A-dec 551 User manual

-DEC

500"

Owner's

Guide

MODEL

ASSISTANT

551

S

INSTRUMENTATION

A-dec

500

Assistant's

Quick

A-dec's About Assistant's Instrumentation

Left-Right Conversion Autoclavable and

Autoclavable and Asepsis

A

Saliva

Rights

À.

the

of

the

HVE

Ejector

HVE

Ejector

Reserved.

ejector.

assistant's

disconnect

The converted To opposite-hand out small 180°,

The

Step|

T | NOTE:

2 | the

4 | detergent,

5

6 | CAUTION:

7 | Reinstall 8

A-dec

Inc.

standard

Optional

vacuum

attachments

HVE

and

for

convert

of

the

HVE

diameter

then

press

table

shows

Action

Remove

To

remove

tubing

control Clean

and

instrumenis Heat

sterilize

either

of

[135°C]

Apply a light

the

control

Operate

that

they

aídec

Start

assistant's

instruments

that

saliva

ejector

opposite-hand

HVE

or

use,

push

body,

side.

Rotate

it

back

the

tip

Turn

off

saliva

ejector.

the

by

pullingit

valve.

rinse water,

to

the

these

maximum

coat

valve.

Use

instrumentation permanent

.the

control

the

HVE

rotate

can

saliva

the

by

pressing

the

into

steps

for

from

the

central

HVE

or

the

valve

and

dry

completely.

valve

methods:

temperature).

of

A-dec

only

valve

and

smoothly.

package

remove

operation.

ejector

control

place.

saliva ejector

the

silicone

the

Instrumentation

Guide

may

include

are

fully

be

easily

on

control

HVE

and

valve

vacuum

apart

body

brushes

body

and

steam

silicone

O-rings.

damage

in

the

saliva

includes

easily

for

valve

the

valve

body.

at

the

and

autoclave,

lubricant

to

valve

ejector

syringe,

an

additional

autoclavable

for

cleaning.

1 - Cannula 2 - Valve 3 - Control

saliva

ejector

before

body,

tailpiece,

control

that

control

lubricant

the

disconnecting

separate

and

valve

have

been

valve

or

chemical

on

©

when

lubricating

Petroleum

O-rings.

body,

and

valves

HVE,

HVE.

and

body;

valve; 4 -

asepsis.

removing

using a mild

provide.

for

six

the

products

the

several

2003-12

and

saliva

The

have

quick

_

opening

the

vapor

O-ring

tubing

(for

tip);

Tailpiece

the

HVE

body

from

the

Allow

minutes

will

times

Rev. A (04123.13)

the

using

(275°F

seals

of

cause

tailpiece.

to

verify

86.0603.00

or

sê

Sterilizing

HVE

Tip

the

It

is

recommended

sterilized

autoclave,

minutes replace

The

Step | Action

NOTE:

between

or

at

temperature).

them

table

shows

1 | Remove

>

Clean then

3 | Sterilize

A-dec

Standard

A-dec

If

not

your

adec’

that

patients

chemical

with

new

the

steps

the

and

rinse

allow

the

HVE

Cannula

A-dec

15

mm

using

A-dec

HVE

cannula

the

stainless

using

vapor

(275°F

If

you

tips

between

for

sterilizing

HVE

tip

the

HVE

tip

to

HVE

tip

HVE — 0.435" + 0.006"

HVE - .592"

HVE

opening.

steel

either

of

[135°C]

are

using

patients.

the

from

the

HVE

tip

using a mild

completely

using

one

Opening:

(14.8

mm).

tips,

select a tip

tips

used

the

following

maximum

disposable

HVE

tip.

valve

dry.

of

the

recommended

(11.05 + 0.15

that

on

the

HVE

methods:

temperature;

HVE

tips,

body. detergent

mm).

is

compatible

be

heat

steam

four

be

sure

and

water,

methods.

with

to

A-dec

500

Assistant’s

Owner’s

Instrumentation

Guide

Solids

Collector

Limit

Switch

Rights

Reserved.

A-dec

The

solids vacuum collector vacuum,

The

table

Step | Action

1

3 | Insert a new

Inc.

If

activated,

motion

A-dec

Saliva

A-dec

Saliva Select a tip cannula

system.

screen.

and

Turn facilitate

Remove

disposable.

CAUTION:

and

opening.

collector

At

This

to

maintain

shows

off

,

the

reverse

the

vacuum,

removal

the

support

Ejector

Ejector — 0.265 + 0.006"

that

aids least

is

steps

screen

Discard

Do

could

screen

the

Cannula

is

compatible

in

preventing

twice a week,

necessary

proper

for

if of

from

not

plug

link

chair

to

treatment

sterilizing

vacuum

the

solids

the

following

empty

in

the

solids

limit

to

prevent

the

switch

Opening:

with

solids

discard

ensure

the

is

on,

，

collector

collector.

your

screen

drain.

collector

(6.73 + 0.15

your

from

proper

room

HVE

open

cap.

