Panasonic CYPA-4003-U Service manual

Specifications*

ORDER NO. ACED060837C7

C1

AUTOMOTIVE AFTERMARKET

CY-PA4003U

4 Channel Power Amplifier

General

Power Supply DC 12V (11V - 16V),

Test Voltage 14.4V

Negative Ground
Current Consumption 32A (at 64W×4)
Speaker Impedance 4 Ω
Power Output (“EIA” Power)
2-CH 190W×2 (20Hz-20000Hz, 1%, 4 Ω)
3-CH 64W×2+190W

(20Hz-20000Hz, 1%, 4 Ω)
4-CH 64W×4 (20Hz-20000Hz, 1%, 4 Ω)
Maximum Power Output
2-CH 220W×2 (20Hz-20000Hz, 10%)
3-CH 85W×2+220W

(20Hz-20000Hz, 10%)
4-CH 85W×4 (20Hz-20000Hz, 10%)
Total Harmonic Distortion 0.08% (1000Hz, at 10W)
Low Pass Filter 50Hz-250Hz
High Pass Filter 50Hz-250Hz
Bass Boost 0dB-15dB (Middle Frequency: 45Hz)
Signal to Noise Ratio 90dB (IHF, A)
Frequency Response 20Hz-20kHz
Input Sensitivity 0.2V-6V
Input Impedance More than 46kΩ

Weight** 9 lbs 14 oz (4.4 kg)

* Specifications and the design are subject to possible modification
without notice due to improvements.

** Dimensions and Weight shown are approximate.
** Above specifications comply with EIA standards.

Dimensions (W×H×D)** 11-1/16” × 2-1/2” × 13-1/8”

(280×62×333 mm)

© 2006 Matsushita Electric Industrial Co., Ltd. All
rights reserved. Unauthorized copying and
distribution is a violation of law.

CY-PA4003U

CONTENTS

Page Page

1 ABOUT LEAD FREE SOLDER (PbF) 2
2 FEATUERS
3 REPLACEING THE FUSE
4 DIMENSIONS
5 WIRING CONNECTION
6 IC BLOCK DIAGRAM
7 PACKING PARTS LIST

8 REPLACEMENT PARTS LIST 6
9 EXPLODED VIEW (Unit)

2
2

10 WIRING DIAGRAM
11 SCHEMATIC DIAGRAM-1

2
3

12 SCHEMATIC DIAGRAM-2

4

13 BLOCK DIAGRAM

5

13
14
20
21
29

1 ABOUT LEAD FREE

SOLDER (PbF)

Distinction of PbF PCB:
PCBs (manufactured) using lead free solder will have a PbF

stamp on the PCB.

Caution :

•

• Pb free solder has a higher melting point than standard

• •

solder; Typically the melting point is 50 - 70°F (30 ­40°C) higher. Please use a soldering iron with
temperature control and adjust it to 700 ± 20°F (370 ±
10°C). In case of using high temperature soldering iron,
please be careful not to heat too long.

•

• Pb free solder will tend to splash when heated too high

• •

(about 1100°F/600°C)

•

• This lead free solder will be used for the products after

• •

serial No. 1,000,001.

2 FEATUERS

•

• 250 W × 4channel maximum power output

• •

•

• Total 1000W maximum power output

• •

•

• An amplifier connected to the 4-, 3- or 2-channel speaker

• •

•

• 2CH/4CH input selection

• •

•

• Low-Pass Filter for subwoofer, High Pass Filter

• •

•

• Hight Level Speaker Input connection

• •

•

• Bass boost control system

• •

•

• Crossover Frequency Control

• •

•

• RCA output terminals

• •

•

• 5.1-channel Surround System (Combination with other

• •

Panasonic car audio products)

3 REPLACEING THE FUSE

Use fuses of thesame specified rating 35 amps. Using different
substitutes or fuses with higher ratings, or connecting the unit
directly without a fuse, could cause fire or damage to the stereo
unit.

4 DIMENSIONS

2

5 WIRING CONNECTION

CY-PA4003U

3

CY-PA4003U

6 IC BLOCK DIAGRAM

6.1. MK494 Block

U401 : 07-00494-85

4

7 PACKING PARTS LIST

CY-PA4003U

•

• Item numbers listed below should not order regular spare parts. (not available)

• •

Item

No.

1 - Display Box 1 Not available
2 - EPE Form in Box 2 Not available
3 - Inner Sheet 1 Not available
4 - Operating Instructions 1 Not available
5 ST-RP450-20 Tapping Screw (5*20) 4
6 YH-00017-00 Plain Washer (5*) 4
7 YH-00016-01 Allen Wrench 1
8 35-00124-00 Speaker Input Connector for Front SP 2

35-00124-01 Speaker Input Connector for Rear SP

9 76-00408-00 Terminal Cover for Short-circuit Prevention 2

76-00409-00 Terminal Cover for Short-circuit Prevention

Part No. Part Name & Description Q’ty Remarks

5

CY-PA4003U

8 REPLACEMENT PARTS

LIST

Notes :

1. Be sure to make your orders of replacement parts
according to this list.

2. Important safety notice: Components, identified by
have special characteristics important for safety. When
replacing any of these components, use only
manufacturer´s specified parts.

3. Location keys in the remarks column indicates the general
location of the parts shown in the exploded drawing, as in a
road map.

4. The marking (RTL) indicates that Retention Time is limited
for this item. After the discontinuation of assembly in
production, the item will continue to be available for a
specific period of time. The retention period of availability is
dependent on the type of assembly, and in accordance with
the laws governing part and product retention. After the end
of this period, the assembly will no longer be available.

5. “T” marks in remarks colum are indicated supply parts of
PTW.

6. Reference materials of parts with the “TSN“ mark in the
remarks column are uploaded in the TSN (Technical
Service Navigation) system website. Please download from
that website for references.

