OWNER’S MANUAL
Outdoor LP Gas Barbecue Grill
Model No. GBC1273SP
WARNING
FOR YOUR SAFETY:
For Outdoor Use Only
(outside any enclosure)
WARNING
FOR YOUR SAFETY:
1.Improper installation, adjustment, alteration, service or maintenance can cause injury or property damage.
2.Read the installation, operation, and maintenance instructions thoroughly before installing or servicing this equipment.
3.Failure to follow these instructions could result in fire or explosion, which could cause property damage, personal injury, or death.
4.This instruction manual contains important information necessary for the proper assembly and safe use of the appliance.
5.Read and follow all warnings and instructions before assembling and using the appliance.
6.Follow all warnings and instructions when using the appliance.
7.Keep this manual for future reference.
DANGER
If you smell gas -
1.Shut off gas to appliance.
2.Extinguish any open flame.
3.Open lid.
4.If odor continues, keep away from the appliance and immediately call your gas supplier or your fire department.
WARNING
FOR YOUR SAFETY:
1.Do NOT store or use gasoline or other flammable liquids or vapors in the vicinity of this or any other appliance.
2.An LP cylinder not connected for use shall not be stored in the vicinity of this or any other appliance.
DANGER
Never operate this appliance unattended.
Made from 75% Bagasse
(environmentally friendly sugar cane pulp by-product)
Table of Contents
Important Safeguards . . . . . . . . . . . . . . . . . . . . . Page 2 Expanded View & Hardware . . . . . . . . . . . . . . . . . . . . . 4 Assembly Instructions . . . . . . . . . . . . . . . . . . . . . . . 5 Assembly Instructions - Rotisserie . . . . . . . . . . . . . . . . . . 11 Installling LP Gas Tank . . . . . . . . . . . . . . . . . . . . . . . 12
Inserting LP Gas Tank . . . . . . . . . . . . . . . . . . . . . . 12 Securing LP Gas Tank . . . . . . . . . . . . . . . . . . . . . . 12 Connecting LP Gas Tank . . . . . . . . . . . . . . . . . . . . . 12 Disconnecting LP Gas Tank . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12 Operating Instructions . . . . . . . . . . . . . . . . . . . . . . . 12 Checking for Leaks . . . . . . . . . . . . . . . . . . . . . . . 12 Operating Main Burners . . . . . . . . . . . . . . . . . . . . . 12 Operating Infrared Sear Burner . . . . . . . . . . . . . . . . . . . 13 Operating Side Burner . . . . . . . . . . . . . . . . . . . . . . 13 Operating Infrared Back Burner . . . . . . . . . . . . . . . . . . 14 Operating Rotisserie . . . . . . . . . . . . . . . . . . . . . . . 14 Cleaning and Care . . . . . . . . . . . . . . . . . . . . . . . . 15 Product Registration . . . . . . . . . . . . . . . . . . . . . . . 15 Replacement Parts . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15 Limited Warranty . . . . . . . . . . . . . . . . . . . . . . . . . 15 Troubleshooting . . . . . . . . . . . . . . . . . . . . . . . . . 16
The use and installation must conform with local codes or, in the absence of local codes, with either the National Fuel Gas Code, ANSI Z223.1/NFPA 54, Natural Gas and Propane Installation Code, CSA B149.1, or Propane Storage and Handling Code, B149.2,or the Standard for Recreational Vehicles, ANSI A 119.2/NFPA 1192, and CSA Z240 RV Series, Recreational Vehicle Code, as applicable.
THIS INSTRUCTION BOOKLET CONTAINS IMPORTANT SAFETY INFORMATION. PLEASE READ AND KEEP FOR FUTURE REFERENCE.
If you are assembling this unit for someone else, give this manual to him or her to read and save for future reference.
California Proposition 65: Chemicals known to the State of California to cause cancer, birth defects, or other reproductive harm are created by the combustion of propane.
Manufactured in China for: Blue Rhino Global Sourcing, Inc |
|
Winston-Salem, NC 27105 USA • 1.800.762.1142 • BlueRhino.com |
|
© Blue Rhino Global Sourcing, Inc. |
|
UniFlame® is a Registered Trademark of Blue Rhino Global Sourcing, Inc. |
GBC1273SP-OM-101 EF |
2 |
Outdoor LP Gas Barbecue Grill |
|
Model No. GBC1273SP |
||
|
||
|
|
Important Safeguards
WW DANGER: Failure to follow the dangers, warnings and cautions in this manual may result in serious bodily injury or death, or in a fire or an explosion causing damage to property.
