VSX-D709S
ORDER NO.
PIONEER CORPORATION 4-1, Meguro 1-chome, Meguro-ku, Tokyo 153-8654, Japan
PIONEER ELECTRONICS SERVICE, INC. P.O. Box 1760, Long Beach, CA 90801-1760, U.S.A.
PIONEER ELECTRONIC NV Haven 1087, Keetberglaan 1, 9120 Melsele, Belgium
PIONEER ELECTRONICS ASIACENTRE PTE. LTD. 253 Alexandra Road, #04-01, Singapore 159936
PIONEER CORPORATION 2000
RRV2365
T – ZZR AUG. 2000 Printed in Japan
CONTENTS
1. CONTRAST OF MISCELLANEOUS PARTS
........
2
2. SCHEMATIC DIAGRAM
.......................................
8
AUDIO/VIDEO MULTI-CHANNEL RECEIVER
VSX-D709S
Model No. Order No. Remarks
VSX-35TX/KUXJI/CA RRV2351
¶ This service manual should be used together with the following manual(s):
THIS MANUAL IS APPLICABLE TO THE FOLLOWING MODEL(S) AND TYPE(S).
RemarksPower RequirementType
Model
VSX-D709S
KUXJI/CA AC120V
VSX-D709S
2
VSX-35TX/KUXJI/CA and VSX-D709S/KUXJI/CA are constructed the same except for the following:
PCB ASSEMBLIES
NSP MAIN ASSY AWK7591 AWK7615
P5- 5 MAIN CONTROL ASSY AWX7560 AWX7618
P5-17 DSP ASSY AWX7561 AWX7611
NSP COMPLEX ASSY AWK7592 AWK7613
P5- 2 EX I/O(5.1CH I/O) ASSY AWX7568 AWX7613
P5- 6 A-CONNECTION ASSY AWX7566 AWX7619
P5- 9 V-CONNECTION ASSY AWX7567 AWX7717
P5-13 TRANS2- 2 ASSY AWX7565 AWX7720
NSP POWER ASSY AWK7593 AWK7598
P5- 4 INPUT ASSY AWX7573 AWX7585
P5-10 SP/PS ASSY AWX7571 AWX7721
NSP FRONT ASSY AWK7594 AWK7617
P5- 7 COMPOSITE ASSY AWX7581 AWX7617
P5- 8 S VIDEO ASSY AWX7580 AWX7616
P7- 1 DISPLAY ASSY AWX7574 AWX7620
P7- 6 FRONT DIGIN ASSY AWX7648 Not used
PACKING SECTION
P3- 3 Operating Instructions(English) ARB7222 ARB7224
P3- 4 Remote Control Unit AXD7266 AXD7268
P3- 8 Packing Case AHD7860 AHD7867
P3-11 NSP Warranty Card ARY7007 ARY7045
EXTERIOR SECTION
P5-31 Rear Panel ANC7910 ANC7941
P5-41 Teminal Screw AKE-031 Not used
FRONT PANEL SECTION
P7- 9 4P Flexible Cable/60V ADD7238 Not used
P7-12 5P Shield with Housing ADX7344 Not used
P7-14 Door AMB7692 AMB7697
P7-19 Digital Cap 35 AAD7576 Not used
P7-21 Window AAK7769 AAK7733
P7-22 Door Sheet AAK7783 AAK7780
P7-25 Front Panel AMB7691 AMB7715
1. CONTRAST OF MISCELLANEOUS PARTS
Parts marked by "NSP" are generally unavailable because they are not in our Master Spare Parts List.
The mark found on some component parts indicates the importance of the safety factor of the part.
Therefore, when replacing, be sure to use parts of identical designation.
Screws adjacent to mark on product are used for disassembly.
Reference Nos. indicate the pages and Nos. in the service manual for the base model.
NOTES:
When ordering resistors, first convert resistance values into code form as shown in the following examples.
Ex.1 When there are 2 effective digits (any digit apart from 0), such as 560 ohm and 47k ohm (tolerance is shown by J=5%,
and K=10%).
Ex.2 When there are 3 effective digits (such as in high precision metal film resistors).
561
473
R50
1R0
5621
560
47k
0.5
1
RD1/4PU J
RD1/4PU J
RN2H K
RS1P K
56 x 10
1
47 x 10
3
R50
1R0
561
473
5.62k RN1/4PC F562 x 10
1
5621
CONTRAST T ABLE
Notes : ÷ For PCB ASSEMBLIES, Refer to “CONTRAST OF PCB ASSEMBLIES”and “2. SCHEMATIC DIAGRAM”.
Ref.
No.
Remarks
VSX-35TX VSX-D709S
/KUXJI/CA /KUXJI/CA
Part No.
Mark Symbol and Description
VSX-D709S
3
CONTRAST OF PCB ASSEMBLIES
AWX7613 and AWX7568 are constructed the same except for the following :
EXI I/O (5.1CH I/O) ASSY
F
B
Mark Symbol and Description
Part No.
Remarks
AWX7568 AWX7613
IC1101- IC1103 UPC4570G2 NJM4558MD
IC1104 UPC4570G2 Not used
Q1157, Q1158 HN1C03F Not used
C1115, C1116 CEAT4R7M50 Not used
C1131, C1132 CEAT100M50 Not used
C1139, C1140 CKSQYB103K50 Not used
R1107, R1108 RS1/10S331J Not used
R1115, R1116 RS1/10S104J Not used
R1125, R1126 RS1/10S474J Not used
R1157, R1158 RS1/10S271J Not used
R1165, R1166 RS1/10S121J Not used
R1173, R1174 RS1/10S101J Not used
R1181, R1182, R1189, R1190 RS1/10S103J Not used
JA1113, JA1163 AKB7046 Not used
AWX7717 and AWX7567 are constructed the same except for the following :
V-CONNECTION ASSY
F
H
Mark Symbol and Description
Part No.
