Sony PXW-FS7K, PXW-FS7 Service Manual

SOLID-STATE MEMORY CAMCORDER

PXW-FS7 PXW-FS7K

SERVICE MANUAL 1st Edition (Revised 3)

警告

このマニュアルは，サービス専用です。お客様が，このマニュアルに記載された設置や保守，点検，修理などを行うと感電や火災，人身事故につながることがあります。危険をさけるため，サービストレーニングを受けた技術者のみご使用ください。

WARNING

This manual is intended for qualiﬁed service personnel only. To reduce the risk of electric shock, ﬁre or injury, do not perform any servicing other than that contained in the operating instructions unless you are qualiﬁed to do so. Refer all servicing to qualiﬁed service personnel.

WARNUNG

Die Anleitung ist nur für qualiﬁziertes Fachpersonal bestimmt. Alle Wartungsarbeiten dürfen nur von qualiﬁziertem Fachpersonal ausgeführt werden. Um die Gefahr eines elektrischen Schlages, Feuergefahr und Verletzungen zu vermeiden, sind bei Wartungsarbeiten strikt die Angaben in der Anleitung zu befolgen. Andere als die angegeben Wartungsarbeiten dürfen nur von Personen ausgeführt werden, die eine spezielle Befähigung dazu besitzen.

A VERTISSEMENT

Ce manual est destiné uniquement aux personnes compétentes en charge de l’entretien. Aﬁn de réduire les risques de décharge électrique, d’incendie ou de blessure n’effectuer que les réparations indiquées dans le mode d’emploi à moins d’être qualiﬁé pour en effectuer d’autres. Pour toute réparation faire appel à une personne compétente uniquement.

PXW-FS7/PXW-FS7K

CAUTION

Danger of explosion if battery is incorrectly replaced. Replace only with the same or equivalent type recommended by the manufacturer. When you dispose of the battery, you must obey the law in the relative area or country.

ATTENTION

Il y a danger d’explosion s’il y a remplacement incor-

rect de la batterie. Remplacer uniquement avec

une batterie du même type ou d’un type équivalent

recommandé par le constructeur. Lorsque vous mettez la batterie au rebut, vous devez respecter la législation en vigueur dans le pays ou la

région où vous vous trouvez.

VORSICHT

Explosionsgefahr bei Verwendung falscher Batterien. Batterien nur durch den vom Hersteller empfohlenen

oder einen gleichwertigen Typ ersetzen.

Wenn Sie die Batterie entsorgen, müssen Sie die

Gesetze der jeweiligen Region und des jeweiligen

Landes befolgen.

注意

指定以外の電池に交換すると，破裂する危険があります。

必ず指定の電池に交換してください。

使用済みの電池は，国または地域の法令に従って

処理してください。

FÖRSIKTIGHET!

Fara för explosion vid felaktigt placerat batteri.

Byt endast mot samma eller likvärdig typ av batteri,

enligt tillverkarens rekommendationer.

När du kasserar batteriet ska du följa rådande lagar

för regionen eller landet.

PAS PÅ

Fare for eksplosion, hvis batteriet ikke udskiftes

korrekt.

Udskift kun med et batteri af samme eller tilsvarende

type, som er anbefalet af fabrikanten.

Når du bortskaffer batteriet, skal du følge

lovgivningen i det pågældende område eller land.

HUOMIO

Räjähdysvaara, jos akku vaihdetaan virheellisesti.

Vaihda vain samanlaiseen tai vastaavantyyppiseen,

valmistajan suosittelemaan akkuun.

Noudata akun hävittämisessä oman maasi tai

alueesi lakeja.

FORSIKTIG

Eksplosjonsfare hvis feil type batteri settes i.

Bytt ut kun med samme type eller tilsvarende

anbefalt av produsenten.

Kasser batteriet i henhold til gjeldende avfallsregler.

