Volkswagen T3 other 1983 User Manual

www.WestfaliaT3.info - a useful website for owners and enthusiasts of VW Westfalia T25 / T3 / Vanagon Campervans

NOTESTO Ov'TNER

www.WestfaliaT3.info - a useful website for owners and enthusiasts of VW Westfalia T25 / T3 / Vanagon Campervans

t

i

Your new Volkswagen

is

the result of

research and sophisticated

vehicle and

driving

your

with

Your

Owner's

contains a

Bead it before

particular

Pay

period

hints" and to all

"Vehicle

Acquaint

features safely. The more Volkswagen, ving it. Foryourown

service

structions

could result

serious

endurance

product

designed for

pleasure,

safety

host

you

attention

operation".

yourself

and know howto operate

the

your

life

of

and

in extensive damage or

personal

years

many

maximum efficiency

a

in mind.

Manual

useful

of

drive

with

you

more

protection

vehicle, heed

warnings. lgnoring

injury.

of technical

testing.

engineering, a

of

vehicle

your

points

know about

you

designed

information.

new vehicle.

"Break-in

to the

listed

your

vehicle's

will enjoy dri-

and longer

lt is a

under

it more

your

in-

our

them

Warranty & Maintenarice

Your

booklet

you

explains

wagen seruiced

ranty &

when

for service. cord

The Warranty &

contains

warranties covering ranties

how

in

top driving regularly.

Maintenance

you

take

each service.

detailed

are:

I Warranty

Vehicles

I Warranty

Vehicle

and Canada)

Emission Control

I Emissions

(USA

only)

I

California

Warranty

you

lf

the Owner's

Maintenance

vehicle to

maintenance next owner.

(California,

your

sell

make all operating, safety

can

Always

yourvehicle

Your

Service

Maintenance

information

for New Volkswagen

for New

Performance

Emission

VW

Manual and

record should be

information available to the

your

keep

condition

by having it

have the War-

booklet

to aVW dealer

Adviser will

booklet also

your

VW. These war-

Volkswagen

System

Warranty

Control System

USA only)

the Warranty

Volks-

you

with

re-

about the

(USA

left in the

and

you

lf

change

boughtthis

to

sure

be

Change"/"Notice

post

card.

Warranty &

the

obtained

your

in

It is

contact

you

ln Canada,

in French. dealer or write to:

Au Canada on

exemplaire de ce

auprds du concessionnaire ou du: Volkswagen

Customer Assistance/

Assistance d la

1940 Eglinton Ave. East

Scarbolough, Ontario

&

your

VW used

in a

send

Used Car

of

This card can

Maintenance

your

own

should

VW dealer.

interest

the need ariss

from

this manual

To

obtain

a copy, contact

peut

Manuel

Canada

Clientele

address

"Notice

lnc.

of

Purcfiase-

be

that we ca

is

also

procurer

se

en

M1L 2M2

il1c

c

Affess

found inn

boold€i oilr

avaiffi

yrann

lrtll

francib

ra

www.WestfaliaT3.info - a useful website for owners and enthusiasts of VW Westfalia T25 / T3 / Vanagon Campervans

'9

"'a5

Abo{rt

Your

equipment

Therefore,

equipment Check

dealer

sories.

this Manual

vehicle may have all

described in this

you

may find explanations of

not

installed in

your

with

authorized Volkswagen

or some

your

vehicle.

manual.

on available options or acces-

of the

Text, illustrations and specifications

manual

this

available

are based on

at the time of

It has always been Volkswagen's

to continuously

VolKswagen,'therefore, to make changes tions, and to

ments in

any obligation to

previously Please note that the items of equipment

marked

on certain as options on other models.

its

with an

improve its

in

design and specifica-

make

additions or

product,

installthem

manufactured.

asterisk*

models

but are only available

information

printing.

policy

products.

reserues the right

improve-

without incurring

products

on

may

be standard

Operating

Government

States

biles

and safety standards.

buifi vehicles sold

you plan

lf

the continental

in

or

Canada,

I

unleaded'fuels

lytic converter

your

and Canada

meet specific

for the U.S.

to take

there

I fuel may

octane

engine

I

selfuel

I service

of

testing equipment;

rating.

damage;

Diesel fuel or the correct

may

may be inadequate due

proper

I replacement

available.

Volkswagen cannot be

the mechanical damage

because of parts

availability.

vehicle outside

regulations

and Canada

in other countries.

limits

is

for vehicles with

may not

have

a considerably

lmproper fuel may cause

not

be available;

service

parts

inadequate fuel, service or

in

require

emission

your

the

that automo-

Therefore

vehicle outside

the

of

United

possibility

available;

be

grade

facilities, tools or

may not be readily

responsible for

that

the U.SA or

the United

regulations

vehicles

from

differ

States

that

cata-

lower

Die-

of

to lack

result

could

Canada

Certain

for delivery

delivery

For details

write to:

U.SA.