Remarks
AWX7567 AWX7717
Q601 KRC103M Not used
C601 CKSQYB103K50 Not used
CN604 KM200TA10 Not used
R601 RS1/10S103J Not used
AWX7585 and AWX7573 are constructed the same except for the following :
INPUT ASSY
F
C
Mark Symbol and Description
Part No.
Remarks
AWX7573 AWX7585
Q1001, Q1002 2SC7878 Not used
D1051 1SS133 Not used
C1051 CGCYX103M16 Not used
R1013– R1016, R1051 RD1/4PU102J Not used
R1017, R1018 RD1/4PU473J Not used
CN1002 KP200TA6L Not used
JA1004 AKB7046 Not used
JA1051 AKN7014 Not used
VSX-D709S
4
AWX7720 and AWX7565 are constructed the same except for the following :
TRANS 2-2 ASSY
F
O
Mark Symbol and Description
Part No.
Remarks
AWX7565 AWX7720
C5501, C5502 CQMA224J50 Not used
R5501 RD1/4MUF100J Not used
AWX7619 and AWX7566 are constructed the same except for the following :
A-CONNECTION ASSY
F
E
Mark Symbol and Description
Part No.
Remarks
AWX7566 AWX7619
IC1501 TC9215AF Not used
IC1502 TC9459F Not used
IC1503 NJM4558MD Not used
IC1551 M62429FP Not used
D1551 UDZS5.1B Not used
C1501– C1504, C1517, C1518 CKSQYB103K50 Not used
C1507, C1508, C1515, C1516, C1551 CEAT100M50 Not used
C1552, C1553 CEAT100M50 Not used
C1511, C1512 CCSQCH560J50 Not used
C1541– C1543, C1554, C1555 CCSQCH101J50 Not used
C1556, C1557 CEAT1R0M50 Not used
R1503, R1504, R1511, R1512 RS1/10S104J Not used
R1505, R1506, R1554, R1555 RS1/10S103J Not used
R1507, R1508 RS1/10S472J Not used
R1509, R1510 RS1/10S152J Not used
R1541– R1545, R1552, R1553 RS1/10S102J Not used
R1551 RS3LMF391J Not used
R1569– R1574 RS1/10S0R0J Not used
CN1552 AKP7068 Not used
CN1554 KM200TA6 Not used
AWX7721 and AWX7571 are constructed the same except for the following :
SP/PS ASSY
F
L
Mark Symbol and Description
Part No.
Remarks
AWX7571 AWX7721
C3001, C3002 (22000µF/56V) ACH7147 ACH7145
L3111, L3112 ATX1012 Not used
VSX-D709S
5
AWX7618 and AWX7560 are constructed the same except for the following :
MAIN CONTROL ASSY
F
D
Mark Symbol and Description
Part No.
Remarks
AWX7560 AWX7618
IC101 M5220FP Not used
IC103 TC9164AF Not used
IC104 NJM4558MD Not used
Q905 DTA124EK Not used
C113, C114 CEAT100M50 Not used
C115, C116 CCSQCH181J50 Not used
C117, C118 CEAT470M25 Not used
C121, C122 CQMA822J50 Not used
C123, C124 CQMA242J50 Not used
C125, C126 CEAT2R2M50 Not used
C127, C128 CEJQ101M25 Not used
C133, C134, C911 CKSRYB103K50 Not used
C135, C136 CEAT1R0M50 Not used
C191, C192, C153 CCSRCH101J50 Not used
R111, R112 RD1/10S0R0J Not used
R113, R114, R117, R118, R129, R130 RS1/10S104J Not used
R139, R140, R203, R204 RS1/10S104J Not uesd
R115, R116 RS1/10S331J Not used
R119, R120 RS1/10S511J Not used
R121, R122 RS1/10S394J Not used
R123, R124 RS1/10S303J Not used
R125, R126 RS1/10S471 Not used
R131, R132 RS1/16S474J Not used
R133, R134 RS1/16S471J Not used
R135, R136 RS1/106S102J Not used
R921, R923 Not used RS1/16S103J
R924 RS1/16S103J Not used
R933 RS1/16S473J Not used
R934– R946, R990, R991 RS1/16S102J Not used
CN103 AKP7057 Not used
CN906 52045-0445 Not used
JA151 VKB1060 Not used
AWX7616 and AWX7580 are constructed the same except for the following :
S VIDEO ASSY
F
G
Mark Symbol and Description
Part No.
Remarks
AWX7580 AWX7616
IC852 BU4053BCF Not used
C854 CCSQCH151J50 Not used
C855, C856 CKSQYB103K50 Not used
R855 RS1/10S103J Not used
R868– R869 RS1/10S102J Not used
R883 Not used RS1/10S0R0J
R884 RS1/10S0R0J Not used
R885 Not used RS1/10S0R0J
VSX-D709S
6
AWX7620 and AWX7574 are constructed the same except for the following :
DISPLAY ASSY
F
S
Mark Symbol and Description
Part No.
