Uniflame Gbc772w, Gbc772w-c Owner's Manual

GOLD

OWNER’S MANUAL

Outdoor LP Gas Barbecue Grill

Model No. GBC772W

WARNING

FOR YOUR SAFETY:

For Outdoor Use Only

(outside any enclosure)

WARNING

FOR YOUR SAFETY:

1. Improper installation, adjustment, alteration, service or maintenance can cause injury or property damage.

2. Read the installation, operation, and maintenance instructions thoroughly before installing or servicing this equipment.

3. Failure to follow these instructions could result in ﬁre or explosion, which could cause property damage, personal injury, or death.

Table of Contents

Important Safeguards . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Page 2

Exploded View & Hardware. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3

Assembly Instructions. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

Installling LP Gas Tank . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8

Insert LP Gas Tank. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8

Secure LP Gas Tank. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8

Connect LP Gas Tank. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8

Operating Instructions. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9

Checking for Leaks . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9

Operating Main Burners . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9

Operating Side Burner. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10

Operating Infrared Back Burner . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10

Cleaning and Care . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11

California Proposition 65: Chemicals known to the State of California to

cause cancer, birth defects, or other reproductive harm are created by the combustion of propane.

Save these instructions for future reference. If you are assembling this unit for someone else, give this manual to him or her to read and save for future reference.

Product Registration . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11

Limited Warranty . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11

Troubleshooting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12

The use and installation of this product must conform to local codes. In absence of local codes, use the National Fuel Gas Code, ANSI Z223.1/NFPA 54, CAN/CGA-B149.1,

Natural Gas and Propane Installation Code.

Manufactured in China for: Blue Rhino Global Sourcing, LLC Winston-Salem, NC USA

1.800.762.1142, www.bluerhino.com

GOLD

Outdoor LP Gas Barbecue Grill Model No. GBC772W

DANGER

If you smell gas -

1. Shut off gas to appliance.

2. Extinguish any open flame.

3. Open lid.

4. If odor continues, keep away from the appliance immediately call your gas supplier or your fire department.

Safety First

DANGERS and Cautions

1. This grill is for outdoor use only, and shall not be used in a building, garage, or any other enclosed area.

2. Do NOT operate, light or use this appliance within 8 feet of walls, structures or buildings.

3. This grill is NOT for commercial use.

4. This grill is for use with liquid propane (LP) gas only. The conversion to or attempted use of natural gas in this LP gas grill is dangerous and will void your warranty.

5. LP gas Characteristics:

a. LP gas is flammable and hazardous if handled improperly. Become

aware of the characteristics before using any LP gas product.

b. LP gas is explosive under pressure, heavier than air, and settles and

pools in low areas.

c. LP gas in its natural state has no odor. For your safety, an odorant is

added that smells like rotten cabbage.

d. Contact with LP gas can cause freeze burns to skin.

6. LP gas tank needed to operate. Only tanks marked “propane” may be used.

a. The LP gas supply tank must be constructed and marked in

accordance with the Specifications for LP gas Cylinders of the

U.S. Department of Transportation (DOT) or the National Standard of Canada, CAN/CSA-B339, Cylinders, Spheres and Tubes for the Transportation of Dangerous Goods; and Commission.

b. LP gas tank must be arranged for vapor withdrawal. c. The LP gas tank must have a listed overfilling prevention device

(OPD).

d. Only use 20-pound cylinders equipped with a cylinder connection

device compatible with the connection for outdoor cooking

appliances. e. The LP gas tank must have a tank collar to protect the tank valve. f. Never use an LP gas tank with a damaged body, valve, collar, or

footing.

g. Dented or rusted LP gas tanks may be hazardous and should be

checked by your LP gas supplier prior to use. h. The LP gas tank should not be dropped or handled roughly. i. Tanks must be stored outdoors out of the reach of children and must

not be stored in a building, garage, or any other enclosed area. Your tank must never be stored where temperatures can reach over 125°F.

j. Never keep a filled LP gas tank in a hot car or car trunk. Heat will

cause the gas pressure to increase, which may open the relief valve and allow gas to escape.

k. Place dust cap on cylinder valve outlet whenever the cylinder is not

in use. Only install the type of dust cap on the cylinder valve outlet

that is provided with the cylinder valve. Other types of caps or plugs

may result in leakage of propane. l. Do not store a spare LP gas tank under or near this appliance. m. Never fill the tank beyond 80 percent full. n. A fire causing, serious injury or damage to property may occur if the

above is not followed exactly.

