Onkyo TXNR-616 Service Manual
AV RECEIVER
MODEL TX-NR616(B)/(S)
TX-NR616
Ref. No. 4390
042012
North American and Taiwanese models ---> “MUSIC OPTIMIZER”
European, Australian and Asian models ---> “PURE AUDIO”
Black and Silver models
B MDC, B MDF
B MMQ, B MMR
B MMP, B MMB, B MMA, S MMP
North American and Taiwanese models ---> “DIMMER”
European, Australian and Asian models ---> “RT/ PTY/ TP”
120V AC, 60Hz
220-240V AC, 50/60Hz
220-240V AC, 50Hz
RC-837M
SERVICE PROCEDURE-1
1. Replacing the fuses
This symbol located near the fuse indicates that the
fuse used is slow operating type, For continued protection against
fire hazard, replace with same type fuse, For fuse rating, refer to
the marking adjacent to the symbol.
Ce symbole indique que le fusible utilise est e lent.
Pour une protection permanente, n'utiliser que des fusibles de meme
type. Ce demier est indique la qu le present symbol est apposre.
REF NO. PART NAME DESCRIPTION PART NO. REMARKS
F6401
F6402
F9002
F9002 or
F9002
F9002 or
F201
F9001
<Notes>
<MDC> : 120V,Canadian model
<MDF> : 120V,Taiwanese model
<MMP> : 220-240V,CE(European) country model
<MMA> : 220-240V,Australian model
<MMB> : 220-240V,UK model
<MMQ> : 220-240V,Hong kong model
<MMR> : 220-240V,Chinese model
FUSE
FUSE
FUSE
FUSE
FUSE
FUSE
FUSE
FUSE
12A-TUL-250V
12A-TUL-250V
10A-UL/T-233
10A-T/UL-ST2
5A-SE-EAK
5A-SE-TL250V
4A-SEUL-TL250V
1A-SEUL-TL250V
252301GR
252301GR
252330GR
252333GR
252078GR
252278GR
252392T
252397T
!
!
!
<MDC, MDF>
!
<MDC, MDF>
!
<MMA, MMB, MMP, MMQ, MMR >
!
<MMA, MMB, MMP, MMQ, MMR>
!
!
TX-NR616
2. Safety check out
(U.S.A. model only)
After correcting the original service problem, perform the following safety check before releasing the unit to the customer.
Leakage current Check
Measure the leakage current to a known earth ground (water pipe or conduct etc.) by connecting a leakage current
tester between the earth ground and exposed metal parts of the unit (input/output ground terminals, screw heads or metal overlays etc.).
Plug the power supply cord directly into a 120Vac 60Hz wall socket and turn ON/STANDBY button on.
Any current measured must not exceed 0.5mA.
3. To initialize the unit
1. Press ON/STANDBY button while pressing down CBL/SAT button when the unit is POWER ON, then the FL displays
"CLEAR", and turn to STAND-BY.
Preset memory and each mode stored in the memory, are initialized and will return to the factory settings.
2. Remove power cord from wall outlet.
ON/STANDBY
Clear
Stand-by
CBL/SAT
SERVICE PROCEDURE-2
4. To check version of each Firmware
1. Press ON/STANDBY (Power On)
2. Press DISPLAY + ON/STANDBY.
TX-NR616
M1.10/1 2 6 1 4 A E
3. Press (Tone) ---> Forward
Press (TONE) ---> Reversed.
(TONE)
(TONE)
M1.10/1 2 6 1 4 A E
D1.06/1 2 6 0 5 A EA
(TONE)
V1.05/1 2 5 1 5 A E
(TONE)
FW Version of Main Microprocessor displayed
only for 3 seconds.
FW Version displayed
only for 3 seconds.
Main Microprocessor
(TONE)
DSP
(TONE)
HDMI/Video Microprocessor
(TONE)
4. Press ON/STANDBY (Power Off).
K1.03/1 2 3 0 9 A EO
(TONE) (TONE)
VSP (Video Signal Processor)
(TONE)
DISPLAYON/STANDBY
SERVICE PROCEDURE-3
5. Notes on repairs (Power supply board)
Some parts on BAPS-1120 may remain high voltages
even after the power cord is disconnected from AC power source.
Before starting repair and any other work , please discharge C9002 by connecting resistors between its terminals. See the figure below
(recommended resistor spec: 5 k ohms/ 10W)
It is dangerous to touch the "HIGH VOLTAGE PRIMARY" area surrounded by white lines without discharging.
U0080
POWER SUPPLY(PRI) PC BOARD ASS'Y
BAPS-1120
Top
TX-NR616
Resistor
TX-NR414/ 515/ 515AE/ 616/ 616AE/ HT-R758/791/ HT-RC440/460/470
DEBUG MODE-1
AUDIO DEBUG MODE-1/6
The operations of DSP and DIR etc are able to checked by the information displayed on FL in this debug mode.
This information will help to analysing digital audio no sound trouble.
To set in Debug mode
1. Press and hold down DISPLAY button, then press ON/STANDBY button.
2. Press + (TONE) button while the version number of microprocessor is displayed.
e.g.
M1.06/1 2 4 1 7 A E
The version number of microprocessor is displayed
only for 3 seconds.
D1.05/1 2 3 2 7 A EA
3. Press DISPLAY button while the version number of DSP is displayed.
e.g.
4. Press DISPLAY button.
e.g.
5. Press DISPLAY button.
e.g.
6. Press DISPLAY button.
e.g.
0A0002: _ _ : 0 0 __
ANA:o:N O N : C : __
1:ANA_0 4 8 k 0 4 8k
2/0.0:_ 2 . 0 : 3 /4
7. Press DISPLAY button.
e.g.
8. Press DISPLAY button.
e.g.
9. Press DISPLAY button.
e.g.
10. Press DISPLAY button.
e.g.
2:o:PCM _ : P C M __
_00:x:F : O F F _ __
SP00F_0 0 F 0 0 4 09
_48_482 5 6 S T B __
The version number of DSP is displayed
only for 3 seconds.
DSP dubug mode
STEP-1
DSP dubug mode
STEP-2
DSP dubug mode
STEP-3
DSP dubug mode
STEP-4
DSP dubug mode
STEP-5
DSP dubug mode
STEP-6
DSP dubug mode
STEP-7
DSP dubug mode
STEP-8
11. Press DISPLAY button.
AUDIO dubug mode
The status of DSP and DIR etc
will be displayed.
TX-NR414/515/515AE
HT-R758/791
HT-RC440/460
ON/STANDBY
+ (TONE)
DISPLAY
Exit
TX-NR616/616AE
HT-RC470
ON/STANDBY DISPLAY
+ (TONE)
TX-NR414/ 515/ 515AE/ 616/ 616AE/ HT-R758/791/ HT-RC440/460/470
DEBUG MODE-2
AUDIO DEBUG MODE-2/6
Contents of Display
STEP-1
1.st_srd.lmd 2.st_srd.extdec
e.g.
C_LM_LAST
C_LM_PURE
C_LM_DIRECT
C_LM_STEREO
C_LM_MONO
C_LM_SURR
C_LM_THX_MUSIC
C_LM_THX_GAME
C_LM_THX_CINEMA
C_LM_THX_U2GAME
C_LM_THX_U2MUSIC
C_LM_THX_U2CINEMA
C_LM_AUDYSSEY
C_LM_DTSSS
C_LM_ORCHESTRA
C_LM_UNPLUGGED
C_LM_STUDIOMIX
C_LM_TVLOGIC
C_LM_ALLCHST
C_LM_FULLMONO
C_LM_TD
C_LM_TESTTONE
C_LM_TESTTHR
C_LM_TESTAUTO
C_LM_ASC
C_LM_FLASH
C_LM_DEBUGMODE
C_LM_FLASH2
C_LM_FLASH3
C_LM_FLASH4
C_LM_FLASH_CHECK
C_LM_RPG
C_LM_ACTION
C_LM_ROCKBAND
C_LM_SPORTS
0A0002:__:00__
1
1 2 3
01
02
03
04
05
20
50
70
90
A0
A8
B0
D0
48
06
07
08
09
0A
0B
0C
F1
F2
F3
F4
F5
F6
F7
F8
F9
FA
0D
0E
0F
10
FL Display
Display area
4
C_EXTDEC_OFF
C_EXTDEC_20_PLII
C_EXTDEC_20_PLIIX
C_EXTDEC_20_PLIIZ
C_EXTDEC_20_NEO6
C_EXTDEC_51_MTR
C_EXTDEC_51_DSC
C_EXTDEC_51_NEO6
C_EXTDEC_51_EX
C_EXTDEC_51_PLIIX
C_EXTDEC_51_PLIIZ
C_EXTDEC_9624
C_EXTDEC_9624_MTR
C_EXTDEC_71MULTI
C_EXTDEC_20_NEURAL
C_EXTDEC_51_NEURAL
3.st_srd.extdecmd
C_EXTDECMD_OFF
C_EXTDECMD_10
C_EXTDECMD_20
C_EXTDECMD_MOVIE
C_EXTDECMD_MUSIC
C_EXTDECMD_GAME
C_EXTDECMD_HEIGHT
C_EXTDECMD_WIDE
00
01
02
03
04
05
06
07
08
09
0A
0B
0C
0E
0F
10
00
01
02
03
04
05
06
07
14
1312106 87432 5 9 11
5
blank
4.Muting port
D
: DIGMUTE port
A
: AMUTE port
5.Factor of muting
bit_1
: SELMUTE
bit_2
: POWMUTE
bit_3
: PROTECTMUTE
bit_4
: AUDIOOUTMUTE
bit_5
: AUDIOMUTE
bit_6
: DIRMUTE
bit_7
: DACMUTE
bit_8
: HDMIMUTE
TX-NR414/ 515/ 515AE/ 616/ 616AE/ HT-R758/791/ HT-RC440/460/470
DEBUG MODE-3
AUDIO DEBUG MODE-3/6
STEP-2
STEP-3
e.g.
e.g.
11.Source_format
UNLK
ANA
PCM
AC3
DTS
MPEG
DATA
UNKW
NORD
NPCM
FS96
ANA:o:N O N : C : __
1
6.Audio input channel
ANA
: Analog
COX
: Coaxial
OPT
: Optical
HDM
: HDMI
ARC
: ARC
1:ANA_0 4 8 k 0 4 8k
1
: DDR_UNLOCK
: DDR_ANALOG
: DDR_PCM
: DDR_AC3
: DDR_DTS
: DDR_MPEG
: DDR_DATA
: DDR_UNKNOWN
: DDR_NOT_READY
: DDR_NOT_PCM
: DDR_FS96
11
7
7.DSP decode
o×: DSP Detect OK
: DSP No Detect
8.HDMI audio lock
STB
: SOUND STATE FIX
TRS
: SOUND STATE UNFIX
NON
: SOUND STATE NONE
NODT
DTSC
AAC
MPCM
MCH
TRUE
MSTR
DSD
PLUS
EXPR
DTSH
: DDR_NOT_DETECT
: DDR_DTSCD
: DDR_AAC
: DDR_MCHPCM
: DDR_MCH
: DDR_TRUE
: DDR_MSTR
: DDR_DSD
: DDR_DDPLUS
: DDR_DTSEXP
: DDR_DTSHD
12
14
1312106 87432 5 9 11
8 1096
blank
9.Display inhibit frag
S
: display_inhibit SET
C
: display_inhibit CLR
10.RX mute
V : HDMI MUTE
14
1312106 87432 5 9 11
13
12.st_srd.fs 13.st_hd_display.fs
???
008
011
012
016
022
024
032
044
048
064
088
096
176
192
: unknown
: 8kHz
: 11kHz
: 12kHz
: 16kHz
: 22kHz
: 24kHz
: 32kHz
: 44.1kHz
: 48kHz
: 64Hz
: 88.2kHz
: 96kHz
: 176.4kHz
: 192kHz
???
008
011
012
016
022
024
032
044
048
064
088
096
176
192
: unknown
: 8kHz
: 11kHz
: 12kHz
: 16kHz
: 22kHz
: 24kHz
: 32kHz
: 44.1kHz
: 48kHz
: 64Hz
: 88.2kHz
: 96kHz
: 176.4kHz
: 192kHz
TX-NR414/ 515/ 515AE/ 616/ 616AE/ HT-R758/791/ HT-RC440/460/470
DEBUG MODE-4
AUDIO DEBUG MODE-4/6
STEP-4
e.g.
2/0.0:_2.0:3/4
1
14
1312106 87432 5 9 11
STEP-5
14
15
14.Information of the input channels
for listening mode transition
???
: C_FMT_UNKNOWN
10
: C_FMT_10
20
: C_FMT_20
30
: C_FMT_30
21
: C_FMT_21
31
: C_FMT_31
22
: C_FMT_22
32
: C_FMT_32
23
: C_FMT_23
33
: C_FMT_33
24
: C_FMT_24
34
: C_FMT_34
4H2
5H2
4W2
5W2
4H4
4H3
5H4
5H3
4W4
4W3
5W4
5W3
11
: C_FMT_42H
: C_FMT_52H
: C_FMT_42W
: C_FMT_52W
: C_FMT_44H
: C_FMT_43H
: C_FMT_54H
: C_FMT_53H
: C_FMT_44W
: C_FMT_43W
: C_FMT_54W
: C_FMT_53W
: C_FMT_11
15.Information of the LFE channel input
0
: SW 0ch
1
: SW 1ch
2
: SW 2ch
e.g.
2:o:PCM_:PCM__
1
:
16
17
16.Channel information for the FL display
four-digit string "10.2" "5.1" "1 +1"
17.Number of channels after decoding
???
