Oster 7716 Installation Manual

User Manual

2.5 L Cool Zone Deep Fryer

Manual de Instrucctiones

MODEL/MODELO

Freidora de 2.5 L. Zona Fría

7716

Visit us at www.oster.com

P.N. 124465

IMPORTANT SAFEGUARDS

When using electrical appliances, basic safety precautions should always be followed,

including the following:

READ AND SAVE THESE INSTRUCTIONS

• Read all instructions before using.

• Do not touch hot surfaces. Use handles or knobs.

• To protect against risk of fire, electric shock, and personal injury do not
immerse control panel assembly, cord or plugs in water or other liquids.

• Close supervision is necessary when Deep Fryer is used near children.
Children should not use this appliance.

• Unplug from outlet when not in use, before putting on or taking off parts
and before cleaning. Allow to cool before putting on or taking off parts,
and before cleaning appliance.

• Do not operate any appliance with a damaged cord or plug, or after the
appliance malfunctions or has been dropped or damaged in any manner.
Contact Customer Service (see warranty) to return for examination,
repair, or electrical or mechanical adjustment.

®

• The use of accessory attachments not recommended by Oster
result in injury.

may

• Do not use outdoors.

• Do not let cord hang over edge of table or countertop, or touch hot
surfaces including the stove.

• Do not place on or near a hot gas or electric burner, or in a heated oven.

• Extreme caution must be used when moving fryer containing hot oil.
Always use oven mitts or hot pads.

• Always attach plug to appliance first, then plug AC cord into the wall outlet.
To disconnect, turn control to OFF, then remove AC cord from walloutlet.

• Do not use appliance for other than intended use.

• Periodically check the handle for looseness. If loose, retighten the screws
using a Philips screwdriver. CAUTION: Over tightening can result in strip­ping of screws or cracking of handle.

T

HIS

This Deep fryer is equipped with an exclusive SureRELEASE™Power Cord
System, which includes a detachable magnetic cord designed to separate from
the unit when certain amounts of force are applied. (See details on pg.4 for
instructions on proper usage of the SureRELEASE
A short power supply cord is provided to reduce the risk resulting from
becoming entangled in or tripping over a longer cord.

WARNING: Do not use an extension cord.
No user-serviceable parts inside. Do not attempt to service this product.

POLARIZED PLUG

U

NITIS

F

OR

This appliance has a polarized plug, (one blade is wider
than the other). As a safety feature to reduce the risk of
electrical shock, this plug is intended to fit in a polarized
outlet only one way. If the plug does not fit fully in the
outlet, reverse the plug. If it still does not fit, contact a
qualified electrician. Do not attempt to defeat this safety
feature or modify the plug in any way. If the plug fits
loosely into the AC outlet or if the AC outlet feels warm
do not use that outlet.

H

OUSEHOLD

U

™

magnetic cord.)

SE

O

NLY

SAVE THESE INSTRUCTIONS

WELCOME

Congratulations on your purchase of an OSTER®Deep Fryer!

To learn more about OSTER

BEFORE USING YOUR OSTER®COOL ZONE DEEP FRYER

Before using your OSTER®Deep Fryer for the first time, remove all packaging
materials from the exterior and interior of the fryer. Make sure the fryer is unplugged.
Clean the frying basket, lid, oil reservoir, housing and condensation trap (all these parts
are dishwasher safe). Gently wipe the Cool-Zone Heating Element with a damp cloth.
Dry all parts thoroughly. See

CARE AND CLEANING

DO NOT IMMERSE THE CORD, POWER STRIP

OR CONTROL PANEL ASSEMBLY

IN WATER OR ANY OTHER LIQUID!

®

products, please visit us at www.oster.com.

.

PARTS IDENTIFICATION

Before using your Deep Fryer for the first time, you should become familiar with all of the parts.
Read all Instructions and Safeguards carefully.

1

2

3

4

20

19

18

17

16

15

14

13

12

1. Filter Cover

2. View Window

3. Charcoal Odor Filter

4. White Grease Filter

5. Lid

6. Condensation Cup

TM

7. SureRelease
Cordset

Break Away

10

11

9

8. Removable Power Strip

9. Main Housing

10. Immersion Heating Element

11. Lid Release Button

12. Timer Knob

13. Temperature Knob

14. Power Indicator Light

8

5

6

7

15. Ready Indicator Light

16. Removable Oil Reservoir

17. Oil Pour Spout

18. Folding Handle

19. Handle Release Button

20. Frying Basket

USING YOUR OSTER®DEEP FRYER

NOTE: Never turn on the fryer with an empty Oil Reservoir. Always use your fryer on
a flat, heat resistant surface.