WW WARNINGS: |
|
|
WW This grill is for outdoor use only, and should not be used in a building, |
WW A fire causing serious injury or damage to property may occur if the |
|
garage or any other enclosed area. |
above is not followed exactly. |
|
WW Do NOT operate, light or use this appliance within ten feet (3.05 m) of |
WW Never attempt to attach this grill to the self-contained LP gas system of |
|
walls, structures or buildings. |
a camper trailer, motor home or house. |
|
WW For residential use only. This grill is NOT for commercial use. |
WW Never use charcoal, lighter fluid, lava rocks, gasoline, kerosene or |
|
WW This grill is not intended for and should never be used as a heater. TOXIC |
alcohol with this product. |
|
|
||
fumes can accumulate and cause asphyxiation. |
WW Your grill has been checked at all factory connections for leaks. |
|
WW This grill is safety certified for use in the United States and/or Canada |
Recheck all connections as described in the “Operating Instructions” |
|
section, as shipping can loosen connections. |
||
only. Do NOT modify for use in any other location. Modification will |
||
|
||
result in a safety hazard and will void your warranty. |
WW Check for leaks even if your unit was assembled for you by someone |
|
WW This grill is for use with liquid propane (LP) gas only. The conversion to |
else. |
|
|
||
or attempted use of natural gas in this LP gas grill is dangerous, may |
WW Do NOT operate if a gas leak is present. Gas leaks may cause a fire or |
|
cause bodily harm and will void your warranty. |
explosion. |
|
WW LP gas characteristics: |
WW You must follow all instructions in “Checking for Leaks” section before |
|
a. LP gas is flammable and hazardous if handled improperly. Become |
operating. To prevent fire or explosion hazard when testing for a leak: |
|
|
||
aware of the characteristics before using any LP gas product. |
a. Always perform a leak test before lighting the grill and each time |
|
b. LP gas is explosive under pressure, heavier than air, and settles/ |
the cylinder is connected for use. |
|
|
||
pools in low areas. |
b. No smoking. Do NOT use or permit sources of ignition in the area |
|
c. LP gas in its natural state has no odor. For your safety, an odorant is |
while conducting a leak test. |
|
|
||
added that smells like rotten cabbage. |
c. Conduct the leak test outdoors in a well-ventilated area. |
|
d. Contact with LP gas can cause freeze burns to skin. |
d. Do NOT use matches, lighters, or a flame to check for leaks. |
|
WW Apartment dwellers: Check with management to learn the requirements |
e. The use of alcohol, prescription or non-prescription drugs may |
|
and fire codes for using a LP gas grill in your apartment complex. |
impair the consumer’s ability to properly assemble or safely operate |
|
If allowed, use outside on the ground floor with a ten foot (3.05 m) |
the appliance. |
|
clearance from any structure. Do NOT use on or under balconies. |
f. Strong odors, colds, sinus congestion, etc. may prevent the |
|
|
||
WW LP gas cylinder needed to operate. Only cylinders marked “propane” |
detection of propane. Use caution and common sense when testing |
|
may be used. |
for leaks. |
|
WW The LP gas cylinder must be constructed and marked in accordance |
g. Do NOT use grill until any and all leaks are corrected. |
|
with the Specifications for LP-gas Cylinders of the U.S. Department |
If you are unable to stop a leak, disconnect the LP gas supply. Call a |
|
of Transportation (D.O.T.) or the National Standard of Canada, CAN/ |
gas appliance serviceman or your local LP gas supplier. |
|
CSA-B339, Cylinders, Spheres and Tubes for the Transportation of |
WW This grill is designed to operate at an inlet pressure of: 11 inches water |
|
Dangerous Goods; and Commission. |
column. |
|
WW LP gas cylinder must be arranged for vapor withdrawal. |
WW Do NOT store or use gasoline or other flammable liquids or vapors |
|
|
||
WW The LP gas cylinder must have a listed overfilling prevention device |
within 25 feet (7.62 m) of this appliance. |
|
(OPD). |
WW Do NOT use in an explosive atmosphere. Keep grill area clear and free |
