Page 1
Electrical Wiring Diagrams
XF
(1a) VIN: S20753 >
Page 2
Page 3
BY APPOINTMENT TO
HER MAJESTY QUEEN ELIZABETH II
MANUFACTURERS OF DAIMLER AND JAGUAR CARS
JAGUAR CARS LIMITED COVENTRY
BY APPOINTMENT TO
HIS ROYAL HIGHNESS THE PRINCE OF WALES
MANUFACTURERS OF DAIMLER AND JAGUAR CARS
JAGUAR CARS LIMITED COVENTRY
Electrical Wiring Diagrams
XF
(1a) VIN: S20753 >
Published by Technical Communications, Jaguar Cars Limited
Publication Part No. JLR 16 04 21_1E
Page 4
PREFACE
PREFACE
While every effort is made to ensure accuracy, design changes to the vehicle may be made in the period between the completion
of this publication and the introduction of vehicles.
All rights reserved. No part of this publication may be reproduced, stored in a retrieval system or transmitted in any form, electronic,
mechanical, recording or other means without prior written permission from Jaguar Cars Limited.
Paper copies of this document are uncontrolled, always refer to the electronic source material fo r the latest information.
© 2011 Jaguar Cars Limited
07/2011
Page 5
ABBREVIATIONS
........................................................................................................................................................................................................ xi
USING THIS PUBLICATION
Health and safety................................ .. ... ..................................... .. ............................................................................................... xii
Using this publication........................................ .................................... ... ...................................................................................... xii
Section numbering................................................................................................................................ ........................................ xiii
Understanding the circuit diagrams .............................................................................................................................................. xiii
204-04 - WHEELS AND TIRES
Tire pressure monitoring system ................................................................................................................................................... 1
205-02 - REAR DRIVE AXLE AND DIFFERENTIAL
....................................................................................................................................................................................................... 2
206-05 - PARKING BRAKE AND ACTUATION
....................................................................................................................................................................................................... 3
206-09 - ANTI-LOCK CONTROL
....................................................................................................................................................................................................... 4
....................................................................................................................................................................................................... 5
211-04 - STEERING COLUMN
Steering wheel ................................................................................................ ... ............................................................................ 6
Steering Column Adjustment ......................................................................................................................................................... 7
303-03 - ENGINE COOLING
PV8 (5.0L) ........................................................................... ........................................................................................................... 8
DV6 ................................................................................................................................................................................................ 9
D4 ................................................................................................................................................................................................ 10
303-06 - STARTING SYSTEM
PV8 (5.0L) ........................................................................... ........................................................... ... ........................................... 11
D4 ................................................................................................................................................................................................ 12
D4 ................................................................................................................................................................................................ 13
303-14E - ELECTRONIC ENGINE CONTROLS - PV8 (5.0L)
Vehicle interface - Part 1 ............................................................................................................... .................................. ... ......... 14
Actuators - Part 1 ................................................................................................................... ............................... .. ..................... 15
Actuators - Part 2 ................................................................................................................... ............................... .. ..................... 16
Actuators - Part 3 ................................................................................................................... ............................... .. ..................... 17
Actuators - Part 4 ................................................................................................................... ............................... .. ..................... 18
Sensors - Part 1 ................................................................................................................................ .................................. .. ....... 19
Sensors - Part 2 ................................................................................................................................ .................................. .. ....... 20
Sensors - Part 3 ................................................................................................................................ .................................. .. ....... 21
Sensors - Part 4 ................................................................................................................................ .................................. .. ....... 22
Sensors - Part 5 ................................................................................................................................ .................................. .. ....... 23
Emissions - Part 1 .................................................................................................................................. .................................. ... . 24
Emissions - Part 2 .................................................................................................................................. .................................. ... . 25
Coolant pump - PV8SC .................................................................................................................... .................................. .. ....... 26
303-14B - ELECTRONIC ENGINE CONTROLS - DV6 (3.0L)
Vehicle interface - Part 1 ............................................................................................................... .................................. ... ......... 27
Vehicle interface - Part 2 ............................................................................................................... .................................. ... ......... 28
Vehicle interface - Part 3 ............................................................................................................... .................................. ... ......... 29
Sensors - Part 1 ................................................................................................................................ .................................. .. ....... 30
Sensors - Part 2 ................................................................................................................................ .................................. .. ....... 31
Sensors - Part 3 ................................................................................................................................ .................................. .. ....... 32
Sensors - Part 4 ................................................................................................................................ .................................. .. ....... 33
Actuators - Part 1 ................................................................................................................... ............................... .. ..................... 34
Actuators - Part 2 ................................................................................................................... ............................... .. ..................... 35
Actuators - Part 3 ................................................................................................................... ............................... .. ..................... 36
Actuators - Part 4 ................................................................................................................... ............................... .. ..................... 37
Emissions - Part 1 .................................................................................................................................. .................................. ... . 38
Emissions - Part 2 .................................................................................................................................. .................................. ... . 39
07/2011 v
Page 6
303-14A - ELECTRONIC ENGINE CONTROLS - D4
Vehicle interface - Part 1 .............................................................................................................................................................. 40
Vehicle interface - Part 2 .............................................................................................................................................................. 41
Vehicle interface - Part 3 .............................................................................................................................................................. 42
Vehicle interface - Part 4 .............................................................................................................................................................. 43
Actuators - Part 1 ......................................................................................................................................................................... 44
Actuators - Part 2 ......................................................................................................................................................................... 45
Actuators - Part 3 ......................................................................................................................................................................... 46
Sensors - Part 1 ................................... ..................................... .. ................................................................................................. 47
Sensors - Part 2 ................................... ..................................... .. ................................................................................................. 48
Sensors - Part 3 ................................... ..................................... .. ................................................................................................. 49
Emissions ..................................................................................................................................................................................... 50
307-01 - AUTOMATIC TRANSMISSION
PV8 (5.0L) .................................................................................................................................................................................... 51
DV6 - 6 speed .............................................................................................................................................................................. 52
DV6 - 8 speed .............................................................................................................................................................................. 53
D4 ................................................................................................................................................................................................. 54
310-01 - FUEL TANK AND FUEL LINES
Petrol - PV8 5.0L .......................................................................................................................................................................... 55
DV6 .............................................................................................................................................................................................. 56
D4 ................................................................................................................................................................................................. 57
310-03 - SPEED CONTROL
Petrol - PV8 5.0L .......................................................................................................................................................................... 58
Adaptive ....................................................................................................................................................................................... 59
DV6 .............................................................................................................................................................................................. 60
D4 ................................................................................................................................................................................................. 61
412-01 - CLIMATE CONTROL
Part 1 ............................................................................................................................................................................................ 62
Part 2 ............................................................................................................................................................................................ 63
Part 3 ............................................................................................................................................................................................ 64
Part 4 ............................................................................................................................................................................................ 65
412-02 - AUXILIARY CLIMATE CONTROL
Heated - front ............................................................................................................................................................................... 66
Heated - rear ................................................................................................................................................................................ 67
413-01 - INSTRUMENT CLUSTER
Part 1 ............................................................................................................................................................................................ 68
Part 2 ............................................................................................................................................................................................ 69
Part 3 ............................................................................................................................................................................................ 70
Part 4 ............................................................................................................................................................................................ 71
413-13 - PARKING AID
Front ............................................................................................................................................................................................. 72
Rear ............................................................................................................................................................................................. 73
Rear view camera ................................... .................................... ... .............................................................................................. 74
414-01 - BATTERY, MOUNTING AND CABLES
Battery cables - Petrol (PV8 5.0L) ................................................................................................................................................ 75
Battery cables - DV6 .................................. ... .................................... ... ........................................................................................ 76
Battery cables - D4 ....................................................................................................................................................................... 77
Engine junction box - Common 1 ................................................................................................................................................. 78
Engine junction box - Common 2 ................................................................................................................................................. 79
Engine junction box - PV8 EMS (5.0L) ......................................................................................................................................... 80
Engine junction box - Petrol Emissions ........................................................................................................................................ 81
Engine junction box - DV6 EMS ................................................................................................................................................... 82
Engine junction box - D4 .............................................................................................................................................................. 83
Engine junction box - Visibility ...................................................................................................................................................... 84
Central junction box ..................................................................................................................................................................... 85
Rear junction box .............................. ..................................... ... .................................... ............................................................... 96
Ground distribution - Petrol EMS ............................................................................................................................................... 104
Ground distribution - Diesel EMS ............................................................................................................................................... 105
Ground distribution ..................................................................................................................................................................... 106
vi 07/2011
Page 7
414-02 - GENERATOR AND REGULATOR
Charging - PV8 5.0L .................................................................................................................................................................. 116
Charging - DV6 .......................................................................................................................................................................... 117
Charging - D4 ............................................................................................................................................................................ 118
415-00 - INFORMATION AND ENTERTAINMENT SYSTEM
Part 1 ......................................................................................................................................................................................... 119
Part 2 ......................................................................................................................................................................................... 120
Part 3 ......................................................................................................................................................................................... 121
10-Speaker system (LHD) ......................................................................................................................................................... 122
10-Speaker system (RHD) ......................................................................................................................................................... 123
12-Speaker system (LHD) ......................................................................................................................................................... 124
12-Speaker system (RHD) ......................................................................................................................................................... 125
15-Speaker system (LHD) ......................................................................................................................................................... 126
15-Speaker system (RHD) ......................................................................................................................................................... 127
SDARS or DAB ....................................... ... .................................... ............................................................................................ 128
Television ................................................................................................................................................................................... 129
417-01 - EXTERIOR LIGHTING
Headlamps ................................................................................................................................................................................. 130
Headlamps - high intensity discharge ........................................................................................................................................ 131
Side lamps ................................................................................................................................................................................. 132
Brake and reverse lamps ........................................................................................................................................................... 133
Turn signal indicators and hazard flashers ................................................................................................................................ 134
Turn signal repeaters ..................................................................... ... ......................................................................................... 135
Fog lamps ........................................................ .. ..................................... ................................................................................... 136
417-02 - INTERIOR LIGHTING
Map and Courtesy ..................................................................................................................................................................... 137
Doors and Luggage compartment ............................................................................................................................................. 138
Ambient lighting ......................................................................................................................................................................... 139
Switch Illumination ..................................................................................................................................................................... 140
Tread plate illumination .............................................................................................................................................................. 141
418-00 - MODULE COMMUNICATIONS NETWORK
CAN bus - High speed - Part 1 .................................................................................................................................................. 142
CAN bus - High speed - Part 2 .................................................................................................................................................. 143
CAN bus - High speed - Part 3 .................................................................................................................................................. 144
CAN bus - High speed - Part 4 .................................................................................................................................................. 145
CAN bus - High speed - Part 5 .................................................................................................................................................. 146
CAN bus - High speed - Part 6 .................................................................................................................................................. 147
CAN bus - Medium speed - Part 1 (Common) ........................................................................................................................... 148
CAN bus - Medium speed - Part 2 (LHD) .................................................................................................................................. 149
CAN bus - Medium speed - Part 3 (LHD) .................................................................................................................................. 150
CAN bus - Medium speed - Part 4 (LHD) .................................................................................................................................. 151
CAN bus - Medium speed - Part 5 (LHD) .................................................................................................................................. 152
CAN bus - Medium speed - Part 2 (RHD) .................................................................................................................................. 153
CAN bus - Medium speed - Part 3 (RHD) .................................................................................................................................. 154
CAN bus - Medium speed - Part 4 (RHD) .................................................................................................................................. 155
CAN bus - Medium speed - Part 5 (RHD) .................................................................................................................................. 156
MOST ........................................................................................................................................................................................ 157
419-01 - ANTI-THEFT SYSTEM
Part 1 ......................................................................................................................................................................................... 158
Part 2 ......................................................................................................................................................................................... 159
Part 3 ......................................................................................................................................................................................... 160
Passive ...................................................................................................................................................................................... 161
419-07 - NAVIGATION SYSTEM
Asia ............................................................................................................................................................................................ 162
Japan ......................................................................................................................................................................................... 163
419-15 - ELECTRONIC FEATURES MODULES
Glove compartment release ....................................................................................................................................................... 164
07/2011 vii
Page 8
501-09 - REAR VIEW MIRRORS
Mirror Movement ........................................................................................................................................................................ 165
Electrochromic ........................................................................................................................................................................... 166
Blind spot monitoring (LHD) ....................................................................................................................................................... 167
Blind spot monitoring (RHD) ...................................................................................................................................................... 168
501-10 - SEATING
Driver seat - Non-memory (LHD) ............................................................................................................................................... 169
Driver seat - Non-memory (RHD) ............................................................................................................................................... 170
Driver seat - 2 way lumbar, without head restraint (LHD) .......................................................................................................... 171
Driver seat - 2 way lumbar, without head restraint (RHD) .......................................................................................................... 172
Driver seat - 4 way lumbar, without head restraint (LHD) .......................................................................................................... 173
Driver seat - 4 way lumbar, without head restraint (RHD) .......................................................................................................... 174
Driver seat - With head restraint (LHD) ...................................................................................................................................... 175
Driver seat - With head restraint (RHD) ..................................................................................................................................... 176
Driver seat - Bolsters (with head restraint) ................................................................................................................................. 177
Passenger seat - Non-memory (USA only) ................................................................................................................................ 178
Passenger seat - Lumbar and bolsters (USA only) .................................................................................................................... 179
Passenger seat - Non-memory (LHD) ........................................................................................................................................ 180
Passenger seat - Non-memory (RHD) ....................................................................................................................................... 181
Passenger seat - With head restraint (LHD) .............................................................................................................................. 182
Passenger seat - With head restraint (RHD) .............................................................................................................................. 183
Passenger seat - Bolsters (with head restraint) ......................................................................................................................... 184
Heated - front ............................................................................................................................................................................. 185
Climate controlled - Front (LHD) ................................................................................................................................................ 186
Climate controlled - Front (RHD) ................................................................................................................................................ 187
501-11 - GLASS, FRAMES AND MECHANISMS
Window lift - front ....................................................................................................................................................................... 188
Window lift - rear ........................................................................................................................................................................ 189
501-12 - INSTRUMENT PANEL AND CONSOLE
Accessory socket(s) ................................................................................................................................................................... 190
501-14 - HANDLES, LOCKS, LATCHES AND ENTRY SYSTEMS
Keyless entry - Front (LHD) ....................................................................................................................................................... 191
Keyless entry - Front (RHD) ....................................................................................................................................................... 192
Keyless entry - Antennae ........................................................................................................................................................... 193
Front power locks ................................. ..................................... .. ............................................................................................... 194
Front dead locks ......................................................................................................................................................................... 195
Keyless entry - Rear ........................................... ..................................... .. ................................................................................. 196
Rear power locks ........................................................ .................................... ... ........................................................................ 197
Rear dead locks ........................... ... .................................... ... .................................... ................................................................ 198
Luggage compartment and fuel flap ........................................................................................................................................... 199
501-16 - WIPERS AND WASHERS
................................................................................................................................................................................................... 200
501-17 - ROOF OPENING PANEL
Roof opening panel and sun blind .............................................................................................................................................. 201
501-20A - SAFETY BELT SYSTEM
................................................................................................................................................................................................... 202
Sensors ...................................................................................................................................................................................... 203
501-20B - SUPPLEMENTAL RESTRAINT SYSTEM
LHD ............................................................................................................................................................................................ 204
RHD ........................................................................................................................................................................................... 205
Passenger air bag deactivation .................................................................................................................................................. 206
501-20C - PEDESTRIAN PROTECTION SYSTEM
................................................................................................................................................................................................... 207
viii 07/2011
Page 9
ABBREVIATIONS
Abbreviation Description
ABS Anti-lock braking system
ADRC Adaptive damping
AFS Adaptive front lighting system
AMP Audio amplifier
AUTO Automatic transmission
AUU Portable audio interface
BSM Blind spot monitoring
CAN Controller area network
CVD Continuously variable damping
DAB Digital audio broadcasting
DSC Dynamic stability control
D4 Diesel engine - Straight-four
DPF Diesel particulate filter
DV6 Diesel engine - V6
DV8 Diesel engine - V8
EGR Exhaust gas recirculation
EMS Engine management system
ETS Electronic transmission shift
FET Field effect transistor
GPS Global positioning system
HID High intensity discharge
HS CAN High speed controller area network bus
IC Instrument cluster
IMT Intake manifold tuning
IP Instrument panel
PV6 Petrol engine - V6
PV8 Petrol engine - V8
PV8NA Naturally aspirated engine - V8
PV8SC Super charged engine - V8
LH Left-hand
LIN Local interconnect network
MAF/IAT Mass air flow / intake air temperature
MS CAN Medium speed controller area network bus
MMM Navigation system module
N/A Normally aspirated
NAS North American specification
PDC Park distance control
RF Radio frequency
RH Right-hand
SAI Secondary air injection
SCL Steering column locking
SDARS Satellite digital audio receiver system
TPMS Tire pressure monitoring system
TSD Touch screen display
TV Television
ULEV Ultra low emission vehicle
USB Universal serial bus
VICS Vehicle information control system
ABBREVIATIONS
07/2011 ix
Page 10
USING THIS PUBLICATION
USING THIS PUBLICATION
Health and safety
Always follow health and safety guidelines, speci fically those detailed in the Workshop Manual.
Using this publication
The information provided in this publication is for use only by competent, qualified auto-electricians. Good product knowledg e is
assumed, as well as the ability to access and use recommended test equipment and other reference material prov ided.
Test equipment and other reference material
The information in this publication should be used in conjunction with the recommended test equipment; refer to Workshop Manual.
Other reference material includes: Technical Service Bulletins (TSB) and the Workshop Manual.
The Electrical Reference Library (ERL) may also prove useful since it provides detailed connector information.
Battery disconnection and reconnecti on
It is imperative that any information relating to battery disconnection and reconnection is followed; refer to the appropriate sections
in the Workshop Manual.
Fault Diagnosis
Always use the recommended test equipment for correct and reliable fault diagnosis, refer to the Workshop Manual.
Harness Repair
Repairs should only be undertaken for connectors where a Service Repair Kit is available; refer to the appropriate Electrical
Reference Library (ERL).
Note: Fibre Optic circuits cannot be repaired; refer to the Workshop Manual.
Engine Harness In-line Connector Designations
It has been necessary to draw certain wiring diagrams to support and permit the sharing of common electrical harnesses, as a
result the in-line connectors linking the engine compartment harness and the engine harness appear on separate pages.
In addition, it should be noted that the connector designations may not match; where this is the case, the matching connector
designations are identified at the bottom right-hand side of the drawing, for example C11-P = C11-A. An arrow or a diamond is
used to highlight the connectors that are affected by this convention.
BU-GY
1
YE-GN
1
YE-GN
1
EN_SU
EN_SU
EN_SU
C11-P/10
C11-P/40
C11-P/15
Refer to sensors
C11-P = C11-A
C11-N = C11-B
C11-M = C11-C
x 07/2011
Page 11
USING THIS PUBLICATION
e
Section numbering
The sections in this publication are ordered to match the Global Outline numbering system as found in the current Workshop
Manual. The Power and Ground distribution circuits can be found under section 414-01, BATTERY, MOUNTING AND CABLES.
Note: Where circuit diagrams show more than one sub-system, the circuit will be located in the section that carries the
first-named sub-system, for example: Starting and Charging will be located under section 303-06 Starting System, since 'Starting'
is the first-named sub-system.
Understanding the circuit diagrams
OP
LH_SEAT_BACK_TED+
LH_SEAT_BACK_TED-
LH_SEAT_BACK_SENSOR
LH_SEAT_BACK_SENSOR_RTN
LH_FANS_PWR
LH_SEAT_BACK_FAN_SPEED
C3HS03A/9 C33-D/21
OP
C3HS03A/10 C33-D/20
IP
C3HS03B/9 C33-D/10
IP
C3HS03B/10 C33-D/9
OP
C3HS03C/16
OP
C3HS03C/12 C33-D/6
Connectors, Ground and Splices
Harnesses for the vehicle originate from a variety of different sources and therefore the connector nomenclature is inconsistent.
GY-VT
WH-VT
VT-OG
GY-BN
GN-BN
BU-GN
DR_B*BY1AD
DR_B*BY1AD
DR_B*BY1AD
DR_B*BY1AD
DR_B*BY1AD
DR_B*BY1AD
C33-D/4
GN-BN
BY1AD
SPL499
Wire Length
Wire length (where stated) is in millimeters and appear directly below the color code for each wire. Wire length values are displayed
for LHD vehicles only, values for RHD vehicles may vary.
Twisted Wires
The 'figure-of-eight' symbol indicates that wires are twisted together.
By-pass Wires
Vehicles are customized to suit market or customer selected options. To reduce the number of circuits drawn, by-pass wires are
shown. By-pass wires are identified by large, upper case letters designed to correspond with the alternative connection
arrangement; refer to figure below.
A
VT-OG
C-
C+
SPL607
C3HS03C/2
C3HS03C/1
1
GY-OG
1
VT-OG
1
GY-OG
1
SPL606
Module-climate-controlled
Seat
MS_CAN_NEG
MS_CAN_POS
DR_B*BY1AD
DR_B*BY1AD
DR_B*BY1AD
DR_B*BY1AD
BC
SPL608
SPL609
VT-OG
1
GY-OG
1
DR_B*BY1AD*D19AB
DR_B*BY1AD*D19AB
SPL610
SPL611
VT-OG
1
GY-OG
1
DR_B*D19AB
DR_B*D19AB
C3MC39B/11
C3MC39B/10
Module-tire pressur
Monitoring system
MS_CAN_POS
MS_CAN_NEG
A
SPL606
SPL607
VT-OG
1
GY-OG
1
DR_B*BY1AA*D19AB
DR_B*BY1AA*D19AB
SPL610
SPL611
C
07/2011 xi
Page 12
USING THIS PUBLICATION
Connector Designation
Certain connectors have been drawn for harness manufacturing purposes only. In Example 1, the left-hand connector is always
used, the connector drawn to the right-hand side of the dotted line is a dummy connector which should be ignored; refer to Service
Interpretation 1.
Example 1:
C23-M/1
C23-M/2 C23-P/2
Ignore connector
(drawn for harness
manufacturing purposes)
C23-P/1
Example 2 depicts that some pairs of connectors have also been drawn for harness manufacturing purposes, these connectors
do not appear in the vehicle and therefore should be ignored; refer to Service Interpretation 2.
Example 2:
YE-BL
C44-M/## C44-N/##
Ignore both connectors
(drawn for harness
manufacturing purposes)
YE-BL YE-BL
Control Module Pins
B+ Battery voltage
C– CAN negative
C+ CAN positive
DData
GND Ground
GREF Sensor / signal ground **
IP Input signal
LIN Local interconnect network
MOST_RX MOST receive
MOST_TX MOST transmit
NEG Negative
OP Output signal
P Power ground
POS Positive
PWR Power
SW Switch
VBATT Battery voltage
VREF Sensor / signal supply V *
Service Interpretation 1:
C23-M/1
C23-M/2
Service Interpretation 2:
*May also indicate Reference Voltage.
**May also indicate Reference Ground or Logic Ground.
Wire Codes
CODE COLOR
BK or B BLACK
BN or N BROWN
BU or U BLUE
GN or G GREEN
GY or S GREY
OG or O ORANGE
OPT FIBER OPTIC
PK or K PINK
RD or R RED
SCR SCREEN BRAID
VT or P PURPLE
WH or W WHITE
YE or Y YELLOW
xii 07/2011
Page 13
USING THIS PUBLICATION
Option Code
A code identifying an optional wiring arrangement, for example BY1AD, may be allocated to certain wires; refer to the Option Code
Table.
The asterisk (*) represents ‘and’; the colon (:) represents ‘or’; for example:
DR_B*BY1AD, represents: left-hand drive AND heated & cooled seats
IBYAD*IESAB:IBYAC*IESAB, represents: satellite digital audio AND television OR digital audio AND television.
OP
LH_SEAT_BACK_TED+
LH_SEAT_BACK_TED-
LH_SEAT_BACK_SENSOR
LH_SEAT_BACK_SENSOR_RTN
LH_FANS_PWR
LH_SEAT_BACK_FAN_SPEED
C3HS03A/9 C33-D/21
OP
C3HS03A/10 C33-D/20
IP
C3HS03B/9 C33-D/10
IP
C3HS03B/10 C33-D/9
OP
C3HS03C/16
OP
C3HS03C/12 C33-D/6
Option Code Table
Cct Vehicle Option or Feature
2W_LUM 2way lumbar
A2CAA without secondary air injection
A2CAB secondary air injection
A2CAC secondary air injection map sensor
A2EAA without USB
A2EAB USB
A3RAA without deployable bonnet
A3RAB deployable bonnet
ADJ_BOL adjustable bolster
B3MAB heated front screen
BDAAD power rear sunblind
BPW brake pad wear
BSBAF electrochromic interior mirror
BSHDF fold back mirrors
BY1AA without heated seats
BY1AC heated seats
BY1AD heated & cooled seats
BYPAM 10way drivers seat movement
BYPAN 16way drivers seat movement
BYQAH 12way passengers seat movement
BYRAA without programmable drivers seat
BYRAB programmable drivers seat
CBAAB power door locks
CBAAD power dead locks
CBGAG keyless entry
CBGAJ without keyless entry
CFKAB headlamp washer
CHAAL power tilt/slide sunroof
CP5AB beltminder
CP5AC occupancy sensing
D19AA without TPMS
D19AB TPMS
DR_B LHD
DR_D RHD
DWMAA without ADRC
DWMAB ADRC
DWMAC Continuously variable damping
07/2011 xiii
GY-VT
WH-VT
VT-OG
GY-BN
GN-BN
BU-GN
DR_B*BY1AD
DR_B*BY1AD
DR_B*BY1AD
DR_B*BY1AD
DR_B*BY1AD
DR_B*BY1AD
C33-D/4
GN-BN
BY1AD
SPL499
Page 14
USING THIS PUBLICATION
Cct Vehicle Option or Feature
EGJAE without electronic differential
EGJAL electronic differential
EM_N ULEV 2 requirements
EN_A5 2.7L diesel engine
EN_AJ 4.2L PV8NA engine
EN_AK 4.2L PV8SC engine
EN_RX 5.0L PV8NA engine
EN_RY 5.0L PV8SC engine
EN_SU 3.0 DV6 engine
EN_WD 3.0 PV6 engine
G1DAA without smog sensor
G1DAB smog sensor
GRBAA without steering column lock
GRBAB steering column lock
GTBAA without heated steering wheel
GTBAB heated steering wheel
GTDAB speed control
GTDAD adaptive stop/go speed control
HKCAA without navigation
HKCAB navigation
HKCAD traffic master
HKCAF VICS
HLLAA without blindspot monitoring
HLLAC blindspot monitoring
HNHAB battery backed security siren
HNHAC passive sounder
HNLAB front parking aid
IBUAB bluetooth phone
IBYAB analog audio
IBYAC digital audio
IBYAD satellite digital audio
IBYAH IBOC
IDAAA standard ice
IDAAB premium ice
IDAAR hi line ice
IESAA without television
IESAB television
IF9AB voice activated controls
J3GAA without electronic road pricing
J3GAB electronic road pricing
J3KAA without park aid camera
J3KAB park aid camera
JBBAB halogen headlamps
JBBAC hid headlamps
JEAAC automatic headlamp leveling
NO_EN_AK without 4.2L SC engine
NO_HD without IBOC
NO_OCS without occupant classification system
NO_SAIMAP without secondary air injection map sensor
NO_TMC without TMC
NO_VICS without VICS
xiv 07/2011
Page 15
Component Depictions
Example:
USING THIS PUBLICATION
1.
1. Complete Components and Control Modules
2. Incomplete Components
3. Components with Internal Electronic Components
2.
3.
