Uniflame GAD920SP User Manual

Made from 75% Bagasse

(Environmentally Friendly Sugar Cane Pulp By-product)

WARNING

FOR YOUR SAFETY:

For Outdoor Use Only (outside any enclosure)

Do Not Use For Cooking.

WARNING

FOR YOUR SAFETY:

If the information in this manual is not followed exactly, a fire or explosion may result causing property damage, personal injury or loss of life.

WHAT TO DO IF YOU SMELL GAS:

•Do not try lighting any appliance.

•Do not touch any electrical switch; do not use any phone in your building.

•Immediately call your gas supplier from a neighbor’s phone.

•Follow the gas supplier’s instructions.

•If you cannot reach your gas supplier, call the fire department.

Installation and service must be performed by a qualified installer, service agency or gas supplier.

Save these instructions for future reference.

If you are assembling this unit for someone else, give this manual to him or her to read and save for future reference.

WARNING

FOR YOUR SAFETY:

Improper installation, adjustment, alteration, service or maintenance can cause injury or property damage.

Read the installation, operation and maintenance instructions thoroughly before installing or servicing this equipment.

DANGER

If you smell gas -

1.Shut off gas to appliance.

2.Extinguish any open flame.

3.Open lid.

4.If odor continues, keep away from the appliance and immediately call your gas supplier or your fire department.

WARNING

FOR YOUR SAFETY:

1.Do not store or use gasoline or other flammable liquids or vapors in the vicinity of this or any other appliance.

2.An LP cylinder not connected for use shall not be stored in the vicinity of this or any other appliance.

DANGER

Never operate this appliance unattended.

OWNER’S MANUAL

LP Gas Outdoor Fireplace

Model No. GAD920SP

DANGER	CARBON MONOXIDE HAZARD
	• This appliance can produce carbon
	monoxide which has no odor.
	• Using it in an enclosed space can kill you.
	• Never use this appliance in an enclosed
	space such as a camper, tent, car or home.

Table of Contents

Dangers and Warnings. . . . . . . . . . . . . . . . . . . . .		Page 2
Exploded View & Hardware . . . . . . . . . . . . . . . . . .	.	. .	4
Assembly Instructions . . . . . . . . . . . . . . . . . . . .	.	. .	5
Installing LP Gas Tank . . . . . . . . . . . . . . . . . . . .	.	. .	8
Insert LP Gas Tank . . . . . . . . . . . . . . . . . . . .	.	. .	8
Secure LP Gas Tank . . . . . . . . . . . . . . . . . . . .	.	.	. 8
Connect LP Gas Tank . . . . . . . . . . . . . . . . . . .	.	. .	8
Disconnect LP Gas Tank . . . . . . . . . . . . . . . . . .	.	. .	8
Operating Instructions . . . . . . . . . . . . . . . . . . . .	.	. .	9
Checking for Leaks . . . . . . . . . . . . . . . . . . . .	.	. .	9
Lighting . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
Turning Off. . . . . . . . . . . . . . . . . . . . . . . . . . . 9
Cleaning and Care . . . . . . . . . . . . . . . . . . . . . . . . . 9
Inspecting . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
Cleaning. . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
Storing . . . . . . . . . . . . . . . . . . . . . . . . . .	.	.	9
Product Registration . . . . . . . . . . . . . . . . . . . . .	.	.	10
Limited Warranty . . . . . . . . . . . . . . . . . . . . . . . . . 10
Troubleshooting . . . . . . . . . . . . . . . . . . . . . . .	.	.	11

The use and installation of this product must conform to local codes. In absence of local codes, use the latest edition of the National Fuel Gas Code, ANSI Z223.1/NFPA 54, or International Fuel Gas Code. This appliance, when installed, must be electrically grounded in accordance with local codes, or in the absence of local codes with the National Electrical Code, ANSI/NFPA 70, if applicable.