• Attach magnetic end of SureRELEASE™ cord assembly directly to the fryer.

This should be done prior to plugging the cord into the wall outlet. The magnetic
end of the cord is designed only to go on one way. Be sure the side stating
“THIS SIDE UP” is facing up.

• Open Lid by pressing the Open Lid Button.

• Remove Frying Basket by pulling the Basket Handle up until it locks into the
horizontal position.

• Pour cooking oil into Oil Reservoir until it reaches between “MIN” and “MAX”
marks inside reservoir. DO NOT OVER OR UNDER FILL. Place Frying Basket
back into Fryer.

• Close Lid.

• Press the Handle Release Button to lower basket into oil.

• Make sure that the fryer is OFF and insert plug into 120 volt AC outlet.

• Turn the fryer to desired temperature position.

• Turn timer knob to STAY ON position. The power light will come on.

• Ready light will turn on when oil is pre-heated. Press the Open Lid button and
place Frying Basket into upper position, by lifting handle up until it clicks into
the horizontal position.

• Place food inside Frying Basket (Do not over stack food). Close Lid. Lower Frying
Basket into Oil Reservoir, by sliding down the handle release button.
CAUTION: Always replace and close Lid before immersing food in oil. Do not
immerse or drain food with Lid removed or open.

• Turn Timer Knob to desired time.
IMPORTANT: When setting the timer for less than 5 minutes, turn the timer past
the 5 minute mark and then rotate back to the desired time setting. This will ensure
that the timer operates correctly and safely.

• After time is up, a bell will sound. Lift Frying Basket out of Oil Reservoir, by sliding
down the handle release button. To remove excess grease and retain crispness, let
food drain in Frying Basket at least 10-20 seconds. Open Lid, then lift Frying Basket
by handle and pour contents onto plate covered with paper towels before serving.

• When finished cooking, make sure fryer is in the OFF position.

™

WARNING: DO NOT USE SureRELEASE

POWER CORD SYSTEM TO
DISCONNECT THE FRYER. ALWAYS DISCONNECT PLUG FROM WALL
OUTLET FIRST TO DISCONNECT FRYER.

Use only Model #PL1215 magnetic cord set with this product. The use of any other
magnetic cord set may cause fire, electric shock, or injury.
CAUTION: The SureRELEASE

™

Power Cord is only for accidental disconnection
and is not to be removed during normal operation. If the cord becomes disconnected,
the user should immediately unplug the cord set from the wall outlet, then reconnect
the magnetic cord to the deep fryer.

H

INTS FORBESTRESULTS

• Fill the unit with oil between the maximum and minimum capacity lines only.

• Do not over fill the basket. To achieve quality results deep frying food needs to be
surrounded by oil. Too much food causes the oil temperature to drop, resulting in
“soggy” food. Food should be no higher than the top of the basket.

• Be sure that all ice crystals are removed from the food and food is completely dry.
Excessive water and ice can cause the oil to splatter and/or overflow.

• Coated foods (bread crumbs, batters, etc.) are best for deep frying. The coating
acts as a protective layer keeping food moist on the inside and crisp on the outside.

• For best results, defrost frozen foods for 20 minutes prior to frying.

• Fry foods at the correct temperature for best results. This will prevent burning and
give you even colored, crispy food.

• Prepackaged frozen cooked chicken may cook faster than uncooked food.

• For even cooking, shake basket half way through cooking time.

• Do not use seasoned or flavored oil such as walnut, olive oil, lard or drippings
because they have a low smoke point. Use blended vegetable oil, pure corn oil,
sunflower oil, soybean oil or grape seed oil (canola oil) because these oils have a
high smoke point. Peanut oil is not recommended because it impacts the
flavor greatly.

• Oils should never be mixed when deep frying.

• High heat, water and burnt food particles break down the oil’s smoke point.

• Replace oil if you notice:

- Excessive smoking at normal temperatures

- Strong oil discoloration

- A rancid smell

- Excessive foaming around the frying food

• Oil darkens with use because the oil and food molecules burn when subjected to
high/prolonged heat. The more you use an oil, the more slowly it will pour.
Its viscosity changes because of changes to the oil’s molecular structure. When
smoke appears on the oils’ surface before the temperature reaches 375°F, your oil
will no longer deep-fry effectively.

