provide a maximum of 5GB (on board memory 1GB). Memory modules are available in 512MB, 1024MB, 2048MB and 4096MB sizes.
•- 200-pin small-size DIMM
•- 1.8V operation
•- DDR2-667/800 support
BIOS ROM (Flash memory)
•- 8Mbit (512K×16-bit chip)
•301KB used for Animation
•288KB used for system BIOS
•64KB used for VGA-BIOS
•64KB used for Finger Print
•32KB used for ACPI
•24KB used for booting
•16KB used for Parameter Block
•Others
PORTEGE R600 Maintenance Manual (960-709) [CONFIDENTIAL] |
1-9 |
1Hardware Overview
North Bridge (Intel Cantiga GS :Intel GS45)
•Penryn Processor System Bus Supports
•System Memory supports :DDR2-667 DDR2-800, 5GB max.
•Internal Graphics
High-performance mode 533MHz /1.05V
Low-power mode 320MHz / 1.00V
•DMI(Direct Media Interface)
•Power management control (ACPI 3.0)
•363-bal 27×25mm FCBGA package (SFF Package)
South Bridge (Intel ICH9M SFF :Intel 82801IEM)
•DMI (Direct Media Interface)
•PCI Express I/F and (6 Prots) PCI Bus I/F Rev2.3 (4 PCI REQ/GNT Pairs)
•Integrated Serial ATA Host Controller and (6 Prots, 300 MB/s) External SATA support
•Intel Matrix Storage Technology (AHCI/RAID)
•Intel High Definition Audio Interface
•USB 2.0 Controller 12 Prots
•LAN controller built-in (IEEE-802.3 conformity) and power management control (ACPI 3.0b conformity)
•SMBus2.0
•SPI Interface (BIOS)
•LPC Interface (EC/KBC, Super I/O)
•Interrupt controller
•RTC built-in
•GPIO
•569-ball 16x16mm FCBGA Package (SFF Package)
1-10 |
[CONFIDENTIAL] PORTEGE R600 Maintenance Manual (960-709) |
1 Hardware Overview
Card controller (R5C847)
•- PCI Interface
•- SD/MMC, Memory Stick, xD card Controller
VGA Controller
An internal Graphics Controller in North Bridge is used.
Sound Controller
•HD Audio Link (Intel High Definition Audio I/F) and RealTec ALC262
•Amplifier: Mathushita made AN12945A
•HD Audio
•speakers
•Digital volume control
•Supports VoIP
•Stereo headphone jack
•External microphone jack
•Built-in microphone
Modem Controller (Not used)
•One MDC is used.
•This controller has the following functions:
–One RJ11 port
–Agere
–V.92 (V.90) 56K Modem/FAX
–Ring wake up support
PORTEGE R600 Maintenance Manual (960-709) [CONFIDENTIAL] |
1-11 |
1 Hardware Overview
Internal LAN Controller
•Intel made only GigaBit Ether is used.
•This controller has the following functions:
–PCI-Ex connection
–Controller Intel madeBoazman (WG82567LM /WG82567LV)
:GLCI(PCI-Ex)/LCI Connection
–Supports Gigabit Ethernet
–One RJ45 port
–WOL support
–Magic Packet support
Wireless LAN
•One PCI Express Mini Card slot1
802.11 b/g Askey/Atheros 11b/g(ROW) XB63L
802.11 b/g/n Askey/Atheros 11b/g/n (MoW) XB91L
802.11 a/b/g/n |
Askey/Atheros 11a/b/g/n, 2x2 (MoW) XB92L |
802.11 a/b/g Intel 11a/b/g Shirley Peak (MOW) MC 1x2 |
|
802.11 a/b/g/n |
Intel 11a/b/g/n Shirley Peak (MOW) MC 1x2 |
•Supports Wireless Communication SW
Bluetooth
•V2.1
•USB interface connection
EC/KBC (Embedded Controller/Keyboard Controller)
•One Mitsubishi M306KAFCLPR micon chip functions as both EC and KBC.
1-12 |
[CONFIDENTIAL] PORTEGE R600 Maintenance Manual (960-709) |
1 Hardware Overview
PSC (Power Supply Controller)
•One TMP86FS49AUG chip is used.
•This controller controls the power sources.
EEPROM for security
•M24C08-WDW6TP (ST micro) chip is used.
TPM
•SLB9635 TT 1.2 Infineon chip is used.
Clock Generator
•ICS9LVRS128 BKLF-T (Integrated Device Technology) is used.
•This device generates the system clock.
Sensor
•Thermal Sensor: One ADM1032ARMZ chip is used.
•Thermistor: It is used at seven places. (Cantiga-GS, Memoryx2, for [ x4 (FAN
getting it blocked normal temperature measurement x2, detection x2) ] failure omens)
•Magnetometric sensor: It is used as an object for LCD opening and closing
(ferrite magneto system).
•Acceleration Sensor : HDD protection(LIS3L02A)
•Fingerprints sensor: Authen Tec maid(AES1610-C-DF-CA-NI00)
PORTEGE R600 Maintenance Manual (960-709) [CONFIDENTIAL] |
1-13 |
1 Hardware Overview
1.33.5-inch Floppy Disk Drive (USB External)
The 3.5-inch FDD is a thin, high-performance reliable drive that supports 720KB (formatted) 2DD and 1.44MB (formatted) 2HD disks.