The

local

into

will

interrupt

damage.

mm)

saliva

ejector

entering

and

replace

suction

asepsis. tip.

the

HVE

solids

regulations.

your

and

the

from

control

collector

cuspidor.

install the

the

base

2003-12

central

the

solids

the

central

valve

to

screen

Doing

cap.

is

so

down

86.0603.00

Rev. A (04123.13)

Я

Copyright

2601

Crestview

Printed

A-dec not shall concerning subject in

All

service

in

Inc.

limited

not

to

writing.

other

marks,

Trademarks

A-dec

500, Preference, Trademark

A-dec,

www.a-dec.com

A-dec

Drive,

USA.

makes

to,

the

be

held

the

furnishing,

change

A-dec

non

A-dec

or

A-dec

Preference

office.

500

A-dec

Newberg,

no

warranty

implied

liable

for

without

Inc.

does

products

product

logo,

Cascade,

Collection,

and

ICX

Inc.

All

Rights

OR

of

any warranties any

errors

performance,

notice.

names

not

are

or

also

If

warrant

services

designated

Cascade

and

trademarks

Reserved.

97132

USA

kind

with

of

merchantability

contained

or

use

you

find

any

that

this

mentioned

by

Master

Radius

are

regard

herein

of

this

problems

document

in

the

companies

Series,

A-dec

of

A-dec

to

the

content

and

fitness

or

any

consequential

material.

this

Century

trademarks

Inc.

The

with

is

error-free.

document

marketing

of

this

for a particular

information

this

document,

are

covered

those

Plus,

Continental,

registered

document,

purpose.

or

other

damages

in

this

please

by

the

products.

Decade,

in

the

including

A-dec

document

report

them

trademarks,

Performer,

U.S.

Patent

but

Inc.

is

to

and

us

A-dec

500

Assistant's

Instrumentation

Warranty

§

2601

Use

this

box

to

log

your

equipment

information.

Warranty

Serial

=.

a

number

Model

Date

A-dec” material

delivery.

warranty

option, ing labor).

(All

are Written

to does

installation

warranty use chemicals not provided maintenance

A-dec lift

of retroactive field. finds

Stool

warranty.

No

otherwise

number

purchased

warrants

or

A-dec's

is

to

provide

The

special,

excluded.)

notice

A-dec

within

not

cover

does

of

cleaning,

and

cover

light in

warrants

and

tilt,

the

chair

The

warranty

to

have

cylinders

other

warranties

are

all

workmanship

to

provide

buyer

incidental,

of

the

damage

or

maintenance,

not

disinfecting

processes.

bulbs.

A-dec's

instructions)

A-dec

for

ten

or

the

to

A-dec

manufacturing

are

made.

Information

products

sole

obligation

parts

the

replacement

shall

and

breach

of

warranty

resulting

cover

damage

The

Failure

Owner's

dental

years

from

cylinder.

chair

covers

covered

as

to

against

for

one

for

have

coincidental

warranty

period.

accident

or

warranty

to

Guide

may

chair

the

This

cylinders

chair

merchantability

defects

year

from

under

the

repair,

product

no

other

remedy.

damages

must

The

warranty

from

improper

or

misuse.

resulting

sterilization

also

follow

void

instructions (operation the

warranty.

cylinders,

date

of

purchase

warranty

already

cylinders

irregularities.

A-dec's

in

time

of

or

at

its

(exclud-

be

given

The

from

the

does

and

both

is

in

the

A-dec

one-year

or

AT

1 - Model

number manufactured; indicates

CAUTION:

atde

oa

S

/

>

PATS.

PENDING

C €

0086

し

LABEL

Serial

indicates

the

A | January

Number

number; 2 -

(e.g., B is

year

B | February | H | August

C | March

D | April

E | May

F | June

Federal

to

sale physician licensed which

‘

order

CRESTVIEW

NEWBERG,

REF:

N:<B42828

MADE

IN

USA

DENTAL

12CJ

©

J

P/N:

051.709.00

The

the

month

of

manufacture

law

by

or or

by

the

he

or

the

use

DRIVE

OREGON

97132

USA

GIP

‘ov

100V~

10

AMPS

CHAIR

Identification

February); 3 -

restricts

on any

she

SSIE,

OX

^

c

UL2601-1

C22.2

NO.

601.1

REV

2

first

letter

the

product

(e.g., 4 is

G | July

| | September

J | October

K | November

L | December

this

the

order

other

practitioner

law

of

the

practices

of

the

device.

|

©

ο

MAX

US

)

of

the

serial

was

First

digit

2004).

device

of a dentist,

state

in

to

use

or

For service Check

this

86.0603.00

я.

information

with

local

product.

