Page 1
SERVICE MANUAL
CD RECEIVER
MA445<Rev.001>20093SERVICE MANUAL
KD-R701E, KD-R701EX, KD-R701EY,
KD-R701EU, KD-R705U, KD-R705UN,
KD-R705UT, KD-R705UH, KD-R707EE
(except KD-R705)
COPYRIGHT © 2009 Victor Company of Japan, Limited
Lead free solder used in the board (material : Sn-Ag-Cu, melting point : 219 Centigrade)
Lead free solder used in the board (material : Sn-Cu, melting point : 230 Centigrade)
1 PRECAUTION. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-6
2 SPECIFIC SERVICE INSTRUCTIONS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-9
3 DISASSEMBLY . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-9
4 ADJUSTMENT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-18
5 TROUBLESHOOTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-24
COPYRIGHT © 2009 Victor Company of Japan, Limited
TABLE OF CONTENTS
No.MA445<Rev.001>
2009/3
Page 2
SPECIFICATION
KD-R701
AUDIO AMPLIFIER SECTION
Maximum Power Output Front/Rear 50 W per channel
Continuous Power Output (RMS) Front/Rear 19 W per channel into 4 Ω, 40 Hz to 20 000 Hz at no more than 0.8%
Load Impedance 4 Ω (4 Ω to 8 Ω allowance)
Tone Control Range Bass ±12 dB (60 Hz, 80 Hz, 100 Hz, 200 Hz) Q1.0, Q1.25, Q1.5, Q2.0
Middle ±12 dB (0.5 kHz, 1.0 kHz, 1.5 kHz, 2.5 kHz) Q0.75, Q1.0, Q1.25
Treble ±12 dB (10.0 kHz, 12.5 kHz, 15.0 kHz, 17.5 kHz) Q = Fixed
Frequency Response 40 Hz to 20 000 Hz
Signal-to-Noise Ratio 70 dB
Line-Out Level/Impedance 2.5 V/20 kΩ load (full scale)
Subwoofer-Out Level/Impedance 2.5 V/20 kΩ load (full scale)
Output Impedance 1 kΩ
Other Terminal USB input jack, AUX (auxiliary) input jack, CD changer jack, Steering
Frequency Range FM 87.5 MHz to 108.0 MHz
AM MW: 522 kHz to 1 620 kHz
FM Tuner Usable Sensitivity 9.3 dBf (0.8 µV/75 Ω)
50 dB Quieting Sensitivity 16.3 dBf (1.8 µV/75 Ω)
Alternate Channel Selectivity (400 kHz) 65 dB
Frequency Response 40 Hz to 15 000 Hz
Stereo Separation 40 dB
MW Tuner Sensitivity 20 µV
Selectivity 40 dB
LW Tuner Sensitivity 50 µV
CD PLAYER SECTION
Type Compact disc player
Signal Detection System Non-contact optical pickup (semiconductor laser)
Number of Channels 2 channels (stereo)
Frequency Response 5 Hz to 20 000 Hz
Dynamic Range 96 dB
Signal-to-Noise Ratio 98 dB
Wow and Flutter Less than measurable limit
MP3 Decoding Format: (MPEG1/2 Audio Layer 3) Max. Bit Rate: 320 kbps
WMA (Windows Media
USB Standard USB 1.1, USB 2.0
Data Transfer Rate (Full Speed) Max. 12 Mbps
Compatible Device Mass storage class
Compatible File System FAT 32/16/12
Playable Audio Format MP3/WMA
Max. Current DC 5 V 500 mA
Power Requirement Operating Voltage DC 14.4 V (11 V to 16 V allowance)
® Audio) Decoding Format Max. Bit Rate: 320 kbps
total harmonic distortion.
wheel remote input
TUNER SECTION
LW: 144 kHz to 279 kHz
USB SECTION
GENERAL
1-2 (No.MA445<Rev.001>)
Page 3
Grounding System Negative ground
Allowable Operating Temperature 0°C to +40°C
Dimensions (W × H × D): (approx.) Installation Size 182 mm × 52 mm × 160 mm
Panel Size 188 mm × 58 mm × 12 mm
Mass 1.3 kg (excluding accessories)
Design and specifications are subject to change without notice.
KD-R705
AUDIO AMPLIFIER SECTION
Maximum Power Output Front/Rear 50 W per channel
Continuous Power Output (RMS) Front/Rear 19 W per channel into 4 Ω, 40 Hz to 20 000 Hz at no more than 0.8%
total harmonic distortion.
Load Impedance 4 Ω (4 Ω to 8 Ω allowance)
Tone Control Range Bass ±12 dB (60 Hz, 80 Hz, 100 Hz, 200 Hz) Q1.0, Q1.25, Q1.5, Q2.0
Middle ±12 dB (0.5 kHz, 1.0 kHz, 1.5 kHz, 2.5 kHz) Q0.75, Q1.0, Q1.25
Treble ±12 dB (10.0 kHz, 12.5 kHz, 15.0 kHz, 17.5 kHz) Q = Fixed
Frequency Response 40 Hz to 20 000 Hz
Signal-to-Noise Ratio 70 dB
Line-Out Level/Impedance 2.5 V/20 kΩ load (full scale)
Subwoofer-Out Level/Impedance 2.5 V/20 kΩ load (full scale)
Output Impedance 1 kΩ
Other Terminal USB input jack, AUX (auxiliary) input jack, CD changer jack
TUNER SECTION
Frequency Range FM 87.5 MHz to 108.0 MHz
AM 531 kHz to 1 602 kHz
FM Tuner Usable Sensitivity 9.3 dBf (0.8 µV/75 Ω)
50 dB Quieting Sensitivity 16.3 dBf (1.8 µV/75 Ω)
Alternate Channel Selectivity (400 kHz) 65 dB
Frequency Response 40 Hz to 15 000 Hz
Stereo Separation 40 dB
AM Tuner Sensitivity 20 µV
Selectivity 40 dB
CD PLAYER SECTION
Type Compact disc player
Signal Detection System Non-contact optical pickup (semiconductor laser)
Number of Channels 2 channels (stereo)
Frequency Response 5 Hz to 20 000 Hz
Dynamic Range 96 dB
Signal-to-Noise Ratio 98 dB
Wow and Flutter Less than measurable limit
MP3 Decoding Format: (MPEG1/2 Audio Layer 3) Max. Bit Rate: 320 kbps
WMA (Windows Media
USB Standard USB 1.1, USB 2.0
Data Transfer Rate (Full Speed) Max. 12 Mbps
Compatible Device Mass storage class
Compatible File System FAT 32/16/12
Playable Audio Format MP3/WMA
® Audio) Decoding Format Max. Bit Rate: 320 kbps
USB SECTION
(No.MA445<Rev.001>)1-3
Page 4
Max. Current DC 5 V 500 mA
GENERAL
Power Requirement Operating Voltage DC 14.4 V (11 V to 16 V allowance)
Grounding System Negative ground
Allowable Operating Temperature 0°C to +40°C
Dimensions (W × H × D): (approx.) Installation Size 182 mm × 52 mm × 160 mm
Panel Size 188 mm × 58 mm × 6 mm
Mass 1.3 kg (excluding accessories)
Design and specifications are subject to change without notice.
KD-R707
AUDIO AMPLIFIER SECTION
Maximum Power Output Front/Rear 50 W per channel
Continuous Power Output (RMS) Front/Rear 19 W per channel into 4 Ω, 40 Hz to 20 000 Hz at no more than 0.8%
total harmonic distortion.
Load Impedance 4 Ω (4 Ω to 8 Ω allowance)
Tone Control Range Bass ±12 dB (60 Hz, 80 Hz, 100 Hz, 200 Hz) Q1.0, Q1.25, Q1.5, Q2.0
Middle ±12 dB (0.5 kHz, 1.0 kHz, 1.5 kHz, 2.5 kHz) Q0.75, Q1.0, Q1.25
Treble ±12 dB (10.0 kHz, 12.5 kHz, 15.0 kHz, 17.5 kHz) Q = Fixed
Frequency Response 40 Hz to 20 000 Hz
Signal-to-Noise Ratio 70 dB
Line-Out Level/Impedance 2.5 V/20 kΩ load (full scale)
Subwoofer-Out Level/Impedance 2.5 V/20 kΩ load (full scale)
Output Impedance 1 kΩ
Other Terminal USB input jack, AUX (auxiliary) input jack
TUNER SECTION
Frequency Range FM 87.5 MHz to 108.0 MHz
FM-LO 65.00 MHz to 74.00 MHZ
AM MW: 522 kHz to 1 620 kHz
LW: 144 kHz to 279 kHz
Usable Sensitivity 9.3 dBf (0.8 µV/75 Ω)
50 dB Quieting Sensitivity 16.3 dBf (1.8 µV/75 Ω)
Alternate Channel Selectivity (400 kHz) 65 dB
Frequency Response 40 Hz to 15 000 Hz
Stereo Separation 40 dB
MW Tuner Sensitivity 20 µV
Selectivity 40 dB
LW Tuner Sensitivity 50 µV
CD PLAYER SECTION
Type Compact disc player
Signal Detection System Non-contact optical pickup (semiconductor laser)
Number of Channels 2 channels (stereo)
Frequency Response 5 Hz to 20 000 Hz
Dynamic Range 96 dB
Signal-to-Noise Ratio 98 dB
Wow and Flutter Less than measurable limit
MP3 Decoding Format: (MPEG1/2 Audio Layer 3) Max. Bit Rate: 320 kbps
1-4 (No.MA445<Rev.001>)
Page 5
WMA (Windows Media
USB Standard USB 1.1, USB 2.0
Data Transfer Rate (Full Speed) Max. 12 Mbps
Compatible Device Mass storage class
Compatible File System FAT 32/16/12
Playable Audio Format MP3/WMA
Max. Current DC 5 V 500 mA
Power Requirement Operating Voltage DC 14.4 V (11 V to 16 V allowance)
Grounding System Negative ground
Allowable Operating Temperature 0°C to +40°C
Dimensions (W × H × D): (approx.) Installation Size 182 mm × 52 mm × 160 mm
Mass 1.3 kg (excluding accessories)
Design and specifications are subject to change without notice.
® Audio) Decoding Format Max. Bit Rate: 320 kbps
USB SECTION
GENERAL
Panel Size 188 mm × 58 mm × 12 mm
(No.MA445<Rev.001>)1-5
Page 6
1.1 Safety Precautions
!
!
!
!
SECTION 1
PRECAUTION
Burrs formed during molding may be left over on some parts of the chassis. Therefore,
Burrs formed during molding may be left over on some parts of the chassis. Therefore,
pay attention to such burrs in the case of preforming repair of this system.
pay attention to such burrs in the case of preforming repair of this system.
Please use enough caution not to see the beam directly or touch it in case of an
Please use enough caution not to see the beam directly or touch it in case of an
adjustment or operation check.
adjustment or operation check.
1-6 (No.MA445<Rev.001>)
Page 7
1.2 Preventing static electricity
Electrostatic discharge (ESD), which occurs when static electricity stored in the body, fabric, etc. is discharged, can destroy the laser
diode in the traverse unit (optical pickup). Take care to prevent this when performing repairs.
1.2.1 Grounding to prevent damage by static electricity
Static electricity in the work area can destroy the optical pickup (laser diode) in devices such as laser products.
Be careful to use proper grounding in the area where repairs are being performed.
(1) Ground the workbench
Ground the workbench by laying conductive material (such as a conductive sheet) or an iron plate over it before placing the
traverse unit (optical pickup) on it.
(2) Ground yourself
Use an anti-static wrist strap to release any static electricity built up in your body.
(caption)
(caption)
Anti-static wrist strap
Anti-static wrist strap
1M
1M
(3) Handling the optical pickup
• In order to maintain quality during transport and before installation, both sides of the laser diode on the replacement optical
pickup are shorted. After replacement, return the shorted parts to their original condition.
(Refer to the text.)
• Do not use a tester to check the condition of the laser diode in the optical pickup. The tester's internal power source can easily
destroy the laser diode.
1.3 Handling the traverse unit (optical pickup)
(1) Do not subject the traverse unit (optical pickup) to strong shocks, as it is a sensitive, complex unit.
(2) Cut off the shorted part of the flexible cable using nippers, etc. after replacing the optical pickup. For specific details, refer to the
replacement procedure in the text. Remove the anti-static pin when replacing the traverse unit. Be careful not to take too long a
time when attaching it to the connector.
(3) Handle the flexible cable carefully as it may break when subjected to strong force.
(4) It is not possible to adjust the semi-fixed resistor that adjusts the laser power. Do not turn it.
1.4 Attention when traverse unit is decomposed
*Please refer to "Disassembly method" in the text for the pickup unit.
• Apply solder to the short land before the card wire is disconnected from the connector on the pickup unit.
(If the card wire is disconnected without applying solder, the pickup may be destroyed by static electricity.)
• In the assembly, be sure to remove solder from the short land after connecting the card wire.
Conductive material
Conductive material
(conductive sheet) or iron plate
(conductive sheet) or iron plate
Mechanism control board
CN102
Flexible wire
Short land section
Pickup
(No.MA445<Rev.001>)1-7
Page 8
1.5 Important for laser products
1.CLASS 1 LASER PRODUCT
2.CAUTION :
(For U.S.A.) Visible and/or invisible class II laser radiation
when open. Do not stare into beam.
(Others) Visible and/or invisible class 1M laser radiation
when open. Do not view directly with optical instruments.
3.CAUTION : Visible and/or invisible laser radiation when
open and inter lock failed or defeated. Avoid direct
exposure to beam.
4.CAUTION : This laser product uses visible and/or invisible
laser radiation and is equipped with safety switches which
prevent emission of radiation when the drawer is open and
the safety interlocks have failed or are defeated. It is
dangerous to defeat the safety switches.
5.CAUTION : If safety switches malfunction, the laser is able
to function.
6.CAUTION : Use of controls, adjustments or performance of
procedures other than those specified here in may result in
hazardous radiation exposure.
!
Please use enough caution not to
see the beam directly or touch it
in case of an adjustment or operation
check.
REPRODUCTION AND POSITION OF LABELS and PRINT
WARNING LABEL and PRINT
1-8 (No.MA445<Rev.001>)
Page 9
SECTION 2
SPECIFIC SERVICE INSTRUCTIONS
This service manual does not describe SPECIFIC SERVICE INSTRUCTIONS.
SECTION 3
DISASSEMBLY
3.1 Main body (Used figure are KD-R701)
3.1.1 Removing the Bottom chassis (See Fig.1)
(1) Remove the two screws A and one screw B attaching the
Heat sink.
(2) Remove the one screw C attaching the RCA jack.
(3) Remove the one screw D attaching the Bottom chassis.
(4) Slide to backward and then remove the Bottom chassis.
AB CDA
Fig.1
3.1.2 Removing the Front chassis (See Fig.2)
(1) Remove the two screws E attaching the both side of the
Front chassis.
(2) Disengage four hooksaengaged both side of the Front
chassis.
(2) Remove the one screw H attaching the CD-CH jack. (See
Fig.4)
H
Fig.4
(3) Remove the three screws J attaching the Main board. (See
Fig.5)
(4) Disconnect the board to board connector CN501
ed to CD mechanism. (See Fig.5)
connect-
J
CN501
J
hook
3.1.3 Removing the Main board (See Fig.3 to 5)
(1) Remove the two screws F and one screw G attaching the
Side panel. (See Fig.3)
E
a
hook
Fig.2
FG F
Fig.3
Fig.5
a
3.1.4 Removing the CD mechanism (See Fig.6)
(1) Remove the three screws K attaching the CD mechanism.
K
K
K
Fig.6
(No.MA445<Rev.001>)1-9
Page 10
3.1.5 Removing the Function board (See Fig.7, 8)
(1) Remove the three screws L attaching the connector brack-
et. (See Fig.7)
L
Fig.7
(2) Disengage one hook b engaged connector bracket and
slide to right ward and the take out the connector bracket.
(See Fig.8)
hook
b
Fig.8
3.1.6 Removing the Switch board (See Fig.9)
(1) Remove the volume knob.
(2) Remove the four screws M attaching the Rear cover.
(3) Disengage ten hooks c engaged Rear cover.
hook
hook
c
c
M
Fig.9
hook
c
M
hook
M
c
1-10 (No.MA445<Rev.001>)
Page 11
3.2 CD MECHANISM assembly section
• Remove the CD MECHANISM assembly from the main body.
Removing the MECHANISM CONTROL BOARD
3.2.1
1
assembly (See Fig.
(1)
From the bottom side of CD MECHANISM assembly,
remove the solders from the soldered sections (
c
) on the MECHANISM CONTROL BOARD assembly.
(See Fig.
(2) Remove the three screws A attaching the MECHANISM
CONTROL BOARD assembly. (See Fig.1.)
(3) Solder the short land sections on the pickup. (See Fig.2.)
Caution:
• Solder the short land sections on the pickup before
•
1
.)
disconnecting the flexible wire from the connector
on the MECHANISM CONTROL BOARD as-
CN102
sembly.
If the card wire is disconnected without attaching
solder, the pickup may be destroyed by static
electricity. (See Fig.2.)
When attaching the MECHANISM CONTROL
BOARD assembly, remove the solders from the
short land sections after connecting the flexible
wire to the connector CN102
CONTROL BOARD assembly.
and 2)
a, b
and
on the MECHANISM
Mechanism
a
b
control board
CN102
A
A
c
A
Fig.1
Mechanism control board
CN102
Flexible wire
Short land section
Pickup
Fig.2
(No.MA445<Rev.001>)1-11
Page 12
3.2.2 Removing the top cover (See Fig.3 to 5)
• Remove the MECHANISM CONTROL BOARD assembly.
(1) From the front side of the CD MECHANISM assembly,
change the hook position of the two roller springs. (See
Fig.3.)
(2) From the side of the CD MECHANISM assembly, remove
the six screws B attaching the top cover. (See Fig.3 and 4.)
(3) Take out the top cover in an upward direction. (See Fig.5.)
Top cover
Top cover
B
B
Roller spring Roller spring
Roller spring Roller spring
Fig.3
Top cover
Top cover
Fig.5
3.2.3 Removing the roller (See Fig.6)
• Remove the MECHANISM CONTROL BOARD assembly and
top cover.
(1) From the bottom side of the top cover, remove the screw C
attaching the gear holder.
(2) Remove the R.holder assembly from disc plate, and then
take out the roller from R.holder assembly in the direction
of the arrow.
Reference:
When attaching the R.ACT gear (2) and R.ACT gear (3),
apply grease to the section d of R.holder assembly.
Top cover
B
B
Fig.4
1-12 (No.MA445<Rev.001>)
Fig.6
3.2.4 Removing the PHOTO BOARD assembly (See Fig.7
and 8)
• Remove the MECHANISM CONTROL BOARD assembly and
top cover.
Page 13
(1)
From the bottom side of the top cover, release the
e
projection
Fig.
7
.)
(2) Take out the disc plate in the direction of the arrow. (See
Fig.7.)
(3) From the reverse side of the disc plate, remove the screw
D attaching the PHOTO BOARD assembly. (See Fig.8.)
from the notch of the disc plate. (See
e
e
SUS
SUS
spring
spring
Mechanism section
Mechanism section
Mecha frame
Mecha frame
SUS
SUS
spring
spring
E
E
Top cover
Fig.7
Disc plate
D
Photo board
Disc plate
Fig.8
3.2.5 Removing the mechanism section (See Fig.9 and 10)
• Remove the MECHANISM CONTROL BOARD assembly and
top cover.
(1)
From the top side of the CD MECHANISM assembly,
E
remove the two screws
assembly. (See Fig.
(2) Remove the two roller springs on the top side of the mecha
frame. (See Fig.9.)
(3) Remove the four SUS springs on the top side of the mecha
frame. (See Fig.9.)
(4) Remove the link spring on the top side of the mecha frame.
(See Fig.10.)
(5) Release section f of the three dampers from the mecha
frame. (See Fig.10.)
Reference:
When attaching the roller spring and SUS spring, keep
direction before remove.
Move the slide cam (R) assembly in the direction of the
(6)
arrow, and then take out the mechanism section in an
upward direction. (See Fig.
Reference:
When attaching the mechanism section, apply grease to
the section g. (See Fig.10.)
attaching the loading motor
9
.)
10.)
SUS
SUS
spring
spring
Roller spring
Roller spring
Loading motor assembly
Loading motor assembly
Fig.9
F
F
Cam cover
Cam cover
Mecha frame
Mecha frame
Fig.10
SUS
SUS
spring
spring
(No.MA445<Rev.001>)1-13
Page 14
3.2.6 Removing the slide cam (L) (See Fig.11 to 13)
• Remove the MECHANISM CONTROL BOARD assembly, top
cover and mechanism section.
(1) From the top side of the mecha frame, remove the screw F
attaching the cam cover. (See Fig.11.)
Take out the cam cover from mecha frame in an upward
(2)
11
F
F
.)
Cam cover
Cam cover
direction. (See Fig.
(3) Take out the slide cam (L) in the direction of the arrow.
(See Fig.12.)
Reference:
When attaching the slide cam (L), apply grease to the
section h. (See Fig.13.)
Slide cam(L)
Slide cam(L)
h
h
Fig.12
h
h
Slide cam(L)
Slide cam(L)
Mecha frame
Mecha frame
Mecha frame
Mecha frame
Fig.11
h
h
h
h
Slide cam(L)
Slide cam(L)
h
h
Fig.13
h
h
h
h
h
h
1-14 (No.MA445<Rev.001>)
Page 15
3.2.7 Removing the F.lock lever and slide cam (R) (See
Fig.14 and 15)
• Remove the MECHANISM CONTROL BOARD assembly, top
cover and mechanism section.
