Installation Instructions
®
Laundry Tubs
Models PFLT2123, PFLT2024 & PFLT4024
To ensure this product is installed properly, please read these instructions carefully before you begin. (Certain installations may require professional help.)
Also be sure your installation conforms to local codes.
1 |
Turn unit upside down and lay on protected surface. |
Slip notched end of leg into corner of tub as shown in DETAIL A. |
|
|
Slip notched end of leg into corner of tub as shown in DETAIL A. |
|
Seat leg carefully by setting a wood block onto leg and striking
Seat leg carefully by setting a wood block onto leg and striking with mallet or hammer.
with mallet or hammer.
LLEGG
|
BOTTOMOTT |
|
|
OFTUB |
|
|
Detail A |
|
|
DETAIL A |
|
2 |
Apply one leveling bolt on each leg as shown in DETAIL B. |
|
Stand tub upright. Adjust all four legs until unit is level. |
||
|
||
|
STEEL LEG |
|
|
LEVELING BOLT |
|
|
ANCHOR |
|
|
(FURNISHED BY OTHERS) |
Detail B
DETAIL B
Warranty
WHAT IS COVERED?
Ferguson Enterprises, Inc. “Ferguson” or the “Company” warrants its products to be free from defects in material and workmanship under normal use and service FOR A PERIOD OF ONE (1) YEAR FROM THE DATE OF INSTALLATION.
WHAT IS NOT COVERED?
The warranty set forth in paragraph 1 does not cover installation or any other labor charges and does not apply to products which have been damaged as a result of any accident, abuse, improper installation or maintenance, or modification of original plumbing product. The warranty of such products is limited to the warranty extended to Ferguson by the product manufacturer. Finally, FERGUSON SHALL NOT BE RESPONSIBLE OR LIABLE FOR ANY FAILURE OR DAMAGE TO THIS PRODUCT OR ANY COMPONENT THEREOF CAUSED BY THE USE OF ABRASIVE CLEANERS.
HOW TO OBTAIN WARRANTY SERVICE US Customers:
The purchaser should contact their local Ferguson location, installing contractor or builder from whom the product was purchased. To find you nearest Ferguson location please visit www.ferguson.com and enter in your address into the Find a Location field.
Canadian Customers:
The purchaser should contact their local Wolseley Canada location, installing contractor or builder from whom the product was purchased. To find your nearest Wolseley Canada location please visit www.wolseleyinc.ca, then click on Find a Location and enter your address into the location field.
PROFLO is a registered trademark of Ferguson Enterprises, Inc.
LIMITATIONS OF IMPLIED WARRANTY AND DISCLAIMER OF CONSEQUENTIAL OR INCIDENTAL DAMAGES FERGUSON DISCLAIMS ANY LIABILITY FOR CONSEQUENTIAL OR INCIDENTAL DAMAGES AND DISCLAIMS ALL EXPRESS OR IMPLIED WARRANTIES, INCLUDING THOSE OF MERCHANTABILITY AND FITNESS FOR A PARTICULAR PURPOSE, AS SET FORTH ABOVE. IMPLIED WARRANTIES OF THE PRODUCTS AND PRODUCT COMPONENTS SET FORTH IN PARAGRAPH 1 ABOVE ARE LIMITED TO THE DURATIONS OF THE RESPECTIVE WARRANTY. Some states do not allow the exclusion or limitation of incidental or consequential damages or limitations on how long an implied warranty lasts, so the above limitations may not apply to you. This warranty gives you specific legal rights and you may also have other rights, which vary from state to state.
|
Distributed Exclusively by Ferguson and Wolseley Canada |
© 2012 Ferguson Enterprises, Inc. All Rights Reserved |
10643 02/12 |
Installation Instructions
®
Laundry Tubs
Models PFLT2123, PFLT2024 & PFLT4024
Drain Assembly and Packing Lists
IMPORTANT NOTICE: The Gasket / Washers supplied with the drain assembly should provide adequate water seal. If additional protection is desired, use ONLY Teflon Tape. Use of Plumbers Putty may adversely affect the structural integrity of the Drain Assembly and will void the warranty.
