Volvo XC90 2009 Wiring Diagram
VOLVO XC90
WIRING DIAGRAM 2009
TP 39131202
Vehicles with SRS (Airbag)/SIPS bag/IC
(Inflatable Curtain)
Warning!
Extra caution must be exercised when working on vehicles equipped with SRS/SIPS bag/IC
in order to avoid:
1. Personal injuries when performing repair work.
2. Damage or malfunction of the SRS/SIPS bag/IC system.
Work involving the SRS/SIPS bag/IC systems or other components in the vehicle that may
affect the SRS/SIPS bag/IC systems must always be performed by an authorized Volvo
workshop.
In case of doubt, consult the SRS and SIPS bag/IC service manual.
Is the vehicle equipped with SRS/SIPS bag/IC?
Vehicles with SRS are most easily recognized by the letters SRS in the center of the steering
wheel. If the vehicle also has a passenger side airbag, the letters SRS are stamped on the
dashboard above the glove compartment. SRS vehicles from 1993 and onward also have
explosive seat belt tensioners. SIPS bags are only installed on SRS vehicles from 1995 and
onward. SIPS bag decals are located on the windshield and seat compartment. Vehicles with
IC can be recognized by the letters IC on the C/D panel (4 door) or the B panel (5 door).
General recommendations
• Be especially careful when working on or around SRS, SIPS, and IC components.
• Make sure that no wires are pinched, frayed, or pierced.
• Never install accessories by the sensors.
• Where applicable, work on the steering wheel, steering shaft, or steering gear must be done
in accordance with the methods in the SRS section of VIDA.
• Certain components of the aforementioned systems must be grounded while working. Read
the appropriate sections in VIDA.
• Install no accessories in the areas between the A and B-posts, the B and C-posts, and the C
and D-posts.
Test terminal
Data link connector in the passenger compartment.
Changes implemented up to and including May 2008.
Any changes made to the vehicles after this date are not included in the manual. If necessary
refer to service bulletins.
Volvo models are sold in versions adapted for different markets. These adaptations depend
on factors such as legal requirements, taxation, and market demands.
This manual may therefore include illustrations and text that do not apply to the vehicles in
your country.
Order number TP 39131202
Replaces previous publication 39131201 of Electronic Wiring Diagram Electronic Wiring
Diagram (EWD) which can be ordered from Technical Information Shop (TIS)
at www.volvocarstechinfo.ford.com/vss
We reserve the right to make modifications.
© Volvo Car Corporation
Table of Contents 1:3
Vehicles with SRS (Airbag)/SIPS bag/IC
(Inflatable Curtain) ......................................................... 2
Explanations .................................................................. 6
Abbreviations................................................................. 6
How to use the wiring diagrams 1:2............................... 7
Fuses
Engine compartment 11A/1-5 ....................................... 11
Engine compartment 11B/1-11 ..................................... 12
Engine compartment 11B/12-14................................... 13
Engine compartment 11B/15 ........................................14
Engine compartment 11B/16-21................................... 15
Passenger compartment 11C/1-4................................. 16
Passenger compartment 11C/5-7................................. 17
Passenger compartment 11C/8-10............................... 18
Passenger compartment 11C/11-14............................. 19
Passenger compartment 11O/1-2.................................20
Cargo compartment 11E/1-7 ........................................ 21
Cargo compartment 11L/1............................................22
Cargo compartment 11O/6-12......................................23
Central electronic module (CEM) F1-F11..................... 24
Central electronic module (CEM) F15-F34................... 25
Rear electronic module (REM) F1-F7........................... 26
Rear electronic module (REM) F8-F28......................... 27
Rear electronic module (REM) F29-F38....................... 28
Relays
Ignition switch and relays............................................. 29
Engine compartment FMA1 - FST3............................. 30
Cargo compartment..................................................... 31
Other relays ................................................................. 32
Ground connections
Overview...................................................................... 33
31/1 - 31/46 ................................................................. 34
31/47 - 31/72 ............................................................... 35
31/73 - 31/84 ............................................................... 36
31/88 - 31/93 ............................................................... 37
31/94 - 31/121 ............................................................. 38
Control modules
Overview of locations................................................... 39
Overview designations................................................. 40
Central Electronic Module (CEM) 1:2 .......................... 41
Rear Electronic Module (REM) 1:2 .............................. 43
Data communication High speed CAN ........................ 45
Data communication Low speed CAN ......................... 46
Data communication LIN 1:2........................................ 47
Data communication MOST......................................... 49
Group 23 Fuel system
Engine management system, Diesel 1:3 ..................... 50
Engine management system, 5-Cyl. Turbo 1:2............ 53
Engine management system, 6-Cyl. 1:2 ...................... 55
Engine management system, 8-Cyl. 1:2 ...................... 57
Emission control, 5-Cyl. Turbo..................................... 59
Emission control, 6-Cyl. ............................................... 60
Emission control, 8-Cyl. ............................................... 61
Group 26 Cooling system
Cooling fan, 5-Cyl. ....................................................... 62
Cooling fan, Diesel, 6-Cyl. & 8-Cyl............................... 63
Group 27 Engine control
Cruise control, 5-Cyl. ................................................... 64
Cruise control, Diesel, 6-Cyl. & 8-Cyl............................65
Group 32 Alternator and voltage regulator
Power supply ............................................................... 66
Group 33 Starting system
Starting system, 5-Cyl.................................................. 67
Starting system, Diesel, 6-Cyl. & 8-Cyl........................ 68
TP 39131202 XC90 2009 3
Table of Contents 2:3
Group 35 Lighting
High and low beam/(Bi-Xenon®) &
Daytime running lamps ............................................... 69
Active headlights (ABL) ............................................... 70
Fog lights ..................................................................... 71
Brake lights.................................................................. 72
Reversing lights ........................................................... 73
Follow-me-home lighting.............................................. 74
Running lights/ Parking lights, Tail lights &
License plate lighting ................................................... 75