Remarks
AWX7574 AWX7620
IC7051 TC7W53FU Not used
Q7053 FMA1A Not used
Q7054 DTC124EK Not used
D7054– D7057 1SS355 Not used
C7053 CKSQYB153K50 Not used
R7056 RS1/10S223J Not used
R7057 RS1/10S392J Not used
R7058, R7061 RS1/10S103J Not used
CN7007 52045-0445 Not used
S7003 ASG7013 Not used
AWX7617 and AWX7581 are constructed the same except for the following :
COMPOSITE ASSY
F
F
Mark Symbol and Description
Part No.
Remarks
AWX7581 AWX7617
IC731 NJM2279M Not used
IC751 TC4W53FU Not used
Q701 2SA933S Not used
D731 DAN202K Not used
C707 CCSQCH181J50 Not used
C712 CEAT101M10 Not used
C713 CEAT101M16 Not used
C714, C732, C733, C736, C785, C786 CKSQYB473K50 Not used
C715 CCSQCH150J50 Not used
C734, C735 CEAT101M10 Not used
C737 CCSQCH470J50 Not used
R707 RS1/10S750J Not used
R712 RS1/10S183J Not used
R713 RS1/10S103J Not used
R714 RS1/10S101J Not used
R715 RD1/2VM201J Not used
R733– R735, R766 RS1/10S102J Not used
R767 RS1/10S104J Not used
703 AKB7017 Not used
JA703 Not used VKB1048
VSX-D709S
7
AWX7611 and AWX7561 are constructed the same except for the following :
DSP ASSY
F
Y
Mark Symbol and Description
Part No.
Remarks
AWX7561 AWX7611
IC9103 CS4391 Not used
IC9602– IC9604 UPC4570G2 NJM4558MD
IC9701– IC9705 UPC4570G2 NJM4558MD
IC9706, IC9707 UPC4570G2 Not used
Q9611, Q9612 2SC3326 Not used
L9105, L9106 QTL1013 Not used
C9120 CEJA470M16 Not used
C9121, C9124, CKSRYB103K50 Not used
C9122 CCSRCH471J50 Not used
C9123, C9125 CEJA1R0M50 Not used
C9126 CKSRYB104K16 Not used
C9167 CKSQYF104Z50 Not used
C9705, C9706, C9759, C9760 CKSQYF104Z25 Not used
C9745, C9746, C9781, C9782 CKSRYB102K50 Not used
C9749– C9752 CCSRCH221J50 Not used
C9753, C9754 CEJA330M10 Not used
C9755, C9756 CKSRYB122K50 Not used
C9757, C9758 CCSRCH271J50 Not used
C9761, C9762 CEJA4R7M50 Not used
C9763, C9764 CKSRYB222K50 Not used
R9104 RS1/16S101J RS1/16S331J
R9120 RS1/10S681J Not used
R9121 RS1/10S562J Not used
R9122 RS1/10S681J Not used
R9123 RS1/10S182J Not used
R9154 RS1/10S104J RS1/10S0R0J
R9173 RS1/10S0R0J Not used
R9577 RS1/16S331J Not used
R9737– R9742, R9753, R9754, R9763, R9764 RS1/16S153J Not used
R9743– R9746, R9755, R9756 RS1/16S332J Not used
R9747, R9748 RS1/16S122J Not used
R9749, R9750 RS1/16S562J Not used
R9751, R9752 RS1/16S822J Not used
R9757, R9758 RS1/16S474J Not used
R9759, R9760 RS1/16S101J Not used
CN9804 S5B-PH-K-S Not used
JA9156 GP1FA551TZ Not used
VSX-D709S
8
A
B
C
D
1
23
4
1234
2. SCHEMATIC DIAGRAM
2.1 EXTRA I/O(5.1 CH I/O) and MAIN CONTROL ASSYS
F
B
: AUDIO SIGNAL ROUTE
JA1111 : AKB7048
JA1113 : AKB7046
5.1CH I/O ASSY
(VSX-D709 : AWX7613)
CN1503
E
CN1501
E
CN1505
E
PREOUT MUTE
B
F
VSX-D709S
9
A
B
C
D
1
234
1
2
3
4
R921 :
10 kΩ
R923 :
10 kΩ
∗1
∗1
∗1
TU
3/3F
MAIN CONTROL ASSY
(VSX-D709S : AWX7618)
D
3/3F
D
VSX-D709S
10
A
B
C
D
1
23
4
1234
F
G
2.2 S VIDEO and TRANS 2-2 ASSY
VSX-D709S
Not used
Y
C
C
Y
Y
Y
Y
Y
C C
OSD SELECTOR
F
S VIDEO ASSY
(VSX-D709S : AWX7616)
G
TRANS 2-2 ASSY
(VSX-D709S:AWX7720)
POWER TRANSFORMER
(ATS7284)
N
5010
F
TRANS 2-2 ASSY
(VSX-D709S : AWX7720)
O
F
O
VSX-D709S
11
A
B
C
D
1
234
1
2
3
4
F
F
2.3 COMPOSITE ASSY
JA704 : AKB7056
Not used
Not used
Not used
JA702 : AKB7056
JA703
VSX-D709S: VKB1048
VSX-35TX
: AUDIO SIGNAL ROUTE
COMPOSITE ASSY
(VSX-D709S : AWX7617)
CN602
OSD SELECTOR
H
F
F
VSX-D709S
12
A
B
C
D
1
23
4
1234
2/5F
Y
2.4 DSP ASSY (2/5)
R9154
VSX-D709S: 0
Y
4/5
MF
2/5F
DSP ASSY
(VSX-D709S : AWX7611)
Y
VSX-D709S
13
A
B
C
D
1
234
1
2
3
4
2/5F
Y
D/A CONVERTER
for SB ch
*
*
2/5F
DSP ASSY
(VSX-D709S : AWX7611)
Y
R9104
330Ω
ORDER NO.