。

codes

contact

and

your

ADA

local

authorized

(Americans

|

A-dec

with

Disabilities

A

al

dec

dealer.

e

Act)

requirements

for

installation

tor

of

~

개

“ee

c

US

LISTED

Classification

Types

CLASS | EQUIPMENT (Dental

CLASS (Chair,

Degree

TYPE B APPLIED

Degree ORDINARY

Mode

CONTINUOUS

Chairs)

Mode

CONTINUOUS (Dental

SRE

(UL)

KOL)

us

UL

2601-1

-

6011

of

shock

protection:

Chairs,

Dental

IT

EQUIPMENT

Wall, & Cart-Mounted

of

shock

PART

of

protection

EQUIPMENT

of

operation:

OPERATION

5%

Duty

Cycle

of

operation:

OPERATION

Chairs)

of

Eguipment

Lights, & Power

protection:

(Delivery

against

(All

WITH

Identification

Recognized

Inc.®

with respect

and

mechanical

dance

with

respect

to

and

other

dance

with

UL

listed

(CAN/CSA

safety

Classified

Inc.

and

dance

respect and dance

to

standards

by

with

respect

mechanical

with

to

other

with

(EN

60601-1)

Supplies)

Delivery

water

products)

Systems)

Systems

ingress:

models

except

INTERMITTENT

Only)

by

Underwriters

to

hazards

UL

2601-1.

electric

shock,

specified

CAN/CSA

US

(UL

C22.2,

electric specified

544)

No.

Underwriters

to

hazards

UL

2601-1.

shock,

CAN/CSA

Dental

LOADING

Laboratories

electric

shock,

only

Recognized

fire,

hazards

electric

hazards

only

C22.2,

No.

and

Canadian

125)

Laboratories

shock,

only

Classified

fire,

only

C22.2,

No.

A-dec

of

Symbols

fire

in

accor-

with

mechanical

in

601.1

|

fire

in

accor-

with

mechanical

in

601.1

accor-

:

accor-

Environmental

Storage

Operating

Electromagnetic

This

equipment

with

the These protection medical you

Flammable

Not anesthetic

limits

installation.

have

any

suitable

500

Assistant’s

С

€

©

o

=

A

e

x

Г]

Temperature:

Relative Temperature:

Relative

has

for

medical

are

designed

against

mixture

harmful

questions.

Gasses

for

use

with

Instrumentation

Conforms

Directives Declaration

Protective

Functional

Attention, accompanying

Type B applied

Class

II

-40°C

Humidity:

Compatibility

been

Contact A-dec

in

the

air,

(-40°F 95%

10°C (50°F 95%

tested

and

devices

to

in

provide

interference

Customer

presence

oxygen,

to

European

(refer

to

Statement)

earth

(ground)

earth

(ground)

.

consult

documents

|

part

equipment

to

70°C

to

158°F)

maximum to

40°C

to

104°F)

maximum

found

to

EN60601-1-2.

reasonable

of a flammable

or

comply

in a typical

Service

nitrous

oxide.

if

A-dec

500

Assistant's

Instrumentation

Table

Welcome

Intended

About

Conventions

How

About

How

to

On/OffSwithh Instruments

How

to LimitSwitches How

to

Short

Long HolderAssembiy

AdjustableHolderss Оиа! ElectricHolders Assistant's

ГеН/

How

to

ManualChairControls

Program

Position O (Entry

Positionsland2...............................

Position

Cup

Bowl AT/A2

Light

Care

_InmnstrucHong

Touch Heat

Specificatlons

Audience

TIhis

Document

........................................,.....

to

Use

This

Guide

Your

Assistant's

Operate

Maintain

Position

Assistant's

Но4ег

Е1эТЕ

Operate

Fill

Rinse

and

Sterilization. , eee

Your

......................

eee

the

.......................

Your

Arm

АззетЬПез

..........................

Touchpad

Сопуег10п

Your

Button

3

Buttons

.......................

/Exit)

.......

,,

Transfer

.................

..

ân

Instrumentation

Assistant's

Sohiids

Assistant's

.....................

................

..............................

...................................

........

.......

Standard

..................................

...................

Surfaces

Instrumentation

Collector

Instrumentation

Touchpad

..

нение

.........................................

ea

иен

of

Contents

eee

e

eee

erra

due

eee

aaa

eue

eee

a

eee

eee.

................................

ων

eee

ee

een

eee

ea

................................

ce

cette

еее

нии

иначе

неа

ερ

ρω

εν

ини

н 요 ㅇ 요 요 이 ㅇ 교 요 ㅇ 교 ㅇ 교

ον

νοκ

ρω

요요

요요 교 요 요

εννοω ε ερ

eee

ーーー κ κ

tent e ees

요요 이 요 요 요 이

ον

νε

νε ρε ο νο

renerne

K

еек

이 이

νο

이 이

ων

an

이 이 이

ων

................................,......