⊼ᛣ

བᵰ᳈ᤶⱘ⬉∴ϡℷ⹂ˈህӮ᳝⟚⚌ⱘ䰽Ǆ

া᳈ᤶৠϔ㉏ൟ៪ࠊ䗴ଚ᥼㤤ⱘ⬉∴ൟোǄ

໘⧚⬉∴ᯊˈᖙ乏䙉ᅜⳌ݇ഄ៪೑ᆊⱘ⊩ᕟǄ

Note:

Be sure to keep your PC used for service and checking of this unit always updated with the latest version of your anti-virus software. In case a virus affected unit was found during service, contact your Service Headquarters.

注意：

修理時に使用するパソコンは，ウィルス検出ソフトが常にアップデートを行っているパソコンを使用してください。もし，修理を行うセット，もしくはパソコンがウィルスに感染している事が判明した場合は，ソニーグループ内は社内技術相談窓口に，特約店様は特約店様専用電話窓口（修理窓口）にご相談ください。

PXW-FS7/PXW-FS7K

SAFETY-RELATED COMPONENT WARNING!! ATTENTION AU COMPOSANT AYANT RAPPORT

À LA SÉCURITÉ!

: LEAD FREE MARK

Be careful to the following points to solder or unsolder.

SAFETY CHECK-OUT

After correcting the original service problem, perform the following

safety checks before releasing the set to the customer.

1. Check the area of your repair for unsoldered or poorly-soldered connections. Check the entire board surface for solder splashes and bridges.

2. Check the interboard wiring to ensure that no wires are “pinched” or contact high-wattage resistors.

3. Look for unauthorized replacement parts, particularly transistors, that were installed during a previous repair. Point them out to the customer and recommend their replacement.

4. Look for parts which, through functioning, show obvious signs of deterioration. Point them out to the customer and recommend their replacement.

5. Check the B+ voltage to see it is at the values specified.

6. Flexible Circuit Board Repairing

• Set the soldering iron tip temperature to 350 °C approximately.

• Do not touch the soldering iron on the same conductor of the

circuit board (within 3 times).

• Be careful not to apply force on the conductor when soldering

or unsoldering.

COMPONENTS IDENTIFIED BY MARK 0 OR DOTTED LINE WITH MARK 0 ON THE SCHEMATIC DIAGRAMS AND IN THE PARTS LIST ARE CRITICAL TO SAFE OPERATION. REPLACE THESE COMPONENTS WITH SONY PARTS WHOSE PART NUMBERS APPEAR AS SHOWN IN THIS MANUAL OR IN SUPPLEMENTS PUBLISHED BY SONY.

UNLEADED SOLDER

This unit uses unleaded solder. Boards requiring use of unleaded solder are printed with the lead free mark (LF) indicating the solder contains no lead. (Caution: Some printed circuit boards may not come printed with

the lead free mark due to their particular size.)

• Set the soldering iron tip temperature to 350 °C approximately. If cannot control temperature, solder/unsolder at high temperature

for a short time.

Caution: The printed pattern (copper foil) may peel away if the

heated tip is applied for too long, so be careful!

Unleaded solder is more viscous (sticky, less prone to

flow) than ordinary solder so use caution not to let solder bridges occur such as on IC pins, etc.

• Be sure to control soldering iron tips used for unleaded solder and those for leaded solder so they are managed separately. Mixing un-

leaded solder and leaded solder will cause detachment phenomenon.

LES COMPOSANTS IDENTIFIÉS PAR UNE MARQUE 0 SUR LES DIAGRAMMES SCHÉMATIQUES ET LA LISTE DES PIÈCES SONT CRITIQUES POUR LA SÉCURITÉ DE FONCTIONNEMENT. NE REMPLACER CES COMPOSANTS QUE PAR DES PIÈCES SONY DONT LES NUMÉROS SONT DONNÉS DANS CE MANUEL OU DANS LES SUPPLÉMENTS PUBLIÉS PAR SONY.