|
|
||
WW Only use LP gas cylinders equipped with a cylinder connection device |
from combustible materials, gasoline and other flammable vapors and |
|
compatible with the connection for outdoor cooking appliances. |
liquids. |
|
WW The LP gas cylinder must have a cylinder collar to protect the cylinder |
WW Minimum clearance from sides and back of unit to combustible |
|
valve. |
construction is 36 inches (91.4 cm). Do NOT use this appliance under |
|
WW Never use a LP gas cylinder with a damaged body, valve, collar or |
any type of overhang or roof. |
|
|
||
footing. |
WW It is essential to keep the grill’s valve compartment, burners and |
|
WW Dented or rusted LP gas cylinders may be hazardous and should be |
circulating air passages clean. |
|
|
||
checked by your LP gas supplier prior to use. |
WW Inspect grill before each use. |
|
WW The LP gas cylinder should not be dropped or handled roughly. |
WW Do NOT alter grill in any manner. Any alteration will void your warranty. |
|
WW LP gas cylinders must be stored outdoors out of the reach of children |
WW Do NOT use the grill unless it is COMPLETELY assembled and all parts |
|
and must not be stored in a building, garage or any other enclosed area. |
are securely fastened and tightened. |
|
Your cylinder must never be stored where temperatures can reach over |
WW Do NOT build this model of grill in any built-in or slide-in construction. |
|
125°F. |
Ignoring this warning could cause a fire or an explosion that can |
|
|
||
WW Do NOT insert any tool or foreign object into the valve outlet or safety |
damage property and cause serious bodily injury or death. |
|
relief valve. You may damage the valve and cause a leak. Leaking |
WW This grill should be thoroughly cleaned and inspected on a regular |
|
propane may result in an explosion, fire, severe personal injury or death. |
||
|
basis. |
|
WW Do NOT block holes in sides or back of grill. |
WW Clean and inspect the hose before each use of the appliance. If there |
|
|
||
WW Never keep an LP gas cylinder in a hot car or trunk. Heat will cause the |
is evidence of abrasion, wear, cuts or leaks, the hose must be replaced |
|
gas pressure to increase, which may open the relief valve and allow gas |
prior to operation. |
|
to escape. |
WW Use only the regulator and hose assembly provided. Use only the |
|
|
||
WW Place dust cap on cylinder valve outlet whenever the cylinder is not in |
replacement regulator and hose assembly specified by Blue Rhino |
|
use. Only install the type of dust cap on the cylinder valve outlet that is |
Global Sourcing, Inc. |
|
provided with the cylinder valve. Other types of caps or plugs may result |
WW Use only Blue Rhino Global Sourcing, Inc. factory-authorized parts. The |
|
in leakage of propane. |
use of any part that is not factory-authorized can be dangerous and will |
|
|
||
WW If grill is not in use, the gas must be turned off at the supply cylinder |
void your warranty. |
|
and disconnected. |
WW Do NOT operate this appliance without reading “Operating Instructions” |
|
|
||
WW Do NOT store a spare LP gas cylinder under or near this appliance. |
in this manual. |
|
WW Never fill the cylinder beyond 80 percent full. |
WW Do NOT touch metal parts of grill until they have completely cooled |
|
|
(about 45 min.) to avoid burns, unless you are wearing protective gear |
|
|
(pot holders, gloves, BBQ mittens, etc.). |
Recipes |
|
Need help? 1.800.762.1142 |
|
Replacement Parts |
|
|
|
|
|
|
|||
|
|
parts.BlueRhino.com |
3 |
|
||
BlueRhino.com/recipes |
|
Do not return to place of purchase. |
|
|
||
|
|
1.800.762.1142 |
|
|
||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
WW Do NOT install or use in or on boats or recreational vehicles.
WW When cooking, fire extinguishing materials should be readily accessible. In the event of an oil/grease fire, do NOT attempt to extinguish with water. Use type BC dry chemical fire extinguisher or smother with dirt, sand or baking soda.
WW Do NOT use grill in high winds.
WW Never lean over the grill when lighting.
WW Do NOT leave a lit grill unattended. Keep children and pets away from grill at all times.