.....8

υἷυἶἷ

ea

eee

esse

K

ине

e

died

idée

R

eee

eee ο ρε

K

reen

rrenee

„8

нанени

εν

rere

erere

nenee

rnvsree

eee

ον

.

ον

10 11

11 11

11

1

1 1 1

1

2

2 3

5 5 6

6

6 6

7 7 7 7

7

8

9

9 9

NE

dec

®

86.0603.00

i'dec

する

Table 1 — Tabple2-

Figure 1 — Figure2- Figure 3 — Figure 4 — Figure 5 — Figure 6 —

Figure

7ーFHunctions

Steps

for

HVE

and

9teps

for

Sterilizing

Parts

of

the

Assistant’s

Solids

Collector Left/Right-Hand Removing Rotation Positioning

the

of

the

Individual

ot

Standard

Saliva

theHVETIip

Conversion

Solids

Collector

Holder

Tables

Ejector

Asepsis

rr

Illustrations

Instrumentation

ее

of

the

Autoclavable

Screen Assembly Holders

Touchpad

............................................

....................................,.........

A-dec

....................,..................

.....................,..................

нина

нии

HVE

500

Assistant's

ини

and

Saliva

е

нии

Ejector

cence

Instrumentation

4 4

2

тененни я 2

.........

tenes

ων

3 6 6

8

7

A-dec

About

Welcome Welcome

source

Intended

This A-dec

About

This

500

this

to

of

technical

Audience

guide

is

500

assistant’s

this

document

* * . .

Assistant’s

the

intended

Document

contains

Conventions

Instrumentation

Document

A-dec

500

Assistant’s

information

for

doctors

instrumentation.

instructions maintenance

detail

product

on

the

specifications.

Instrumentation

for

servicing

and

dental

left/right procedures functions

of

and

maintaining

staff

to

conversion

for

the

solid

the

touchpad,

Owner's

use

when

of a HVE

collector

and

Guide.

This

your

assistant’s

operating

and

saliva

About

guide

and

ejector

This

provides

instrumentation.

maintaining

Document

an

easy

to

use

A

number

designed

e

¢

How

This assistant’s feel

for

and.

of

to

References Delivery

Important

NOTE:

Bubble

to

Use

guide

provides

instrumentation.

the

warnings.

items

and

instructions

make

it

quick

to

sections,

System.

supplemental

The

foot

numbers,

this

capabilities

callouts,

Guide

detailed

of

and

easy

or

reference

information

control

also

and

descriptions

Before

the

assistant’s

appear

to

using

throughout

find

and

documentation

about

has....

tables

identify

and

the

assistant’s

instrumentation

this

understand

the

covered

key

operation

instrumentation,

document.

information.

appear

components

instructions

and

in

topic

its

to

italic

appears

operation.

The

formatting

type,

as a note,

in

an

illustration.

for

the

use

review

e.g.,

of

the

this

Make

conventions

How

to

Operate

e.g.,

A-dec

document

note

of

500

to

all

cautions

are

the

get

a

vi

adec

86.0603.00

ο

σα

$e

Page

1

Operation

A-dec

500

Assistant's

Instrumentation

A-dec

500

Assistant's

Instrumentation

Operation

|

About

Your

Assistant’s

Instrumentation

A-dec’s package saliva additional

the

The

autoclavable attachments

How

standard

includes

ejector.

assistant’s

Optional

HVE.

instrumentation,

instrumentation

vacuum

and

that

to

Operate

assistant’s autoclavable

The

solids

have

are

easily

Instrumentation

On/Off

There

assistant's

button

On/Off

Power

Switch

are

two

power

instrumentation,

on

the

chair

toggle.

On/Off

Button

and

instrumentation.

syringe,

instruments

collector

located

arm.

instruments

quick

disconnect

removed

Your

source

locations

the

delivery

Power

HVE,

and

may

include

is

also a part

at

the

are

fully

for

cleaning.

end

an

of

Assistant’s

for

the

On/Off

system

master

Figure 1 Parts

of

the

Instrumentation.

Assistant's

Instruments

Autoclavable

For

information maintenance to

your

Autoclavable

(P/N

85.0680.00).

Autoclavable

The

autoclavable equipped valve

body

autoclaving.

Left/Right-Hand

Autoclavable

The

HVE for

operation

To

convert

the

other,

body,

by Rotate into

the

place.