Ganada

lf

want to bring it back

out

quirements,

customs

Volkswagen

in Europe under

return shipment

and

consult

Volkswagen of

Tourist

818

Englewood Cliffs,

Volkswagen

Tourist

1940

Scarborough,

SM2

you

bought

Delivery

Sylvan

Delivery

Eglinton

your

about shipping and

well as current

as

regulations

models are

your

America

Avenue

Canada

Avenue

Ontario

vehicle

home, be sure

available

our

program.

VW dealer

N.J. 07632

lnc.

M 1 L

abroad and

fonrarding

import and

first.

tourist

or

lnc.

East

to find

re-

INSTRUMENT

www.WestfaliaT3.info - a useful website for owners and enthusiasts of VW Westfalia T25 / T3 / Vanagon Campervans

PANEL

910r1

13 14

15 16

17

l8

19

n 21 2223 2425

Ers-r??

page

www.WestfaliaT3.info - a useful website for owners and enthusiasts of VW Westfalia T25 / T3 / Vanagon Campervans

1-Airvents

2

Headlight switch and thumb wheel

-

for instrument illumination . . . . . .

3- Safetybeltandbrakewarninglights 4-

Speedometerwithtripodometer

S-Warning/indicatorlights....

6

-

7- Rearwindowdefoggerswitch

8-Emergencyflasherswitch

9

-

with

Clock

fuelgauge and water

temperaturegauge

.. ......32

For additional

switch

1O-Airvent

....35

.

. 32

.. . ... .28

.

.30

......27

....

30,31

......32

..-...35

11-Ashtray i..... ....42

12

Loudspeeker

-

grille

13

Fuses

-

14-Turnsignal/headlightdimmerswitchlever . . . . . . . .

15

Button for

-

1 6

Steering lock/ignition/starter

-

17

Temperature

-

18

Windshield wiper/washer

-

1

9

Secondary heat

-

20 - Cold start knob 21

-Climatecontrols

horn

operation

for

switch

exchanger switch

(Diesel

switch

auxiliary

heater*

lever

. ; . . . . .

engine only)

::i;

33

. . . . . . . 24

. . . .38

. . . .

34

. . . .

. . . 37

. . . . . . . 26

....36

22-Airvents.... ......35

23

Radio.

-

have a radio

(vehicles

with factory fitted radio)

instruction leaflet)

24-Cigarettelighter ....41

25-Glovecompartment

.where

applicable

.......42

E?5ZOI

www.WestfaliaT3.info - a useful website for owners and enthusiasts of VW Westfalia T25 / T3 / Vanagon Campervans

Your Volkswagen comes

I two keys A I two keys B

Key A can be

way.

Key A is

lock, the doors and the

partment

Key B

with a

Tag C

is

lockable gives

inserted into locks

for the

used

lid.

provided

glove

key number.

the

for vehicles

compartment.

rear luggage

with four

ignition/steering

keys:

either

com-

equipped

your protection,against

For

I Record the

place,

safe

keep it in the vehicle.

you

I lf

VW

dealer

a duplicate

I Do not leave

with the

key and lock the doors. The

buzzer

driver's

lock. This is key and lock the doors.

key number and keep it in a

your

as

such

should

key in the ignition

door with the

lose a key,

with the key

key.

your

vehicle unattended

will

sound

your

reminder to remove the

theft:

wallet.

number to

when

key in the ignition

Do

provide

lock. Takethe

you

your

obtain

open the

not

DOORS

www.WestfaliaT3.info - a useful website for owners and enthusiasts of VW Westfalia T25 / T3 / Vanagon Campervans

Front

doors

To lock, unlock and open doors

the outside

Lock

I

turning the

I Open

ger

I The

without a

knob, then

and unlock

key

the

in the outer

doors by squeezing

passenger's

key.

close

I The driver's

from the outside with the key.

caution

driver's

the vehicle.

was taken

door while the key is

the front

to the right or

handle.

door

door can be locked

First depress the locking

the door.

can

door

prevent

to

doors

left.

the trig-

only be

This

locking the

still

from

by

locked

pre-

inside

To lock, unlock and open doors

the inside

To lock

I

knob. This will from inside and outside.

I To I To

handle after raising the locking knob.

doors depress

prevent

unlock doors raise

open doors

pull

the locking

opening the doors

the locking knob.

the inside door

from

the sliding

www.WestfaliaT3.info - a useful website for owners and enthusiasts of VW Westfalia T25 / T3 / Vanagon Campervans

lf

try, operate

back

door

not attempt

the door

chanism.

and

door

the

to its

to use

damage

not

does

handle

again

fully open

You could

force.

the

on finil

close

and

position.

sliding

Pd

Do

iam

me

Sliding

To open

I Unlock I Then

the door

the fully open

door

from

the door

press

the rear.

to

the outside

with

handle

the

position

The door

bY a

the

keY.

down

catch.

and sltde

is held

in

To close

Press the

I

catch.

closed.