• When frying foods with strong flavor and/or aroma like fish or chicken, use the oil
only once.

• Filtering the oil with a cooking oil filter or fine-mesh strainer can keep it fresher.
Although storing oil in a refrigerator may extend the life of the oil, this should never
be done. This process of chilling oil then brining the oil to room temperature causes
excessive splattering during the heat up process.

• Store the covered oil in a cool dark place, for up to three months. Check the oil
before using for color, smell, or excessive foaming. Discard the oil if it shows any
of these qualities.

C

ARE ANDCLEANING

WARNING: Always turn control to OFF then disconnect plug from wall outlet
BEFORE disconnecting BREAK-AWAY CORD.

CAUTION:

• Do not immerse cord sets in water or any liquids

™

• Do not attempt to defeat the detachable magnetic SureRELEASE

Cord system

by trying to permanently attach cord set to product.

• Do not stick pins or other sharp objects in holes on magnetic cord set.

• Do not use any type of steel wool to clean magnetic contacts.

NOTE: Make sure fryer has cooled before cleaning.

• Turn unit OFF.

• Unplug from outlet and allow unit to cool completely.

• Remove SureRELEASE™ magnetic cord from the fryer socket.

• Remove the Lid.

• Open the Filter Cover and remove the Filters.

• Remove Frying Basket.

• Lift Control Panel Assembly up from the front of the fryer.

• Carefully lift Oil Reservoir straight up out of the Housing by holding the rim
of the bowl. The built-in oil pour spout allows you to better drain the oil into your
storage container. Store oil in an airtight container. See Hints for Best Results.
Oil Reservoir is also Dishwasher Safe.
WARNING: Do not remove Oil Reservoir until the unit has cooled completely
and is unplugged.

• Remove Power Strip from the interior of the back of the fryer. (please note that the
control panel assembly must be removed first before the power strip can be removed).

• Remove Condensation Trap from the back of the fryer.
NOTE: This trap will collect any water that has been condensed on the inside of the
Lid when the Lid is opened after frying. Remember to empty and clean the
Condensation Trap after each use.

• The Frying Basket, Lid, Oil Reservoir, Housing and Condensation Trap are
dishwasher safe. Dry all parts thoroughly after cleaning.

• The Control Panel Assembly and Power Strip should never be immersed in water or
other liquids. Gently clean the outer surface of the Control Panel Assembly with a
damp cloth containing mild soap solution or plain water, and dry thoroughly.

• Ensure that both the Lid and Oil Reservoir are completely dry after washing and
before use.

• Insert the Power Strip back into the fryer Housing.

• Insert Oil Reservoir back into Housing.

• Insert Control Panel into front of the unit.

• Place Frying Basket into bowl.

• Put Filters back into Lid and put Cover on.

• Replace and close Lid.

R

EPLACING ANDCLEANINGFILTERS

NOTE: Replace every 3 months or after 12 uses.

• Open the Filter Cover, and remove filters.

• Foam white Grease Filter may be washed in hot soapy water. Allow to air dry.

• Charcoal Filters are not meant to be washed and it is recommended to replace
every 3 months or after 12 uses.

• Clean the inside of the cover with a damp soapy sponge. Rinse and dry thoroughly.

• Place clean White Grease Filter on Lid, followed by Black Charcoal Odor Filter,
then replace Filter Cover.

NOTE: For replacement Charcoal Odor or Grease Filter, order through our website at

www.oster.com or by calling 1-800-334-0759.

F

RYINGTIME ANDTEMPERATURE

The frying times in this chart are a guide and should be adjusted to suit the different
quantities or thickness of food and to suit your own taste.

Preheat time is 7-10 minutes for fryer to reach desired temperature. (Ready light will
cycle On/Off during frying as temperature fluctuates due to food load.)

FOOD

Chicken Strips 375°F 5-8

Chicken Pieces, Bone-In 360°F 15-20

Fish, Battered 340°F 8-10

French Fries, Frozen 375°F 3-5

Fritters 375°F 2-4

Onion Rings 375°F 3-5

Shrimp, Breaded 375°F 2-4

NOTE: Prepackaged frozen cooked chicken may cook faster than above time.

TEMP.

S

ETTING

TIME

(MINUTES)