Alpine INAN-333-RRS, INAN-333-RS Service manual

INA-N333RRS

SERVICE MANUAL

GPS Car Navigation / CD Receiver

INA-N333RS

- Confidential -

3 /04-A
68E36308S01

"Schematic Diagram (ECU P.W.Board / ASSY,FPC SHEET SW) cannot use a reference function"

INA-N333RS/

(INA-N333RS)

TO ALPINE Home Page

<Cautions for Safe Repair Work>

r

s

.

- 2 -

The following cautions will prevent accidents in the workplace and will ensure safe products.
*The symbols indicate caution is needed to prevent injuries and damage to property.
The symbols and their meanings follow.

Warning

Caution

*The following symbols indicate two levels of cautions.

When you see this symbol, you have to be very careful.

When you see this symbol, you have to follow the instructions there.

If you ignore this symbol and handle the product incorrectly or unsafely,
serious injury or death may result.

If you ignore this symbol and handle the product incorrectly or unsafely,
injury or only material damage may result.

Warning

Do not look squarely into the laser light
coming from the pickup.

You may loose you sight. Use of an incorrect fuse may result in a fire.

Caution

Do not allow wiring to be caught in the Battery Caution
screw/chassis. Use the designated battery.

If wiring is caught in the screw/chassis, it may Confirm the correct polarity and seat of the battery.
cause a short circuit, resulting in a fire. An incorrect battery or an improperly connected or

Fuse Caution

Always use a designated fuse.

seated battery may result in a fire.

High Temperature Caution Designated Parts Caution

Touching the heat sink may cause severe burns. Look up the part list and ensure that only

designated parts are used to prevent problems or
accidents.

Reverse Power Supply Connections o
Misconnections Caution

Reverse power supply connections or prevent problems with ignition/breakdown.
misconnections may cause ignition problems and
smoke may result.

Soldering Caution Wear Glove

Hot solder from solder splash may cause severe Wear gloves to prevent electrical shocks or injury
burns. from the end face of the metal.

For the FDA laser standard, the following CAUTION label is stuck on each product

Please be careful for repair.

CAUTION-Laser radiation when open, DO NOT STARE INTO BEAM

Wiring Caution

Ensure that the wiring is correct when rewiring to

Contents

- 3 -

INA-N333RS/INA-N333RRS

Packing Assembly Parts List
Packing Method View
System Connection
Specifications
I/O Interface

5 to 7

8 , 9

10 to 16

Extension Cable
Adjustment Procedures
Block Diagram
Parts Layout on P.W.Boards and Wiring Diagram
Schematic Diagram
Terminal Voltage of IC/ TR

18 , 19

20, 21
22 to 26
27 to 40
41 to 48

4
4

17

Description of IC Terminal
Exploded View (Cabinet)
Exploded View (DVD Deck Mechanism) (DV33M01B)

49 to 55

56 , 57

58

NOTE : Due to continuing product improvement, specifications and designs are subject to
change without notice.

105

102

103

106

104

101

Packing Method View

101 -1

X4

105

X1

104

X1

101 -3

X1

101 -2

X1

101 -4

X1

X1

102

0.5

0.85

AMP

0.5

0.85

AMP

X3

X1

X1

103

Packing Assembly Parts List

Symbol

No.

Part No.

Description

101-1
101-2
101-3
101-4
102

103
104
105
106

03S60820Y16
03S60824Y01
36A11113W01
03A60836Y01
01T15359Y14

01T85385W04
15D50063Y01
15D50406W02
68-00323Z55

SCR,MCH 5X8 ZN A
SCR,WAV 1.7X4 ZN A
CAP,RUBBER(A)
SCR,CUS 5X7 ZN A
ASSY,ISO CONN N033RS

GPS ANT,GPA-CG2C1
CARRYING,CASE
CASE,INNER
O/M AOEU

Symbol

No.

Part No.

Description

INA-N333RS/INA-N333RRS

- 4 -

TO CONTENTS

System Connection

- 5 -

TO CONTENTS

<Connection>

INA-N333RS/INA-N333RRS

ISO Antenna Converter Plug

(Yellow/Blue) PARKING BRAKE

(Pink/Black) AUDIO INTERRUPT IN

(Blue/White) REMOTE TURN-ON

(Orange) DIMMER

(Red) IGNITION

(Black) GND

(Blue) POWER ANT

coil

10



BATTERY (Yellow)

choke

6

7

8

9



SPEED SENSOR

(Green/White)

1

11





12



*

speed sensor
auxiliary lead

Antenna

ISO Antenna Plug

2



3



4



5



To remote control

13





14

15



interface Box

To RDS-TMC Box (TMC-001P)

To the parking brake signal line

To vehicle phone

To amplifier or equalizer
To the instrument cluster

illumination lead
To power antenna

Ignition Key

Battery

To the vehicle speed pulse line

CD Changer

(Ai-NET)

(Sold Separately)

Speakers

18



Ai-NET

NORM EQ/DIV



24

19





22

20





17



21

16



(Green)

(Green/Black)

(White)

(White/Black)

(Gray/Black)

(Gray)

(Violet/Black)

(Violet)

-

25



26



27



28



29




30
31



32

22

22



Amplifier

Amplifier

Amplifier

Rear Left

Front Left

Speakers

Front Right

Rear Right

Front

Rear

Subwoofer



23

INA-N333RS/INA-N333RRS

- 6 -

TO CONTENTS

1

Antenna Receptacle

Connect to the supplied ISO antenna converter plug.

