EG1400X
Owner’s Manual
EG1400X l EG2200X
Thank you tor purchasing a Honda generator.
This manual covers operation and maintenace of EG1400X and EG2200X
generators. All information in this publication is based on the latest product
information available at the time of approval for printing.
Honda Motor Co., Ltd. reserves the right to make changes at any time without
notice and without incurring any obligation.
No part of this publication may be reproduced without written permission.
This manual should be considered a permanent part of the generator and
should remain with the generator when it is sold.
Pay special attention to statements preceded by the following words:
m Indicates a strong possibility of severe personal injury or loss of
life if instructions are not followed.
CAUTION: Indicates a’ possibility of personal injury or equipment damage if
instructions are not followed.
NOTE: Gives helpful information.
If a problem should arise, or if you have any questions about the generator,
consult an authorized Honda dealer.
B Honda generators are designed to give safe and dependable service
if operated according to instructions.
Manual before operating the generator. Failure to do so could result in personal injury or equipment damage.
Read and understand the Owner’s
1
CONTENTS
CONTENTS
CAUTION LABEL LOCATION
GENERATOR SAFETY
::
COMPONENT IDENTIFICATION
3.
PRE-OPERATION CHECK
4.
STARTING THE ENGINE
5.
l
High altitude operation.
6.
GENERATOR USE ..................................
STOPPING THE ENGINE .............................
;:
MAINTENANCE
9.
TRANSPORTING/STORAGE
10.
TROUBLESHOOTING
11.
WIRING DIAGRAM
12.
SPECIFICATIONS
13.
WARRANTY SERVICE
...............................
............................
.............................
.............................
.................................... 18
................................
................................. 29
...................................
...............................
......................... 3
........................
10
12
13
17
.......................... 26
27
30
31
4
5
7
2
1 .CAUTION LABEL LOCATION
CARBON MONOXIOE CAUTION LABEL
(a
ATTENTION
I
ATENCION
)XIIIE POISON,NG,
ROT USE lNo00RS DUE TO OAffiER Of CAGGON
NE PAS UTILISER OANS UN ENOROll fERME A CAUSE OU
RLSGUE D’EMPOISONNEMENT OU GAZ.
NO LO USE EN LUG
DE CARBON0 ES VE
OIL LEVEL LABEL
ls===i
GASOLINE CAUTION LABEL
2.GENERATOR SAFETY
To ensure safe operation -
l
Place the generator at least 1 m (3 ft) away from buildings or other equipment during operation.
l
Operate the generator on a level surface.
If the generator is tilted, fuel spillage may result.
l
Exhaust gas contains poisonous carbon monoxide.
Never run the generator in an enclosed area.
Be sure to provide adequate ventilation.
l
Know how to stop the generator quickly and understand operation of all
the controls. Never permit anyone to operate the generator without proper
instructions.
l
The generator is a potential source of electrical shock if misused. Do
not expose the generator to moisture, rain or snow. Do not let the
generator get wet, and do not operate it with wet hands.
l
Keep children and pets away from the generator when it is in operation.
l
Keep away from rotating parts while the generator is running.
l
Connections for standby power to a building’s electrical system must
be made by a qualified electrician and must comply,with all applicable
laws and electrical codes. Improper connections can allow electrical
current from the generator to backfeed into the utility lines. Such
backfeed may electrocute utility company workers or others who
contact the lines during a power outage, and when utility power is
restored, the generator may explode, burn, or cause fires in the
building’s electrical system.
STARTER
GRIP
3,COMPONENT IDENTIFICATION
DC CIRCUIT BREAKER
OIL FILLER CAP
5
FUEL FILLER CAP
MUFFLER
6
4.PRE-OPERATION CHECK
CAUTION: Be sure to check the generator on a level surface with the engine
stopped.
1. Check the engine oil level.
CAUTION: Engine oil is a major factor affecting engine performance and
service life. Nondetergent or vegetable oils are not recommended.
Use Honda 4-stroke oil, or an equivalent high detergent, premium quality
motor oil certified to meet or exceed U.S. automobile manufacturers’
requirements for Service Classification SG,SF/CC,CD. Motor oils classified SG,SF/CC,CD will show this designation on the container.
