Uniflame GAD1399SP User Manual

Made from 75% Bagasse

(Environmentally Friendly Sugar

Cane Pulp By-product)

WARNING

FOR YOUR SAFETY:

For Outdoor Use Only (outside any enclosure) Do Not Use For Cooking.

OWNER’S MANUAL

LP Gas Outdoor Fireplace

Model No. GAD1399SP

WARNING

FOR YOUR SAFETY:

If the information in this manual is not

followed exactly, a fire or explosion may result causing property damage, personal injury or loss of life.

WHAT TO DO IF YOU SMELL GAS:

• Do not try lighting any appliance.

• Do not touch any electrical switch; do not use any phone in your building.

• Immediately call your gas supplier from a neighbor’s phone.

• Follow the gas supplier’s instructions.

• If you cannot reach your gas supplier, call the fire department.

Installation and service must be performed

by a qualified installer, service agency or gas supplier.

Save these instructions for future

reference. If you are assembling this unit for someone else, give this manual to him or her to read and save for future reference.

WARNING

FOR YOUR SAFETY:

Improper installation, adjustment,

alteration, service or maintenance can cause injury or property damage.

Read the installation, operation and

maintenance instructions thoroughly before installing or servicing this equipment.

DANGER

If you smell gas -

1. Shut off gas to appliance.

2. Extinguish any open flame.

3. Open lid.

4. If odor continues, keep away from the appliance and immediately call your gas supplier or your fire department.

WARNING

FOR YOUR SAFETY:

1. Do not store or use gasoline or other

flammable liquids or vapors in the vicinity of this or any other appliance.

2. An LP cylinder not connected for use shall

not be stored in the vicinity of this or any other appliance.

DANGER

• This appliance can produce carbon monoxide which has no odor.

• Using it in an enclosed space can kill you.

• Never use this appliance in an enclosed space such as a camper, tent, car or home.

CARBON MONOXIDE HAZARD

Table of Contents

Dangers and Warnings . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Page 2

Exploded View & Hardware........................................... 4

Assembly Instructions............................................... 5

Installing LP Gas Tank............................................... 7

Insert LP Gas Tank............................................... 7

Secure LP Gas Tank.............................................. 7

Connect LP Gas Tank............................................. 7

Disconnect LP Gas Tank........................................... 7

Operating Instructions............................................... 7

Checking for Leaks ............................................... 7

Lighting........................................................ 7

Turning Off ... .. .. ..... .. .. ..... .. ..... .. .. ..... .. .. ..... .. ..... 8

Cleaning and Care ................................................. 8

Inspecting ...................................................... 8

Cleaning . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8

Storing .. ... .. . .. ... .. . .. ... .. . .. ... .. . .. ... ... .. . .. ... .. . .. ... 8

Product Registration ................................................ 8

Limited Warranty .................................................. 9

Troubleshooting .. ... ... ... ... ... ... ... ... ... ... ... ... ... ... ... ... 10

The use and installation of this product must conform to local codes. In absence of local codes, use the latest edition of the National Fuel Gas Code, ANSI Z223.1/NFPA 54, or International Fuel Gas Code. This appliance, when installed, must be electrically grounded in accordance with local codes, or in the absence of local codes with the National Electrical Code, ANSI/NFPA 70, if applicable.

For installation in Canada - these instructions, while generally acceptable do not necessarily comply with the Canadian installation codes, particularly with piping above and below ground. In Canada the installation of this appliance must comply with local codes and/or standard CAN/ CGA B149.1 (installation code for propane burning appliances and equipment).

California Proposition 65: Chemicals known to the State of California to cause cancer, birth defects, or other reproductive harm are created by the combustion of propane.

DANGER

Do not leave this appliance unattended while it is in operation.

Manufactured in China for: Blue Rhino Global Sourcing, Inc Winston-Salem, NC 27105 USA • 1.800.762.1142, www.BlueRhino.com

is a Registered Trademark of Blue Rhino Global Sourcing, Inc. GAD1399SP-OM-102 EF

LP Gas Outdoor Fireplace Model No. GAD1399SP Series

DANGERS and WARNINGS: FOR YOUR SAFETY

W DANGER: Failure to follow the dangers, warning and cautions in this manual may result in serious bodily injury or death, or in a fire or an explosion

causing damage to property. W WARNING: W This appliance is for outdoor use only, and shall NOT be used in a

building, garage or any other enclosed area.