2

king Brak

Par

Connect this lead to the power supply side of the parking
brake switch to transmit the parking brake status signals to
the INA-N333RR.

3

Audio Interrupt In Lead (Pink/Blac

Connect this lead to the Audio Interface output of a cellular
phone which pro
received.

4

Remote Turn-On Lead (Blue/White)

Connect this lead to the remote turn-on lead of your
amplifier or signal processor.

5

Dimmer Lead (Or

This lead may be connected to the vehicle's instrument
cluster illumination lead. This will enable the vehicle's
dimmer control to dim the backlighting of the unit.

6

Switched Power

Connect this lead to an open terminal on the vehicle's fuse
box or another unused power source which provides (+) 12V
only when the ignition is turned on or in the accessory
position.

7

Ground Lead (Black)

Connect this lead to a good chassis gr
Mak

e sure the connection is made to bare metal and is

securely fastened using the sheet metal screw provided.

8

wer Antenna Lead (Blue)

Po

Connect this lead to the +B terminal of your po
if applicable.

e Lead (Yello

vides ground shorting w

ange)

Lead (Ignition) (Red)

w/Blue)

k)

hen a call is

ound on the v

wer antenna,

NOTE

This lead should be used only for controlling the vehicle's power
antenna. Do not use this lead to turn on an amplif
processor,

9

Batter

Connect this lead to the positive
battery.

10

Fuse Holder (10A)

11

ISO Power Supply Connector
Speed Sensor (Green/White)

12

Connect to

Improper connection of the speed pulse line may cause
important safety fe
brakes or air bags). Such failures may result in an accident
and loss of life. We strongly recommend that the installation
be performed by a tr

* If the connectors of the vehicle are not ISO type or they

etc.

w)

y Lead (Y

are ISO type but not equipped with the speed sensor
terminal on the v
supplied speed sensor auxiliary cable to connect to the
speed sensor cable of the vehicle.

ello

VSS (Digital or Analog 0V - 3V)

atures of the v

ained

ehicle side ISO connector

(+) post of the v

ehic

ized Alpine dealer.

, author

le to fail (suc

ier or a signal

ehicle's

, use the

ehic

h as the

le.

Remote Control Interf

13

To remote control interf

14

To RDS-TMC Receiv

ace Connector

ace box.

er (Optional)

NOTE

To connect an
dealer.

15

GPS Antenna (Included)
Power Supply Connector

16



Ai-NET Connector

17

Connect this to the output or input connector of other
product (CD chang

NET.

Ai-

System Switch

18

When connecting a pr
switch in the EQ/DIV position.
connected

Alpine RDS-TMC Recei

er

, Equalizer

ocessor using

, leave the

switch

in the NORM position.

consult your

ver,

.) equipped with

, etc

Ai-NET

When no de

Alpine

, place this

vice is

NOTE

Be sur

e to turn the power of

h position.

switc

Front Output RCA Connectors

19

RED is right and WHITE is left.

Rear Output RCA Connectors

20

-

RED is right and WHITE is left.

21

Subwoofer Output RCA Connectors

RED is right and WHITE is left.

22

RCA Extension Cab

23

Ai-NET Cable (Included with CD Changer)

24

ISO Connector (Speaker Output)

25

Left Rear (+) Speak

26

Left Rear (

27

Left Front (+) Speak

28

Left F

29

Right F
Right F

30

Right Rear (–) Speak

31

Right Rear (+) Speaker Output Lead (Violet)

32

–) Speaker Output Lead (Green/Black)

ront (–) Speaker Output Lead (White/Blac

ront (–) Speaker Output Lead (Gra
ront (+) Speak

f to the unit befor

le (Sold Separately)

er Output Lead (Green)

er Output Lead (White)

er Output Lead (Gra

er Output Lead (Violet/Blac

e c

y/Blac
y)

hang

ing the

k)

k)

k)

To prevent external noise from entering the audio system.

• Locate the unit and route the leads at

• Keep

• Connect the gr

• If you add an optional noise suppressor
suppressors, contact them for further information.

• Y

the battery power

ound lead securely to a bare metal spot (remove any paint, dirt or gr

our Alpine dealer knows best a

leads as far

least 10 cm away

away from other leads as possible.

, connect it as far away

bout noise prevention measures so consult your dealer for

from the car harness.

r

from the unit as possible.

ease if necessary) of the car c

hassis.

Alpine dealer carries various noise

Y

our

further information.

<Connection with optional RDS-TMC Receiver Box TMC-001P>

- 7 -

TO CONTENTS

<INA-N333RS/INA-N333RRS>

INA-N333RS/INA-N333RRS

TMC-001P
Attached
antenna

ACC (Ignition) (Red)

Battery lead (Yellow)

Ground (Black)

TMC-001P

TMC Receiver Box

(Sold Separately)

 For further information about the connection and

installation of TMC-001P, refer to the owner's manual of
TMC-001P.

NOTE

* Matching the optional Navig

to part of

the b

uilt-in

ation Disc (NVD-T334) with the RDS-TMC Receiver Bo

TMC tuner.