You can

door

ing

To open

Move the

I

pull

the handle

and

Slide

only

from from

from

lock

handle

door

the

lock and

outside

the

inside

the

small

back.

the outside

down

forward

unlock

sliding

release

to

until

the

the key.

with

knob uP

the

it

slid'

and

is

To close

Pull the

I

close

catch,

knob down.

sliding

VANAGON

the

ln Delivery

area

Calgo

sure

Make

is loaded

area

obstructed

not transpoft

Do

lock

and

handle

the

Van

the cargo

operation

from

forward

and

door

Kombiand

correctly,

people

the inside

release

to

the small

move

VANAGON

compartment

of the

to

in the

permit

sliding

cargo area.

the

floor

un-

door.

REAR LID

www.WestfaliaT3.info - a useful website for owners and enthusiasts of VW Westfalia T25 / T3 / Vanagon Campervans

ENGINE COMPARTMENT LID

To unlock the rear lid,

I lnsert key into vertical

and turn to

Press lock

I

The

at any desired

I To

left.

cylinder in

hatchback

open

close, swing

height.

use the key

lock slot

and

will stay in

lid

down.

I Lock with key.

Be careful when loading

larEe

objects. Sharp edged articles may

damage

window.

For

locked at

Before taking Gar

as otherwise the bristles

brushes

the

defogger wires in the rear

safety

Wash, lock

reasons

all

times.

yourvehicleto

may

operate the lock

keep the rear lid

the rear lid with the key,

of

A.

position

lift lid.

position

or removing

an automatic

the washing

cylinder.

You have

ment lid from inside

partment. To

of the way and turn both lock handles to the

To

cedure.

access to the engine compart-

the luggage com-

the lid, roll

open

left.

close the lid, reverse the

the

floor

covering out

pro-

above

WINDOWS

www.WestfaliaT3.info - a useful website for owners and enthusiasts of VW Westfalia T25 / T3 / Vanagon Campervans

MIRRORS

rear.

the

to

mirrors

your

g

important

s

good

be-

seat

vision

Ventwindows"

I To

latch.

the

I To close,

seal and

Dgorwindows

Lower and

winders

*where

10

open,

turn

the door

in

apPlicable

press

latch

raise

button

vent

until

windows

the

Panels.

latch and

in

window

button

turn

against

engages.

with

the

Sliding

To open,

window

slide

windows"

press

locking

open.

knob down

and

Outside

The flat against

either

Inside

You can clear

lity

bottom daylight

night driving

mirrors

outside

direction.

day-night

adjust

daylight

night

at

of

driving

mirrors

the

by

the

are

vehicle

when

mirror

the day-night

moving

lever

-

lever

-

to

forward down

visibility mirror.

hinged

non-glare

the

and

struck

mirror

lever

fold

from

visibi-

at the

SEATS

www.WestfaliaT3.info - a useful website for owners and enthusiasts of VW Westfalia T25 / T3 / Vanagon Campervans

Seats in

driver's

cab

Vehicles

Seat adjustment (forward

The

vidually.

I Pull

of seat.

I

Slide

I

Let

back

securely

with

bucket

up lower

seat to

lever

and

forth

locked.

bucket

seats

lever

desired

go

to

can

and

make

(1)

move

seats

or backward)

be adjusted

at

outboard

position.

seat

sure tfre

sligthly

seat

indi-

side

i3

Seatback

The

backrest

forward

I To

backrest cover

I

tion rest in

Removing

adjust,

on right

Exert

desired

position.

accidentally.

slight

I Stand

and

slide

I Lift

stop

loading,

stop.

I

Release

ward

out

When

reinstalling

procedure. lifted

as the

the

stop.

adjustment

is

secured

take

push

and

side of body

and let

bucket

outside

seat all the

vehicle,

hook

hold

there

stop

hook

guide

of

seat, reverse

The

stop hook

seat

can

and

body weight

down lever

seat.

pressure

go

lever

seats

pull

way

forward.

(3)

up against

and

stide

and

rails.

(3)

just

be

cannot

(2)

in the

lock

to

up lever (1)

seai

slide

seat for-

the

need

pushed

off the

at hinge

direc-

back-

spring-

past

above

not

be

past

tilt

11

Vehicles

www.WestfaliaT3.info - a useful website for owners and enthusiasts of VW Westfalia T25 / T3 / Vanagon Campervans

ieat

The

cated

The

the

two

The

adjustment

Removing

First on

the

Then

the

wiffr

adiustment (fonrard

two

seater

in front

adjustment procedure

front

seater.

backrest

remove

backrest.

proceed

bucket

adjusts

lever

two

bolts from

seats.

of the

seater

as

two-seater

adjustment

seat.

seats

also

at

the

is

operated.

the

ouflined

or

baclovard)

lever

ouilined

applies

same

upper

for

removal

to

time

hinge

is

lo-

for

the

of

Vehicles

Before

I

Position

with

turning

shift

transmission)

transmission).