For installation in Canada - these instructions, while generally acceptable do not necessarily comply with the Canadian installation codes, particularly with piping above and below ground. In Canada the installation of this appliance must comply with local codes and/or standard CAN/ CGA B149.1 (installation code for propane burning appliances and equipment).

California Proposition 65: Chemicals known to the State of California to cause cancer, birth defects, or other reproductive harm are created by the combustion of propane.

Manufactured in China for: Blue Rhino Global Sourcing, Inc

Winston-Salem, NC 27105 USA • 1.800.762.1142, www.bluerhino.com

© Blue Rhino Global Sourcing, Inc. All Rights Reserved
UniFlame® is a Registered Trademark of Blue Rhino Global Sourcing, Inc. All Rights Reserved	GAD920SP-OM-104 E

LP Gas Outdoor Fireplace Model No. GAD920SP

DANGERS and WARNINGS: FOR YOUR SAFETY

DANGER: Failure to follow the dangers, warning and cautions in this manual may result in serious bodily injury or death, or in a fire or an explosion causing damage to property.

WARNING:

This appliance is for outdoor use only, and shall NOT be used in a building, garage or any other enclosed area.

Do NOT operate, light or use this appliance within ten (10) feet (3.05 m) of walls, structures or buildings.

For residential use only. This outdoor fireplace is NOT for commercial use.

This outdoor fireplace is safety certified for use in the United States and/ or Canada only. Do not modify for use in any other location. Modification will result in a safety hazard.

Do NOT use this outdoor fireplace for indoor heating. TOXIC carbon monoxide fumes can accumulate and cause asphyxiation.

Apartment Dwellers: Check with management to learn the requirements and fire codes for using an LP gas outdoor fireplace in your apartment complex. If allowed, use outside on the ground floor with a ten (10) foot (3.05 m) clearance from any structure. Do not use on or under balconies.

This outdoor fireplace is for use with liquid propane (LP) gas only. The conversion to or attempted use of natural gas in this outdoor fireplace is dangerous and will void your warranty.

LP gas is flammable and hazardous if handled improperly. Become aware of the characteristics before using any LP gas product.

a.LP gas is explosive under pressure, heavier than air, and settles and pools in low areas.

b.LP gas in its natural state has no odor. For your safety, an odorant is added that smells like rotten cabbage.

c.Contact with LP gas can cause freeze burns to skin.

LP gas tank needed to operate. Only tanks marked “propane” may be used.

a.The LP gas supply tank must be constructed and marked in accordance with the Specifications for LP gas LP gas tanks of the U.S. Department of Transportation (DOT) or the National Standard of Canada, CAN/CSA-B339, LP gas tanks, Spheres and Tubes for the Transportation of Dangerous Goods; and Commission.

b.LP gas tank must be arranged for vapor withdrawal.

c.The LP gas tank must have a listed overfilling prevention device (OPD) and a QCCI or Type I (CGA810) LP gas tank connection.

d.The LP gas tank must have a tank collar to protect the tank valve.

e.Never use an LP gas tank with a damaged body, valve, collar or footing.

f.Dented or rusted LP gas tanks may be hazardous and should be checked by your LP gas supplier prior to use.

g.The LP gas tank should not be dropped or handled roughly.

h.Tanks must be stored outdoors, out of the reach of children and must not be stored in a building, garage or any other enclosed area. Your LP gas tank must never be stored where temperatures can reach over 125°F.

i.Do not insert any tool or foreign object into the valve outlet or safety relief valve. You may damage the valve and cause a leak. Leaking propane may result in explosion, fire, severe personal injury or death.

j.Never keep a filled LP gas tank in a hot car or car trunk. Heat will cause the gas pressure to increase, which may open the relief valve and allow gas to escape.

k.Place dust cap on valve outlet whenever the LP gas tank is not in use. Only install the type of dust cap on the LP gas tank valve outlet that is provided with the LP gas tank valve. Other types of caps or plugs may result in leakage of propane.

l.Do not store a spare LP gas tank under or near this appliance.

m.Never fill the tank beyond 80 percent full.

