Départ. Technical supportCM640 |
PROCEDURE |
COMPANY RESTRICTED |
|
|
|
|
|
PHILIPS Consumer |
Service Repair Support |
VY-V-640-120-2 |
|
Communications |
|
|
|
|
|
Page : 1 of 45 |
|
|
|
|
|
Centre du Mans |
|
|
Language : EN |
|
|
|
Date : 23/04/02 |
|
|
|
|
|
|
|
|
SERVICE MANUAL
Repair for Cellular Telephone
LEVEL2
Fisio 120 VOICE
& Fisio 121 W@P
PHILIPS ELECTRONICS N.V. 1999 |
VY-V-640- |
All rights reserved. Reproduction in whole or in part is prohibited without the written consent of the copyright owner.
Départ. Technical supportCM640 |
PROCEDURE |
COMPANY RESTRICTED |
|
|
|
|
|
PHILIPS Consumer |
Service Repair Support |
VY-V-640-120-2 |
|
Communications |
|
|
|
|
|
Page : 2 of 45 |
|
|
|
|
|
Centre du Mans |
|
|
Language : EN |
|
|
|
Date : 23/04/02 |
|
|
|
|
|
|
|
|
SERVICE Manual
Last updates :
|
DATE |
MODIFICATION |
PAGE |
|
|
|
|
|
|
23/04/02 |
CREATION |
|
|
|
|
|
|
|
|
25/11/02 |
New Data Connect Cable Part No |
4 |
|
|
|
|
Add RF Pliers Part No |
4 |
|
|
|
Suppress of Component list |
44 - 45 - 46 |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
PHILIPS ELECTRONICS N.V. 1999 |
VY-V-640- |
All rights reserved. Reproduction in whole or in part is prohibited without the written consent of the copyright owner.
Départ. Technical supportCM640 |
PROCEDURE |
COMPANY RESTRICTED |
||||
|
|
|
|
|
||
|
PHILIPS Consumer |
|
Service Repair Support |
VY-V-640-120-2 |
||
|
Communications |
|
|
|
||
|
|
|
|
Page : 3 of 45 |
||
|
|
|
|
|
|
|
|
|
Centre du Mans |
|
|
|
Language : EN |
|
|
|
|
|
|
Date : 23/04/02 |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
CONTENTS |
|
|
1.0 |
|
PURPOSE ......................................................................................................................................................................... |
|
|
4 |
|
2.0 |
|
SCOPE............................................................................................................................................................................... |
|
|
4 |
|
3.0 |
|
REFERENCE ................................................................................................................................................................... |
|
|
4 |
|
4.0 |
|
GLOSSARY/ACRONYM LIST...................................................................................................................................... |
|
|
4 |
|
5.0 |
TEST EQUIPMENT AND TOOLS |
................................................................................................................................ |
|
4 |
||
6.0 |
TEST AND INSPECTION PLAN................................................................................................................................... |
|
|
5 |
||
6.1 |
User Interface Test ......................................................................................................................................................... |
|
|
5 |
||
6.2 |
RF Test ........................................................................................................................................................................... |
|
|
5 |
||
7.0 |
|
BEFORE STARTING...................................................................................................................................................... |
|
|
6 |
|
7.1 |
Description Of The Transceiver ..................................................................................................................................... |
|
|
6 |
||
7.2 |
Description Of The Display............................................................................................................................................ |
|
|
7 |
||
7.3 |
Using The Carousel ........................................................................................................................................................ |
|
|
8 |
||
7.4 |
Removing The Battery ................................................................................................................................................... |
|
|
9 |
||
7.5 |
Inserting The Micro SIM-Card....................................................................................................................................... |
|
|
9 |
||
7.6 |
Inserting The Battery...................................................................................................................................................... |
|
|
9 |
||
7.7 |
Attach The Battery Cover............................................................................................................................................. |
|
|
10 |
||
7.8 |
Charging The Battery ................................................................................................................................................... |
|
|
10 |
||
7.9 |
Customise your Phone.................................................................................................................................................. |
|
|
11 |
||
7.10 |
W@P Introduction........................................................................................................................................................ |
|
|
13 |
||
8.0 |
|
TEST PROCEDURES ................................................................................................................................................... |
|
|
15 |
|
8.1 |
Initial Functional Check for Fisio 120 ....................................................................................Voice “1 Meg version” |
|
15 |
|||
8.2 |
Initial Functional Check for Fisio 121 ......................................................W@P & Fisio 120 Voice “2Meg version” |
19 |
||||
8.3 |
RF Test ......................................................................................................................................................................... |
|
|
23 |
||
8.4 |
Battery Charging (IGN : Ignition) / ..........................................................................................Current Consumption |
|
27 |
|||
8.5 |
W@P Test Procedure ................................................................................................................................................... |
|
|
29 |
||
9.0 ASSEMBLY/DISMANTLEMENT PROCEDURES......................................................................................................... |
|
35 |
||||
9.1 |
Dismantlement Procedure ............................................................................................................................................ |
|
|
35 |
||
9.2 |
Assembly Procedure..................................................................................................................................................... |
|
|
39 |
||
9.3 |
Exploded view of the transceiver ................................................................................................................................. |
|
|
42 |
||
10 SOLUTIONS IN CASE OF PROBLEMS DURING THE TESTS ...................................................................................... |
|
43 |
||||
ANNEX 1..................................................................................................................................................................................... |
|
|
45 |
PHILIPS ELECTRONICS N.V. 1999 |
VY-V-640- |
All rights reserved. Reproduction in whole or in part is prohibited without the written consent of the copyright owner.