Ref. No. Part No. Part Name & Description Remarks
[11-05C01-32-D] Power AMP Block
IC´s AND TRANSISTORs

U3 07-04574-00 IC T
U4 07-04574-00 IC T
U7 07-04574-00 IC T
U8 07-04574-00 IC T
KG1 07-00817-02 IC (coupler) T
Q503 08-10970-00 Transistor T
Q504 08-12240-01 Transistor T
Q505 08-12240-01 Transistor T
Q506 08-12240-01 Transistor T
Q507 08-10970-00 Transistor T
Q508 08-10970-00 Transistor T
Q509 08-10970-00 Transistor T
Q510 08-12240-01 Transistor T
Q511 08-10667-01 Transistor T
Q512 08-10647-01 Transistor T
Q513 08-10667-01 Transistor T
Q514 08-00035-00 Transistor T
Q515 08-00036-00 Transistor T
Q516 08-12240-01 Transistor T
Q517 08-05551-00 Transistor T
Q518 08-05551-00 Transistor T
Q519 08-05551-00 Transistor T
Q520 08-05551-00 Transistor T
Q603 08-10970-00 Transistor T
Q604 08-12240-01 Transistor T
Q605 08-12240-01 Transistor T
Q606 08-12240-01 Transistor T
Q607 08-10970-00 Transistor T
Q608 08-10970-00 Transistor T
Q609 08-10970-00 Transistor T
Q610 08-12240-01 Transistor T
Q611 08-10667-01 Transistor T
Q612 08-10647-01 Transistor T
Q613 08-10667-01 Transistor T
Q614 08-00035-00 Transistor T
Q615 08-00036-00 Transistor T
Q616 08-12240-01 Transistor T

mark

Ref. No. Part No. Part Name & Description Remarks

Q617 08-05551-00 Transistor T
Q618 08-05551-00 Transistor T
Q703 08-10970-00 Transistor T
Q704 08-12240-01 Transistor T
Q705 08-12240-01 Transistor T
Q706 08-12240-01 Transistor T
Q707 08-10970-00 Transistor T
Q708 08-10970-00 Transistor T
Q709 08-10970-00 Transistor T
Q710 08-12240-01 Transistor T
Q711 08-10667-01 Transistor T
Q712 08-10647-01 Transistor T
Q713 08-10667-01 Transistor T
Q714 08-00035-00 Transistor T
Q715 08-00036-00 Transistor T
Q716 08-12240-01 Transistor T
Q717 08-05551-00 Transistor T
Q718 08-05551-00 Transistor T
Q803 08-10970-00 Transistor T
Q804 08-12240-01 Transistor T
Q805 08-12240-01 Transistor T
Q806 08-12240-01 Transistor T
Q807 08-10970-00 Transistor T
Q808 08-10970-00 Transistor T
Q809 08-10970-00 Transistor T
Q810 08-12240-01 Transistor T
Q811 08-10667-01 Transistor T
Q812 08-10647-01 Transistor T
Q813 08-10667-01 Transistor T
Q814 08-00035-00 Transistor T
Q815 08-00036-00 Transistor T
Q816 08-12240-01 Transistor T
Q817 08-05551-00 Transistor T
Q818 08-05551-00 Transistor T
QP3 08-05401-00 Transistor T
QP4 08-05401-00 Transistor T
QP5 08-50N06-00 MOSFET T
QP6 08-50N06-00 MOSFET T
QP7 08-50N06-00 MOSFET T
QP8 08-50N06-00 MOSFET T
QP9 08-50N06-00 MOSFET T
QP10 08-50N06-00 MOSFET T
QP13 08-03421-00 Transistor T
QP14 08-01358-00 Transistor T

DIODEs

D507 09-14148-01 Diode T
D508 09-14148-01 Diode T
D509 09-14148-01 Diode T
D510 09-14148-01 Diode T
D511 09-14148-01 Diode T
D512 09-14148-01 Diode T
D513 09-14148-01 Diode T
D514 09-14148-01 Diode T
D607 09-14148-01 Diode T
D614 09-14148-01 Diode T
D707 09-14148-01 Diode T
D714 09-14148-01 Diode T
D807 09-14148-01 Diode T
D814 09-14148-01 Diode T
DP5 09-14148-01 Diode T
DP6 09-14148-01 Diode T
DP7 09-20390-03 Zener Diode T
DP8 09-14148-01 Diode T
DP9 09-20390-03 Zener Diode T
DP10 09-14148-01 Diode T
DP14 09-15401-01 Diode T
DP15 09-20160-02 Diode T
DP16 09-20160-02 Diode T
DP100 09-14001-01 Diode T
N1 09-01620-01 Diode T
N2 09-01620-02 Diode T

6

Ref. No. Part No. Part Name & Description Remarks

LED

LED2 19-00329-00 LED T

CAPACITORs

C114 03-25630-05 0.056µF 63WV T
C115 03-25630-05 0.056µF 63WV T
C116 02-21001-45 Electrolytic, 10µF 50WV T
C214 03-25630-05 0.056µF 63WV T
C215 03-25630-05 0.056µF 63WV T
C216 02-21001-45 Electrolytic, 10µF 50WV T
C314 03-25630-05 0.056µF 63WV T
C315 03-25630-05 0.056µF 63WV T
C316 02-21001-45 Electrolytic, 10µF 50WV T
C414 03-25630-05 0.056µF 63WV T
C415 03-25630-05 0.056µF 63WV T
C416 02-21001-45 Electrolytic, 10µF 50WV T
C505E 02-21001-45 Electrolytic, 10µF 50WV T
C513 04-21000-05 Ceramic, 100PF 50WV T
C515 04-20100-05 Ceramic, 10PF 50WV T
C516 04-21000-05 Ceramic, 100PF 50WV T
C517 03-21040-07 0.1µF 100WV T
C518 02-21000-43 Electrolytic, 1µF 50WV T
C519 03-21040-07 0.1µF 100WV T
C520 02-22202-22 Electrolytic, 220µF 10WV T
C521 02-22202-25 Electrolytic, 220µF 16WV T
C605E 02-21001-45 Electrolytic, 10µF 50WV T
C613 04-21000-05 Ceramic, 100PF 50WV T
C615 04-20100-05 Ceramic, 10PF 50WV T
C616 04-21000-05 Ceramic, 100PF 50WV T
C617 03-21040-07 0.1µF 100WV T
C618 02-21000-43 Electrolytic, 1µF 50WV T
C619 03-21040-07 0.1µF 100WV T
C620 02-22202-22 Electrolytic, 220µF 10WV T
C705E 02-21001-45 Electrolytic, 10µF 50WV T
C713 04-21000-05 Ceramic, 100PF 50WV T
C715 04-20100-05 Ceramic, 10PF 50WV T
C716 04-21000-05 Ceramic, 100PF 50WV T
C717 03-21040-07 0.1µF 100WV T
C718 02-21000-43 Electrolytic, 1µF 50WV T
C719 03-21040-07 0.1µF 100WV T
C720 02-22202-22 Electrolytic, 220µF 10WV T
C805E 02-21001-45 Electrolytic, 10µF 50WV T
C813 04-21000-05 Ceramic, 100PF 50WV T
C815 04-20100-05 Ceramic, 10PF 50WV T
C816 04-21000-05 Ceramic, 100PF 50WV T
C817 03-21040-07 0.1µF 100WV T
C818 02-21000-43 Electrolytic, 1µF 50WV T
C819 03-21040-07 0.1µF 100WV T
C820 02-22202-22 Electrolytic, 220µF 10WV T
C9001 02-24701-35 Electrolytic, 47µF 25WV T
C9002 02-24701-35 Electrolytic, 47µF 25WV T
C9003 02-24701-35 Electrolytic, 47µF 25WV T
C9004 02-24701-35 Electrolytic, 47µF 25WV T
CP14 02-22203-51 Electrolytic, 2200µF 35WV T
CP14A 02-22203-51 Electrolytic, 2200µF 35WV T
CP15 02-22203-51 Electrolytic, 2200µF 35WV T
CP16 04-21040-05 Ceramic, 0.1µF 50WV T
CP17 04-21040-05 Ceramic, 0.1µF 50WV T
CP18 04-21040-05 Ceramic, 0.1µF 50WV T
CP19 04-21040-05 Ceramic, 0.1µF 50WV T
CP20 04-21040-05 Ceramic, 0.1µF 50WV T
CP21 02-21002-35 Electrolytic, 100µF 25WV T
CP22 02-21002-35 Electrolytic, 100µF 25WV T
CP23 02-21002-35 Electrolytic, 100µF 25WV T
CP24 02-21002-35 Electrolytic, 100µF 25WV T
CP25 04-26800-05 Ceramic, 680PF 250WV T
CP26 02-22203-52 Electrolytic, 2200µF 35WV T
CP27 02-22203-52 Electrolytic, 2200µF 35WV T
CP28 02-22203-52 Electrolytic, 2200µF 35WV T
CP29 02-22203-52 Electrolytic, 2200µF 35WV T
CP30 04-21040-05 Ceramic, 0.1µF 50WV T
CP31 04-21040-05 Ceramic, 0.1µF 50WV T

