Invacare Tilt Only, Basic Tilt, Recline 4XP, Recline Only, Tilt-Recline User Manual
Parts Catalog
Issued: Jul 7, 2008
Tarsys®
Basic Tilt,
Tilt Only,
Recline 4XP,
Recline Only,
Tilt/Recline
For
Storm Series®
Powered Wheelchairs
Yes, you can. ™
Throughout this catalog you will notice letters to draw your attention to specific footnotes which are located at the
bottom of the page or below specified charts.
Parts Catalog Usage Guide
To order call toll free 1-800-333-6900, or www.invacare.com
The information contained in this document is subject to change without notice. This catalog contains
service parts for Form No. 96-194. If you have any questions regarding this catalog, please contact one
of our Customer Service Representatives.
For Customer Service Support Call:
1-800-333-6900
For Faxed In Orders Call:
1-800-678-4682 or
1-440-366-0709
For Technical Service Call:
1-800-832-4707
Literature Can Be Found at:
www.invacare.com or
1-800-828-6272
SYMBOL DEFINITION
Examples:
A,B,C etc.
NOTE:
NLA
= Special Comments
= General information pertaining to that specific page
= No Longer Available
HARDWARE MEASUREMENTS
The measurements for the hardware will be listed as follows:
Screws, Bolts
Washers
Spacers
For your convenience, we have supplied an area for you to list your Invacare Representatives.
©2008 Invacare Corporation. Elyria, Ohio. Invacare, Yes, you can., the Blue Medallion Design, Storm Series, Arrow, and Tarsys are registered trademarks
and Ranger X is a trademark of Invacare Corporation. Otto Bock is a registered trademark of Otto Bock Orthopaedische Industrie GMBH & Co.. SKF is a
registered trademark of SKF Industries, Inc.. Motion Systems is a registered trademark of Motion Systems Corporation.
Diameter X Thread Count/Pitch X Length
Inside Diameter X Outside Diameter X Thickness
Inside Diameter X Outside Diameter X Length
Name Phone Numbers
Form No.
96-194
1
Accessories, Vent Tray Assembly (After 4/30/96) - Basic Recline 4XP or Tilt/Recline and
Recline Only
Accessories, Vent Tray Assembly (Before 5/1/96) - Basic Recline 4XP or Tilt/Recline and
Recline Only
TABLE of CONTENTS
Page
Number
To order call toll free 1-800-333-6900, or www.invacare.com
Form No.
96-194
Description
Accessories, Anti-Tip Wheel Extension Assembly - For 2G Suspension Arms After 6/30/98 .. 150
Accessories, Armrest - Otto Bock ............................................................................................ 122
Accessories, Headrest Assembly - A.B.S. Curved Back .......................................................... 124
Accessories, Headrest Assembly - Back Cane Only Option .................................................... 128
Accessories, Headrest Assembly - Profile and Recessed Back .............................................. 126
Accessories, Lateral Support Assembly - Basic Recline (4XP) or Tilt/Recline and Recline Only 132
Accessories, Lateral Support Assembly - Basic Recline (4XP) or Tilt/Recline and Recline Only 136
Accessories, Lateral Support Assembly - Basic Tilt and Tilt Only ............................................ 130
Accessories, Lateral Support Assembly - Basic Tilt and Tilt Only ............................................ 134
Accessories, Miscellaneous .................................................................................................... 155
Accessories, Power Wheelchair Tool Kit .................................................................................. 153
Accessories, Retrofit Kits for Storm Power Bases ................................................................... 152
145
Accessories, Vent Tray Assembly (After 4/30/96) - Basic Tilt and Tilt Only ............................. 142
140
Accessories, Vent Tray Assembly (Before 5/1/96) - Basic Tilt and Tilt Only ............................ 138
Accessories, Vent Tray Battery Box and Basket Assembly (After 4/30/96) ............................. 148
Armrest Assembly - Basic Recline 4XP or Tilt/Recline and Recline Only ................................ 33
Armrest Assembly - Basic Tilt and Tilt Only After 10/14/98 ...................................................... 30
Armrest Assembly - Basic Tilt and Tilt Only Before 10/15/98 ................................................... 27
Back Assembly, A.B.S. Curved - Basic Recline 4XP ............................................................... 38
2
Electronics - MAX Controller 5.7 S/N start at TE4000 & 4-Way Switch (Tilt/Recline and Recline
Only)
Electronics - MKIV Recliner Control (1815M4) & Recliner Cable - (Basic Tilt and Tilt Only) or
(Basic Recline 4XP)
TABLE of CONTENTS
Page
Number
To order call toll free 1-800-333-6900, or www.invacare.com
Form No.
