Nokia 2320 CLASSIC RM-514, 2320 CLASSIC RM-515, 2330 CLASSIC RM-512, 2330 CLASSIC RM-513, 2323 CLASSIC RM-543 Service Manual

Download

Page 1

Nokia 2320 classic / Nokia 2323 classic / Nokia 2330 classic

RM-512 / RM-513 / RM-514 / RM-515 / RM-543

Service Manual Level 1&2

SERVICE MANUAL

Level 1&2

RM-514 / RM-515 RM-543 RM-512 / RM-513

EU (RM-512, RM-514, RM-543): EGSM 900/1800 US (RM-513, RM-515) GSM 850/1900

Resolution 128 x 160

1.8 65000 color TFT display

RM-512 RM-513 RM-514 RM-515 RM-543

RM-512 RM-514 RM-543

Series 40

VGA (640x480 pixels)

Radio recording

AC-3 charger, AC-6C travel USB charger, 2.5 mm AV connector, Bluetooth 2.0 (RM-512 / RM-513 / RM-543)

550 h 560 h 580 h 580 h 575 h

380 h 400 h 318 h

Standby time and Talk time depends on network parameters and phone settings

4h 40 min 5 h 20 min 4 h 40 min 5 h 20 min 4 h 30 min

3 h 15 min 3 h 15 min 2 h 30 min

Up to 624 h Up to 560 h Up to 580 h Up to 580 h Up to 575 h

Up to 388 h Up to 397 h Up to 393 h

Up to 7 h 10 min Up to 7 h 40 min Up to 7 h 25 min

Up to 8 h Up to 7 h

Up to 5 h Up to 5 h

Up to 4 h 50 min

Page 2

Nokia 2320 classic / Nokia 2323 classic / Nokia 2330 classic

RM-512 / RM-513 / RM-514 / RM-515 / RM-543

Service Manual Level 1&2

1. Change history ............................................................................................................................................................................... 3

2. Copyright .......................................................................................................................................................................................... 4

3. Warnings and cautions ............................................................................................................................................................... 5

3.1 Warnings .............................................................................................................................................................................. 5

3.2 Cautions ................................................................................................................................................................................ 5

4. ESD protection ................................................................................................................................................................................ 6

5. Care and maintenance ................................................................................................................................................................ 7

6. Battery information ..................................................................................................................................................................... 8

7. Nokia 2330 classic Exploded view .......................................................................................................................................... 9

8. Nokia 2320 classic and Nokia 2323 classic Exploded view ..........................................................................................10

9. Service devices .............................................................................................................................................................................11

10. SW-update ................................................................................................................................................................................12

11. Disassembly instruction .......................................................................................................................................................13

12. Assembly hints ........................................................................................................................................................................18

13. Solder components ................................................................................................................................................................19

Page 3

Nokia 2320 classic / Nokia 2323 classic / Nokia 2330 classic

RM-512 / RM-513 / RM-514 / RM-515 / RM-543

Service Manual Level 1&2

Approved 1.0 01.04.2009 Approved

The purpose of this document is to help NOKIA service levels 1 and 2 workshop technicians to carry out service to NOKIA products. This Service Manual is to be used only by authorized NOKIA service suppliers, and the content of it is confidential. Please note that NOKIA provides also other guidance documents (e.g. Service Bulletins) for service suppliers, follow these regularly and comply with the given instructions.

While every endeavor has been made to ensure the accuracy of this document, some errors may exist. If you find any errors or if you have further suggestions, please notify NOKIA using the address below:

mailto:Service.Manuals@nokia.com

Please keep in mind also that this documentation is continuously being updated and modified, so watch always out for the newest version.

Page 4

Nokia 2320 classic / Nokia 2323 classic / Nokia 2330 classic

RM-512 / RM-513 / RM-514 / RM-515 / RM-543

Service Manual Level 1&2

Reproduction, transfer, distribution or storage of part or all of the contents in this document in any form without the prior written permission of Nokia is prohibited.

Nokia, Nokia Connecting People, and Nokia X and Y are trademarks or registered trademarks of Nokia Corporation. Other product and company names mentioned herein may be trademarks or tradenames of their respective owners.

Nokia operates a policy of continuous development. Nokia reserves the right to make changes and improvements to any of the products described in this document without prior notice.

Under no circumstances shall Nokia be responsible for any loss of data or income or any special, incidental, consequential or indirect damages howsoever caused.

The contents of this document are provided "as is . Except as required by applicable law, no warranties of any kind, either express or implied, including, but not limited to, the implied warranties of merchantability and fitness for a particular purpose, are made in relation to the accuracy, reliability or contents of this document. Nokia reserves the right to revise this document or withdraw it at any time without prior notice.

The availability of particular products may vary by region.