CY-PA4003U

Ref. No. Part No. Part Name & Description Remarks

CP100 02-24701-35 Electrolytic, 47µF 25WV T
CP112 04-21040-05 Ceramic, 0.1µF 50WV T
CP113 02-21002-35 Electrolytic, 100µF 25WV T
CP114 04-21040-05 Ceramic, 0.1µF 50WV T
CP115 02-21002-35 Electrolytic, 100µF 25WV T
CP201 02-20220-45 Electrolytic, 0.22µF 50WV T

RESISTERs

R123 01-12020-63 2kΩ 1/8W T
R124 01-13620-63 3.6kΩ 1/8W T
R125 01-12020-63 2kΩ 1/8W T
R126 01-12020-63 2kΩ 1/8W T
R127 01-12020-63 2kΩ 1/8W T
R128 01-11130-63 11kΩ 1/8W T
R129 01-11520-61 1.5kΩ 1/8W T
R130 01-11130-63 11kΩ 1/8W T
R131 01-11000-63 10Ω 1/8W T
R132 01-11000-63 10Ω 1/8W T
R133 01-11000-63 10Ω 1/8W T
R134 01-11030-63 10kΩ 1/8W T
R135 01-11030-63 10kΩ 1/8W T
R223 01-12020-63 2kΩ 1/8W T
R224 01-13620-63 3.6kΩ 1/8W T
R225 01-12020-63 2kΩ 1/8W T
R226 01-12020-63 2kΩ 1/8W T
R227 01-12020-63 2kΩ 1/8W T
R228 01-11130-63 11kΩ 1/8W T
R229 01-11520-61 1.5kΩ 1/8W T
R230 01-11130-63 11kΩ 1/8W T
R231 01-11000-63 10Ω 1/8W T
R232 01-11000-63 10Ω 1/8W T
R233 01-11000-63 10Ω 1/8W T
R236 01-11030-63 10kΩ 1/8W T
R323 01-12020-63 2kΩ 1/8W T
R324 01-13620-63 3.6kΩ 1/8W T
R325 01-12020-63 2kΩ 1/8W T
R326 01-12020-63 2kΩ 1/8W T
R327 01-12020-63 2kΩ 1/8W T
R328 01-11130-63 11kΩ 1/8W T
R329 01-11520-61 1.5kΩ 1/8W T
R330 01-11130-63 11kΩ 1/8W T
R331 01-11000-63 10Ω 1/8W T
R332 01-11000-63 10Ω 1/8W T
R333 01-11000-63 10Ω 1/8W T
R334 01-11030-63 10kΩ 1/8W T
R335 01-11030-63 10kΩ 1/8W T
R423 01-12020-63 2kΩ 1/8W T
R424 01-13620-63 3.6kΩ 1/8W T
R425 01-12020-63 2kΩ 1/8W T
R426 01-12020-63 2kΩ 1/8W T
R427 01-12020-63 2kΩ 1/8W T
R428 01-11130-63 11kΩ 1/8W T
R429 01-11520-61 1.5kΩ 1/8W T
R430 01-11130-63 11kΩ 1/8W T
R431 01-11000-63 10Ω 1/8W T
R432 01-11000-63 10Ω 1/8W T
R433 01-11000-63 10Ω 1/8W T
R436 01-11030-63 10kΩ 1/8W T
R514E 01-11230-63 12kΩ 1/8W T
R529 01-12210-63 220Ω 1/8W T
R530 01-11020-63 1kΩ 1/8W T
R531 01-12230-63 22kΩ 1/8W T
R532 01-11020-63 1kΩ 1/8W T
R533 01-12210-63 220Ω 1/8W T
R534 01-11020-63 1kΩ 1/8W T
R535 01-14700-63 47Ω 1/8W T
R536 01-13300-63 33Ω 1/8W T
R537 01-13300-63 33Ω 1/8W T
R538 01-13300-63 33Ω 1/8W T
R539 01-13300-63 33Ω 1/8W T
R540 01-11020-63 1kΩ 1/8W T
R541 01-14700-63 47Ω 1/8W T
R543 01-12230-63 22kΩ 1/8W T