I

block

wheels

vehiclefrom

I

release parking

swivel

the

lever

or in

if

necessary

moving.

brdke.

seats

driver's

park

in

first

swivel

(automatic

geai

to

pro-

ent et seats

seat:

(manual

prcvent

The

to

the

The

right

The turn.

driver,s

passenger

(half

left

seat

(quarter

seats

will

seat

circte).

can

circle).

lock

automatically

can

be turned

slightly

Then

ofthe

gOoto

at

for-

push

seat.

1gf

the

every

12

Seats

www.WestfaliaT3.info - a useful website for owners and enthusiasts of VW Westfalia T25 / T3 / Vanagon Campervans

ln the

9-seater version

the backrest

row

can be

way

for easy

To

disengage

pull

up the lever

rest.

of the

tilted fonryard

access

the

compatment

first

to

lock

on the

(U.S.

model

seat in

and

the rear

of the

side of

only),

middle

the

out

of the

bench.

backrest,

the back-

Removing center Remove the four

rear

and

of seat bench, and take bench

seat

bolts

out of attachment rails.

To install the the above

Note:

Keep the

center seat bench,

procedure.

attachment

bench

from

rails

under

clean.

front

reverse

Removing The rear

bolt

on each

covering.

the seat.

bench

should

To install

procedure.

rear

seat bench

sidewall

Remove

The

the rear

both bolts and

baclsest

not

be

seat, reverse

is secured with

underneath the

poftion

removed.

passenger

in

one

seat

take out

the

of

the above

13

REAR

www.WestfaliaT3.info - a useful website for owners and enthusiasts of VW Westfalia T25 / T3 / Vanagon Campervans

SEAT/LUGGAGE COMPARTMENT HEAD

RESTRAINTS

You

can

ment load

of the rear seat bench down.

Folding

rear

Unlock the

driving

it

rests

The

when

Make

the

14

expand

surface by

backrest for

seat bench

backrest by

direction.

on seat cushion.

backrest will

returned

sure the lap belts remain

seat cushion, ready for

the luggage compart-

folding the backrest

pulling

Fold

backrest

locked

be

to its upright

strap

down until

automatically

position.

on top of

use.

When transporting

cargo, secure

such articles

sudden stop.

Be careful when

jects

through the rear

edged objects

ger

wires in the rear window.

Keep

the luggage compaftment

at all times to

access to the vehicle.

in

luggage

place

it in

from

shifting during a

removing large

may damage the defog-

prevent

or other

prevent

to

lid.

unauthorized

ob-

Sharp

locked

I For height adjustment

restraint with both

push

down.

hands and

grasp

pull

Er-:eil

head

up or

SAFETY

www.WestfaliaT3.info - a useful website for owners and enthusiasts of VW Westfalia T25 / T3 / Vanagon Campervans

BELTS

to

r':

d'

:

)

Combination

www.WestfaliaT3.info - a useful website for owners and enthusiasts of VW Westfalia T25 / T3 / Vanagon Campervans

Belt waming An audio-visual

connected

time the

Every

FASTEN

for about 6

on

for the duration

With the driver's

will

buckle

belt, the

safety

go

buckled

lnertia

up. lf the

reel retractor

lapshoulder

system

with the driver's

ignition

BELTS

seconds

driver does

buzzer

of

off as

soon

up.

The combination inertia reel

automatically ments as long

slow.

Rapid deceleration

a collision

when

lock hill

or

locking

to

as the

locks

you

in a sharp

drive up

warning

door

system

is turned

as

will also

this six

closed,

as the

lap-shoulder

mechanism

your

size and

pull

during

the belt.

The belt

or

curve.

belts

is inter-

belt.

safety

on,

will come

light

a reminder

not fasten

come

the

period.

buzzer

second

driver

belt

adjusts

move-

the belt

on

hard braking

will also

down a steep

the

to

the

on

has

with

is

or

To fasten,

I

in continuous

belt

your

chest

lnsert belt

I

side

board

is

securely

Pull belt to

Pull

I

beh

I

and

on

shoulder

fits snugly

Belts

should

chest.

the retractor.

grasp

laP.

and

tongue

the seat.

of

locked

check.

with an

section

across

fit snugly

Make sure

tongue

belt

motion across

slow

into buckle

Push

audible

to make sure

hiPs.

the

across

any slack

and

down

th6

is wound

pull

on

until

click.

pelvis

in-

it

not wear shoulder

I Do

your

or otherwise

arm

This wo-uld

serious

I

buckle.