Syringe

on

of

A-dec's

HVE

with a quick

from

the

HVE

and

saliva

from

the

HVE

push

the

pressing

control

the

operation,

autoclavable

Syringe

tubing

Conversion

ejector

either

or

control on valve

Owner's

and

Saliva

and

saliva

disconnect

for

and

Saliva

can

side

saliva

valve

the

small

180°,

care,

syringe,

Guide

Ejector

ejector

to

remove

cleaning

of

the

Ejector

be

easily

of

the

chair.

ejector

then

to

out

of

diameter

push

and

refer

are

the

and

converted

one

side

the

HVE

side.

it

back

Figure 3 Left/Right-Hand

the

Autoclavable

Saliva

1 - Cannula

or 3 -

Control

opening

valve; 4 -

Ejector

(for

tip); 2 -Valve

Tailpiece

Conversion

HVE

and

body;

of

The

Power

of

the

chair. power the in, the

Delivery

The

side

delivery

to

CAUTION:

Page

or

touch

the

system

master

of

the

chair.

2

disengage

system

On/Off

This

of a button.

has

System

On/Off

control

For

turn

button

function

power

has

power.

no

power.

Master

toggle,

head,

as

well

prolonged

power

is

allows

to

When

located

controls

as

other

life

OFF

located

you

the

entire

the

button

the

On/Off

the

modules

of

your

when

on

the

to

engage

system

is

pressed

button

Toggle

on

the

right

utilities

mounted 5 -

equipment,

not

in

use.

_

base

at

is

out,

for

the

dec

Figure

1 - Autoclavable

>"

2.

Solids

Autoclavable

Touchpad; 6 -

HVE; 2 -

saliva

Collector.

ejector; 4 -

Solids

collector

Autoclavable

syringe;

Holder

assembly;

86.0603.00

|

86.0603.00

À.

a

dec

Page

3

Operation

A-dec

500

Assistant's

Instrumentation

A-dec

500

Assistant’s

Instrumentation

Solids

Collector

Autoclavable

The

table

shows

Step

How

It is

either

ture; new

The

|Action

1

Remove

NOTE:

>

To

remove

at

the

3.

[Remove

A

Clean

that

have

5

Heat

sterilize

methods:

Apply a light

6

|CAUTION:

7

|Reinstall

8

|Operate

to

Sterilize

recommended

of

the

following

four

minutes

tips

between

table

shows

HVE

and

the

steps

Table 1 Steps

the

tip

from

Turn

OFF

the

HVE

tailpiece.

the

control

and

rinse

the

been

provided.

the

steam

autoclave,

coat

Use

only

Petroleum

the

control

the

HVE

the

HVE

that

the

methods:

at

temperature).

patients.

the

steps

Saliva

for

HVE

the

central

or

saliva

valve

body

of

A-dec

silicone

products

valve

and

the

Tip

stainless

steam

for

sterilizing

Ejector

and

saliva

valve

body.

vacuum

ejector

by

pushing

body

and

Allow

and

or

chemical

silicone

lubricant

in

the

saliva

steel

autoclave,

If

you

Asepsis

ejector

for

HVE

before

body,

it

out

control

the

instruments

control

vapor

lubricant

when

will

cause

valve

body,

ejector

the

tips

are

HVE

valves

used

using

asepsis.

and

Saliva

disconnecting

separate

of

the

HVE

valve

using a mild

to

valve

for 6 minutes

(275°F

on

the

lubricating

permanent

and

the

several

on

the

HVE

or

chemical

disposable

tip.

Ejector

the

body:

or

dry

completely.

[135°C]

O-ring

damage

body

times

be

vapor

HVE

Asepsis

the

HVE

from

saliva

detergent,

using

maximum

seals

instrumentation

to

on

the

to

verify

heat

sterilized

(275°F

tips,

or

saliva

the

tubing

ejector

of

valve

either

temperature).

the

control

the

O-rings.

tubing

that

[135°C]

be

sure

ejector.

by

pulling

body.

water,

of

O-rings.

tailpiece.

they

between

to

and

the

following

valve.

rotate

maximum

replace

patients

them

it

apart

the

brushes

smoothly.

using

tempera-

with

How

The entering

At collector

suction

proper

screens, reference

to

Maintain

solids

collector

the

least

twice a week,

screen.

from

treatment

contact

Pinnacle

Follow

these | To

steps...

3

central

This

the

central

room

your

P/N

the

Solids

aids

in

preventing

vacuum

is

Authorized

system.

discard

and

necessary

vacuum,

asepsis.

5512.

For

perform

function...

Turn

off

vacuum,

is

on,

open

the

valve

to

facilitate

the

solids

collector

Remove

collector.

The

disposable.

your

CAUTION:

Insert a new solids

the

solids

local

collector

cap.

screen

collector

Discard

regulations.

Do

screen

cuspidor. Doing plug

Collector

solids

replace

to

and

A-dec

the

ensure

to

maintain

replacement

Dealer

this

or

if

vacuum

HVE

control

removal

cap.

from

screen following

not

empty

into

so

could

the

drain.

screen

and

in

the

install

from

solids

proper

and

of

the

is

the

your

Figure 4 Removing

1 - Solids

Collector

collector

the

Screen.

screen

Solids

Step

1

>

3

NOTE:

Page

4

|Action [Remove

Clean completely

|Sterilize

A-dec 15

your A-dec

Select a tip

the

and

the

HVE

mm

HVE — .592"

HVE

Saliva

HVE

rinse

the

dry.