SAE low-30 is recommended for general, all-temperature use. Other
viscosities shown in the chart may be used when the average temperature
in your area is within the indicated range.
Remove the oil filler cap, and wipe the dipstick with a clean rag. Check the
oil level by inserting the dipstick in the filler hole without screwing it in.
If the oil level is below the end of the dipstick, add oil to the upper level
mark on the dipstick.
NOTE: The Oil Alert System will automatically stop the engine before
the oil level falls below the safe limit. However, to avoid the inconvenience
of an unexpected shutdown, it is still advisable to visually inspect the oil
level regularly.
>I II -
I I
2OW-40,2OW-50
I I I
I
1 ow.40
I
low-30
-20 0 20 40 60 80 100°F
,
-30 -20 -10 0 10 20 30 .40-c
h UPPER LEVEL
I
1
OIL FILLkR HOLE
OIL FILLER
DIP &TICK
h
-t
LOWER LEVEL
7
2. Check the fuel level
Remove the filler cap and check the fuel level.
Refill the tank if the fuel level is low.
Your engine is designed to use any gasoline that has a pump octane number
(y) of 86 or higher, or that has a research octane number of 91 or higher.
Gasoline pumps at service station normally display the pump octane number.
We recommend that you use unleaded fuel because it produces fewer
engine and spark plug deposits and extends the life of exhaust system
components.
Never use stale or contaminated gasoline or an oil/gasoline mixture. Avoid
getting dirt, dust or water in the fuel tank. Use of a lower octane gasoline
can cause persistent “pinging” or heavy “spark knock” (a metallic rapping
noise) which, if severe, can lead to engine damage.
CAUTION: If “spark knock” or “pinging” occurs at a steady engine
speed under normal load, change brands of gasoline. If spark knock or
pinging persists, consult your authorized Honda dealer. Failure to do so
is considered misuse, and damage caused by misuse is not covered by
Honda’s Limited Warranty.
Occasionally you may experience light spark knock while operating under
heavy loads. This is no cause for concern,
it simply means your engine is
operating efficiently .
Clean the fuel filler screen ragularly.
Fuel tank capacity
EG1400X: 2.7 0 (0.71 US gal)
EG2200X: 3.7 P (0.98 US gal)
FUEL FILLER
SCREEN
l
Gasoline is extremely flammable and is explosive under certain
conditions.
l
Refuel in a well-ventilated area with the engine stopped. Do not
smoke or allow flames or sparks in the area where the engine is
refueled or where gasoline is stored.
l
Do not overfill the fuel tank (there should be no fuel in the filler neck.)
After refueling, make sure the tank cap is closed properly and secureIY.
l
Be careful not to spill fuel when refueling. Spilled fuel or fuel vapor
may ignite. If any fuel is spilled, make sure the area is dry before
starting the engine.
l
Avoid repeated or prolonged contact with skin or breathing of vapor.
KEEP OUT OF REACH OF CHILDREN.
GASOLINES CONTAINING ALCOHOL
If you decide to use a gasoline containing alcohol (gasohol), be sure it’s
cotane rating is at least as high as that recommended by Honda. There are
two types of “gasohol”: one containing ethanol, and the other containing
methanol. Do not use gasohol that contains more than 10% ethanol. Do not
use gasoline containing methanol (methyl or wood alcohol) that does not
also contain consolvents and corrosion inhibitors for methanol. Never use
gasoline containing more than 5% methanol, even if it has con-solvents and
corrosion inhibitors.
NOTE:
l
Fuel system damage or engine performance problems resulting front the
use of fuels that contain alcohol is not covered under the warranty.
Honda cannot endorse the use of fuels containing methanol since evi-
dence of their suitability is as yet incomplete.
l
Before buying fuel from an unfamiliar station, try to find out if the fuel
contans alcohol, if it does, confirm the type and percentage of alcohol
used. If you notice any undesirable operating symptoms while using a
gasoline that contains alcohol, or one that you think contains alcohol,
switch to a gasoline that you know does not contain alcohol.
9
5.STARTING THE ENGINE
Disconnect any load from the DC
(1)
terminals and make sure that the AC
circuit breaker is in the OFF position.
mil
ON OFF
(2) Turn on the fuel valve,
(3) Turn on the engine switch.
10
Loading...