96-194
Description
Back Assembly, A.B.S. Curved - Basic Tilt and Tilt Only ......................................................... 35
Back Assembly, A.B.S. Curved - Recline, Fixed Back (Non-VSR) .......................................... 40
Back Assembly, A.B.S. Curved - Recline, Sliding Back (VSR) ................................................ 43
Back Assembly, Mechanical Shear Reduction Linkage - Basic Recline 4XP .......................... 58
Back Assembly, Profile (Fixed) ................................................................................................ 46
Back Assembly, Profile (Fixed, Non-VSR) ............................................................................... 49
Back Assembly, Profile (Sliding, VSR) ..................................................................................... 52
Back Assembly, Recessed (Sliding, VSR) ............................................................................... 55
Back Cane Assembly - Basic Tilt and Tilt Only ........................................................................ 21
Back Cane Assembly - Tilt/Recline and Recline Only .............................................................. 25
Back Cane Assembly (Includes Recline Actuator) - Basic Recline 4XP .................................. 23
Electronics - MAX Controller 5.0, 5.5 & 4-Way Switch - Tilt/Recline and Recline Only ........... 81
Electronics - Max Controller 5.0, 5.5 & 4-Way Switch (Tilt Only) ............................................. 79
Electronics - MAX Controller 5.7 S/N start at TE4000 & 4-Way Switch (Tilt Only) ................... 83
85
Electronics - Midline Assembly ................................................................................................. 100
93
Electronics - Quad Link (QLA) After 4/06/06 ............................................................................ 98
Electronics - Quad Link Assembly Before 4/07/06 ................................................................... 94
Electronics - S.F.T. Switch After 1/17/99 w/ Drive Lockout Built In - Basic Recline 4XP ......... 77
Electronics - S.F.T. Switch After 1/17/99 w/ Drive Lockout Built In - Basic Tilt Only ................ 75
3
Electronics - T.R.C.M. Upgrade Kit with Mercury Switches - Tilt Only or Tilt/Recline and Recline
Only
Front Rigging - Front Rigging Hanger Assembly - Sector, Genius, Pin, AML4A Style (Basic
Recline 4XP)
Front Rigging - Legrest, Genius - (Tilt Only) or (Basic Recline 4XP) or (Tilt/Recline and Recline
Only)
Front Rigging - Motor Actuators, Genius and AT5544 Legrest - (Tilt Only) or (Tilt/Recline and
Recline Only)
TABLE of CONTENTS
Page
Number
To order call toll free 1-800-333-6900, or www.invacare.com
Form No.
96-194
Description
Electronics - S.F.T. Switch Before 1/18/99 w/ Drive Lockout and DAD Box - Basic Recline 4XP 73
Electronics - S.F.T. Switch Before 1/18/99 w/ Drive Lockout and DAD Box - Basic Tilt Only .. 71
Electronics - T.R.C.M. & 4-Way Switch - Tilt Only or Tilt/Recline and Recline Only ................ 87
90
Frame, Seat 2" Higher Seat-to-Floor Mounting Plate Assembly - Basic Tilt and Tilt Only ....... 19
Frame, Seat and Hardware - (Basic Tilt and Tilt Only) or (Tilt/Recline and Recline Only) ....... 7
Frame, Seat and Hardware - Basic Recline 4XP ..................................................................... 9
Frame, Seat Attaching Hardware - Basic Recline 4XP ............................................................ 14
Frame, Seat Attaching Hardware - Tilt/Recline and Recline Only ............................................ 16
Frame, Seat Attaching Hardware (Includes Tilt Actuator) - Basic Tilt and Tilt Only ................. 11
Front Rigging - Front Rigging Hanger Assembly - Sector, Genius, Pin, AML4A Smartleg Style 102
105
Front Rigging - Legrest, AT5544 (Power) - Tilt Only or Tilt/Recline and Recline Only ............. 108
111
Front Rigging - Legrest, Mechanical Actuator Linkage With M.S.R. - Basic Recline 4XP ....... 117
Front Rigging - Legrest, Mechanical Actuator Linkage Without M.S.R. - Basic Recline 4XP .. 115
Front Rigging - Legrest, Power Elevating - Basic Recline 4XP ............................................... 109
120
Motor Actuators - (Tilt, Recline, V.S.R.) (See Back Cane Assembly For BR4XP) ................... 60
Packaging and Literature ......................................................................................................... 6
Seat Pan and Extensions - Basic Recline 4XP ........................................................................ 66
4
TABLE of CONTENTS
Page
Number
To order call toll free 1-800-333-6900, or www.invacare.com
Form No.