Ignition Key

Battery

x (TMC-001P) may cause function failure

INA-N333RS/INA-N333RRS

- 8 -

TO CONTENTS

Specifications

<FM RADIO>

Intermediate Frequency ......................................................................................................................... 10.7±0.1MHz

Frequency Range ............................................................................................................................... 87.5 to 108MHz

Usable Sensitivity (Mono, 30dB S/N, at 98.1MHz) .......................................................................................... 20.2dBf

-3dB Limiting Sensitivity (at 98.1MHz) ............................................................................................................ 21.2dBf

Residual Noise (Ref. 400Hz (narrow), at 98.1MHz) ...................................................................................... 28±10dB

S/N Ratio (at 98.1MHz) ......................................................................................................................... Stereo : 55dB

Mono : 58dB

Image Rejection (at 106.1MHz) .......................................................................................................................... 40dB

IF Rejection (at 90.1MHz) ................................................................................................................................... 60dB

Distortion (Input 60dBu, at 98.1MHz) ................................................................................................................... 1%

Frequency Response (Ref. 400Hz, at 98.1MHz) ................................................................................. 100Hz : 0±3dB

10kHz : -10±3dB

Stereo Separation (1kHz, at 98.1MHz) ............................................................................................................... 20dB

PS Sensitivity (at 98.1MHz) ............................................................................................................................ 36.2dBf

<MW RADIO>

Intermediate Frequency ....................................................................................................................... 1st. : 10.7MHz

2nd. : 450kHz

Frequency Range .............................................................................................................................. 531 to 1,602kHz

Usable Sensitivity (20dB S/N, at 999kHz) ........................................................................................................... 36dB

S/N Ratio (at 999kHz) ......................................................................................................................................... 44dB

Image Rejection (at 1,404kHz) ............................................................................................................................ 50dB

IF Rejection (at 603kHz) ..................................................................................................................................... 60dB

Distortion (at 999kHz) .......................................................................................................................................... 1.5%

Frequency Response (Ref. 400Hz, at 999kHz) .................................................................................. 100Hz : -3±4dB

2.5kHz : -5+3, -5dB

<LW RADIO>

Intermediate Frequency ....................................................................................................................... 1st. : 10.7MHz

2nd. : 450kHz

Frequency Range ................................................................................................................................. 153 to 281kHz

Usable Sensitivity (20dB S/N, at 216kHz) ........................................................................................................... 42dB

S/N Ratio (at 216kHz) ......................................................................................................................................... 44dB

Image Rejection (at 270kHz) ............................................................................................................................... 50dB

IF Rejection (at 162kHz) ..................................................................................................................................... 60dB

Distortion (at 216kHz) .......................................................................................................................................... 1.5%

Frequency Response (Ref. 400Hz, at 216kHz) .................................................................................. 100Hz : -3±4dB

2.5kHz : -5+3, -5dB

INA-N333RS/INA-N333RRS

- 9 -

TO CONTENTS

<CD SECTION>

System ....................................................................................................................... Optical (Compact Disc System)

Channel Balance (TCD-782, 1kHz) ................................................................................................................... 0±3dB

Distortion (TCD-782, 1kHz) ................................................................................................................................. 0.1%

Frequency Response (TCD-782, Ref. 997Hz) ....................................................................................... 17Hz : 0±3dB

127Hz : 0±2dB

10.007kHz : 0±2dB

19.997kHz : 0±4dB

S/N Ratio (TCD-782) ........................................................................................................................................... 80dB

Separation (TCD-782, 1kHz) ............................................................................................................................... 55dB

De-Emphasis (TCD-782, Ref. 1kHz) .................................................................................................. 4kHz : -20±3dB

16kHz : -20±3dB

<Pickup>

Wave Length .................................................................................................................................................... 655nm

Laser Power .................................................................................................................................................. CLASS II

<GENERAL>

Power Output (TCD-782 (Track No. 2, 1kHz), T.H.D. 10%) /Impedance .............................................. 18W/ch/4ohm

Pre Output (TCD-782 (0dB, 1kHz), Ref. FRONT, T.H.D. 1%) /Impedance ............................ 2V±2.5dBV/ch/10kohm

Sub-Woofer Output Level (TCD-782 (0dB, 1kHz), STEP-0, Ref. FRONT PRE-OUT) ................................... -15±3dB

Navigation Voice Output Level (1kHz, -6dB) ...................................................................................... 800±150mVrms

Back-Up Current .................................................................................................................................................. 5mA

Dimensions (W x H x D) ................................................................................................. Chassis : 178 x 50 x 158mm

Nose (at Closed) : 188 x 58 x 24.5mm

Nose (at Full Opened) : 188 x 58 x 52mm

Weight .................................................................................................................................................................... 2kg

NOTE : Due to Continuing product improvement, specifications and designs are subject to change without notice.

INA-N333RS/INA-N333RRS

- 10 -

TO CONTENTS

INA-N333RS/INA-N333RRS

- 11 -

TO CONTENTS

INA-N333RS/INA-N333RRS

- 12 -

TO CONTENTS

INA-N333RS/INA-N333RRS

- 13 -

TO CONTENTS

INA-N333RS/INA-N333RRS

- 14 -

TO CONTENTS

INA-N333RS/INA-N333RRS

- 15 -

TO CONTENTS

INA-N333RS/INA-N333RRS

- 16 -

TO CONTENTS

INA-N333RS/INA-N333RRS

- 17 -

TO CONTENTS

Extension Cable

* When repairing or measuring the voltage of this unit, connect with the Extension Cable as shown in below.