W Do NOT operate, light or use this appliance within ten (10) feet (3.05 m)

of walls, structures or buildings.

W For residential use only. This outdoor fireplace is NOT for commercial

use.

W This outdoor fireplace is safety certified for use in the United States

and/or Canada only. Do not modify for use in any other location. Modification will result in a safety hazard.

W Do NOT use this outdoor fireplace for indoor heating. TOXIC carbon

monoxide fumes can accumulate and cause asphyxiation.

W Apartment Dwellers: Check with management to learn the requirements

and fire codes for using an LP gas outdoor fireplace in your apartment complex. If allowed, use outside on the ground floor with a ten (10) foot (3.05 m) clearance from any structure. Do not use on or under balconies.

W This outdoor fireplace is for use with liquid propane (LP) gas only. The

conversion to or attempted use of natural gas in this outdoor fireplace is dangerous and will void your warranty.

W LP gas is flammable and hazardous if handled improperly. Become

aware of the characteristics before using any LP gas product. a. LP gas is explosive under pressure, heavier than air, and settles and

pools in low areas.

b. LP gas in its natural state has no odor. For your safety, an odorant is

added that smells like rotten cabbage.

c. Contact with LP gas can cause freeze burns to skin.

W LP gas tank needed to operate. Only tanks marked “propane” may be

used.

a. The LP gas supply tank must be constructed and marked in

accordance with the Specifications for LP gas tanks of the U.S.

Department of Transportation (DOT) or the National Standard of Canada, CAN/CSA-B339, LP gas tanks, Spheres and Tubes for the Transportation of Dangerous Goods; and Commission.

W Do not operate if gas leak is present. Gas leaks may cause a fire or

explosion.

W You must follow all leak-checking procedures before operating. To

prevent fire or explosion hazard when testing for a leak: a. Always perform leak test before lighting the outdoor fireplace and

each time the tank is connected for use.

b. No smoking. Do not use or permit sources of ignition in the area

while conducting a leak test. c. Conduct the leak test outdoors in a well-ventilated area. d. Do not use matches, lighters or a flame to check for leaks. e. Do not use outdoor fireplace until any and all leaks are corrected.

If you are unable to stop a leak, disconnect the LP gas supply. Call a

gas appliance serviceman or your local LP gas supplier.

W Do not store or use gasoline or other flammable liquids or vapors within

25 feet (7.62 m) of this appliance.

W Do not use in an explosive atmosphere. Keep outdoor fireplace

area clear and free from combustible materials, gasoline and other flammable vapors and liquids.

W This outdoor fireplace is NOT to be operated by children. W This outdoor fireplace is NOT to be used in or on boats or recreational

vehicles.

W Do NOT connect to a remote gas supply. W Never attempt to attach this outdoor fireplace to the self-contained LP

gas system of a camper trailer, motor home or house.

W Always use in accordance with all applicable local, state and national

codes. Contact your local fire department for details on outdoor burning.

W When using this outdoor fireplace, exercise the same precautions you

would with any open fire.

W The use of alcohol, prescription or non-prescription drugs may impair

the consumer’s ability to properly assemble or safely operate this outdoor fireplace.

b. LP gas tank must be arranged for vapor withdrawal. c. The LP gas tank must have a listed overfilling prevention device

(OPD) and a QCCI or Type I (CGA810) LP gas tank connection. d. The LP gas tank must have a tank collar to protect the tank valve. e. Never use an LP gas tank with a damaged body, valve, collar or

footing. f. Dented or rusted LP gas tanks may be hazardous and should be

checked by your LP gas supplier prior to use. g. The LP gas tank should not be dropped or handled roughly. h. Tanks must be stored outdoors, out of the reach of children and

must not be stored in a building, garage or any other enclosed area.