96-194
Description
Seat Pan and Extensions - Basic Tilt and Tilt Only .................................................................. 63
Seat Pan and Extensions - Tilt/Recline and Recline Only ........................................................ 68
5
Item
Number
Part Number
DescriptionNote
Quantity Per
Package Assembly
0310600 Carton 1 1A,B
0310400 Insert, Carton 1 1A,B
0289400 Lid, Carton 1 2A,C
0289300 Skid Pack Sleeve, Carton 1 1A,C
0162400-NLA Carton, Outer Pack 1 1A,C
0282500 Owners Manual, Basic Recline (4XP) 1 1A
1080705 Owners Manual, Basic Tilt, Tilt Only, Recline Only
and Tilt/ Recline
1 1A
A - Not Shown
B - Seating System Only
C - Seating System with Base
NOTE:
When adjusting or replacing parts, please refer to your owner's manual for assistance.
NOTE:
Packaging and Literature
Form No.
96-194
To order call toll free 1-800-333-6900, or www.invacare.com
6
Seat Frame and Hardware
(Basic Tilt and Tilt Only) or (Tilt/Recline and Recline Only)
Form No.
96-194
7
To order call toll free 1-800-333-6900, or www.invacare.com
Seat Frame and Hardware
#1 Seat Side Frame and Hardware
Seat Depth
14-15" Wide
Right
14-15" Wide
Left
16-24" Wide
Right
16-24" Wide
Left
N/AN/A1072934107293314"-15" Depth
107274510727441072932-NLA1072931-NLA16"-20" Depth
10728081072807N/AN/A21"-24" Depth
Item
Number
Part Number
DescriptionNote
Quantity Per
Package Assembly
See Chart #1 Seat Side Frame and Hardware 1 11 A
0114702 Seat Frame 1 12 B
0208902 Seat Frame 1 12 C
1025736 Locknut (1/4-20) 1 23
0050406 Washer, Flat (1/4 x 5/8 x 1/16") 1 44
0050506 Lockwasher, High Collar, Split (1/4") 1 45
0051006-NLA Screw, Hex Head Full Thread (1/4-20 x 1-1/2") 1 26
A - Includes seat side frame and items 3-6
B - 14" - 20" Wide
C - 21" - 24" Wide
NOTE:
(Basic Tilt and Tilt Only) or (Tilt/Recline and Recline Only)
Form No.
96-194
To order call toll free 1-800-333-6900, or www.invacare.com
8
Seat Frame and Hardware
Basic Recline 4XP
Form No.
96-194
9
To order call toll free 1-800-333-6900, or www.invacare.com
Seat Frame and Hardware
Item
Number
Part Number
DescriptionNote
Quantity Per
Package Assembly
0055306 Screw, Hex Head (5/16-18 x 1-3/4") 1 21
0216302 Frame Assembly, Rear (4XP) 16" Wide 1 12
0216402 Frame Assembly, Rear (4XP) 18" Wide 1 12
0158402 Frame Assembly, Center (4XP) 16" Wide 1 13
0158502 Frame Assembly, Center (4XP) 18" Wide 1 13
0050406 Washer, Flat (1/4 x 5/8 x 1/16") 1 204
1025736 Locknut (1/4-20) 1 105
0051006-NLA Screw, Hex Head Full Thread (1/4-20 x 1-1/2") 1 26
0216702 Frame Assembly, Front (4XP) 16" Wide 1 17
0216802 Frame Assembly, Center (4XP) 18" Wide 1 17
1024793 Screw, Hex Head (1/4-20 x 1-3/4") 1 88
0054906 Locknut, High Profile (5/16-18) 1 29
0216602 Seat Side Frame (4XP) Right 1 110
0216502 Seat Side Frame (4XP) Left 1 110
Basic Recline 4XP
Form No.