WW Do NOT leave grill unattended while preheating or burning off food residue on high. If grill has not been cleaned, a grease fire can occur that may damage the product.
WW Do NOT place empty cooking vessels on the appliance while in operation.
WW Use caution when placing anything on the grill while the appliance is in operation.
WW Do NOT attempt to move grill when in use. Allow the grill to cool before moving or storing.
WW LP gas cylinder must be properly disconnected and removed prior to moving this grill.
WW Storage of grill indoors is permissible only if the cylinder is disconnected, removed from the grill and properly stored outdoors.
WW Always open grill lid carefully and slowly as heat and steam trapped within grill can cause severe burns.
WW Do NOT attempt to disconnect the gas regulator from the cylinder or any gas fitting while the grill is in use.
WW Always place your grill on a hard, non-combustible, level surface. An asphalt or blacktop surface may not be acceptable for this purpose.
WW Move gas hoses as far away as possible from hot surfaces and dripping hot grease.
WW Keep all electrical cords away from a hot grill.
WW After a period of storage and/or nonuse, check for leaks, burner obstructions and inspect for any abrasion, wear or cuts to the hose.
WW Failure to open lid while igniting the grill’s burners, or not waiting 5 minutes to allow the gas to clear if the grill does not light, may result in an explosive flame-up.
WW Never operate grill without its heat plates installed.
WW Always use a meat thermometer to ensure food is cooked to a safe temperature.
WW Use protective gloves when assembling this product.
WW Do NOT force parts together as this can result in personal injury or damage to the product.
WW Never cover entire cooking area with aluminum foil.
WW Deaths, serious injury or damage to property may occur if the above is not followed exactly.
4 |
Outdoor LP Gas Barbecue Grill |
|
Model No. GBC1273SP |
||
|
||
|
|
Parts List
1 |
Warming Rack |
55-22-043 |
|
|
|
|
|
2 |
Cooking Grid (3) |
55-22-044 |
|
|
|
|
|
3 |
Temperature Gauge* |
55-22-049 |
|
|
|
|
|
4 |
Grill Body Assembly* |
55-22-075 |
|
|
|
|
|
5 |
Lid Handle* |
55-22-046 |
|
|
|
|
|
6 |
Lid* |
55-22-620 |
|
|
|
|
|
7 |
Heat Plate (3) |
55-22-048 |
|
|
|
|
|
8 |
Side Burner Grid |
55-22-049 |
|
|
|
|
|
9 |
Side Burner |
55-22-913 |
|
|
|
|
|
10 |
Regulator/Hose Assembly* |
55-08-091 |
|
|
|
|
|
11 |
Infrared Back Burner* |
55-22-051 |
|
|
|
|
|
12 |
Burner (3)* |
55-22-050 |
|
|
|
|
|
13 |
Infrared Sear Burner* |
55-22-051 |
|
|
|
|
|
14 |
Control Knob Bezel (6) |
55-08-071 |
|
|
|
|
|
15 |
Control Knob (6) |
55-09-341 |
|
|
|
|
|
16 |
Right Side Shelf |
55-22-052 |
|
Assembly* |
|||
|
|
||
17 |
Towel Bar |
55-07-548 |
|
|
|
|
|
18 |
Tool Hook (4)* |
55-07-729 |
|
|
|
|
|
19 |
Left Side Shelf |
55-22-053 |
|
|
|
|
|
20 |
Left Side Shelf Front Panel |
55-22-054 |
|
|
|
|
|
21 |
Right Side Shelf Front |
55-22-055 |
|
Panel |
|||
|
|
||
|
|
|
|
22 |
Rotisserie Motor |
55-22-056 |
|
|
|
|
|
23 |
Rotisserie Motor Support |
55-22-057 |
|
|
|
|
|
24 |
Rotisserie Fork (2) |
55-10-261 |
|
|
|
|
|
25 |
Rotisserie Handle |
55-22-058 |
|
|
|
|
|
26 |
Rotisserie Counterweight |