7. Never attempt to attach this grill to the self-contained LP gas system of a camper trailer, motor home, or house.

8. The use of alcohol, or prescription or non-prescription drugs may impair the consumer’s ability to properly assemble or safely operate the appliance.

9. Never use charcoal, lighter fluid, lava rocks, gasoline, kerosene, or alcohol with this product.

10. Your grill has been checked at all factory connections for leaks.

Recheck all connections, as movement in shipping can loosen connections.

11. Check for leaks even if your unit was assembled for you by someone

else.

12. Do not operate if gas leak is present. Gas leaks may cause a fire or

explosion.

13. You must follow all leak-checking procedures before operating. To

prevent fire or explosion hazard when testing for a leak: a. Always perform leak test before lighting the grill and each time the

tank is connected for use.

b. No smoking. Do not use or permit sources of ignition in the area

while conducting a leak test.

WARNING

FOR YOUR SAFETY

1. Do not store or use gasoline or other flammable liquids or vapors in the vincinity of this or any other appliance.

2. An LP cylinder not connected for use shall not be stored in the vicinity of this or any other appliance.

c. Conduct the leak test outdoors in a well-ventilated area. d. Do not use matches, lighters, or a flame to check for leaks. e. Do not use grill until any and all leaks are corrected.

If you are unable to stop a leak, disconnect the LP gas supply. Call a gas appliance serviceman or your local LP gas supplier.

14. Do not store or use gasoline or other flammable liquids or vapors within 25 feet (7.62 m) of this appliance.

15. Do not use in an explosive atmosphere. Keep grill area clear and free from combustible materials, gasoline and other flammable vapors and liquids.

16. Minimum clearance from sides and back of unit to combustible construction, 21 inches from side and 21 inches from back. Do not use this appliance under overhead combustible surfaces.

17. It is essential to keep the grill’s valve compartment, burners, and circulating air passages clean. Inspect grill before each use.

18. Do not alter grill in any manner.

19. Do not use the grill unless it is COMPLETELY assembled and all parts are securely fastened and tightened.

20. This grill should be thoroughly cleaned and inspected on a regular basis. Clean and inspect the hose before each use of the appliance. If there is evidence of abrasion, wear, cuts, or leaks, the hose must be replaced prior to the appliance being put into operation.

21. Use only the regulator and hose assembly provided. The replacement regulator and hose assembly shall be that specified by the manufacturer.

22. Use only Blue Rhino Global Sourcing, LLC. factory authorized parts. The use of any part that is not factory authorized can be dangerous. This will also void your warranty.

23. Do not use this appliance without reading “Operating Instructions” in this manual.

24. Do not touch metal parts of grill until it has completely cooled (about 45 min.) to avoid burns, unless you are wearing protective gear (pot holders, gloves, BBQ mittens, etc.).

25. When cooking, fire extinguishing materials shall be readily accessible. In the event of an oil grease fire, do not attempt to extinguish with water. Use type BC dry chemical fire extinguisher or smother with dirt, sand or baking soda.

26. Do not install or use in or on boats or recreational vehicles.

27. Do not use grill in high winds.

28. Never lean over the grill when lighting.

29. Do not leave a lit grill unattended, especially keep children and pets away from grill at all times.

30. Do not attempt to move grill when in use. Allow the grill to cool before moving or storing.

31. Storage of grill indoors is permissible only if the tank is disconnected, removed from the grill and properly stored outdoors.

32. Always open grill lid carefully and slowly as heat and steam trapped within grill can severely burn you.

33. Do not attempt to disconnect the gas regulator from the tank or any gas fitting while the grill is in use.

34. Always place your grill on a hard non-combustible, level surface. An asphalt or blacktop surface may not be acceptable for this purpose.

35. Move gas hoses as far away as possible from hot surfaces and dripping hot grease.

36. Keep all electrical cords away from a hot grill.

37. Do not use grill for indoor cooking or heating. TOXIC fumes can accumulate and cause asphyxiation.

38. After a period of storage and/or nonuse, check for leaks, burner obstructions and inspect for any abrasion, wear, cuts to the hose.

39. Failure to open lid while igniting the grill’s burners, or not waiting 5 minutes to allow the gas to clear if the grill does not light, may result in an explosive flame-up.

40. If grill is not in use, the gas must be turned off at the supply tank.

41. Never operate grill without heat plates installed.

42. Always use a meat thermometer to ensure food is cooked to a safe temperature.

43. Please use protective gloves when assembling this product.

44. Do not force parts together as this can result in personal injury or damage to the product.

45. Deaths, serious injury or damage to property may occur if the above is not followed exactly.

Contact 1.800.762.1142 for assistance. Do not return to place of purchase.

page no.