7

CY-PA4003U

Ref. No. Part No. Part Name & Description Remarks

R544 01-15630-43 56kΩ 1/4W T
R545 01-14700-63 47Ω 1/8W T
R546 01-13920-63 3.9kΩ 1/8W T
R547 01-12720-63 2.7kΩ 1/8W T
R548 01-15630-43 56kΩ 1/4W T
R549 01-14700-63 47Ω 1/8W T
R550 01-12210-43 220Ω 1/4W T
R551 01-13301-63 3.3Ω 1/8W T
R552 01-13301-63 3.3Ω 1/8W T
R553 01-31500-51 0.15Ω 5W T
R554 01-31500-51 0.15Ω 5W T
R555 01-13020-63 3kΩ 1/8W T
R556 01-12230-63 22kΩ 1/8W T
R557 01-11520-61 1.5kΩ 1/8W T
R558 01-11030-63 10kΩ 1/8W T
R560 01-30002-51 0.02Ω 5W T
R561 01-14700-01 4.7Ω 1W T
R562 01-11530-63 15kΩ 1/8W T
R563 01-14730-63 47kΩ 1/8W T
R564 01-11030-63 10kΩ 1/8W T
R565 01-11030-63 10kΩ 1/8W T
R566 01-15620-43 5.6kΩ 1/4W T
R567 01-11030-63 10kΩ 1/8W T
R568 01-11040-63 100kΩ 1/8W T
R569 01-11020-63 1kΩ 1/8W T
R614E 01-11230-63 12kΩ 1/8W T
R629 01-12210-63 220Ω 1/8W T
R630 01-11020-63 1kΩ 1/8W T
R631 01-12230-63 22kΩ 1/8W T
R632 01-11020-63 1kΩ 1/8W T
R633 01-12210-63 220Ω 1/8W T
R634 01-11020-63 1kΩ 1/8W T
R635 01-14700-63 47Ω 1/8W T
R636 01-13300-63 33Ω 1/8W T
R637 01-13300-63 33Ω 1/8W T
R638 01-13300-63 33Ω 1/8W T
R639 01-13300-63 33Ω 1/8W T
R640 01-11020-63 1kΩ 1/8W T
R641 01-14700-63 47Ω 1/8W T
R643 01-12230-63 22kΩ 1/8W T
R644 01-15630-43 56kΩ 1/4W T
R645 01-14700-63 47Ω 1/8W T
R646 01-13920-63 3.9kΩ 1/8W T
R647 01-12720-63 2.7kΩ 1/8W T
R648 01-15630-43 56kΩ 1/4W T
R649 01-14700-63 47Ω 1/8W T
R650 01-12210-43 220Ω 1/4W T
R651 01-13301-63 3.3Ω 1/8W T
R652 01-13301-63 3.3Ω 1/8W T
R653 01-31500-51 0.15Ω 5W T
R654 01-31500-51 0.15Ω 5W T
R655 01-13020-63 3kΩ 1/8W T
R656 01-12230-63 22kΩ 1/8W T
R657 01-11520-61 1.5kΩ 1/8W T
R658 01-11030-63 10kΩ 1/8W T
R660 01-30002-51 20mΩ 5W T
R661 01-14700-01 4.7Ω 1W T
R662 01-11530-63 15kΩ 1/8W T
R663 01-14730-63 47kΩ 1/8W T
R664 01-11030-63 10kΩ 1/8W T
R714E 01-11230-63 12kΩ 1/8W T
R729 01-12210-63 220Ω 1/8W T
R730 01-11020-63 1kΩ 1/8W T
R731 01-12230-63 22kΩ 1/8W T
R732 01-11020-63 1kΩ 1/8W T
R733 01-12210-63 220Ω 1/8W T
R734 01-11020-63 1kΩ 1/8W T
R735 01-14700-63 47Ω 1/8W T
R736 01-13300-63 33Ω 1/8W T
R737 01-13300-63 33Ω 1/8W T
R738 01-13300-63 33Ω 1/8W T
R739 01-13300-63 33Ω 1/8W T
R740 01-11020-63 1kΩ 1/8W T
R741 01-14700-63 47Ω 1/8W T

Ref. No. Part No. Part Name & Description Remarks

R743 01-12230-63 22kΩ 1/8W T
R744 01-15630-43 56kΩ 1/4W T
R745 01-14700-63 47Ω 1/8W T
R746 01-13920-63 3.9kΩ 1/8W T
R747 01-12720-63 2.7kΩ 1/8W T
R748 01-15630-43 56kΩ 1/4W T
R749 01-14700-63 47Ω 1/8W T
R750 01-12210-43 220Ω 1/4W T
R751 01-13301-63 3.3Ω 1/8W T
R752 01-13301-63 3.3Ω 1/8W T
R753 01-31500-51 0.15Ω 5W T
R754 01-31500-51 0.15Ω 5W T
R755 01-13020-63 3kΩ 1/8W T
R756 01-12230-63 22kΩ 1/8W T
R757 01-11520-61 1.5kΩ 1/8W T
R758 01-11030-63 10kΩ 1/8W T
R760 01-30002-51 0.02Ω 5W T
R761 01-14700-01 4.7Ω 1W T
R762 01-11530-63 15kΩ 1/8W T
R763 01-14730-63 47kΩ 1/8W T
R764 01-11030-63 10kΩ 1/8W T
R814E 01-11230-63 12kΩ 1/8W T
R829 01-12210-63 220Ω 1/8W T
R830 01-11020-63 1kΩ 1/8W T
R831 01-12230-63 22kΩ 1/8W T
R832 01-11020-63 1kΩ 1/8W T
R833 01-12210-63 220Ω 1/8W T
R834 01-11020-63 1kΩ 1/8W T
R835 01-14700-63 47Ω 1/8W T
R836 01-13300-63 33Ω 1/8W T
R837 01-13300-63 33Ω 1/8W T
R838 01-13300-63 33Ω 1/8W T
R839 01-13300-63 33Ω 1/8W T
R840 01-11020-63 1kΩ 1/8W T
R841 01-14700-63 47Ω 1/8W T
R843 01-12230-63 22kΩ 1/8W T
R844 01-15630-43 56kΩ 1/4W T
R845 01-14700-63 47Ω 1/8W T
R846 01-13920-63 3.9kΩ 1/8W T
R847 01-12720-63 2.7kΩ 1/8W T
R848 01-15630-43 56kΩ 1/4W T
R849 01-14700-63 47Ω 1/8W T
R850 01-12210-43 220Ω 1/4W T
R851 01-13301-63 3.3Ω 1/8W T
R852 01-13301-63 3.3Ω 1/8W T
R853 01-31500-51 0.15Ω 5W T
R854 01-31500-51 0.15Ω 5W T
R855 01-13020-63 3kΩ 1/8W T
R856 01-12230-63 22kΩ 1/8W T
R857 01-11520-61 1.5kΩ 1/8W T
R858 01-11030-63 10kΩ 1/8W T
R860 01-30002-51 0.02Ω 5W T
R861 01-14700-01 4.7Ω 1W T
R862 01-11530-63 15kΩ 1/8W T
R863 01-14730-63 47kΩ 1/8W T
R864 01-11030-63 10kΩ 1/8W T
R9001 01-12720-63 2.7kΩ 1/8W T
R9002 01-12720-63 2.7kΩ 1/8W T
R9003 01-12720-63 2.7kΩ 1/8W T
R9004 01-12720-63 2.7kΩ 1/8W T
RP20 01-11020-63 1kΩ 1/8W T
RP21 01-11020-63 1kΩ 1/8W T
RP22 01-11020-63 1kΩ 1/8W T
RP23 01-11020-43 1kΩ 1/4W T
RP24 01-11020-43 1kΩ 1/4W T
RP25 01-14700-63 47Ω 1/8W T
RP26 01-14700-63 47Ω 1/8W T
RP27 01-14700-63 47Ω 1/8W T
RP28 01-14700-63 47Ω 1/8W T
RP29 01-14700-63 47Ω 1/8W T
RP30 01-14700-63 47Ω 1/8W T
RP39 01-12200-63 22Ω 1/8W T
RP40 01-11020-13 1kΩ 1W T
RP41 01-11210-51 120Ω 5W T