: C_FMT_UNKNOWN
10
: C_FMT_10
20
: C_FMT_20
30
: C_FMT_30
21
: C_FMT_21
31
: C_FMT_31
22
: C_FMT_22
32
: C_FMT_32
23
: C_FMT_23
33
: C_FMT_33
24
: C_FMT_24
34
: C_FMT_34
4H2
: C_FMT_42H
5H2
: C_FMT_52H
4W2
: C_FMT_42W
5W2
: C_FMT_52W
4H4
: C_FMT_44H
4H3
: C_FMT_43H
5H4
: C_FMT_54H
5H3
: C_FMT_53H
4W4
: C_FMT_44W
4W3
: C_FMT_43W
5W4
: C_FMT_54W
5W3
: C_FMT_53W
11
: C_FMT_11
14
1312106 87432 5 9 11
18
18. Audio output OK/NG
ox: decode OK
: decode NG
19
20
blank
19.Details of input format 20.Details of the format for the FL display
ANA
PCM
DLB
DEX
DTS
MTR
DSC
D96
96M
AAC
MCH
DSP
MPCM
DSD
TRUE
TREX
MSTR
PLUS
PLEX
EXP
DTSH
DSUR
DPSR
TRSR
: C_SRC_ANA
: C_SRC_PCM
: C_SRC_DD
: C_SRC_DD_EX
: C_SRC_DTS
: C_SRC_DTS_MTR
: C_SRC_DTS_DSC
: C_SRC_DTS_96
: C_SRC_DTS_96M
: C_SRC_AAC
: C_SRC_MCH
: C_SRC_DSP
: C_SRC_MCHPCM
: C_SRC_DSD
: C_SRC_TRUE
: C_SRC_TRUE_EX
: C_SRC_MSTR
: C_SRC_DDPLUS
: C_SRC_DDPLUS_EX
: C_SRC_DTSEXP
: C_SRC_DTSHD
: C_SRC_DD_SUR
: C_SRC_DDPLUS_SUR
: C_SRC_TRUE_SUR
ANA
PCM
DLB
DEX
DTS
MTR
DSC
D96
96M
AAC
MCH
DSP
MPCM
DSD
TRUE
TREX
MSTR
PLUS
PLEX
EXP
DTSH
DSUR
DPSR
TRSR
: C_SRC_ANA
: C_SRC_PCM
: C_SRC_DD
: C_SRC_DD_EX
: C_SRC_DTS
: C_SRC_DTS_MTR
: C_SRC_DTS_DSC
: C_SRC_DTS_96
: C_SRC_DTS_96M
: C_SRC_AAC
: C_SRC_MCH
: C_SRC_DSP
: C_SRC_MCHPCM
: C_SRC_DSD
: C_SRC_TRUE
: C_SRC_TRUE_EX
: C_SRC_MSTR
: C_SRC_DDPLUS
: C_SRC_DDPLUS_EX
: C_SRC_DTSEXP
: C_SRC_DTSHD
: C_SRC_DD_SUR
: C_SRC_DDPLUS_SUR
: C_SRC_TRUE_SUR
TX-NR414/ 515/ 515AE/ 616/ 616AE/ HT-R758/791/ HT-RC440/460/470
DEBUG MODE-5
AUDIO DEBUG MODE-5/6
STEP-6
e.g.
_00:x:F:OFF___
1
14
1312106 87432 5 9 11
blank
21
21.Dialog norm
Dialog Norm value from 0 to 31
22.Return value of DIRINT Request_dir
(DDC_STATUS)
o
: LOCK
x
: UNLOCK
STEP-7
e.g.
SP00F_00F00409
1
26. AudioIF DA830 input
: AUD_IF_I2S_H
IH
: AUD_IF_DSD
DS
: AUD_IF_I2S
IS
: AUD_IF_NET
NT
: AUD_IF_SPDIF
SP
: AUD_IF_ADC
AD
: AUD_IF_DDDTSHR
HR
27. Information of DIR Burst Preamble
DS
DP
Preamble Val
28. DIR Free or Busy
F
: Free
B
: Busy
29. DIR Detect Fs
CLOCK_FREQ_UNKNOWN
00
CLOCK_FREQ_8K
01
CLOCK_FREQ_11K
02
CLOCK_FREQ_12K
03
CLOCK_FREQ_16K
04
CLOCK_FREQ_22K
05
CLOCK_FREQ_24K
06
CLOCK_FREQ_32K
07
CLOCK_FREQ_44K
08
CLOCK_FREQ_48K
09
CLOCK_FREQ_64K
0A
CLOCK_FREQ_88K
0B
CLOCK_FREQ_96K
0C
CLOCK_FREQ_128K
0D
CLOCK_FREQ_176K
0E
CLOCK_FREQ_192K
0F
: DTSHD HR
: DD PLUS
: 0x??
22
23
24 25
23.Return value of DIR busy or free
Request_dir (DDC_BUSY)
FB: Free
: Busy
2826
3027 31 3229
30. DIR sequence number
SEQ_DIG_POWEROFF
00
SEQ_DIG_RESET
10
SEQ_DIG_POWERON_WAIT
11
SEQ_DIG_RESTART
12
SEQ_DIG_WAIT_HDMI_FREE
13
SEQ_DIG_INPSEL_SET
20
SEQ_DIG_ANALOG_SET
30
SEQ_DIG_DIGITAL_SET
31
SEQ_DIG_MCHPCM_SET
32
SEQ_DIG_MCHANA_SET
33
SEQ_DIG_DDPDTSHD_SET
34
SEQ_DIG_NET_SET
35
SEQ_DIG_INIT_ERROR
40
SEQ_DIG_CHK_ERROR1
41
SEQ_DIG_CHK_ERROR2
42
SEQ_DIG_CHK_FREE
43
SEQ_DIG_CHK_ANALOG
50
SEQ_DIG_LOCK_PLL
60
SEQ_DIG_LOCK_ANA
61
SEQ_DIG_FREE
f0
SEQ_DIG_FREE_ANA
f1
31. DIR switch sequence number
00
SEQ_SWITCH_POWEROFF
SEQ_SWITCH_RESET
01
SEQ_SWITCH_POWERON_WAIT
02
SEQ_SWITCH_CHANGE
03
SEQ_SWITCH_FREE
04
32. DAC sequence number
00
SEQ_DAC_POWEROFF
01
SEQ_DAC_RESET
02
SEQ_DAC_POWERON_WAIT
03
SEQ_DAC_INITIALIZE
04
SEQ_DAC_RESTART
05
SEQ_DAC_CMND_SET
06
SEQ_DAC_FREE_WAIT
07
SEQ_DAC_FREE
blank
24.emphasis of information
F
: Free
B
: Busy
25.HDDVD/BLUE(only DDPLUS)
BD
: Bluray
HD
: HDDVD
14
1312106 87432 5 9 11
/* POWER OFF*/
/* DIR RESET*/
/* POWER ON Waiting*/
/* DIGITAL RESTART */
/* HDMI(Waiting for final)*/
/* DIGITAL INPUT Setting */
/* DIR ANALOG Input setting*/
/* DIR DIGITAL Input setting*/
/* DIR MCHPCM Input setting*/
/* DIR MCHANA Input setting*/
/* DIR DD+ DTS-HD HR Input setting*/
/* DIR NET Input setting*/
/* DIR INIT ERROR*/
/* DIR CHECK ERROR1*/
/* DIR CHECK ERROR2*/
/* DIGITAL CHECK FREE*/
/* CHECK ANALOG MODE */
/* 2nd PLL LOCK*/
/* ANALOG 2nd PLL LOCK*/
/* DIGITAL FREE*/
/* ANALOG Fix*/
/* POWER OFF */
/* RESET */
/* POWER ON WAIT */
/* CHANGE */
/* FREE */
/* POWER OFF */
/* RESET */
/* POWERON WAIT */
/* INITIALIZE */
/* RESTART */
/* COMMAND SET */
/* FREE WAIT */
/* FREE */
TX-NR414/ 515/ 515AE/ 616/ 616AE/ HT-R758/791/ HT-RC440/460/470
DEBUG MODE-6
AUDIO DEBUG MODE-6/6
STEP-8
e.g.
_48_482 5 6 S T B __
1
33
33. Information of the input FS of DA830
UNK
: C_FS_UNKNOWN
8
: C_FS_08
11
: C_FS_11
12
: C_FS_12
16
: C_FS_16
22
: C_FS_22
24
: C_FS_24
32
: C_FS_32
44
: C_FS_44
48
: C_FS_48
64
: C_FS_64
88
: C_FS_88
96
: C_FS_96
176
: C_FS_176
192
: C_FS_192
34. Information of the output FS of DA830
UNK
: C_FS_UNKNOWN
8
: C_FS_08
11
: C_FS_11
12
: C_FS_12
16
: C_FS_16
22
: C_FS_22
24
: C_FS_24
32
: C_FS_32
44
: C_FS_44
48
: C_FS_48
64
: C_FS_64
88
: C_FS_88
96
: C_FS_96
176
: C_FS_176
192
: C_FS_192
34 35 36
35. Information of the input MCLK of DA830
: AUD_MCLK_64Fs
64
: AUD_MCLK_128Fs
128
: AUD_MCLK_256Fs
256
: AUD_MCLK_384Fs
384
: AUD_MCLK_512Fs
512
: AUD_MCLK_640Fs
640
: AUD_MCLK_768Fs
768
36. State of the audio input of DA830
: AUD_STS_SOUND_NO
NO
: AUD_STS_SOUND_TRANS
TRS
: AUD_STS_SOUND_STAB
STB
1312106 87432 5 9 11
blank
14
TX-NR414/ 515/ 515AE/ 616/ 616AE/ HT-R758/791/ HT-RC440/460/470
DEBUG MODE-7
HDMI DEBUG MODE-1/6
HDMI-related operations can be checked to some extent by displaying HDMI debug mode.
To enter this mode
Hold down DISPLAY button for 3 seconds. Information display will last for about 8 seconds.
Content of Display
1
Resolution display
Input resolution Output resolution
0
80i
1
1
List of standard resolution
4 8 0 i / 6 0
4 8 0 p / 6 0
1 0 8 0 i / 6 0
7 2 0 p / 6 0
1 0 8 0 p / 6 0
2 4 0 p / 6 0
# 4 8 0 i / 6 0
6
/
0
14
1312106 87432 5 9 11
1
# 5 7 6 i / 5 0
# 5 7 6 p / 5 0
# 2 8 8 p / 5 0
1 0 8 0 p / 2 4
1 0 8 0 p / 2 5
1 0 8 0 p / 3 0
V G A
14
1312106 87432 5 9 11
80
1 0
6
/
i
5 7 6 p 2 0 0
5 7 6 i 2 0 0
4 8 0 p / 6 0
4 8 0 p 2 4 0
4 8 0 i 2 4 0
* 4 8 0 p / 6 0
* 5 7 6 p / 5 0
1312106 87432 5 9 11
0
14
# 4 8 0 p / 6 0
# 2 4 0 p / 6 0
5 7 6 i / 5 0
5 7 6 p / 5 0
1 0 8 0 i / 5 0
7 2 0 p / 5 0
1 0 8 0 p / 5 0
2 8 8 p / 5 0
1 0 8 0 i 1 0 0
7 2 0 p 1 0 0
5 7 6 p 1 0 0
5 7 6 i 1 0 0
1 0 8 0 i 1 2 0
7 2 0 p 1 2 0
4 8 0 p 1 2 0
4 8 0 i 1 2 0
7 2 0 p / 2 4
7 2 0 p / 2 5
7 2 0 p / 3 07 2 0 p / 3 0
TX-NR414/ 515/ 515AE/ 616/ 616AE/ HT-R758/791/ HT-RC440/460/470
DEBUG MODE-8
HDMI DEBUG MODE-2/6
Display of Input resolution
DVI input signal
VGA input signal
No input
Display of Output resolution
4 8 0 I / 6 0
1
4 8 0 P / 6 0
1
i / p will be capitalized.
V G A
1
Display the ” ” in column 1
U n k n o w n
1
14
1312106 87432 5 9 11
14
1312106 87432 5 9 11
14
1312106 87432 5 9 11
14
1312106 87432 5 9 11
For a video processor
DVI input signal
VGA input signal
RSEN is OFF
EDID_READ is NG
Via VSP
VSP skip
1 0 8 0 i / 6 0
1
Display the ” ” in column 4
1 0 8 0 i / 6 0
1
4 8 0 I / 6 0
1
4 8 0 P / 6 0
1
i / p will be capitalized.
4 8 0 p / 6 0
1
Display the ” ” in column 5
4 8 0 p / 6 0
1
4 8 0 p / 6 0
1
14
1312106 87432 5 9 11
14
1312106 87432 5 9 11
14
1312106 87432 5 9 11
14
1312106 87432 5 9 11
14
1312106 87432 5 9 11
14
1312106 87432 5 9 11
Display the ” ” in column 14
#
14
1312106 87432 5 9 11
Display the ” # ” in column 14
Resolution Error
No output
(Signal output destination
can not be found.)
Hot-plug of Sink equipment
can not be detected.