(1) From the top side of the mecha frame, take out the slide
cam (R) assembly in an upward direction. (See Fig.14.)
(2) Rotate the F.lock lever in the direction of the arrow 1, and
then take out the direction of the arrow 2. (See Fig.14.)
Reference:
When attaching the slide cam (R) assembly, the f.lock
lever and the link arm apply grease to the section
14
(See Fig.
F.lock lever
F.lock lever
and 15.)
Slide cam(R) assembly
Slide cam(R) assembly
h
h
2
2
1
1
h
h
h
h
h
3.2.8 Removing the damper (See Fig.16)
• Remove the MECHANISM CONTROL BOARD assembly, top
cover and mechanism section.
From the mechanism section, pull out the three dampers in the
direction of the arrow.
Reference:
Before inserting the shaft to the dampers, apply IPA to the
pocket j of damper.
.
Damper (Brown)
Damper (Brown)
j
j
j
j
Damper (Gray)
Damper (Gray)
j
j
Damper (Brown)
Damper (Brown)
Fig.16
Mecha frame
Mecha frame
h
h
h
h
Link arm
h
h
h
h
Link arm
Fig.14
Slide cam(R) assembly
Slide cam(R) assembly
h
h
h
h
h
h
Slide cam(R) assembly
Slide cam(R) assembly
Fig.15
3.2.9 Removing the clamper assembly (See Fig.17)
• Remove the MECHANISM CONTROL BOARD assembly, top
h
h
cover and mechanism section.
(1) From the top side of the mechanism section, release the
clamper spring.
(2) Move the clamper assembly in the direction of the arrow,
and then release the joints (k and m).
Take out the clamper assembly from the T.M chassis
(3)
assembly.
h
h
Clamper assembly
Clamper assembly
Clamper spring
Clamper spring
k
k
T.M. chassis assembly
T.M. chassis assembly
m
m
Fig.17
(No.MA445<Rev.001>)1-15
Page 16
3.2.10 Removing the feed motor (See Fig.18 and 19)
r
r
• Remove the MECHANISM CONTROL BOARD assembly, top
cover, mechanism section and clamper assembly.
(1) From the bottom side of the T.M chassis assembly, remove
the two screws G attaching the feed motor assembly. (See
Fig.18.)
Remove the two screws H attaching the feed motor to
(2)
19
f.motor holder. (See Fig.
Reference:
When attaching the f. wheel gear, trigger arm and feed
motor, apply grease to the sections (n, p and q). (See
Fig.18 and 19.)
.)
Feed motor
Feed motor
F.worm gear
F.worm gear
q
q
Comp. spring
Comp. spring
H
H
3.2.11 Removing the SWITCH BOARD assembly (See
Fig.18)
• Remove the MECHANISM CONTROL BOARD assembly, top
cover, mechanism section, clamper assembly and feed motor
assembly.
From the bottom side of the T.M chassis assembly, take out
the SWITCH BOARD assembly in an upward direction from
T.M chassis assembly.
G
G
p
Feed motor assembly
Feed motor assembly
Switch board
Switch board
p
n
n
F.wheel gear
F.wheel gear
Trigger arm
Trigger arm
F.motor holder
F.motor holder
Fig.19
3.2.12 Removing the loading motor (See Fig.20)
• Remove the MECHANISM CONTROL BOARD assembly, top
cover, mechanism section and clamper assembly.
(1) From the right side of the L.M base assembly, remove the
two screws J attaching the loading motor.
(2) Take out the loading motor in the direction of the arrow
from the L.M base assembly.
Reference:
When attaching the loading motor, apply grease to the
section r.
J
J
L.M. base assembly
L.M. base assembly
Fig.20
r
r
L.worm gear
L.worm gear
Loading moto
Loading moto
T.M. chassis assembly
T.M. chassis assembly
Fig.18
1-16 (No.MA445<Rev.001>)
Page 17
3.2.13 Removing the pickup assembly (See Fig.21 to 22)
• Remove the MECHANISM CONTROL BOARD assembly, top
cover, mechanism section, clamper assembly and feed motor
assembly.
Caution:
• Do not touch section u on the pickup assembly. (See Fig.21
and 22.)
(1) From the bottom side of the T.M chassis assembly, move
the pickup assembly in the direction of the arrow from the
T.M chassis assembly. (See Fig.21.)
(2) Pull out the main shaft. (See Fig.21.)
(3) Remove the screw K attaching the pickup to the rack plate.
(See Fig.22.)
Reference:
When attaching the loading motor, apply grease to the
sections s and t. (See Fig.21.)
t
t
Main shaft
Pick up assembly
Pick up assembly
Main shaft
3.2.14 Removing the spindle motor (See Fig.23 and 24)
Remove the MECHANISM CONTROL BOARD assembly,
•
top cover, mechanism section, clamper assembly, feed motor
assembly and pickup assembly.
(1) From the top side of the T.M chassis assembly, remove the
CD T.table assembly from the spindle motor. (See Fig.23.)
(2) Remove the two screws L attaching the spindle motor.
(See Fig.23.)
(3) Take out the spindle motor from the bottom side of the T.M
chassis assembly. (See Fig.23.)
Reference:
When attaching the CD T.table assembly to the spindle
motor shaft, apply loctite 460 to inside the CD T.table
assembly. (See Fig.24.)
LL
LL
CD T.table assembly
CD T.table assembly
u
u
T.M.chassis assembly
T.M.chassis assembly
Spindle motor
Spindle motor
Fig.23
s
s
T.M. chassis assembly
T.M. chassis assembly
Fig.21
K
K
Rack plate
Rack plate
u
u
CD T.table assembly
CD T.table assembly
Spindle motor
Spindle motor
Fig.24
Loctite
Loctite
Pick up
Pick up
Fig.22
(No.MA445<Rev.001>)1-17
Page 18
SECTION 4
ADJUSTMENT
4.1 Test instruments required for adjustment
(1) Digital oscilloscope (100MHz)
(2) Digital tester
(3) Test Disc
(4) Extension cable : EXTCD004-28P
4.2 Standard measuring conditions
Power supply voltage DC14.4V(10.5 to 16V)
Load impedance 20K ohm (2 Speakers connection)
Output Level Line out 2.5V (Vol. MAX)
4.5 How to connect the extension cable for adjusting
Caution:
Be sure to attach the heat sink and rear bracket onto the power amplifier IC and regulator IC respectively, before supply the power.
If voltage is applied without attaching these parts, the power amplifier IC and regulator IC will be destroyed by heat.
Extension cable
EXTCD004-28P
4.3 Standard volume position
Balance and Bass &Treble volume : lndication"0"
Loudness : OFF
4.4 Dummy load
Exclusive dummy load should be used for AM,and FM.
For FM dummy load, there is a loss of 6dB between SSG output and antenna input.
The loss of 6dB need not be considered sincedirect reading of
figures are applied in this working standard.
1-18 (No.MA445<Rev.001>)
Page 19
4.6 Service mode
Operating key: [MENU] [DOWN] (3 sec)
Navigation key : Press [SEL] in any main display item to select that option.
Volume Knob Turn: forward and backward selection
INIT ALL Initialize all data to factory shipment state.
SIRIUS RST SIRIUS Soft Reset
XM RST XM Soft Reset (It clears all contents of built-in RAM and EEPROM, and performs software reset.)
HD RST HD Soft Reset (It clears all contents of built-in RAM and EEPROM, and performs software reset.)
DAB RST DAB Soft Reset (It clears all contents of built-in RAM and EEPROM, and performs software reset.)
BT RST BT Soft Reset (It clears all contents of built-in RAM and EEPROM, and performs software reset.)
RUNNING MODE 1 CD4 module running mode 1 (Only factory use)
(It clears all the contents of built-in RAM and EEPROM, and performs software reset.)
* Active at the time of SIRIUS connection.
* Active at the time of XM connection.
* Active at the time of HD connection.
* Active at the time of DAB connection.
* Active at the time of BT connection.
MODE 2
Note : A disc is inserted, and it is displayed only at the time of CD function.
CHECK MODE NORMAL PLAY Disc operation & playback. (playback from starting position)
CURENT ##** Laser Electric Current Value
JITTER #### Jitter Value
OUT TRK OFF Tracking off at CD outermost lap.
INN TRK OFF Tracking off at CD innermost lap.
CD LASER ON CD Laser Illumination and electric current.
CURENT ##** Laser Electric Current Value
JITTER #### Jitter Value
STOP Disc stop, LD(Laser) OFF
CD ERROR Display the CD Error past record stored in EEPROM.
TOTAL-****: Total error count
E#xxyyyy : Latest 3 errors recorded. #: counter xx: error code yyyy: detailed error code
0#xxyyyy : The first 5 errors recorded. #: counter xx: error code yyyy: detailed error code
Note: Shifting among the above items is done by using "FF" or "REW" key.
CLR CDERROR Clear CD Error history from EEPROM.
CD4 module running mode 2 (Only factory use)
##: Initial value **: Current value
Note: Pressing "FF" or "REW" key to switch between current value
and jitter value display.
##: Initial value **: Current value
Note: Pressing "FF" or "REW" key to switch between current value
aand jitter value display.
CH ERROR Display the CH Error past record stored in EEPROM
* Active at the time of CD CHANGER/ iPod (J-BUS) connection
E#xxyyyy : Latest 3 errors recorded. #: counter xx: error code yyyy: detailed error code
0#xxyyyy : The first 5 errors recorded. #: counter xx: error code yyyy: detailed error code
Note: Shifting among the above items is done by using "FF" or "REW" key.
CLR CHERROR Clear CH Error history from EEPROM.
* Active at the time of CD CHANGER/ iPod (J-BUS) connection
TSUBUYAKI Only engineer use
(No.MA445<Rev.001>)1-19
Page 20
4.7 Tuner service mode
Key operation (FM, AM and DAB mode)
Enter service mode: [SEL] [MENU] (3 sec)
Exit service mode: press [ENTER] (SEL) key.
Go to next item: press [DISP] key
Back to previous item: press [BACK] key
VER=#*** MICON version display
CD4V#### CD4 module version display.
######## Tuner device and version identification display
TINJ= ## Tuner injection indicator
SPI=#### FOR DAB ONLY
# indicates destination: J=USA, U=OTHERS (eg. ASIA), R=EUROPE, E=EASTERN EUROPE
*** indicates version No.
Display :TOM V1 for TOMIC V1 tuner.
Display :TOM V2 for TOMIC V2 tuner.
Display :ATOM V2 for ATOMIC V2 tuner.
Display: ATOM V3 for ATOMIC V3 tuner.
"##" indicates current tuner injection.
To link SID display that DAB receives and FM station (Search PI), the reception situation of DAB is
displayed.
"####" indicates SID code.
FOR RDS ONLY
PI =#### PI display of receiving station, "####" indicates PI code.
PTY=## PTY display of receiving station (00~29), "##" indicates PTY code.
TP=#TA=* TP, TA display of receiving station
"#" indicates TP ON/OFF: 1=ON; 0=OFF;
"*" indicates TA ON/OFF: 1=ON; 0=OFF.
MS=#DI=* M/S, DI display of receiving station
"#" indicates M/S ON/OFF: 1=ON; 0=OFF;
"*" indicates DI ON/OFF: 1=ON; 0=OFF.
AF=#### Display the contents of AF memory (by scrolling) "####" indicate AF frequencies.
LEV= ##H Field strength indicator.
U&W= ##H Adjacent and Multipath noise level indicator.
IFC= ##H IF COUNTER result indicator.
IFBW= # FM IF filter bandwidth indicator.
RFAGC=## FM RF AGC resulting attenuation.
IFAGC=## FM IF AGC resulting attenuation.
##** CLOCK display of receiving station (Original DISP key operation)
######## FOR RDS ONLY
PS NAME display of receiving station (Original DISP key operation)
##### FREQUENCY display of receiving station (Original DISP key operation)
1-20 (No.MA445<Rev.001>)
Page 21
4.8 Error code
4.8.1 Mechanical Error Detail Codes
Condition Details Error Code Detail Code
LOADING Error Error without SW change in LOAD when time-out is done
B1 time out
C1 time out
B2 time out
When there is no change in the state of the switch from the state with
DISC forward.
When there is no change in the state of the switch from the state that
DISC is drawn in a half.
When there is no change in the state of the switch from the state that
DISC is in the interior.
09 0011
09 0012
09 0015
EJECT Error Error without SW change in EJECT when time-out is done.
B1 time out
C2 time out
B2 time out
When there is no change in the state of the switch from the state that
DISC is in the interior.
When there is no change in the state of the switch from the state that
DISC is drawn in a half.
When there is no change in the state of the switch in EJECT from initial
LOAD ERROR.
01 0023
01 0026
01 0027
FORCE EJECT Error Transition to Force EJECT waiting or Force EJECT transition from error by abnormal SW.
E1 FORCE EJECT ERROR When detect abnormal SW from the state of NO DISC 01 0041
E2 FORCE EJECT ERROR When detect abnormal SW from the state with DISC forward in LOAD. 01 0042
E3 FORCE EJECT ERROR When detect abnormal SW from the initial state. 01 0043
E5 FORCE EJECT ERROR
E7 FORCE EJECT ERROR
E8 FORCE EJECT ERROR
E9 FORCE EJECT ERROR
When detect abnormal SW from the state that half DISC is drawn in
LOAD and EJECT.
When detect abnormal SW from the state that DISC is in the interior in
LOAD and EJECT.
When receive Force EJECT key after it makes an error from Force
EJECT.
When receive Force EJECT key after it makes an error from LOAD
error or EJECT error.
01 0045
01 0047
01 0048
01 0049
Error in Running mode
Case 1 When DISC was extracted or fall in EJECT END and EJECT START. 09 0031
Case 2 When DISC is pushed in EJECT END. 09 0032
4.8.2 Disc error code
Condition Details Error Code Detail Code
TOC READING Error When it hasn't completed CD TOC reading. 84 0059
1'st track access Error
Last track access Error
It doesn't end even if the first track access passes 30sec after the TOC
reading ends in the running mode.
It doesn't end even if the last track access passes 30sec after the first
track ends in the running mode.
NO DISC judgment It be judged NO DISC. 80 0090
NO DISC with start failure Not possible to start. 80 0091
Stopped with no playback When it was stopped in playback in the running mode. 80 0093
Logical format NG
Analysis of logical format is impossible or it does not correspond to
logical formats.
80 0060
80 0061
80 0094
(No.MA445<Rev.001>)1-21
Page 22
4.8.3 CD changer mechanism error code
Condition Details Error Code Detail Code
Tray eject error
1.TRAYINSW time over
Tray motor time over
Tray motor does not operate
(TRAYINSW:L, TRAYOUTSW:H)
2.TRAYOUTSW time over
Tray stops
(TRAYINSW:H, TRAYOUTSW:H)
3.TRAYIN/OUTSW time over
TRAYINSW NG etc
(TRAYINSW:L, TRAYOUTSW:L)
4.MAGINSW:L→H
Tray return error
1.TRAYOUTSW time over
Magazine is ejected while Tray is being returned
Tray motor time over
Tray motor does not operate
(TRAYINSW:H, TRAYOUTSW:L)
2.TRAYINSW time over
Tray stops
(TRAYINSW:H, TRAYOUTSW:H)
3.TRAYIN/OUTSW time over
TRAYOUTSW NG etc
(TRAYINSW:L, TRAYOUTSW:L)
4.MAGINSW:L→H
Lifter up error
1.WAIT position time over
2.WAIT position time over
3.WAIT position time over
Lifter down error
1.WAIT position time over
2.WAIT position time over
3.WAIT position time over
Chucking error
1.Play position time over
2.Play position time over
3.Play position time over
Unchucking error
1.WAIT position time over
2.WAIT position time over
3.WAIT position time over
Eject error
1.Eject position time over
2.Eject position time over
3.MAGINSW time over
Magazine is ejected while Tray is being returned
Position motor time over
Position motor does not operate
Position is not stable in fine adjustment mode
Other condition
Position motor time over
Position motor does not operate
Position is not stable in fine adjustment mode
Other condition
Position motor time over
Position motor does not operate
Position is not stable in fine adjustment mode
Other condition
Position motor time over
Position motor does not operate
Position is not stable in fine adjustment mode
Other condition
Eject cannot be carried out
Position motor does not operate
Improper EJECT position *
Magazine is not ejected
Initialize error
1.Mechanism SW NG error
2.Absolute position time over
TRAYINSW and TRAYOUTSW are L
Position is not stable in absolute position
03
03
03
03
03
03
03
03
02
02
02
02
02
02
02
02
02
02
02
02
02
02
01
03
02
0011
0012
0013
0014
0016
0017
0018
0019
0021
0022
0023
0026
0027
0028
0031
0032
0033
0036
0037
0038
0041
0042
0043
0046
0047
*"Position is not stable in WAIT position," "Position is not stable in PLAY position," and "Position is not stable in absolute position,"
and "Improper EJECT are all Position Motor TIME OVER.
1-22 (No.MA445<Rev.001>)
Page 23
4.8.4 CD changer disc error code
Condition Details Error code Detail code
Pickup movement error
1.Time over of pickup movement in
an inner direction (10s)
2.Time over of pickup movement in
an outer direction (10s)
Focus search error
Focus is not adjusted by 3-round fo-
Time over at PUBWD and PUFWD by monitoring RESET SW
Pickup cannot move in an inner direction
04
0051
RESET SW is not on
Pickup cannot move in an outer direction
04
0052
RESET SW is not off
When focus is not adjusted by 3-round(1set) focus search
after disc change or focus shock, the result is NG 81 0053
cus search
Tracking balance adjustment error.
Time over(1s)
TOC area search error
Time over (10s)
Focus balance adjustment error
Time over(2s)
Focus gain adjustment error
Time over(0.6s)
Tracking gain adjustment error
Time over(0.6s)
Tracking balance adjustment is not finished 1s after adjustment
command(TBA) is executed
TOC area search is not finished after 10s
Focus balance adjustment is not finished 2s after adjustment
command(FBA) is executed
Focus gain adjustment error is not finished 0.6s after adjustment
command(FGA) is executed
Tracking gain adjustment error is not finished 0.6s after adjustment command(TGA) is executed
82 0054
80 0055
82 0056
82 0057
82 0058
TOC read error TIME over(30s) TOC read operation is not finished after 30s 84 0059
First track access error
Time over(10s)
Last track access error
Time over(10s)
Q code read error
Time over(0.6s)
First track access is not finished 10s after TOC reading is finished
Last track access is not finished 10s after first track in running
mode
Q code is not read for 0.6s during playback of TOC and program
area
80 0060
80 0061
80 0062
(No.MA445<Rev.001>)1-23
Page 24
TROUBLESHOOTING
5.1 16 PIN CORD DIAGRAM (for KD-R701, KD-R707)
SECTION 5
2
16
15
1
3
13
8
7
6
5
4
3
2
1
RD1
YL1
OR/WH
BK
BL/WH
BR
GN
GN/BK
VI/BK
VI
NC
BL/WH
RD
BK
WH
WH/BK
GY/BK
GY
BR
NC
OR/WH
YL
10
11
12
13
14
15
16
9
Black
BK
RD
BL
WH
VI
Red
Blue
White
Violet
GN
GY Gray
BR
OR
YL
RD2
Green
Brown
Orange
Yellow
1
3
5
7
RD3
YL2
NC
NC
BL/WH
RD3
7
4
6
8
5
2
BR
YL2
OR/WH
BK
2
4
6
8
GN
8
GN/BK
7
VI
5
VI/BK
6
WH
9
WH/BK
10
GY
12
GY/BK
11
1-24 (No.MA445<Rev.001>)
7
8
1
2
5
6
3
4
VI/BK
VI
1
GY
3
WH
5
GN
7
GY/BK
WH/BK
GN/BK
2
4
6
8
Page 25
5.2 16 PIN CORD DIAGRAM (for KD-R705)
1
16
4
3
8
7
6
5
4
3
2
1
BK
YL
BL
BL/WH
GN
GN/BK
VI/BK
VI
BL
BL/WH
RD
BK
WH
WH/BK
GY/BK
GY
NC
NC
OR/WH
YL
9
10
11
12
13
14
15
16
BK
RD
BL
WH
VI
Black
Red
Blue
White
Violet
GN
GY
OR
YL
Green
Gray
Orange
Yellow
RD
2
OR/WH
15
GN
8
GN/BK
7
VI
5
VI/BK
6
WH
9
WH/BK
10
GY
12
GY/BK
11
(No.MA445<Rev.001>)1-25
Page 26
Victor Company of Japan, Limited
Mobile Entertainment Division 10-1,1chome,Ohwatari-machi,Maebashi-city,371-8543,Japan
(No.MA445<Rev.001>)
Printed in Japan
VPT
Page 27
SCHEMATIC DIAGRAMS
CD RECEIVER
KD-R701E,KD-R701EX,KD-R701EY
KD-R701EU,KD-R705U,KD-R705UN
KD-R705UT,KD-R705UH,KD-R707EE
DVD-ROM No.SML2008Q4
(except KD-R705)
Lead free solder used in the board (material : Sn-Ag-Cu, melting point : 219 Centigrade)
Lead free solder used in the board (material : Sn-Cu, melting point : 230 Centigrade)
Contents
Block diagram
Standard schematic diagrams
Printed circuit boards
COPYRIGHT 2009 Victor Company of Japan, Limited.
2-1
2-2
2-6 to 8
No.MA445SCH<Rev.001>
2009/3
Page 28
Safety precaution
!
!
Burrs formed during molding may be left over on some parts of the chassis. Therefore,
pay attention to such burrs in the case of preforming repair of this system.
