Alinco DR-599E, DR-599T Service Manual

5 9 9 T /E

S ervice M a n u a l

• SPECIFICATIONS

• PARTS LIST

• CABINET PARTS LOCATION................................ 9

• ADJUSTMENT

• BLOCK DIAGRAM

• OVERALL WIRING.............................................13

• SCHEMATIC; DIAGRAM OF VHF MAIN UNIT

• VHF MAIN PC BOARDS......................................15

• SCHEMATIC DIAGRAM OF UHF MAIN UNIT

• UHF MAIN PC BOARDS

• SCHEMATIC' DIAGRAM OF VHF/UHF PA UNIT

• VHF PA PC BOARDS........................................-19

• UHF PA PC BOARDS-.........................................20

• SCHEMATIC DIAGRAM OF FRONT CONTROL UNIT--21

• FRONT CONTROL PC BOARDS.............................22

• SCHEMATIC DIAGRAM OF SUB CONTROL UNIT

»SUB CONTROL PC BOARDS................................24

• SCHEMATIC: DIAGRAM OF VOL UNIT

• VOL PC BOARDS

• SCHEMATIC!DIAGRAM OF VHF VCO UNIT

• VHFVCO PC BOARDS........................................26

• SCHEMATIC!DIAGRAM OF UHF VCO UNIT

• UHF VCO PC BOARDS

• SCHEMATIC DIAGRAM OF VHF PLL UNIT

•VHF PLL PCiBOARDS

• SCHEMATIC: DIAGRAM OF UHF PLL UNIT

• UHF PLL PCIBOARDS.........................................29

•SCHEMATIC: DIAGRAM OF VHF AIR UNIT

•VHF AIR PCiBOARDS

•SCHEMATIC DIAGRAM OF 880 FRONT UNIT

•880 FRONT PC BOARDS

.............................................

.....................................-.............

..................................................10

..................

.............................

........................................

....

...........................

.........

................

...............................

................................30

.....................................

...........

............

........

.........

......

....................25

.....

..............

--27

..............

.............

..............

........

— 30

..........

1 2

12 14

16 17 18

30 30

A LINCO ELECTRONICS INC

■ SPECIFICATIONS

■ General

Frequency coverage

Frequency Resolution Antenna Impedance Power Supply Requirement Current Drain at 13.8V

Dimension • Weight

.......

■Transmitter

Output Power--

Emission Mode

Modulation System.......

Max. Frequency Deviation • Spurious Emission Microphone Operating Mode

DTMF Encoder

■ Receiver

Receiving System Modulation Acceptance Intermediate Frequency

Sensitivity

Selectivity...........................±6kHz or under at —6dB

Audio Power Output Speaker Impedance

■ MODEL CHART

Type DR-599T Tone Burst Not Available 1.750Hz Subaudible Tone Encode Included, Decode Optional DTMF Included (16 Buttons) Optional

Note : S pe cific ations a re app roxima te a nd are su bject to change without notice or obliga tio n.

.....................150mm(W) X 50mm(H) X 178mm(D)

.....................Approx. 1.5kgs (3.3lbs.)

..........

.......

..............

.........

................

.............

........

•'■.................12dB SINAD — 16dByu

................

• DR-599T(U.S.Version)

144.000-147.995MHz (TX), 130.000-173.995MHZ (RX),

440.000-449.995MHz (TX), 400.000-500.000 MHz (RX)

• DR-599E(Europe Version)

144.000-145.995MHz (TX & RX)

430.000-439.995MHz (TX&RX)

...............5, 10, 12.5, 15, 20, and 25kHz steps

................

.........

..............

50 Ohms, unbalanced

13.8 Volts D.C. Receiving

Squelched : does not exceed 800mA Trans-mitting VHF High : 45W approx. 9.5A

Middle: 10W approx. 4.5A

Low: 5W approx. 3.5A

UHF High ; 35W approx. 10A

Middle: 8W approx. 5A

Low: 4W approx. 4A

(5-9/10") (2") (7")

VHF

Middle

High

Approx. 45W 10W

Low 5W

UHF

Middle

High

Approx. 35W

Low 4W

■ F3 (FM)

-Variable Reactance F.M.

•±5kHz

•—60dB or under below carrier

•Electret Condenser Microphone

■Simplex .. Duplex :

5kHz and 12.5kHz steps between 0 and 10.995MHz from receive frequency at 144-147.995MHZ and 440-449.995MHz

■ Built-in (DR-599T only)

■Superheterodyne, Dual Conversion

............

F3 (FM) 1st 21.6MHz and 455kHz at VHF

1st 30.825MHz and 455kHz at UHF

±12kHz or under at -60dB

................

Approx. 2.5W 8 Ohms

DR-599E

Optional

■ PARTS LIST

Ref.

No.

Part Code

Part Name and Number

VHF MAIN Unit

CU9007

CU8016

CU0060

C3 C4 CU8016

CU0069

CU0060

CU0067

C8 Cil CU8016

CU0071

Cl 2

CU8016

C13 Cl 4 CUSO 16 Cl 5 CU0062 C16

CU8016

Cl 7 CUS016

CU0060

c 1 a

CU0060

Cl 9 C20 CE0030 Chemical C, 16MS7 10 C21 CU8032

CU8003

C22 C23 CU8003 Chip C, C2012JF1E104Z C24 CU8003 Chip C, C2012JF1E104Z

CUSO 16

C25 C26 CUSO16 C28 CU8016

CUSO 16

C29 C30 CU8028

CS0060

C31

CU8022

C32

CU8035

C33 C34 CE0312

CU8003

C35

CU0045

C36

CUSO16

C37

CS 0061

C38

CS0061

C39

CU8035

C40

CU8028

C41

CU8034

C42

CU8035

C43

CU8025

C44

CU8025

C45

CU8016

C46

CEO 124

C47

CU8038

C48

CU8038

C49

CUSO 16

C50

CU8016

C5I

CUSO 16

C52

CU80I6

C53

CU8028

C54

CU8028

C55

CUS01

C56

CU8016

C57

CU8016

C58

CUSO 16

C59

CU0004

C60

CS0049

C61

CU0068

C62

CUSO 16

C63 C64 CE0312 C65 CS0049

CU8016

C66

CU0064

C67

CU0071

C68

CU0043

C69

CU8028

C70 C71 CUS016

CU0006

C72

CU8016

C73

CU8028

C74

CU8028

C75

CU0071

C76

CU0071

C77

CU0071

C78 C79 CU8038 C80 CUSO 16

CU0066

C81

CS0049

C82

CUSO 16

C83

Chip C ,CC3216CH1H330J Chip C, C2012B1H102K Chip C.C2012CH1H470J Chip C ,C2012B1H102K Chip C.C2012CH1H680J Chip C, C2012CH1H470J Chip C .C20I2CHIH390J Chip C ,C201281 Hl 02K Chip C.C2012CH1HI01J Chip C, C2012B1H102K Chip C.C2012B1HI02K Chip C, C2012CH1H150J Chip C.C2012B1H102K Chip C.C201281H102K Chip C ,C2012CH1H470J Chip C, C2012CH1H470J

Chip C.C2012B1E223K Chip C.C2012JF1E104Z

Ch ip C ,C2012B1H102K Chip C.C2012B1H102K Chip C, C2012B1H102K Chip C, C2012B1H102K Chip C.C2012B1H103K Chip T an ta l, TMC1E474 Ch ip C ,C2012B1H332K Chip C ,C20L2BIE393K

Ch emical C , 16CV10B Chip C, C2012JF1E104Z Chip C, C2012CH1H271K Chip C.C2012BIH102K Chip Tantal, TMC1V224 Chip Tan tal, TMC1V224 Chip C, C2012B1E393K Chip C. C2012B1H103K Chip C, C2012X7R1E333K Chip C, C2012B1E393K Chip C, C2012B1H562K Chip C.C2012B1H562K Chip C. C2012B1H102K Chemical C, 16MS7 47 Chip C. CM316Y5V105Z25VA Chip C, CM316Y5V105Z25VA Chip C, C2012B1H102K Chip C ,C2012B1H102K Chip C, C2012B1H102K Chip C ,C2012B1H102K Chip C, C2012B1H103K

Chip C, C2012B1H103K

Chip C, C2012B1H102K

Chip C.C2012B1H102K

Chip C. C2012B1H l02K

Chip C, C2012B1H102K

Chip C. C2012CH1H030C Ch ip T a n tal,TMCSA1C105MTR

Chip C ,C2012CH1H560J Chip C, C2012B1H102K Chemical C, 16CV 10B Chip Tantal, TMC1C105 Chip C.C2012B1HI02K Chip C, C2012CH1H220J Chip C. C2012CH1HI 01J Chip C ,C2012CH1H221K Chip C, C2012BÎHÎ 03K

Chip C. C2012B1H102K

Chip C, C2012CH1H050C Chip C.C2012B1H102K Chip C, C2012B1H103K

Chip C.C2012B1HI03K Chip C, C2012CH1H101J Chip C ,C2012CH1H101J Chip C. C2012CH1H101J Chip C. CM316Y5V105Z25VAT Chip C.C2012B1H102K Chip C ,C2012CH1H330J Chip T an tal, TMC1Cl 05

Chip C.C2012B1H102K

Ref.

Part Code

No.

C84

CU8016 CE0315

C85 C86 CU0051 C87 CUSO 16 C88 CU8016 C89 CU0051

CS0061

C90

CUSO 16

C91

CUS016

C92 C93 CUS016 C94 CU8016

CU0062

C95 C96 CU0051

CUSO 16

C97 C98 CUSO 16

CUS016

C99

CUSO 16 Chip C, C2012B1H102K

ClOO

CU0003

C101

CUS016

Cl 02 C104

CE03I2 CU8016

Cl 05

CU8038

CT 06 C107 CE0312

CU8038

Cl 08

CE0124

C109 C110 CE0042

cm CE0124

CEO 124 Chemical C, I6MS7 47

Cl 12

CEO 124 Chemical C, 16MS7 47

Cl 13 Cl 14 CEO181 C115 CE0181

CU8003

Cl 16

CU8003

C117

cus CE0192

CU8016

Cl 19

CU0071

C120

CU8016 Chip C,C2012B1H102K

C122

CU8041

C123

CU0003

C124

CU8032

C125

CU0004

C126

CU0066

C127

CU0067

Cl 28

CU8016

C129

CU8003

C130

CU0051

C131

CUSO 16

C132

CU0006

Cl 33

CE0312

C134

CUSO 16

CI36

CE0312

C137

CS0050

C138

CU0066

C139

CU8034

C140

CUSO 16

Cl 41

CE0033

C142

CU8016

C143

CUSO 16

C145

CU8016 Chip C,C2012B1H102K

C148

RK0069

RK0052

RK0018

RK0069

RK0011

RK0018

RK0045

RK0069

R10

RK0035

Rll

RK0056

R12

RK0011

R13

RK0045

R14

RK0074

R15

RK0018

R16

RK0018

R17

RK0025

R18

RK0062

R19

RK0069

R20

RK0059

R21

Chip C, C2012B1Hl02K Chemical C, 16CV 47B Chip C.C2012CH1H471K

Chip C, C2012B1H102K Chip C, C2012B1H102K Chip C.C2012CH1H471K Chip Ta ntal. TMC1V224TR Chip C, C2012B1H102K Chip C.C2012B1H102K Chip C, C2012B1H102K Chip C, C2012B1H102K Chip C, C2012CH1H150J Chip C. C2012CH1H471K Chip C, C2012B1H102K Chip C, C2012B1H102K Chip C. C2012B1HI02K