Parts List

Warming Rack

Cooking Grid (3)

Temperature Gauge

Grease Tray

Tool Holder Bar (2)

Tool Holder Hook (8)

Lid

Infrared Back Burner

Left Side Shelf

Left Side Shelf Front

Grill Body

Main Burner (4)

Side Burner Assembly

Side Burner Grid

Exploded View

Side Burner

Control Knob (6)

Front Cart Support

Side Burner Front

Grease Cup Support

Grease Cup

Control Knob Support

Regulator/Hose Assembly

Cart Assembly

LP Gas Tank Restraint

Tank Guard (2)

Left Door

Left Cart Plate

Door Handle (2)

Right Door

Rear Wheel (2)

Front Cart Plate

Right Cart Plate

Lighting Rod

Front Wheel (2)

Hardware

A B C D E F

Screw

M4x8 Zinc Plated Phillips Truss Head

M5x10 Zinc Plated Phillips Truss Head

M6x15 Zinc Plated Phillips Truss Head

M6x25 Zinc Plated Phillips Truss Head

M6x20 Zinc Plated Phillips Hex Head

M6x40 Zinc Plated Phillips Truss Head

4 pcs

2 pcs

11 pcs

4 pcs

17 pcs

2 pcs

Tools Required for Assembly (Included)

#2 Phillips Head Screwdriver

M6 Wrench

G H

J K

Nut

Washer

Lock Washer

M6 Zinc Plated

ø4.3 Zinc Plated

ø6.5 Zinc Plated

2 pcs

6 pcs

12 pcs

GOLD

Assembly Instructions

Outdoor LP Gas Barbecue Grill Model No. GBC772W

DO NOT RETURN PRODUCT TO STORE. For assistance call 1.800.762.1142 toll free. Please have your owner’s manual and serial

number available for reference.

Remove Cart Frame

For Easiest Assembly:

• To avoid losing any small components or hardware, assemble your product on a hard level

surface that does not have cracks or openings.

Attach Wheels

Attach Front Cart Support

Attach Doors

x 2

Contact 1.800.762.1142 for assistance. Do not return to place of purchase.

page no.

• Clear an area large enough to layout all components and hardware.

• When applicable, tighten all hardware connections by hand first. Once the step is completed, go back and fully tighten all hardware.

Attach Cart Plates

• Follow all steps in order to properly assemble your product.

Secure Cart Plates

Attach LP Gas Tank Restraint

x 7

x 4

Attach Tank Guards

x 2

GOLD

Assembly Instructions (continued)

Outdoor LP Gas Barbecue Grill Model No. GBC772W

Attach Grill Body Assembly

Assemble Left Side Shelf

Attach Side Burner

x 4

Attach Left Side Shelf

x 1

x 4

x 1

x 2

Contact 1.800.762.1142 for assistance. Do not return to place of purchase.

page no.

Attach Tool Holder Bar Assembly

Attach Regulator/Hose Assembly and Side Burner Front Panel

Attach Left Side Shelf

x 1

Attach Grease Cup Support, Grease Cup and Insert Grease Tray

x 2

x 3

x 2

x 5

GOLD

Outdoor LP Gas Barbecue Grill Model No. GBC772W

Assembly Instructions (continued)

Insert Cooking Grids and Warming Rack

Installing LP Gas Tank

To operate you will need (1) precision-filled standard grill LP gas tank (20#) with external valve threads.

Note: An empty standard grill LP gas tank weighs approximately 18 lbs. A precision-filled standard grill LP gas tank should weigh no more than 38 lbs.

Insert LP Gas Tank

Place precision filled LP gas tank upright into hole in grill body so it is arranged for vapor withdrawal.

Secure LP Gas Tank

Secure tank by sliding tank retainer wire over shoulder of LP gas tank.

Connect LP Gas Tank

Before connecting, be sure that there is no debris caught in the head of the LP gas tank, head of the regulator valve or in the head of the burner and burner ports.

Connect gas line to tank by turning knob clockwise until it stops.

Disconnect LP Gas Tank

Before disconnecting make sure the LP gas tank valve OFF.

Disconnect gas line to tank by turning knob counterclockwise until it is loose.

Need a tank of gas? Try tank exchange service. It’s easy, fast, safe, and available at tens of thousands of conveniently located retail outlets nationwide. You can purchase a new full tank or exchange your empty for a precision filled one.

+ 16 hidden pages