PIONEER ELECTRONIC CORPORATION 4-1, Meguro 1-chome, Meguro-ku, Tokyo 153-8654, Japan
PIONEER ELECTRONICS SERVICE, INC. P.O. Box 1760, Long Beach, CA 90801-1760, U.S.A.
PIONEER EUROPE N V Haven 1087, Keetberglaan 1, 9120 Melsele, Belgium
PIONEER ELECTRONICS ASIACENTRE PTE. LTD. 253 Alexandra Road, #04-01, Singapore 159936
PIONEER ELECTRONIC CORPORATION 2000
c
VSX-35TX
RRV2351
1. SAFETY INFORMATION
......................................
2
2. EXPLODED VIEWS AND PARTS LIST
...............
3
3. BLOCK DIAGRAM AND SCHEMATIC DIAGRAM
.....
8
4. PCB CONNECTION DIAGRAM
.........................
48
5. PCB PARTS LIST
...............................................
76
6. ADJUSTMENT
....................................................
89
CONTENTS
7. GENERAL INFORMATION
................................
90
7.1 DISASSEMBLY
............................................
90
7.2 PARTS
..........................................................
92
7.2.1 IC
............................................................
92
7.2.2 DISPLAY
.................................................
97
7.3 REMOTE CONTROL UNIT
........................
100
8. PANEL FACILITIES AND SPECIFICATIONS
.....
105
T – ZZR AUG. 2000 Printed in Japan
VSX-33TX
AUDIO/VIDEO MULTI-CHANNEL RECEIVER
Type
Model
Power Requirement
Remarks
VSX-35TX
VSX-33TX
KUXJI/CA
KUXJI/CA
AC120V
AC120V
THIS MANUAL IS APPLICABLE TO THE FOLLOWING MODEL(S) AND TYPE(S).
VSX-35TX
REFERENCE AUDIO/VIDEO MULTI–CHANNEL RECEIVER
2
VSX-35TX, VSX-33TX
1. SAFETY INFORMATION
This service manual is intended for qualified service technicians ; it is not meant for the casual do-it-
yourselfer. Qualified technicians have the necessary test equipment and tools, and have been trained
to properly and safely repair complex products such as those covered by this manual.
Improperly performed repairs can adversely affect the safety and reliability of the product and may
void the warranty. If you are not qualified to perform the repair of this product properly and safely, you
should not risk trying to do so and refer the repair to a qualified service technician.
WARNING
This product contains lead in solder and certain electrical parts contain chemicals which are known to the state of California to cause
cancer, birth defects or other reproductive harm.
Health & Safety Code Section 25249.6 – Proposition 65
NOTICE
(FOR CANADIAN MODEL ONLY)
Fuse symbols (fast operating fuse) and/or (slow operating fuse) on PCB indicate that replacement parts must
be of identical designation.
REMARQUE
(POUR MODÈLE CANADIEN SEULEMENT)
Les symboles de fusible (fusible de type rapide) et/ou (fusible de type lent) sur CCI indiquent que les pièces
de remplacement doivent avoir la même désignation.
ANY MEASUREMENTS NOT WITHIN THE LIMITS
OUTLINED ABOVE ARE INDICATIVE OF A POTENTIAL
SHOCK HAZARD AND MUST BE CORRECTED BEFORE
RETURNING THE APPLIANCE TO THE CUSTOMER.
2. PRODUCT SAFETY NOTICE
Many electrical and mechanical parts in the appliance
have special safety related characteristics. These are
often not evident from visual inspection nor the protection
afforded by them necessarily can be obtained by using
replacement components rated for voltage, wattage, etc.
Replacement parts which have these special safety
characteristics are identified in this Service Manual.
Electrical components having such features are identified
by marking with a
on the schematics and on the parts list
in this Service Manual.
The use of a substitute replacement component which does
not have the same safety characteristics as the PIONEER
recommended replacement one, shown in the parts list in
this Service Manual, may create shock, fire, or other hazards.
Product Safety is continuously under review and new
instructions are issued from time to time. For the latest
information, always consult the current PIONEER Service
Manual. A subscription to, or additional copies of, PIONEER
Service Manual may be obtained at a nominal charge from
PIONEER.
1. SAFETY PRECAUTIONS
The following check should be performed for the
continued protection of the customer and service
technician.
LEAKAGE CURRENT CHECK
Measure leakage current to a known earth ground (water
pipe, conduit, etc.) by connecting a leakage current tester
such as Simpson Model 229-2 or equivalent between the
earth ground and all exposed metal parts of the appliance
(input/output terminals, screwheads, metal overlays, control
shaft, etc.). Plug the AC line cord of the appliance directly
into a 120V AC 60Hz outlet and turn the AC power switch
on. Any current measured must not exceed 0.5mA.
(FOR USA MODEL ONLY)
Leakage
current
tester
Reading should
not be above
0.5mA
Device
under
test
Test all
exposed metal
surfaces
Also test with
plug reversed
(Using AC adapter
plug as required)
Earth
ground
AC Leakage Test
3
VSX-35TX, VSX-33TX
2.1 PACKING
(1) PACKING PARTS LIST
Mark No. Description Part No.