Your LP gas tank must never be stored where temperatures can

reach over 125°F. i. Do not insert any tool or foreign object into the valve outlet or safety

relief valve. You may damage the valve and cause a leak. Leaking

propane may result in explosion, fire, severe personal injury or

death. j. Never keep a filled LP gas tank in a hot car or car trunk. Heat will

cause the gas pressure to increase, which may open the relief valve

and allow gas to escape. k. Place dust cap on valve outlet whenever the LP gas tank is not in

use. Only install the type of dust cap on the LP gas tank valve outlet

that is provided with the LP gas tank valve. Other types of caps or

plugs may result in leakage of propane. l. Do not store a spare LP gas tank under or near this appliance. m. Never fill the tank beyond 80 percent full.

W Your outdoor fireplace has been checked at all factory connections

for leaks. Recheck all connections as described in the “Operating Instructions” section of this manual, as movement in shipping can loosen connections.

W Check for leaks even if your unit was assembled for you by someone

else.

W Do NOT use this outdoor fireplace without reading the entire “Owner’s

Manual.”

W Do NOT burn solid fuels such as: wood, charcoal briquets, lump

charcoal, manufactured logs, driftwood, trash, leaves, paper, cardboard, plywood, painted or stained or pressure treated wood in this outdoor fireplace.

W It is essential to keep the outdoor fireplace’s valve compartment,

burners, and circulating air passages clean. Inspect outdoor fireplace before each use.

W Do NOT use this outdoor fireplace until it is COMPLETELY assembled and

all parts are securely fastened and tightened.

W Do NOT use this outdoor fireplace near automobiles, trucks, vans or

recreational vehicles.

W Do NOT use this outdoor fireplace under any overhang or near any

unprotected combustible constructions. Avoid using near or under overhanging trees and shrubs.

W Always use this outdoor fireplace on a hard, level, non-combustible

surface such a concrete, rock or stone. An asphalt or blacktop surface

may not be acceptable for this purpose. W Do NOT use this outdoor fireplace for cooking. W Do NOT use this outdoor fireplace if any part has been under water.

Immediately call a qualified service technician to inspect the appliance

and to replace any part or control system and any gas control which

has been under water. W Do NOT wear flammable or loose clothing when operating this outdoor

fireplace. W Do NOT use in windy conditions. W Never lean over this outdoor fireplace when lighting or when in use. W Do NOT use this outdoor fireplace unless burner is securely in place. W Keep all electrical cords away from outdoor fireplace during use.

Need help? 1.800.762.1142

Do not return to place of purchase.

Replacement Parts

parts.BlueRhino.com /

1.800.762.1142

page no.

W Certain areas of this outdoor fireplace when in use will become too

hot to touch. To avoid burns, do not touch hot surfaces until the unit has cooled (about 45 minutes) unless you are wearing protective gear (insulated pot holder or heat resistant gloves or mittens).

W Do NOT leave a lit outdoor fireplace unattended, especially around

children and pets.

W Children and adults should be alerted to the hazards of high surface

temperatures and should stay away to avoid burns or clothing ignition.

W Young children should be carefully supervised when they are in the area

of the appliance.

W Clothing or other flammable materials should not be hung from the

appliance or placed on or near the appliance.

W Any guard or other protective device removed for servicing the

appliance must be replaced prior to operating the appliance. W Cover must be removed when burner is in operation. W Do not attempt to move outdoor fireplace when in use. Allow the

outdoor fireplace to cool before moving or storing. W This outdoor fireplace should be thoroughly cleaned and inspected

on a regular basis. Clean and inspect the hose before each use of the

appliance. If there is evidence of abrasion, wear, cuts, or leaks, the hose

must be replaced prior to the appliance being put into operation. W This outdoor fireplace should be inspected at least annually by a

qualified service person. Depending on amount of use, more frequent

cleaning may be required. Do not operate until all parts have been

repaired or replaced. W Use only the regulator and hose assembly provided. The replacement

regulator and hose assembly shall be that specified by the

manufacturer.

W Storage of this outdoor fireplace indoors is permissible only if the tank

is disconnected, removed from the outdoor fireplace and properly stored outdoors.

W Do not attempt to disconnect the gas regulator from the tank or any gas

fitting while the outdoor fireplace is in use.