Your outdoor fireplace has been checked at all factory connections for leaks. Recheck all connections as described in the “Operating

Instructions” section of this manual, as movement in shipping can loosen connections.

Check for leaks even if your unit was assembled for you by someone else.

Do not operate if gas leak is present. Gas leaks may cause a fire or explosion.

You must follow all leak-checking procedures before operating. To prevent fire or explosion hazard when testing for a leak:

a.Always perform leak test before lighting the outdoor fireplace and each time the tank is connected for use.

b.No smoking. Do not use or permit sources of ignition in the area while conducting a leak test.

c.Conduct the leak test outdoors in a well-ventilated area.

d.Do not use matches, lighters or a flame to check for leaks.

e.Do not use outdoor fireplace until any and all leaks are corrected.

If you are unable to stop a leak, disconnect the LP gas supply. Call a gas appliance serviceman or your local LP gas supplier.

Do not store or use gasoline or other flammable liquids or vapors within 25 feet (7.62 m) of this appliance.

Do not use in an explosive atmosphere. Keep outdoor fireplace area clear and free from combustible materials, gasoline and other flammable vapors and liquids.

This outdoor fireplace is NOT to be operated by children.

This outdoor fireplace is NOT to be used in or on boats or recreational vehicles.

Do NOT connect to a remote gas supply.

Never attempt to attach this outdoor fireplace to the self-contained LP gas system of a camper trailer, motor home or house.

Always use in accordance with all applicable local, state and national codes. Contact your local fire department for details on outdoor burning.

When using this outdoor fireplace, exercise the same precautions you would with any open fire.

The use of alcohol, prescription or non-prescription drugs may impair the consumer’s ability to properly assemble or safely operate this outdoor fireplace.

Do NOT use this outdoor fireplace without reading the entire “Owner’s Manual”.

Do NOT burn solid fuels such as: wood, charcoal briquets, lump charcoal, manufactured logs, driftwood, trash, leaves, paper, cardboard, plywood, painted or stained or pressure treated wood in this outdoor fireplace.

It is essential to keep the outdoor fireplace’s valve compartment, burners, and circulating air passages clean. Inspect outdoor fireplace before each use.

Do NOT use this outdoor fireplace until it is COMPLETELY assembled and all parts are securely fastened and tightened.

Do NOT use this outdoor fireplace near automobiles, trucks, vans or recreational vehicles.

Do NOT use this outdoor fireplace under any overhead or near any unprotected combustible constructions. Avoid using near or under overhanging trees and shrubs.

Always use this outdoor fireplace on a hard, level, non-combustible surface such a concrete, rock or stone. An asphalt or blacktop surface may not be acceptable for this purpose.

Do NOT use this outdoor fireplace for cooking.

Do NOT use this outdoor fireplace if any part has been under water. Immediately call a qualified service technician to inspect the appliance and to replace any part or control system and any gas control which has been under water.

Do NOT wear flammable or loose clothing when operating this outdoor fireplace.

Do NOT use in windy conditions.

Never lean over this outdoor fireplace when lighting or when in use.

Do NOT use this outdoor fireplace unless burner is securely in place.

Keep all electrical cords away from outdoor fireplace during use.

Certain areas of this outdoor fireplace when in use will become too hot to touch. To avoid burns, do not touch hot surfaces until the unit has cooled (about 45 minutes) unless you are wearing protective gear (insulated pot holder or heat resistant gloves or mittens).

Contact 1.800.762.1142 for assistance. Do not return to place of purchase.	page no.
	3

Do NOT leave a lit outdoor fireplace unattended, especially around children and pets.

Children and adults should be alerted to the hazards of high surface temperatures and should stay away to avoid burns or clothing ignition.

Young children should be carefully supervised when they are in the area of the appliance.

Clothing or other flammable materials should not be hung from the appliance or placed on or near the appliance.

Any guard or other protective device removed for servicing the appliance must be replaced prior to operating the appliance.

Cover must be removed when burner is in operation.