2. EXPLODED VIEWS AND PARTS LIST
NOTES:
•
Parts marked by "NSP" are generally unavailable because they are not in our Master Spare Parts List.
•
The mark found on some component parts indicates the importance of the safety factor of the part.
Therefore, when replacing, be sure to use parts of identical designation.
•
Screws adjacent to mark on the product are used for disassembly.
1 AM Loop Antenna ATB7009
2 FM Wire Antenna ADH7004
3 Operating Instructions See Contrast table (2)
(English)
4 Remote Control Unit See Contrast table (2)
NSP 5 Alkaline Dry Cell Battery VEM1021
(LR6, AA)
6 Front Pad 35 AHA7287
7 Rear Pad 35 AHA7288
8 Packing Case See Contrast table (2)
9 Packing Sheet AHG7010
NSP 10 Polyethylene Bag Z21-038
(230 × 340 × 0.03)
NSP 11 Warranty Card ARY7007
12 Battery Cover See Contrast table (2)
(2) CONTRAST TABLE
VSX-35TX and VSX-33TX are constructed the same except for the following :
Mark No. Symbol and Description
Part No.
Remarks
VSX-35TX VSX-33TX
3
4
4
8
8
12
Operating Instructions (English)
Remote Control Unit (35TX)
Remote Control Unit (33TX)
Packing Case 35TX
Packing Case 33TX
Battery Cover
ARB7222
AXD7266
Not used
AHD7860
Not used
AZN7841
ARB7223
Not used
AXD7267
Not used
AHD7861
AZN7826
1
2
3,11
10
12
9
5
4
6
7
8
FRONT
4
VSX-35TX, VSX-33TX
2.2 EXTERIOR SECTION
C
B
F
E
B
P
N
O
Q
R
S
J
H
I
K
L
R
T
P
Q
V
B
T
U
F
S
V
U
O
E
M
C
D
L
A
K
D
G
A
I
H
N
G
J
33
51
51
28
48
22
17
PCB Holder
22
48
48
12
36
47
47
47
47
47
47
47
31
37
47
40
47
45
47
47
47
47
47
35
34
44
47
47
47
47
47
49
47
47
47
29
25
47
45
47
46
45
47
38
15
21
Refer to
"2.3 HEAT SINK SECTION".
47
23
4
6
11
19
14
13
50
50
18
20
5
2 or 3
51
47
Refer to
"2.4 FRONT PANEL SECTION".
B
C
E
N
A
F
G
R
L
Q
H
Y
M
P
O
D
47
47
47
47
47
47
9
24
47
47
48
10
43
30
42
22
7
52
41
47
1
26
49
27
(VSX-35TX
Only)
(VSX-35TX
Only)
(VSX-35TX
Only)
8
16
43
43
39
47
32
47
47
Screw Cover
Screw Cover
47
51
5
VSX-35TX, VSX-33TX
1 FM/AM TUNER Module AXQ7231
2 EX I/O Assy See Contrast table (2)
3 5.1CH I/O Assy See Contrast table (2)
4 INPUT Assy See Contrast table (2)
5 MAIN CONTROL Assy See Contrast table (2)
6 A-CONNECTION Assy See Contrast table (2)
7 COMPOSITE Assy See Contrast table (2)
8 S VIDEO Assy See Contrast table (2)
9 V-CONNECTION Assy See Contrast table (2)
10 SP/PS Assy See Contrast table (2)
11 TRANS 2-1 Assy AWX7572
12 REGULATOR Assy AWX7562
13 TRANS 2-2 Assy See Contrast table (2)
NSP 14 TRANS 1 Assy AWX7564
15 PRIMARY Assy AWX7563
16 COMPONENT Assy See Contrast table (2)
17 DSP Assy See Contrast table (2)
18 Power Transformer (T1) ATS7284
19 Fuse (FU4 : 2.5A) REK1112
20 Fuse (FU5 : 2.5A) REK1112
21 Fuse (FU1 : 10A) VEK1029
22 20P Flexible Cable/60V ADD7241
23 22P Flexible Cable/60V ADD7243
24 14P Flexible Cable/60V ADD7244
25 SE Angle 35 ANG7335
(1) EXTERIOR PARTS LIST
Mark No. Description Part No. Mark No. Description Part No.
26 Cord Stopper CM-22C
27 Power Cord VDG1075
28 Spacer 35 (3 × 10 × 40) AEB7210
29 Cushion 8 × 8 AED7046
NSP 30 Under Base ANA7113
31 Rear Panel See Contrast table (2)
NSP 32 Panel Stay 35 AND7035
33 Bonnet 35 AZN7835
34 Trans Frame 35 ANG7292
35 Trans Shield 35 ANG7293
36 DSP Shield 35 A ANG7295
37 DSP Shield 35 B ANG7296
38 Primary Angle 35 ANG7301
39 Insulator PNW2766
40 Fiber Washer VEC1254
41 Earth Terminal See Contrast table (2)
42 PCB Mold AMR2534
43 Card Spacer DNK2769
44 Locking Card Spacer PNW2917
45 Cord Clamper RNH-184
46 65 Label ARW7050
47 Screw BBZ30P080FZK
48 Screw IBZ30P150FCC
49 Screw IBZ30P100FCC
50 Screw ABA7066
51 Screw FBT40P080FZK
52 13P Flexible Cable/60V ADD7242
(2) CONTRAST TABLE
VSX-35TX and VSX-33TX are constructed the same except for the following :
Mark No. Symbol and Description
Part No.