96-194
10
To order call toll free 1-800-333-6900, or www.invacare.com
Seat Frame Attaching Hardware
Basic Tilt and Tilt Only
Form No.
96-194
11
To order call toll free 1-800-333-6900, or www.invacare.com
Seat Frame Attaching Hardware
Item
Number
Part Number
DescriptionNote
Quantity Per
Package Assembly
0308500 Actuator Assembly, Large 5" Stroke 1 11
0060500 Bushing (3/8 x 1/2 x 5/8") 1 12
1028848 Roll Pin (1/8" x 7/8") 1 13
0054106 Locknut, High Profile (3/8-16) 1 14
0053900 Washer, Nylon (3/8 x 13/16 x 1/16") 1 45
0054506 Screw, Hex Head (3/8-16 x 2-1/2") 1 16
1072786 Actuator, Large 5" Stroke with Hardware 1 17
0055800 Washer, Nylon (7/16 x 3/4 x 3/32") 1 168
0060300 Bushing, Bronze (5/16 x 7/16 x 1-1/4") 1 29
0140506 Screw, Socket Head w/ Thread Lock (5/16 x 18 x 1") 1 410
0115102 Plate, Seat Frame Inner Mounting - Right 1 211
0115202 Plate, Seat Frame Inner Mounting - Left 1 211
0054906 Locknut, High Profile (5/16-18) 1 212
0115302 Plate, Seat Frame Outer Mounting - Right 1 213
0115402 Plate, Seat Frame Outer Mounting - Left 1 213
0190102-NLA Connector Bracket 1 114
7930333 Locknut (1/4-20) 25 615
0050406 Washer, Flat (1/4 x 5/8 x 1/16") 1 1216
0115024 Bar, Mounting 1 217
0140406 Screw, Socket Head Cap (5/16-18 x 1-1/2) 1 218
0052306-NLA Screw, Hex Head (1/4-20 x 2-1/4") 1 519
0055506 Screw, Socket Head (5/16-18 x 2") 1 220
0143205 Locknut, Low Profile (#6-32) 1 221
313329 Screw, Phillips Head (#6-32 x 1/2") 1 222
1072747 Plates, Seat Frame Mounting w/ Hardware 1 123
0115502 Link, Mounting Plate 1 124
0139806 Screw, Hex Head (5/16-18 x 3") 1 125
0115624 Link, Tilt Upper 1 226
0120300 Bushing (3/8 x 1/2 x 7/8") 1 427
0054506 Screw, Hex Head (3/8-16 x 2-1/2") 1 228
0140306 Screw, Hex Head (3/8-16 x 4-1/2") 1 129
0140006 Washer (13/32 x 5/8 x 1/32") 1 230
0115724 Link, Tilt Lower 1 231
0120100 Bushing (3/8 x 1/2 x 3/4") 1 432
0054106 Locknut, High Profile (3/8-16) 1 433
0139606 Screw, Hex Head (5/16-18 x 1") 1 234
1072692 Lockwasher, Split (5/16") 1 435
0140600 Washer, Rubber (13/16 x 13/32 x 3/32) 1 236
0140206 Screw, Hex Head (3/8-16 x 3-1/2") 1 137
1072809 Hardware, Seat Frame Mounting 1 138 D
1072746 Tilt Actuator w/ Tilt Mounting Hardware 1 139
1077357 Pin, Roll (3/16 x 1-1/8" Long) 1 140
0211102 Tilt Stop Weldment 1 141
Basic Tilt and Tilt Only
Form No.
96-194
12
To order call toll free 1-800-333-6900, or www.invacare.com
Seat Frame Attaching Hardware
Item
Number
Part Number
DescriptionNote
Quantity Per
Package Assembly
1077358 Lockwasher, Split (3/8-16) 1 142
1077359 Nut, Hex (3/8-16) 1 143
0225100 Bumper, Tilt 1 144
0309019-NLA Cover, Controller 1 145 C
1077365 Knob, Thumb Screw (5/16-18 x 1") 1 146
0052206 Screw, Hex Head (1/4-20 x 2-1/2") 1 147
0313900 Rod End with Locknut and Roll Pin 1 148 A
1077197 Rod End w/ Locknut and Roll Pin 1 148 B
A - SKF Actuator
B - Motion Systems Actuator
C - Tarsys/Storm
D - Tilt
NOTE:
Basic Tilt and Tilt Only
Form No.
