Peerless-AV HCC201 Installation

HCC101, HCC201

40 lb

MAX

(18 kg)

1

2012-09-20 #:009-9075-1

WARNING

ENG - Do not begin to install your Peerless product until you have read and understood the instructions and

warnings contained in this Installation Sheet. If you have any questions regarding any of the instructions
or warnings, for US customers please call Peerless customer care at 1-800-865-2112, for all international
customers, please contact your local distributor.

• This product should only be installed by someone of good mechanical aptitude, and fully understands
these instructions.

• Never exceed the Maximum Load Capacity on page 1.

• Always use an assistant or mechanical lifting equipment to safely lift and position equipment.

• Tighten screws fi rmly, but do not overtighten. Overtightening can damage the items, greatly reducing their
holding power.

• The cart is not affi xed or secured to the fl oor, and may therefore tip over and/or fall if display and/or stand
is shaken or hit. Always monitor children and do not let children play alone around stand as they could get
hurt by a falling display. Not recommended for use in areas with heavy traffi c.

• This product is intended for indoor use only. Use of this product outdoors could lead to product failure and
personal injury.

Recommended cleaning steps

• The following procedures are not guaranteed to control infection. The hospital infection control administra­tor or epidemiologist should be consulted regarding cleaning procedures and processes.

• To avoid risk of electric shock, do not expose electrical components to water, cleaning solutions or other
potentially corrosive liquids or substances.

• Do not immerse cart or cart components in liquid or allow liquids to fl ow into the cart. Wipe all cleaners off
surface immediately using a damp cloth. Thoroughly dry surface after cleaning.

• Do not use fl ammable cleaners on cart surfaces due to close proximity of electrical power and equipment.

• All paints and plastic cart components will withstand cleaning by most commonly used, diluted, non­abrasive solutions such as quaternary ammonia compounds, ammonia enzyme cleaners, bleach or alcohol
solutions.

• Pen and permanent and dry erase markers can be removed with 91% isopropyl alcohol and a soft cloth.

• Iodine stains can be removed with commonly used cleaners and a soft cloth.

• Never use steel wool or other abrasive materials that will damage the surface fi nish.

• Do not use strong solvents such as trichloroethylene and acetone. These solvents will damage the
surface fi nish.

• It is recommended that any cleaning solution be tested on a small, inconspicuous area to ensure surface is
not harmed.

ENG

Symbols

Do not overtighten screws.

ENG

ENG

#

Skip to step.

ENG

WARNING

ENG

Tools Needed for
Assembly

x3

ENG

Screws must get at least three
full turns and fi t snug.

2

2012-09-20 #:009-9075-1

A

ENG

Parts (Before beginning, make sure you have all parts shown below)

Parts List

Description Qty

main assembly
iPad® kit adapter bracket

B
C

iPad® kit adapter plate
security lock 1 565-0066 565-0066

D

battery

E
F scanner bracket 1 009-S7479 009-S7479

G

iPad® cable

H battery key 1 not included

*These items may be purchased separately

(1)

A

main assembly

Tablet not included

HCC101 HCC201
Part # Part #

009-S7610 009-S7598

1
1 009-S7615 009-S7615
1 009-S7615 009-S7615

3 not included* HCACC401

1 not included* HCACC102

(1)

B

adapter bracket

(1)

D

security lock

(1)

C

adapter plate

(3)

E

battery

(1)

F

scanner bracket

(1)

H

battery key

3

2012-09-20 #:009-9075-1

G

(1)

cable

Lock brakes before making adjustments

ENG

1

C

C

2 3

B

C

ENG

Tighten.

4

ENG

Tighten.

B

2012-09-20 #:009-9075-1

4

A

4a

The calibration settings for column tension are designed to work

ENG

with most confi gurations. If column tension needs to be adjusted
then follow steps below.

CAUTION

Adjust tension with normal load on tray. Over

ENG

tensioning of the column could make it diffi cult
to adjust.

A

5

2012-09-20 #:009-9075-1

5

D

D

6a 6b

A

A

D

Loosen, Adjust, Tighten.

ENG

6

2012-09-20 #:009-9075-1

7

H

E (3)

8

ENG

Push button to check power level.

E (3)

ENG

needs charging

ENG

9

E (3)

Fully chargedBattery low,

7

2012-09-20 #:009-9075-1

10

G

10a

G

8

2012-09-20 #:009-9075-1

11

12

Remove screw to remove keyboard tray

ENG

F

9

2012-09-20 #:009-9075-1

ENG

This page intentionally left blank.

10

2012-09-20 #:009-9075-1

LIMITED WARRANTY

Peerless Industries, Inc. (“Peerless-AV
free from defects in material and workmanship, under normal use, for the periods listed below, from the date of purchase by the original
end-user. At its option, Peerless-AV® will repair or replace with new or refurbished products or parts, or refund the purchase price of any
Peerless-AV® product which fails to conform with this warranty.

In no event shall the duration of any implied warranty of merchantability or fi tness for a particular purpose be longer than the
period of the applicable express warranty set forth above. Some states do not allow limitations on how long an implied warranty lasts,

so the above limitation may not apply to you.
This warranty does not cover damage caused by (a) service or repairs by the customer or a person who is not authorized for such service

or repairs by Peerless-AV
to follow Peerless-AV®’s instructions or warnings when installing, using or storing the product, or (d) misuse or accident, in transit or
otherwise, including in cases of third-party actions and force majeure. This warranty also does not cover corrosion or rust resulting from
damaged, scratched or chipped paint or other surfaces.

In no event shall Peerless-AV
product, whether or not secured by a security device which may be included with the Peerless-AV® product. Some states do not

allow the exclusion or limitation of incidental or consequential damages, so the above limitation or exclusion may not apply to you.
This warranty is in lieu of all other warranties, express or implied, and is the sole remedy with respect to product defects. No dealer,

distributor, installer or other person is authorized to modify or extend this Limited Warranty or impose any obligation on Peerless-AV
connection with the sale of any Peerless-AV® product.

®

, (b) the failure to utilize proper packing when returning the product, (c) incorrect installation or the failure

®

”) warrants to original end-users of Peerless-AV® products that Peerless-AV® products will be

®

be liable for incidental or consequential damages or damages arising from the theft of any

®

in

This warranty gives specifi c legal rights, and you may also have other rights which vary from state to state.

Product
Mounts
Furniture
Cables
Cleaning Products
Electronic Products and components

Warranty Period
5 years
1 year
25 years
1 year
1 year

11

2012-09-20 #:009-9075-1

Peerless-AV

2300 White Oak Circle
Aurora, IL 60502
Email: [e-mail]
Ph: [phone]
Fax: [phone]
www.peerless-av.com

© 2012, Peerless Industries, Inc.

Peerless-AV Europe

Unit 3 Watford Interchange,
Colonial Way, Watford, Herts,
WD24 4WP, United Kingdom
Customer Care
44 (0) 1923 200 100
www.peerless-av.com

© 2012, Peerless Industries, Inc.

Peerless-AV de Mexico

Ave de las Industrias 413
Parque Industrial Escobedo
Escobedo N.L Mexico 66050
Servicio al Cliente
01-800-849-65-77
www.peerless-av.com

© 2012, Peerless Industries, Inc.