To

the body

I

to wind tongue

injury

To unfasten

Belt will spring

release

pressure

To store

up on

to its stowed

increase

in case

belt,

a locked

belt,

off

lap-shoulder

retractor

position

paft

out

possibility

the

an accident.

of

push

in

of buckle.

out

lean back

the

belt.

belt,

you

as

on doorpost.

of belt under

position.

of

release on

to take

allow belt guide

belt

of

16

Lap

www.WestfaliaT3.info - a useful website for owners and enthusiasts of VW Westfalia T25 / T3 / Vanagon Campervans

belts

Seats in the equipped

The

belts

of the seat for ready

them

I To

right angle to

respective

direction. Adjusting tongue

Take the

belt.

passenger

with

adjustable

should

get

to

caught

adjust the

the belt tongue

belt

of buckle are

up any

slack by moving

always

under the

belt, hold

section in

compartment are

lap

belts.

be kept

u'se. Do

nbt

seat.

the belt at a

and

the desired

is

easier if

pressed

together.

the slide

top

on

permit

pull

the

cap and

on

I To fasten

on outboard

pelvis

and insert

I To

unfasten belt,

PRESS

ked

lap

side

in the buckle.

grasp

belt,

seat,

of

in

inboard buckle.

push

tongue

belt

pull

across

in release mar-

17

BRAKES

www.WestfaliaT3.info - a useful website for owners and enthusiasts of VW Westfalia T25 / T3 / Vanagon Campervans

Functioning

brake

One

wheels

vehicle

and

to

a safe

brake

of

circuit

other

the

operates

the

stop.

system

rear

front

the

wheels'

Brake

pedal

brake

oPeration

Brake

one

light

habit

a

it

brakes

liqht

and

details

warning

Make

.,^,,, hrakoq hcfore drivino. The

vour

i^,arnino lioht will lioht uo

ivaininq

is crank-ind

or one of t-he brake

or

more

and

to check

before

will

see

driving.

up

liqht

parking

the

circuits

"Brake warning

the

while

brake

should

operation

The

the

is

onpage27.

Keeo

incrbases creases. example,

lonoer

very

At

it

than

mind

in

Tiritraction

roads

the

always

fore,

that

rapidly

mPh

60

not

is

30

at

also

is

wet

are

maintain

braking

the

as

or

twice

mPh

less

and

safe

at

speed

the

km/h,

100

lour

but

50

at

or

effective

slippery'

distance.

distance

brake

engine

pulled

fail.

light"

times

km/h'

when

There-

of

For

infor

booster

brake

booster

18

brake

lf one

will still

an

on

experience,

full stop.

Avoid

towed

fied

operate.

increased

brake.

the

driving

to

workshoP.

circuit

However,

pedal

Should

your

bring

the

the nearest

failed,

has

travel

you

encounter

vehicle

dealer

\Ml

you

when

and

the

will

you

safely

have

or

other

notice

step

such

to

quali'

Brake

The

a

it

assists

braking

g.

When

engine

brake

to a

cle

only

the

is not pedal

stoP.

road salt

www.WestfaliaT3.info - a useful website for owners and enthusiasts of VW Westfalia T25 / T3 / Vanagon Campervans

Moisture brakes

WARNING

Driving

lraction.

road

Cautiously

Brakes cleaned

applications.

Brake

Our

but

ing

brake

or

affects

through water

Moisture

water,

may affect

salt

apply

will dry and

off after

wear

automobiles

they on

still subject

are

the brakes

how

system

recommended

Schedule.

pads

possible

during

150 to

pads

or

brake

New

Brake

highest

Therefore

new.

distance

miles or

on

braking

may reduce

on brakes

wash, or coating

car

braking

brakes

coating

sah

a few cautious

excellent

have

inspected

in

linings

braking

allow

the

250 kilometers.

wear, depend-

to

used.

are

at

Your

linings

or

may not

efficiency

for longer

initial 100

tire

from

of

efficiency.

test.

for a

will be

brake

brakes,

the

Have

intervals

the

Maintenance

the

have

when

braking

to 150

lever

Parking The

ween

I To set

ver

brake

I To

lever

button

the

fully released,

go

brake

parking brake

front seats.

the

parking

the

way up.

allthe

warning release

light

the

slightly

(airow),

way down.

out.

lever

brake,

With the

will light

parking

is located

pull

the

ignition on,

uP.

pull

brake,

he release

lever

the

ing brake

light

ing

bet-

le-

the

will

WARNING

I

Release

partially

the rear brakes,

ness

all

is

the

engaged

and cause

parking brake

will overheat

brake

reduce

excessive

their effective-

wear.