PXW-FS7/PXW-FS7K

サービス，点検時には次のことにご注意ください。

：レッドフリーマーク

無鉛半田は，下記の点に注意して使用してください。

1. 注意事項をお守りください。

サービスのとき特に注意を要する個所については，キャビネット，シャーシ，部品などにラベルや捺印で注意事項を表示しています。これらの注意書き及び取扱説明書等の注意事項を必ずお守り下さい。

2. 指定部品のご使用を

セットの部品は難燃性や耐電圧など安全上の特性を持ったものとなっています。従って交換部品は，使用されていたものと同じ特性の部品を使用して下さい。特に回路図，部品表に0印で指定されている安全上重要な部品は必ず指定のものをご使用下さい。

3. 部品の取付けや配線の引きまわしはもとどおりに

安全上，チューブやテープなどの絶縁材料を使用したり，プリント基板から浮かして取付けた部品があります。また内部配線は引きまわしやクランパによって発熱部品や高圧部品に接近しないよう配慮されていますので，これらは必ずもとどおりにして下さい。

4. サービス後は安全点検を

サービスのために取外したネジ，部品，配線がもとどおりになっているか，またサービスした個所の周辺を劣化させてしまったところがないかなどを点検し，安全性が確保されていることを確認して下さい。

5. チップ部品交換時の注意

・取外した部品は再使用しないで下さい。・タンタルコンデンサのマイナス側は熱に弱いため交

換時は注意して下さい。

6. フレキシブルプリント基板の取扱いについて

・半田こてのこて先温度は約350℃に設定してくださ

い。

・同一パターンに何度もコテ先を当てないで下さい。

（3回以内）

・パターンに力が加わらないよう注意して下さい。

無鉛半田について

本機には無鉛半田が使用されています。無鉛半田を使用している基板には，無鉛（LeadFree）を意味するレッドフリーマークがプリントされています。

（注意：基板サイズによっては，無鉛半田を使用していても

レッドフリーマークがプリントされていないものがあります）

・ 半田こてのこて先温度は約350℃に設定してください。 温度調節が無理な場合は，高温短時間で作業を行ってくだ

さい。

注意：半田こてを長く当てすぎると，基板のパターン（銅

箔）がはがれてしまうことがありますので，注意してください。また，従来の半田よりも粘性が強いため， IC端子などが半田ブリッジしないように注意してください。

・半田こてのこて先は，必ず無鉛半田用と有鉛半田用に分け

て管理してください。

 無鉛半田と有鉛半田が混在すると剥離現象が発生してしま

います。

PXW-FS7/PXW-FS7K

Model Information

Model PXW-FS7 PXW-FS7K

Destination UC, J CEE, CN1 UC, J CEE, CN1

COLOR system NTSC PAL NTSC PAL

Internal recording media

LENS – – – –

Projector – – – –

GPS – – – –

EVF Attachable Attachable Attachable Attachable

Wi-Fi ✓ ✓ ✓ ✓

NFC ✓ ✓ ✓ ✓

Multi interface shoe ✓ ✓ ✓ ✓

Charging capacitor (for

ash)

Bundled lens – – FE PZ 28-135mm

[About the service of this model]

PXW

-FS7K is commodity that packed the Solid-State Memory Camcorder and Interchangeable Lenses.

Refer to each following service manual the Interchangeable Lens kit, when you repair.

– – – –

FE PZ 28-135mm

F4 G OSS

Model Lens Service Manual of Lens

PXW-FS7 No supplied lens No supplied lens

PXW-FS7K SELP28135G (FE PZ 28-135mm F4 G OSS) 9-896-716-[][]

PXW-FS7/PXW-FS7K

Model Information

Manual Structure

Purpose of this manual....................................................................................................................7

Related manuals...........................................................................................................................7

Trouble Shooting

1-1. Self-diagnosis Function....................................................................................................... 1-1

1-1-1. Self-diagnosis Function.................................................................................................1-1

1-1-2. Self-diagnosis Code Table..............................................................................................1-1

2. Service Note

2-1. Operation Notes...............................................................................................................2-1