The FDD is shown in figure 1-4. The specifications for the FDD are listed in Table 1-1.
Figure 1-4 3.5-inch FDD (USB External)
Table 1-1 3.5-inch FDD specifications
|
|
TEAC FD-05PUB-337 |
||
Items |
(G8AC0000B320) |
|||
|
|
720KB mode |
|
1.44MB mode |
|
|
|
|
|
Data transfer rate |
FDD part |
250K bits/second |
|
500K bits/second |
|
|
|
|
|
|
USB |
Full speed mode (12M bits/second) |
||
|
|
|
|
|
Disk rotation speed |
|
300rpm |
||
|
|
|||
Track density |
5.3 track/mm (135TPI) |
|||
|
|
|
|
|
1-14 |
[CONFIDENTIAL] PORTEGE R600 Maintenance Manual (960-709) |
1 Hardware Overview
1.42.5-inch Hard Disk Drive
The removable HDD is a random access non-volatile storage device. It has a non-removable 2.5-inch magnetic disk and mini-Winchester type magnetic heads.
The computer supports a 80GB, 120GB, 160GB, 200GB or 250GB. The HDD is shown in figure 1-5. Specifications are listed in Table 1-2.
Figure 1-5 2.5-inch HDD
Table 1-2 2.5-inch HDD specifications
Items |
|
|
Specifications |
|
|||
|
|
|
|
|
|
|
|
|
|
|
TOSHIBA |
TOSHIBA |
|
TOSHIBA |
TOSHIBA |
|
|
|
G8BC0004G080 |
G8BC0004G120 |
|
G8BC0004G160 |
G8BC0004G250 |
|
|
|
|
|
|
|
|
Outline |
|
Width |
|
100.0 |
|
|
|
|
|
(mm) |
|
|
|
||
|
|
|
|
|
|
|
|
Dimensions |
|
Height |
|
9.5 |
|
|
|
|
|
(mm) |
|
|
|
||
|
|
|
|
|
|
|
|
|
|
Depth |
|
69.85 |
|
|
|
|
|
(mm) |
|
|
|
||
|
|
|
|
|
|
|
|
|
|
Weigh |
|
98 max |
|
102 max |
|
|
|
t (g) |
|
|
|||
|
|
|
|
|
|
|
|
Storage size (formatted) |
80GB |
120GB |
|
160GB |
250GB |
||
|
|
|
|
|
|
|
|
Speed (RPM) |
|
|
5,400 |
|
|
||
|
|
|
|
|
|
||
Data transfer speed |
|
335-613(Mbits/s) |
|
||||
Internal Transfer rate |
|
|
|||||
|
300 (Mbytes/s) |
|
|||||
Host Transfer rate |
|
|
|
||||
|
|
|
|
|
|
||
|
|
|
|
|
|||
Data buffer size |
|
|
8,192Kbyte |
|
|||
|
|
|
|
||||
Motor startup time (s) |
|
3.5 typical |
|
||||
|
|
|
|
9.5 max |
|
||
|
|
|
|
|
|
|
|
PORTEGE R600 Maintenance Manual (960-709) [CONFIDENTIAL] |
1-15 |
Table 1-2 2.5-inch HDD specifications
|
|
|
|
|
|
Specifications |
|
|
|
|
|
|
|
|
|
|
|
|
Items |
|
HGST |
HGST |
HGST |
HGST |
HGST |
|
|
|
G8BC00051 |
G8BC00051 |
G8BC00051 |
G8BC00046 |
G8BC0005 |
||
|
|
|
|
|||||
|
|
|
080 |
120 |
160 |
200 |
1250 |
|
|
|
|
|
|
|
|
|
|
Outline |
|
Width (mm) |
|
|
|
100.2±0.25 |
|
|
Dimensio |
|
Height (mm) |
|
|
|
9.5±0.2 |
|
|
ns |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
Depth (mm) |
|
|
|
69.85±0.25 |
|
|
|
|
Weight (g) |
|
|
95 max |
|
|
102 max |
Storage size (formatted) |
|
80GB |
120GB |
160GB |
200GB |
250GB |
||
|
|
|
|
|
|
|
||
Speed (RPM) |
|
|
5,400 |
|
7,200 |
5,400 |
||
|
|
|
|
|
|
|
||
Data transfer rate |
|
|
|
|
|
|
||
Disk-buffer to/from |
|
|
|
|
|
|
||
media(Mbps) |
|
|
|
775 max |
|
|
||
Buffer-host data transfer |
|
|
|
3.0/1.5 max. |
|
|
||
(Ggit/sec) |
|
|
|
|
|
|
|
|
Data buffer size (MB/s) |
|
|
|
8 |
|
|
||
|
|
|
|
|
|
|
||
Positioning Time(read and |
|
|
|
Read: 12ms |
|
|
||
seek time) |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
||
Motor startup time (s) |
|
|
|
3.5 |
|
|
||
|
|
|
|
|
|
|
|
|
1-16 |
[CONFIDENTIAL] PORTEGE R600 Maintenance Manual (960-709) |
Loading...