4 8 0 p / 6 0
1
Display the ” x ” in column 14
x
14
1312106 87432 5 9 11
- - - - - -
1
14
1312106 87432 5 9 11
O F F
1
14
1312106 87432 5 9 11
TX-NR414/ 515/ 515AE/ 616/ 616AE/ HT-R758/791/ HT-RC440/460/470
DEBUG MODE-9
HDMI DEBUG MODE-3/6
4K Upscaling
Display of input resolution
1 0 8 0 i / 6 0
1
Display of Output resolution
14
1312106 87432 5 9 11
1
List of resolution
3 8 4 0 x 2 1 6
1
3 8 4 0 x 2 1 6
1
3 8 4 0 x 2 1 6
1
4 0 9 6 x 2 1 6
1
Resolution Error
EDID_READ_NG
x
p
/
0 p / 3
0 p / 2
0 p / 2
0 p / 2
3 8 4 0 x 2 1 6
1
3 8 4 0 x 2 1 6
1
14
1312106 87432 5 9 11
If the three-digit numbers are refrate
14
131211
0
14
1312106 87432 5 9 11
5
14
1312106 87432 5 9 11
4
14
1312106 87432 5 9 11
4
14
1312106 87432 5 9 11
0 p / 3
0 p / 3
x
0
14
1312106 87432 5 9 11
0
#
14
1312106 87432 5 9 11
TX-NR414/ 515/ 515AE/ 616/ 616AE/ HT-R758/791/ HT-RC440/460/470
DEBUG MODE-10
HDMI DEBUG MODE-4/6
Resolution display
Status Display
3D format
INPUT/OUTPUT
Display of Input resolution
RSEN OFF
EDID READ NG
Resolution Error
1 0 8 0 p / 2 4
1
(
3 D
H D M I t4 4 4 3 6 b i
1
F r a m cP a
1
I N : UO
1
1 0 8 0 p / 2 4
1
H D M I t4 4 4 3 6 b i
1
Display the ” # ” in column 9
1 0 8 0 p / 2 4
1
k i n ge
T
:
(
Display the ” ” in column 14
#
(
Display the ” x ” in column 13
)
14
1312106 87432 5 9 11
14
1312106 87432 5 9 11
14
1312106 87432 5 9 11
14
1312106 87432 5 9 11
3 D
3 D
)
14
1312106 87432 5 9 11
14
1312106 87432 5 9 11
)
x
14
1312106 87432 5 9 11
Status
Input Mode
Input Color
Deep Color
HDMI input
DVI input
No input
RGB
422
444
24bit
30bit
H D M I t4 4 4 3 6 b i
1
1312106 87432 5 9 11
D V I t4 4 4 3 6 b i
1
1312106 87432 5 9 11
- - - t4 4 4 3 6 b i
1
1312106 87432 5 9 11
H D M I tR G B 3 6 b i
1
1312106 87432 5 9 11
H D M I t4 2 2 3 6 b i
1
1312106 87432 5 9 11
H D M I t4 4 4 3 6 b i
1
1312106 87432 5 9 11
H D M I tR G B 2 4 b i
1
1312106 87432 5 9 11
H D M I tR G B 3 0 b i
1
1312106 87432 5 9 11
14
14
14
14
14
14
14
14
36bit
H D M I tR G B 3 6 b i
1
1312106 87432 5 9 11
14
TX-NR414/ 515/ 515AE/ 616/ 616AE/ HT-R758/791/ HT-RC440/460/470
DEBUG MODE-11
HDMI DEBUG MODE-5/6
3D format
Frame Packing
F r a m __ P a k i n ge c
1
14
1312106 87432 5 9 11
Field alternative
Line alternative
Side-by-Side(Full)
L+depth
L+depth + graphics
Side by Side(Harf)
Top and Bottom
unknown
F _ a l _e r n t i v et a
1
L _ a l _e r n t i v et a
1
S i d e _y S i e ( F )b d
1
L d e _t h _ _ _ _ _p _
1
L d e ct h g a p h ip r
1
S i d e _y S i e ( H )b d
1
T o p - mn d - o t t oa B
1
U N K N _W N _ _ _ _ _O _
1
14
1312106 87432 5 9 11
14
1312106 87432 5 9 11
14
1312106 87432 5 9 11
14
1312106 87432 5 9 11
14
1312106 87432 5 9 11
14
1312106 87432 5 9 11
14
1312106 87432 5 9 11
14
1312106 87432 5 9 11
INPUT/ OUTPUT
I N : O T :U
1
14
1312106 87432 5 9 11
TX-NR414/ 515/ 515AE/ 616/ 616AE/ HT-R758/791/ HT-RC440/460/470
DEBUG MODE-12
HDMI DEBUG MODE-6/6
PC resolution
Input Resolution
1 0 2 4 x 7 6 p / 6 08
1
14
1312106 87432 5 9 11
Output Resolution
Display of Input resolution
Horizontal resolution
DVI input
HDMI input
Three-digit numbers
are Referat
No input
Display of Output resolution
Horizontal resolution
1 0 2 4 x 7 6 p / 6 08
1
1
Display uppercase
P/I
Display lowercase
p/i
1
x p /
Vertical resolution
1 0 2 4 x 7 6 P / 6 08
1
1 0 2 4 x 7 6 p / 6 08
1
1 0 2 4 x 7 6 P 1 2 08
1
U N K N O W N
1
x p /
Vertical resolution
1312106 87432 5 9 11
Referat
1312106 87432 5 9 11
Referat
14
1312106 87432 5 9 11
14
14
1312106 87432 5 9 11
14
1312106 87432 5 9 11
14
1312106 87432 5 9 11
14
1312106 87432 5 9 11
14
DVI output
HDMI output
Display”-----”
Three-digit numbers
are Referat
EDID READ NG
Resolution through
INPUT/ OUTPUT
Display uppercase
P/I
Display lowercase
p/i
Display the ” # ” in
column 13
Display the ” x ” in
column 13
I N : O T :U
1
1 0 2 4 x 7 6 P / 6 08
1
14
1312106 87432 5 9 11
1 0 2 4 x 7 6 p / 6 08
1
14
1312106 87432 5 9 11
- ----
1
14
1312106 87432 5 9 11
1 0 2 4 x 7 6 P 1 2 08
1
14
1312106 87432 5 9 11
1 0 2 4 x 7 6 P / 6 08 #
1
14
1312106 87432 5 9 11
1 0 2 4 x 7 6 P / 6 08 x
1
14
1312106 87432 5 9 11
14
1312106 87432 5 9 11
TX-NR515/515AE/616/616AE/ HT-RC460/470/ HT-R791/ DTR-20.4/30.4
OPERATION CHECK-1
1.OPERATION CHECK(1/2)
1-1. OPERATIONS OF VOLTAGE-DETECTION PROTECTORS.
See “OPERATION CHECK-3,-5” for TEST MODE operation.
NOTE: Don't connect load nor short speaker terminals.
a. Change the state to "TEST-4-21".
b. It tests by being automatic in order of TEST4-21(FL+) → 22(FR-) → 23(C+) → 24(SL-)
→ 25(SR+) → 26(SBL-/SW-) → 27(SBR+). If TEST-4-27 (DTR-20.4 is 4-25) is ok, it becomes the display of "TEST-4-35."
c. It will complete, if displayed on FL TUBE as "TEST-4-35."
1-2. OPERATIONS OF CURRENT-DETECTION PROTECTORS
See “OPERATION CHECK-3,-5” for TEST MODE operation.
a. Change the state to "TEST-4-35".
Even if you connect 3-ohm load for every channel of L, R, C, SL, SR, SBL and SBRch, a relay should not cut off.
If 1-ohm load is connected for every channel of L, R, C, SL, SR,SBL and SBRch, a relay should hold the state of ON
1-3. CONFIRMATION OF RDS (RADIO DATA SYSTEM) OPERATION (Applied to MM*/MP* type )
a. Input 98MHz,30dBμ signal modurated with RDS data.
b. When a PS information is received, the name of the station "RDS TEST" shall be displayed within 2 seconds instead of the frequency.
1-4. CONFIRMATION OF HEAD PHONE OPERATION.
Confirm the Listening Mode is automatically switched to "STEREO" mode when headphones plug is inserted into the PHONES jack.
1-5. COMFIRMATION OF FRONT USB
See “OPERATION CHECK-3,-4” for TEST MODE operation.
a. Connect ipod to AVR USB port.
b. When set to TEST-3-09, confirm that the display of AVR change "connecting" to "press mode" after few seconds.
iPod classic, 3G nano, 4G nano, 5G nano
1-6. COMFIRMATION OF REAR USB
See “OPERATION CHECK-3,-4” for TEST MODE operation.
Applied to TX-NR515(AE), HT-RC460, TX-NR616(AE), HT-RC470, DTR-20.4, DTR-30.4.
a. Connect USB-Storage to AVR USB port.
b. When set to TEST-3-9 3-10, confirm that the display of AVR change device name.
1-7. COMFIRMATION OF AirPlay
See “OPERATION CHECK-3,-4” for TEST MODE operation.
Applied to TX-NR515AE, TX-NR616AE.
a. iTunes of PC is started before testing. And Connect the receiver to the router.
b. Confirm to display IP address , when TEST MODE is set to TEST-3-18.
*Please wait for about 20 seconds after turning on the power supply of the set when you use TEST-3-18.
c. Select model name (ex. "TX-NR515AE") in pull-up menu by clicking AirPlay icon on iTunes.
d. Click to select an appropriate music content on iTunes, then click Play icon to play music.
e. Check sound performance and the content information displayed on AVR VFD.
f. Stop music on iTunes, and select "My computer" in pull-up menu by clicking AirPlay icon on iTunes.
g. Press ON/STANDBY button, and AirPlay icon is removed on iTunes.
1-8. CONFIRMATION OF OUTPUT SENSOR AND THERMAL SENSOR.
See “OPERATION CHECK-3,-5” for TEST MODE operation.
a. Set the TEST MODE to "TEST-4-36" and "TEST-4-37".
After light "FM STEREO" on FL display ,
the relays RL691/692 is OFF and "FM STEREO"is off .
b. Push ON/Standby button while pushing down DISPLAY button to display CPU PROGRAM version.
Push TONE button while displaying CPU PROGRAM version to display value of temparature sensor.
Confirm outside temperature ±20C is displayed immediately after energizing.
Note that the error margin is caused by the rise of the temperature of the heat sink when time passes.
No singal condition (Ex. Display)
>00 034 F:x S:H
Voltage
of VOLH port
Temparature
of thermal sensor
FAN condition
x: Stop
L: Low speed
M: Mid speed
H: High speed
Amplifier power
supply voltage condition
H: High-B
L: Low-B
TX-NR515/515AE/616/616AE/ HT-RC460/470/ HT-R791/ DTR-20.4/30.4
OPERATION CHECK-2
1.OPERATION CHECK(2/2)
1-9. CONFIRMATION OF OSD(ON SCREEN DISPLAY) OPERATION
a. When SETUP button is pushed, confirm that setup menu is displayed in HDMI Out.
b. Confirm that specified operations for ENTER(with 4-cursor) buttons are made.
1-10. CONFIRMATION OF HDMI AUDIO OPERATION.
CONFIRMATION OF HDMI I2S SIGNAL
See “OPERATION CHECK-3,-6” for TEST MODE operation.
a. Input the one of these signals below from HDMI1 terminal.
DTS-HD MasterAudio 7.1ch
Dolby TrueHD 7.1ch
LPCM 7.1ch
b. Change the state to TEST 6-00. Confirm the signal is output from L/R,SW/C,SL/SR,SBL/SBR.
c. When TEST 6-08, confirm the sound(HDMI1 input) outputs from the TV.
CONFIRMATION OF HDMI SPDIF SIGNAL
d. SPDIF signal is input from HDMI terminal.
e. When TEST 6-06, confirm the sound(HDMI IN1)outputs from the speaker.
f. When TEST 6-07, confirm the sound(BD/DVD analog input) outputs from the TV.(VIDEO is HDMI1)
CONFIRMATION OF HDMI DSD SIGNAL.
g. When TEST 6-10 confirm the sound of DSD 5.1ch input HDMI IN 3, output from the speaker.
1-11. VIDEO FUNCTION CHECK
See “OPERATION CHECK-3,-6” for TEST MODE operation.
a. Confirm Video output signal as shown Table 2, while Video signal are input as shown Table 1.
NOTE 1: Confirm the HDMI path at 1080p signal.
NOTE 2: Confirm the TEST5-08(COMPONENT--->HDMI) path at 480i signal.
Table 1
Input
BD/DVD
CBL/SAT
STB/DVR
GAME
PC
IN6
IN7
AUX
USB
Composite Video
A
B
C
D
---
---
--E
E
Component
IN1
IN2
---
---
---
---
---
---
---
F
G
No
No
No
No
No
No
No
HDMI
IN1
IN2
IN3
IN4
IN5
IN6
IN7
AUX
---
H
J
K
L
M
N
O
P
---
Table 2
Test mode
5-00(BD/DVD)
5-01(CBL/SAT)
5-02(STB/DVR)
5-03(GAME)
5-04(PC)
5-05(AUX IN6)
5-06(IN6 IN7)
5-07(IN7 AUX)
5-08(BD/DVD)
5-09(USB/AUX)
Composite Video
Monitor out
A
B
C
D
---
---
---
--A
E
b. OPERATIONS OF VIDEO SIGNAL-DETECTION
Set the TEST MODE to "TEST 5-00".
When the component video signal is input to IN1, confirm that "RDS" of FL TUBE lights.
1-12. CONFIRMATION OF 12V TRIGGER OPERATIONS.(DTR-20.4/30.4 ONLY)
a. After checking that there is no output from 12V TRIGGER A terminal,it checks that
there is an output of 12V±10%/150mA after switched the "TEST2-11".
b. After checking that there is no output from 12V TRIGGER B terminal,it checks that
there is an output of 12V±10%/25mA after about 1 seconds switched the "TEST2-12".
c. After checking that there is no output from 12V TRIGGER C terminal,it checks that
there is an output of 12V±10%/25mA after 2 seconds switched the "TEST2-13".
Component
OUT
F
G
---
---
---
---
---
--F
---
HDMI
Main
H
J
K
L
M
N
O
P
F
E
Sub
H
J
K
L
M
N
O
P
F
E
1-13. CONFIRMATION OF COOLING FAN OPERATION (TX-NR616/HT-RC470/DTR-30.4 only)
See “OPERATION CHECK-3,-5” for TEST MODE operation.
a. Confirm to fan no rotate
b. When TEST 4-36 or TEST 4-37, confirm to fan rotate.