2-1-1. Flexible Board..........................................................................................................2-1

2-1-2. Fine-Wire Coaxial Cable............................................................................................... 2-1

2-2. Power Supply during Repairs .................................................................................................2-2

2-2-1. AC power adaptor...................................................................................................... 2-2

2-3. Precaution on Replacing the Board........................................................................................... 2-3

2-4. Service Menu..................................................................................................................2-4

2-4-1. How to Display the Service Menu......................................................................................2-4

2-4-2. Service Menu List...................................................................................................... 2-4

2-4-3. Details of Each Menu...................................................................................................2-4

2-5. Precaution on Replacing the IM E Mount Base Block Assy..................................................................2-6

3. Adjustment

4. Replacement of Main Parts

4-1. Identifying Parts...............................................................................................................4-1

4-2. Disassembly...................................................................................................................4-3

4-2-1. Overall Section-1.......................................................................................................4-3

4-2-2. Overall Section-2.......................................................................................................4-5

4-2-3. Overall Section-3.......................................................................................................4-8

4-2-4. Overall Section-4......................................................................................................4-12

4-2-5. Overall Section-5......................................................................................................4-15

4-2-6. Handle Section-1......................................................................................................4-18

4-2-7. Handle Section-2......................................................................................................4-19

4-2-8. Handle Section-3......................................................................................................4-20

4-2-9. Inside Panel Section-1.................................................................................................4-21

4-2-10. Inside Panel Section-2.................................................................................................4-22

4-2-11. Outside Assy Section..................................................................................................4-23

4-2-12. Rear Assy Section.....................................................................................................4-24

4-2-13. VF Hood Section......................................................................................................4-25

PXW-FS7/PXW-FS7K

4-2-14. VF Panel Section......................................................................................................4-26

4-2-15.

4-2-16. Front Assy Section-2..................................................................................................4-29

4-2-17. Grip Section-1.........................................................................................................4-30

4-2-18. Grip Section-2.........................................................................................................4-31

Front Assy Section-1..................................................................................................4-27

5. Repair Parts List

5-1. Note on Repair Parts.......................................................................................................... 5-1

5-2. Exploded View................................................................................................................5-2

Overall Section-1.................................................................................................................... 5-2

Overall Section-2.................................................................................................................... 5-3

Overall Section-3 ....................................................................................................................5-4

Overall Section-4.................................................................................................................... 5-6

Overall Section-5 ....................................................................................................................5-7

Handle Section-1.....................................................................................................................5-9

Handle Section-2................................................................................................................... 5-10

Handle Section-3....................................................................................................................5-11

Inside Panel Section-1..............................................................................................................5-12

Inside Panel Section-2 ............................................................................................................. 5-13

Outside Assy Section...............................................................................................................5-14

Rear Assy Section.................................................................................................................. 5-15

VF Hood Section................................................................................................................... 5-16

VF Panel Section................................................................................................................... 5-17

Front Assy Section-1............................................................................................................... 5-19

Front Assy Section-2............................................................................................................... 5-21

Grip Section-1...................................................................................................................... 5-22

Grip Section-2...................................................................................................................... 5-24

5-3. Accessories...................................................................................................................5-25

Except Japanese Model.............................................................................................................5-25

Japanese Model.....................................................................................................................5-27

5-4. Electrical Parts List.......................................................................................................... 5-29

AVP-25 BOARD................................................................................................................... 5-29

AXM-54 BOARD.................................................................................................................. 5-32

CN-3742 BOARD..................................................................................................................5-32

CN-3743 BOARD..................................................................................................................5-32

CT-283 BOARD....................................................................................................................5-33

CT-284 FLEXIBLE BOARD.......................................................................................................5-33

DC-177 BOARD................................................................................................................... 5-33

DPR-365 BOARD..................................................................................................................5-33

DR-680 BOARD................................................................................................................... 5-45

DV-36 BOARD.....................................................................................................................5-45

EC-83 BOARD.....................................................................................................................5-45