HVE

Cannula

cannula

Ejector

that

is

Table 2 Steps

tip

from

the

HVE

tip

using

one

Opening:

(14.8

mm).

opening.

Cannula

compatible

for

HVE

valve

using a mild

of

the

recommended

Standard

If

not

using

Opening:

with

your

a

Sterilizing

body.

detergent

A-dec

HVE — 0.435" + 0.006"

A-dec

HVE

A-dec

Saliva

saliva

ejector

dec

the

HVE

Tip

and

water,

methods.

Tips,

Ejector — 0.265 + 0.006"

cannula

then

allow

(11.05 + 0.15

select a tip

opening.

the

that

is

(6.73 + 0.15

tip

to

mm).

compatible

86.0603.00

A-dec

with

mm)

Limit

If interrupt chair

Switch

activated,

the

to

prevent

the

base

86.0603.00

a,

support

down

damage.

link

limit

motion

switch

and

will

reverse

ide

the

Page

5

Positioning

How

to

Position

Instrumentation

The

A-dec equipped for

easy

are

equipped assemblies positioning.

Short

The cuspidor

forward,

easy

A

pivot allows minimize to

an

The way of

operation.

reset

Long

The

the

short

headrest.

variable

Holder

The

positioning

500

assistant’s

with

either a short

positioning

with a touchpad

with

Assistant’s

short

assistant’s

or

along

backward,

positioning

joint

located

the

entire

damage

object.

arm

segment,

downward

Simply

and

continue

Assistant's

long

assistant’s

arm,

and

In

addition,

height

adjustment

Assembly

holder

assembly

to

suit

individual

side

and

arm

to

attached

if

forced

Your

instrumentation

or

long

of

instrumentation.

and

holders

Arm

arm

positions

the

chair

back.

and

side-to-side

access

to

the

close

to

the

to

“tip-up,”

the

equipment

to

the

beyond

lift

the

arm

operation.

Arm

arm

has

the

can

be

positioned

this

arm

accommodates

for

multiple

rotates

most

completely

procedures

Assistant's

is

assistant’s

Both

holder

for

added

near

the

It

adjusts

movement

instrumentation.

support

if

forced,

if

lowered

touchpad,

its

normal

back

into

same

features

closer

users.

for

(see

arms

link,

to

gives

range

place

to

the

Figure

arm

in

for

on

as

5).

A-dec

a

Figure 5 Rotation

to

500

Assistant's

of

Instrumentation

the

Holder

Assembly.

A-dec

500

Assistant’s

Adjustable

The

independently pivoted positioning assembly.

To from and

Dual

The team

saliva

holder

differentiate dental

Electric

The this activate

340

degrees

for

rotate

each

the

adjacent

release

(see

Holder

dual

holder

the

ability

ejector,

assembly

and

procedure.

Holders

optional functionality.

electric

automatically.

Assistant's

A

standard

The

touchpad

A-dec

relay

touchpad

module

Left/Right

Positioning amount the

support

place,

the

of

time.

link

reattach

Holders

adjustable

to

allow

each

instrument

holder,

pull

one,

Figure

twist

6).

Assemblies

assemblies

to

offset

or

and

HVE

placement.

helps

the

assistant

locate

the

holders

When

the

When

Touchpad

serves

also

provides a one

(a1,

a2).

Conversion

assistant’s

Loosen

back

the

support

instrumentation

the

cover,

Instrumentation

holders

customized

holder

to

the

option

alternate

instruments

provide

HVE

placed back

as a convenient

support

and

link

can

on

the

holder

slightly

desired

gives

the

syringe,

The

additional

to

comfortably

during

vacuum

or

saliva

touch

surface

link

reposition

cover,

and

be

away

position

dental

the

on/off

ejector

into

the

handle

to

the

locking

the

arm

tighten

Figure 6 Positioning

switching

is

lifted

holder,

rotating

for

controlling

opposite

screw

located

to

the

support

for

from

the

vacuum

340

degrees

the

side

of

the

under

opposite

link

users

whose

holder,

will

for

chair,

dental

chair

the

swivel

side.

Once

locking

Individual

vacuum

the

vacuum

be

turned

easy

access

light,

can

be

done

brake

the

instruments

screw

finger

Positioning

Holders.

system

pump

off.

and

in a minimal

handle,

tight.

requires

will

visibility.

cuspidor/

unsnap are

in

NOTE:

Page

6

If

you

have

assembly

electric

can

be

holders,

rotated

340

the

holder

degrees

only.

i

sa

dec

86.0603.00

Le

a

i

dec

θες

$

#4

|

Раде

7

Touchpad

A-dec

500

Assistant’s

Instrumentation

A-dec

500

Assistant’s

Instrumentation

|

Touchpad

How

Standard

Manual

The

movement. To down height,

The the chair button position,

Program

Use the chair rinse

Position 0 (Entry/Exit)

Pressing preset

Positions 1 and

Pressing

chair

Page

to

Operate

Chair

Base

function

To

lower

the

arrow

then

release

Back

function

chair

back, press

back,

press

until

the

then

Button

the

Program

arrows

Pressing

position

Entry/Exit

Position 1 or

Position

on positions times.