07/2011 xv
Page 16
Page 17
204-04 - WHEELS AND TIRES Tire pressure monitoring system
204-04 - WHEELS AND TIRESTire pressure monitoring system
phcr83-70267-a-a4
Junction box-rear
VBATT
DATA
GND
F32
5A MINI
C3MC45/3
C3MC45/2
B+
B+
Receiver-tirePressure monitoring
Junction box-central
B+
B+
TPMS_VBATT
VT-RD
2554
BK
182
IGN_SUPPLY_1_CABIN
D19AB
D19AB
OP
C+
MS_CAN_IN_POS
C-
MS_CAN_IN_NEG
MS_CAN_OUT_POS
MS_CAN_OUT_NEG
C+
C-
SYSTEM_GND
B+
P
G3D182B/1
MS CAN BUS
MS CAN BUS
C3BP01C/7
VT-RD
87
BN-YE
2931
BK
1
D19AB
SPL66
SPL51
VT-RD
99
YE
2653
BN-YE
50
G3D138/1
D19AB
D19AB
D19AB
C3MC39B/16C4BP01D/10
C3MC39B/4C3MC45/1
C3MC39B/8C3BP01D/14
MS CAN BUS
Module-tire pressure
Monitoring system
VBATT
EXT_RF_RX
VIGN
MS_CAN_POS
MS_CAN_NEG
LH_FRONT_INITIATOR_PWR
LH_FRONT_INITIATOR_RTN
RH_FRONT_INITIATOR_PWR
RH_FRONT_INITIATOR_RTN
LH_REAR_INITIATOR_PWR
LH_REAR_INITIATOR_RTN
RH_REAR_INITIATOR_PWR
RH_REAR_INITIATOR_RTN
C3MC39A/13 C1MC40/1
C3MC39A/14 C1MC40/2
C3MC39A/15 C1MC41/1
C3MC39A/16 C1MC41/2
C3MC39A/5 C4MC42/1
C3MC39A/6 C4MC42/2
C3MC39B/12
GND
VT-BN
4632
YE
4632
BU-BN
3033
BN-WH
3033
BN-YE
2967
BU-OG
2967
BN-GN
2095
GY-VT
2095
BK
304
D19AB
D19AB
D19AB
D19AB
D19AB
D19AB
D19AB
D19AB
D19AB
C13-B/1
C13-B/2
C13-B/6
C13-B/5
C44-W/1
C44-W/2
C44-Y/1
C44-Y/2
VT-BN
456
YE
456
BU-BN
464
BN-WH
464
BN-YE
1
BU-OG
1
BN-GN
1
GY-VT
1
G3D183B/1
D19AB
D19AB
D19AB
D19AB
D19AB
D19AB
D19AB
D19AB
C4MC43/1C3MC39A/7
C4MC43/2C3MC39A/8
Initiator-front-lh
PWR
RTN
M282
Initiator-front-rh
PWR
RTN
Initiator-rear-lh
PWR
RTN
Initiator-rear-rh
PWR
RTN
Sensor-tireFront-lh
Sensor-tireFront-rh
Sensor-tireRear-lh
Sensor-tireRear-rh
XF - S20753 > (1a) 1
x
Page 18
205-02 - REAR DRIVE AXLE AND DIFFERENTIAL
205-02 - REAR DRIVE AXLE AND DIFFERENTIAL
phcr83-70046-a-a4
C44-M/## C44-N/##
Ignore both connectors
(drawn for harness
Manufacturing purposes)
Junction box-central
B+
B+
Junction box-rear
B+
B+
F9
40A
A1-S
IGN_SUPPLY_2_EDIFF
MS_CAN_IN_POS
MS_CAN_IN_NEG
MS_CAN_OUT_POS
MS_CAN_OUT_NEG
OP
C+
C-
C+
C-
SYSTEM_GND
B+
EDIFF_PWR
C3BP01D/10
P
C3BP01C/7
C4BP01C/2
MS CAN BUS
MS CAN BUS
RD
1
BK
1
GN-VT
1
EGJAL
EGJAL
SPL850
G3D138/1
RD
1
RD
1
RD
1
EGJAL
EGJAL
EGJAL
C4ET63B/4
HS CAN BUS
C4ET63B/5
C4ET63B/7
C4ET63B/8
Rear differential
Control module
HALL_SENSOR_7V
B+
IGN
HALL_SENSOR_SIG_A
HALL_SENSOR_SIG_B
HALL_SENSOR_GND
BRAKE_ACT_SOLENOID_+
BRAKE_ACT_SOLENOID_-
C
CAN_IN_POS
C
CAN_IN_NEG
B+
VBATT1
B+
VBATT2
B+
VBATT3
TEMP_1+
TEMP_1-
MOTOR_POS
MOTOR_NEG
TEMP_2+
TEMP_2-
VREF
GREF
OP
OP
OP
OP
OP
OP
GND1
GND2
GND3
IP
IP
IP
IP
P
P
P
C4ET63A/1
C4ET63A/4
C4ET63A/7
C4ET63A/10
C4ET63A/18
C4ET63A/17
C4ET63A/13
C4ET63A/16
C4ET63A/3
C4ET63A/12
C4ET63A/8
C4ET63A/11
C4ET63B/3
C4ET63B/6
C4ET63B/9
BU-WH
1
BU-BN
1
GY
1
GN-WH
1
WH-VT
1
BU-GN
1
VT-BN
1
YE-BU
1
VT-OG
1
YE-GN
1
GN
1
GY-YE
1
BK
275
BK
275
BK
275
EGJAL
EGJAL
EGJAL
EGJAL
EGJAL
EGJAL
EGJAL
EGJAL
EGJAL
EGJAL
EGJAL
EGJAL
EGJAL
EGJAL
EGJAL
SPL851
C44-M/4 C44-N/4
C44-N/84C44-M/84
C44-N/85C44-M/85
C44-M/86 C44-N/86
C44-M/87 C44-N/87
C44-N/88C44-M/88
C44-N/89C44-M/89
C44-M/90 C44-N/90
C44-N/91C44-M/91
C44-M/92 C44-N/92
C44-M/93 C44-N/93
C44-N/94C44-M/94
BK
275
EGJAL
BU-WH
1
BU-BN
1
GY
1
GN-WH
1
WH-VT
1
BU-GN
1
VT-BN
1
YE-BU
1
VT-OG
1
YE-GN
1
GN
1
GY-YE
1
C44-N/95C44-M/95
EGJAL
EGJAL
EGJAL
EGJAL
EGJAL
EGJAL
EGJAL
EGJAL
EGJAL
EGJAL
EGJAL
EGJAL
BK
1
C4ET64A/5
C4ET64A/7
C4ET64A/8
C4ET64A/6
C4ET64A/12
C4ET64A/11
C4ET64A/1
C4ET64A/2
C4ET64A/4
C4ET64A/9
C4ET64A/3
C4ET64A/10
EGJAL
0.50GN
0.50YE
0.50OG
0.50BN
1.00RD
1.00GN
0.50WH
0.50BU
2.50RD-BU
2.50BN-WH
0.50YE
0.50RD
G4D173/1
C4ET66A/1
C4ET66A/2
Actuator-rear differential
HALL_SENSOR_PWR
HALL_SIGNAL_A
HALL_SIGNAL_B
HALL_SENSOR_RTN
SOLENOID_POS
SOLENOID_NEG
MOTOR_TEMP_POS
MOTOR_TEMP_NEG
MOTOR_POS
MOTOR_NEG
Sensor-temperatureDifferential oil
POS
NEG
MOTOR
POSITION
SENSORS
ACTUATOR
BRAKE
SOLENOID
MOTOR
TEMPERATURE
SENSOR
CLUTCH
ACTUATION
MOTOR
M
XF - S20753 > (1a) 2
x
Page 19
206-05 - PARKING BRAKE AND ACTUATION
206-05 - PARKING BRAKE AND ACTUATION
phcr83-70167-a-a4
Junction box-central
B+
B+
F21
5A MINI
F34
5A MINI
Junction box-rear
F3
30A A1-S
B+
B+
FOOTBRAKE_SW_SUPPLY
EPB_LOGIC_PWR
IGN_SUPPLY_2_CABIN
MS_CAN_IN_POS
MS_CAN_IN_NEG
MS_CAN_OUT_POS
MS_CAN_OUT_NEG
B+
B+
OP
C+
C-
C+
C-
SYSTEM_GND
B+
EPB_PWR
C3BP01E/20
C3BP01D/18
C3BP01D/13
P
C3BP01C/7
MS CAN BUS
MS CAN BUS
BK
1
BU-RD
193
GY-RD
1
YE-RD
1
GY-BN
2973
G3D138/1
C4CB01B/11
C4CB01B/9
HS CAN BUS
C4CB01B/1C4BP01F/5
Switch-brake pedal
FOOTBRAKE
SWITCH
C2CA29/4C2CA29/1
Module-parking brake
BRAKE_PEDAL_SW
B
LOGIC_BATT
B
IGN
C+
HS_CAN_POS
C-
HS_CAN_NEG
B
BATT_SUPPLY
HALL_SENSOR_GND
HALL_SIGNAL
HALL_SUPPLY
MOTOR_POS
MOTOR_NEG
APPLY_SW_2
RELEASE_SW_2
APPLY_SW_1
RELEASE_SW_1
SWITCH_RTN
Ignore both connectors
C44-N/##C44-M/##
VT-BN
1
IP
C4CB01B/7
GREF
C4CB01A/13
IP
C4CB01B/10
OP
C4CB01A/12
OP
C4CB01A/14
OP
C4CB01A/7 C4CB18/6
IP
C4CB01B/2 C33-C/4
IP
C4CB01B/14 C33-C/16
IP
C4CB01A/10 C33-C/3
IP
C4CB01A/11 C33-C/15
GREF
C4CB01B/6 C33-C/10
VT-BN
2911
YE-BU
947
BN-WH
937
BU-GY
947
VT-BN
947
YE-GN
947
BN-YE
2956
YE-OG
2956
VT-OG
2949
GN-OG
2949
BN-BU
2956
SPL786
C44-M/10 C44-N/10
C44-M/6 C44-N/6
SPL259
VT-BN
1
C44-N/7C44-M/7
C44-N/9C44-M/9
C44-N/8C44-M/8
(drawn for harness
Manufacturing purposes)
C13-E/9
VT-BN
4546
YE-BU
3420
BN-WH
3420
BU-GY
3420
VT-BN
3420
YE-GN
3420
C44-P/5
C44-R/2
C44-R/1
C44-R/3
C44-R/4
YE-BU
1
BN-WH
1
BU-GY
1
VT-BN
1
YE-GN
1
BN-YE
2956
YE-OG
2956
VT-OG
2949
GN-OG
2949
BN-BU
2956
C4CB18/5
C4CB18/4
C4CB18/3
C4CB18/1
C3ET37/8
C3ET37/19
C3ET37/9
C3ET37/20
C3ET37/10
Parking brake
Actuator
HALL_RTN
HALL_SIGNAL
HALL_PWR
MOTOR_POS
MOTOR_NEG
Module-transmission shift
OP
EPB_APPLY_2
OP
EPB_REL_2
OP
EPB_APPLY_1
OP
EPB_REL_1
GREF
EPB_RTN
150 463
APPLY
150 463
RELEASE
HS_CAN_POS
HS_CAN_NEG
463150
463150
C+
HS CAN BUS
C-
C+
MS_CAN_POS
C-
MS_CAN_NEG
SYSTEM_GND
P
C4BP01C/7
MS CAN BUS
BK
275
P
C4CB01B/13
GND
C44-N/72C44-M/72
BK
1
G4D173/1
D278
BK
304
C44-N/68C44-M/68
BK
1
G4D173/1
XF - S20753 > (1a) 3
x
Page 20
206-09 - ANTI-LOCK CONTROL
206-09 - ANTI-LOCK CONTROL
phcr83-70165-a-a4
MS CAN BUS
MS CAN BUS
Junction-box engine
B+
Junction box-central
B+
B+
C+
MS_CAN_IN_POS
C-
MS_CAN_IN_NEG
C+
MS_CAN_OUT_POS
C-
MS_CAN_OUT_NEG
F25
10A MINI
F5
40A A1
ABS_VALVES
F21
25A MINI
IGN_SUPPLY_2_FWD
SYSTEM_GND
TAP1_1
TAP1_2
ABS_ECM
ABS_PUMP
TAP2_2
TAP2_1
OP
C1BB01B/74
C1BB01B/75
C1BB01B/31
C1BB01B/9
C1BB01B/26
C1BB01B/73
C1BB01B/72
C3BP01E/16
P
C3BP01C/7
RD
1
RD
96
GY-RD
96
GY-RD
96
RD
1
GN-VT
168
BK
1
G3D138/1
SPL302
GN-VT
2118
C1CA01B/7
C1CA01B/1
C1CA01B/25
C1CA01B/35
HS CAN BUS
Abs module
B
ECM_SUPPLY
B
PUMP_SUPPLY
B
VALVE_SUPPLY
B
IGNITION_SENSE
C+
HS_CAN_IN_POS
C-
HS_CAN_OUT_NEG
VAC_SENSOR_PWR
VREF
VAC_SENSOR_SIG_1
VAC_SENSOR_SIG_2
GREF
VAC_SENSOR_GND
VALVE_GND
PUMP_GND
C1CA01B/9
IP
C1CA01B/29
IP
C1CA01B/28
C1CA01B/27
P
C1CA01B/38
P
C1CA01B/13
BK
632
BK
632
BK
632
BK
1
YE-OG
3451
BN-VT
3451
BU-GN
3451
WH-BU
3451
DR_B
DR_D
DR_B
DR_D
EN_WD
EN_WD
EN_WD
EN_WD
C1CA37/3
C1CA37/4
C1CA37/1
C1CA37/2
Sensor-dsc
SENSOR_SUPPLY
SENSOR_SIG1
SENSOR_SIG2
SENSOR_GND
V6 ONLY
G1D120/1
G1D123/1
XF - S20753 > (1a) 4
x
Page 21
206-09 - ANTI-LOCK CONTROL
phcr83-70165-b-a4
MS CAN BUS
MS CAN BUS
Junction box-central
B+
B+
C+
MS_CAN_IN_POS
C-
MS_CAN_IN_NEG
C+
MS_CAN_OUT_POS
C-
MS_CAN_OUT_NEG
Sensor-steeringAngle
R
PWR
G
SIGNAL_A
Y
SIGNAL_B
B
GND
HS CAN BUS
OP
P
GN-VT
684
GY-BN
684
VT-OG
684
BN-VT
684
C3BP01E/16
C3BP01C/7
IGN_SUPPLY_2_FWD
SYSTEM_GND
C2CS06/4
C2CS06/2
C2CS06/3
C2CS06/1 C1CA01B/15
GN-VT
168
BK
1
C12-A/17
C12-A/15
C12-A/16
C12-A/14
G3D138/1
GN-VT
1
GY-BN
3106
VT-OG
3106
BN-VT
1
SPL302
GN-VT
2118
C1CA01B/35
C1CA01B/8
C1CA01B/4
Abs module
LH_FRONT_WHSPEED_SENSOR_SIG
LH_FRONT_WHSPEED_SENSOR_POWER
C+
HS_CAN_IN_POS
C-
HS_CAN_OUT_NEG
RH_FRONT_WHSPEED_SENSOR_SIG
RH_FRONT_WHSPEED_SENSOR_POWER
LH_REAR_WHSPEED_SENSOR_SIG
LH_REAR_WHSPEED_SENSOR_POWER
B
IGNITION_SENSE
RH_REAR_WHSPEED_SENSOR_SIG
RH_REAR_WHSPEED_SENSOR_POWER
IP
STRG_ANGLE_SIG_A
IP
STRG_ANGLE_SIG_B
GREF
STRG_ANGLE_SENSOR_RTN
IP
OP
IP
OP
IP
OP
IP
OP
C1CA01B/22
C1CA01B/21
C1CA01B/6
C1CA01B/18
C1CA01B/20
C1CA01B/33
C1CA01B/31
C1CA01B/19
Wheel speed sensorLh front
VT-WH
3226 SIGNAL
YE
3226
GY-VT
2107
VT
2107
BU-OG
2167
BN-GN
2167
WH-OG
2167
BN
2167
BU-OG
3990
BN-GN
3990
WH-OG
3154
BN
3154
C13-C/5
C13-C/6
C44-P/6
C44-P/7
C13-C/12
C13-C/13
C44-P/4
C44-P/3
BU-OG
1
BN-GN
1
WH-OG
1
BN
1
C1CA03/1
C1CA03/2
C1CA05/1
C1CA05/2
C4CA04/2
C4CA04/1
C4CA06/2
C4CA06/1
POWER
Wheel speed sensorRh front
SIGNAL
POWER
Wheel speed sensorLh rear
SIGNAL
POWER
Wheel speed sensorRh rear
SIGNAL
POWER
Sensor-yaw rate
SENSOR_PWR
HS_CAN_POS
HS_CAN_NEG
SENSOR_GND
Junction-box engine
B+
C4CA09A/1
C4CA09A/2
C4CA09A/3
C4CA09A/4
F25
10A MINI
F5
40A A1
F21
25A MINI
GN-VT
1
BU-WH
1
GN-OG
1
BK
1
TAP1_1
TAP1_2
ABS_ECM
ABS_PUMP
ABS_VALVES
TAP2_2
TAP2_1
C1BB01B/74
C1BB01B/75
C1BB01B/31
C1BB01B/9
C1BB01B/26
C1BB01B/73
C1BB01B/72
C13-B/9
C13-C/9
C13-C/10
RD
1
RD
96
GY-RD
96
GY-RD
96
RD
1
G3D161/1
GN-VT
1
BU-WH
1
GN-OG
1
C1CA01B/37
C1CA01B/24
C1CA01B/7
C1CA01B/1
C1CA01B/25
C+
HS_CAN_2_POS
C-
HS_CAN_2_NEG
B
ECM_SUPPLY
B
PUMP_SUPPLY
B
VALVE_SUPPLY
OP
ISO_9141
SUNROOF_SPEED_SIG
OP
VALVE_GND
PUMP_GND
C1CA01B/17
C1CA01B/36
P
C1CA01B/38
P
C1CA01B/13
GY
1
BU
2167
BK
632
BK
632
BK
632
BK
1
CHAAL
DR_B
DR_D
DR_B
DR_D
C13-B/18
G1D120/1
GY
1
BU
1252
CHAAL
G1D123/1
C2DB04B/9C12-A/18
C9PR32/6
Diagnostic connector
ABS_COMMS
Roof opening panel
Control module
SPEED_SWITCH
x
XF - S20753 > (1a) 5
Page 22
211-04 - STEERING COLUMN Steering wheel
211-04 - STEERING COLUMNSteering wheel
phcr83-70170-a-a4
SA003/1
SA003/2
SA002/1
SA002/2
Module-air bag-
-driver
STAGE2_PWR
STAGE2_RTN
STAGE1_PWR
STAGE1_RTN
U106
Switch-remote-ice
R
1
R
1
Clock spring
STAGE2_PWR
STAGE2_RTN
STAGE1_PWR
STAGE1_RTN
SA001/3
SA001/4
SA001/1
SA001/2
NW
1
SW
1
SB
1
NR
1
PWM_ILLUM
ICE_SW
GND_RTN
HORN_SW
IGNITION
LIN
CLOCKSPRING
Slip rings-steering wheel
SW001/1
SW015/1
SW012/1
SW008/1
SW002/2
SW002/1
SW002/4
Switch-hornRh
Switch-hornLh
SW002/3
SW002/6
SWS01
SW014/1
SW013/1
B
1
B
1
B
11
B
1
B
1
B
1
B
1
N
1
SW003/5
SW003/3
SW003/6
SW007/1 SW007/4
GTBAB
SA004/2 SW003/2
SA004/1 SW003/1
SA004/4 SW003/4
SA004/5
SA004/3
SA004/6
RW
1
RW
1
B
GW
1
GW
1
YU
1
YR
1
R
1
NO
1
GTBAB
GTBAB
ILLUM_IN
R1
R2
R3
VOL+
VOL-
MEM+
MEM-
ICE_SIG
GND
ELECTRONICS
HORN_GND
IGNITION_IN
LIN
Heater-steering
Wheel
NTC
SENSOR
SENSOR_GND
SENSOR
ELEMENT
ELEMENT_GND PWR
R4
R5
MUTE
MEDIA
SW007/2
SW007/3
ILLUM_OUT_2
ILLUM_OUT_1
MUTE
MEDIA
R6
MEM -
MEM +
VOL +
VOL -
CRUISE_SW_GND
PADDLE_SW_GND
CRUISE_SIG
PADDLE_SHIFT_UP
PADDLE_SHIFT_DOWN
SW005/1
SW004/1
SW004/3
SW005/5
SW004/2
SW005/3
SW005/4
B
1
S
1
NB
1
G
1
B
1
N
1
RW
1
B
1
B
1
B
1
S
1
GTBAB
GTBAB
GTBAB
GTBAB
Cruise controlsRemote
SW009/1
ILLUM_PWR
SW009/3
RTN
SW009/2
CRUISE_SIGNAL
Upshift paddle
Switch
SW010/3
GND
SW010/2
SHIFT_UP
Downshift paddle
Switch
SW011/3
GND
SW011/2
SHIFT_DWN
ModuleHeated steering wheel
SW006/5
PWR
SW006/3
SENSOR_RTN
SW006/2
SENSOR
SW006/7
HEATER_ELEMENT
SW006/6
GND
R1R2R3R4R5
HEAD+
HEAD-
SET+
SET- CAN
SW010/1
ILLUM
SW011/1
ILLUM
RES
RESUME
SET/ACCEL
R6
HEADWAY -
HEADWAY +
DECEL
CANCEL
2K2
1K0
510R
300R
180R
120R
x
XF - S20753 > (1a) 6
Page 23
211-04 - STEERING COLUMN Steering Column Adjustment
Steering Column Adjustment
phcr83-70360-a-a4
Junction box-central
Instrument cluster
B+
B+
F14
COLUMN_PEDAL_ADJUST_PWR
10A MINI
F31
5A MINI
B+
B+
CLUSTER_LOGIC_PWR
BN-RD
1
WH-RD
144
C12-B/11
C23-D/3C3BP01D/9
BN-RD
1
WH-RD
1355
C2MC01B/19C3BP01G/9
C2MC01B/16
B
COLUMN_PWR
B
LOGIC_PWR
Switch-steering column
Adjustment
OUT
820
330
IN
UP
1K5
2K2
DOWN
MODE SWITCH
1
2
1=COL ADJ
2=COL ADJ + EASY ENTRY MODE
COLUMN_ADJ
MODE_SEL
SWITCH_RTN
GN-VT
666
YE-VT
666
GN-OG
666
C2MC01A/13C2PP11/1
C2MC01A/24C2PP11/5
C2MC01A/19C2PP11/3
MS CAN BUS
COLUMN_DWN_OUT
IP
COLUMN_ADJUST
COLUMN_POT_FEED
IP
COLUMN_ADJUST_AUTO_MAN
GREF
COLUMN_RTN
C+
MS_CAN_IN_POS
C-
MS_CAN_IN_NEG
COLUMN_POT_RTN
REACH_SOLENOID
VREF
COLUMN_UP_IN
VREF
IP
REACH_POT
VREF
GREF
IP
RAKE_POT
VREF
RAKE_SOLENOID
VREF
GND
LOGIC_GND
C2MC01B/18 C2PP03/3
C2MC01B/20 C2PP03/4
C2MC01A/32 C2PP03/8
C2MC01B/4 C2PP03/6
C2MC01B/5 C2PP03/5
C2MC01A/27 C2PP03/7
C2MC01B/24 C2PP03/9
C2MC01B/23 C2PP03/1
P
C2MC01B/22
P
C2MC01B/32
BN-GN
586
GY-OG
586
VT-BN
578
WH-BN
586
YE-GN
586
WH
578
BN-VT
586
WH-GN
586
BK
535
BK
676
Assembly-steering column
STEERING
COLUMN
MOTOR
COLUMN_UP_IN
COLUMN_DOWN_OUT
COLUMN_REACH_POT
COLUMN_POT_VREF
COLUMN_POT_RTN
COLUMN_RAKE_POT
RAKE_PWR
REACH_PWR REACH_GND
RAKE
SOLENOID
REACH
SOLENOID
G2D115/1
RAKE_GND
C2PP03/10
C2PP03/2
BK
52
BK
52
BK
585
SPL187
XF - S20753 > (1a) 7
x
Page 24
303-03 - ENGINE COOLING PV8 (5.0L)
303-03 - ENGINE COOLINGPV8 (5.0L)
phcr83-70033-b-a4
Control unitCooling fan
SPL859
GN
1
EN_RX:EN_RY
C1EC01D/1
C1EC01D/4
BATT
IGN
M
Junction-box engine
FAN_MIDIFUSE
B+
F45
100A MIDIFUSE
F42
10A/20A/30A MINI
F36
20A/15A MINI
EMS_SUPPLY_5_FUSE
HIGH CURRENT
PETROL/DIESEL
EMS
RELAY
RLY16
F9
50A A1
F26
10A MINI
COOLING_FAN
EMS_SUPPLY_2
EMS_SUPPLY_5
EMS_FUSES
EMS_FUSE_SUPPLY
EMS_RLY_CTRL
EMS_RLY_COIL
EMS_RLY_SUPPLY
EMS_POWER_FUSE
TCM_EMS_POWER
TAP1_2
TAP1_1
C1BB01E/1
C1BB01B/63
C1BB01B/51
C1BB01B/50
C1BB01B/62
C1BB01B/P5
C1BB01B/P2
C1BB01B/P1
C1BB01B/P3
C1BB01B/13
C1BB01B/32
C1BB01B/75
C1BB01B/74
RD
1
GN
1
BU-BN
1
GY
0
GY
0
GY
0
RD
0
RD
0
YE-RD
28
RD
1
EN_RX:EN_RY:EN_SU:EN_KN
EN_RX:EN_RY
EN_RX:EN_RY
EN_RX:EN_RY:EN_SU
EN_RX:EN_RY:EN_SU:EN_KN
EN_RX:EN_RY:EN_SU:EN_KN
RD
0
SPL862
SPL792
SPL310
SPL083
BU-BN
1
BU-BN
1
GY-VT
1
YE-RD
1
EN_RX:EN_RY
EN_RX:EN_RY
EN_RX:EN_RY
EN_RX:EN_RY
C1E120B/5
C1E120B/6
C1E120B/15
C1E120B/43
Engine controlModule (ecm)
B+
ECM_POWER_1
B+
ECM_POWER_2
OP
EMS_MAIN_RLY
B+
BATTERY
OP
RAD_FAN_PWM
C+
HS_CAN_POS
C+
HS_CAN_NEG
POWER_GND_1
POWER_GND_2
POWER_GND_3
P
P
P
C1E120B/56
HS CAN BUS
C1E120B/1
C1E120B/2
C1E120B/3
VT
1
BK
1
BK
1
BK
1
EN_RX:EN_RY
EN_RX:EN_RY
EN_RX:EN_RY
EN_RX:EN_RY
C1EC01D/3
G1D108/1
GNDPWM_CTRL
850W RAD FAN FLYLEAD
BK
580
G1D132B/1
EN_RX:EN_RY:EN_SU:EN_KN
C1EC01D/2
XF - S20753 > (1a) 8
x
Page 25
303-03 - ENGINE COOLING DV6
DV6
phcr83-70033-d2-a4
Control unitCooling fan
GY
1
EN_SU
C1EC01D/1
C1EC01D/4
BATT
IGN
M
Junction-box engine
FAN_MIDIFUSE COOLING_FAN
B+
F45
100A MIDIFUSE
F43
5A/10A MINI
F42
10A/20A/30A MINI
HIGH CURRENT
PETROL/DIESEL
EMS
RELAY
RLY16
F9
50A A1
EMS_SUPPLY_3
EMS_SUPPLY_2
EMS_FUSES
EMS_FUSE_SUPPLY
EMS_RLY_CTRL
EMS_RLY_COIL
EMS_RLY_SUPPLY
EMS_POWER_FUSE
C1BB01E/1
C1BB01B/65
C1BB01B/63
C1BB01B/62
C1BB01B/P5
C1BB01B/P2
C1BB01B/P1
C1BB01B/P3
C1BB01B/13
GY
0
GY
0
RD
0
RD
0
RD
0
RD
1
GY
1
GN
1
EN_RX:EN_RY:EN_SU:EN_KN
EN_RX:EN_RY:EN_SU:EN_KN
EN_RX:EN_RY:EN_SU:EN_KN
EN_SU
EN_SU
SPL168
SPL862
SPL792
SPL863
GN
1
GN
1
GY-VT
1
EN_SU
EN_SU
EN_SU
C1E116B/3
C1E116B/5
C1E116B/55
Engine controlModule (ecm)
B+
SWITCHED_SUPPLY_1
B+
SWITCHED_SUPPLY_2
COOLING_FAN_CTRL
OP
EMS_RELAY_CTRL
OP
C-
HS_CAN_NEG
C+
HS_CAN_POS
POWER_GND_4
POWER_GND_3
POWER_GND_2
POWER_GND_1
P
P
P
P
C1E116B/56
HS CAN BUS
C1E116B/6
C1E116B/4
C1E116B/2
C1E116B/1
BK
409
BK
409
BK
417
BK
417
VT
1
EN_SU
EN_SU
EN_SU
EN_SU
EN_SU
C1EC01D/3
GNDPWM_CTRL
850W RAD FAN FLYLEAD
BK
580
G1D132B/1
EN_RX:EN_RY:EN_SU:EN_KN
C1EC01D/2
G1D108/1
XF - S20753 > (1a) 9
x
Page 26
303-03 - ENGINE COOLING D4
D4
phcr83-70033-d-a4
Control unitCooling fan
SPL894
GY
1
EN_KN
C1EC01D/1
C1EC01D/4
BATT
IGN
M
Junction-box engine
FAN_MIDIFUSE COOLING_FAN
B+
F45
100A MIDIFUSE
F43
5A/10A MINI
F42
10A/20A/30A MINI
HIGH CURRENT
PETROL/DIESEL
EMS
RELAY
RLY16
F9
50A A1
EMS_SUPPLY_3
EMS_SUPPLY_2
EMS_FUSES
EMS_FUSE_SUPPLY
EMS_RLY_CTRL
EMS_RLY_COIL
EMS_RLY_SUPPLY
EMS_POWER_FUSE
C1BB01E/1
C1BB01B/65
C1BB01B/63
C1BB01B/62
C1BB01B/P5
C1BB01B/P2
C1BB01B/P1
C1BB01B/P3
C1BB01B/13
RD
1
GY
1
GN
1
GY
0
GY
0
RD
0
RD
0
RD
0
EN_RX:EN_RY:EN_SU:EN_KN
EN_KN
EN_KN
EN_RX:EN_RY:EN_SU:EN_KN
EN_RX:EN_RY:EN_SU:EN_KN
SPL792
SPL893
SPL862
GN
1
GN
1
GY-VT
1
EN_KN
EN_KN
EN_KN
C1E104C/2
C1E104C/5
C1E104C/28
Engine controlModule (ecm)
B+
SUPPLY_1
B+
SUPPLY_2
OP
EMS_RLY_CTRL
ECFC_CTRL
HS_CAN_POS
HS_CAN_NEG
OP
C
C
C1E104C/13
HS CAN BUS
VT
1
EN_KN
C1EC01D/3
GNDPWM_CTRL
850W RAD FAN FLYLEAD
BK
580
G1D132B/1
EN_RX:EN_RY:EN_SU:EN_KN
C1EC01D/2
POWER_GND_1
POWER_GND_2
SIGNAL_GND_3
C1E104C/4
P
C1E104C/3
P
C1E104C/53
BK
1
BK
1
BK
1
EN_KN
EN_KN
EN_KN
G1D108/1
P
XF - S20753 > (1a) 10
x
Page 27
303-06 - STARTING SYSTEM PV8 (5.0L)
303-06 - STARTING SYSTEMPV8 (5.0L)
phcr83-70021-b-a4
G4D178/1
BK
360
Battery
C4D101/1 C1DC12A/1C4BF10A/1C4DC02A/1 C4DF10A/1
+-
RD
148 3264
PETROL
Junction box-rear
B+
B+
START_STOP_SW_SENSE
IP
C4BP01M/15
Junction box-central
OP
OP
OP
OP
EMS_EWU
OP
C3BP01J/20
IP
C3BP01M/20
IP
C3BP01M/3
C3BP01E/16
IP
C3BP01M/27
C3BP01G/16
C3BP01J/4
P
C3BP01C/7
MS CAN BUS
MS CAN BUS
B+
B+
C+
MS_CAN_IN_POS
C-
MS_CAN_IN_NEG
C+
MS_CAN_OUT_POS
C-
MS_CAN_OUT_NEG
ETS_WAKE_UP
START_STOP_SW1
START_STOP_SW2
IGN_SUPPLY_2_FWD
PARK_NEUTRAL_SIG
ENGINE_CRANK
FPDB_IGNITION_CTRL
SYSTEM_GND
Junction box-battery
400A
250A
250A
YE-OG
1744
VT-WH
1
YE-OG
1313
GN-VT
168
GN
1
BK
1
RD
SPL271
G3D138/1
PETROL
SPL302
Stud-cable junction
GN-VT
SPL220
48
GN
1
YE-RD
2099
C1DC12B/1
C11-P/34
RD
1
C13-E/2
C13-C/8
C13-C/16
EN_RX:EN_RY
VT-WH
1
BN-VT
2512
YE-OG
1199
GN-VT
2568
YE-RD
2568
SPL069
RD
1
EN_RX:EN_RY
Refer to vehicle interface
C33-C/6
C33-C/5
C33-C/17
C33-C/7
C33-C/21 C3ET37/15
C33-C/20
VT-WH
1
BN-VT
1
YE-OG
1
GN-VT
1
GN
1
YE-RD
1
Starter motor
C1DC35A/1 C1D101/1
MOTOR
SOLENOID
GND
Module-transmission shift
C3ET37/12
C3ET37/7
C3ET37/18
C3ET37/2
C3ET37/1
L
LIN
IP
PARK
IP
WAKE_UP
OP
START_STOP_1
OP
START_STOP_GND
STOP_START_2
B
IGN
OP
P_N_SIG
B
BATTERY
C+
HS_CAN_POS
C-
HS_CAN_NEG
OP
OK_TO_CRANK
GND
P
P
HS CAN BUS
C3ET37/11
C3ET37/22
BK
1
BK
1
BK
1
G1D124/1
C33-C/9
C33-C/8
BK
1
BK
128
G3D182B/1
Junction-box engine
B+
30A
10A MINI
CONVENTIONAL STARTER
RELAY
FULL ISO
STR_MOTOR_SUPPLY
STR_MOTOR_RLY_CTRL
RLY17
STARTER_MOTOR_RLY_COIL
STARTER_MOTOR_RLY_SUPPLY
F14
STARTER_MOTOR_RLY
A1
F26
TCM_EMS_POWER
TAP1_2
TAP1_1
C1BB01B/Q5
C1BB01B/Q2
C1BB01B/Q1
C1BB01B/Q3
C1BB01B/18
C1BB01B/32
C1BB01B/75
C1BB01B/74
VT-OG
2135
BN-RD
0
YE-RD
28
RD
1
EN_RX:EN_RY:EN_WD:EN_SU
SPL310
GN
1
C13-E/3
GN
1
BU-WH
1
VT-OG
1
GN-VT
1
GY-OG
1
YE
1
YE-RD
1
EN_RX:EN_RY
EN_RX:EN_RY
EN_RX:EN_RY
EN_RX:EN_RY
EN_RX:EN_RY
EN_RX:EN_RY
EN_RX:EN_RY
C1E120B/36
C1E120B/14
C1E120B/19
C1E120B/17
C1E120B/9
C1E120B/11
C1E120B/43
Engine controlModule (ecm)
IP
PN_SW
IP
CRANK_REQUEST
IP
EMS_EWU
IP
IGNITION_SW
OP
STARTER_RELAY_-
OP
STARTER_RELAY_+
B+
BATTERY