Départ. Technical supportCM640 |
PROCEDURE |
COMPANY RESTRICTED |
|
|
|
|
|
PHILIPS Consumer |
Service Repair Support |
VY-V-640-120-2 |
|
Communications |
|
|
|
|
|
Page : 4 of 45 |
|
|
|
|
|
Centre du Mans |
|
|
Language : EN |
|
|
|
Date : 23/04/02 |
|
|
|
|
|
|
|
|
1.0PURPOSE
This document establishes the functional test and inspection procedures for the first level service repair of the FISIO 120/121 transceivers.
2.0SCOPE
The test plan is applicable to all levels of service repair of the FISIO 120/121 transceivers.
3.0REFERENCE
None.
4.0GLOSSARY/ACRONYM LIST
Board |
Transceiver Without LCD and Plastics parts |
LCD Module |
LCD part with plastic cover, earpiece and vibrator |
SW |
Software |
PN |
Hardware Configuration of the Mobile |
CN |
Matrix for Types of SW used on the different hardware |
HW |
Hardware |
ASC |
Authorized Service Center |
NSC |
National Service Center |
Test SIM Card |
Used for functionality of PHILIPS Mobile Phones |
Test SIM Card « SP » |
SIM Card used to simulate the user interface and enable radio tests |
5.0TEST EQUIPMENT AND TOOLS
Equipment / Tools |
|
- Test SIM Card « Production » |
- Part No. : 4311 255 00781 |
- Test SIM Card « SP » |
- Part No. : 4311 255 00782 |
- Data Connect Cable |
- Part No. : 4311 258 10392 |
- Fisio 120 Mat Software provided by Philips |
|
- Digital Multimeter |
- Recommended Model : Fluke |
|
Specification with current reading in mA. |
-Digital Radiocommunication Tester.
-Coupling system with shielded chamber
or |
|
- RF Pliers With mechanical adaptation |
- Part No.: 4311 255 30041 |
PHILIPS ELECTRONICS N.V. 1999 |
VY-V-640- |
All rights reserved. Reproduction in whole or in part is prohibited without the written consent of the copyright owner.
Départ. Technical supportCM640 |
PROCEDURE |
COMPANY RESTRICTED |
|
|
|
|
|
PHILIPS Consumer |
Service Repair Support |
VY-V-640-120-2 |
|
Communications |
|
|
|
|
|
Page : 5 of 45 |
|
|
|
|
|
Centre du Mans |
|
|
Language : EN |
|
|
|
Date : 23/04/02 |
|
|
|
|
|
|
|
|
6.0TEST AND INSPECTION PLAN
The test plan is derived from the Product Test Reference of FISIO 120/121.
6.1User Interface Test
Use the Test SIM Card « SP » to test the transceivers as follows :
On/Off button
LCD Backlight
Keyboard Test
Buzzer Test
Vibrator Test
Audio Test
LCD
IMEI
Tester Status/Eeprom Status
With a fast Charger connected with the PRODUCT’s bottom connector , check the full scrolling from one mode to the next when charging IGN (Ignition) – Battery.