Interior lighting ............................................................. 76
Beam length adjustment.............................................. 77
Auxiliary lights.............................................................. 78
Group 36 Additional electrical equipment
Rain sensor.................................................................. 79
Direction indicator and Hazard warning flashers ......... 80
Wiper/washer Windshield ............................................ 81
High pressure headlight washer .................................. 82
Wiper/washer Rear window......................................... 83
Horn ........................................................................ 84
Electronic immobilizer.................................................. 85
Anti-theft alarm ............................................................ 86
Parking assistance....................................................... 87
Alcohol lock.................................................................. 88
Accessory Electronic Module (AEM) 1:2 ..................... 89
Group 37 Wiring and fuses
Diagnostics system...................................................... 91
12V outlet .................................................................... 92
Tow hitch cable harness, 4/7-pin ................................. 93
Tow hitch cable harness, 7-pin .................................... 94
Tow hitch cable harness, 13-pin ................................. 95
Accessory USB unit (AUU) .......................................... 96
Group 38 Instruments
Seat belt reminder ....................................................... 97
Driver information module, 5-Cyl. ................................ 98
Driver information module Diesel................................. 99
Driver information module, 6-Cyl. .............................. 100
Driver information module, 8-Cyl. .............................. 101
Group 39 Other
Audio with external amplifier...................................... 102
Audio with internal amplifier ....................................... 103
Portable navigation system........................................ 104
Road Traffic Information module (RTI) ...................... 105
Satellite radio ............................................................. 106
Rear seat entertainment ............................................ 107
Rear seat entertainment, accessory .......................... 108
Infotainment ............................................................... 109
Rear seat entertainment, roof mounted ..................... 110
Parking camera.......................................................... 111
Parking camera & AEM.............................................. 112
Bluetooth handsfree, external amplifier ..................... 113
Bluetooth handsfree, internal amplifier ...................... 114
Bluetooth handsfree with AEM,
internal amplifier, LHD ............................................... 115
Bluetooth handsfree with AEM,
internal amplifier, RHD............................................... 116
Bluetooth handsfree with AEM,
external amplifier, LHD .............................................. 117
Bluetooth handsfree with AEM,
external amplifier, RHD.............................................. 118
Group 43 Transmission
Automatic transmission AW51AWD........................... 119
Automatic transmission TF-80SC AWD 8-Cyl. .......... 120
Automatic transmission TF-80SC/TF-80SC AWD
6-Cyl. & Diesel ........................................................... 121
Geartronic AW51 AWD.............................................. 122
Shift lock AW51 & Manual ......................................... 123
Differential Electronic Module (DEM)......................... 124
TP 39131202 XC90 2009 4
Table of Contents 3:3
Group 59 Brake system
Brake control system ................................................. 125
Group 64 Steering
Electronic power steering .......................................... 126
Group 83 Doors and openings
Central locking........................................................... 127
Power windows.......................................................... 128
Power sunroof............................................................ 129
Group 84 Exterior decorative elements, etc.
Power exterior rearview mirrors................................. 130
Blind spot information system.................................... 131
Heated exterior rearview mirrors ............................... 132
Heated rear window................................................... 133
Group 85 Interior equipment
Power driver’s seat .................................................... 134
Power passenger seat ............................................... 135
Heated seats.............................................................. 136
Massage seats with ventilation.................................. 137
Heated seats second row of seats............................. 138
Group 87 Climate control system
Climate control system, 5-Cyl. 1:2............................. 139
Climate control system, Diesel, 6-Cyl. & 8-Cyl. 1:2 ... 141
Climate control system rear....................................... 143
Parking heater, auxiliary heater ................................. 144
Relay, electric engine heater ..................................... 145
Group 88 Internal equipment
Remote garage door opener...................................... 146
Supplemental Restraint System (SRS)...................... 147
Connectors................................................148
Branching points .....................................173
Cable harness routine in vehicle
Engine harness Gasoline 5-Cyl. ................................. 183
Engine harness Gasoline 6-Cyl. ................................. 184
Engine harness 8-Cyl..................................................185
Engine harness Diesel................................................186
Engine compartment harness LHD.............................187
Engine compartment harness RHD ............................188
Passenger compartment harness LHD....................... 189
Passenger compartment harness RHD ......................190
Cargo compartment harness ......................................191
Roof harness ..............................................................192
Tailgate harness .........................................................192
Door harness ..............................................................193
Executive harnesses...................................................194
Component illustrations ..........................195
Index 1:2 ....................................................248
List of components 1:7 ............................250
TP 39131202 XC90 2009 5
Explanations
Abbreviations
Groups
Group 23 = Fuel system
Group 26 = Cooling system
Group 27 = Engine controls
Group 32 = Alternator and voltage regulator
Group 33 = Starting system
Group 35 = Lighting
Group 36 = Additional electrical equipment
Group 37 = Wiring and fuses
Group 38 = Instruments
Group 39 = Other
Group 43 = Transmission
Group 59 = Brake system
Group 64 = Steering
Group 76 = Shock absorbers
Group 83 = Doors and openings
Group 84 = Exterior decorative elements, etc.