DVD Deck Mechanism

Extension Cable

(01E33127S01)

SUB P.W.Board

ASSY, NAVI CARD V-245

Extension Cable

(01E30083S01)

Extension Cable

(01V33125S01)

MAIN P.W.Board

Step

Description

Connection

Signal Generator

Dial Control

Test Point /

P.W.Board

Coordinates

Adjustment

1

Signal Meter
Adjustment

Figure 2

90.1MHz, 26dBu
(Mod. OFF)

90.1MHz

TP503

(3-A)

TP504

(5-E)

Auto Adjustment :
After setting up of Signal Generator,
short GND and TP504.
(SPEC) TP503 : 1.5±0.1V

45ohm

10ohm

60ohm

Input

Output

For 50 ohm FM Signal Generator

Figure 1

FM Signal Generator

FM Dummy
Antenna

Antenna Receptacle

+

-

+

-

Unit Under Test

Figure 2

* only short-circuit at adjustment

TP503

GND

TP504

DC Volt Meter

Adjustment Procedures

- 18 -

TO CONTENTS

1. Tuner Adjustment

-1. FM SECTION

(1) Dummy Antenna Circuit

(2) Connection

INA-N333RS/INA-N333RRS

(3) Control Settings

Fader Control ............................

Center Position Band Switch ............................................. FM

Balance Control ........................ Center Position Others .................................................... OFF

Treble Control ........................... Center Position

Bass Control ............................. Center Position

(4) Adjustment Procedures

(4) Adjustment Procedures

Step

Description

Connection

Signal Generator

Dial Control

Test Point /

P.W.Board

Coordinates

Adjustment

1

MW
Signal Meter
Adjustment

Figure 4

999kHz, 30dBu

(Mod. OFF)

999kHz

TP503

(3-A)

TP504

(5-E)

Auto Adjustment :
After setting up of Signal Generator,
short GND and TP504.
(SPEC) TP503 : 1.0±0.1V

2

LW
Signal Meter
Adjustment

Figure 4

216kHz, 30dBu

(Mod. OFF)

216kHz

TP503

(3-A)

TP504

(5-E)

Auto Adjustment :
After setting up of Signal Generator,
short GND and TP504.
(SPEC) TP503 : 1.0±0.1V

For 50 ohm AM Signal Generator

15pF

30ohm

65pF

Input

Output

Figure 3

AM Signal Generator

AM Dummy
Antenna

Antenna Receptacle

+

-

+

-

Unit Under Test

Figure 4

* only short-circuit at adjustment

TP503

GND

TP504

DC Volt Meter

(2) Connection

(3) Control Settings

Fader Control ............................ Center Position Band Switch ..................................... MW/LW

Balance Control ........................ Center Position Others .................................................... OFF

Treble Control ........................... Center Position

Bass Control ............................. Center Position

-2. AM SECTION

(1) Dummy Antenna Circuit

NOTE : For the Test Points, refer to the Parts Layout on P.W.Boards and Wiring Diagram.

INA-N333RS/INA-N333RRS

- 19 -

TO CONTENTS

Block Diagram

- 20 -

TO CONTENTS

(signal Block)

INA-N333RS/INA-N333RRS

FAN+B

TUNER

DVD MECHA
(DV33M010)

NAVI CARD

CONVERTER

MEMORY

JASO ANTENNA WIRE

IIC

ATAPI

3V-5V

FLASH

RESET

DIRECT ACCESS KEY

LED/LAMP

AUDIO

PROCESSOR

SERVO+5V SW

ADC

MCU

DISPLAY RESET

IS BUS

ROTARY

ENCODER

EJECT

ST MULTICHIP-IC

KEY MATRIX

EEP-ROM

IIC

MAIN u-COM

NAVI+3.3V

TAB II

NAVI u-COM

SERIAL BUS

DISPLAY

u-COM

OELD DISPLAY MODULE

AUDIO

BUFFER

Ai-NET Hi CIRCUIT

SYSTEM RESET/BATT-DET

REMO-CON

NAVI BUCK-UP+3.3V

D-RAM

SOUND CODEC

MEMORY-IC

I/R RECEIVER

POWER-IC

SERVO +7V

SWING MOTOR+B

OELD+B

VDD+5V/ACC+5V

NAVI +5V

TUNER+B

AUDIO+B

M

PREOUT-FRONT
PREOUT-REAR

PREOUT-SUB.W

4ch SP-OUT

TEL-MUTE CIRCUIT

ACC-DET CIRCUIT

SYSTEM

REGULATOR-IC

BATT-DET

5V-REG
5V-REG

8.3V-REG

8.5V-REG
7V-REG

HIGH-SIDE SW

PARKING BRAKE

CIRCUIT

SPEED SENSOR

I/F

GPS RECEIVER

GYRO SENSOR

REMO-CON DET

CIRCUIT

BATT

OREM+B

ST-REMO

Ai-NET

DIN

GT5

VEHICLE CONNECTOR (16P)

(POWER SUPPLY Block)

- 21 -

TO CONTENTS

SYSTEM

BATT

REGULATOR-IC

BATT 5V

5V

*

7V

*

8.3V

8.5V

*

HSW

500mA MAX.

500mA MAX.

1.2A MAX.

150mA MAX.

250mA MAX.

1A MAX.

at usually 5V
power supply

3.3V REG

3.3V REG

MAIN u-COM

Ai-NET

RDS DECODER

INA-N333RS/INA-N333RRS

NAVI CARD

3.3V

1.2A MAX.