Chip C,C2012CH1H020C Chip C, C2012B1HI02K Chemical C, 16CV 10B Chip C.C2Q12B1Hl02K Chip C, CM316Y5V105Z25VAT Chemical C, 16CV 1 OB Chip C, CM316Y5V105Z25VAT Chemical C, 16MS7 47 Chemical C, 16V 220 u F Chemical C. 16MS7 47

Chemical C, 10TWSS 470 Chemical C, 10TWSS 470 Chip C, C2012JF1El04Z Chip C.C2012JF1E104Z Chemical C, 16TWSS 470 Chip C, C2012B1H102K Chip C, C2012CH1H101J

Ch ip C,C2012UJ1H471J Chip C, C2012CHIH020C

Chip C. C2012B1E223K Ch ip C,C2012CH1H030C Chip C.C2012CH1H330J Chip C, C2012CH1H390J Chip C, C2012B1H102K Chip C, C2012JF1E104Z Chip C, C2012CH1H471K

Chip C, C2012B1H102K Chip C, C2012CH1H050C Chemical C, 16CV 10B Chip C, C2012B1H102K Chemical C, 16CV 10B Ch ip Tantal,TMCSB1A475MTR Chip C, C2012CH1H330J Chip C, C2012X7R1E333K Chip C, C2012B1H102K Chemical C, 10MV 10UWA Chip C, C2012B1H102K Chip C, C2012B1H102K

Ch ip R, MCR10EZHJ104 Chip R.MCRI OEZHJ 103E Chip R, MCR1OEZHJ101E Chip R, MCR10EZHJ104E Chip R.MCR10EZHJ470E Chip R.MCR10EZHJ1OIE Ch ip R.MCR10EZHJ472 Chip R,MCR1OEZHJ104E Chip R, MCR1 OEZHJ 104E Chip R, MCR10EZHJ104E Chip R, MCR1OEZHJ102E Chip R.MCRI0EZHJ223E Chip R, MCR1OEZHJ47OE Chip R, MCR10EZHJ472E Chip R, MCR10EZHJ274E Chip R, MCR 10EZHJ101E Chip R, MCR1OEZHJ101E Ch ip R,MCR10EZHJ331 Chip R, MCR10EZHJ473E Ch ip R,MCR10EZHJ104 Chip R,MCR10EZHJ333

Part Name and Number

Ref.

Part Code

No.

R22

RK0035 Ch ip R,MCR10EZHJ102 RK0028

R23 R24 RK0062 R25 RK0035 R26 RK0056 R27 RK0035 R28 RKQ076

RK0044

R29

RK0069

R30 R31 RK0035

RK0052 Chip R.MCR1OEZHJ103E

R32 R33 RK0069 R34

RK0073

R35 RK0025

RK0081

R36

RK0081

R38

RK0042

R39

RK0047 Chip R, MCR10EZHJ562E

R40

RK0056

R41

RK0056

R42

RK0062

R43

RK0035

R44

RK0035

R45

RK0018 Chip R ,MCR10EZHJ101E

R46

RK0081

R47

RK0053

R48

RK0039

R49

RK0023

R50

RK0056

R51

RK0062

R52

RK0052

R53 R54 RK0081

RK0045

R55

RK0079

R56

RK0039

R57

RK0039

R58

RK0107 Chip R.MCRI0EZHJ000E

R59

RK0069

R60

RK0039

R61

RK0042

R62

RK0052

R63

RK0045

R66

RK0001

R67

RK0056

R68

RK0052

R69

RK0035

R70

RK0018

R71

RK0076

R72

RK0039

R73

RK0018

R74

RK0052

R75

RK0052

R76

RK0038

R77

RK0056

R78

RK0038

R79

RK0052

R80

RK0052

R81

RK0056

R82

RK0018

R83

RK0039

R84

RK0018

R85

RK0035

R86

RK0056

R87

RK0045

R88

RK0014 Chip R,MCR1OEZHJ680E

R89

RK0018

R90

RK0025

R91

RK001I Chip R. MCR10EZHJ470E

R92

RK0037 Chip R.MCR1OEZHJ152E

R93 R94

RK0008 RK0011

R95

RK0022

R96 R97 RK0I28 Chip R, MCR10EZHJ5R6E R98 RK0022

RK2010

R99

RK0035

R100 RIO! RK0056

RK0052

R102 R103 RK0052 Chip R.MCRI OEZHJ 103E R104 RK0056

RK2000

R105

Part Name and Number

Chip R, MCR10EZHJ47ÏE Chip R ,MCR10EZHJ473 Chip R.MCRI0Ë2HJ102E Chip R. MCR10EZHJ223E Chip R. MCR1OEZHJ102E Chip R.MCRI0EZHJ334E Chip R.MCR10EZHJ392E Chip R.MCR1OEZHJ104E

Chip R, MCR1OEZHJ102E

Chip R.MCRI OEZHJ 104E Chip R.MCR10EZHJ224 Chip R, MCR10EZHJ331E

Ch ip R ,MCR10EZHJ564 Chip R, MCR10EZHJ564E Chip R, MCR10EZHJ332E

Chip R.MCRI0EZHJ223E Chip R.MCR1 OEZHJ 223E Chip R.MCR10EZHJ473E Chip R ,MCR1OEZHJ102E Chip R.MCR1 OEZHJ 102E

Chip R,MCR10EZHJ564E Ch ip R ,MCR10EZHJ123 Chip R,MCR1OEZHJ222E Chip R,MCR10EZHJ271E Chip R, MCR10EZHJ223E Chip R.MCRI0EZHJ473E Chip R.MCR1OEZHJ103E Chip R.MCRI0EZHJ564E Chip R, MCR10EZHJ472E Chip R, MCR10EZHJ474E Chip R,MCR10EZHJ222E Chip R,MCR10EZHJ222E

Chip R,MCR1OEZHJ104E Chip R,MCR10EZHJ222E Chip R, MCR10EZHJ332E Ch ip R ,MCR10EZHJ103 Chip R, MCR10EZHJ472E Chip R.MCR1OEZHJ100E Chip R, MCR10EZHJ223E Chip R, MCR10EZHJ103E Chip R.MCR1 OEZHJ I02E Chip R, MCRTOEZHJ101E Chip R, MCR10EZHJ334E Chip R,MCR10EZHJ222E Chip R.MCR10EZHJ101E Chip R.MCR1 OEZHJ 103E Chip R.MCR10EZHJ103E Chip R.MCR10EZHJ182E Chip R, MCR10EZHJ223E Chip R.MCR1OEZHJ182E Chip R.MCR10EZHJ103E Chip R, MCR1OEZHJ103E Chip R.MCR10EZHJ223E Chip R, MCR1OEZHJ101E Chip R, MCRTOEZHJ222E Chip R. MCR1OEZHJ101E Chip R.MCR1 OEZHJ 102E Chip R, MCR10EZHJ223E Chip R,MCR10EZHJ472E

Chip R, MCR1OEZHJ101E Chip R, MCR10EZHJ331E

Chip R, MCR10EZHJ330E Chip R, MCR10EZHJ470E Chip R.MCRIOEZHJ221E

Chip R, MCR10EZHJ221E

Chip R, MCR50EZHJ330E Chip R,MCR10EZHJ102E Chip R.MCR10EZHJ223E Chip R.MCRIOEZHJ103E

Chip R, MCR10EZHJ223E Chip R, MCR50EZHJ4R7E

- 2 -

Ref.

Part Code

No.

R106 RK0011

RK0130

R107

RK0130

R108

RK0069

R109

m m

R110

RK0011

R ill

RK0037

R112

RK0045 Chip R, MCR10EZHJ472E

R113

RK0023

R114

RK0023 Chip R, MCR10EZHJ271E

R115

RK0069

R116

RK0070

R117

RK0052 Chip R, MCR10EZHJ103E

R119

RK1107

R120

RK0035 Chip R,MCR10EZHJ102E

R121

RK0071 Chip R,MCR10EZHJ154E

R122

RK2000

R123

RK0059

R124

RK0073

R125

RK0052

R130 R131 RK0076

RK0107

R132 R133 RK0056

UE0041

TP1

UE0047

TP2

UE0047 Round Pin, R9 X1 0

TP3

UE0047 Round Pin, R9 X 10

TP4

UE0043

CN30

UE0109

CN31

UE0113

CN32

UEO108 Connector, 6FE-BT

CN33

UE0075

CN34

UE0075

CN35

XA0156 IC ,MC3361BD

IC I

XA0033 IC, uPC393G

IC2

XA0114

IC3

XA0116 IC , LA4445

IC4

XA0115 IC, TC4S66F

IC5

XA0115

IC6

XA0087 IC . TC4S01F

IC7

XD0112

XD0100 Varicap, 1SV164

XD0097 D jod e ,1SS268TE85

XD0100

XD0118

D1I

XD0120-

D12

XD0097

D13

XD0041

D14

X00041

D15

XD0040

D16 D17 XD0113

XD0104

D18

XD0108

D19

XD0103

D20

XD0103

D21

XD0040

D22

Q1 XE0013 Q2 XE0013

XT0037

XT0081

XT0037 Trans is to r, 2SC2412KR

XT0037 Tran sistor, 2SC2412KR

XT0037

XT0037 Trans is to r , 2SC2412KT148R

XT0037

Q10

XT0037

Q11

XT0077

012

XU0014

013

Part Name and Number

Chip R, MCR10EZHJ470E Chip R,MCR10EZHJ4R7E Chip R, MCR10EZHJ4R7E Ch ip R ,MCR10EZHJ104 Chip R ,MCR10EZHJ224

Chip R, MCR10EZHJ470E

Ch ip R.MCR10EZHJ152E

Chip R, MCR10EZHJ271E

Chip R.MCR10EZHJ104E Chip R.MCR10EZHJ124E

Chip R,MCR18EZHJ000E

Chip R, MCR50EZHJ4R7E Chip R.MCR10EZHJ333E Chip R, MCR10EZHJ224E Chip R ,MCRIOEZHJ103 Ch ip R ,MCR10EZHJ334 MCR10EZHJ000 Chip R.MCR10EZHJ223

Pin Jack, TMP-J01X-V6 Round Pin, R9 X1 0

Post With Base, PI22A02M Connector, 52030-1810 Connector, 5512-03A

Pin Jack, TMP-J01X-A2 Pin Jack, TMP-J01X-A2

IC, u PD6345GS

IC, TC4S66F

Pin-D , 1SV128

Varicap, 1SV164 Va ricap , 1SV164 Diode,MA716 Diode, MA716 Diode. MA704WK Diode, 1SS268 Diode. DAP202K Diode, DAP202K Diode, DAN202K Zener Diode, 02CZ4. 3Y Zene r Diode, 02CZ6. 2Y

Diode,MA704TX

Diode, 1SS226 Diode,1SS226TE 85L Diode,D AN202KT H6

FET, 3SK184S

FET, 3SK184S Trans i s t o r ,2SC2412KT146R

Trans is to r, 2SC2714T

Trans is tor, 2SC2412KR

Trans is to r, 2SC2412KR

Trans is to r, 2SC2412KR Trans isto r, 2SC2412KR

Tra nsistor , 2SC3326AL D ig it a l Tran sist or,

DTC144EK

Ref.

Part Code

No.