Group 85 = Interior equipment
Group 87 = Climate control system
Group 88 = Internal equipment
Ignition switch symbols
X = Accessories (audio position)
S = Powered upon insertion of key
15 = Contact remains connected during
start
15l = Contact is broken while starting
30 = Constant power from the battery
50 = Start
Countries/Markets
A = Austria
AUS = Australia
B = Belgium
CDN = Canada
CH = Switzerland
D = Germany
DK = Denmark
E= Spain
EU/OS = Markets outside USA and Canada
FIN = Finland
GB = Great Britain
ISR = Israel
J = Japan
KOR = Korea
N= Norway
NL = Netherlands
S = Sweden
USA = United States of America
WEU = Western Europe
Other
ABL = Active Bi-Xenon® Light
ACC = Accessories
Ag = Silver plated
Au = Gold plated
AUDIO = Audio system
AUTO = Automatic transmission
Bi-X = Bi-Xenon®
BLIS = Blind spot information system
CEM = Central Electronic Module
DIESEL = D5244 T4/T5/T6/T7
DRL = Daytime Running Lights
DSTC = Dynamic Stability Traction Control
ECC = Electronic climate control system
ECPS = Electronic power steering
EXC = Exclusive
EXT. D = Extended electrical distribution
HISPEED = High speed data bus
LH = Left-hand side
LHD = Left-hand drive
LOSPEED = Low speed data bus
MAN = Manual transmission
MCC = Manual Climate Control
PCL = Power Child Lock
PETROL = Gasoline
REM = Rear Electronic Module
RH = Right-hand side
RHD = Right-hand drive
RTI = Road Traffic Information
SRS = Airbag
T = Turbocharged engine
W/O = Without
5CYL = 5-cylinder engine
6CYL = 6-cylinder engine
8CYL = 8-cylinder engine
Colors
BL = Blue
BN = Brown
GN = Green
GR = Gray
NL = Natural
LBL = Light Blue
LGN = Light Green
OR = Orange
P= Pink
R= Red
SB = Black
VO = Violet
W= White
Y = Yellow
TP 39131202 XC90 2009 6
How to use the wiring diagrams 1:2
The descriptions below apply in general
to all wiring diagram manuals, although
not all sections are necessarily contained in this manual.
A. Component designation
Every component has a component designation that
consists of two parts.
The first part is a type number that describes the
type of component in question, for example 3/xx.
The second part of the designation is a serial number, e.g. x/2.
Together, this constitutes a component designation,
e.g. 3/2.
At the end of the manual is a list of components,
where, with the help of the component designation,
you can read off the name of the component, for
example, 3/2 = light switch.
List of type numbers
The list shows which type of component that respective type numbers refer to, for example, 3/x = switch,
6/x = electric motor, etc.
1 Battery
2Relay
3 Switch
4 Control module
5 Driver information module
6 Electric motor
7Sensor
8 Actuator
9 Heating element
10 Light
11 Fuse
15 Electrical distribution rail/box
16 Audio
17 Service/diagnostics
18 Contact reel
19 Meter
20 Ignition component/shunt
26 Converter
27 Optics
31 Ground connection
53 Branching point
54 Connector
B. Branching points
The wiring diagrams contain numbered junction
points, e.g. 53/352.
This manual contains a section with a list of branching points. This list shows all the components that
are connected to each branching point.
The location of the branching points is shown in the
"Cable harness routing in vehicle" section.
C. Connectors
Connectors provide a bridge between two cable harnesses and are described in the "Connectors" section.
D. Electrical distribution
Operation of the fuses and relays is shown in the
"Electrical distribution" section.
E. Data communication
Today’s cars are equipped with CAN, LIN & MOST
networks that transmit information. Connections to
these networks are not shown in their entirety on the
respective wiring diagram. Complete information on
Data communication can be found in the section
entitled "Control modules".
F. Abbreviations
A number of different abbreviations are used in the
manual. These are explained in the section "Abbreviations".
G. Component location
There is a section at the end of the manual in which
the appearance and location of components is
described in numerical order.
TP 39131202 XC90 2009 7
How to use the wiring diagrams 2:2
GN-W
AF EDCB
30+
1
1
11C/7
11C/6
2
2
R
3/254
SWM
LIN
7
4/70
UEM
3
VO-W
5
13
CAN
8
LIN
20
RSM
LIN
7/149
1
2
3
4
54/16
W
1
BN
2
VO-W
3
W-BL W
4
GN
BN
VO-W
53/505
R
21
54/13
1
R
11
R
List of symbols
= System voltage
= Ground connection via wiring
= Ground connection in
component/chassis
= Screened wire
= Junction point
= Twisted cable
= Electrical connection
= Variant
= CAN communication
4/56
D:11
CEM
D:58
CAN
D:34
D:49
LIN
W
C:31
D:50
D:35
54/13
14
BN
20
BL-W
BN
53/503
BN
= CAN high data signal (CAN H)
= CAN low data signal (CAN L)
= LIN communication
10/1-2
6/1
53/331
53/397
L
31/93
321
H
BN
4
SB
BN
BN
31/98
31/83
LIN
CAN
= LIN communication
= DIN cable, coaxial cable, etc.