Please use enough caution not to see the beam directly or touch it in case of an
adjustment or operation check.
Page 29
2-1
Block diagram
MEMORY
TUNER
FM/AM
DETECTOR
RDS
IC71
TUSDA, TUSCL
RDSCL
RDSDA
MUX
4.332MHz
X71
Used for KD-R701, KD-R707
INPUT
AUX
AUX.L/R
CN741
CN742
CN601
J601
J602
CN701
Front section
Sub section
ILM.10V
EJECT
SW
EJECT
S2441
LED
D2443
to
D2441
RGBCLK
LCE
LDA
LCL
KEY0
KEY1
REMOCON
AUX.L/R
AUX.L/R
CPU
IC701
E.VOLUME
IC161
TEL MUTE
Q891
POWER AMP.
IC301
REGULATOR
IC901
EACH BLOCK
TU.L/R
TU.L/R
STEERING
LFOUT, RFOUT
RR+/-
RL+/-
FR+/-
FL+/-
VOL_CLK
VOL_SDA
ANT
J1
BATTERY
SPK
CN901
CD.L/R
CD-USB.RO
CH.L/R
CH.L/R
3.3V,SW5V,ACC5V,VDD5V,CD8V,9V,ILM.10V
ACC, REMOTE
MEMORY
ANT
ILLUMINATION
Used for KD-R701
Used for KD-R701, KD-R707
JVC BUS
BUSSO
BUSSI
/BUSIO
BUSCLK
BUSINT
BUSCK
SI/SO
J801J321
CONTROL
CHANGER
TELMUTE
TELMUTE
PS2
PS2
DIMMER INPUT
Q881
DIMIN
CD_ON
CTRL
32.768kHz
X702
MUTE
MUTE
ANTENNA
AUTO
D851, D852
Used for KD-R705
ANT
ANT
8MHz
X701
SUB WOOFER
REAR/
FRONT
REMOTE
STEERING
CN703
MUTE CONTROL
MUTING
LINE OUT
USB_5V
USB5V
D+/-
USB-D+/D-
USB
USB
IC932
IC931
RESET
IC702, S701
EPROM
IC771
E2PROM_DI
E2PROM_CLK
RST
SUBMUTE
Q785
Main amplifier & System control section
LINE OUT
LROUT, RROUT
IC801
,
Q331
Q321
IC1
DC-DC 5V
,
Q977
Q976
,
Q782
Q781
,
Q784
S702
OPEN
OPEN
DETACH
S703
DETACH
X1
4MHz
PICK UP
TRACKING
FOCUSING
PHOTO SENSOR
SW1
REST SW
Q212
Q211
,
COIL
COIL
TRK+/-
FOCUS+/-
CD PICK UP
LOAD MOTOR
FEED MOTOR
SPINDLE MOTOR
VF1, VF2
VT1, VT2
MD, LD
M
M
M
I, O
CPU/CD RF
SERVO/DSP
Q101
Q301
PHOTO SWITCH
D101,D201
IR LED
SW1
SW2
LD
VF1, VF2
VT1, VT2
MD
PSW
CN102
Q201
,
SW2
SW1
CDLDCUR
SW5V
LD
Q302
CLK, LRMUTE
NRST (CDRESET)
NPWDOWN(NPDOUT)
IC301
&
PS2
UCS, SCS
SW1
PS2
DRIVER
FOCUS+/-
TRK+/-
LOAD+/-
FEED+/-
SP+/-
FOP
TRP
TRVP
SPOUT
FWD
REV
MUTE
Q501
CD
IC501
OUTL
OUTR
IC302
EEPROM
X301
16.9344MHz
SCL
SDA
CN101
REMOTE
STBY
POWER
ANT.CTRL
Used for KD-R701, KD-R705
BUSIO
BEEP
BEEP
OUTSW/OUTLR2, OUTSW/OUTRR2
CD-USB.LO
CD-USB.L
CD-USB.R
SUPPLY
ENC1
ENC2
AL/AR
Q607
DIM SW
D600, D602
D603
LCDCL
LCDCE
LCD MODULE
LCD1
COM1 to 4
S2 to 51
DRIVER
IC601
DIM
LCD
LCDDA
POWER LED
D601
ACC5V
LED
ENCODER
EN601
ENC1, ENC2
KEY MATRIX
S601 to S611
KEY0
KEY1
REMOCON
IC602
REMOCON
Q603, Q604, Q605, Q606
RGB LIGHTING DRIVER
IC603, Q601, Q602
SCL
RGB LIGHTING
D604 to D608
Q608
5V REG.
10V5V
12MHz
X302
Q303
SW1
DECODER
IC303
IPOD
CP_RST
CP_CK
CP_DA
USB_IN
USBNPP
D+, D-
CN501
VOL1
VOL2
REMOCON
KEY1
KEY0
LCDCL
LCDDA
LCDCE
RGB_CL
EJECT
CD4_CLK
LRMUTE
USBNPP
USB_IN
NRST
NPWDOWN
CD4_SI
CD4_SO
CD4_UCS
SCS
SW1
CD servo control section
Page 30
2-2
Standard schematic diagrams
*** POWER, CD_ON, ILLUMINATION and AUTO ANTENNA
( MODE 1 and MODE 2 )
4.9V
0V
0V
0V0V
0V0V
2.2/50
0V
0V
4.8V
4.8V
4.8V
4.8V
4.8V
0V
5.2V
5.2V
0V
3.3V
0V
4.0V
3.3V
4.9V
3.3V
3.3V
3.3V
BUSINT
4.9V
BUSCLK
BUSSI
4.9V
0V
Version
EE,E,U
0V
Version
/BUSIO
U
Version
EE,E
Version
2.2/50
1.6V 1.6V
1.6V
1.6V
1.6V
3.2V
( )
3.2V
3.2V
1.6V
1.6V
3.2V
0V
0V
0V
0V
Version
** Regulator Pin Voltage
3.0V
OPERATION
2.9V
4.2V
8.5V
8.5V
0V
(CLK DISP ON)
2.3V
4.1V
5.7V
0V
8.5V
7.2V
3.9V
5.2V
5.2V
0V
6.2V
6.2V
3. STBY
3.8V
3.6V
0.4V
3.8V
3.8V
8.5V
3.2V
3.2V
0V
0V
0V
0V
1.4V
0V
0V
AMSELOUT2
AMSELOUT1
AMIFAGC1
AMSELIN2
AMSELIN1
PLL2
PLLREF
PLL1
VCO
GNDRF
VCC
VREG
VREF
SDA
TUNER SECTION
SCL
DGND
XTAL
TEST
RSSI
MPXOUT
MPXIN
AMIFAGC2
AGND
ROUT
LOUT
AMRFAGC
VCC
GNDRF
FMRFIN1
FMRFIN2
AMRFIN
AMRFDEC
3.2V
Aux Mode
GND
CD Mode
Tuner Mode
1.5V
2. Power ON
1. Power OFF
MODE 2
0V
0V
0V0V0V
EE,E,U
1.5V
3.0V
6.8V
5V
6.8V
0V
4.9V
4.9V
3.3V
*
0V
0V
0V
3.3V
0V
0V
0V
QTE1H57-105Z
( )
QTE1H57-105Z
0V
3.3V
2.5V
0V
3.3V
0V
3.3V
***
0V
4.9V
Version
EE,E,U
3.3V
5.2V
5.2V
JVC BUS
0V
0V
5.2V
5.2V
5.2V
3.3V
0.62V
0.8V
0V
0V
BUSIO
( )
( )
1SS355W-X
( )
( )
( )
5V
5V
0V
0V
2.5V
***
2.5V
0V
0V
2.4V
5V
5V
5V
***
0V
0V
***
5.1V
4.5V
5.1V
5.1V
5.2V
5.2V
0.2V
0.2V
2.4V
9.2V
4.0V
4.0V
4.0V
4.0V
4.0V
UDZW5.6B-X
( )
( )
CD
TAB
( )
3.3V
( )
( )
0V
( )
( )
QAM1150-001
100P
100P
QAM1146-001
EEPROM
( )
QAM1150-001
*
S-24CS16A0I-G-X
S-24CS16A0I-G-XS-24CS04AFJ-G-X
0V
USED
0V
( )
( )
*
( )
N/AN/A
*
NC
GND
RST
VDD
0.0V
0.0V
3.3V
3.3V
N/A
GND
KEY0
KEY1
I
LCDCL
LCDDA
LCDCE
ENC2
ENC1
REMOCON
N/A
*
0V
N/A
LCD_DATA
NPWDOWN
NRST
(NC)
(NC)
(NC)
OC
OUT
OUT
E.VOLUME
ILL
USB_IN
NC
SW1
VOL2
O
STEERING_REMOTE
CD_ON
DIM_IN
TEL_MUTE
AUTO_ANT
NC
GND
ILM.10V
ILM.ADJ
3.3V
MODE2
ANT
MEMORY IN
SW5V
EXT
USED
0V
CD8V
10.1V
MODE1
8.1V
*
USED
QUAL
T57
OSCO
AUTO ANTENNA
9.1V
**
5.1V
5.2V
N/A
5.1V
4.4V
*
OSCI
TEST
N/A
R771,C771,R772
N/A
USED
N/A
USED
MODE
USED
SERIES
KD-R707EE
SERIES
MUX
CIN
KD-R701E
KD-R705U
0V
USED
USED
0V
SCOUT
( )
D902
VDD5V
ILLUMINATION
0V
CD_ON
POWER
N/A
U
Vref
5.6V
5.1V
4.9V
0V
0V
Version
0V
0V
5.2V
DATA
Vdd
GND
CLK
MODE 1
3.2V
( )
(1/8W)
(1/4W)
USED
3.3V
OUT
USED
EN
Vdd
A0
A1A2WPIN
GND
N/A
NOTES
ALL E.CAPACITORS ARE SHOWN IN THE FORM OF CAPACITANCE(uF)/RATED VOLTAGE(V)
ALL CAPACITANCE VALUES ARE IN uF(P=pF)
ALL RESISTANCE VALUES ARE IN OHM.
ALL CAPACITORS ARE 50V OR 25V CERAMIC CAPACITOR.
ALL RESISTORS ARE 1/16W 5% METAL GLAZE RESISTOR.
UNLESS OTHERWISE SPECIFIED.2.
CONDITION---FM MODE. AM MODE. ( )CD MODE.
1. VOLTAGES ARE DC-MEASURED WITH A DIGITAL VOLT METER WITHOUT INPUT SIGNAL
A-GND
3.3V
5.0V
3.3V
3.3V
3.3V
1.8V
3.3V
( )
0V
3.3V
0V
0V
ACC.IN
ACC5V
9V
USED
USED
3.3V
IC771,R777,
POWER CORD
5.1V
0V
4.3V
0V
0V
4.9V
0V
0V
3.3V
D715-D718:
QTE1C57-106Z
D719,D720:
**
3.3V
3.3V
3.3V
COMPONENTS
OUTSW/OUTRR2
WINTC
WIN_IN
DC_ERR
VDD
SDA
( )
( )
SCL
TELMUTE
CD CHANGER
CN703,D712,C710
STEERING REMOTE
MUTE
N/A
C851,&C852
OUTLF
( )
( )
D851,D852,R851,
( )
NAF0029-001X
AUTO ANTENNA
0V
R770,R773
RDS COMPONENTS
USB-D-
( )
100/6.3
220/10
3.3V
100p
0V
OUTLR
OUTRR
OUTRF
3.3V
OUTSW/OUTLR2
GNDCREF
SE4R
SE4R0
3.3V
0.47u
0.47u
0V
8.4V
BUSSO
0V
0V
100p
0V
100p
100p
( )
( )
0V
7.0V
14.4V
14.4V
5.2V
4.5V
USB-D+
( )
0V
2.5V
4.9V
2.5V
2.5V
1.9V
0V
4.9V
0V
2.5V
2.4V
6.9V
RDS DETECTOR
6.9V
6.9V
6.9V
PS2
7.1V
7.1V
7.1V
7.1V
7.1V
7.1V
POWER
7.1V
7.1V
( )
SE4L0
AUX.R
AUX.G
SE4L
QD3R
0V
0V
3.3V
AUX.L
1.8V
3.3V
RDS_CLK
ANTENNA
1.4V
0V
VDD5
REMOCON
D702-D710:
VREF+
NC
NC
RDS_DATA
UCS
TU_CLK
NC
NC
NC
IN
IN
GND
( )
( )
0.47
RT1P141C-X
QD3G
UN2211
UN2111
QD3L
10K
SE3R
SE3L
10K
SE2R
SE2L
0V
10K
SE1R
RT1N141C-X
10K
*
( )
0V
ONLY
SE1L
1.6V
3.3V
VERSION
( )
R709
GND
REGULATOR
ACC
SCS
BUZZER
REMOTE
PRE-GND
ANT
NC
CLK
3.3V
DET OFFSET
TELMUTE
*
0V
27p
330/6.3
REAR LEFT(+)
FRONT LEFT(+)
0V
0V
0V
FRONT RIGHT(+)
REAR RIGHT(+)
( )
REAR LEFT(-)
FRONT LEFT(-)
CPU
FRONT RIGHT(-)
CD8V
3.3V
1.6V
0V
27p
( )
( )
REAR RIGHT(-)
MEMORY
FOR E & U VERSION ONLY
( )
MAIN PWB: GEB10262A
* REMARKS
( )
EE,E
3.3V
(1/10W)
*
(1/10W)
POWER CORD ASS'Y
(1/10W)
FUSE 15A
ILLUMINATION
R708
*
33u
( )
( )
R743,R745
3.3V
NOT USED
( )
NC
USED
POWER AMP.
NOT
( )
1.3V
DETACH
TELMUTE
( )
14.4V
( )
( )
TUNER
FM/AM
13.7V
13.4V
1.7V
( )
( )
COMPONENTS IN () INDICATE NOT USE.
*
4.7u
( )
11V
3.
(1/10W)
0V
3.3V
( )
FOR E VERSION ONLY
0.47
( )
( )
5.2V
0.47
( )
14.4V
GND
FOR U VERSION ONLY
RIGHT
O
( )
BCLK
*
OUTFL-
LEFT
USBGND
GND
3.3V
3.3V
0V
*
0V
0V
5.0V
5.0V
0V
0V
0V
0V
0V
0V
3.3V
3.2V
Parts are safety assurance parts.
( )
3.3V
EPROM
GND
1/8W
GND
( )
USB5V
( )
2700/16
47/16
sure to use the specified one.
0.47
GND
*
INFL
OUTFL+
OUTRL+
OUTRL-
MUTE
INRL
RIPPLE
GND
OUTFR-
GND
OUTFR+
INFR
INRR
OUTRR-
GND
VCC3/4
GND
TAB
OUTRR+
VCC1/2
AC-GND
STBY
MEMORY.IN
SI/SO
Vdd
NQL093K-1R8X
HI-SIDE SWITCH
AUX.G
( )
VSS
REAR/SUBWOOFER R
KEY1
*
Vdd
SCL
*
( )
( )
0V
KEY0
0
0V
( )
5V
RT
FOR
NC
REAR/SUBWOOFER L
NC
DOMESTIC
USED
DIMMER INPUT
EN
When replacing those parts make
LCD_CLK
LCD_CE
NC
GND
10/6.3
FRONT L
GND
( )
NC
EVOL_CLK
INV
NC
SDA
EVOL_SDA
SUB-MUTE
OUT_VOL1
NC
NC
CD4_UCS
MUTE
DETACH
LRCK
PS1NC
( )
NC
DCDC-SWREG
AUTO
NC
NC
E2PROM_CLK
E2PROM_DO
FB
VSS
( )
NC
VDD18
CD4_CLK
E2PROM_DI
VSS
FRONT R
RST
NC
VOL1
USBGND
MOTOR_SEL
NC
OUT_VOL2
VOLMUTE
EJECT
SCS
( )
NC
XO
VDD18
NC
RGB_CLK
NC
VDD33NCXI
VSS
OSC1
OSC2
MMOD
OPEN
NC
NC
NC
NC
LRMUTE
STAGE1
TU_SDA
CD4_SI
CD4_SO
( )
NOT
( )
SW
RESET
CHANGER CONTROL
VIN
RGB_CL
0V
EJECT
OPEN
DC-DC 5V USB SUPPLY
0V
3.3V
0V
( )
0V
( )
( )
3.3V
SRDATA
( )
( )
FOR E & EE
*
0.082
10
MGND
( )
( )
0V
FR-
TELMUTE
LROUT
KEY1
KEY0
FL-
FL+
RL-
RL+
RR+
VOL_SDA
RROUT
RDSCL
RR-
FR+
RDSDA
FR-
SW1
VOLMUTE
NPWDOWN
NRST
RDSCL
TUSCL
RDSDA
ACC5V
ENC2
10V
PS2
REMOCON
FL-
RL+
RR-
BEEP
BEEP
RL-
FL+
FR+
SCS
RR+
AGND
VOL_CLK
BUSSI
BUSCLK
BUSSI
BUSSO
BUSINT
/BUSIO
BUSIO
CD8V
TUSDA
LCDCL
USB-D+
LCDCE
ENC2
LCDDA
CD4_CLK
USB-D-
LRMUTE
EJECT
USB_IN
CD4_SI
SUB-MUTE
USB_IN
BUSSO
/BUSIO
BUSCLK
REMOCON
STEERING
TELMUTE
BUSINT
BUSIO
SW5V
CD4_SO
AUX.G
AUX.R
AUX.L
ENC1
RFOUT
RROUT
CH.R
ENC1
LFOUT
CH.R
TU.R
SWREG
TU.R
DIMIN
TU.L
DOMMUTE
DIMIN
LFOUT
CD-USB.LO
CD-USB.RO
RFOUT
VOLMUTE
TU.L
TUSDA
TUSCL
LROUT
RGBCL
AUX.L
LCDCE
CD-USB.R
MODE2
MUTE
RGB_CL
CH.L
VOL_CLK
CD-USB.RO
VOL_SDA
CD-USB.LO
3.3V
LCDCL
CD-USB.R
KEY0
MODE2
CD-USB.L
CD-USB.L
CD4_CLK
CD4_SI
NPWDOWN
CD4_SO
DOMMUTE
SWREG
CD4_UCS
NRST
SCS
CD4_UCS
STEERING
SW1
MUTE
KEY1
CH.L
EJECT
LCDDA
SUB-MUTE
LRMUTE
1817161514
131211
10
987654321
QMFZ064-150-J1
J1
QNB0190-001
C24
0.01
R7
100
L7
4.7u
C26
100/16
R6
100
C25
0.01
C17
0.1
R4
4.7K
L5
560u
L6
560u
C11
0.01
L8
4.7u
C12
0.01
R5
22
C18
0.01
C16
0.01
C19
0.1
C2
5.6p
C23
0.1
X1
QAX0928-001Z
C15
0.1
C14
0.22
R1
NI
C1
0.001
C22
15p
R2 470K
R11
4.7
C3
0.001
L1
0.47u
L3
QQL213M-R22Z
C5
15p
12345678910111213141516
17181920212223242526272829303132
IC1 TEF6606T/V3-X
C29
NI
D1
NI
C27
10/25
C10
1
C28
NI
C6
22P
R730
1K
R720
1K
R728
1K
C723
NI
Q785
NI
R725
1K
R724
1K
C724
NI
C585
QTE1H65-225Z
C586
QTE1H65-225Z
C588
330p
C583
3300p
C587
330p
C991
NI
43
21
IC702
S-80824CNNB-G-W
C584
3300p
R585
1K
C715
0.1
D708
D706
D704
D702
D709
UDZW6.2B-X
D707
D705
D703
C714
0.1
R587
18K
R583
15k
R764
82K
R763 82K
C720
82p
R305
1K
R307
27k
R739 100
R930
0
R741 100
C852
0.22
R851
10K
C851
10/25
R584
15k
R760
1.2k
R717
0
R722
1K
R723
0
R721
1K
R719
1K
R718
0
R745
100
16151413121110987654321
IC901
AN34002A
C178
10/16
R172
100
R171
100
R780
NI
C728
NI
R711 NI
C184
0.1
1 2 3 4 5 6 7 8 9 1011121314
1516171819202122232425262728
IC161
TDA7718-X
R354
47k
R344
47k
C315
1
MOD
C183
220/10
R311
1k
R312
1k
D720
UDZW5.1B-X
D719
C733
0.1
D717
UDZW6.2B-X
D718
C385
4.7/50
R301
1k
C386
4.7/50
C165
1
C164
1
C171 1
C161
1
D716
D785
1SS355W-X
R936
NI
C725
NI
TUBUYAKI
Q978
2SC3928A/QR/-X
C716
NCJ11EK-106X-A
C936
18p
R776
4.7K
R778
4.7K
C4
0.22
C77
47/6.3
R75
NI
C73
10/25
R71
0
R73
2.2k
R72
2.2K
X71
QAX0926-001Z
C74
33p
C75
33p
C71
560p
C76
0.01
C72
330p
R74
100
Q922
RT1N141C-X
R922
1K
3
2
1
CN703
QNS0283-001
12345678
910111213141516
IC71
LC72725KM-X
C30
NI
R726 10K
R92
8.2k
C78
0.01
R81 6.8k
C713
56p
R82
8.2k
R91 6.8k
R164
NI
C990
0.0047
R731
100
R703
100k
R704
100k
C787
NI
R757
1.2k
R881
47K
C934
100p
C993
NI
R777
10K
C771
0.047
R772
270
R771
270
1234
5678
IC771
23
8
654
7
1
J801
QNZ0095-001
Q881
RT1N141C-X
C881
22/16
D971
MA22F20-X
C705
NI
R712
330
R921
47K
J321
QNN0815-001
C971
0.1
C162
1/50
R882
4.7K
C172
1/50
R714
0
R727
47k
R773
22k
R770
2.2k
R588
18K
C915
NI
R807
100K
C908
220/10
27
26
25
24
23
22
21
20
19
18
17
16
15
14
13
12
11
10
9
8
7
6
5
4
3
2
1
IC301
TDA7851A
Q891
RT1N141C-X
Q976
RT1N141C-X
D782
1SS355W-X
Q784
RT1P141C-X
R586
1K
R806
1K
Q921
2SB1132/QR/-W
R343
100
R353
100
3
4
2
1
S703
QSW0451-001
R351
2.2K
R341
2.2K
R342
820
R352
820
Q781
RT1P141C-X
C784
100/16
R901
1k
R902
9.1k
R903
4.7k
D901
1N5401-F64
C325
NI
C324
NI
C323
NI
C322
NI
C318
2.2/50
R746
100K
R805