C+
HS_CAN_NEG
C+
HS_CAN_POS
LIN
LIN_A
POWER_GND_1
POWER_GND_2
POWER_GND_3
P
P
P
HS CAN BUS
C1E120B/1
C1E120B/2
C1E120B/3
BK
1
BK
1
BK
1
EN_RX:EN_RY
EN_RX:EN_RY
EN_RX:EN_RY
G1D108/1
x
XF - S20753 > (1a) 11
Page 28
303-06 - STARTING SYSTEM D4
D4
phcr83-70021-d-a4
Junction box-battery
350A
BK
360
G4D178/1
Battery
C4D101/1 C1DC12A/1C4BF10A/1C4DC02B/1
Junction box-rear
B+
B+
Junction box-central
B+
B+
C+
MS CAN BUS
MS CAN BUS
MS_CAN_IN_POS
C-
MS_CAN_IN_NEG
C+
MS_CAN_OUT_POS
C-
MS_CAN_OUT_NEG
Junction-box engine
B+
+-
F26
10A MINI
RD
505
OP
ETS_WAKE_UP
OP
OP
OP
EMS_EWU
OP
SYSTEM_GND
TAP1_2
TAP1_1
IP
IP
IP
IP
P
START_STOP_SW_SENSE
START_STOP_SW1
START_STOP_SW2
IGN_SUPPLY_2_FWD
PARK_NEUTRAL_SIG
ENGINE_CRANK
FPDB_IGNITION_CTRL
TCM_EMS_POWER
EN_SU:EN_KN
C4BP01M/15
C3BP01J/20
C3BP01M/20
C3BP01M/3
C3BP01E/16
C3BP01M/27
C3BP01G/16
C3BP01J/4
C3BP01C/7
C1BB01B/32
C1BB01B/75
C1BB01B/74
C4DF10B/1
YE-OG
1744
VT-WH
1
BN-VT
2512
YE-OG
1313
GN-VT
168
GN
1
BK
1
YE-RD
28
RD
1
150A
450A
250A
250A
SPL271
G3D138/1
BK
3430
SPL310
EN_SU:EN_KN
SPL302
Stud-cable junction
SPL220
GN
1
RD
680
C13-E/2
YE-OG
1199
GN-VT
48
GN
1 1
YE-RD
2099
C13-C/8
C33-C/21 C3ET37/15
C13-C/16
VT-WH
1
GN-VT
2568
YE-RD
2568
GN
1
BU-WH
1
VT-OG
1
GN-VT
1
EN_KN
EN_KN
EN_KN
EN_KN
EN_KN
C33-C/6
C33-C/5
C33-C/17
C33-C/7
C33-C/20
C1E104C/24C13-E/3
C1E104C/51
C1E104C/9
C1E104C/19
Engine controlModule (ecm)
IP
PN_SIG
IP
CRANK_REQUEST
IP
WAKE_UP
IP
IGN_SENSE
OP
STARTER_RLY_NEG_1
OP
STARTER_RLY_POS
VT-WH
1
BN-VT
1
YE-OG
1
GN-VT
1
GN
YE-RD
1
C3ET37/12
C3ET37/7
C3ET37/18
C3ET37/2
C3ET37/1
HS_CAN_POS
HS_CAN_NEG
POWER_GND_1
POWER_GND_2
SIGNAL_GND_3
Starter motor
MOTOR
SOLENOID
Module-transmission shift
L
LIN
IP
PARK
IP
WAKE_UP
OP
START_STOP_1
OP
START_STOP_GND
STOP_START_2
B
IGN
OP
P_N_SIG
B
BATTERY
C
HS CAN BUS
C
P
C1E104C/4
P
C1E104C/3
P
C1E104C/53
C1D101/1C1DC35A/1C1DC12B/1
GND
HS_CAN_POS
HS_CAN_NEG
OK_TO_CRANK
GND
BK
1
BK
1
BK
1
C+
C-
OP
P
P
EN_KN
EN_KN
EN_KN
HS CAN BUS
C3ET37/11
C3ET37/22
BK
1
BK
1
BK
1
G1D124/1
C33-C/9
C33-C/8
BK
1
BK
128
G3D182B/1
G1D108/1
XF - S20753 > (1a) 12
x
Page 29
303-06 - STARTING SYSTEM D4
D4
phcr83-70024-a-a1
Junction box-battery
350A
BK
360
G4D178/1
Battery
BATTERY
C4BF10F/1
150A
C4DC02B/1C4D101/1
+-
RD
505
EN_SU:EN_KN
C4DF10B/1
450A
250A
250A
C4BF10A/1
C4BF10B/1C4DF10C/1
C4BF10C/1
RD
1
BK
3430
RD
1
TSS
EN_SU:EN_KN
Stud-cable junction
C1DC12A/1 C1DC12B/1
SPL080
RD
400
C4BP01P/1
RD
680
EN_KN
Junction box-rear
B+
B+
BCMB LOADS
Starter motor
C1DC35A/1 C1D101/1
C1DC71A/2
C1DC71A/1
PINION
MOTOR
GNDBATT
BK
1
G1D124/1
C4Y124E/1
Junction boxDual battery
BATT_2
GND
BATT_1
CONTACT 2
CONTACT 1
F10
40A A1-S
F9
20A A1-S
DBFB
CTRL_2
BATT_OUT
CTRL_1
RLY_1
RLY_2
C4Y124D/1
C4Y124B/1
C4Y124B/2
RD
1
GY-OG
1
GY-BU
1
TSS
TSS
TSS
C44-AB/2
C44-AB/1
GY-OG
1
GY-BU
1
TSS
TSS
C13-H/1
C13-H/2
GY-OG
1
GY-BU
1
EN_KN
EN_KN
C1BB01B/Q3
C1BB01B/M3
Junction-box engine
RD
1
CONVENTIONAL STARTER / PINION
RELAY
FULL ISO
RLY17
F23
5A MINI
TSS STARTER MTR
RELAY
FULL ISO
RLY13
STR_MONITOR_FUSE
STR_MONITOR
C3BP01P/1
C1BB01B/Q5
C1BB01B/Q2
C1BB01B/Q1
C1BB01B/M5
C1BB01B/M2
C1BB01B/M1
Junction box-central
B+
B+
VT-OG
2135
GY-OG
1
YE
1
GY-BU
1
GN-BN
1
YE
1
BCM LOADS
EN_KN
EN_KN
EN_KN
EN_KN
EN_KN
SPL234
YE
1
C11-P/34
EN_KN
C11-P/9
C1E104C/41
C1E104C/17
C1E104C/27
Refer to vehicle interface
Engine controlModule (ecm)
HS_CAN_POS
OP
PINION_RLY_CTRL
OP
STARTER_RLY_POS
OP
MOTOR_RLY_CTRL
HS_CAN_NEG
POWER_GND_1
POWER_GND_2
SIGNAL_GND_3
C
C
P
C1E104C/4
P
C1E104C/3
P
C1E104C/53
HS CAN BUS
BK
1
BK
1
BK
1
EN_KN
EN_KN
EN_KN
G1D108/1
XF - S20753 > (1a) 13
x
Page 30
303-14E - ELECTRONIC ENGINE CONTROLS - PV8 (5.0L) Vehicle interface - Part 1
303-14E - ELECTRONIC ENGINE CONTROLS - PV8 (5.0L)Vehicle interface - Part 1
phaj133-70031-a-a5
Air conditioning (a/c)
Compressor solenoid
R
POS
B
NEG
Starter motor
SOLENOID
Transmission control
Module
C+
HS_CAN_POS
C-
HS_CAN_NEG
C1ET34/6
C1ET34/2
WH-BU
168
WH
168
JAG
JAG
PIS40
PIS39
GY
2721
VT
2721
VT-OG
500
WH-BU
1825
WH
1825
JAG
JAG
JAG
JAG
JAG
C11-P/36C1H421/1
C11-P/42C1H421/2
C11-P/34PI099/1
C11-P/17
C11-P/18
Refer to climate control
Refer to engine junction box
PN_SIGNAL
Engine controlModule (ecm)
VISCOUS_FAN_SPEED
VISCOUS_FAN_CONTROL
E_BOX_FAN
K_LINE
B+
BATTERY
OP
B+
IGNITION
LIN
GND_2
GND_1
OP
OP
OP
D
C
P
P
C1ET34/3
C1ET34/14
C1ET34/10
C1ET34/9
C1ET34/8
C1ET34/16
C1ET34/13
C1E117/84
BK
2035
BK
353
JAG
JAG
PIS41
WH
1825
WH-BU
1825
GY
1925
YE-RD
328
WH-BN
1925
GY
70
BN-VT
1925
BK
173
VT
1
JAG
JAG
JAG
JAG
JAG
JAG
JAG
JAG
JAG
C11-P/21
C11-P/20
C11-P/22
C11-P/31
C11-P/37
C11-P/13
C11-P/35
C11-P/7
C11-P/28
Refer to can bus - high speed
Refer to engine junction box
Refer to transmission
Refer to engine junction box
XK
C11-P = PI041
C11-P = C11-PXF - XJ
Generator
LIN
C1E117/95 C1DC14/1
LIN_A
BU-BN
2267
XF - S20753 > (1a) 14
BATT
L
GND
x
Page 31
303-14E - ELECTRONIC ENGINE CONTROLS - PV8 (5.0L) Actuators - Part 1
Actuators - Part 1
phcr83-70038-b-a4
Junction-box engine
B+
D1
F37
15A MINI
IGN_COILS_VAPS_HEADLAMP_LEVEL
10A/20A/30A MINI
5A/10A/15A MINI
F36
15A/20A MINI
10A MINI
IGNITION_RLY_DIODE_ANODE
IGNITION_RLY_DIODE_CATHODE
IGN_COILS
1/2 ISO
IGNITION
RELAY
IGNITION_RLY_OUTPUT
IGNITION_RLY_COIL
RLY19
IGNITION_RLY_CTRL
IGNITION_RLY_SUPPLY
F42
EMS_SUPPLY_2
F44
EMS_SUPPLY_4
EMS_SUPPLY_5
EMS_SUPPLY_5_FUSE
HIGH CURRENT
PETROL/DIESEL
EMS
RELAY
RLY16
F9
50A A1
F26
EMS_FUSES
EMS_FUSE_SUPPLY
EMS_RLY_CTRL
EMS_RLY_COIL
EMS_RLY_SUPPLY
EMS_POWER_FUSE
TCM_EMS_POWER
TAP1_2
TAP1_1
SPL305
C1BB01B/69
C1BB01B/68
C1BB01B/53
C1BB01B/54
C1BB01B/S5
C1BB01B/S2
C1BB01B/S1
C1BB01B/S3
C1BB01B/63
C1BB01B/67
C1BB01B/51 C1E120B/5
C1BB01B/50
C1BB01B/62
C1BB01B/P5
C1BB01B/P2
C1BB01B/P1
C1BB01B/P3
C1BB01B/13
C1BB01B/32
C1BB01B/75
C1BB01B/74
GN-VT
28
GY-BN
0
YE-GY
0
BK
0
RD
0
GN
1
VT
1
BU-BN
1
GY
0
GY
0
GY
0
RD
0
RD
0
RD
0
YE-RD
28
RD
1
GTDAB*JBBAC
EN_RX:EN_RY
EN_RX:EN_RY
EN_RX:EN_RY
EN_RX:EN_RY:EN_SU
EN_RX:EN_RY:EN_SU:EN_KN
EN_RX:EN_RY:EN_SU:EN_KN
SPL792
SPL310
G1D123/1
SPL862
SPL871
SPL083
GN-VT
2171
VT
1
BU-BN
1
BU-BN
1
GY-VT
1
YE-RD
1
EN_RX:EN_RY
EN_RX:EN_RY
EN_RX:EN_RY
EN_RX:EN_RY
EN_RX:EN_RY
C3BP01E/5
SPL859
C1E120B/33
C1E120B/6
C1E120B/15
C1E120B/43
Junction box-central
B+
B+
OP
FPDB_IGNITION_CTRL
OP
UHEGO_RLY_CTRL
WH
2051
GN
1
VT
1
Engine controlModule (ecm)
B+
VVT_POWER
B+
ECM_POWER_1
B+
ECM_POWER_2
OP
EMS_MAIN_RLY
B+
BATTERY
EN_RX:EN_RY:EN_WD
EN_RX:EN_RY
EN_RX:EN_RY
COOLING_FAN
HS_CAN_POS
HS_CAN_NEG
POWER_GND_1
POWER_GND_2
POWER_GND_3
MS_CAN_IN_POS
MS_CAN_IN_NEG
MS_CAN_OUT_POS
MS_CAN_OUT_NEG
OP
C+
C+
P
P
P
C+
C-
C+
C-
SYSTEM_GND
HS CAN BUS
C1E120B/1
C1E120B/2
C1E120B/3
P
C3BP01C/7
MS CAN BUS
MS CAN BUS
C11-P/30
C11-P/11
C11-P/41
BK
1
BK
1
BK
1
BK
1
EN_RX:EN_RY
EN_RX:EN_RY
EN_RX:EN_RY
G3D138/1
Refer to actuators
G1D108/1
x
XF - S20753 > (1a) 15
Page 32
303-14E - ELECTRONIC ENGINE CONTROLS - PV8 (5.0L) Actuators - Part 2
Actuators - Part 2
phaj133-70035-f-a5
Engine controlModule (ecm)
IGNITION_1A
IGNITION_2A
IGNITION_3A
OP
IGNITION_4A
OP
IGNITION_1B
OP
C1E117/61 C1E303/1
OP
C1E117/59 C1E304/1
OP
C1E117/57 C1E305/1
C1E117/55 C1E306/1
C1E117/60 C1E307/1
WH-VT
1594
YE-BU
1499
BU-OG
1401
GN-VT
1313
WH-BN
1536
Ignition coil-1
CTRL IGN
GND
CYL 1
Ignition coil-3
CTRL IGN
GND
CYL 3
Ignition coil-5
CTRL IGN
GND
CYL 5
Ignition coil-7
CTRL IGN
GND
CYL 7
Ignition coil-2
CTRL IGN
GND
CYL 2
C1E303/3
C1E303/2
C1E304/3
C1E304/2
C1E305/3
C1E305/2
C1E306/3
C1E306/2
C1E307/3
C1E307/2
WH
1072
WH
977
WH
879
WH
791
WH
459
PIS20
BK
753
BK
658
WH
977
BK
560
BK
472
BK
778
PIS26
PIS28
BK
995
WH
631
WH
1147
JAG
Capacitor
6.8uF
C11-P/30
PI054/2PI054/1
BK
312POS GND
Refer to engine junction box
PI080/001
OP
IGNITION_2B
OP
IGNITION_3B
OP
IGNITION_4B
C1E117/58 C1E308/1
C1E117/56 C1E309/1
C1E117/54 C1E310/1
VT-BN
1441
YE-GY
1343
BU-BN
1255
Ignition coil-4
CTRL IGN
GND
CYL 4
Ignition coil-6
CTRL IGN
GND
CYL 6
Ignition coil-8
CTRL IGN
GND
CYL 8
C1E308/3
C1E308/2
C1E309/3
C1E309/2
C1E310/3
C1E310/2
WH
364
WH
266
WH
178
PIS27
BK
683
WH
977
BK
585
BK
497
PIS21
BK
778
PI082/001
XK
C11-P = PI041
XF - XJ C11-P = C11-P
x
XF - S20753 > (1a) 16
Page 33
303-14E - ELECTRONIC ENGINE CONTROLS - PV8 (5.0L) Actuators - Part 3
Actuators - Part 3
phaj133-70035-g-a5
Engine controlModule (ecm)
Refer to actuators
Fuel injector-no.1
C1E205/1
C1E206/1
C1E207/1
C1E208/1 C1E208/2
CYL 1
CYL 3
CYL 5
CYL 7
C1E205/2
C1E206/2
C1E207/2
IGN CTRL
Fuel injector-no.3
IGN CTRL
Fuel injector-no.5
IGN CTRL
Fuel injector-no.7
IGN CTRL
GN-BU
1477
YE-BU
724
GY-YE
1384
BU-OG
631
VT
1281
GN-VT
528
YE-OG
1188
BU
435
C1E117/73
C1E117/49
C1E117/4
C1E117/28
C1E117/3
C1E117/27
C1E117/2
C1E117/26
INJECTOR_1A
OP
INJECTOR_1A_COMMON
OP
INJECTOR_2A
OP
INJECTOR_2A_COMMON
OP
INJECTOR_3A
OP
INJECTOR_3A_COMMON
OP
INJECTOR_4A
OP
INJECTOR_4A_COMMON
OP
ACTIVE_EXT_VALVE
VFS_IN_A
VFS_EX_A
VFS_IN_B
VFS_EX_B
OP
OP
OP
OP
OP
C1E117/81
C1E117/86
C1E117/88
C1E117/87
C1E117/89
BU
1
VT-BN
1
VT-GY
1
WH-GN
1
WH-OG
1
JAG
C1E421/1
C1E421A/1
C1E422/1
C1E422A/1
Solenoid-vvtBank 1-intake
SUPPLYCTRL
Solenoid-vvtBank 1-exhaust
SUPPLYCTRL
Solenoid-vvtBank 2-intake
SUPPLYCTRL
Solenoid-vvtBank 2-exhaust
SUPPLYCTRL
C1E421/2
C1E421A/2
C1E422/2
C1E422A/2
GN
1
GN
1
GN
1
GN
1
PIS84
GN
982
JAG
C11-P/32
C11-P/41
Refer to engine junction box
C1E209/1
C1E210/1
C1E211/1
C1E212/1
Fuel injector-no.2
CYL 2
CYL 4
CYL 6
CYL 8
C1E209/2
C1E210/2
C1E211/2
C1E212/2
IGN CTRL
Fuel injector-no.4
IGN CTRL
Fuel injector-no.6
IGN CTRL
Fuel injector-no.8
IGN CTRL
BN
1454
WH-GN
608
GN-WH
1351
BN-VT
505
GY-BN
1248
BU-WH
402
VT-OG
1140
WH-OG
294
C1E117/75
C1E117/51
C1E117/1
C1E117/25
C1E117/74
C1E117/50
C1E117/5
C1E117/29
INJECTOR_1B
OP
INJECTOR_1B_COMMON
OP
INJECTOR_2B
OP
INJECTOR_2B_COMMON
OP
INJECTOR_3B
OP
INJECTOR_3B_COMMON
OP
INJECTOR_4B
OP
INJECTOR_4B_COMMON
OP
CPS_A
OP
CPS_B
OP
IMTV
OP
PURGE_VALVE
OP
C1E117/90
C1E117/92
C1E117/85
C1E117/94
YE
1
OG
1
GN
1
WH-BN
1
EN_RX
EN_RX
C11-A/10
GN
1
PI061/1
PI063/1
C1E316/2
C1E135/1
Solenoid-camshaft profile
Switching-bank 1
CTRL SUPPLY
Solenoid-camshaft profile
Switching-bank 2
CTRL SUPPLY
SolenoidManifold intake tuning
Or symposer
PI061/2
PI063/2
C1E316/1
SUPPLYCTRL
Purge control valve
CTRL IGN
C1E135/2
GY
1
GY
1
GY
1
GY
1
EN_RX
EN_RX
C11-A/9
GY
1
PIS88
GY
1
JAG
C11-P/11
Refer to engine junction box
XK
C11-P = PI041
C11-P = C11-PXF - XJ
XF - S20753 > (1a) 17
x
Page 34
303-14E - ELECTRONIC ENGINE CONTROLS - PV8 (5.0L) Actuators - Part 4
Actuators - Part 4
phaj133-70035-h-a5
Engine controlModule (ecm)
Pump 2-high pressure fuel
HIGH_PRESS_FUEL_PUMP_CTRL_2+
HIGH_PRESS_FUEL_PUMP_CTRL_2-
HIGH_PRESS_FUEL_PUMP_CTRL_1+
HIGH_PRESS_FUEL_PUMP_CTRL_1-
OP
OP
OP
OP
C1E117/77
C1E117/53
C1E117/76
C1E117/52
GN-BU
1
WH-BN
1
YE-GY
1
GY-OG
1
C1E515/1
C1E515/2
C1E515A/1
C1E515A/2
PUMP_SUPPLY_2
PUMP_RTN_2
Pump 1-high pressure fuel
PUMP_SUPPLY_1
PUMP_RTN_1
XF - S20753 > (1a) 18
x
Page 35
303-14E - ELECTRONIC ENGINE CONTROLS - PV8 (5.0L) Sensors - Part 1
Sensors - Part 1
phcr83-70034-b-a4
Junction-box engine
B+
F43
5A/10A MINI
F41
5A/10A MINI
F36
20A/15A MINI
HIGH CURRENT
PETROL/DIESEL
EMS
RELAY
RLY16
EMS_SUPPLY_3
EMS_SUPPLY_1
EMS_SUPPLY_5
EMS_SUPPLY_5_FUSE
EMS_FUSES
EMS_FUSE_SUPPLY
EMS_RLY_CTRL
EMS_RLY_COIL
EMS_RLY_SUPPLY
C1BB01B/65
C1BB01B/61
C1BB01B/50
C1BB01B/62
C1BB01B/P5
C1BB01B/P2
C1BB01B/P1
C1BB01B/P3
GY
1
BU
1
BU-BN
1
GY
0
GY
0
GY
0
RD
0
RD
0
EN_RX*EM_N:EN_RY*EM_N
EN_RX:EN_RY
EN_RX:EN_RY
EN_RX:EN_RY:EN_SU
EN_RX:EN_RY:EN_SU:EN_KN
EN_RX:EN_RY:EN_SU:EN_KN
SPL792
SPL862
SPL858
SPL083
GY
1
EN_RX*EM_N:EN_RY*EM_N
BU-BN
1
BU-BN
1
GY-VT
1
EN_RX:EN_RY
EN_RX:EN_RY
EN_RX:EN_RY
C1E120B/46
C1E120B/5C1BB01B/51
C1E120B/6
C1E120B/15
Engine controlModule (ecm)
AP5V
AP1
AP-
5VREF+
AP2
AP2-
B+
ETB_MOTOR_POWER
B+
ECM_POWER_1
B+
ECM_POWER_2
LOW_PRESS_FUEL_PRESS_SENSOR
B_BANK_SENSOR_GND_2
OP
EMS_MAIN_RLY
AMBIENT_TEMP_SENSOR
IP
GREF
IP
C1E120B/32
C1E120B/25
C1E120B/12
C1E120B/31
C1E120B/26
C1E120B/13
C1E120B/18
C1E120B/4
C1E120B/29
C11-P/5
GN-OG
1
YE-OG
1
VT-GN
1
BU-GY
1 1
BU-WH
1
YE-GN
1
GN-WH
1
BN-VT
1 1
BN-VT
1
YE-GN
1
EN_RX:EN_RY
EN_RX:EN_RY
EN_RX:EN_RY
EN_RX:EN_RY
EN_RX:EN_RY
EN_RX:EN_RY
EN_RX:EN_RY
EN_RX:EN_RY
EN_RX:EN_RY
EN_RX:EN_RY
Refer to sensors
C13-E/11
C13-E/4
BN-VT
1
YE-GN
278
SPL860
SPL861
DR_B
DR_B
A
BU-GY
BU-GY
1
BN-VT
C3A-A/15
C3A-A/16
EN_RX:EN_RY
EN_RX:EN_RY
EN_RX:EN_RY
BK
1
BK
744
DR_B
DR_B
C2E818A/1
C2E818A/2
C2E818A/3
C2E818A/6
C2E818A/5
C2E818A/4
C1E830/3
C1E830/2
C1E830/1
CAPM26/11
CAPM26/10
B
Sensor-positionAccelerator pedal
VREF_1
DEMAND_1
GND_1
VREF_2
DEMAND_2
GND_2
Sensor-low fuelPressure
+5V
VOUT
GND
Sensor-ambient air
Temperature
(part of lh door mirror assembly)
AMBIENT_AIR_SIG
AMBIENT_AIR_SIG_GND
F9
50A A1
F26
10A MINI
EMS_POWER_FUSE
TCM_EMS_POWER
TAP1_1
TAP1_2
C1BB01B/13
C1BB01B/74
C1BB01B/75
C1BB01B/32
RD
0
RD
1
YE-RD
28
SPL310
YE-RD
1
EN_RX:EN_RY
C1E120B/43
B+
BATTERY
POWER_GND_1
POWER_GND_2
POWER_GND_3
P
P
P
C1E120B/1
C1E120B/2
C1E120B/3
BK
1
BK
1
BK
1
EN_RX:EN_RY
EN_RX:EN_RY
EN_RX:EN_RY
G1D108/1
A
C13-E/11
C13-E/4
BN-VT
1
YE-GN
278
DR_D
DR_D
RHD
C3B-A/15
C3B-A/16
BK
1
BK
744
DR_D
DR_D
B
CBPM31/11
CBPM31/10
XF - S20753 > (1a) 19
x
Page 36
303-14E - ELECTRONIC ENGINE CONTROLS - PV8 (5.0L) Sensors - Part 2
Sensors - Part 2
phaj133-70035-j-a5
Engine controlModule (ecm)
OIL_QUALITY_SENSOR
OIL_QUALITY_SENSOR_GND
INLET_AIR_TEMP_SENSOR_A
MAF_SENSOR_A_GND
IP
GREF
OP
MAF_SENSOR_A
GREF
IP
C1E117/63
C1E117/22
C1E117/82
C1E117/70
C1E117/15
BU-OG
1
GY-YE
1
BK-RD
2100
BK-GN
2100
BK-BU
2100
BK-OG
1595
BK
1
C1E717/3
C1E717/2
Sensor-oil temperatureLevel
SIG
GND
Sensor-maf/iat-bank 1
C1E807/3
C1E807/1
C1E807/5
C1E807/4
C1E807/2
PWR
IAT_OUTPUT
MAF_SENSOR_OUTPUT
MAF_SENSOR_GND
IAT_SENSOR_GND
VREF
C1E717/1
BK-OG
1595
PIS15
BK-OG
1595
JAG
C11-P/5
Refer to engine junction box
INLET_AIR_TEMP_SENSOR_B
IP
OP
MAF_SENSOR_B
GREF
MAF_SENSOR_B_GND
GREF
AIR_TEMP_SENSOR_GND
IP
KNOCK_SENSOR_1A_+
GREF
KNOCK_SENSOR_1A_GND
IP
KNOCK_SENSOR_1B_+
GREF
KNOCK_SENSOR_1B_GND
IP
KNOCK_SENSOR_2A_+
GREF
KNOCK_SENSOR_2A_GND
C1E117/39
C1E117/71
C1E117/16
C1E117/14
C1E117/42
C1E117/18
C1E117/43
C1E117/19
C1E117/44
C1E117/20
BK-RD
2100
BK-GN
2100
BK-BU
2100
BK
1
VT-OG
1067
WH-BN
1067
BN-BU
1067
BN-GN
1067
VT
1067
WH
1067
PIS10
C11-A/1
C11-A/2
C11-A/3
C11-A/4
C11-A/5
C11-A/6
BK-OG
2026
BK
1
VT-OG
1067
WH-BN
1067
BN-BU
1067
BN-GN
1067
VT
1067
WH
1067
Sensor-maf/iat-bank 2
C1E808/3
C1E808/1
C1E808/5
C1E808/4
C1E808/2
PWR
IAT_OUTPUT
MAF_SENSOR_OUTPUT
MAF_SENSOR_GND
IAT_SENSOR_GND
Sensor-knock-bank 1-front
C1E801/1
SENSOR
C1E801/2
GND
Sensor-knock-bank 1-rear
VL002/1
SENSOR
VL002/2
GND
Sensor-knock-bank 2-front
C1E802/1
SENSOR
C1E802/2
GND
XK
C11-P = PI041
C11-P = C11-PXF - XJ
KNOCK_SENSOR_2B_+
IP
GREF
KNOCK_SENSOR_2B_GND
C1E117/45
C1E117/21
BU
1067
GN
1067
C11-A/7
C11-A/8
BU
1067
GN
1067
Sensor-knock-bank 2-rear
VL004/1
SENSOR
VL004/2
GND
XF - S20753 > (1a) 20
x
Page 37
303-14E - ELECTRONIC ENGINE CONTROLS - PV8 (5.0L) Sensors - Part 3
Sensors - Part 3
phaj133-70035-b-a5
Engine controlModule (ecm)
COOLANT_TEMP_SENSOR_GND
IP
IP
COOLANT_TEMP_SENSOR
IP
COOLANT_TEMP_SENSOR_2
C1E117/13
C1E117/68
C1E117/40
BN-GN
431
YE
1326
YE
1326
PIS43
BN-GN
431
BN-GN
431
Sensor 1-engine coolant
Temperature (ect) - pv8
C1E716/2
C1E716/1
C1E716A/2
C1E716A/1
GND
SIG
Sensor 2-engine coolant
Temperature (ect)-pv8
GND
SIG
XF - S20753 > (1a) 21
x
Page 38
303-14E - ELECTRONIC ENGINE CONTROLS - PV8 (5.0L) Sensors - Part 4
Sensors - Part 4
phaj133-70035-c-a5
Engine controlModule (ecm)
GREF
MAP_SENSOR_GND
IP
TMAP_PRESS_SENSOR
IP
TMAP_TEMP_SENSOR
C1E117/23
C1E117/37
C1E117/83
WH-BN
1
BU-GY
1
GY-OG
1
EN_RY
EN_RY
GN-BN
1
EN_RY
C1E804/4
C1E804/3
C1E804/2
Sensor-temperature and manifoldAbsolute pressure (tmap)
SIG
VREF
TEMP
GND
C1E804/1
WH-BN
1
EN_RY
PIS29
SENSOR_5V_SUPPLY
VREF
IP
MAP_SENSOR
IP
FUEL_HIGH_PRESS_SENSOR
GREF
FUEL_HIGH_PRESS_SENSOR_GND
IP
LOW_PRESS_FUEL_PRESS_SENSOR
C1E117/47
C1E117/69
C1E117/38
C1E117/17
GN-BN
1
GY
1
BU
1
BU-BN
1
PIS30
GN-BN
1
GN-BN
1
C1E803/1
C1E803/3
C1E727/2
C1E727/3
Sensor-manifold absolutePressure (map)
VREF
SIG
Sensor-fuel railPressure
SIG
VREF
GND
GND
C1E803/2
C1E727/1
WH-BN
1
XF - S20753 > (1a) 22
x
Page 39
303-14E - ELECTRONIC ENGINE CONTROLS - PV8 (5.0L) Sensors - Part 5
Sensors - Part 5
phaj133-70035-d-a5
Engine controlModule (ecm)
Sensor-camshaft position-
CAM_SENSOR_A_SUPPLY
OP
IP
CAM_IN_SENSOR_A
IP
CAM_EX_SENSOR_A
GREF
CAM_SENSOR_A_GND
C1E117/10
C1E117/33
C1E117/31
C1E117/9
GN-VT
1
BN
1
WH-GN
1
YE-VT
1
PIS08
PIS07
GN-VT
1
YE-VT
1
GN-VT
1
YE-VT
1
Bank 1-inlet
C1E706/1
PWR_5V
C1E706/3
SENSOR
C1E706/2
GND
Sensor-camshaft positionBank 1-outlet
C1E706A/1
C1E706A/3
C1E706A/2
PWR_5V
SENSOR
GND
Unit-electric throttle
VREF
POT_1
GND
POT_2
MOTOR_NEG
MOTOR_POS
C1E137/2
C1E137/4
C1E137/5
C1E137/6
YE
1792
BN
1792
BU-OG
1792
GN-VT
1792
BU-GN
1792
YE-VT
1792
C1E117/46
C1E117/65C1E137/1
C1E117/66
C1E117/67C1E137/3
C1E117/72
C1E117/96
CAM_SENSOR_B_SUPPLY
VREF
TPS_5V_FEED
IP
THROTTLE_POSITION_SENSOR_1
GREF
THROTTLE_POSITION_SENSOR_GND
IP
THROTTLE_POSITION_SENSOR_2
OP
THROTTLE_MOTOR_-
OP
THROTTLE_MOTOR_+
CAM_IN_SENSOR_B
CAM_EX_SENSOR_B
CAM_SENSOR_B_GND
CRANK_SENSOR
CRANK_SENSOR_GND
OP
GREF
GREF
IP
IP
IP
C1E117/7
C1E117/34
C1E117/32
C1E117/8
C1E117/30
C1E117/6
PIS42
PIS31
PIS06
WH-RD
2839
SCR
2839
BN-BU
1 1
VT
1
YE-BU
1
GN-BN
1
BN-RD
2839
BK
100
BN-BU
GN-BN
1
BN-BU
1
GN-BN
1
PIU01
Sensor-camshaft positionBank 2-inlet
C1E707/1
PWR_5V
C1E707/3
SENSOR
C1E707/2
GND
Sensor-camshaft positionBank 2-outlet
C1E707A/1
C1E707A/3
C1E707A/2
C1E711/1
C1E711/2
PWR_5V
SENSOR
GND
Sensor-crankshaftPosition (ckp)
SENSOR
GND
XF - S20753 > (1a) 23
x
Page 40
303-14E - ELECTRONIC ENGINE CONTROLS - PV8 (5.0L) Emissions - Part 1
Emissions - Part 1
phcr83-70035-b-a4
Junction-box engine
B+
FULL ISO
HEGO
RELAY
RLY8
F4
20A A1
F3
20A A1
F9
50A A1
HEGO_RELAY_CTRL
HEGO_RELAY_OUT
HEGO_RELAY_COIL
HEGO_RELAY_SUPPLY
TAP3_1
HEGO_B_HEATERS
HEGO_B_FUSE
HEGO_A_HEATERS
HEGO_A_FUSE
EMS_POWER_FUSE
C1BB01B/H1
C1BB01B/H5
C1BB01B/H2
C1BB01B/H3
C1BB01B/76
C1BB01B/8
C1BB01B/7
C1BB01B/6
C1BB01B/5
C1BB01B/13
YE-VT
2199
VT
0
BK
0
RD
1
VT
2135
VT
0
GY
2141
VT
0
RD
0
EN_RX:EN_RY:EN_WD
EN_RX:EN_RY:EN_WD
EN_RX:EN_RY:EN_WD
EN_RX:EN_RY:EN_WD
EN_RX:EN_RY:EN_WD
EN_RX:EN_RY:EN_WD
EN_RX:EN_RY:EN_WD
EN_RX:EN_RY:EN_WD
SPL792
SPL291
G1D123/1
C3BP01E/15
Engine controlModule (ecm)
OX_SENSOR_A_GND
Junction box-central
B+
B+
OP
FPDB_IGNITION_CTRL
OP
UHEGO_RLY_CTRL
