Aerus lite User Manual

Lightweight Upright Vacuum Cleaner

Aspirateur vertical léger

BEFORE OPERATING YOUR VACUUM, PLEASE READ THESE INSTRUCTIONS CAREFULLY.

AVANT D’UTILISER VOTRE ASPIRATEUR, VEUILLEZ LIRE ATTENTIVEMENT LES INSTRUCTIONS SUIVANTES.

947-1884 EA-03715

2

IMPORTANT SAFETY INSTRUCTIONS

When you use a vacuum cleaner, basic precautions should always be followed, including the following:

• READ ALL INSTRUCTIONS BEFORE USING THE VACUUM CLEANER.

• ALWAYS FOLLOW THESE SAFETY INSTRUCTIONS.

• DO NOT LEAVE VACUUM CLEANER UNATTENDED WHEN PLUGGED IN.

WARNING: Fully assemble before operating. This vacuum is intended for household use only.

WARNING: TO REDUCE THE RISK OF FIRE,

ELECTRIC SHOCK OR INJURY:

• Do not leave appliance when plugged in. Unplug from outlet when not in use and before servicing.

• Do not use outdoors or on wet surfaces.

• Do not allow to be used as a toy. Close attention is necessary when used by or near children.

• Use only as described in this manual.

• Do not use with damaged cord or plug. If appliance is not working as it should, has been dropped,

damaged, left outdoors, or dropped into water, return it to a service center for inspection.

• Do not pull or carry by cord, use cord as a handle, close a door on cord, or pull cord around sharp

edges or corners.

• Do not run appliance over cord. Keep cord away from heated surfaces.

• Do not unplug by pulling on cord. To unplug, grasp the plug, not the cord.

• Do not handle plug or appliance with wet hands.

• Do not put any object into openings. Do not use with any opening blocked; keep free of dust, lint,

hair and anything that may reduce airow.

• Keep hair, loose clothing, ngers, and all parts of body away from openings and moving parts.

• Turn off all controls before unplugging.

• Use extra care when cleaning on stairs.

• Do not use to pick up ammable or combustible liquids, such as gasoline, or use in areas where

they may be present.

• Keep your hands, feet, hair and clothing away from moving parts, especially the revolving brush.

Do not use the vacuum cleaner without lter bag and/or lters in place.

• Do not pick up anything that is burning or smoking, such as cigarettes, matches, or hot ashes.

State of California Proposition 65 Warnings:

WARNING: This product contains one or more chemicals known to the State of California to

cause cancer. WARNING: This product contains one or more chemicals known to the State of

California to cause birth defects or other reproductive harm.

SAVE THESE INSTRUCTIONS

3

CONGRATULATIONS

TABLE OF CONTENTS

Your new Lite by Aerus vacuum cleaner has been designed and built to provide you with the best in
cleaning power, convenience, and durability.

The following pages are designed to answer questions concerning the use of your Lite by Aerus
vacuum cleaner. For additional information regarding this or any of our ne products, please contact
your local Aerus Representative or call Aerus Customer Service toll-free at:

800.243.9078 (U.S

)

800.668.0763 (Canada

)

POLARIZATION INSTRUCTIONS

IMPORTANT: Use only genuine Aerus replacement parts.

Safety Instructions ................................................................................................................................. Page 2

Polarization Instructions ......................................................................................................................... Page 3

Features .................................................................................................................................................Page 4

Assembly ................................................................................................................................................ Page 5

Operation ................................................................................................................................................Page 6

Maintenance & Care ...............................................................................................................................Page 7

Replacing the Vacuum Bag .................................................................................................................Page 8

Replacing the Agitator Belt ..................................................................................................................Page 9

Replacing the Squeegee .....................................................................................................................Page 10

Key Replacement Parts ....................................................................................................................... Page 11

Troubleshooting Guide ............................................................................................................................Page 11

Warranty ................................................................................................................................................. Page 12

Power Cord, 2-Wire Polarized Cord

To reduce the risk of electric shock, this

product is equipped with a polarized

alternating current line plug (a plug having

one blade wider than the other). This plug will

t into the power outlet only one way. This is

a safety feature. If you are unable to insert

the plug fully into the outlet, try reversing the

plug. If the plug should still fail to t, contact

a qualied electrician to replace the obsolete

outlet. Do not defeat the safety purpose of the

polarized plug.