1-14. MISCELLANEOUS
a. Please confirm LED and FL displaying by the FL test mode.
And confirm the destination setting. ---> See to “OPERATION CHECK-3”
b. Confirm the version of each firmware.---> See to “SERVICE PROCEDURE-2”
c. Confirm the Firmware Combination Check.---> See to “OPERATION CHECK-3”
d. Please confirm the Check Sum.---> See to “OPERATION CHECK-3”
TX-NR515/515AE/616/616AE/ HT-RC460/470/ HT-R791/ DTR-20.4/30.4
OPERATION CHECK-3
2.TEST MODE(1/4)
2-1.TEST MODE FOR MODEL, DESTINATION AND FL DISPLAY
NOTE1: If VOL value is not 25(initial setting), test mode cannot be set.(Apply to TX-NR515/515AE, HT-R791, HT-RC460 and DTR-20.4)
NOTE2: If VOL value is not 30(initial setting), test mode cannot be set.(Apply to TX-NR616/616AE, HT-RC470 and DTR-30.4)
a. Push STANDBY/ON key while pushing down TV/CD button button to display "TEST-".
b. Then push DIMMER(RT/PTY/TP) button and get the FL test mode.
c. In the FL test mode, TONE - button is FL TEST UP and TONE + button is FL TEST DOWN.
d. REC OUT and ZONE2 button's originally operation can't work when it is in FL test mode.
e. The contents of the step are as follows.
1. Lit all segment
2. Lit '23456789ABCDEF'
3. Lit a even number segment
4. Lit an odd number segment
5. The Destination setting is displayed. Please see the below for detail.
f. To close the FL test, push POWER button.
N R 6 1 6 D x 2 0 0 0
MODEL Name
MODEL
FL DIS Name
Destination
ABCD
MODEL
FL DIS Name
Destination
ABCD
Destination
Dx : USA/Canada
DF : Taiwan
xx : Other(Europe, Asia)
JJ : Japan
TX-NR515
NR515
DF
Dx
0800
2600
TX-NR616
NR616
Dx
2800
DF
0600xx8600JJ4600
xx
8800
JJ
4800
A BCD
A:Value of AD port of BAND
B:Value of AD port of INIT1
C:Value of AD port of INIT2
D:Value of AD port of INIT3
TX-NR515AE
NR515A
xx
8200
xx
8400
JJ
4200
Dx
2400DF0400
TX-NR616AE
NR616A
Dx
2200
HT-RC460
RC460
Dx
2802
HT-RC470
RC470
Dx
2602
HT-R791
HT791
Dx
2820
Dx
2842
2-2. TEST MODE FOR OPERATION
a. Push STANDBY/ON button while pushing down TV/CD button to display "TEST-_".
b. Next, if the following keys are pushed, it becomes a each TEST MODE.
c. In the test mode, (TONE)- button is TEST MODE DOWN and (TONE)+ button is TEST MODE UP.
d. "TEST-1-00" and "TEST-1-01" are used to check a protection circuit, and the relay recovered in one second.
TEST MODE
Test No. --->
Button --->
1-00 2-00 3-00 4-00 5-00 6-00 KEY TEST
BD/DVD
CBL/SAT GAME PC AUX TV/CD
MEMORY
(CINEMA FILTER)
DTR-20.4
DTR204
Dx
2840xx8840
DTR-30.4
DTR304
xx
8842
IDLING TIMER
TUNING MODE
(LATE NIGHT)
JJ
4842
FL TEST
DIMMER
(RT/PTY/TP)
FIRMWARE
VERSION
TONE
TEST MODE
FIRMWARE
COMBINATION
CHECK
ENTER
CHECK SUM
When the MPU version
is displayed, push
"MEMORY(CINEMA FILTER)"
TX-NR515/515AE/616/616AE/ HT-RC460/470/ HT-R791/ DTR-20.4/30.4
OPERATION CHECK-4
2.TEST MODE(2/4)
2-2. TEST MODE FOR OPERATION(Continue)
e. Test mode is as follows.
TEST
No
1-00
1-01
1-02
2-00
2-01
2-02
2-03
2-04
2-05
2-06
2-07
2-08
2-09
2-10
2-11
2-12
2-13
2-14
2-15
2-16
2-17
2-18
2-19
2-20
2-21
2-22
2-23
2-24
2-26
3-00
3-01
3-02
3-03
3-04
3-05
3-06
3-09
3-10
3-11
3-12
3-13
3-14
3-15
3-16
3-17
3-18
3-20
3-21
3-22
3-23
Analog Input
[Rec Sel]
(Zone2/Zone3)
BD/DVD (Off)
BD/DVD (Off)
BD/DVD (Off)
BD/DVD (Off)
BD/DVD (Off)
BD/DVD (Off)
Multi channel
BD/DVD (Off)
BD/DVD (Off)
BD/DVD (Off)
BD/DVD (Off)
BD/DVD (Off)
BD/DVD (Off)
BD/DVD (Off)
CBL/SAT (Off)
CBL/SAT (Off)
CBL/SAT (Off)
GAME (Off)
AUX (Off)
BD/DVD (Off)
BD/DVD (Off)
CBL/SAT (Off)
BD/DVD (Off)
BD/DVD (Off)
BD/DVD (Off)
DVD/Source
MIC
MIC
PC (Off)
FM/Source
GAME (TV/CD)
GAME (TV/CD)
GAME (TV/CD)
TV/CD (Off)
Sirius (Off)
PORT (Source)
USB/(Source)
USB/(Source)
NET/(Source)
NET/(Source)
NET/(Source)
NET/(Source)
NET/(Source)
NET/(Source)
NET/(Source)
NET/(Source)
GAME (TV/CD)
GAME (TV/CD)
GAME (TV/CD)
GAME (TV/CD)
Listening Mode/
Input Format
Direct
Direct
Direct
Stereo(Direct)
Stereo(Direct)
DVD Direct
Multich Amp Test
VOL Direct
ADC DSP 8ch Thru.
ADC DSP 8ch Thru.
ADC DSP 7ch Thru.
ADC DSP 8ch Thru.
ADC DSP 8ch Thru.
ADC DSP 8ch Thru.
Automatic
Automatic
DIR DSP 8ch Thru
DIR DSP 8ch Thru
DIR DSP 8ch Thru
DIR DSP 8ch Thru
DIR DSP 8ch Thru
Automatic
DIR DSP 8ch Thru
DIR DSP 8ch Thru
DIR DSP 8ch Thru
DIR DSP 8ch Thru
ADC DSP 8ch Thru.
ADC DSP 8ch Thru.
DIR DSP 8ch Thru
Stereo(Direct)
Stereo(Direct)
Stereo(Direct)
Stereo(Direct)
ALL CH STEREO
Stereo(Direct)
ADC DSP 8ch Thru.
Stereo(Direct)
Stereo(Direct)
Stereo(Direct)
Stereo(Direct)
Stereo(Direct)
Stereo(Direct)
Stereo(Direct)
Stereo(Direct)
Stereo(Direct)
Stereo(Direct)
Stereo(Direct)
Stereo(Direct)
Stereo(Direct)
Stereo(Direct)
VIDEO
Input
BD/DVD
BD/DVD
BD/DVD
BD/DVD
BD/DVD
BD/DVD
BD/DVD
BD/DVD
BD/DVD
BD/DVD
BD/DVD
BD/DVD
BD/DVD
BD/DVD
CBL/SAT
CBL/SAT
CBL/SAT
GAME
AUX
BD/DVD
BD/DVD
BD/DVD
BD/DVD
BD/DVD
BD/DVD
BD/DVD
BD/DVD
BD/DVD
PC -
DVD
DVD
DVD
DVD
DVD
DVD
PORT
Last
Last
Last
Last
Last
Last
Last
Last
Last
Last
DVD
DVD
DVD
DVD
Compo-
nent V
IN1
IN1
IN1
IN1
IN1
IN1
IN1
IN1
IN1
IN1
IN1
IN1
IN1
IN1
-
-
-
-
-
-
-
DVD
DVD
DVD
DVD
DVD
DVD
DVD
-
DVD
DVD
DVD
DVD
DVD
DVD
-
-
-
-
-
-
-
-
-
-
-
DVD
DVD
DVD
DVD
HDMI
IN1
IN1
IN1
IN1
IN1
IN1
IN1
IN1
IN1
IN1
IN1
IN1
IN1
IN1
IN2
IN2
IN3
IN4
-
-
-
IN2
IN2
IN2
IN3
IN3
IN1
IN1
-
IN1
IN1
IN1
IN1
IN1
IN1
-
-
-
-
-
-
-
-
-
-
-
IN1
IN1
IN1
IN1
12V
Trigger
A
B
C
-
-
-
-
-
-
-
-
-
-
Digital Input
/Output
-
-
-
-
-
-
-
-
-
-
-
-
-
-
*OPT1
*COAX1
*OPT1
OPT1
COAX1
COAX1
*OPT2
*OPT2
*OPT2
*COAX2
*COAX2
-
-
OPT1
-
-
-
-
-
SIRIUS JIG Board
-
FrontUSB
RearUSB
NET
NET
NET
NET
NET
NET
NET
NET
-
-
-
-
Config.
-
-
-
-
-
Y/L/L/L/L
Y/L/L/L/L
Y/L/L/L/L
Y/L/L/L/L
Y/L/L/L/L
Y/L/L/L/L
Y/L/L/L/L
Y/L/L/L/L
Y/L/L/L/L
Y/L/L/L/L
Y/L/L/L/L
Y/L/L/L/L
Y/L/L/L/L
Y/L/L/L/L
Y/L/L/L/L
Y/L/L/L/L
Y/L/L/L/L
Y/L/L/L/L
Y/L/L/L/L
Y/L/L/L/L
Y/L/L/L/L
Y/L/L/L/L
Y/L/L/L/L
-
-
-
-
Y/L/L/L/L
-
-
-
-
-
-
-
-
-
-
-
-
-
-
-
-
Master Vol.
NonTHX
(THX)
Max(Max)
Max(Max)
MIN(Min)
Max(Max)
64(Ref)
Max(Max)
64(Ref)
Max(Max)
62(80)
64(Ref)
57(75)
52(70)
MIN(Min)
64(Ref)
64(Ref)
64(Ref)
64(Ref)
64(Ref)
64(Ref)
Max(Max)
64(Ref)
52(70)
64(Ref)
64(Ref)
64(Ref)
64(Ref)
64(Ref)
64(Ref)
4-Mar-00
64(Ref)
Max(Max)
64(Ref)
64(Ref)
64(Ref)
43(61)
57(75)
57
57
48
Max
48
48
48
48
48
48
64(Ref)
64(Ref)
64(Ref)
64(Ref)
Speaker
Relay
F/CS/SB/Z2
F/CS/SB/Z2
F/CS/SB/Z2
F
F
F/CS/SB
F/CS/SB
F/CS/SB
F/CS/SB
F/CS/SB
F/CS/SB
F/CS/SB
F/CS/SB
CS/SB
F/CS/SB
F/CS/SB
F/CS/SB
F/CS/SB
F/CS/SB
F/CS/SB
F/CS/SB
F/CS/SB
F
F
CS
F/CS/SB
F/CS/SB
F/CS/SB
F
F/Z2
F/Z2
F/Z2
F/CS/FH
F
F
F
F
F
F
F
F
F
F
F
F
F/Z2
F/Z2
F/Z2
F/Z2
etc.
SBL,SBR
SW=NO
SW=NO
L in ->L,SL,SBL / R in ->R,SR,SBR
SW:MUTE
SPRLF OFF
AMUT OFF
MICMUTE ON
Z2MUTE ON
"Output Level / Distortion"
SN Ratio
Freq. Resp.
Freq. Resp.
Separation
Separation
"Output Level / Distortion"
Net connection check
*1 PROTECT
"*1 PROTECTFOR SBL ch"
Z2/Z3Vol=Fix 64(78)
Z2/Z3Vol=Fix 64(78)
*2
"WAV, 44.1kHz, 16bit, 1kHz,
0dBfs, from server"
"WAV, 44.1kHz, 16bit,
-∞dBfs, from server"
"WAV, 44.1kHz, 16bit, 20Hz,
0dBfs, from server"
"WAV, 44.1kHz, 16bit, 20kHz,
0dBfs, from server"
"WAV, 44.1kHz, 16bit, 1kHz,
0dBfs, Lch from server"
"WAV, 44.1kHz, 16bit, 1kHz,
0dBfs, Rch from server"
"WAV, 48kHz, 16bit, 1kHz,
0dBfs, from server"
display IP address
"Z2/Z3Vol=60(78)Z2 Bass=Max"
"Z2/Z3Vol=60(78)Z2 Bass=Min"
"Z2/Z3Vol=60(78)Z2 Treble=Max"
"Z2/Z3Vol=60(78)Z2 Treble=Min"
In all test modes, it is not concerned with detection of VOLH but SEC1H are made "H" fixation. (Except TEST4-36 and 4-37.)
*1: All SP-RELAYs are turned ON only at the time of this STEP.
Moreover, whether make RELAY restoration time at the time of protection operation into 1 second, and PROTECT input "H" is detected
how many times or it continues 1 second or more, RELAY is not held at OFF or POWER OFF is not carried out, either.
When "H" is 1 seconds or more to PROTECT input and it is set to "L", RELAY is turned ON again.
Moreover, not any MUTE is outputted at the time of this STEP.
TX-NR515/515AE/616/616AE/ HT-RC460/470/ HT-R791/ DTR-20.4/30.4
OPERATION CHECK-5
2.TEST MODE(3/4)
2-2. TEST MODE FOR OPERATION(Continue)
Auto Measurement Mode
TEST
DSP Output ch
No.