OP
HTR_HEGO_A
HEGO_SENSOR_A
C1E120B/47
C1E120B/7
C1E120B/20
MS_CAN_IN_POS
MS_CAN_IN_NEG
MS_CAN_OUT_POS
MS_CAN_OUT_NEG
WH-OG
1
GN
1
YE-GN
1
C+
C-
C+
C-
SYSTEM_GND
EN_RX:EN_RY
EN_RX:EN_RY
EN_RX:EN_RY
P
C3BP01C/7
MS CAN BUS
MS CAN BUS
BK
1
C11-P/9
C11-P/1
C11-P/14
C11-P/26
C11-P/25
G3D138/1
Refer to emissions part 2
F36
20A/15A MINI
HIGH CURRENT
PETROL/DIESEL
EMS
RELAY
RLY16
10A MINI
EMS_SUPPLY_5_FUSE
F26
EMS_SUPPLY_5
EMS_FUSE_SUPPLY
EMS_RLY_CTRL
EMS_RLY_COIL
EMS_RLY_SUPPLY
TCM_EMS_POWER
TAP1_2
TAP1_1
C1BB01B/50
C1BB01B/P5
C1BB01B/P2
C1BB01B/P1
C1BB01B/P3
C1BB01B/32
C1BB01B/75
C1BB01B/74
BU-BN
1
GY
0
GY
0
RD
0
RD
0
YE-RD
28
RD
1
EN_RX:EN_RY
EN_RX:EN_RY:EN_SU
EN_RX:EN_RY:EN_SU:EN_KN
SPL862
SPL083
SPL310
BU-BN
1
BU-BN
1
GY-VT
1
YE-RD
1
EN_RX:EN_RY
EN_RX:EN_RY
EN_RX:EN_RY
EN_RX:EN_RY
C1E120B/5C1BB01B/51
C1E120B/6
C1E120B/15
C1E120B/43
B+
ECM_POWER_1
B+
ECM_POWER_2
OP
EMS_MAIN_RLY
B+
BATTERY
OP
HTR_HEGO_B
OX_SENSOR_B_GND
HEGO_SENSOR_B
POWER_GND_1
POWER_GND_2
POWER_GND_3
P
P
P
C1E120B/48
C1E120B/8
C1E120B/21
C1E120B/1
C1E120B/2
C1E120B/3
BU-WH
1
WH-GN
1
WH
1
BK
1
BK
1
BK
1
EN_RX:EN_RY
EN_RX:EN_RY
EN_RX:EN_RY
EN_RX:EN_RY
EN_RX:EN_RY
EN_RX:EN_RY
C11-P/15
C11-P/10
C11-P/16
G1D108/1
XF - S20753 > (1a) 24
x
Page 41
303-14E - ELECTRONIC ENGINE CONTROLS - PV8 (5.0L) Emissions - Part 2
Emissions - Part 2
phaj133-70035-e-a5
Engine controlModule (ecm)
Sensor-oxygen-oddPre-catalyst
HTR_CTRL_A_UPSTREAM
UHEGO_A_CONSTANT
UHEGO_A_VARIABLE
OP
IP
IP
GN-BN
2633
VT-GN
2633
YE-GN
2633
C1E735/2C1E117/48
CTRL
C1E735/3C1E117/11
CONSTANT
C1E735/4C1E117/35
VARIABLE
C1E735/1
IGN
t
GY
298
JAG
PIS11
GY
2405
JAG
C11-P/1
Refer to engine junction box
HTR_CTRL_B_UPSTREAM
UHEGO_B_CONSTANT
UHEGO_B_VARIABLE
OP
IP
IP
Refer to emissions - part 1
Refer to emissions - part 1
C11-P/14
C11-P/26
C11-P/25
C11-P/15
C11-P/10
C11-P/16
WH-OG
2668
YE-GN
2668
GN
2668
GY-VT
2724
WH-BU
2724
VT-BN
2724
BU-WH
2754
WH
2754
WH-GN
2754
JAG
JAG
JAG
JAG
JAG
JAG
Sensor-oxygen-oddPost catalyst
C1E731/2
CTRL
C1E731/3
RTN
C1E731/4
SIGNAL
Sensor-oxygen-evenPre-catalyst
C1E737/2C1E117/24
CTRL
C1E737/3C1E117/12
CONSTANT
C1E737/4C1E117/36
VARIABLE
Sensor-oxygen-evenPost catalyst
C1E733/2
CTRL
C1E733/3
RTN
C1E733/4
SIGNAL
C1E731/1
IGN
t
C1E737/1
IGN
GY
333
VT
258
JAG
JAG
PIS22
VT
2536
JAG
C11-P/9
Refer to engine junction box
t
C1E733/1
IGN
t
VT
288
JAG
XK
C11-P = PI041
C11-P = C11-PXF - XJ
XF - S20753 > (1a) 25
x
Page 42
303-14E - ELECTRONIC ENGINE CONTROLS - PV8 (5.0L) Coolant pump - PV8SC
Coolant pump - PV8SC
phcr83-70031-b-a4
Engine controlModule (ecm)
Junction-box engine
F41
5A/10A MINI
F36
20A/15A MINI
HIGH CURRENT
PETROL/DIESEL
EMS
B+
RELAY
RLY16
F9
50A A1
F26
10A MINI
1/2 ISO
S/CHARGED
WATERPUMP
RELAY
RLY18
F40
MINI
15A
EMS_SUPPLY_1
EMS_SUPPLY_5
EMS_SUPPLY_5_FUSE
EMS_FUSES
EMS_FUSE_SUPPLY
EMS_RLY_CTRL
EMS_RLY_COIL
EMS_RLY_SUPPLY
EMS_POWER_FUSE
TCM_EMS_POWER
SC_PMP_RLY_OUT
SC_PMP_RLY_CTRL
SC_WATER_PMP_RLY_COIL
SC_WATER_PMP_RLY_SUPPLY
SC_WATER_PUMP
SC_WATER_PUMP_SUPPLY
C1BB01B/61 C1E120B/46
C1BB01B/51
C1BB01B/50
C1BB01B/62
C1BB01B/P5
C1BB01B/P2 C1E120B/15
C1BB01B/P1
C1BB01B/P3
C1BB01B/13
C1BB01B/75
TAP1_2
C1BB01B/74
TAP1_1
C1BB01B/R5
C1BB01B/R2
C1BB01B/R1
C1BB01B/R3
C1BB01B/58
C1BB01B/59 C1E318B/2C11-R/6 C1E318B/1 C11-R/4
BU-BN
1
GY
0
GY
0
GY
0
RD
0
RD
0
RD
0
YE-RD
28
RD
1
VT-RD
0
GY
0
RD
0
YE-GN
708
EN_RX:EN_RY
EN_RX:EN_RY:EN_SU
EN_RX:EN_RY:EN_SU:EN_KN
EN_RX:EN_RY:EN_SU:EN_KN
SPL792
EN_RY
EN_RY
EN_RY
EN_RY
SPL083
SPL862
SPL310
BU
1
BU-BN
1
BU-BN
1
GY-VT
1
YE-RD
1
BN
1
YE-GN
140
EN_RX:EN_RY
EN_RX:EN_RY
EN_RX:EN_RY
EN_RX:EN_RY
EN_RX:EN_RY
EN_RY
EN_RY
C1E120B/5
C1E120B/6
C1E120B/43C1BB01B/32
C1E120B/35
B+
ETB_MOTOR_POWER
B+
ECM_POWER_1
B+
ECM_POWER_2
OP
EMS_MAIN_RLY
B+
BATTERY
POWER_GND_1
POWER_GND_2
OP
IC_COOLANT_PMP_CTRL
Pump-coolantAir charge
POWER_GND_3
C+
HS_CAN_POS
C+
HS_CAN_NEG
P
P
P
HS CAN BUS
C1E120B/1
C1E120B/2
C1E120B/3
BK
54
BK
1
BK
1
BK
1
EN_RY
EN_RX:EN_RY
EN_RX:EN_RY
EN_RX:EN_RY
BK
1
G1D108/1
EN_RY
G1D131/1
XF - S20753 > (1a) 26
x
Page 43
303-14B - ELECTRONIC ENGINE CONTROLS - DV6 (3.0L) Vehicle interface - Part 1
303-14B - ELECTRONIC ENGINE CONTROL S - DV6 (3.0L)Vehicle interface - Part 1
phtdv6-70032-a
Clutch-compressor-airConditioning (a/c)
POS
C1H401A/1
VT-WH
2090
C11-A/12
Refrigerant solenoid
Valve
C1H401/2
NEG
C1H401/1
POS
Switch-oil pressure
C1MC24/1
SIGNAL
Starter motor
GND
MOTOR
SOLENOID
Generator
BATT
C1DC73A/1
C1DC74A/1
LIN
GND
BK-GN
2350
VT-WH
2350
GY
1520
GY-OG
2250
BU-BN
2090
C11-A/42
C11-A/36
C11-A/16
C11-A/34
C11-A/24
Refer to climate control
Refer to instrument cluster
Refer to dv6 - starting
Refer to dv6 - charging
Tcm and control valve body
B+
BATTERY
B+
IGNITION
K_LINE
C
LIN
OP
PARK
C-
HS_CAN_NEG
C+
HS_CAN_POS
P
GND_2
P
GND_1
Refer to transmission
C11-B/8
C11-C/9
C11-B/5
C11-B/16
C11-B/6
C11-B/2
C11-B/1
C11-B/13
C11-B/9
OG-BK
1440
OG-GY
1440
GY
1440
BN-VT
1400
GN-OG
1400
130
WH-BU
160
OG
1270
OG
1270
C11-A/31
C11-A/13
C11-A/22
C11-A/35
C11-A/6
S5
S6
WHWH
1450
WH-BU
1410
C11-A/21
C11-A/20
Refer to transmission
C11-A = C11-P
C11-B = C11-N
C11-C = C11-M
WH-BU
1410
WH
1450
OG
S2
150
C11-A/17
C11-A/18
C11-A/7
x
XF - S20753 > (1a) 27
Page 44
303-14B - ELECTRONIC ENGINE CONTROLS - DV6 (3.0L) Vehicle interface - Part 2
Vehicle interface - Part 2
phtdv6-70032-b
Engine controlModule (ecm)
LPTR_A
LPV_A
LPC_A
LPPC_A
IP
FUEL_DIVERTER_SOL
CCCOT_B
C1E116A/83
C1E116A/84
C1E116A/61
C1E116A/60
C1E116A/21
C1E116A/30
GY-BU
1400
GY-OG
1540
GY-VT
1540
GN
1540
BU-BN
1540
OG-BK
430
YE-GY
1440
C11-A/3
C11-B/11
C11-B/10
C11-B/7
C11-B/15
C11-B/4
C11-A/38
C11-C/4
Refer to engine junction box
Refer to emissions part 2
Not used
SENSOR_GND_11
SENSOR_GND_13
LPPH_A
PFOT
CCCIT_B
SENSOR_GND_22
PFIT
STOT
SENSOR_GND_10
C1E116A/29
C1E116A/38
C1E116A/22
C1E116A/37
C1E116A/81
C1E116A/77
C1E116A/79
C1E116A/86
C1E116A/78
OG-BU
1100
OG-GN
1440
OG-GY
1440
WH-OG
1440
YE-OG
1440
BN
1440
WH-BN
1440
VT-OG
1440
GY-VT
1440
S8
OG-BU
350
C11-C/5
C11-C/8
C11-C/12
C11-C/11
C11-C/1
C11-C/3
C11-C/6
C11-C/7
C11-C/2
Refer to emissions part 2
C11-A = C11-P
C11-B = C11-N
C11-C = C11-M
OG-BU
1040
C1E755/2
Sensor-temperatureAir charge
XF - S20753 > (1a) 28
x
Page 45
303-14B - ELECTRONIC ENGINE CONTROLS - DV6 (3.0L) Vehicle interface - Part 3
Vehicle interface - Part 3
phtdv6-70032-c
Refer to emissions - part 1
Sensor-differential pressure
VREF
PRESS
C11-B/3
C11-B/14
BU-WH
1400
VT
1400
C11-A/32
C11-A/33
Refer to emissions - part 1
GND
C11-B/12
BK
110
BK
110
BK
110
BK
110
BK
110
BU-OG
1400
C11-A/29
C11-A/8
C11-A/9
C11-A/28
C11-A/30
C11-A/27
C11-A/39
C11-A/19
C11-A/23
C11-A/11
Not used
Not used
Not used
Not used
Not used
Not used
Not used
Not used
Not used
BLIND_END
BK
110
BK
110
BK
130
C11-A/37
C11-A/25
C11-A/26
C11-A/2
C11-A/41
C11-A/14
Not used
Not used
Not used
Not used
Not used
Not used
C11-A = C11-P
C11-B = C11-N
C11-C = C11-M
XF - S20753 > (1a) 29
x
Page 46
303-14B - ELECTRONIC ENGINE CONTROLS - DV6 (3.0L) Sensors - Part 1
Sensors - Part 1
phtdv6-70034-a
Engine controlModule (ecm)
5V_SENSOR_SUPPLY_5
CPS
SENSOR_GND_21
CID
SENSOR_GND_20
5V_SENSOR_SUPPLY_2
RPS
SENSOR_GND_15
C1E116A/66
C1E116A/44
C1E116A/53
C1E116A/41
C1E116A/40
C1E116A/87
C1E116A/55
C1E116A/90
GY-VT
910
YE-VT
2340
BN-RD
2340
WH-GN
1800
VT
1800
GY
1720
BU-BN
1720
BU-BN
1720
S5V3/V9
GY-VT
1530
GY-VT
990
C1E711/1
C1E711/2
C1E711/3
C1E706/3
C1E706/1
C1E706/2
C1E727/3
C1E727/2
C1E727/1
Sensor-crankshaftPosition (ckp)
VA2C
CPS
GND
Sensor-camshaftPosition (cmp)
VA2D
CID
GND
Sensor-pressureFuel rail
VA1_E
PRT
RPS
GND
IFTS
SENSOR_GND_14
ACT
SENSOR_GND_10
ECT
SENSOR_GND_12
MAT
C1E116A/31
C1E116A/39
C1E116A/57
C1E116A/78
C1E116A/36
C1E116A/54
GN
1500
VT-WH
1500
YE-VT
2000
OG-BU
YE
2040
BN-GN
2040
C1E728/1
C1E728/2
C1E755/1
S8
OG-BU
10401100
OG-BU
350
C11-C/2
C1E755/2
C1E716/1
C1E716/2
SIGNAL
GND
Sensor-temperatureAir charge
SIGNAL
GND
Refer to emissions - part 1
Sensor-engine coolant
Temperature (ect) - dv6
SIGNAL
GND
C11-A = C11-P
C11-B = C11-N
C11-C = C11-M
Sensor-temperature-fuel
XF - S20753 > (1a) 30
x
Page 47
303-14B - ELECTRONIC ENGINE CONTROLS - DV6 (3.0L) Sensors - Part 2
Sensors - Part 2
phcr83-70034-d2-a4
Sensor-ambient air
Temperature
(part of lh door mirror assembly)
YE-GN
1
BN-VT
1
EN_SU
EN_SU
C1E116B/20
C1E116B/21
Engine controlModule (ecm)
GREF
SENSOR_GND_7
IP
AMBIENT_AIR_TEMP
C13-E/4
C13-E/11
A
278
1
A
C13-E/4
C13-E/11
DR_B
DR_B
YE-GN
278
BN-VT
1
DR_D
DR_D
C3A-A/16
C3A-A/15
RHD
C3B-A/16
C3B-A/15
BK
744
BK
1
BKYE-GN
744
BKBN-VT
1
DR_D
DR_D
DR_B
DR_B
CBPM31/10
CBPM31/11
CAPM26/10
CAPM26/11
AMBIENT_AIR_SIG
AMBIENT_AIR_SIG_GND
Sensor-positionAccelerator pedal
Junction-box engine
10A/20A/30A MINI
B+
F9
50A A1
F42
HIGH CURRENT
PETROL/DIESEL
EMS
RELAY
RLY16
EMS_SUPPLY_2
EMS_FUSES
EMS_FUSE_SUPPLY
EMS_RLY_CTRL
EMS_RLY_COIL
EMS_RLY_SUPPLY
EMS_POWER_FUSE
C1BB01B/63
C1BB01B/62
C1BB01B/P5
C1BB01B/P2
C1BB01B/P1
C1BB01B/P3
C1BB01B/13
GN
1
GY
0
GY
0
RD
0
RD
0
RD
0
EN_SU
EN_RX:EN_RY:EN_SU:EN_KN
EN_RX:EN_RY:EN_SU:EN_KN
SPL792
SPL862
SPL863
GN
1
GN
1
GY-VT
1
EN_SU
EN_SU
EN_SU
HS CAN BUS
C1E116B/3
C1E116B/5
C1E116B/55
SENSOR_SUPPLY_8
PED_DEMAND_1
SENSOR_GND_8
SENSOR_SUPPLY_9
C+
HS_CAN_POS
C-
HS_CAN_NEG
B+
SWITCHED_SUPPLY_1
B+
SWITCHED_SUPPLY_2
OP
EMS_RELAY_CTRL
PED_DEMAND_2
SENSOR_GND_9
SCOP_SENSOR
POWER_GND_4
POWER_GND_3
POWER_GND_2
POWER_GND_1
VREF
GREF
VREF
GREF
IP
IP
IP
P
P
P
P
C1E116B/23
C1E116B/35
C1E116B/36
C1E116B/22
C1E116B/48
C1E116B/49
C1E116B/50
C1E116B/6
C1E116B/4
C1E116B/2
C1E116B/1
GN-OG
1
YE-OG
1
VT-GN
1
BU-GY
1
BU-WH
1
YE-GN
1
BK
409
BK
409
BK
417
BK
417
EN_SU
EN_SU
EN_SU
EN_SU
EN_SU
EN_SU
EN_SU
EN_SU
EN_SU
EN_SU
SPL865
SPL864
BU-GY
1
YE-GN
1
BU-GY
1
YE-GN
1
YE-GN
1
EN_SU
EN_SU
EN_SU
EN_SU
EN_SU
C11-P/10
C11-P/40
C11-P/15
C2E818A/1
C2E818A/2
C2E818A/3
C2E818A/6
C2E818A/5
C2E818A/4
VREF_1
DEMAND_1
GND_1
VREF_2
DEMAND_2
GND_2
Refer to sensors
C11-P = C11-A
C11-N = C11-B
C11-M = C11-C
G1D108/1
XF - S20753 > (1a) 31
x
Page 48
303-14B - ELECTRONIC ENGINE CONTROLS - DV6 (3.0L) Sensors - Part 3
Sensors - Part 3
phtdv6-70034-b
Engine controlModule (ecm)
Sensor-throttlePosition (tp)
SENSOR_GND_5
TPA_POS
TPA_NEG
TPS
5V_SENSOR_SUPPLY_4
MAP
SENSOR_GND_4
C1E116A/17
C1E116A/72
C1E116A/96
C1E116A/56
C1E116A/65
C1E116A/80
C1E116A/14
YE
YE-VT
1910
GN-VT
1910
BN
1910
GY
S4
1910
YE
12201030
YE
900
BU-GN
1590
BN-GN
1590
C1E818/1
C1E818/3
C1E818/4
C1E818/2
C1E818/6
C1E803/3
C1E803/2
C1E803/1
SGD
TPA+
TPA-
TPS_1
VA2_B
Sensor-manifold absolutePressure (map)
VA1_B
MAP
GND
PRT
EGR_A_NEG
EGR_A_POS
5V_SENSOR_SUPPLY_1
EVP_A
SENSOR_GND_3
EGR_B_NEG
EGR_B_POS
EVP_B
VGT_NEG
VGT_POS
5V_SENSOR_SUPPLY_6
VGT_FB
SENSOR_GND_19
C1E116A/92
C1E116A/93
C1E116A/64
C1E116A/82
C1E116A/5
C1E116A/94
C1E116A/95
C1E116A/7
C1E116A/48
C1E116A/24
C1E116A/67
C1E116A/15
C1E116A/42
BN-WH
760
BU-OG
1060
Actuator-egr-bank 1
BU-GN
1730
VE-VT
S3
1730
BN-WH
990
VE-VT
1730
BU-OG
1070
C1E720A/1
NEG
C1E720A/5
POS
C1E720A/6
5V
C1E720A/2
SIG
C1E720A/4
RTN
Actuator-egr-bank 2
BU-GN
1660
VE-VT
1660
BN-WH
910
VE-VT
1660
BU-OG
610
BU
2460
WH
2460
BU-WH
2230
WH-OG
2230
GY
2230
C1E720B/5
C1E720B/1
C1E720B/6
C1E720B/2
C1E720B/4
C1E814B/2
C1E814B/1
C1E814B/5
C1E814B/4
C1E814B/3
NEG
POS
5V
SIG
RTN
Actuator-vane vgt
VGT-
VGT+
5V
SIG
RTN
C11-A = C11-P
C11-B = C11-N
C11-C = C11-M
XF - S20753 > (1a) 32
x
Page 49
303-14B - ELECTRONIC ENGINE CONTROLS - DV6 (3.0L) Sensors - Part 4
Sensors - Part 4
phtdv6-70034-c
Sensor-boost air pressure
SUPPLY
SIG
RTN
C1A233/1
C1A233/2
C1A233/3
OG-BU
1900
OG-YE
1900
OG
1900
C11-A/40
C11-A/15
C11-A/10
Refer to sensors
Engine controlModule (ecm)
OTL
SENSOR_GND_18
5V_SENSOR_SUPPLY_8
SENSOR_GND_16
TSVF
C1E116A/45
C1E116A/19
C1E116A/89
C1E116A/68
C1E116A/12
OG-BK
2360
BU-OG
2360
GY-YE
2360
YE
1460
VT-BN
1460
GY
1460
C11-A/5
Sensor-oil temperatureLevel
C1E717/1
C1E717/3
C1E717/2
C1E437/2
C1E437/1
C1E437/3
SUPPLY
SIG
GND
Sensor-valve positionTurbine intake
SUPPLY
RTN
SIG
Refer to engine junction box
C11-A = C11-P
C11-B = C11-N
C11-C = C11-M
XF - S20753 > (1a) 33
x
Page 50
303-14B - ELECTRONIC ENGINE CONTROLS - DV6 (3.0L) Actuators - Part 1
Actuators - Part 1
phtdv6-70038-a
Engine controlModule (ecm)
Valve-controlFuel pressure
S11
OG-WH
1140
C11-A/4
Refer to engine junction box
PCV
MEU
INJ_1_PWR_OUT_HIGH
INJ_1_PWR_OUT_LOW
C1E116A/91
C1E116A/46
C1E116A/73
C1E116A/49
BU-GY
1690
BN-YE
1550
GN-BU
1750
YE-BU
1750
C1A102/1C1A102/2
PWRPCV
Valve-controlFuel volume
C1A101/1 C1A101/2
PWRVCV
Fuel injector-no.1
C1E205/2
C1E205/1
INJ_HI
INJ_LOW
OG-WH
1110
OG-WH
130
INJ_2_PWR_OUT_HIGH
INJ_2_PWR_OUT_LOW
INJ_3_PWR_OUT_HIGH
INJ_3_PWR_OUT_LOW
INJ_4_PWR_OUT_HIGH
INJ_4_PWR_OUT_LOW
INJ_5_PWR_OUT_HIGH
INJ_5_PWR_OUT_LOW
C1E116A/74
C1E116A/50
C1E116A/75
C1E116A/51
C1E116A/25
C1E116A/1
C1E116A/26
C1E116A/2
GN-YE
1860
BU-OG
1860
VT-GY
1970
GN-VT
1970
BN
1500
WH-GN
1500
GN-WH
1400
BN-VT
1400
C1E206/2
C1E206/1
C1E207/2
C1E207/1
C1E208/2
C1E208/1
C1E209/2
C1E209/1
Fuel injector-no.2
INJ_HI
INJ_LOW
Fuel injector-no.3
INJ_HI
INJ_LOW
Fuel injector-no.4
INJ_HI
INJ_LOW
Fuel injector-no.5
INJ_HI
INJ_LOW
C11-A = C11-P
C11-B = C11-N
C11-C = C11-M
Fuel injector-no.6
INJ_6_PWR_OUT_HIGH
INJ_6_PWR_OUT_LOW
C1E116A/27
C1E116A/3
GY-BN
1310
BU-WH
1310
C1E210/2
INJ_HI
C1E210/1
INJ_LOW
XF - S20753 > (1a) 34
x
Page 51
303-14B - ELECTRONIC ENGINE CONTROLS - DV6 (3.0L) Actuators - Part 2
Actuators - Part 2
phtdv6-70038-b
Engine controlModule (ecm)
Solenoid-boost air
Recirculation
S1
OG-GY
170
C11-A/1
Refer to engine junction box
CRV
CSOV
C1E116A/71
C1E116A/69
GN-VT
2560
GN-BU
1850
C1E112/2
C1E114/2
PWRSIG
Solenoid-boost air
PWRSIG
C1E112/1
C1E114/1
OG-GY
2410
OG-GY
1700
TSOV
EGRCBV
C1E116A/47
C1E116A/70
YE-BU
1910
YE-GY
1200
C1E435/2
C1E743/2
SolenoidTurbine intake
PWRSIG
SolenoidEgr cooling bypass
PWRSIG
C1E435/1
C1E743/1
OG-GY
1760
OG-GY
1050
C11-A = C11-P
C11-B = C11-N
C11-C = C11-M
XF - S20753 > (1a) 35
x
Page 52
303-14B - ELECTRONIC ENGINE CONTROLS - DV6 (3.0L) Actuators - Part 3
Actuators - Part 3
phcr83-70037-d2-a4
Ecu-glow plug
Junction-box engine
B+
F18
60A A3
GLOWPLUG_MODULE
C1BB01B/22
SPL870
SPL890
BN-RD
1
BU-BN
1
BK-GN
1
VT-GN
1
BN-VT
1
EN_SU
EN_SU
EN_SU
EN_SU
EN_SU
C1E513A/5
C1E513A/4
C1E513A/3
C1E513A/1
C1E513A/2
BATT
IGN_SUPPLY
GND
DIAGNOSTIC
CTRL
PLUG1
PLUG2
PLUG3
PLUG4
PLUG5
PLUG6
C1E513B/3
C1E513B/1
C1E513B/4
C1E513B/6
C1E513B/2
C1E513B/5
BK-VT
1
BU-BN
1
VT-BN
1
BK-BU
1
BK-GN
1
GN-BN
1
EN_SU
EN_SU
EN_SU
EN_SU
EN_SU
EN_SU
C11-H/1
BROWN CONNECTOR
C11-H/2
BROWN CONNECTOR
C11-H/3
BROWN CONNECTOR
C11-J/3
BLACK CONNECTOR
C11-J/2
BLACK CONNECTOR
C11-J/1
BLACK CONNECTOR
Glow plug
Glow plug
Glow plug
Glow plug
Glow plug
Glow plug
F36
5A/15A/20A MINI
F42
10A/20A/30A MINI
HIGH CURRENT
PETROL/DIESEL
EMS
RELAY
RLY16
50A A1
EMS_SUPPLY_5
EMS_SUPPLY_5_FUSE
EMS_SUPPLY_2
EMS_FUSE_SUPPLY
EMS_RLY_SUPPLY
F9
EMS_POWER_FUSE
EMS_FUSES
EMS_RLY_CTRL
EMS_RLY_COIL
C1BB01B/51
C1BB01B/50
C1BB01B/63
C1BB01B/62
C1BB01B/P5
C1BB01B/P1
C1BB01B/P3
C1BB01B/13
BU-BN
1
GY
0
GN
1
GY
0
GY
0
RD
0
RD
0
RD
0
EN_SU
EN_RX:EN_RY:EN_SU
EN_SU
EN_RX:EN_RY:EN_SU:EN_KN
EN_RX:EN_RY:EN_SU:EN_KN
SPL862
SPL792
SPL863
BK-GN
1
GN
1
GN
1
GY-VT
1
EN_SU
EN_SU
EN_SU
EN_SU
C1E116B/54
C1E116B/14
C1E116B/10
C1E116B/3
C1E116B/5
C1E116B/55C1BB01B/P2
Engine controlModule (ecm)
OP
GLOWPLUG_CTRL
IP
GLOWPLUG_MONITOR_1
GREF
SENSOR_GND_6
B+
SWITCHED_SUPPLY_1
B+
SWITCHED_SUPPLY_2
OP
EMS_RELAY_CTRL
IP
IGN_SENSE
C-
HS_CAN_NEG
C+
HS_CAN_POS
POWER_GND_4
POWER_GND_3
POWER_GND_2
POWER_GND_1
P
P
P
P
HS CAN BUS
C1E116B/6
C1E116B/4
C1E116B/2
C1E116B/1
BK
409
BK
409
BK
417
BK
417
Refer to vehicle interface
EN_SU
EN_SU
EN_SU
EN_SU
G1D108/1
XF - S20753 > (1a) 36
x
Page 53
303-14B - ELECTRONIC ENGINE CONTROLS - DV6 (3.0L) Actuators - Part 4
Actuators - Part 4
phcr83-70038-d2-a4
Junction-box engine
5A/10A MINI
5A/10A/15A MINI
5A/10A MINI
10A/20A/30A MINI
B+
50A
F41
F44
F43
F42
HIGH CURRENT
PETROL/DIESEL
EMS
RELAY
RLY16
F9
A1
EMS_SUPPLY_1
EMS_SUPPLY_4
EMS_SUPPLY_3
EMS_SUPPLY_2
EMS_FUSES
EMS_FUSE_SUPPLY
EMS_RLY_CTRL
EMS_RLY_COIL
EMS_RLY_SUPPLY
EMS_POWER_FUSE
C1BB01B/61
C1BB01B/67
C1BB01B/65
C1BB01B/63
C1BB01B/62
C1BB01B/P5
C1BB01B/P2
C1BB01B/P1
C1BB01B/P3
C1BB01B/13
BU
1
VT
1
GY
1
GN
1
GY
0
GY
0
RD
0
RD
0
RD
0
EN_SU:EN_KN
EN_SU
EN_SU
EN_SU
EN_RX:EN_RY:EN_SU:EN_KN
EN_RX:EN_RY:EN_SU:EN_KN
SPL863
SPL862
SPL792
GN
1
GN
1
EN_SU
EN_SU
GY-VT
1
EN_SU
C1E116B/3
C1E116B/5
C1E116B/55
Engine controlModule (ecm)
B+
SWITCHED_SUPPLY_1
B+
SWITCHED_SUPPLY_2
OP
EMS_RELAY_CTRL
SPL869
SPL168
OP
COOLING_FAN
C-
HS_CAN_NEG
C+
HS_CAN_POS
POWER_GND_4
POWER_GND_3
POWER_GND_2
POWER_GND_1
P
P
P
P
HS CAN BUS
C1E116B/6
C1E116B/4
C1E116B/2
C1E116B/1
VT
1
GY
1
BK
409
BK
409
BK
417
BK
417
EN_SU
EN_SU
EN_SU
EN_SU
EN_SU
EN_SU
C11-P/4
C11-P/1
C11-P/5
Refer to actuators
Refer to actuators
Refer to sensors
G1D108/1
C11-P = C11-A
C11-N = C11-B
C11-M = C11-C
XF - S20753 > (1a) 37
x
Page 54
303-14B - ELECTRONIC ENGINE CONTROLS - DV6 (3.0L) Emissions - Part 1
Emissions - Part 1
phcr83-70035-d2-a4
Refer to vehicle interface
Junction-box engine
F36
20A/15A MINI
EMS_SUPPLY_5
EMS_SUPPLY_5_FUSE
C1BB01B/51
C1BB01B/50
BU-BN
1
GY
0
EN_SU
EN_RX:EN_RY:EN_SU
SPL862
HS CAN BUS
Engine controlModule (ecm)
C+
HS_CAN_POS
CHS_CAN_NEG
IP
MAFS_A
GREF
MAFS_B
IP
IP
AIR_INTAKE_TEMP
SENSOR_GND_2
C1E116B/27
C1E116B/7
C1E116B/29
C1E116B/17
BK-GN
1
BK-VT
1
BK-BU
1
BK-GY
1
EN_SU
EN_SU
EN_SU
EN_SU
SPL870
SPL868
SPL869
BU-BN
1
BU-BN
1
VT
1
BN-BU
1
BK-BU
1
BN-BU
1
EN_SU
EN_SU
EN_SU
EN_SU
EN_SU
EN_SU
C11-P/3
C1E513A/4
C11-P/1
C1E807B/4
C1E807B/1
C1E807B/2
C1E807B/3
C1E808B/4
C1E808B/1
Refer to glow plugs
Refer to actuators
Sensor-maf/iat-bank 2
SUPPLY
CONTROL
MAF_SIG
IAT_SIG
GND
Sensor-maf/iat-bank 1
SUPPLY
CONTROL
MAF_SIG
B+
F44
5A/10A/15A MINI
F42
10A/20A/30A MINI
HIGH CURRENT
PETROL/DIESEL
EMS
RELAY
RLY16
F9
50A A1
EMS_SUPPLY_4
EMS_SUPPLY_2
EMS_FUSES
EMS_FUSE_SUPPLY
EMS_RLY_CTRL
EMS_RLY_COIL
EMS_RLY_SUPPLY
EMS_POWER_FUSE
C1BB01B/67
C1BB01B/63
C1BB01B/62
C1BB01B/P5
C1BB01B/P2
C1BB01B/P1
C1BB01B/P3
C1BB01B/13
VT
1
GN
1
GY
0
GY
0
RD
0
RD
0
RD
0
EN_SU
EN_SU
EN_RX:EN_RY:EN_SU:EN_KN
EN_RX:EN_RY:EN_SU:EN_KN
SPL792
SPL863
GN
1
GN
1
GY-VT
1
EN_SU
EN_SU
EN_SU
C1E116B/3
C1E116B/5
C1E116B/55
B+
SWITCHED_SUPPLY_1
B+
SWITCHED_SUPPLY_2
SENSOR_SUPPLY_10
DPF_PRESSURE_SENSOR
OP
EMS_RELAY_CTRL
IP
IGN_SENSE
SENSOR_GND_1
VREF
GREF
POWER_GND_4
POWER_GND_3
POWER_GND_2
POWER_GND_1
IP
P
P
P
P
C1E116B/8
C1E116B/37
C1E116B/24
C1E116B/6
C1E116B/4