6.2RF Test
The radio test must be performed with a Digital Radio Test Set. The mobile has to be set on the antenna coupler inside the shielded chamber.
PHILIPS ELECTRONICS N.V. 1999 |
VY-V-640- |
All rights reserved. Reproduction in whole or in part is prohibited without the written consent of the copyright owner.
Départ. Technical supportCM640 |
PROCEDURE |
COMPANY RESTRICTED |
|
|
|
|
|
PHILIPS Consumer |
Service Repair Support |
VY-V-640-120-2 |
|
Communications |
|
|
|
|
|
Page : 6 of 45 |
|
|
|
|
|
Centre du Mans |
|
|
Language : EN |
|
|
|
Date : 23/04/02 |
|
|
|
|
|
|
|
|
7.0BEFORE STARTING
7.1Description Of The Transceiver
PHILIPS ELECTRONICS N.V. 1999 |
VY-V-640- |
All rights reserved. Reproduction in whole or in part is prohibited without the written consent of the copyright owner.
Départ. Technical supportCM640 |
PROCEDURE |
COMPANY RESTRICTED |
|
|
|
|
|
PHILIPS Consumer |
Service Repair Support |
VY-V-640-120-2 |
|
Communications |
|
|
|
|
|
Page : 7 of 45 |
|
|
|
|
|
Centre du Mans |
|
|
Language : EN |
|
|
|
Date : 23/04/02 |
|
|
|
|
|
|
|
|
7.2Description Of The Display
PHILIPS ELECTRONICS N.V. 1999 |
VY-V-640- |
All rights reserved. Reproduction in whole or in part is prohibited without the written consent of the copyright owner.
Départ. Technical supportCM640 |
PROCEDURE |
COMPANY RESTRICTED |
|
|
|
|
|
PHILIPS Consumer |
Service Repair Support |
VY-V-640-120-2 |
|
Communications |
|
|
|
|
|
Page : 8 of 45 |
|
|
|
|
|
Centre du Mans |
|
|
Language : EN |
|
|
|
Date : 23/04/02 |
|
|
|
|
|
|
|
|
7.3Using The Carousel
The carousel is a circular loop of icons displayed on the screen. These icons provide access to the different menus and sub menus used to operate your phone.
PHILIPS ELECTRONICS N.V. 1999 |
VY-V-640- |
All rights reserved. Reproduction in whole or in part is prohibited without the written consent of the copyright owner.
Départ. Technical supportCM640 |
PROCEDURE |
COMPANY RESTRICTED |
|
|
|
|
|
PHILIPS Consumer |
Service Repair Support |
VY-V-640-120-2 |
|
Communications |
|
|
|
|
|
Page : 9 of 45 |
|
|
|
|
|
Centre du Mans |
|
|
Language : EN |
|
|
|
Date : 23/04/02 |
|
|
|
|
|
|
|
|
7.4Removing The Battery
7.5Inserting The Micro SIM-Card
7.6Inserting The Battery
PHILIPS ELECTRONICS N.V. 1999 |
VY-V-640- |
All rights reserved. Reproduction in whole or in part is prohibited without the written consent of the copyright owner.
Départ. Technical supportCM640 |
PROCEDURE |
COMPANY RESTRICTED |
|
|
|
|
|
PHILIPS Consumer |
Service Repair Support |
VY-V-640-120-2 |
|
Communications |
|
|
|
|
|
Page : 10 of 45 |
|
|
|
|
|
Centre du Mans |
|
|
Language : EN |
|
|
|
Date : 23/04/02 |
|
|
|
|
|
|
|
|
7.7Attach The Battery Cover
7.8Charging The Battery
PHILIPS ELECTRONICS N.V. 1999 |
VY-V-640- |
All rights reserved. Reproduction in whole or in part is prohibited without the written consent of the copyright owner.
Départ. Technical supportCM640 |
PROCEDURE |
COMPANY RESTRICTED |
|
|
|
|
|
PHILIPS Consumer |
Service Repair Support |
VY-V-640-120-2 |
|
Communications |
|
|
|
|
|
Page : 11 of 45 |
|
|
|
|
|
Centre du Mans |
|
|
Language : EN |
|
|
|
Date : 23/04/02 |
|
|
|
|
|
|
|
|
7.9Customise your Phone
PHILIPS ELECTRONICS N.V. 1999 |
VY-V-640- |
All rights reserved. Reproduction in whole or in part is prohibited without the written consent of the copyright owner.