55-22-059 |
|
|
|
|
|
27 |
Rotisserie Rod |
55-22-060 |
|
|
|
|
|
28 |
Grease Cup |
55-11-018 |
|
|
|
|
|
29 |
Grease Tray |
55-22-061 |
|
|
|
|
|
30 |
Basket (2) |
55-09-337 |
|
|
|
|
|
31 |
Cart Frame Support |
55-22-062 |
|
|
|
|
|
32 |
Basket Support (4) |
55-22-063 |
|
|
|
|
|
33 |
Left Side Panel |
55-22-064 |
|
|
|
|
|
34 |
Rear Panel |
55-22-065 |
|
|
|
|
|
35 |
LP Gas Tank Retainer |
55-22-066 |
|
Wire* |
|||
|
|
Expanded View
|
|
1 |
2 |
2 |
|
|
2 |
|
|
|
|
|
|
7 |
18 |
17 |
|
|
|
|
|
|
|
19 |
|
|
20 |
22 |
|
|
|
23 |
24 |
|
|
|
30
33
31 |
32 |
|
41
42 |
43 |
43
37 |
Door Handle (2) |
55-22-068 |
|
|
|
38 |
Left Door |
55-23-621 |
|
|
|
39 |
Right Door |
55-23-622 |
|
|
|
40 |
Lighting Hook* |
55-07-331 |
|
|
|
41 |
Bottom Shelf |
55-22-071 |
|
|
|
42 |
Front Cart Frame Support |
55-22-072 |
|
|
|
43 |
Door Magnet (4)* |
55-10-174 |
|
|
|
44 |
Rear Locking Wheel (2) |
55-22-073 |
|
3 |
|
|
|
5 |
|
6 |
|
8 |
|
|
|
|
|
|
11 |
|
|
|
|
12 |
|
|
9 |
14 |
13 |
|
4 |
16 |
|
|
|||
|
|
|
||
|
|
|
|
10 |
15 |
|
|
|
21 |
|
|
|
|
|
|
25 |
|
|
14 |
|
|
|
|
|
27 |
26 |
|
|
15 |
29 |
|
|
|
28 |
|
|
|
|
34 |
|
37 |
37 |
|
|
|
|
|
35 |
36 |
38 |
|
|
40 |
|
|
|
|
|
|
|
|
39 |
44
45
36 Right Side Panel |
55-22-067 |
45 |
Front Wheel (2) |
55-22-074 |
|
|
|
* Pre assembled
Hardware
A |
Screw |
M4x12 Nickel Plated Phillips Truss Head |
12 pcs |
B |
Screw |
M6x12 Nickel Plated Phillips Truss Head |
33 pcs |
C |
Screw |
M6x60 Nickel Plated Phillips Truss Head |
4 pcs |
D |
Bolt |
M6x15 Nickel Plated Hex Head |
20 pcs |
E |
Nut |
M6 Nickel Plated |
10 pcs |
F |
Washer |
ø6.5x13 Nickel Plated |
10 pcs |
G |
Washer |
ø6.5x18 Nickel Plated |
14 pcs |
H |
Lock Washer |
ø6.5 Nickel Plated |
10 pcs |
Tools Required for Assembly (Included)
#2 Phillips Head Screwdriver 1 pc
M10-M6 Wrench |
1 pc |
Recipes |
|
Need help? 1.800.762.1142 |
|
Replacement Parts |
|
|
|
|
|||
|
|
parts.BlueRhino.com |
5 |
||
BlueRhino.com/recipes |
|
Do not return to place of purchase. |
|
||
|
|
1.800.762.1142 |
|
||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
Assembly Instructions – Grill
1 |
DO NOT RETURN TO PLACE OF PURCHASE. |
|
2 |
Attach Wheels |
For assistance, call 1.800.762.1142 toll-free. Please have |
Note: Locking wheels get attached in the back. |
|||
your Owner’s Manual and model number available for |
|
reference.
Note: The model number is printed on a label which can be found on the inside door, back or side of the cart assembly.
Assembly Tips:
1.Select an area where you will assemble this product. To protect components, choose a smooth surface that’s free of cracks or openings.
2.Spread out all parts.
3.Tighten all hardware connections by hand first. Then, before completing each step, go back and fully tighten all hardware. Be careful not to over-tighten. That could damage surfaces or strip threads.
4.For best results, complete each step in the order presented.
To complete assembly you will need:
•(1) Leak detection solution (instructions on how to make the solution are included in the “Operating Instructions” section of this manual).
•(1) Precision-filled LP gas grill tank with Acme Type 1 external threaded valve connection (standard grill size).