C1E116B/2
C1E116B/1
GY-OG
1
YE-VT
1
BN-WH
1
BK
409
BK
409
BK
417
BK
417
EN_SU
EN_SU
EN_SU
EN_SU
EN_SU
EN_SU
EN_SU
G1D108/1
BK-BU
1
C11-P/32
C11-P/33
C11-P/29
EN_SU
C1E808B/3
IAT_SIG
GND
Refer to vehicle interface
C11-P = C11-A
C11-N = C11-B
C11-M = C11-C
XF - S20753 > (1a) 38
x
Page 55
303-14B - ELECTRONIC ENGINE CONTROLS - DV6 (3.0L) Emissions - Part 2
Emissions - Part 2
phcr83-70035-d3-a4
Sensor-temperatureDpf-intake
C11-M/6
C11-M/8
C11-M/11
C11-M/1
C11-M/2
VT-BN
1
EN_SU*DPF
SPL889
VT-OG
1
VT-BN
1
YE-OG
1
VT-BN
1
BN
1
VT-BN
1
EN_SU*DPF
EN_SU*DPF
EN_SU*DPF
EN_SU*DPF
EN_SU
EN_SU
C1E747B/1
C1E747B/2
C1E748B/1
C1E748B/2
C1E710C/1
C1E710C/2
SIGNAL
GND
Sensor-temperatureDpf-outlet
SIGNAL
GND
Sensor-temperature-catalytic
Converter-upstream
SIGNAL
GND
Refer to vehicle interface
C11-M/4
C11-M/5
C11-M/7
C11-M/3
C11-N/4
C11-N/10
C11-M/12
C11-N/11
C11-N/15
C11-N/7
YE-GY
1
VT-BN
1
GY-VT
1
VT-BN
1
BU-GN
1
GY-OG
1
WH-OG
1
GY-BU
1
GN
1
GY-VT
1
EN_SU*DPF
EN_SU*DPF
EN_SU
EN_SU
EN_SU
EN_SU
EN_SU
EN_SU
EN_SU
EN_SU
C1E709C/1
C1E709C/2
C1E752B/1
C1E752B/2
C1E735B/1
C1E735B/5
C1E735B/3
C1E735B/4
C1E735B/2
C1E735B/6
Sensor-temperature-catalytic
Converter-downstream
SIGNAL
GND
SensorOutlet temperatureFixed turbocharger
SIGNAL
GND
Sensor-oxygenPre catalyst
PUMPING_CURRENT
TRIM_RESISTOR
HEATER_GND
HEATER_SUPPLY
VIRTUELLE_GND
NERNST_VOLTAGE
Sensor-differential pressure
C11-N/3
C11-N/14
C11-N/12
BU-WH
1
VT
1
BU-OG
1
EN_SU*DPF
EN_SU*DPF
EN_SU*DPF
C1E708B/3
C1E708B/1
C1E708B/2
VREF
PRESS
GND
XF - S20753 > (1a) 39
x
Page 56
303-14A - ELECTRONIC ENGINE CONTROLS - D4 Vehicle interface - Part 1
303-14A - ELECTRONIC ENGINE CONTRO LS - D4Vehicle interface - Part 1
phcr83-70031-d-a4
Junction-box engine
F41
5A/10A MINI
F44
5A/10A/15A MINI
F43
5A/10A MINI
F42
10A/20A/30A MINI
HIGH CURRENT
PETROL/DIESEL
EMS
RELAY
RLY16
B+
50A
F9
A1
EMS_SUPPLY_1
EMS_SUPPLY_4
EMS_SUPPLY_3
EMS_SUPPLY_2
EMS_FUSES
EMS_FUSE_SUPPLY
EMS_RLY_CTRL
EMS_RLY_COIL
EMS_RLY_SUPPLY
EMS_POWER_FUSE
C1BB01B/61
C1BB01B/67
C1BB01B/65
C1BB01B/63
C1BB01B/62
C1BB01B/P5
C1BB01B/P2
C1BB01B/P1
C1BB01B/P3
C1BB01B/13
BU
1
VT
1
GY
1
GN
1
GY
0
GY
0
RD
0
RD
0
RD
0
EN_SU:EN_KN
EN_KN
EN_KN
EN_KN
EN_RX:EN_RY:EN_SU:EN_KN
EN_RX:EN_RY:EN_SU:EN_KN
SPL862
SPL792
SPL894
SPL893
GN
1
GN
1
GY
1
GY-VT
1
EN_KN
EN_KN
EN_KN
EN_KN
C1E104C/2
C1E104C/5
HS CAN BUS
C1E104C/28
Engine controlModule (ecm)
B+
SUPPLY_1
ACTIVE_ENGINE_MOUNT
B+
SUPPLY_2
HS_CAN_POS
C
HS_CAN_NEG
C
BRAKE_VAC_SWITCH
OP
EMS_RLY_CTRL
OP
POWER_GND_1
POWER_GND_2
SIGNAL_GND_3
C1E104C/8
IP
P
C1E104C/4
P
C1E104C/3
P
C1E104C/53
C11-P/4
C11-P/1
C11-P/29
GN-BN
1
EN_KN
C11-P/27
Refer to vehicle interface
C11-P/19
BK
1
BK
1
BK
1
EN_KN
EN_KN
EN_KN
VT-GN
1
G1D108/1
Refer to actuators
Refer to actuators
Refer to sensors
Active engine mounting
Solenoid
Switch-brake vacuum
C1CA38A/1 C1CA38A/2
TSS
SIG
GND
BK
1
BK
1
DR_D*TSS
DR_B*TSS
G1D123/1G1D120/1
XF - S20753 > (1a) 40
x
Page 57
303-14A - ELECTRONIC ENGINE CONTROLS - D4 Vehicle interface - Part 2
Vehicle interface - Part 2
phdw12c-70031-a-a3
Starter motor
SPL008
VT-OG
830
C11-P/34
Refer to d4 - starting
Generator
C1DC71A/2
PINION
C1DC71A/1 C11-P/9
MOTOR
VT-OG
230
GY-YE
1060
Compressor
Air-conditioning (a/c)
NEG
POS
CLUTCH_POS
Engine controlModule (ecm)
LIN
C1H401B/2
C1H401B/1
C1H401A/1
C1DC74A/1
VCV_CTRL
OP
C1E104B/2
BU-BN
1255
VT
1410
GY
1410
YE-GY
1390
BU-OG
1000
C1E256A/2
Valve-controlFuel volume
PWRCTRL
C1E256A/1
BU
390 700
SPL003
BU
C11-P/24
C11-P/13
C11-P/10
C11-P/12
C11-P/4
Refer to d4 - charging
Refer to climate control
Refer to engine junction box
OP
PCV_CTRL
EGR_BYPASS_CTRL
BRAKE_VAC_SWITCH
OP
IP
C1E104B/42
C1E104B/53
C1E104A/22
BN-WH
1705
GN-VT
955
GN-VT
330
TSS
C1E259A/2
C1E139A/1
Valve-controlFuel pressure
C1E259A/1
PWRCTRL
Valve-egr bypass
C1E139A/2
PWRCTRL
BU
700
BU
385
SPL004
BU
740
C11-P/1
C11-P/19
Refer to engine junction box
Refer to vehicle interface
x
XF - S20753 > (1a) 41
Page 58
303-14A - ELECTRONIC ENGINE CONTROLS - D4 Vehicle interface - Part 3
Vehicle interface - Part 3
phdw12c-70031-b-a3
Engine controlModule (ecm)
IP
SRS_ENS
GLOWPLUG_CTRL
GLOWPLUG_MONITOR
OP
IP
C1E104A/19
C1E104B/7
C1E104A/7
BN-YE
330
VT-GN
360
BN-VT
330
C11-P/5
C11-P/22
C11-P/23
Refer to fuel tank and lines
Refer to glow plugs
Active engine mounting
Solenoid
SUPPLY
C1E925A/1C1E925A/2
SIG
BK-VT
2195
BU-BN
2195
VT-BN
2195
BK-BU
2195
GY
360
SPL007
GY
750
C11-S/1
C11-T/1
C11-S/2
C11-T/2
C11-S/3
C11-T/3
C11-S/4
C11-T/4
C11-P/29
Link-glowPlug
Refer to glow plugs
Link-glowPlug
Refer to glow plugs
Link-glowPlug
Refer to glow plugs
Link-glowPlug
Refer to engine junction box
OIL LEVEL SENSOR
GN-BN
1110
C11-P/27
Refer to vehicle interface
XF - S20753 > (1a) 42
x
Page 59
303-14A - ELECTRONIC ENGINE CONTROLS - D4 Vehicle interface - Part 4
Vehicle interface - Part 4
phdw12c-70031-c-a3
Module-transmissionControl
C
HS_CAN_POS
C
HS_CAN_NEG
B+
BATTERY_SUPPLY
B+
IGN_SUPPLY
OP
PARK_SIGNAL
LIN
P
GND
C1ET02/5
C1ET02/6
C1ET02/13
C1ET02/9
C1ET02/1
C1ET02/4
L
C1ET02/14
WH-BU
565
WH
515
YE-RD
1656
GN-VT
1565
WH-BN
1565
BN-VT
1565
BK
1565
SPL001
SPL002
WH-BU
1000
WH
1050
WH
1050
WH-BU
1000
C11-P/20
C11-P/21
C11-P/18
C11-P/17
C11-P/31
C11-P/3
C11-P/6
C11-P/16
C11-P/7
Refer to can bus - high speed
Refer to transmission
XF - S20753 > (1a) 43
x
Page 60
303-14A - ELECTRONIC ENGINE CONTROLS - D4 Actuators - Part 1
Actuators - Part 1
phcr83-70037-d-a4
Ecu-glow plug
Junction-box engine
B+
F18
60A A3
GLOWPLUG_MODULE
C1BB01B/22
BN-RD
1
VT-GN
1
BN-VT
1
EN_KN
EN_KN
EN_KN
C1E513C/4
C1E513C/3
C1E513C/8
BATT
DIAGNOSTIC
CTRL
PLUG1
PLUG2
PLUG3
PLUG4
GND
C1E513C/2
C1E513C/7
C1E513C/1
C1E513C/6
C1E513C/5
BK-VT
1
BU-BN
1
VT-BN
1
BK-BU
1
BK
1
EN_KN
EN_KN
EN_KN
EN_KN
EN_KN
C11-S/1
C11-S/2
C11-S/3
C11-S/4
Glow plug
Glow plug
Glow plug
Glow plug
Refer to vehicle interface
F42
10A/20A/30A MINI
HIGH CURRENT
PETROL/DIESEL
EMS
RELAY
RLY16
F9
50A A1
EMS_SUPPLY_2
EMS_FUSES
EMS_FUSE_SUPPLY
EMS_RLY_CTRL
EMS_RLY_COIL
EMS_RLY_SUPPLY
EMS_POWER_FUSE
C1BB01B/63
C1BB01B/62
C1BB01B/P5
C1BB01B/P2
C1BB01B/P1
C1BB01B/P3
C1BB01B/13
GN
1
GY
0
GY
0
RD
0
RD
0
RD
0
EN_KN
EN_RX:EN_RY:EN_SU:EN_KN
EN_RX:EN_RY:EN_SU:EN_KN
SPL792
SPL862
C11-P/22
C11-P/23
Refer to vehicle interface
SPL893
GN
1
GN
1
GY-VT
1
EN_KN
EN_KN
EN_KN
C1E104C/2
C1E104C/5
C1E104C/28
Engine controlModule (ecm)
OP
GLOWPLUG_CTRL
IP
GLOWPLUG_MONITOR
B+
SUPPLY_1
B+
SUPPLY_2
OP
EMS_RLY_CTRL
HS_CAN_POS
HS_CAN_NEG
POWER_GND_1
POWER_GND_2
SIGNAL_GND_3
C
C
P
C1E104C/4
P
C1E104C/3
P
C1E104C/53
HS CAN BUS
BK
1
BK
1
BK
1
G1D131/1
EN_KN
EN_KN
EN_KN
G1D108/1
XF - S20753 > (1a) 44
x
Page 61
303-14A - ELECTRONIC ENGINE CONTROLS - D4 Actuators - Part 2
Actuators - Part 2
phdw12c-70038-a-a3
Engine controlModule (ecm)
Fuel injector-no.1
OP
INJECTOR_1_HIGH
INJECTOR_1_LOW
INJECTOR_2_HIGH
INJECTOR_2_LOW
INJECTOR_3_HIGH
INJECTOR_3_LOW
OP
OP
IP
IP
IP
C1E104A/11
C1E104A/35
C1E104A/24
C1E104A/48
C1E104A/23
C1E104A/47
GN-BU
1610
YE-BU
1610
GY-YE
1500
BU-OG
1500
VT-GY
1535
GN-VT
1535
C1E205A/1
C1E205A/2
C1E206A/1
C1E206A/2
C1E207A/1
C1E207A/2
HIGH
LOW
Fuel injector-no.2
HIGH
LOW
Fuel injector-no.3
HIGH
LOW
VREF
TPS_5V
TPS_SIG
GREF
TPS_RTN
POS
NEG
OP
IP
IP
INJECTOR_4_HIGH
INJECTOR_4_LOW
THROTTLE_MOTOR_POS
THROTTLE_MOTOR_NEG
C1E104A/12
C1E104A/36
C1E104A/4
C1E104A/39
C1E104A/40
C1E104A/46
C1E104A/34
YE-OG
1580
BU
1580
YE
1245
BU-WH
1245
BU-OG
1245
YE-VT
1245
BU-GN
1245
C1E208A/1
C1E208A/2
C1E818A/5
C1E818A/4
C1E818A/3
C1E818A/1
C1E818A/2
Fuel injector-no.4
HIGH
LOW
Sensor-throttlePosition (tp)
VREF
SIG
GND
MOTOR_POS
MOTOR_NEG
XF - S20753 > (1a) 45
x
Page 62
303-14A - ELECTRONIC ENGINE CONTROLS - D4 Actuators - Part 3
Actuators - Part 3
phdw12c-70038-b-a3
Engine controlModule (ecm)
Actuator-vane vgt
VREF
VGT_POS_ACTUATOR_5V
VGT_POS_ACTUATOR_SIG
VGT_POS_ACTUATOR_RTN
VGT_POS_ACTUATOR_POS
VGT_POS_ACTUATOR_NEG
GREF
POS
NEG
IP
C1E104A/13
C1E104A/25
C1E104A/31
C1E104A/44
C1E104A/32
YE
2225
BU
2225
GY
2225
WH
2225
BU
2225
C1E432A/1
C1E432A/3
C1E432A/2
C1E432A/5
C1E432A/4
VREF
SIG
RTN
EGR_POS
EGR_NEG
EGR_POS_SENSOR_5V
EGR_POS_SENSOR_SIG
EGR_POS_SENSOR_RTN
EGR_POS_SENSOR_POS
EGR_POS_SENSOR_NEG
VREF
GREF
POS
NEG
IP
C1E104A/1
C1E104A/17
C1E104A/27
C1E104A/45
C1E104A/33
BN-WH
1190
WH-OG
1190
GY-OG
1190
WH-VT
1190
YE-BU
1190
C1E147A/1
C1E147A/3
C1E147A/2
C1E147A/5
C1E147A/4
Actuator-egr-electric
VREF
SIG
RTN
EGR_POS
EGR_NEG
XF - S20753 > (1a) 46
x
Page 63
303-14A - ELECTRONIC ENGINE CONTROLS - D4 Sensors - Part 1
Sensors - Part 1
phcr83-70034-d-a4
Sensor-ambient air
Temperature
(part of lh door mirror assembly)
AMBIENT_AIR_SIG
AMBIENT_AIR_SIG_GND
YE-GN
1
BN-VT
1
EN_KN
EN_KN
Engine controlModule (ecm)
A
C13-E/4
C13-E/11
278
1
DR_B
DR_B
C3A-A/16
C3A-A/15
BKYE-GN
744
BKBN-VT
1
DR_B
DR_B
CAPM26/10
CAPM26/11
Junction-box engine
10A/20A/30A MINI
B+
F9
50A A1
F42
HIGH CURRENT
PETROL/DIESEL
EMS
RELAY
RLY16
EMS_SUPPLY_2
EMS_FUSES
EMS_FUSE_SUPPLY
EMS_RLY_CTRL
EMS_RLY_COIL
EMS_RLY_SUPPLY
EMS_POWER_FUSE
C1BB01B/63
C1BB01B/P5
C1BB01B/P2
C1BB01B/P1
C1BB01B/P3
C1BB01B/13
GN
1
GY
0
GY
0
RD
0
RD
0
RD
0
EN_KN
EN_RX:EN_RY:EN_SU:EN_KN
EN_RX:EN_RY:EN_SU:EN_KN
SPL792
SPL862
SPL893
GN
1
GN
1
GY-VT
1
EN_KN
EN_KN
EN_KN
C1E104C/43
C1E104C/32
C1E104C/2
C1E104C/5C1BB01B/62
C1E104C/28
GREF
AMBIENT_AIR_TEMP_RTN
IP
AMBIENT_AIR_TEMP
APP_1_RTN
APP_2_RTN
B+
SUPPLY_1
B+
SUPPLY_2
HS_CAN_POS
OP
EMS_RLY_CTRL
HS_CAN_NEG
VREF
APP_1_5V
APP_1
VREF
APP_2_5V
APP_2
IAT_2_SIG
GREF
IAT_2_RTN
C1E104C/46
IP
C1E104C/35
IP
C1E104C/47
C1E104C/20
IP
C1E104C/34
IP
C1E104C/44
C
C
IP
HS CAN BUS
A
C13-E/4
C13-E/11
YE-GN
278
BN-VT
1
DR_D
DR_D
GN-OG
1
YE-OG
1
VT-GN
1
BU-GY
1
BU-WH
1
YE-GN
1
RHD
C3B-A/16
C3B-A/15
EN_KN
EN_KN
EN_KN
EN_KN
EN_KN
EN_KN
C11-P/30
C11-P/26
BK
744
BK
1
DR_D
DR_D
BN-VT
1
GY-BN
1
CBPM31/10
CBPM31/11
EN_KN
EN_KN
C2E818A/1
C2E818A/2
C2E818A/3
C2E818A/6
C2E818A/5
C2E818A/4
C1E740A/1
C1E740A/2
Sensor-positionAccelerator pedal
VREF_1
DEMAND_1
GND_1
VREF_2
DEMAND_2
GND_2
Sensor-ambient airTemperature
SIGNAL
RTN
ACT_SENSOR
POWER_GND_1
POWER_GND_2
SIGNAL_GND_3
C1E104C/4
P
C1E104C/3
P
C1E104C/53
BK
1
BK
1
BK
1
EN_KN
EN_KN
EN_KN
G1D108/1
P
XF - S20753 > (1a) 47
x
Page 64
303-14A - ELECTRONIC ENGINE CONTROLS - D4 Sensors - Part 2
Sensors - Part 2
phdw12c-70034-a-a3
Engine controlModule (ecm)
Sensor-temperature-
FUEL_TEMP_SENSOR_SIG
FUEL_TEMP_SENSOR_RTN
OP
GREF
C1E104B/23
C1E104B/24
GN
1640
YE-BU
1640
C1E728A/1
C1E728A/2
Fuel rail
SIGNAL
RTN
IP
IAT_2_SIG
GREF
IAT_2_RTN
OIL_PRESS_SW
CRANK_SENSOR_SUPPLY
CRANK_SENSOR_SIG
CRANK_SENSOR_RTN
CAM_POS_SENSOR_5V
CAM_POS_SENSOR_SIG
CAM_POS_SENSOR_RTN
IP
VREF
IP
GREF
VREF
IP
GREF
C1E104B/15
C1E104B/16
C1E104B/52
C1E104B/51
C1E104B/14
C1E104B/28
C1E104A/2
C1E104A/28
C1E104A/29
BN-VT
360
GY-BN
360
BU-BN
1245
GY-VT
2215
YE-VT
2215
GN-BN
2215
GN-BN
1665
BN-BU
1665
VT
1665
C11-P/30
C11-P/26
C1MC24A/2
C1E711A/1
C1E711A/3
C1E711A/2
C1E706A/1
C1E706A/2
C1E706A/3
Refer to sensors
Switch-oil pressure
PRESS_SENSE
Sensor-crankshaftPosition (ckp)
VREF
X
SIG
GND
Sensor-camshaftPosition (cmp)
VREF
X
SIG
GND
SensorEgr bypass position
EGR_POS_SENSOR_5V
EGR_POS_SENSOR_SIG
EGR_POS_SENSOR_RTN
VREF
IP
GREF
C1E104B/49
C1E104B/22
C1E104B/10
BU-GN
1655
WH-GN
1655
BN-YE
1655
C1E756A/3
C1E756A/2
C1E756A/1
5V_VREF
SIG
RTN
XF - S20753 > (1a) 48
x
Page 65
303-14A - ELECTRONIC ENGINE CONTROLS - D4 Sensors - Part 3
Sensors - Part 3
phdw12c-70034-b-a3
Engine controlModule (ecm)
Sensor
Engine coolant
COOLANT_TEMP_SENSOR
COOLANT_TEMP_SENSOR_RTN
OIL_LEVEL_SENSOR
OLT_SENSOR_RTN
OP
GREF
IP
GREF
C1E104B/39
C1E104B/40
C1E104B/13
C1E104B/46
YE
1020
WH-BN
1020
GN-OG
1415
WH-VT
995
SPL006
WH-VT
420
C1E716A/2
C1E716A/1
C1E763A/3
C1E763A/2
Temperature(ect)
SIGNAL
RTN
Sensor-oil level
LEVEL_SENSE
SUPPLY
RTN
C1E763A/1
GY
655
SPL007
AEM SOLENOID
GY
750
C11-P/29
Refer to vehicle interface
OIL_TEMP_SENSOR
FUEL_RAIL_PRESS_SENSOR_SUPPLY
FUEL_RAIL_PRESS_SENSOR_SIG
FUEL_RAIL_PRESS_SENSOR_RTN
MAP_SENSOR_SUPPLY
MAP_SENSOR_SIG
MAP_SENSOR_RTN
OP
VREF
OP
GREF
VREF
OP
GREF
C1E104B/45
C1E104B/47
C1E104B/35
C1E104B/36
C1E104B/50
C1E104B/25
C1E104B/26
BU-OG
1205
GY
1705
BU-BN
1705
BU-BN
1705
BU-WH
1040
GN-BU
1040
YE-GN
1040
WH-VT
210
C1E764A/1
C1E764A/2
C1E727A/3
C1E727A/1
C1E727A/2
C1E150A/1
C1E150A/3
C1E150A/2
Ecu-air bag
TEMP_SENSE
RTN
Sensor-pressureFuel rail
5V_VREF
SIG
RTN
Sensor-manifold absolutePressure (map)
5V_VREF
SIG
RTN
Sensor-temperature-
TURBINE_OUTLET_TEMP
TURBINE_OUTLET_TEMP_RTN
IP
GREF
C1E104A/42
C1E104A/30
YE-OG
1420
YE-GN
1430
C1E842A/1
C1E842A/2
Boost air
SIGNAL
RTN
XF - S20753 > (1a) 49
x
Page 66
303-14A - ELECTRONIC ENGINE CONTROLS - D4 Emissions
Emissions
phdw12c-70035-a-a3
Engine controlModule (ecm)
Sensor-temperature-
DPF_INLET_TEMP_SENSOR
DPF_INLET_TEMP_SENSOR_RTN
DPF_OUTLET_TEMP_SENSOR
DPF_OUTLET_TEMP_SENSOR_RTN
UHEGO_HTR_CTRL
OP
GREF
OP
GREF
UHEGO_LSCP
UHEGO_LSCA
UHEGO_UREF
UHEGO_UN
IP
IP
IP
IP
IP
C1E104B/11
C1E104B/12
C1E104B/20
C1E104B/19
C1E104B/44
C1E104B/32
C1E104B/31
C1E104B/43
VT-OG
920
BU
920
YE-OG
920
YE-GN
920
YE-GN
1360
BU
1360
VT-OG
1360
BU-BN
1360
VT-BN
1360
DPF
DPF
DPF
DPF
C1E747A/3
C1E747A/1
C1E748A/2
C1E748A/1
C1E761A/3C1E104B/3 C1E761A/4
C1E761A/1
C1E761A/5
C1E761A/2
C1E761A/6
Dpf-intake
SIGNAL
RTN
Sensor-temperatureDpf-outlet
SIGNAL
RTN
Sensor-heated oxygen(ho2s)-front
CTRL
UHEGO_LSCP
UHEGO_LSCA
UHEGO_UREF
UHEGO_UN
SUPPLY
UHEGO
BU
610
SPL004
BU
740
C11-P/1
Refer to vehicle interface
VREF
DPF_SENSOR
DPF_SENSOR_SIG
DPF_SENSOR_RTN
GREF
MAFS_SIG
IAT_1_SIG
GREF
MAFS_RTN
IP
IP
IP
C1E104B/48
C1E104B/37
C1E104B/38
C1E104A/9
C1E104B/33
C1E104B/34
Sensor-differential pressure
BN-WH
1060 5V_VREF
VT
1060
GY-BU
1060
DPF
DPF
DPF
C1E749A/3
C1E749A/1
C1E749A/2
SIG
RTN
Sensor-maf/iat
YE-VT
1565
VT-GY
1595
BU
1595
C1E807C/5
C1E807C/2
C1E807C/4
MAF_SIG
IAT_SIG
GND
SUPPLY
CONTROL
C1E807C/3
BU
1025
XF - S20753 > (1a) 50
x
Page 67
307-01 - AUTOMATIC TRANSMISSION PV8 (5.0L)
307-01 - AUTOMATIC T RANSMISSIONPV8 (5.0L)
phcr83-70041-b-a4
MS CAN BUS
MS CAN BUS
Junction box-central
B+
B+
C+
MS_CAN_IN_POS
C-
MS_CAN_IN_NEG
C+
MS_CAN_OUT_POS
C-
MS_CAN_OUT_NEG
IGN_SUPPLY_2_FWD
OP
SYSTEM_GND
C3BP01E/16
P
C3BP01C/7
GN-VT
168
BK
1
G3D138/1
SPL302
SPL310
GN-VT
48
YE-RD
2099
C13-C/8
C13-C/16
GN-VT
2568
YE-RD
2568
C33-C/12
C33-C/22
C33-C/7
C33-C/20
WH-BN
2568
BN-VT
2568
BN-VT
1
WH-BN
1
GN-VT
1
YE-RD
1
C13-C/11
C13-C/4
Module-transmission shift
L
C3ET37/3
LIN
C3ET37/14
C3ET37/2
C3ET37/1
IP
PARK
B
IGN
B
BATTERY
C+
HS_CAN_POS
C-
HS_CAN_NEG
GND
P
HS CAN BUS
C3ET37/22
WH-BN
432
BN-VT
432
BK
1
EN_RX:EN_RY:EN_WD
EN_RX:EN_RY:EN_SU:EN_WD
C33-C/8
BK
128
G3D182B/1
Junction-box engine
F26
10A MINI
B+
TCM_EMS_POWER
TAP1_2
TAP1_1
C1BB01B/32
C1BB01B/75
C1BB01B/74
YE-RD
28
RD
1
GN-VT
384
YE-RD
2107
BK
1
G1D108/1
EN_RX:EN_RY:EN_SU:EN_WD
EN_RX:EN_RY:EN_SU:EN_KN
C11-P/13
C11-P/31
C11-P/7
Refer to vehicle interface
Tcm and control valve body
B+
IGNITION
B+
BATTERY
P
GND_2
P
GND_1
6 SPEED
C+
HS_CAN_POS
C-
HS_CAN_NEG
LIN
PARK
C
OP
HS CAN BUS
C11-P/35
C11-P/37
Refer to vehicle interface
x
XF - S20753 > (1a) 51
Page 68
307-01 - AUTOMATIC TRANSMISSION DV6 - 6 speed
DV6 - 6 speed
phcr83-70041-d3-a4
Refer to vehicle interface
MS CAN BUS
MS CAN BUS
Junction box-central
B+
B+
C+
MS_CAN_IN_POS
C-
MS_CAN_IN_NEG
C+
MS_CAN_OUT_POS
C-
MS_CAN_OUT_NEG
IGN_SUPPLY_2_FWD
OP
SYSTEM_GND
C3BP01E/16
P
C3BP01C/7
GN-VT
168
BK
1
G3D138/1
SPL302
SPL310
GN-VT
48
YE-RD
2099
C13-C/8
C13-C/16
BN-VT
2568
WH-BN
2568
GN-VT
2568
YE-RD
2568
C13-C/11
C13-C/4
C33-C/12
C33-C/22
C33-C/7
C33-C/20
WH-BN
432
BN-VT
432
BN-VT
1
WH-BN
1
GN-VT
1
YE-RD
1
EN_SU
EN_RX:EN_RY:EN_SU:EN_WD
Module-transmission shift
C3ET37/3
C3ET37/14
C3ET37/2
C3ET37/1
L
LIN
IP
PARK
B
IGN
B
BATTERY
C+
HS_CAN_POS
C-
HS_CAN_NEG
GND
P
HS CAN BUS
C3ET37/22
C11-P/6
C11-P/35
BK
1
C33-C/8
BK
128
G3D182B/1
Junction-box engine
F26
10A MINI
B+
TCM_EMS_POWER
TAP1_2
TAP1_1
C1BB01B/32
C1BB01B/75
C1BB01B/74
YE-RD
28
RD
1
GN-VT
384
YE-RD
2107
BK
1
G1D108/1
EN_RX:EN_RY:EN_SU:EN_WD
EN_RX:EN_RY:EN_SU:EN_KN
C11-P/13
C11-P/31
C11-P/7
Refer to vehicle interface
C11-M/9
C11-N/8
C11-N/13
C11-N/9
GY
1
YE-RD
1
BK
1
BK
1
EN_SU*6SPD
EN_SU*6SPD
EN_SU*6SPD
EN_SU*6SPD
C1ET02B/9
C1ET02B/14
C1ET02B/13
C1ET02B/16
Tcm and control valve body
B+
IGNITION
B+
BATTERY
P
GND_2
P
GND_1
6 SPEED
6SPD_TCM
C+
HS_CAN_POS
C-
HS_CAN_NEG
LIN
OP
PARK
C
C1ET02B/8
C1ET02B/10
HS CAN BUS
BN-VT
1
WH-BN
1
EN_SU*6SPD
EN_SU*6SPD
C11-N/16
C11-N/6
Refer to vehicle interface
C11-P = C11-A
C11-N = C11-B
C11-M = C11-C
XF - S20753 > (1a) 52
x
Page 69
307-01 - AUTOMATIC TRANSMISSION DV6 - 8 speed
DV6 - 8 speed
phcr83-70041-d2-a4
Refer to vehicle interface
MS CAN BUS
MS CAN BUS
Junction box-central
B+
B+
C+
MS_CAN_IN_POS
C-
MS_CAN_IN_NEG
C+
MS_CAN_OUT_POS
C-
MS_CAN_OUT_NEG
IGN_SUPPLY_2_FWD
OP
SYSTEM_GND
C3BP01E/16
P
C3BP01C/7
GN-VT
168
BK
1
G3D138/1
SPL302
SPL310
GN-VT
48
YE-RD
2099
C13-C/8
C13-C/16
BN-VT
2568
WH-BN
2568
GN-VT
2568
YE-RD
2568
C13-C/11
C13-C/4
C33-C/12
C33-C/22
C33-C/7
C33-C/20
WH-BN
432
BN-VT
432
BN-VT
1
WH-BN
1
GN-VT
1
YE-RD
1
EN_SU
EN_RX:EN_RY:EN_SU:EN_WD
Module-transmission shift
C3ET37/3
C3ET37/14
C3ET37/2
C3ET37/1
L
LIN
IP
PARK
B
IGN
B
BATTERY
HS_CAN_POS
HS_CAN_NEG
GND
C+
C-
P
HS CAN BUS
C3ET37/22
C11-P/6
C11-P/35
BK
1
C33-C/8
BK
128
G3D182B/1
Junction-box engine
F26
10A MINI
B+
TCM_EMS_POWER
TAP1_2
TAP1_1
C1BB01B/32
C1BB01B/75
C1BB01B/74
YE-RD
28
RD
1
GN-VT
384
YE-RD
2107
BK
1
G1D108/1
EN_RX:EN_RY:EN_SU:EN_WD
EN_RX:EN_RY:EN_SU:EN_KN
C11-P/13
C11-P/31
C11-P/7
Refer to vehicle interface
C11-M/9
C11-N/8
C11-N/13
GY
1
YE-RD
1
BK
1
EN_SU*8SPD
EN_SU*8SPD
EN_SU*8SPD
C1ET02/9
C1ET02/13
C1ET02/14
Tcm and control valve body
B+IGN_SUPPLY
BATTERY_SUPPLYB+
PGND
8 SPEED8SPD_TCM
HS_CAN_POS
HS_CAN_NEG
LIN
OP
PARK_SIGNAL
C
C
L
HS CAN BUS
C1ET02/4
C1ET02/1
BN-VT
1
WH-BN
1
EN_SU*8SPD
EN_SU*8SPD
Refer to vehicle interface
C11-N/16
C11-N/6
C11-P = C11-A
C11-N = C11-B
C11-M = C11-C
XF - S20753 > (1a) 53
x
Page 70
307-01 - AUTOMATIC TRANSMISSION D4
D4
phcr83-70041-d-a4
Refer to vehicle interface
MS CAN BUS
MS CAN BUS
Junction box-central
B+
B+
C+
MS_CAN_IN_POS
C-
MS_CAN_IN_NEG
C+
MS_CAN_OUT_POS
C-
MS_CAN_OUT_NEG
IGN_SUPPLY_2_FWD
OP
SYSTEM_GND
C3BP01E/16
P
C3BP01C/7
GN-VT
168
BK
1
G3D138/1
SPL302
SPL310
GN-VT
48
YE-RD
2099
C13-C/8
C13-C/16
BN-VT
2568
WH-BN
2568
GN-VT
2568
YE-RD
2568
C13-C/11
C13-C/4
C33-C/12
C33-C/22
C33-C/7
C33-C/20
WH-BN
432
BN-VT
432
BN-VT
1
WH-BN
1
GN-VT
1
YE-RD
1
EN_KN
EN_KN
C3ET37/3
C3ET37/14
C3ET37/2