Q14 XU0014

XT0061

Q15 Q16 XT0081

QI7

XT0030 Q18 XT0048 Q19 XT0078 Q20 XT0061 Q21 XU0019

Q22

XU0019

023 XT0037 T ra nsis to r, 2SC2412KR Q24 XT0037 T ra nsis to r, 2SC2412KR 027

XU0014

Q28 XU0014

Q30 XU0014

XT0037

Q31

XU0014

Q32

Q33

XE0004 FET.2SK209GRTE85L

FL1 XF0001 X ' fil, DFM21615B1 FL2 XC0001 Ceramic F i lt e r , CF1N455F

XI X00023 Ceramic F ilter,

X2 XQ0038

XS0004

TH1

0A0057

QA0066

ÛA0066

L3 L4 QA0066 Coil, 144M S-10

QA0005 Coil, 40092

L5 L6 0A0005 C oil, 40092

QA0044

L7 L8 QA0058 Coil

QC0034 Chip Coil, NL322522T-R39M

QC0065 Chip Coil, NL322522T—068M

L10

QC0067 Chip C o il, NL322522T-R10M

LI 1

LI2 QC0063

RH0037

VR1 VR2

RH0031

RH0038

VR3

TC1

CT0031

TC2

CT0030 TC3

CT 0030

Part Name and Number

D ig it a l T ra n sis to r,D T C 114

Transistor, 2SB1132 Q Trans istor,2 SC2 714YT E85L Trans isto r, 2SC3356BR25 Trans isto r, 2SC3357RE Trans isto r, 2SC3369 Transistor, 2SB1132 Q D i g ita l T r ansisto r ,

D ig it a l T ra nsis to r,

D igital Transisto r,

D ig it a l T ran s ist or,

Transistor, 2SC2412KR D i g ita l T ran s istor,

Ceramic Filte r .

Therm istor, TD5A150D

Coil, Front End Coil, 144M S-10 Coil, 144M S-10

Coil, 455kHz

Chip C o il. NL322522T-047M

VR. CVR-42A-472AD VR.CVR-42A-103AD VR, CVR-42A-473AD

Trinm er, CTZ-05A Trimmer, CTZ-20C Trimmer, CTZ-20C

EKT14

DTA114YKT14

DTA144YK

DTC144EK

DTC114EKT14

UM— 1 22. 055MHz

HC-49/U, 12. 8MHz

UHF MAIN Unit

CU8016

CU0006

CU8028

C3 C4 CU0071

CU0003

CU8016

C6 C7 CU0067

CU8016

CU0066

C12

CU0071

C13

CU0006

C14

CU8016

C15

CU8016 C16 CU0005 C18 CU0060

CU0011

C19 C20

CU8016

CU0067

C21 C22 CU8028 C23 CU8003 C24

CU8003 C25

CU8041

Chip C, C2012B1H102K Chip C, C2012CH1H050C Chip C, C2012CH1H103K Chip C, C2012CH1H101J Chip C, C20T 2CH1H020C Chip C, C2012B1H102K Chip C, C2012CH1H390J Chip C, C2012B1H102K Chip C,C2012B1H102K Chip C, C2012CH1H330J Chip C, C2012CH1H101J Chip C. C2012CHTH050C Chip C. C20T2B1H102K Chip C, C2012B1H102K Chip C, C2012CH1H040C Chip C, C2012CH1H470J Chip C, C2012CH1H100D Chip C, C2012B1H102K Chip C, C2012CH1H390J Chip C, C2012CH1H103K Chip C. C2012JF1E104Z Chip C, C2012JF1E104Z

Ch ip C ,C2012UJ1H471J

Ref.

Part Code

No.

C26 CU8032 C27

CU8003 CU0067 Chip C ,C2012CH1H390J

C28 C29

CU0051 C30 CU0071 C31

CU8028

CS0060

C32 C33 CU0064 C34

CU8003 C35

CU0043 C36 CU8016 C37

CS0061

C38 C39

CU8035 C40

CU8028 C41 CU8034 C42 CU8035

C43 CU8025 C44

CU8025

C45 CU8038 C46

CU8016

C47 CE0124 C48 CU8038 C49 CU0051 C50 CU0051 C51 CU8016

CU8016

C52 C53

CU8016

C54

GS0049

C55

CU8016

C56

CE0312

C57

CU8016

C58

CE0312

C59

CU8016

C60

CE0315

061

CU8016

C62

CU8016

C63 CSQ065 C64

CU8016

C65

CU0071

C66

CU0071

C67

CU0071

C68

CU8038

C69

CU8016

C70

CU8016

C71

CU0004

C72

CU8016

C73

CU0006

C74

CU8016

C75

CU0005

C76

CU0051

C77

CU0061

C78

CU0051

C79

CU0006

C80

CU005I

C81

CU0051

C82

CU0063

C83

CU0004

C84

CU0051

C85

CU0062

C86

CU0051

C87

CU0051

C88

CE0312

C89

CE0312

C90

CU0051

C91

CU0051

C92

CU0051

C93

CU8016

C94

CU8016

C95

CU8016

C96

CE0030

C97

CU8028

C98

CU8028

C99

CS0049

C100

CE0312

C101

CS0049

C102

CU8028

Cl 03

CU8028

C104

CE0312

C105

CE0030

C106

CE0312

Chip C,C2012B1E223K Chip C,C2012JF1E104Z

Ch ip C.C2012CH1H471K Chip C.C2012CH1H101J Chip C,C2012CH1HT 03K Chip T antal, TMC1E474 Chip C ,C2012CH1H220J Ch ip C,C2012JF1E104Z Chip C ,C2012CH1H221K Chip C,C2012B1H102K Chip T anta l, TMC1V224 Ch ip Tan tal, TMC1V224 Chip C ,C2012B1E393K Chip C ,C2012CH1H103K Chip C, C2012X7R1E333K

Chip C, C2012B1E393K Chip C.C2012B1H562K Chip C, C2012B1HS62K Chip C. CM316Y5V1Q5Z25VA Chip C, C2012BIH102K Chemical C, 16VMS7 47 Chip C, CM316Y5V105Z25VA Chip C, C2012CH1H471K Chip C, C2012CH1H471K Chip C, C20I2B1H102K Chip C, C2012B1H102K Ch ip C.C2012B1H102K Chip T an ta l, TMC1C105 Chip C, C2012B1H102K Chanical C, 16CV10B Chip C, C2012B1H102K Chanical C, I6CV10B Chip C, C2012B1H102K Chanical C, 16CV47B Chip C, C2012B1H1Û2K Chip C, C2012B1H102K Chip Tan ta l, TMC10684 Chip C, C2012B1H102K Chip C ,C2012CH1H101J Chip C, C2012CH1H101J Chip C, C2012CH1HI 01J Chip C ,CM316Y5V105Z25VA Chip C ,C2012B1H102K Chip C, C2012B1H102K Chip C ,C2012CH1H030C Chip C ,C2012B1H102K Chip C ,C2012CH1H050C Chip C,C2012B1H102K Chip C ,C2012CH1H040C Chip C ,C2012CH1H471K Chip C, C2012CH1H471K Chip C, C2012CH1H471K Chip C, C2012CH1H050C Chip C. C20I2CH1H471K Ch ip C ,C2012CH1H471K Chip C, C2012CH1H180J Chip C ,C2012CH1H030C Chip C. C2012CH1H471K Chip C, C2012CH1H150J Chip C, C2012CH1H471K .Chip C, C2012CH1H471K Chanical C, 16CV10B Chemical C, 16CV10B Chip C ,C2012CH1H471K Chip C ,C2012CH1H471K Chip C, C2012CH1H471K Ch ip C ,C2012B1H102K Chip C, C2012B1H102K Chip C, C2012B1H102K Chemical C, 16VMS7 10 Chip C.C2012CH1H103K Chip C ,C2012CH1H103K Chip Tan tal, TMC1C105 Chemical C, 16CV10B Chip Tan tal, ™C1 Cl 05 Chip C, C2012CH1H103K Chip C.C2012CH1H103K Chemical C, 16CV10B

Chemical C, 16VMS7 10 Chanical C,16CV10B

Part Name and Number

- 3 -

Ref.

Part Code

No.

C107 CU0071 C108

CU8032 C110 CU8016 c m CU0051

CU0067

Cl 12 C113

CE0312 Cl 14

CU8016 Cl 15 CU8016 C116 CU8016

Cl 17 CU8016

C118

CU801G Cl 19 CU0003 C120

CU8016 C121

CU8016 Cl 22 CU8016 C124 CS0049

C125

CU8016 Cl 26

CU8016

C127

CE0312 C128

CU8016

Cl 29

CJ8016 C130 CU0060

CE0124

C131 C132 CU0071 C133

CU8016

Cl 34

CU0071

C135

CU0003

CU0005 Chip C,C2012CH1H040C

C136

RK0059

RK0069

RK0018

RK 0005

RK0018

RK0056

RK0035

R10

RK0038

R11

RK0052

R12

RK0022

R13

RK0042

R14

RK0045

R15

RK0069

R16

RK0035

R17

RK0052

H18

RK0056

R19

RK0045

R20

RK0076

R21

RK0044

R22

RK0076

R23

RK0044

R24

RK 0052

R25

RK0069

R26

RK0028

R27

RK0056

R28

RK0081

R29

RK0042 R30 RK0047 R31 RK0069 R32

RK0035

R33

RK0035 R34

RK0018 R35

RK0056

R36

RK0044 R37

RK0081 R38

RK0039 R39

RK0023 R40

RK0056 R41

RK0062 R43

RK0081 R44

RK0045

R45

RK0079

R46

RK0Q39

R47

RK0035

R48

RK0107

R49

RK0039

R51

RK0006

R52

RK0045 R53

RK0006

R54

RK0056

R55

RK0056

Chip C.C2012CH1H101J Chip C. C2012B1E223K Chip C.C2012B1H102K Chip C.C2012CH1H471K Chip C, C2012CH1H390J Chemical C,16CV10B

Chip C,C2012B1H102K Chip C.C2012B1H102K Chip C, C2012B1H102K Chip C, C2012B1H102K Chip C,C2012B1H102K Chip C, C2012CH1H020C Chip C. C2012B1 HI02K

Chip C.C2012B1H102K Chip C.C2012B1H102K Chip Tan tal, TNC1Cl 05

Chip C,C2012B1H102K

Chip C ,C20Í2B1H102K Chemical C, 16CV10B Ch ip C. C2012B1H102K Chip C,C2012B1Hl02K Chip C, C2012CH1H470J Chemical C, 16VMS7 47 Chip C.C2012CH1H101J Chip C. C2012B1H102K Chip C, C2012CH1H101J Ch ip C, C2012CH1H020C

Chip Chip Chip Chip Chip Chip Chip Chip

Chip Chip

Chip

Chip Chip

Chip

Chip R, MCR10EZHJ103E Chip Chip Chip Chip Chip Chip Ch ip

Chip Chip

Chip

Chip Chip Chip Chip Chip Chip Chip Chip R,MCR10EZHJ564E Chip Chip Chip Chip Chip Chip Chip Chip Chip Chip R. MCR10EZHJ223E Chip

Part Name and Number

R.MCR10EZHJ333E R. MCR10EZHJ104E R. MCR10EZHJ101E R,MCR10EZHJ101E R,MCR10EZHJ220E R.MCR10EZHJ101E R. MCR10EZHJ223E R. MCR10EZHJ102E R.MCR10EZHJ182E R.MCR10EZHJ103E R.MCR10EZHJ221E R, MCR10EZHJ332E R, MCR10EZHJ472E R, MCR10EZHJ104E R,MCR10EZHJ102E R, MCR10EZHJ103E R. MCR10EZHJ223E R. MCR10EZHJ682E R, MCR1QEZHJ334E R, MCR10EZHJ392E R, MCR10EZHJ334E R.MCR10EZHJ392E

R. MCR10EZHJ104E R.MCR10EZHJ471E R, MCR10EZHJ223E R.MCR10EZHJ564E R, MCR10EZHJ332E R. MCR10EZHJ562E

R, MCR10EZHJ104 R, MCR10EZHJ102E R. MCR10EZHJ102E R. MCR10EZHJ101E R,MCR10EZHJ223E R,MCR10EZHJ392E R, MCR10EZHJ564E R.MCR10EZHJ222E R, MCR10EZHJ271E R. MCR10EZHJ223E R. MCR10EZHJ473E

R. MCR10EZHJ472E R, MCR10EZHJ474E R, MCR10EZHJ222E R. MCR10EZHJ102E R. MCR10EZHJ000E R. MCR10EZHJ222E

R. MCR10EZHJ270E

R, MCR10EZHJ472E

R, MCR10EZHJ270E

R.MCR10EZHJ223E

Ref.