FP-215 FLEXIBLE BOARD.......................................................................................................5-46

FP-216 FLEXIBLE BOARD.......................................................................................................5-46

FP-217 FLEXIBLE BOARD.......................................................................................................5-46

FP-219 FLEXIBLE BOARD.......................................................................................................5-46

FP-220 FLEXIBLE BOARD.......................................................................................................5-46

FP-221 FLEXIBLE BOARD.......................................................................................................5-46

FP-222 FLEXIBLE BOARD.......................................................................................................5-46

FP-223 FLEXIBLE BOARD.......................................................................................................5-46

FP-2231 FLEXIBLE BOARD......................................................................................................5-46

PXW-FS7/PXW-FS7K

FP-224 FLEXIBLE BOARD.......................................................................................................5-46

FP-237 FLEXIBLE BOARD.......................................................................................................5-47

FP-239 FLEXIBLE BOARD.......................................................................................................5-47

FP-248 FLEXIBLE BOARD.......................................................................................................5-47

FP-249 FLEXIBLE BOARD.......................................................................................................5-47

GP-1019 BOARD.................................................................................................................. 5-47

HN-421 BOARD................................................................................................................... 5-47

HP-172 BOARD....................................................................................................................5-48

IF-1270 BOARD................................................................................................................... 5-48

IF-1273 BOARD................................................................................................................... 5-49

IS-102 BOARD.....................................................................................................................5-49

-734 BOARD....................................................................................................................5-49

KY-735 BOARD....................................................................................................................5-49

KY-739 BOARD....................................................................................................................5-49

LC-43 BOARD.....................................................................................................................5-51

PM-26 BOARD.....................................................................................................................5-51

PS-894 BOARD.................................................................................................................... 5-52

RC-115 FLEXIBLE BOARD...................................................................................................... 5-52

RE-328 BOARD....................................................................................................................5-52

SD-60 BOARD.....................................................................................................................5-55

SE-1158 FLEXIBLE BOARD......................................................................................................5-56

SW-1647 BOARD..................................................................................................................5-56

SW-1660 BOARD..................................................................................................................5-56

VF-93 BOARD.....................................................................................................................5-56

VIF-58 BOARD.................................................................................................................... 5-57

6. Block Diagrams

Overall (1/8)............................................................................................................................ 6-1

Overall (2/8)............................................................................................................................ 6-2

Overall (3/8)............................................................................................................................ 6-3

Overall (4/8)............................................................................................................................ 6-4

Overall (5/8)............................................................................................................................ 6-5

Overall (6/8)............................................................................................................................ 6-6

Overall (7/8)............................................................................................................................ 6-7

Overall (8/8)............................................................................................................................ 6-8

Power (1/10)............................................................................................................................6-9

Power (2/10)...........................................................................................................................6-10

Power (3/10)...........................................................................................................................6-11

Power (4/10)...........................................................................................................................6-12

Power (5/10)...........................................................................................................................6-13

Power (6/10)...........................................................................................................................6-14

Power (7/10)...........................................................................................................................6-15

Power (8/10)...........................................................................................................................6-16

Power (9/10)...........................................................................................................................6-17

Power (10/10)......................................................................................................................... 6-18

7. Frame Schematic Diagrams

Frame Wiring (1/4).....................................................................................................................7-1

Frame Wiring (2/4).....................................................................................................................7-2

PXW-FS7/PXW-FS7K

Frame Wiring (3/4).....................................................................................................................7-3

Frame W

iring (4/4)..................................................................................................................... 7-4

8. Schematic Diagrams

AVP-25................................................................................................................................. 8-2

AXM-54...............................................................................................................................8-17

CN-3742...............................................................................................................................8-18

CN-3743...............................................................................................................................8-20

CT-283.................................................................................................................................8-21

CT-284.................................................................................................................................8-22

DC-177................................................................................................................................8-22

DPR-365...............................................................................................................................8-23

DR-680................................................................................................................................8-58

DV-36..................................................................................................................................8-59