C3ET37/1
Module-transmission shift
L
LIN
IP
PARK
B
IGN
B
BATTERY
C+
HS_CAN_POS
C-
HS_CAN_NEG
GND
P
C3ET37/22
HS CAN BUS
C11-P/6
C11-P/16
BK
1
C33-C/8
BK
128
G3D182B/1
Junction-box engine
F26
10A MINI
B+
TCM_EMS_POWER
TAP1_2
TAP1_1
C1BB01B/32
C1BB01B/75
C1BB01B/74
YE-RD
28
RD
1
GN-VT
384
YE-RD
2107
BK
1
G1D108/1
EN_KN
EN_RX:EN_RY:EN_SU:EN_KN
C11-P/3
C11-P/31
C11-P/7
Refer to vehicle interface
Tcm and control valve body
B+IGN_SUPPLY
BATTERY_SUPPLYB+
PGND
8 SPEED
HS_CAN_POS
HS_CAN_NEG
LIN
OP
PARK_SIGNAL
C
C
L
HS CAN BUS
XF - S20753 > (1a) 54
x
Page 71
310-01 - FUEL TANK AND FUEL LINES Petrol - PV8 5.0L
310-01 - FUEL TANK AN D FUEL LINESPetrol - PV8 5.0L
phcr83-70036-b-a4
MS CAN BUS
Junction box-rear
B+
B+
C+
MS_CAN_POS
C-
MS_CAN_NEG
FUEL PUMP
RELAY
F25
25A MINI
RLY 2
FUEL_SENDER_RTN
Junction-box engine
B+
5A/10A MINI
5A/15A/20A MINI
B+
FPDM_SUPPLY
FUEL_SENDER_B
FUEL_SENDER_A
GREF
LPPR_INPUT
SYSTEM_GND
F43
F36
EMS_SUPPLY_5_FUSE
HIGH CURRENT
PETROL/DIESEL
EMS
RELAY
RLY16
F9
50A
A1
F26
10A MINI
C4BP01C/10
IP
C4BP01M/3
IP
C4BP01M/19
C4BP01M/18
IP
C4BP01M/27
P
C4BP01C/7
EMS_SUPPLY_3
EMS_SUPPLY_5
EMS_FUSES
EMS_FUSE_SUPPLY
EMS_RLY_CTRL
EMS_RLY_COIL
EMS_RLY_SUPPLY
EMS_POWER_FUSE
TCM_EMS_POWER
TAP1_2
TAP1_1
WH-OG
1
YE-VT
1690
GN-OG
1690
GN-BU
1690
BK
1
BK
275
C1BB01B/65
C1BB01B/50
C1BB01B/62
C1BB01B/P5
C1BB01B/P2
C1BB01B/P1
C1BB01B/P3
C1BB01B/13
C1BB01B/32
C1BB01B/75
C1BB01B/74
EN_RX:EN_RY:EN_WD
EN_RX:EN_RY:EN_WD
BK
1
BK
1
G4D173/1
GY
1
BU-BN
1
GY
0
GY
0
GY
0
RD
0
RD
0
RD
0
YE-RD
28
RD
1
C44-M/83 C44-N/83
C44-N/72C44-M/72
EN_RX:EN_RY:EN_WD
EN_RX*EM_N:EN_RY*EM_N
EN_RX:EN_RY
EN_RX:EN_RY:EN_SU
EN_RX:EN_RY:EN_SU:EN_KN
EN_RX:EN_RY:EN_SU:EN_KN
SPL792
SPL310
C44-E/1
SPL862
WH-OG
410
SPL083
EN_RX:EN_RY:EN_WD
BN-WH
1
YE-OG
C13-A/3
C13-A/4
BN-WH
1
YE-OG
1
BU-BN
1
BU-BN
1
GY-VT
1
YE-RD
1
1
YE-OG
1
BN-WH
1
EN_RX:EN_RY
EN_RX:EN_RY
EN_RX:EN_RY
EN_RX:EN_RY
EN_RX:EN_RY
EN_RX:EN_RY
SPL858
Module-fuelPump driver
C4ES15/4
C4ES15/5
C4ES15/2
EN_RX:EN_RY:EN_WD
EN_RX:EN_RY:EN_WD
EN_RX:EN_RY:EN_WD
EN_RX:EN_RY:EN_WD
C1E120B/28
C1E120B/24
C1E120B/5C1BB01B/51
C1E120B/6
C1E120B/15
C1E120B/43
SUPPLY
PWM_CTRL
MONITOR
Engine controlModule (ecm)
FPDM_MONITOR
FPDM_CONTROL
IGNITION_SW
ECM_POWER_1
ECM_POWER_2
EMS_MAIN_RLY
BATTERY
C44-M/## C44-N/##
C44-E/4
C44-E/6
C44-E/5
FUEL_PUMP_POS
FUEL_PUMP_NEG
FET
C44-E/2
C44-E/3
IP
OP
IP
B+
PUMP_HEATER_CONTROL
B+
OP
B+
GND
IP
SRS_SIGNAL
C+
HS_CAN_NEG
C+
HS_CAN_POS
OP
FUEL_LEAK_PUMP
OP
OP
COV
POWER_GND_1
POWER_GND_2
POWER_GND_3
P
P
P
Ignore both connectors
(drawn for harness
Manufacturing purposes)
C4ES15/6
C4ES15/3
C4ES15/1
C1E120B/30
C1E120B/1
C1E120B/2
C1E120B/3
HS CAN BUS
GY
1
BN-YE
1
SPL593
EN_RX:EN_RY
GN-OG
428
VT-OG
428
BU-GY
428
EN_RX*EM_N:EN_RY*EM_N
EN_RX*EM_N:EN_RY*EM_N
EN_RX*EM_N:EN_RY*EM_N
BK
1
BK
1
BK
1
EN_RX:EN_RY
EN_RX:EN_RY
EN_RX:EN_RY
EN_RX*EM_N:EN_RY*EM_N
BK
4
YE-VT
30
GN-OG
30
GN-BU
1
YE-GY
1
WH-BN
1
SCR
21
BK
BK
1
EN_RX:EN_RY:EN_WD
EN_RX:EN_RY:EN_WD
EN_RX:EN_RY:EN_WD
EN_RX:EN_RY:EN_WD
EN_RX:EN_RY:EN_WD
EN_RX:EN_RY:EN_WD
EN_RX:EN_RY:EN_WD
EN_RX:EN_RY:EN_WD
EN_RX:EN_RY:EN_WD
C13-C/14
BN-YE
1
C13-D/2
SPL597
G1D108/1
SPL592
BN-YE
1
GN-OG
3126
VT-OG
3126
BU-GY
3126
C4MC11A/5
C4MC11A/2
C4MC11A/6
C4MC11A/1
C4MC11A/4
C4MC11A/3
BK
14
C3R114B/42
EM_N
EM_N
EM_N
GY
3126
Fuel tank-petrol
JPM_GND
FDM_RHS
JPM_LHS
FDM_GND
PUMP_SUPPLY
PUMP_RTN
EN_RX:EN_RY:EN_WD
Restraints control
Module (rcm)
SRS_ENS
Unit-leak detection
C4E730/2C1E120B/52 C13-A/14
C4E730/1C1E120B/53 C13-A/13
C4E730/3C1E120B/34 C13-A/12
HEATER
PUMP_RTN
VALVE_RTN
EM_N
SPL784
FUEL GAUGE
SENDER UNIT
FUEL GAUGE
SENDER UNIT
FUEL PUMP
C44-E/7
HS_CAN_NEG
HS_CAN_POS
SRS_MODULE
C4E730/4
BATT
BK
855
G3D162/1
HS CAN BUS
XF - S20753 > (1a) 55
x
Page 72
310-01 - FUEL TANK AND FUEL LINES DV6
DV6
phcr83-70036-d2-a4
Ignore both connectors
C44-N/##C44-M/##
(drawn for harness
Manufacturing purposes)
Junction box-rear
FUEL PUMP
RELAY
B+
RLY 2
B+
MS CAN BUS
MS_CAN_POS
MS_CAN_NEG
C+
C-
Junction-box engine
F42
10A/20A/30A MINI
F43
5A/10A MINI
FPDB
B+ EMS_POWER_FUSE
HIGH CURRENT
PETROL/DIESEL
EMS
RELAY
RLY16
F9
50A A1
EMS_SUPPLY_2
EMS_SUPPLY_3
EMS_FUSES
EMS_FUSE_SUPPLY
EMS_RLY_CTRL
EMS_RLY_COIL
EMS_RLY_SUPPLY
IP
GREF
IP
IP
P
IP
F25
25A MINI
FUEL_SENDER_RTN
AIRBAG_DEPLOYED
C1BB01B/63
C1BB01B/65
C1BB01B/62
C1BB01B/P5
C1BB01B/P2
C1BB01B/P1
C1BB01B/P3
C1BB01B/13
B+
FPDM_SUPPLY
FUEL_SENDER_B
FUEL_SENDER_A
SYSTEM_GND
LPPR_INPUT
GN
1
GY
1
GY
0
GY
0
RD
0
RD
0
RD
0
C4BP01C/10
C4BP01M/3
C4BP01M/18
C4BP01M/19
C4BP01M/32
C4BP01C/7
C4BP01M/27
EN_SU
EN_SU
EN_RX:EN_RY:EN_SU:EN_KN
EN_RX:EN_RY:EN_SU:EN_KN
WH-OG
1
YE-VT
1690
GN-BU
1690
GN-OG
1690
BN-YE
1
BK BK
275
VT-GN
1
SPL792
EN_SU:EN_KN
C44-M/72 C44-N/72
EN_SU:EN_KN
SPL168
SPL862
SPL882
C44-E/4
C44-E/5
C44-E/6
GY
1
WH-OG
1
WH-OG
1
GN-BU
68
1
EN_SU
EN_SU:EN_KN
EN_SU:EN_KN
BN-YE
1
C13-A/19
EN_SU:EN_KN
G4D173/1
C44-E/1
SPL224
SPL597
SPL863
WH-OG
304
YE-VT
122
GN-BU
216
GN-OG
142
GN-BU
236
C13-C/14
BN-YE
1
GY-VT
1
EN_SU:EN_KN
EN_SU:EN_KN
EN_SU:EN_KN
EN_SU:EN_KN
EN_SU:EN_KN
BN-YE
1
VT-GN
1
GN
1
GN
1
EN_SU
EN_SU
EN_SU
EN_SU
EN_SU
Fuel tank-diesel
LIFT
FUEL PUMP
C4MC11B/4 C4MC11B/3
C4MC11B/2
C4MC11B/5
C4MC11B/6
C4MC11B/1
C3R114B/42
C1E116B/25
C1E116B/41
C1E116B/3
C1E116B/5
C1E116B/55
PUMP_SUPPLY PUMP_GND
FUEL GAUGE
SENDER UNIT
FDM_LEVEL
FDM_RTN
JPM_LEVEL
JPM_RTN
Restraints control
Module (rcm)
SRS_ENS
Engine controlModule (ecm)
IP
SRS_INPUT
OP
LIFT_PUMP_RELAY_CTRL
FUEL_LIFT_PUMP_MONITOR
B+
SWITCHED_SUPPLY_1
B+
SWITCHED_SUPPLY_2
OP
FUEL_DIVERTER_SOL
OP
EMS_RELAY_CTRL
IP
IGN_SENSE
FUEL GAUGE
SENDER UNIT
HS_CAN_NEG
HS_CAN_POS
C-
HS_CAN_NEG
C+
HS_CAN_POS
WIF_SENSOR
GREF
SENSOR_GND_6
POWER_GND_4
POWER_GND_3
POWER_GND_2
POWER_GND_1
IP
IP
P
P
P
P
HS CAN BUS
HS CAN BUS
C1E116B/12
C1E116B/11
C1E116B/10
C1E116B/6
C1E116B/4
C1E116B/2
C1E116B/1
WH-OG
1
BU-BN
1
BK-GN
1
BK
409
BK
409
BK
417
BK
417
EN_SU
EN_SU
EN_SU
EN_SU
EN_SU
EN_SU
EN_SU
BK
304
SPL890
EN_SU:EN_KN
SPL883
BK-GN
1
G1D108/1
EN_SU
C44-E/7
WH-OG
1
C1E823/2
C1E823/3
C1E823/1
BK
855
EN_SU
Water in fuel
Sensor
OP
SIG
GREF
GND
B+
SUPPLY
G3D162/1
C13-D/14
XF - S20753 > (1a) 56
x
Page 73
310-01 - FUEL TANK AND FUEL LINES D4
D4
phcr83-70036-d-a4
Ignore both connectors
C44-N/##C44-M/##
(drawn for harness
Manufacturing purposes)
Junction box-rear
MS CAN BUS
Junction-box engine
B+
MS_CAN_POS
MS_CAN_NEG
DW12C_DIODE_CATHODE
D2
DW12C_DIODE_ANODE
FUEL PUMP
RELAY
RLY 2
B+
C+
C-
IP
GREF
IP
IP
P
IP
F25
25A MINI
FUEL_SENDER_RTN
AIRBAG_DEPLOYED
C1BB01B/70
C1BB01B/71
B+
FPDM_SUPPLY
FUEL_SENDER_B
FUEL_SENDER_A
SYSTEM_GND
LPPR_INPUT
BN-YE
1
BN-YE
1
C4BP01C/10
C4BP01M/3
C4BP01M/18
C4BP01M/19
C4BP01M/32
C4BP01C/7
C4BP01M/27
EN_KN
EN_KN
SPL882
WH-OG
1
YE-VT
1690
GN-BU
1690
GN-OG
1690
BN-YE
1
BK
275 1
VT-GN
1
EN_SU:EN_KN
C44-M/72 C44-N/72
EN_SU:EN_KN
C13-C/14
C44-E/4
C44-E/5
C44-E/6
BN-YE
1
WH-OG
1
WH-OG
1
GN-BU
68
BK
C13-A/19
EN_SU:EN_KN
EN_SU:EN_KN
EN_SU:EN_KN
G4D173/1
SPL224
SPL597
C11-P/5
C44-E/1
WH-OG
304
YE-VT
122
GN-BU
216
GN-OG
142
GN-BU
236
BN-YE
1
VT-GN
1
Refer to vehicle interface
EN_SU:EN_KN
EN_SU:EN_KN
EN_SU:EN_KN
EN_SU:EN_KN
EN_SU:EN_KN
EN_KN
Fuel tank-diesel
LIFT
FUEL PUMP
C4MC11B/4 C4MC11B/3
C4MC11B/2
C4MC11B/5
C4MC11B/6
C4MC11B/1
C3R114B/42
C1E104C/16
PUMP_SUPPLY PUMP_GND
FUEL GAUGE
SENDER UNIT
FDM_LEVEL
FDM_RTN
JPM_LEVEL
JPM_RTN
Restraints control
Module (rcm)
SRS_ENS
Engine controlModule (ecm)
OP
LPPR
IP
SRS_ENS
FUEL GAUGE
SENDER UNIT
HS_CAN_NEG
HS_CAN_POS
HS_CAN_POS
HS_CAN_NEG
FUEL_PUMP_MONITOR
IP
C
C
HS CAN BUS
HS CAN BUS
BK
304
EN_SU:EN_KN
C44-E/7
BK
855
C13-D/14
Not connected
G3D162/1
F42
10A/20A/30A MINI
HIGH CURRENT
PETROL/DIESEL
EMS
RELAY
RLY16
B+ EMS_POWER_FUSE
F9
50A A1
EMS_SUPPLY_2
EMS_FUSES
EMS_FUSE_SUPPLY
EMS_RLY_CTRL
EMS_RLY_COIL
EMS_RLY_SUPPLY
C1BB01B/63
C1BB01B/62
C1BB01B/P5
C1BB01B/P2
C1BB01B/P1
C1BB01B/P3
C1BB01B/13
GN
1
GY
0
GY
0
RD
0
RD
0
RD
0
EN_KN
EN_RX:EN_RY:EN_SU:EN_KN
EN_RX:EN_RY:EN_SU:EN_KN
SPL862
SPL792
SPL893
GN
1
GN
1
GY-VT
1
EN_KN
EN_KN
EN_KN
C1E104C/2
C1E104C/5
C1E104C/28
B+
SUPPLY_1
B+
SUPPLY_2
OP
EMS_RLY_CTRL
POWER_GND_1
POWER_GND_2
SIGNAL_GND_3
P
C1E104C/4
P
C1E104C/3
P
C1E104C/53
BK
1
BK
1
BK
1
EN_KN
EN_KN
EN_KN
G1D108/1
XF - S20753 > (1a) 57
x
Page 74
310-03 - SPEED CONTROL Petrol - PV8 5.0L
310-03 - SPEED CONTROLPetrol - PV8 5.0L
phcr83-70190-b-a4
Instrument cluster
YR
1
YU
1
B
1
C+
C-
L
LIN
C2MC01A/22
SW002/6
SW002/3
SW002/4
Cruise controls-
SW009/2
SW009/3
Remote
CRUISE_SIGNAL
RTN
Switch-remote-ice
B
1
B
1
B
1
SW003/6
SW003/3
SW003/4
LIN
IGNITION_IN
GND
CRUISE_SIG
CRUISE_SW_GND
SW004/2
SW004/3
B
1
B
1
Switch-brake pedal
FOOTBRAKE
SWITCH
IN OUT
CRUISE
DEACTIVATION
SWITCH
DEACTIN_2
G1D120/1
G1D123/1
BK
1
BK
1
DR_B
DR_D
C2CA29/1 C2CA29/4
C2CA29/3 C2CA29/2
MS CAN BUS
MS CAN BUS
Junction box-central
C+
MS_CAN_IN_POS
C-
MS_CAN_IN_NEG
C+
MS_CAN_OUT_POS
C-
MS_CAN_OUT_NEG
B+
B+
5A MINI
IGN_SUPPLY_1_CABIN
IGN_SUPPLY_2_FWD
FPDB_IGNITION_CTRL
F21
FOOTBRAKE_SW_SUPPLY
OP
OP
OP
SYSTEM_GND
B+
C3BP01D/14
C3BP01E/16
P
C3BP01C/7
C3BP01E/20
BN-YE
2931
GN-VT
168
BK
1
SPL51
BN-YE
1
G3D138/1
C23-D/12
SPL302
BN-YE
1
SPL86
SPL791
G2D115/1
WH
190
WH
646
BN-YE
1
BK
901
C+
MS CAN BUS HS CAN BUS
MS_CAN_IN_POS
C-
MS_CAN_IN_NEG
HS_CAN_IN_POS
HS_CAN_IN_NEG
Clock spring
C2R115A/8
C2R115A/5
C2R115A/6
LIN
IGNITION
GND_RTN
GY-RD
1
SA004/6
SA004/3
SA004/4
Junction-box engine
B+
5A/10A MINI
F36
5A/15A/20A MINI
F41
EMS_SUPPLY_5_FUSE
HIGH CURRENT
PETROL/DIESEL
EMS
RELAY
RLY16
F9
50A A1
F26
10A MINI
EMS_SUPPLY_1
EMS_SUPPLY_5
EMS_FUSES
EMS_FUSE_SUPPLY
EMS_RLY_CTRL
EMS_RLY_COIL
EMS_RLY_SUPPLY
EMS_POWER_FUSE
TCM_EMS_POWER
TAP1_2
TAP1_1
GN-VT
1
C1BB01B/61
C1BB01B/51 C1E120B/5
C1BB01B/50
C1BB01B/62
C1BB01B/P5
C1BB01B/P2
C1BB01B/P1
C1BB01B/P3
C1BB01B/13
C1BB01B/32
C1BB01B/75
C1BB01B/74
BU-BN
1
GY
0
GY
0
GY
0
RD
0
RD
0
RD
0
YE-RD
28
RD
1
EN_RX:EN_RY
EN_RX:EN_RY:EN_SU
EN_RX:EN_RY:EN_SU:EN_KN
EN_RX:EN_RY:EN_SU:EN_KN
SPL792
SPL310
SPL862
SPL083
BU
1
BU-BN
1
BU-BN
1
GY-VT
1
YE-RD
1
EN_RX:EN_RY
EN_RX:EN_RY
EN_RX:EN_RY
EN_RX:EN_RY
EN_RX:EN_RY
EN_RX:EN_RY
C1E120B/17
C1E120B/46
C1E120B/6
C1E120B/15
C1E120B/43
Engine controlModule (ecm)
IP
IGNITION_SW
B+
ETB_MOTOR_POWER
B+
ECM_POWER_1
B+
ECM_POWER_2
OP
EMS_MAIN_RLY
B+
BATTERY
C+
HS_CAN_NEG
C+
HS_CAN_POS
IP
BRAKE_SW_2
BRAKE_SW
IP
POWER_GND_1
POWER_GND_2
POWER_GND_3
P
P
P
HS CAN BUS
C1E120B/40
C1E120B/37
C1E120B/1
C1E120B/2
C1E120B/3
VT-OG
1
VT-BN
1
BK
1
BK
1
BK
1
EN_RX:EN_RY
EN_RX:EN_RY
EN_RX:EN_RY
EN_RX:EN_RY
EN_RX:EN_RY
G1D108/1
SPL786
VT-BN
1
x
XF - S20753 > (1a) 58
Page 75
310-03 - SPEED CONTROL Adaptive
Adaptive
phcr83-70486-a-a4
Junction-box engine
MS CAN BUS
MS CAN BUS
B+
F9
50A A1
F19
5A MINI
IGN
RELAY
1/2 ISO
RLY19
D1
IGNITION_RLY_DIODE_CATHODE
FPDB
Junction box-central
B+
B+
C+
MS_CAN_IN_POS
C-
MS_CAN_IN_NEG
C+
MS_CAN_OUT_POS
C-
MS_CAN_OUT_NEG
Switch-auxiliary lighting
EMS_POWER_FUSE
IGNITION_RLY_SUPPLY
ACC_SUPPLY
ACC_FUSE
IGNITION_RLY_OUTPUT
IGNITION_RLY_COIL
IGNITION_RLY_CTRL
IGNITION_RLY_DIODE_ANODE
OP
FPDB_IGNITION_CTRL
OP
IGN_SUPPLY_1_FWD
OP
IGN_SUPPLY_1_CABIN
P
SYSTEM_GND
C1BB01B/13
C1BB01B/S3
C1BB01B/24
C1BB01B/23
C1BB01B/S5
C1BB01B/S2
C1BB01B/S1
C1BB01B/68
C1BB01B/69
C3BP01E/5
C3BP01G/5
C3BP01C/7
RD
0
RD
0
YE-GY
0
YE-GY
0
BK
0
GY-BN
0
GN-VT
28
GN-VT
2171
GN-VT
2307
BK
1
GTDAD
GTDAD:JBBBB
GTDAD
SPL792
SPL103
SPL305
G3D138/1
BN-WH
1
G1D123/1
GTDAD
Sensor-pressurePower steering
C1MF04A/1
HS CAN BUS
C1MF04A/10 C1MF04A/3
BATTERY
HS_CAN_POS
HS_CAN_NEG
IGNITION GND
ACC_ESR
Instrument cluster
C+
HS CAN BUS MS CAN BUS
HS_CAN_IN_POS
C-
HS_CAN_IN_NEG
MS_CAN_IN_POS
MS_CAN_IN_NEG
C+
C-
L
LIN
BK
1
GTDAD
G1D131/1
470
Fwd Alert Off
SW3
10k 3.3k
AUX_SW_SIGNAL
3.3k
FA_STATUS
GND
C2LF23/12
WH
572
BK
1
C2MC01A/31C2LF23/2
IP
AUX_SW_SIGNAL
GREF
AUX_SW_RTN
G2D115/1
XF - S20753 > (1a) 59
x
Page 76
310-03 - SPEED CONTROL DV6
DV6
phcr83-70190-d2-a4
Instrument cluster
YR
1
YU
1
B
1
C+
C-
L
LIN
C2MC01A/22
SW002/6
SW002/3
SW002/4
Cruise controls-
SW009/2
SW009/3
Remote
CRUISE_SIGNAL
RTN
Switch-remote-ice
B
1
B
1
B
1
SW003/6
SW003/3
SW003/4
LIN
IGNITION_IN
GND
CRUISE_SIG
CRUISE_SW_GND
SW004/2
SW004/3
B
1
B
1
Switch-brake pedal
FOOTBRAKE
SWITCH
IN OUT
CRUISE
DEACTIVATION
SWITCH
DEACTIN_2
BK
1
BK
1
C2CA29/1 C2CA29/4
C2CA29/3 C2CA29/2
DR_B
DR_D
MS CAN BUS
MS CAN BUS
Junction box-central
C+
MS_CAN_IN_POS
C-
MS_CAN_IN_NEG
C+
MS_CAN_OUT_POS
C-
MS_CAN_OUT_NEG
B+
B+
5A MINI
IGN_SUPPLY_1_CABIN
IGN_SUPPLY_2_FWD
FPDB_IGNITION_CTRL
F21
FOOTBRAKE_SW_SUPPLY
OP
OP
OP
SYSTEM_GND
B+
C3BP01D/14
C3BP01E/16
P
C3BP01C/7
C3BP01E/20
BN-YE
2931
GN-VT
168
BK
1
SPL51
BN-YE
1
G3D138/1
BN-YE
1
SPL302
SPL86
SPL791
WH
190
WH
646
BN-YE
1
BK
901
G2D115/1
GY-RD
1
C+
MS CAN BUS HS CAN BUS
MS_CAN_IN_POS
C-
MS_CAN_IN_NEG
HS_CAN_IN_POS
HS_CAN_IN_NEG
Clock spring
C2R115A/8
C2R115A/5C23-D/12
C2R115A/6
LIN
IGNITION
GND_RTN
SA004/6
SA004/3
SA004/4
Junction-box engine
10A/20A/30A MINI
B+
F9
50A A1
F42
HIGH CURRENT
PETROL/DIESEL
EMS
RELAY
RLY16
EMS_SUPPLY_2
EMS_FUSES
EMS_FUSE_SUPPLY
EMS_RLY_CTRL
EMS_RLY_COIL
EMS_RLY_SUPPLY
EMS_POWER_FUSE
C1BB01B/63
C1BB01B/62
C1BB01B/P5
C1BB01B/P2
C1BB01B/P1
C1BB01B/P3
C1BB01B/13
GN
1
GY
0
GY
0
RD
0
RD
0
RD
0
EN_SU
EN_RX:EN_RY:EN_SU:EN_KN
EN_RX:EN_RY:EN_SU:EN_KN
SPL862
SPL792
SPL863
GN-VT
1
GY-VT
1
GN
1
GN
1
EN_SU
EN_SU
EN_SU
EN_SU
C1E116B/15
C1E116B/3
C1E116B/5
C1E116B/55
Engine controlModule (ecm)
IP
IGN_SENSE
B+
SWITCHED_SUPPLY_1
B+
SWITCHED_SUPPLY_2
OP
EMS_RELAY_CTRL
C-
HS_CAN_NEG
C+
HS_CAN_POS
BRAKE_SW_2
BRAKE_SW_1
POWER_GND_4
POWER_GND_3
POWER_GND_2
POWER_GND_1
IP
C1E116B/45
IP
C1E116B/26
P
C1E116B/6
P
C1E116B/4
P
C1E116B/2
P
C1E116B/1
HS CAN BUS
VT-OG
1
VT-BN
1
BK
409
BK
409
BK
417
BK
417
EN_SU
EN_SU
EN_SU
EN_SU
EN_SU
EN_SU
G1D120/1
G1D123/1
SPL786
VT-BN
1
G1D108/1
XF - S20753 > (1a) 60
x
Page 77
310-03 - SPEED CONTROL D4
D4
Instrument cluster
YR
1
YU
1
B
1
C+
C-
L
LIN
C2MC01A/22
SW002/6
SW002/3
SW002/4
Cruise controls-
SW009/2
SW009/3
Remote
CRUISE_SIGNAL
RTN
Switch-remote-ice
B
1
B
1
B
1
SW003/6
SW003/3
SW003/4
LIN
IGNITION_IN
GND
CRUISE_SIG
CRUISE_SW_GND
SW004/2
SW004/3
B
1
B
1
Switch-brake pedal
FOOTBRAKE
SWITCH
IN OUT
CRUISE
DEACTIVATION
SWITCH
DEACTIN_2
BK
1
BK
1
C2CA29/1 C2CA29/4
C2CA29/3 C2CA29/2
DR_B
DR_D
MS CAN BUS
MS CAN BUS
Junction box-central
C+
MS_CAN_IN_POS
C-
MS_CAN_IN_NEG
C+
MS_CAN_OUT_POS
C-
MS_CAN_OUT_NEG
B+
B+
5A MINI
IGN_SUPPLY_1_CABIN
IGN_SUPPLY_2_FWD
FPDB_IGNITION_CTRL
F21
FOOTBRAKE_SW_SUPPLY
OP
OP
OP
SYSTEM_GND
B+
C3BP01D/14
C3BP01E/16
P
C3BP01C/7
C3BP01E/20
BN-YE
2931
GN-VT
168
BK
1
SPL51
BN-YE
1
G3D138/1
SPL302
BN-YE
1
SPL86
SPL791
WH
190
WH
646
BN-YE
1
BK
901
G2D115/1
C+
MS CAN BUS HS CAN BUS
MS_CAN_IN_POS
C-
MS_CAN_IN_NEG
HS_CAN_IN_POS
HS_CAN_IN_NEG
Clock spring
GY-RD
1
C2R115A/8
C2R115A/5C23-D/12
C2R115A/6
LIN
IGNITION
GND_RTN
SA004/6
SA004/3
SA004/4
Junction-box engine
10A/20A/30A MINI
B+
F9
50A A1
F42
HIGH CURRENT
PETROL/DIESEL
EMS
RELAY
RLY16
EMS_SUPPLY_2
EMS_FUSES
EMS_FUSE_SUPPLY
EMS_RLY_CTRL
EMS_RLY_COIL
EMS_RLY_SUPPLY
EMS_POWER_FUSE
C1BB01B/63
C1BB01B/62
C1BB01B/P5
C1BB01B/P2
C1BB01B/P1
C1BB01B/P3
C1BB01B/13
GN
1
GY
0
GY
0
RD
0
RD
0
RD
0
EN_KN
EN_RX:EN_RY:EN_SU:EN_KN
EN_RX:EN_RY:EN_SU:EN_KN
SPL862
SPL792
SPL893
GN-VT
1
GN
1
GN
1
GY-VT
1
EN_KN
EN_KN
EN_KN
EN_KN
C1E104C/19
C1E104C/2
C1E104C/5
C1E104C/28
Engine controlModule (ecm)
IP
IGN_SENSE
B+
SUPPLY_1
B+
SUPPLY_2
OP
EMS_RLY_CTRL
HS_CAN_POS
HS_CAN_NEG
IP
BRAKE_SWITCH_2
IP
BRAKE_SWITCH_1
POWER_GND_1
POWER_GND_2
SIGNAL_GND_3
C
C
C1E104C/39
C1E104C/22
P
C1E104C/4
P
C1E104C/3
P
C1E104C/53
HS CAN BUS
BK
1
BK
1
BK
1
EN_KN
EN_KN
EN_KN
VT-OG
1
VT-BN
1
G1D120/1
EN_KN
EN_KN
G1D108/1
G1D123/1
SPL786
VT-BN
1
x
XF - S20753 > (1a) 61
Page 78
412-01 - CLIMATE CONTROL Part 1
412-01 - CLIMATE CONTROLPart 1
phcr83-70295-a-a4
Junction box-central
B+
B+
F25
10A MINI
IGN_SUPPLY_1_CABIN
AIRCON_BATT_PWR
MS_CAN_IN_POS
MS_CAN_IN_NEG
MS_CAN_OUT_POS
MS_CAN_OUT_NEG
B+
OP
C+
C-
C+
C-
SYSTEM_GND
C3BP01C/9 C23-D/8
C3BP01D/14
MS CAN BUS
MS CAN BUS
P
C3BP01C/7
RD
1
BN-YE
2931
BK
1
G3D138/1
SPL51
TOUCH
SCREEN
BN-YE
2975
BN-YE
1
RD
1
MOST BUS
G1DAB
ICM
C2H101A/1
MS CAN BUS
MS CAN BUS
Module-climate
Control
B
IN_CAR_TEMP_SENSOR
VBATT
C+
CAN_IN_POS
C-
CAN_IN_NEG
C+
CAN_OUT_POS
C-
CAN_OUT_NEG
HUMIDITY_SENSOR
IP
IP
ASPIRATOR_DIAG
IP
GREF
SENSOR_GND
C2H101A/26
C13-D/11
B
SPL791
SPL231
BU-BN
786
G2D115/1
B
C12-A/12
C23-D/12
Sensor-temperatureIn-car
BU-BN
1
SPL232
C2H414/6C2H101A/18
C2H414/2C2H101A/7
C2H414/4C2H101A/16
HUMIDITY PWR
ASPIRATOR_DIAG MOTOR_GND
TEMP GND
G1DAA
BU-BN
2090
BK
68
BU-BN
44
G1DAB
G1DAB
G1DAB
HUMIDITY
SENSOR
ASPIRATOR
MOTOR
TEMP
SENSOR
WH-BU
1579
GY
1579
GN-BU
1579
BU-BN
844
C1H433A/1
A
C2H414/1
C2H414/3
C2H414/5
BN-YE
1
BN-YE
1
BK
276
BU-BN
734
C12-A/12
Instrument cluster
Junction box-rear
B+
B+
G3D138/1
GREFAUTOLAMP_RTN
BK
512
C2MC01A/30
IPAUTOLAMP_SENSOR
C2MC01B/26
BU-BN
614
BU-BN
112
BLOWER_MOTOR_SUPPLY
B+
C+
MS_CAN_POS
C-
MS_CAN_NEG
SYSTEM_GND
BK
164
P
C2H415/2
C2H415/5
C4BP01C/3 C2H123/2C23-L/1
C4BP01C/7
C2H102/1C23-L/2
BU
3272
C44-M/## C44-N/##
MS CAN BUS
BK BK
275
Module-blowerMotor control-front
C2H102/4
C2H102/2
C2H102/3
D258
SensorSunlight
AUTOLAMP SUNLOAD_L
SUNLOAD_R
GND
BU
132
Ignore both connectors
(drawn for harness
Manufacturing purposes)
C44-N/72C44-M/72
YE-BU
176
WH-VT
192
YE-BU
192
1
C2H415/1
C2H415/6
Motor-blower
C2H123/1
G4D173/1
VT-GY
956
YE-OG
956
C2H101A/24
C2H101A/23
C2H101C/7
C2H101C/19
IPLH_SOLAR_SENSOR
IPRH_SOLAR_SENSOR
PRESSURE_SENSOR
OP
BLOWER_CTRL
IP
BLOWER_FBACK
VREF
SENSOR_5V
NOX_INPUT
HC_INPUT
SYSTEM_GND
C2H101A/17 C12-A/1
IP
C2H101A/22
IP
C2H101A/14
IP
C2H101A/15
P
C2H101A/6
GY-BN
524
VT-OG
524
WH-GN
524
WH-OG
524
BK
1
C12-A/2
G1DAB
G1DAB
C12-A/3
C12-A/4
G2D115/1
GY-BN
2139
VT-OG
2139
BK
2163
BK
2163
G1DAB
G1DAB
C1H454/4
C1H454/2
Sensor-pressureRefrigerant
C1H433A/3
C1H433A/2
VREF
SIG GND
T278
Sensor-air quality
NOX_SENSOR
HC_SENSOR
T306
SENSOR_GND
PWR
GND
A
C1H433A/1
C1H454/1
C1H454/3
C1H454/6
BK
4074
BK
1
G1DAB
G1DAB
G1D129/1
XF - S20753 > (1a) 62
x
Page 79
412-01 - CLIMATE CONTROL Part 2
Part 2
phcr83-70295-b-a4
Module-climate
Control
Motor-recirculated air
VREF
Junction box-central
B+
B+
F25
10A MINI
AIRCON_BATT_PWR
MS_CAN_IN_POS
MS_CAN_IN_NEG
MS_CAN_OUT_POS
MS_CAN_OUT_NEG
B+
C+
C-
C+
C-
SYSTEM_GND
C3BP01C/9
P
C3BP01C/7
MS CAN BUS
MS CAN BUS
BK
1
RD
1
G3D138/1
C23-D/8
TOUCH
SCREEN
RD
1
MOST BUS
ICM
C2H101A/1
MS CAN BUS
MS CAN BUS
AIR_INTAKE_FEEDBACK
B
VBATT
C+
CAN_IN_POS
C-
CAN_IN_NEG
C+
CAN_OUT_POS
C-
CAN_OUT_NEG