5V

500mA MAX.

Ope : 40mA MAX.
Erase : 100mA MAX.

19mA MAX.

NAVI-ON 5V

3.3V BACK-UP

1mA MAX.

GPS RECEIVER

*
*

*

CD CHG

POWER-IC

AMP-ON

MOTOR+B

MOTOR-CNT

VHH+B

V-CNT

RESET

5.2V DET

4.5V DET

16V DET

IIC BUS

adjustable

*

EL-ON

1A MAX., 0.35A typ

150mA MAX.

MECHA SERVO+5V

MAIN u-COM
MAIN u-COM

NAVI u-COM

700mA MAX.

FM-ON

NOSE POWER

5.2V DET

MECHA SERVO

+7V REG

FM-ON

NOSE-ON+B

ACC

A-HOLD

FAN+B

80mA MAX.

1A MAX.

MULTICHIP

FMAM

MULTICHIP

7511

B-HOLD

A-HOLD

ACC-ON 5V

9mA MAX.

FM 62mA MAX.

AM 60mA MAX.

DISPLAY u-COM

GRAPHIC

MEMORY

REMO-CON

RECEIVER

MULTICHIP

EEP-ROM

ST-REMO

Ai-NET

IN-INT I/F

PARKING I/F

80mA MAX.

50mA MAX.

10mA MAX.

3mA MAX.

0.2mA MAX.

31mA MAX.

0.1mA MAX.

0.1mA MAX.

ACC 8.5V DET

LED+B

AMP-ON

270mA MAX.

MAIN u-COM
NAVI u-COM

MULTICHIP

7402 AUDIO

MECHA

AUDIO+B

P-ANT

500mA MIN.

O-REM

10mA

50mA MAX.

10mA MAX.

Parts Layout on P.W.Boards and Wiring Diagram (1/5)

- 22 -

TO CONTENTS

MAIN P.W.Board

1

2

3

4

5

(Component Side View)

R097

R096

CB201

CB801

E263

R817
R829

R815

R819
C810

L882

L881

IC261

IC811

E262

CB271

E817

C882

C801

Q828

R827

E811

E815

E812

E814

E882

E881

C261
C263

C264

C262

D821

C816

IC881

C806

R826
R825

Q827

C818

R265
C267

C291
C294

Q826

E816

E813

Q841

ZD801

R618

Q261

C293
C292

R824

L884

R841

CB841

E264

R612

E823

R842

C618

Q842

R619

ZD618

R622

R621

C612

CB591

R617

L813

R292

CB583

CB611

E621

D611

C622

TP602

R573

R571

C655

Q611

D621

TP601

E701

R291

R578

ZD621

R611

Q622
Q621

C578

R579

Q625

D665

R658

C656

D581

D582

R657

Q562

R547

R574

L581

L582

R625

ZD665

C653

C652

C654

R659

C659

R562

C561

R575

R589

CB571

Q626

R654

C661

XL521

E861

R561

Q561

R587

Z581

Z582

R652

C523

R588

C651

D651

R653

R550

R861

C861

TP535

R549
R551

RA515

R576

R581

R582

R661

IC651

C522

TP501

R577

Q581

C581

R662

R656

RA521

R521

RA514

R539

IC581

R663

E651

R655

IC521

TP533

RA513

R563
R517

R518
R537
R536

Q627

E865

RA512

L865

C585
R590

SW201

R522

RA501
C503

XL502

C504

CB581

ZD521

ZD574

ZD573

E866

C867

RA511

R555

IC501

C866

R871

C874

R870

R515

R542

E867

R508

R543

R506
R507

C501

C502

E873

GR591

R073

R072

IC071

R063

R226

R222

C222

Q221

R224

R223

R221

C221

R225

R282R281

R262

IC282

IC281

C281

C506

R283

R264

RA509

XL501

IC871

LD631LD632

R552

C873

R284

R501

R878

E868

E871

RA508

C512

RA506

RA505 RA507

RA504

R263

TP505

E501

GS592

C225

Q062

R069

R232

E872

L871

C029

C062
C063

Q002

R261

R231

R002

R251

R252

R242

E061

E072

C231

Q231

C232

R241

C605
C598

C224

C026

C251

Q251

Q631

C223

R062

L005

L001

R001

Q001

E001

C252

C241

Q241

C242

TH641

C846
R849

C226

R061

R233

R234

R253

R254

R243

R244

C599

C064

R235

R236

R255

R256

R245

R246

R560
R559

R602

C590

C606

C027
C025

R298 R297R296 R293R295 R294

R603

C591

C023

L010

TP009

R605

C021

XL002

CB221

CB081

R606

R607

Q601

Q602

R601

C071

CF003

Q604

C601

C072

E011

R098

CB501

C603

Q603
D601
C602

IC001

CF002

R099

TP209
TP208

E012

E013

D891

Q899

R899

CB601

R032

C053

C898

Q853

VT005

CB891

ZD891

L853

E854

R1851

E006

E008

ZD898

R843
R844
R845

CF001

Q081

R1852

XL001

C036

C037

C052

C049
C048

C044

C046

VT004

R043

E007

E091

C891

C032

R019

IC891

VT003

VT002

R007

C077

E081

E853

D851

E852

C075

L091

E015

R012

C008

L007

C015

L006

C098
C099

C897

R891

C016

R092

C092

C009

C006

L092

R892

E014

Q003

C057

C076

Q004

E897

C078

D005

XL091

R893

VT001

C003

R010

R894

L852

R631

TP006

R895

INA-N333RS/INA-N333RRS

ANT001

L002

L003

SW632

R632

R896

SW631

A

Orange Color Pattern:Component Side Pattern
Blue Color Pattern:Foil Side Pattern

BCDE FG

Parts Layout on P.W.Boards and Wiring Diagram (2/5)