0
R804
18K
C785
NI
D787
NI
C320
100p
C706
0.01
C782
NI
C912
0.01
D784
UDZW11B-X
R729 100K
R710
NI
R971
3.3K
R740 560
R756
4.7k
R755 4.7k
C719
100/10
R742
100
R743
100
L932
NQLH25M-4R7X
C330
0.01
C331
0.01
C329 NI
D711
UDZW6.2B-X
C302
QFV91HJ-474Z
Q977
ISA1530AC1/R/-X
R715
NI
C13
1
C317 QTE1C57-476Z
C909
330/6.3
B903
0
C913
NI
R735
47k
D902
GS1J-X
R744
100
C935
0.0015
L930
NI
R905
NI
R904
0
R976
27k
R977
12k
R713
NI
C731
22p
C732
22p
R892
47k
R891
1k
C891
0.1
CLK
C710
100P
C704
27p
C703
27p
C316
4.7/50
C702
C701
R972
NI
X702
QAX0401-001
R750
220K
DATA
R3
0
C301
QFV91HJ-474Z
C901
QEZ0870-278
B901
0
C708
0.1
R753 4.7K
C712
NI
R758
47k
R754 27K
C718
0.1
C32
NI
R751 1.2k
D712
1SS355W-X
D781
1SS355W-X
R783
10K
X701
QAX0667-001Z
R766
NI
C933
NCB10JK-106X-A
R734
10k
B902
NI
R768
NI
C931
470/25
R774
47k
R775
2.2k
R705
10k
D332
NI
28
27
26
25
24
23
22
21
20
19
18
17
16
15
14
13
12
11
10
9
8
7
6
5
4
3
2
1
CN701
QGB1004K1-28
D322
NI
C907
220/10
D972
MA22D23-X
C938
2.2
R322 820
R937
220
R302
1k
C319
100p
R709
47k
C711
47/6.3
C328 NI
4
6
1
3
L4
QQR1813-001
C174
1
C928
0.0047
C721
0.1
D715
R752
4.7K
R928
75k
7654321
IC931
BD9007HFP-W
R161
4.7k
R701
10k
R702
10k
R162
4.7k
R15
4.7k
C802
NI
R708
100K
R893
3.3K
R782
4.7k
R332 820
C892
0.1
65
4
321
Q331
IMX9-W
C903
100/16
R333
100
R736
560
Q892
RT1N141C-X
D331
MC2836-X
-
R737
560
D2
NI
L701
4.7u
R769
4.7K
R323 100
C321
NI
R334 47k
R324
47k
L2
NI
123456789
101112131415161718
CN901
QNZ0607-001
R331
2.2K
R321
2.2K
C326
22/16
C730
4700p
65
4
321
Q321
IMX9-W
R761
1.2k
C781
100/6.3
C709
0.1
C911
NI
C905
47/16
C910
10/25
C729
4700p
R733
47k
L702
4.7u
D891
MC2836-X
-
R749
1K
D321
MC2836-X
-
R748
1.2k
C177
56p
R929
51k
R939
15k
R310
4.7k
R940
82k
L931
QQL92AK-330Z
D931
RSX201L-30-X
C932
QBZ0006-337Z
C917
330/6.3
D342
NI
R811
6.8K
R767
47k
C801
0.047
R809
47k
R813
1K
28
27
26
25
24
23
22
21
20
19
18
17
16
15
14
13
12
11
10
9
8
7
6
5
4
3
2
1
CN501
QGB2027ME-28
R808
100
R801
1K
R812
100K
C304
NI
C303
NI
C314
NI
R803
33K
C902
2.2/50
C717
820p
R762
1.2k
R706
47k
C916
0.01
C366
4.7/50
Q782
2SC3928A/QR/-X
L31
NI
C33
NI
C313
NI
D701
NI
R802
100K
R779
100
3
4
2
1
S702
QSW0451-001
R781
47K
R759
NI
100
99
98
97
96
95
94
93
92
91
90
89
88
87
86
85
84
83
82
81
80
79
78
77
76
75 74 73 72 71 70 69 68 67 66 65 64 63 62 61 60 59 58 57 56 55 54 53 52 51
50
49
48
47
46
45
44
43
42
41
40
39
38
37
36
35
34
33
32
31
30
29
28
27
26
25242322212019181716151413121110987654321
IC701
MN101EF16ZXW
C34
NI
C726
NI
R747 10K
R732
47k
C906
0.01
R309
10
R765
470
R14
4.7k
D851
MA22F20-X
S701
QSW0648-001Z
C365
4.7/50
C327
82p
D352
NI
R13
NI
C82
NI
R12 0
R738
560
D713
NI
C311
QFV91HJ-474Z
L901
QQR1809-001
1234
5678
IC932
TPS2051BD-X
R810
3.9K
D852
MA22D23-X
R819
47k
C707
100/16
C727
NI
C92
NI
R814
100
D710
C783
NI
1234567
8 9 10 11 12 13 14
IC801
74AHCT126PW-X
C312
QFV91HJ-474Z
C937
0.47
R938
NI
C914
100/16
C722
4.7/25
To CD section
To LCD & Key control section
Main section
Page 31
2-3
( ) ( )
( )
ENC1
ENC2
AUX IN
( )
4.4V
4.4V
4.4V
4.4V
4.4V
4.4V
0V
0V
0V
0V
5.02V
5.02V5.02V
5.02V
5.02V
5.02V
0V
0V
ACC5V
1/10W
1/10W
1/8W
1/8W
1/8W
1/10W
1/10W
1/10W
RGBCLK
( )
( )
( )
1/10W
1/10W
1/10W
0.08V
0V
4.9V
5.6V
10V
0.1V
0.6V
0V
5.0V
0V
1/10W
( )
( )
5.02V
LCDCE
( )
5.0V
EQ/(TP/PTY)
SRC
POWER/ATT
MENUBACK
KEY MATRIC
UP F-SKIP
COLOUR/PHONEDISP
DOWNB-SKIP
1%
Vbat
Vout
SCL
IREF
SDA
AGND
R-LED
G-LED
B-LED
GND
IC
IC
0V
LCDDA
Q604, Q605, Q606 : UN2222-X
Q601, Q602, Q603 : 2SA2174G-X
( )
( )
LCDCL
LOUD
TAG
USERROCK POPS
EQ
HD
STMO
PTYTPREGAF
DISC
HOLD
RPT
RND
CH
Tr
( )
COM4
COM3
0V
1.6V
3.3V
S50
S49
S33
S34
S35
S36
S37
S38
S39
S40
S41
S42
S43
S44
S45
S46
S47
S48
S32
S31
S30
S29
S28
S27
S26
S25
S24
S23
S22
S21
S20
S19
S18
S17
S16
S15
S14
S13
S12
S11
S10
S9S8S7
S6
S5S4S3S2DIM
HIPHOPCLASSIC
P
VDD
OUT
( )
( )
VCC5V
D-
( )
( )
D+
GND
( )
GEB10256A2
VIEWTOP
KEY0
T --- TANTALUM CAPACITOR.
NOTES
ALL E.CAPACITORS ARE SHOWN IN THE FORM OF CAPACITANCE(uF)/RATED VOLTAGE(V)
ALL CAPACITANCE VALUES ARE IN uF(P=pF)
ALL RESISTANCE VALUES ARE IN OHM.
ALL CAPACITORS ARE 50V OR 25V CERAMIC CAPACITOR.
UNLESS OTHERWISE SPECIFIED.2.
1. VOLTAGES ARE DC-MEASURED WITH A DIGITAL VOLT METER WITHOUT INPUT SIGNAL
GEB10256A1PWB:
UNR9211G-X
UN2222-X
( )
JAZZ
COMPONENTS IN ( ) INDICATE NOT USE.3.
OV 4.5V
10K
ENC2
USB
2.5V
2.5V
2.5V
2.5V
2.5V
2.5V
2.5V
2.5V
2.5V
2.5V
2.5V
2.5V
2.5V
2.5V
2.5V
4.9V
2.5V
2.5V
2.5V
2.5V
2.5V
2.5V
2.5V
2.5V
2.5V
2.5V
2.5V
2.5V
2.5V
2.5V
2.5V
2.5V
2.5V
2.5V
2.5V
2.5V
2.5V
2.5V
2.5V
2.5V
2.5V
2.5V
2.5V
2.5V
2.5V
2.5V
2.5V
2.5V
0V
0V
0V
2.5V
2.5V
2.5V
2.5V
2.5V
5.0V
1.6V
5.0V
ENCODER
LCD DISPLAY
REMOCON
( )
RESISTORS
4.5V
GLAZE
( )
( )
METAL
LCDDA
SW
1/16WARERESISTORS
LCD DRIVER
LIGHTING DISPLAY
NC
ALL
10K
SELECT
GND
COM2
2.5V
4.7K
RGBCLK
4.7K
GND
KEY1
RGB CIRCUIT
COM1
GND
VSS
GND
( )
( )
2.5V
S51
( )
( )
( )
( )
REMOCON
( )
( )
NC
USBGND
S601-S611 : NSW0316-001X
USB_5V
ENC1
( )
( )
( )
S49
S48
S47
S46
S45
S44
S43
S42
S41
S40
S39
S38
S37
S36
S35
S34
S33
S32
S31
S30
S29
S28
S27
S26
S25
S24
S23
S22
S21
S20
S19
DATA
CLK
S18
CE
S17
KEY1
OSC
S16
S15
S14
S13
S12
DIM
S11
S2
S50
S10S9S8
S7
LCDCE
S6S5S4
LCDCL
S3
LCDDA
COM2
COM1
S49
S39
COM2
COM3
COM4
S47
S46
S45
S44
S41
S40
S35
VDD
VDD1
VDD2
S34
S25
AUXGND
S48
S36
S38
S42
S33
S32
S31
S30
S29
S28
S27
S26
S43
S37
S24
S23
S22
S21
S20
S19
S18
S17
S16
S15
S14
S13
S50
COM3
S12
S11
S10
S9
S8
S7
S6
S5
COM4
S4
S3
S2
LCDCL
RGBCL
S51
COM1
GND
KEY0
S51
LCDCE
ENC1
ENC1
AUX.R
KEY0
N.C.
KEY1
ENC1
USBGND
DIM
LCDDA
USB-D-
AUX.L
USB-D+
ENC2
INH
USB_5V
ENC2
D616
NI
D615
NI
R617
NI
R615
NI
R618
NI
R616
NI
C600
1
B602
0
D600
LHQ974/LM/-X
R648
0
S605
S604
S603
S602
S606
S609
S607
S608
R610
2.7K
R604
1.8K
R603
1.2K
R602
820
R607
820
R608
1.2K
R606
820
R609
1.8K
R605
2.7K
R601
820
D645
Q608
2SC3928A/QR/-X
R649
1K
C606
0.1
H
G
F
A
R669
100
C608
10/16
R668
150K
C609
1
1234567
141312111098
IC603
NCP5623DTBR2G-X
C617
0.22
Q606
Q605
R624
100
R666
100
C615
0.22
6
5
4 3
2
1
D604
NSSM065T-X
E
D
C
Q603
C616
0.22
R673
2.2k
R672
2.2k
R671
2.2k
Q604
R638
560
D649
R640
820
R639
560
6
5
4 3
2
1
D606
NSSM065T-X
R643
750
R642
470
R641
470
R637
620
R636
330
R635
330
B
B601
0
Q602
D603
LHQ974/LM/-X
C605
0.1
C604
0.1
R667
1k
Q601
L688
NQR0007-002X
C692
NCJ11EK-106X-R
4
3
2
1
J602
QNZ1007-001X
C691
NI
D691
UDZW5.1B-X
D692
UDZW5.1B-X
L687
NQR0007-002X
3 4
12
L691
NQR0536-001X
R663
1k
3
1
2
J601
QNS0280-001
R631
330
L686
NQR0007-002X
R693
C612
4.7
R691
1K
321
3724
IC602
NJL29H380A
C613
4.7/6.3
D602
LHQ974/LM/-X
6
5
4 3
2
1
D608
NSSM065T-X
D601LHQ974/LM/-X
R630
270
R656
100
R655
100
R654
100
C602
150p
C601
0.022
R625
100
R694
100K
D643
R623
C622
1000p
4
32
1 5
EN601
QSW1231-002
R665
1k
C681
C682
6
5
4 3
2
1
D605
NSSM065T-X
64
63
62
61
60
59
58
57
56
55
54
53
52
51
50
49
48 47 46 45 44 43 42 41 40 39 38 37 36 35 34 33
32
31
30
29
28
27
26
25
24
23
22
21
20
19
18
17
16151413121110987654321
IC601
PTC6526LQ-L
D641
MA8056/M/-X
C621
1000p
54535251504948474645444342414039383736353433323130292827262524232221201918171615141312111098765432
1
LCD1
QLD0577-001
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
CN601
QGZ1201M1-25W
R621
100K
C610
D647
R620
100k
S601
S611
R659
220k
C611
0.1
Q607
UNR9211G-X
C623
820p
D653
C607
0.1
D646
R633
R692
470
R634
680
S610
R632
D642
MA111-X
C603
1
D651
R658
390K
D644
LCD & Key control section
To Main section
Page 32
2-4
USB-D+
USB-D-
SUB BOARD
GEB10274A
RGBCL
CD CD
EJECT
EJECT
EJECT
GND
GND
USB5V
USB5V
USB-D-
USB-D+
USBGND
USBGND
GND
AUX.R
AUX.G
AUX.L
AUX.G
N.C.
GND
ENC1
KEY0
KEY1
RGBCL
LCDCL
LCDDA
LCDCE
REMOCON
ACC5V
ENC2
10V
USB-D+
USB-D-
USBGND
USBGND
USB_5V
USB_5V
N.C.
AUX.R
AUX.L
GND
ACC5V
10V
LCDCE
LCDDA
LCDCL
KEY0
KEY1
REMOCON
ENC2
ENC1
GND
GND
AUXGND
GND
GND
ENC1
ENC1
ENC2
KEY1
KEY0
LCL
LDA
LCE
RGBCL
AR
USB-D-
USB-D+
AR
AGND
AL
AGND
RGBCL
LCE
LDA
LCL
KEY0
AL
KEY1
REMOCON
REMOCON
AGND
USB-D-
USB-D+
ENC2
S2441
NSW0316-001X
D2443
LHQ974/LM/-X
D2442
LHQ974/LM/-X
D2441
LHQ974/LM/-X
25
24
23
22
21
20
19
18
17
16
15
14
13
12
11
10
9
8
7
6
5
4
3
2
1
CN742
QGZ1201L1-25
R2443
1.5K
R2442
680
28
27
26
25
24
23
22
21
20
19
18
17
16
15
14
13
12
11
10
9
8
7
6
5
4
3
2
1
CN741
QGB1004J2-28X
Function section
To Main section
To LCD & Key control section
Page 33
2-5
3.2V
3.3V
3.1V
3.4V
1.8V
0.0V
0.1V
0.0V
1.9V
1.6V
2.0V
0.0V
2.0V
3.3V
1.9V
0.0V
3.3V
3.2V
0.0V
0.0V
0.0V
1.5V
0.0V
1.6V
0.0V
3.3V
0.0V
3.3V
3.3V
3.3V
0.0V
0.0V
0.0V
IPOD 2.0B
1/8W F
F
1/8W
Dwire32A
Trace
1.2V
0.0V
0.0V
3.3V
3.3V
0.0V
0.0V
0.0V
0.0V
0.0V
0.0V
0.0V
1.2V
12MHz
2SD601A/R/-X
2SD601A/R/-X
LVB10834-A1
3.2V
0.0V
0.0V
0.0V
3.3V
3.3V
0.0V
1.2V
0.0V
0.0V
1.8V
0.0V
0.0V
0.0V
0.0V
0.0V
3.3V
0.0V
3.3V
3.3V
0.0V
3.3V
0.1V
3.3V
3.3V
3.3V
0.0V
0.0V
0.0V
1.2V
0.0V
3.3V
3.0V
0.0V
0.0V
3.3V
1.6V
1.5V
0.0V
0.0V
3.3V
3.3V
3.3V
0.0V
1.2V
3.3V
1.2V
3.3V
3.3V
1.6V
0.0V
0.0V
1.7V
3.3V
1.7V
0.0V
1.7V
0.0V
1.4V
1.4V
1.0V
1.6V
1.6V
1.1V
1.2V
1.1V
1.7V
1.1V
1.5V
2.1V
3.3V
0.0V
2.3V
0.1V
1.9V
1.9V
1.8V
1.8V
2.0V
2.0V
1.6V
1.6V
1.5V
1.6V
0.0V
1.6V
1.5V
3.3V
1.2V
3.3V
0.0V
0.0V
0.0V
3.3V
3.2V
3.3V
0.0V
3.3V
3.2V
1.2V
1.2V
0.0V
1.2V
3.3V
3.3V
3.3V
3.3V
3.3V
3.3V
0.0V
0.0V
0.0V
3.3V
0.0V
1.6V
1.6V
1.6V
7.2V
6.3V
3.3V
3.2V
3.1V
3.4V
0.0V
3.2V
3.3V
3.1V
3.5V
0.0V
0.0V
7.2V
0.0V
0.0V 0.0V
4.8V
3.2V
3.2V
1.6V
1.7V
1.6V
0.0V
1.6V
1.2V
4.3V
1.4V
1.5V
7.1V
1.6V
1.6V
1.7V
1.6V
1.6V
5.0V
3.2V
3.2V
3.1V
0.0V
0.0V
0.0V
0.0V
0.0V
3.1V
3.2V
3.2V
3.3V
0.0V
1.7V
0.0V
1.7V
0.0V
0.0V
0.0V
7.9V
7.8V
3.3V
0.0V
0.0V
0.0V
0.6V
0.0V
0.6V
0.0V
0.1V
3.3V
4.3V
5.0V
3.0V
2.3V
1.8V
1/2W
16.9344MHz
PHOTO SWITCH
CPU/CD RF & SERVO/DSP
CD DRIVER
-
-
-
+
+
+
GND
SW2
SW1
LVB10787-A2
PHOTO PWB
MOTOR
MOTOR
MOTOR
LOAD
FEED
SPINDLE
LVB10787-A3
REST SW PWB
109876
5 4 3 2 1
HDU-120
0.1
1k
0.1
1
15
14
13
12
11
10
9
8
7
6
5
4
3
2
1
A'SSYPICKUP
OPTIMA-727A1
FOCUSING COILTRACKING COIL
TRACKING-
TRACKING+
FOCUS+
FOCUS-
LD
MD
VR
VF1
Vc
VT1
GND
GND
VT2
Vcc
VF2
M.G
USB_IN
SW5V
NRST
D32SDATA
D32SCLK
EXTRG
TRP
TRP
FOP
FOP
TRVP
TRVP
SPOUT
SPOUT
TRK+
TRK-
FOCUS+
FOCUS-
FEED-
FEED+
SP-
SP+
CP_RST
USBNPP
TSUBUYAKI
TSUBUYAKI
USBNOC
CP_CK
CP_CK
CP_DACP_DA
CP_CK
CP_DA
CP_RST
AGND
SW2
SW1
CUR3.3V
SW1
SW1
OUTL
NRST
NRST
TRCCLK
EXTRG
D32SCLK
USBNPP
USBNOC
D32SDATA
USB_IN
NPDOUT
PS2
PS2
OOOUTR
BCLK
BCLK
SRDATA
SRDATA
SCS
SCS
VDD3.3V
LRCK
LRCK
UCS
UCS
LRMUTE
LRMUTE
CLK
CLK
I
I
D-
D+
TRCST
TRCD0
TRCCLK
TRCD3
TRCD2
TRCD1
TRCST
TRCD0
TRCD1
TRCD3
TRCD2
D+
D-
O
I
NRST
UCS
SCS
PSW
SW2
MUTE
FWD
REV
CUR3.3V
CDLDCUR
CLK
SPOUT
TRVP
TRP
FOP
MD
VT1
BCLK
MUTE
LD
TRK-
TRK+
FOCUS+
FOCUS-
CDLDCUR
LRMUTE
PS2
MD
VF1
VT1
VT2
VF2
LOAD-
SRDATA
LRCK
PSW
OUTR
LOAD-
LOAD+
FEED-
FEED+
SP-
SP+
OUTL
LD
VF1
VF2
VT2
LOAD+
FWD
REV
SW1
FG1
FG2
NSW0291-001X
SW1
PS1191RB22/BC/X
Q212
PS1191RB22/BC/X
Q211
NAX0367-001X
X302
NAX0375-001X
X301
SW1M
D+
D-
TP86
ARF
TP70
LD-
LD+
VR
FCS-
FCS+
TRK+
TRK-
VC
VCC
RFGND1
CD8V
OUTL
AGND
OUTRIO
UCS
SCS
CLK
BCLK
LRCK
SRDATA
M.GND
GND
CD5V
MONI1
LRMUTE
TP001
PS2
NRST
VDD3.3V
NPDOUT
SW5V
EXTRG1
USB_IN
USBNPP
USBNOC
USBG
VREF
LD
MD
NPD_OUT
NSTBY_OUT
VF1
TE
FE
BDO
NRFDET
MONI3
MONI4
MONI5
TUBUYAKI
VT1
VT2
TP002
OSCIN
VF2
RF
SL001
DEBAC_SHORT
R501 10
R202
NI
47k
R302
R301 10
R520
8.2k
R512 15k
R508
15K
R511 10k
R320
0
R102
8.2k
47k
R206
611
R215
15k
47k
R207
R321
0
R105
18K
R322 8.2K
R361 10K
47k
R324
R307 1k
R312
100
R313 100
R311 100
R362
220
1%
5
R217
30
R323 8.2K
R507
6.8k
R509
18k
R505
33k
R506
68k
R316
82k
R504
5.1k
1%
5
R216
30
R513 8.2k
R330
47k
R11 NI
R12 NI
47k
R241
R525
47k
10R304
R325 10
611
R214
15k
R349
0
R305
NI
R306 NI
R308
100K