Entry/Exit

entry/exit

Position 1 or 2 on

base

and

this

(0)

3

8

Your

Touchpad

Controls

controls

raise

the

chair,

press

the

until

the

chair

it.

controls

the

right

the

left

arrow.

chair

back

release

the

2

it.

button

and

position.

back

|

located

touchpad

cuspidor

(Position

2

to a preset

Causes

Chair

base

me

preset

Chair

moves

. ，，

operating Chair

back

x-ray /rinse position.

chair

lift,

press

down

arrow.

reaches

the

chair

arrow.

Hold

reaches

to

the

this

the

in

between

save

the

cup

fill

0)

sends

touchpad

position.

action...

and

back

entry/exit

to a programmed

position.

moves

a

or

vertical

the

up

the

back.

To

lower

down

desired

settings

and

bowl

the

sends

move

position.

to

an

arrow.

Hold

desired

To

raise

the

for

chair

to

a

the

to

aldec

Figure 7 Functions

Touchpad.

Icon

Entry

Position

Position 3 (x-ray

Program

fooeeo |

Back

Base

Back

„|-|

Base

afdec

vi

Status

Cup

Bowl

Light

61616

on

the

Description

/exit

1

2

button

down

up

icon

fill

rinse

al

A-dec

Relay

a2

A-dec

Relay

Standard

/rinse)

Module

86.0603.00

Position

Position 3 is x-ray/rinse

position

Cup

The timed

Bowl

The timed

If

the

operation.

A1/A2 The

module,

NOTE:

86.0603.00

A.

3

can

Fill

cup

fill

operation,

Rinse

bowl

rinse

operation,

bowl

rinse

To

Buttons

a1/a2

buttons

contact

You installed. module

factory

position. À second

be

function

can

preset

to

changed

or

function

or

button

stop

your

only

You

and a cuspidor.

to a programmable

allows

hold

for a manual

provides

hold

for a manual

is

pressed

the

continuous

can

be

used

authorized

operate

must

an

water

an

upgrade

x-ray/rinse

press

on

to

flow

operation.

rinse

water

operation.

twice

bowl

rinse

to

operate

A-dec

dealer.

A-dec

relay

to a deluxe

에어

Lee

position.

the

button

position

from

in

less

an

A-dec

module

are

for

Pressing

returns

like 1 and

the

cuspidor

the

cuspidor

than

two

operation,

relay

with a standard

touchpad,

press

Position 3 moves

the

chair

2.

into a cup.

bowl.

seconds,

the

module.

if

you

"dec

back

Tap

it

will

bow]

For

touchpad

wish

Tap

the

be

rinse

more

to

the

back

to

the

operating

the

cup

fill

bowl

rinse

set

into a continuous

button

details

operate

once.

on

if a cuspidor

an

A-dec

to

position.

button

the

A-dec

an

for

relay

is

not

relay

This

a

때

kd

Touchpad

Dental

The light

A location medium composite

The dental automatically

NOTE:

How

There

dental

on

quick

dental

light

to

are

Light

light

or

off

press of

the

intensity

setting,

light

will

If

Position 3 has

turn

on/off

Disable Factory

two

button

from

on

dental

also come

when

on

the

touchpad

either

the

touchpad

the

button

settings

the

has

Position 0 (entry/exit)

when

allows

light’s

intensity

or

composite

indicator

an

auto

on

when

been

reprogrammed

Position 3 is

Preset

factory

preset

options

you

light

on/off

the

chair

works

or

the

to

toggle

switch.

and

high

to

the

feature.

reaches

or

Position 3 (x-ray/rinse)

to a programmable

pressed.