- 23 -

TO CONTENTS

MAIN P.W.Board (Foil Side View)

1

2

3

4

C002

L009

L004

SA001

R031

R006

C010

C001

D001

C050

C004

R091

R095

C096

TP002

R016
R015

C007

C012

C097

R897

R851

R855

L013
TP001

R024

R023

R037
C005

C013

D013

R009

R898

R852

R856

C054

D003

R017

C051

TP003

R005

D004

R011

TP004

C014

C894

R853

R857

C043
R029

R020
C087

IC091

C042

C035

TP005

R008

C011

R854

C040

C045

R004

C093

C853

R030

C017

R859

L854

C038

R018

C047

C083

Q898

R858

C041

D002

R021

C095
C091

R850

R1854

C030

R028

C039

C031

C034

C033

R050

IC087

C094

RA091

C852

IC851

Q1852
R1853

R013

L021

TP503

R886
R887

Q1851

C081

C055

R087

Q005

C082

Q852

R885

C856

F852

R035

L022

R022

C056

C018

C895

Q855
Q856

Q851

R036

C019

R044

C024

C058

R082

C066

Q897

C854

TP520
TP518
TP516
TP514
TP512

R026

C074

C020

C060
C061

Q006

R025

C065

R860

TP519
TP517
TP515
TP513

R846

R065
R074

TP061

C069

Q846

C073

R066

C028

R068

R064

C068

C022

TP511

R548

Q086

R086

IC086

R045

F846

R067

C594

R847

C086

C067

Q847

R831 R832

C593
R593

C555

R580

D871

R557

R584

R556

Q873

R504
R503
R641
R502

R553
R554

C556

R509

R880

C557

TP530
TP531
TP534

L504

C878

R873

R516

C505

L502

R879

Q872

R075

R534

Q628

C509

C879

L592

R513
R511

C507
C508

R875

R872

L505

L501

C871

R874

C875

C596

R596

R505

RA503

R876

R877

R595

R541

R519

L872
Q871

F865

C595

C597

R524

Q521

RA510

TP502

D501

RA502

R520

R525

R512

R538

C511

Q865

R531

R526

R514

L597

R530

R527

R533

R535
TP532

L503

R510

R866

R868

R867

C532

Q623

R528

R544
R545
R546

R865

R529

C521

R532

C510
R540

C530

L595

R623

Q624

R838

R839

R837

L596

L521

C524

C531

R624

R651

C657

R523

Q861

TP597

R833

R634

R583

C658

D521

R615

TP504

Q866

R863

R862

Q862

R834

R633

C865

C864

IC864

D864

R835

R836

TP571

TP594

R572

TP593

TP591

TP595

TP596

TP592

Q262

Q263

D826

R616

Q615

C616

R823
R822

R821

R806

C883

R820

R807

R818
R811

R830

R884

L883

Q825

R808

C814

Q811

R882

R883

C811
R816
C815
C822
C821
R812

C807

C265

R805

C813C812

C881

C817

D881

Q881
R881

D801

R266

R828

C803

C819

R802

R801

C802

C804

C805

INA-N333RS/INA-N333RRS

NOTE:#1:For INA-N333RS Model Only,
$1:For INA-N333RRS Model Only,
Others:Common.

5

A

Orange Color Pattern:Component Side Pattern
Blue Color Pattern:Foil Side Pattern

BCDE FG

Parts Layout on P.W.Boards and Wiring Diagram (3/5)

- 24 -

TO CONTENTS

INA-N333RS/INA-N333RRS

1

2

3

LD921

SW909

SW913

LD927

LD911

SW907

LD922

IC909 IC910

LD925LD926

PL901

C958

C957

FRONT P.W.Board (Component Side View)

SW904

LD904

LD913

SW905

LD909

LD906

SW901

LD902LD903

SW902

90

LD

R1078

LD914

LD908

7

LD901

6

R1066

SW90

SW914

R1098
R1099
R1100
R1101

R908
R909
R910

R903
R930
R1075
R929
R1074

R915
R1076

C911

R968
R969
R970

R971

R914

D904

R906

R1043

R1044

R1084

R1086

R905

R1002

R1087
R1085

D905

R1097

R1010

R902

R907

R1096

R966

R1004

R1082

R972

R967

C912

R1012

C904

R991

R1094

R1081

R1006

C918

R1089

C917

R1088

R1095

C909

R977

R1014

R1083

R916

D906

R1093

C921

R918

R1106

R913

LD910

SW903

SW908

LD924

LD905

LD923

SW910

SW911 SW912

LD912

FRONT P.W.Board (Foil Side View)