fully'

A

.19

Manual

www.WestfaliaT3.info - a useful website for owners and enthusiasts of VW Westfalia T25 / T3 / Vanagon Campervans

The

chronized

not

gears

shift

moving.

forward

arranged

Reverse Only

is

Transmission

the

in

and

illustrated.

as

Reverse

into

forwArd

reverse

the

when

is fully

syn-

gears. The

gear

are

vehicle

the

S-speeit

transm

To engage

beyonE then

To

bevond down,

ihe

pull

the

engage

the

and

ission*

gear,

first

spring

lever

Reverse, spring

pull

then

move

pressure

back.

move

pressure

lever

the

lever

point,

lever point'

fonrard.

to

and

to

press

let

left

4-speed

transmission

Gearshift

engine

Start tral, clutch

Resting

driving

while

in the transmission.

20

lever

pedal

your

gearshift lever

with

dePressed.

onthe

hand

willcause

s-speed

transmission

Neu-

in

knob

lever

shift

premature wear

seconds

Back-up

Reverse

before

lights

gear

shifting

go

with

into

when

on

ignition

Reverse.

you

on.

engage

-where

apPlicable

AUTOMATIC

www.WestfaliaT3.info - a useful website for owners and enthusiasts of VW Westfalia T25 / T3 / Vanagon Campervans

Ir

D

?D

Selector lever

P

Park

-

Engage Park

push

and

mission

Shift

releasing

it

is then

out of

the

through

the Park

parking

TRANSMISSION

positions

only when

mechanically

the vehicle

R to P.

position,

brake.

The

locked.

trans-

before

R

Reverse

-

Reverse position only

when

full

stop

idle

speed.

Before

reverse

push

button

lever.

N

Neutral

-

Shift

to this

brakes

Do

not

Coasting

in-

is

neutral

will

result

transmission.

D

Normaldriving

-

Position

driving.

and

all

dependi

the vehicle

and the

you

move

position

applied.

use neutralfor

downhill

and

in

the

you

in the

position

the

damage

engine

handle

with

engine not

should

be selected

has

come

is running

selector

have

coasting

position

lever

to

depress

of the

for

standing with

the trahsmission

to

the automatia

to

to the

the

selector

downhill.

operating

2

This

a

driving

at

want

effect. ln

eng_age

shift

speed is

not necessary

1

-

This driving

for

engage

button

Position

-

position

or

to make

"2",

only the first

down

Position

position

or

maximum

this

in

for

hilly

stretches

is to

driving,

use

position

to let

for

steep hills

is to

driving. lt

engine

gear

be used

of engine's

and second

mph

up

be used

depress

of the

slow

automatically.

into

below 54

slow

the handle

for mountain

braking

gears

vehicle

you

will

only

tt is

and also when

Therefore,

when

"2"

or 87 km/h.

on the accelerator.

for mountain

provides

also

braking

effect.

the

selector sion will shift. Only speed is

stay in

To

push

lever

shift

below

21

Driving

www.WestfaliaT3.info - a useful website for owners and enthusiasts of VW Westfalia T25 / T3 / Vanagon Campervans

the

automatic transmission

Observe

break-in-period

Starting

The

or Park.

positions

prevents

Emergency

Your

cannot

lf

discharged

started

"Emergency

Should

your

22

the

speed ranges lor

see

-

the

engine

selector lever must

VW

be

engine

with

the

nearest

As long

is

the

with Automatic Transmission

started by

does not

as one of the

engaged

engine from

starting

battery, the vehicle

jumper

starting with

engine fail to

VW

dealer.

page47.

the

be in Neutral

a safety

being started.

pushing

driving

switch

or towing.

start because

can be

cables. Refer

jumper

cables".

start consult

of to

Selecting a

driving

position

Maneuvering When alternating

reverse

ing

only

-

to a full

idle

Stuck in

When

reverse

depress

while

release

shifting. Do

for instance,

-

the vehicle into

shift

stop and the

speed.

snow, mud

alternating

in

an effort to free

the accelerator

the transmission

the

between forward

a tight

when

the vehicle

engine is running

between forward

accelerator

not race the

spinning the wheels.

while maneuver-

parking

has

space

come

or sand

the vehicle,

pedal

slightly

gear,

is in

pedal

engine

Do

and avoid

not

repeat

while

and

at

and

Stopping

www.WestfaliaT3.info - a useful website for owners and enthusiasts of VW Westfalia T25 / T3 / Vanagon Campervans

Kick-down

,wAnnttne

device

r.:r

':r:

;.,,1,

,,:.t.

,.::.

.,.:

::,

,:

:l

WARNING

l-Never

wften Iector

I

you

lf

me

sebctor

ing

brake.