HVAC_SENSOR_5V
IP
OP
AIR_INTAKE-
OP
AIR_INTAKE+
GREF
HVAC_SENSOR_GND
IP
EVAP_SENSOR
P
SYSTEM_GND
C2H101C/3
C2H101C/17
C2H101C/21
C2H101C/9
C2H101C/26
C2H101C/5
C2H101A/6
YE-VT
572
BK
1
SPL233
BN-WH
500
BN-YE
500
GN-OG
500
BU-GY
500
YE-VT
168
VT-BN
616
YE-VT
44
DR_B
DR_B
DR_B
DR_B
C2H406/1
C2H406/2
C2H206/1
C2H206/5
C2H206/7
C2H206/6
C2H206/3
M140
Sensor-temperature-evaporator
SIGNAL
GND
T165
C2H101C/3
C2H101C/21
C2H101C/9
SPL233
RHD
BN-WH
500
GN-OG
500
BU-GY
500
YE-VT
168
DR_D
DR_D
DR_D
DR_D
C2H206/3
C2H206/6
C2H206/7
C2H206/1
Motor-mode-airMix-lh
Motor-mode-airMix-rh
C2H237/5
C2H237/1
C2H237/3
C2H237/2
C2H211/5
C2H211/1
C2H211/3
C2H211/2
BN-WH
116
GY-BU
116
WH
240
BN
240
GY
240
SPL840
SPL839
WH
140
WH-GN
116
BN-WH
116
GY-BU
116
WH-GN
1
C2H227/2
C2H201/5
C2H201/2
C2H201/4
C2H201/6
Screen air distribution
Door motor
C2H227/5
C2H227/1
C2H227/3
M259
Motor-air distributionFeet
C2H201/1
C2H201/3
WH-GN
588
BN-WH
588
GY-BU
588
BN
140
GY
140
SPL776
SPL837
WH-GN
1
SPL838
BN-WH
588
GY-BU
588
C2H101C/11
C2H101C/1
C2H101C/25
L
LIN
L
LIN_PWR_1
L
LIN_GND
LIN_PWR_2
L
C12-D/1
C2H101A/3
BN-WH
1
SPL777
BN-WH
1
WH
885
BN-WH
1
WH-GN
1340
BN-WH
1
WH
890
BN-WH
1
WH-GN
1615
Motor-lh outer register
C2H429/4
C2H429/2
SUPPLY
LIN_OUT GND
LIN_IN
Motor-lh inner register
C2H427/4
C2H427/3
C2H427/2
SUPPLY
LIN_OUT GND
LIN_IN
Motor-rh inner register
C2H428/4
C2H428/3
C2H428/2
SUPPLY
LIN_OUT GND
LIN_IN
Motor-rh outer register
C2H430/4
C2H430/3
C2H430/2
SUPPLY
LIN_OUT GND
LIN_IN
C2H429/1
C2H427/1
C2H428/1
C2H430/1
BK
1
BK
1
BK
1
BK
1
Heater-electric booster
G2D115/1
WH-GN
1
C2HP01A/1
LIN
BATTERY
GND
C2HP01C/1
BK
84
EN_SU:EN_KN
G3D169/1
XF - S20753 > (1a) 63
x
Page 80
412-01 - CLIMATE CONTROL Part 3
Part 3
phcr83-70295-c-a4
BA
Module-climate
Junction box-central
B+
B+
F25
10A MINI
AIRCON_BATT_PWR
MS_CAN_IN_POS
MS_CAN_IN_NEG
MS_CAN_OUT_POS
MS_CAN_OUT_NEG
B+
C+
C-
C+
C-
SYSTEM_GND
C3BP01C/9
P
C3BP01C/7
MS CAN BUS
MS CAN BUS
BK
1
RD
1
G3D138/1
TOUCH
SCREEN
RD
1
MOST BUS
ICM
C2H101A/1C23-D/8
MS CAN BUS
MS CAN BUS
Control
B
VBATT
C+
CAN_IN_POS
C-
CAN_IN_NEG
C+
CAN_OUT_POS
C-
CAN_OUT_NEG
COMP_SOLENOID_NEG
IP
OP
COMP_SOLENOID_POS
C2H101A/10
C2H101A/9
VT
524
GY
524
C12-B/1
C12-B/2
C12-B/1
C12-B/2
VT
432 NEG
GY
432
EN_RX:EN_RY:EN_SU
EN_RX:EN_RY:EN_SU
VT
432
GY
432
EN_WD
EN_WD
C11-P/42
C11-P/36
C11-P/29
C11-P/36
Refer to vehicle interface
Air Conditioning (A/C)
compressor Solenoid
AJ133
POS
Air Conditioning (A/C)
compressor Solenoid
NEG
AJV6
POS
Junction-box engine
F35
5A MINI
1/2 ISO
COMPRESSOR CLUTCH
RELAY
RLY5
HIGH CURRENT
PETROL/DIESEL
EMS
RELAY
RLY16
B+
AC_COMP_CLUTCH
AC_COMP_CLUTCH_FUSE
COMP_RELAY_CTRL
COMP_RELAY_COIL
COMP_RELAY_SUPPLY
EMS_FUSE_SUPPLY
EMS_RLY_SUPPLY
F9
50A A1
EMS_POWER_FUSE
EMS_RLY_CTRL
EMS_RLY_COIL
C1BB01B/49
C1BB01B/48
C1BB01B/E5
C1BB01B/E2
C1BB01B/E1
C1BB01B/E3
C1BB01B/P5
C1BB01B/P2
C1BB01B/P1
C1BB01B/P3
C1BB01B/13
YE-GY
1
VT-WH
1
BK
1
WH-OG
1
GY
1
GY
0
RD
0
RD
0
RD
0
EN_SU:EN_KN
EN_SU:EN_KN
EN_SU:EN_KN
EN_SU:EN_KN
EN_SU:EN_KN
EN_RX:EN_RY:EN_SU:EN_KN
SPL792
SPL862
C12-B/15
WH-OG
1
G1D123/1
GY-VT
1
EN_SU:EN_KN
EN_SU
C2H101A/2
C1E116B/55
OP
CLUTCH_CTRL
Engine controlModule (ecm)
OP
EMS_RELAY_CTRL
SYSTEM_GND
P
C2H101A/6
BK
1
C12-B/1
C12-B/2
VT
432
GY
432
G2D115/1
EN_RX:EN_RY:EN_SU
EN_RX:EN_RY:EN_SU
C11-P/12
C11-P/42
C11-P/36
BA
Clutch-compressor-airConditioning (a/c)
CLUTCH_POS
Air Conditioning (A/C)
compressor Solenoid
NEG
POS
Refer to vehicle interface
3.0D
XF - S20753 > (1a) 64
x
Page 81
412-01 - CLIMATE CONTROL Part 4
Part 4
phcr83-70295-d-a4
Sensor-
Junction box-central
B+
B+
F25
10A MINI
RAIN_SENSOR_PWR
RAIN_SENSOR_GND
AUX_WATER_PUMP
MS_CAN_IN_POS
MS_CAN_IN_NEG
MS_CAN_OUT_POS
MS_CAN_OUT_NEG
AIRCON_BATT_PWR
OP
GREF
OP
C+
C-
C+
C-
SYSTEM_GND
B+
C3BP01D/3
C3BP01K/18
C3BP01E/6
P
C3BP01C/7
C3BP01C/9
MS CAN BUS
MS CAN BUS
BN
1
VT
2512
BU-GN
1
BK
1
RD
1
TSS
G3D138/1
C23-D/8
C49-B/1
C49-B/22
RD
1
BN
1
VT
1
SPL660
TSS
TSS
TSS
TSS
C9H459A/3
C9H459A/1
SPL661
BN
1
VT
1
Pump-auxiliary coolant
C1E318A/2 C1E318A/1
Module-climate
Control
C2H101A/1
B
VBATT
Windshield misting
SUPPLY
LIN
GND
CAN_IN_POS
C+
CAN_IN_NEG
CAN_OUT_POS
CAN_OUT_NEG
MS CAN BUS
C-
MS CAN BUS
C+
C-
C9H459A/2 C49-B/14
ICM
BK
1
WH
1
TSS
MOST BUS
TSS
TOUCH
SCREEN
WH
1
TSS
G1D131/1
C4BP01K/8
Junction box-rear
C10-8
MISTING_SENSOR_LIN
Compressor
Air Conditioning (a/c)
Junction-box engine
F35
5A MINI
1/2 ISO
COMPRESSOR CLUTCH
RELAY
RLY5
HIGH CURRENT
PETROL/DIESEL
EMS
RELAY
RLY16
B+
AC_COMP_CLUTCH
AC_COMP_CLUTCH_FUSE
COMP_RELAY_CTRL
COMP_RELAY_COIL
COMP_RELAY_SUPPLY
EMS_FUSE_SUPPLY
EMS_RLY_SUPPLY
F9
50A A1
EMS_POWER_FUSE
EMS_RLY_CTRL
EMS_RLY_COIL
C1BB01B/49
C1BB01B/48
C1BB01B/E5
C1BB01B/E2
C1BB01B/E1
C1BB01B/E3
C1BB01B/P5
C1BB01B/P2
C1BB01B/P1
C1BB01B/P3
C1BB01B/13
YE-GY
1
VT-WH
1
BK
1
WH-OG
1
GY
1
GY
0
RD
0
RD
0
RD
0
EN_SU:EN_KN
EN_SU:EN_KN
EN_SU:EN_KN
EN_SU:EN_KN
EN_SU:EN_KN
EN_RX:EN_RY:EN_SU:EN_KN
SPL862
SPL792
C12-B/15
WH-OG
1
EN_SU:EN_KN
G1D123/1
C2H101A/2
OP
CLUTCH_CTRL
COMP_SOLENOID_NEG
IP
OP
COMP_SOLENOID_POS
SYSTEM_GND
C2H101A/10
C2H101A/9
P
C2H101A/6
VT
524
GY
524
BK
1
GY-VT
1
EN_KN
C12-B/1
C12-B/2
C1E104C/28
VT
1
GY
1
G2D115/1
Engine controlModule (ecm)
OP
EMS_RLY_CTRL
EN_KN
EN_KN
C11-P/13
C11-P/10
C11-P/12
NEG
POS
CLUTCH_POS
XF - S20753 > (1a) 65
x
Page 82
412-02 - AUXILIARY CLIMATE CONTROL Heated - front
412-02 - AUXILIARY CLI MATE CONTROLHeated - front
phcr83-70131-a-a4
Junction box-central
SPL296
C3BP01E/5
B+
B+
OP
FPDB_IGNITION_CTRL
HFS_RELAY_CTRL
MS_CAN_IN_POS
MS_CAN_IN_NEG
MS_CAN_OUT_POS
MS_CAN_OUT_NEG
OP
C+
C-
C+
C-
SYSTEM_GND
C3BP01J/25
P
C3BP01C/7
MS CAN BUS
MS CAN BUS
GY-OG
2171
BK
1
B3MAB
G3D138/1
GN-VT
2171
Junction-box engine
B+
RH_FRONT_SCREEN_HTR_RLY_COIL
RH_FRONT_SCREEN_HTR_RLY_SUPPLY
F15
40A A1
LH_FRONT_SCREEN_HTR_RLY_COIL
LH_FRONT_SCREEN_HTR_RLY_SUPPLY
F16
40A A1
RH FRONT SCREEN
HEATER RELAY
FULL ISO
RHF_HTR_SUPPLY
RHF_HTR_RLY_CTRL
RLY10
RH_FRONT_SCREEN_HTR_RLY
LH FRONT SCREEN
HEATER RELAY
FULL ISO
LHF_HTR_SUPPLY
LHF_HTR_RLY_CTRL
RLY11
LH_FRONT_SCREEN_HTR_RLY
C1BB01B/J5
C1BB01B/J2
C1BB01B/J1
C1BB01B/J3
C1BB01B/20
C1BB01B/K5
C1BB01B/K2
C1BB01B/K1
C1BB01B/K3
C1BB01B/19
BU-GN
2127
GN-VT
28
VT-RD
0
BN-BU
3074
GN-VT
28
WH-RD
0
B3MAB
B3MAB
B3MAB
B3MAB
B3MAB
B3MAB
SPL305
GY-OG
28
GY-OG
28
B3MAB
B3MAB
BU-GN
446
BN-BU
488
B3MAB
B3MAB
Windshield rh
Heater element
C9RD04A/1C13-D/7 C9RD04B/1
Windshield lh
Heater element
C9RD03A/1C13-E/7 C9RD03B/1
H114
BK
397
BK
488
B3MAB
G3D138/1
B3MAB
G3D133/1
XF - S20753 > (1a) 66
x
Page 83
412-02 - AUXILIARY CLIMATE CONTROL Heated - rear
Heated - rear
phcr83-70132-a-a4
Ignore both connectors
(drawn for harness
Manufacturing purposes)
MIRROR_HEATING
OP
GREF
MIRROR_GND
C+
MS_CAN_POS
C-
MS_CAN_NEG
KL_31_GND
P
CAPW02B/10 CAPM26/9
CAPW02B/23 CAPM26/12
MS CAN BUS
CAPW02A/13
BK
736
C3A-B/12
BK
424
BK
424
BK
260
DR_B
C3A-B/12
G3D133/1
Mirror-doorDriver side
MIRROR_HEATING
MIRROR_GND
BK
384
RHD
DR_D
G3D138/1
Junction box-rear
B+
B+
F16
25A MINI
DRIV_DOOR_ECM
B+
C4BP01F/11
VT-RD
4628
BK
736
C44-N/##C44-M/##
Module-driver door
CAPW02A/2C3A-B/1
B
KL_30
F29
25A MINI
PASS_DOOR_ECM
B+
B+
HRW_PWR
C+
MS_CAN_POS
C-
MS_CAN_NEG
SYSTEM_GND
P
C4BP01C/1
MS CAN BUS
C4BP01C/7
GY-RD
3096
BN-BU
2080
BK
Module-passenger door
C3B-B/1C4BP01C/5
BK
812
CBPW04A/2
FERRITE
C9RD0A/1
C44-N/72C44-M/72
BK
1275
G4D173/1
B
KL_30
Rf filter
POS
WAVE
TRAP
MIRROR_HEATING
OP
GREF
MIRROR_GND
C+
MS_CAN_POS
C-
MS_CAN_NEG
KL_31_GND
CBPW04B/10 CBPM31/9
CBPW04B/23 CBPM31/12
MS CAN BUS
P
CBPW04A/13
BK
1580
Rear window
Heater element
C3B-B/12
BK
400
BK
400
BK
384
DR_B
G3D138/1
Rf filter (with tv installed
Grounds through fixing)
WAVE
TRAP
Mirror-doorPassenger side
MIRROR_HEATING
MIRROR_GND
C3B-B/12
BK
260
RHD
DR_D
G3D133/1
XF - S20753 > (1a) 67
x
Page 84
413-01 - INSTRUMENT CLUSTER Part 1
413-01 - INSTRUMENT CLUSTERPart 1
phcr83-70210-a-a4
Instrument cluster
Junction box-central
B+
B+
OP
FPDB_IGNITION_CTRL
5A MINI
10A MINI
Switch-auxiliary lighting
SW1
220
SW2
470
SW3
F31
CLUSTER_LOGIC_PWR
F14
COLUMN_PEDAL_ADJUST_PWR
MS_CAN_OUT_POS
MS_CAN_OUT_NEG
CLUSTER_SECURITY
Trunk Release Sw
Fwd Alert Off
MS_CAN_IN_POS
MS_CAN_IN_NEG
SYSTEM_GND
330
REAR_FOG_SIGNAL
1K8
5K01K0
B+
B+
C3BP01G/9
C+
MS CAN BUS
C-
C+
MS CAN BUS
C-
IP
C3BP01M/9
P
C3BP01C/7
AUX_SW_SIGNAL
DIMMER_VREG
DIMMER_SIGNAL
GND
WH-RD
144 1355
BN-RD
1
BN-VT
160
BK
1
C23-D/3
C12-B/11
C23-R/4
G3D138/1
C2LF23/1
C2LF23/2
C2LF23/3
C2LF23/4
C2LF23/12
BK
1
G2D115/1
WH-RD
BN-RD
1
BN-VT
1355
BN-YE
572
WH
572
WH-BN
580
BU-WH
572
MS CAN BUS
HS CAN BUS
C2MC01B/16C3BP01D/9
C2MC01B/19
C2MC01B/8
C2MC01A/28
C2MC01A/31
C2MC01B/6
C2MC01A/9
C+
MS_CAN_IN_POS
C-
MS_CAN_IN_NEG
C+
HS_CAN_IN_POS
C-
HS_CAN_IN_NEG
B
LOGIC_PWR
B
COLUMN_PWR
OP
SECURITY_IND
IP
AUTOLAMP_SENSOR
OP
IC_SECURITY_OUT
IP
FOG_SW
IP
AUX_SW_SIGNAL
VREF
DIMMER_FEED
IP
DIMMER_LEVEL
GREF
AUX_SW_RTN
IP
COOLANT_LEVEL_SWITCH
MASTER_WIPE_SW
MAIN_BEAM_FLASH_SW
COLUMN_ADJUST_AUTO_MAN
COLUMN_DWN_OUT
COLUMN_POT_FEED
COLUMN_POT_RTN
REACH_SOLENOID
WASH_WIPE_SW
INT_WIPE_SW
FLICK_WIPE_SW
GREF
WIPER_SW_RTN
EXIT_DELAY_SW
HEADLAMP_SW
DI_SW
TRIP_CYCLE_SW
GREF
STALK_SW_RET
COLUMN_ADJUST
GREF
COLUMN_RTN
VREF
COLUMN_UP_IN
VREF
REACH_POT
VREF
GREF
RAKE_POT
VREF
RAKE_SOLENOID
VREF
IP
C2MC01A/8 C2RW08/2
IP
C2MC01A/29 C2RW08/5
IP
C2MC01A/26 C2RW08/4
IP
C2MC01A/25 C2RW08/3
C2MC01B/27 C2RW08/6
IP
C2MC01A/12 C2LF27/3
IP
C2MC01A/11 C2LF27/4
IP
C2MC01A/15 C2LF27/2
IP
C2MC01A/16 C2LF27/1
IP
C2MC01A/14 C2LF27/5
C2MC01A/6 C2LF27/6
IP
C2MC01A/13
IP
C2MC01A/24
C2MC01A/19
C2MC01B/18 C2PP03/3
C2MC01B/20 C2PP03/4
IP
C2MC01A/32 C2PP03/8
C2MC01B/4 C2PP03/6
C2MC01B/5 C2PP03/5
IP
C2MC01A/27 C2PP03/7
C2MC01B/24 C2PP03/9
C2MC01B/23 C2PP03/1
GY-BN
774
GN-VT
774
BU-GN
774
WH-GN
774
BN-VT
782
VT-GN
794
YE-BU
794
GN-BN
794
VT-BN
794
WH-BN
794
GY-YE
794
GN-VT
666
YE-VT
666
GN-OG
666
BN-GN
586
GY-OG
586
VT-BN
578
WH-BN
586
YE-GN
586
WH
578
BN-VT
586
WH-GN
586
BK
52
BK
52
Switch-steering columnWiper
WASH_WIPE_SW
INT_WIPER_SW
MASTER_WIPE_SW
FLICK_WIPE_SW
WIPER_SW_RTN
Switch-steering columnLighting
AUTOLAMP_EXIT
MASTER_LIGHTING
MAIN_BEAM
DI
TRIP_SIGNAL
SW_RET
Switch-steering column
Adjustment
C2PP11/1
COLUMN_ADJ
C2PP11/5
MODE_SEL 2
C2PP11/3
SWITCH_RTN
Assembly-steering column
COLUMN_UP_IN
COLUMN_DOWN_OUT
COLUMN_REACH_POT
COLUMN_POT_VREF
COLUMN_POT_RTN
COLUMN_RAKE_POT
RAKE_PWR
REACH_PWR REACH_GND
RIGHT
OFF
LEFT
1
OFF
INTERMITTENT
SLOW
FAST
MAIN BEAM
OFF
FLASH
470R
RAKE_GND
INT 6
INT 5
INT 4
INT 3
INT 2
INT 1
AUTOWIPE
DOWN
UP
IN
OUT
C2PP03/10
C2PP03/2
EXIT 3
EXIT 2
EXIT 1
AUTOLAMP
AUTOLAMP
DIP BEAM
SIDELIGHT
OFF
P
GND
LOGIC_GND
C2MC01B/22
P
C2MC01B/32
BK
535
BK
676
SPL187
BK
585
G2D115/1
XF - S20753 > (1a) 68
x
Page 85
413-01 - INSTRUMENT CLUSTER Part 2
Part 2
phcr83-70210-b-a4
Instrument cluster
Start control unit
SPL86
C12-B/4
C13-E/12
WH
1190
BN-BU
1
BN
1
BPW
BPW
C2DC06/3
C1MC06/1
C1MC06/2
LIN
Sensor-pad wearFront-lh
IN
OUT
Junction box-central
F31
5A MINI
B+
B+
F14
10A MINI
CLUSTER_LOGIC_PWR
B+
B+
COLUMN_PEDAL_ADJUST_PWR
C3BP01D/9
C3BP01G/9
WH-RD
144
BN-RD
1
C23-D/3
C12-B/11
WH-RD
1355
BN-RD
1
C2MC01B/16
C2MC01B/19
B
LOGIC_PWR
B
COLUMN_PWR
LIN
IP
BRAKE_PAD_WEAR
L
C2MC01A/22
C2MC01A/23
WH
BN-BU
1
BPW
BN
1
BPW
C3BP01E/5
MS_CAN_IN_POS
MS_CAN_IN_NEG
MS_CAN_OUT_POS
MS_CAN_OUT_NEG
OP
FPDB_IGNITION_CTRL
CLUSTER_SECURITY
SYSTEM_GND
GN-VT
2171
Junction-box engine
IGNITION_RLY_DIODE_ANODE
D1
IGNITION_RLY_DIODE_CATHODE
F38
5A MINI
IGN_COILS_VAPS_HEADLAMP_LEVEL
IGNITION
RELAY
1/2 ISO
IGNITION_RLY_OUTPUT
IGNITION_RLY_COIL
RLY19
IGNITION_RLY_CTRL
IGNITION_RLY_SUPPLY
B+ EMS_POWER_FUSE
F9
50A A1
VAPS
C+
C-
C+
C-
IP
P
MS CAN BUS
MS CAN BUS
C3BP01C/7
C1BB01B/69
C1BB01B/68
C1BB01B/55
C1BB01B/54
C1BB01B/S5
C1BB01B/S2
C1BB01B/S1
C1BB01B/S3
C1BB01B/13
BK
1
GN-VT
28
GY-BN
0
GY-BU
2123
YE-GY
0
BK
0
RD
0
RD
0
GTDAB*JBBAC
G3D138/1
SPL792
SPL305
GY-BU
1297
G1D123/1
HS CAN BUS
MS CAN BUS
C2MC01B/29C12-B/8
C+
HS_CAN_IN_POS
C-
HS_CAN_IN_NEG
C+
MS_CAN_IN_POS
C-
MS_CAN_IN_NEG
B
VAPS_PWR
BRAKE_PAD_WEAR_RTN
GREF
GREF
LOW_BRAKE_FLUID_RTN
IP
LOW_BRAKE_FLUID
IP
OIL_PRESSURE_SW
VREF
VAPS_POS
GREF
VAPS_NEG
GND
LOGIC_GND
C44-P/1
C44-P/2
C2MC01B/28
C2MC01B/25 C12-B/9
C2MC01B/12 C12-A/11
C2MC01B/30 C1CS09A/1C12-A/19
C2MC01B/31 C1CS09A/2C12-A/20
P
C2MC01B/22
P
C2MC01B/32
GY-OG
1
YE-GY
1
GY-VT
1
GY
1297
BK
535
BK
676
BPW
SPL187
BK
585
GN-BU
751
751
GY
428
C23-A/14
EN_SU:EN_WD
C1CS09B/1
C1CS09B/2
G2D115/1
C12-B/10
BN
1
GY-OG
1
GY-OG
1
YE-GY
1
GY-VT
1
BPW
BPW
BPW
C11-P/16
GN-BU
646
WH-GNWH-GN
646
GN-BU
646
WH-GN
646
C4MC09/1
C4MC09/2
C1MC19/2
C1MC19/1C2MC01B/1
C1CS09C/1
C1CS09C/2
Sensor-pad wearRear-rh
IN
OUT
Switch-brakeFluid level
TEST_SIG
BFL_SW
Refer to vehicle interface
Solenoid-power steering
POS
NEG
Solenoid-power steering
POS
NEG
XF - S20753 > (1a) 69
x
Page 86
413-01 - INSTRUMENT CLUSTER Part 3
Part 3
phcr83-70210-c-a4
SensorSunlight
ANTI THEFT LED
PATSBATT
GND AUTOLAMP
Instrument cluster
B
LOGIC_PWR
B
COLUMN_PWR
AUTOLAMP_SENSOR
C2H415/4
C2H415/2
GREF
AUTOLAMP_RTN
IP
OP
SECURITY_IND
C2MC01B/26
C2MC01A/30
C2MC01B/11
WH-VT
622
BU-BN
614
BU-BN
112
Junction box-central
F23
5A MINI
B+
B+
F31
5A MINI
F14
10A MINI
B+
ICP_ASS
B+
CLUSTER_LOGIC_PWR
B+
COLUMN_PEDAL_ADJUST_PWR
C3BP01E/12
C3BP01D/9
C3BP01G/9
WH-RD
1
WH-RD
144
BN-RD
1
C12-B/12
C23-D/3
C12-B/11
WH-RD
1
WH-RD
1355
BN-RD
1
SPL818
WH-RD
1
C2H415/3
C2H415/5
C2MC01B/16
C2MC01B/19
OP
FPDB_IGNITION_CTRL
MS_CAN_IN_POS
MS_CAN_IN_NEG
MS_CAN_OUT_POS
MS_CAN_OUT_NEG
CLUSTER_SECURITY
C+
C-
C+
C-
SYSTEM_GND
BK
1
G1D131/1
G1D129/1
IP
P
MS CAN BUS
MS CAN BUS
C3BP01M/9
C3BP01C/7
EN_SU
BK
1
BN-VT
160
BK
1
C11-G/1
G3D138/1
BK
1
EN_RX:EN_RY:EN_KN
EN_SU
Sensor-engine coolant-level - dv6
SIG
GND
SensorEngine coolant-levelPv8_5l
GND
C1MC21A/2C1MC21A/1 C11-G/2
SIG
C1MC21B/1C1MC21B/2 C12-B/3
WH-OG
1
C23-R/4
EN_SU
WH-OG
1
WH-OG
1
EN_RX:EN_RY:EN_KN
BN-VT
1355
EN_SU
C12-B/3
WH-OG
1
C2MC01B/8
C2MC01B/14
OP
IC_SECURITY_OUT
IP
COOLANT_LEVEL_SWITCH
MS_CAN_IN_NEG
MS_CAN_IN_POS
HS_CAN_IN_NEG
HS_CAN_IN_POS
C-
C+
C-
C+
GND
LOGIC_GND
P
C2MC01B/22
P
C2MC01B/32
MS CAN BUS
HS CAN BUS
BK
535
BK
676
SPL187
BK
585
G2D115/1
Sensor-engine coolantLevel
BK
1
G1D131/1
EN_WD
C11-R/1
BK
1
EN_WD
GND
SIG
C1MC21A/2C1MC21A/1
WH-OG
1
EN_WD
C11-R/2
WH-OG
1
EN_WD
C12-B/3
XF - S20753 > (1a) 70
x
Page 87
413-01 - INSTRUMENT CLUSTER Part 4
Part 4
phcr83-70210-d-a4
Ignore both connectors
C44-N/##C44-M/##
(drawn for harness
Manufacturing purposes)
Switch packCenter instrument panel
UNLOCK
C2PL109A/2
BN-GN
1
Junction box-rear
B+
B+
Junction box-central
F23
5A MINI
B+
B+
HAZARD_SW
OP
HAZARD_ILLUM
C+
MS_CAN_POS
C-
MS_CAN_NEG
SYSTEM_GND
B+
ICP_ASS
MS_CAN_IN_POS
MS_CAN_IN_NEG
MS_CAN_OUT_POS
MS_CAN_OUT_NEG
C+
C-
C+
C-
IP
C4BP01M/26
C4BP01D/12
MS CAN BUS
P
C4BP01C/7
C3BP01E/12 C12-B/12
MS CAN BUS
MS CAN BUS
BN-YE
1
GN-OG
1
BK
275
WH-RD
1
C44-M/72 C44-N/72
BK
1
WH-RD
1
C23-R/5
C23-R/15
G4D173/1
SPL818
BN-YE
1
GN-OG
1
WH-RD
1
WH-RD
1
C2PL109A/1
C2PL109A/4
C2PL109A/6
C2ME14A/6
MS CAN BUS
BACKLIGHT_PWM
HAZARD_SWITCH
HAZARD_ILLUM_RTN
HAZARD_ILLUM
Integrated control panel
VBATT
MS_CAN_POS
MS_CAN_NEG
LOCK
VARIANT
SCREEN_PWR
GND
SCREEN_PWR
PWM_BACKLIGHT
VARIANT
C2PL109A/8
C2PL109A/10
C2PL109A/12
C2PL109A/9
C2PL109A/7
C2ME14A/4
C2ME14A/12
C2ME14A/10
C2ME14A/7
GND
GY-BN
1
YE-GN
1
VT-GY
1
WH-BU
1
BK
1
BK
220
G2D116/1
G2D116/1
IP
MASTER_LOCK
IP
MASTER_UNLOCK
P
SYSTEM_GND
C3BP01M/4
C3BP01M/21
C3BP01C/7
GY-BN
1
BN-GN
1
BK
1
G3D138/1
C23-D/4
C23-D/2
XF - S20753 > (1a) 71
x
Page 88
413-13 - PARKING AID Front
413-13 - PARKING AIDFront
phcr83-70481-c-a4
ModuleParking aid
FRONT_SENSOR_SUPPLY
VREF
C4MP01B/2
VT-GY
4219
C44-M/## C44-N/##
C13-B/12
HNLAB
VT-GY
1059
Ignore both connectors
(drawn for harness
Manufacturing purposes)
HNLAB
C11-E/5
VT-GY
694
HNLAB
Junction box-rear
B+
B+
PARK_AID_IGN_SUPPLY
OP
C+
MS_CAN_POS
C-
MS_CAN_NEG
SYSTEM_GND
C4BP01D/2
P
C4BP01C/7
MS CAN BUS
BU
1
BU
1
BK
275
HLLAC:J3KAB
HLLAA*J3KAA
SPL361
HNLAB
HNLAB
HNLAB
SPL341
C11-E/2C13-B/16
C11-E/3
C11-E/4
VT-GY
430
BU-GN
320
VT-GY
36
WH-BU
731
VT-GY
540
BU-GY
1235
HNLAB
HNLAB
HNLAB
HNLAB
HNLAB
HNLAB
C1MP11/2
C1MP10/1
C1MP10/2
C1MP12/2
Sensor-parking aidOuter-front-lh
PWR RTN
SIGNAL
Sensor-parking aidInner-front-lh
PWR RTN
SIGNAL
Sensor-parking aidInner-front-rh
PWR RTN
SIGNAL
C1MP11/3C1MP11/1
C1MP10/3
C1MP12/3C1MP12/1
YE-OG
430
YE-OG
36
YE-OG
540
HNLAB
HNLAB
HNLAB
SPL340
C-
MS CAN BUS
BU
1
C44-N/72C44-M/72
HLLAC:J3KAB
BK
1
BU
1
BU
1
C44-M/13 C44-N/13
HLLAA*J3KAA
HLLAC:J3KAB
C44-N/13C44-M/13
G4D173/1
C4MP01A/1
MS_CAN_NEG
C+
MS_CAN_POS
LF_OUTBOARD_SENSOR
LF_INBOARD_SENSOR
RF_INBOARD_SENSOR
B
IGN_SUPPLY
IP
IP
IP
C4MP01B/5
C4MP01B/6
C4MP01B/7
BU-GN
4219
WH-BU
4219
BU-GY
4219
HNLAB
HNLAB
HNLAB
C13-B/15
C13-B/14
BU-GN
1059
WH-BU
1059
BU-GY
1059
Sensor-parking aidOuter-front-rh
C1MP13/3C1MP13/1
YE-OG
1076
YE-OG
694
HNLAB
HNLAB
Overhead console
PARKING
AID
SWITCH
PARKING
AID
STATUS LED
PARKING_AID_SW
PARK_AID_STATUS
GND
C9LN28/12 C4MP01A/4
C9LN28/11 C4MP01A/13
C9LN28/10
GN-BN
1
GN-BU
1
BK
1220
C44-M/14 C44-N/14
C44-N/15C44-M/15
G3D138/1
GN-BN
1
GN-BU
1
RF_OUTBOARD_SENSOR
IP
SWITCH_INPUT
FRONT_SENOR_GND
OP
STATUS_LED
GREF
GND
IP
P
C4MP01B/8
C4MP01B/1
C4MP01A/8
BU-OG
4219
YE-OG
4219
BK
1
HNLAB
HNLAB
C13-B/13
BU-OG
1059
SPL841
HNLAB
C13-B/17
BK
1
C11-E/6
VT-GY
1076
BU-OG
1770
YE-OG
1059
G4D171/1
HNLAB
HNLAB
HNLAB
C1MP13/2
C11-E/1
PWR RTN
SIGNAL
XF - S20753 > (1a) 72
x
Page 89
413-13 - PARKING AID Rear
Rear
phcr83-70481-a-a4
Ignore both connectors
(drawn for harness
Manufacturing purposes)
BU-WH
212
C44-F/4
SPL243
BU-WH
542
Junction box-rear
MS CAN BUS
ModuleParking aid
C-
MS_CAN_NEG
C+
MS_CAN_POS
REAR_SENSOR_SUPPLY
VREF
C4MP01C/11
BU-WH
212
C44-M/## C44-N/##
C44-N/55 C44-M/55
B+
B+
Overhead console
PARKING
AID
SWITCH
PARKING
AID
STATUS LED
PARK_AID_IGN_SUPPLY
OP
C+
MS_CAN_POS
C-
MS_CAN_NEG
SYSTEM_GND
PARKING_AID_SW
PARK_AID_STATUS
GND
C4BP01D/2
MS CAN BUS
P
C4BP01C/7
C9LN28/12 C4MP01A/4
C9LN28/11 C4MP01A/13
C9LN28/10
BU
1
BU
1
BK
275
GN-BN
1
GN-BU
1
BK
1220
HLLAC:J3KAB
HLLAA*J3KAA
SPL361
BU
1
C44-N/72C44-M/72
BU
1
BU
1
C44-M/14 C44-N/14
C44-N/15C44-M/15
G3D138/1
HLLAC:J3KAB
BK
1
HLLAA*J3KAA
HLLAC:J3KAB
C44-M/13 C44-N/13
GN-BN
1
GN-BU
1
C44-N/13C44-M/13
G4D173/1
C4MP01A/1
LR_OUTBOARD_SENSOR
LR_INBOARD_SENSOR
RR_INBOARD_SENSOR
B
IGN_SUPPLY
RR_OUTBOARD_SENSOR
IP
SWITCH_INPUT
OP
STATUS_LED
REAR_SENSOR_GND
IP
C4MP01C/5 C4MP15/2C44-F/2
IP
C4MP01C/3 C4MP14/2C44-F/1
IP
IP
GREF
C4MP01C/8
P
C4MP01A/8
GND