4

FEATURES

1. Ergonomic Handle

2. On/Off Power Switch

3. Bag Compartment

4. Vacuum Nozzle

5. Headlight

6. Furniture Guard

7. Circuit Breaker Reset Button

8. Handle Release Pedal

9. Quick Release Cord Hook

10. Upper Cord Hook

1

2

3

4

5

6

7

8

9

10

5

ASSEMBLY

NOTE: Do not plug in the vacuum until it is completely assembled.

Attaching the Handle to the Vacuum

The vacuum cleaner and the handle are packed

separately and require assembly.

1. Thread the cord through the lower and upper cord

guides on the back of the vacuum bag (Fig. 1).

2. Remove the handle bracket by removing the two

screws (Fig. 2).

3. Place handle onto the back of the vacuum, aligning

holes with pegs (Fig. 3).

4. Place the handle bracket back into position (Fig. 4).

5. Secure with two screws removed in Step 2.

6. Unzip the outer bag compartment to ensure a

vacuum bag is in place.

7. Close the outer bag. Your vacuum is now ready

for use.

Unwinding the Power Cord

The lower cord hook rotates to allow for quick access

to the power cord.

Turn the lower cord hook upward and you can quickly

drop the power cord to the oor without unwinding it

from the cord hooks.

When storing the vacuum cleaner, turn the lower cord

hook to the downward position and wind the power

cord clockwise around the top and bottom cord hooks.

Fasten the plug to the wrapped cord using the channel

on the plug.

6

OPERATION

WARNING: Fully assemble before operating. This vacuum is intended for household use only.

Reclining the Handle

Press the handle release pedal located on the back of the vacuum

with your foot to recline the handle (Fig. 1).

On/Off Switch

The power switch located on the vacuum handle, is a three-way

switch (Fig. 2). The middle position (O) is the “Off” setting, the rear

position (I) is the “On” setting and the forward position (II) is for

“Maximum Power” (Fig. 3).

Use the “Maximum Power” setting (II) for carpet cleaning. Use the

“On” setting (I) for cleaning bare oors and throw rugs. Always turn

the vacuum cleaner to the “Off” setting (O) before unplugging it

from the electrical outlet.

Edge Cleaning

The edge cleaning feature provides improved cleaning near walls

and stationary furniture. For maximum edge cleaning, place the left

side of the nozzle, from the user’s perspective, against the wall or

stationary furniture.

Automatic Carpet Height Adjustment

Your vacuum is designed with an automatic self-adjusting nozzle.

No manual adjustments are required. The height of the nozzle

automatically adjusts to the ooring surface. This self-adjusting

feature allows the nozzle to oat evenly over all ooring surfaces.

Bare Floor Cleaning

Your vacuum is equipped with a squeegee on the bottom of the

vacuum to improve its effectiveness in cleaning bare oors (Fig. 4).

When cleaning tile, hardwood, vinyl, etc., use the “On” setting (I) for

best results.

7

MAINTENANCE & CARE

Power Cord Care

NOTE: If the cord or plug has any apparent damage, refrain from

using the vacuum. Please visit your nearest authorized Aerus

location or call Aerus Customer Service at 800.243.9078 (U.S)

and 800.668.0763 (Canada) to obtain a new cord or plug.

• When the vacuum is in use, hold the cord behind you with

the opposite hand to keep from running over it.

• Avoid obstructions and do not pull the cord around sharp

edges or corners.

• Always keep the cord away from heated surfaces and

never close doors on it as this may damage the wiring.

• To unplug, always grasp the plug, not the cord.

Vacuuming Under Furniture

Your vacuum will lay at on the oor for effective cleaning under

beds and tables.

1. Press the handle release pedal once for normal vacuum

cleaning (Fig. 1).

2. Continue to lower the handle to enable the vacuum to lay

at on the oor (Fig. 2).

8

MAINTENANCE & CARE

Replacing the Vacuum Bag

NOTE: Unplug the vacuum cleaner from the electrical

outlet before changing the bag.

1. Unzip the outer bag compartment.

2. Remove the used vacuum bag by pulling the

green bag collar tab away from the vacuum

(Fig. 1). Slide the used bag out of the bag holder

which automatically seals the bag opening

(Fig. 2). Discard the used bag.

3. To install a new bag, slide the bottom of the

green bag collar into the bag holder until it

“snaps” into place (Fig. 3).

4. Push the top of the bag collar upward until the

collar “snaps” into place on the vacuum (Fig. 4).

5. Tuck the bag corners into the bag compartment

then zip the bag compartment closed.

9

MAINTENANCE & CARE

Removing / Reinstalling the Bottom Plate

WARNING! To reduce the risk of electrical shock or injury from

moving parts, unplug before servicing or cleaning.