R309
100K
R310
47K
R318
47K
47K
R334
NI
R335
R332
1M
R205
15k
R346
NI
R336
33
R345
4.7k
NI
R341
R337
47k
R338
NI
R510
68k
R319
0
R317
47k
R315
820
R514 13k
R331
150
R344
NI
R503
8.2k
R516
5.6k
R327
NI
R328
NI
R329
NI
R314
2.7k
R339
NI
NI
R340
R517
NI
R242
1K
R343
4.7k
R245 NI
R371
0
R203
180k
611R229
10K
611
R228
10K
611R230
10K
R104
180k
0
R342
R515
5.6k
R326 10
NIR303
0
B302
static C/M
0 B303
static C/M
0 B305
static C/M
B304
0
static C/M
611 B306 0
static C/M
0B307
R518
NI
R103
180k
R522
8.2k
R101
390
R523
8.2k
R333
220
0B301
R519 8.2k
R201
390
R521 8.2k
R524
8.2k
R16 NI
R14 NI
R15 NI
R13 NI
R204
180k
RT1N441C-X
Q302
RT1N441C-X
Q303
2SC3928A/R/-X
Q201
2SC3928A/R/-X
Q101
ISA1530AC1/RS/X
Q301
2SB1424/R/-W
Q501
626
K102
0
626
K103
0
626
K101
0
VCOF128
PLLFO127
PLLF126
IREF125
DSLF124
ARFIN123
ARFFB122
ARFOUT121
ARFDC120
RFIN119
RFOUT118
RFENV117
CENV116
AVDD2115
AVSS2114
LD113
PD112
A111
C110
B109
D108
F107
E106
VREF105
CTRCRS104
OSCIN103
FOP102
TRP101
NC100
TRVP99
SPOUT98
DVSS97
IOVDD
96
DVDD95MUTE
94
FWD
93
REV
92NC91
IPOD_SEL
90
PSW
89
CE188CE2
87NC86
CLK(SCLK)
85
I(S2UDT)
84
O(U2SDT)
83
SREGVDD82SREGOUT
81
SRAMVDD180SRAMVDD2
79
DVSS
78
DVDD
77
NPWDWM
76
NSTANDBY
75
IOVDD
74
NSTANDBY_OUT
73
NPWDWN_OUT
72
CP_RST
71
CP_RDY
70
CP_DA69CP_CK
68
USB_IN
67NC66
TSUBUYAKI
65
NRST 64
DOUT/BCLK 63
LRCK 62
SRDATA 61
IOVDD 60
VDD3 59
LRMUTE 58
DVDD 57
TRCD3 56
TRCD2 55
VDD18 54
TRCD1 53
DVSS 52
TRCD0 51
TRCST 50
TRCCLK 49
EXTRG1 48
VPPEX 47
EXTRG0 46
DWier32ASCLK 45
DWier32ASDATA 44
DVDD 43
DVSS 42
IOVDD 41
SW2 40
PS2 39
SW1 38
EEPROMCK 37
EEPROMDA 36
EEPROMCS 35
NRFDET 34
BDO 33
DVDD32DVSS31TEST130CUR3.3V29CDLDCUR28TE27FE26IOVDD25MX224MX123DVSS22USBDP21USBAVDD20USBDM19USBNPP18USBNOC17DVSS16DVDD15IOVDD14DVDD13REGON12IOVDD
11X210X19
DVSS
8
CSEL7TEST06OUTR
5
AVDD14AVREF
3
AVSS12OUTL
1
MN6627946JC
IC301
38
GND
37
GND
36
S-GND
35
VCONT
34
MUTE1
33
MUTE234
32
VIN4-
31
VIN4
30
VREF-IN
29
VREF-OUT
28
REG-OUT
27
REG-IN
26
VIN+OP
25
VIN-OP
24
VO-OP
23
VIN3
22
VIN3-
21
VIN2
20
VIN2-
19
VIN2+
18
VIN117VIN1-16VIN1+15VCCS14VCCP113VO1+12VO1-11VO2-10VO2+9VO3-8VO3+7VO4-6VO4+5VLO+4VLO-3VCC22REV1FWD
LA6565-X
IC501
NC 20
NC 19
NC 18
NC 17
NC 16
NC
15
MODE0
14
I2C_SDA
13
I2C_SCL
12
VSS
11
NC10
NC9
NC8
NC7
NC6
VCC
5
nRESET
4
NC
3
MODE1
2
NC
1
MFI341S2162-X
IC303
A0
1
A1
2
A2
3
GND4SDA
5
SCL
6
WPIN
7
VCC
8
BR24L16F-W-X
IC302
853
D203
NI
853
D204
NI
1SR154-400-X
D502
NI
MA2SD31-X
D301
AN1105W21/AB/-X
D101
1SR154-400-X
D503
AN1105W21/AB/-X
D201
1SR154-400-X
D501
NI
C318
C323
47/6.3
C531 100/6.3
C301
22/6.3
C315
47/6.3
C551 100/10
C316
47/6.3
C333
NI
C501 47/25
C303
47/6.3
C534
1000p
C533
NI
C519
NI
C520 NI
C521
NI
C352
27p
C351
27p
C338
0.1
C104 0.1
C392
0.1
C393
0.1
C394
0.1
C395
0.1
C330
10/6.3
C304
0.1
C329 0.1
C306
0.1
C326
10/6.3
C334 0.1
C332
10/6.3
C535 NI
C325
10/6.3
C335
0.1
C339
0.1
C340
0.1
C343
0.1
C344
10/6.3
C347
0.1
C345 0.1
C346 0.1
C552
NI
C202
NI
610
C201
0.1/16
C522 NI
C513
2700p
C512
2200p
C511
6800p
C514
1200p
C307
0.33
C308
1000p
C309
0.082
C310
1000p
C312
0.015
C311
0.1
C313
4.7
C314
3300p
C317 0.022
C319 0.33
C322
0.15
C503
68p
NI
C504
NIC505
C502
0.1
NI
C506NIC507NIC508
C321 2700p
C320 NI
C324
0.1
C302
0.1
C305
0.1
C373
0.1
C328 680p
C327 0.1
C331
10/6.3
C341
27p
C342
27p
C336
0.1
C337
0.1
C532 0.1
C101
0.1
C102
0.1
C103
0.1
C371
NI
USB_IN28
USBNPP27
USBNOC/TSUBUYAKI26
USBG25
D+24
D-23
22
21
20
19
18
17
16
15
14
13
12
11
10
9
OUTR8
7
OUTL6
5
M.GND4
GND3
CD8V2
CD5V1
QGB2027L5-28X
CN101
N.C.20
N.C.19
GND18
GND17
TRCST16
N.C.15
N.C.14
TRCD713
TRCD612
TRCD511
TRCD410
TRCD39
TRCD28
TRCD17
TRCD06
N.C.5
GND4
GND3
N.C.2
TRCCLK1
NI
SICA2P20S
CN302
15
14
13
12
11
10
9
8
7
6
5
4
3
2
1
QGF0522F3-15W
CN102
nRESET6
VDD5
SDATA4
SCLK3
EXTRG2
GND1
NI
QGA1002C1-06X
CN301
CD section
To Main section
Page 34
2-6
Printed circuit boards
Lead free solder used in the board (material : Sn-Ag-Cu, melting point : 219 Centigrade)
Lead free solder used in the board (material : Sn-Cu, melting point : 230 Centigrade)
Main board
Lead free solder used in the board (material : Sn-Ag-Cu, melting point : 219 Centigrade)
Lead free solder used in the board (material : Sn-Cu, melting point : 230 Centigrade)
LVA10834-A2
MARK
UL
PbF
SW1
CD switch board
C
T1A
F
A
F
E
E
D
D
C
B
B
A
GEB10262A
C328
R311
R312
R302
R301
C713
R936
C725
C716
C935
L932
C330
R769
C732
C731
R780
C934
B703
B705
B930
B702
B907
B903
B721
B719
R776
R778
C733
B928
L930
B701
B931
TSUBUYAKI
R905
R904
B902
B901
Q921
R921
R922
Q922
B911
R768
R766
B722
B720
B164
B165
Q978
B723
B804
B712
B711
B710
B709
B708
B713
B706
D710
D701
B302
B704
B1
B718
B714
MOD
CN901
B715
B161
B707
C932
C937
R937
L931
D931
R940
B2
B4
C928
B162
R939
B160
R929
R928
C938
3.3V
RST
GND
CLK
B163
DA
B306
B307
B716
B304
B305
B303
B801
B717
B912
B910
B909
B803
B905
B906
B501
B904
B802
C331
C991
B308
X702
X701
X71
X1
S703
S702
S701
R977
R976
R972
R971
R938
R930
R903
R902
R901
R893
R892
R891
R882
R881
R851
R819
R814
R813
R812
R811
R810
R809
R808
R807
R806
R805
R804
R803
R802
R801
R783
R782
R781
R779
R777
R775
R774
R773
R772
R771
R770
R767
R765
R764
R763
R762
R761
R760
R759
R758
R757
R756
R755
R754
R753
R752
R751
R750
R749
R748
R747
R746
R745
R744
R743
R742
R741
R740
R739
R738
R737
R736
R735
R734
R733
R732
R731
R730
R729
R728
R727
R726
R725
R724
R723
R722
R721
R720
R719
R718
R717
R715
R714
R713
R712
R711
R710
R709
R708
R706
R705
R704
R703
R702
R701
R588
R587
R586
R585
R584
R583
R354
R353
R352
R351
R344
R343
R342
R341
R334
R333
R332
R331
R324
R323
R322
R321
R310
R309
R307
R305
R172
R171
R164
R162
R161
R92
R91
R82
R81
R75
R74
R73
R72
R71
R15
R14
R13
R12
R11
R7
R6
R5
R4
R3
R2
R1
Q977
Q976
Q892
Q891
Q881
Q785
Q784
Q782
Q781
Q331
Q321
L901
L702
L701
L31
L8
L7
L6
L5
L4
L3
L2
L1
J801
J321
J1
IC901
IC801
IC771
IC702
IC701
IC932
IC161
IC71
IC1
D972
D971
D902
D901
D891
D852
D851
D787
D785
D784
D782
D781
D720
D719
D718
D717
D716
D715
D713
D712
D711
D709
D708
D707
D706
D705
D704
D703
D702
D352
D342
D332
D331
D322
D321
D2
D1
C931
IC931
C329
CN703
CN701
CN501
C993
C936
C990
C971
C917
C916
C915
C914
C913
C912
C911
C910
C909
C908
C907
C906
C905
C903
C902
C901
C892
C891
C881
C852
C851
C802
C801
C787
C785
C784
C783
C782
C781
C771
C730
C729
C728
C727
C726
C724
C723
C722
C721
C720
C719
C718
C717
C715
C714
C712
C711
C710
C709
C708
C707
C706
C705
C704
C703
C702
C701
C588
C587
C586
C585
C584
C583
C933
C386
C385
C366
C365
C327
C326
C325
C324
C323
C322
C321
C320
C319
C318
C317
C316
C315
C314
C313
C312
C311
IC301
C304
C303
C302
C301
C184
C183
C178
C177
C174
C172
C171
C165
C164
C162
C161
C92
C82
C78
C77
C76
C75
C74
C73
C72
C71
C34
C33
C32
C30
C29
C28
C27
C26
C25
C24
C23
C22
C19
C18
C17
C16
C15
C14
C13
C12
C11
C10
C6
C5
C4
C3
C2
C1
B3
Page 35
2-7
Switch board
S1B
A1
GEA10256-
D600
S611
S610
S609
S608
S607
S606
S605
S604
S603
S602
S601
R634
R633
R612R611
R610
R609
R608
R607
R606
R605
R604
R603
R602
R601
Q607
LCD1
J602
J601
IC602
EN601
D646
D606
D605
D604
D603
D602
D601
C607
Lead free solder used in the board (material : Sn-Ag-Cu, melting point : 219 Centigrade)
Lead free solder used in the board (material : Sn-Cu, melting point : 230 Centigrade)
forward side
T1B
GEB10256A1
R615
D616
D615
R617
R618
C617
C615
C616
B604
B602
B603
R616
CN601
R694
D647
R693
R692
R691
L688
L687
L686
R673
R672
R671
R669
R668
R667
R666
R665
R663
R625
R659
R658
R656
R655
R654
R624
R649
R648
R643
R642
R641
R640
R639
R638
R637
R636
R635
R632
R631
R630
R623
R621
R620
Q608
Q606
Q605
Q604
Q603
Q602
Q601
L691
L
K
J602
J601
J
IC603
IC602
IC601
I
H
G
F
EN601
D692
D691
B600
D653
D651
D649
C600
D645
D644
D643
D642
D641
PbF
MARK
UL
C692
C691
C682
C681
C623
C622
C621
C613
C612
C611
C610
C609
C608
C606
C605
C604
C603
C602
C601
B605
B601
B606
A
reverse side
Lead free solder used in the board (material : Sn-Ag-Cu, melting point : 219 Centigrade)
Lead free solder used in the board (material : Sn-Cu, melting point : 230 Centigrade)
LVA10834-A3
RED
ORANGE
BROWN
MARK
UL
PbF
Q212
Q211
Photo board
Page 36
2-8
reverse side
forward side
Function board
S2A
GEA10274-
A
PbF
MARK
UL
S2441
D2443
D2442
D2441
CN742
Lead free solder used in the board (material : Sn-Ag-Cu, melting point : 219 Centigrade)
Lead free solder used in the board (material : Sn-Cu, melting point : 230 Centigrade)
forward side
T2A
GEB10274A
R2443R2442
CN741
Lead free solder used in the board (material : Sn-Ag-Cu, melting point : 219 Centigrade)
Lead free solder used in the board (material : Sn-Cu, melting point : 230 Centigrade)
LED board
S1B
GEA10256A2
D608
C
D
T1B
GEB10256A2
PbF
MARK
UL
reverse side
forward side
S1C
1
C534
B307
B302
R242
R202
R340
C346
C345
C347
C344
C343
C340
C339
R318
R310
D204
R214
R304
C306
R241
K103
K102
K101
R216
R217
R215
D203
C394
C393
C392
R206
R207
C104
IC302
C533
R518
R103
R522
R523
R524
R204
R104
R343
R344
R345
R346
R205
R105
R102
R302
R303
R326
R203
R314
R329
R328
R327
R515
R514
R317
R510
R325
R503
R504
R316
R506
R505
R507
R511
Q101
Q201
C511
C514
C307
C308
C312
C311
C313
C314
C317
C503
C305
C331
C336
C337
C532
C101
C371
Lead free solder used in the board (material : Sn-Ag-Cu, melting point : 219 Centigrade)
Lead free solder used in the board (material : Sn-Cu, melting point : 230 Centigrade)
CD board
reverse side
T1B
A1
BROWN
YELLOW
BROWN
ORANGE
ORANGE
WHITE
BLACK
RED
WHITE
ORANGE
RED
LVA10834-
C
1
1
1
1
1
1
C
B
B
A
A
B306
B304
B305
B303
R342
R341
TP86
PbF
MARK
UL
USBNPP
USBG
D-
USB_IN
USBNOC
D+
C522
R230
R228
R229
C201
TP70
C202
R245
R339
C552
C551
D501
C335
C325
R338
R337
Q303
C535
M.GND
GND
CD5V
MONI1
R336
DEBAC_SHORT
C332
C334
C326
R335
R334
R309
R308
EXTRG1
R306
R305
CN101
NPD_OUT
NSTBY_OUT
TE
FE
BDO
NRFDET
MONI3
SL001
D503
D301
C329
C304
C330
C395
TP002
C338
R361
R324
R307
R312
R313
R311
R362
X302
C351
C352
IC301
C521
C520 C519
X301
SW5V
NPDOUT
VDD3.3V
NRST
PS2
LRMUTE
SRDATA
LRCK
BCLK
CLK
SCS
UCS
OIOUTR
AGND
OUTL
SW1M
CD8V
RFGND1
VCC
VC
TRK-
TRK+
FCS+
FCS-
VR
LD+
LD-
ARF
VREF
LD
MD
VF1
VT1
VT2
VF2
RF
OSCIN
R101
R333
B301
R519
R201
R521
R16
R14
R15
R13
R520
R332
R349
R525
R12
R11
R330
R509
R371
R517 R516
R301
R331R315
R319
R513
R501
R323
R322
R321
R320
R508
R512
Q302
Q501
Q301
IC501
D201
D502
D101
C
N
1
0
2
C531
C323
C318
C303
C315
C316
C333
C501
C301
C513
C512
C309
C310
C319
C322
C504
C505
C502
C506
C507
C508
C321
C320
C324
C302
C373
C328
C327
C341
C342
C102
C103
Page 37
< MEMO >
Page 38
Victor Company of Japan, Limited
Mobile Entertainment Division 10-1,1chome,Ohwatari-machi,Maebashi-city,Gumma-ken,371-8543,Japan
(No.MA445SCH<Rev.001>)
Printed in Japan
VPT
Page 39
PARTS LIST
KD-R701E,KD-R701EX,KD-R701EY
KD-R701EU,KD-R705U,KD-R705UN
KD-R705UT,KD-R705UH,KD-R707EE
* All printed circuit boards and its assemblies are not available as service parts.
- Contents -
Exploded view of general assembly and parts list (Block No.M1)
CD mechanism assembly and parts list (Block No.MB)
Electrical parts list (Block No.01~04)
Packing materials and accessories parts list (Block No.M3)
MA445PAR<Rev.001>
3- 2
3- 6
3- 8
3-14
3-1
Page 40
Exploded view of general assembly and parts list
Block No.
EE only
14
12
68
Except EE
10
UT only
M
M
1
M
17
Switch
board
63
27
18
8
33
31
19
6
50
33
52
52
26
Function
board
52
52
5
1
F
B
G
A
F
6
E
67
6
41
35
40
38
37
48
3-2
36
53
45
39
46
34
51
42
47
43
44
49
54
66
55
56
59
57
Page 41
G
62
26
Function
board
25
28
20
A
16
21
65
B
7
23
32
29
24
8
30
22
Main board
7
C
64
7
55
52
52
54
61
60
2
58
Only
E,EX,EY,EU,EE ver
11
4
13
E
9
C
15
3
58
The parts without symbol number are not service.