Part Code

No.

RK0035

R56 R57 RK0038

RK0052

R58

RK0052

R59

RK0052

R60

RK0052

R61

RK0056

R62 R63 RK0018 R65 RK0018

RK0039

R66 R67

RK0035

R68 RK0045

RK0035

R69 R70 RK0011 R71 RK0018 R72 RK0011

RK0037

R73 R74 RK0001 R75

RK0038 RK0045

R76 R77 P.K0056 R78 RK0056 R79 RK0056 R80 RK0056 R81 RK0052 R82

RK0028 R83 RK0052 R84

RK0020 R85

RK0010 R86 RK0020 R87 RK0020

RK0039

R88 R89 RK0036 R90 RK2010 R91 RK0052 R92 RK0052 R93

RK0059 R94

RK0107 R95 RK0011 R96 RK0045 R98 RK0070 R99 RK0052 R100

RK0038 R101 RK2006 R102 RK0073 R103 RK0036

RK0069

R104

R105

RK0107 R106

RK0107 R108

RK0107

RH0031 VR, CVR-42A-I03AD

VR1

RH0038

VR2

RH0031 VR,CVR-42A-103AD

VR3

RH0051 VR,CVR-42A-472AD

VR4

RH0036

VR5

CT0031 Trimmer, CTZ-05A

TCI

CT0031

TC2

QA0069

LI L2 QA0069

QA0042 Coil, 30R8MIF

QA0044

QK0036

L6 L7 QC0056

QC0057

QC0062

QC0039

n o

QC0059

L11

QC0055

L12

QC0055

L13

QK0037

L14

QK0038

LI5

L17 QC0061 Chip L. NL322522T—033M

0C0055

L18

XS0004

TH1

XS0008

TH2

UE0041

TP1

Part Name and Number

Chip R. MCR10EZHJ102E Chip R. MCR10EZHJ182E Chip R, MCR10EZHJ103E Chip R. MCR10EZHJ103E Chip R, MCR10EZHJ103E Chip R, MCR10EZHJ103E Chip R.MCR10EZHJ223E Chip R.MCR10EZHJ101E Chip R. MCR10EZHJ101E Chip R,MCR10EZHJ222E Chip R, MCR10EZHJ102E Chip R, MCR10EZHJ472E Chip R.MCR10EZHJ102E Chip R, MCR10EZHJ470E Chip R, MCR10EZHJ101E Chip R. MCR10EZHJ470E

Chip R,MCR10EZHJ152E

Chip R, MCR10EZHJ100E Chip R, MCR10EZHJ182E Chip R.MCR10EZHJ472E

Chip R, MCR10EZHJ223E Chip R.MCR10EZHJ223E Chip R, MCR10EZHJ223E Chip R, MCR10EZHJ223E

Chip R, MCR10EZHJ103E Chip R, MCR10EZHJ471E Chip R, MCR10EZHJ103E

Chip R,MCR10EZHJ151E

Chip R, MCR10EZHJ390E

Chip R, MCR10EZHJ151E

Chip R, MCR10EZHJ151E Chip R, MCR10EZHJ222

Chip R, MCR10EZHJ122E

Chip R, MCR50JZHJ330E

Chip R. MCR10EZHJ103E

Chip R, MCR10EZHJ333E

Chip R.MCR10EZHJ000E

Chip R, MCR10EZHJ470E

Chip R, MCR 10EZHJ472E

Chip R, MCR10EZHJ124E

Chip R, MCR10EZHJ103E

Chip R.MCR10EZHJ182E

Chip R, MCR50EZHJ150E

Chip R.MCR10EZHJ224E Chip R, MCR10EZHJ122E

Chip R, MCR10EZHJ104E

Chip R,MCR10EZHJ000E

MCR10EZHJ000 MCR10EZHJ000

VR. CVR-42A-473AD

VR, CVR-42A-102AD

Trijnn er, CTZ-05A

HF C oil. 110-90124 HF C oil. 110-90124

Coil, 455kHz Coil, 0R6-3-1R5RM Chip L,NL322522T-012M Chip L,NL322522T-015M

Chip L,NL322522T—039M Chip L, NL322522T-1R0M

Chip L,NL322522T-022M Chip L, NL322522T-0I0M

Chip L, NL322522T—010M C o il, 0R6-3-2R5RM C oil. 0R7-3-1R5RM

Chip L, NL322522T-010M

Th ermistor, TD5A150D Th ermis tor. TD5C220D

Pin Jack, TMP-J01X-V6

Ref.

Part Code

No.

UE0047

TP2

TP4 UE0047

CN51

UE0109 CN52 UE0111 CN53

UE0108 CN54

UE0075 CN55

UE0075 CN58

UE0108

XA0156

IC1 IC2 XA0033 IC3

XA0114

IC4

XA0119

XD0040

XD0118

XD0040

DIO

XD0120

Dll

XD01I2

D12

XD0141

D13

XD0041

DI 4

XD0041 Diode. DAP202K

D15

XD0014

D16

XD0040

DI7

XD0113 Zener, 02CZ4. 3Y

D18

XD0104

D19

XD0103

D20

XD0103

XE0013 FET, 3SKI34S

02 XE0014

XE0002 04 XT0030

XT0037

06 Q7 XT0037

XT0037

Q8 Q10 XU0019

XU0018 D igit a l T ransistor ,

Q12

XT0077

Q13 XU0014

014 XU0014

015 XT0061 Q16

XT0030 Ql 7 XT0030 018

XT0048 Q19

XT0078 Q20

XU0014

Q2I

XT0061

Q22

XU0019 D igital Tran sistor,

Q23 XT 0037

Q24 XT0037 Q26

XT0038

Q27

XT0037

Q28

XT0092

Q29

XU0018

Q30 XU0014

Q31

XT0061

Q32

XT0030

Q32 XU0014

FL1

XF0006

FL2

XC0001

UX1004 Wire

XQ0034

Diode. DAP202K

Diode. MI308 Diode. DAN202K

Zener, 02CZ6, 2Y Diode. 1SS226 Diode,1SS226 TE85L

FET. 3SK184R

FET, 2SK125 Tra nsistor , 2SC3356BR25 Transistor, 2SC2412KR Tra nsistor, 2SC2412KR Transistor, 2SC2412KR Tra nsistor , 2SC2412KR

D i g ita l T ran s isto r,

Tra nsistor , 2SC3326A D ig it a l Tr ans istor,

D ig it a l Tr an sistor,

T rans is tor,2SB1132Q

Trans istor,2SC 3356B R25 Transistor, 2SC3356BR25 Transistor, 2SC3357RE Tra nsistor , 2SC3369 D i g ita l T ran sistor,

Transistor, 2SB1132Q

Tra nsistor, 2SC2412KR Tra nsistor , 2SC2412KR Transistor,2S A1037KT146R Tra nsistor , 2SC2412KR Trans is tor. 2SA1307Y D ig it a l Trans isto r.

D ig it a l Trans is to r,

Transistor.2SB1132 Q

Tra nsistor , 2SC3356BR25

D i g ita l Trans is to r,

X ' ta l F i lte r , 30. 8M15AUM-1 Ceramic F i lt e r , CF1N455F

X 'ta l, HC-4 9/T 30. 4MHz

Part Name and Number

Round Pin, R9 X 10 Round Pin, R9 X 10

Connector, 52030-1810 Connector,5513-03CPB Connector, 6FE-BT Pin Jack, TMP-J01X-A2 Pin Jack, TMP-JO 1X-A2 Connector, 6FE-BT

IC,MC3361BD IC, nPC393G IC, u PD6345GS IC.AN8010M

Diode, DAN202K Diode, MA716 Diode. MA716 Diode, DAN202K Diode.MA704WK Pin-D,1SV 128 Diode ,1S V237T E85R

DTA114YKT14

DTC124EK

DTC144EK

DTC124EK

DTC144EK

- 4 -

Ret.

No.

Part Code

Part Name and Number

V H F P A U n it

CU8016

CE0201

CU8016

CE0201

CC5022

CU8016

CC5021 Ceranic C, HM60SJ220J

CU0006

CU0002

CIO

CC5023 Ceram ic C.HM60SJ390J

C11

CU7003

C12

CC5023

C13

CU0002

C14

CU8016 C16 CU8016 C17 CC5003

CU8016

CIS

UJ0020

J1 J2 UJ0021 Jack, HSJ0837-01-010

UE0108 Connector, 6FE-BT

CN42

CN44

UE0114

UE0043

CN48

RT1

UE0119 RT P in,RT -01T-l.0 B RT2 UE0119 RT3 UE0119 RT Pin, RT-01T-1.0B

: ' IC I XA0122

XD0106

XD0014

D2 D3 XD0102

QK0061

QK0042

QK0060 C oil, 0R8-3-5R 0 RS

QK0059

L5 ÜK0061 C o il, 0R 5-3-9R 5 l_M L6

QK0059

RK0045

RK0011

RK2018

VR1

RH0038

UX1005

UX1007

»6 UX1009

Chip C,C2012B1H102K Chemical C, 16MV10SZ

Chip C, C2012B1H102K

Chemical C ,16MV10SZ Ceramic C, HM60SJSL270K Chip C, C2012B1H102K

Chip C.C2012CH1H050C Chip C, C2012CH1H010C

Chip C, C3CK1NAR102K Ceramic C, HM60SJ390J Chip C.C2012CH1H010C Chip C, C2012B1H102K Chip C, C2012B1HI02K Ceramic C, HM60SJ330J Chip C, C2012B1H102K

Jack, HSJ0836-01-310

Connector, 5512-04A Post w ith Base, PI22A02M

RT Pin, RT-01T-1.0B

IC. M57726R

Diode, UM940I

Diode, MI308 Diode, 1SS101

C oil, 0R8-3-9R5TLM Coil,0R6-3-5 R0 RM

Coil, 0R 8-3-4R0 RS

C oil, 0R 8-3-4R0 RS C oil, 0R 8-3-4R0 RS

Chip R, MCR10EZHJ472E Chip R, MCR10EZHJ470E Chip R.MCR50JZHJ151E

VR, CVR-42A-473AD

Hire Hire H ir e

U H F P A U n it

CE0163 Chemical C,16MV 1000AZ

Cl C2 CU0051 Chip C, C2012CH1H471K C3 CE0201 C4

CU0051

C5 CE0201 Chemical C, 16MV 10SZ

CU7014

C6 C7

CU0051 Chip C.C2012CH1H471K C8 CU0007 C9

CC5008 Ceramic C, HN60SJSL070D

CC5016 Ceramic C, HN60SJSL080D

CIO

CU0002 C11

CU8028 Chip C. C2012B1H103K C12 CU7021 C13

CU7022

C13

CU7016

Cl 4

CU8016 C15

CU8016 C16 CU8016

Chemical C, 16MV 10SZ Chip C. C2012CH1H471K

Chip C, JC232H0060D-T

Chip C,C2012CH1H060D

(E only)

Chip C.C2012CH1H010C

Chip C,UC232H0160J Chip C. TE82JC232H0100D

Chop C. TE82UC232H0080D

Chip C. C2012B1H102K Chip C. C2012B1H102K Chip C, C2012B1H102K

(T o nly)

(E only )

(T on ly)

Ret.