EC-83..................................................................................................................................8-60

FP-215.................................................................................................................................8-61

FP-216.................................................................................................................................8-61

FP-217.................................................................................................................................8-62

FP-219.................................................................................................................................8-62

FP-220.................................................................................................................................8-63

FP-221.................................................................................................................................8-63

FP-222.................................................................................................................................8-64

FP-223.................................................................................................................................8-64

FP-224.................................................................................................................................8-65

FP-237.................................................................................................................................8-65

FP-239.................................................................................................................................8-66

FP-248.................................................................................................................................8-66

FP-249.................................................................................................................................8-66

GP-1019...............................................................................................................................8-67

HN-421................................................................................................................................8-68

HP-172................................................................................................................................ 8-69

IF-1270................................................................................................................................8-70

IF-1273................................................................................................................................8-73

IS-102................................................................................................................................. 8-74

KY-734................................................................................................................................ 8-75

KY-735................................................................................................................................ 8-75

KY-739................................................................................................................................ 8-76

LC-43..................................................................................................................................8-79

PM-26................................................................................................................................. 8-80

PS-894.................................................................................................................................8-82

RC-115................................................................................................................................ 8-82

RE-328................................................................................................................................ 8-83

SD-60..................................................................................................................................8-87

SE-1158............................................................................................................................... 8-88

SW-1647...............................................................................................................................8-88

SW-1660...............................................................................................................................8-89

VF-93..................................................................................................................................8-90

VIF-58.................................................................................................................................8-91

PXW-FS7/PXW-FS7K

9. Printed Wiring Boards

VP-25................................................................................................................................. 9-2

AXM-54................................................................................................................................ 9-3

CN-3742................................................................................................................................9-3

CN-3743................................................................................................................................9-3

CT-283..................................................................................................................................9-3

CT-284..................................................................................................................................9-4

DC-177................................................................................................................................. 9-5

DR-680................................................................................................................................. 9-6

DRP-365 (1/2)..........................................................................................................................9-7

DRP-365 (2/2)..........................................................................................................................9-8

DV-36...................................................................................................................................9-9

EC-83..................................................................................................................................9-10

FP-248.................................................................................................................................9-10

FP-249.................................................................................................................................9-11

GP-1019............................................................................................................................... 9-11

HN-421................................................................................................................................9-12

HP-172................................................................................................................................ 9-12

IF-1270................................................................................................................................9-13

IF-1273................................................................................................................................9-13

IS-102................................................................................................................................. 9-14

KY-734................................................................................................................................ 9-14

KY-735................................................................................................................................ 9-14

KY-739................................................................................................................................ 9-15

LC-43..................................................................................................................................9-15

PM-26................................................................................................................................. 9-16

PS-894.................................................................................................................................9-16

RC-115................................................................................................................................ 9-16

RE-328................................................................................................................................ 9-17

SD-60..................................................................................................................................9-18

SE-1158............................................................................................................................... 9-18

SW-1647...............................................................................................................................9-19

SW-1660...............................................................................................................................9-19

VF-93..................................................................................................................................9-19

VIF-58 (1/2)...........................................................................................................................9-20

VIF-58 (2/2)...........................................................................................................................9-21

Revision History

PXW-FS7/PXW-FS7K

Manual Structure

Purpose of this manual

This manual describes the information items that premise the service based on the components parts assuming use of

system and service engineers.

Related manuals

Besides this manual, the following manuals are available.

•

Before Using this Unit (Supplied with this unit)

• Operating Guide (CD-ROM)(Supplied with this unit)

• Adjust Manual (Available on request)

The adjustment software is necessary for adjustment and various checking of this unit for the service.