This document is intended for use by qualified service personnel only.

Page 5

Nokia 2320 classic / Nokia 2323 classic / Nokia 2330 classic

RM-512 / RM-513 / RM-514 / RM-515 / RM-543

Service Manual Level 1&2

Please refer to the phone!s user guide for instructions relating to operation, care and maintenance including important safety information. Note also the following:

1. CARE MUST BE TAKEN ON INSTALLATION IN VEHICLES FITTED WITH ELECTRONIC ENGINE

MANAGEMENT SYSTEMS AND ANTI#SKID BRAKING SYSTEMS. UNDER CERTAIN FAULT CONDITIONS, EMITTED RF ENERGY CAN AFFECT THEIR OPERATION. IF NECESSARY, CONSULT THE VEHICLE DEALER/MANUFACTURER TO DETERMINE THE IMMUNITY OF VEHICLE ELECTRONIC SYSTEMS TO RF ENERGY.

2. THE HANDPORTABLE TELEPHONE MUST NOT BE OPERATED IN AREAS LIKELY TO CONTAIN POTENTIALLY EXPLOSIVE ATMOSPHERES, EG PETROL STATIONS (SERVICE STATIONS), BLASTING AREAS ETC.

3. OPERATION OF ANY RADIO TRANSMITTING EQUIPMENT, INCLUDING CELLULAR TELEPHONES, MAY INTERFERE WITH THE FUNCTIONALITY OF INADEQUATELY PROTECTED MEDICAL DEVICES. CONSULT A PHYSICIAN OR THE MANUFACTURER OF THE MEDICAL DEVICE IF YOU HAVE ANY QUESTIONS. OTHER ELECTRONIC EQUIPMENT MAY ALSO BE SUBJECT TO INTERFERENCE.

1. Servicing and alignment must be undertaken by qualified personnel only.

2. Ensure all work is carried out at an anti#static workstation and that an anti#static wrist strap is worn.

3. Use only approved components as specified in the parts list.

4. Ensure all components, modules screws and insulators are correctly re#fitted after servicing and alignment.

5. Ensure all cables and wires are repositioned correctly

Page 6

Nokia 2320 classic / Nokia 2323 classic / Nokia 2330 classic

RM-512 / RM-513 / RM-514 / RM-515 / RM-543

Service Manual Level 1&2

Nokia requires that service points have sufficient ESD protection (against static electricity) when servicing the phone.

Any product of which the covers are removed must be handled with ESD protection. The SIM card can be replaced without ESD protection if the product is otherwise ready for use.

To replace the covers ESD protection must be applied.

All electronic parts of the product are susceptible to ESD. Resistors, too, can be damaged by static electricity discharge.

All ESD sensitive parts must be packed in metallized protective bags during shipping and handling outside any ESD Protected Area (EPA).

Every repair action involving opening the product or handling the product components must be done under ESD protection.

ESD protected spare part packages MUST NOT be opened/closed out of an ESD Protected Area.

For more information and local requirements about ESD protection and ESD Protected Area, contact your local Nokia After Market Services representative.

Page 7

Nokia 2320 classic / Nokia 2323 classic / Nokia 2330 classic

RM-512 / RM-513 / RM-514 / RM-515 / RM-543

Service Manual Level 1&2

This product is of superior design and craftsmanship and should be treated with care. The suggestions below will help you to fulfil any warranty obligations and to enjoy this product for many years.

Keep the phone and all its parts and accessories out of the reach of small children.

Keep the phone dry. Precipitation, humidity and all types of liquids or moisture can contain minerals that will corrode electronic circuits.

Do not use or store the phone in dusty, dirty areas. Its moving parts can be damaged.

Do not store the phone in hot areas. High temperatures can shorten the life of electronic devices, damage batteries, and warp or melt certain plastics.

Do not store the phone in cold areas. When it warms up (to its normal temperature), moisture can form inside, which may damage electronic circuit boards.

Do not drop, knock or shake the phone. Rough handling can break internal circuit boards.

Do not use harsh chemicals, cleaning solvents, or strong detergents to clean the phone.

Do not paint the phone. Paint can clog the moving parts and prevent proper operation.

Use only the supplied or an approved replacement antenna. Unauthorised antennas, modifications or attachments could damage the phone and may violate regulations governing radio devices.

All of the above suggestions apply equally to the product, battery, charger or any accessory.

Page 8

Nokia 2320 classic / Nokia 2323 classic / Nokia 2330 classic

RM-512 / RM-513 / RM-514 / RM-515 / RM-543

Service Manual Level 1&2

Note: A new battery!s full performance is achieved only after two or three complete charge and discharge cycles! The battery can be charged and discharged hundreds of times but it will eventually wear out.