Part Code

No.

CU7003

C17

CU8016

C24

CU8016

C25

CS0208

C26

CJ8016

C27

CU8016

C28

CS0208

C29 C30 CU8016

CU0051

C31

CU8016

C32

CU0005

C33

UE0108

CN62 CN64 JE0112 CN65 UE0116

UE0116

CN67

UA0002

CN68

UE0108

CN6A

UE0119

RT1

UE0119

RT2

UE0119

RT3

UE0119

RT5

RK0107

RK0045

RM501 \

l'IC I XA0077A

DI XD0106

XD0014

XD0102

XD0040

XD0107

QK0044

QK0068

QK0065

0K0065

QK0094

QB0003

VR1

RH0038

MRAE08CC

»1 «8 UX1007

UX1008

W9 #18

HRAH08FC Wire #24R15 -0 80-05

Part Name and Number

Chip C, C3K3INAR102K Chip C,C2012B1H102K Chip C,C2012B1H102K Chip T antal, TMC-M0J475M Chip C, C2012B1H102K Chip C, C2012B1H102K Chip T an tal, TMC-M0J475M Chip C, C2012B1HI02K Chip C, C2012CH1H471K Chip C, C2012B1H102K Chip C,C2012CH1H040C C33

Connector, 6FE-BT Connector, 5513-04CPB Pin 1 .0 X18 L (T only) Pin 1 .0X1 8L R/B 1.25 X0 .25M Plug Connector, 6FE-BT

RT Pin, RT-01T-1. 0B RT Pin. RT-01T-1. 0B RT Pin, RT-01T-1.0B RT Pin, RT-01T-1. 0B

Chip R, MCR10EZHJ000E Chip R, MCR10EZHJ000E Chip R.MCR10EZHJ472E Chip R, MCR10EZHJ470E

IC,M57788M

Diode, UM9401 Diode, MI308 Diode, 1SS101 Diode, DAN202K Diode, G3B

Air Core Coil,0R5-3R0-9R 5T

Air Core C oil,0R8-3R0-2R5T

Air Core Co il,0R8-4R0-1R2T

A ir Core Coil, 0R8-4R0-1R2T

Air Core C oil,0R8-3R4-1R2T

OP-2. 6-3 -1 .2

VR, CVR-42A-473AD

» ire #18R05—080—05

Wire Wire

CONTROL Unit

C1 CU8003 Chip C, C2012JF1E104Z C2 CU8003 C3 CU8003 Chip C, C2012JF1E104Z C4

CU8003 C5 CU8003 Chip C, C2012JF1E104Z C6 CU8003 Chip C. C2012JF1E104Z C7 CU8003 C8 CU8003 Chip C, C2012JF1E104Z C9 CU8003 Chip C.C2012JF1E104Z

CU8003

CIO

CU8003 Chip C.C2012JF1E104Z

C11

CU8003 Chip C, C2012JF1E104Z

CI2 C13 CU8003 C14 CU8003 Chip C, C2012JF1E104Z

CU8003 Chip C, C2012JF1E104Z

C15

CU8003 Chip C, C2012JF1E l04Z

C16 C17

CU8003 Chip C, C2012JF1EI04Z CU8028 Chip C.C2012B1H103K

C18

CU8028 Chip C. C2012B1Hl03K

C19 C20 CU8028 C21 CU8016

CU8016

C22

Chip C, C2012JF1E104Z

Chip C.C2012JF1E104Z

Chip C, C2012JF1E104Z

Chip C.C2012B1H103K Chip C, C2012B1H102K Chip C, C2012B1HI02K

(E o nly)

(T only )

Ref.

Part Code

No.

C23

CU8016

C24

CU8016

C25

CU8016

C26

CU8016 Chip C.C2012B1H102K

C27

CU8016

C28

CU8016 Chip C.C2012B1H102K

C29

CU8016

C30

CS0052

C31

CU0071 Chip C, C2012CH1H101J

C32

CU8034 Chip C .C2012X7R1E333K CU8040 Chip C, 2012JB1E473K

C34

CU8038

C35

CU8038

C36

CU8038

C36

CU9010

C37

CU8038 Chip C, CM316Y5V105Z25VA

C38

CU8038 Chip C, CM316Y5V105Z25VA

C39

CU8016

C40

CE0118 Chemical C, 6R3MS7 220

C41

CS0052 Chip Tan ta l, TMC1A336

C42

CU8016 Chip C,C2012B1H102K

C43

CU8016 Chip C, C2012B1H102K

C44

CS0052

C45

CE0315

C46

CU8016

C48

CS0221

C49

CU0071

C50

CU0051 CU0051

C51 C52

CU0060

C53

CU0065 Chip C,C2012CH1H270J

C54

CU0065 Chip C.C2012CH1H270J

C55

CS0057

C56

CU8003

C57

GU8003

C58

CU0071 Chip C,C2012CH1H101J

C59

CU8028

C60

CU8028

C61

CU8028

C62

CU8028

C63

CJ8016

C64

CU3023

C65

CU3023

C66

CU3023

C67

CU0071

C68

CU0071

C69

CU3053

C70

CU80 40

RA0002 R- A lly, MNR12E0AJ473E

RA0002

RA0002 R. A lly, MNR12E 0AJ473E

RA0002

RK0086 Chip R,’mCR10EZHJ105E

RK0052

R10

RK0105 Chip R,MCR10EZHJ2R2E

Rll

RK0062 Chip R, MCR10EZHJ473E

R12

RK0062 Chip R, MCR10EZHJ473E

R13

RK0036 Chip R, MCR10EZHJ122E

R14

RK0036 Chip R,MCR10EZHJ122E

R15

RK0033 Chip R. MCR10EZHJ821E

R16

RK0033

R17

RK0033 Chip R, MCR10EZHJ821E

R18

RK0033 Chip R. MCR10EZHJ821E

R19

RA0005 R. A lly , MNR14AJ473E

R20

RA0005

R21

RA0005 R. A lly. MNR14AJ473E

R22

RA0005 R. A lly, MNR14AJ473E

R23

RK0059 Chip R, MCR10EZHJ333E

R24

RK 0062

R25

RK0042 C hip R, MCR10EZHJ332E

R26

RK0037 C hip R, MCR10EZHJ152E

R27

RK0056

R28

RK0045

R29

RK0062

R30

RK0062

R31

RK0107 Chip R, MCR10EZHJ000E

Part Name and Number

Chip C, C2012B1H102K Chip C. C2012B1H102K Chip C,C2012B1H102K

Chip C, C2012B1H102K

Chip C, C2012B1H102K Chip T an ta l, TMC1A336

Chip C,CM316Y5V105Z25VA Chip C. CM316Y5V105Z25VA

Chip C. CM316Y5V105Z25VAT

Ch ip C, C32161H223KB

Chip C, C2012B1H102K

Chip T an tal, TMC1A336

Chemical C, 16CV47B Chip C. C2012B1H102K Chip Tan tal, TMCM1C475TR Chip C,C2012CH1H101J Chip C, C2012CH1H471K Ch ip C, C2012CH1H471K Chip C.C2012CHÍH470J

Ch ip T antal,TMC0J225 Ch ip C,C2012JF1E104Z

Ch ip C,C2012F1E104Z

Ch ip C,C2012B1H103K Chip C.C2012B1H103K Ch ip C .C2012B1H103K Chip C,C2012B1H103K Chip C .C2012B1H102K Ch ip C,CM105CH101K50VA

Chip C, CM105CH101K50VA

Chip C, C2012CH1H101J

Ch ip C, C2012CH1H101J Ch ip C, CM105Y5V333Z25VA Ch ip C ,2 012JB1E473K

R. A lly, MNR12E 0AJ473E R. A l ly , MNR12E0AJ473E R. A lly , MNR12E0AJ473E

R. A lly, MNR12E0AJ473E

Chip R, MCR10EZHJ103E

Ch ip R, MCR10EZHJ821E

R. A lly, MNR14AJ473E

Chip R, MCR10EZHJ473E

Chip R. MCR10EZHJ223E Chip R. MCR10EZHJ472E

Chip R, MCR10EZHJ473E

(E only)

- 5 -

Ref.

Part Code

No.

RK0107

R34

RA0006

R36

R36 RD0115 R37 RA0005

RK0050

R38 R39 RK0025 R41 RA0005

RKQ033

R42

RK0033

R43 R44 RK0039 R45 RK0039 Chip R, MCR10EZHJ222E R46

RK0039 Chip R. MCR10EZHJ222E

R47

RK0039

R4S RK0001

RK0069

R49

RK0056

R50 R5I

RK0001 RK0036

R52 R53 RK0035 R54 RK0079

RK0072

R55 R56 RK0073 R57

RK0059

R59 RK0064 C hip R,MCRI0EZHJ563

RK0062

R60

R61 RK0045 R62 RK0069

R63 RK0035

RK0107

R64

VR1

RH0038

VR2 RH0038

QC0104

CN12 UE0115

UE0121 Connector. R-DR590

CN15 CN16 UE0035

SW1

UU0011 Tact Switch, SKHMPU

SW2

UU0011 T act Switch, SKHMPU

SW3

UU0011

SW4

UU0011 Tact Switch. SKHMPU

SW5

UU0011

SW6

UU0011

SW7

UU0011

SW8

UU0011 Tact Switch, SKHMPU

SW9

UU0011 Tact Switch, SKHMPU

SW10

UU0011

SW11

UU0011 T act Switch. SKHMPU

SW12

UU0011 Tact Sw itch, SKHMPU

SW13

UU0011

SW14

UQ0013

SW15

UQ0013

SW16

UU0011 Tact Sw itch, SKHMPU

SW17

UU0011

SW18

UQ0011 Sw itch. ESB-64801

SW19

UR0002 Switch. EVQWQGF1542B

ED0006 L ithiu n Battery, BR2032-1F2 TZ0024 Insu latin g Paper

LCD

EL0017

XD0040 Diode,DAN202K

XD0041 Diode, 1SS226

XD0040

XD0040 D6 XD0040 Diode, 0AN202K D il XL0026 D12

XL0026

D13

XL0026 Chip LED,AA1101W-72-TR

D14

XL0026

D15

XL0026 C hip LED,AA1101W-72—TR

D16

XL0026 Chip LED,AA1101W-72-TR

D17

XL0026

Part Name and Number

Chip R. MCR10EZHJ000E

R. A lly , EXB-M16D6ALG

JPWOIFCO 3 0Q (E o nly)

R. A lly , MNR14AJ473E Chip R,MCR10EZHJ822E Chip R,MCR10EZHJ331E R. Ally. MNR14AJ473E Ch ip R,MCR10EZHJ821E Ch ip R,MCR10EZHJ821E Chip R.MCR10EZHJ222E

Chip R,MCR10EZHJ222E Chip R,MCR10EZHJ100E Chip R, MCR10EZHJ104E Ch ip R, MCR10EZHJ223E Chip R, MCR10EZHJ100E Chip R,MCR10EZHJ122E Ch ip R. MCR10EZHJ102E Ch ip R,MCR10EZHJ474E

Chip R, MCR10EZHJ184E

Chip R.MCR10EZHJ224E Chip R, MCR10EZHJ333E

Ch ip R, MCR10EZHJ473E

Chip R, MCR10EZHJ472E

Chip R, MCR10EZHJ104E

Ch ip R,MCR10EZHJ102E

Chip R,MCRIOEZHJOOOE

VR. CVR-42A-473AD

Chip L, LER015T1R5M

Ch ip L,LER015T1R5M

Connector, 50020-8106

Mic Connector, FM214-8SMPY

Tact Switch, SKHMPU

Tact Sw itch, SKHMPU

Tact Switch. SKHMPU

Tact Sw itch, SKHMPU

Tact Sw itch. SKHMPU

Sw itch, EVQ-QEC-04K

Tact Sw itch, SKHMPU

LCD U nit,DR599T

Diode, DAN202K Diode, DAN202K

Ch ip LED,AA1101W-72-TR ' Chip LED,AA1101W-72-TR

Ch ip LED,AA1101W -72-TR

Ch ip LED,AA1101W-72-TR

(E only)

(T on ly)

(T only)

(E o nly)

Ref.