= Data communication
= CAN communication
= MOST communication
= MOST communication
= Connection with distribution
box
= Further connection to...
G
1
= Connector between cable
harnesses
1
= Connector connected in
component
TP 39131202 XC90 2009 8
Electrical distribution 1:2
Overview
15/31
54/1C
1
1
11A/1
RR
2
1
11A/2
2
1
11A/3
2
R
1
11A/4
2
4/71:2
1
11A/5
2
A1 A1 A1
123
17/17
SB
R
R
DIESEL
1
11B/1
2
4/109:11
4/46B:27
4/46B:42
1
11B/2
2
Y-W
Y-W
1
2
5(87)2(85)
11B/3
R-W
3(30)1(86)
2/90
R
R-W
1
11B/4
2
FMA2
6 CYL
DIESEL
GN-Y
2
1
11B/5
2
1
3(30)1(86)
PETROL
2/32
FST1
R-W
1
11B/6
2
R
2
5(87)2(85)
4
Y-W
R-W
1
11B/7
2
DIESEL
1
FMA3
3(30)1(86)
3
8 CYL
4/46B:16 4/46B:51
GN-Y
2/91
1
PETROL
11B/8
2
R-W
2
R
R
Y
4/46
B:9
Y
1
11B/9
2
1
3(30)1(86)
2/35
BL-OR
6 CYL
R-SB
FST2
BL-OR
8 CYL
1
11B/10
2
2
5(87)2(85)
4
1
11B/11
2
GN-OR
BL-R
R
6CYL / 8CYL
1
FMA1
3(30)1(86)
3
4/46B:11
4/46B:10
4/46B:53
GN-Y
GN-OR
6 CYL
8 CYL
2/182
1
11B/12
2
BL-GN
BL-GN
2
BL-R
2/22
1
2
1
3(30)1(86)
11B/13
53/305
BL-R
2
5(87)2(85)
4
FST3
1
11B/14
2
1
3(30)1(86)
4(87a)
3
5
R
FMI2
1
11B/15
2
1
11B/16
2
BL-R
DIESEL
DIESEL
2/133
DIESEL
DIESEL
2
4
1
2
5(87)2(85)
11B/17
BL
GN-OR
GR
GN-GR
BL-R
1
3(30)1(86)
3
R-W
SB
GN-W
GN-R
BL-OR
Y
FMI1
4(87a)
5
1
11B/18
2
1
11B/19
2
4/46B:29
54/1B:6
4/56B:1
6/114:1
8/84:1
4/46B:32
54/1B:8
4/46B:44
6/104:1
54/146
11L/1
1
11B/20
2
R-W
1
R
2
1
11B/21
2
4/56C:3
6/1
6/1
A
1
R
B
DC FGE
5(87)2(85)
4
Y
Y
BL
4(87a) 5(87)2(85)
35
4
4(87a) 5(87)2(85)
35
4
4(87a)
35
GN-SB
GR-SB
GR
4/56C:25
53/331
4/56C:4
TP 39131202 XC90 2009 9
Electrical distribution 2:2
Overview
ABCDEF G
53/408
VO
VO
1 1
2 2
VO
VO
3/1
S
37506
11C/2
5
X
11C/3
3/157:1
4/9B:27/55
4
30
15
15 15I
1
11
1
11C/4
11C/5
222
R-SB
BL-R
8
BL-R
53/443
BL-R
BL-R
BL-R
Y
Y-W
1
11C/61111C/7
2 22
16/65:1
3/157:2
4/9B:28/56
11C/8
1
11C/91111C/10
2 22
4/56
C:13
D:16
C:14
D:15
F3, 5-10,
D:60
17-23,
31-32 ,34
D:8
F1-2, 1
13-16,
26-30, 33
D:35
D:50
CEM
CAN
LIN
R
R
R
R
R
R
1 1
11C/1111C/1
2 2
1
11C/1311C/12
11C/14
2
54/40C
12
53/403
R
53/415
R
DIESEL
8CYL
6/25
R
BL
R-W
BL-R
R
M
31
1
30
R
53/3009
8CYL
A:1
R
R
B+
ACM
G
LIN
RR
6/26
SB
31
4/58
BL
B:2
B:24
B:3
B:16
11E
E:A
1,
R
54/40D
E:B
R
2
1
67
2
245222322
R
R
R
R
1
R
1
2
R
A:29
C:14
C:13
A:13
K:1
REM
CAN
LIN
F1-38
F29
A:23
Y-R
31/53
1/1
-
12V
+
SB
TP 39131202 XC90 2009 10
Fuses
Engine compartment 11A/1-5
5
4
3
2
1
11A Fuses in the engine compartment
No. Fuse function via A
1 4/109 Glow plug control unit (GCU)
20/22-26 Glow plug
2 6/29 Cooling fan motor, Diesel 4/71 60
3- --
4- --
5- --
-
4/109
60
TP 39131202 XC90 2009 11
Fuses
Engine compartment 11B/1-11
9
8
7
13
21
17
16
12
20
11
15
19
10
14
18
11B Fuses in the engine compartment
No. Fuse function via A
1 4/16 Brake Control Module (BCM) - 30
2 4/16 Brake Control Module (BCM) - 30
3 6/104 High pressure headlight washer motor 2/182 35
4 6/35 Fuel pump, auxiliary heater
6/73 Coolant pump, auxiliary heater
9/30 Auxiliary heater
5 54/8 Connector, cable harness, auxiliary lights, 30-feed - 20
6 6/25 Starter motor 2/35 35
7 2/90 Relay, windshield wiper, low/high speed
2/91 Relay, intermittent wiping
6/1 Windshield wiper motor
8 4/83 Control module fuel pump
6/33 Fuel pump
9 4/28 Transmission Control Module (TCM), TF-80SC/TF-80SC AWD - 15
10 4/46 Engine Control Module (ECM), Diesel
20/3-8 Spark plug and ignition coil, not 8-Cyl.