YE-GN
212
WH-OG
212
YE-GY
212
YE-OG
212
GN-WH
212
BK
1
C44-N/58 C44-M/58
C44-N/59 C44-M/59
C44-M/56C44-N/56
C44-M/57C44-N/57
C44-M/60C44-N/60
SPL841
YE-GN
WH-OG
YE-GY YE-GY
212
YE-OG YE-OG
212
GN-WH
212
BK
1
C44-F/3
G4D171/1
BU-WH
928
YE-GN
1470212
BU-WH
480
WH-OG
1022212
BU-WH
50
593
BU-WH
522
76
GN-WH
542
C4MP15/1
C4MP14/1
C4MP16/1
C4MP16/2C4MP01C/2 C44-F/6
C4MP17/1
C4MP17/2C4MP01C/4 C44-F/5
Sensor-parking aidOuter-rear-lh
PWR RTN
SIGNAL
T216
Sensor-parking aidInner-rear-lh
PWR RTN
SIGNAL
Sensor-parking aidInner-rear-rh
PWR RTN
SIGNAL
Sensor-parking aidOuter-rear-rh
PWR RTN
SIGNAL
C4MP15/3
C4MP14/3
C4MP16/3
C4MP17/3
GN-WH
928
GN-WH
480
GN-WH
50
GN-WH
522
SPL242
XF - S20753 > (1a) 73
x
Page 90
413-13 - PARKING AID Rear view camera
Rear view camera
phcr83-70481-b-a4
Ignore both connectors
C44-M/## C44-N/##
(drawn for harness
Manufacturing purposes)
MOST BUS
Junction box-rear
B+
B+
F6
40A A1-S
Touch screen
Display
MOST_TX
MOST_RX
RVPA_CAMERA_CVBS_SIG
RVPA_CAMERA_CVBS_GND
PARK_AID_IGN_SUPPLY
MS_CAN_POS
MS_CAN_NEG
SYSTEM_GND
F24
15A MINI
SUPPLY_1
SUPPLY_2
C2MC02A/8
C2MC02A/16
C2MC02C/1
C2MC02C/2
OP
RVPA_LIN
C+
C-
B+
HLDF
C4BP01D/2
L
C4BP01K/10
P
C4BP01C/7
C4BP01E/9
RD
1
SCR
1
MS CAN BUS
BK
275
VT-RD
1
VT-RD
1
VT-RD
1
J3KAB
J3KAB
BU
1
WH-BU
1
HLLAC:J3KAB
J3KAB
C44-M/72 C44-N/72
C23-D/5
C23-K/1
C23-K/2
VT-RD
1257
RD
1
SCR SCR
1
BK
1
J3KAB
J3KAB
SPL361
SPL165
BK
1
G4D173/1
C44-N/61 C44-M/61
J3KAB
Camera-rear view
BU
1
C44-M/71C44-N/71
C44-M/62C44-N/62
BK
1
RD
1
1
J3KAB J3KAB
J3KAB
J3KAB
C44-B/1
C44-B/2
BK
1
BK
485
BK
1
BK
1
SCR
1
J3KAB
J3KAB
J3KAB
J3KAB
J3KAB
C44-C/1C44-A/1
C44-C/8C44-A/8
C44-C/9C44-A/9
C44-D/1
C44-D/2
BK
1
BK
1
J3KAB
J3KAB
BK
1
BK
1
SCR
1
SPL355
BK
1
J3KAB
J3KAB
J3KAB
BK
1
J3KABJ3KAB
C4MP19A/1
C4MP19A/2
C4MP19A/3
C4MP19A/4
C4MP19A/6
C4MP19A/7
SUPPLY
LIN
GND
SHIELD
VIDEO_POS
VIDEO_NEG
for camera
GND_2
GND_1
LIN
C2MC02A/5
C2MC02A/13
BK
220
BK
220
PARK_AID_CAMERA
G2D116/1
MS CAN BUS
MS_CAN_NEG
MS_CAN_POS
HLDF
XF - S20753 > (1a) 74
x
Page 91
414-01 - BATTERY, MOUNTING AND CABLES Battery cables - Petrol (PV8 5.0L)
414-01 - BATTERY, MOUNTING AND CABLESBattery cables - Petro l (PV8 5.0L)
phcr83-70010-b-a4
Relay-transit
BK
1
C44-M/70C44-N/70
BK
1
C4DC27/1
TIMER
C4DC27/2
BN-WH
1
C23-R/14
BN-WH
1
SPL438
BN-WH
1
G4D171/1
BK
360
G4D178/1
Battery
C4D101/1 C4DC02A/1
+-
RD
148
PETROL
Junction box-battery
400A
C4BF10A/1C4DF10A/1
250A
C4BF10B/1
250A
C4BF10C/1
RD
3264
PETROL
Diagnostic connector
C2DB04B/1
TRANSIT
Instrument cluster
C-
HS CAN BUS
HS_CAN_IN_NEG
C+
HS_CAN_IN_POS
Stud-cable junction
C1DC12A/1 C1DC12B/1
L
LIN
C2MC01A/22
RD
1
BN-WH
1
WH
190
EN_RX:EN_RY
SPL069
SPL86
RD
1
WH
1
EN_RX:EN_RY
Start control unit
SUPPLY
C2DC06/3
LIN
Generator
C1DC16/1
BATT GND
Starter motor
TRANSIT_MODE
GND
C2DC06/4
C2DC06/2
LIN
BK
1
G2D115/1
AJ133
Stud-through panel
C3DC11A/1
C1DC11B/1
C44-M/## C44-N/##
RD
1
RD
1
EN_RX:EN_RY:EN_SU:EN_KN
Ignore both connectors
(drawn for harness
Manufacturing purposes)
SPL080
RD
1
SPL200
RD
1
RD
1
RD
1
RD
400
EN_RX:EN_RY:EN_SU:EN_KN
EN_RX:EN_RY:EN_SU:EN_KN
C4BP01P/1
C3BP01P/1
C1BB01C/1
C1BB01D/1
Junction box-rear
B+
B+
BCMB LOADS
Junction box-central
B+
B+
BCM LOADS
Junction-box engine
B+
FAN_MIDIFUSE COOLING_FAN
FPDB LOADS
F45
100A MIDIFUSE
RD
1
EN_RX:EN_RY
C1DC35A/1 C1D101/1
MOTOR
SOLENOID
GND
BK
1
G1D124/1
x
XF - S20753 > (1a) 75
Page 92
414-01 - BATTERY, MOUNTING AND CABLES Battery cables - DV6
Battery cables - DV6
phcr83-70010-c-a4
Relay-transit
BK
1
C44-N/70 C44-M/70
BK
1
C4DC27/1
TIMER
C4DC27/2
BN-WH
1
C23-R/14
1
SPL438
BN-WHBN-WH
1
G4D171/1
BK
360
G4D178/1
Stud-through panel
C4D101/1 C4DC02B/1 C1DC12A/1 C1DC12B/1
C3DC11A/1
C1DC11B/1
Battery
RD
1
Diagnostic connector
HS CAN BUS
TRANSIT
Instrument cluster
C-
HS_CAN_IN_NEG
C+
HS_CAN_IN_POS
C2DB04B/1
L
C2MC01A/22
LIN
BN-WH
1
WH
190
SPL86
WH
1
C2DC06/3
Start control unit
SUPPLY
TRANSIT_MODE
LIN
GND
C2DC06/4
C2DC06/2
BK
1
G2D115/1
Generator
Junction box-battery
450A
250A
250A
C4BF10A/1
C4BF10B/1
C4BF10C/1
BK
3430
RD
400
EN_SU:EN_KN
C4BP01P/1
+-
RD
505
EN_SU:EN_KN
SPL080
C4DF10B/1
RD
1
Stud-cable junction
Junction box-rear
B+
B+
BCMB LOADS
RD
1
RD
1
EN_SU
EN_SU
C1DC16/1
C1DC35B/1
C1DC35A/1
BATT GND
Starter motor
ALTERNATOR
MOTOR
SOLENOID
LIN
GND
C1D101/1
BK
1
G1D124/1
Junction box-central
RD
1
C3BP01P/1
B+
B+
BCM LOADS
Junction-box engine
RD
1
Ignore both connectors
C44-M/##C44-N/##
(drawn for harness
Manufacturing purposes)
EN_RX:EN_RY:EN_SU:EN_KN
SPL200
RD
1
RD
1
EN_RX:EN_RY:EN_SU:EN_KN
EN_RX:EN_RY:EN_SU:EN_KN
C1BB01C/1
C1BB01D/1
B+
FAN_MIDIFUSE COOLING_FAN
FPDB LOADS
F45
100A MIDIFUSE
XF - S20753 > (1a) 76
x
Page 93
414-01 - BATTERY, MOUNTING AND CABLES Battery cables - D4
Battery cables - D4
phcr83-70010-a-a4
Relay-transit
BK
1
C44-N/70 C44-M/70
BK
1
C4DC27/1
TIMER
C4DC27/2
BN-WH
1
C23-R/14
BN-WH
1
SPL438
BN-WH
1
G4D171/1
BK
360
G4D178/1
Diagnostic connector
C2DB04B/1
TRANSIT
Instrument cluster
C-
HS CAN BUS
HS_CAN_IN_NEG
C+
HS_CAN_IN_POS
Junction box-battery
350A
150A
Battery
C4D101/1 C4DC02B/1 C1DC12A/1 C1DC12B/1
+-
RD
505
EN_SU:EN_KN
C4DF10B/1
450A
250A
250A
C4BF10E/1
C4BF10A/1
C4BF10B/1
C4BF10C/1
RD
124
BK
3430
EN_SU:EN_KN
EN_SU:EN_KN
Stud-cable junction
L
LIN
C2MC01A/22
BN-WH
1
WH
190
C33-K/1
SPL86
RD
124
WH
1
EN_SU:EN_KN
C2DC06/3
C2HP01B/1
Start control unit
SUPPLY
TRANSIT_MODE
LIN
GND
C2DC06/4
C2DC06/2
Heater-electric booster
LIN
BATTERY
DIESEL ONLY
GND
C2HP01C/1
BK
1
BK
84
G2D115/1
EN_SU:EN_KN
G3D169/1
Stud-through panel
C3DC11A/1
C1DC11B/1
C44-N/## C44-M/##
RD
1
RD
1
Ignore both connectors
(drawn for harness
Manufacturing purposes)
SPL080
EN_RX:EN_RY:EN_SU:EN_KN
RD
1
SPL200
RD
400
RD
1
RD
1
RD
1
EN_RX:EN_RY:EN_SU:EN_KN
EN_RX:EN_RY:EN_SU:EN_KN
C4BP01P/1
C3BP01P/1
C1BB01C/1
C1BB01D/1
Junction box-rear
B+
B+
BCMB LOADS
Junction box-central
B+
B+
BCM LOADS
Junction-box engine
B+
FAN_MIDIFUSE COOLING_FAN
FPDB LOADS
F45
100A MIDIFUSE
RD
680
RD
630
EN_KN
EN_KN
C1DC35A/1
C1DC16/1
Starter motor
MOTOR
SOLENOID
Generator
BATT GND
C1D101/1
GND
LIN
BK
1
G1D124/1
x
XF - S20753 > (1a) 77
Page 94
414-01 - BATTERY, MOUNTING AND CABLES Engine junction box - Common 1
Engine junction box - Common 1
phcr83-70010-k-a4
Junction-box engine
F5
40A A1
F27
5A MINI
F26
10A MINI
F25
10A MINI
F31
20A MINI
F32
20A MINI
CIGAR LIGHTER
RELAY
HIGH CURRENT
RLY4
CIGAR_LTR_RLY_SUPPLY
F7
50A A1
HORN
RELAY
1/2 ISO
RLY2
F21
25A MINI
F20
15A MINI
B+
ABS_PUMP
TCM_EMS_POWER
POWERPOINT
CIGAR_LTR_FUSE
POWERPOINT_FUSE
CIGAR_LTR_RLY_OUT
CIGAR_LTR_RLY_CTRL
CIGAR_LTR_RLY_COIL
CIGAR_LTR_FUSE_1
HORN_SUPPLY
HORN_RLY_CTRL
HORN_RLY_COIL
HORN_RLY_SUPPLY
ABS_VALVES
SAI_FUSE
ABS_ECM
TAP1_2
TAP1_1
CIGAR_LTR
HORN_RLY
TAP2_2
TAP2_1
C1BB01B/9
C1BB01B/32
C1BB01B/31
C1BB01B/75
C1BB01B/74
C1BB01B/41
C1BB01B/43
C1BB01B/42
C1BB01B/40
C1BB01B/D5
C1BB01B/D2
C1BB01B/D1
C1BB01B/D3
C1BB01B/11
C1BB01B/B5
C1BB01B/B2
C1BB01B/B1
C1BB01B/B3
C1BB01B/26
C1BB01B/25
C1BB01B/73
C1BB01B/72
GY-RD
96
YE-RD
28
RD
1
BU-OG
2127
GN-VT
2127
GN-BU
1
GN-BU
1
GN-BU
1
WH-RD
1
WH-RD
1
WH-RD
1
BK
1064
GN-RD
0
GN-RD
0
GN-RD
0
RD
1
SPL283
SPL892
SPL891
C13-D/8
SPL310
BU-WH
2123
YE-RD
2099
YE-RD
2107
GN-VT
2540
C12-A/5
BU-WH
56
C13-C/16
C11-P/31
C33-C/1C13-D/1
SPL246
YE-RD
2568
Tcm and control valve body
BU-WH
114
C33-C/20
YE-RD
1
YE-RD
1
RD
96
BU-OG
1
GN-VT
2540
GY-YE
2199
BU-WH
2980
BU-WH
1690
GY-RD
96
EN_RX:EN_RY
C1CA01B/1
C1E120B/43
C3ET37/1
C1CA01B/7
C3DC09/2
C3DC07A/1
C3BP01J/11
C1RH02/1
C4BP01D/14C23-R/6
C2R115A/7
C1CA01B/25
Abs module
Engine controlModule (ecm)
Module-transmission shift
Abs module
Socket-accessoryRear
Cigar lighter-front
Junction box-central
Horn(s)
Junction box-rear
Clock spring
Abs module
XF - S20753 > (1a) 78
x
Page 95
414-01 - BATTERY, MOUNTING AND CABLES Engine junction box - Common 2
Engine junction box - Common 2
phcr83-70010-l-a4
Junction-box engine
FAN_MIDIFUSE
F45
100A MIDIFUSE
STARTER MOTOR
RELAY
FULL ISO
RLY17
STARTER_MOTOR_RLY_COIL
STARTER_MOTOR_RLY_SUPPLY
F14
30A A1
F28
5A MINI
F29
5A MINI
COOLING_FAN
STR_MOTOR_SUPPLY
STR_MOTOR_RLY_CTRL
STARTER_MOTOR_RLY
LH_AFS_MOT_OP
RH_AFS_MOT_OP
C1-34
C1-36
C1BB01E/1
C1BB01B/Q5
C1BB01B/Q2
C1BB01B/Q1
C1BB01B/Q3
C1BB01B/18
C1BB01B/34
C1BB01B/36
RD
1
BN-RD
0
VT-WH
1
VT-WH
1
EN_RX:EN_RY:EN_SU:EN_KN
EN_RX:EN_RY:EN_WD:EN_SU
JBBBB
JBBBB
C1EC01D/1
Control unitCooling fan
VT-OG
2135
GY-OG
12
GY-OG
1
GY-OG
1
GY-OG
1
YE
1
YE
1
YE
2131
EN_WD
EN_KN
EN_SU
EN_RX:EN_RY
EN_SU
EN_RX:EN_RY
EN_WD
C11-P/34
Starter motor
C1E117B/51
C1E104C/41
C1E116B/42
C1E120B/9
C1E104C/17
C1E116B/19
C1E120B/11
C1E117B/11
C1LF08A/14
C1LF09A/14
Engine controlModule (ecm)
Engine controlModule (ecm)
Engine controlModule (ecm)
Engine controlModule (ecm)
Engine controlModule (ecm)
Engine controlModule (ecm)
Engine controlModule (ecm)
Engine controlModule (ecm)
Headlamp-lh
Headlamp-rh
F39
HEADLAMP_LEVEL
5A MINI
F38
5A MINI
F37
15A MINI
F19
5A MINI
IGN_COILS_VAPS_HEADLAMP_LEVEL
IGNITION
RELAY
1/2 ISO
RLY19
F9
50A A1
IGNITION_RLY_DIODE_CATHODE
D1
B+
IGNITION_RLY_DIODE_ANODE
IGN_COILS
ACC_SUPPLY
ACC_FUSE
AFS_MOT_IP
IGNITION_RLY_OUTPUT
IGNITION_RLY_COIL
IGNITION_RLY_CTRL
IGNITION_RLY_SUPPLY
EMS_POWER_FUSE
VAPS
C1-35
C1BB01B/57
C1BB01B/55
C1BB01B/53
C1BB01B/24
C1BB01B/23
C1BB01B/54
C1BB01B/37
C1BB01B/S5
C1BB01B/S2
C1BB01B/S1
C1BB01B/S3
C1BB01B/13
C1BB01B/68
C1BB01B/69
VT-WH
602
GY-BU
2123
WH
2051
BN-WH
1
YE-GY
0
YE-GY
0
YE-GY
0
YE-GY
0
BK
0
RD
0
RD
0
GY-BN
0
GN-VT
28
EN_RX:EN_RY:EN_WD
GTDAD
GTDAD
GTDAD:JBBBB
JBBBB
GTDAD:JBBBB
SPL792
SPL103
C1BB01B/54
C1BB01B/S5
G1D123/1
YE-GY
0
GTDAB*JBBAC
SPL305
C12-B/8
SPL528
VT-WH
1850
VT-WH
1
VT-WH
1
GY-BU
1297
GN-VT
2171
C1LF39/10
C1LF08A/5
C1LF09A/5
C2MC01B/29
C11-P/30
C1MF04A/1
C3BP01E/5
Module-headlamp
Control
Headlamp-lh
Headlamp-rh
Instrument cluster
Ignition coils
Speed control module
Junction box-central
XF - S20753 > (1a) 79
x
Page 96
414-01 - BATTERY, MOUNTING AND CABLES Engine junction box - PV8 EMS (5.0L)
Engine junction box - PV8 EMS (5.0L)
phcr83-70010-e-a4
Junction-box engine
D1
IGNITION_RLY_DIODE_ANODE
C1BB01B/69
GN-VT
28
SPL305
GN-VT
2171
C3BP01E/5
Junction box-central
EMS_SUPPLY_5
F36
20A/15A MINI
IGN_COILS_VAPS_HEADLAMP_LEVEL
IGNITION
RELAY
1/2 ISO
EMS_SUPPLY_5_FUSE
IGNITION_RLY_DIODE_CATHODE
F37
15A MINI
IGN_COILS
IGNITION_RLY_OUTPUT
S
IGNITION_RLY_COIL
RLY19
IGNITION_RLY_CTRL
IGNITION_RLY_SUPPLY
F44
5A/10A/15A MINI
F43
5A/10A MINI
F42
10/20A/30A MINI
F41
5A/10A MINI
HIGH CURRENT
PETROL/DIESEL
EMS
RELAY
RLY16
F9
B+ EMS_POWER_FUSE
50A A1
S/CHARGED
WATERPUMP
RELAY
1/2 ISO
RLY18
SC_WATER_PMP_RLY_SUPPLY
F40
15A MINI
EMS_SUPPLY_4
EMS_SUPPLY_3
EMS_SUPPLY_2
EMS_SUPPLY_1
EMS_FUSES
EMS_FUSE_SUPPLY
EMS_RLY_CTRL
EMS_RLY_COIL
EMS_RLY_SUPPLY
SC_PMP_RLY_OUT
SC_PMP_RLY_CTRL
SC_WATER_PMP_RLY_COIL
SC_WATER_PUMP
SC_WATER_PUMP_SUPPLY
C1BB01B/50
C1BB01B/68
C1BB01B/53
C1BB01B/54
C1BB01B/S5
C1BB01B/S2
C1BB01B/S1
C1BB01B/S3
C1BB01B/67
C1BB01B/65
C1BB01B/63
C1BB01B/61
C1BB01B/62
C1BB01B/P5
C1BB01B/P2
C1BB01B/P1
C1BB01B/P3
C1BB01B/13
C1BB01B/R5
C1BB01B/R2
C1BB01B/R1
C1BB01B/R3
C1BB01B/58
C1BB01B/59
BU-BN
1
GY
0
GY-BN
0
YE-GY
0
YE-GY
0
BK
0
RD
0
VT
1
GY
1
GN
1
GY
0
GY
0
RD
0
RD
0
RD
0
GY
0
RD
0
VT-RD
0
YE-GN
708
EN_RX:EN_RY
EN_RX:EN_RY:EN_SU
SPL103
GTDAD:JBBBB
GTDAD:JBBBB
EN_RX:EN_RY
EN_RX*EM_N:EN_RY*EM_N
EN_RX:EN_RY
EN_RX:EN_RY:EN_SU:EN_KN
EN_RX:EN_RY:EN_SU:EN_KN
EN_RY
EN_RY
EN_RY
EN_RY
C1BB01B/54
C1BB01B/S5
SPL792
YE-GY
0
SPL862
GTDAB*JBBAC
G1D123/1
SPL871
C11-R/6
SPL083
SPL858
SPL859
BU-BN
1
BU-BN
1
WH
2051
VT
1
VT
1
GY
1
GY
1
GY
1
GN
1
GN
1
BU
1
GY-VT
1
BN
1
YE-GN
140
EN_RX:EN_RY
EN_RX:EN_RY
EN_RX:EN_RY:EN_WD
EN_RX:EN_RY
EN_RX:EN_RY
EN_RX*EM_N:EN_RY*EM_N
EN_RX*EM_N:EN_RY*EM_N
EN_RX*NO_EM_N:EN_RY*NO_EM_N
EN_RX:EN_RY
EN_RX:EN_RY
EN_RX:EN_RY
EN_RX:EN_RY
EN_RY
EN_RY
C13-D/2
GY
3126
C11-P/30
C11-P/41
C11-P/5
C11-P/11
EM_N
C1E120B/5C1BB01B/51
C1E120B/6
C1E120B/33
C4E730/4
C1EC01D/4
C1E120B/46
C1E120B/15
C1E120B/35
C1E318B/2
Engine controlModule (ecm)
Engine controlModule (ecm)
Refer to actuators
Refer to actuators
Engine controlModule (ecm)
Unit-leak detection
Refer to sensors
Control unitCooling fan
Refer to actuators
Engine controlModule (ecm)
Engine controlModule (ecm)
Engine controlModule (ecm)
Pump-superchargeCoolant
x
XF - S20753 > (1a) 80
Page 97
414-01 - BATTERY, MOUNTING AND CABLES Engine junction box - Petrol Emissions
Engine junction box - Petrol Emissions
phcr83-70010-g-a4
Junction-box engine
F4
20A A1
F3
20A A1
HEGO
RELAY
FULL ISO
RLY8
HEGO_A_HEATERS
HEGO_B_HEATERS
HEGO_B_FUSE
HEGO_A_FUSE
HEGO_RELAY_OUT
HEGO_RELAY_CTRL
HEGO_RELAY_COIL
HEGO_RELAY_SUPPLY
C1BB01B/6
C1BB01B/8
C1BB01B/7
C1BB01B/5
C1BB01B/H5
C1BB01B/H1
C1BB01B/H2
C1BB01B/H3
VT
2135
VT
0
VT
0
VT
0
BK
0
GY
2141
EN_RX:EN_RY:EN_WD
EN_RX:EN_RY:EN_WD
EN_RX:EN_RY:EN_WD
EN_RX:EN_RY:EN_WD
EN_RX:EN_RY:EN_WD
EN_RX:EN_RY:EN_WD
SPL291
G1D123/1
C11-P/1
C11-P/9
YE-VT
2199
EN_RX:EN_RY:EN_WD
C3BP01E/15
Sensor-oxygen-oddPost catalyst
Sensor-oxygen-oddPre-catalyst
Sensor-oxygen-evenPost catalyst
Sensor-oxygen-evenPre-catalyst
Junction box-central
B+
C1BB01B/76
TAP3_1
RD
1
EN_RX:EN_RY:EN_WD
XF - S20753 > (1a) 81
x
Page 98
414-01 - BATTERY, MOUNTING AND CABLES Engine junction box - DV6 EMS
Engine junction box - DV6 EMS
phcr83-70010-j-a4
Junction-box engine
F44
5A/10A/15A MINI
EMS_SUPPLY_4
C1BB01B/67
VT
1
EN_SU
SPL869
VT
1
BN-BU
1
EN_SU
EN_SU
C11-P/1
C1E808B/4
Refer to actuators
Sensor-maf/iat-bank 2
F43
5A/10A MINI
F42
10A/20A/30A MINI
F41
5A/10A MINI
F36
15A/20A MINI
F35
5A MINI
COMPRESSOR CLUTCH
RELAY
1/2 ISO
RLY5
EMS_SUPPLY_3
EMS_SUPPLY_2
EMS_SUPPLY_1
EMS_SUPPLY_5
AC_COMP_CLUTCH
AC_COMP_CLUTCH_FUSE
COMP_RELAY_CTRL
COMP_RELAY_COIL
COMP_RELAY_SUPPLY
EMS_SUPPLY_5_FUSE
C1BB01B/65
C1BB01B/63
C1BB01B/61
C1BB01B/51
C1BB01B/49
C1BB01B/48
C1BB01B/E5
C1BB01B/E2
C1BB01B/E1
C1BB01B/E3
C1BB01B/50
GY
1
GN
1
BU-BN
1
VT-WH
1
BK
1
GY
1
GY
0
EN_SU
EN_SU
EN_SU
EN_SU:EN_KN
EN_SU:EN_KN
EN_SU:EN_KN
EN_RX:EN_RY:EN_SU
SPL862
G1D123/1
WH-OG
1
EN_SU:EN_KN
SPL168
SPL863
SPL870
C12-B/15
GY
1
GY
1
GY
1
GN
1
GN
1
BU
1
BU-BN
1
BU-BN
1
BN-BU
1
YE-GY
1
WH-OG
1
EN_SU
EN_SU
EN_SU
EN_SU
EN_SU
EN_SU:EN_KN
EN_SU
EN_SU
EN_SU
EN_SU:EN_KN
EN_SU:EN_KN
C11-P/5
C11-P/4
C11-P/3
C11-P/12
C1E823/1
C1EC01D/4
C1E116B/3
C1E116B/5
C1E513A/4
C1E807B/4
C2H101A/2
Refer to sensors
Water in fuel
Sensor
Control unitCooling fan
Engine controlModule (ecm)
Engine controlModule (ecm)
Refer to sensors
Refer to vehicle interface
Ecu-glow plug
Sensor-maf/iat-bank 1
Refer to climate control
Module-climate
Control
EMS_FUSES
HIGH CURRENT
PETROL/DIESEL
EMS
RELAY
EMS_FUSE_SUPPLY
RLY16
50AF9A1
B+
F18
A360A
EMS_RLY_CTRL
EMS_RLY_COIL
EMS_RLY_SUPPLY
EMS_POWER_FUSE
GLOWPLUG_MODULE
C1BB01B/62
C1BB01B/P5
C1BB01B/P2
C1BB01B/P1
C1BB01B/P3
C1BB01B/13
C1BB01B/22
GY
0
GY
0
RD
0
RD
0
EN_RX:EN_RY:EN_SU:EN_KN
EN_RX:EN_RY:EN_SU:EN_KN
RD
0
SPL792
GY-VT
1
BN-RD
1
EN_SU
EN_SU
C1E116B/55
C1E513A/5
Engine controlModule (ecm)
Ecu-glow plug
XF - S20753 > (1a) 82
x
Page 99
414-01 - BATTERY, MOUNTING AND CABLES Engine junction box - D4
Engine junction box - D4
phcr83-70010-d-a4
Junction-box engine
F44
5A/10A/15A MINI
F43
5A/10A MINI
F42
10A/20A/30A MINI
F41
5A/10A MINI
F36
15A/20A MINI
F35
5A MINI
EMS_SUPPLY_4
EMS_SUPPLY_3
EMS_SUPPLY_2
EMS_SUPPLY_1
EMS_SUPPLY_5
AC_COMP_CLUTCH
AC_COMP_CLUTCH_FUSE
C1BB01B/67
C1BB01B/65
C1BB01B/63
C1BB01B/61
Not used
C1BB01B/49
C1BB01B/48
VT
1
GY
1
GN
1
BU
1
YE-GY
1
VT-WH
1
EN_KN
EN_KN
EN_KN
EN_SU:EN_KN
EN_SU:EN_KN
EN_SU:EN_KN
SPL894
SPL893
GY
1
EN_KN
GY
1
GN
1
GN
1
EN_KN
EN_KN
EN_KN
C11-P/1
C11-P/29
C11-P/4
C1EC01D/4
C1E104C/2
C1E104C/5
Refer to actuators
Refer to sensors
Control unitCooling fan
Engine controlModule (ecm)
Engine controlModule (ecm)
Refer to actuators
COMPRESSOR CLUTCH
RELAY
1/2 ISO
COMP_RELAY_CTRL
RLY5
COMP_RELAY_COIL
COMP_RELAY_SUPPLY
EMS_SUPPLY_5_FUSE
HIGH CURRENT
PETROL/DIESEL
EMS
RELAY
EMS_FUSE_SUPPLY
RLY16
50AF9A1
EMS_RLY_CTRL
EMS_RLY_COIL
EMS_RLY_SUPPLY
EMS_POWER_FUSE
EMS_FUSES
C1BB01B/E5
C1BB01B/E2
C1BB01B/E1
C1BB01B/E3
Not used
C1BB01B/62
C1BB01B/P5
C1BB01B/P2
C1BB01B/P1
C1BB01B/P3
C1BB01B/13
BK
1
GY
1
GY
0
GY
0
RD
0
RD
0
RD
0
EN_SU:EN_KN
EN_SU:EN_KN
EN_RX:EN_RY:EN_SU:EN_KN
EN_RX:EN_RY:EN_SU:EN_KN
SPL862
SPL792
G1D123/1
WH-OG
1
EN_SU:EN_KN
C12-B/15
WH-OG
1
GY-VT
1
EN_SU:EN_KN
EN_KN
C11-P/12
C2H101A/2
C1E104C/28
Refer to climate control
Module-climate
Control
Engine controlModule (ecm)
B+
F18
A360A
GLOWPLUG_MODULE
C1BB01B/22
BN-RD
1
EN_KN
C1E513C/4
Ecu-glow plug
XF - S20753 > (1a) 83
x
Page 100
414-01 - BATTERY, MOUNTING AND CABLES Engine junction box - Visibility
Engine junction box - Visibility
phcr83-70010-m-a4
Junction-box engine
WIPER RUN/PARK
RELAY
1/2 ISO
RLY15
WIPER_RUN_PARK_RLY_COIL
WIPER_RUN_PARK_RLY_SUPPLY
WIPER
HI/LOW
RELAY
FULL ISO
RLY12
MOTOR_PARK
MOTOR_RUN
RUN_PARK_RLY_CTRL
LOW_SPEED_OUTPUT
HI_SPEED_OUTPUT
HI_LOW_RLY_CTRL
WIPER_HI_LOW_RLY_COIL
WIPER_HI_LOW_RLY_SUPPLY
C1BB01B/O4
C1BB01B/O5
C1BB01B/O2
C1BB01B/O1
C1BB01B/O3
C1BB01B/L4
C1BB01B/L5
C1BB01B/L2
C1BB01B/L1
C1BB01B/L3
GY-RD
0
GY-RD
0
GY-RD
0
VT-WH
0
SPL288
BK
1500
G1D123/1
GY-BN
2199
GY-BN
2412
BN-WH
2412
BN-WH
2199
C3BP01J/2
C1RW01/2
C1RW01/1
C3BP01J/17
Junction box-central
Motor-wiperWindscreen
Motor-wiperWindscreen
Junction box-central
F13
30A A1
POWERWASH PUMP
RELAY
FULL ISO
RLY14
POWERWASH_RLY_SUPPLY
F6
30A A1
RH FRONT SCREEN
HEATER RELAY
FULL ISO
RLY10
RH_FRONT_SCREEN_HTR_RLY_COIL
RH_FRONT_SCREEN_HTR_RLY_SUPPLY
F15
40A A1
RH_FRONT_SCREEN_HTR_RLY
LH FRONT SCREEN
HEATER RELAY
FULL ISO
RLY11
LH_FRONT_SCREEN_HTR_RLY_COIL
LH_FRONT_SCREEN_HTR_RLY_SUPPLY
F16
B+ LH_FRONT_SCREEN_HTR_RLY
40A A1
WIPER_RLYS
PWASH_PMP_SUPPLY
PWASH_RLY_CTRL
POWERWASH_RLY_COIL
POWERWASH_RLY
RHF_HTR_SUPPLY
RHF_HTR_RLY_CTRL
LHF_HTR_SUPPLY
LHF_HTR_RLY_CTRL
C1BB01B/17
C1BB01B/N5
C1BB01B/N2
C1BB01B/N1
C1BB01B/N3
C1BB01B/10
C1BB01B/J5
C1BB01B/J2
C1BB01B/J1
C1BB01B/J3
C1BB01B/20
C1BB01B/K5
C1BB01B/K2
C1BB01B/K1
C1BB01B/K3
C1BB01B/19
GY-RD
0
BN-RD
0
BN-RD
0
BN-RD
0
GY-OG
28
GN-VT
28
VT-RD
0
GY-OG
28
GN-VT
28
WH-RD
0
CFKAB
CFKAB
CFKAB
B3MAB
B3MAB
B3MAB
B3MAB
B3MAB
B3MAB
SPL287
SPL305
SPL296
BU-GN
2127
BN-BU
3074
B3MAB
B3MAB
GN-VT
2171
C13-D/7
C13-E/7
WH-BU
264
YE-GN
2199
BU-GN
446
GY-OG
2171
BN-BU
488
CFKAB
CFKAB
B3MAB
B3MAB
B3MAB
C1RW18/1
C3BP01J/18
C9RD04A/1
C3BP01J/25
C3BP01E/5
C9RD03A/1
Pump-power wash
Junction box-central
Windshield rh
Heater element
Junction box-central
Junction box-central
Windshield lh
Heater element
XF - S20753 > (1a) 84
x
Loading...