Typical assembly is approximately one hour.
B
E
x 8
x 8
F |
x 8 |
H |
x 8 |
|
|
|
3 Attach Side and Rear Panels |
4 Attach Front Cart Frame Support |
|
A |
B |
B |
x 11 |
x 4
x 4
G |
x 4 |
6
Assembly Instructions – Grill (continued)
5 Attach Cart Frame Support
A |
x 2 |
7 Insert Baskets
Outdoor LP Gas Barbecue Grill
Model No. GBC1273SP
6 Attach Basket Supports
B |
x 8 |
8 Attach Door Handles
C |
x 4 |
G |
x 4 |
Recipes |
|
Need help? 1.800.762.1142 |
|
Replacement Parts |
|
|
|
|
|
|
|||
|
|
parts.BlueRhino.com |
7 |
|
||
BlueRhino.com/recipes |
|
Do not return to place of purchase. |
|
|
||
|
|
1.800.762.1142 |
|
|
||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
9 Attach Doors |
10 Attach Grill Body Assembly |
D |
x 4 |
G |
x 4 |
11 |
Attach Side Shelf Front Panels and Towel Bar |
|
12 |
Attach Left Side Shelf |
|
|
Note: Leave 5 mm of bolt threads exposed. |
A |
x 2 |
|
|
|
D |
x 6 |
G |
x 2 |
|
|
D |
x 2 |
||
|
|
|
8
Assembly Instructions – Grill (continued)
13 Secure Left Side Shelf
D |
x 3 |
15 Secure Right Side Shelf
D |
x 3 |
Outdoor LP Gas Barbecue Grill
Model No. GBC1273SP
14 Attach Right Side Shelf
Note: Leave 5 mm of bolt threads exposed.
D |
x 2 |
16 |
Attach Side Burner Regulator/Control Valve, Control |
Knob Bezel and Control Knob |
A x 2
Recipes |
|
Need help? 1.800.762.1142 |
|
Replacement Parts |
|
|
|
|
|
|
|||
|
|
parts.BlueRhino.com |
9 |
|
||
BlueRhino.com/recipes |
|
Do not return to place of purchase. |
|
|
||
|
|
1.800.762.1142 |
|
|
||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
17 Attach Side Burner, Igniter Wire and Side Burner Grid |
18 Insert Heat Plates and Cooking Grids |
A |
x 2 |
|
19 Insert Warming Rack |
20 Insert Grease Tray and Grease Cup |
10 |
Outdoor LP Gas Barbecue Grill |
|
Model No. GBC1273SP |
||
|
||
|
|
Assembly Instructions – Grill (continued)
21 Insert Regulator/Control Valve
Recipes |
|
Need help? 1.800.762.1142 |
|
Replacement Parts |
|
|
|
|
|||
|
|
parts.BlueRhino.com |
11 |
||
BlueRhino.com/recipes |
|
Do not return to place of purchase. |
|
||
|
|
1.800.762.1142 |
|
||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
Assembly Instructions - Rotisserie
|
|
|
|
|
1 |
Remove Warming Rack |
2 |
Assemble Rotisserie Rod |
|
|
|
|
|
|
|
|
|
3 Attach Rotisserie Motor Support and Rostisserie Motor |
4 Insert Rotisserie Rod |
B
E
x 2
x 2
F |
x 2 |
H |
x 2 |
12 |
Outdoor LP Gas Barbecue Grill |
|
Model No. GBC1273SP |
||
|
||
|
|
Installing LP Gas Tank
To operate, you will need one precision-filled standard grill LP gas tank with external valve threads.
WW CAUTION: LP gas tank must be properly disconnected and removed prior to moving this grill.
Inserting LP Gas Tank
20 lb
9Kg
12.2in. / 31 cm
cm 5.45 / .in 9.17
Place precision filled LP gas tank upright into the notches in the right cart frame so the tank valve is facing the gas line connection.
Securing LP Gas Tank
Secure tank by sliding tank retainer wire over shoulder of LP gas tank.
Connecting LP Gas Tank
1. Before connecting, be sure there is no debris caught in the head of the LP gas tank, head of the regulator valve or in the head of the burner or burner ports.