To remove the bottom plate:

1. Press the handle release pedal to place the vacuum cleaner in

the at position.

2. Turn the vacuum cleaner over, exposing the bottom plate.

3. Turn the two screws a quarter turn to release the bottom plate

(Fig. 1). Remove the bottom plate.

4. Reinstall the bottom plate by aligning the front edge of the

bottom plate into the notches inside the nozzle housing (Fig. 2).

5. Press the bottom plate into position until the plate “clicks” on

both sides. Tighten the two screws a quarter turn to secure the

bottom plate.

Replacing the Agitator Belt

WARNING! To reduce the risk of electrical shock or injury from

moving parts, unplug before servicing or cleaning.

NOTE: To ensure maximum cleaning efciency, the belt should be

checked regularly to be sure it is in good condition. Check to see if

the belt is stretched, cracked, or if excessive slipping is occurring.

Replace if needed with service #49831.

1. Remove the bottom plate.

2. Remove the brushroll and the worn or broken belt from the

brushroll pulley and the motor drive shaft (Fig. 1).

3. Loop the new belt around the motor drive shaft and the

brushroll (Fig. 2).

4. Reinstall the brushroll into the housing. Turn the brushroll by

hand, making sure the belt is not twisted and all rotating parts

move smoothly.

5. Reinstall the bottom plate.

10

MAINTENANCE & CARE

Resetting the Circuit Breaker

WARNING! To reduce the risk of electrical shock or injury from

moving parts, unplug before servicing or cleaning.

Your vacuum features a circuit breaker to protect the machine

against damage due to a surge in the electrical current.

Electrical surging can be a result of, though not limited to, a

jammed motor fan.

1. Should your vacuum cleaner experience a jammed

brushroll with the circuit breaker tripping, rst turn the

vacuum off and unplug the unit.

2. Inspect the brushroll by removing the bottom plate and

remove any debris that may be causing the jam.

3. Reinstall the bottom plate and reset the circuit breaker by

pressing the Circuit Breaker Reset Button.

4. Plug in the power cord and turn on the vacuum. If

the vacuum fails to turn on, visit an authorized Aerus

location for assistance or call Aerus Customer Service at

800.243.9078 (U.S) and 800.668.0763 (Canada).

Replacing the Squeegee

If your squeegee splits or begins to look worn, simply slide

the worn squeegee from its track and slide a new one into the

track (service #49832). If you have trouble installing the new

squeegee, please visit your nearest authorized Aerus location

or call Aerus Customer Service at 800.243.9078 (U.S) and

800.668.0763 (Canada).

Annual Checkup

To keep your vacuum in peak operating condition, it is

recommended you bring it to an authorized Aerus location for

an annual checkup. The Service Representative will conduct a

comprehensive examination to ensure your vacuum is in top

operating condition.

11

TROUBLESHOOTING GUIDE

WARNING! To reduce the risk of electrical shock or injury from moving parts, unplug before servicing or cleaning.

CAUTION! To reduce the risk of electrical shock, do not handle plug or appliance with wet hands.

ANY OTHER SERVICING SHOULD BE DONE BY AN AUTHORIZED AERUS SERVICE REPRESENTATIVE.

In the event that further assistance is required, visit your nearest authorized Aerus location or call Aerus Customer
Service at 800.243.9078 (U.S) and 800.668.0763 (Canada). The service parts used in this vacuum are easily replaced
and readily available from an authorized Aerus Franchisee. Always identify your cleaner by the model number and
serial number when requesting information or ordering replacement parts. (The model and serial number appear on
the rear of the cleaner.)

PROBLEM POSSIBLE REASON POSSIBLE SOLUTION

Vacuum won’t
turn on

Power cord not rmly plugged in.
Blown fuse.
Tripped breaker.
Needs service.

Plug cord in rmly.
Check house fuse or breaker.
Replace fuse/reset breaker.
Contact nearest Aerus location for service.

Cleaner won’t
pick-up or
low suction

Filter bag not installed properly.
Filter bag is full.
Broken or worn brushroll.
Broken or worn belt.

Install bag properly.
Replace lter bag.
Replace belt.
Replace brushroll.

Dust escaping
from vacuum

Filter bag not installed properly.
Filter bag is full.

Install bag properly.
Replace lter bag.

MAINTENANCE & CARE

Key Replacement Parts

For your convenience, your Lite by Aerus vacuum was shipped with (1) replacement Bag and (1) replacement Belt.