When the operating time (talk-time and standby time) is noticeably shorter than normal, it is time to buy a new battery. Use only batteries approved by the phone manufacturer and recharge the battery only with the chargers approved by the manufacturer.

Unplug the charger when not in use. Do not leave the battery connected to a charger for longer than a week, since overcharging may shorten its lifetime.

If left unused a fully charged battery will discharge itself over time Temperature extremes can affect the ability of your battery to charge.

For good operation times with Ni-Cd/NiMh batteries, discharge the battery from time to time by leaving the product switched on until it turns itself off (or by using the battery discharge facility of any approved accessory available for the product).

Do not attempt to discharge the battery by any other means Use the battery only for its intended purpose.

Never use any charger or battery which is damaged.

Do not short-circuit the battery. Accidental short-circuiting can occur when a metallic object (coin, clip or pen) causes direct connection of the + and - terminals of the battery (metal strips on the battery) for example when you carry a spare battery in your pocket or purse. Shortcircuiting the terminals may damage the battery or the connecting object.

Leaving the battery in hot or cold places, such as in a closed car in summer or winter conditions, will reduce the capacity and lifetime of the battery. Always try to keep the battery between 15°C and 25°C (59°F and 77°F).

A phone with a hot or cold battery may temporarily not work, even when the battery is fully charged. Batteries! performance is particularly limited in temperatures well below freezing.

Do not dispose batteries in a fire! Dispose of batteries according to local regulations (e.g. recycling).

Do not dispose as household waste.

Page 9

SCREW1.4X4.6

TORX+4IP

I0016

Nokia 2320 classic / Nokia 2323 classic / Nokia 2330 classic

RM-512 / RM-513 / RM-514 / RM-515 / RM-543

Service Manual Level 1&2

A-COVERASSY I0001

SCREWRF1.4X5.0 TORX+4IP I0015

UISHIELDING I0002

LCDAM128x160 I0003

A1=LIGHTSWAPPACKAGE(I0004-I0008)

FM/BTSHIELDINGLID

A2=D-COVERASSYBLACK(I0009-I0011)

EARPIECEMODULE

I0006

I0010

D-COVER

I0009

EFIICOVER

I0011

SCREWM1.4X3.4

TORX+4IP

I0014

DOMESHEETASSY I0004

LIGHTSWAPPWB I0005

BBSHIELDINGLID I0007

A3=ANTENNAMODULE(I0012-I0013)

MICROPHONE(BSE) I0012

IHFSPEAKER I0013

TYPELABEL I0008

BATTERYCOVER I0017

Ver.1.0

Onlyavailableas assembly

Thesepartscannotbe reusedafterremoval

Page 10

SCREW1.4X4.6

TORX+4IP

I0016

Nokia 2320 classic / Nokia 2323 classic / Nokia 2330 classic

RM-512 / RM-513 / RM-514 / RM-515 / RM-543

Service Manual Level 1&2

A-COVERASSY I0001

SCREWRF1.4X5.0 TORX+4IP I0015

UISHIELDING I0002

LCDAM128x160 I0003

A1=LIGHTSWAPPACKAGE(I0004-I0008)

FM/BTSHIELDINGLID

A2=D-COVERASSYBLACK(I0009-I0011)

(RM-543)

I0006

EARPIECEMODULE

I0010

D-COVER

I0009

EFIICOVER

I0011

SCREWM1.4X3.4

TORX+4IP

I0014

DOMESHEETASSY I0004

LIGHTSWAPPWB I0005

BBSHIELDINGLID I0007

A3=ANTENNAMODULE(I0012-I0013)

MICROPHONE(BSE) I0012

IHFSPEAKER I0013

TYPELABEL I0008

BATTERYCOVER I0017

Ver.1.0

Onlyavailableas assembly

Thesepartscannotbe reusedafterremoval

Page 11

Nokia 2320 classic / Nokia 2323 classic / Nokia 2330 classic

RM-512 / RM-513 / RM-514 / RM-515 / RM-543

Service Manual Level 1&2

FLS-5 Flash Device

AC-3 Travel Charger

CA-112DS Data Service Cable

BL-5C Battery

CA-111DS Service Cable

(alternative)

ACF-8 Power Supply

FLS-4s POS Flash Device

(alternative)

ACF-8 Country-Specific Adapters

For more information, refer to the Service Bulletin (SB-011) on NOKIA Online. Supplier or manufacturer contacts for tool re-order can be found in "Recommended service equipment document on NOKIA Online.

Page 12

Nokia 2320 classic / Nokia 2323 classic / Nokia 2330 classic

RM-512 / RM-513 / RM-514 / RM-515 / RM-543

Service Manual Level 1&2

To use the FLS-5 or FLS-4s Flash Dongle, you have to follow the user guide inside the sales package. Please check always for the latest version of flash software, wich is available on Nokia Online.