W If the outdoor fireplace is not in use, the gas must be turned off at the

supply tank. W The pressure regulator is set for 11 inches of water column (pressure). W The maximum inlet gas pressure for this outdoor fireplace is 11 inches

of water column pressure. W Turn LP gas tank valve closed, disconnect gas regulator prior and during

pressure testing of the gas supply piping system at test pressures equal

to or less than 1/2 psi (3.5 kPa). W Do NOT sit on the mantle. W Do not throw anything onto the fire when the unit is in operation. W Fire logs and lava rock are very hot, keep the children or pets away at a

safe distance. W The opening of the tank collar should face toward the door side for easy

access. W Do NOT store any combustible materials in the base enclosure. W Use protective gloves when assembling this product. W Do not force parts together as this can result in personal injury or

damage to the product. W Deaths, serious injury or damage to property may occur if the above is

not followed exactly.

W Use only Blue Rhino Global Sourcing, Inc factory authorized parts. The

use of any part that is NOT factory authorized can be dangerous and will void your warranty.

LP Gas Outdoor Fireplace Model No. GAD1399SP Series

Parts List

Bowl Assembly*

Burner*

Igniter*

Igniter Button*

Control Knob* Regulator/Hose

Assembly*

Hearth*

Leg A (2)

Leg B

Side Panel (3)

Foot (4)*

LP Gas Tank Support

58-22-024

58-22-001

55-05-441

55-05-442

55-05-436

58-22-003

58-23-059

58-23-060

58-23-061

58-23-062

58-23-063

55-05-458

Exploded View

LP Gas Tank Support

Chain*

LP Gas Tank Tray Chain*

LP Gas Tank Tray*

Right Door Leg

Door Handle*

Door

Cover

Lava Rocks (sold separately)

Logs (sold separately)

Black Glass Rocks

Glass Rocks (sold separately)

* Pre-assembled

†

Only use Blue Rhino Global Sourcing, Inc. products.

†

55-05-447

55-05-449

55-05-448

58-23-064

58-23-065

58-23-066

58-23-067

†

GLS-BLK

†

1618

Hardware

A B

Screw

M4x10 Black Nickel Plated Truss Head

M5x12 Black Nickel Plated Truss Head

2 pcs

16 pcs

22 23

Tools Required for Assembly (Not Included)

#2 Phillips Head Screwdriver 1 pc

C D E F G

Screw

Nut

Wing Nut

AA Battery

M5x16 Black Nickel Plated Step Head

M5x20 Black Nickel Plated Truss Head

M4 Black Nickel Plated

M5 Black Nickel Plated

1.5 V AA Battery

1 pc

4 pcs

2 pcs

3 pcs

1 pc

Need help? 1.800.762.1142

Do not return to place of purchase.

Assembly Instructions

Replacement Parts

parts.BlueRhino.com /

1.800.762.1142

page no.

DO NOT RETURN PRODUCT TO STORE.

For assistance call 1.800.762.1142 toll free. Please have your owner’s manual and model number available for reference.

For Easiest Assembly:

• To avoid losing any small components or hardware, assemble your product on a level surface that does not have cracks or openings.

• Clear an area large enough to layout all components and hardware and that is soft to not scratch or damage any surface finishes.

• When applicable, tighten all hardware connections by hand first. Once the step is completed go back and fully tighten all hardware while being cautious not to over tighten to avoid damaging surfaces or stripping hardware.

• Follow all steps in order to properly assemble your product.

To complete assembly you will need:

• (1) Leak Detection Solution (Instructions on how to make solution are included in the “Operating Instructions” section of this manual)

• (1) Precision Filled LP Gas Grill Tank with Acme Type 1 external threaded valve connection (4-5 gallon size)

Attach Legs

Typical assembly: approximately 1 (one) hour.

Attach Panels

Attach Base

x 4

x 12

x 4

Assembly Instructions (continued)

LP Gas Outdoor Fireplace Model No. GAD1399SP Series

Attach LP Gas Tank Support

Attach Door

A E

Insert Battery

Note: Remove plastic wrapper before installing battery.

x 2

x 3

Place Glass Rocks

W CAUTION: Do NOT dump glass rocks out of package. Carefully

place glass rocks by hand so dust does not clog burner.

W CAUTION: Do NOT cover pilot housing.

Note: Glass rocks should be 0.4-1.2 in. (1-3 cm) long. Approx. 14.5 lbs. (6.6 kg) of glass rocks are needed.

x 1

+ 14 hidden pages