C955

C956

C915

C916

IC902

R911

C923

Z901

IC912

C924

R1080

TP984

C925

TP983

C926

C927

TP965

TP977

TP976

TP975

TP985

R925

R1055

RA906

RA910

C950

Z903

R1065

XL901

C901C902

RA905

R1048

R1049

R1047

R1113

R1069
R1068
R1070
R1071
R1072

R1112

R1008
R1111

R1007

CB902

TP994TP992

TP993TP991TP988

IC901

TP995

R1110

L902

R900

R932

Q908

CB905

Q907

R931

Q991

C922

CB904

R901

C905 C907

R1041 R1042

C991

C992

IC991

ZD902
ZD903

R1090

C919

Q906

R1045
R1046

Z902

L901

Q905

C951
C952
C953

C954

CB901

RA909

RA903RA902

RA908

RA907

R1000
R998

R1077

R999

R973

R997

R974

IC911

R990

Q902

Q901

Q909

R1116

C910

R1001

RA904

R992

R1104

R980

R988
R986

R983

R917
R919

R1003

R1115

R1114

R1036

R981

Q904

Q903

R984

R1034

R982

TH901

R994

R1031

R1030

R927

R1032
R1035

R1033

R1029

RA901

R993

R996

R1027

R1024

R1028
R1026

R1118

R1022

R1025

4

5

A

Orange Color Pattern:Component Side Pattern
Blue Color Pattern:Foil Side Pattern

BCDE FG

Parts Layout on P.W.Boards and Wiring Diagram (4/5)

- 25 -

TO CONTENTS

1

INA-N333RS/INA-N333RRS

AMP P.W.Board
(Component Side View)

2

3

AMP P.W.Board
(Foil Side View)

4

5

R715

R716

CB701

CB702

R703

C705
C706
C707

R709

R712

R708

R711

R713

IC702

R714

TP702

R710

R704

R706

R705

L705

R702
L702

L703

L704

R701

L701

TP701

C701
C702
C703

CB703

IC101

A

SUB P.W.Board
(Component Side View)

Orange Color Pattern:Component Side Pattern
Blue Color Pattern:Foil Side Pattern

BCDE FG

Parts Layout on P.W.Boards and Wiring Diagram (5/5)

- 26 -

TO CONTENTS

1

INA-N333RS/INA-N333RRS

2

FPC,DRIVE P.W.Board
(Foil Side View)

LIMIT P.W.Board

3

(Foil Side View)

4

FPC,LOAD P.W.Board
(Foil Side View)

TP418
TP417

SW406

The patterns should be short-circuited,
when the PICKUP is removed
from DVD Mechanism.

MAIN-LSI P.W.Board
(Foil Side View)

TP104

TP103

TP105

TP444

TP101

TP409

R440

TP202

SD402

TP405

TP406

TP441

TP411

TP412

TP416

TP415

TP413

TP414
TP355

TP356

CB601

TP357

TP358

TP369

TP400

TP430

TP429

TP344

CB60

TP390

TP337

TP339

R518

TP383

C526

TP316

R517

Q507

C525

Q508

TP308

E505

TP440

TP102

R631
R345
R360

C301

TP410

TP204

R630

E301

TP367 TP368

TP359

TP338

2

TP385

TP388

E503

C524

TP317

TP107

R131
R102

C361

C302C303

TP360

TP439

R403

C451
C450

TP401

C512

C513

C529

C530

C507

C523

R520

TP112

TP113

TP106

C362

R308
R302

C318

TP207

TP442

R415
C401

TP402

TP320

R519

TP307

TP111
TP109

C358

TP246
R304

R303

TP313

R325

R323

C403

C402

R426

CL401

R402

TP325

TP321

TP327

IC501

TP110

RA101

TP108

RA102

C317

C307

TP247

C346

R324

SD602

R428

TP326

L301

TP324

TP387

C308

R329

R332

TP312

R439

C808

TP404

TP386

R504

CB101

RA103

R331

TP364

C453

C452

C809

R808

TP403

TP384

R505

R503

C501

RA104

IC301

TP288

TP457

C415

C406

C454

R425

R809

TP391

TP381
TP382

C506

R506

C502

R524

R305

C322

IC401

TP262TP263

R513

TP447

C511
R509

R508

TP319

C505

C503C504

R507

R807

RA105

C314

R306

C404

TP279

R514
R515

TP318

Q501
TP322

C804
R804

C807

RA106

XL301

TP363

TP393

TP394

R422

R407

TP282

TP264TP265

TP456

TP453

C510

R806

C806

TP335

C354

R340

R406

TP323

TH402

TP212TP213TP216

TP214TP215

TP219

TP220

TP139

TP138

TP140

R122

R307

R330
C712

R328

TP445

C410
R442
C420

R443

C405

R418

R417

TH401

TP222

TP221

TP141

TP289

TP285

TP284

C364

R322

C334
C333

C328

C330
C320
C319

C321

TP446

C604

R437

C411

C419

R404
C408

R409

TP218

CB401

TP224

TP223

TP142

TP143

TP306

TP304TP305

TP301
TP296

R318

TP292

R316

C329

R333

TP273

TP274

C418

IC403

TP267

R423
C416

R424

R405

IC402

TP443

TP144TP145

TP353

TP302TP303

TP294TP295

TP293

TP354

C348

C417

TP351

R416

TP352

MAIN-LSI P.W.Board
(Component Side View)