Part Code

No.

DI8

XL0026 D19 XL0026 D20 XL0026 D21 XL0026 D22 XL0026 D23

XL0026 D24 XL0026 D25 XL0026 D26 XL0026

IC1

XA0180

IC2

XA0105 IC, MC145436DWR

IC3

XA0117

IC4

XA0118 IC, S-8054ALR-LN

IC5

XA0075 IC, NJM78L08UA

IC6

XA0068 IC ,M5218FP-T01-1

IC7

XA0089

IC8 XA0087

Q1 XT0037 Q2

XU0028

XU0012

Q5 XT0037 Trans istor, 2SC2412KR Q6

XT0018 T ra nsistor, 2SB744Q

XU0014

Q10

XT0037 T ra nsistor, 2SC2412KR

*12

MRCL02AA W10 MACL02AA W16 »CCLQ2AA.

MGCL02AA

W17

XQ0021

Part Name and Number

Ch ip LED,A A IIO IW -72'TR Chip LED,AAU01W -7 2'T R Chip LED,AA1101W-72'TR Chip LED,AA1101W-72-TR Chip LED,AA1101W-72-TR Chip LED,AA1101W-72-TR Chip LED.AAl101W-72JTR Chip LED,AA1101W-72-TR Chip LED,AAU 01W-72-TR

IC, u PD75116GFF19-3BE

IC. S—2510A

IC, NJM78L06UA IC. TC4S01F

Trans is to r, 2SC2412KR

D ig ital Trans is to r, FMC2 D ig ita l Trans is to r,

D ig ital Tran sistor,

D ig ita l Trans is tor,

D ig ita l Tr ans istor.

D ig ita l Trans is to r,

Wire »3 0R 02-020-02 Wire K 30A02-020-02 Wire # 30 G02-020-02 Wire » 30 G02-020-02

DSMAT3. 58MHz

DTC114EK

DTC144EK

S U B C O N T R O L U n i t

CU8016 C2 CE0124 Chemical C, 16MV47SWB C3 CU8016 C4

CE0313

CS0210

CE0310

CU8016

CU0060

CIO

CU0060

C11

CUQ051

C12 C13 CS0051 C14 CU8003

.-C l 5 CU8038

C16

TBW IU C17 CU8016 C18 CU0055 C19 CU8022 C20 CU0070

CU8016

C21

CS0221

C22 C23 CU8020 C24 CU8028 C25

CU8028 C26 CU8016 C27 CU8016 C29 CS005I Chip Tantal, TMC1CI 06 C30

CU8003 C31 CE0124 C32 CU8028

CU8034

C33 C3A

CU8028

C35 CU8016

CU8034

C36 C37

CU8028 C39

CU8028

Chip C, C2012B1H102K

Chip C.C2012B1H102K Chemical C. 16CV22B Ch ip T a n ta l , TMCMB0J156MTR Chemical C, 10CV33B Chip C.C2012B1H102K Chip C, C2012CH1H470J Chip C. C2012CH1H470J Chip C.C2012CH1H470J Chip C.C2012CH1H470J Chip C.C2012CH1H471K Chip Ta ntal, TMC 1C106 Chip C, C2012JF1E104Z Chip C,CM316Y5V105Z25VAT

“Chen L'cal C, 10CV33B

Chip C, C2012B1H102K Chip C.C2012CH1H681K Chip C, C2012B1H332K Chip C, C2012CH1H820J Chip C, C2012B1H102K Chip Tantal, TMGM1C475MTR Ch ip C,C2012B1H222K

Chip C. C2012B1Hl03K Chip C, C2012B1H103K Chip C,C2012B1H102K Chip C, C2012B1Hl02K

Chip C, C2012JF1E104Z Chemical C. 16MV47SWB Chip C. C2012B1H103K Chip C. C2012X7R1E333K Chip C.C2012B1H103K Chip C. C2012B1H102K Chip C, C2012X7R1E333K Chip C, C2012B1H103K Chip C, C2012B1H103K

.........

Ref.

Part Code

No.

C40 CU8028 G42 CU8034 C43 CU8034 C44

CU8038

C45

CU8038

C46

CS0221

C47

CU8028 C4S CS0051 C49 CU8038 C50 CE0315

CU8028

C51 C52 CU8038

CU8003

C53 C54

CS0051

C55 CU8028 C56

CU8028

C57 CU8028 C58 CU8028

CU8028

C59 C60 CU8Q28 C61 CU8028

CS0057

C62 C63 CS0057 C64 CU3023 C65 CU3023 C66 CU3023 C67 CU3023

CU3023

C68 C69 CU3023

C71 CU8038

UE0120

CN21

UE0100

CN22

UE0110

CN23

UE0109

CN24

UE0109

CN25

RI RA0003

RA0003

R6 RA0QQ3

R7 RK0035 R8 RK0035

R9 RK0035

RIO RK0035

RK0035

R11

RA0004

RI 2 R13 RK0052

RI 4

RK0056

R15

RK0061

R16

RK0067

R17

RK0052

R18

RK0056

R19

RK0061

R20

RK0067

R21

RK0062

R22

RK0062

R23

RA0004

R24

RA0002

R25

RA0005

R26

RK0038

R27

RK0038

R28

RK0035

R30

RK0035

R31

RK0035

R32

RK0045

R33

RK0062

R34

RK0107 Chip R, MCRIOEZHJOOOE

R35

RK0018

R36

RK0052

R37

RK0056

R38

RK0061

R39

RK0067

R40

RK0044

R41

RK0044

R42

RK0044

R43

RK0044

R45

RK0045

R46

RK0052

Chip C. C2012BTH103K Chip C. C2012X7R1E333K Chip C, C2012X7R1E333K Chip C, CM316Y5V105Z25VAT Chip C, CM316Y5V105Z25VAT Chip T antal, TMCM1C475MTR Chip C.C2012B1H103K Chip Tan ta l, TMC1C106 Chip C, CM316Y5V105Z25VAT Chemical C, 16CV47B Chip C.C2012B1H103K Chip C, CM316Y5V105Z25VAT Chip C, C2012JF1E104Z Chip Tan ta l, TMC1 CI 06 Chip C.C2012B1H103K Chip C,C2012B1H103K Chip C, C2012B1H103K Chip C. C2012B1H103K Chip C,C2012B1H103K Chip C.C2012B1H103K

Chip C, C2012B1H103K

Chip Tan ta l, TMCOJ225M

Chip T antal, TWC0J225M

Chip C, CM105CH101K Chip C.CM105CH101K Chip C, CM105CH101K Chip C, CM105CH101K

Chip C.CM105CH101K

Chip C, CM105CH101K CM316YV105Z25AT(E only )

Connector, P-DR590

Connector, 52030-1610

Connector, 52030-1210

Connector, 52030-1810

R. A l ly , MNR14E0AJ102E

R. A l ly . MNR14E0AJ102E R. Ally, MNR14E0AJ102E

R. A lly, MNR14E0AJ102E R. Ally, MNR14E0AJ102E R- Ally, MNRl4E QAJ102E

Chip R,MCR10EZHJ102E

Chip R, MCR10EZHJ102E

Chip R.MCR10EZHJ102E Chip R.MCR10EZHJ102E Chip R. MCR10EZHJ102E

R. A lly, MNR14J473E

Chip R, MCR10EZHJ103E

Chip"R, MCR10EZHJ223E

Chip R, MCR10EZHJ393E Chip R, MCR10EZHJ823E

Chip R, MCR10EZHJ103E

Chip R. MCR10EZHJ223E

Chip R, MCR10EZHJ393E

Chip R, MCR10EZHJ823E Chip R, MCR10EZHJ473E

Chip R, MCR10EZHJ473E

R. A lly , MNR14J392E

R. A lly , MNR12J473E

R. A lly . MNR14J473E Chip R,MCR10EZHJ182E Chip R, MCR10EZHJ182E Chip R.MCR10EZHJ102E Chip R. MCR10EZHJ102E Chip R, MCR10EZHJ102E Chip R, MCR10EZHJ472E Chip R. MCR10EZHJ473E

Chip R, MCR10EZHJ101E Chip R, MCR10EZHJ103E Chip R, MCR10EZHJ223E Chip R, MCR10EZHJ393E Chip R,MCR10EZHJ823E

Chip R,MCR10EZHJ392E Chip R, MCR10EZHJ392E Chip R, MCR10EZHJ392E Chip R, MCR10EZHJ392E Chip R, MCR10EZHJ472E Chip R. MCR10EZHJ103E

Part Name and Number

- 6 -

Ref.

Part Code

No.

R47

RK0056

R48

RK0061 Chip R, MCR10EZHJ393E R49 RK0067 R51 RK0044 R52 RK0044 R53 RK0044 R54 RK0044 R55 RK0038 R56

RK0052 Chip R, MCR10EZHJ103E

R57

RK0045

R58

RK0062 Chip R, MCR10EZHJ473E

R60

RK0062 Chip R, MCR10EZHJ473E

R61

RK0045 Chip R, MCR10EZHJ472E

R63

RK0005

R64

RK0052 Chip R.MCR10EZHJ103E (E only ) RK0062

R65

RK0078

R66

R67

RK0076 R68 RK0072 R69 RK0073

RK0047

R70 R71 RK0047

RK0067

R72 R73 RK0070 Chip R, MCR10EZHJ124E R74 RK0070 Chip R, MCR 10EZHJ124E R75 RK0069 Chip R, MCR10EZHJ104E R76 RK0056 Chip R, MCR10EZHJ223E R77

RK0001 Chip R, MCRI0EZHJ100E R78 RK0039 Chip R, MCR10EZHJ222E R79 RK0081 R80

RK0035 R81

RK0045 R82 RK0062 Chip R, MCRI0EZHJ473E R83 RK0052 Chip R. MCRI0EZHJ103E R84

RK0045 Chip R,MCRI0EZHJ472E

R85 RK0039 Chip R, MCRI0EZHJ222E R86 RK0045. Chip R, MCR10EZHJ472E

R87

RK0001 Chip R. MCRI0EZHJ100E R88

RK0035

R89 RK0081 R90

RK0018

R91

RK0039

R92 RK0045 R93 RK0062 Chip R, MCR10EZHJ473E R94

RK0045 Chip R, MCR10EZHJ472E

R95 RK0001 Chip R,MCR10EZHJ100E R96

RK0035 Chip R, MCR10EZHJ102E

R97

RK0081 Chip R,MCR10EZHJ564E

R99 RK0070 Chip R, MCR10EZHJ124E RI 00 RK0070 Chip R,MCRI0EZHJ124E

R102

RK0052

RI 03

RK0052

R104

RK0045

R105

RK0045

RI 06

RK0018

RI 07

RK0027

RI 08

RK0027

R111

RK0052

R112

RK0052

R] 13

RK0052

R114

RK0052

R115

RK0045 R116 RK0069 R117

RK0052 R118

RK0107 Chip R, MCR10EZHJ000E RI 19

RK0001 R120

RK0069 R121

RK0069

R122

RK0073 Chip R, MCRI0EZHJ224E(E only)