96-194
13
To order call toll free 1-800-333-6900, or www.invacare.com
Seat Frame Attaching Hardware
Basic Recline 4XP
Form No.
96-194
14
To order call toll free 1-800-333-6900, or www.invacare.com
Seat Frame Attaching Hardware
Item
Number
Part Number
DescriptionNote
Quantity Per
Package Assembly
0140506 Screw, Socket Head w/ Thread Lock (5/16 x 18 x 1") 1 41
0054806 Washer, Flat (5/16") 1 42
0131406 Screw, Hex Head (5/16-18 x 1-3/4") 1 43
0139900 Washer, Nylon (1/2 x 3/4 x 3/32") 1 84
0280700 Bushing (5/16 x 1/2 x 7/8") 1 45
0054906 Locknut, High Profile (5/16-18) 1 46
0055406 Screw, Socket Head (5/16-18 x 1") 1 27
1072692 Lockwasher, Split (5/16") 1 28
0115724 Link, Tilt Lower 1 29
0215300 Bracket, Seat Support 1 210
0139606 Screw, Hex Head (5/16-18 x 1") 1 211
1077373 Hardware Assembly, Seat Attaching (4XP) 1 112
Basic Recline 4XP
Form No.
96-194
15
To order call toll free 1-800-333-6900, or www.invacare.com
Seat Frame Attaching Hardware
Tilt/Recline and Recline Only
Form No.
96-194
16
To order call toll free 1-800-333-6900, or www.invacare.com
Seat Frame Attaching Hardware
Item
Number
Part Number
DescriptionNote
Quantity Per
Package Assembly
0055800 Washer, Nylon (7/16 x 3/4 x 3/32") 1 61
0060300 Bushing, Bronze (5/16 x 7/16 x 1-1/4") 1 22
0115102 Plate, Seat Frame Inner Mounting - Right 1 23
0115202 Plate, Seat Frame Inner Mounting - Left 1 23
0115302 Plate, Seat Frame Outer Mounting - Right 1 14
0115402 Plate, Seat Frame Outer Mounting - Left 1 14
0190102-NLA Connector Bracket 1 15
0143205 Locknut, Low Profile (#6-32) 1 26
313229-NLA Screw, Phillips Pan Head (#6-32 x 1/2") 1 27
0115502 Link, Mounting Plate 1 18
0055800 Washer, Nylon (7/16 x 3/4 x 3/32") 1 119
0140306 Screw, Hex Head (3/8-16 x 4-1/2") 1 210
0140206 Screw, Hex Head (3/8-16 x 3-1/2") 1 111
0118524 Link, Tilt 1 212
0054106 Locknut, High Profile (3/8-16) 1 513
0139606 Screw, Hex Head (5/16-18 x 1") 1 214
0054906 Locknut, High Profile (5/16-18) 1 115
1072692 Lockwasher, Split (5/16") 1 416
0139806 Screw, Hex Head (5/16-18 x 3") 1 117
7930333 Locknut (1/4-20) 25 618
0050406 Washer, Flat (1/4 x 5/8 x 1/16") 1 1219
0115024 Bar, Mounting 1 220
0140406 Screw, Socket Head Cap (5/16-18 x 1-1/2) 1 221
0052306-NLA Screw, Hex Head (1/4-20 x 2-1/4") 1 522
0055506 Screw, Socket Head (5/16-18 x 2") 1 223
0115624 Link, Tilt Upper 1 224
0120300 Bushing (3/8 x 1/2 x 7/8") 1 425
0054506 Screw, Hex Head (3/8-16 x 2-1/2") 1 126
0140006 Washer (13/32 x 5/8 x 1/32") 1 427
0140206 Screw, Hex Head (3/8-16 x 3-1/2") 1 128
0120100 Bushing (3/8 x 1/2 x 3/4") 1 429
0115724 Link, Tilt Lower 1 230
0140600 Washer, Rubber (13/16 x 13/32 x 3/32) 1 231
0140506 Screw, Socket Head w/ Thread Lock (5/16 x 18 x 1") 1 232
1072747 Plates, Seat Frame Mounting w/ Hardware 1 133
1072810-NLA Hardware, Seat Frame Mounting 1 134 A
1072809 Hardware, Seat Frame Mounting 1 135 B
1077357 Pin, Roll (3/16 x 1-1/8" Long) 1 136
0211102 Tilt Stop Weldment 1 137
1077358 Lockwasher, Split (3/8-16) 1 138
1077359 Nut, Hex (3/8-16) 1 139
0225100 Bumper, Tilt 1 140
0309019-NLA Cover, Controller 1 141 C
Tilt/Recline and Recline Only
Form No.