11
3-3
Page 42
General Assembly
Block No. [M][1][M][M]
Symbol No. Part No. Part Name Description Local
1 GE10258-002A TOP CHASSIS 701E,701EX,701EY,701EU,705U,705UN,705UT,705UH
1 GE10258-001A TOP CHASSIS 707EE
2 GE33497-001A INSULATOR
3 GE20254-004A BOTTOM COVER 701E,701EX,701EY,701EU
3 GE20254-003A BOTTOM COVER 705U,705UN,705UT,705UH,707EE
4 GE33234-001A HEATSINK
5 GE40395-001A SIDE PANEL
6 QYSDST2604ZA TAP SCREW M2.6 x 4mm(x3)
7 GE40377-002A SCREW (x3)
8 QYSDST2004ZA TAP SCREW M2 x 4mm(x2)
9 QYSDSF2606ZA TAP SCREW M2.6 x 6mm
10 QYSDST2606ZA TAP SCREW M2.6 x 6mm 701E,701EX,701EY,701EU,705U,705UN,705UT,705UH
11 GE40377-001A SCREW (x2)
12 GE40377-002A SCREW (x2)
13 QYSDST2610ZA TAP SCREW M2.6 x 10mm
14 QYSDST2608ZA TAP SCREW M2.6 x 8mm
15 QYSDST2606ZA TAP SCREW M2.6 x 6mm
16 GE33503-001A F.CHASSIS ASSY
17 GE40454-001A BLIND
18 GE33084-001A LOCK LEVER(L)
19 GE33493-001A DETACH LEVER
20 GE33491-001A OPEN LEVER
21 GE33492-001A LOCK LEVER(T)
22 GE33083-001A LOCK LEVER(R)
23 QZW0108-002 DAMPER
24 GE40154-001A GEAR
25 GE33495-001A CONNECTOR BKT
26 GE40462-001A INSULATOR
27 GE40456-002A T.SPRING
28 GE40461-001A T.SPRING
29 GE40455-003A T.SPRING
30 GE40472-001A T. SPRING
31 GE40202-023A COMPRESSION SPRING
32 QYSDSF2006ZA TAP SCREW M2 x 6mm
33 GE40425-001A SCREW (x3)
34 GE33499-002A FRONT PANEL ASSY
35 GE33502-002A FINDER L ASSY 701E,701EX,701EY,701EU
35 GE33502-004A FINDER L ASSY 705U,705UN,705UT,705UH
35 GE33502-003A FINDER L ASS 707EE
36 GE33501-002A FINDER ASSY 701E,701EX,701EY,701EU
36 GE33501-001A FINDER ASSY 705U,705UN,705UT,705UH
36 GE33501-003A FINDER ASSY 707EE
37 GE33437-001A VOL KNOB ASSY 701E,701EX,701EY,701EU
37 GE33437-002A VOL KNOB ASSY 705U,705UN,705UT,705UH
37 GE33437-003A VOL KNOB ASSY 707EE
38 GE40127-005A KNOB SPRING
39 GE40458-002A PUSH BTN ASSY 701E,701EX,701EY,701EU
39 GE40458-001A PUSH BTN ASSY 705U,705UN,705UT,705UH
39 GE40458-005A PUSH BTN ASSY 707EE
40 GE33476-001A SEARCH BTN
41 GE33478-002A SRC BTN
42 GE33480-001A POWER BTN
43 GE33481-001A DISP BTN 701E,701EX,701EY,701EU,707EE
43 GE33481-002A DISP BTN 705U,705UN,705UT,705UH
44 GE33479-001A OPEN BTN
45 GE33474-001A UP BTN
46 GE33475-001A DOWN BTN
47 GE33490-001A LIGHT GUIDE
48 GE40463-001A JVC BADGE
49 GE40202-016A COMP.SPRING
50 GE10256-001A REAR COVER
51 VKZ4777-011 SCREW
52 VKZ4777-010 MINI SCREW (x4)
53 GE40431-003A REMOTE SHEET
54 GE33483-001A LENS CASE
55 GE33482-001A LCD LENS
56 GE40453-001A LIGHTING SHEET
57 GE33484-001A LCD CASE
58 GE33596-001A NAME PLATE 701E,701EX,701EY,701EU
58 GE33593-001A NAME PLATE 705U,705UN,705UT,705UH
58 GE33599-001A NAME PLATE 707EE
59 QLD0577-001 LCD MODULE
60 QNZ1015-001 RUBBER CONNECTO
61 QNZ1016-001 RUBBER CONNECTO
3-4
Page 43
Symbol No. Part No. Part Name Description Local
62 QMFZ064-150-J1 FUSE 15A
63 GE31574-0B3A UT LABEL 705UT
64 GE40354-001A IC BRACKET
65 GE40396-002A REG BRACKET
66 GE40416-001A USB HOLDER
67 GE40218-0A2A SHEET
68 QYSDST2604ZA TAP SCREW M2.6 x 4mm 707EE
3-5
Page 44
CD mechanism assembly and parts list
FMU-CD4-21D
Grease
JVG-31N
FG-87HS
JVS-1003
43
24
42
10
44
Block No.
50
MMMB
48
A
61
D
29
62
33
F
46
47
64
Photo board
44
44
32
45
D
31
46
C
E
30
Rest switch board
44
F
28
9
Back side
4
8
G
23
2
5
3
57
B
60
59
58
49
59
B
6
35
39
56
41
35
36
51
53
55
54
52
40
37
G
48
7
37
11.1mm
38
0.1mm
A
48
34
48
C
1
14
21
16
14
E
Mecha control board
63
63
65
63
3-6
61
48
22
11.1mm
0.1mm
11
13
12
17
18
15
The parts without symbol number are not service.
20
19
Page 45
CD mechanism
Symbol No. Part No. Part Name Description Local
1 LV11598-001A MECHA FRAME
2 LV36800-002A LINK ARM
3 LV22300-001A SLIDE CAM(L)
4 LV22298-002A SLIDE CAM(R)
5 LV36802-001A LOAD RACK
6 LV44552-001A RETURN SPRING
7 LV36803-002A F LOCK LEVER
8 LV36804-002A CAM COVER
9 VKZ4539-054 MINI SCREW
10 LV11260-002A TOP COVER
11 QAR0373-002 MOTOR
12 QYSPSPT2025MA SCREW M2 x 2.5mm(x2)
13 LV36903-002A L.M.BASE ASSY
14 VKZ4539-054 MINI SCREW (x2)
15 LV36806-001A L.WORM GEAR
16 LV36805-001A M WHEEL GEAR
17 LV36807-001A A WHEEL GEAR
18 LV36808-001A R.ACT GEAR(1)
19 LV36809-001A LOAD ACT GEAR
20 LV36810-001A LOADING GEAR
21 QYWDL1230250 SLIT WASHER 3mm/1.2mm x 0.25mm
22 LV44589-002A COMPRESSION SPRING
23 LV44658-001A LINK SPRING
24 CM-FLMCD1D SPINDLE MOTOR ASSY
28 QAL0993-001 PICK UP
29 LV44555-001A MAIN SHAFT
30 LV36799-001A RACK PLATE
31 LV45227-001A RACK SPRING
32 QYSPSGT1745ZA TAP SCREW M1.7 x 4.5mm
33 LV36813-001A SUB GUIDE CAP
34 QAR0144-003 MOTOR 2.0V DC
35 QYSPSPT2025MA SCREW M2 x 2.5mm(x2)
36 LV22296-001A F.MOTOR HOLDER
37 VKZ4539-054 MINI SCREW (x2)
38 LV36814-001A F.WORM GEAR
39 LV36815-001A F.WHEEL GEAR
40 LV36816-001A TRIGGER ARM
41 LV44589-002A COMPRESSION SPRING
42 LV37326-002A CLAMPER ASSY
43 LV44557-002A CLAMPER SPRING
44 LV44558-001A SUS SPRING (x4)
45 LV36820-001A WIRE HOLDER
46 LV36904-001A DAMPER (x2)
47 LV37061-001A DAMPER
48 VKZ4539-054 MINI SCREW (x6)
49 LV11264-003A DISC PLATE
50 LV44586-001A SPECIAL SCREW
51 LV36801-002A GEAR HOLDER
52 VKZ4539-054 MINI SCREW
53 LV36821-001A R.ACT GEAR(2)
54 LV36822-001A R.ACT GEAR(3)
55 LV36823-001A ROLLER GEAR
56 LV44559-002A ROLLER SHAFT
57 LV22325-002A R H ASSY
58 LV44560-001A ROLLER (x2)
59 LV44590-001A WASHER (x2)
60 LV44561-001A ROLLER COLLAR
61 LV44562-002A ROLLER SPRING (x2)
62 QAL0817-003 FPC
63 VKZ4539-054 MINI SCREW (x3)
64 WJS0085-001A-E E-FL/RB WIRE
65 LV34916-001A WIRE CLAMP
Block No. [M][B][M][M]
3-7
Page 46
Electrical parts list
Main board
Block No. [0][1]
Symbol No.
IC1 TEF6606T/V3-X IC1
IC71 LC72725KM-X IC 701E,701EX,7
IC161 TDA7718-X IC
IC301 TDA7851A IC
IC701 MN101EF16ZXW1E IC 701E,701EX,7
IC701 MN101EF16ZXW1D IC 705U,705UN,7
IC702 S-80824CNNB-G-W IC
IC702 or IC-PST3424U-X IC
IC771 S-24CS16A0I-G-X IC 701E,701EX,7
IC771 S-24CS04AFJ-G-X IC 705U,705UN,7
IC801 74AHCT126PW-X IC 701E,701EX,7
IC901 AN34002A REGULATOR IC
IC931 BD9007HFP-W IC
IC932 TPS2051BD-X IC
Q321 IMX9-W PAIR
Q331 IMX9-W PAIR
Q781 RT1P141C-X DIGI
Q781 or UN2111-X TRANSISTOR
Q782 2SC1623A/5-6/-X TRANSISTOR
Q782 or 2SC3928A/QR/-X TRANSISTOR
Q784 RT1P141C-X DIGI
Q784 or UN2111-X TRANSISTOR
Q881 RT1N141C-X DIGI
Q881 or UN2211-X TRANSISTOR
Q891 RT1N141C-X DIGI
Q891 or UN2211-X TRANSISTOR 701E,701EX,7
Q976 RT1N141C-X DIGI
Q976 or UN2211-X TRANSISTOR
Q977 2SA812A/5-6/-X TRANSISTOR
Q977 or ISA1530AC1/R/-X TRANSISTOR
Q978 2SC1623A/5-6/-X TRANSISTOR
Q978 or 2SC3928A/QR/-X TRANSISTOR
D321 MC2836-X DIODE
D321 or MA152WA-X DIODE
D331 MC2836-X DIODE
D331 or MA152WA-X DIODE
D711 UDZW6.2B-X Z DIODE 701E,701EX,7
D711 or MA8062/M/-X Z DIODE 701E,701EX,7
D712 1SS355W-X DIODE
D712 or MA111-X SI DIODE
D715 UDZW6.2B-X Z DIODE
D715 or MA8062/M/-X Z DIODE
D716 UDZW6.2B-X Z DIODE
D716 or MA8062/M/-X Z DIODE
D717 UDZW6.2B-X Z DIODE
D717 or MA8062/M/-X Z DIODE
D718 UDZW6.2B-X Z DIODE
D718 or MA8062/M/-X Z DIODE
D719 UDZW5.1B-X SB DIODE
D719 or MA8051/M/-X Z DIODE
Part No. Part Name Description Local
01EY,701EU,7
07EE
01EY,701EU,7
07EE
05UT,705UH
01EY,701EU,7
07EE
05UT,705UH
01EY,701EU,7
05U,705UN,70
5UT,705UH
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
701E,701EX,7
01EY,701EU,7
07EE
01EY,701EU,7
07EE
01EY,701EU
01EY,701EU
Symbol No.
D720 UDZW5.1B-X SB DIODE
D720 or MA8051/M/-X Z DIODE
D781 1SS355W-X DIODE
D781 or MA111-X SI DIODE
D782 1SS355W-X DIODE
D782 or MA111-X SI DIODE
D784 UDZW11B-X Z DIODE
D784 or MA8110/M/-X Z DIODE
D785 1SS355W-X DIODE
D785 or MA111-X SI DIODE
D851 MA22F20-X SB DIODE 705U,705UN,7
D852 MA22D23-X SB DIODE 705U,705UN,7
D852 or RB160M-30-X SB DIODE 705U,705UN,7
D852 or CRS03-W SB DIODE 705U,705UN,7
D891 MC2836-X DIODE 701E,701EX,7
D891 or MA152WA-X DIODE 701E,701EX,7
D901 1N5401-F64 SI DIODE
D901 or 1N5401-TU-15 SI DIODE
D902 GS1J-LTP-X DIODE 701E,701EX,7
D931 RSX201L-30-X SB DIODE
D971 MA22F20-X SB DIODE
D972 MA22D23-X SB DIODE
D972 or RB160M-30-X SB DIODE
D972 or CRS03-W SB DIODE
C1 NCB31HK-102X C CAPACITOR 1000pF 50V K
C2 NDC31HJ-5R6X C CAPACITOR 5.6pF 50V J
C3 NCB31HK-102X C CAPACITOR 1000pF 50V K
C4 NCB31AK-224X C CAPACITOR 0.22uF 10V K
C5 NDC31HJ-150X C CAPACITOR 15pF 50V J
C6 NDC31HJ-220X C CAPACITOR 22pF 50V J
C10 NCB21AK-105X C CAPACITOR 1uF 10V K
C11 NCB31HK-103X C CAPACITOR 0.01uF 50V K
C12 NCB31HK-103X C CAPACITOR 0.01uF 50V K
C13 NCB21AK-105X C CAPACITOR 1uF 10V K
C14 NCB31AK-224X C CAPACITOR 0.22uF 10V K
C15 NCB31CK-104X C CAPACITOR 0.1uF 16V K
C16 NCB31HK-103X C CAPACITOR 0.01uF 50V K
C17 NCB31CK-104X C CAPACITOR 0.1uF 16V K
C18 NCB31HK-103X C CAPACITOR 0.01uF 50V K
C19 NCB31CK-104X C CAPACITOR 0.1uF 16V K
C22 NDC31HJ-150X C CAPACITOR 15pF 50V J
C23 NCB31CK-104X C CAPACITOR 0.1uF 16V K
C24 NCB31HK-103X C CAPACITOR 0.01uF 50V K
C25 NCB31HK-103X C CAPACITOR 0.01uF 50V K
C26 QEKJ1CM-107Z E CAPACITOR 100uF 16V M
C27 QEKJ1EM-106Z E CAPACITOR 10uF 25V M
C71 NDC31HJ-561X C CAPACITOR 560pF 50V J 701E,701EX,7
C72 NDC31HJ-331X C CAPACITOR 330pF 50V J 701E,701EX,7
C73 QEKJ1EM-106Z E CAPACITOR 10uF 25V M 701E,701EX,7
C74 NDC31HJ-330X C CAPACITOR 33pF 50V J 701E,701EX,7
C75 NDC31HJ-330X C CAPACITOR 33pF 50V J 701E,701EX,7
C76 NCB31HK-103X C CAPACITOR 0.01uF 50V K 701E,701EX,7
C77 QEKJ0JM-476Z E CAPACITOR 47uF 6.3V M 701E,701EX,7
Part No. Part Name Description Local
05UT,705UH
05UT,705UH
05UT,705UH
05UT,705UH
01EY,701EU,7
07EE
01EY,701EU,7
07EE
01EY,701EU
01EY,701EU,7
07EE
01EY,701EU,7
07EE
01EY,701EU,7
07EE
01EY,701EU,7
07EE
01EY,701EU,7
07EE
01EY,701EU,7
07EE
01EY,701EU,7
07EE
3-8
Page 47
Symbol No.
Part No. Part Name Description Local
Symbol No.
Part No. Part Name Description Local
C78 NCB31HK-103X C CAPACITOR 0.01uF 50V K 701E,701EX,7
C161 NCB31AK-105X C CAPACITOR 1uF 10V K
C162 QTE1H57-105Z E CAPACITOR 1uF 50V 701E,701EX,7
C164 NCB31AK-105X C CAPACITOR 1uF 10V K
C165 NCB31AK-105X C CAPACITOR 1uF 10V K
C171 NCB31AK-105X C CAPACITOR 1uF 10V K
C172 QTE1H57-105Z E CAPACITOR 1uF 50V 701E,701EX,7
C174 NCB31AK-105X C CAPACITOR 1uF 10V K
C177 NDC31HJ-560X C CAPACITOR 56pF 50V J
C178 QTE1C57-106Z E CAPACITOR 10uF 16V
C183 QEKJ1AM-227Z E CAPACITOR 220uF 10V M
C184 NCB31CK-104X C CAPACITOR 0.1uF 16V K
C301 QFV91HJ-474Z MF CAPACITOR 0.47uF 50V J
C302 QFV91HJ-474Z MF CAPACITOR 0.47uF 50V J
C311 QFV91HJ-474Z MF CAPACITOR 0.47uF 50V J
C312 QFV91HJ-474Z MF CAPACITOR 0.47uF 50V J
C315 NCB31AK-105X C CAPACITOR 1uF 10V K
C316 QEKJ1HM-475Z E CAPACITOR 4.7uF 50V M
C317 QTE1C57-476Z E CAPACITOR 47uF 16V
C318 QEKJ1HM-225Z E CAPACITOR 2.2uF 50V M
C319 NDC31HJ-101X C CAPACITOR 100pF 50V J
C320 NDC31HJ-101X C CAPACITOR 100pF 50V J
C326 QEKJ1CM-226Z E CAPACITOR 22uF 16V M
C327 NDC31HJ-820X C CAPACITOR 82pF 50V J
C330 NCB31HK-103X C CAPACITOR 0.01uF 50V K
C331 NCB31HK-103X C CAPACITOR 0.01uF 50V K
C365 QEKJ1HM-475Z E CAPACITOR 4.7uF 50V M
C366 QEKJ1HM-475Z E CAPACITOR 4.7uF 50V M
C385 QEKJ1HM-475Z E CAPACITOR 4.7uF 50V M
C386 QEKJ1HM-475Z E CAPACITOR 4.7uF 50V M
C583 NCB31HK-332X C CAPACITOR 3300pF 50V K
C584 NCB31HK-332X C CAPACITOR 3300pF 50V K
C585 QTE1H65-225Z E CAPACITOR 2.2uF 50V
C586 QTE1H65-225Z E CAPACITOR 2.2uF 50V
C587 NDC31HJ-331X C CAPACITOR 330pF 50V J
C588 NDC31HJ-331X C CAPACITOR 330pF 50V J
C703 NDC31HJ-270X C CAPACITOR 27pF 50V J
C704 NDC31HJ-270X C CAPACITOR 27pF 50V J
C706 NCB31EK-103X C CAPACITOR 0.01uF 25V K
C707 QEKJ1CM-107Z E CAPACITOR 100uF 16V M
C708 NCB31CK-104X C CAPACITOR 0.1uF 16V K
C709 NCB31CK-104X C CAPACITOR 0.1uF 16V K
C710 NDC31HJ-101X C CAPACITOR 100pF 50V J 701E,701EX,7
C711 QEKJ0JM-476Z E CAPACITOR 47uF 6.3V M
C713 NDC31HJ-560X C CAPACITOR 56pF 50V J
C714 NCB31CK-104X C CAPACITOR 0.1uF 16V K
C715 NCB31CK-104X C CAPACITOR 0.1uF 16V K
C716 NCJ11EK-106X-A C CAPACITOR 10uF 25V K
C717 NDC31HJ-821X C CAPACITOR 820pF 50V J
C718 NCB31CK-104X C CAPACITOR 0.1uF 16V K
C719 QERF1AM-107Z E CAPACITOR 100uF 10V M
C720 NDC31HJ-820X C CAPACITOR 82pF 50V J
C721 NCB31CK-104X C CAPACITOR 0.1uF 16V K
C722 QERF1EM-475Z E CAPACITOR 4.7uF 25V M
C729 NCB31HK-472X C CAPACITOR 4700pF 50V K
C730 NCB31HK-472X C CAPACITOR 4700pF 50V K
C731 NDC31HJ-220X C CAPACITOR 22pF 50V J
C732 NDC31HJ-220X C CAPACITOR 22pF 50V J
C733 NCB31CK-104X C CAPACITOR 0.1uF 16V K
C771 NCB31CK-473X C CAPACITOR 0.047uF 16V K
C781 QEKJ0JM-107Z E CAPACITOR 100uF 6.3V M
C784 QERF1CM-107Z E CAPACITOR 100uF 16V M
C801 NCB31CK-473X C CAPACITOR 0.047uF 16V K 701E,701EX,7
C851 QEKJ1EM-106Z E CAPACITOR 10uF 25V M 705U,705UN,7
C852 NCB31CK-224X C CAPACITOR 0.22uF 16V K 705U,705UN,7
C881 QEKJ1CM-226Z E CAPACITOR 22uF 16V M
01EY,701EU,7
07EE
01EY,701EU,7
05U,705UN,70
5UT,705UH
01EY,701EU,7
05U,705UN,70
5UT,705UH
01EY,701EU
01EY,701EU,7
05U,705UN,70
5UT,705UH
05UT,705UH
05UT,705UH
C891 NCB31CK-104X C CAPACITOR 0.1uF 16V K 701E,701EX,7
C901 QEZ0870-278 E CAPACITOR 2700uF
C902 QERF1HM-225Z E CAPACITOR 2.2uF 50V M
C903 QEKJ1CM-107Z E CAPACITOR 100uF 16V M
C905 QEKJ1CM-476Z E CAPACITOR 47uF 16V M
C906 NCB31HK-103X C CAPACITOR 0.01uF 50V K
C907 QERF1AM-227Z E CAPACITOR 220uF 10V M
C908 QERF1AM-227Z E CAPACITOR 220uF 10V M
C909 QERF0JM-337Z E CAPACITOR 330uF 6.3V M
C910 QEKJ1EM-106Z E CAPACITOR 10uF 25V M
C912 NCB31HK-103X C CAPACITOR 0.01uF 50V K
C914 QEKJ1CM-107Z E CAPACITOR 100uF 16V M
C916 NCB31HK-103X C CAPACITOR 0.01uF 50V K
C917 QERF0JM-337Z E CAPACITOR 330uF 6.3V M
C928 NCB31HK-472X C CAPACITOR 4700pF 50V K
C931 QEZ0595-477Z E CAPACITOR 470uF 25V M
C932 QBZ0006-337Z TA E CAPACITOR 330uF
C933 NCB10JK-106X-A C CAPACITOR 10uF 6.3V K
C934 NDC31HJ-101X C CAPACITOR 100pF 50V J
C935 NCB31HK-152X C CAPACITOR 1500pF 50V K
C936 NDC31HJ-180X C CAPACITOR 18pF 50V J
C937 NCB21CK-474X C CAPACITOR 0.47uF 16V K
C938 NCJ21EK-225X-D C CAPACITOR 2.2uF 25V K
C971 NCB31EK-104X C CAPACITOR 0.1uF 25V K
C990 NCB31HK-472X C CAPACITOR 4700pF 50V K
R2 NRSA63J-474X MG RESISTOR 470k
R3 NRSA63J-0R0X MG RESISTOR 0
R4 NRSA63J-472X MG RESISTOR 4.7k
R5 NRS181J-220X MG RESISTOR 22
R6 NRSA63J-101X MG RESISTOR 100
R7 NRSA63J-101X MG RESISTOR 100
R11 NRS181J-4R7X MG RESISTOR 4.7
R12 NRSA63J-0R0X MG RESISTOR 0
R14 NRSA63J-472X MG RESISTOR 4.7k
R15 NRSA63J-472X MG RESISTOR 4.7k
R71 NRSA63J-0R0X MG RESISTOR 0
R72 NRSA63J-222X MG RESISTOR 2.2k
R73 NRSA63J-222X MG RESISTOR 2.2k
R74 NRSA02J-101X MG RESISTOR 100
R81 NRSA63J-682X MG RESISTOR 6.8k
R82 NRSA63J-822X MG RESISTOR 8.2k
R91 NRSA63J-682X MG RESISTOR 6.8k
R92 NRSA63J-822X MG RESISTOR 8.2k
R161 NRSA63J-472X MG RESISTOR 4.7k
R162 NRSA63J-472X MG RESISTOR 4.7k
R171 NRSA63J-101X MG RESISTOR 100
R172 NRSA63J-101X MG RESISTOR 100
R301 NRSA63J-102X MG RESISTOR 1k
R302 NRSA63J-102X MG RESISTOR 1k
R305 NRSA63J-102X MG RESISTOR 1k
R307 NRSA63J-273X MG RESISTOR 27k
R309 NRSA63J-100X MG RESISTOR 10
R310 NRSA63J-472X MG RESISTOR 4.7k
R311 NRSA63J-102X MG RESISTOR 1k
R312 NRSA63J-102X MG RESISTOR 1k
R321 NRSA63J-222X MG RESISTOR 2.2k
R322 NRSA63J-821X MG RESISTOR 820
R323 NRSA63J-101X MG RESISTOR 100
R324 NRSA63J-473X MG RESISTOR 47k
R331 NRSA63J-222X MG RESISTOR 2.2k
R332 NRSA63J-821X MG RESISTOR 820
R333 NRSA63J-101X MG RESISTOR 100
R334 NRSA63J-473X MG RESISTOR 47k
R341 NRSA63J-222X MG RESISTOR 2.2k
R342 NRSA63J-821X MG RESISTOR 820
R343 NRSA63J-101X MG RESISTOR 100
R344 NRSA63J-473X MG RESISTOR 47k
Ω
Ω
1/10W J
Ω
1/16W J
Ω
1/8W J
Ω
1/16W J
Ω
1/16W J
Ω
1/8W J
Ω
1/10W J 701E,701EX,7
Ω
1/16W J
Ω
1/16W J
Ω
1/10W J 701E,701EX,7
Ω
1/16W J 701E,701EX,7
Ω
1/16W J 701E,701EX,7
Ω
1/10W J 701E,701EX,7
Ω
1/16W J
Ω
1/16W J
Ω
1/16W J
Ω
1/16W J
Ω
1/16W J
Ω
1/16W J
Ω
1/16W J
Ω
1/16W J
Ω
1/16W J
Ω
1/16W J
Ω
1/16W J
Ω
1/16W J
Ω
1/16W J
Ω
1/16W J
Ω
1/16W J
Ω
1/16W J
Ω
1/16W J
Ω
1/16W J
Ω
1/16W J
Ω
1/16W J
Ω
1/16W J
Ω
1/16W J
Ω
1/16W J
Ω
1/16W J
Ω
1/16W J
Ω
1/16W J
Ω
1/16W J
Ω
1/16W J
1/16W J
01EY,701EU,7
07EE
01EY,701EU,7
07EE
01EY,701EU,7
07EE
01EY,701EU,7
07EE
01EY,701EU,7
07EE
01EY,701EU,7
07EE
3-9
Page 48
Symbol No.