4-00
ALL
4-01
ALL
4-02
ALL
4-03
SW
4-04
FL,FR
4-05
FR,C,SL,SR,SBL,SBR,SW
4-06
FL,C,SL,SR,SBL,SBR,SW
4-07
FL,FR,SL,SR,SBL,SBR,SW
4-08
FL,FR,C,SR,SBL,SBR,SW
4-09
FL,FR,C,SL,SBL,SBR,SW
4-10
FL,FR,C,SL,SR,SBR,SW
4-11
FL,FR,C,SL,SR,SBL,SW
4-12
FL,FR,C,SL,SR,SBL,SBR
4-13
ALL
4-14
ALL
4-15
ALL
4-16
ALL
4-17
ALL
4-18
ALL
4-19
ALL
4-20
ALL
4-21
FL
4-22
FR
4-23
C
4-24
SL
4-25
SR
4-26
SBL
4-27
SBR
4-28
FL
4-29
FR
4-30
C
4-31
SL
4-32
SR
4-33
SBL
4-34
SBR
4-35
ALL
4-36
FL,FR,C,SL,SR
4-37
C,SL,SR,SBL,SBR
4-38
*7
DSP Output
Frequency
1kHz
30Hz
20kHz
30Hz
30Hz
10kHz
10kHz
10kHz
10kHz
10kHz
10kHz
10kHz
30Hz
1kHz
30Hz
1kHz
30Hz
100Hz
10kHz
100Hz
10kHz
+DC
-DC
+DC
-DC
+DC
-DC
+DC
-DC
+DC
-DC
+DC
-DC
+DC
-DC
Pulse
1kHz
1kHz
DSP
Output
Voltage
-20dBFS
-20dBFS
-20dBFS
-20dBFS
-20dBFS
-20dBFS
-20dBFS
-20dBFS
-20dBFS
-20dBFS
-20dBFS
-20dBFS
-20dBFS
-20dBFS
-20dBFS
-20dBFS
-20dBFS
-20dBFS
-20dBFS
-20dBFS
-20dBFS
+Max
-Max
+Max
-Max
+Max
-Max
+Max
-Max
+Max
-Max
+Max
-Max
+Max
-Max
-10dBFS
0dBFS
0dBFS
CConfig.
Y/L/L/L/L
Y/L/L/L/L
Y/L/L/L/L
N/L/L/L/L
N/L/L/L/L
Y/L/L/L/L
Y/L/L/L/L
Y/L/L/L/L
Y/L/L/L/L
Y/L/L/L/L
Y/L/L/L/L
Y/L/L/L/L
Y/L/L/L/L
Y/L/L/L/L
Y/L/L/L/L
Y/L/L/L/L
Y/L/L/L/L
Y/L/L/L/L
Y/L/L/L/L
Y/L/L/L/L
Y/L/L/L/L
Y/L/L/L/L
Y/L/L/L/L
Y/L/L/L/L
Y/L/L/L/L
Y/L/L/L/L
Y/L/L/L/L
Y/L/L/L/L
Y/L/L/L/L
Y/L/L/L/L
Y/L/L/L/L
Y/L/L/L/L
Y/L/L/L/L
Y/L/L/L/L
Y/L/L/L/L
Y/L/L/L/L
Y/L/L/L/L
Y/L/L/L/L
Master Vol.
NonTHX
(THX)
64(Ref)
64(Ref)
64(Ref)
58(76)
64(Ref)
64(Ref)
64(Ref)
64(Ref)
64(Ref)
64(Ref)
64(Ref)
64(Ref)
64(Ref)
64(Ref)
64(Ref)
Min(Min)
Min(Mind)
64(Ref)
64(Ref)
64(Ref)
64(Ref)
Max(Max)
Max(Max)
Max(Max)
Max(Max)
Max(Max)
Max(Max)
Max(Max)
Max(Max)
Max(Max)
Max(Max)
Max(Max)
Max(Max)
Max(Max)
Max(Max)
58(76)
64(Ref)
64(Ref)
Speaker
Relay
F/CS/SB
F/CS/SB
F/CS/SB
F/CS/SB
F/CS/SB
F/CS/SB
F/CS/SB
F/CS/SB
F/CS/SB
F/CS/SB
F/CS/SB
F/CS/SB
F/CS/SB
F/CS/SB
F/CS/SB
F/CS/SB
F/CS/SB
F/CS/SB
F/CS/SB
F/CS/SB
F/CS/SB
F/CS/SB
F/CS/SB
F/CS/SB
F/CS/SB
F/CS/SB
F/CS/SB
F/CS/SB
F/CS/SB
F/CS/SB
F/CS/SB
F/CS/SB
F/CS/SB
F/CS/SB
F/CS/SB
F/CS/SB
F/CS/SB
F/CS/SB
etc.
*5
*5
*5
*5
*5
Mute:FL *5
Mute:FR *5
Mute:C *5
Mute:SL *5
Mute:SR *5
Mute:SBL *5
Mute:SBR *5
Mute:SW *5
*mut on *5
*mut on *5
*5
*5
BASS ALL:+12
TREBLE ALL+12
BASS ALL:-12
TREBLE ALL-12
*1,*2
*1,*2
*1,*2
*1,*2
*1,*2
*1,*2
*1,*2
*1,*2
*1,*2
*1,*2
*1,*2
*1,*2
*1,*2
*1,*2
*1,*3
*4
*4
DSP Gain
DSP Freq.Response
DSP Freq.Response
Characteristic(1)
Characteristic(2)
Separation
Separation
Separation
Separation
Separation
Separation
Separation
Separation
Muting
Muting
Volume Max.Attenuation
Volume Max.Attenuation
BASS Max.
TREBLE Max.
BASS Min.
TREBLE Min.
+DC Protect
-DC Protect
+DC Protect
-DC Protect
+DC Protect
-DC Protect
+DC Protect
-DC Protect
+DC Protect
-DC Protect
+DC Protect
-DC Protect
+DC Protect
-DC Protect
Current Protect
VOLH DET
VOLH DET
Key Test,SEC1H="L"
*2 : When TEST No. 4-21 34 is setted, DC votage is putted out immediately at each channel. (within 100msec.)
*3 : The following signal is putted out at all channel continuously in TEST4-35
Max
Max
2 mS 2 mS
20 mS
*4 : VOLH is detected and H/L of SEC1H is changed.
A detection level is the same as the normal mode.
When it is detected, light "FM STEREO" on FLD.
*7 : In TEST4-38, some character is displayed while pushing down some button. Another character shall be displayed by each button.
*8 : In TEST3-06,when I-Pod pull out from jug I-POD DET is detectedt han change to standby.
TX-NR515/515AE/616/616AE/ HT-RC460/470/ HT-R791/ DTR-20.4/30.4
OPERATION CHECK-6
2.TEST MODE(4/4)
2-2. TEST MODE FOR OPERATION(Continue)
VIDEO & HDMI TEST MODE
TEST
No.
5-00
5-01
5-02
5-03
5-04
5-05
5-06
5-07
5-08
5-09
6-00
6-01
6-04
6-06
6-07
6-08
6-09
6-10
6-11
6-12
6-14
6-20
6-21
6-22
Input selector
BD/DVD
CBL/SAT
GAME
PC
IN5
AUX IN6
IN6 IN7
IN7 AUX
BD/DVD
USB/AUX(30.4)
BD/DVD
BD/DVD
CBL/SAT
BD/DVD
BD/DVD
BD/DVD
BD/DVD
TV/CD
BD/DVD
BD/DVD
BD/DVD
BD/DVD
AUX
AUX
AUX
DIGITAL
INPUT
HDMI
HDMI
HDMI
HDMI
HDMI
HDMI
HDMI
HDMI
-
-
-
HDMI
HDMI
HDMI
HDMI
COAX1*
HDMI
HDMI ARC
HDMI
HDMI
HDMI
HDMI
HDMI
HDMI
HDMI
COMPO-
NENT/D4
IN1
-
-
-
-
-
-
-
IN1
-
-
IN1
-
IN1
IN1
IN1
IN1
-
IN1
IN1
IN1
IN1
-
-
-
VoVolume
NonTHX/THX
31/51
31/51
31/51
31/51
31/51
31/51
31/51
31/51
MIN
MIN
MIN
40/60
40/60
40/60
40/60
MIN
MIN
40/60
40/60
40/60
40/60
30/50
31/51
31/51
31/51
HDMI
IN1
IN2
IN3
IN4
IN5
AUX IN6
IN6 IN7
IN7 AUX
-
-
-
IN1
IN2
IN3
IN1
IN1
IN1
-
IN3
IN3
IN3
IN2
AUX
AUX
AUX
MODE
Through(Main/Sub:Both)
Through(Main/Sub:Both)
Through(Main/Sub:Both)
Through(Main/Sub:Both)
Through(Main/Sub:Both)
Through(Main/Sub:Both)
Through(Main/Sub:Both)
Through(Main/Sub:Both)
COMPONENT--->HDMI(Main/Sub:Both)
CV--->HDMI(Main/Sub:Both)
CV--->HDMI(Main)
HDMI I2S SIGNAL/CEC Check
HDMI I2S SIGNAL/CEC Check
HDMI DSD SIGNAL
HDMI SPDIF SIGNAL
Audio TV OUT = ON, VOL=0, ANALOG(DVD)
Audio TV OUT = ON, VOL=0, I2S SIGNAL
HDMI AUDIO RETURN CHANNEL
HDMI DSD SIGNAL
HDMI DSD SIGNAL
HDMI DSD SIGNAL
Normal operation
MHL Check(WAKE UP/CABLE DET)
MHL Check(VBUS=OFF)
MHL Check(VBUS=ON)
etc
Audio TV OUT = ON
Audio TV OUT = ON
Audio TV OUT = ON
Audio TV OUT = ON
Audio TV OUT = ON
Audio TV OUT = ON
Audio TV OUT = ON
Audio TV OUT = ON
20.4 ONLY
DIRECT
DIRECT
DIRECT
Output CH = L/R to L/R
Output CH = C/SW to L/R
Output CH = SL/SR to L/R
DIRECT
NOTES
1. DSP Thru of Lstn Mode outputs L Input signal to L/C/LS/SB, and outputs R Input signal to R/RS/SBR/RSW.
2. Config. is in order of SW/Front/Center/Surround/Surround Back.
3. Mute is function to stop output(from the channel) by using inner DSP programming.
4. When Lstn Mode is DSP thru, an analog SW is changed into the state of SURROUND.
5. At the time of PRTCTTHM detection, it is displayed on FLT as "THERMAL PROTECT".
f. Following frequencies are automatically written in the preset memory, when the unit goes into test mode.
FM
AM
FM
AM
PRESET No.
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
MD*
89.9MHz
97.9MHz
98.9MHz
107.1MHz
107.9MHz
100.1MHz
88.1MHz
104.1MHz
95.3MHz
106.7MHz
530KHz
630KHz
990KHz
1440KHz
1710KHz
670KHz
830KHz
1310KHz
1200KHz
530KHz
87.5MHz
107.9MHz
103.7MHz
104.5MHz
1180kHz
1220kHz
MW*(10k)
89.90MHz
97.90MHz
98.90MHz
107.10MHz
107.90MHz
100.10MHz
88.10MHz
104.10MHz
95.30MHz
106.70MHz
530KHz
630KHz
990KHz
1440KHz
1710KHz
670KHz
830KHz
1310KHz
1200KHz
530KHz
87.50MHz
108.00MHz
104.00MHz
104.20MHz
1180kHz
1220kHz
MP*,MG*
MW*(9k)
89.90MHz
97.90MHz
98.90MHz
107.10MHz
107.90MHz
100.10MHz
88.10MHz
104.10MHz
95.30MHz
106.70MHz
522KHz
630KHz
990KHz
1440KHz
1611KHz
666KHz
828KHz
1314KHz
1197KHz
522KHz
87.50MHz
108.00MHz
104.00MHz
104.20MHz
1179kHz
1215kHz
MJJ
76.00MHz
82.00MHz
83.00MHz
84.00MHz
90.00MHz
80.00MHz
85.10MHz
88.10MHz
76.00MHz
90.00MHz
522kHz
630kHz
990kHz
1440kHz
1611kHz
666kHz
828kHz
1314kHz
1197kHz
522kHz
76.00MHz
90.00MHz
79.80MHz
80.20MHz
1179kHz
1215kHz
TX-NR515/515AE/616/616AE/ HT-RC460/470/ HT-R791/ DTR-20.4/30.4
OPERATION CHECK-7
COOLING FAN (TX-NR616/616AE/ HT-RC470 only)
Circuit
Thermal sensor
Q6380
Power amp.
THERMAL
VOLH
Condition to operate
OFF or
Headphone
OFF
THERMAL
LOW
MID
HIGH
THERMAL(Temparature of thermal sensor)
-30
Shut down
immediately
LOW
LOW
LOW
MID
OFF
135
136
55
Q7009
(Main Microprocessor)
Normal/ Bi-Amp
MPU
LOW MID
STOP
HIGH
60
STOP STOP STOPSTOP STOP STOP
LOWLOW
MID MID MIDMID MID MIDMID
HIGH HIGH HIGH HIGHHIGHHIGH
62
LOW
Value D/A output of the MPU
OFF
LOW
MID
HIGH
FANCTRL
3
VOLH
HIGH
LOW LOW LOW LOW LOW
65
MID
OFF or
Headphone
73
0V
1.7V
2.2V
3.3V
Powerd Zone-2, 3
75
HIGH
Fan drive
Q2401,
Q2402
LOW MID
95
COOLING FAN
HIGH
Shut down in
10 minutes
continuously
100
Shut down
immediately
Hysteresis control
VOLH(Voltage of VOLH port)
OFF
0.35V
0.4V
1.9V
LOW
Hysteresis control
How to check
1. How to check Cooling Fan.
See 1-13 in ”OPERATION CHECK-2”.