96-194
17
To order call toll free 1-800-333-6900, or www.invacare.com
Seat Frame Attaching Hardware
Item
Number
Part Number
DescriptionNote
Quantity Per
Package Assembly
1077365 Knob, Thumb Screw (5/16-18 x 1") 1 142
0052206 Screw, Hex Head (1/4-20 x 2-1/2") 1 143
0308600 Roll Pin (1/8 x 7/8") 1 144
0313900 Rod End with Locknut and Roll Pin 1 145 D
1077197 Rod End w/ Locknut and Roll Pin 1 145 E
A - Recline "Only"
B - Tilt "and" Recline
C - Tarsys/Storm
D - SKF Actuator
E - Motion Systems Actuator
NOTE:
Tilt/Recline and Recline Only
Form No.
96-194
18
To order call toll free 1-800-333-6900, or www.invacare.com
NOTE: Storm Arrow heavy duty bases come standard with 2" higher seat-to-floor assemblies. Non-heavy
duty bases are done as a "special" when ordered "on-chair" with the original order.
2" Higher Seat-to-Floor Mounting Plate Assembly
Basic Tilt and Tilt Only
Form No.
96-194
19
To order call toll free 1-800-333-6900, or www.invacare.com
2" Higher Seat-to-Floor Mounting Plate Assembly
Item
Number
Part Number
DescriptionNote
Quantity Per
Package Assembly
0195302 Mounting Plate, Seat Frame Inner 20" S.T.F. - Right 1 11
0195202 Mounting Plate, Seat Frame Inner 20" S.T.F. - Left 1 11
0195502 Mounting Plate, Seat Frame Outer 20" S.T.F. - Right 1 12
0195402 Mounting Plate, Seat Frame Outer 20" S.T.F. - Left 1 12
0188202 Mounting Plate, Link 20" S.T.F. 1 13
0139606 Screw, Hex Head (5/16-18 x 1") 1 24
0054906 Locknut, High Profile (5/16-18) 1 25
1072692 Lockwasher, Split (5/16") 1 46
0139806 Screw, Hex Head (5/16-18 x 3") 1 17
7930333 Locknut (1/4-20) 25 68
0050406 Washer, Flat (1/4 x 5/8 x 1/16") 1 129
0140406 Screw, Socket Head Cap (5/16-18 x 1-1/2) 1 210
0052306-NLA Screw, Hex Head (1/4-20 x 2-1/4") 1 511
0052206 Screw, Hex Head (1/4-20 x 2-1/2") 1 112
1072683 Retrofit Assembly to Raise Seat-To-Floor 2" 1 113 A
A - Includes items 1-12
NOTE:
Basic Tilt and Tilt Only
Form No.
96-194
20
To order call toll free 1-800-333-6900, or www.invacare.com
Back Cane Assembly
Basic Tilt and Tilt Only
Form No.
96-194
21
To order call toll free 1-800-333-6900, or www.invacare.com
Back Cane Assembly
Item
Number
Part Number
DescriptionNote
Quantity Per
Package Assembly
0014500 Hand Grip 1 11
0053006-NLA Screw, Hex Head (1/4-20 x 3/4") 1 32
7930333 Locknut (1/4-20) 25 13
0050006 Lockwasher, Split (1/4") 2 24
0062800 Bracket, Cable/Wire Mounting, Black 1 15
0054906 Locknut, High Profile (5/16-18) 1 16
0060600 Bushing (7/16 x 5/16 x 1-1/4") 1 17
0055800 Washer, Nylon (7/16 x 3/4 x 3/32") 1 48
0055506 Screw, Socket Head (5/16-18 x 2") 1 19
0309902 Back Cane w/ Grip 1 110
0116702 Mounting Post 1 111
0054700 Washer, Nylon (5/16 x 1/2 x 1/16") 1 412
0052606 Screw, Hex Head (1/4-20 x 2") 1 113
0049824 Spacer, Coved (7/8") 1 114
0050506 Lockwasher, High Collar, Split (1/4") 1 315
1072788 Back Cane Assembly w/ Hardware 1 116
7930332 Locknut, High Profile (#10-32) 25 117
0139306 Screw, Socket Button Head (#10-32 x 3/4") 1 118
0002902 Bracket, Mounting - Left 1 119
Basic Tilt and Tilt Only
Form No.