Part No. Part Name Description Local
Symbol No.
Part No. Part Name Description Local
R351 NRSA63J-222X MG RESISTOR 2.2kΩ 1/16W J
R352 NRSA63J-821X MG RESISTOR 820
R353 NRSA63J-101X MG RESISTOR 100
R354 NRSA63J-473X MG RESISTOR 47k
R583 NRSA63J-153X MG RESISTOR 15k
R584 NRSA63J-153X MG RESISTOR 15k
R585 NRSA63J-102X MG RESISTOR 1k
R586 NRSA63J-102X MG RESISTOR 1k
R587 NRSA63J-183X MG RESISTOR 18k
R588 NRSA63J-183X MG RESISTOR 18k
R701 NRSA63J-103X MG RESISTOR 10k
R702 NRSA63J-103X MG RESISTOR 10k
R703 NRSA63J-104X MG RESISTOR 100k
R704 NRSA63J-104X MG RESISTOR 100k
R705 NRSA63J-103X MG RESISTOR 10k
R706 NRSA63J-473X MG RESISTOR 47k
R708 NRSA63J-104X MG RESISTOR 100k
R709 NRSA63J-473X MG RESISTOR 47k
R712 NRSA63J-331X MG RESISTOR 330
R714 NRSA63J-0R0X MG RESISTOR 0
R717 NRSA63J-0R0X MG RESISTOR 0
R718 NRSA63J-0R0X MG RESISTOR 0
R719 NRSA63J-102X MG RESISTOR 1k
R720 NRSA63J-102X MG RESISTOR 1k
R721 NRSA63J-102X MG RESISTOR 1k
R722 NRS181J-102X MG RESISTOR 1k
R723 NRSA63J-0R0X MG RESISTOR 0
R724 NRSA63J-102X MG RESISTOR 1k
R725 NRSA63J-102X MG RESISTOR 1k
R726 NRSA63J-103X MG RESISTOR 10k
R727 NRSA63J-473X MG RESISTOR 47k
R728 NRSA63J-102X MG RESISTOR 1k
R729 NRSA63J-104X MG RESISTOR 100k
R730 NRSA63J-102X MG RESISTOR 1k
R731 NRSA63J-101X MG RESISTOR 100
R732 NRSA63J-473X MG RESISTOR 47k
R733 NRSA63J-473X MG RESISTOR 47k
R734 NRSA63J-103X MG RESISTOR 10k
R735 NRSA63J-473X MG RESISTOR 47k
R736 NRSA63J-561X MG RESISTOR 560
R737 NRSA63J-561X MG RESISTOR 560
R738 NRSA63J-561X MG RESISTOR 560
R739 NRSA63J-101X MG RESISTOR 100
R740 NRSA63J-561X MG RESISTOR 560
R741 NRSA63J-101X MG RESISTOR 100
R742 NRSA63J-101X MG RESISTOR 100
R743 NRSA63J-101X MG RESISTOR 100
R744 NRSA63J-101X MG RESISTOR 100
R745 NRSA63J-101X MG RESISTOR 100
R746 NRSA63J-104X MG RESISTOR 100k
R747 NRSA63J-103X MG RESISTOR 10k
R748 NRSA63J-122X MG RESISTOR 1.2k
R749 NRSA63J-102X MG RESISTOR 1k
R750 NRS181J-224X MG RESISTOR 220k
R751 NRSA63J-122X MG RESISTOR 1.2k
R752 NRSA63J-472X MG RESISTOR 4.7k
Ω
1/16W J
Ω
1/16W J
Ω
1/16W J
Ω
1/16W J
Ω
1/16W J
Ω
1/16W J
Ω
1/16W J
Ω
1/16W J
Ω
1/16W J
Ω
1/16W J
Ω
1/16W J
Ω
1/16W J
Ω
1/16W J
Ω
1/16W J
Ω
1/16W J
Ω
1/16W J 705U,705UN,7
Ω
1/16W J 701E,701EX,7
Ω
1/16W J
Ω
1/10W J
Ω
1/10W J 701E,701EX,7
Ω
1/10W J 701E,701EX,7
Ω
1/16W J 701E,701EX,7
Ω
1/16W J
Ω
1/16W J 701E,701EX,7
Ω
1/8W J 701E,701EX,7
Ω
1/10W J 701E,701EX,7
Ω
1/16W J
Ω
1/16W J
Ω
1/16W J
Ω
1/16W J
Ω
1/16W J
Ω
1/16W J
Ω
1/16W J
Ω
1/16W J
Ω
1/16W J
Ω
1/16W J
Ω
1/16W J
Ω
1/16W J
Ω
1/16W J
Ω
1/16W J
Ω
1/16W J
Ω
1/16W J
Ω
1/16W J
Ω
1/16W J
Ω
1/16W J
Ω
1/16W J 701E,701EX,7
Ω
1/16W J
Ω
1/16W J 701E,701EX,7
Ω
1/16W J
Ω
1/16W J
Ω
1/16W J
Ω
1/16W J
Ω
1/8W J
Ω
1/16W J
Ω
1/16W J
05UT,705UH,7
07EE
01EY,701EU
01EY,701EU,7
05U,705UN,70
5UT,705UH
01EY,701EU,7
05U,705UN,70
5UT,705UH
01EY,701EU,7
05U,705UN,70
5UT,705UH
01EY,701EU,7
05U,705UN,70
5UT,705UH
01EY,701EU,7
05U,705UN,70
5UT,705UH
01EY,701EU,7
05U,705UN,70
5UT,705UH
01EY,701EU,7
07EE
01EY,701EU,7
07EE
R753 NRSA63J-472X MG RESISTOR 4.7kΩ 1/16W J
R754 NRSA63J-273X MG RESISTOR 27k
R755 NRSA63J-472X MG RESISTOR 4.7k
R756 NRSA63J-472X MG RESISTOR 4.7k
R757 NRSA63J-122X MG RESISTOR 1.2k
R758 NRSA63J-473X MG RESISTOR 47k
R760 NRSA63J-122X MG RESISTOR 1.2k
R761 NRSA63J-122X MG RESISTOR 1.2k
R762 NRSA63J-122X MG RESISTOR 1.2k
R763 NRSA63J-823X MG RESISTOR 82k
R764 NRSA63J-823X MG RESISTOR 82k
R765 NRSA63J-471X MG RESISTOR 470
R767 NRSA63J-473X MG RESISTOR 47k
R769 NRS181J-472X MG RESISTOR 4.7k
R770 NRSA63J-222X MG RESISTOR 2.2k
R771 NRSA63J-271X MG RESISTOR 270
R772 NRSA63J-271X MG RESISTOR 270
R773 NRSA63J-223X MG RESISTOR 22k
R774 NRSA63J-473X MG RESISTOR 47k
R775 NRSA63J-222X MG RESISTOR 2.2k
R776 NRSA63J-472X MG RESISTOR 4.7k
R777 NRSA63J-103X MG RESISTOR 10k
R778 NRSA63J-472X MG RESISTOR 4.7k
R779 NRSA63J-101X MG RESISTOR 100
R781 NRSA63J-473X MG RESISTOR 47k
R782 NRSA63J-472X MG RESISTOR 4.7k
R783 NRSA63J-103X MG RESISTOR 10k
R801 NRSA63J-102X MG RESISTOR 1k
R802 NRSA63J-104X MG RESISTOR 100k
R803 NRSA63J-333X MG RESISTOR 33k
R804 NRSA63J-183X MG RESISTOR 18k
R805 NRS181J-0R0X MG RESISTOR 0
R806 NRS181J-102X MG RESISTOR 1k
R807 NRSA63J-104X MG RESISTOR 100k
R808 NRSA63J-101X MG RESISTOR 100
R809 NRSA63J-473X MG RESISTOR 47k
R810 NRSA63J-392X MG RESISTOR 3.9k
R811 NRSA63J-682X MG RESISTOR 6.8k
R812 NRSA63J-104X MG RESISTOR 100k
R813 NRSA63J-102X MG RESISTOR 1k
Ω
1/16W J
Ω
1/16W J
Ω
1/16W J
Ω
1/16W J
Ω
1/16W J
Ω
1/16W J
Ω
1/16W J
Ω
1/16W J
Ω
1/16W J
Ω
1/16W J 701E,701EX,7
Ω
1/16W J
Ω
1/16W J
Ω
1/8W J
Ω
1/16W J 701E,701EX,7
Ω
1/16W J
Ω
1/16W J
Ω
1/16W J 701E,701EX,7
Ω
1/16W J
Ω
1/16W J
Ω
1/16W J
Ω
1/16W J
Ω
1/16W J
Ω
1/16W J
Ω
1/16W J
Ω
1/16W J
Ω
1/16W J
Ω
1/16W J 701E,701EX,7
Ω
1/16W J 701E,701EX,7
Ω
1/16W J 701E,701EX,7
Ω
1/16W J 701E,701EX,7
Ω
1/8W J 701E,701EX,7
Ω
1/8W J 701E,701EX,7
Ω
1/16W J 701E,701EX,7
Ω
1/16W J 701E,701EX,7
Ω
1/16W J 701E,701EX,7
Ω
1/16W J 701E,701EX,7
Ω
1/16W J 701E,701EX,7
Ω
1/16W J 701E,701EX,7
Ω
1/16W J 701E,701EX,7
01EY,701EU,7
07EE
01EY,701EU
01EY,701EU
01EY,701EU,7
05U,705UN,70
5UT,705UH
01EY,701EU,7
05U,705UN,70
5UT,705UH
01EY,701EU,7
05U,705UN,70
5UT,705UH
01EY,701EU,7
05U,705UN,70
5UT,705UH
01EY,701EU,7
05U,705UN,70
5UT,705UH
01EY,701EU,7
05U,705UN,70
5UT,705UH
01EY,701EU,7
05U,705UN,70
5UT,705UH
01EY,701EU,7
05U,705UN,70
5UT,705UH
01EY,701EU,7
05U,705UN,70
5UT,705UH
01EY,701EU,7
05U,705UN,70
5UT,705UH
01EY,701EU,7
05U,705UN,70
5UT,705UH
01EY,701EU,7
05U,705UN,70
5UT,705UH
01EY,701EU,7
05U,705UN,70
5UT,705UH
3-10
Page 49
Symbol No.
R814 NRS181J-101X MG RESISTOR 100Ω 1/8W J 701E,701EX,7
R819 NRSA63J-473X MG RESISTOR 47k
R851 NRSA63J-103X MG RESISTOR 10k
R881 NRS181J-473X MG RESISTOR 47k
R882 NRSA63J-472X MG RESISTOR 4.7k
R891 NRSA63J-102X MG RESISTOR 1k
R892 NRSA63J-473X MG RESISTOR 47k
R901 QRE142J-102X C RESISTOR 1k
R902 NRSA02J-912X MG RESISTOR 9.1k
R903 NRSA02J-472X MG RESISTOR 4.7k
R904 NRS181J-0R0X MG RESISTOR 0
R928 NRSA63J-753X MG RESISTOR 75k
R929 NRSA63J-513X MG RESISTOR 51k
R930 NRSA63J-0R0X MG RESISTOR 0
R937 NRS181J-221X MG RESISTOR 220
R939 NRSA63D-153X MG RESISTOR 15k
R940 NRSA63D-823X MG RESISTOR 82k
R971 NRS181J-332X MG RESISTOR 3.3k
R976 NRSA02J-273X MG RESISTOR 27k
R977 NRSA02J-123X MG RESISTOR 12k
L1 NQL093K-R47X COIL 0.47uH K
L3 QQL213M-R22Z COIL 0.22uH M
L4 QQR1813-001 COIL
L5 QQL244J-561Z COIL 560uH J
L6 QQL244J-561Z COIL 560uH J
L7 QQL244J-4R7Z P COIL 4.7uH J
L8 QQL244J-4R7Z P COIL 4.7uH J
L701 QQL244J-4R7Z P COIL 4.7uH J
L702 QQL244J-4R7Z P COIL 4.7uH J
L901 QQR1809-001 CHOKE COIL
L931 QQL92AK-330Z COIL 33uH K
L932 NQLH25M-4R7X COIL 4.7uH M
CN501 QGB2027ME-28 CONNECTOR B-B (1-28)
CN701 QGB1004K1-28 CONNECTOR B-B (1-28)
CN703 QNS0283-001 STEERING
CN901 QNZ0607-001 CAR
J1 QNB0190-001 ANT TERMINAL
J321 QNN0815-001 PIN JACK
J801 QNZ0095-001 CONNECTOR 701E,701EX,7
S701 QSW0648-001Z TACT SWITCH
S702 QSW0451-001 PUSH SWITCH
S703 QSW0451-001 PUSH SWITCH
X1 QAX0928-001Z CRYSTAL
X71 QAX0926-001Z CRYSTAL 701E,701EX,7
X701 QAX0667-001Z C RESONATOR 8.000MHz
X702 QAX0401-001 CRYSTAL 32.768KHz
Part No. Part Name Description Local
01EY,701EU,7
05U,705UN,70
1/16W J
1/10W J
1/10W J
1/8W J
5UT,705UH
01EY,701EU,7
05U,705UN,70
5UT,705UH
05UT,705UH
01EY,701EU,7
07EE
01EY,701EU,7
07EE
701E,701EX,7
01EY,701EU
01EY,701EU,7
05U,705UN,70
5UT,705UH
01EY,701EU,7
07EE
REMOTE
CONNECTOR
Ω
1/16W J 701E,701EX,7
Ω
1/16W J 705U,705UN,7
Ω
1/8W J
Ω
Ω
1/16W J 701E,701EX,7
Ω
1/16W J 701E,701EX,7
Ω
1/4W J
Ω
Ω
Ω
1/8W J
Ω
1/16W J
Ω
1/16W J
Ω
1/10W J
Ω
1/8W J
Ω
1/16W D
Ω
1/16W D
Ω
Ω
1/10W J
Ω
1/10W J
Switch board
Block No. [0][2]
Symbol No.
IC601 PTC6526LQ-L IC
IC602 NJL29H380A REMOCON RCV
IC603 NCP5623DTBR2G-X IC
Q601 2SA2174G-X TRANSISTOR
Q601 or 2SA1774/QR/-X TRANSISTOR
Q602 2SA2174G-X TRANSISTOR
Q602 or 2SA1774/QR/-X TRANSISTOR
Q603 2SA2174G-X TRANSISTOR
Q603 or 2SA1774/QR/-X TRANSISTOR
Q604 UN2222-X IC
Q604 or DTD143EK-X TRANSISTOR
Q605 UN2222-X IC
Q605 or DTD143EK-X TRANSISTOR
Q606 UN2222-X IC
Q606 or DTD143EK-X TRANSISTOR
Q607 UNR9211G-X TRANSISTOR
Q607 or DTC114EEB-X TRANSISTOR
Q608 2SC1623A/5-6/-X TRANSISTOR
Q608 or 2SC3928A/QR/-X TRANSISTOR
D600 LHQ974/LM/-X LED
D601 LHQ974/LM/-X LED
D602 LHQ974/LM/-X LED
D603 LHQ974/LM/-X LED
D604 NSSM065T-X LED
D605 NSSM065T-X LED
D606 NSSM065T-X LED
D608 NSSM065T-X LED
D642 MA111-X SI DIODE
D642 or 1SS355W-X DIODE
D645 or UDZW5.6B-X Z DIODE
D645 MA8056/M/-X Z DIODE
D691 or UDZW5.1B-X SB DIODE
D691 MA8051/M/-X Z DIODE
D692 or UDZW5.1B-X SB DIODE
D692 MA8051/M/-X Z DIODE
C600 NCB31CK-105X C CAPACITOR 1uF 16V K
C601 NCB31CK-223X C CAPACITOR 0.022uF 16V K
C602 NDC31HJ-151X C CAPACITOR 150pF 50V J
C603 NCB31CK-105X C CAPACITOR 1uF 16V K
C604 NCB31CK-104X C CAPACITOR 0.1uF 16V K
C605 NCB31CK-104X C CAPACITOR 0.1uF 16V K
C606 NCB31CK-104X C CAPACITOR 0.1uF 16V K
C608 NBE21CM-106X TA E CAPACITOR 10uF 16V M
C609 NCB31CK-105X C CAPACITOR 1uF 16V K
C611 NCB31EK-104X C CAPACITOR 0.1uF 25V K
C623 NCB31CK-104X C CAPACITOR 0.1uF 16V K
C692 NCJ11EK-106X-R C CAPACITOR 10uF 25V
R601 NRSA63J-821X MG RESISTOR 820
R602 NRSA63J-821X MG RESISTOR 820
R603 NRSA63J-122X MG RESISTOR 1.2k
R604 NRSA63J-182X MG RESISTOR 1.8k
R605 NRSA63J-272X MG RESISTOR 2.7k
R606 NRSA63J-821X MG RESISTOR 820
R607 NRSA63J-821X MG RESISTOR 820
R608 NRSA63J-122X MG RESISTOR 1.2k
R609 NRSA63J-182X MG RESISTOR 1.8k
R610 NRSA63J-272X MG RESISTOR 2.7k
R624 NRSA63J-101X MG RESISTOR 100
R625 NRSA63J-101X MG RESISTOR 100
R630 NRSA02J-271X MG RESISTOR 270
R631 NRSA02J-331X MG RESISTOR 330
R634 NRSA02J-681X MG RESISTOR 680
R635 NRSA02J-331X MG RESISTOR 330
R636 NRSA02J-331X MG RESISTOR 330
R637 NRSA02J-621X MG RESISTOR 620
R638 NRS181J-561X MG RESISTOR 560
R639 NRS181J-561X MG RESISTOR 560
R640 NRS181J-821X MG RESISTOR 820
R641 NRS181J-471X MG RESISTOR 470
R642 NRS181J-471X MG RESISTOR 470
Part No. Part Name Description Local
Ω
1/16W J
Ω
1/16W J
Ω
1/16W J
Ω
1/16W J
Ω
1/16W J
Ω
1/16W J
Ω
1/16W J
Ω
1/16W J
Ω
1/16W J
Ω
1/16W J
Ω
1/16W J
Ω
1/16W J
Ω
1/10W J
Ω
1/10W J
Ω
1/10W J
Ω
1/10W J
Ω
1/10W J
Ω
1/10W J
Ω
1/8W J
Ω
1/8W J
Ω
1/8W J
Ω
1/8W J
Ω
1/8W J
3-11
Page 50
Symbol No.
Part No. Part Name Description Local
Symbol No.