8

Ref. No. Part No. Part Name & Description Remarks

RP42 01-13020-63 3kΩ 1/8W T
RP43 01-13020-63 3kΩ 1/8W T
RP44 01-11210-51 120Ω 5W T

VARIABLE RESISTOR

VR3 15-40050-09 Variable Resister T
VR6 15-40050-09 Variable Resister T

SWITCHs

SW2 18-00886-00 Switch T
SW3 18-00887-00 Switch T
SW5 18-00888-00 Switch T

FUSEs

F1 76-00416-00 35A Fuse T
F2 76-00416-00 35A Fuse T

CONNECTORs

CN2 30-00114-01 7Pin Connector T
CN3 30-00276-00 8Pin Connector T
CN4 30-00115-00 2Pin Connector T
CN5 25-00708-00 15P Connector T
CONT 32-00637-02 3pin Terminal (+12V, CONT) T
(SP) 32-00639-01 8pin Terminal (Speaker) T

TRANSFORMER

T1 20-00207-00 Transformer T

THERMISTER

HTR 13-00215-00 Thermister T

OTHERs

GND 74-00208-00 GND Terminal T
JP2 01-00072-00 Corper Wire T
JUMP 01-00012-00 Jumper T
LP1 20-00208-00 Inductor T
MJ1 01-00071-00 Metal Jumper T
MJ2 01-00071-00 Metal Jumper T
MJ3 01-00074-00 Metal Jumper T
MJ4 01-00073-00 Corper Wire T
MJ5 01-00073-00 Corper Wire T
MJ6 01-00072-00 Corper Wire T
MJ7 01-00072-00 Corper Wire T
MJ8 01-00072-00 Corper Wire T
MJ9 01-00072-00 Corper Wire T
MJ10 01-00072-00 Corper Wire T

CY-PA4003U

Ref. No. Part No. Part Name & Description Remarks

IC AND TRANSISTORs

U401 07-00494-85 IC T
Q6 08-05551-85 Transistor T
Q410 08-05401-85 Transistor T
Q412 08-05551-85 Transistor T
Q416 08-05401-85 Transistor T

DIODEs

D401 09-14148-85 Diode T
D407 09-14001-85 Diode T
D410 09-14148-85 Diode T
D412 09-14148-85 Diode T
Z1 09-00047-85 Zener Diode T
Z5 09-00120-85 Zener Diode T

CAPACITORs

C13 04-21040-85 Ceramic, 0.1µF 50WV T
C26 02-21002-85 Electrolytic, 100µF 16WV T
C401 04-21040-85 Ceramic, 0.1µF 50WV T
C402 04-24720-85 Ceramic, 4700PF 50WV T
C405 02-21001-85 Electrolytic, 10µF 16WV T
C433 02-21002-85 Electrolytic, 100µF 16WV T
C434 02-24700-85 Electrolytic, 4.7µF 25WV T
C437 02-24700-85 Electrolytic, 4.7µF 25WV T

RESISTERs

R39 01-53320-84 3.3kΩ T
R66 01-51020-85 1kΩ T
R67 01-51530-85 15kΩ T
R68 01-54730-84 47kΩ T
R89 01-51020-85 1kΩ T
R90 01-51030-85 10kΩ T
R401 01-53020-85 3kΩ T
R402 01-51030-85 10kΩ T
R406 01-54720-84 4.7kΩ T
R407 01-52050-85 2MΩ T
R423 01-54720-84 4.7kΩ T
R424 01-54720-84 4.7kΩ T
R425 01-51030-85 10kΩ T
R426 01-51040-85 100kΩ T
R427 01-51030-85 10kΩ T
R428 01-51030-85 10kΩ T
R437 01-53320-84 3.3kΩ T
R438 01-53320-84 3.3kΩ T
R439 01-51550-85 1.5MΩ T

CONNECTOR

CON1 30-00273-00 12P Connector T

[11-C000080-01] LED Block
LED

LED1 19-00328-00 LED T
LED2 19-00328-00 LED T
LED3 19-00328-00 LED T
LED4 19-00328-00 LED T
LED5 19-00328-00 LED T
LED6 19-00328-00 LED T
LED7 19-00328-00 LED T
LED8 19-00328-00 LED T

RESISTERs

R1 01-10000-96 150Ω T
R3 01-10000-96 150Ω T
RJ1 01-10000-95 Jumper T
RJ2 01-10000-95 Jumper T

[11-05C04-32-B] MK494 Block

[11-05C02-32-D] Pre AMP Block
IC´s

U1 07-04574-00 IC T
U2 07-04574-00 IC T
U5 07-04574-00 IC T
U6 07-04574-00 IC T

CAPACITORs

C102 02-24700-45 Electrolytic, 4.7µF 50WV T
C103 02-24700-45 Electrolytic, 4.7µF 50WV T
C104 02-22201-45 Electrolytic, 22µF 16WV T
C105 02-22201-45 Electrolytic, 22µF 16WV T
C106 04-21000-05 Ceramic, 100PF 50WV T
C107 04-21000-05 Ceramic, 100PF 50WV T
C108 02-21001-45 Electrolytic, 10µF 25WV T
C109 02-24701-35 Electrolytic, 4.7µF 25WV T
C110 04-21000-05 Ceramic, 100PF 50WV T
C111 04-21000-05 Ceramic, 100PF 50WV T