96-194
22
To order call toll free 1-800-333-6900, or www.invacare.com
Back Cane Assembly
Basic Recline (4XP)
Form No.
96-194
23
To order call toll free 1-800-333-6900, or www.invacare.com
Back Cane Assembly
Item
Number
Part Number
DescriptionNote
Quantity Per
Package Assembly
1077416 Push Bar with Hardware, 16" Wide 1 11 A
1077417 Push Bar with Hardware, 18" Wide 1 11 A
0014500 Hand Grip 1 22
1077143 Lockwasher, External Tooth (#10) 1 23
0139306 Screw, Socket Button Head (#10-32 x 3/4") 1 14
1027095 Plug Button, Black (7/8") 1 25
0062800 Bracket, Cable/Wire Mounting, Black 1 16
7930332 Locknut, High Profile (#10-32) 25 17
7930333 Locknut (1/4-20) 25 48
0029324 Back Post, Recliner 1 29
0053006-NLA Screw, Hex Head (1/4-20 x 3/4") 1 410
0309600 Actuator, Basic Recline (4XP) 4.5" Stroke 1 111
0054606 Screw, Hex Head (3/8-16 x 2") 1 112
0056000 O-Ring (1/2 x 7/8 x 3/16") 1 213
0054106 Locknut, High Profile (3/8-16) 1 214
0054506 Screw, Hex Head (3/8-16 x 2-1/2") 1 115
0053900 Washer, Nylon (3/8 x 13/16 x 1/16") 1 416
1028848 Roll Pin (1/8" x 7/8") 1 117
0060500 Bushing (3/8 x 1/2 x 5/8") 1 118
1077402 Actuator w/Attaching Hardware 1 119 B
0313900 Rod End with Locknut and Roll Pin 1 120 C
1077197 Rod End w/ Locknut and Roll Pin 1 120 D
A - Includes items 2, 8, 10
B - Includes items 11-18
C - SKF Actuator
D - Motion Systems Actuator
NOTE:
Basic Recline (4XP)
Form No.
96-194
24
To order call toll free 1-800-333-6900, or www.invacare.com
Back Cane Assembly
Tilt/Recline and Recline Only
Form No.
96-194
25
To order call toll free 1-800-333-6900, or www.invacare.com
Back Cane Assembly
Item
Number
Part Number
DescriptionNote
Quantity Per
Package Assembly
0014500 Hand Grip 1 21
0053006-NLA Screw, Hex Head (1/4-20 x 3/4") 1 42
7930333 Locknut (1/4-20) 25 63
1072883 Push Bar with Hardware, 14" Wide 1 14 B
1072884 Push Bar with Hardware, 15" Wide 1 14 B
1072812 Push Bar with Hardware, 16" Wide 1 14 B
1072813 Push Bar with Hardware, 17" Wide 1 14 B
1072814 Push Bar with Hardware, 18" Wide 1 14 B
1072815 Push Bar with Hardware, 19" Wide 1 14 B
1072816 Push Bar with Hardware, 20" Wide 1 14 B
1072885 Push Bar with Hardware, 21" Wide 1 14 B
1072886 Push Bar with Hardware, 22" Wide 1 14 B
0117206 Mounting Plate, Max Controller (4.0-5.5) 1 15 A
0050006 Lockwasher, Split (1/4") 2 26
0067106 Screw, Phillips Pan Head (#10-32 x 1/2") 1 17
0188902 Mounting Bracket, Max Controller 1 28
7930332 Locknut, High Profile (#10-32) 25 19
0062800 Bracket, Cable/Wire Mounting, Black 1 110
1027095 Plug Button, Black (7/8") 1 211
0029324 Back Post, Recliner 1 212
0054906 Locknut, High Profile (5/16-18) 1 213
0060600 Bushing (7/16 x 5/16 x 1-1/4") 1 214
0055800 Washer, Nylon (7/16 x 3/4 x 3/32") 1 415
0055506 Screw, Socket Head (5/16-18 x 2") 1 216
1072811 Back Cane Assembly with Hardware 1 217
0053006-NLA Screw, Hex Head (1/4-20 x 3/4") 1 218
7930323 Package, Locknut (1/4-20) 25 219
A - Only used on systems with 4.0 to 5.5 MAX box.