2. Connect regulator/hose assembly to tank by turning knob clockwise until it stops.
Disconnecting LP Gas Tank
1. Before disconnecting, make sure the LP gas tank valve is “CLOSED.”
2. Disconnect regulator/hose assembly from LP gas tank by turning knob counterclockwise until it is loose.
WW CAUTION: LP gas tank must be properly disconnected and removed prior to moving this grill.
3.Place the protective cap cover on the LP tank and
store the tank outdoors in a well ventilated area out of direct sunlight.
Getting More Propane
Need a tank of gas? One option is to try propane exchange. It’s easy, fast, safe, and available at tens of thousands of conveniently located retail outlets nationwide, which are typically open nights and weekends. You can purchase a fresh, precision-filled tank or exchange your empty for a fresh, precision-filled tank. Another option is to have your tank refilled at a refill station. Be sure to check the hours of operation for the refill station.
Operating Instructions
Checking for Leaks
Burner Connections
1.Make sure the regulator valve and hose connections are securely fastened to the burner and the tank.
2.Visually check the connection between the burner/venturi tube and orifice.
3.Make sure the burner/venturi tube fits over the orifice.
WW WARNING: Failure to inspect this connection or follow these instructions could cause a fire or an explosion which can cause death, serious bodily injury or damage to property.
4.Please refer to diagram for proper installation (Figures 1 and 2).
5.If the burner/venturi tubedoes not rest flush to the orifice, as shown, please contact 1.800.762.1142 for assistance.
|
Figure 1 |
Back burner soft |
Burner |
pipe connection |
venturi |
|
pipe |
X
Valve |
|
soft pipe |
LP gas |
connection |
valve with |
|
orifice |
|
Figure 2 |
LP Gas Valve |
LP Gas |
with Orifice |
Connection |
Tank/Gas Line Connection
1.Make 2-3 oz. of leak detection solution by mixing one part liquid dishwashing soap with three parts water.
2.Make sure control knobs are in the “ OFF” position (Figure 3).
3.Connect LP gas tank per “Installing LP Gas Tank” section.
4.Turn LP gas tank valve to “OPEN.”
5.Spoon several drops of solution, or use a squirt bottle, at all “X” locations (Figures 1, 2 and 4).
a.If any bubbles appear, turn LP gas tank valve to “CLOSED,” reconnect and re-test.
b.If you continue to see bubbles after several attempts, turn LP gas tank valve to “CLOSED” and disconnect LP gas tank, per “Disconnect LP Gas Tank” section. Contact 1.800.762.1142 for assistance.
c.If no bubbles appear after one minute, turn LP gas tank valve to “CLOSED,” wipe away solution and proceed.
Valve
Soft Pipe
Connection
X
X
Burner venturi pipe
Figure 3
OFF
ARRÊT
Operating Main Burners
Figure 4
First Use
1.Make sure all labels, packaging and protective films have been removed from the grill.
2.Remove manufacturing oils before cooking on this
grill for the first time by operating the grill for at least 15 minutes on (HIGH) with the lid closed. This will “heat clean” the internal parts and dissipate odors.
Lighting
|
X |
|
X |
X |
X |
X |
|
|
|
|
WW CAUTION: Keep outdoor gas cooking appliance area clear and free from
combustible materials, gasoline and other flammable vapors and liquids.
WW CAUTION: Do NOT obstruct the flow of combustion and ventilation air. WW CAUTION: Check and clean burner/venturi tubes for insects and insect
nests. A clogged tube can lead to a fire.
WW CAUTION: Attempting to light the burner with the lid closed may cause an explosion.
1.Open lid.
2.Check for obstructions of airflow to the burners. Spiders, insects and webs can clog the burner/venturi tube. A clogged burner tube can lead to a fire.
3.All control knobs must be in the “ OFF” position (Figure 3).
4.Connect LP gas tank per “Installing LP Gas Tank” section.
5.Turn LP gas tank valve to “OPEN.”
6.Push and turn any control knob to (HIGH). The burner should light. If it does not, repeat up to three times.
7.If ignition does not occur in 5 seconds, turn burner control knob “ OFF,” wait 5 minutes, and repeat lighting procedure.
8.If igniter does not light burner, use a lit match secured with the lighting rod (included with grill) to light burners. Access the burners through the cooking grid and heat plates. Position lit match near side of burner (Figure 5).