Départ. Technical supportCM640 |
PROCEDURE |
COMPANY RESTRICTED |
|
|
|
|
|
PHILIPS Consumer |
Service Repair Support |
VY-V-640-120-2 |
|
Communications |
|
|
|
|
|
Page : 12 of 45 |
|
|
|
|
|
Centre du Mans |
|
|
Language : EN |
|
|
|
Date : 23/04/02 |
|
|
|
|
|
|
|
|
PHILIPS ELECTRONICS N.V. 1999 |
VY-V-640- |
All rights reserved. Reproduction in whole or in part is prohibited without the written consent of the copyright owner.
Départ. Technical supportCM640 |
PROCEDURE |
COMPANY RESTRICTED |
|
|
|
|
|
PHILIPS Consumer |
Service Repair Support |
VY-V-640-120-2 |
|
Communications |
|
|
|
|
|
Page : 13 of 45 |
|
|
|
|
|
Centre du Mans |
|
|
Language : EN |
|
|
|
Date : 23/04/02 |
|
|
|
|
|
|
|
|
7.10 W@P Introduction |
|
|
|
The purpose of W@p (Wireless Application Protocol) is to enable easy and fast delivery of relevant information and services to mobile users. However, mobile Internet does not mean navigating on the Internet with a wireless device but rather to access to some services in a mobile context.
The W@P architecture was designed to enable standard Internet servers to provide services to wireless devices. The W@P wireless protocol is based on Internet standards such as HTTP and TLS but has been optimized
according to the constraints |
of the wireless terminals: low memory capacity, small screen size |
and |
of the network: limited bandwidth. |
The W@P architecture is made up of 4 technological parts which are necessary for accessing W@P services on a mobile phone. These are:
W@P navigator or browser Mobile operator network W@P gateway / W@P server Web server
Customer |
Gateway |
Server |
1.0 Encoded |
Encoder/ |
2.0 Request |
Request |
Decoder |
|
|
|
Content |
|
|
Generation |
4.0 Encoded |
3.0 Answer |
Answer
* Subscription
The customer has to contact his Network Operator to inquire about his subscription and the options he can subscribe to. Generally the customer just have to request his W@P access to his provider and he will not be charged for that.
PHILIPS ELECTRONICS N.V. 1999 |
VY-V-640- |
All rights reserved. Reproduction in whole or in part is prohibited without the written consent of the copyright owner.
Départ. Technical supportCM640 |
PROCEDURE |
COMPANY RESTRICTED |
|
|
|
|
|
PHILIPS Consumer |
Service Repair Support |
VY-V-640-120-2 |
|
Communications |
|
|
|
|
|
Page : 14 of 45 |
|
|
|
|
|
Centre du Mans |
|
|
Language : EN |
|
|
|
Date : 23/04/02 |
|
|
|
|
|
|
|
|
* W@P parameters
Parameters have to be set in the mobile phone in order to access W@P services . However, there are two cases depending on the commercial offer:
*Transceiver sold via an operator package(with subscription included):
-Parameters cannot be accessed from the W@P settings menu of the mobile phone: The transceiver is W@P locked. The W@P connections will always be made from the operator W@P homepage and search engines will be available. The customer will have to ask for a password from his/her operator to unlock the W@P settings.
-Parameters can be accessed from the W@P settings menu of the mobile
phone:
The customer changes the W@P parameters according to his/her own convenience.
*Retail transceiver(without subscription included):
-Phones are configured by the manufacturer with no W@P parameter. The end user has to ensure that the W@P functionalities and a data/fax options have been subscribed. The end user has also to set the W@P parameters by asking for them from
his/her operator or by using parameters of another company (available on Internet, newspaper etc.)
Detailed parameters
Phone Number (or dial-up number) : to establish a connection with the Internet Service Provider
Login (or User Name) |
: if requested by your ISP |
The password |
: if requested by your ISP |
IP address for the Gateway |
: for communications between Internet Service Provider and Gateway |
& Port Number (for a secure or non secure connection)
Home page address(or URL address): for communications between Gateway and Web server
Please note that it is important to respect small and capital letters according to your operator instructions. It is also possible that your provider does not require the Login and/or Password.
PHILIPS ELECTRONICS N.V. 1999 |
VY-V-640- |
All rights reserved. Reproduction in whole or in part is prohibited without the written consent of the copyright owner.