B - Includes items 1-3
NOTE:
Tilt/Recline and Recline Only
Form No.
96-194
26
To order call toll free 1-800-333-6900, or www.invacare.com
Armrest Assembly
Non-Flip Back Arms Before 10/15/98
Basic Tilt and Tilt Only
Form No.
96-194
27
To order call toll free 1-800-333-6900, or www.invacare.com
Armrest Assembly
Item
Number
Part Number
DescriptionNote
Quantity Per
Package Assembly
1041522 Arm Tube, Upper with Plug Buttons (Black) - Full
Length
1 11
1070859 Arm Tube, Upper with Plug Buttons (Black) - Desk
Length
1 11
1117328 Arm Pad, Full Length, Urethane Waterfall with
Screws, Black
(13" L x 2-5/8" W)
1 12 A
1110818 Arm Pads, Full Length, Urethane Waterfall
with Screws, Black (13" L x 2-5/8" W) (Pair)
2 12
1117327 Arm Pad, Desk Length, Urethane Waterfall with
Screws, Black
(9" L x 2-5/8" W)
1 12 A
1110817 Arm Pads, Desk Length, Urethane Waterfall with
Screws, Black (9" L x 2-5/8" W) (Pair)
2 12
1027095 Plug Button, Black (7/8") 1 23
1055949 Screws, Phillips Pan Head (#10-32 x 1-1/8") 2 14
1094270 Screw, Phillips Pan Head (#10-32 x 1-1/4") (Pair) 2 14 B
1090768 Kit, Lock Handle w/Rivets (both LT & RT side) 2 15
47471X074 Spring, Arm Lock 1 16
1028594 Pin, Arm Lock 1 17
1032245 Grip, Foam Hand (6-7/8" Long) 1 18
1018225 Spring, Torsion with Button Lock 1 19
1028645 Rivet 1 610
1064130 Clothing Guard 1 111
1035065 Cover, Clothing Guard with Pocket - For Fixed
Height Desk Length & Adjustable Height Full/Desk
Length
1 112
0050406 Washer, Flat (1/4 x 5/8 x 1/16") 1 813
7930333 Locknut (1/4-20) 25 414
1024793 Screw, Hex Head (1/4-20 x 1-3/4") 1 415
0050506 Lockwasher, High Collar, Split (1/4") 1 416
See Chart Armrest Assembly - 14-15" Deep 1 1C
A - As of 1/3/02 upholstered waterfall armpads were replaced with black urethane waterfall armpads. Order in pairs with
screws for chairs serviced before 1/3/02.
B - For Black Urethane Waterfall Arm Pads only
C - Not Shown
NOTE:
Item Number 2117 17 18 19 20
Armrest
Mounting
Hardware
Armrest
Socket
Rear
Armrest
Socket
Front
Arm Base
Assembly
Arm Tube
with Arm Pad
Desk Length
Arm Tube
with Arm Pad
Full Length
Description
Non-Flip Back Arms Before 10/15/98
Basic Tilt and Tilt Only
Form No.
96-194
To order call toll free 1-800-333-6900, or www.invacare.com
28
Armrest Assembly
Item Number 2117 17 18 19 20
1072949012160210729511072943
1110819
1110821
14" Deep
Right
See Note(s) A See Note(s) A
1072950012150210729521072944
1110820
1110822
14" Deep
Left
See Note(s) A See Note(s) A
1072789012130201215021057411
1110819
1110821
15" and Deeper
Right
See Note(s) A See Note(s) A
1072930012140201216021057412
1110820
1110822
15" and Deeper
Left
See Note(s) A See Note(s) A
A - As of 1/3/02 upholstered waterfall armpads were replaced with black urethane waterfall armpads. Order right and left arm tube
with arm pad for chairs serviced before 1/3/02.
NOTE:
Non-Flip Back Arms Before 10/15/98
Basic Tilt and Tilt Only
Form No.
96-194
To order call toll free 1-800-333-6900, or www.invacare.com
29
Loading...