2. How to check the value of THERMAL and VOLH.
See 1-8 in ”OPERATION CHECK-1”.
2.0V
MID
2.3V 3.3V
2.2V
HIGH
TX-NR616
EXPLODED VIEWS-1
OVERALL
P901
A056
A025
x 4 pcs.
A060
x 2 pcs.
Refer to
EXPLODED VIEWS-2
P6601A
x 14 pcs.
U0030
U0013
A058
H.C.P.S
A027
F6402
F6401
U0080
P8004
U010
P101
A023
F9002
F9002E
U0050
A281
x 2 pcs.
To U0051
(P8651)
A021
A283
P2800
A017
To U0040
(P3101)
U0041
A068
4 pcs.
U0010
To U0040
(P701)
P2801
U0020
A001
U0060
U0021
x 2 pcs.
A254
x 7 pcs.
A040
A069
A069
To U0040
(P703)
A342
x 9 pcs.
A093
A054
A036
x 4 pcs.
A043
U0011
U0012
P2510
A095
x 4 pcs.
A340
A360
A270
x 4 pcs.
A362
MDC only
Refer to
EXPLODED VIEWS-2
U0034
A042
x 2 pcs.
A034
A038
x 2 pcs.
T901
MDF only
A110
x 2 pcs.
P907
P901B
To U0080
A024
A256
A009
x 3 pcs.
A013
x 2 pcs.
A010
U0043
A040
x 2 pcs.
A003
x 4 pcs.
A005
x 4 pcs.
A007
x 4 pcs.
A045
x 2 pcs.
U0035
A030
A032
TX-NR616
Refer to
EXPLODED VIEWS-3
EXPLODED VIEWS-2
HEAT SINK / REAR PANEL SECTION
HEAT SINK SECTION
Front
TX-NR616
Q6066
Q6056
Q6064
Q6054
Q6061
Q6051
Q6062
Q6052
Q6050B
x 6 pcs.
Q6060
Q6050
Q6050A
x 2 pcs.
Q6063
Q6053
Q6065
Q6055
A050
x 14 pcs.
Front
A101
REAR PANEL SECTION
A102
A102
A105
x 30 pcs.
A107
A103
x 9 pcs.
A099
TX-NR616
TX-NR616
EXPLODED VIEWS-3
FRONT SECTION
U0014
A273
x 2 pcs.
A242
U0042
A212
A225
x 22 pcs.
U0040
A217
To U0050
To U0060
A216
To U0050
P703
P3101
P701
A212
A219
A202
A201
A215
A320
A321
To U0050
P8651
A211
A224
x 2 pcs.
U0051
A214
U0031
A213
A260
x 4 pcs.
A207
x 3 pcs.
Front
A255
TX-NR616
TX-NR616/ HT-RC470/ DTR-30.4
A
SCHEMATIC DIAGRAMS-1 (PART-1)
BLOCK DIAGRAM (AUDIO) SECTION
BADIS1093 1/4
(TX-NR616/HT-RC470 Series)
BADIS1101 1/4
1
2
3
4
5
BADIS1093 4/4
(TX-NR616/HT-RC470 )
BADIS1101 4/4
(DTR-30.4 Series)
DATA+
USB
YKF45-0029N
(DTR-30.4Series)
BAHDM1110 (1/1)
IN
(FRONT HDMI)
IN7
IN6
IN5
IN4
IN3
IN2
IN1
OUT1
OUT2
DATA-
VBUS
FRONT BOARD
MIC
TUNER PACK
TUNER
(NM)
TV/CD
PC
GAME
STB/DVR
CBL/SAT
DVD
HDMI BLOCK DIAGRAM
HDMI
RX
HDMI
TX
COAX 1
COAX 2
OPT1
OPT2
BADG1087 1/2
MIC AMP
Q7401
MIC DET
Rch
Lch
Rch
Lch
ARC_SPDIF
HDMI_SPDIF
HDMI MCK
HDMI BCK
HDMI LRCK
HDMI FLR
DATA NET
LRCK NET
BCK NET
MCK NET
DIR BCK
Q3001
DIR LRCK
DIR FLR
DIR MCK
D808K013BPTP
CX LRCK
CX SCLK
DSP SBLR
(BL/BR)
DSP SLR
(SL/SR)
DSP CSW
(CT/SW)
DSP FLR
(FL/FR)
B C D E F G H
BADIS1093 2/4
(TX-NR616/HT-RC470 Series)
BADIS1101 2/4
SPRLSB
SPRLCS
SPRLZ2
12V TRIDDER
CONTROL
IR
RS232
RS232
MICOM
Q7009
uPD70F3747
XIN
XOUT
5MHz
(DTR-30.4 Series)
NR616/RC470 EXCEPT
BADIS1093 3/4
(TX-NR616/HT-RC470 Series)
RI
BADIS1101 3/4
(DTR-30.4 Series)
FLDCLK
FLDSDO
SPI
SDI
SDO
CLK
HEADPHONES
BATRM1089 1/1
FRONT LEFT
SPEAKER TERMINALS
FRONT RIGHT
CENTER
SURR. LEFT
SURR. RIGHT
SUUR. BACK
HIGH/WIDE
LEFT
HIGH/WIDE
RIGHT
ZONE2
ZONE2/HIGH/
WIDE LEFT
ZONE2/HIGH/
WIDE RIGHT
NR616MJJ
EXCEPT
12V TRIGGER A
12V TRIGGER B
12V TRIGGER C
IR IN
IR IN
IR OUT
SDI
SDO
CLK
AUX IN
(FRONT IN)
Lch
Rch
SPI to Micom
BAAF1078
87
L
86
R
79
L
78
R
71
L
70
R
69
L
68
R
65
L
64
R
63
L
62
R
61
L
60
R
59
L
58
R
57
L
56
R
L
R
L
R
83
L
82
R
L
R
L
84
R
85
L
73
R
72
L
R
Z2NET R
+6dB
LPF
+-
Q1002
DATA NET
LRCK NET
PCM1754D
BCK NET
2ch DAC
MCK NET
COAX1
COAX2
OPT1
OPT2
HDMI MCK
HDMI BCK
HDMI LRCK
HDMI FLR
REC_L
REC_R
BADG1087 1/2
Z2NET L
+6dB
LPF
+-
MAINL
MAINR
L
ADCL
R
ADCR
0/-6/-12/-18dB
SUB1L
L
R
SUB1R
SUB2L
L
R
SUB2R
SUB1L
SUB1R
MAINL
MAINR
LTAD
RTAD
2ch ADC
PCM9211
DIR
Q1005
Buffer
53
54
46
Z2
47
32
Z3
33
SUB1 should be always ON.
DIG CLK
DIG SD0
DIG SD1
DIR BCK
DIR LRCK
DIR FLR
DIR MCK
X-Tl
MCLK
R2A15220FP
Ana all ch st
FL+FR (-6dB)
SW 80Hz LPF
-12dB/oct
L
R
L
NR616/RC470
Z2 Lineout
R
SBR(Whole House_MODE)
FR
VLSC
Q431
+6dB
Q421
Q411
NR616MJJ ONLY
X1001-XTAL
11.2896MHz
Q1001
TC7SZU04FU
FL
Q431
non VLSC
Q421
VLSC
Q411
Q4001
+6dB
NR616 ONLY
Q4003
Downmix
FL/FR -12dB
SW +3.5dB
non VLSC
DIR MCK
CX LRCK
CX SCLK
DSP SBLR
DSP SLR
DSP CSW
FL
(FR)
INVERTING
INVERTING
FR
(FL)
(Whole House_MODE)
C
C(DAC)
(Whole House_MODE)
SW
SW(DAC)
SL(DAC)
(Whole House_MODE)
SL
(Whole House_MODE)
SR
SR(DAC)
Zone2L Out
SBL(DAC)
(Whole House)
SBL
Zone2R Out
SBR(DAC)
Zone2 in(L-ch)
(INR)
Zone2 in(R-ch)
(INL)
Zone3 in(L-ch)
Zone3 in(R-ch)
LPF
(BL/BR)
(SL/SR)
(CT/SW)
(FL/FR)DSP FLR
FL(DAC)
43
FRIN2
FL(MIX)
91
FRIN1
FR(DAC)
90
FLIN1
FR(MIX)
42
FLIN2
38
CIN2
92
CIN1
39
SWIN2
93
SWIN1
44
SBRCIN
95
SRIN1
41
SRIN2
40
SLIN2
94
SLIN1
45
SBLCIN
34
SRCIN
97
SBRIN1
37
SBRIN2
35
SLCIN
96
SBLIN1
36
SBLIN2
+6dB
+- +-
Z2 Lineout
Z3 Lineout
LPF
*NOTICE
ex)(FR)<--->FL ,(FL)<--->FR
MAINR
1
2
MAINL
1
2
Z2L
3
28
30
26
2
29
27
31
4
(CIN)
5 12
(SWIN)
39
(ADCR)
40
(ADCL)
7
(SRIN)
6
(SLIN)
ZONE FUNCTION
NR616/RC470
ONLY
+6dB
Q4304
M61540FP
except NR616/RC470
+6dB
+6dB
LPF
LPF
+- +- +- +- -
TONE
TONE
1
2
1
2
SRC
SLC
SBRC
SBLC
Z2R
TONE
TONE
+6dB
LPF
8ch DAC
Q1004
PCM1690
SPI
1.Actually the right and left in/output signal of Q4001/Q4301(R2A15220FP/M61540FP) is connected reversely to real signal.
22
FL
(FR)
23
POWER AMPLIFIER
DTR-30.4
ONLY
SPI
NR616MJJ/
DTR-30.4
ONLY
Zone2
Line/Preout
Zone3
Line/Preout
ZONE OUT
PREOUT
NR616/RC470
EXCEPT
FL
FR
C
SW1
SW2
SL
SR
SBL
SBR
SBRELAY
Z2MUTE
Z3MUTE
Z2 L
Z2 R
Z3 L
Z3 R
+29dB
+29dB
+29dB
+29dB
+29dB
+29dB
+29dB
VMCLK
VMSDO
VMSDI
DIGSDI
DIGSDO
DIGCLK
priority terminal
0.5dB step/each VR
+6dB
LPF
LPF
+6dB
24
20
19
18
16
17
15
14
Subwoofer
13
10
11
12
8
7
6
2
3
4
1
100
99
98
17
Z2 out(L-ch)
(ROUT)
18
Z2 out(R-ch)
(LOUT)
Z2 L Line/preout
(COUT)
Z2 R Line/preout
11
(SWOUT)
9
Z3 L Line/preout
(SROUT)
10
Z3 R Line/preout
(SLOUT)
+6dB
LPF
SW
++ -
FR
(FL)
CEN
(SR)
(SL)
SBL
(SBR)
SBR
(SBL)
SL
SR
AV=+20dB
DIG CLK
DIG SDO
AMUT
SPRLF
SBZ2MUT
PRERELAY
REMOTE SENSOR
TRANSMITTERS
RI
INTERFACE
(HDMISLC)
(HDMI SDA)
XTAL-X7001
BADIS1101 4/4
(DTR-30.4 Series)
Q7501
FJDL9208A-01
MODEL NO. TX-NR616/HT-RC470/DTR-30.4
BLOCK DIAGRAM (PART-1) AUDIO SECTION
2011.12.27
Q7001
EEPROM
FRONT
TX-NR414/ 515/ 616/ HT-R758/ 791/ HT-RC460/ 470/ DTR-20.4/ 30.4
A
SCHEMATIC DIAGRAMS-2 (PART-2)
BLOCK DIAGRAM VIDEO SECTION
TX-NR510,HT-R691
1
TMDS
TMDS
CEC
CEC
DDC
HDMI IN6
HDMI IN5
HDMI IN4
HDMI IN3
2
HDMI IN2
HDMI IN1
3
4
COMPONENT VIDEO INPUT
DVD
CBL/SAT
STB/DVR
GAME
5
AUX1
(FRONT)
DDC
+5V
HP DET
TMDS
CEC
DDC
+5V
HP DET
TMDS
CEC
DDC
+5V
HP DET
TMDS
CEC
DDC
+5V
HP DET
TMDS
CEC
DDC
+5V
HP DET
TMDS
CEC
DDC
+5V
HP DET
JAPAN Model
7
14
6
13
12
5
4
11
10
3
9
2
1
8
D4 VIDEO INPUT
Y2
CB2
CR2
Y1
CB1
CR1
COMPOSITE VIDEO INPUT
UPORT
RPWR
HPD
TMDS
CEC
DDC
RPWR
HPD
TMDS
CEC
DDC
RPWR
HPD
TMDS
CEC
DDC
RPWR
HPD
TMDS
CEC
DDC
RPWR
HPD
TMDS
CEC
DDC
RPWR
HPD
ISO
B C D E F G H
TX-NR610,TX-NR710, HT-R791, HT-RC460, HT-RC470, DTR-20.4, DTR-30.4
IN2
EQ
IN1
EQ
IN0
EQ
Q8101
SII9573
MUX
MUX
SiI9185A
TX-NR609, TX-NA609, DTR-30.3
HDMI
FRONT
HDMI IN7
HDMI IN6
HDMI IN5
HDMI IN4
HDMI IN3
I2C
RESET
PWRDWN
INTRQ
HDMI IN2
HDMI IN1
8bit ITU-R BT.656 YCrCb 4:2:2
TMDS
DDC
HP DET
TMDS
CEC
DDC
HP DET
TMDS
CEC
DDC
HP DET
TMDS
CEC
DDC
+5V
HP DET
TMDS
CEC
DDC
+5V
HP DET
TMDS
CEC
DDC
+5V
HP DET
TMDS
CEC
DDC
+5V
HP DET
TMDS
CEC
DDC
+5V
HP DET
Tx
RX5
RX4
RX3
RX2
RX1
RX0
TMDS
DDC
Parallel VIDEO
TMDS
DDC
RPWR
HPD
TMDS
CEC
DDC
RPWR
HPD
TMDS
CEC
DDC
RPWR
HPD
TMDS
CEC
DDC
RPWR
HPD
TMDS
CEC
DDC
RPWR
HPD
TMDS