|
DRAIN ASSEMBLY |
||
|
PFLT4024 |
||
|
STOPPER |
|
|
NOTE: APPLY |
DRAIN |
NOTE: APPLY |
|
NOTE: |
|
NOTE: |
|
TEFLON TAPE |
|
TEFLON TAPE |
|
APPLY TEFLON |
|
APPLY TEFLON |
|
TAPE BEFORE |
TUB |
TAPE BEFORE |
|
INSTALLATIONATION |
INSTALLATION |
||
|
|||
|
RUBBERrubberWASHERwasher |
||
|
drainDRAIN NUTnut |
|
|
|
TAIL PIECE WASHER |
||
|
TWINTUBTUB |
||
|
WASTE ASSEMBLY |
||
|
WASTE ASSEMBLY |
||
|
|
PIPIPE |
|
|
(SUPPLIED BY OTHERS) |
||
QTY |
DESCRIPTION |
1 |
Laundry Tub |
|
|
4 |
Painted Steel Legs |
|
|
4 |
Carriage Bolts |
|
|
8 |
1/4" - 20 Hexnuts |
|
|
2 |
Stoppers |
|
|
2 |
Tail Piece Washers |
|
|
2 |
Tail Piece Nuts |
|
|
2 |
Drains |
|
|
2 |
Rubber Washers |
|
|
2 |
Drain Washers |
|
|
1 |
Waste Pipe Assembly |
|
|
1 |
Installation Manual |
DRAINASSEMBLY
PFLT2024
STOPPER
|
TUB |
NOTE: APPLY |
|
NOTE: |
|
APPLYTEFLONTEFLONTAPE |
|
TAPE BEFORE |
|
ATION |
|
INSTALLATION |
TAIIL PIECE WASHER |
|
TAIL PIIECE NUT |
|
|
|
|
|
|
|
|
|
|
|
|
|
PIPE |
|
|
|
|
|
|
|
|
BY |
|
|
|
|
|
|
(SUPPLIED BYOTHERS) |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
||
QTY |
|
|
|
DESCRIPTION |
|
||
1 |
|
Laundry Tub |
|
||||
1 |
|
Laundry Tub |
|
||||
4 |
|
PaintedSteel Legs |
|
||||
4 |
|
|
|||||
4 |
|
CarriageriageBolts |
|
||||
4 |
|
|
|||||
8 |
|
1/4" - 20 H |
|
||||
8 |
|
1/4" - 20 Hexnuts |
|
||||
1 |
|
Stopper |
|
||||
|
|
|
|
||||
1 |
|
Tail Piece Washer |
|
||||
|
|
|
|
||||
1 |
|
Tail Piece Nut |
|
||||
|
|
|
|
||||
1 |
|
Installation Manual |
|
||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
DRAIN ASSEMBLY
PFLT2123
NOTE: APPLY
NOTE:
TEFLON TAPE
APPLY TEFLON TAPE BEFORE
INSTALLATION
STOPPER
DRAIN
TUB
RUBBERrubberWASHERwasher
drainDRAIN NUTnut |
TAIL PIECE WASHER |
TAIL PIECE NUT |
|
|
|
|
|
PIPE |
|
|
|
|
|
|
|
|
(SUPPLIEI D BY OTHERS) |
|
||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
QTY |
|
|
DESCRIPTION |
|
||||
1 |
|
|
|
Tub |
|
|||
1 |
|
Laundry Tub |
|
|||||
4 |
|
PaintedSteel Legs |
|
|||||
4 |
|
|
||||||
4 |
|
CarrriageBolts |
|
|||||
4 |
|
|
||||||
88 |
|
1/4"--20HHexnuts |
|
|||||
1 |
|
Stopper |
|
|||||
|
|
|
|
|
|
|
||
1 |
|
Tail Piece Washer |
|
|||||
|
|
|
|
|
|
|
||
1 |
|
Tail Piece Nut |
|
|||||
|
|
|
|
|
|
|
||
1 |
|
Drain |
|
|||||
|
|
|
|
|
|
|
||
1 |
|
Rubber Washer |
|
|||||
|
|
|
|
|
|
|
||
1 |
|
Drain Washers |
|
|||||
|
|
|
|
|
|
|
||
1 |
|
Installation Manual |
|
|||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
Distributed Exclusively by Ferguson and Wolseley Canada |
© 2012 Ferguson Enterprises, Inc. All Rights Reserved |
10643 02/12 |