9

CY-PA4003U

Ref. No. Part No. Part Name & Description Remarks

C112 03-24740-04 0.47µF 63WV T
C113 03-21040-07 0.1µF 63WV T
C202 02-24700-45 Electrolytic, 4.7µF 50WV T
C203 02-24700-45 Electrolytic, 4.7µF 50WV T
C204 02-22201-45 Electrolytic, 22µF 16WV T
C205 02-22201-45 Electrolytic, 22µF 16WV T
C206 04-21000-05 Ceramic, 100PF 50WV T
C207 04-21000-05 Ceramic, 100PF 50WV T
C208 02-21001-45 Electrolytic, 10µF 25WV T
C209 02-24701-35 Electrolytic, 4.7µF 25WV T
C210 04-21000-05 Ceramic, 100PF 50WV T
C211 04-21000-05 Ceramic, 100PF 50WV T
C212 03-24740-04 0.47µF 63WV T
C213 03-21040-07 0.1µF 63WV T
C302 02-24700-45 Electrolytic, 4.7µF 50WV T
C303 02-24700-45 Electrolytic, 4.7µF 50WV T
C304 02-22201-45 Electrolytic, 22µF 16WV T
C305 02-22201-45 Electrolytic, 22µF 16WV T
C306 04-21000-05 Ceramic, 100PF 50WV T
C307 04-21000-05 Ceramic, 100PF 50WV T
C308 02-21001-45 Electrolytic, 10µF 25WV T
C309 02-24701-35 Electrolytic, 4.7µF 25WV T
C310 04-21000-05 Ceramic, 100PF 50WV T
C311 04-21000-05 Ceramic, 100PF 50WV T
C312 03-24740-04 0.47µF 63WV T
C313 03-21040-07 0.1µF 63WV T
C402 02-24700-45 Electrolytic, 4.7µF 50WV T
C403 02-24700-45 Electrolytic, 4.7µF 50WV T
C404 02-22201-45 Electrolytic, 22µF 16WV T
C405 02-22201-45 Electrolytic, 22µF 16WV T
C406 04-21000-05 Ceramic, 100PF 50WV T
C407 04-21000-05 Ceramic, 100PF 50WV T
C408 02-21001-45 Electrolytic, 10µF 25WV T
C409 02-24701-35 Electrolytic, 4.7µF 25WV T
C410 04-21000-05 Ceramic, 100PF 50WV T
C411 04-21000-05 Ceramic, 100PF 50WV T
C412 03-24740-04 0.47µF 63WV T
C413 03-21040-07 0.1µF 63WV T
CP108 03-21002-35 Electrolytic, 100µF 25WV T
CP109 04-21040-05 Ceramic, 0.1µF 50WV T
CP110 04-21040-05 Ceramic, 0.1µF 50WV T
CP111 03-21002-35 Electrolytic, 100µF 25WV T

RESISTERs

C101 04-21030-05 Jumper T
C201 04-21030-05 Jumper T
C301 04-21030-05 Jumper T
C401 04-21030-05 Jumper T
R102 01-53630-61 36kΩ 1/8W T
R103 01-53630-61 36kΩ 1/8W T
R104 01-14710-22 470Ω 1/2W T
R105 01-53640-63 360kΩ 1/8W T
R106 01-53640-63 360kΩ 1/8W T
R110 01-51230-61 12kΩ 1/8W T
R111 01-51230-61 12kΩ 1/8W T
R112 01-11030-63 10kΩ 1/8W T
R113 01-11030-63 10kΩ 1/8W T
R114 01-18210-63 820Ω 1/8W T
R115 01-11010-63 100Ω 1/8W T
R116 01-11010-63 100Ω 1/8W T
R117 01-51020-63 1kΩ 1/8W T
R118 01-14740-61 470kΩ 1/8W T
R119 01-11830-63 18kΩ 1/8W T
R120 01-17510-63 750Ω 1/8W T
R121 01-11220-63 1.2kΩ 1/8W T
R122 01-12440-63 240kΩ 1/8W T
R202 01-53630-61 36kΩ 1/8W T
R203 01-53630-61 36kΩ 1/8W T
R204 01-14710-22 470Ω 1/2W T
R205 01-53640-63 360kΩ 1/8W T
R206 01-53640-63 360kΩ 1/8W T
R210 01-51230-61 12kΩ 1/8W T
R211 01-51230-61 12kΩ 1/8W T

Ref. No. Part No. Part Name & Description Remarks

R212 01-11030-63 10kΩ 1/8W T
R213 01-11030-63 10kΩ 1/8W T
R214 01-18210-63 820Ω 1/8W T
R215 01-11010-63 100Ω 1/8W T
R216 01-11010-63 100Ω 1/8W T
R217 01-51020-63 1kΩ 1/8W T
R218 01-14740-61 470kΩ 1/8W T
R219 01-11830-63 18kΩ 1/8W T
R220 01-17510-63 750Ω 1/8W T
R221 01-11220-63 1.2kΩ 1/8W T
R222 01-12440-63 240kΩ 1/8W T
R302 01-53630-61 36kΩ 1/8W T
R303 01-53630-61 36kΩ 1/8W T
R304 01-14710-22 470Ω 1/2W T
R305 01-53640-63 360kΩ 1/8W T
R306 01-53640-63 360kΩ 1/8W T
R310 01-51230-61 12kΩ 1/8W T
R311 01-51230-61 12kΩ 1/8W T
R312 01-11030-63 10kΩ 1/8W T
R313 01-11030-63 10kΩ 1/8W T
R314 01-18210-63 820Ω 1/8W T
R315 01-11010-63 100Ω 1/8W T
R316 01-11010-63 100Ω 1/8W T
R317 01-51020-63 1kΩ 1/8W T
R318 01-14740-61 470kΩ 1/8W T
R319 01-11830-63 18kΩ 1/8W T
R320 01-17510-63 750Ω 1/8W T
R321 01-11220-63 1.2kΩ 1/8W T
R322 01-12440-63 240kΩ 1/8W T
R402 01-53630-61 36kΩ 1/8W T
R403 01-53630-61 36kΩ 1/8W T
R404 01-14710-22 470Ω 1/2W T
R405 01-53640-63 360kΩ 1/8W T
R406 01-53640-63 360kΩ 1/8W T
R410 01-51230-61 12kΩ 1/8W T
R411 01-51230-61 12kΩ 1/8W T
R412 01-11030-63 10kΩ 1/8W T
R413 01-11030-63 10kΩ 1/8W T
R414 01-18210-63 820Ω 1/8W T
R415 01-11010-63 100Ω 1/8W T
R416 01-11010-63 100Ω 1/8W T
R417 01-51020-63 1kΩ 1/8W T
R418 01-14740-61 470kΩ 1/8W T
R419 01-11830-63 18kΩ 1/8W T
R420 01-17510-63 750Ω 1/8W T
R421 01-11220-63 1.2kΩ 1/8W T
R422 01-12440-63 240kΩ 1/8W T

VARIABLE RESISTERs

VR1 15-22030-07 Variable Resister T
VR2 15-22030-07 Variable Resister T
VR4 15-22030-07 Variable Resister T
VR5 15-22030-07 Variable Resister T

SWICTHs

SW1 18-00889-00 4P2T Swicth T
SW4 18-00889-00 4P2T Switch T

CONNECTOR

CN2 25-00714-00 7P Connector T

OTHER

RCA 32-00667-00 RCA Jack T

[11-05C03-32-C] Servo Block
IC´s AND TRANSISTORs

U9 07-04574-00 IC T
U10 07-04574-00 IC T

10

Ref. No. Part No. Part Name & Description Remarks

U11 07-04574-00 IC T
U12 07-04574-00 IC T
Q501 08-05551-00 Transistor T
Q502 08-05551-00 Transistor T
Q601 08-05551-00 Transistor T
Q602 08-05551-00 Transistor T
Q701 08-05551-00 Transistor T
Q702 08-05551-00 Transistor T
Q801 08-05551-00 Transistor T
Q802 08-05551-00 Transistor T