Functions

that

can

be

A-dec

as a three-way

dental

light.

between

dental

intensity

button

When

turned

flashes.

using a programmed

an

operating

on

three

light

settings.

or

500

switch

can

position.

off

allowing

intensity

be

toggled

When

is

position,

from

Assistant's

settings,

between

the

chair

The

dental

pressed.

the

standard

Instrumentation

you

to

turn

depending

composite

dental

light

position

light

dental

touchpad.

light

the

is

(1

will

dental

on

in

the

or

turn

not

the

and

2), off

the

A-dec

Care

Touch

during

touchpad(s),

Transfer inanimate

Continental”

A-dec must barrier

recommendations patient

For compromised, recommendations

500

Assistant's

Instructions

and

Transfer

surfaces

dental

recommends

be

FDA

film

treatment.

touch

are

procedures.

control

surfaces

objects.

instrument

market-cleared

is

suitable

and

transfer please

those

head

are

those

The

primary

pad,

barrier

for

specific

surfaces

refer

on

proper

Instrumentation

Surfaces

areas

that

require

The

minimum

brake

handles,

surfaces

protection

this

to

your

to

cleaning

that

transfer

and

trays.

for

barrier

A-dec’s

plastic.

application.

locale.

where

barrier

Equipment

and

contact

touch

surface

and

dental

are

contaminated

surfaces

all

Barrier

chemical

on

applicable Cover-All™

Refer

to plastics

protection

Asepsis

and

become

locations

light

the

A-dec

touch

your

national

is

Owner’s

disinfection.

potential

handles

by

contact

500

and

barrier

should

not

applicable

Guide

cross-contamination

on

A-dec

and

switches.

with

product

transfer

film

or

any

regulatory

be

removed

(P/N

500

products

instruments

include

surfaces.

other

authorities

or

when

85.0696.00)

and

discarded

traditional

When

FDA

barriers

points

include

and

market-cleared

for

the

other

holders,

used,

barriers

barrier

after

each

are

Dental

Auto

button

return

Light

On/Off

together

to

the

(auto

setting

for

three

factory

on/off)

can

be

seconds.

preset

Position 3 (x-ray/rinse)

Position 3 can Position confirms

beeps

confirms

3,

press

that

be

toggled

Program

the

position

that

from

and

can

the

x-ray/rinse

turned

repeat

the

then

be

programmed.

off

by

pressing

One

beep

will

steps.

Three

x-ray/rinse

press

and

function

is

and

holding

confirm

beeps

position

hold

To

on.

that

will

confirm

to a programmed

Position 3 together

return

to

the

Program

the

factory

that

the

x-ray/rinse

preset

the

auto

position.

for

three

position,

button

has

on/off

To

seconds.

and

then

been

turned

function

program

One

repeat

the

Light

off.

is

on.

beep

steps.

To

Three

Heat

High between

HVE — steam SE — steam Air

Each patient

Sterilization

volume

/Water

handheld

evacuators

patients.

autoclave autoclave Syringe - steam

to

reduce

The

device

the

chance

Specifications

Minimum

Air:

Water:

Vacuum: Specifications

2.50

1.50

air,

cfm

12

water

(70.80

gpm

cfm

are

and

1/min)

(5.68

(339.84

subject

(HVE),

following

at

134°C

at

134°C

autoclave

with

air

of

vacuum

at

80

1/min)

at

1/min)

to

change

saliva

ejectors

protocol

(273°F), 6 minutes

at

134°C

and

water

cross-contamination

service

psi

(551

40

psi

(276

at 8 inches

without

(SE),

should

lines

requirements

kPa).

be

holding

(273°F), 4 minutes

should

kPa).

of

mercury

notice.

and

air/water

followed:

holding

as a result

time

be

discharged

for

proper

(27

kPa).

syringes

holding

for

of

potential

unit

should

time

20-30

seconds

bio-burden

operation:

be

steam

between

retraction.

autoclaved

each

Page

10

a

4

dec

86.0603.00

À.

a

Ne

dee

Page

11

sê

Conclusion

Thank

We email

A-dec Technical 2601 Newberg, OR

Reach

email:

website:

you

would

or

phone

Inc.

Communications

Crestview

us

by

for

taking

appreciate

us

with

Drive

97132

phone

at:1-800-547-1883

the

time

to

use

the

any

feedback

your

comments.

Department

techcomm@a-dec.com www.a-dec.com

or

A-dec

500

comments

You

can

Assistant’s

you

have

about

reach

us

at:

Instrumentation

this

document.

Owner's

Guide.

Please

mail,

si

dee

A-dec

2601

Newberg,

Tel: Tel: www.a-dec.

A-dec

2601

Newberg,

Tel:

www.a-dec.biz

A-dec

Austin

Nuneaton, Tel: Tel:

www.a-dec.co.uk

A-dec

41-43 Alexandria

Tel:

www.a-dec.com.au

Inc.

Crestview

OR

97132

1-800-547-1883 1-503-538-7478

biz

International

Crestview

OR

97132

1-503-538-9471

United

House,

0800 44

24

Australia

Bowden

61

(0)2

11

Warwickshire

ADECUK

7635

NSW

9699

Drive

USA

within

outside

Drive

USA

Kingdom

Liberty

(233285)

0901

outside

Street

2015

4600

USA/Canada

Inc.

Way

CV11

within

UK

Australia

6RZ

England

UK

Rev A (04123.13)

Inc.

rights

reserved

2004

A-dec 551 User manual

Specifications and Main Features

Frequently Asked Questions

User Manual