Remarks
VSX-35TX VSX-33TX
2
3
4
5
6
7
8
9
10
13
16
17
31
31
41
EX I/O Assy
5.1CH I/O Assy
INPUT Assy
MAIN CONTROL Assy
A-CONNECTION Assy
COMPOSITE Assy
S VIDEO Assy
V-CONNECTION Assy
SP/PS Assy
TRANS 2-2 Assy
COMPONENT Assy
DSP Assy
Rear Panel 35
Rear Panel 33
Earth Terminal
AWX7568
Not used
AWX7573
AWX7560
AWX7566
AWX7581
AWX7580
AWX7567
AWX7571
AWX7565
AWX7582
AWX7561
ANC7910
Not used
AKE-031
Not used
AWX7613
AWX7585
AWX7610
AWX7619
AWX7617
AWX7616
AWX7717
AWX7721
AWX7720
Not used
AWX7611
Not used
ANC7911
Not used
6
VSX-35TX, VSX-33TX
29
35
35
35
34
28
15
14
30
35
35
35
37
37
12
37
35
26
38
39
18
19
17
20
35
23
2
4
6
3
5
16
13
35
36
11
9
7
8
10
VSX-35TX
Only
VSX-35TX
Only
VSX-35TX
Only
T
S
W
U
X
V
35
1
34
24
21
22
25
31
40
27
33
33
41
32
1 FRONT AMP Assy AWX7569
2 REAR AMP Assy AWX7570
3 V-AMP Assy AWX7578
4 13P Flexible Cable/60V ADD7242
5 Mica Sheet 35 AEE7035
6 H.S Angle 35 F ANG7297
7 H.S Angle 35 R ANG7298
8 PCB Angle 35 ANG7299
9 FET Angle 35 ANG7300
NSP 10 Heat Sink 35 ANH7126
11 Screw BBZ30P080FZK
12 Screw IBZ30P150FCC
•
HEAT SINK SECTION PARTS LIST
Mark No. Description Part No.
2.3 HEAT SINK SECTION
2.4 FRONT PANEL SECTION
D
G
I
H
N
G
J
7
11
5
11
11
11
11
11
11
11
11
11
12
12
2
4
8
8
9
9
6
10
3
1
I
J
K
7
VSX-35TX, VSX-33TX
1 DISPLAY Assy See Contrast table (2)
2 VOLUME-CONT Assy AWX7577
3 HEADPHONE Assy AWX7602
4 FRONT AV Assy AWX7579
5 STAND BY Assy AWX7576
6 FRONT DIGIN Assy See Contrast table (2)
7 7P Flexible Cable/60V ADD7236
8 5P Flexible Cable/60V ADD7237
9 4P Flexible Cable/60V See Contrast table (2)
10 32P Flexible Cable/60V ADD7239
11 8P Flexible Cable/60V ADD7240
12 5P Shield Wire with Housing See Contrast table (2)
13 Door Stay 35 AAH7063
14 Door 35 AMB7692
15 Door Hinge 35 L AMR7291
16 Door Hinge 35 R AMR7293
17 Volume Knob 26 AAB7193
18 Rotary Knob 35 AAB7226
19 Digital Cap 35 See Contrast table (2)
20 Volume Ring 26 AAK7623
(1) FRONT PANEL SECTION PARTS LIST
Mark No. Description Part No. Mark No. Description Part No.
21 Window See Contrast table (2)
22 Door Sheet See Contrast table (2)
NSP 23 Earth Spring 35 ABH7193
24 Cushion Circle 6B AED7044
25 Front Panel See Contrast table (2)
26 Panel Base 35 AMB7695
27 Magnet 35 AMF7007
28 Door Shaft 35 AMR7295
29 SE Angle 35 ANG7334
30 Damper Assy (100) AXA7089
31 Pioneer Badge PAM1776
32 LED Lens PNW2019
33 Screw BBZ26P060FZK
34 Screw BPZ26P080FMC
35 Screw BPZ30P080FMC
36 Cord Clamper RNH-184
37 Screw ABA7009
38 Nut MK70FUC
39 Nut MK90FUC
40 Screw BBZ30P080FZK
41 Earth Lead Wire ADH7022
(2) CONTRAST TABLE
VSX-35TX and VSX-33TX are constructed the same except for the following :
Mark No. Symbol and Description
Part No.