DIODEs

D501 09-14148-01 Diode T
D502 09-14148-01 Diode T
D601 09-14148-01 Diode T
D602 09-14148-01 Diode T
D701 09-14148-01 Diode T
D702 09-14148-01 Diode T
D801 09-14148-01 Diode T
D802 09-14148-01 Diode T

CAPACITORs

C500A 04-24700-03 Ceramic, 470PF 50WV T
C500B 04-24700-03 Ceramic, 470PF 50WV T
C501 02-21001-35 Electrolytic, 10µF 25WV T
C502 02-22201-45 Electrolytic, 22µF 50WV T
C503 02-22201-35 Electrolytic, 22µF 25WV T
C508 02-22201-35 Electrolytic, 22µF 25WV T
C509 03-24740-04 0.47µF 63WV T
C509A 04-20470-04 Ceramic, 47µF 50WV T
C510 02-22201-55 Electrolytic, 22µF 35WV T
C511 02-22201-55 Electrolytic, 22µF 35WV T
C600A 04-24700-03 Ceramic, 470PF 50WV T
C600B 04-24700-03 Ceramic, 470PF 50WV T
C601 02-21001-35 Electrolytic, 10µF 25WV T
C602 02-22201-45 Electrolytic, 22µF 50WV T
C603 02-22201-35 Electrolytic, 22µF 25WV T
C608 02-22201-35 Electrolytic, 22µF 25WV T
C609 03-24740-04 0.47µF 63WV T
C609A 04-20470-04 Ceramic, 47µF 50WV T
C610 02-22201-55 Electrolytic, 22µF 35WV T
C611 02-22201-55 Electrolytic, 22µF 35WV T
C700A 04-24700-03 Ceramic, 470PF 50WV T
C700B 04-24700-03 Ceramic, 470PF 50WV T
C701 02-21001-35 Electrolytic, 10µF 25WV T
C702 02-22201-45 Electrolytic, 22µF 50WV T
C703 02-22201-35 Electrolytic, 22µF 25WV T
C708 02-22201-35 Electrolytic, 22µF 25WV T
C709 03-24740-04 0.47µF 63WV T
C709A 04-20470-04 Ceramic, 47µF 50WV T
C710 02-22201-55 Electrolytic, 22µF 35WV T
C711 02-22201-55 Electrolytic, 22µF 35WV T
C800A 04-24700-03 Ceramic, 470PF 50WV T
C800B 04-24700-03 Ceramic, 470PF 50WV T
C801 02-21001-35 Electrolytic, 10µF 25WV T
C802 02-22201-45 Electrolytic, 22µF 50WV T
C803 02-22201-35 Electrolytic, 22µF 25WV T
C808 02-22201-35 Electrolytic, 22µF 25WV T
C809 03-24740-04 0.47µF 63WV T
C809A 04-20470-04 Ceramic, 47µF 50WV T
C810 02-22201-55 Electrolytic, 22µF 35WV T
C811 02-22201-55 Electrolytic, 22µF 35WV T
CP40 04-21040-05 Ceramic, 0.1µF 50WV T
CP41 04-21040-05 Ceramic, 0.1µF 50WV T
CP42 02-21002-35 Electrolytic, 100µF 25WV T
CP43 02-21002-35 Electrolytic, 100µF 25WV T

RESISTERs

R501 01-11040-63 100kΩ 1/8W T
R502 01-11030-63 10kΩ 1/8W T
R503 01-11030-63 10kΩ 1/8W T

CY-PA4003U

Ref. No. Part No. Part Name & Description Remarks

R504 01-11030-63 10kΩ 1/8W T
R505 01-11540-63 150kΩ 1/8W T
R506 01-11540-63 150kΩ 1/8W T
R507 01-11030-63 10kΩ 1/8W T
R508 01-11030-63 10kΩ 1/8W T
R509 01-51020-63 1kΩ 1/8W T
R510 01-52230-61 22kΩ 1/8W T
R511 01-51020-63 1kΩ 1/8W T
R512 01-52230-61 22kΩ 1/8W T
R513 01-51020-63 1kΩ 1/8W T
R516 01-11230-63 12kΩ 1/8W T
R519 01-54730-61 47kΩ 1/8W T
R520 01-16820-63 1.8kΩ 1/8W T
R521 01-11520-61 1.5kΩ 1/8W T
R522 01-54730-61 47kΩ 1/8W T
R522A 01-54730-61 47kΩ 1/8W T
R523 01-55110-61 510Ω 1/8W T
R524 01-57510-63 750Ω 1/8W T
R524A 01-55101-63 5.1kΩ 1/8W T
R525 01-55110-61 510Ω 1/8W T
R526 01-57510-63 750Ω 1/8W T
R526A 01-55101-63 5.1kΩ 1/8W T
R527 01-51820-63 1.8kΩ 1/8W T
R528 01-51820-63 1.8kΩ 1/8W T
R601 01-11040-63 100kΩ 1/8W T
R602 01-11030-63 10kΩ 1/8W T
R603 01-11030-63 10kΩ 1/8W T
R604 01-11030-63 10kΩ 1/8W T
R605 01-11540-63 150kΩ 1/8W T
R606 01-11540-63 150kΩ 1/8W T
R607 01-11030-63 10kΩ 1/8W T
R608 01-11030-63 10kΩ 1/8W T
R609 01-51020-63 1kΩ 1/8W T
R610 01-52230-61 22kΩ 1/8W T
R611 01-51020-63 1kΩ 1/8W T
R612 01-52230-61 22kΩ 1/8W T
R613 01-51020-63 1kΩ 1/8W T
R616 01-11230-63 12kΩ 1/8W T
R619 01-54730-61 47kΩ 1/8W T
R620 01-16820-63 1.8kΩ 1/8W T
R621 01-11520-61 1.5kΩ 1/8W T
R622 01-54730-61 47kΩ 1/8W T
R622A 01-54730-61 47kΩ 1/8W T
R623 01-55110-61 510Ω 1/8W T
R624 01-57510-63 750Ω 1/8W T
R624A 01-55101-63 5.1kΩ 1/8W T
R625 01-55110-61 510Ω 1/8W T
R626 01-57510-63 750Ω 1/8W T
R626A 01-55101-63 5.1kΩ 1/8W T
R627 01-51820-63 1.8kΩ 1/8W T
R628 01-51820-63 1.8kΩ 1/8W T
R701 01-11040-63 100kΩ 1/8W T
R702 01-11030-63 10kΩ 1/8W T
R703 01-11030-63 10kΩ 1/8W T
R704 01-11030-63 10kΩ 1/8W T
R705 01-11540-63 150kΩ 1/8W T
R706 01-11540-63 150kΩ 1/8W T
R707 01-11030-63 10kΩ 1/8W T
R708 01-11030-63 10kΩ 1/8W T
R709 01-51020-63 1kΩ 1/8W T
R710 01-52230-61 22kΩ 1/8W T
R711 01-51020-63 1kΩ 1/8W T
R712 01-52230-61 22kΩ 1/8W T
R713 01-51020-63 1kΩ 1/8W T
R716 01-11230-63 12kΩ 1/8W T
R719 01-54730-61 47kΩ 1/8W T
R720 01-16820-63 1.8kΩ 1/8W T
R721 01-11520-61 1.5kΩ 1/8W T
R722 01-54730-61 47kΩ 1/8W T
R722A 01-54730-61 47kΩ 1/8W T
R723 01-55110-61 510Ω 1/8W T
R724 01-57510-63 750Ω 1/8W T
R724A 01-55101-63 5.1kΩ 1/8W T
R725 01-55110-61 510Ω 1/8W T