Towing

lf

the

vehicle

you

must

section

get

the

lever

out

engine

is not

must

lever

has

leave

read

"Emergency

ions

vehicle

foot

i

the

p

to

be

the

instructions

towing,,

must

brakes

vehicle

and

towed

never

at rest

uphill.

when

seat

e se-

..:

r

move

apply park-

at

any

time,

in

the

p"g"

on

SS.

be

''.:

23

STEERING

www.WestfaliaT3.info - a useful website for owners and enthusiasts of VW Westfalia T25 / T3 / Vanagon Campervans

LOCK

/ IGNITION / STARTER SWITCH

The

steering

ignition lock.

is equipped

with

an antitheft

Switch

1

2

3

positions

lgnition offlsteering can be

-

Pull

wheel until it

lgnition on/steering

-

operation

lf

position steering

freely.

Starter engages.

-

Key released.

the key and turn steering

out

it is difficult

locks.

for Diesel engine.

to turn the key from

lo

2,

gently

1

wheel until the key turns

returns to

Pos. 2 as

freelglow

soon

"Starting procedures"

pages.

position

ln

headlights, windshield wipers, blower

motor and rear window temporarily interrupted to conserve

battery

3,

power.

the

power

defogger

locked.

move

as it is

see

supply

plug

the

key must be turned back

the The non-repeat

prevents

when engine

damage

ln dicator

"Warning/indicator lights" for

the starter.

position

lights will come on.

lock in the ignition switch

the starter

is running as this could

2

and 3 several

Buzer

you

lf

leave the key

lock, the buzzer

driver's

reminder

to

is

is opened.

door

to remove the

can

be operated

from

being operated

again

position

to

warning/in-

Refer to

details.

in the ignition/steering

will

sound

when the

This is

key.

1 .

your

24

Automatic

www.WestfaliaT3.info - a useful website for owners and enthusiasts of VW Westfalia T25 / T3 / Vanagon Campervans

fn-gine

rn

Neutral

Manual

Startwith

pedal

depressed,

has

to

crank

Starting

I Do

starting.

As

soon.as

tgnftton

Operate

0

seconds.

Allow

not

about

attempt.

wnen temperature.

I

rne

l_

1

I

starting

Transmission

will

only

start

or Park.

Transmission

gearshift

gasoline

the

lever

so

engine.

engine

depress

This

applies

the

key.

the

engine

starter

1

minute

with

selector

in

Neutral,

that

the

startbi

accelerator

at

any

stafts,

art

the

off

and

pedal

attempt.

for

no

more

between

clutch

oedal

outside

release

first

restart.

slowly

than

each

lever

only

time

Starting

page

Cold To

rs

a

This

ngntotthe

on

rne

Starting

I

Before

Temperatures

cold

temperatures, pulled

l"rly

better. I_

Switch

and

trgnt goes,

oepress

power.

28.

starting

facilitate

cold

start

device

steering

next page).

cold

start

handte

out

the

-

glow

start

engine

out.

the

Diesel

until

engine

aid

starting

device

is

operated

column (see

engine

starting

down

out

fuily.

the

handle

the

ensine

engine

witithen

ptugs

as

While

accelerator

operating

tf

engine

).

p

operating

longer

engine

with

a

glow

plug

lamp

which

t

temperature

a

cold

the

injection pump.

Ov

a

engine

_15"

to

At

tower'ouisiJJ

should

is

engine,

hanOr"

at

tirinq

in

usu;ily;i'art

on

key

soon

a-s

tne

slightly

sthris

starter

(maximum

runs

under

glow

warm-up

is

_

there

6n

illustration

outside

pull

C,

n;i

reoul

position

blow

oluo

startei

(about

to

for

own

plug

con-

see

ii"

the

b;

2

1/.

fird

a

30

25

STOPPING ENGINE

www.WestfaliaT3.info - a useful website for owners and enthusiasts of VW Westfalia T25 / T3 / Vanagon Campervans

I

30

and

I

operating

start handle Cpld weather

Planning

help

At

Diesel

wax

filter

from Therefore,

ized

temperatures.

26

lf engine

seconds,

start as

When

does not

switch

described.

engine has

temperature,

in.

staning

ahead

Fuel

running.

use

good

No. 2 loses strainer

fuel

assure

temperatures

separation,

or tank

Diesel

start,

glow

reached its

for

the cold

starting

below 20" F

which

may clog

and keep

Diesel fuel

No. 2,it

For

details

plugs

push

and

its

No. 1

you

see

wait

for on again

the cold

weather

driving.

(-7"

fluidity

the

orwinter-

expect

page

about

normal

will

C),

due

the fuel

engine

those

50.

Engine making

starting.

to

crank

Diesel

cranked

engine)

Change

viscosity

oil

page

to have

increase battery warmer

optimum

Starting

I Do I Do

starting.