20/14 Condenser, ignition coils, 8-Cyl.
20/46-53 Spark plug with ignition coil, 8-Cyl.
11 6/44 Cooling fan, electrics box, engine compartment
7/51 Accelerator pedal sensor
8/3 Electromagnetic clutch, climate control system
6
5
4
3
2
1
4/7
4/7
4/7
2/91
-
2/90, 2/91
4/56
4/56
-
-
-
-
-
-
2/22
continues
25
25
15
20
10
TP 39131202 XC90 2009 12
Fuses
Engine compartment 11B/12-14
9
8
7
13
21
17
16
12
20
11
15
19
10
14
18
11B Fuses in the engine compartment
No. Fuse function via A
12 7/17 Mass air flow sensor (MAF), Diesel - 5
4/46 Engine Control Module (ECM), Gasoline not 8-Cyl.
7/17 Mass air flow sensor (MAF), Gasoline not 8-Cyl.
8/6-11 Injection valves, Gasoline not 8-Cyl.
8/1468/153 Injection valves, 8-Cyl.
13 4/46 Engine Control Module (ECM), 8-Cyl.
6/120 Throttle body motor, 8-Cyl.
4/46 Engine Control Module (ECM), Diesel
6/118 Swirl throttle control motor, Diesel
6/120 Throttle body motor, Diesel
6/139 Upper actuating motor, intake manifold
6/140 Lower actuating motor, intake manifold
8/98 Fuel pressure control valve, Diesel
8/111 Fuel flow control valve
14 7/15 Heated oxygen sensor, Diesel - 10
7/15 Heated oxygen sensor
7/82 Heated oxygen sensor, diagnosis 1
7/103 Heated oxygen sensor 3
7/15 Front heated oxygen sensor, bank 2, 8-Cyl.
7/82 Front heated oxygen sensor, bank 1, 8-Cyl.
7/103 Rear heated oxygen sensor, bank 2, 8-Cyl.
7/104 Rear heated oxygen sensor, bank 1, 8-Cyl.
6
5
4
3
2
1
-
-
-
-
-
4/46
4/46
4/46
-
4/46
4/46
-
-
-
-
-
-
-
continues
15
10
15
20
20
TP 39131202 XC90 2009 13
Fuses
Engine compartment 11B/15
9
8
7
13
21
17
16
12
20
11
15
19
10
14
18
11B Fuses in the engine compartment
No. Fuse function via A
15 6/67 Pump, fuel leakage control
8/18 EVAP valve
8/19 Solenoid, variable valve timing, intake
8/28 Turbocharger control valve
8/81 Solenoid, variable valve timing outlet
9/32 PTC resistor, crankcase ventilation
8/125 Variable valve lifter, front plane, 6-Cyl.
8/126 Variable valve lifter, rear plane, 6-Cyl.
4/46 Engine Control Module (ECM), 8-Cyl.
6/67 Pump, fuel leakage control, 8-Cyl.
7/17 Mass air flow sensor (MAF), 8-Cyl.
8/3 Electromagnetic clutch, climate control system, 8-Cyl.
8/18 EVAP valve, 8-Cyl.
8/19 Solenoid, variable valve timing, intake, bank 2, 8-Cyl.
8/81 Solenoid, variable valve timing, exhaust, bank 2, 8-Cyl.
8/107 Valve, variable intake, 8-Cyl.
8/117 Solenoid, variable valve timing, intake, bank 1, 8-Cyl.
8/118 Solenoid, variable valve timing, exhaust, bank 1, 8-Cyl.
