Aprilia SCARABEO 50 I.E Dealer Instruction
DEALER INSTRUCTION SHEET DEALER INSTRUCTION SHEET
2
1
ASSEMBLING THE LOCK
SCARABEO 50 i.e. SCARABEO 50 i.e.
1
Scarabeo 50 i.e.
Scarabeo 50 i.e.
••
• Remove the nut (1) from the lock unit (2).
••
••
• Fit the lock unit to the housing on the street car
••
cover and secure with the nut (1).
Make sure the nut (1) is tight.
INSTRUCTIONS FOR REMOVING
MOTORCYCLE FROM CRATE
SAFETY MESSAGES
The following warning messages are used on all the
instruction sheets to draw your attention to the situations
described below.
Safety warning symbol. When you see this
symbol on the motorcycle or instruction sheets,
beware of potential injury hazards.
Failure to observe the instructions following these
symbols may affect your safety, the safety of
others and that of the motor cycle!
Risk of serious injury or death.
Possible risk of slight injury or damage to motor
cycle.
DANGER
Risk of serious injury or death.
CAUTION
Possible risk of slight injury or damage to motor
cycle.
IMPORTANT
The word “IMPORT ANT”is written before any important
information on the instruction sheet.
For the sake of safety, before starting the
vehicle, carry out a thorough preliminary check.
See the PRELIMINARY CHECK LIST IN THE
VEHICLE OPERATION AND MAINTENANCE
HANDBOOK.
Failure to carry out these checks may lead to
serious injury or damage to the vehicle.
Very little time is required, and the benefits in terms
of safety are enormous.
The components in this handbook are supplied
disassembled, and have to be fitted to the motor cycle.
These instruction sheets for dealers describe the
correct fitting procedures.
Read the instructions in the sheets to avoid
breakages or incorrect assembly.
Remove the rear street case from the packing case,
containing the mirrors, battery and components.
After removing the nailed-on supports and crosspieces
from the crate (used for transport purposes), push the
motor cycle off the bottom of the crate and position it
on the stand.
You can now proceed with the operations described
below.
aprilia part #8202313 - 01/02 - USA
Pag. 8
Pag. 1
SCARABEO 50 i.e. SCARABEO 50 i.e.
DEALER INSTRUCTION SHEET DEALER INSTRUCTION SHEET
2
1
BATTERY
Battery electrolyte is toxic, caustic and the contact
with the skin may cause serious burns, since it
contains sulfuric acid. Wear protective clothing, a
face shield and/or tight fitting goggles when
working around the battery. In case of cont act with
the skin, flush immediately with plenty of water.
In case of contact with the eyes, flush with plenty
of water for at least 15 minutes. Immediately
consult an oculist.
If the electrolyte is accidentally swallowed, drink
large quantities of water or milk, and then milk of
magnesia or vegetable oil. Immediately consult a
health professional. The battery gives off noxious
and explosive gases; keep it away from cigarettes,
flames, sparks and any other source of heat.
During the recharging or the use, make sure hat
the room is properly ventilated and avoid inhaling
the gases released during the recharging.
KEEP A W A Y FROM CHILDREN.
Do not tip the vehicle too much, or tip the battery
too much, to avoid electrolyte leaking out.
4
3
INITIAL BATTERY CHARGING
••
• Lift the saddle (1) and remove the tool kit holder (2).
••
••
• Remove the plug (3) from the recharge container (4).
••
••
• Fit the container into the battery as shown in the
••
drawing (see the battery instructions in the recharge
pack).
••
• Use the same plug (3) to stop up battery holes.
••
2
2
1
1
FITTING THE STORAGE BOX
Follow the assembly instructions for the storage box.
••
• Fit the spacer bushes (1) in the carrier housings
••
and the inner street case housings.
••
•
Secure the street case to the carrier with the screws
••
TBEI M6X35 (2) and self-locking nuts M6 (3).
Screw (2) tightening torque: 7.37 ftlb (10 Nm).
1
CAUTION
The battery liquid is corrosive. Do not pour or
sprinkle it, particularly on plastic parts. When the
battery has been removed it must be placed in a
safe place out of the reach of children. The battery
is very dangerous and may cause serious injury
or death.
Pag. 2
3
Pag. 7
Loading...