Genuine Lite by Aerus Home Solutions HEPA Media Vacuum Bags: Service #49827 (6-pack)

Genuine Lite by Aerus Vacuum Belts: Service #49831

Genuine Lite by Aerus Squeegee: Service #49832

For Best Performance

• Keep your vacuum clean and in good operating condition.

• Change the vacuum bag once a month or when the bag is 2/3 full to maximize cleaning performance.

• Always use genuine Aerus vacuum bags and replacement parts. Use of other products may result in poor
cleaning performance, potential vacuum cleaner damage, and may void the warranty. Genuine products are
designed for maximum cleaning performance.

• Have your vacuum checked annually.

• Store your vacuum carefully in a dry area.

• For optimum cleaning performance and safety, follow the instructions in this manual.

12

LIMITED 5 YEAR WARRANTY

WHAT IS COVERED BY THIS WARRANTY - Aerus warrants its products to the consumer subject to the conditions

below, against defects in workmanship or material, provided that the products are returned to an Aerus location within

the following time period:

• Motor and fan unit - within 5 years of initial date of purchase of the Lite by Aerus vacuum cleaner.

• All other defects in workmanship and materials – within 1 year of initial date of purchase of the Lite by Aerus

vacuum cleaner.

HOW TO OBTAIN WARRANTY SERVICE - Upon contacting and returning, at consumer’s sole cost and expense, the

product with proof of purchase (including purchase date) to an Aerus location within the above time period, Aerus will

repair or replace and return the product, without charge and within a reasonable period of time, if its examination

discloses any part to be defective in workmanship or material. If Aerus is unable to repair the product after a

reasonable number of attempts, Aerus will provide either a refund of the purchase price or a replacement unit, at the

company’s option.

WHAT IS NOT COVERED BY THIS WARRANTY - This product is intended for household use only. Ordinary wear and

tear shall not be considered a defect in workmanship or material. These warranties do not apply for loss or damage

caused by accident, re, abuse, misuse, modication, misapplication, commercial use, or by any repairs other than

those provided by an authorized Aerus Service Center. The warranty with respect to the motor and fan unit is null and

void if it is damaged as a result of vacuuming damp or wet surfaces, or dirt leakage through a lter bag other than an

Aerus lter bag.

EXCLUSION OF OTHER WARRANTIES AND CONDITIONS - EXCEPT AS PROVIDED HEREIN, AERUS MAKES NO

REPRESENTATION OR WARRANTY OF ANY KIND. ALL OTHER WARRANTIES OF ANY KIND, EXPRESS OR IMPLIED, ARE

HEREBY EXPRESSLY DISCLAIMED, INCLUDING ANY IMPLIED WARRANTY OF MERCHANTABILITY OR FITNESS FOR A

PARTICULAR PURPOSE.

LIMITATION OF LIABILITY FOR SPECIAL, INCIDENTAL, OR CONSEQUENTIAL DAMAGES - AERUS SHALL NOT IN ANY

CASE BE LIABLE FOR SPECIAL, INCIDENTAL, OR CONSEQUENTIAL DAMAGES ARISING FROM BREACH OF EXPRESS OR

IMPLIED WARRANTIES, CONDITIONS, GUARANTEES OR REPRESENTATIONS, BREACH OF CONTRACT, NEGLIGENCE, OR

ANY OTHER LEGAL THEORY. Such excluded damages include, but are not limited to, loss of prots or revenue and loss

of the use of the products.

FOR U.S. APPLICATION ONLY - This warranty gives you specic legal rights, and you may also have other rights which

vary from state to state. Some states do not allow limitations on warranties, or on remedies for breach. In such states,

the above limitations may not apply to you.

FOR CANADIAN APPLICATION ONLY - Exclusion of Subsequent Owners: Except as otherwise required by applicable

legislation, this warranty is not transferable. This warranty gives you specic legal rights and you may also have other

rights which vary from province to province. Some provinces and territories do not allow limitations on warranties, or

on remedies for breach. In such provinces or territories, the above limitations may not apply to you.

If any provision of this warranty or part thereof is held by a court of competent jurisdiction to be invalid, illegal or

unenforceable, the validity, legality, and enforceability of the remaining provisions or parts thereof will not in any way

be affected or impaired within the jurisdiction of that court. This entire warranty shall continue to be valid, legal, and

enforceable in any jurisdiction where a similar determination has not been made.

AERUS CUSTOMER SERVICE: 800.243.9078 (U.S) / 800.668.0763 (CANADA)