4/109 Glow plug control unit (GCU)
6/143 Turbo control motor, Diesel
8/64 Solenoid valve, engine pad, Diesel
8/113 Bypass valve, EGR cooling, Diesel
8/120 EGR valve, Diesel
6
5
4
3
2
1
-
-
-
-
-
-
-
-
-
-
-
-
-
-
-
-
-
-
-
-
-
-
continues
10
15
TP 39131202 XC90 2009 14
Fuses
Engine compartment 11B/16-21
9
8
7
13
21
17
16
12
20
11
15
19
10
14
18
11B Fuses in the engine compartment
No. Fuse function via A
16 10/1 Left front lamp housing, daytime running lights
10/70 Low beam, left
17 10/2 Right front lamp housing, daytime running lights
10/66 Low beam, right
19 2/32 Main relay, engine management system
4/46 Engine Control Module (ECM)
20 10/11 Running/parking light, front left
10/12 Running/parking light, front right
10/71 Side running light, front left
10/73 Side running light, front right
21 6/114 Vacuum pump 2/133 20
6
5
4
3
2
1
4/56
4/56
4/56
4/56
-
-
4/56
4/56
4/56
4/56
20
20
5
15
TP 39131202 XC90 2009 15
Fuses
Passenger compartment 11C/1-4
1
2
3
4
5
6
7
8
12
13
9
10
14
15
11
11C Fuses in the passenger compartment
No. Fuse function via A
1 6/28 Motor, passenger compartment fan 4/31 30
2 16/105 Audio Module (AUD) - 30
3 4/52 Power Seat Module (PSM)
6/16 Motor driver’s seat, backrest angle
6/17 Motor driver’s seat, up/down front edge
6/18 Motor driver’s seat, up/down rear edge
6/19 Motor driver’s seat, fore/aft
4 6/20 Motor passenger seat, fore/aft
6/64 Motor passenger seat, backrest angle
6/65 Motor passenger seat, up/down front edge
6/66 Motor passenger seat, up/down rear edge
32
25
33
26
34
27
20
16
21
35
28
36
29
22
17
18
37
30
23
24
19
38
31
4/52
4/52
4/52
4/52
3/27
3/27
3/27
3/27
continues
25
25
TP 39131202 XC90 2009 16
Fuses
Passenger compartment 11C/5-7
1
2
3
4
5
6
7
8
12
13
9
10
14
15
11
11C Fuses in the passenger compartment
No. Fuse function via A
5 3/74 Left-hand front door lock unit
3/126 Driver/Passenger Door Module (DDM)/(PDM)
6/58 Motor, front left power window
6/62 Left power exterior rearview mirror
9/33 Left heated exterior rearview mirror
10/148 Left exterior rearview mirror lighting
6 3/75 Right-hand front door lock unit
3/127 Passenger/Driver Door Module (PDM)/(DDM)
6/60 Motor, front right power window
6/63 Right power exterior rearview mirror
9/34 Right heated exterior rearview mirror
10/149 Right exterior rearview mirror lighting
7- --
32
25
33
26
34
27
20
16
21
35
28
36
29
22
17
18
37
30
23
24
19
38
31
3/126
25
-
3/126
3/126
3/126
3/126
3/127
25
-
3/127
3/127
3/127
3/127
continues
TP 39131202 XC90 2009 17
Fuses
Passenger compartment 11C/8-10
1
2
3
4
5
6
7
8
12
13
9
10
14
15
11
11C Fuses in the passenger compartment
No. Fuse function via A
8 16/1 Integrated Audio Module (IAM)
16/109 DVD player/control module
9 4/124 Accessory USB unit (AUU)
16/46 Multimedia display
16/108 Multimedia Module (MMM)
16/109 DVD player/control module
16/139 Global Positioning System Module (GPS)
16/145 Remote Digital Audio Receiver (RDAR)
54/112 Connector, cable harness, infotainment, 30-feed
10 3/111 Light Switch Module (LSM)
3/254 Steering Wheel Module (SWM)
4/68 Steering Wheel Angle Sensor Module (SAS)
17/13 Data link connector
32
25
33
26
34
27
20
16
21
35
28
36
29
22
17
18
37
30
23
24
19
38
31
-
-
-
-
-
-
-
-
-
-
-
3/254
-
continues
15
10
5
TP 39131202 XC90 2009 18
Fuses
Passenger compartment 11C/11-14
1
2
3
4
5
6
7
8
12
13
9
10
14
15
11
11C Fuses in the passenger compartment
No. Fuse function via A
11 3/157 Switch, passenger side airbag
4/9 Supplemental Restraint System module (SRS)
4/28 Transmission Control Module (TCM)
4/46 Engine Control Module (ECM)
4/56 Central Electronic Module (CEM)
4/58 Rear Electronic Module (REM)
11O/1 Fuses in spare fuse holder, passenger compartment
11O/2 Fuses in spare fuse holder, passenger compartment
16/65 Antenna ring/ignition switch illumination
12 3/117 Switch unit, ceiling light
4/33 Sun Roof Module (SRM)
4/70 Upper Electronic Module (UEM)
4/76 Remote control unit for garage door opener
7/149 Rain Sensor Module (RSM)
10/114 Vanity mirror lighting, left
10/115 Vanity mirror lighting, right
10/150 Rear reading light
10/172 Reading light, third row of seats