CEC
DDC
RPWR
HPD
Q8661
TMDS141
Rx
HDMI Buffer
TMDS
CEC
CEC
DDC
RPWR
+5V
HPD
TMDS
CEC
DDC
RPWR
+5V
HPD
TMDS
CEC
DDC
RPWR
+5V
HPD
Q8161
MUX
HDMI
Receiver
HDMI
Receiver
CEC
HDMI
SWITCH
Driver
TMDS
TX
DDC
RPWR
HPD
I2C
RESET
INT
MUX
MUX
MUX
MUX
Q8200
DE2755
Video
Processor
KYOTOG2H
TMDS TMDS
AUDIO OUT
MULTI CH
AUDIO IN
2CH
OSD
AUDIO IN
2CH
AUDIO OUT
2CH
DDC
RPWR
HPD
DIGITAL VIDEO
AUDIO IN 2CH
SPI for UPDATE
TX0
TX1
12bit x3
ARC0
SPDIF
I2S
DSD
I2S from DSP
TMDS
Tx 0
DDC
RPWR
HPD
TMDS
Tx 1
DDC
HPD
I2S from DSP
SPDIF
I2S
ARC1
I2C
RESET
INT
HDMI RX
INPUT
FLEXI
PORT
ON-CHIP
PROCESSOR
SPI FLASH
128MB
XTAL
27MHz
SOURCE
SELECT
PROCESSING
PIP/OSD
Overlay
DDR2/DDR3
CONTROL
DDR3
1Gbit 667MHz
AUDIO
DELAY
VIDEO
BLOCK
AUDIO
MUX
PLLs
XTAL
20MHz
HDMI TX
VIDEO
DDC
HPD
I2C
RESET
INT
RDY
LOCK
REQ
Model No. TX-NR414/515/616/HT-R758/791/HT-RC460/470/DTR-20.4/30.4
SCHEMATIC DIAGRAM (PART-2) BLOCK DIAGRAM(VIDEO)
28-12-2011
RX5
RX4
RX3
RX2
RX1
RX0
Parallel VIDEO
Yin1
Yin2
Yin3
PBin1
PBin2
PBin3
PRin1
PRin2
PRin3
Vin2
Vin3
Vin4
Vin5
Vin1
Vin6
Vin7
ISOOUT
ISOIN
Q8101
SII9573
HDMI
MUX MUX
Receiver
HDMI
MUX
Receiver
PY
NJM1328
DETECT
PY
6dB
6dB
PB
6dB
PR
6dB
DETECT
CV
ISO
6/4dB Buf
6/4dB
6/4dB
MUX
DRV
DRV
DRV
DRV
DRV
CEC
ARC0
SPDIF
ADINPB
ADINPR
I2S
DSD
+5V
TMDS
Tx 0
TX0
DDC
HPD
SPI
SPI FLASH
16MB
SPI for UPDATE
TMDS
Tx 1
TX1
DDC
HPD
I2S/SPDIF
SPDIF
I2S
ARC1
XTAL
27MHz
I2C
RESET
INT
UP to 480i
MUX
XTAL
28.6363MHz
PLL
10bit
86MHz
A/D
TMDS
CEC
HDMI OUT
DDC
+5V
MAIN
HP DET
TMDS
CEC
HDMI OUT
DDC
+5V
SUB
HP DET
SD VIDEO DECODER
ADV7180
2D Comb
VBI SLICER
COLOR DEMOD
MUX
AUDIO OUT
MULTI CH
AUDIO IN
2CH
OSD
AUDIO IN
2CH
MUX
AUDIO OUT
2CH
ADINPY/ADINCV
Buf
Buf
Y
CB
Buf
CR
COMPONENT
OUT
MONITOR
COMPOSITE VIDEO OUTPUT
I2C
MUTE
CEC
+5V
TMDS
CEC
HDMI OUT
DDC
MAIN
+5V
HP DET
+5V
TMDS
CEC
HDMI OUT
DDC
SUB
+5V
HP DET
TX-NR515/ 616/ HT-R791/ HT-RC460/ 470/ DTR-20.4/ 30.4
A
B C D E F G H
SCHEMATIC DIAGRAMS-3 (PART-3)
BLOCK DIAGRAM (DIGITAL AUDIO) SECTION
1
2
EthernetController
w/LocalBus
WiFi Dongle
BGC_RST
+3.3V
Ethernet Capacitive connection
/Non AutoMDIX/fiexd100Mbps/FullDplx
DataBus
AddressBus
CS/WE/RE/INT/PME
DA83_RST
+3.3V
ResetGen.
Reg1.2V
PHY
LAN8700
ResetGen.
USB 2.0
+1.2V
Reg1.2V
BGC_RST
D+/D-
50MHz
MDIO
RMII
+1.2V
Hynics or Numonyx Winbond/Samsung
1Gbit NAND flash
NAND flash
24MHz
DataBus
ControlSig.s
DM860
256Mbit NAND flash
NAND flash
24MHz
DataBus
ControlSig.s
DA83_RST
w/NAT Routing, QoS
USB 1.1
256Mbit 166MHz
SDRAM
AddressBus
256Mbit 133MHz x2pcs
AddressBus
DA830
DataBus
SDRAM
DataBus
ControlSig.s
ControlSig.s
I2C
ACP_RST
JTAG
UART
BGC_SPDIF
BGC_BCLK
BGC_LRCK
BGC_ADAT0
BGC_MCLK
SPI
CS
Ready
Apple ACP
ACP_RST
I2C0
Serial Console
Apple ACP
Req
DA830_CS
SPI0
JTAG
UART1
Serial Console
BGC_RST
DA83_RST
DA830_CS
Req
HOST uCom
SPI0
SPI
DIR_CS
DIR_INT0
DIR_RST
DACCS
DACMUT
DACRST
Z2DACMUT
AData3
AData4
McASP0
AData5
NET_BCLK
NET_LRCK
NET_ADAT0
NETMCK
74VHC157
Z2DACINPSEL
AData5
AData4
AData3
AData2
AData1
AData0
BCLK
LRCK
MCLK
Z2BCLK
Z2LRCK
Z2AData0
Z2MCK
PCM1690
DAC
SPI
DACCS
DACRST
DACMUT
PCM1754
NET Z2 DAC
Z2DACMUT
Lch
Rch
Cch
SLch
SRch
SBLch
SBRch
SWch
Z2.Lch
Z2.Rch
RJ-45
Tx+/-
ARC
DIVIDE
DIVIDE
Rx+/-
HDMI_AData5
HDMI_AData4
HDMI_AData3
HDMI_AData2
HDMI_AData1
HDMI_AData0
HDMI_LRCK
HDMI_BCLK
HDMI_MCLK
PCM9211
DIR/ADC
DIR
D
I
R
RECOUT0
RECOUT1
XMCKO
ADC clock
AUXIN0
AUXIN2
ADC
AUXIN1
3
HDMI Block
HDMI_SPDIF
AD.Rch
4
AD.Lch
SPDIFn
SPDIF0
ARC
HDMI_SPDIF
BGC_SPDIF
11.2896MHz
5
24.576MHz
VINL
VINR
RXIN0
RXIN1
RXIN2
RXIN3
RXIN4
RXIN5
RXIN6
RXIN7
MPIO_A0
MPIO_A1
MPIO_A2
MPIO_A3
XTI
A
D
C
SCKO
LRCK
DOUT
MAIN OUT
MPIO_C0
MPIO_C1
MPIO_C2
MPIO_C3
MPIO_C
MPIO_B0
MPIO_B1
MPIO_B2
MPIO_B3
MPIO_B
MPO0
MPO1
BCK
Tx+/-
Rx+/-
PHY
DIR_MCK
DIR_BCK
DIR_LRCK
DIR_ADATA0
HDMI_MCLK
HDMI_BCLK
HDMI_LRCK
HDMI_AData0
12.288/11.2896
MCLK
RMII
MDIO
50MHz
McASP1 AXR1_5 -0
AData2
AData4
AData5
AData1
AData3
AData0
BCLK
LRCK
MCLK
McASP1 AXR1_6 -11
LRCK
BCLK
AData0
AData1
AData2
DIR_INT0
DIR_RST
SPI
DIR_CS
Model No. TX-NR515/NR616//HT-R791/HT-RC460/470/DTR-20.4/30.4
SCHEMATIC DIAGRAM (PART-3) BLOCK DIAGRAM(DIGITAL AUDIO)
2011/12/28
TX-NR616 / HT-RC470/ DTR-30.4
SCHEMATIC DIAGRAMS-4 (PART-4)
ASP SECTION
TX-NR616 / HT-RC470/ DTR-30.4
C_OUT
DMIXL
DMIXR
S1L-
S1L+
GND_S1
+24V
SL_OUT
SBR_OUT
Z2MUT
SBZ2MUT
SEC1H
VOLH
VPROTECT
IPROTECT
+15V
Z3MUT
VOLCLK
-15V
VOLDATA
SW_OUT
SBL_OUT
FR_OUT
FL_OUT
SBR
SR
R
SBL
GND
L
C
SL
SR_OUT
GND_E
Z2R
Z2LE
PRRLF
SBRELAY
VOLH
SEC1H
IPROTECT
VPROTECT
Z2VOLCLK
AMUT
AUX_L
AUX_R
MICOUT
Z2L
GND_AMP
Z2RE
TU_RI
TU_LI
GNDTU
+5VTU
GND_CH
TU_SDA
TU_SCL
TU_SDA
TU_RST
GND_CH
TU_RST
TU_SCL
GND
Z2NET_L
LTAD
Z2NET_R
GND
RTAD
GND
DAC_FR
DAC_FL
DAC_SW
DAC_CT
DAC_SR
DAC_SL
DAC_SBR
DAC_SBL
GND_A
PC
GAME
VCR
DVD
SR
SBL
SBR
sw
SL
FR
FL
CEN
SL
SR
PRE_C/SW
FRONT L
FRONT R
SBR/HIGH/WIDE R
SBL/HIGH/WIDE L
PRE_SURRBK
PRE_SURR
Lch
Rch
Lch
Rch
Rch
Lch
GND
GND
GND
GND
Downmix
FL/FR -12dB
SW +3.5dB
Ana All ch
Stereo
+60mA max
+45mA typ
-60mA max
-45mA typ
HIGH/WIDE/RIGHT
HIGH/WIDE/LIFT
Z2_R CH
Z2_L CH
PREOUT RELAY
-25V
Subwoofer
AV=20dB
F
Z2_R OUT
Z2_L OUT
ZONE3_R CH
ZONE3_L CH
LINE/PREOUT
LINE/PREOUT
LINE/PREOUT
LINE/PREOUT
ZONE2_R CH
ZONE2_L CH
ZONE3_R CH
ZONE3_L CH
Z2_R OUT
Z2_L OUT
K
Z3_L CH
Z3_R CH
Except
GND
-42mA max
TUN
CBL/SAT
NC
Center
FL+FR(-6dB)
Ana All ch st
R CH
L CH
80Hz -12dB/oct
Subwoofer
Ana All ch st
ZONE2_L CH
ZONE2_R CH
LINE/PREOUT
ZONE2_L CH
LINE/PREOUT
ZONE3_L CH
ZONE OUT
SW
Except
PRE OUT
+32mA typ
+42mA max
-32mA typ
Rch
DVD/BD
Lch
Lch
Lch
Rch
Rch
PC
GAME
STB/DVR
CBL/SAT
Rch
ZONE2_R CH
Except
T7/T7US/A7/RC47
Z2 Line OUT
LINE/PREOUT
ZONE3_R CH
Z3 Line OUT
LINE/PREOUT
Lch
NM
NM
LIST
LIST
LIST
LIST
LIST
LIST
LIST
LIST
LIST
LIST
LIST
LIST
LIST
LIST
LIST
LIST
LIST
LIST
LIST
LIST
NM
LIST
LIST
LIST
LISTLIST
LIST
LIST
LIST
K
K
K
LIST
TV/CD
TV/CD
NM
NM
NM
NM
NM
NM
E
A
H
A7
-1C-1A -1A -1B-1B -1D -1E
RC47
X
0
3.3
Table: F
XX
0.473.33.33.3 0.470.47
X X X X
0 0 0
Table: A
PREOUT
1W
Table: G
X
X X
0
0 0 0 0
X
X
ZONE LINE/PREOUT
ZONE2 SPK(Lever)
GNDA_AUX
*MUTE
R4210
Table: B
R4180 R4211
R4182
0
0
0
X
R4185
T7/RC47
-1A/-1B
A7
-1C
0
0
0
X
X
00
0
-1D/-1E
Z3MUT
SB/Z2MUT
AMUT
Z2MUT
FROM TUNER PACK
2.5mm FFC CABLE
TUNER
DG
Lever
Zone2 SPK or High or Wide SPK
SP TRM
DG
26/7HAND BLK
1007#22
*SW
C4211
X
X
X
X
0
0
0
0
0
X
X
X
X
X
X
X
X
X
X
-1C
220K2.2K2.2K
220K
0
0
0
-1C
*ZONE LINE/PREOUT
0
X
X
0
0
0
0
0
0
0
Table: E
*PREOUT_RELAY
0
-1C
X
X
0X
0
0
0
Table: D
R4168
R4200
R4128
R4201-02
X
X X
0
0
R4209
R4208
C4200
D4200
D4201
Q4200
Q4201
RL4200
RL4201
P4010
Table: K
C4307-08
R4225
R4300
R4301-03
R4306-07
R4322-23
2.2K
100
2P 1P 1P
R4110-14
R4115-16
R4120-24
R4125-26
Q4105-06
Q4110-14
Q4115-16
100
100
2.2K
2.2K
120
120
0
0
0
0
0
X
X
0
Table: C
OTHER
J4301-02
X X
2.2K
0
0
0
X
X
X
X
X
X
X
X
X
-1C/-1D/-1E
-1A/-1B
-1A/-1B
-1A/-1B
-1D/-1E
-1D/-1E
-1D/-1E
*PREOUT
MODEL
CRIMP AS
AMP
TO BAAF-1078
TO BAAF-1078
AMP
NM
NM
NM
NM
NM
NM
NM
NM
NM
NM
NM
NM
NM
D3
D3
D3
D3
(D3 ONLY)
D3
PREOUT RELAY
D3
D3
GND
NM
DG
HT-RC470
RC47
D3
DTR-30.4
T6
A6
A6/D3
T6/RC47
A6
T6/RC47
A6
T6/RC47
A6
PRE_FRONT (A6/D3)
C
(ONLY A6/D3)
ONLY A6/D3
(D3 ONLY)
TX-NR616
TX-NR616MJJ
T7
Table: H
LIST
LIST
LIST