11

CY-PA4003U

Ref. No. Part No. Part Name & Description Remarks

R726 01-57510-63 750Ω 1/8W T
R726A 01-55101-63 5.1kΩ 1/8W T
R727 01-51820-63 1.8kΩ 1/8W T
R728 01-51820-63 1.8kΩ 1/8W T
R801 01-11040-63 100kΩ 1/8W T
R802 01-11030-63 10kΩ 1/8W T
R803 01-11030-63 10kΩ 1/8W T
R804 01-11030-63 10kΩ 1/8W T
R805 01-11540-63 150kΩ 1/8W T
R806 01-11540-63 150kΩ 1/8W T
R807 01-11030-63 10kΩ 1/8W T
R808 01-11030-63 10kΩ 1/8W T
R809 01-51020-63 1kΩ 1/8W T
R810 01-52230-61 22kΩ 1/8W T
R811 01-51020-63 1kΩ 1/8W T
R812 01-52230-61 22kΩ 1/8W T
R813 01-51020-63 1kΩ 1/8W T
R816 01-11230-63 12kΩ 1/8W T
R819 01-54730-61 47kΩ 1/8W T
R820 01-16820-63 1.8kΩ 1/8W T
R821 01-11520-61 1.5kΩ 1/8W T
R822 01-54730-61 47kΩ 1/8W T
R822A 01-54730-61 47kΩ 1/8W T
R823 01-55110-61 510Ω 1/8W T
R824 01-57510-63 750Ω 1/8W T
R824A 01-55101-63 5.1kΩ 1/8W T
R825 01-55110-61 510Ω 1/8W T
R826 01-57510-63 750Ω 1/8W T
R826A 01-55101-63 5.1kΩ 1/8W T
R827 01-51820-63 1.8kΩ 1/8W T
R828 01-51820-63 1.8kΩ 1/8W T

VARIABLE RESISTERs

VR510 13-00219-00 Variable Resister T
VR610 13-00219-00 Variable Resister T
VR710 13-00219-00 Variable Resister T
VR810 13-00219-00 Variable Resister T

CONNECTORs

CN3 25-00715-00 8Pin Connector T
CN5 30-00277-00 15P Connector T

Ref. No. Part No. Part Name & Description Remarks

6 73-00160-00 Bracket 2VR T
7 73-00159-00 Bracket 1VR T
8 11-00662-00 Pre AMP PCB w/Component T/RTL
9 74-00207-00 Column Hexagon T
10 11-00661-00 Power AMP PCB w/Component T/RTL
11 11-00665-00 LED PCB w/Component T/RTL
12 76-00413-00 Display Lens T
13 77-00349-00 Heatsink T
14 76-00414-00 Display Cover T
15 71-00686-00 Top Cover T
16 74-00188-00 Bracket U Form T
17 74-00180-00 Bracket U Form T
18 30-00277-00 Servo PCB w/component T/RTL
19 74-00206-00 Column Hexagon T
20 74-00205-00 Column Hexagon T
21 71-00687-00 Side Panel Left T
22 78-00412-00 Mica Sheet T
23 78-00308-00 Mica Sheet T
24 74-00179-00 Bracket U Form T
25 78-00351-00 EVA Foam T
26 76-00412-00 Display Lens Sheet T
27 78-00407-00 Insulated Sheet T
28 78-00409-00 Insulated Sheet T
29 78-00408-00 EVA Foam T
30 76-00239-00 Fuse Holder T
31 24-00314-00 LED Holder T
32 11-00664-00 MK494 PCB w/Component T/RTL
33 25-00707-00 2P Connect Line T
34 24-00313-00 3.0*50 MM heat-shrink tube T
35 25-00706-00 Connect Line T
36 25-00705-00 Connect Line T
37 78-00348-00 1.0*8 MM fiber tube T
38 78-00323-00 1.0*10MM fiber tube T
39 78-00419-00 1.0*19 MM fiber tube T
40 78-00418-00 2.0*9 MM fiber tube T
41 34-00157-00 Wire 5P T
42 34-00157-01 Wire 5P T
43 76-00410-00 Wrap RCA Jack T
44 25-00709-00 Output wire SGND (Black) T
45 25-00710-00 Output wire RL OUT TO X2 (Brown) T
46 25-00711-00 Output wire FR OUT TO X3 (Gray) T
47 25-00712-00 Output wire RR OUT TO X4 (Green) T
48 25-00713-00 Output wire FL OUT TO X1 (White) T
49 76-00415-00 Tie Nylon T

Accessories
PRINTING

Installation Hardware
(For Installation)

(For Wiring)

MECHANICAL PARTS
MISCELLANEOUS

1 72-00475-00 Bottom Panel T
2 78-00411-00 Gasket Bottom T
3 78-00410-00 Gasket Switch T
4 71-00688-00 Side Panel Right T
5 76-00411-00 VR Cap T

- Operating Instructions TSN

ST-RP450-20 Tapping Screw (5*20) T
YH-00017-00 Plain Washer (5*) T
YH-00016-01 Allen Wrench T

35-00124-00 Speaker Input Connector for Front SP T
35-00124-01 Speaker Input Connector for Rear SP T
76-00408-00 Terminal Cover for Short-circuit

76-00409-00 Terminal Cover for Short-circuit

Prevention

Prevention

61 SM-1H240-09 Screw T
62 SM-FP220-05 Screw T
63 S3-RP430-06 Screw T
64 S3-RP420-10 Screw T
65 SM-RP240-12 Screw T
66 S3-RP430-05 Screw T
67 SM-RP430-08 Screw T
68 S3-RP430-10 Screw T
69 SM-RP230-W8 Screw T
70 S3-RP230-08 Screw T
71 YH-00019-00 Spring Washer for PCB Mounting T
72 YH-00018-00 Plat Washer T

T

T

12

9 EXPLODED VIEW (Unit)

CY-PA4003U

13