13 4/70 Upper Electronic Module (UEM)
6/15 Sunroof motor
14 16/60 Phone Module (PHM) - 5
32
25
33
26
34
27
20
16
21
35
28
36
29
22
17
18
37
30
23
24
19
38
31
3/1
3/1
3/1, 4/56
3/1, 4/56
3/1
3/1
3/1
3/1
4/70
4/70
-
4/70
4/70
4/70
4/70
4/70
4/70
-
4/33
7.5
10
15
-
TP 39131202 XC90 2009 19
Fuses
Passenger compartment 11O/1-2
11O/1-2
11O/1-2 Fuses in spare fuse holder, passenger compartment
No. Fuse function via A
1 Alcohol lock
Alcohol lock
2 Alcohol lock -5
-
2/241
5
TP 39131202 XC90 2009 20
Fuses
Cargo compartment 11E/1-7
1
1E/7
1
1E/1
11E Fuses at battery
No. Fuse function via A
1 4/58 Rear Electronic Module (REM)
Main fuse for: F1-F38
3 11O/7 Fuse in spare fuse holder, cargo compartment
11O/8 Fuse in spare fuse holder, cargo compartment
11O/12 Fuse in spare fuse holder, cargo compartment
4 4/56 Central Electronic Module (CEM)
Main fuse for: F1-F2, F11, F13-F16, F26-F30, F33
5 4/56 Central Electronic Module (CEM)
Main fuse for: F3, F5-F10, F17-F23, F31-F32, F34
6 11C/1, 3-6 Fuses in passenger compartment fuse box - 50
7 11C/2, 9-14 Fuses in passenger compartment fuse box - 50
-
-
-
-
-
-
-
-
-
60
40
50
50
TP 39131202 XC90 2009 21
Fuses
Cargo compartment 11L/1
11L Fuse Diesel
No. Fuse function via A
1 11B/9 Fuses in engine compartment fuse box
11B/10-15 Fuses in engine compartment fuse box
-
2/32
50
TP 39131202 XC90 2009 22
Fuses
Cargo compartment 11O/6-12
5
4321
R1
R2
11O/611O/711O/811O/12
R3
6
11O Fuses in spare fuse holder in cargo compartment
No. Fuse function via A
6 2/196 Relay comfort system seats
3/64 Switch, heated rear seat, left
3/69 Switch, heated rear seat, right
7 9/14 Control module, rear left seat heater 2/84 15
8 9/15 Control module, rear right seat heater 2/85 15
12 4/131 Control module back massage left
4/133 Control back massage right
6/150 Ventilation fan seat place left seat
6/152 Ventilation fan seat place right seat
-
-
-
2/196
2/196
2/196
2/196
G032145
5
5
TP 39131202 XC90 2009 23
Fuses
Central electronic module (CEM) F1-F11
31 32 33
2
1
3
4
363534
17
18
6
5
19 20
31 32 33
7
8
21 22 23
9
10
24
12
11
25 26
13
15
16
14
28
29
27
30
4/56 Central Electronic Module (CEM)
No. Fuse function via A
F1 9/13 Seat Heating Module (SHM), right-hand - 15
F2 9/12 Seat Heating Module (SHM), left-hand - 15
F3 16/10 Horn 1 - 15
F5 4/120 Parking Assistance Camera module (PAC)
16/1 Integrated Audio Module (IAM)
16/16 LH window antenna amplifier 1
16/46 Multimedia display
16/94 Infotainment Control Module (ICM)
16/105 Audio Module (AUD)
16/108 Multimedia Module (MMM)
16/109 DVD player/control module
54/112 Connector, cable harness infotainment, extended D-feed
F8 16/35 Siren Control Module (SCM) - 5
F9 3/9 Contact brake light - 5
F10 3/112 Climate Control Module (CCM)
4/7 Combustion Preheater Module (CPM)
4/52 Power Seat Module (PSM)
5/1 Driver Information Module (DIM)
6/48 Damper Motor Module (DMM), recirculation
6/69 Damper Motor Module (DMM), ventilation/floor/defroster
6/95 Damper Motor Module (DMM), temperature, left-hand side
6/96 Damper Motor Module (DMM), temperature, right-hand side
6/102 Damper Motor Module (DMM), defroster
6/103 Damper Motor Module (DMM), floor/ventilation
7/93 Occupant Weight Sensor (OWS)
7/159 Air Quality Sensor (AQS)
F11 9/1 Outlet 12V front
9/25 Outlet 12V rear
continues
-
-
-
-
-
-
-
-
-
-
-
-
-
-
-
-
-
-
-
-
2
1
10
10
15
TP 39131202 XC90 2009 24
Fuses
Central electronic module (CEM) F15-F34
31 32 33
2
1
3
4
363534
17
18
5
19 20
7
6
21 22 23
8
9
10
24
12
11
25 26
13
15
16
14
28
29
27
30
4/56 Central Electronic Module (CEM)
No. Fuse function via A
F15 4/16 Brake Control Module (BCM) - 5
F16 4/99 Electronic power steering control module
4/118 Headlight Control Module (HCM)
6/38 Motor, left headlight adjustment
6/39 Motor, right headlight adjustment
10/1 Left front lamp housing, Bi-Xenon®
10/2 Right front lamp housing, Bi-Xenon®
F17 10/5 Fog light, front left - 7.5
F18 10/6 Fog light, front right - 7.5
F20 6/113 Coolant pump, 8-Cyl. - 5
F21 3/156 Gear Selector Module (GSM)
4/28 Transmission Control Module (TCM)
8/36 Solenoid shift lock