R121

SW403

C352
C357
C353

R313

R334

C606

R603
R604
R419

SW404

R124

R352
R413

C351

R312

R311

C356
C347
C345

R643
R614

R450

R126

R132

R309

C810

R810

C811

R128
R129

R125
R127

R133

R421

C339
C340
C338
C337

C335

C311
C310

TP291

R310

C355

R640
R642
R615

R811

R414

R611

R451

R118
R119

R123

RA107 RA108

C313
R321

R320
R319
C312

R317

R702

TP449

C822
R646
R645

R641
R644
R647

IC601

C803

R533

C332

C821

C802

C331

E702

C309

C360

C820

R408

R802

R101

C101

C336

C704 C705

TP448

R338

R337

TP450

R336

TP451

C365

R803

R339

R350

R601

R639
R636
R635
R638
R637

R427

C516
R510

R120

C359

R705R706
C702C703

R707R708

R717R718

C706

TP210

IC701

C363

TP452

R351

R410

R438
C407

C519

C518

C315

C812

SD603

R203

C203

C521

R512

C514

C316

R801

IC201

C202

R206

IC202

C515

R511

SW401

IC203

R813R812

C813

C801

E202

E203

SW402

C800

R209

R800

RA109

R357
R356
R355
R301

C304

R522

R521

R544

R528

R530

C528

R529

R531

SW405

RA110

R545

R412

C305

C205

R200

R722
R723

R208

R411

C207

R204

R210

R212

C204

IC204

C522

Q506

R724
R725
R726

5

A

Orange Color Pattern:Component Side Pattern
Blue Color Pattern:Foil Side Pattern

BCDE FG

R082

- 27 -

TO CONTENTS

TO PARTS LIST

TO P. W. BOARD

22k

XN1A312

Q081

C082

1u

Q001

2SA1774

R001

R002

ANT001

ASSY, ANT 033R0/561A0

SA001

E081

10/16

100p

C083

C093
330p

C094

2200p

L001

2.2uH

E006

4.7

R044

E001

L005

R004

C004 7p

C005

C097 2200p

2.2uH

22

0.1

C011

11p

BK1608HM102

XL091

4.33MHz

R037

N.U.

C087

22/16

C006 1p

56k

ANT1 FM 5KR

L092

C098

5.6k

R092

C099

27p

27p

L002

4.7uH

D004

VT001

R021

L021

10

BK1608HM102

1k

R008

1mH

C012

1SV172

TP002

22k

10k

L006

1M

R010

C051

OSC F/A 5KR

TP004

Q004
FC18

C0761C013

VT002

RF FM 5KR

R012

10

0.01

100

R017

R022

10

VT003

1p

C035

C036

22p

N.U.

E014

E015

22/16

C038

L013

2.2uH

C041

C040

2200p

0.01

R028
100k

C043

C042

0.01

1000p

R029

56k

R030

5.6k

2.2k

R007

4700p

R009

2.2k

1

C014

C075

1000p

Q003

3SK195

1

0.01

C050

C078

D003

R023

0.01

5.6k
KV1410

680

C009

TP003

R095

RA091

C001

0.022

D001

D013

MA133

R005

22

8p

1k

1kx4

R015

0.01

C010

R016

C054

TP001TP006

R024

10k

R099

10k

R098

L004

R006

15uH

10-1/4

L003

52mH

C008
N.U.

5p

C007

R020

56k

KV1410

C096

0.022

L007

TP005

68uH

68p

100p

C015

C016

D002

KV1410

R013

56k

R019 3.3k

C081

0.047

L022

BK1608HM102

XL001

10.25MHz

R025 1k

R026 1k

N.U.

C058

C031

0.022

C017

C033 3300p

R011

4.7k

0.01

7p

C047

56k

R018

68p

C032

15p

C037

0.1

22/16

C039

0.01

C044 0.022

C045 0.022
C046 0.022

C048 6p

C049 6p

C052 10p

0.1

C034

N.U.

C030

Q006

N.U.

1

C077

C029

N.U.

C026

0.022

Q002

XN1A311

3.3k

1.5k

CSA30-201M

C002

10p

C003

1000p

0

R031

D005

1SV316

L009

0.22uH

L091

BK1608HM102

C092

0.022

E091

2.2/35

C091

0.022

0.01

C057

C095

560p

IC091 SAA6588T

470k

R091

22/16

C018

N.U.

CF001

SFELA10M7

12k

VT004

IFT1 F/A 5PG

R050

C055 100p

R032

E007

4.7

R043

22/16

C019
N.U.

XL002

CFWLA450K

CF003

CF002

SFELA10M7

SFELA10M7

VT005

IFT2 AM 5PG

C056 0.022

220-1/4

TP209

TP208

C053

0.022

R035 470

R036 470

E008 22/16

C020 0.1

IC001

TDA7518

TP009

C021 0.022

C060 0.47

C061 0.47

E011 10/16

C022 3900p

E013

10

R045

N.U.

10k

R087

C025

0.01

E012 22/16

C024 0.01

R074
100k

C023 120p

L010 1mH

0.1

C027

C5901C5911C071

10u

R073

Q005
UN9215J

C086

C074

1k

IC087

TC7S66F

10k

E061
22/16

TP061

C066

R064
N.U.

N.U.

C067

R061

R062

470

C064

1000p

C605 N.U.

R075

2.2k

C028

0.1

R068
220k

C065

0.015

47p

C068

N.U.

470

C606 N.U.

C598

1

R086

Q086

UN9212J

0.22

C069

E072

C599

10/16

4.7k

R066

0

R067

0.1

Q062

C063

UN9212J

0.68

C062

1

10u

C072

R063

R069

N.U.

0

IC086

0.1
TC7S66F

C073

0.22

0.1
R065

0

IC071

NJM2904V

R072

1k

IC071

NJM2904V