I

The

can

to

gets

oil

i

engine,

fast

before it will

over to the

when

viscosity

56). You

an engine

engine cranking

pedormance.

warm

pull

not

depress

glow plug

start the

engine immediately.

thicker

as it

ank the

ttery has

when

however,

(faster

than

start.

proper

cold weather

chart for

may

engine

also want

block heater

to keep

engine

out

cold start handle.

accelerator

light will

not light

gets

engine

it is

needs

sets in

speed,

your

colder,

when

less

energy

cold. Your

to

gasoline

a

engine

oils

your

dealer

installed

and a

battery

while

up. You

be

oil

(see

on

Do not

hard

running

minutes

build-up.

to at

I

matically

certain

(even

temperature

Applies

I Turn

to all engines:

key back

or

The radiator

temperature

with ignition

to

prevent

to

fan

when the

drops.

position

1.

immediately

ving.

Keep

idle

for

excessive

switches coolant

and

continues

off) until

after

engine

about

two

heat

on auto-

reaches

to

the coolant

run

a

WARNING

www.WestfaliaT3.info - a useful website for owners and enthusiasts of VW Westfalia T25 / T3 / Vanagon Campervans

/ INDICATOR

LIGHTS

Your vehicle

impodant

monitorthe continued reliable operation

to

your

of

devices so if one should come on

lhese

you

know what to

warnings may

lhese

is

equipped with

indicator and warning

vehicle.

Familiarize

Failure to heed

do.

result in serious

several

devices

yourself

lamage.

with

1

Brake warning light

-

or mrit

t

The light

cranking.

comes on

goes

lt

started and the

released. This is brake warning light functions

lf the

while

handbrake, there may the electrical system. ln this case, contact your

brake

cranking

VW

dealer.

warning light

while the

engine

out after the engine parking

your

the

brake is fully

assurance

properly.

not light

does

engine or setting

be a malfunction in

that the

up

the

]

is

The

brake warning light

brake fluid level in the reservoir. Check

the fluid level

nance

servtces.

For

detailed information

page

1 8.

between regular

does

see

not indicate

mainte-

uBrakeso

on

2

Safety

-

lisht

Refer

details.

"Safety

to

belt

warning

belts" on

Rlt$ttn

page

15

litn

for

6

www.WestfaliaT3.info - a useful website for owners and enthusiasts of VW Westfalia T25 / T3 / Vanagon Campervans

Service

-

Thefollowing

rg_nttton

after

lf

your

take your

the ance

is

the

engine

the

lights

odometer.

scheduled

service.

turned

vehicle

reminder

lights

on

is

started.

come

on

The

to

emission

light"

willcome

and

should go

and

time

your

VW

control

on

stay

ha6

when

on,

read

come

dealer

mainten_

the out

to

for

5

6

-

Glow

8

plug

tight"

o0-

W-u4

Exhaust

recirculation

on

gas

every

light

15,000

ffii*

4

Alternator

-

warning

light

Oxygen

sensor

;il".

system

be

ln

contact

28

loose

this

or the

or

broken.

case,

your

V-belt

turn

VW

to

the

dealer.

the

alternator

engine

off

may

and

"where

"

light

on

every

applicable

30,000

mites

EGR

or 24,OOO

OXS

or 48,000

pressure

www.WestfaliaT3.info - a useful website for owners and enthusiasts of VW Westfalia T25 / T3 / Vanagon Campervans

Oil

-

the

ure warning check.

has

pressure

the

oil

up when

tht

not

ct

AT

light

ing

your

go

comes

light also

electrical

only brake

the

engine

pressure

oil

ntor for

>k the

page

58).

the

have

enough

do not

Dealer.

occasional

waming_

e

after a long

I

for

acceleration

ignition

lt

should

started.

turning

out

after

VW

dealer

ONCE

on while

comes

system.

off!

warning

low

level,

oil

engine

oil. lf

drive

flickering

light

concern

warning

is

turned

light

comes

go

warning

the ignition

starting

immediately.

the

oil

ln

always

in

when

if

the

pressure

driving.

on

case

light

lights

to

doubt

contact

of the

the

light

if

warning

engine

oil level

on but

high-speed

light

on, the

on for

out after

light

does not

on

the

engine,

(Brake

due to

design

of

brake

will

is

not an

oil level.

use

dipstick

make

about

nearest

pres-

oil

engine

trif is

goes

trz,

oil

the

if it

or

war-

come

To

sure

the

is

no

out

a

I

High

-

Refer

switch

9

-

Refer page

beam

"Turn

to

lever"

on

Watertemperature

"Water

to

30 for

details.

=D

signal/headlight

page

33 for

dimmer

details.

f

temperature gauge"

on

29

Volkswagen T3 other 1983 User Manual

Specifications and Main Features

Frequently Asked Questions

User Manual