8/134 Solenoid, reverse interlock, manual
F22 10/68 High beam, left - 10
F23 10/64 High beam, right - 10
F28 3/27 Switch unit, power passenger seat
16/109 DVD player/control module
F29 6/31 Feed pump, ejectors 4/58 7.5
F30 27/3 Left Camera Module (LCM)
27/4 Right Camera Module (RCM)
F33 2/133 Relay vacuum pump - 20
F34 6/127 Washer motor - 15
-
-
-
-
-
-
-
-
3/156
-
-5
-
-
10
10
5
TP 39131202 XC90 2009 25
Fuses
Rear electronic module (REM) F1-F7
4
5
3
21
9
6
1110 12
8
7
16
13 1514
27 28
4/58 Rear Electronic Module (REM)
No. Fuse function via A
F1 10/48 Reversing light, right
10/55 Reversing light, left
54/98 Connector, cable harness, rear seat entertainment, reverse gear
signal
F2 10/3 License plate lighting
10/19 Brake light extra
10/44 Tail light 1, right
10/46 Fog light, rear right
10/51 Tail light 1, left
10/53 Fog light, rear left
10/173 Cargo compartment lighting, tailgate
F3 4/78 Accessory Electronic Module (AEM)
4/106 Control module, remote parking heater start
F5 4/58 Rear Electronic Module (REM) - 10
F6 16/82 DVD player roof mounted
54/98 Connector, cable harness, rear seat entertainment, 30-feed
F7 17/39 13-pin outlet, tow hitch cable harness - 15
continues
29
31
3332 34 35
1817 19
20302221
26232425
37
36
38
3703456r
-
-
-
-
-
-
-
-
-
-
-
-
-
-
10
20
15
7.5
TP 39131202 XC90 2009 26
Fuses
Rear electronic module (REM) F8-F28
4
5
3
21
9
6
1110 12
8
7
16
13 1514
27 28
4/58 Rear Electronic Module (REM)
No. Fuse function via A
F8 17/19 12V outlet, cargo compartment - 15
F9 2/139 Deadlock relay, right-hand rear door
3/86 Power window switch, right rear door
6/93 Motor, rear right power window
F10 2/138 Deadlock relay, left-hand rear door
3/85 Power window switch, left rear door
6/92 Motor, rear left power window
F13 8/85 Thermostatic switch and fuel filter heating - 15
F14 6/76 Climate control system, rear - 15
F19 6/32 Rear window wiper motor - 15
F20 11O/6 Fuse in spare fuse holder, cargo compartment
17/38 7-pin outlet, tow hitch cable harness
17/39 13-pin outlet, tow hitch cable harness
F21 Spare -10
F23 4/82 Differential Electronic Module (DEM) - 7.5
F26 4/86 Parking Assistance Module (PAM) - 5
F27 Main fuse for F20, F21, F23, F24, F26 - 30
F28 3/76 Lock unit, left rear door
3/77 Lock unit, right rear door
3/78 Lock unit, tailgate
6/37 Lock motor, fuel filler flap
continues
29
31
3332 34 35
1817 19
20302221
26232425
37
36
38
3703456r
-
20
-
3/86
-
20
-
3/85
-
20
-
-
-
15
-
-
-
TP 39131202 XC90 2009 27
Fuses
Rear electronic module (REM) F29-F38
4
5
3
21
9
6
1110 12
8
7
16
13 1514
27 28
4/58 Rear Electronic Module (REM)
No. Fuse function via A
F29 4/110 Trailer Module
- running light
- left-hand direction indicator
26/4 Converter, direction indicators & brake lights, USA
- running light
- left-hand direction indicator
F30 4/110 Trailer Module
- brake lights
- fog lights
- right-hand direction indicator
F31 Main fuse for F37-F38 - 40
F37 9/2 Heated rear window - 20
F38 9/2 Heated rear window - 20
29
31
3332 34 35
1817 19
20302221
26232425
37
36
38
3703456r
-
-
-
-
-
-
-
-
-
-
25
25
TP 39131202 XC90 2009 28
Relays
Ignition switch and relays
1423
15 15 30
S
15IX50
Position
Key Out
0
I
II
III
30
X
X
X
X
X
Terminal
15
XXXX
X
X
X
X
15I
S1550
X
XX
XX
Term.
1
2
3
4
5
6
7
8
587 6
Color
BL-R
-
Y
R-SB
VO
Y-W
BL
Relays, general
The diagram indicates two or three different designations for the relay’s position. This
is described below.
ABC
2
1(86)
2(85)
5(87)
4
1
3(30)
4(87a)
5
3
A = Corresponds to the position on the back
of the relay box (wiring side)
B = Corresponds to the position on the relay
C = An old designation that may be found on
the relay
TP 39131202 XC90 2009 29
Relays
Engine compartment FMA1 - FST3
FST3
FMA3
FMA2 FST2
FST1FMA1
FMI1
FMI2
Relays in the engine compartment
Pos Relay function
FMA1 2/35 Relay, starter motor
FMA3 2/32 Main relay, engine management system
FMI1 2/133 Relay vacuum pump
FMI2 2/22 Relay, climate control system
FST1 2/90 Relay, windshield wiper, low/high speed
FST2 2/91 Relay, intermittent wiping
FST3 2/182 Relay, high pressure headlight washer motor
TP 39131202 XC90 2009 30
Loading...