For flashing with FLS-5 use the CA-112DS cable

For flashing with FLS-4 use the CA-111DS cable NOTE: No longer available for purchase

Page 13

Nokia 2320 classic / Nokia 2323 classic / Nokia 2330 classic

RM-512 / RM-513 / RM-514 / RM-515 / RM-543

Service Manual Level 1&2

1) Nokia 2320 classic, Nokia 2323 classic and Nokia 2330 classic disassembly. Please notice that the model used in the following instructions is Nokia 2330 classic.

3) Press the BATTERY COVER release button to remove the BATTERY COVER.

2) Use the Nokia Standard Toolkit version 2.

4) Remove the BATTERY COVER.

5) Unscrew the two Torx+ 4 SCREWS in the order shown. The SCREWS cannot be used again. Discard them.

6) Use the SRT-6 to release the five snaps on the right side of the A-COVER.

Page 14

Nokia 2320 classic / Nokia 2323 classic / Nokia 2330 classic

RM-512 / RM-513 / RM-514 / RM-515 / RM-543

Service Manual Level 1&2

7) Continue to release the snaps on the left side of the A-COVER with the SRT-6.

9) Unscrew the five Torx+ 4 SCREWS in the order shown. The SCREWS cannot be used again. Discard them.

8) Remove the A-COVER.

10) Protect the LCD with a protective film.

11) Separate the ENGINE MODULE from the D-COVER by releasing the first clip using the SRT-6.

12) Release the second clip on the left side of the ENGINE MODULE using the SRT-6.

Page 15

Nokia 2320 classic / Nokia 2323 classic / Nokia 2330 classic

RM-512 / RM-513 / RM-514 / RM-515 / RM-543

Service Manual Level 1&2

13) Remove the ENGINE MODULE. 14) Use the SS-93 to remove the ANTENNA MODULE.

15) Use the dental tool to lever out the microphone.

Be careful not to damage yourself or the microphone!

17) Remove the EARPIECE MODULE using tweezers. 18) Remove EF II COVER by pulling it out gently in

16) Use the dental tool to lever out the EARPIECE MODULE.

the direction shown.

Page 16

Nokia 2320 classic / Nokia 2323 classic / Nokia 2330 classic

RM-512 / RM-513 / RM-514 / RM-515 / RM-543

Service Manual Level 1&2

19) On the right side of the UI SHIELDING, release the

first clip using the SS-93.

21) Remove the UI SHIELDING. 22) Carefully release the LCD connector using the

20) Release the second clip on the left side of the UI SHIELDING using the SS-93.

SS-93. Be careful not to damage the connector or any other components nearby!

23) Remove the LCD. 24) Use the dental tool to lift an edge of the DOME

SHEET. Be careful not to damage the DOME SHEET or the PWB!

Page 17

Nokia 2320 classic / Nokia 2323 classic / Nokia 2330 classic

RM-512 / RM-513 / RM-514 / RM-515 / RM-543

Service Manual Level 1&2

25) Slowly peel back and remove the DOME SHEET. The

DOME SHEET cannot be used again. Discard it.

26) Nokia 2330 Classic disassembly is now complete.

- END OF DISASSEMBLING -

Page 18

Nokia 2320 classic / Nokia 2323 classic / Nokia 2330 classic

RM-512 / RM-513 / RM-514 / RM-515 / RM-543

Service Manual Level 1&2

1) Make sure the DOME SHEET is glued back in its

correct place on the PWB.

3) Place the ENGINE MODULE in its place with respect

to the snap on the D-COVER.

2) Press the PWB gently in the direction shown to lock with the snaps of the UI SHIELDING.

4) Then press gently on the lower ends of the ENGINE MODULE to lock with the two snaps on the DCOVER.

5) After placing the ENGINE MODULE, tighten the five

Torx+ 4 screws to the torque of 18 Ncm in the order shown.

6) After the A-COVER is in place, tighten the two Torx+ 4 screws to the torque of 14 Ncm in the order shown.

Page 19

Nokia 2320 classic / Nokia 2323 classic / Nokia 2330 classic

RM-512 / RM-513 / RM-514 / RM-515 / RM-543

Service Manual Level 1&2

F2000

X1001 V2411

Above is RM-512 and RM-513 PWB Layout. For RM-514, RM-515 and RM-543, the solder components are

the same position as RM-512.

V2410 X7802

X7801

Nokia 2320 CLASSIC RM-514, 2320 CLASSIC RM-515, 2330 CLASSIC RM-512, 2330 CLASSIC RM-513, 2323 CLASSIC RM-543 Service Manual

Specifications and Main Features

Frequently Asked Questions

User Manual