Remarks
VSX-35TX VSX-33TX
1
6
9
12
19
21
21
22
22
25
25
DISPLAY Assy
FRONT DIGIN Assy
4P Flexible Cable/60V
5P Shield Wire with Housing
Digital Cap 35
Window 35R
Window 33R
Door Sheet 35
Door Sheet 33
Front Panel 35
Front Panel 33
AWX7574
AWX7648
ADD7238
ADX7344
AAD7576
AAK7769
Not used
AAK7783
Not used
AMB7691
Not used
AWX7614
Not used
Not used
Not used
Not used
Not used
AAK7733
Not used
AAK7775
Not used
AMB7714
VSX-35TX, VSX-33TX
8
A
B
C
D
1
23
4
1234
DGITAL I / O
FRONT DIGITAL INPUT
FRONT IN
AC3-RF
OPT OUT1
OPT OUT2
AK4527:1/2
AXQ7231
UNIT
CN291
CN1001
IC101
IC102 IC103
TC9164
IC103
REC MUTE
Tape2 OFF
Source
RecSel
Tape2 IN
IC9151
IC9201
IC9202
NJM2100M
IC9101
IC9071
IC9102
AK4112
IC9501
FL, FR, SL,SR
MIXAMP &
GAIN SW
AK4527: 2/2
IC9601
TC9164AF
CN104
CN9801
8
D
Y
C
E
A
1
3
4
6
5
CN7201
R
3
CN102
2
5
15 3 1
7
1
59
16
26
30
27
CN1001
Q113
IC109
C
E
2
1
2
1
75
19
X
CN7601
5
CN1101
VSX-33TX
VSX-35TX Only
VSX-35TX :Only
B
CN9806,5
16
14
12
10
CN702
2
3
13
1
2
3
5
12
7, 8
SBL/SBR
VSX-35TX
Only
IC1101
IC1103
IC1102
IC1104
9, 7
5, 6
3, 4
1, 2
CN9804
2
F
IC701
IC751
IC701
IC701
IC731
3
7
5
9
13
11
15
1
13
12
14
1315
15
1
2
1312
10
B
R
DSP
u - COM
CS49329
AK7706
CONTROL
IC9551
VSX-35TX:Only
VSX-35TX:Only
VSX-35TX:Only
IC503,IC502 :TK15420MIC501:TC74HC4053
COMPONENT OUT
COMPONENT IN
8
6
3. BLOCK DIAGRAM AND SCHEMATIC DIAGRAM
3.1 BLOCK DIAGRAM
VSX-35TX, VSX-33TX
9
A
B
C
D
5
678
5
6
7
8
U+5.6V
AD+5V
A+15V
DSP
+5V
A-15V
T1
POWER
TRANSFORMER
T6001
AC IN
D3301–D3304
VH+
VH-
Q3301
Q3302
D5005
D5001–D5004
V+5.6V
V-5.6V
IC5005
D5009
D3001,D3002
IC5008
ST
+5V
D6001
RY6001
IC6001
IC5006
IC5001
IC5002
IC5007
IC5004
A-15V
A+15V
V+5.6V
V-5.6V
S6001
Q
M
N
N
CN5003
SBL/SBRch
D
I
J
L
U
K
G
CN905,
CN908
IC107
IC108
Q271
IC114
IC112
IC113
IC115
Q109
Q110
Q111
Q112
Q107
Q108
IC109
IC1501
EXT
SBL / SBR
SBL / SBR
IC109
IC7501, IC7502
IC7541, IC7542
IC7601, IC7602
IC109
IC105
6, 8
25,4
31
7, 10
19,22
25
26
27
7, 11
6, 10
18
19
3,
26
6, 9
20,
23
4,6
6, 4
5,3
1,7
8, 2
2,8
IC1502:TC9459
IC1503
IC1501: TC9215AF
21,
23
4,6
2,8
17
9
11
10
9, 12
24
14, 16
10, 12
CN2001
Q2008
RY3105
RY3101
RY3103
RY3104
RY3102
Q2501
Q2524
Q2541
Q2544
Q2601
Q2504
Q550
Q610
9
7
13
CN2002
14, 16
9, 11
11, 13
CN2001
CN2601CN2101
9, 11
14, 16 J30 : 1,3
3, 5
CN109
14
8
31
31
31
16
SBL/SBR
VSX-35TX
Only
SBL/SBR
VSX-35TX
Only
CN107
9, 10
2, 8
3, 4
CN804
IC851
IC852
IC852
IC852
IC801
IC801
IC802
2
13
12
14
2
1
15
5
3
4
1
1
7
5
9
13
5
9
13
15
14
12
2
3
13
3
11
15
11
15
3
7
3
J30 : 2
J33 :1,2
7003
J7301
JA7201
39
OTHERS
+3.5 ~ +8.5dB
(Normally :
+8.5dB)
+3.5 ~ +8.5dB
(Normally :
+8.5dB)
+3.5 ~ +8.5dB
(Normally :
+8.5dB)
CN501
46
Y3Y2
5498
VSX-35TX, VSX-33TX
10
A
B
C
D
1
23
4
1234
T
VOLUME-CONT
ASSY
(AWX7577)
DISPLAY ASSY
(VSX-35TX : AWX7574)
(VSX-33TX : AWX7614)
S
V-AMP ASSY
( AWX7578 )
I
1/5- 5/5
DSP ASSY
(VSX-35TX : AWX7561)
(VSX-33TX : AWX7611)
Y
Y Y
FM/AM TUNER
UNIT
(AXQ7231)
1/3- 3/3
MAIN CONTROL ASSY
(VSX-35TX : AWX7560)
(VSX-33TX : AWX7610)
D
D D
REGULATOR ASSY
(AWX7562)
N
A-CONNECTION ASSY
(VSX-35TX:AWX7566)
(VSX-33TX:AWX7619)
E
EX I/O ASSY (For VSX-35TX)
(AWX7568)
5.1CH I/O ASSY (For VSX-33TX)
(AWX7613)
B
A
INPUT ASSY
(VSX-35TX : AWX7573)
(VSX-33TX : AWX7585)
C
X
U
FRONT DIGIN
ASSY
(AWX7648)
HEADPHONE
ASSY
(AWX7602)
W
STAND BY
ASSY
(AW7576)
VSX-35TX
ONLY
VSX-35TX
ONLY
VSX-35TX
ONLY
VSX-35TX
ONLY
CN201
3.2 OVERALL WIRING DIAGRAM
VSX-35TX, VSX-33TX
11
A
B
C
D
5
678
5
6
7
8
T1
POWER TRANSFORMER
(ATS7284)
FRONT AV ASSY
( AWX7579 )
V
COMPOSITE ASSY
(VSX-35TX : AWX7581)
(VSX-33TX : AWX7617)
F
S VIDEO ASSY
(VSX-35TX : AWX7580)
(VSX-33TX : AWX7616)
G
V-CONNECTION ASSY
(VSX-35TX : AWX7567)
(VSX-33TX : AWX7717)
H
SP/PS ASSY
(VSX-35TX : AWX7571)
(VSX-33TX : AWX7721)
L
PRIMARY ASSY
(AWX7563)
POWER CORD
: VDG1075
AC120V
60Hz
Q
FRONT AMP
ASSY
(AWX7569)
J
REAR AMP
ASSY
(AWX7570)
K
TRANS 2-1 ASSY
(AWX7572)
M
TRANS 2-2 ASSY
(VSX-35TX : AWX7565)
(VSX-33TX : AWX7720)
O
TRANS 1 ASSY
(AWX7564)
P
COMPONENT
ASSY
(AWX7582)
VSX-35TX
ONLY
R
Note : When ordering service parts, be sure to refer to "EXPLODED VIEWS and PARTS LIST" or "PCB P ARTS LIST".