PXW-FS7/PXW-FS7K

このマニュ

本書の目的...............................................................................................................................7

関連マニュアル......................................................................................................................... 7

アルについて

1. トラブルシューティング

1-1. 自己診断機能................................................................................................................1-1

1-1-1. 自己診断機能について...............................................................................................1-1

1-1-2. 自己診断コード表....................................................................................................1-1

2. サービスノート

2-1. 作業時の注意................................................................................................................2-1

2-1-1. フレキシブル基板....................................................................................................2-1

2-1-2. 細線ケーブル..........................................................................................................2-1

2-2. 修理時の電源供給について................................................................................................2-2

2-2-1. AC アダプタ...........................................................................................................2-2

2-3. 基板交換時の注意事項......................................................................................................2-3

2-4. サービスメニュー...........................................................................................................2-4

2-4-1. Service メニューを表示させるには................................................................................2-4

2-4-2. Service メニュー一覧................................................................................................2-4

2-4-3. 各メニューの説明....................................................................................................2-5

2-5. IM E マウントベース部組交換時の注意..................................................................................2-6

3. 調整について

4. Replacement of Main Parts

4-1. Identifying Parts............................................................................................................ 4-1

4-2. Disassembly................................................................................................................. 4-3

4-2-1. Overall Section-1.....................................................................................................4-3

4-2-2. Overall Section-2.....................................................................................................4-5

4-2-3. Overall Section-3.....................................................................................................4-8

4-2-4. Overall Section-4....................................................................................................4-12

4-2-5. Overall Section-5....................................................................................................4-15

4-2-6. Handle Section-1....................................................................................................4-18

4-2-7. Handle Section-2....................................................................................................4-19

4-2-8. Handle Section-3....................................................................................................4-20

4-2-9. Inside Panel Section-1..............................................................................................4-21

4-2-10. Inside Panel Section-2..............................................................................................4-22

4-2-11. Outside Assy Section...............................................................................................4-23

4-2-12. Rear Assy Section...................................................................................................4-24

4-2-13. VF Hood Section....................................................................................................4-25

4-2-14. VF Panel Section....................................................................................................4-26

4-2-15. Front Assy Section-1............................................................................................... 4-27

4-2-16. Front Assy Section-2............................................................................................... 4-29

PXW-FS7/PXW-FS7K

4-2-17. Grip Section-1.......................................................................................................4-30

4-2-18.

Grip Section-2.......................................................................................................4-31

5. Repair Parts List

5-1. Note on Repair Parts........................................................................................................5-1

5-2. Exploded View...............................................................................................................5-2

Overall Section-1...................................................................................................................5-2

Overall Section-2...................................................................................................................5-3

Overall Section-3 ..................................................................................................................5-4

Overall Section-4...................................................................................................................5-6

Overall Section-5 ..................................................................................................................5-7

Handle Section-1...................................................................................................................5-9

Handle Section-2.................................................................................................................5-10

Handle Section-3.................................................................................................................5-11

Inside Panel Section-1...........................................................................................................5-12

Inside Panel Section-2 ..........................................................................................................5-13

Outside Assy Section............................................................................................................ 5-14

Rear Assy Section................................................................................................................5-15

VF Hood Section................................................................................................................. 5-16

VF Panel Section................................................................................................................. 5-17

Front Assy Section-1.............................................................................................................5-19

Front Assy Section-2.............................................................................................................5-21

Grip Section-1.................................................................................................................... 5-22

Grip Section-2.................................................................................................................... 5-24

5-3. Accessories.................................................................................................................5-25

Except Japanese Model..........................................................................................................5-25

Japanese Model..................................................................................................................5-27

5-4. Electrical Parts List........................................................................................................5-29

AVP-25 BOARD...................................................................................................................5-29

AXM-54 BOARD..................................................................................................................5-32

CN-3742 BOARD.................................................................................................................5-32

CN-3743 BOARD.................................................................................................................5-32

CT-283 BOARD...................................................................................................................5-33

CT-284 FLEXIBLE BOARD...................................................................................................... 5-33

DC-177 BOARD...................................................................................................................5-33

DPR-365 BOARD.................................................................................................................5-33

DR-680 BOARD...................................................................................................................5-45

DV-36 BOARD....................................................................................................................5-45