Do not attempt to move outdoor fireplace when in use. Allow the outdoor fireplace to cool before moving or storing.

This outdoor fireplace should be thoroughly cleaned and inspected on a regular basis. Clean and inspect the hose before each use of the

appliance. If there is evidence of abrasion, wear, cuts, or leaks, the hose must be replaced prior to the appliance being put into operation.

This outdoor fireplace should be inspected at least annually bu a qualified service person. Depending on amount of use, more frequent cleaning may be required. Do not operate until all parts have been repaired or replaced.

Use only the regulator and hose assembly provided. The replacement regulator and hose assembly shall be that specified by the manufacturer.

Use only Blue Rhino Global Sourcing, Inc factory authorized parts. The use of any part that is NOT factory authorized can be dangerous and will void your warranty.

Storage of this outdoor fireplace indoors is permissible only if the tank is disconnected, removed from the outdoor fireplace and properly stored outdoors.

Do not attempt to disconnect the gas regulator from the tank or any gas fitting while the outdoor fireplace is in use.

If the outdoor fireplace is not in use, the gas must be turned off at the supply tank.

The pressure regulator is set for 10.5 inches of water column (pressure).

The maximum inlet gas pressure for this outdoor fireplace is 11 inches of water column pressure.

Turn LP gas tank valve closed, disconnect gas regulator prior and during pressure testing of the gas supply piping system at test pressures equal to or less than 1/2 psi (3.5 kPa).

Do NOT sit on the mantle.

Do not throw anything onto the fire when the unit is in operation.

Fire logs and lava rock are very hot, keep the children or pets away at a safe distance.

The opening of the tank collar should face toward the door side for easy access.

Do NOT store any combustible materials in the base enclosure.

Use protective gloves when assembling this product.

Do not force parts together as this can result in personal injury or damage to the product.

Deaths, serious injury or damage to property may occur if the above is not followed exactly.

LP Gas Outdoor Fireplace Model No. GAD920SP

Parts List

			55-05-432
	1	Cement Log (4)	55-05-433
			55-05-434
			55-05-435
	2	Lava Rock	55-05-443
	3	Lava Rock Grid	55-05-444
	4	Side Panel (6)	58-10-000
	5	Bowl Assembly*	55-05-430
	6	Burner*	55-05-431
	7	Igniter*	55-05-441
	8	Control Knob*	55-05-436
	9	Regulator/Hose Assembly*	55-05-452
	10	Hearth	58-10-001
	11	Back Leg (2)	58-10-002
	12	Middle Support Leg (3)	58-10-003
	13	Tank Guard	55-05-458
	14	LP Gas Tank Retaining	55-05-447
		Chain
	15	LP Gas Tank Tray Peg	55-05-449
	16	Base Support Bar	58-10-004
	17	Left Front Leg	58-10-005
	18	Left Door	58-10-006
	19	Door Support Leg	58-10-007
	20	Right Door	58-10-008
	21	Right Front Leg	58-10-009
	22	Door Knob (2)*	58-10-010
	23	Base*	58-10-011
	24	LP Gas Tank Tray*	55-05-448
	25	LP Gas Tank Shield	55-05-458
	26	Cover (not shown)	55-05-693

* Pre-assembled

Exploded View

1

2

3

	4	6
		5
	4

	7
9	8	4

	25	4
10

			11
11		13	12	16
4		12
			14
4	12	15
			19	21
				20
23		17	18

24

22

	Hardware					Tools Required for Assembly (Included)
	A	Screw	M5x10 Black Nickel Plated Hex	9 pcs		M5 Allen Wrench
	B	Screw	M5x10 Black Nickel Plated Truss Head	68 pcs
	C	Screw	ø4x16 Black Nickel Plated Truss Head	2 pcs
	D	Wing Nut	ø5 Black Nickel Plated	3 pcs
	E	AA Battery	1.5 V AA Battery	1 pc
						Tools Required for Assembly (Not Included)
						#2 Phillips Head Screwdriver