VSX-35TX, VSX-33TX
12
A
B
C
D
1
23
4
1234
FM FRONT END
MW RF TUNING BLOCK
FM/AM TUNER UNIT (AXQ7231)
A
OSC : 980 - 2150kHz
10k step
(AM)
(AM)
(AM)
(AM) (AM)
(AM)
(FM)
(FM) (FM)
(FM)
(FM)
(FM)
(FM) (FM)
(FM)
(FM)
3.3 FM/AM TUNER UNIT
A
VSX-35TX, VSX-33TX
13
A
B
C
D
5
678
5
6
7
8
3/3
D
CN291
L201
ATE7003
PLL IC
AM/FM IF+MPX IC
ATF7026
: AUDIO SIGNAL ROUTE (TUNER)
(TX)
: AM SIGNAL ROUTE
(AM)
: FM SIGNAL ROUTE
(FM)
(AM)
(AM)
(FM)
(AM)
(AM)
(AM)
(AM)
(AM)
(AM)
(FM)
(AM)
(FM)
(TX)
(TX)
(TX)
(TX)
(TX)
(FM)
: The power supply is shown with the marked box.
A
VSX-35TX, VSX-33TX
14
A
B
C
D
1
23
4
1234
VSX-35TX
VSX-33TX
EX I/O ASSY (For VSX-35TX)
(AWX7568)
5.1CH I/O ASSY (For VSX-33TX)
(AWX7613)
B
JA1111 : AKB7048
JA1113 : AKB7046
CN1505
E
CN1501
E
CN1503
E
PREOUT MUTE
VSX-35TX ONLY
VSX-35TX ONLY
: AUDIO SIGNAL ROUTE
B
3.4 EX I/O (5.1CH I/O) ASSY
VSX-35TX, VSX-33TX
15
A
B
C
D
1
234
1
2
3
4
JA1004 : AKB7046
JA1003 : AKB7048
JA1003 : AKB7048
JA1003 : AKB7048
INPUT ASSY
(VSX-35TX : AWX7573)
(VSX-33TX : AWX7585)
VSX-35TX ONLY
CN1553
E
CN1554
E
C
: AUDIO SIGNAL ROUTE (VCR1)
V1
V1 V1
V1 V1
V2
V2
V2
V2
: AUDIO SIGNAL ROUTE (VCR2)
V2
: AUDIO SIGNAL ROUTE (MR)
MR
MR
MR
MR
MR
: AUDIO SIGNAL ROUTE
: AUDIO SIGNAL ROUTE (LD)
LD
: AUDIO SIGNAL ROUTE (TV)
TV
LD
LD
LD
LD
TV
TV
TV
MR MUTE
3.5 INPUT ASSY
C
VSX-35TX, VSX-33TX
16
A
B
C
D
1
23
4
1234
PHONO RIAA-EQ
: The power supply is
shown with the marked box.
D
2/3
CN7005
S
CN1551
E
D
2/3
VSX-35TX ONLY
P
P
LD
CD
T2
TU
V2
P
CD
CD
CD
T2
MD
TUTU
MD
TU
T2
TU
T2
P
V1
MD
TV
LD
TV
V2
V1
1/3
D
3.6 MAIN CONTROL ASSY (1/3)
VSX-35TX, VSX-33TX
17
A
B
C
D
5
678
5
6
7
8
BUFFER FOR MR
1/3
MAIN CONTROL ASSY
(VSX-35TX : AWX7560)
(VSX-33TX : AWX7610)
D
CN5004
N
CN1552
E
D
2/3
D
2/3
D
2/3
VSX-35TX ONLY
D302
D301
RB501V-40
RB501V-40
: AUDIO SIGNAL ROUTE (LD)
LD
: AUDIO SIGNAL ROUTE
: AUDIO SIGNAL ROUTE (TV)
TV
: AUDIO SIGNAL ROUTE (VCR1)
V1
: AUDIO SIGNAL ROUTE (VCR2)
V2
: AUDIO SIGNAL ROUTE (MD)
MD
: AUDIO SIGNAL ROUTE (PHONO)
P
: AUDIO SIGNAL ROUTE (TUNER)
TU
: AUDIO SIGNAL ROUTE (CD)
CD
: AUDIO SIGNAL ROUTE (TAPE2)
T2
: AUDIO SIGNAL ROUTE (MR)
MR
MR
MR
MR
MR
MR
MR
1/3
D
Loading...