R123

RK0107 RI 25

RK0055

XB0004

QC0104

IC1

XA0183

IC2

XA0118

IC3

XA0098 IC. NJM78L05UA

IC4

XA0082

Pan Name and Number

Chip R, MCR10EZHJ223E

Chip R, MCR10EZHJ823E IC7 Chip R, MCR10EZHJ392E Chip R.MCR10EZHJ392E Chip R, MCR10EZHJ392E Chip R. MCR10EZHJ392E Chip R,MCR10EZHJ182E

Chip R,MCR10EZHJ472E

Chip R, MCR10EZHJ220E

Chip R, MCR10EZHJ473E Chip R,MCR10EZHJ394 Chip R, MCR10EZHJ334E Chip R, MCR10EZHJ184E Chip R, MCR10EZHJ224E Chip R, MCR10EZHJ562E Chip R, MCR10EZHJ562E Chip R.MCR10EZHJ823E

Chip R,MCRI0EZHJ564E Chip R, MCR10EZHJ102E Chip R, MCRI0EZHJ472E

Chip R, MCR10EZHJ102E Chip R, MCRI0EZHJ564E Chip R. MCRIQEZHJ101E Chip R, MCRI0EZHJ222E Chip R, MCRI0EZHJ472E

Chip R.MCR10EZHJ103E Chip R, MCR10EZHJ103E R23 Chip R, MCR10EZHJ472E Chip R, MCRI0EZHJ472E Chip R, MCR10EZHJ101E Chip R.MCR10EZHJ391E Chip R, MCR10EZHJ391E Chip R, MCR10EZHJ103E Chip R, MCRI0EZHJ103E Chip R,MCR10EZHJ103E Chip R,MCR10EZHJ103E Chip R.MCRI0EZHJ472E Chip R,MCR10EZHJ104E Chip R, MCRI0EZHJ103E

Chip R, MCRIOEZHJ100E Chip R, MCR10EZHJ104E Chip R. MCR1OEZHJ104E

Chip R, MCR10EZHJ000E Ch ip R,MCRI0EZHJ183

FAR. C4CA04194000K01

Chip L , LER105T1R5M Chip L . LERI05T1R5M

IC,uPD 75108GFR78-3BE IC. S-8054ALR-LN

IC, MC7808CT

Ref.

Pari Code

No.

IC5

XA0068

IC6

XA0120

XA0087 IC8 XA0087 IC9

XA0115

IC10

XA0115

XT0037

Q1 Q2 XT0037

XT0037

XU0015

Q5 XU0015

Q6 XU0014

XU 0012

XT0091

XII0019

Q10

XU0014

IC,M5218FP-T01-1

IC.M51132L IC,TC4S01F IC,TC4S01F IC, TC4S66F IC, TC4S66F

Trans isto r, 2SC2412KR T rans is tor, 2SC2412KR

Transistor, 2SC2412KR U H F V C O U n it

D igital Trans is to r,

Trans istor, 2SB1412QF5T200 C18 D igital T ra nsistor, C19

D igital T ra nsistor,

V O L U n i t

RV0016

VR1

RV0016 VR, RK0972210L2550KB X 2

VR2

VR, RK0972210L2550KBX 2

V H F V C O U n i t

C10 CU8016

C11

CU 80 28

C12

CU0059 Chip C.C2012CH1H1R5C

C13

CU0051 Chip C, C2012CH1H471K

C14

CU8028

C15 CU0059

C16

CU0064

C17

CU8016

C18

CU8016

C19

CS0063 CU8028

C20 C21 CU8028 C23

CU0059

C24 CU0064

CU8028

C25 C26 CU0071 C27 CU0066 C30 CE0033

CE 0033

C31

UE0076 Pin Header, SB4P'HVQ-CA

CN3D

UE0097 Pin Header, SB3P-HVG-CA

CN36

XU0012

XE0010

XT0081

XE0010

XT 0081

XU0012

Q10

XD0077

QA0067

QC0110

QC0104

QC0110

QA0067

L10

RK0048

R16 RI7 RK0018 R18 RK0021

RK0028

R19

RK0045

R20

R21 RK0028

RK0039

R22

Chip C, C2012B1H102K Chip C, C2012B1H103K

Chip C, C2012B1H103K Chip C, C2012CH1H1R5C L3 QC0101 Chip C. C2012CH1H220J L4 QK0086 C o il, 0R5-2R2-3R5TRS Chip C. C2012B1H102K Chip C.C2012B1H102K Chip Tantal. TWC1V104 Chip C. C2012B1H103K Chip C,C2012B1Hl03K Chip C.C2012CH1H1R5C Chip C. C2012CH1H220J Chip C. C2012B1H103K Chip C, C2012CH1Hl 01J Chip C, C2012CH1H330J Chemical C, 10MV10UWA R21 Chemical C. 10MV10UWA

D igital Trans is to r,

FET, 2SK508K52T1 Transistor, 2SC2714Y FET,2SK508K52T1 Transistor, 2SC2714Y D igital T ra nsis to r,

Va ricap, 1SV161

Va ricap, ISV161

Coil. 100M0SC-2

Chip L. LER015T4R7K Chip !_, LER015T1R5M Chip L, LER015T1R5M Chip L, LER015T4R7K Coil, 100M0SC-2

Chip R, MCRI0EZHJ682E Chip R, MCR1OEZHJ101E

Chip R.MCR10EZHJ181E Chip R, MCRI0EZHJ471E Chip R. MCRI0EZHJ472E Chip R, MCR 10EZHJ471E Chip R, MCR10EZHJ222E

Pari Name and Number

DTC144TK

DTC144EK

DTC114EK

DTA114YK

DTC144EKT146

DTC114EK

Ref.

Pan Code

No.

R23 RK0018 R24 RK0018

RK0018

R25 R26 RK0045 R27 RK0028 Chip R, MCRI0EZHJ471E R28 RK0039 R29 RK0Ö21 R32 RK0039

C10

CU8016 C11 CU0003 C12

CU0064 C13

CU8016 Chip C,C2012B1H102K C14

CU0010 CI 5 CU8016 C16

CS0063 C17

CU0060 Chip C.C2012CH1H470J

CU0005 Chip C. C2012CH1H040C

CU0061 Chip C.C2012CH1H120J C20 CU0001

CU0009

C21

CU0006

C22 C23 CU0006 Chip C.C2012CH1H050C

C28 CE0033 Chip C. C201210MV10UMA

CN56 UE0097 CH5C

UE0076 P in Header,SB4P-HVQ-CA

Q5 XE0002 Q6 XT0030

XD0100 D5 XD0077

XD0077

QC0099 Chip L, LER015TR56M

L5 L6 QC0062 Chip L, NL322522T-039M

QC0096

L7 L8

QC0101

RK0056

R16 R17 RK0065 Chip R,MCRI0EZHJ683E

RK0018

R18

RK0028

R19

RK0052

R20

RK0018 Chip R, MCR1OEZHJi 01E RK0044

R22

RK0013 Chip R, MCRI0EZHJ560E

RK0107 Chip R, MCR10EZHJ000E

R26

RK0018 Chip R, MCRIOEZHJ101E

R29

Part Name and Number

Chip R. MCRI0EZHJ101E Chip R, MCR10EZHJ101E Chip R, MCR1OEZHJ101E Chip R, MCRI0EZHJ472E

Chip R, MCRI0EZHJ222E Chip R. MCRIOEZHJ181E Chip R, MCR10EZHJ222E

Chip C,C2012B1H102K Chip C.C2012CH1H020C Chip C,C20I2CH1H220J

Chip C, C2012CH1H090D Chip C.C2012B1H102K Chip Tan ta l, TMC1V104

Chip C, C2012CH1H0R5C

Chip C.C2012CH1H080D Chip C. C2012CH1H050C

Pin Header. SB3P-HVQ-CA

FET, 2SK125 Transistor, 2SC3356BR25

Va ricap , 1SV164 Va ricap , 1SV161

Varicap, 1SV161

Chip L, LER015TR82M

Chip L,LER015TR33M Chip L. LER015TR82M

Chip R, MCR10EZHJ223

Chip R,MCR10EZHJ101E Ch ip R,MCR10EZHJ471

Chip R, MCRIOEZHJ103E

Chip R, MCR10EZHJ392E

VHF P L L Unit

CS0221

CS0063 Chip T antal, TWC1VI04 C3 CU0071 C4

CU8016 Chip C.C2012B1H102K C5 CS0061

C6 CS0057 C8

cuoon Chip C.C2012CH1H100D

CU8016

C28

CU0071

C29

RK0052

RK0018 R6 RK0018 R7

RK0035

RK0107

RK0045

R9 R10

RK0018 R11 RK0107 Chip R, MCR10EZHJ000E R12

RK0056 R13

RK0052

Chip T antal. TMC-MIC475

Chip C. C2012CH1H101J

Chip T antal, TMC1V224 Chip Ta ntal, TMC0J225

Chip C,C2012B1H102K Chip C, C2012CH1H101J Chip C, C2012CH1Hl01J

Chip R, MCR10EZHJ103E Chip R, MCR10EZHJ103E

Chip R, MCR10EZHJ103E Chip R, MCR1OEZHJ103E Chip R.MCR1 OEZHJ 101E Ch ip R,MCR1OEZHJ101 Chip R, MCR10EZHJ102E MCRI0EZH J000 Ch ip R,MCR10EZHJ472

Chip R, MCR10EZHJ101E

Chip R, MCR10EZHJ223E Chip R. MCR10EZHJ103E

- 7 -

Rel.

No.

RI 4 R15 R30 R31

CN37

IC1

Part Code

RK0056 RK0022 RK0035 RK0107

UE0117

»01 49

XT0038

XT0Q77

XU0017 ‘

XT0081

X00104

QC0108

Part Name and Number

Chip R, MCR10EZHJ223E Chip R.MCRI0EZHJ221E Chip R, MCR10EZHJ102E Chip R ,MCR10EZHJ000E

Pin Header, SB7P-HVQ-27

IC, MB15101LPF

Transistor, 2SAI037KR Tra nsistor , 2SC3326A O ig it a l Tr an sistor,

0TA144EK

Tra nsistor , 2SC2714Y

Diode, 02CZ6. 2Y

Chip L,LER015T3R3K

U H F P L L U n it

CI CU8016 C2

CS0057

CS0063

CS0221 R5 RK0018 R7 RK0107 R8 RK0045

CU8016 C25

CU80I6

C26

GUQ060 C27

CU0060

CN57

UE0117

XA0149 IC, MB!501LPFGBNOTF

ICI

XT0038

XT0077

Q2 Q3 XT0038

XT0081

XD0104

QC0062 Chip L . NL322522T-039M

RK0052 C hip R,MCR1OEZHJ103E

RK 0018

RK0052 Chip R ,MCR10EZHJ103E

RK0052 Chip R, MCR1OEZHJ103E

RK0039 Chip R, MCR10EZHJ222E

RK0035 Chip R.MCR1OEZHJ102E

RK0052 Chip R, MCR10EZHJ103E

RK0039

RK0052 Chip R,MCR1OEZHJ103E

R9 RIO RK0018 Chip R.MCR1OEZHJ101E

RK0I07

RU R12 RK0062 Chip R, MCR10EZHJ473E

RK0045 Chip R, MCR10EZHJ472E

R13 R14

RK0039 C hip R,MCR10EZHJ222E RK0045 Chip R.MCR10EZHJ472E

R15

R25 RK0022 Chip R,MCR10EZHJ221E R27

RK0018 C hip R, MCR10EZHJ101E

R28 RK0018 Chip R. MCR10EZHJ101E

RK 0107

R30

Chip C.C2012B1H102K

Chip Tan tal, TWC0J225 Chip T an ta l, TMC1VI04

Chip T antal, TMC MIC475

Chip R,MCR1OEZHJ101

MCR 10EZHJ000 Chip R,MCR10EZHJ472 Chip C ,C2012B1H102K

Chip C ,C2012B1H102K Ch ip C, C2012CH1H470J

Chip C ,C2012CH1H470J

Pin Header, SB7P HVC-27

Transistor, 2SA1037KR

Transistor, 2SC3326A Tra nsistor, 2SA1037KR

Transi sto r , 2SC2714YT E85L

Zenner, 02CZ6. 2Y

Chip R. MCR 10EZHJ101E

Chip R.MCR10EZHJ222E

Ch ip R,MCR10EZHJ000E

Chip R, MCR10EZHJ000E

V H F A IR U n i t

C 1 CU8016 Chip C ,C2012B1H102K C 2 CU0007 Ch ip C ,C2012CH1H060D

C 3

CU0064

C 5 CU8016 Chip C ,C2012B1H102K

C 6

CU0072

C 7

CU8016 C 8 CU8016 C 9

CU8016

CLOOU Ch ip C.C2012CH1H100D

CIO C ll CU0060 C12 CU0060

CU0066

C13

Chip C,C2012CH1H220J

Chip C ,C2012CH1H240J Chip C.C2012B1H102K

Ch ip C.C2012B1H102K

Chip C.C2012B1H102K

Ch ip C.C2012CH1H470J Chip C.C2012CH1H470J Chip C,C2 012CH1H330J

Ref.