Part No. Part Name Description Local
R643 NRS181J-751X MG RESISTOR 750Ω 1/8W J
R648 NRS181J-0R0X MG RESISTOR 0
R649 NRSA63J-102X MG RESISTOR 1k
R654 NRSA63J-101X MG RESISTOR 100
R655 NRSA63J-101X MG RESISTOR 100
R656 NRSA63J-101X MG RESISTOR 100
R658 NRSA63J-394X MG RESISTOR 390k
R659 NRSA63J-224X MG RESISTOR 220k
R663 NRSA63J-102X MG RESISTOR 1k
R665 NRSA63J-102X MG RESISTOR 1k
R666 NRSA63J-101X MG RESISTOR 100
R667 NRSA63J-102X MG RESISTOR 1k
R668 NRSA63F-154X MG RESISTOR 150k
R669 NRSA63J-101X MG RESISTOR 100
R671 NRSA63J-222X MG RESISTOR 2.2k
R672 NRSA63J-222X MG RESISTOR 2.2k
R673 NRSA63J-222X MG RESISTOR 2.2k
R691 NRSA63J-102X MG RESISTOR 1k
R692 NRSA63J-471X MG RESISTOR 470
R694 NRS181J-104X MG RESISTOR 100k
L686 NQR0007-002X FERRITE BEADS
L687 NQR0007-002X FERRITE BEADS
L688 NQR0007-002X FERRITE BEADS
L691 NQR0536-001X CHOKE COIL
CN601 QGZ1201M1-25W CONNECTOR (1-25)
EN601 QSW1231-002 ROTARY ENCODER
J601 QNS0280-001 3.5 JACK
J602 QNZ1007-001 USB JACK
S601 NSW0316-001X TACT SWITCH
S602 NSW0316-001X TACT SWITCH
S603 NSW0316-001X TACT SWITCH
S604 NSW0316-001X TACT SWITCH
S605 NSW0316-001X TACT SWITCH
S606 NSW0316-001X TACT SWITCH
S607 NSW0316-001X TACT SWITCH
S608 NSW0316-001X TACT SWITCH
S609 NSW0316-001X TACT SWITCH
S610 NSW0316-001X TACT SWITCH
S611 NSW0316-001X TACT SWITCH
Ω
1/8W J
Ω
1/16W J
Ω
Ω
Ω
Ω
1/16W J
Ω
1/16W J
Ω
Ω
1/16W J
Ω
Ω
1/16W J
Ω
Function board
Block No. [0][3]
Symbol No.
D2441 LHQ974/LM/-X LED
D2442 LHQ974/LM/-X LED
D2443 LHQ974/LM/-X LED
R2442 NRSA63J-681X MG RESISTOR 680
R2443 NRSA63J-152X MG RESISTOR 1.5k
CN741 QGB1004J2-28X CONNECTOR B-B (1-28)
CN742 QGZ1201L1-25 CONNECTOR (1-25)
S2441 NSW0316-001X TACT SWITCH
Part No. Part Name Description Local
Ω
Mecha control board
Block No. [0][4]
Symbol No.
IC301 MN6627946JC IC(MCU)
IC302 BR24L16F-W-X IC(DIGITAL)
IC303 MFI341S2162-X IC
IC501 LA6565-X IC
Q101 2SC3928A/R/-X TRANSISTOR
Q201 2SC3928A/R/-X TRANSISTOR
Part No. Part Name Description Local
1/16W J
1/16W J
1/16W J
Ω
1/16W J
Ω
1/16W J
1/16W J
Ω
1/16W F
1/16W J
Ω
1/16W J
Ω
1/16W J
Ω
1/16W J
1/16W J
Ω
1/8W J
1/16W J
Ω
1/16W J
Q211 PS1191RB22/BC/X PHOTO
Q212 PS1191RB22/BC/X PHOTO
Q301 ISA1530AC1/RS/X TRANSISTOR
Q302 RT1N441C-X TRANSISTOR
Q303 RT1N441C-X TRANSISTOR
Q501 2SB1424/R/-W TRANSISTOR
D101 AN1105W21/AB/-X IR LED
D201 AN1105W21/AB/-X IR LED
D501 1SR154-400-X SI DIODE
D502 1SR154-400-X SI DIODE
D503 1SR154-400-X SI DIODE
C101 NCB31CK-104X C CAPACITOR 0.1uF 16V K
C102 NCB31CK-104X C CAPACITOR 0.1uF 16V K
C103 NCB31CK-104X C CAPACITOR 0.1uF 16V K
C104 NCB31CK-104X C CAPACITOR 0.1uF 16V K
C201 NCB31CK-104X C CAPACITOR 0.1uF 16V K
C301 NEAF0JM-226X E CAPACITOR 22uF 6.3V M
C302 NCB31CK-104X C CAPACITOR 0.1uF 16V K
C303 NEAF0JM-476X E CAPACITOR 47uF 6.3V M
C304 NCB31CK-104X C CAPACITOR 0.1uF 16V K
C305 NCB31CK-104X C CAPACITOR 0.1uF 16V K
C306 NCB31CK-104X C CAPACITOR 0.1uF 16V K
C307 NCB31CK-334X C CAPACITOR 0.33uF 16V K
C308 NCB31HK-102X C CAPACITOR 1000pF 50V K
C309 NCB31EK-823X C CAPACITOR 0.082uF 25V K
C310 NCB31HK-102X C CAPACITOR 1000pF 50V K
C311 NCB31CK-104X C CAPACITOR 0.1uF 16V K
C312 NCB31HK-153X C CAPACITOR 0.015uF 50V K
C313 NCJ21CK-475X-R C CAPACITOR 4.7uF 16V K
C314 NCB31HK-332X C CAPACITOR 3300pF 50V K
C315 NEAF0JM-476X E CAPACITOR 47uF 6.3V M
C316 NEAF0JM-476X E CAPACITOR 47uF 6.3V M
C317 NCB31HK-223X C CAPACITOR 0.022uF 50V K
C319 NCB31CK-334X C CAPACITOR 0.33uF 16V K
C321 NCB31HK-272X C CAPACITOR 2700pF 50V K
C322 NCB31CK-154X C CAPACITOR 0.15uF 16V K
C323 NEAF0JM-476X E CAPACITOR 47uF 6.3V M
C324 NCB31CK-104X C CAPACITOR 0.1uF 16V K
C325 NCJ20JK-106X-R C CAPACITOR 10uF 6.3V K
C326 NCJ20JK-106X-R C CAPACITOR 10uF 6.3V K
C327 NCB31CK-104X C CAPACITOR 0.1uF 16V K
C328 NCB31HK-681X C CAPACITOR 680pF 50V K
C329 NCB31CK-104X C CAPACITOR 0.1uF 16V K
C330 NCJ20JK-106X-R C CAPACITOR 10uF 6.3V K
C331 NCJ20JK-106X-R C CAPACITOR 10uF 6.3V K
C332 NCJ20JK-106X-R C CAPACITOR 10uF 6.3V K
C334 NCB31CK-104X C CAPACITOR 0.1uF 16V K
C335 NCB31CK-104X C CAPACITOR 0.1uF 16V K
C336 NCB31CK-104X C CAPACITOR 0.1uF 16V K
C337 NCB31CK-104X C CAPACITOR 0.1uF 16V K
C338 NCB31CK-104X C CAPACITOR 0.1uF 16V K
C339 NCB31CK-104X C CAPACITOR 0.1uF 16V K
C340 NCB31CK-104X C CAPACITOR 0.1uF 16V K
C341 NDC31HJ-270X C CAPACITOR 27pF 50V J
C342 NDC31HJ-270X C CAPACITOR 27pF 50V J
C343 NCB31CK-104X C CAPACITOR 0.1uF 16V K
C344 NCJ20JK-106X-R C CAPACITOR 10uF 6.3V K
C345 NCB31CK-104X C CAPACITOR 0.1uF 16V K
C346 NCB31CK-104X C CAPACITOR 0.1uF 16V K
C347 NCB31CK-104X C CAPACITOR 0.1uF 16V K
C351 NDC31HJ-270X C CAPACITOR 27pF 50V J
C352 NDC31HJ-270X C CAPACITOR 27pF 50V J
C373 NCB31CK-104X C CAPACITOR 0.1uF 16V K
C392 NCB31CK-104X C CAPACITOR 0.1uF 16V K
C393 NCB31CK-104X C CAPACITOR 0.1uF 16V K
C394 NCB31CK-104X C CAPACITOR 0.1uF 16V K
C395 NCB31CK-104X C CAPACITOR 0.1uF 16V K
C501 NEHN1EM-476X E CAPACITOR 47uF 25V M
C502 NCB31CK-104X C CAPACITOR 0.1uF 16V K
C503 NDC31HJ-680X C CAPACITOR 68pF 50V J
C511 NCB31HK-682X C CAPACITOR 6800pF 50V K
C512 NCB31HK-222X C CAPACITOR 2200pF 50V K
C513 NCB31HK-272X C CAPACITOR 2700pF 50V K
C514 NCB31HK-122X C CAPACITOR 1200pF 50V K
TRANSISTOR
TRANSISTOR
3-12
Page 51
Symbol No.
Part No. Part Name Description Local
Symbol No.
Part No. Part Name Description Local
C531 NEHL0JM-107X E CAPACITOR 100uF 6.3V M
C532 NCB31CK-104X C CAPACITOR 0.1uF 16V K
C551 NEHN1AM-107X E CAPACITOR 100uF 10V M
Ω
R101 NRSA63J-391X MG RESISTOR 390
R102 NRSA63J-822X MG RESISTOR 8.2k
R103 NRSA63J-184X MG RESISTOR 180k
R104 NRSA63J-184X MG RESISTOR 180k
R105 NRSA63J-183X MG RESISTOR 18k
R201 NRSA63J-391X MG RESISTOR 390
R203 NRSA63J-184X MG RESISTOR 180k
R204 NRSA63J-184X MG RESISTOR 180k
R205 NRSA63J-153X MG RESISTOR 15k
R206 NRSA63J-473X MG RESISTOR 47k
R207 NRSA63J-473X MG RESISTOR 47k
R214 NRSA63D-153X MG RESISTOR 15k
R215 NRSA63D-153X MG RESISTOR 15k
R216 NRS181F-300X MG RESISTOR 30
R217 NRS181F-300X MG RESISTOR 30
R228 NRSA63J-103X MG RESISTOR 10k
R229 NRSA63J-103X MG RESISTOR 10k
R230 NRSA63J-103X MG RESISTOR 10k
R241 NRSA63J-473X MG RESISTOR 47k
R242 NRSA63J-102X MG RESISTOR 1k
R301 NRSA63J-100X MG RESISTOR 10
R302 NRSA63J-473X MG RESISTOR 47k
R304 NRSA63J-100X MG RESISTOR 10
R307 NRSA63J-102X MG RESISTOR 1k
R308 NRSA63J-104X MG RESISTOR 100k
R309 NRSA63J-104X MG RESISTOR 100k
R310 NRSA63J-473X MG RESISTOR 47k
R311 NRSA63J-101X MG RESISTOR 100
R312 NRSA63J-101X MG RESISTOR 100
R313 NRSA63J-101X MG RESISTOR 100
R314 NRSA63J-272X MG RESISTOR 2.7k
R315 NRSA63J-821X MG RESISTOR 820
R316 NRSA63J-823X MG RESISTOR 82k
R317 NRSA63J-473X MG RESISTOR 47k
R318 NRSA63J-473X MG RESISTOR 47k
R319 NRSA63J-0R0X MG RESISTOR 0
R320 NRSA63J-0R0X MG RESISTOR 0
R321 NRSA63J-0R0X MG RESISTOR 0
R322 NRSA63J-822X MG RESISTOR 8.2k
R323 NRSA63J-822X MG RESISTOR 8.2k
R324 NRSA63J-473X MG RESISTOR 47k
R325 NRSA02F-100X MG RESISTOR 10
R326 NRSA02F-100X MG RESISTOR 10
R327 NRSA63J-101X MG RESISTOR 100
R328 NRSA63J-101X MG RESISTOR 100
R329 NRSA63J-101X MG RESISTOR 100
R330 NRSA63J-473X MG RESISTOR 47k
R331 NRSA63J-151X MG RESISTOR 150
R332 NRSA63J-105X MG RESISTOR 1M
R333 NRSA63J-221X MG RESISTOR 220
R334 NRSA63J-473X MG RESISTOR 47k
R336 NRSA63J-330X MG RESISTOR 33
R337 NRSA63J-473X MG RESISTOR 47k
R342 NRSA63J-0R0X MG RESISTOR 0
R343 NRSA63J-472X MG RESISTOR 4.7k
R345 NRSA63J-472X MG RESISTOR 4.7k
R349 NRSA63J-0R0X MG RESISTOR 0
R361 NRSA63J-103X MG RESISTOR 10k
R362 NRSA63J-221X MG RESISTOR 220
R371 NRSA63J-0R0X MG RESISTOR 0
R501 NRS125J-100X MG RESISTOR 10
R503 NRSA63J-822X MG RESISTOR 8.2k
R504 NRSA63J-512X MG RESISTOR 5.1k
R505 NRSA63J-333X MG RESISTOR 33k
R506 NRSA63J-683X MG RESISTOR 68k
R507 NRSA63J-682X MG RESISTOR 6.8k
R508 NRSA63J-153X MG RESISTOR 15k
R509 NRSA63J-183X MG RESISTOR 18k
R510 NRSA63J-683X MG RESISTOR 68k
R511 NRSA63J-103X MG RESISTOR 10k
R512 NRSA63J-153X MG RESISTOR 15k
R513 NRSA63J-822X MG RESISTOR 8.2k
R514 NRSA63J-133X MG RESISTOR 13k
R515 NRSA63J-562X MG RESISTOR 5.6k
1/16W J
Ω
1/16W J
Ω
Ω
Ω
1/16W J
Ω
1/16W J
Ω
Ω
Ω
1/16W J
Ω
1/16W J
Ω
1/16W J
Ω
1/16W D
Ω
1/16W D
Ω
1/8W F
Ω
1/8W F
Ω
1/16W J
Ω
1/16W J
Ω
1/16W J
Ω
1/16W J
Ω
1/16W J
Ω
1/16W J
Ω
1/16W J
Ω
1/16W J
Ω
1/16W J
Ω
Ω
Ω
1/16W J
Ω
1/16W J
Ω
1/16W J
Ω
1/16W J
Ω
1/16W J
Ω
1/16W J
Ω
1/16W J
Ω
1/16W J
Ω
1/16W J
Ω
1/16W J
Ω
1/16W J
Ω
1/16W J
Ω
1/16W J
Ω
1/16W J
Ω
1/16W J
Ω
1/10W F
Ω
1/10W F
Ω
1/16W J
Ω
1/16W J
Ω
1/16W J
Ω
1/16W J
Ω
1/16W J
Ω
1/16W J
Ω
1/16W J
Ω
1/16W J
Ω
1/16W J
Ω
1/16W J
Ω
1/16W J
Ω
1/16W J
Ω
1/16W J
Ω
1/16W J
Ω
1/16W J
Ω
1/16W J
Ω
1/16W J
Ω
1/2W J
Ω
1/16W J
Ω
1/16W J
Ω
1/16W J
Ω
1/16W J
Ω
1/16W J
Ω
1/16W J
Ω
1/16W J
Ω
1/16W J
Ω
1/16W J
Ω
1/16W J
Ω
1/16W J
Ω
1/16W J
Ω
1/16W J
1/16W J
1/16W J
1/16W J
1/16W J
1/16W J
1/16W J
R516 NRSA63J-562X MG RESISTOR 5.6kΩ 1/16W J
R519 NRSA63J-822X MG RESISTOR 8.2k
R520 NRSA63J-822X MG RESISTOR 8.2k
R521 NRSA63J-822X MG RESISTOR 8.2k
R522 NRSA63J-822X MG RESISTOR 8.2k
R523 NRSA63J-822X MG RESISTOR 8.2k
R524 NRSA63J-822X MG RESISTOR 8.2k
R525 NRSA63J-473X MG RESISTOR 47k
CN101 QGB2027L5-28X CONNECTOR B-B (1-28)
CN102 QGF0522F3-15W CONNECTOR FFC/FPC (1-15)
K101 NRSA63J-0R0X MG RESISTOR 0
K102 NRSA63J-0R0X MG RESISTOR 0
K103 NRSA63J-0R0X MG RESISTOR 0
SW1 NSW0291-001X DETECT SWITCH
X301 NAX0375-001X CRYSTAL 16.9344MHz
X302 NAX0367-001X CRYSTAL
Ω
Ω
Ω
Ω
Ω
Ω
Ω
1/16W J
Ω
1/16W J
Ω
1/16W J
Ω
1/16W J
1/16W J
1/16W J
1/16W J
1/16W J
1/16W J
1/16W J
3-13
Page 52
Packing materials and accessories parts list
No additional / supplemental order of WARRANTY CARDs are available.
Block No.
3
M
M
M
Only U ver.
P3
A1,A3,A4,A5
A6,A7
Only UN,UT,UH ver.
P3
A1,A4,A7
KIT : A8,A9,A10
A11,A12
P7
A15
A14
A20
A19
A16
A13
P5
P6
P2
Only U ver.
P8
Only E,EX,EY ver.
P3
A1,A3,A4,A5,A7
A17,A18
Only EU ver.
P3
A1,A3,A4,A5,A7
Only EE ver.
P3
A1,A4,A17,A18
P4
P2
A2
P1
The parts without symbol number are not service.
3-14
Page 53
Packing and Accessories
Block No. [M][3][M][M]
Symbol No. Part No. Part Name Description Local
A 1 GET0596-001A INST BOOK GER FRE ITA 701E
A 1 GET0596-003A INST BOOK ENG FRE 701EX,701EU
A 1 GET0596-006A INST BOOK ENG GER RUS GRE 701EY
A 1 GET0595-001A INST BOOK ENG THA 705U,705UH
A 1 GET0595-004A INST BOOK ENG INA 705UN
A 1 GET0595-005A INST BOOK ENG CHI(TAIWAN) 705UT
A 1 GET0597-001A INST BOOK ENG RUS UKR 707EE
A 2 GET0595-002A INST BOOK ARA KOR CHI(TAIWAN) PER 705U
A 3 GET0596-002A INST BOOK SPA POR 701E
A 3 GET0596-004A INST BOOK DUT DAN FIN SWE 701EX
A 3 GET0596-007A INST BOOK HUN CZE POL 701EY
A 3 GET0596-005A INST BOOK RUS SPA PER TUR 701EU
A 3 GET0595-003A INST BOOK RUS 705U
A 4 GET0596-008A INSTALL MANUAL GER FRE ITA 701E
A 4 GET0596-010A INSTALL MANUAL ENG FRE 701EX,701EU
A 4 GET0596-013A INSTALL MANUAL ENG GER RUS GRE 701EY
A 4 GET0595-006A INSTALL MANUAL ENG THA 705U,705UH
A 4 GET0595-009A INSTALL MANUAL ENG INA 705UN
A 4 GET0595-010A INSTALL MANUAL ENG CHI(TAIWAN) 705UT
A 4 GET0597-002A INSTALL MANUAL ENG RUS UKR 707EE
A 5 GET0596-009A INSTALL MANUAL SPA POR 701E
A 5 GET0596-011A INSTALL MANUAL DUT DAN FIN SWE 701EX
A 5 GET0596-014A INSTALL MANUAL HUN CZE POL 701EY
A 5 GET0596-012A INSTALL MANUAL RUS SPA PER TUR 701EU
A 5 GET0595-007A INSTALL MANUAL ARA KOR CHI(TAIWAN) PER 705U
A 6 GET0595-008A INSTALL MANUAL RUS 705U
A 7 LVT1672-002A INST SHEET 701E,701EX,701EY,701EU,705U,705UN,705UT,705UH
A 8 VKZ4027-202 PLUG NUT
A 9 GE40426-002A MOUNT BOLT
A 10 VKZ4328-003 LOCK NUT
A 11 QYWWS53A008ZA WASHER 0mm/5.3mm x
A 12 GE40130-002A HOOK (x2)
A 13 GE32320-001A HARD CASE ASSY
A 14 RM-RK50C REMOCON UNIT
A 15 ------------ LITHIUM BATTERY
A 16 QAM1150-001 POWER CORD 701E,701EX,701EY,701EU,707EE
A 16 QAM1146-001 16P CORD ASSY 705U,705UN,705UT,705UH
A 17 ------------ WARRANTY CARD BT-54038-1 701E,701EX,701EY,707EE
A 18 VND3046-001 SERIAL TICKET 701E,701EX,701EY,707EE
A 19 GE20137-003A MOUNTING SLEEVE
A 20 GE20218-012A TRIM PLATE 701E,701EX,701EY,701EU,707EE
A 20 GE20235-001A TRIM PLATE 705U,705UN,705UT,705UH
KIT SRW-MA372 SCREW PARTS KIT
P 1 GE33597-001A CARTON 701E,701EX,701EY,701EU
P 1 GE33594-001A CARTON 705U,705UN,705UT,705UH
P 1 GE33600-001A CARTON 707EE
P 2 GE10260-001A EPS CUSHION 701E,701EX,701EY,701EU,707EE
P 2 GE10259-001A EPS CUSHION 705U,705UN,705UT,705UH
P 3 FSPG4002-001 POLY BAG
P 4 QPC03004315PB POLY BAG 30cm x 43cm
P 5 QPA01003003 POLY BAG 10cm x 30cm
P 6 GE40467-002A NON WOVEN SHEET
P 7 QPA00801205 POLY BAG 8cm x 12cm
P 8 FSPG4002-001 POLY BAG 705U
3-15
Loading...