LIST
SW1(ONLY T6/RC47)
SW2
R4029
FROM BADG-1087
FROM PART 7
BD TO BD
FROM BADG-1087
FROM PART 7
BD TO BD
FROM BADG-1087
FROM PART 7
BD TO BD
FROM PART 5
FROM BAAF-1078
FROM PART 5
FROM BAAF-1078
AMP
AMP
TO PART 5
T0 PART 5
TO BATRM-1089
TO PART 8
BAAF-1078 (1/2)
ASP
C4103
47/50
C4104
47/50
Q4171 79M15
3
O2I
1
G
R4101
220K
R4106
220K
R4127
100
R4023
0
R4226
0
R4210
0
C4102
47/50
Q4117
RN1441
R4182
220K
C4187
220/25
C4185
220/25
Q4185
2SA965
R4211
0
C4184
220/25
C4186
220/25
C4172
220/25
R4184
1K
C4173
220/25
D4305
D4304
R4088 2.2K
R4087
2.2K
Q4100
RN1441
R4102
220K
Q4102
RN1441
Q4104
RN1441
R4183
1K
R4233
0
C4079 47/50
C4078
47/50
R4084
100K
R4083
100K
Q4184
2SC2235
C4052
220/10
R4075
220K
R4076
220K
R4073
220K
R4077
22KR4074
220K
C4027
221J
C4030
221J
C4031
221J
C4033
221J
C4171
10/50
C4170
10/50
R4043
100K
R4044
100K
C4008
221JE
C4007
221JE
R4014
330
C4014
221J
C4013
221J
C4009
221J
R4010
330
C4010
221J
R4009
330
R4047
100K
R4048
100K
R4049
100K
R4050
100K
R4053
100K
R4054
100K
C4003
221J
R4013
330
C4004
221J
TP4401
C4055
47/25
R4227
0
R4228
0
D4200
KDS4148U
C4200
103K
Q4201
RN1402
D4201
KDS4148U
C4211 103K
RL421
8
10
5
3
12 1
4
9
C4207
221J
D4207
D4208
R4094
10K
R4190
220K
R4091
22K
R4090
12K
C4090 101J
R4092
330
R4096
330
R4097
3.3K
R4189
220K
R4095
10K
C4166
220/25
C4210
47/25
C4167
220/25
R4099
22K
R4098
12K
R4093
3.3K
C4091 101J
Q4003A
NJM4580M
1
2
3
4
Q4003B
NJM4580M
7
8
6
5
R4167
22
C4209
47/25
R4181
220K
R4028
100
R4166
22
R4171
1W
8.2
R4180
220K
R4185
220K
R4170
1W
3.3
C4302
470/35
C4301
1000/35
C4300
334J
D4300
D4301
RL1N4003
D4303D4302
R4192
220K
R4194
220K
R4193
220K
R4196
220K
R4195
220K
C4056
47/25
R4082 100K
R4132
15K
R4131
47K
C4131
221J
R4133
1.2K
Q4130B
NJM4580M
5
6
8
7
R4130
220
R4220
0
C4106
47/50
R4221
0
Q4301
M61540FP
1
AGND
2
LIN
3
RIN
4
CIN
5
SWIN
6
SLIN
7
SRIN
8
AGND
9
SROUT
10
SLOUT
11
SWOUT12COUT13DVDD14DATA
15
CLOCK
16
DGND
17
ROUT
18
LOUT
19
BASR2
20
BASR1
21
BASL2
22
BASL1
23
TRER
24
TREL
25
AGND
26
INR1
27
INL1
28
INR2
29
INL2
30
INR3
31
INL3
32
AGND
33
INL4
34
INR4
35
INL5
36
INR5
37
AVCC
38
AVEE
39
ADCR
40
ADCL
R4320
220K
R4312
470
R4313
470
C4309333J
C4310333J
C4311224J
C4313473J
R4315
4.7K
C4314
473J
R4314
4.7K
R4317
2.2K
C4315
220/25
R4319
470
R4318
2.2K
D4306
UDZS3.6B
R4326
10
R4321
220K
R4201
0
R4202
0
R4089
0
R4230
0
R4231
0
C407147/50
C407047/50
C4077
47/50
C407247/50
C407447/50
C407347/50
C407647/50
C407547/50
R4079
47K
R4078
47K
TP5502
Q4170 78M15
3
O
2
G
1
I
R4007
330
R4008
330
R4507
10K
R4511
6.8K
R4512
2.7K
R4514
220K
C4508
47/50
R4232
0
C4502
47/50
C4501
47/50
Q4503B
NJM4580M
6
5
7
8
Q4503A
NJM4580M
2
3
4
1
Q4502B
NJM4580M
6
5
7
8
Q4502B
NJM4580M
6
5
7
8
Q4502B
NJM4580M
6
5
7
8
Q4502B
NJM4580M
6
5
7
8
C4050
220/10
C4051
220/10
C4053
47/25
C4057
47/25
C4054
47/25
R4327
10
C4108
47/50
C4109
47/50
C4175
470/16
R4308
2.2K
R4309
2.2K
R4311
220K
R4310
220K
Q4303
RN1441
C4305
221J
C4306
221J
C4321
47/50
C4320
47/50
C4322
221J
C4323
221J
D4307
KDS4148U
D4308
KDS4148U
C4324 102J
R4329
2.2K
R4330
2.2K
R4331
220K
R4332
220K
C4318
470/16
C4319
470/16
C4308
47/50
C4307
47/50
R4302
0
R4333
0
R4029
100
R4027
22K
C4037
221J
R4303
0
R4301
0
R4117
270
C4107
47/50
R4222
0
R4107
220K
R4103
220K
C4105
47/50
R4105
220K
R4104
220K
C4101
47/50
C4100
47/50
R4100
220K
Q4103
RN1441
Q4101
RN1441
Q4200
RN1402
Q4107
RN1441
Q4106
RN1441
Q4105
RN1441
R4022
0
R4510
220K
C4510
47/25
Q4302
RN1441
R4334
0
C4312
224J
R4174
(1W)
22
R4176
(1W)
22
R4175
(1W)
22
R4177
(1W)
22
C4203 102J
R4018
330
C4018
221J
R4017
330
R4058
100K
R4059
100K
C4019
221JE
C4020
221JE
R4019
330
R4060
100K
C4017
221J
R4057
100K
C4204
102J
R4020
330
C4130
47/50
C4206
102
R4328
0
R4316
10K
C4506
105J
R4004
330
Q4305
RN1441
Q4304
RN1441
R4335
0
R4336
0
R4505
10K
Q4501A
NJM4580M
2
3
4
1
Q4501B
NJM4580M
5
6
8
7
R4502
220K
R4501
220K
R4506
10K
C4507
224Z
R4513
6.8K
R4519
0
R4518
0
C4503 NM
C4504 NM
Q4130A
NJM4580M
3
2
1
4
C4132103J
R4134
10K
D4400
UDZS5.6B
C4174
470/16
D4172
UDZS7.5B
D4171
UDZS7.5B
R4122
100
R4116
120
R4125
100
R4114
120
R4123
100
R4113
120
R4111
120
R4110
120
R4120
100
Q4115
RN1441
Q4111
RN1441
Q4110
RN1441
Q4112
RN1441
Q4116
RN1441
R4126
100
R4115
120
Q4114
RN1441
R4124
100
Q4113
RN1441
R4121
100
R4160
1W
3.3
R4162
1W
3.3
R4163
1W
3.3
R4161
1W
3.3
R4031
100
R4030
100
R4071
220K
R4070
220K
R4072
220K
R4032
100
R4034
100
R4033
100
C4032
221J
C4034
221J
C4036
221J
C4035
221J
R4036
100
R4035
100
R4200
0
C4208221J
R4038
100
C4205 102J
D4217
KDS4148U
D4218
KDS4148U
P101B NSCT-09P2102
1
234
5
6
7
8
9
R4225
0
R4300
0
R4112
120
R4307
220K
R4306
220K
R4323
220K
R4322
220K
R4305
100
R4304
100
R4325
100
R4324
100
C4002
221J
C4001
221J
R4069
100K
R4108
220K
R4109
220K
R4223
0
Q4001
R2A15220FP
80
INR11/RECR5
79
INL10/RECL4
78
INR10/RECR4
77
INLB/RECL2
76
INRB/RECR2
75
INL9
74
INR9
73
INLA/RECL1
72
INRA/RECR1
71
INL8
70
INR8
69
INL7
68
INR7
67
INL6
66
INR6
65
INL5
64
INR5
63
INL4
62
INR4
61
INL3
60
INR3
59
INL2
58
INR2
57
INL1
56
INR1
55
AGND
54
ADCR
53
ADCL
52
AVEE
51
MUTE
50
DATA
49
CLOCK
48
DGND
47
SUBR1
46
SUBL1
45
SBLCIN
44
SBRCIN
43
FRIN2
42
FLIN2
41
SRIN2
40
SLIN2
39
SWIN238CIN237SBRIN236SBLIN235SLCIN
34
SRCIN
33
SUBR2
32
SUBL2
31
AVCC
30
TRER
29
BASSR2
28
BASSR1
27
TREL
26
BASSL2
25
BASSL1
24
FRC
23
FR_Pri-OUT
22
FR_OUT
21
AGND
20
FL_OUT
19
FL_Pri_OUT
18
FLC
17
CC
16
C_OUT
15
AGND
14
SW_OUT
13
SWC
12
SRC
11
SR_Pri_OUT
10
SR_OUT
9
AGND
8
SL_OUT
7
SLPri_OUT
6
SLC
5
AGND
4
SBRC
3
SBR_Pri_OUT
2
SBR_OUT
1
AGND
100
SBL_OUT
99
SBL_Pri_OUT
98
SBLC
97
SBR_IN1
96
SBL-IN1
95
SRIN1
94
SLIN1
93
SWIN1
92
CIN1
91
FRIN1
90
FLIN1
89
RECL3
88
RECR3
87
INL14
86
INR14
85
INL13
84
INR13
83
INL12
82
INR12
81
INL11/RECL5
R4042
100K
R4001
330
R4041
100K
JL604A
NSCT-5P896
1
2
3
4
5
C6351
103J
C6352
103J
C6353
102J
C6354
102J
P6351
NTM-4PDML422
5
4
2
3
1
6
L
R
JL408A
1
P4003
LIST
7
2
1
3
5
4
6
P4004
LIST
7
2
1
3
5
4
6
P4009
LIST
6
4
5
3
1
2
7
JL408B
1
P5505B
1
R4401
1K
R4400
1K
C4060 47/50C4060 47/50
C4061
47/50
R4402
100K
R4404
680
R4405
(1W)
100
Q4400
2SC2235-Y
C4403
47/25
C4404
47/25
R4420
0
R4421
0
R4423
100KK
R4424
100KK
R4428
22
C4420
47/50
C4424
47/25
Q4420B
NJM4580M
5
6
8
7
C4421
47/50
R4425
100K
R4426
100K
C4423
47/25
Q4420A
NJM4580M
3
2
1
4
R4427
22
R4003
330
R4002
330
P4002
LIST
7
2
1
3
5
4
6
P4001
4
2
1
3
R4406
680
R4407
33K
RL420
8
10
5
3
12
1
4
9
C4405
104Z
R4408
NM
C4402
104Z
Q4170A RAD-196
2
1
4
3
C4505
47/50
P4007
LIST
6
4
5
3
1
2
7
P4008
LIST
6
4
5
3
1
2
7
P5510B
1234
P5508
234 1
P6205
CB-71683(L=50)
P6204
CB-71683(L=50)
P6206
CB-71683(L=50)
P6207
CB-71683(L=50)
R4229
0
R4128
22
R4168
22
J4302
J4301
C4316
47/50
C4317
47/50
P4010
LIST
4
2
1
3
P4010
LIST
4
2
1
3
R4403
100K
C4401 102K
C4400 102K
R4517
0
C4509
47/25
Q4502A
NJM4580M
2
3
4
1
R4520
NM
R4515
22
R4516 22
R4508
10K
R4509
NM
R4503
5.6K
R4504
68K
P5502B
12345
6
7
8
9
10
11
12
131415
16
171819
20
P5503B
1
2
345
6
7
P5504B
1
234
5
6
7
8
9
101112
13
P6200B
1
2
3
4
5
6
7
8
9
10
11
12
13
MODEL NO. TX-NR616/HT-RC470/DTR-30.4
SCHEMATIC DIAGRAM (PART-4) ASP SECTION
2011.12.27
U0010
AUDIO PC BOARD
K
G
C
B
D
A
1
2
3
4
5
B C D E F G H
6
7
8
I
J K
Loading...