Part Code

No.

CU0011

C14

RK0039

R 1

RK0039

R 2

RK0048

R 3

RK0040

R 4

RK0106 Chip R ,MCR10EZHJ3R3

R 5

RK0022

R 6

RK0037 Chip R ,MCR10EZHJ152

R 7

RK0039

R 8

RK00L8 C hip R.MCRIOEZHJIOI

R 9

QC0057

L 1

QC0067 C hip L.NL322522T-R10M

L 2

QC0067 Chip L , NL322522T—R1 OM

L 3

QK0085

L 4

QK0085 C o il, 0R8-3R0-6R5TRM

L 5

QC0067 Chip L , NL322522T-R10M

L 6

XD0066

D 1

XD0066

D 2

Part Name and Number

Ch ip C ,C2012CH1H100D

Ch ip R ,MCR10EZHJ222 Ch ip R ,MCR10EZHJ222 Ch ip R ,MCR10EZHJ682 Ch ip R ,MCR10EZHJ272

Chip R ,MCR10EZHJ221

p R ,MCR10EZHJ222

p L , NL322522T—01 5M

Co i 1, 0R8-3R0-6R5TRM

Diod e, RLS135TE11

Diode, RLS135TE11

D 3 XD0112 Diod e, 1SV128TE85L

XT003Û

Q 1

XU0012 D i g ita l T r ansisto r,

Q 2

UE0118

CN3E

Trans is t o r,2SC3356T1BR25

DTC114EKT14

T erm ina l,SL2 .5 0-10

8 8 0 F R O N T U n i t

CU0006

C I C 2 CU0006 C 3 CU0005 C 4 CU0005 C 5 CU0004 C 6 CU0051

C 7 CU0051

C 8 CU0003 C 9 CU0003

CIO

CU0002

C ll

CU0003

C12

CU0011

C13

CÜ0004

C15

CU0051

C16

CU0064

C17

CU8016

CN5B UEO 118

XT0030

Q 1

XE0013

Q 2

XT0030

Q 3

XU0012

Q 4

L 6 QC0055

QC0055 NL322522T-010M

L 7

RK0048 Ch ip R ,MCR10EZHJ682

R 1

RK0035 Ch ip R, MCR1OEZHJ102

R 2 R 3 RK00I8

RK0018

R 4

RK0036

R 5

RK0045

R 6

RK0045 Ch

R 7

Ch P C,C2012CH1H050C Ch p C,C2012CH1H050C Ch P C ,C2012CH1H040C

P C,C2012CH1 H030C

Ch Ch P C,C2012CH1H030C

P C,C2012CH1H471K

P C.C2012CH1H471K

Ch Ch P C,C2012CH1H020C Ch P ' C, C2012CH1H020C Ch P C, C2012CH1 HO 1OC Ch P C ,C2012CH1H020C Ch P C , C2012CH1H090D

P C,C2012CH1H030C

P C, C2012CH1H471K

P C,C2012CH1H220J

Ch Ch

P C, C2012B! H102K

Ter m inal, SL2.50-10

T ransis to r,2SC3356T1BR25

FET, 3SK184STX

Trans i s tör, 2SC3356T1BR25 D i g ita l T rans isto r,

DTC114EKT14

NL322522T-010M

P R,MCR10EZHJ101

Ch P R, WCR1OEZHJ101 Chip R ,MCR10EZHJ122 Ch ip R.MCR10EZHJ472

P R,MCR10EZHJ472

R 8 RK0039 Ch ip R ,MCR10EZHJ222

RK0028 Chip R, MCR10EZHJ471

R 9 RIO RD0028 R20 R-02J 471

RK0I07 Chi P R ,MCR10EZHJOOO

RI 1

■CABINET PARTS LOCATION

Réf.

No.

Part Code

Part Name and Number

S c r e w s

AF0014 AA0031 AJ0017

AP0006

AN0012

AP0006

M2. 6 X 3. 5 M2.6 X5 M2. 6 X 6 M3 X8

M3 X8 M2. 6 X 6 M2. 6 X 16

M3 X2 5

Nut M7

(Supp lied w ith

Ro tary Encoder Only) Nut M2. 6 M2X 6

M e c h a n i c a l P a r t s

NK0023

.NK0022

*■41110006

ND0009

ND0011

N DO 012

FF0013 SP Sheet

ST0009

FB0002 Cord Bush

UE0122A

UA0002 DC Power Cable UR0002

SH0044

SS0047 Main Chassis o

KM0130

KB0037 B uttom Panel

NP0062 Power Bu tton KM0131

DG0010 Encoder Lig ht

TS0035 KU0079 Upper Case

KS0035 Lower Case

D ial Knob (LG)

Volume Knob(G)

Sq uelch Knob(G)

D ial Rubber (L) Volume Rubber Sq uelch Rubber

SP M etal Crasp

MR M Antenna Cord DR599VHF

Rotary Encoder

IC F ix in g Metal

Front Panel (DR599T) ¡T' f >■&

Front Panel(DR599E)

Shield Lid

ES0007 S peaker VS-57-0814 1.5W

DP0059

TZ0034

TL0004

ET0001 Fan Moter

UL0009

ST0024 ST0025

TZ0033 FM0061

FP0044

Tran sp aren t Panel

In s u lat e Sheet Shield Film

Therm al Relay Fan Cover Therm al R elayfix Voliroe Shield LCD Shield

Code Band

■7 lc D

i >0 "

,Q\V

■ ADJUSTMENT

1. VHF Unit

ITEM

VCO VOLTAGE

BASIC FREQUENCY

POWER OUTPUT

DEVIATION

MIC GAIN

ADJUSTMENT POINT (S)

(D TC1

® VR2 (HI)

ADJUSTMENT METHOD

At 145.00MHz, adjust L3 so that the voltage of TP2 on B substrate is 3.0V. At 145.00MHz, pressing the PTT button, adjust L10 so that the voltage of TP2 on B substrate is 3.4V.

Pressing PTT button, adjust TC1 so that f-counter indicates 145.950 ±0.1 kHz (T) or 144.950 ±0.1 kHz (E) MHz.

On “HI” position, pressing the PTT button, adjust TC2 and TC3 so that the power is maximum at 145.95MHz (T) or 144.95MHz (E).

On “HI” position, turn VR2 for 45W output at 145.95MHz (T) or

144.95MHz (E). Verify the lightining of the entire RF meter. On “MID" position, turn VR3 for 10W output at 145.95MHz (T) or

144.95MHz (E).

On "LO" position, turn VR4 for 5W output at 145.95MHz (T) or

144.95MHz (E).

Enter the AF level of OdBm, then pressing the PTT button, adjust VR3 so that you obtain 4.8kHz/Dev at 145.95MHz (T) or 144.95MHz (E) and AF 1kHz.

Enter the AF level of -46dBm, then pressing the PTT button, adjust VR1 so that

you obtain 4.0kHz/Dev at 444.95MHz (T) or 434.95MHz (E) and AF 1 kHz.

SUBAUDIBLE TONE DEVIATION (DR-590T)

1750Hz TONE DEVIATION (DR-590E)

DESCRIMINATOR

SENSITIVITY

SQUELCH

S-METER

L3, 4, 8

Pressing the tone button at 145.95MHz, verify 0.6-0.8kHz/D ev at tone

frequency of 88.5Hz.

Pressing the tone button, verify that the tone frequency is 1750Hz and the deviation is 3.5kHz ± 0.2kHz.

At 146.03MHz (T) or 145.03MHz (E) and 60 dBjiz input, adjust L5, 6, 7 so that the distortion is minimum at 50mW.

Adjust L1, 2, 3, 4, 8 so that 12dB SINAD sensitivity is the highest at

146.03MHz (T) or 145.03MHz (E). At 146.03MHz (T) or 145.03MHz (E) and cut SG output. Adjust squelch

knob point by VR2.

At 145.03MHz (T) and 3-dBjiz [EMF], adjust VR1 so that 2 in the S-meter

begins to light.

VR2

115

rc2

|©||©|©|©

O lio Q l3

O l8 O TC3

VHF VCO

TP 2 O

Lcj

^ VR1 17

( Jvm VHF

OvR3R1

WVR3 MAIN

L60 o

i s r

2. UHF Unit

ITEM

VCO VOLTAGE

ADJUSTMENT POINT (S)

(VCO BOX)

POWER

OUTPUT

MIC GAIN

SUBAUDIBLE

TONE DEVIATION

(DR-590T)

1750Hz TONE

ADJUSTMENT METHOD

At 445.00MHz (T) or 435.00MHz (E), adjust L4 so that the voltage of TP2 on E substrate is 4.0V (T) or 3.2V (E).

On “HI” position, turn VR1 for 35W output at 444.95MHz (T) at

434.95MHz (E).

Verify the lighting of the entire RF meter.

On “MID” position, turn VR3 for 8W output at 444,95MHz (T) or

434.95MHz (E). On “LO” position, turn VR4 for 4W output at 444.95MHz (T) or

434.95MHz (E). Enter the AF level of OdBm, then pressing the PTT button, adjust VR2 so

that you obtain 4.8kHz/Dev at 444.95MHz (T) or 434.95MHz (E) and AF 1kHz.

so that you obtain 4.0kHz/Dev at 444.95MHz (T) or 434.95MHz (E) and AF 1kHz.

frequency of 88.5Hz. Adjust VR2.

the deviation is 3.5kHz ±0.2kHz. Adjust VR2.

HELICAL FILTER

DESCRIMINATOR

SQUELCH

S-METER

L1, L2

Connect the output of a tracking generator to the antena and spectrum analyzer to TP1 the adjust TC1, 2 and L1, 2 so that the sensitivity is at its peak between 440 and 450MHz at maximum gain. (570E : 430-440MHz)

At 445.03MHz (T) or 435.03MHz (E) and 60 dB,« input, adjust L3, L5 so that the distortion is minimum at 50mW.

At 445.03MHz (T) or 435.03MHz (E) and cut the SG output power. Adjust squelch knob point by VR1.

that 2 in the S-meter begins to light.

UHF PA

MAIN O O O

VR 5 VR4 V R3

\ J W/M L 3 TP1

L5 li“ “ 1

O VR 2

di VR1 n t?2

O O

O o

_____

UHF VCO

VR1

L1 O

iO Q TC1

TC 2

u Ld

+ 27 hidden pages